Embed Size (px)
Citation preview
KENR6331-04April 2009
G3520C Generator Set Engine
Electrical Systemwith Auxiliary Sensing Module
GZA1-UPGZB1-UPGZM1-UPGZN1-UPRLP1-UPLGS1-UP
© 2009 Caterpillar, All Rights Reserved Printed in U.S.A.
1
2 200-L32 BK-14
AG-C4111-7898
L-C123E-5179
C-C4130-6795
9X-1123Component Part Number
Single WireConnector
SocketPin
AG-C3130-6795
Pin or Socket Number
Wire, Cable, or Harness Assembly Identification:Includes Harness Identification Letters and Harness
Connector Serialization Codes Harness Connector Serialization Code: The "C" standsfor "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)Part Number For Connector Recepticle
Part Number forConnector Plug
Harness Identification Letter(s):(A, B, C, ..., AA, AB, AC, ...)
Plug
GroundConnection
325-AG135 PK-14
Circuit IdentificationNumber Wire Color Wire Gauge
Harness identification code: This example indicates wire 135 in harness "AG".
Receptacle
PressureSymbol
T
TemperatureSymbol
LevelSymbol
FlowSymbol
Circuit BreakerSymbol
Harness and Wire Symbols
1 12 2
Sure-Seal connector: Typical representationof a Sure-Seal connector. The plug and receptacle contain both pins and sockets.
Deutsch connector: Typical representationof a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.
Symbols
Symbols and Definitions
Harness And Wire Electrical Schematic Symbols
Fuse(5 Amps)
5A
Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).No circle indicates that the wire cannot be disconnected from the component.
Ground (Wired): This indicates that the component is connected to a grounded wire. Thegrounded wire is fastened to the machine.
Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.T
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.
KE
NR
6331-0
43
6 P
ag
e,
(Dim
en
sio
ns
: 4
8 i
nc
he
s x
35
in
ch
es
)
SPEED TIMINGSENSOR
POWER DISTRIBUTIONBOX
JACKET WATERTEMPERATURE SENSOR
JACKET WATER OUTPRESSURE SENSOR
MANIFOLD AIR INLETTEMPERATURE SENSOR
LEFT EXHAUST TO TURBO
OIL TEMPERATURESENSOR
JACKET WATER INLETPRESSURE SWITCH
UNFILTERED OILPRESSURE SENSOR
FILTERED OILPRESSURE SENSOR
RIGHT EXHAUST TO TURBO
COMPRESSOR BYPASS VALVEACTUATOR FOR THE
THROTTLE ACTUATOR
MANIFOLD AIR PRESSURESENSOR
LEFT EXHAUST TO TURBO
LEFT EXHAUST FROM TURBO
RIGHT EXHAUST FROM TURBO
(ALTERNATE LOCATION)
FUEL METERING VALVE
FUEL METERING VALVE
LEFT SIDE VIEW
TOP SIDE VIEW
RIGHT SIDE VIEW
POWER DISTRIBUTION BOX
2 AMPBREAKER
10 AMPBREAKER
35 AMPBREAKER
2 AMPBREAKER
(STARTER)
TERMINAL (B+) TERMINAL (B-)
P6B0A-RD-16
P2A0-RD-14P2A1-RD-14P200A-RD-16P200B-RD-16P200C-RD-16
P130-RD-08
P270-RD-16
P234-RD-16
C990-RD-16
C991-BK-16
P1B1B-RD-10
P1B0A-RD-10P1B1A-RD-10P1B1A-RD-10
P1B0B-RD-10
C991-BK-16P6B1-BK-16
P6B0B-RD-16
P6B0B-RD-16
C990-RD-16
2A 35A 10A 2A
POWER DISTRIBUTION BOX
SIMMS #1 SIMMS #2
P130-RD-08
P1B0A-RD-10
TERMINAL BOX PRIMARY ECM
P2 CONNECTOR
P1 CONNECTOR
AUXILARY ECM
PANEL LIGHT SWITCH
P5 CONNECTOR
SECONDARY ECMP3 CONNECTOR
P4 CONNECTOR
ITSM MODULE
EMERGENCY STOPBUTTON
SERVICE TOOLCONNECTOR
CUSTOMERCONNECTOR
P7CONNECTOR
P8CONNECTOR
P9CONNECTOR
J8CONNECTOR
J9CONNECTOR
J7CONNECTOR
J6CONNECTOR
SERVICE TOOLCONNECTOR
ITSM MODULECONNECTOR
IGNITION (LEFT)CONNECTOR
EMERGENCY STOPBUTTON
CAN LINKTERMINATION
IGNITION (RIGHT)CONNECTOR
JUNCTION BOX RIGHT SIDE VIEWLEFT SIDE VIEW
Event CodesEngine Control
Event Code Condition Event Code Condition
E004 Engine Overspeed Shutdown E407 Cylinder #7 Detonation Shutdown
E015 High Engine Coolant Temperature Derate E408 Cylinder #8 Detonation Shutdown
E016 High Engine Coolant Temperature Shutdown E409 Cylinder #9 Detonation Shutdown
E017 High Engine Coolant Temperature Warning E410 Cylinder #10 Detonation Shutdown
E019 High Engine Oil Temperature Shutdown E411 Cylinder #11 Detonation Shutdown
E020 High Engine Oil Temperature Warning E412 Cylinder #12 Detonation Shutdown
E025 High Inlet Air Temperature Derate E413 Cylinder #13 Detonation Shutdown
E026 High Inlet Air Temperature Shutdown E414 Cylinder #14 Detonation Shutdown
E027 High Inlet Air Temperature Warning E415 Cylinder #15 Detonation Shutdown
E038 Low Engine Coolant Temperature Warning E416 Cylinder #16 Detonation Shutdown
E040 Low Engine Oil Pressure Shutdown E417 Cylinder #17 Detonation Shutdown
E042 Low System Voltage Shutdown E418 Cylinder #18 Detonation Shutdown
E043 Low System Voltage Warning E419 Cylinder #19 Detonation Shutdown
E050 High System Voltage Warning E420 Cylinder #20 Detonation Shutdown
E053 Low Fuel Pressure Warning E801 Cylinder #1 High Exhaust Port Temp
E073 High Oil Filter Differential Pressure Warning E802 Cylinder #2 High Exhaust Port Temp
E073 High Oil Filter Differential Pressure Shutdown E803 Cylinder #3 High Exhaust Port Temp
E096 High Fuel Pressure Warning E804 Cylinder #4 High Exhaust Port Temp
E100 Low Engine Oil Pressure Warning E805 Cylinder #5 High Exhaust Port Temp
E127 Engine Oil Filter Diff Pressure Low Warning E806 Cylinder #6 High Exhaust Port Temp
E128 Engine Oil Filter Diff Pressure Low Shutdown E807 Cylinder #7 High Exhaust Port Temp
E129 Engine Oil Filter Diff Pressure High Warning E808 Cylinder #8 High Exhaust Port Temp
E130 Engine Oil Filter Diff Pressure High Shutdown E809 Cylinder #9 High Exhaust Port Temp
E135 Low Jacket Water Pressure Shutdown E810 Cylinder #10 High Exhaust Port Temp
E197 High Engine Oil Temperature Warning E811 Cylinder #11 High Exhaust Port Temp
E197 High Engine Oil Temperature Shutdown E812 Cylinder #12 High Exhaust Port Temp
E198 Low Fuel Pressure Warning E813 Cylinder #13 High Exhaust Port Temp
E199 Low Engine Coolant Temperature Warning E814 Cylinder #14 High Exhaust Port Temp
E223 High Gas Temperature E815 Cylinder #15 High Exhaust Port Temp
E224 High Jacket Water Inlet Pressure E816 Cylinder #16 High Exhaust Port Temp
E225 Engine Overcrank E817 Cylinder #17 High Exhaust Port Temp
E226 Driven Equipment Start Inhibit E818 Cylinder #18 High Exhaust Port Temp
E228 Low Jacket Water Outlet Pressure Shutdown E819 Cylinder #19 High Exhaust Port Temp
E229 Fuel Energy Content Set Too Low E820 Cylinder #20 High Exhaust Port Temp
E230 Fuel Energy Content Set Too High E821 Cyl #1 Exhaust Port Temp Deviating High
E231 Fuel Quality Out of Range E822 Cyl #2 Exhaust Port Temp Deviating High
E243 High Left Turbo Turbine Outlet Temperature E823 Cyl #3 Exhaust Port Temp Deviating High
E244 High Right Turbo Turbine Outlet Temperature E824 Cyl #4 Exhaust Port Temp Deviating High
E245 High Right Turbo Turbine Inlet Temperature E825 Cyl #5 Exhaust Port Temp Deviating High
E246 High Left Turbo Turbine Inlet Temperature E826 Cyl #6 Exhaust Port Temp Deviating High
E264 Emergency Stop Activated E827 Cyl #7 Exhaust Port Temp Deviating High
E267 High Fuel Pressure Warning E828 Cyl #8 Exhaust Port Temp Deviating High
E268 Unexpected Engine Shutdown E829 Cyl #9 Exhaust Port Temp Deviating High
E269 Customer Fault Stop E830 Cyl #10 Exhaust Port Temp Deviating High
E270 Driven Equipment Shutdown Requested E831 Cyl #11 Exhaust Port Temp Deviating High
E337 High Engine Oil to Engine Coolant Diff Temp Warning E832 Cyl #12 Exhaust Port Temp Deviating High
E337 High Engine Oil to Engine Coolant Diff Temp Shutdown E833 Cyl #13 Exhaust Port Temp Deviating High
E360 Low Engine Oil Pressure Warning E834 Cyl #14 Exhaust Port Temp Deviating High
E360 Low Engine Oil Pressure Shutdown E835 Cyl #15 Exhaust Port Temp Deviating High
E361 High Engine Coolant Temperature Warning E836 Cyl #16 Exhaust Port Temp Deviating High
E361 High Engine Coolant Temperature Derate E837 Cyl #17 Exhaust Port Temp Deviating High
E361 High Engine Coolant Temperature Shutdown E838 Cyl #18 Exhaust Port Temp Deviating High
E362 Engine Overspeed Shutdown E839 Cyl #19 Exhaust Port Temp Deviating High
E368 High Inlet Air Temperature Warning E840 Cyl #20 Exhaust Port Temp Deviating High
E368 High Inlet Air Temperature Derate E841 Cyl #1 Exhaust Port Temp Deviating Low
E368 High Inlet Air Temperature Shutdown E842 Cyl #2 Exhaust Port Temp Deviating Low
E401 Cylinder #1 Detonation E843 Cyl #3 Exhaust Port Temp Deviating Low
E402 Cylinder #2 Detonation E844 Cyl #4 Exhaust Port Temp Deviating Low
E403 Cylinder #3 Detonation E845 Cyl #5 Exhaust Port Temp Deviating Low
E404 Cylinder #4 Detonation E846 Cyl #6 Exhaust Port Temp Deviating Low
E405 Cylinder #5 Detonation E847 Cyl #7 Exhaust Port Temp Deviating Low
E406 Cylinder #6 Detonation E848 Cyl #8 Exhaust Port Temp Deviating Low
E407 Cylinder #7 Detonation E849 Cyl #9 Exhaust Port Temp Deviating Low
E408 Cylinder #8 Detonation E850 Cyl #10 Exhaust Port Temp Deviating Low
E409 Cylinder #9 Detonation E851 Cyl #11 Exhaust Port Temp Deviating Low
E410 Cylinder #10 Detonation E852 Cyl #12 Exhaust Port Temp Deviating Low
E411 Cylinder #11 Detonation E853 Cyl #13 Exhaust Port Temp Deviating Low
E412 Cylinder #12 Detonation E854 Cyl #14 Exhaust Port Temp Deviating Low
E413 Cylinder #13 Detonation E855 Cyl #15 Exhaust Port Temp Deviating Low
E414 Cylinder #14 Detonation E856 Cyl #16 Exhaust Port Temp Deviating Low
E415 Cylinder #15 Detonation E857 Cyl #17 Exhaust Port Temp Deviating Low
E416 Cylinder #16 Detonation E858 Cyl #18 Exhaust Port Temp Deviating Low
E417 Cylinder #17 Detonation E859 Cyl #19 Exhaust Port Temp Deviating Low
E418 Cylinder #18 Detonation E860 Cyl #20 Exhaust Port Temp Deviating Low
E419 Cylinder #19 Detonation E864 Low Gas Fuel Differential Pressure
E420 Cylinder #20 Detonation E865 High Gas Fuel Differential Pressure
E401 Cylinder #1 Detonation Shutdown E866 Low Gas Fuel Flow Rate
E402 Cylinder #2 Detonation Shutdown E867 Improper Gas Flow Control Valve Response
E403 Cylinder #3 Detonation Shutdown E868 Gas Flow Control Valve Malfunction
E404 Cylinder #4 Detonation Shutdown E875 Low System Voltage Warning
E405 Cylinder #5 Detonation Shutdown E875 Low System Voltage Shutdown
E406 Cylinder #6 Detonation Shutdown E876 High System Voltage Warning
Component Identifiers (CID¹)Module Identifier (MID²)
Engine Control (Secondary)(MID No. 033)
CID Component0041 8 Volt DC Supply voltage.0168 Electrical System Voltage.0301 Ignition Transformer Primary #1.0303 Ignition Transformer Primary #3.0305 Ignition Transformer Primary #5.0307 Ignition Transformer Primary #7.0309 Ignition Transformer Primary #9.0311 Ignition Transformer Primary #11.0313 Ignition Transformer Primary #13.0315 Ignition Transformer Primary #15.0320 Speed/Timing Sensor.0401 Ignition Transformer Secondary #1.0403 Ignition Transformer Secondary #3.0405 Ignition Transformer Secondary #5.0407 Ignition Transformer Secondary #7.0409 Ignition Transformer Secondary #9.0411 Ignition Transformer Secondary #11.0413 Ignition Transformer Secondary #13.0415 Ignition Transformer Secondary #15.0590 Engine Control Module.1501 Cylinder #1 Detonation Sensor.1505 Cylinder #5 Detonation Sensor.1509 Cylinder #9 Detonation Sensor.1513 Cylinder #13 Detonation Sensor.1517 Cylinder #17 Detonation Sensor.1748 Ignition Transformer Secondary #17.1750 Ignition Transformer Secondary #19.1752 Ignition Transformer Primary #17.1754 Ignition Transformer Primary #19.
Engine Control (Primary)(MID No. 036)
CID Component0017 Fuel Shutoff Valve.0041 8 Volt DC Supply voltage.0100 Engine Oil Pressure Sensor.0109 Engine Coolant Outlet Pressure Sensor.0110 Engine Coolant Temperature Sensor.0145 12 Volt DC Power Supply.0168 Electrical System Voltage.0172 Intake Manifold Air Temperature Sensor.0175 Engine Oil Temperature Sensor.0254 Electronic Control Module.0261 Engine Timing Calibration.0262 5 Volt Sensor DC Power Supply.0302 Ignition Transformer Primary #2.0304 Ignition Transformer Primary #4.0306 Ignition Transformer Primary #6.0308 Ignition Transformer Primary #8.0310 Ignition Transformer Primary #10.0312 Ignition Transformer Primary #12.0314 Ignition Transformer Primary #14.0316 Ignition Transformer Primary #14.0320 Speed/Timing Sensor.0323 Engine Shutdown Lamp.0324 Warning Lamp (Action).0336 Engine Control Switch.0342 Secondary Engine Speed Sensor.0402 Ignition Transformer Secondary #2.0404 Ignition Transformer Secondary #4.0406 Ignition Transformer Secondary #6.0408 Ignition Transformer Secondary #8.0410 Ignition Transformer Secondary #10.0412 Ignition Transformer Secondary #12.0414 Ignition Transformer Secondary #14.0416 Ignition Transformer Secondary #16.0444 Starter Motor Relay.0445 Run Relay.0524 Desired Engine Speed Sensor.0542 Engine Oil Pressure Sensor -Before Oil Filter.1042 ITSM (Integrated Temperature Sensing Module)1440 Throttle Actuator.1446 Fuel Metering Module.1447 Fuel Metering Sensor Module.1502 Cylinder #2 Detonation Sensor.1506 Cylinder #6 Detonation Sensor.1510 3 Cylinder #10 Detonation Sensor.1514 4 Cylinder #14 Detonation Sensor.1518 3 Cylinder #18 Detonation Sensor.1636 (Secondary) Engine #2 Electronic Control Module.1719 Generator Output Power Sensor.1720 Turbocharger Compressor Bypass Valve Actuator.1749 Ignition Transformer Secondary #18.1751 Ignition Transformer Secondary #20.1753 Ignition Transformer Primary #18.1755 Ignition Transformer Primary #20.2449 Fuel Quality Sensor.
Integrated Temperature Sensing Module(MID No. 111)
CID Component0591 EEPROM checksum fault.1489 Left Turbo Turbine Outlet Temperature Sensor.1490 Right Turbo Turbine Outlet Temperature Sensor.1491 Right Turbo Turbine Inlet Temperature Sensor.1492 Left Turbo Turbine Inlet Temperature Sensor.1531 Engine Cylinder #1 Exhaust Port Temperature Sensor.1532 Engine Cylinder #2 Exhaust Port Temperature Sensor.1533 Engine Cylinder #4 Exhaust Port Temperature Sensor.1534 Engine Cylinder #4 Exhaust Port Temperature Sensor.1535 Engine Cylinder #5 Exhaust Port Temperature Sensor.1536 Engine Cylinder #6 Exhaust Port Temperature Sensor.1537 Engine Cylinder #7 Exhaust Port Temperature Sensor.1538 Engine Cylinder #8 Exhaust Port Temperature Sensor.1539 Engine Cylinder #9 Exhaust Port Temperature Sensor.1540 Engine Cylinder #10 Exhaust Port Temperature Sensor.1541 Engine Cylinder #11 Exhaust Port Temperature Sensor.1542 Engine Cylinder #12 Exhaust Port Temperature Sensor.1543 Engine Cylinder #13 Exhaust Port Temperature Sensor.1544 Engine Cylinder #14 Exhaust Port Temperature Sensor.1545 Engine Cylinder #15 Exhaust Port Temperature Sensor.1546 Engine Cylinder #16 Exhaust Port Temperature Sensor.1547 Engine Cylinder #17 Exhaust Port Temperature Sensor.1548 Engine Cylinder #18 Exhaust Port Temperature Sensor.1549 Engine Cylinder #19 Exhaust Port Temperature Sensor.1550 Engine Cylinder #20 Exhaust Port Temperature Sensor.
Auxiliary Sensing Module(MID No. 034 )
0106 Air Inlet Pressure Sensor.0145 12 Volt DC Power Supply.0168 Electrical System Voltage.0253 Personality Module.0262 5 Volt Sensor DC Supply.1719 Generator Output Power Sensor.2852 Compressor Discharge Pressure Sensor.
¹ The CID is a diagnostic code that indicates which circuit is faulty.² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.
Failure Mode Identifiers (FMI)¹FMI No. Failure Description
0 Data valid but above normal operational range.1 Data valid but below normal operational range.2 Data erratic, intermittent, or incorrect.3 Voltage above normal or shorted high.4 Voltage below normal or shorted low.5 Current below normal or open circuit.6 Current above normal or grounded circuit.7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.9 Abnormal update.10 Abnormal rate of change.11 Failure mode not identifiable.12 Bad device or component.13 Out of calibration.14 Parameter failures.15 Parameter failures.16 Parameter not available.17 Module not responding.18 Sensor supply fault.19 Condition not met.20 Parameter failures.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
KE
NR
6331-0
43
6 P
ag
e,
(Dim
en
sio
ns
: 4
8 i
nc
he
s x
35
in
ch
es
)
THIS SCHEMATIC IS FOR THE G3520C & G3520E ENGINEPART NUMBER: 324-7475, CHANGE: 00, VERSION: (-)Components are shown installed on a fully operable engine, with the key in the off position.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
45678 23
A
C
D
E
F
B
1
1
2345678
A
B
C
D
E
F
ABBREVRDWHORYLPKBKGYPUBRGNBU
COLORRED
WHITEORANGEYELLOW
PINKBLACKGRAY
PURPLEBROWNGREENBLUE
COLOR ABBREVIATIONS
SYMBOL DESCRIPTION
BLADE, SPADE, RING OR SCREWTERMINAL
CIRCUIT CONNECTED
CIRCUIT NOT CONNECTED
ELECTRICAL CONNECTION TOMACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTIONTO SURFACE OF COMPONENT
CONNECTOR
ATCH WIRE, CABLE, COMPONENT
CIRCUIT CONNECTED
SPLICE
CIRCUIT GROUPING DESIGNATIONH#
HIGHWAYS
SENSOR / ACTUATOR SUPPLY
SIGNAL TO ECM
(+) BATTERY SWITCHED
(+) BATTERY
(-) BATTERY / SENSOR RETURN
STARTING CIRCUIT
CAT DATA LINK
CONTROL (POSITIVE) FROM ECM
CONTROL (RETURN) FROM ECM
CAN DATA LINK
A-C51607690
AUXILIARY ECM154-6713
J5
+24V SUPPLYBATT(-)
CAT DATA LINK (+)CAT DATA LINK (-)
COP SIG.IMAP SIG.KWM SIG.
CAN DATA LINK (-)
SPD SIG.
SPD TIMING +12V
CAN DATA LINK (+)SPD RETURN
FUSED BATT (+)FUSED BATT (+)
FUSED BATT (+)
FUSED BATT (+)
HARNESS CODE JUMPER
HARNESS CODE JUMPER
BATT (-)
BATT (-)
BATT (-)
BATT (-)GECM KEY IN
A-C31607690
123456789101112131415161718192021222324
A-C41471443
25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
SECONDARY ECM15406713
J3
J4
CAT DATA LINK (+)CAT DATA LINK (-)
E-STOP
SPD TIMING SIG.
HARNESS CODE JUMPER
HARNESS CODE JUMPER
FUSED BATT (+)FUSED BATT (+)
FUSED BATT (+)
FUSED BATT (+)
BATT (-)
BATT (-)
BATT (-)
BATT (-)GECM KEY IN
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
CAN SHIELD
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
ITSM
P401-A001 BK-16P501-A002 BK-16P501-A003 BK-16P501-A004 BK-16D100-A005 BK-16D100-A006 BK-16K995-A007 BK-16
G853-A011 BK-16
M170-A009 BK-16
M975-A012 BK-16
M170-A008 BK-16
M164-A013 BK-16M530-A014 BK-16C256-A015 BK-16M510-A016 BK-16994-A017 BK-16E796-A019 BK-16B829-A020 BK-16M190-A021 BK-16A447-A022 BK-16P500-A023 BK-16999-A024 BK-16
M170-A010 BK-16
F889-A026 BK-16G889-A027 BK-16
M152-A028 BK-16M153-A029 BK-16
J1939SH4-A031 CU-19996-A030 BK-16
J1939G4-A033 GN-19
A998-A034 BK-16150-A035 BK-16150-A036 BK-16150-A037 BK-16
150-A039 BK-16A320-A038 BK-16
A620-A040 BK-16A620-A041 BK-16P613-A042 BK-16P615-A043 BK-16229-A044 BK-16P614-A045 BK-16229-A046 BK-16M120-A047 BK-16229-A048 BK-16229-A049 BK-16P231-A157 BK-16
A330-A226 BK-16A330-A227 BK-16
J1939Y4-A032 YL-19
D100-A072 BK-16D100-A077 BK-16G256-A080 BK-16999-A085 BK-16150-A131 BK-16150-A132 BK-16150-A133 BK-16150-A134 BK-16229-A135 BK-16229-A136 BK-16229-A137 BK-16229-A138 BK-16P231-A156 BK-16
A330-A095 BK-16X809-A096 BK-16
A310-A098 BK-16
C293-A100 BK-16
M140-A101 BK-16P696-A102 BK-16P698-A103 BK-16P697-A104 BK-16E976-A105 BK-16E976-A106 BK-16E976-A107 BK-16E976-A108 BK-16E976-A109 BK-16E978-A110 BK-16E978-A111 BK-16E977-A112 BK-16E977-A113 BK-16C130-A114 BK-16C130-A115 BK-16
A310-A092 BK-16
A330-A224 BK-16
385-A260 BK-16
385-A361 BK-16
150-A210 BK-16229-A193 BK-16D100-A194 BK-16D100-A195 BK-16R779-A196 BK-16
150-A198 BK-16R779-A197 BK-16
999-A200 BK-16
996-A202 BK-16
997-A204 BK-16150-A142 BK-16150-A143 BK-16150-A144 BK-16150-A145 BK-16229-A149 BK-16229-A150 BK-16229-A151 BK-16229-A152 BK-16
J1939Y2-A086 YL-19
J1939SH2-A165 CU-19
J1939G2-A164 GN-19
TWISTED PAIR
TWISTED PAIR
A-S5
A-S7
A-S9
A-S14
A-S22
A-S15
A-S6
A-S20
A-S21
E976-A180 BK-16E976-A181 BK-16E976-A182 BK-16E976-A183 BK-16E976-A184 BK-16E978-A190 BK-16E978-A191 BK-16E977-A173 BK-16E977-A174 BK-16
150-A210 BK-16
P501-A003 BK-16
P501-A003 BK-16
D100-A005 BK-16
D100-A006 BK-16
K995-A007 BK-16
G853-A011 BK-16
M170-A009 BK-16
M975-A012 BK-16
M170-A008 BK-16M164-A013 BK-16
M530-A014 BK-16
C256-A015 BK-16
M510-A016 BK-16
E796-A019 BK-16
B829-A020 BK-16
M190-A021 BK-16
M975-A012 BK-16
M530-A014 BK-16
M510-A016 BK-16
M190-A021 BK-16
A447-A022 BK-16
F889-A026 BK-16
G889-A027 BK-16
M152-A028 BK-16M153-A029 BK-16
J1939SH4-A031 CU-19
J1939G4-A033 GN-19
A320-A038 BK-16
A620-A040 BK-16
A447-A022 BK-16A620-A040 BK-16
A620-A041 BK-16
P613-A042 BK-16P615-A043 BK-16P614-A045 BK-16
M120-A047 BK-16
P231-A157 BK-16 P231-A159 BK-16
A330-A226 BK-16A330-A227 BK-16
J1939Y4-A032 YL-19
D100-A072 BK-16D100-A194 BK-16
D100-A077 BK-16D100-A195 BK-16
G256-A080 BK-16
999-A024 BK-16
229-A135 BK-16229-A136 BK-16229-A137 BK-16229-A138 BK-16
229-A146 BK-16
229-A213 BK-16229-A215 BK-16
229-A214 BK-16
229-A166 BK-16
229-A147 BK-16229-A148 BK-16229-A167 BK-16
229-A146 BK-16229-A213 BK-16
229-A215 BK-16
229-A146 BK-16
229-A213 BK-16
229-A215 BK-16
150-A198 BK-16
229-A166 BK-16
229-A148 BK-16229-A167 BK-16
229-A212 BK-16
229-A214 BK-16
229-A212 BK-16
A330-A095 BK-16
A330-A225 BK-16A330-A099 BK-16
A330-A225 BK-16
A330-A099 BK-16
A620-A153 BK-16A620-A154 BK-16
D100-A074 BK-16D100-A073 BK-16
D100-A076 BK-16D100-A078 BK-16
E977-A126 BK-16
E977-A128 BK-16E977-A127 BK-16
A998-A034 BK-16
A998-A090 BK-16A998-A091 BK-16
A620-A153 BK-16
A620-A154 BK-16
A998-A090 BK-16
A998-A091 BK-16
E977-A129 BK-16E977-A130 BK-16
X809-A096 BK-16
A310-A098 BK-16
C293-A100 BK-16
C293-A100 BK-16
M140-A101 BK-16
K995-A007 BK-16
G853-A011 BK-16
M170-A009 BK-16
M170-A008 BK-16
M170-A008 BK-16
M164-A013 BK-16
M164-A013 BK-16
F889-A026 BK-16
G889-A027 BK-16
M153-A029 BK-16
M152-A028 BK-16
M120-A047 BK-16
M140-A101 BK-16
P696-A102 BK-16P698-A103 BK-16P697-A104 BK-16
E976-A105 BK-16E976-A106 BK-16E976-A107 BK-16E976-A108 BK-16E976-A109 BK-16
E977-A112 BK-16
E977-A113 BK-16
A-S25
A-S27
E977-A168 BK-16
E977-A170 BK-16E977-A169 BK-16
E977-A171 BK-16E977-A172 BK-16
E977-A173 BK-16
E977-A174 BK-16
A-S11
M170-A088 BK-16M170-A089 BK-16
M170-A088 BK-16
M170-A089 BK-16
M170-A010 BK-16
A-S2
P501-A069 BK-16P501-A070 BK-16
P501-A063 BK-16P501-A064 BK-16
P501-A061 BK-16P501-A062 BK-16
P501-A059 BK-16P501-A060 BK-16
P501-A002 BK-16
A-S4
P501-A067 BK-16P501-A068 BK-16
P501-A004 BK-16
A-S10
A-S12
J1939SH1-A203 CU-19J1939SH3-A162 CU-19
J1939Y1-A199 YL-19J1939Y3-A087 YL-19
A-S8
P500-A219 BK-16P500-A081 BK-16P500-A082 BK-16
P500-A023 BK-16
A-S23P231-A158 BK-16P231-A155 BK-16
P231-A156 BK-16
A-S19
E978-A124 BK-16E978-A125 BK-16
E978-A122 BK-16E978-A123 BK-16
E978-A111 BK-16
A-S18
E978-A120 BK-16E978-A121 BK-16
E978-A118 BK-16E978-A119 BK-16
E978-A116 BK-16E978-A117 BK-16
E978-A110 BK-16
A-S26
E978-A188 BK-16E978-A189 BK-16
E978-A178 BK-16E978-A179 BK-16
E978-A191 BK-16
A-S1
P401-A054 BK-16P401-A065 BK-16
P401-A051 BK-16
P401-A053 BK-16P401-A052 BK-16
P401-A001 BK-16
A-S24
E978-A186 BK-16E978-A187 BK-16
E978-A177 BK-16E978-A185 BK-16
E978-A175 BK-16E978-A176 BK-16
E977-A126 BK-16E977-A128 BK-16E977-A127 BK-16
E977-A129 BK-16E977-A130 BK-16
E977-A168 BK-16
E977-A170 BK-16E977-A169 BK-16
E977-A171 BK-16E977-A172 BK-16
E978-A124 BK-16
E978-A125 BK-16E978-A122 BK-16
E978-A123 BK-16E978-A120 BK-16
E978-A121 BK-16E978-A118 BK-16
E978-A119 BK-16E978-A116 BK-16
E978-A117 BK-16
E978-A188 BK-16
E978-A178 BK-16E978-A179 BK-16
E978-A186 BK-16E978-A187 BK-16
E978-A177 BK-16
E978-A185 BK-16
E978-A175 BK-16E978-A176 BK-16
E978-A190 BK-16
C130-A114 BK-16C130-A115 BK-16
B829-A020 BK-16
C130-A114 BK-16
C130-A115 BK-16
A310-A092 BK-16
A330-A224 BK-16
229-A193 BK-16
R779-A196 BK-16R779-A197 BK-16
P613-A042 BK-16
P613-A042 BK-16
P615-A043 BK-16
P614-A045 BK-16
X809-A096 BK-16
P696-A102 BK-16
P698-A103 BK-16
P697-A104 BK-16
R779-A196 BK-16
R779-A197 BK-16
229-A149 BK-16229-A150 BK-16229-A151 BK-16229-A152 BK-16
J1939Y2-A086 YL-19
J1939SH2-A165 CU-19
J1939G2-A164 GN-19 A-S13
J1939G1-A201 GN-19J1939G3-A163 GN-19
J1939SH1-A203 CU-19
J1939SH3-A162 CU-19
J1939Y1-A199 YL-19
J1939Y3-A087 YL-19
J1939G1-A201 GN-19
J1939G3-A163 GN-19
E976-A180 BK-16E976-A181 BK-16E976-A182 BK-16E976-A183 BK-16E976-A184 BK-16
E796-A019 BK-16
E976-A105 BK-16E976-A106 BK-16E976-A107 BK-16E976-A108 BK-16E976-A109 BK-16E976-A180 BK-16E976-A181 BK-16E976-A182 BK-16E976-A183 BK-16E976-A184 BK-16
994-A017 BK-16
999-A085 BK-16 999-A084 BK-16
999-A084 BK-16
C256-A083 BK-16
C256-A083 BK-16
M530-A014 BK-16
C256-A083 BK-16
D100-A071 BK-16
D100-A075 BK-16
996-A030 BK-16
150-A035 BK-16150-A036 BK-16150-A037 BK-16150-A039 BK-16
229-A044 BK-16229-A046 BK-16229-A048 BK-16229-A049 BK-16
150-A131 BK-16150-A132 BK-16150-A133 BK-16
150-A139 BK-16150-A140 BK-16150-A141 BK-16
150-A134 BK-16
385-A260 BK-16385-A361 BK-16
150-A207 BK-16
150-A140 BK-16150-A141 BK-16
150-A207 BK-16
150-A198 BK-16
150-A210 BK-16
999-A200 BK-16
A320-A038 BK-16
A320-A038 BK-16
A330-A226 BK-16
A330-A226 BK-16
A330-A227 BK-16
M170-A088 BK-16
A330-A227 BK-16
A330-A095 BK-16
M140-A101 BK-16
A330-A095 BK-16
A310-A098 BK-16
A310-A092 BK-16
999-A200 BK-16
996-A202 BK-16997-A204 BK-16
994-A017 BK-16
996-A030 BK-16
385-A260 BK-16
385-A361 BK-16
996-A202 BK-16
997-A204 BK-16
150-A142 BK-16150-A143 BK-16150-A144 BK-16150-A145 BK-16
150-A139 BK-16
150-A198 BK-16
229-A147 BK-16D100-A074 BK-16D100-A075 BK-16
150-A139 BK-16
229-A147 BK-16
D100-A074 BK-16
P270-A161 BK-16
F717-A221 BK-16
C256-A083 BK-16
229-A146 BK-16
229-A213 BK-16
229-A215 BK-16
150-A198 BK-16
A320-A038 BK-16
P613-A042 BK-16
F719-A222 BK-16
D100-A073 BK-16
M164-A013 BK-16
M530-A014 BK-16
P234-A160 BK-16
M170-A008 BK-16
A330-A226 BK-16
F715-A220 BK-16
A330-A095 BK-16
D100-A076 BK-16
A330-A227 BK-16
M170-A009 BK-16
A330-A225 BK-16
P231-A158 BK-16
M170-A088 BK-16
M140-A101 BK-16
P698-A103 BK-16
M120-A047 BK-16
P615-A043 BK-16
385-A361 BK-16
M170-A089 BK-16
M510-A016 BK-16
A330-A097 BK-16
P500-A218 BK-16
F889-A026 BK-16
G889-A027 BK-16
385-A260 BK-16
P614-A045 BK-16
M190-A021 BK-16
P696-A102 BK-16
P697-A104 BK-16
D100-A075 BK-16
A-C18
140-7684
A-C20
174-3016
A-C21471443
A-C11607690
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
PRIMARY ECM154-6713
J2
J1
+5V SUPPLY5V RETURN
JACKET WATER OUT PRESS +8VJACKET WATER OUT PRESS COM
CAT DATA LINK (+)CAT DATA LINK (-)
MAPS SIG.SPD. POT. +5VSPD. POT. SIG.SPD. POT. COM.
INLET MANIFOLD AIR TEMP SIGOIL TEMP SIG
TIMING SETTINGDRIVEN EQUIPMENT
E-STOPNORMAL E-STOP
FILTERED OIL PRESS SIG
UN-FILTERED OIL PRESS SIG.JACKET WATER TEMP SW. SIG.
IDLE/RATED
PRELUBE PRESS SW.DIGITAL RETURN
SPD TIMING SIG.
DESIRED SPD 4-20 IN + (OPT.)DESIRED SPD 4-20 IN - (OPT.)
GAS BTU SOURCE GAS BTU RETURNTIMING CAL (-)TIMING CAL (+)
SPD TIMING +12V
CAN SHIELDCAN DATA LINK (-)CAN DATA LINK (+)SPD TIMING COM.FUSED BATT (+)FUSED BATT (+)
FUSED BATT (+)MANUAL PRELUBEFUSED BATT (+)
RAPTOR VALVE CONTROL PWM+
RAPTOR PWM RETURN/SHIELDSTOP
STARTBATT (-)
AUTOBATT (-)
ON/OFF GRIG SWITCH INBATT (-)
BATT (-)GECM KEY IN
12345678910111213151816351417202122232425262728293031493332193637383940414843444546474234505152535455565758596061626364656667686970
P401-A001 BK-16P501-A002 BK-16P501-A003 BK-16P501-A004 BK-16
D100-A005 BK-16D100-A006 BK-16
K995-A007 BK-16
G853-A011 BK-16
M170-A009 BK-16
M975-A012 BK-16
M170-A008 BK-16
M164-A013 BK-16M530-A014 BK-16C256-A015 BK-16M510-A016 BK-16994-A017 BK-16
E796-A019 BK-16B829-A020 BK-16M190-A021 BK-16
A447-A022 BK-16P500-A023 BK-16
999-A024 BK-16
M170-A010 BK-16
F889-A026 BK-16G889-A027 BK-16
M152-A028 BK-16M153-A029 BK-16
J1939SH4-A031 CU-19
996-A030 BK-16
J1939G4-A033 GN-19
A998-A034 BK-16150-A035 BK-16150-A036 BK-16
150-A037 BK-16
150-A039 BK-16A320-A038 BK-16
A620-A040 BK-16
A620-A041 BK-16P613-A042 BK-16P615-A043 BK-16229-A044 BK-16P614-A045 BK-16229-A046 BK-16M120-A047 BK-16229-A048 BK-16
229-A049 BK-16P231-A157 BK-16
A330-A226 BK-16A330-A227 BK-16
J1939Y4-A032 YL-19
D100-A073 BK-16
D100-A073 BK-16
D100-A076 BK-16
D100-A076 BK-16
D100-A078 BK-16D100-A071 BK-16
P500-A218 BK-16
P231-A159 BK-16
P500-A219 BK-16
P500-A081 BK-16P500-A082 BK-16
P231-A158 BK-16
P231-A158 BK-16
P231-A155 BK-16
P401-A054 BK-16
P401-A065 BK-16
P401-A051 BK-16
P401-A053 BK-16P401-A052 BK-16
P500-A218 BK-16
M510-A016 BK-16
M190-A021 BK-16
A330-A225 BK-16
M170-A009 BK-16
F889-A026 BK-16
G889-A027 BK-16
M120-A047 BK-16
M170-A089 BK-16
P615-A043 BK-16
P614-A045 BK-16
P696-A102 BK-16
P698-A103 BK-16
P697-A104 BK-16
385-A260 BK-16
385-A361 BK-16
P500-A218 BK-16
P501-A057 BK-16P501-A058 BK-16
P501-A055 BK-16P501-A056 BK-16
P501-A069 BK-16
P501-A070 BK-16
P501-A063 BK-16P501-A064 BK-16
P501-A061 BK-16P501-A062 BK-16
P501-A059 BK-16
P501-A060 BK-16
P501-A067 BK-16
P501-A068 BK-16
P501-A057 BK-16
P501-A058 BK-16
P501-A055 BK-16
P501-A056 BK-16
229-A166 BK-16
D100-A078 BK-16
D100-A071 BK-16
P231-A159 BK-16
229-A166 BK-16
D100-A078 BK-16
D100-A071 BK-16
P231-A159 BK-16
L-M1
R-M1
R-C21
8N-1513
RE-C21
8N-1514
L-C21
8N-1513
LE-C21
8N-1514
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
J202-27 BK-16
J201-26 RD-16
J182-35 BK-16
J181-34 RD-16
J162-17 BK-16
J161-16 RD-16
J022-02 BK-16
J021-01 RD-16
J042-15 BK-16
J041-14 RD-16
J062-49 BK-16
J061-48 RD-16
J082-25 BK-16
J081-24 RD-16
J102-33 BK-16
J101-32 RD-16
J122-04 BK-16
J121-03 RD-16
J142-51 BK-16
J141-50 RD-16
CYL NO. 16 CYL NO. 14 CYL NO. 12 CYL NO. 10 CYL NO. 8 CYL NO. 6 CYL NO. 4 CYL NO. 2CYL NO. 20 CYL NO. 18
LEFT SIDE IGNITION
B A B A B A B A B A B A B A B A B A B A
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
PLUG AS.
9X-8482
RIGHT SIDE IGNITION
J012-02 BK-16
J031-14 RD-16
J032-15 BK-16
J011-01 RD-16
J191-26 RD-16
J192-27 BK-16
J171-34 RD-16
J172-35 BK-16
J151-16 RD-16
J152-17 BK-16
J131-50 RD-16
J132-51 BK-16
J111-03 RD-16
J112-04 BK-16
J091-32 RD-16
J092-33 BK-16
J071-24 RD-16
J072-25 BK-16
J051-48 RD-16
J052-49 BK-16
CYL NO. 19 CYL NO. 17CYL NO. 1CYL NO. 3CYL NO. 5CYL NO. 7CYL NO. 9CYL NO. 11CYL NO. 13CYL NO. 15
B A B A B A B A B A B A B A B A B A B A
CAT DATA LINK (+)
CAT DATA LINK (-)
SERVICE CONNECTOR
CUSTOMER CONNECTOR
POWER
COMMON
A B
A-C11
9W1951
A-C6
9X7148
P-6
9X7147
A-C7
1030213
P-7
9X4391
C D E F G H J
A-C17
6D5234 E H ML NGF J KIA B C D
DETONATION F SIG.DETONATION G SIG.DETONATION H SIG.DETONATION J SIG.
DETONATION K SIG.
DET. COMMONDET. COMMONDET. +8VOLTSDET. +8VOLTS
E976-A180 BK-16E976-A181 BK-16E976-A182 BK-16E976-A183 BK-16
E976-A184 BK-16
E978-A190 BK-16E978-A191 BK-16E977-A173 BK-16E977-A174 BK-16
F719-A222 BK-16
F717-A221 BK-16
P500-A219 BK-16
F715-A220 BK-16
P500-A219 BK-16
F719-A222 BK-16
F717-A221 BK-16
F715-A220 BK-16
IGNITION CYLINDER 9 (+)IGNITION CYLINDER 9 (-)
IGNITION CYLINDER 11 (+)IGNITION CYLINDER 11 (-)
IGNITION CYLINDER 1 (+)IGNITION CYLINDER 1 (-)
IGNITION CYLINDER 13 (+)IGNITION CYLINDER 13 (-)
IGNITION CYLINDER 15 (+)IGNITION CYLINDER 15 (-)
IGNITION CYLINDER 17 (+)IGNITION CYLINDER 17 (-)
IGNITION CYLINDER 19 (+)IGNITION CYLINDER 19 (-)
IGNITION CYLINDER 3 (+)IGNITION CYLINDER 3 (-)
IGNITION CYLINDER 5 (+)IGNITION CYLINDER 5 (-)
IGNITION CYLINDER 7 (+)IGNITION CYLINDER 7 (-)
AIR/ELEC START SIG.(+)GAS SHUTOFF VALVE (+)
PRELUBE RELAYALM/SHUTDOWN
AIR/ELEC START RETURNGAS SHUTOFF (-)
PRELUBE RELAY RETURNALM/SHUTDOWN RETURN
RUN RELAYCRANK TERMINATEENGINE FAILURE
ACTIVE ALARMIGNITION CYLINDER 10 (+)IGNITION CYLINDER 10 (-)
IGNITION CYLINDER 12 (+)IGNITION CYLINDER 12 (-)
IGNITION CYLINDER 2 (+)IGNITION CYLINDER 2 (-)
DETONATION A SIG.DETONATION B SIG.DETONATION C SIG.DETONATION D SIG.
DETONATION E SIG.
DET. COMMONDET. COMMON
DET. +8VOLTSDET. +8VOLTS
JACKET WATER OUT PRESS SIG.JACKET WATER INLET PRESS (+)
A330-A095 BK-16X809-A096 BK-16
A310-A098 BK-16
C293-A100 BK-16
M140-A101 BK-16P696-A102 BK-16P698-A103 BK-16P697-A104 BK-16
E976-A105 BK-16E976-A106 BK-16E976-A107 BK-16E976-A108 BK-16
E976-A109 BK-16
E978-A110 BK-16E978-A111 BK-16E977-A112 BK-16E977-A113 BK-16
C130-A114 BK-16C130-A115 BK-16
A310-A092 BK-16
A330-A224 BK-16
385-A260 BK-16
J022-L29 BK-16J021-L28 RD-16
J122-L14 BK-16J121-L13 RD-16
J042-L26 BK-16J041-L25 RD-16
J162-L08 BK-16J161-L07 RD-16
385-A361 BK-16
IGNITION CYLINDER 14 (+)IGNITION CYLINDER 14 (-)
IGNITION CYLINDER 16 (+)IGNITION CYLINDER 16 (-)
IGNITION CYLINDER 18 (+)IGNITION CYLINDER 18 (-)
IGNITION CYLINDER 20 (+)IGNITION CYLINDER 20 (-)
IGNITION CYLINDER 4 (+)IGNITION CYLINDER 4 (-)
IGNITION CYLINDER 6 (+)IGNITION CYLINDER 6 (-)
IGNITION CYLINDER 8 (+)IGNITION CYLINDER 8 (-) J082-L20 BK-16
J081-L19 RD-16
J202-L02 BK-16J201-L01 RD-16
J102-L17 BK-16J101-L16 RD-16
J182-L05 BK-16J181-L04 RD-16
J062-L23 BK-16J061-L22 RD-16
J142-L11 BK-16J141-L10 RD-16
J022-L29 BK-16J021-L28 RD-16
J122-L14 BK-16J121-L13 RD-16
J042-L26 BK-16J041-L25 RD-16
J162-L08 BK-16J161-L07 RD-16
J082-L20 BK-16J081-L19 RD-16
J202-L02 BK-16J201-L01 RD-16
J102-L17 BK-16J101-L16 RD-16
J182-L05 BK-16J181-L04 RD-16
J062-L23 BK-16J061-L22 RD-16
J043-L27 CU-16J023-L30 CU-16
J083-L21 CU-16J063-L24 CU-16
J163-L09 CU-16J143-L12 CU-16
J203-L03 CU-16J183-L06 CU-16
J123-L15 CU-16J103-L18 CU-16
J033-R27 CU-16J013-R30 CU-16
J073-R21 CU-16J053-R24 CU-16
J153-R09 CU-16J133-R12 CU-16
J193-R03 CU-16J173-R06 CU-16
J113-R15 CU-16J093-R18 CU-16
J142-L11 BK-16J141-L10 RD-16
J012-R29 BK-16J011-R28 RD-16
J112-R14 BK-16J111-R13 RD-16
J032-R26 BK-16J031-R25 RD-16
J152-R08 BK-16J151-R07 RD-16
J072-R20 BK-16J071-R19 RD-16
J192-R02 BK-16J191-R01 RD-16
J092-R17 BK-16J091-R16 RD-16
J172-R05 BK-16J171-R04 RD-16
J052-R23 BK-16J051-R22 RD-16
J132-R11 BK-16J131-R10 RD-16
J012-R29 BK-16J011-R28 RD-16
J112-R14 BK-16J111-R13 RD-16
J032-R26 BK-16J031-R25 RD-16
J152-R08 BK-16J151-R07 RD-16
J072-R20 BK-16J071-R19 RD-16
J192-R02 BK-16J191-R01 RD-16
J092-R17 BK-16J091-R16 RD-16
J172-R05 BK-16J171-R04 RD-16
J052-R23 BK-16J051-R22 RD-16
J132-R11 BK-16J131-R10 RD-16
J022-L29 BK-16
J021-L28 RD-16
J122-L14 BK-16
J121-L13 RD-16
J042-L26 BK-16
J041-L25 RD-16
J162-L08 BK-16
J161-L07 RD-16
J082-L20 BK-16
J081-L19 RD-16
J202-L02 BK-16
J201-L01 RD-16
J102-L17 BK-16
J101-L16 RD-16
J182-L05 BK-16
J181-L04 RD-16
J062-L23 BK-16
J061-L22 RD-16
J142-L11 BK-16
J141-L10 RD-16
J043-L27 CU-16
J023-L30 CU-16
J083-L21 CU-16
J063-L24 CU-16
J163-L09 CU-16
J143-L12 CU-16
J203-L03 CU-16
J183-L06 CU-16
J123-L15 CU-16
J103-L18 CU-16
J022-LE29 BK-16
J021-LE28 RD-16
J122-LE14 BK-16
J121-LE13 RD-16
J042-LE26 BK-16
J041-LE25 RD-16
J162-LE08 BK-16
J161-LE07 RD-16
J082-LE20 BK-16
J081-LE19 RD-16
J202-LE02 BK-16
J201-LE01 RD-16
J102-LE17 BK-16
J101-LE16 RD-16
J182-LE05 BK-16
J181-LE04 RD-16
J062-LE23 BK-16
J061-LE22 RD-16
J142-LE11 BK-16
J141-LE10 RD-16
J043-LE27 CU-16
J023-LE30 CU-16
J083-LE21 CU-16
J063-LE24 CU-16
J163-LE09 CU-16
J143-LE12 CU-16
J203-LE03 CU-16
J183-LE06 CU-16
J123-LE15 CU-16
J103-LE18 CU-16
J012-R29 BK-16
J011-R28 RD-16
J112-R14 BK-16
J111-R13 RD-16
J032-R26 BK-16
J031-R25 RD-16
J152-R08 BK-16
J151-R07 RD-16
J072-R20 BK-16
J071-R19 RD-16
J192-R02 BK-16
J191-R01 RD-16
J092-R17 BK-16
J091-R16 RD-16
J172-R05 BK-16
J171-R04 RD-16
J052-R23 BK-16
J051-R22 RD-16
J132-R11 BK-16
J131-R10 RD-16
J033-R27 CU-16
J013-R30 CU-16
J073-R21 CU-16
J053-R24 CU-16
J153-R09 CU-16
J133-R12 CU-16
J193-R03 CU-16
J173-R06 CU-16
J113-R15 CU-16
J093-R18 CU-16
J012-RE29 BK-16
J011-RE28 RD-16
J112-RE14 BK-16
J111-RE13 RD-16
J032-RE26 BK-16
J031-RE25 RD-16
J152-RE08 BK-16
J151-RE07 RD-16
J072-RE20 BK-16
J071-RE19 RD-16
J192-RE02 BK-16
J191-RE01 RD-16
J092-RE17 BK-16
J091-RE16 RD-16
J172-RE05 BK-16
J171-RE04 RD-16
J052-RE23 BK-16
J051-RE22 RD-16
J132-RE11 BK-16
J131-RE10 RD-16
J033-RE27 CU-16
J013-RE30 CU-16
J073-RE21 CU-16
J053-RE24 CU-16
J153-RE09 CU-16
J133-RE12 CU-16
J193-RE03 CU-16
J173-RE06 CU-16
J113-RE15 CU-16
J093-RE18 CU-16
J043-L27 CU-16J023-L30 CU-16
J083-L21 CU-16J063-L24 CU-16
J163-L09 CU-16J143-L12 CU-16
J203-L03 CU-16J183-L06 CU-16
J123-L15 CU-16J103-L18 CU-16
J033-R27 CU-16J013-R30 CU-16
J073-R21 CU-16J053-R24 CU-16
J153-R09 CU-16J133-R12 CU-16
J193-R03 CU-16J173-R06 CU-16
J113-R15 CU-16J093-R18 CU-16
150-A210 BK-16229-A193 BK-16
D100-A194 BK-16D100-A195 BK-16
R779-A196 BK-16
150-A198 BK-16R779-A197 BK-16
999-A200 BK-16
996-A202 BK-16
997-A204 BK-16150-A142 BK-16150-A143 BK-16
150-A144 BK-16150-A205 BK-16
150-A145 BK-16
150-A259 BK-16
229-A149 BK-16
229-A150 BK-16
229-A151 BK-16150-A259 BK-16229-A152 BK-16150-A205 BK-16
J1939Y2-A086 YL-19
D100-A072 BK-16D100-A077 BK-16
G256-A080 BK-16
999-A085 BK-16
150-A230 BK-16
150-A230 BK-16
150-A131 BK-16150-A132 BK-16
150-A133 BK-16
150-A134 BK-16
229-A135 BK-16
229-A136 BK-16
229-A137 BK-16
229-A138 BK-16P231-A156 BK-16
J1939SH2-A165 CU-19
J1939G2-A164 GN-19
TWISTED PAIR
_R_F
J-C2
1402052
1352942
J E AC_V_Q_E H B _U_JAF Y O AD_W T K _D D _G X C F _B_M S N L U _P_SAB_C_N A_Z
_X G _H_TAAAG P Z _YAE M V _A_K W R
_R_F
J-C1
1509597
J E AC_V_Q_E H B _U_JAF Y O AD_W T K _D D _G X C F _B_M S N L U _P_SAB_C_N A_Z
_X G _H_TAAAG P Z _YAE M V _A_K W R
S0816-J01 RD-18
S0830-J03 YL-18
S0803-J04 RD-18
S0816-J06 YL-18
S0809-J02 RD-18
S0830-J05 RD-18
S0809-J07 YL-18
S0803-J08 YL-18
S0819-J09 RD-18
S0806-J10 RD-18
S0841-J11 YL-18
S0815-J12 RD-18
S0810-J13 RD-18
S0802-J14 YL-18
S0841-J15 RD-18
S0819-J16 YL-18
S0806-J17 YL-18
S0802-J18 RD-18
S0831-J19 RD-18
S0815-J20 YL-18
S0810-J21 YL-18
S0804-J22 RD-18
S0840-J23 RD-18
S0818-J24 RD-18
S0807-J25 RD-18
S0801-J26 RD-18
S0831-J27 YL-18
S0814-J28 RD-18
S0811-J29 RD-18
S0804-J30 YL-18
S0840-J31 YL-18
S0818-J32 YL-18
S0807-J33 YL-18
S0801-J34 YL-18
S0820-J35 RD-18
S0814-J36 YL-18
S0811-J37 YL-18
S0805-J38 RD-18
S0817-J39 RD-18
S0808-J40 RD-18
S0812-J48 YL-18
S0813-J47 YL-18
S0808-J46 YL-18
S0817-J45 YL-18
S0805-J44 YL-18
S0820-J43 YL-18
S0812-J42 RD-18
S0813-J41 RD-18
S0816-F32 RD-18
S0830-F43 YL-18
S0803-F06 RD-18
S0816-F31 YL-18
S0809-F18 RD-18
S0830-F44 RD-18
S0809-F17 YL-18
S0803-F05 YL-18
S0819-F38 RD-18
S0806-F12 RD-18
S0841-F45 YL-18
S0815-F30 RD-18
S0810-F20 RD-18
S0802-F03 YL-18
S0841-F46 RD-18
S0819-F37 YL-18
S0806-F11 YL-18
S0802-F04 RD-18
S0831-F42 RD-18
S0815-F29 YL-18
S0810-F19 YL-18
S0804-F08 RD-18
S0840-F48 RD-18
S0818-F36 RD-18
S0807-F14 RD-18
S0801-F02 RD-18
S0831-F41 YL-18
S0814-F28 RD-18
S0811-F22 RD-18
S0804-F07 YL-18
S0840-F47 YL-18
S0818-F35 YL-18
S0807-F13 YL-18
S0801-F01 YL-18
S0820-F40 RD-18
S0814-F27 YL-18
S0811-F21 YL-18
S0805-F10 RD-18
S0817-F34 RD-18
S0808-F16 RD-18
S0812-F23 YL-18
S0813-F25 YL-18
S0808-F15 YL-18
S0817-F33 YL-18
S0805-F09 YL-18
S0820-F39 YL-18
S0812-F24 RD-18
S0813-F26 RD-18
CBL-J01
CBL-J05
CBL-J03
CBL-J07
CBL-J09
CBL-J13
CBL-J11
CBL-J15
CBL-J17
CBL-J19
CBL-J31
CBL-J30
CBL-J40
CBL-J41
CBL-J20
CBL-J18
CBL-J16
CBL-J14
CBL-J12
CBL-J10
CBL-J08
CBL-J06
CBL-J04
CBL-J02
BC A
J1939SH1-A203 CU-19
J1939G1-A201 GN-19
J1939Y1-A199 YL-19
LAMP 17G-9730
LAMP 27G-9730
LAMP 37G-9730
LAMP 47G-9730
SWITCH8D-2676
2 3
1
229-A212 BK-16
150-A251 BK-16
150-A251 BK-16
150-A252 BK-16
150-A252 BK-16
150-A253 BK-16
150-A253 BK-16
150-A254 BK-16
150-A254 BK-16
229-A255 BK-16
229-A255 BK-16
229-A256 BK-16
229-A256 BK-16229-A257 BK-16 229-A257 BK-16
229-A258 BK-16
229-A258 BK-16
150-A207 BK-16
A-S29
E-STOPSWITCH
1 2 3 214 5 6 7 8 9 10
121314151617181920
11
222324252627282930
323334353637
31 1 2 3 214 5 6 7 8 9 10
121314151617181920
11
222324252627282930
323334353637383940
31
1 2 3 214 5 6 7 8 9 10
121314151617181920
11
222324252627282930
323334353637
31
A-S16
A-S28
1 2 3 4 5 6 7 8 9 101112131415161718192021222324 25
262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970
P501-A003 BK-16
M975-A012 BK-16
A447-A022 BK-16
A620-A040 BK-16
229-A148 BK-16
229-A167 BK-16
A330-A099 BK-16
A620-A153 BK-16
A620-A154 BK-16
A998-A090 BK-16
A998-A091 BK-16
C293-A100 BK-16
K995-A007 BK-16
G853-A011 BK-16
B829-A020 BK-16
C130-A114 BK-16
C130-A115 BK-16
X809-A096 BK-16
E796-A019 BK-16
999-A084 BK-16
150-A140 BK-16
150-A141 BK-16
A310-A098 BK-16
A310-A092 BK-16
994-A017 BK-16
996-A030 BK-16
P500-A081 BK-16
P500-A082 BK-16
P231-A155 BK-16
P401-A054 BK-16
P401-A065 BK-16
P401-A051 BK-16
P401-A053 BK-16
P401-A052 BK-16
P501-A069 BK-16
P501-A070 BK-16
P501-A063 BK-16
P501-A064 BK-16
P501-A061 BK-16
P501-A062 BK-16
P501-A059 BK-16
P501-A060 BK-16
P501-A067 BK-16
P501-A068 BK-16
P501-A057 BK-16
P501-A058 BK-16
P501-A055 BK-16
P501-A056 BK-16
P501-A003 BK-16
M975-A012 BK-16
A447-A022 BK-16
A620-A040 BK-16
229-A148 BK-16
229-A167 BK-16
A330-A099 BK-16
P270-A161 BK-16
A330-A097 BK-16
A620-A153 BK-16
A620-A154 BK-16
A998-A090 BK-16
A998-A091 BK-16
C293-A100 BK-16
K995-A007 BK-16
G853-A011 BK-16
B829-A020 BK-16
C130-A114 BK-16
C130-A115 BK-16
X809-A096 BK-16
E796-A019 BK-16
999-A084 BK-16
150-A140 BK-16
150-A141 BK-16
A310-A098 BK-16
A310-A092 BK-16
994-A017 BK-16
996-A030 BK-16
P500-A081 BK-16
P500-A082 BK-16
P231-A155 BK-16
P234-A160 BK-16
P270-A161 BK-16
A330-A097 BK-16
P234-A160 BK-16
P270-A161 BK-16
A330-A097 BK-16
P234-A160 BK-16
A-C8
9X1343
P-8
8T9834 1 2 3 214 5 6 7 8 9 10
121314151617181920
11
222324252627282930
323334353637383940
31
P401-A054 BK-16
P401-A065 BK-16
P401-A051 BK-16
P401-A053 BK-16
P401-A052 BK-16
P501-A069 BK-16
P501-A070 BK-16
P501-A063 BK-16
P501-A064 BK-16
P501-A061 BK-16
P501-A062 BK-16
P501-A059 BK-16
P501-A060 BK-16
P501-A067 BK-16
P501-A068 BK-16
P501-A057 BK-16
P501-A058 BK-16
P501-A055 BK-16
P501-A056 BK-16
S130-RD-16
S000-WH-16
A620-RD-16
P300B-BK-16
P3OOC-BK-16
A331-BK-16
P270-RD-16
A330-BK-16
A620-BK-16
A620-CU-16
S850-BK-16
S850-CU-16
S110-WH-16
S010-WH-16
S030-RD-16
S130-WH-16
C130-WH-16
S100-WH-16
S850-WH-16
P200B-RD-16
P200A-RD-16
P6B1-BK-16
P6B0A-RD-16
S101-WH-16
S850-RD-16
P500-BK-16
P231-RD-16
P234-RD-16
S100-RD-16
S110-RD-16
S010-RD-16
S000-RD-16
S101-RD-16
S110-BK-16
S110-CU-16
S000-CU-16
S100-CU-16
S000-BK-16
S100-BK-16
S101-BK-16
S101-CU-16
S130-BK-16
S130-CU-16
S030-BK-16
S030-CU-16
S010-BK-16
S010-CU-16
E978-A189 BK-16
E977-A126 BK-16
E977-A128 BK-16
E977-A127 BK-16
E977-A129 BK-16
E977-A130 BK-16
E977-A168 BK-16
E977-A170 BK-16
E977-A169 BK-16
E977-A171 BK-16
E977-A172 BK-16
E978-A124 BK-16
E978-A125 BK-16
E978-A122 BK-16
E978-A123 BK-16
E978-A120 BK-16
E978-A121 BK-16
E978-A118 BK-16
E978-A119 BK-16
E978-A116 BK-16
E978-A117 BK-16
E978-A188 BK-16
E978-A178 BK-16
E978-A179 BK-16
E978-A186 BK-16
E978-A187 BK-16
E978-A177 BK-16
E978-A185 BK-16
E978-A175 BK-16
E978-A176 BK-16
E976-A105 BK-16
E976-A106 BK-16
E976-A107 BK-16
E976-A108 BK-16
E976-A109 BK-16
E976-A180 BK-16
E976-A181 BK-16
E976-A182 BK-16
E976-A183 BK-16
E976-A184 BK-16
E978-A189 BK-16
E977-A126 BK-16
E977-A128 BK-16
E977-A127 BK-16
E977-A129 BK-16
E977-A130 BK-16
E977-A168 BK-16
E977-A170 BK-16
E977-A169 BK-16
E977-A171 BK-16
E977-A172 BK-16
E978-A124 BK-16
E978-A125 BK-16
E978-A122 BK-16
E978-A123 BK-16
E978-A120 BK-16
E978-A121 BK-16
E978-A118 BK-16
E978-A119 BK-16
E978-A116 BK-16
E978-A117 BK-16
E978-A188 BK-16
E978-A178 BK-16
E978-A179 BK-16
E978-A186 BK-16
E978-A187 BK-16
E978-A177 BK-16
E978-A185 BK-16
E978-A175 BK-16
E978-A176 BK-16
E976-A105 BK-16
E976-A106 BK-16
E976-A107 BK-16
E976-A108 BK-16
E976-A109 BK-16
E976-A180 BK-16
E976-A181 BK-16
E976-A182 BK-16
E976-A183 BK-16
E976-A184 BK-16
E978-A189 BK-16
S381-G05 RD-16
S383-G13 RD-16
S385-G21 RD-16
S387-G29 RD-16
S389-G37 RD-16
S380-G01 RD-16
S382-G09 RD-16
S384-G17 RD-16
S386-G25 RD-16
S388-G33 RD-16
S381-G07 BK-16
S383-G15 BK-16
S385-G23 BK-16
S387-G31 BK-16
S389-G39 BK-16
S380-G03 BK-16
S382-G11 BK-16
S384-G19 BK-16
S386-G27 BK-16
S388-G35 BK-16
S381-G06 WH-16
S383-G14 WH-16
S385-G22 WH-16
S387-G30 WH-16
S389-G38 WH-16
S380-G02 WH-16
S382-G10 WH-16
S384-G18 WH-16
S386-G26 WH-16
S388-G34 WH-16
S381-G08 CU-16
S383-G16 CU-16
S385-G24 CU-16
S387-G32 CU-16
S389-G40 CU-16
S380-G04 CU-16
S382-G12 CU-16
S384-G20 CU-16
S386-G28 CU-16
S388-G36 CU-16
A-C9
J-9
9X0145
7X6222
1 2 3 214 5 6 7 8 9 10
121314151617181920
11
222324
229-A214 BK-16
M153-A029 BK-16
M152-A028 BK-16
R779-A196 BK-16
R779-A197 BK-16
J1939SH3-A162 CU-19
J1939Y3-A087 YL-19
J1939G3-A163 GN-19
150-A210 BK-16
999-A200 BK-16
996-A202 BK-16
997-A204 BK-16
229-A214 BK-16
M153-A029 BK-16
M152-A028 BK-16
R779-A196 BK-16
R779-E01 WH-18
R779-A197 BK-16
R779-E02 WH-18
J1939SH3-A162 CU-19
J1939Y3-A087 YL-19
J1939G3-A163 GN-19
150-A210 BK-16
999-A200 BK-16
996-A202 BK-16
997-A204 BK-16
J843-E10 BK-18
M300A-WH-16
M300B-BK-16
D200A-CU-19
D200A-YL-19
D200A-GN-19
R997-E06 RD-18
999-E03 WH-18
996-E07 RD-18
997-E13 BK-18
R779-E01 WH-18R779-E02 WH-18
J843-E10 BK-18
M300A-WH-16M300B-BK-16
D200A-CU-19
D200A-YL-19D200A-GN-19
M300A-WH-16M300B-BK-16
D200A-CU-19
D200A-YL-19D200A-GN-19
D200A-CU-19
D200A-YL-19D200A-GN-19
R997-E06 RD-18
999-E03 WH-18996-E07 RD-18
997-E13 BK-18
R779-E01 WH-18R779-E02 WH-18
J843-E10 BK-18J843-E08 BK-18
R997-E06 RD-18R997-E04 RD-18
J843-E09 BK-18
R997-E05 RD-18
999-E03 WH-18
996-E07 RD-18
997-E13 BK-18
R779-E01 WH-18
R779-E02 WH-18
J843-E08 BK-18R997-E04 RD-18
R779-E01 WH-18J843-E08 BK-18R997-E04 RD-18
J843-E09 BK-18R997-E05 RD-18
R779-E02 WH-18
J843-E09 BK-18
R997-E05 RD-18
999-E03 WH-18997-E13 BK-18
996-E07 RD-18
999-E03 WH-18
997-E13 BK-18
A-S17
S381-G05 RD-16
S383-G13 RD-16
S385-G21 RD-16
S387-G29 RD-16
S389-G37 RD-16
S380-G01 RD-16
S382-G09 RD-16
S384-G17 RD-16
S386-G25 RD-16
S388-G33 RD-16
S381-G07 BK-16
S383-G15 BK-16
S385-G23 BK-16
S387-G31 BK-16
S389-G39 BK-16
S380-G03 BK-16
S382-G11 BK-16
S384-G19 BK-16
S386-G27 BK-16
S388-G35 BK-16
S381-G06 WH-16
S383-G14 WH-16
S385-G22 WH-16
S387-G30 WH-16
S389-G38 WH-16
S380-G02 WH-16
S382-G10 WH-16
S384-G18 WH-16
S386-G26 WH-16
S388-G34 WH-16
S381-G08 CU-16
S383-G16 CU-16
S385-G24 CU-16
S387-G32 CU-16
S389-G40 CU-16
S380-G04 CU-16
S382-G12 CU-16
S384-G20 CU-16
S386-G28 CU-16
S388-G36 CU-16
A B CA B CA B CA B C
S381-G07 BK-16
S381-G06 WH-16
S381-G08 CU-16
A B C
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
DETONATION
SENSOR
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
+8
COM
SIG
8T-8732
8T-8732
8T-8732
8T-8732
8T-8732
A B C A B C
8T-8732
8T-8732
8T-8732
8T-8732
8T-8732
LEFT SIDE DETONATION
RIGHT SIDE DETONATION
CYL NO.18 & 20
CYL NO.14 & 16
CYL NO.10 & 12
CYL NO.6 & 8
CYL NO.2 & 4
CYL NO.1 & 3
CYL NO.5 & 7
CYL NO.9 & 11
CYL NO.13 & 15
CYL NO.17 & 19
S381-G05 RD-16
S383-G15 BK-16
S383-G14 WH-16
S383-G16 CU-16
S383-G13 RD-16
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
DETONATION
SENSOR
195-2431
S385-G23 BK-16
S385-G22 WH-16
S385-G24 CU-16
S385-G21 RD-16
S387-G31 BK-16
S387-G30 WH-16
S387-G32 CU-16
S387-G29 RD-16
S389-G39 BK-16
S389-G38 WH-16
S389-G40 CU-16
S389-G37 RD-16
S380-G01 RD-16
S380-G03 BK-16
S380-G02 WH-16
S380-G04 CU-16
S382-G09 RD-16
S382-G11 BK-16
S382-G10 WH-16
S382-G12 CU-16
S384-G17 RD-16
S384-G19 BK-16
S384-G18 WH-16
S384-G20 CU-16
S386-G25 RD-16
S386-G27 BK-16
S386-G26 WH-16
S386-G28 CU-16
S388-G33 RD-16
S388-G35 BK-16
S388-G34 WH-16
S388-G36 CU-16
A B C A B C A B C
S0816-F32 RD-18
S0830-F43 YL-18
S0803-F06 RD-18
S0816-F31 YL-18
S0809-F18 RD-18
S0830-F44 RD-18
S0809-F17 YL-18
S0803-F05 YL-18
S0819-F38 RD-18
S0806-F12 RD-18
S0841-F45 YL-18
S0815-F30 RD-18
S0810-F20 RD-18
S0802-F03 YL-18
S0841-F46 RD-18
S0819-F37 YL-18
S0806-F11 YL-18
S0802-F04 RD-18
S0831-F42 RD-18
S0815-F29 YL-18
S0810-F19 YL-18
S0804-F08 RD-18
S0840-F48 RD-18
S0818-F36 RD-18
S0807-F14 RD-18
S0801-F02 RD-18
S0831-F41 YL-18
S0814-F28 RD-18
S0811-F22 RD-18
S0804-F07 YL-18
S0840-F47 YL-18
S0830-F43 YL-18S0830-F44 RD-18
S0841-F45 YL-18S0841-F46 RD-18
S0831-F42 RD-18
S0840-F48 RD-18
S0831-F41 YL-18
S0840-F47 YL-18
S0818-F35 YL-18
S0807-F13 YL-18
S0801-F01 YL-18
S0820-F40 RD-18
S0814-F27 YL-18
S0811-F21 YL-18
S0805-F10 RD-18
S0817-F34 RD-18
S0808-F16 RD-18
S0812-F23 YL-18
S0813-F25 YL-18
S0808-F15 YL-18
S0817-F33 YL-18
S0805-F09 YL-18
S0820-F39 YL-18
S0812-F24 RD-18
S0813-F26 RD-18
S0803-F06 RD-18
S0809-F17 RD-18
S0809-F18 YL-18
S0803-F05 YL-18
S0819-F38 RD-18
S0815-F30 RD-18
S0819-F37 YL-18
S0815-F29 YL-18
S0807-F13 RD-18
S0801-F02 RD-18
S0811-F21 RD-18
S0807-F14 YL-18
S0801-F01 YL-18
S0811-F22 YL-18
S0805-F09 RD-18
S0817-F34 RD-18
S0813-F25 YL-18
S0817-F33 YL-18
S0805-F10 YL-18
S0813-F26 RD-18
CYL #19
THERMOCOUPLE
207-2371
CYL #17
THERMOCOUPLE
207-2371
CYL #15
THERMOCOUPLE
207-2371
CYL #13
THERMOCOUPLE
207-2371
CYL #11
THERMOCOUPLE
207-2371
CYL #9
THERMOCOUPLE
207-2371
CYL #7
THERMOCOUPLE
207-2371
CYL #5
THERMOCOUPLE
207-2371
CYL #3
THERMOCOUPLE
207-2371
CYL #1
THERMOCOUPLE
207-2371
RIGHT SIDE THERMOCOUPLES
CBA CBA
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
CYL #2
THERMOCOUPLE
207-2371
CYL #4
THERMOCOUPLE
207-2371
CYL #6
THERMOCOUPLE
207-2371
CYL #8
THERMOCOUPLE
207-2371
CYL #10
THERMOCOUPLE
207-2371
CYL #12
THERMOCOUPLE
207-2371
CYL #14
THERMOCOUPLE
207-2371
CYL #16
THERMOCOUPLE
207-2371
CYL #18
THERMOCOUPLE
207-2371
CYL #20
THERMOCOUPLE
207-2371
LEFT SIDE THERMOCOUPLES
CBA CBA CBA CBACBACBA CBA CBA
CBA CBA
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
8T-8731
CBA CBA CBA CBACBACBA CBA CBA
S0816-F32 RD-18
S0816-F31 YL-18
S0806-F12 RD-18
S0810-F20 RD-18
S0802-F03 YL-18
S0806-F11 YL-18
S0802-F04 RD-18
S0810-F19 YL-18
S0804-F08 RD-18
S0818-F36 RD-18
S0814-F28 RD-18
S0804-F07 YL-18
S0818-F35 YL-18
S0820-F40 RD-18
S0814-F27 YL-18
S0808-F16 RD-18
S0812-F23 YL-18
S0808-F15 YL-18
S0820-F39 YL-18
S0812-F24 RD-18
LEFT TURBO IN
TURBO OUT(LEFT)
RIGHT TURBO IN
CBA
60HZ
50HZ
ABC
CBA
ABC
ABC
CBA
ABC
RIGHT TURBO IN
RIGHT TURBO OUT
LEFT TURBO OUT
LEFT TURBO IN
THERMOCOUPLE207-2371
THERMOCOUPLE207-2371
THERMOCOUPLE152-0807
THERMOCOUPLE152-0807
THERMOCOUPLE152-0807
THERMOCOUPLE152-0807
THERMOCOUPLE152-0807
TURBO THERMOCOUPLES
S0830-F43 YL-18
S0830-F44 RD-18
S0841-F46 YL-18
S0841-F45 RD-18
S0831-F42 RD-18
S0831-F41 YL-18
CUSTOMER B+
N.O. E-STOP
KILOWATT INPUT
KILOWATT RETURN
KILOWATT SHIELD
CONTROL/KEY BATT+
SPD. POT. +5VOLTS
GAS BTU SOURCE
CAT DATA LINK + CUST. CON.
TIMING SETTING
DRIVEN EQUIPMENT
N.C. E-STOP
CUSTOMER CON. B-
N.O. E-STOP JUMPER
SWT CONTROL/KEY BATT+ IN
SPD. POT. COM.
GAS BTU RETURN
CAT DATA LINK - CUST. CON.
MANUAL PRELUBE
N.C. E-STOP
STOP
GAS S/O VALVE +
RUN RELAY
ENGINE FAILURE
GAS SHUTOFF -
SPD. POT. SIG.
ALM/SHUTDOWN
DESIRED SPD 4-20 IN - (OPTIONAL)
ON/OFF GRID SWITCH IN
START
NORMAL STOP
GAS S/O VALVE +
CRANK TERMINATE
ACTIVE ALARM
ALM/SHUTDOWN RETURN
SPD. POT. SHIELD
DIGITAL RETURN MODE SWITCH
DESIRED SPD 4-20 IN + (OPTIONAL)
IDLE/RATED
AUTO
S000-WH-16
A620-RD-16
P300B-BK-16P3OOC-BK-16
A331-BK-16
P270-RD-16
A330-BK-16
A620-BK-16A620-CU-16
S010-WH-16
C130-WH-16
S100-WH-16S100-CU-16
P200B-RD-16P200A-RD-16P6B1-BK-16P6B0A-RD-16
P500-BK-16
P231-RD-16
P234-RD-16
P300B-BK-16P3OOC-BK-16
P300B-BK-16P3OOC-BK-16
P270-RD-16
P200B-RD-16P200A-RD-16
P200A-RD-16P200B-RD-16
P6B1-BK-16P6B0A-RD-16
P6B0A-RD-16
P234-RD-16
P200C-RD-16P300D-BK-16
P300D-BK-16
P2A0-RD-14P3A1-BK-14
P3A1-BK-14
P2A1-RD-14
P2A1-RD-14
P2A1-RD-14P2A0-RD-14
P3A0-BK-14
P3A0-BK-14
P200C-RD-16
P300D-BK-16
P2A0-RD-14
P3A1-BK-14
P2A1-RD-14
P3A0-BK-14
S100-RD-16
S110-RD-16
S010-RD-16
S000-RD-16
S110-BK-16S110-WH-16S110-CU-16
S000-CU-16
S000-BK-16S000-WH-16
A620-RD-16A620-BK-16A620-CU-16
P231-RD-16
S110-RD-16
S000-RD-16
S110-BK-16S110-WH-16S110-CU-16
S000-CU-16
S000-BK-16
S100-BK-16
S101-WH-16S101-CU-16
S101-RD-16S101-BK-16
M300A-WH-16
M300B-BK-16
C130-WH-16
S100-WH-16
S100-CU-16
P500-BK-16
S100-RD-16
S100-BK-16
S101-WH-16
S101-CU-16
S101-RD-16
S101-BK-16
S130-CU-16S130-RD-16S130-BK-16S130-WH-16S030-CU-16S030-RD-16S030-BK-16S850-CU-16S850-RD-16S850-BK-16S850-WH-16
S010-BK-16
S010-CU-16
A331-BK-16
A330-BK-16
S010-WH-16
S010-RD-16
S130-CU-16
S130-RD-16
S130-BK-16
S130-WH-16
S030-CU-16
S030-RD-16
S030-BK-16
S850-CU-16
S850-RD-16
S850-BK-16
S850-WH-16
S010-BK-16
S010-CU-16
E-S1
E-S2
E-C2
3E3370
1042921
E-C13E3370
E-C3
9D3955
3E3364
1552269
8T8732
8T8732
8T8732
8T8731
8T8731
8T8731
M300A-WH-16
M300B-BK-16
C130-WH-16
S100-WH-16
S100-CU-16
P500-BK-16
S100-RD-16
S100-BK-16
S101-WH-16
S101-CU-16
S101-RD-16
S101-BK-16
8T8732
8T8731
S000-WH-16
S000-CU-16
S000-RD-16
S000-BK-16
8T8732
8T8731
S010-WH-16
S010-CU-16
S010-RD-16
S010-BK-16
8T8732
8T8731
S850-WH-16
S850-CU-16
S850-RD-16
S850-BK-16
8T8732
S130-WH-16
S130-CU-16
S130-RD-16
S130-BK-16
8T8732
8T8731
S110-WH-16
S110-CU-16
S110-RD-16
S110-BK-16
1042921
5S-7433
A330-BK-16
A331-BK-16
S030-RD-16
S030-CU-16
S030-BK-16
156-4588
D200A-CU-19
D200A-YL-19
D200A-GN-19
S000-WH-16
A620-RD-16
A620-BK-16
A620-CU-16
P231-RD-16
S110-RD-16
S000-RD-16
S110-BK-16
S110-WH-16
S110-CU-16
S000-CU-16
S000-BK-16
S000-WH-16
P200C-RD-16
P300D-BK-16
P2A0-RD-14
P3A1-BK-14
P3A2-BK-14
P3A3-BK-14
D200-BK-14
D200-BK-14
P2A1-RD-14
P2A1-RD-14
P3A0-BK-14
D200A-CU-19
D200A-YL-19
D200A-GN-19
A620-RD-16
A620-BK-16
A620-CU-16
P231-RD-16
D200B-GN-19
D200B-YL-19
P200C-RD-16
P300D-BK-16
P2A0-RD-14
P3A0-BK-14
D200A-YL-19
D200A-GN-19
A620-RD-16
A620-BK-16
A620-CU-16
P231-RD-16
D200B-CU-19
D200B-GN-19
D200B-YL-19
D200C-GN-19
D200C-YL-19
D200C-CU-19
P2A0-T8 RD-14
P3A0-T7 BK-14
D200B-T3 CU-19
D200B-T2 GN-19
D200B-T1 YL-19
D200C-T4 GN-19
D200C-T5 YL-19
D200C-T6 CU-19
S110-RD-16
S000-RD-16
S110-BK-16
S110-WH-16
S110-CU-16
S000-CU-16
S000-BK-16
BUSS BAR B+
233-7424
INTERNAL B+ STUD
EXTERNAL B+ STUD
INTERNAL B- STUD
EXTERNAL B- STUD
POWER DISTRIBUTION BOX
207-8496CIRCUIT BREAKER
207-8496STARTER BREAKER
207-8497CIRCUIT BREAKER
207-8498CIRCUIT BREAKER
9F-3099
MAGNETIC
SWITCH ASSY.
9F-3099
MAGNETIC
SWITCH ASSY.
SMMS 1
SMMS 2
P2A1-RD-14
P2A0-RD-14
P270-RD-16P234-RD-16
P2A0-RD-14
P270-RD-16
P234-RD-16
P234-RD-16
P270-RD-16
P200A-RD-16
P200B-RD-16
P200C-RD-16
P200A-RD-16P200B-RD-16P200C-RD-16
P200C-RD-16
P6B0A-RD-16
P6B0A-RD-16
P6B1-BK-16
P6B1-BK-16
P6B1-BK-16
C991-BK-16
C990-RD-16
P390-BK-08
P390-BK-08
P190-RD-08
P190-RD-08
P130-RD-08
P130-RD-08
P1B0A-RD-10
P1B0B-RD-10
P1B0B-RD-10
P1B0B-RD-10
P1B1A-RD-10
P1B1A-RD-10
P1B1B-RD-10
P1B1B-RD-10
P1B1B-RD-10
P6B0B-RD-16
GS
MTR
BAT
MOTOR
GS
MTR
BAT
MOTOR
THROTTLEPROACT #1
RAPTOR COMPRESSOR BYPASSPROACT #2
SPLICE #2 SPLICE #1
996-E07 RD-18
NOTE 1: THIS IS A CUSTOMER INSTALLED JUMPER.IT IS NEEDED IN ORDER FOR THE ENGINE TO RUN.
GN
-18
YL-
18O
R-1
8A CB
+VG
RO
UN
DS
IGN
AL
A
CB
+VGROUND
COMPRESSOR OUTPRESSURE SENSOR
SIGNAL
A CB+V G
RO
UN
D
SP
ED
DS
EN
SO
R19
3-55
17
SIG
NA
L
IMA
PS
EN
SO
R19
4-67
24
GN
-18
YL-
18O
R-1
8A CB
+VG
RO
UN
DS
IGN
AL
BK
-18
YL-
1821
GR
OU
ND
TIM
ING
CA
L
JAC
KE
T W
ATE
R IN
LET
PR
ES
SU
RE
SW
ITC
H11
0-11
68
GN
-18
YL-
18O
R-1
8A CB
OR
-18
BK
-18
WH
-18
B CA
+V+V
GR
OU
ND
SIG
NA
L
UN
FILT
ER
ED
OIL
PR
ES
SU
RE
SE
NS
OR
163-
8523
FILT
ER
ED
OIL
PR
ES
SU
RE
SE
NS
OR
163-
8523
H
CA
N D
ATA
LIN
K (-
)
CA
N D
ATA
LIN
K (-
) C
AN
DAT
A LI
NK
(-)
BAT
TER
Y (-
)
BAT
TER
Y (-
)
BAT
TER
Y (-
)
CA
N D
ATA
LIN
K (+
)
CA
N D
ATA
LIN
K (+
)C
AN
DAT
A LI
NK
(+)
CA
N D
ATA
LIN
K S
HIE
LDC
AN
DAT
A LI
NK
(-)
CA
N D
ATA
LIN
K (+
)
CA
N D
ATA
LIN
K S
HIE
LD
CA
N D
ATA
LIN
K (-
)C
AN
DAT
A LI
NK
(+)
CA
N D
ATA
LIN
K S
HIE
LD
BAT
TER
Y (+
)
BAT
TER
Y (+
)B
ATTE
RY
(-)
BAT
TER
Y (+
)
JGFEDCBA
H
PW
M S
IGN
AL
(-)
PW
M S
IGN
AL
(+)
KE
Y IN
JGFEDCB S TRPNMLKA H IGFEDCB PONMLKJA
INTE
RN
AL
TER
MIN
ATIN
GR
ES
ISTO
R
G IFOABMN LKJP HEDC
WH
-18
BK
-18
OR
-18
A CB+V G
RO
UN
DS
IGN
AL
OIL
TE
MP
ER
ATU
RE
SE
NS
OR
130-
8299
WH
-18
BK
-18
OR
-18
A CB+V G
RO
UN
DS
IGN
AL
WH
-18
BK
-18
OR
-18
A CB+V G
RO
UN
DS
IGN
AL
MA
NIF
OLD
AIR
INLE
T T
EM
PE
RAT
UR
E S
EN
SO
R13
0-82
99
A CB+V G
RO
UN
DS
IGN
AL
JAC
JET
WAT
ER
OU
T P
RE
SS
UR
E S
EN
SO
R13
0-82
99
SP
EE
D T
IMIN
G S
EN
SO
R26
5-90
34
WH
-18
BK
-18
OR
-18
A CB+V G
RO
UN
DS
IGN
AL
MA
PS
SE
NS
OR
194-
6724
GN-18YL-18OR-18
194-6724
BAG
RO
UN
D
GA
S S
HU
T/O
FF V
ALV
E
+V
1 2G
RO
UN
D
JAC
KE
T W
ATE
RTE
MP
ER
ATU
RE
SE
NS
OR
130-
9811
SIG
NA
L
35A
10A
2A
2A
NEG
POS
JUMPERS (SEE NOTE#1)
TERMINAL BOX
TERMINAL BOX
TERMINAL BOX
