17
No Diving or Jumping. Observe all Safety Rules. 1-1 1 Pool Component Installation Manual General Instructions A All Round Pools Part No. 1920283 rev. 4 SECTION Your pool contains a large quantity of water, and is deep enough to present inherent dangers to life and health unless the following safety rules are strictly observed. irst- time users run the highest risk of injury. Make sure everyone understands all safety rules before entering the pool. Post NO DIVING and NO JUMPING signs beside the pool. or additional safety information please read the enclosed booklet The Sensible Way To Enjoy Your Aboveground/Onground Swimming Pool. 1. No Jumping or Diving The top rail of your pool is not a walkway and must not be used for jumping or diving. Do not permit jumping or diving into the pool from a deck or the top rail of the pool. Diving or jumping into the pool can result in serious injury. 2. Never use the Pool Alone Never permit the pool to be used unless it is attended by at least one person other than the bather. Someone should always be available to lend assistance in an emergency. 3. Never Leave Children Unattended Never leave a child alone and unsupervised in or near the poolnot even for a sec- ond. There is no substitute for constant adult supervision. 4. No Rough-housing Do not permit rough-housing in and around your pool. Surfaces can become slip- pery and hazardous when wet. 5. Light the Pool at Night If the pool is used after dusk, adequate lighting must be provided. Illumination in the pool area must be sufficient to clearly judge pool depth and all features in and around the pool. or lighting recommendations, consult your local licensed electrical contractor. 6. Restrict Access to the Pool Do not leave chairs or other furniture beside the pool that could be used by a child to climb up into the pool. Ladders must be removed whenever the pool is unattended. A fence with a lockable gate around the pool or yard is strongly recommended and may be required by law in some jurisdictions. 7. No Alcohol or Drugs The use of alcohol or drugs does not mix with pool activities. Persons who have been drinking alcohol or using any drugs should not be allowed in the pool, and should be carefully supervised in the surrounding area. 8. Keep Your Pool Clean and Sanitary Your filter system will remove suspended particles from the water and the surface skimmer will remove insects, leaves and other debris from the water surface. Use the correct pool chemicals as directed to destroy harmful bacteria and prevent formation of algae. Remember, unsanitary water is a serious health hazard. Safety Rules or Pool Owners This manual must be left with the pool owner

 · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

  • Upload
    lyhuong

  • View
    221

  • Download
    0

Embed Size (px)

Citation preview

Page 1:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ����������������������������

���������������� �� ���

� �� �

������������ ����

����������������

❏ � ��������������������

�������

������������� ��� �� ������ ��������� ����� ������������������������������

������������� ��� ������������������������ ����������� ������������� �������!�����

��"��������������������������#�����$�����% #�������������������� �� ���� ����

������ ������������������������������� ��� �������������� ��������������

!��� ���� ��� ���������" ������� ����� ������������ ��#��������������������

������������� ��������!"������!��#�������$����

�������������������������&�������� ���������������������� �� �#� �� ���������� ����������$�"������������

����������"���$�"����������������������������"� ���#������������� ���������������

'��������$�"������������������ �������������������$����

������������������������������"��������������� ������������������ ����� �� ���� ��������������������

���� ������(�"���������� �� ��� �� � �� ��������� ����� ����� ��"�������

�������! ������"���#� �""������� ��� ������ ���� ������������������ ����������)����������� �����

���&������������ ���������������� �� ���������������

$������%&����'�������(����������"���*������������+��� � ���������������(��� ����� � ���"�������

����� �� , �������������

)���!����������� �����-������������������ �������#�� ��� ���������������� ����������-���"� ���������

����� �� �"���� ������������������ ����$�������������� � ����� ��������

��������������!���������������""� ��������������������� ����������������� �

���� �����

*���&���+��++�������������������� ����� ���������������������� ���������������� ������� ������ �� ��������

���" ������������������. ��������� ����"������������������������� �������

���������� ����# ���� ��� ����������������� �����������������""���

" �� ���������� ��� ������"��$�����������

,��������+�������������&���������� ������������������������"�/����������� ����������������������� ��� ��

��#��� ��������������� ���������������� �� ������������������ ������� �

� ��������������������������������� �� �

-���.��/����������� �� �"�� �� �0�����������������"��������"������������ �����������"������ ���� ��������� ��

�#�""����������"�������������� ���� �������� �������"������ �������� ����0������

����������������"�� ��� �������������������� �"���� ����� � �����������" ���

��� �� ��������������� �� ���� ������� ����������� ����� , ��

� 10�&����2���������3���

������ �� ������4��1�3�����������3��

Page 2:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������1

�� ����"�+��������� ������0��������& "� ��������+�����+�����0�41���0���4����

&�����������������/�� ������������ ��������������(�"��������������

����� �����������������(� �������������� �������������� ��������������

������������������������$���������������������������������

���������� ����� ��� 10�&���� ������������������������#��������

�������� � ��������� ������ �� ������� ���2������������ ����

� 10�&����� �" #������������������������������������ �� ����� �����"�

5� ������ �!�+ ����1���0���������� ������ ��

� ������� �� ������������������������������� �����������������3

4 5������ �� ���� �� �� ���� �

������� ������� ���

4 5������ ���������������"

� ���)"�������� �����������

����������� ��� ����� ��� �

������ ���� ������� ��"����

����������"�� ������� ��

�����

4 5���#����������������� ���

��������������6� ����������

����� �� ��&�������������� ��

" ����������������������

����������������� ��������� �

������ ��������� ������

��� �����������

4 (����� �� ������������� �

" �������� �������� � �

��������������� ������������

�����) ������ ����������

� ����"����������"�����

����� ���

$

!����� ����6

6�������� � �

����������������

"�����"���� �

��������������� ��

� ��������������

������1���" ���

�������������������

������������ ���"�

���������"������

��� ������� �

��"������������

���������������

������������ ����

Page 3:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������7

�� �������������"

��������� �������������� ����

�� �����������������3

4 8���� ��������� � �����

4 8����� ������� ���������

�����

4 2����������� ����������

� ��������� ������������

������������������������

����������� �������4'

1����������

4 9����� ���������� ��

4 ��� ������������� � ���

4 6� ���������� ��������6� ��

������������� �����������

������ ������� ������

����� " �����������������

4 ��� ������������� ������������ �������#�����������"�� �����

�������,����

� �� ���� "

4 :�������� �� ��� � $ ������#�� ���;�2������������ ��

���"�

4 :�������� ������������ �������������������� ���� ������ ����

���������������� �;�.�� �������������� ���������������������� ���

� ������"���� ����� ���� �� ������������ �����

�� ��� ���

2���" �����1

0���������� � �7��������

� '����� �����������������

������+���������� ��

����������� ������������

� 0��� �������������������

�������������� � ��

������ ��� ���� �" �#�

�������������������5�����

�������������������������

�����������������"������� ��

�������/��� ����&���������

����� ��<=�>�?@�"A� ������ ��

������ ����������

) *

,

-

Size of foundation circle

Size of pool

6"(15 cm)

8

!����� �6

:������ �������

������������������

4��������� #�

���������� ���

������������

>��#��� ����

�����A��������� �

���"��>�� ��

���"���� ,� ��

����A��� ����������

" �����������

�������� ���

������� ����������

���������"���

���� ����� ���

��� ������������

���������

Page 4:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ����������������������������

�������9 !�����1������ !�����1��'40'$

�1B <B�<=�>1CC@�"A <B�<=�>1CC@�"A

�?B DB�C=�>1��@�"A DB�C=�>1��@�"A

�DB EB�<=�>1EC@�"A EB�<=�>1EC@�"A

1�B ��B�C=�>77?@�"A ��B�C=�>77?@�"A

1�B �1B�<=�>7DC@�"A �1B�<=�>7DC@�"A

1FB ��B�C=�>�1<@�"A ��B�C=�>�1<@�"A

�� &��������" � ��"���� ������ ��� ��

���"������������

� ��"���� ������#��������

����������"������������

� � 7����� �2� � �"�!��

� ���� ����������������������

�� ���������� #��� ���� ����=

>1?@""A���� ��� �<=

>�?@�"A������'����������

������������������������ ���

� � ����������� ��� ���

1� ������������������������ #��

5�������������������1� ���

������������������������"

������ ��� �����0��� � ��

����������������������

�������1� ������������� #�������

������� �������� ��������

�� ���� �� ������G�������������

1� ���� ���������� � ���

�����������������������

����������

&��4�6

����������"���� �

����������������

& #��������"�����

������ ������

�������� ������

����������������

!:��6

0��� ���������G�

�� �������� ����

� ������G�����������

������ � �� ���

��

��

�;

Page 5:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������?

� ��"���� �����������������

����� ����������������� #���2�

���� ������������ ����"���

��������"���������������

������ �� ���� �� ����"�"�

������������������ �������

�������=�>1?@""A� ���������

� "�����������������

�� ����������������� �� ���!�����

�������� ��� ��� ������ �

�������������������(" ������

���������" �� �����������

����������������� ��� ��

� �#������� �� "���������

�� ������#������������1=�>7C@�"A

�����������������������������

� �������� ���% #������������

������������������������&��

����"������������������ ��

����������� ������������ �� ������ ����������

$� � ��������<����� �=

� 5�������� ����������" �� ���� ��� ������ ������� ��������� �

����"���������������&������������ ��� ���" #��� � �����

��� ������������������ ����� �����������1=�>7C@�"A����� ���������

�������� ��������������� �������#��5�����������" �����

� ����������������������������������"������� ����������/�

� ���

12"(30 cm)

�*

&��4�6

&����������1=

>7C@�"A�������

�������"���� �

������������ ���&��

����"�����������

���������������� �

�����������

� ������ ��

��������& #�����

��"�����������

������������ �� ���

������������ ��

������

�$

�)

Page 6:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������<

�������9 ���4���1�� ��������<����� �=

�1B �C

�?B �C

�DB �1

1�B ��

1�B �<

1FB �D

� &�"��� ������ ���������� ��

� ���� � ����� ���� ���

������������H ��� ����� ��

����������������� ��������

� ����������% #�� �" �#��

��������� ��� ��� ��

�� ���

�� ��"�������� ���� ����

����� ���� �� ���������

� ���������� ��������������

���������� ����� ���������

� &���� �������������� �

��#��������������������

����� ����������������������

�������"��0�������� ����

���G�����������" #����������

� ���������� ������������

������ ���������������

������0�������� ������G�

������ � �1� ���� �����

� �������������" #����������

������ ��������������� ��

������

�� ��"���������������� #�� �1� ����

)� ���+"����+�����

� 5�����������(������1���� ���" �������������

� &�����������(����������� �������" ��������� ����� ��������

������ ���" ��������������

�-

�8

�,

Page 7:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������F

�� � �� ������0������������������� ������������� ������������������������������������������

#���������� � ��������� ���

�� ���!���

� 5���#��������������� ���������� #��

� %������� ����� � ��" ������������������� ���� ���#���

�� �����> ��� �"�?��+ ���������

� I�������������� ��� ������� ������"����� ��: �����������

�������������"����� ������������� � ����������"�� �����

��� �����

� : ������� �����������������"�� ��������� � ��

�� ���� �� ������������������ ���������� ���������� �����

� 5���#� ���"�� ��� ������������������ ����� ���� ������������� ���

�� &����������� ������ ������� �� ���"�� ��� ���������" �����

��������� ����!�������������������������� ���� �

�� H����������� ��������������� ��������������������������1=�>7C��"A

�������"�������������������������������"����������� ���

���#�������������������������������������� ���

�� � ������� �� ���������� ���� #�� �������#�""��� ������

��������.� #������ ����/���""�� �����

�� >����9����0���������������������������""����� ��������"�����������������������������" #�

������������ ����������������

�� !�3����> ��!�� ���.���������� ��������������������������������� ����<=�>�?��"A� ��������

� �����������������

�����"���� ��������� �� ������������#�""��� ������������������ 7����

���3 �����"� ��"�1�������7������������@� �"�� 7���������� ���4�����1����7���������1�#��!#AA���

�� ��+7� ��������� �"��+�3�

���% #������� ��������� "��$����� ��������������������������% #����������

������ ���� ���������������"����� ����"�� ���

���% #������� ���������� � ����� ���������

� ��+7�1���&��� ��� ����� ��������������� �� ������� ��������� ���

$� ��+7���!���% #������������������������������������ �� ����������������� ���������� ����

����������������"����������������"��������������"�� ���������������������������/������� �� ������������ �� �������� �������"������������������������

)��2��"����! 7�

% #����������������� ������ #����5���#���������������� #�� ���� ��� �

����������� ������� ������.� #��������������� �� ����������� " �����

����������

� ����6

5��������

" ������������

����� �"�� �

� �����: ��� �

������������� � ��

&��4�6

��������� �� ���

���������� ���"���

����� ���

����#�������� ���

������ ������ ��

������������ ��

� ����� ����

� ����6

������� �� ��

����� �������"

�����������������

������� �"����

��"�������������

���"��������

" ������ �����

����������

������"��B�� �

Page 8:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

��������������� ����� ���������������������������D

&��4�6

! ������������ ��

����*����

:�����,���I��+

�����������

������,���������

�������� �����

��������������

������������" �

������������

� �� ���

*� ������++��������"���� �������� ��������������"����������������������� ����.� ������

�#�""��� ��������� ���� +�"�������������� �����H������� �������#�""��

��������� ���� �"���������� ���4�����1����7��������������� � ++���� "�3 ��+ ��"� ������"� �0�

,�����2���'����������������������"������������!������������������������������������,��

������������

����� ��>����9�������+���������6

&���� ����������"���� ��" �� ��� ���� ���7+� ����������#�""��

�����������������������������(�������� ����"���� ����"���� �

��"������ �������������������� ��������G������������#�""��

�����������������&���� �������� +�"������7����� �"�����1����������������� ���4�����1����7������#���4

7���������� � ++���� "�3 ��+ ��"� ������"� �0�

������3�����(��7�����6

-� ������������ ��������������:�����,���I���>� �����" ����7FC�7DA

"���� ������������������1+��#�""���>����������� ���� ����A

2 ���������� �����%�����>����9����.�(� �"�1����3��3����9�������+"��@���� ++��" �+�3�����������+����@�� 0

���"��������3 �� �0�

&��������:�����,���I���>� �����" ����7FC�7DA���� ���� � �� ������"

����������� ����

���������6

'����� �� ������������������������������ ����������������� ��� �����

�����#�""���

�����:�������I��

�1+�:���%����

(#�""��

% �� ��� ���

������ ���� ���7+

������#�""��

����������������

���������

7+

-��������������:�����,���I���>� �����" ����7FC�7DA����������#�""��

�����������������������������#�""����� �����8���"���#�""��������" �� �

����� ���������"������� "����" #�� ������������� J������� �����

��������#����������� ������������������

Page 9:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

A. Assemble your Pool Base1. Lay out the Base Plates and Bottom Rails

a. Place the base plates equallyspaced around the perimeter ofyour foundation. If you areusing the optional patio stones,place one base plate on eachstone.

b. Slide the curved bottom railstogether with the base plates.Leave a 2-1/8" (55 mm) gapbetween the ends of the bottomrails.

2. Spread out Brick Sanda. Spread a layer of fine brick

sand over the foundation area,2" (5 cm) deep. Use a rake tomake the brick sand flat andsmooth. Instead of brick sand,you can use 1" or 1-1/2" (25 or 38mm) thick sheets of styrofoam.Cut the sheets to fit and jointhem with duct tape along thewhole length of each seam.

No Diving or Jumping. Observe all Safety Rules.

SECTION Pool Component Installation Manual

Assembling thePool Base

2-1

2

5

?Remember:Spread brick sand orsheets of styrofoamout over the entirepool foundation areainside the base rails.This provides aprotective surface forthe pool liner to reston. Pools with astyrofoam layermust still have acove.

2-1/8" (55 mm) gap2-1/8" (55 mm) gap

43

1

2

!Note:If you want, insteadof using patio stonesyou can makecrushed limestonepads. Dig a 12" x 12"(30 x 30 cm) squarehole 2" (5 cm) deepand fill the hole withcrushed limestone,packing it downhard. Spray thecrushed limestonewith water as youpack it down.

A❏ Part No. 1920289 rev. 1

Page 10:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.

A. Assemble your Pool WallThis section is for Round and Oval pools (Round pools are shown).

1. Set the Pool Wall in placea. Wait for a calm day. Do not attempt to install the pool wall in the wind.b. Unpackage the coiled pool wall

and stand it on a piece of card-board or plywood at the centreof the pool. The cut-outs for thethrough-the-wall skimmershould be towards the top of thewall. Look for a “THIS WAY UP”label and arrow.

c. Start uncoiling the wall, guid-ing the bottom edge into thecurved bottom rail. The startingend of the wall must be posi-tioned over a base plate, andthe skimmer and return holesshould be positioned where thepump and filter will be.

d. Set lengths of slotted tube ontothe top edge of the wall as youuncoil it and join the slottedtubes with connectors as yougo, leaving a 1/2" (13 mm) gapbetween each. Make sure thegap is directly above the baseplate (this applies to roundpools, oval pools and GibraltarStyle pools). (If you have abeaded pool liner, set lengthsof liner retainer on the top edgeof the wall first, then the slottedtubes and connectors.)

SECTION Pool Component Installation Manual

Assembling thePool Wall & Liner

3-1

3

!Caution:Do not attempt toinstall the pool wallin the wind. Wait fora calm day.

!Hint:Bring the followingitems onto the poolfoundation beforeyou start uncoilingthe pool wall: thepool liner, someextra brick sand tomake the cove inStep 5, and a ladderto climb out after thewall is assembled.

1

?Remember:For best results, theskimmer should bemounted on thedownwind side ofthe pool (that is,directly across fromthe most commonwind direction).

Locate the skimmer on this side

Wind

(Retainer for beaded liner only)

2

3 4

Page 11:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

e. Work around the foundation until the entire pool wall is uncoiled into thebottom rails and the top edge is covered with slotted tubes and connec-tors (and beaded liner retainers if you have a beaded pool liner).

2. Join the Ends of the Pool Walla. Line up the holes in the two

ends of the pool wall.

b. To line up the holes, make the circle bigger orsmaller by nudging the base plates in or out withyour foot.

c. Join the ends of the pool wallwith a bolt and nut througheach hole. Place each bolt headtowards the inside of the pooland each nut towards the out-side.

d. Tighten each bolt and nut se-curely.

e. Cover the seam and bolt headson the inside of the pool wallcompletely with 2" (50 mm) ducttape.

No Diving or Jumping. Observe all Safety Rules.3-2

?Remember:The bolt heads mustbe toward the insideof the pool. Coverthe bolt heads withduct tape.

!

Hint:Stick a screwdriverthrough two of theholes to help line upthe ends of the wall.

Inside

Outside

7

Inside

Outside

5

6

InsideOutside

8

Page 12:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

3. Make sure the Pool Wall is Levela. Use a length of string and a

line-level to check across thetop edge of the pool wall to seeif it is level. Check the wall inseveral different directions. Thewall must be level. If the level isoff by more than 1" (25 mm)across the diameter of the pool,take the wall apart and levelthe foundation again.

4. Make sure the Pool Wall is Rounda. Using a tape measure, measure

across the circle at each baseplate. The pool wall must beround within 1" (25 mm) (all ofthe measurements must bewithin 1" (25 mm) of each other).Adjust the circle by nudging thebase plates in or out with yourfoot.

b. Adjusting the pool to the proper shape may causethe base rails and base plates to slip out of align-ment a little. Recheck all of the base plates to makesure each one is centred where the base rails meet.

5. Make a Covea. Make a curved cove about 6"

(15 cm) high and 8" (20 cm) wideall around the bottom of thepool wall on the inside.

b. Use fine earth or brick sand tomake the cove, and pack itfirmly into shape.

No Diving or Jumping. Observe all Safety Rules.

6" (15 cm)

8" (20 cm)

Pool Wall

Base Rail

Brick Sand or styrofoam

Earth CoveEarth Cove

13

11

1" (25 mm) MAX

3-3

!Caution:The pool must belevel within 1"(25 mm) across thediameter. A pool thatis not level is dan-gerous and maycollapse.

9

10

?Remember:The cove is animportant part of thepool structure. Takeyour time to make acomplete, full-sizecove.

centredcentred

12

Page 13:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.

6. Install the “Wall-Saver” Gasketa. The Wall-Saver gasket provides

a water-tight seal around theskimmer cut-out for thethrough-the-wall skimmer.Gently spread apart the twolayers of the gasket and insert itinto the skimmer cut-out so thatit sandwiches the wall. Be verycareful not to tear or damagethe seam in the gasket or thegasket may leak. Take extracare not to cut or damage thegasket when you are installingthe skimmer later. If the gasketis damaged, you must get areplacement from your pooldealer.

B. Install your Pool Liner1. Set the liner in place

a. Open the carton. Do not use anything sharp to open the carton.b. Unpack and unfold the liner and spread it out in the sun to warm it up.

Inspect all the seams and surfaces for holes.c. Spread out the liner, smooth

side down. The curved seamshould be centred on the coveat the base of the wall. Theother seams will form straightlines across the bottom of thepool.

d. Smooth out all the wrinkles inthe bottom.

3-4

!Caution:The “Wall-Saver”gasket is importantfor protectionagainst corrosion.Failure to installthis gasket properlymay void the war-ranty of your poolwall. If the gasket isdamaged, get areplacement fromyour pool dealer.

Wall-Saver gasketWall-Saver gasket

Cut-out for skimmer

14

15

Curved Seam Straight Seams

16

Pool Wall

Earth Cove

Seam is centred in middle of Earth Cove

Base Rail

Pool Liner

17

!

Hint:If possible, unfold theliner on the grassone to two hoursbefore installation.Be careful not toleave the liner toolong or you maydamage the grass.

Page 14:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.3-5

2. Fasten the Liner in place (Overlap Liner only)This step applies only if you have an Overlap Liner. See the next page ifyou have a Beaded Liner.a. Lift the sides of the liner and

drape them over the top of thepool wall. If you have a 52" (132cm) high pool, pull the liner upuntil there is 2" (5 cm) overhang;if you have a 48" (122 cm) highpool, pull the liner up until thereis 6" (15 cm) overhang.

b. Fasten the liner to the top of thewall with plastic coping. Let theliner hang slack for now. Do notpull the liner tight.

c. Start filling the pool with water. As the pool fills,work out all the wrinkles and smooth the liner to thewall. Remove the plastic coping around the topedge of the wall one piece at a time and adjust theliner. Keep smoothing out the wrinkles.

3. Trim the Plastic Coping and Roll Up the Excess Linera. After all the wrinkles in the liner are removed, trim

any extra length of plastic coping so there is nooverlap.

b. Roll up any excess liner hanging below the plasticcoping and tape it in place near the top of the poolwall. Important: Do not trim off the excess liner.

?Remember:Do not trim off theexcess liner. (If theliner ever needs tobe removed, trim-ming the liner willmake re-installationvery difficult.) In-stead, roll up anyexcess liner andtape it in place nearthe top of the poolwall.

!Hint:To smooth out thewrinkles in step 2(c),use a vacuumcleaner: block theskimmer outlet withcardboard and tapeand put the vacuumhose through theskimmer return hole,between the linerand pool wall. Sealthe hole with tapeand keep the hose 2"(5 cm) above thesand cove so youdon’t suck up anysand. Start thevacuum and run ituntil most of thewrinkles are gone.Then, stop thevacuum and add 1"(2.5 cm) of water tothe pool. Finally,remove the vacuumhose and unplug theskimmer hole.

18

19

20

tapetape

excess linerexcess liner21

Page 15:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.

4. Fasten the Liner in place (Beaded Liner only)This step applies only if you have a Beaded Liner. See the previous page ifyou have an Overlap Liner.a. Lift the sides of the liner and

insert the beaded edge into theliner retainer on the top edge ofthe pool wall.

b. Start filling the pool with water.As the pool fills, work out all thewrinkles and smooth the liner tothe wall.

5. Proceed to Section 4a. Continue with Section 4 to finish assembling your pool.

22

23

3-6

Page 16:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.

A. Attach your Verticals and Top Rails1. Continue filling your Pool

a. Continue filling your pool with water. Do not put in more than 12" (30 cm)of water until the top rails and vertical columns are all attached.

b. Keep working on the top rails and vertical columns while the pool fills.

• See the drawing on the next page for an overview of all the parts usedto install the verticals, top rails and top connectors.

2. Install the Vertical Columns and Top Railsa. Line up the bottom of one vertical column (key 1)

with the tab on one base plate (key 2). The tab mustbe on the outside of the vertical column.

b. Line up the screw holes and fasten with one self-tapping screw (key 3).

c. Place a top connector (key 4)over the top edge of the poolwall (key 5) with the tab on theoutside of the pool. Line up thehole in the tab with the screwhole near the top of the verticalcolumn. The tab must be on theoutside of the vertical column.Make sure the vertical columnis straight up and down.

d. Slide one end of a top rail (key 6) into the top connector.e. Fasten the top connector to the vertical column with one self-tapping

screw (key 7).f. Repeat the last five steps for each of the vertical columns around the

pool wall.

SECTION Pool Component Installation Manual

Installing the TopRails & Verticals

!Hint:Use the ridges in thepool wall to makesure the verticalcolumn is straight upand down.

14-1

4

1

1

3

2

2

4

6

5

7

Page 17:  · ˘ˇ d & 4 ˆ6! ˘ ˘ ˜ * :˘ ˘,˘ ˇi˘ + ˝˛ ˜ ˛˘ ˘,˘ ˇ ˚˘ ˛˘ ˜ ˜ ˘ ˘ ˚" ˙ ˘ ˜ ˛ ˙ * ˜++ ˆ

No Diving or Jumping. Observe all Safety Rules.

Overview ofVertical, Top Railand Top ConnectorAssembly

!Important:The pool wall maybulge and shift alittle while fillingwith water. This isnormal.

!Caution:Before anyone usesyour pool, read andfollow all the SafetyRules in Section 1.This pool is not fordiving or jumping.

4-2

5

7

2

3

1

4

6

g. Make the pool settle into aperfect circle by pushing the topof the pool wall vigorouslyinward at each vertical (this willhelp make the bottom of thepool wall shift into a perfectcircle).

h. Coat all showing screw heads with clear outdoor varnish.

B. Fill your Pool with Water1. Finish filling the pool

a. Fill the pool with water to 2" (5 cm) below the lowest opening. Next,follow the installation instructions for your skimmer.

Push vigorouslyPush vigorously

3