View
10
Download
0
Category
Preview:
Citation preview
~~EN IR Y
COMAND Online I Audio50 I Audio 20: The central display inter
mittently displays the message "Anti-theft protection activated"
Topic number
Version
Design group
Date
Validity
Reason for change
Reason for block
Complaint:
Ll82.85-P-058185
4
82.85 Navigation and Communication system (CNS, ICS, COMAND, FleetBoard)
09-02-2014
Model 11 7, 156, 166, 172, 176,204 , 207,212,218, 246 with OM651
Validity adapted. Remedy adapted.
Intermittently after the COMAND Online (A40/3) or Audio 50 (A2/56) or Audio 20 (A2) control unit has booted up, the Audio/COMAND display (A40/8) may show the fault message "Anti-theft protection activated. Please visit your Mercedes-Benz workshop" (see attachment for examples). The fault code 9561 "The PIN for the anti-theft protection is incorrect or absent" is current and/or stored in the quick test of XENTRY Diagnostics in the COMAND Online (A40/3) or Audio 50 (A2/56) or Audio 20 (A2) control unit. When the complaint is active, the COMAND Online (A40/3) or Audio 50 (A2/56) or Audio 20 (A2) control unit cannot be operated .
Attachments
File Description
display _message .jpg Event message "Anti-theft protection activated".
Displaymeldung .jpg Display message "Anti-theft protection activated".
Cause: CAN communication wi th motor electronics control unit (N3/9).
Remedy: ill. Check of glow time output stage (N14/3) by means of voltage test: Important: There are two different connector variants, 8-pin (without fuel-filter heater) and 10-pin (with fuel-filter heater); the pin assignments of the glow time output stages can be found in the attachment. 1. Remove glow time output stage (N 14/3). 2. Apply 12 V to circuit 30 and circuit 31 of glow time output stage (N14/3) (e.g. from on-board electrical system battery). 3. Measure voltage between circuit 15 (without fuel-filter heater) or 87 (with fuel-filter heater) and circuit 31 of glow time output stage (N14/3) using a multimeter. The glow time output stage is defective if the multimeter indicates a voltage greater than approx. 1 V. If this test confirms that the glow time output stage (N14/3) is defective, it must be replaced. If the issue in the glow time output stage is not confirmed, perform remedy b). 121 Please perform the following work: - Check circuit 30 pin in connector "F" (2) of motor electronics control unit (N3/9) for voltage, expansion of pin and corrosion.
09-02-2014 5:46 PM ©Copyright Daimler AG
PLUBONS Page 1/10
\\ .
~~ENTRY
- Check chassis CAN (high and low) pins in connector "F" (2) of motor electronics control unit (N3/9) for expansion of pin and corrosion. Causes identified to date include e.g.: - Pin of circuit 30 in connector "F" (2) of motor electronics control unit (N3/9) not clipped in at connector housing (cf. attachment "Circuit 30 pin.jpg"). - Pin of ci rcuit 30 in connector "F" (2) of motor electronics control unit (N3/9) or in control unit itself corroded. - Connector in front SAM control unit (connector 41), which supplies the motor electronics control unit (N3/9) with cir-cuit 30(z) and chassis CAN, was not clipped in correctly (refer to wiring diagram in WIS for pin assignment). - Wiring harness was chafed under the wiper linkage (cf. attachment "Figure 2a.jpg" and "Figure 2b.jpg"). -> 12V was measured in the vo ltage measurement at the pin of circuit 30 in connector "F" (2) of the motor electronics control unit (N3/9), but this voltage collapsed under load. If no noticeable problems are found here, perform remedy c). g Perform the test procedure described in the attachment. If this cause the theft protection to activate, replace the motor electronics control unit (N3/9). If the complaint still exists after replacement of the engine control unit, perform remedy d). Q} Create a TIPS case containing the following data : current quick test and current control unit log for COMAND Online (A40/3) or Audio 50 (A2/56) or Audio 20 (A2). J.rru:lortant: Always use the damage code of the part causing the damage! Note: Replacing the COMAND Online control unit (A40/3), the Audio50 control unit (A2/56) or the Audio20 control unit (A2) does not remedy the problem.
Attachments
File Description
Abbildung 1 .jpg Circuit 30 pin not locked
Abbildung 2a.JPG Chafed cable set
Abbildung 2b.JPG Chafed cable set
Prufablauf_Diebstahlschutz.pdf Test procedure
test-procedure_antitheft.pdf Test procedure
Stecker_Connector 8 pins .pdf Connector, 8-pin
Stecker_Connector 10 pins.pdf Connector, 10-pin
Symptoms
Communication/information I Entertainment I Display message I Enter security code
Communication/information I Entertainment I Display message I Service Required
Communication/information I Entertainment I Display message I Please enter activation code!
Communication/information I Entertainment I Display message I Antitheft protection active!
Work units
Op. no. Operation text Time Damage Note code
15-4422 REPLACE GLOW OUTPUT STAGE OF 4AW 82546 52 Use only if remedy a) rectified the PREGLOW SYSTEM (AFTER CHECK)
54-0650 MAINTAIN BATIERY VOLTAGE (FOR TESTING AND DIAGNOSIS WORK)
54-1011 PERFORM QUICK TEST
54-9824 REPLACE ENGINE CONTROL UNIT
09-02-2014 5:46 PM ©Copyright Daimler AG
complaint.
1AW
3AW
4AW 54581 73 Use only if remedy c) rectified the complaint.
PLUBONS Page 2/10
~~ ENT R \'
Validity
Vehicle
A (176)
B (242, 246)
c (204)
CLA (117)
CLS (218)
E (207)
E (212)
GLA {156)
GLK (204)
M (166)
SLK (172)
Full model designation breakdown
Vehicle
11 7.301
117.301
11 7.302
11 7.303
11 7.305
117.308
117.308
156.902
156.903
156.905
156.908
156.908
166.003
166.004
172.403
172.403
172.403
176.000
176.000
176.001
176.001
176.002
176.003
176.005
176.007
176.007
09-02-2014 5:46 PM © Copyright Daimler AG
Engine Transmission
651 . 651 . 651 . 651 . 651 . 651 . 651 . 651 . 651 . 651 . 651 .
Engine Transmission
651.901 711 .642
651.901 724.003
651.930 724 .011
651.930 724.003
651.930 724.011
651 .930 711 .645
651.930 724 .003
651.930 724.011
651.930 724.004
651.930 724.011
651.930 711 .632
651.930 724.004
651.960 722.908
651 .960 722.908
651.980 7 11 .670
651.980 722.908
651.980 725.011
651.901 711.642
651.901 724.003
651.901 7 11 .642
651.901 724.003
651.930 724.011
651.930 724.003
651.930 724.011
651.930 71 1.645
651 .930 724.003
PLUBONS Page 3/10
~~ENTRY
176.008
176.008
204.000
204 .000
204.000
204 .000
204.001
204 .001
204.001
204.001
204.002
204 .002
204 .002
204 .002
204 .003
204.003
204.003
204.082
204 .084
204 .084
204.200
204 .200
204 .200
204.200
204.201
204.201
204.201
204.201
204.202
204.202
204.202
204 .202
204.203
204.203
204 .203
204.282
204.284
204.284
204.302
204.302
204.302
204.302
204 .303
09-02-2014 5:46 PM ©Copyright Daimler AG
651.930 711 .645
651.930 724.003
651.913 71 1.653
651.913 716.656
651.913 722.694
651.913 722.996
651.913 711.653
651.913 716.656
651.913 722.694
651 .913 722.996
651.911 711 .653
651.911 716.656
651.911 722.646
651.9 11 722.908
651.911 711.670
651.911 722.646
651.911 722.908
651.912 722.965
651.912 71 1.653
651 .912 722.965
651.913 7 11 .653
651.913 716.656
651.913 722.694
651.913 722.996
651.913 71 1.653
651.913 716.656
651.913 722.694
651.913 722.996
651.911 71 1.653
651.911 716.656
651.911 722.646
651.911 722.908
651.911 711.670
651.911 722.646
651.911 722.908
651.912 722.965
651.912 7 11 .653
651.912 722.965
651.911 711.653
651.911 716.656
651.911 722.646
651.911 722.908
651 .911 711 .670
PLUBONS Page 4/10
~~ENT -\ .
204.303 651.911 722.646
204.303 651.91 1 722.908
204.901 651.916 711 .653
204 .901 651.916 722.908
204 .901 651.916 722.996
204 .902 651.916 711.653
204.902 651 .916 716.658
204.902 651.916 722.908
204 .904 651.912 722.965
204.982 651.912 722.965
204.984 651.912 722.965
204 .997 651.912 722.965
207 .301 651.911 711 .653
207 .301 651 .911 722.646
207 .301 651.91 1 722.908
207 .301 651.911 725.011
207.302 651.911 711 .653
207.302 651.911 716.656
207.302 651.911 722.646
207.302 651.911 722.908
207.302 651.911 725.011
207.303 651.911 711 .670
207 .303 651.911 722.646
207.303 651 .911 722.908
207.303 651.911 725.011
207.304 651 .911 711 .670
207.304 651.911 722.646
207.304 651.911 722.908
207.304 651.911 725.011
207.401 651.911 7 11 .653
207.401 651.911 722.646
207.401 651 .911 722 .908
207.401 651.911 725.01 1
207.402 651.911 71 1.653
207.402 651 .911 716.656
207.402 651 .911 722.646
207.402 651.911 722.908
207.402 651.911 725.01 1
207.403 651 .911 7 11.670
207.403 651.911 722.646
207.403 651.911 722.908
207.403 651.911 725.011
207.404 651 .911 711 .670
09-02-2014 5:46 PM PLUBONS © Copyright Daimler AG Page 5/10
~~ENTRY
207.404
207.404
207.404
212.001
212.001
212.001
212.001
212.002
212.002
212.002
212.002
212.002
212.003
212.003
212.003
212.003
212.004
212.004
212.004
212.004
212.005
212.005
212.005
212.005
212.005
212.006
212.006
212.006
212.006
212.082
212.097
212.098
212.201
212.201
212.201
212.201
212.202
212.202
212.202
212.202
212.202
212.203
212.203
09-02-2014 5:46 PM © Copyright Daimler AG
651.911 722.646
651.911 722.908
651.911 725.011
651.924 711 .653
651.924 722.646
651.924 722.908
651.924 725.011
651.924 711 .653
651.924 716.656
651.924 722.646
651.924 722.908
651.924 725.011
651.924 711 .670
651 .924 722.646
651.924 722.908
651.924 725.011
651.924 711 .670
651.924 722.646
651.924 722.908
651.924 725.011
651.925 711 .653
651.925 716.656
651.925 722.694
651.925 722.996
651.925 725.011
651.925 71 1.653
651.925 722.694
651.925 722.996
651.925 725.011
651.924 722.965
651.924 722.965
651.924 724.208
651.924 71 1.653
651.924 722.646
651.924 722.908
651.924 725.011
651.924 7 11 .653
651.924 716.656
651.924 722.646
651.924 722.908
651 .924 725.011
651.924 711 .670
651.924 722.646
PLUBONS Page 6/10
~~EN IR\'
212.203
212.203
212.204
212.204
212.204
212.204
212.205
212.205
212.205
212.205
212.205
212 .206
212.206
212.206
212.206
212.282
212.297
212.298
218.301
218.301
218.303
218.303
218.304
218.304
218.397
218.901
218.901
218.903
218.903
218.904
218.904
218.997
246.200
246.200
246.201
246.201
246.202
246.203
246.205
246.207
246.207
246.208
246.208
09-02-2014 5:46 PM © Copyright Daimler AG
651 .924
651 .924
651 .924
651.924
651 .924
651.924
651.925
651.925
651.925
651.925
651.925
651.925
651 .925
651 .925
651.925
651.924
651.924
651 .924
651 .924
651 .924
651.924
651 .924
651.924
651 .924
651.924
651 .924
651.924
651.924
651.924
651 .924
651.924
651.924
651 .901
651.901
651.901
651 .901
651.930
651 .930
651 .930
651.930
651.930
651 .930
651.930
PLUBONS
722.908
725.01 1
71 1.670
722.646
722.908
725.011
711.653
716.656
722.694
722.996
725.011
711 .653
722.694
722.996
725.01 1
722.965
722.965
724.208
722.908
725.011
722.908
725.01 1
722.908
725.011
722.965
722.908
725.01 1
722.908
725.011
722.908
725.01 1
722.965
711 .642
724.003
711 .642
724.003
724.011
724.003
724.01 1
711 .645
724.003
71 1.645
724.003
Page 7/10
~~ENTRY
J Attachments display _message.jpg:
Displaymeldung.jpg:
09-02-2014 5:46 PM © Copyright Daimler AG
PLUBONS Page 8/10
i~ ENTRY
Abbildung 1.jpg:
Abbildung 2a.JPG:
09-02-201 4 5:46 PM © Copyright Daimler AG
On the CDI control unit F connector, the PIN 16 (Terminal 30) was loose inside
PLUBONS Page 9/10
~~ENTRY
Abbildung 2b.JPG:
09-02-2014 5:46 PM PLUBONS © Copyright Daimler AG Page 10/10
Testablauf (auf dem Fahrerplatz sitzend): (Die Punkte 1 und 2 sind keine Alternativen sondern nacheinander durchzuflihren)
1. Fahrzeug in Busruhe bringen: >- alle Tliren schlieBen Y Schlusse l aus dem EZS (N73) abziehen >-- ggf. Warnmeldungen auf dem Kombiinstrument quittieren >-- Fahrertur offnen und gleich wieder schlieBen >-- warten bis sich das Kombiinstrument abschaltet >- weitere 30 Sekunden warten
2. Start ohne Zundung: Y Head Unit uber den ON-Button starten );:> Schlussel in das EZS (N73) stecken );:> Schlussel auf erste Raste drehen (ACC, Klemme 15R) >-- 30 Sekunden warten
Falls das beschriebene Fehlerbild vorliegt, erscheint im Audio/ COMAND Display (A40/ 8) die Fehlermeldung "Diebstahlschutz aktiv" .
Gegenprobe: Die oben beschriebene Sequenz wiederholen, jedoch unter .,2 . Start ohne Zundung" den Schlussel sofort auf die zweite Raste drehen (IGN, Klemme 15). Die Fehlermeldung "Diebstahlschu tz aktiv" so llte in diesem Fa ll nicht erscheinen.
Test procedure (sitting on the driver's seat): (Points 1 and 2 are no alternatives but to carry out one after another)
1. Bring the vehicle CAN-Bus in its sleeping mode >- close all doors >-- remove the key out of the EIS (N73) >-- confirm any potential messages in the instrument cluster >- open driver's door and shut it immediately );:- wait until the instrument cluster goes into its sleeping mode ;.... wait another 30 s
2. Start without ignition 'Y start the head unit without ignition ? insert the key in the EIS (N73) ;.... turn it to the first position (terminal 15R) 'Y wait for 30 s
If the described issue is present, the error message "antitheft protection active" appears in the Audio/COMAND display (A40/ 8).
Countercheck: Repeat the sequence described above, but below "2. Start without ignition" turn the key immediately to the second position (IGN terminal 15). The error message "antitheft protection active" should not appear in thi s case.
Detail B: Anschlussbild I pin assignment
G4 G3 G2 G1
LIN 15 31 NC KL30
Detail A: Anschlussbild I pin assignment 2: 1
© 6 7 8
Sensor Kl31 LIN
2 I 2
9 K.187
4
G3
10 G1
5
G2 ~ ~
Recommended