10
Solar Charge Controller

Solar charge controller

Embed Size (px)

DESCRIPTION

Solar charge controller

Citation preview

Page 1: Solar charge controller

Solar Charge Controller

Page 2: Solar charge controller

About Solar charge controller:-

You must buy a solar charge controller if you are buying a solar power system because it will help the system battery to extend its life. Solar charge controller controls the electricity flow and also works on stabilizing the voltage of the device. Thus it as important device you must buy to increase the health of the battery of solar power system.

Page 3: Solar charge controller

Regulating the electricity of solar charge controller:-

At the time of over discharging when a 12 volt battery drops below the 11 volts. The low voltage disconnected circuit gets disconnected loads. It just reconnects the loads only the time when the charge is being accumulated. Photovoltaic panels work on the mechanism of pumping the current into the reverse direction which results in slight discharge from the battery. It is easily preventable with the help of a charge controller. In most of the controllers charge current passes through the semiconductor as it helps to pass it only one direction.

Page 4: Solar charge controller

Working of a PWM controller:- For the PWM charger working

mechanism which is two stages regulation the controller initially holds the voltage to the unit of safe maximum point until the battery gets fully charged. After that it drops he voltage lower for sustaining the trickle or finish charge. Two stage regulations are very important for the battery which is used now a day. It maintains full charge but decreases the loss of water and stress.

Page 5: Solar charge controller

Metering and display of the charge controllers:-

Solar Charge controllers come in various kinds of displays. The range starts from single red light displays to digital displays which are used for displaying the unit of voltage and currents. These displays are useful for monitoring the battery charges. This display is also used in the car which shows the amount of power in and out of the system. It also indicates the approximate charge of the battery of your car and the limit results.

Page 6: Solar charge controller

Electronic protections provided by this controller are:-

Overcharge protection is enabled in the battery at the end of the charge voltage

For boosting the charge voltage deep charge protection is used.

Reverse polarity for the load is protected with module and battery reconnection voltage.

It has a deep discharge protection with an automated electronic fuse.

Less risk of short circuit as the module and load are protected.

Circuit is protected without the battery. The degree of overload protection is high. Battery is over the voltage shutdown Module input is protected from the over voltage

protection.

Page 7: Solar charge controller

Specifications of this product:- The accuracy is maintained by a

digital microcontroller The grounding is done with common

positive concept. Voltage series regulation of the system

voltage It has a typical idle consumption with a

PWM control. Uses the technology named state of

charge. Temperature is compensated with an

open circuit voltage for solar module.

Page 8: Solar charge controller

Jams the overturn current

Prohibits from overcharging and undercharging

Manages the set points.

Page 9: Solar charge controller

For knowing about the cost of solar charge controller please visit the site of Medors.

For knowing the features and cost of the solar charge controllers go through the following link

http://www.medors.in/solar-off-grid-applications/

Page 10: Solar charge controller