56
DELL E173FP Service Manual 1 17” LCD Monitor DELL E173FP THESE DOCUMENTS ARE FOR REPAIR SERVICE INFORMATION ONLY. EVERY REASONABLE EFFORT HAS BEEN MADE TO ENSURE THE ACCURACY OF THIS MANUAL; WE CANNOT GUARANTEE THE ACCURACY OF THIS INFORMATION AFTER THE DATE OF PUBLICATION AND DISCLAIMS RE LIABILITY FOR CHANGES, ERRORS OR OMISSIONS. Prepared By: WuHaiyan Checked By: Sushi Manufacture Date: May-29-04 SERVICE MANUAL

Dell TFT-LCD Color Monitor E173FP Service Manual

  • Upload
    ivolai

  • View
    127

  • Download
    13

Embed Size (px)

Citation preview

Page 1: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

1

17” LCD Monitor

DELL E173FP

THESE DOCUMENTS ARE FOR REPAIR SERVICE INFORMATION ONLY. EVERY REASONABLE EFFORT HAS BEEN MADE TO ENSURE THE ACCURACY OF THIS MANUAL; WE CANNOT GUARANTEE THE ACCURACY OF THIS INFORMATION AFTER THE DATE OF PUBLICATION AND DISCLAIMS RE LIABILITY FOR CHANGES, ERRORS OR OMISSIONS.

Prepared By: WuHaiyan

Checked By: Sushi Manufacture Date: May-29-04

SERVICE MANUAL

Page 2: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

2

Table of Contents

Table of Contents -----------------------------------------------------------------------------------------------2

1. MONITOR SPECIFICATIONS -----------------------------------------------------------------------------4

2. LCD MONITOR DESCRIPTION -----------------------------------------------------------------------------5

3. OPERATING INSTRUCTIONS --------------------------------------------------------------------------6

3.1 GENERAL INSTRUCTIONS ----------------------------------------------------------------------------6

3.2 CONTROL BUTTONS ----------------------------------------------------------------------------------------6

3.3 ADJUSTING THE PICTURE ----------------------------------------------------------------------------7

4. Input/Output Specification--------------------------------------------------------------------------------------10

4.1 Input Signal Connector ----------------------------------------------------------------------------------------10

4.1.1 Analog D-SUB Connector ----------------------------------------------------------------------------------10

4.2 Factory Preset Display Modes ----------------------------------------------------------------------------10

4.3 Power Supply Requirements ----------------------------------------------------------------------------11

4.3.1 Input Requirements --------------------------------------------------------------------------------------11

4.3.2 Output Requirements ----------------------------------------------------------------------------------------11

4.4 PANEL SPECIFICATION -------------------------------------------------------------------------------------11

4.4.1 Panel Feature ----------------------------------------------------------------------------------------------11

4.4.2 Display Characteristics ----------------------------------------------------------------------------------11

4.4.3 Optical Characteristics --------------------------------------------------------------------------------12

4.4.4 Parameter guide line for CCFL Inverter --------------------------------------------------------------12

5. Block Diagram ----------------------------------------------------------------------------------------------------13

5.1 Monitor Exploded View ----------------------------------------------------------------------------------------13

5.2 Software Flow Chart ----------------------------------------------------------------------------------------14

5.3 Electrical Block Diagram --------------------------------------------------------------------------------16

5.3.1 Main Board ----------------------------------------------------------------------------------------------------16

5.3.2 Inverter/Power Board ----------------------------------------------------------------------------------------17

6. Schematic ----------------------------------------------------------------------------------------------------------18

6.1 Main Board --------------------------------------------------------------------------------------------------18

6.2 Inverter/Power Board --------------------------------------------------------------------------------------23

Page 3: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

3

7. PCB Layout ----------------------------------------------------------------------------------------------------25

7.1 Main Board --------------------------------------------------------------------------------------------------25

7.2 Inverter/Power Board --------------------------------------------------------------------------------------26

7.3 Keypad Board ----------------------------------------------------------------------------------------------------28

8. Maintainability -----------------------------------------------------------------------------------------------------29

8.1 Equipments and Tools Requirements ---------------------------------------------------------------------29

8.2 Trouble Shooting -----------------------------------------------------------------------------------------------30

8.2.1 Main Board ----------------------------------------------------------------------------------------------------30

8.2.2 Power/Inverter Board ---------------------------------------------------------------------------------------33

8.2.3 Key Pad Board ------------------------------------------------------------------------------------------------35

9. White-Balance, Luminance adjustment ---------------------------------------------------------------------36

10. EDIT Content ----------------------------------------------------------------------------------------------38

11. ISP User Manual-------------------------------------------------------------------------------------------------39

11.1. Connect ISP Writer preparation action-------------------------------------------------------------------39

11.2. To Use ISP WRITER-----------------------------------------------------------------------------------------39

11.3. Executing ISP--------------------------------------------------------------------------------------------------43 12. BOM List ----------------------------------------------------------------------------------------------------------44

Page 4: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

4

1. MONITOR SPECIFICATIONS Driving system TFT Color LCD

LCD Panel Size 43cm(17.0")

Pixel pitch 0.264mm(H) x 0.264mm(V)

Viewable angle 140˚ (H) 120˚ (V)

Response time (typ.) 16 ms

Video Analog Only

Input Sync. Type H/V TTL Separate and Composite Sync.

H-Frequency 30kHz – 80kHz

V-Frequency 56-75Hz

Display Colors Over 16.2 million Colors

Dot Clock 135MHz

Max. Resolution 1280 x 1024

Plug & Play VESA DDC2BTM

Power Consumption ON Mode

<35W

Power Saving

<2W

Maximum Screen Size Horizontal : 337.92mm Vertical: 270.336mm

Power Source 90~264VAC,47~63Hz

Environmental Considerations

Operating Temp: 0°C to 50°C Storage Temp.: -20°C to 60°C Operating Humidity: 10% to 90%

Weight (N. W.) Packaged 5.8Kgs Unit

Unpackaged 4.6Kgs Unit

Page 5: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

5

2. LCD MONITOR DESCRIPTION The LCD MONITOR will contain a main board, an internal inverter/power board, keypad board, which house the flat panel control logic, brightness control logic and DDC. The internal Inverter/power board will drive the backlight of panel and the DC-DC conversion. and provides the 12V DC-power to main board.

Inverter/Power Board

Flat Panel and

CCFL backlight

Main Board

Keyboard

RS232 Connector

For white balance

adjustment in

factory mode

HOST Computer

CCFT Driver.

Video signal, DDC

Monitor Block Diagram

AC Power IN

Page 6: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

6

3. OPERATING INSTRUCTIONS 3.1 GENERAL INSTRUCTIONS

Press the power button to turn the monitor on or off. The other control buttons are located at front panel of

the monitor. By changing these settings, the picture can be adjusted to your personal preferences.

- The power cord should be connected.

- Connect the video cable from the monitor to the video card.

- Press the power button to turn on the monitor, the power indicator will light up.

3.2 CONTROL BUTTONS - Power Button:

When pressed, the monitor enters the off mode, and the LED turns blank. Press again to restore normal status.

- Brightness Button: The Brightness Button is used to select the Brightness/Contrast adjust functions. Press to switch functions or adjust settings.

- Auto Adjust Key: The Auto Adjust Key is used to automatically set the H Position, V Position, Clock and Phase.

- Power Indicator: Green — Power On mode. Orange — Power Saving mode. Blank —Power Off Mode.

A. Buttons for the OSD menu (On-Screen-display) B. Brightness Button C. Auto Adjust Button D. Power On/Off Button and indicator

Control Buttons

Page 7: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

7

3.3 ADJUSTING THE PICTURE To set the OSD menu, perform the following steps: Briefly press the SELCT / MENU button to activate the OSD menu.

The main menu appears on the screen with icons for the setting functions.

The first symbol (Exit) is highlighted.

Necessary, press the - or + button to mark another icon (e.g. Positioning).

Press the SELECT/MENU button to select the highlighted icon.

The corresponding setting window (here: Positioning) is displayed.

The first symbol (Exit) is highlighted.

If necessary, press the – or + button to mark the desired icon.

Press the SELECT/MENU button to select the highlighted function.

Press the – or + button to adjust the value for the selected function.

Press the SELECT/MENU button to exit the function.

Press the SELECT/MENU button to exit the sub-menu when “Exit” function is highlighted;

All changes are stored automatically. Adjusting the brightness and contrast

Calling the Brightness / Contrast setting window using Brightness button.

Brightness

Setting the brightness of the display

With this function you change the brightness of the background lighting.

Contrast

Setting the contrast of the display

With this function you modify the contrast of bright colour tones.

Page 8: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

8

Adjusting size and position

Calling the Positioning setting window

H-Position Adjusting the horizontal position

With this function you move the picture to the left or to the right.

V-Position Adjusting the vertical position

With this function you move the picture up or down.

Setting Image

Calling the Image setting window

Auto

Adjust

Auto adjust will produce best image automatically, The information of “ Auto

Adjust In Progress” will show;

Pixel clock Adjusting the pixel clock

Phase Adjusting the phase

Setting colour temperature and colours

Calling the Color setting window

Selecting the colour temperature

The colour temperature is measured in K (= Kelvin). You can select from Normal

Preset, Blue Preset, Red Preset to User Preset;

Normal preset

Blue preset

Red preset

User preset

= Original colour of the LCD display, it’s 6500K;

=5700Kcolour of the LCD display, it’s 9300K;

=9300K colour of the LCD display, it’s 5700K;

= Setting user-defined colours

In the user preset setting you can change the colour ratios of the basic colours (red,

green, blue) as required.

Setting display of the OSD menu

Calling the OSD Set up setting window

Horizontal

Position

Setting the horizontal position of the OSD menu

With this function you move the OSD menu to the left or to the right.

Vertical

Position

Setting the vertical position of the OSD menu

With this function you move the OSD menu up or down.

Page 9: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

9

OSD

Hold

Time

Setting the display duration of the OSD menu

With this function you select a value from 0 to 60 seconds.

If the set time expires without a setting being made, the OSD menu is automatically

faded out.

OSD

Lock

Setting the display of the OSD menu lock or unlock.

With this function you select Yes to lock OSD, NO to unlock it.

Setting Language

Calling the Language setting window

With this function you choose between English (default setting), French, German,

Spanish and Japanese as the language for the OSD menu.

Factory Reset

Activating the factory settings

With this function all settings except Language of OSD are reset to the factory settings

without prompting for confirmation.

Page 10: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

10

4. Input/Output Specification 4.1 Input Signal Connector 4.1.1 Analog D-SUB Connector

1 6 2 7 3 8 4 9 5

11 12 13 14 1510

17 16

Pin Meaning Pin Meaning

1 Video input red 9 +5 V (DDC)

2 Video input green 10 VGA-PG

3 Video input blue 11 Ground

4 Ground 12 DDC-Data

5 Ground 13 H. Sync

6 Red video ground 14 V. Sync

7 Green video ground 15 DDC Clock

8 Blue video ground

4.2 Factory Preset Display Modes The following are the most frequently used of the preset operating modes:

Horizontal frequency Refresh rate Screen resolution

31.5 kHz

31.5 kHz

37.5 kHz

37.9 kHz

46.9 kHz

48.4 kHz

60.0 kHz

67.5KHz

64.0KHz

79.9KHz

70 Hz

60 Hz

75 Hz

60 Hz

75 Hz

60 Hz

75 Hz

75Hz

60Hz

75Hz

720 x 400

640 x 480

640 x 480

800 x 600

800 x 600

1024 x 768

1024 x 768

1152 x 864

1280 x 1024

1280 x 1024 For ergonomic reasons, a screen resolution of 1280 x 1024 pixels is recommended. Because of the

technology used (active matrix) an LCD monitor provides a totally flicker-free picture even with a refresh rate of

60 Hz.

Page 11: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

11

4.3 Power Supply Requirements 4.3.1 Input Requirements AC INPUT VOLTAGE: 90V ~ 264V

AC INPUT FREQUENCY: 47 ~ 63 HZ

AC INPUT CURRENT: 1.5A max.

INRUSH CURRENT: 60A MAX AT 264VAC COLD START

LEAKAGE CURRENT: 3.5 mA MAX and less then 0.25 mA at 100Vac

4.3.2 Output Requirements ITEM MIN. TYP. MAX. UNIT REMARK

Output voltage (12V) 11.4 12 12.6 V

Output current (12V) 0 2.0 3.0 A

Output voltage ( 5V) 4.75 5.0 5.25 V

Output current (5V) 0 1.5 2.0 A

Ripple & Noise (12V) 200 mV

Ripple & Noise (5V) 100 mV

4.4 PANEL SPECIFICATION 4.4.1 Panel Feature -High contrast ratio, high aperture structure

-Wide viewing angle

-High-speed response

-SXGA (1280 x 1024 pixels) resolution

-Low power consumption

4.4.2 Display Characteristics

Items Specification Unit Display Area 337.92x270.336 mm Driver element a-Si TFT active matrix Display color 16.2M Colors Number of pixels 1280 x 1024 pixel Pixel Arrangement RGB vertical stripe Pixel pitch 0.264(H) x 0.264(W) mm Display Mode Normally Black

Page 12: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

12

4.4.3 Optical Characteristics The optical characteristics are measured under stable conditions at 25℃ (Room Temperature):

4.4.4 Parameter guide line for CCFL Inverter

Page 13: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

13

5. Block Diagram 5.1 Monitor Exploded View

Page 14: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

14

5.2 Software Flow Chart

1

2

N

Y

5

Y

N

10

Y

N

12

Y

N

7Y

N

6

4

3

8

9

14

11

13

Y

N

15

Y

N16

17

19

Y

N18

Page 15: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

15

1) MCU Initializes. 2) Is the EEprom blank? 3) Program the EEprom by default values. 4) Get the PWM value of brightness from EEprom. 5) Is the power key pressed? 6) Clear all global flags. 7) Are the AUTO and SELECT keys pressed? 8) Enter factory mode. 9) Save the power key status into EEprom.

Turn on the LED and set it to green color. Scalar initializes.

10) In standby mode? 11) Update the lifetime of back light. 12) Check the analog port, are there any signals coming? 13) Does the scalar send out an interrupt request? 14) Wake up the scalar. 15) Are there any signals coming from analog port? 16) Display "No connection Check Signal Cable" message. And go into standby mode afterthe message disappears. 17) Program the scalar to be able to show the coming mode. 18) Process the OSD display. 19) Read the keyboard. Is the power key pressed?

Page 16: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

16

5.3 Electrical Block Diagram 5.3.1 Main Board

H-sync, V-sync

RGB

OSD Control

Interface (CN101)

Scalar GmZan3-SL (Include ADC, Scalar, OSD)

(U102)

MCU

Win Bond W78E65 (SyncMos SM5964)

(U101)

EEPROM M24C16 (U104)

D-Sub Connector (CN100)

EEPROM 24C02 (U103)

RXD TXD

DB12_SDA, DB15_SCL

NVRAM_SDANVRAM_SCL

LCD Interface (CN103)

LCD Panel

Page 17: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

17

5.3.2Power Block Diagram

R8CCFL

VrmsM5METER V

Note 1: M3 / M4/M5/M6 need to use two channel multimeter , such asFLUKE 45 , or use the oscilloscope check frequency.

CN901

NL

GN

D

VrmsM6METER V

R12CCFL

ON/OFF

1. M3 / M4/M5/M6 = 6.5 +- 5 mV @DIM= 5V

2. Check M3 / M4/M5/M6operating frequency. (note 1 )

CON2071

2

GND

CN10212345678

109

1112

PWPC1742LGD1

GND

R1110 

12V

M3 / M4 /M5/M6= 3.0 +- 5 mV @DIM= 0V

VrmsM4METER V

M1 = 12V +- 0.5V , M2 = 5V +- 0.25V

R6CCFL

R10CCFL

CON2061

2

2. M3 / M4/M5/M6= 55KHz+- 5 KHz

DIM

R710 

VM2METER V

R25  

R1310 

VR110K  

R5100  

Specification :

AC IN

CON2081

2

R4560  

Function test step :

VrmsM3METER V

5V

Step1 :

R1100  

PCBNO.715L1283-1

Model name :

PWPC1742LGD1Function test

VM1METER V

R910 

CON2051

2

1. Adjust VR1 ( Set Vdim voltage from 0V to 5V) , then check M3 /M4/M5/M6 Vrms .

Page 18: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

18

6. Schematic 6.1 Main Board

R114 47 1/16W 

C109

NC

CLK_DDC

GND

GND

HSYNC 2

GND

gndG

D10

2

MLL5232B 5.6V

C114 0.047uF

HSI

GND

R120 100 1/16W 

FB102 22 1/16W 

+5V

GIN

R105 100 OHM

R116

2.2K

1/1

6W 

VGA_CAB 2

D10

3

MLL5232B 5.6V

R111100 1/16W 

RXD 2

R102 100 1/16W 

GND

R10

775

1/1

6W 

D107

MLL

5232

B 5

.6V

R118 47K 1/16W 

R115

2.2K

1/1

6W 

C104 0.047uF

GND

GND

BLUE+ 2

R110100 1/16W GND

BIN

R109100 1/16W 

GREEN- 2

D110

BAT54C-GS083

1 2C117

NC

DAT_DDC

RED- 2

C119 0.1uF/16V

GND

R103 NC

R129 100 1/16W 

D109

MLL

5232

B 5

.6V

GND

PC5V

R13

12.

7K 1

/16W

 

R101 100 OHM

R119 100 1/16W 

D111MLL5232B 5.6V

+5V

C106 0.047uF

D101BAV99

3

12

GND

HSI

R100 100 1/16W 

FB104 0 1/16W 

R11747K 1/16W 

C108 0.047uF

DDC_/WP 2

C111

NC

DDC_SDA 2GND

DDC_SCL 2

VSYNC 2

R128 100 1/16W 

C118

NC

CN100

VGA

162738495

11

12

13

14

1510

1716

PC5VGND

R13

22.

7K 1

/16W

 

C112 0.047uF

CLK_DDC

U103M24C02WMN6

4

8 123

765 GND

VCC A0A1A2

WPSCLSDA

RED+ 2

GND

R104 100 OHM

C110

NC

VGA_CON

R10

675

1/1

6W 

BLUE- 2

GND

DAT_DDC

GND

PC5V

VSI

R15647K 1/16W 

FB101 22 1/16W gndR

D106BAV99

3

12

R112 47 1/16W 

TXD 2

RIN

R113 100 1/16W 

FB103 22 1/16W 

GND

VSI

C113 0.047uF

D112MLL5232B 5.6V

D105BAV99

3

12

D108

MLL

5232

B 5

.6V

R10

875

1/1

6W 

gndB

GND

Zan3 SL MAIN BOARD C

Input ConnectorA

1 5Friday , February 13, 2004

Title

Size Document Number Rev

Date: Sheet of

D104

MLL5232B

5.6V

GREEN+2

Page 19: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

19

3.3V_LAVDD

R124-RESETFUNCTION

RDn

R133

4.7K 1/16W

 

83.4m A

LVDS_E8

/WPR139 100 1/16W 

L106120 OHM

1.8V_DVDD

GND

LED_G 3

R140 NC

R135

4.7K 1/16W

 

C125

0.1uF/16V

R123

4.7K

1/1

6W 

Close to respective pow er Pins

1.8V_AVDD

6.4m A

C144

0.1uF/16V LVDS_E0

VGA_CAB

R142 0 1/16W 

LVDS_O0

L103120 OHM

KEY_ONOFF 3

U101

SOCKET

23456789

10

111314151617

1819

2021

22

242526272829303132

3335

3637383940414243

44

1122334

P1.0/T2P1.1/T2EXP1.2/ECIP1.3/CEX0P1.4/CEX1P1.5/CEX2P1.6/CEX3/WAIT#P1.7/CEX4/A17/WRST

P3.0/RXDP3.1/TXDP3.2/INT0#P3.3/INT1#P3.4/T0P3.5/T1

P3.6/WR#P3.7/RD#/A16

XTAL2XTAL1

VSS

A8/P2.0A9/P2.1

A10/P2.2A11/P2.3A12/P2.4A13/P2.5A14/P2.6A15/P2.7

PSEN#

ALE/PROG#EA#/VPP

AD7/P0.7AD6/P0.6AD5/P0.5AD4/P0.4AD3/P0.3AD2/P0.2AD1/P0.1AD0/P0.0

VCC

P4.2P4.3/INT2

P4.0P4.1

3.3V_DVDD

+5V

DDC_SCL1

C141

0.1uF/16V

RDn

8.1m A

A15

R126

100

1/1

6W 

+C12222uF/16V

G-PROBE

C150

0.1uF/16V

GND

GND

C124

0.1uF/16V

LED_O 3

R1224.7K 1/16W 

R151 NC

+5V

C126

0.1uF/16V

139m A

GND

GND

LVDS_E5

C137

0.1uF/16V

X10114.318MHz

R152 NC

LVDS_O3LVDS_O2

1.8V_AVDD

3.3V_PVDD

KEY_MENU 3 IRQn

LVDS_E[0..9]

C134

0.1uF/16V

OPTIONALFORDEBUGGINGPURPOSESONLY

GREEN+1

Refer BOOTSTRAP OPTIONS

42.2m A

R148 4.7K 1/16W 

LVDS_E3

PBIAS

3.3V_LAVDDU102

GMZAN3 SLQFP-100

777874757071

87

88

6263

3940

1

42434445

41

35

90

46

2

8284

807672

33 51

89

4731 67

3029

9596

32 48 64 68 100

81

16

1413121110

765

28

89

93

85

69

94 92

6661

605958

73

5554

5352

50

49

5756

65

34

38

91

8386

3736

17181920212223242526

4

31527

99

79

9798

RED+RED-GREEN+GREEN-BLUE+BLUE-

XTAL

TCLK

STI_TM1STI_TM2

GPIO12/AD6GPIO11/AD5

AVDD_LV_3.3

HDATA3/AD3HDATA2/AD2HDATA1/AD1HDATA0/AD0

HFS/AD4

HCLK/ALE

RESETn

GPIO10/IRQn

VCO_LV

VDD_ADC_1.8VDD_RPLL_1.8

AGND_ADCAGND_ADCAGND_ADC

RV

DD

_3.3

RV

DD

_3.3

AVDD_RPLL_3.3

CV

DD

_1.8

CV

DD

_1.8

CV

DD

_1.8

PPWRPBIAS

HSYNCVSYNC

CR

VS

SC

RV

SS

CR

VS

SC

RV

SS

CR

VS

S

GND_ADC

VDD_OUT_LV_3.3

CH0N_LV_E/G1CH0P_LV_E/G0CH1N_LV_E/R7CH1P_LV_E/R6CH2N_LV_E/R5

CLKP_LV_E/R2CH3N_LV_E/R1CH3P_LV_E/R0

VDD_OUT_LV_3.3

CLKN_LV_E/R3CH2P_LV_E/R4

CR

VS

S

VBUFS_RPLL

AVDD_ADC_3.3 RV

DD

_3.3

CV

DD

_1.8

NCNC

GPIO8/B6GPIO7/B4GPIO6/B7

SOG_MCSS

GPIO3/DVSGPIO2/DHS

GPIO1/PWM1GPIO0/PWM0

GPIO9/B5

NC

GPIO5/DCLKGPIO4/DEN

CV

DD

_1.8

MEM_REG

GPIO13/AD7

RESET_OUT

VSS_RPLLAVSS_RPLL

RDnWRn

CH3P_LV_O/G2CH3N_LV_O/G3CLKP_LV_O/G4CLKN_LV_O/G5CH2P_LV_O/G6CH2N_LV_O/G7CH1P_LV_O/B0CH1N_LV_O/B1CH0P_LV_O/B2CH0N_LV_O/B3

VDD_OUT_LV_3.3

AVSS_LVVSS_OUT_LVVSS_OUT_LV

CV

DD

_1.8

AVDD_ADC_3.3

DDC_SCLDDC_SDA

C14710pF

TXD1

GND

BRIGHTNESS 5

A14

GND

Zan3 SL MAIN BOARD C

ZAN3 SL & MCUC

2 5Friday , February 13, 2004

Title

Size Document Number Rev

Date: Sheet of

R136 NC

3.3V_AVDD

NVRAM_SDA

L102120 OHM

CN102

1234

R173NC

BLUE-1

GNDLVDS_E9

R130

100

1/1

6W 

R125100 1/16W 

1.8V_DVDD

LVDS_O5

C135

0.1uF/16V

UDART_DO

C133

0.1uF/16V

A14 => MEM_REG(ZAN3SL)

LVDS_O[0..9]

VSYNC1

GND

GND

KEY_RIGHT 3

C139

0.1uF/16V

LVDS_E[0..9] 4

L104120 OHM

LVDS_O1

+C13622uF/16V C142

0.1uF/16V

NVRAM_SCL

WRn

A15 => HCLK(ZAN3SL)

3.3V_AVDD

3.3V_DVDD

+5V

PPWR

A15

C128

0.1uF/16V

R146 0 1/16W 

R124NC

Philips P89C51RD2Winbond W78E65P-PLCC44SyncMOS SM2965

RED-1

+5V

GND

3.3V_PVDD

C14810pF

C127

0.1uF/16V

UDART_DIUDART_DO

LVDS_O4

+1.8V_VDD

GND

KEY_LEFT 3

LVDS_E2

R150NC

R147 4.7K 1/16W 

LVDS_O[0..9] 4

LVDS_E6

GND

+5V

PPWR

R138 NC

TCLK

KEY_MENU

R1274.7K 1/16W 

PBIAS 5

GND

RED+1

Har

dwav

e IS

P fu

nctio

n

C151NC

GND

LVDS_O7

+5V

R14

34.

7K 

TCLK FOR ZAN3SL

RXD1

R153NC

R134

4.7K 1/16W

 

R145NC

+5V

+C14022uF/16V

PBIAS

HSYNC1

WRn

U104

M24C16-MN6T

1234 5

678

A0A1A2VSS SI

SCKWP

VCC

C1450.1uF/16V

Close to respective pow er Pins

LVDS_E1

+3.3V_VDD

GND+5V

LVDS_O6

PPWR 5

LVDS_O9

C149

0.1uF/16VR

144

4.7K

 

KEY_ONOFF

C138

0.1uF/16V

R121 22 1/16W 

GND

GND

GREEN-1

C131

0.1uF/16V

KEY_RIGHT

C123

0.1uF/16V

R137 100 1/16W 

Close to respective pow er Pins

+C129

22uF/16V

WINBOND W78E65P-40-56L1125-137-X

BLUE+1

C132

0.1uF/16V

VGA_CAB 1

LVDS_E4

GND

+5V

LVDS_O8

DDC_SCLDDC_SDA

L105120 OHM

L101120 OHM

/WP

A14

ALE

+C14322uF/16V

PLCC44 - SOCKET-87L202-44

UDART_DI

58.27m A

3.3V_DVDD

+5V

KEY_LEFT

DDC_SDA1

DDC_/WP1

C130

0.1uF/16V

ALE

LVDS_E7

R141 100 1/16W 

Page 20: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

20

C1530.001uF

KEY_LEFT

GND

LED_ORANGE

KEY_ONOFF

C1520.001uF

LEFT

LED_O2

+5V

GND

R155

4.7K 1/16W 

LED_G

KEY_ONOFF2

C156

0.001uF

CN101

CONN

12345678

KEY_RIGHT

Q102

PMBS3904

32

1

C155

0.001uF

GNDGND

LED_GREEN

C154

0.001uF

Zan3 SL MAIN BOARD C

KEYS CONNECTIONA

3 5Friday , February 13, 2004

Title

Size Document Number Rev

Date: Sheet of

+5V

GND

LED_O

R158 220 1/16W  RIGHT

RP1034.7K 1/16W 

1 2 3 4

8 7 6 5

To keyboardENTER

KEY_MENU2KEY_MENU

R160 220 1/16W 

GND

KEY_RIGHT2KEY_LEFT2

R154

4.7K 1/16W 

R159 220 1/16W 

GND

R157 220 1/16W 

Q101

PMBS3904

32

1

POWER

LED_G2

C1570.001uF

+5V

Page 21: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

21

LVDS_E5

GND

LVDS_E1

LVDS_O2

RXO2+RXOC-RXO3-

15.4

mA

LVDS_E2

LVDS_E4

LVDS_O5LVDS_O6

LVDS_E9

LVDS_O8

RXEC-

FOR LAYOUT 100uF/16V

LVDS_E[0..9]2

RXO3+

LVDS_E6

LVDS_O6

LVDS_E3

LVDS_O9

LVDS_E0

RXO1-

LVDS_O1

RXE0-

LVDS_E8LVDS_E7

C159

0.1uF/16V

RXE3+

LVDS_O2

LVDS_E0LVDS_O9

GND

LVDS_E3

RXO2-

LVDS_E9

CN103

CONN24A

24681012141618202224

13579

11131517192123

LVDS_O4

LVDS_O7

+VLCD

RXO0+

LVDS_O[0..9]2

+

C158100uF/16V

RXO1+LVDS_O1

RXE1+

LVDS_O3

R172

330 1/8W 

RXEC+

LVDS_O8

RXO0-

LVDS_E7

LVDS_O3 LVDS_O0

LVDS_O5

LVDS_E6

RXE3-

Zan3 SL MAIN BOARD C

PANEL INTERFACEA

4 5Friday , February 13, 2004

Title

Size Document Number Rev

Date: Sheet of

RXE1-RXE2+RXE2-

LVDS_E4

LVDS_O0

LVDS_E8

LVDS_E2

RXOC+

LVDS_E1

LVDS_E5

GND

LVDS_O4

RXE0+

LVDS_O7

Page 22: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

22

GND

AO3401

R1641K 1/16W 

GND

U106

3 2

1

VI VO

GN

D

2

CN104

CONN

123456

GND

R170NC

+3.3V_VDD

1

GND

0.8A-m ax

R162 4.7K 1/16W 

+5V

+5V

D

+ C165

47uF/16V

R171100K 1/16W 

BLON/OFF

1

C167

0.1uF/16V

G

GND

TO263

Zan3 SL MAIN BOARD C

POWERA

5 5Friday , February 13, 2004

Title

Size Document Number Rev

Date: Sheet of

GND

C1640.1uF/16V

+C162

100uF/16V

3

+ C17222uF/16V

GND

C173

0.1uF/16V

GND

Q104AO3401

SOT-223

C1740.1uF/16V

GND

FB105 120 OHM

DIMMING

+5V

GND147m A

PPWR2 Q105PMBS3904

32

1

204m A

D113 NC

GNDBRIGHTNESS2

Brightness

+5V

+C1692.2uF

R165

1K 1/16W 

GND

R1684.7K 1/16W 

+5V

GND

C175

0.1uF/16V

GND

C1680.1uF/16V

GND

2

R167NC

+3.3V_VDD

+VLCD

U105AIC1084-33M

3

1

2VIN

ADJ

VOUT

3

+C166

47uF/16V

C163

0.1uF/16V

S

PBIAS2

+C171

47uF/16V

+1.8V_VDD

R1690 1/16W 

Page 23: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

23

6.2 Internal Power Board

R9021M 1/4W 

R9261K 1/4W 

C9020.001uF/250V

R92047 1/2W 

GND

ZD902HZ12B2

5V

C9100.001uF

ON/OFF

C9311000P/50V

C9301000P/50V

C9120.0047uF/250V

GND

IC903HTL431

L903

ZD903HZ5C1

D902PS102RC907

0.1uF

5V

R9233.6K 1/4W 

R9061M 1/4W 

12V

R9251K 1/4W 

DIM

L904

12V

+C90622uF

Q903FQPF7N80C,STP8NK80ZFP

R9041M 1/4W 

C921

0.001uF/500V

F901FUSE

12V

12V

L902

1 4

2 3

C9280.01uF

Q9012PA733P

SG6841

IC901SG6841

13

4

72

5 6

8

R912100 1/4W 

ZD904SML4736

C9270.1uF

+C924470uF/16V

C9090.1uF

DIM

C9200.001uF/500V

D91110A/100V

GND

R9094.7K 1/4W 

CN901

12

3

Q9022PC945P

R92233K 1/4W 

GND

R9270 1/4W 

R92147 1/2W 

IC902PC123FY82 4P

12

43

R9071M 1/4W 

R9051M 1/4W 

C9260.1uF

-+

DB9012KBP06M

1

4

3

2

R9242.4K 1/4W 

C903 0.47uF/250V

R9281K 1/4W 

C9050.0015uF/2KV

R903100K 2W 

R9104.7K 1/4W 

+ C9221000uF/16V

GND

R91610K 1/4W 

R91510 1/4W 

FB901BEAD

t

NR901NTCR

R91424K 1/4W 

GND

C911N.C 1/6W

+ C904120uF/400V

PWPC1742LGD1(715L-1283-1) A

1.POWER 12V&5V OUTPUT

AOC (Top Victory) Electronics Co., Ltd.

2 2Tuesday, March 16, 2004

Title

Size Document Number Rev

Date: Sheet of

ON/OFF

R91310K 1/4W  R917

0.39 2W 

5V

+C925470uF/16V

C9010.001uF/250V

D9031N4148

73L-174-26-T

C9080.1uF

C9290.1uF

R9085.1 1/4W 

D901

UF4007

O

O

O

T901

19

3

5

4

7,8

7,8

10,11

5V

R9114.7K 1/4W 

D910

20A/100V

C0N102

33A8009-12G-H

123456789

101112

R9011M 1/4W 

ZD901MTEJ20B

R929100 1/4W 

+ C9231000uF/16V

GND

Page 24: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

24

D208RLS4148

R21012K

Q210

2SC5706

1

23

is signal GND

CON203

33L8021-2D

1

2

F2014A/63V

CON202

33L8021-2D

1

2

PT201

80AL15T-7-YS

5 9

3,4

6

71

2

Q212

2SC5706

1

23

C222

0.47U/25V

C213

0.18U/160V

R240

51K

C207

4.7U/16V

R220 12K

L206JUMP

C2111U/25V

NO/OFF

C209

1U/25V

R237 510

R221 12K

R215

3.9K

C208

330P/50V

R20668K

R20568K

C221

0.47U/25VL202 150UH

R2301K

R20124K

C202

0.1U/25V

+12V

C204

0.1U/25V

R2321K

R234 620

R222 15K

TP1

HVO1

R217220

R20410K

L201 150UH

D20411B

R218 470

D207RLS4148

R216220

R207OPEN

CON201

33L8021-2D

1

2Q202

DTA144WKATP3

HVL

1

R21112K

C203

1U/25V

Q211

2SC5706

1

23

R214

3.9K

R2311K

C227

OPEN

C210

1U/25V

R241

51K

C205

0.1U/25V

+ C201

150U/25V

D205 RLS4148

D210RLS4148

D202SMAL240 OR SR24

D209 RLS4148

R235 620

TP4HVL

1

Q203 SI4431 OR AO4411

4

8

567

321

U20

1TL

1451

ACD

R

1 2 3 4 5 6 7 8910111213141516

CT

RT

1IN

+1I

N-

1FB

K1D

TC1O

UT

GN

DV

cc2O

UT

2DTC

2FB

K2I

N-

2IN

+S

CP

RE

F

Q201

DTC144WKA

C230

1000P/50V

R2271K

TP5 HVL

1

L205

JUMP

C219

1U/25V

R2331K

PWPC1742LGD1(715L-1283-1) A

2. FOR 17"&15" 4 LAMPS INVERTER

AOC (Top Victory) Electronics Co., Ltd.

2 2Tuesday, March 16, 2004

Title

Size Document Number Rev

Date: Sheet of

R236510

R2084.7K

Q208SST3906

R23912K

Q209

2SC5706

1

23

C228

OPEN

R2241K

Q205SST3904

R2025.1K

C216

0.18U/160V

C224

OPEN

Q207SST3906

R2094.7K

PT202

80AL15T-7-YS

5 9

3,4

6

71

2

C225

OPEN

D201SMAL240 OR SR24

R2123.9K

TP6

HVL

1

TP2

HVO1

C229

OPEN

Q206SST3904

DIM

R2261K

R2133.9K

R23812K

R2281K

is power GND

L203

73L174-30-YS

1 4

2 3

CON204

33L8021-2D

1

2

R223 15K

C226

OPEN

R2035.1K

R219470

D20311B

Q204 SI4431 OR AO4411

4

8

567

321

C2121U/25V

L204

73L-174-30-YS

1 4

2 3

+ C223

150U/25V

C220

1U/25V

R2291K

R2251K

D206 RLS4148

C231

1000P/50V

C206

0.1U/25V

Page 25: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

25

7. PCB Layout 7.1 Main Board

Page 26: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

26

7.2 Inverter/Power Board

Page 27: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

27

Page 28: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

28

7.3 Keypad Board

8. Maintainability 8.1 Equipments and Tools Requirement

Voltage meter.

Oscilloscope.

Pattern Generator.

DDC Tool with a IBM Compatible Computer.

Alignment Tool.

LCD Color Analyzer.

Service Manual.

User Manual.

Page 29: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

29

8.2 Trouble Shooting 8.2.1 Main Board 1) No display

Note: 1. If Replace “MAIN-BOARD”, Please re-do “DDC-content” programmed & “WHITE-Balance”.

2. If Replace “Inverter Board” only, Please re-do “WHITE-Balance”

No DC Level

Check Power board, is there DC level output?. Check

U105 pin3=5V, P105 pin2=3.3V? Is there any

shortage or cold solder or PCB trace is disconnected?

Check Correspondent component

Yes. There have OSD show

Connected the Signal cable again,

Check LED status.

LED Green

Replace U102

Scalar IC

Check Power switch is in

Power-on status, and check if

Power switch had been stuck?

Led Orange

OK, Keyboard no stuck

Led orange

Measured RGB (R112, R114) H, V Input

at U102 pin 95, 96, was there have signal?

Check Correspondent

component short/open

Protection Diode and

Signal cable bad? NG

OK, U102 data OK

Replace Inverter board and

Check Inverter control relative

Re-do White balance

Measured CN104 pin 5 = 5 V?

Measured U101 pin44=5V?

Measured U105 pin 2= 3.3V?

Yes, all DC level exist

Disconnected the Signal cable (Loose the

Signal cable), Is the screen show Block

WRGB color bars?

No, nothing is show

Connected the Signal cable again,

Check LED status.

Led Green

Check the Wire-Harness from CN101

OK, Wire tight enough

Check Panel-Power Circuit Block

OK, Panel Power

Check U200 Data-output Block

OK, input Normal

Measured Crystal X101

OK, clock normal

Replace U102 (GMZan3SL)

OK

Page 30: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

30

2) PANEL-POWER CIRCUIT

3) INVERTER CONTROL RELATIVE CIRCUIT

Check R172 should have response from 0V to 5V

When we switch the power switch from on to off

NGCheck the PPWR panel power relative circuit,

Q105, Q104 In normal operation, when LED =green,

R172 should =5 v,

If PPWR no-response when the power switch

Turn on and turn off, replace the U102(GMZan3-SL)OK, R172 have response

NG, no

Measured the Q104 pin 3= 5 V? Check U202 pin 4, 16, 28=3.3V?

OK

OK

Replace Q104 ( N-mos, AO3401)

Yes

Measured the inverter connector CN104

Pin1 on/off control=3.3V (on)

Pin2 PWM signal control dim 0V-5V

NGCheck the Bklt-On relative circuit, R162,

In normal operation, when LED =green,

R162 Bklt-On should =3.3V,

If Bklt-On no-response when the power switch turn on-off,

Replace U102 GMZan3-SL

NG, still no screen

Replace Inverter board to new-one,

and Check the screen is normal??

OK

NGCheck NO SCREEN APPEAR block

Page 31: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

31

4) U102-DATA OUTPUT

OK

OK

Measured U102 DVS, DHS

Is the waveform ok?

DCLK around 48 MHZ, DVS=60.09Hz, DHS

around 31 KHz? (Refer to input

signal=640x480@60 Hz 31k, and LED is

Green)

NG, no transition

OK

Replace GMZan3 –SL (U102) or

replace MAINBOARD.

Check U102 GMZan3-XL

Signal output TX1+, TX1-, TX2+,

TX2-, TX3+, TX3-, Is the

waveform ok?

If Main Board being replaced please

do the DDC – content reprogrammed

and re-do white balance adjustment NG

Page 32: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

32

8.2.2 Power/Inverter Board

1.) No power

Check to CN102 Pin9 and

pin10 = 5V

Check Interface board OK NG

Check AC line volt 120V or 220V

NG

OKChange F901 , check BD901,Q903,IC901

Check the voltage of C904(+)

Check bridge rectified circuit cFailure point NG

OK

Check start voltage for the pin3 of IC901

Change IC901 NG

Repeating the start voltage

Check the auxiliary voltage is smaller than 20V

1) Check IC902, IC903

2) Check Q901,Q902…OVP circuit

NGOK

Check R919, D910,D911,D912,D913, ZD904

Page 33: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

33

2.) W / LED, No Backlight

Check C201 (+)

NG

OK

Change F902

Check D201/Q209/Q210 or

Check ON/OFF signal

Check Interface board NG

Check U201 pin9=12V voltage

of C905(+)

NG

OK Change Q201 or Q202

Check the pin1 of U201 have sawtooth wave

NGOK

Change U201

Check D201(-),D202(-) have the output of square wave at short time.

NG

OK

Check Q205/Q207/Q203/D201 or

Q206/Q208/Q204/D202

Check the resonant wave of pin2 & pin5 for PT201/PT202

NG

Check the output of

Check Q209/Q210/C213 or

Q211/Q212/C214

Check connector & lamp

NGChange PT201or PT202

Page 34: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

34

8.2.3 Keypad Board OSD is unstable or not working

Is Keypad Board connecting normally? Connect Keypad Board

Is Button Switch normally? Replace Button

Y

N

N

Is Keypad Board Normally? Replace Keypad

Y N

Y

Check Main Board

Page 35: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

35

9. White-Balance, Luminance adjustment Approximately 2 Hours should be allowed for warm up before proceeding white balance adjustment.

Before started adjust white balance, please setting the Chroma-7120 MEM. Channel 1 to 65000K colors, MEM. Channel 3 to 93000K colors, MEM. Channel 1 to 57000K (our 9300 parameter is x = 296 ±10, y = 311 ±10, Y = 180 ±10 cd/m2, 6500 parameter is x = 313 ±10, y = 329 ±10, Y = 180 ±10 cd/m2,and 5700 parameter is x = 328 ±10, y = 344 ±10, Y = 180 ±10 cd/m2)

How to setting MEM.channel you can reference to chroma 7120 user guide or simple use “ SC” key and “ NEXT” key to modify xyY value and use “ID” key to modify the TEXT description

Following is the procedure to do white-balance adjust

Press MENU and AUTO-ADJUST button during press Power button will activate the factory mode,

Gain adjustment: Move cursor to “-Factory Setting-” and press MENU key to enter this sub-menu; Move cursor to “ Factory” and press MENU key; Move cursor to “ Auto Level” and press MENU key to adjust Gain and Offset automatically;

a. Adjust sRGB (65000K) color-temperature 1 Switch the chroma-7120 to RGB-mode (with press “MODE” button) 2 Switch the MEM.channel to Channel 01 (with up or down arrow on chroma 7120) 3 The LCD-indicator on chroma 7120 will show x = 313 ±10, y = 329 ±10, Y = 180 ±10 cd/m2 4 In sRGB sub-menu, adjust C to 192, adjust L to 230 ; 5 Adjust the RED on OSD window until chroma 7120 indicator reached the value R=100 6 Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 7 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 8 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the tolerance

=100±2

b. Adjust Color1 (93000K) color-temperature 9 Switch the chroma-7120 to RGB-mode (with press “MODE” button) 10 Switch the MEM.channel to Channel 03 ( with up or down arrow on chroma 7120 ) 11 The LCD-indicator on chroma 7120 will show x = 296 ±10, y = 311 ±10, Y = 180 ±10 cd/m2 12 In Color1 sub-menu, adjust C to 192, adjust L to 230 ; 13 Adjust the RED on OSD window until chroma 7120 indicator reached the value R=100 14 Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 15 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 16 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the

tolerance =100±2

Page 36: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

36

c. Adjust Color2 (57000K) color-temperature 17 Switch the chroma-7120 to RGB-mode (with press “MODE” button) 18 Switch the MEM.channel to Channel 03 (with up or down arrow on chroma 7120) 19 The LCD-indicator on chroma 7120 will show x = 328 ±10, y = 344 ±10, Y = 180 ±10 cd/m2 20 In Color2 sub-menu, adjust C to 192, adjust L to 230 ; 21 Adjust the RED on OSD window until chroma 7120 indicator reached the value R=100 22 Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 23 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 24 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the

tolerance =100±2 25 Move cursor to “ Exit/Save” sub-menu and press MENU key to save adjust value and exit; Turn the POWER-button off to on to quit from factory mode.

Page 37: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

37

10. EDIT Content D-SUB Connector (Analog)

00 01 02 03 04 05 06 07 08 09 A B C D E F

0: 00 FF FF FF FF FF FF 00 10 AC 0B A0 43 31 30 30

16: 34 0D 01 03 68 22 1B 78 2A 2D 90 A4 57 4A 9C 25

32: 11 50 54 A5 4B 00 71 4F 81 80 01 01 01 01 01 01

48: 01 01 01 01 01 01 30 2A 00 98 51 00 2A 40 30 70

64: 13 00 78 2D 11 00 00 1E 00 00 00 FF 00 36 34 31

80: 38 30 33 39 43 30 30 31 43 0A 00 00 00 FD 00 38

96: 4C 1F 50 0E 00 0A 20 20 20 20 20 20 00 00 00 FC

112: 00 44 45 4C 4C 20 45 31 37 33 46 50 63 20 00 49

Note: Byte 0C, 0D, 0E, 0F means Serial No. Byte 10, 11 means Manufacture Time. Byte 7F

means checksum

Page 38: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

38

11. ISP (In System Program) User Manual 11.1. Connect ISP Writer preparation action:

Connect RXD and TXD of PC to RXD (P3.0) and TXD (P3.1) of CPU through RS-232.

a. There are two ways to entering Reboot Mode. The settings for Reboot Mode is as follow: ☆Both P2.6、P2.7 are LOW and RESET pin is HI. ☆P4.3 is LOW and RESET pin is HI .

11.2. To Use ISP WRITER Press the “–“ key at front bezel and plug the AC power cord in, then the MCU enter ISP mode;

a. You will enter the window as follow after executing the ispwriter.exe file.

Page 39: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

39

b. Click the “Select Chip” button, and choose the type you’re going to program.

Choose “W78E65”

and click “OK”

button

Page 40: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

40

c. Click the “Select Bank0” button and selecting a file which a binary Format required.

Choose bin file and open it

Page 41: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

41

d. Select the communication Setting: Port Name

e. Click the “ConNect” button.

These buttons will be enable.

Page 42: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

42

f. Click “Program all” to start programming.

11.3. Executing ISP

a. Click “Program All” button that will execute erase and program and verify. Then you can get the window as follow, and click “OK” to complete ISP process.

b. Complete the ISP process, click “eXit LD” button to reset monitor.

Page 43: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

43

12. Bill Of Material List

Location Part Number Description Qty. Unit

CBPC780KGLDD CONVERSION BOARD 1 PCS

KEPC780KED1 KEY BOARD 1 PCS

PWPC1742LGD1 POWER BOARD 1 PCS

11L6036 1 SPACER SUPPORT SCC-24 1 PCS

15L8054 2 MAIN FRAME 1 PCS

23L3178700 1A LOGO 1 PCS

33L4669 GV C POWER BUTTON 1 PCS

33L4670 GV T KEY PAD 1 PCS

34L1367AY2 T BEZEL 1 PCS

34L1368 Y2 T REAR COVER 1 PCS

40L 152509 RECYCLE LABEL 0 PCS

40L 152512 RECYCLE LABEL 0 PCS

40L 154501 16444 HI-POT 1 PCS

40L 190700 1A6310 ID LABEL 1 PCS

40L 459700 1A6444 DELL S/N LABEL 1 PCS

40L 581 267046036 SHIPPING LABEL 0.01 PCS

40L 581700 3A6444 CARTON LABEL 1 PCS

41L7800700 2A QSG 1 PCS

44L3733 1 EPS 1 PCS

44L3733 2 EPS 1 PCS

44L3733700 1A CARTON 1 PCS

44L6000 4 6B SPACE PAPER 0.0077 PCS

45L 77512 F6863 BARCODE RIBBOR 18 MM

45L 88607DE6 PE BAG FOR MONITOR 1 PCS

52L 1186 SMALL TAPE 8 CM

52L6020 2DE4 FILM PROTECT 1 PCS

52L6022 1500 SMALL TAPE 12 CM

70L1700700 1A CD MANUAL 1 PCS

85L 672 1 SHIELD 1 PCS

85L 673 1 SHIELD-INVERTER 1 PCS

89L1738GAA 16 SIGNAL CABLE 1 PCS

89L401A18NHRA POWER CORD 1 PCS

95L8018 30529 WIRE HARNESS 1 PCS

M1L1140 6128 SCREW 4X6 1 PCS

M1L1430 6128 SCREW M3X6 4 PCS

M1L1430 6128 SCREW M3X6 5 PCS

M1L1430 6128 SCREW M3X6 3 PCS

Page 44: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

44

M1L2640 10225 SCREW 4 PCS

Q1L 330 8 47 SCREW 3X8mm 3 PCS

705L 780 87 DL CN901 ASS'Y 1 PCS

705L780KB34 79 BACK COVER ASS'Y 1 PCS

750LLG70E01 3 LVDS PANEL LM170E01-A5N 1 PCS

44L3231511 旧筿獁粗 2 PCS

44L3231512 旧筿獁粗 3 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: CBPC780KGLDD CONVERSION BOARD

-------- ------------------- -------------------------- -------- -----

AIC780KSLDD MAIN BOARD 1 PCS

CN101 33L3802 8H WAFER 8P RIGHT ANGLE PI 1 PCS

CN104 33L8013 6 H 6P PLUG R/A 1 PCS

CN103 33L8027 24 H CONN W TO B12P*2 P*2.0 1 PCS

U101A 56L1125137LD3 W78E65P-40 BY WINBOND 1 PCS

C158 67L309V101 3 100UF 16V 1 PCS

C162 67L309V101 3 100UF 16V 1 PCS

C122 67L309V220 3 22UF +-20% 16V 1 PCS

C129 67L309V220 3 22UF +-20% 16V 1 PCS

C136 67L309V220 3 22UF +-20% 16V 1 PCS

C140 67L309V220 3 22UF +-20% 16V 1 PCS

C143 67L309V220 3 22UF +-20% 16V 1 PCS

C172 67L309V220 3 22UF +-20% 16V 1 PCS

C169 67L309V229 7 2.2UF +-20% 50V 1 PCS

C165 67L309V470 3 47UF 16V 85C 1 PCS

C166 67L309V470 3 47UF 16V 85C 1 PCS

C171 67L309V470 3 47UF 16V 85C 1 PCS

CN100 88L 35315F H D-SUB 15PIN 1 PCS

X101 93L 22 53 CRYSTAL 14.318MHzHC-49U 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: AIC780KSLDD MAIN BOARD

-------- ------------------- -------------------------- -------- -----

U102 56L 562 58 GMZAN3/SL (AC) 1 PCS

U106 56L 563 27 AIC1117A-18CY SOT-223 1 PCS

U106 56L 56327A AP1117E18A SOT223-3L 0 PCS

U105 56L 585 4 AIC1117-33CY 1 PCS

U105 56L 585 4A AP1117E33A 0 PCS

U103 56L1133 34 M24C02-WMN6T SMT 1 PCS

U104 56L1133 56 M24C16-WMN6T/W SO-8 1 PCS

Q101 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS

Page 45: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

45

Q102 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS

Q105 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS

Q104 57L 763 1 A03401 SOT23 BY AOS(A1) 1 PCS

Q104 57L 763 1A AP2305N 0 PCS

RP103 61L 125472 8 CHIP AR 8P4R 4.7K OHM+- 1 PCS

FB104 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS

R142 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS

R146 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS

R169 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS

R102 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R109 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R110 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R111 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R119 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R120 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R125 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R126 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R128 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R129 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R130 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R137 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R139 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R141 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS

R164 61L0603102 CHIPR 1K OHM +-5% 1/10W 1 PCS

R165 61L0603102 CHIPR 1K OHM +-5% 1/10W 1 PCS

R171 61L0603104 CHIPR 100K OHM +-5% 1/1 1 PCS

FB101 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS

FB102 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS

FB103 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS

R121 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS

R157 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R158 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R159 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R160 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R115 61L0603222 CHIPR 2.2K OHM+-5% 1/10 1 PCS

R116 61L0603222 CHIPR 2.2K OHM+-5% 1/10 1 PCS

R131 61L0603272 CHIP 2.7K OHM 1/10W 1 PCS

R132 61L0603272 CHIP 2.7K OHM 1/10W 1 PCS

R112 61L0603470 CHIPR 47 OHM +-5% 1/10W 1 PCS

R114 61L0603470 CHIPR 47 OHM +-5% 1/10W 1 PCS

Page 46: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

46

R122 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R123 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R127 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R133 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R134 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R135 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R143 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R144 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R147 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R148 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R154 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R155 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R161 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R162 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R163 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R168 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R117 61L0603473 CHIP 47K OHM 1/10W 1 PCS

R118 61L0603473 CHIP 47K OHM 1/10W 1 PCS

R156 61L0603473 CHIP 47K OHM 1/10W 1 PCS

R106 61L0603750 9F 75OHM 1% 1/10W 1 PCS

R107 61L0603750 9F 75OHM 1% 1/10W 1 PCS

R108 61L0603750 9F 75OHM 1% 1/10W 1 PCS

R172 61L1206331 CHIP 330OHM 5% 1/4W 1 PCS

C147 65L0603100 31 CHIP 10PF+-0.5PF 50V NP 1 PCS

C148 65L0603100 31 CHIP 10PF+-0.5PF 50V NP 1 PCS

C152 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C153 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C154 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C155 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C156 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C157 65L0603102 32 1000PF +-10% 50V X7R 1 PCS

C119 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C123 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C124 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C125 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C126 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C127 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C128 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C130 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C131 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

Page 47: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

47

C132 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C133 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C134 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C135 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C137 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C138 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C139 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C141 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C142 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C144 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C145 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C149 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C150 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C159 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C163 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C164 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C167 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C168 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C173 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C174 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C175 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS

C104 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

C106 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

C108 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

C112 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

C113 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

C114 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS

FB105 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L101 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L102 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L103 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L104 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L105 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

L106 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS

R101 71L 59Q101 CHIP BEAD 100 OHM 1 PCS

R104 71L 59Q101 CHIP BEAD 100 OHM 1 PCS

R105 71L 59Q101 CHIP BEAD 100 OHM 1 PCS

U101 87L 202 44 PLCC SMT CONN PD41C-441 1 PCS

D102 93L 39146 LL5232B SMT 0 PCS

D103 93L 39146 LL5232B SMT 0 PCS

Page 48: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

48

D104 93L 39146 LL5232B SMT 0 PCS

D107 93L 39146 LL5232B SMT 0 PCS

D108 93L 39146 LL5232B SMT 0 PCS

D109 93L 39146 LL5232B SMT 0 PCS

D111 93L 39146 LL5232B SMT 0 PCS

D112 93L 39146 LL5232B SMT 0 PCS

D102 93L 39149 MLL5232B BY FULL POWER 1 PCS

D103 93L 39149 MLL5232B BY FULL POWER 1 PCS

D104 93L 39149 MLL5232B BY FULL POWER 1 PCS

D107 93L 39149 MLL5232B BY FULL POWER 1 PCS

D108 93L 39149 MLL5232B BY FULL POWER 1 PCS

D109 93L 39149 MLL5232B BY FULL POWER 1 PCS

D111 93L 39149 MLL5232B BY FULL POWER 1 PCS

D112 93L 39149 MLL5232B BY FULL POWER 1 PCS

D110 93L 60230 BAT54C(L43) 1 PCS

D101 93L 64 33 BAV99 0 PCS

D105 93L 64 33 BAV99 0 PCS

D106 93L 64 33 BAV99 0 PCS

D101 93L 6433P BAV99 1 PCS

D105 93L 6433P BAV99 1 PCS

D106 93L 6433P BAV99 1 PCS

715L1280 D DELL MAIN BOARD 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: KEPC780KED1 KEY BOARD

-------- ------------------- -------------------------- -------- -----

R101 61L 60210152T 100OHM +- 5% 1/6W 1 PCS

SW101 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS

SW102 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS

SW103 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS

SW104 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS

DP101 81L 12 1A GP LED 1 PCS

CN101 95L8014 8 10 WURE HARNESS 1 PCS

715L1153 1A PCB 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: PWPC1742LGD1 POWER BOARD

-------- ------------------- -------------------------- -------- -----

PW1742LGD1AI POWER BOARD 1 PCS

PW1742LGD1SMT POWER BOARD 1 PCS

CON201 33L8021 2D E WAFER 0 PCS

CON202 33L8021 2D E WAFER 0 PCS

Page 49: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

49

CON203 33L8021 2D E WAFER 0 PCS

CON204 33L8021 2D E WAFER 0 PCS

CON201 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS

CON202 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS

CON203 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS

CON204 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS

CN901 33L8029 4A PLUG 1 PCS

40L 45762420A ID LABEL 1 PCS

IC902 56L 139 3B PC123 Y82 1 PCS

IC901 56L 379 32 SG6841D BY SYSTEM 1 PCS

Q209 57L 761 6 2SC5706 DIP SANYO 1 PCS

Q210 57L 761 6 2SC5706 DIP SANYO 1 PCS

Q211 57L 761 6 2SC5706 DIP SANYO 1 PCS

Q212 57L 761 6 2SC5706 DIP SANYO 1 PCS

NR901 61L 58120 WT NTCR 12OHM 20% 2A SCK-1 1 PCS

C903 63L 107474 5S 0.47UF +-10% 250VAC 0 PCS

C903 63L 107474 FS 0.47UF +-10% 250VAC 0 PCS

C903 63L 107474 HS 0.47UF +-10% 250VAC 0 PCS

C903 63L 10747410S 0.47UF +-10% 250VAC 1 PCS

C213 63L210J1842A2 PMS 0.18UF 250V 1 PCS

C214 63L210J1842A2 PMS 0.18UF 250V 1 PCS

C213 64L180J184AAT CAP 0.18UF 160V R79 0 PCS

C214 64L180J184AAT CAP 0.18UF 160V R79 0 PCS

C226 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS

C227 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS

C228 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS

C229 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS

C226 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS

C227 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS

C228 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS

C229 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS

C901 65L305M1022B2 1000PF 400VAC/250VAC 0 PCS

C902 65L305M1022B2 1000PF 400VAC/250VAC 0 PCS

C901 65L305M1022EM 1000PF +-20% 250VAC/400 1 PCS

C902 65L305M1022EM 1000PF +-20% 250VAC/400 1 PCS

C913 65L306M3322F2 3300PF +-20% 400VAC Y1 1 PCS

C912 65L306M4722B2 4700PF +-20% 400VAC Y1 1 PCS

C922 67L215C102 3H EC LESR 1000UF16V HERME 1 PCS

C923 67L215C102 3H EC LESR 1000UF16V HERME 1 PCS

C922 67L215C102 3K 1000UF/16V 0 PCS

Page 50: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

50

C923 67L215C102 3K 1000UF/16V 0 PCS

C904 67L215S10115H 100UF 450V 18*36 105 BY 0 PCS

C904 67L215S10115K 100UF 450V 0 PCS

C904 67L215S10115N 100UF+-20% 450V 1 PCS

C922 67L215S102 3N EC 105 16V 1000UF KZE16 0 PCS

C923 67L215S102 3N EC 105 16V 1000UF KZE16 0 PCS

71L 55 2 A FERRITE BEAD 6.5*5*1.7 1 PCS

L902 73L 174 26 LS COMMON CHOKE 0 PCS

L902 73L 174 26 T1 LINE LILTER 0.45mm 1 PCS

L203 73L 174 30 H FILTER 500MH HA 0 PCS

L204 73L 174 30 H FILTER 500MH HA 0 PCS

L203 73L 174 30 LS FILTER 0 PCS

L204 73L 174 30 LS FILTER 0 PCS

L203 73L 174 30 YS FILTER 1 PCS

L204 73L 174 30 YS FILTER 1 PCS

L903 73L 253 91 L CHOKE BY LI TA 0 PCS

L904 73L 253 91 L CHOKE BY LI TA 0 PCS

L903 73L 253 91 LS CHOKE BY LI SHIN 1 PCS

L904 73L 253 91 LS CHOKE BY LI SHIN 1 PCS

L201 73L 253139 YL CHOKE 1 PCS

L202 73L 253139 YL CHOKE 1 PCS

PT201 80LL15T 7 DN X'FMR 0 PCS

PT202 80LL15T 7 DN X'FMR 0 PCS

PT201 80LL15T 7 YS X'FMR 1 PCS

PT202 80LL15T 7 YS X'FMR 1 PCS

T901 80LL17T 2 T X'FMR 1 PCS

T901 80LL17T 2 LS ADAPTOR BY LISHIN 0 PCS

BD901 93L 50460 8 BRIDGE 2KBP06M2A600V 1 PCS

CON102 95L8014 6 19 PIN HEADER 1 PCS

705L 560 57 DL D910/D911 ASS'Y 1 PCS

705L 560 61 05 R917 ASS'Y 1 PCS

705L 560 61 06 R903 ASS'Y 1 PCS

705L 780 57 DL Q903 ASS'Y 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: PW1742LGD1AI POWER BOARD

-------- ------------------- -------------------------- -------- -----

CN901 6L 31500 EYELET 2 PCS

C213 6L 31502 1.5MM RIVET 2 PCS

C214 6L 31502 1.5MM RIVET 2 PCS

C904 6L 31502 1.5MM RIVET 2 PCS

Page 51: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

51

L902 6L 31502 1.5MM RIVET 4 PCS

PT201 6L 31502 1.5MM RIVET 2 PCS

PT202 6L 31502 1.5MM RIVET 2 PCS

T901 6L 31502 1.5MM RIVET 4 PCS

715L1283 2 POWER BOARD 1 PCS

J001 95L 90 23 TIN COATED 0 PCS

J002 95L 90 23 TIN COATED 0 PCS

J003 95L 90 23 TIN COATED 0 PCS

J004 95L 90 23 TIN COATED 0 PCS

J005 95L 90 23 TIN COATED 0 PCS

J006 95L 90 23 TIN COATED 0 PCS

J007 95L 90 23 TIN COATED 0 PCS

J008 95L 90 23 TIN COATED 0 PCS

J009 95L 90 23 TIN COATED 0 PCS

J010 95L 90 23 TIN COATED 0 PCS

J011 95L 90 23 TIN COATED 0 PCS

J012 95L 90 23 TIN COATED 0 PCS

J014 95L 90 23 TIN COATED 0 PCS

J015 95L 90 23 TIN COATED 0 PCS

J016 95L 90 23 TIN COATED 0 PCS

J017 95L 90 23 TIN COATED 0 PCS

J018 95L 90 23 TIN COATED 0 PCS

J020 95L 90 23 TIN COATED 0 PCS

J021 95L 90 23 TIN COATED 0 PCS

L205 95L 90 23 TIN COATED 0 PCS

L206 95L 90 23 TIN COATED 0 PCS

R927 95L 90 23 TIN COATED 1 PCS

R915 61L 17210052T 100HM 5% 1/4W 1 PCS

R929 61L 17210152T 100 OHM 5% 1/4W 1 PCS

R224 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R225 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R226 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R227 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R228 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R229 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R230 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R231 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R232 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R233 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R925 61L 17210252T 1K OHM 5% 1/4W 1 PCS

Page 52: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

52

R926 61L 17210252T 1K OHM 5% 1/4W 1 PCS

R916 61L 17210352T CFR 10KOHM +-5% 1/4W 1 PCS

R924 61L 20024252T 2.4KOHM 1% 1/4W 1 PCS

R922 61L 20033352T 33KOHM 1% 1/4W 1 PCS

R923 61L 20036252T 3.6KOHM 1% 1/4W 1 PCS

R201 61L 60224352T 24K OHM 5% 1/6W 1 PCS

R920 61L175L47052T 47OHM +-5% 1/2W 1 PCS

R921 61L175L47052T 47OHM +-5% 1/2W 1 PCS

R904 61L214Y10552T 1M,1/4W 1 PCS

R905 61L214Y10552T 1M,1/4W 1 PCS

R906 61L214Y10552T 1M,1/4W 1 PCS

R907 61L214Y10552T 1M,1/4W 1 PCS

FB901 71L 55 29 FERRITE BEAD 1 PCS

ZD902 93L 39 5452T ZENER HZ12B2 1 PCS

ZD903 93L 39 7752T ZENER HZ5C1 1 PCS

D901 93L 6026T52T RECTIFIER DIODE FR107 1 PCS

D902 93L 6038P52T PS102R 1 PCS

D205 93L 64 1152T 1N4148 1 PCS

D206 93L 64 1152T 1N4148 1 PCS

D207 93L 64 1152T 1N4148 1 PCS

D208 93L 64 1152T 1N4148 1 PCS

D209 93L 64 1152T 1N4148 1 PCS

D210 93L 64 1152T 1N4148 1 PCS

D903 93L 64 1152T 1N4148 1 PCS

IC903 56L 158 4 T A HTL431 1 PCS

Q902 57L 419 PP T 2PC945P 1 PCS

Q901 57L 420 PP T 2PA733P 1 PCS

C929 64L700J1040AT 0.1UF 50V PEN 1 PCS

C905 65L 2K152 1T6052 1.5NF/2KV Y5P +-10% 0 PCS

C905 65L 2K152 1T6285 1.5NF/2KV Y5P +-10% 0 PCS

C905 65L 2K152 1T6921 1.5NF/2KV Y5P +-10% 1 PCS

C920 65L517K102 5T 1000PF 10% Y5P 500V 1 PCS

C921 65L517K102 5T 1000PF 10% Y5P 500V 1 PCS

C906 67L 305220 7T 22UF +-20% 50V 1 PCS

C207 67L 305330 7T 33UF 105   1 PCS

C924 67L215B4713HT 470UF 16V LTR471M1CF11V 1 PCS

C925 67L215B4713HT 470UF 16V LTR471M1CF11V 1 PCS

C924 67L215B4713KT LOW ESR 470UF16V BY HER 0 PCS

C925 67L215B4713KT LOW ESR 470UF16V BY HER 0 PCS

C201 67L215C1514HT LOW ESR 150UF 25V 8*7MM 1 PCS

Page 53: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

53

C223 67L215C1514HT LOW ESR 150UF 25V 8*7MM 1 PCS

C924 67L215N4713NT EC 105 16V 470UF KZE16V 0 PCS

C925 67L215N4713NT EC 105 16V 470UF KZE16V 0 PCS

F901 84L 56 1 FUSE 2A 250V WICKMANN 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: PW1742LGD1SMT POWER BOARD

-------- ------------------- -------------------------- -------- -----

U201 56L 608 1 TL1451ACD 1 PCS

U201 56L 622 1 BA9741F-SMT 0 PCS

Q205 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS

Q206 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS

Q207 57L 417 6 PMBS3906/PHILIPS-SMT(06 1 PCS

Q208 57L 417 6 PMBS3906/PHILIPS-SMT(06 1 PCS

Q203 57L 600 37 STS6PF30L SO-8 0 PCS

Q204 57L 600 37 STS6PF30L SO-8 0 PCS

Q202 57L 760 4 DTA144WKA BY ROHM SMT(7 1 PCS

Q201 57L 760 5 DTC144WKA BY ROHM SMT(8 1 PCS

Q203 57L 763 3 AO4411 SO-8 BY AOS SMT 0 PCS

Q204 57L 763 3 AO4411 SO-8 BY AOS SMT 0 PCS

Q203 57L 763 4 RSS050P03 1 PCS

Q204 57L 763 4 RSS050P03 1 PCS

R204 61L0603103 CHIPR 10K OHM +-5% 1/10 1 PCS

R210 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R211 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R220 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R221 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R238 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R239 61L0603123 CHIP 12K OHM 1/10W 1 PCS

R222 61L0603153 CHIPR 15KOHM+-5% 1/10W 1 PCS

R223 61L0603153 CHIPR 15KOHM+-5% 1/10W 1 PCS

R216 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R217 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS

R212 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS

R213 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS

R214 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS

R215 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS

R218 61L0603471 CHIPR 470 OHM+-5% 1/10W 1 PCS

R219 61L0603471 CHIPR 470 OHM+-5% 1/10W 1 PCS

R208 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

R209 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS

Page 54: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

54

R236 61L0603511 CHIPR 510 OHM+-5% 1/10W 1 PCS

R237 61L0603511 CHIPR 510 OHM+-5% 1/10W 1 PCS

R202 61L0603512 CHIP 5.1K OHM 1/10W 1 PCS

R203 61L0603512 CHIP 5.1K OHM 1/10W 1 PCS

R240 61L0603513 CHIP 51K OHM 1/10W 1 PCS

R241 61L0603513 CHIP 51K OHM 1/10W 1 PCS

R234 61L0603621 CHIPR 620 OHM+-5% 1/10W 1 PCS

R235 61L0603621 CHIPR 620 OHM+-5% 1/10W 1 PCS

R205 61L0603683 CHIP 68K OHM 1/10W 1 PCS

R206 61L0603683 CHIP 68K OHM 1/10W 1 PCS

F201 61L1206000 CHIPR 0 OHM +-5% 1/4W 1 PCS

R912 61L1206101 CHIP 100 OHM 5% 1/4W 1 PCS

R928 61L1206102 CHIP 1K OHM 5% 1/4W 1 PCS

R913 61L1206103 CHIP 10KOHM 5% 1/4W 1 PCS

R901 61L1206105 CHIP 1MOHM 5% 1/4W 1 PCS

R902 61L1206105 CHIP 1MOHM 5% 1/4W 1 PCS

R914 61L1206243 CHIP 24K OHM 5% 1/4W 1 PCS

R909 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS

R910 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS

R911 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS

R908 61L1206519 CHIPR 510OHM +-5% 1/4W 1 PCS

C230 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS

C231 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS

C910 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS

C930 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS

C931 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS

C202 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS

C204 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS

C205 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS

C206 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS

C907 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS

C908 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS

C909 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS

C926 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS

C927 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS

C203 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C209 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C210 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C211 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C212 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

Page 55: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

55

C219 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C220 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS

C208 65L0805331 32 CHIP 330PF 50V X7R 0805 1 PCS

C221 65L0805474 22 CHIP 0.47UF 25V X7R 080 1 PCS

C222 65L0805474 22 CHIP 0.47UF 25V X7R 080 1 PCS

D203 93L 39S 3 T BZT52-C11 0 PCS

D204 93L 39S 3 T BZT52-C11 0 PCS

D203 93L 39S 8 T ZD RLZ11B ROHM 1 PCS

D204 93L 39S 8 T ZD RLZ11B ROHM 1 PCS

ZD901 93L 39S 12 T RLZ20B BY ROHM 1 PCS

ZD904 93L 39S 16 T SML4737A/1 0 PCS

ZD904 93L 39S 19 T PTZ7.5B 1 PCS

D201 93L2004 2A SM240A 0 PCS

D202 93L2004 2A SM240A 0 PCS

D201 93L3004 1 SMAL340XXXRO 3A 40V SMA 0 PCS

D202 93L3004 1 SMAL340XXXRO 3A 40V SMA 0 PCS

D201 93L3004 2 SR34 PAN JIT 1 PCS

D202 93L3004 2 SR34 PAN JIT 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L 560 57 DL D910/D911 ASS'Y

-------- ------------------- -------------------------- -------- -----

90L6064 1 HEAT SINK 1 PCS

D911 93L 60235 FCQ10A06(F10P06Q) 1 PCS

D911 93L 60236 FMB-26L 0 PCS

D910 93L 60238 FCH10A15 T0-220 1 PCS

D910 93L 60239 FME-210B T0-220 0 PCS

M1L1730 8128 SCREW M3x8 2 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L 560 61 05 R917 ASS'Y

-------- ------------------- -------------------------- -------- -----

R917 61L 2J39858H 0.390OHM 5% 2W 1 PCS

96L 29 6 SHRINK TUBE UL/CSA 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L 560 61 06 R903 ASS'Y

-------- ------------------- -------------------------- -------- -----

R903 61L152M10458F 100K OHM 5% 2W 1 PCS

96L 29 6 SHRINK TUBE UL/CSA 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L 780 57 DL Q903 ASS'Y

-------- ------------------- -------------------------- -------- -----

Page 56: Dell TFT-LCD Color Monitor E173FP Service Manual

DELL E173FP Service Manual

56

Q903 57L 600 35 STP8NK80ZFP 0 PCS

Q903 57L 667 15 FQPF7N80 TO-220F 1 PCS

90L6064 1 HEAT SINK 1 PCS

M1L1730 8128 SCREW M3x8 1 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L 780 87 DL CN901 ASS'Y

-------- ------------------- -------------------------- -------- -----

87L 501 14 RF AC SOCKET 1 PCS

95L 900 42 HARNESS 1 PCS

95L8021 2508 WIRE HARNESS 1 PCS

96L 29 6 SHRINK TUBE UL/CSA 3 PCS

-------- ------------------- -------------------------- -------- -----

PARENT NO: 705L780KB34 79 BACK COVER ASS'Y

-------- ------------------- -------------------------- -------- -----

12L 394 5 FOOT PORON 0 PCS

15L8053 1 BRACKET BASE 1 PCS

20L 015 1 RISER DIECASTING 1 PCS

34L1369 Y2 T VESA COVER 1 PCS

34L1370 Y2 T STAND FRANT 1 PCS

34L1371 Y2 T STAND BACK 1 PCS

34L1372 Y2 T BASE 1 PCS

37L 483 2 HINGE 1 PCS

M1L 130 8225 SCREW 3 PCS

M1L 140 8 47 SRCEW 4 PCS

Q1L 330 8 47 SCREW 3X8mm 4 PCS

Q1L 330 8 47 SCREW 3X8mm 2 PCS