Upload
saurav-kumar-sahoo
View
938
Download
8
Embed Size (px)
DESCRIPTION
dairy plant operations like Preparation of pasteurised milk, SMP, ETP or waste treatment in dairy plant. This is about concerned dairy plant OMFED, Odisha.
Citation preview
Milk Processing unit operations in Dairy Plant Venue of the Training:OMFED, Bhubaneswar
Topics Covered: Pasteurization of Milk and HTST Pasteurizer. Production procedure of Skimmed Milk Powder
(SMP). Effluent Treatment Plant (ETP).
Apex Level Milk Federation or dairy plant of Odisha, affiliated to “National Dairy Development Board (NDDB)”.
Milk Products From OMFED:
Pasteurized Milk (Toned: 3% Fat), Paneer, Table Butter, Ghee, Ice-cream, Flavoured Milk, Plain Curd,
Sweet Curd, Lassi, Buttermilk AND Skim Milk Powder (Powder Plant)
Milk from Silo For
Pasteurisation
Balance Tank
Duplex Filter
HTST PASTEURISER
HTST Pasteuriser:Raw Milk Regenerators(3,2,1)[Temp. 60°C] Heater [72°C]
FDV (Held For 15 Seconds)
Chiller (4°C)
PasteurisedMilk
Skim MilkBalance
TankDuplex Filter
Pre-Heater (4)
Pre-Heater (3)
Pre-Heater (1)
Pre-Heater (2)
(Temp. : 60°C)
Normal Temperature Pasteuriser
(NTP)
Temp. : 85°C
CALENDRIA(Falling Film
Principle)
Concentrated Milk
EVAPORATION CHAMBER
Stored in Conc. Tank for 2-3 Hrs(Temp: 50°C )
Duplex Filter
Spiral Holder
65°CSPRAYDRYERSPRAYDRYER
Skim Milk Powder (SMP)
Skim Milk Powder (SMP)
DRYING CHAMBER
DUPLEX FILTER FOR POWDER PLANT
SPIRAL HOLDER FOR THE POWDER PLANT AT OMFED PLANT
Aims at Treatment & Utilisation of Waste Products in order to avoid Environment Pollution
Primary Clarification : STRAINER
Macro particles Such as
Polyethylene,Conc. Fat/Sludge,And other WasteProducts areSeparated.
2. AGITATION CHAMBER: Sewerage is agitated through Pump Unit to break
down all Macro molecules of Sludge
2. AGITATION CHAMBER: Sewerage is agitated through Pump Unit to break
down all Macro molecules of Sludge
In the Third section, after being passed out from the “Agitation Chamber”, The sewerage enters into
“DECOMPOSITION CHAMBER”.
Here, In the Decomposition Chamber, the waste products were allowed for Anaerobic
Decomposition, resulting in the Production of Methane Gas.
Methane gas is used for Electricity Generation, for
partial compensation of the Power Consumption by the plant
Urea, Grommer & Cow dung are added with agitation for Aeration of the Slurry
4. AERATION CHAMBER
5. CLARIFICATION CHAMBER
From “Clarification Chamber”, Liquid effluents gets collected in “TREATED EFFLUENT SUMP”. This water can be used for gardening purposes.
Solid Sludge
TREATED EFFLUENT SUMP