4) SCHEMATICS...1) ABBREVIATIONS 2) WIRE LIST 3) SYMBOLS 4) SCHEMATICS MODULAR LAYOUT 0233-GG9-000 ABS 0233-GG9-002 ACCESSORY POWER TO FUSES 0233-GG9-004 ADJUSTABLE PEDALS 0233-GG9-006

1) ABBREVIATIONS2) WIRE LIST3) SYMBOLS4) SCHEMATICS

MODULAR LAYOUT 0233-GG9-000

ABS 0233-GG9-002

ACCESSORY POWER TO FUSES 0233-GG9-004

ADJUSTABLE PEDALS 0233-GG9-006

AIR DRYER 0233-GG9-008

AIR DUMP/TAG DUMP SYSTEM 0233-GG9-010

BACKLIGHTING

0233-GG9-012

BATTERY POWER

0233-GG9-014

CAPTAIN'S AND DRIVER'S SEAT POWER/AIR

0233-GG9-016

CLEAN GROUND

0233-GG9-018

CLEAN POWER

0233-GG9-020

CLIMATE CONTROL

0233-GG9-022

0233-GG9-024

0233-GG9-026

CUSTOMER CONNECTORS

0233-GG9-028

DATALINK/DIAGNOSTICS

0233-GG9-032

ENGINE ECM/FAN

0233-GG9-034

HEADLAMP/TURN/MARKER (PAGE 1 OF 2)

HEADLAMP/TURN/MARKER (PAGE 2 OF 2)

0233-GG9-036

HORN

0233-GG9-038

IGNITION/START/CHARGE (PAGE 1 OF 2)

IGNITION POWER TO FUSES

INSTRUMENT POWER

0233-GG9-042

0233-GG9-042

0233-GG9-046

0233-GG9-048MOISTURE EJECTORS

NEUTRAL SIGNAL

0296-GG7 2009-10 ENTEGRA COACH MMGT

SPARES 0233-GG9-054

0233-GG9-058

STOP/REVERSE LIGHTS

0233-GG9-060

THROTTLE

0233-GG9-062

TIRE PRESSURE MONITOR/ASR

0233-GG9-064

TOW VEHICLE

0233-GG9-066

TRANSMISSION ECU

0233-GG9-068

TRW COLUMN

0233-GG9-070

CIRCUIT FUNCTION SCHEMATIC NUMBER

BACKBONE ENGINE HARNESS

CAB HARNESS

ABS REAR AXLE W/ATC

CIRCUIT FUNCTION SCHEMATIC NUMBER

DRAWING FUNCTION DRAWING NUMBER

FRONT ABS HARNESS

FUSE/RELAY ASSEMBLY (2969-GG5C-001) PAGE 1 OF 2

FUSE/RELAY ASSEMBLY (2969-GG5C-001) PAGE 2 OF 2 0233-GG9-072

WIPER (PAGE 1 OF 2)

0233-GG9-070

BUSSMANN (2961-GG5C-003) PAGE 1 OF 2

0233-GG9-072

FRONT CHASSIS HARNESS

REAR CHASSIS HARNESS

START/RUN CUMMINS HARNESS

TAG AXLE ABS HARNESS

0233-GG9-056

ALTERNATOR/WIF

AUXILIARY BRAKE

COMMON GROUND (PAGE 1 OF 2)5) CONNECTOR DESCRIPTION

0233-GG9-028COMMON GROUND (PAGE 2 OF 2)

PARK BRAKE/LEVEL CONTROL

0233-GG9-038

IGNITION/START/CHARGE (PAGE 2 OF 2)

0233-GG9-044

0233-GG9-052

BUSSMANN (2961-GG5C-003) PAGE 2 OF 2

3064-GG10B

3086-GG10A

2666-GG10A

2665-GG10A

NF/TF CHP WIPER RELAY HARNESS 3326-GG10B

MAIN CHASSIS HARNESS 3060-GG10D

3070-GG10A

2888-GG10C

3093-GG10A

2664-GG10A

CRUISE CONTROL 0233-GG9-030

0233-GG9-040

0233-GG9-050

0233-GG9-068WIPER (PAGE 2 OF 2)

ABBREVIATION LIST

A

DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION And & Ampere A Air Cleaner A/CL Air Deflector A/DFL Air over Hydraulic A/H Anchor nut A/NUT Arm rest A/RST Anti rattle A/RTL Air suspension A/SUSP Automatic transmission A/TRNS Absolute ABS Absorber ABS Antilock brake system ABS Above ABV Air Conditioning AC Alternating current AC Access ACC Accelerator ACCEL Accumulator-Front ACCF Accelerometer ACCLRM Accumulator-Rear ACCR

Acceleration ACCRTN Accumulator ACCUM Accent ACNT Accessory ACSRY Actuator ACTR Active ACTV Adapter ADAP Additive ADDT Adhesive ADHES Adjust ADJ Adjuster ADJR Advance ADV Aft Extension AE Air AIR Aluminum AL All seasons touring AL2 All seasons performance AL3 Alarm ALRM All seasons ALS Alternator ALT Altitude ALT

Amplitude modulation AM Ambient AMB Ammeter AMM Amplifier AMPF Armature AMT Anchor ANC Antenna ANT Applique' APLQ Application APPL Assembly ASM Assist ASST Attach ATCH Axle-torque-Left Rear ATLR Axle torque-Right Rear ATRR Automatic AUTO Auxiliary AUX Average AVG After the Event POST Average Roughness RA Ambient TAMB

B DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Bellcrank B/C Ball Joint B/JNT Back Up B/U Balance BAL Barometric BARO Barrier BARR Battery BAT Barrel BBL Body control module BCM Board BD Beam BEAM Both fronts BF Baffle BFL Bulkhead BHD Binding BIND Backing BKG Buckle BKL Booklet BKLT Backplate BKPLT Brakeplate BKPLT

Brake switch - 12 volt BKSW Bucket BKT Backup BKUP Bleeder BLEDR Block BLK Blower BLO Below BLW Bleed BLW Bolster BOLS Bolt/Screw BOLT Booster BOOS Bumper BPR Both rears BR Brace BR Braid BRD Border BRDR Bearing BRG Brake BRK Brake BRK Breaker BRKR

Bracket BRKT Breather BTHER Bottom BTM Button BTN Bushing BUSH Button BUT Blackwall BW Bezel BZL Boot Caliper - Left TBCL Boot Caliper - Right TBCR Bearing inner Race - Left Front TBILF Bearing inner Race - Left Rear TBILR Bearing Inner Race - Right Front TBIRF Bearing Inner Race - Right Rear TBIRR Bearing Outer Race - Left Front TBOLF Bearing Outer Race - Left Front TBOLR Bearing Outer Race - Right Front TBORF Bearing Outer Race - Right Rear TBORR Booster Skin TBSKIN

ABBREVIATION LIST

C DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Counterbalance C/BAL Cross Bar C/BAR Cylinder block C/BLK Crankcase C/CASE Courtesy Lamp C/LP Cigarette lighter C/LTR Crossmember C/MBR Crossover C/OVR Center Pillar C/PLR Cross Shaft C/SHF Control Valve C/VLV Cabinet CABT Calibrate CAL Calibration CALN Calibrator CALR Cancel CANC Capacitor CAPAC Carburetor CARB Carrier CARR Case CASE Cavity CAV Citizens band CB Cable CBL Compact disc CD Compact disc player CD/PLYR Conduit CDT Combination emission control CEC Certification CERT Cable tension - park brake left rear CFLR Chassis CH Channel CHAN Chassis CHAS Chemical CHEM Check CHK Chamber CHMBR Charge CHRG Circuit CIR Circuit CIRC Clamp CLA Clear CLER Clearance CLER Cooling CLG Clock CLK Cleaning CLNG

Cleaner CLNR Closed loop CLOOP Caliper CLPR Cooler CLR Closure CLSR Clutch CLT Clutch CLU Clevis CLV Camshaft CM/SHF Component CMP Compound CMPD Compression CMPR Compressor CMPTR Computer CMPTR Commutator CMTR Contact CNCT Conductor CNDCT Condenser CNDSR Console CNSL Canister CNSTR Container CNTNR Control CNTNR Counter CNTR Coaxial COAX Coefficient of friction COEF Coil COIL Column COL Collar COLR Communication COM Combination COMB Commercial COML Communicate COMM Compensator COMP Complete COMPL Compartment COMPT Connector CONN Control CONT Contamination CONTAM Continue CONTAM Converter CONV Convertible CONV Coolant COOL Coolant COOL Corner CORN

Cornering CORN Corporation CORP Cotter COT Coupling CPLG Capillary CPLY Companion CPN Capsule CPSL Carpet CPT Cross CR Cruise Control CRCONT Crank CRK Corrosion CRSN Cruise CRUZ Customer CST Casting CSTG Cluster CSTR Crankshaft CT/SHF Coated CTD Cable tension - park brake front CTF Coating CTG Catch CTH Catcher CTHR Central CTL Cataytic CTLTC Carton CTN Cable tension - park brake CTPB Center CTR Cable travel - park brake front CTRF Cable travel left rear CTRLR Cable tension - park brake right rear CTRR Cable travel - park brake right rear CTRRR Countershaft CTSHF Courtesy CTSY Contour CTUR Current CUR Cushion CUSH Curtain CUT Constant velocity CV Cover CVR Counterweight CWT Cycle CYC Cylinder CYL Continually Increasing Rate RAMP

ABBREVIATION LIST

D DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Dust Cover D/CVR Dual Exhaust D/EXH Double offset D/O Dust Seal D/SEAL Driver Seat D/SEAT Dust Shield D/SHLD Dimmer Switch D/SW Dash DA Double DBL Decelerate DCLR Deadener DDN Deceleration DECL Defogger DEFG Defroster DEFR Dehydrator DEHYDR Depression DEPR Devices DEV Deflector DFL Diode DI Diagonal DIAG Diagram DIAG Diagnostic DIAGN Diaphragm DIAPH Differential DIFF

Dimmer DIMR Direct DIR Discharge DISCH Displacement - front DISF Displacement - left front DISLF Displacement DISP Displacement DISPL Dispenser DISPR Displacement - left rear DISR Displacement Rear DISR Displacement Right Front DISRF Displacement Right Rear DISRR Distance DIST Distribution DISTR Distributor DISTR Divider DIV Division DIV Delivery DLVR Damage DMG Dome DMG Down DN Do Not Shift DNSFT Down Shift DNSHFT Documentation DOC

Design of experiment DOE Dome DOME Dampener DPNR Door DR Drain DRN Drive DRV Driven DRVN Driver DRVR Dryer DRY Design DSGN Dash DSH Diesel DSL Détente DTNT Deterrent DTRNT Dump DUMP Diverter DVTR Drawing DWG Drum Down - Left Rear TDDLR Drum Down - Right Rear TDDRR Drum Up - Left Rear TDULR Drum Up - Right Rear TDURR

E DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Extrusion *EXTR Engine Compartment E/CMPT End Gate E/GATE Each EA Eccentric ECC Economic Commission for Europe ECE Engine Control Module ECM ECM Low voltage potential ECMLO ECM input voltage ECMV ECU ECU European Economic Community EEC Early Fuel evaporation EFE Exhaust gas recirculation EGR Ejector EJCTR Ejector EJT Elbow EL

Electronic level control ELC Electric ELEC Electrically disconnected ABS ELEC DISC ABS Electronic ELEK Emblem EMB Event marker EMCO Emergency EMER Emission EMIS Engine ENG Engine ENG Engagement ENGMT Energy ENGY Energizer ENGZR Envelope ENV End of test EOT Exhaust pressure regulator EPR

Equalizer EQLZR Equipped EQUIP Engine RPM ERPM European Community Commission ESCC Escutcheon ESCUT Evaporative EVAP Evaporator EVAP Exchanger EXCH Exhaust EXH Exhaust EXH Expanding EXPDG Expansion EXPN External EXT Extension EXTN Exterior EXTR Eyelet EYLT

ABBREVIATION LIST

F DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

First 1ST Fourth 4TH Four Wheel Antilock 4WAL FIFTH 5TH Fifth 5th Front Axle F/AXL Front Compartment F/CMPT Front of dash F/D Front Seat F/DEAT Front end F/END Front Fender F/FDR Front Floor F/FLR Fast Idle F/IDL Foot Rest F/RST Folding Top F/TOP Facing FACT Factor FACT Fender FDR

Foundation FDTN Filament FILA Filler FILA Finish FIN Folding FLDG Flexible FLEX Flange FLG Flammability FLMBTY Floor FLR Floor Board FLRBD Flasher FLSH Flasher FLSHR Filter FLTR Float FLTR Flywheel FLYWHL Frequency Modulation FM Forging FORG Frequency FREQ

Friction FRICT Frame FRM Frame Unit FRM/U From FROM Front FRT Fastener FSTN Front FT fitting FTG Front View FV Forward FWD Front wheel Slide FWS Fluid - Left Front TFLF Fluid - Left Rear TFLR Fluid - Right Front TFRF Fluid - Right Rear TFRR

G DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Government *GOVT Gear AR Glass Channel D/CHAN Glencove and tollgate EMSP Garnish Molding G/MLDG Glass Run G/RUN Gage GA Gauge GA Gallery GAL Gallon GAL Garnish GARN

Gasket GASKT Guide GDE Generator GEN Glass GLS Glaze GLZ Ground GND Ground GND Governor GOV Grille GRL Grommet GROM Group GRP

Groove GRV Grooved GRVD Gravel GRVL Gold Stripe GS General Services Administration GSA Gutter GTR Gusset GUSS Gross Vehicle Weight GVWR Gross Vehicle Weight GVWR

H DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

High Performance D/PRF Head Restraint D/RST High Compression H/C Hinge Pillar H/ILR Heat Shield H/SHLD Harmonic HARM Harness HARN Heat Cycle HC

Head HD Head HD Handle HDL Headlining HDLNG Headlamp HDLP Header HDR Hardware HDW Hinge HE

Handle Force - Park Brake HFPB High HI Holder HLDR High Line Pressure HLP Hanger HNGR Hold Down HOLDN Hood HOOD Horizontal HORIZ

ABBREVIATION LIST

Hour HR Hour HR Horn HRN Housing HSG Heat HT Heated HTD Heater HTR Heavy HVY Heavy HVY Highway high Performance HW4 Highway HWY Hydraulic HYD Hertz HZ Hazard HZD Hydraulic Line Pressure - Left Front LBLF Hydraulic Line Pressure –Booster Input

LPBI

Hydraulic Line Pressure –Before Lh LPBLF

hose Hydraulic Line Pressure –Booster output

LPBO

Hydraulic Line Pressure –Rear before Hose

LPBR

Hydraulic Line Pressure –Before RF hose

LPBRF

Hydraulic Line Pressure – Front LPF Hydraulic Line Pressure –After Combo

LPFAC

Hydraulic Line Pressure –Before ABS LPFBA Hydraulic Line Pressure –Before Combo

LPFBC

Hydraulic Line Pressure – 4Wal Unit LPLFA Hydraulic Line Pressure - Left Rear LPLR Hydraulic Line Pressure –Master Cylinder

LPMC

Hydraulic Line Pressure –Master LPMCF

Front Hydraulic Line Pressure –Master Rear LPMER Hydraulic Line Pressure – Rear LPR Hydraulic Line Pressure –Rear 4wal pump

LPR4P

Hydraulic Line Pressure –Rear after ABS

LPRAA

Hydraulic Line Pressure –Rear after Comb

LPRAC

Hydraulic Line Pressure –Rear before ABS

LPRBA

Hydraulic Line Pressure –Rear before Colv

LPRBC

Hydraulic Line Pressure –Right Front LPRF Hydraulic Line Pressure –4wal Combo LPRF4 Hydraulic Line Pressure –Right Rear LPRR

I DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Idler arm I/ARM Instrument Panel I/P Inside I/S Intermediate Seat I/SEAT Input - Current - ABS IAB Inhibit IBIT Ignition Control Module ICM Identification IDENT Identify IDENT Ignition IGN Ignition IGN Illuminated ILLUM Impact IMP Impeller IMP Intercooler INCLR Indicate IND Indicator IND Indicator IND

Inflatable INFL Inflator INFL Information INFO Injection INJN Injector INJR Inlet INL Inner INR Insert INS Insulator INSL Inspection INSP Instrument INST Instrument INST Install INSTL Instruction INSTR Intake INT Internal INT Intermediate INTER Interlock INTLK

Interior INTR Inverter INV Iso Valve Rear Four Wheel Antilock ISOR Interface ITRF Intermittent ITRM Inner Bearing - Left Front TIBLF Inner Bearing - Left Rear TIBLR Inner Bearing - Right Front TIBRF Inner Bearing - Right Rear TIBRR Inboard Pad - Left Front TIPLF Inboard Pad - Right Front TIPLF Inboard Pad - Left Rear TIPLR Inboard Pad - Right Rear TIPRR Inboard Rotator - Right Front TIRIF Inboard Rotor - Left Front TRILF Inboard Rotor - Left Rear TRILR Inboard Rotor - Right Rear TRIRR

J DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Junction Block J/BLK Jack JK Jacking JKG Jacket JKT

Jumper JPR Jumper JRP Jack Shaft JS Joint JT

Junction JUNC

ABBREVIATION LIST

K DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Kick up K/UP Knuckle KNU

L DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Lift Gate *L/GATE Lock Pillar L/PLR Limited Slip L/SLIP Lift Window L/WDO Laboratory LAB Label LABL Laminate LAM Latch LAT Lateral LATL Lacing LCG Ledge LDG Left Front LF Left LFT Lifter LFTR Light LGT Longitudinal LGTDNL Left Hand LH License LIC

Limit LIM Liquid LIQ lock LK locking LKG Lightly Loaded Vehicle Weight LLVW Lamp LMP Limiting LMTNG Lining LNG Linkage LNKG Liner LNR Low LO Location LOC Lamp LP Left Rear LR Left Seat LSEAT Listing LSTG Light LT Left Temperature LTR

Letter LTR Left Turn LTRN Lubricate LUB Luggage LUGG Louver LUV Level LVL Leveling LVLG Lever LVR Lower LWR Lower LWR Left Sensor PULSLS Left Rear - Pivot TLRP Left Rear - Thread TLRT Leading Shoe - Left Rear TLSLR Leading Show - Right Rear TLSRR

M DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Mile marker EMMI Master Cylinder M/CYL Malfunction M/FUNC Multifunction M/FUNC Multiport M/PORT Manual transmission M/TRNS Magnetic MAG Maintenance MAINT Manual MAN Manifold MANIF Manifold Absolute Pressure MAP Manifold Absolute Pressure MAP Master MAS Material MATL Material Specification MATLSPEC Maximum MAX

Member MBR Machining MCHG Module MDL Manifold differential pressure MDP Medallion MEDLN Metal MET Mass Flow Booster Input MFBI Mass Flow Booster Output MFBO Microphone MIC Military MIL Minimum MIN Mirror MIR Miscellaneous MISC Mixture MIX Marker MKR Marker MKR

Molding MLDG Moderate MOD Modulator MOD Moisture MOIST Monitor MON Monitor MON Motor MOT Motor MOT Moisture MSTRE Mount MT Mounting MTG Meter MTR Meter MTR Metering MTRG Muffler MUFF

ABBREVIATION LIST

N DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Name plate N/PLT Name NA Needle NDL Negative NEG Negative NEG

Neutral NEU Neutral NEVT Nipple NIP Number NO No contamination NOCONTAM

Nozzle NOZ Notice NTC No wheel slide NWS

O DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Overdrive O/D Oil gage O/GA Oil pump O/PMP Outside O/S Odometer ODOM Oil OIL On/Off road OOR Operate OPER Opening OPG Option OPT Orientation ORIENT

Ornament ORNA Overspeed OSPD Outlet OTLT Overtemp OTMP Output OTP Outer OTR Outrigger OTRGR Overflow OVFL Oxidation OXIDN Oxygen OXY Outer Bearing - Left Front TOBLF

Outer Bearing - Left Rear TOBLR Outer Bearing - Right Front TOBRF Outer Bearing - Right Rear TOBRR Outboard Pad - Left Front TOPLF Outboard Pad - Left Front TOPLR Outboard Pad - Rear Front TOPRF Outboard Pad - Right Rear TOPRR Outboard Rotor - Left Rear TRILR Outboard Rotor - Right Rear TRIRR Outboard Rotor - Left Front TROLF

P DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Park Brake Apply - Foot Lever BPAF Power Brake P/B Pushbutton P/BUT Pinion Gear P/GR Power Steering P/S Passenger Seat P/SEAT Power Window P/W Procedure P[ROC Public address PA Parking PARK Pedal acceleration - Service Brake PASB Passage PASS Passenger PASS Pattern PATT Park Brake PB Park Brake PB Park Brake Apply - Hand Lever PBAH Park Brake Release Force PBRF Park Brake PBRK Park Brake - Structload - Left Rear PBSL Park Brake - Structload - Right Rear PBSRR Peak Count PC

Peak Count PC Powertrain Control Module PCM Positive Crankcase Ventilation PCV Pedal Effort PE Pedal PED Pendulum PENDLM Performance PERF Pedal Force - Park Brake PFPB Pedal Force Park brake PFPB Pedal Force - Service Brake PFSB Pedal Force Service Brake PFSB Preheat PHT Pillow PILO Pitman PIT Pivot PIV Package PKG Packaging PKG Pocket PKT Plunger PLGR Plenum PLMN Planetary PLNT Pillar PLR

Plate PLT Platform PLTF Plumbing PLUMB Player PLYR Panel PNL Point PNT Pointer PNT Pinch Out PO Positive PO Positive POS Position POSN Purple PPL Prior to the event PRE Predelivery PREDLVY Pressure PRES Present PRESS Pressure PRESS Prevent PREV Program PRGM Primary PRIM Proportion PROBN

ABBREVIATION LIST

Process PROC Programmer PROGMR Propeller PROP Protection PROTN Protector PROTR Protective PROTV Passive PSIV Piston PSTN Position PSTN Prop Shaft Torque PSTQ Pedal Travel PT

Pintle Hook PTLHK Power Take-Off PTO Pedal Travel - Park Brake PTPB Pedal Travel Service Brake PTSB Pickup Box PUBX Pulley PUL Pull-down PULDN Pull PULL Printed Wiring Board PWB Pulse Width Modulation PWM Pulse Width Modulation Rear PWMR

Power PWR Power PWR Piston Castilation - Left Front TORS Piston Castilation - Right Front TPCLF Piston Bel Cast & slot - Left Front TPCRF Piston Bel Cast & slot - Right Front TPCSRF Piston Inner/Closed - Left Front TPICLF Piston Inner/Closed - Right Front TPICRF Primary Brake Shoe - Left Rear TPSLR Primary Brake Shoe - Right Rear TPSRR

Q DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Quarter Panel Q/PNL Quarter Window Q/WDO

R DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Right Sensor PULSRS Rear R Rear Floor R.FLR Rear Overhang R.OH Rear Quarter R.Q Rear Axle R/AXL Rear Compartment R/COMPT Remote Control R/CON Rear Door R/D Rear End R/END Rear Fender R/FDR Ring Gear R/GR Reveal Molding R/MLDG Roof Rail R/RL Rear Seat R/SEAT Removable Top R/TOP Rear Window R/WDO Radio RAD Rebound RBND Receiving RCVG Receiver RCVR Recovery RCVY Reduction RDCN Reducer RDCR Reading RDG Radiator RDO Recliner RECL Recirculation RECRG

Reflector REFL Reflectivity REFLTY Refrigerant REFRIG Regulator REG Reinforcement REINF Release REL Remote REM Remote REMT Replace REPL Requirement REQT Resistor RES Resume RES Resonator RESO Reserve RESV Retainer RET Retractor RETR Revere REV Reverse REV Reversible REV Revision REV Reverberator REVBR Revalidation REVLDT Right Front RF Roof RF Radio Frequency Interference RFI Right Hand RH Rivet RIV Rocker RKR

Rail RL Relief RLF Roller RLR Relay RLY Relay RLY Round RND Range RNG Roof ROOF Rotator ROT Rotor ROT Revolutions Per Minute RPM RPM Steering Pump RPMSP Repair RPR Report RPRT Rear RR Right Rear RR Reset Switch Combo Valve RSC Riser RSR Reset Switch Rear 4Wal RSR4 Restraint RST Restriction RSTN Restrictor RSTR Reservoir RSVR Right RT Return RTN Retarder RTRDR Right Seat RTST Right Turn RTTRN

ABBREVIATION LIST

Reveal RVL Rear Wheel Antilock RWAL Rear Wheel Drive RWD

Rear Wheel Slide RWS Roughness Depth RZ Right Rear - Pivot TRRP

Right Rear - Thread TRRT

S DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Second 2nd Side Rail RL Straight and Smooth S&S Shock Absorber S/ABS Side Door S/D Steering Gear S/GR Steering Knuckle S/KNU Stop Lamp S/LP Side Member S/MBR Side Panel S/PNL Sunshade S/S Sealing Strip S/STR Safety SAF Scavenging SCAV Source SCE Scalp SCP Screen SCRN Sector SCTR Sender SDR Secondary SECD Section SECT Selector SEL Sensor SEN Sensor SENS Separator SEP Sequential SEQ Serial SER Service SERV Set SET Spot Face SF Sheet SH Shaft SHF Shock SHF Shift SHFT Shifter SHFT Shackle SHKL Shield SHLD Shoulder SHLDR Shelf SHLF Shipping SHPG Shroud SHRD

Side SI Signal SIG Signal SIG Silencer SIL Skirt SK Sliding SLDG Solder SLDR Sleeve SLEV Solvent SLV Small SM Snubber SNBR Sound SND Sender SNDR Snuffer SNFR Socket SOC Solenoid SOL Solenoid SOL Start of test SOT Spare SPA Spare Channel Descriptor SPARE Supercharge SPCHG Spacer SPCR Speed SPD Speed SPD Spindle SPDL Speedometer SPDO Specification SPEC Specified SPECD Speedometer SPEEDO Splash SPH Spherical SPHER Speaker SPKR Sprocket SPKT Spark Plug SPLG Spot Lamp SPLP Splitter SPLTR Supply SPLY Spoiler SPR Spring SPR Specified Weld SPWELD Specified Welds SPWELD

Steering SRGER Sear ST Start ST Stationary STA Stabilizer STAB Stator STAT Stitching STCHG Stiffener STFNR Strainer STNR Stop STOP Storage STOR Stowage STOW Staple STPL Starter STR Strip STR Stringer STRGER Striker STRK Strap STRPE Stripe STRPE Starter STRTR Suction SUC Supplement SUP Suppressor SUPPR Support SUPT Surface SURF Suspension SUSP Side View SV Switch SW Switch SW Steering Wheel Angle SWA Steering Wheel Front SWE Swivel SWIV Synchronizer SYN System SYS Sensor Conduit Inside - Left Front TSCILF Sensor Conduit Inside - Right Front TSCIRF Sensor Conduit Outside - Right Front TSCORF Sensor Face - Left Front TSFLF Sensor Face - Right Front TSFRF Sensor Head Center - Left Front TSHCLF Sensor Head Center - Right Front TSHCRF

ABBREVIATION LIST

Sensor Left Side - Left Front TSLSLF Sensor Left Side - Right Front TSLSRF Sensor Conduit Outside - Left Front TSOLF Sensor Pulse - Left TSPL Sensor Pulse - Rear TSPR Sensor Right Side - Left Front TSRSLF Sensor Right Side - Right Front TSRSRF Sensor Inside Bearing - Left Rear TSSBLF Sensor Inside Bearing - Right Front TSSBRF

Shield Surface Inside - Left Front Wire

TSSILF

Shield Surface Inside - Right Front Wire

TSSIRFD

Sensor Shield Lower TSSL Secondary Brake Shoe - Left Rear TSSLR SHD Surface Outside - Left Front Rotor

TSSOLF

SHD Surface Outside - Right Front TSSORF

Rotor Secondary Brake Show - Right Rear TSSRR Sensor Shield Upper TSSU Sensor Top Front - Left Front TSTLF Sensor Top Front - Right Front TSTRF Shield at Clip - Left Front TSWACLF Shield at Clip - Right Front TSWACRF Stopping distance - 5th wheel VDFW

T DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Third 3rd Three Way 3WAY Tilt and Telescope T&T Terminal Block T/BLK Torque Converter T/CV Temperature Gage T/GA Tail Lamp T/LP Tape Player T/PLYR Trim Panel T/PNL Turn Signal T/SIG Throttle Valve T/V Tachometer TACH Tachometer TACH Tappet TAP Tapping TAP Tarpaulin TARP Throttle Body Fuel Injection TBI Transfer Case TCASE Torque Converter Clutch TCC Transmission Control Module TCM Telephone TEL Temperature TEMP Temporary TEMP

Template TEMPL Tension TENS Tensioner TENSR Terminal TERM Thread THD Thermostat THERM Thinner THNR Thrust THR Throttle THROT Tank TK Tubeless TL Telescope TLSCP Timing TMG Temperature TMP Torque TORQ Torsion TORQ Throttle Position Sensor TPS Trim TR Traction TRACT Transmission TRANS Transmission TRANS Transfer TRFER Track TRK

Trailer TRLR Trailer TRLR Turn TRN Throttle TRTL Trunnion TRUN Time Speed Distance TSD Test TST Tube Type TT Trailing Shoe - Left Rear TTSLR Trailing Shoe - Right Rear TTSRR Tumbler TUMB Tunnel TUN Turbine TURB Turbocharger TURBO Tower TWR Thermal Expansion Valve TXV Transceiver XCVR Transducer XDCR Transformer XFMR Transmitter XMTR

U DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Unit U Underhood U/HOOD Underbody U/N Underseat U/SEAT

Under Vehicle U/V Universal Joint UJT Under UND Upper UP

Upper UPR Upshift UPSHFT

V DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

ABBREVIATION LIST

Vacuum VAC Vacuum Booster VAVB Vacuum Engine VACE Valance VAL Valve VLV Valve VLV Valve Cover V/CVR Vanity VAN

Vapor VPR Variable VAR Vehicle VEH Vehicle Control Module *VCM Vehicle description Number VDN Vehicle Identification Number VIN Vehicle Speed - 5th Wheel VSFW Vehicle Speed - Transmission VSTR

Vehicle Test Specifications VTS Velocity V Vertical VERT Vibrate VIB Volt V Volt VOLT

W DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Watt W With W/ Wheelhouse W/H Windlace W/LACE Without W/P Water Pump W/PMP Windshield W/S Weather-strip W/STR Warm Up W/UP Washer WA Warranty WARR Water WAT Wheelbase WB Window WDO Webbing WEBG Wheel Torque - Left Rear WFLR

Wedge WGE Wheel WHL White Letter WL Welding WLDG Worm Gear WMGR Wide Open Throttle WOT Wiper WPR Wiper WPR Wiring WRG Wheel Revolutions - Left Front WRLF Wheel Revolutions - Left Rear WRLR Warning WRN Warning WRNG Wheel Revolutions - Right Front WRRF Wheel Revolutions - Right Rear WRRR Wheel Slide WS

White Stripe WS Washer WSHR Wheel Speed - Left Front WSLF Wheel Speed - Left Rear WSLR Wheel Speed - Right Front WSRF Wheel Speed - Right Rear WSRR Windshield Wiper WSW Windshield Washer WSWA Weight WT Wheel Torque - Left Front WTLF Wheel Torque - Right Front WTRF Wheel Torque - Rear Right WTRR Wheel Well WWL Weather WX

XYZ DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION ABBREVIATION

Zipper ZPR

ABBREVIATION LIST

COLOR ABBREVIATIONS COLOR ABBREVIATION COLOR ABBREVIATION COLOR ABBREVIATION

BLACK BK BLUE BE BROWN BN BROWN w/WHITE STRIP BN/WE CLEAR CR DARK BLUE DKBE DARK BLUE w/WHITE STRIP DKBE/WE DARK GREEN DKGN GREEN GN

GREEN/YELLOW GN/YW GREY GY LIGHT BLUE LTBE LIGHT GREEN LTGN LIGHT GREY LTGY LIGHT PURPLE LTPE ORANGE OE PINK PK PURPLE PE

RED RD RED/WHT STRIPED RE/WE SHIELD SD SILVER SR TAN TN WHITE WE YELLOW YW

Spartan Motors Chassis, Inc. Circuit Numbers WIRE PART PART DESCRIPTION

CIRCUIT NUMBERS

COLOR SPECIAL NOTES TRANS CIRCUIT DEFINITION PRIMARY

AT101 BE-Blue 2000 AUX RANGE INHIBIT AT101 BE-Blue 3000 AUX RANGE INHIBIT AT102 YW-Yellow 2000 ENG BRK POS PRES REQ AT102 YW-Yellow 3000 ENG BRK POS PRES REQ AT103 YW-Yellow 2000 SIGNAL RETURN AT103 YW-Yellow 3000 SIGNAL RETURN AT104 YW-Yellow 2000 ENG BRK ENABLE AT104 YW-Yellow 3000 ENG BRK ENABLE AT105 OE-Orange 2000 OUTPUT SPEED INDICATOR A AT105 OE-Orange 3000 OUTPUT SPEED INDICATOR A AT106 YW-Yellow 2000 J2284 CAN POS AT106 YW-Yellow 3000 J2284 CAN POS AT107 YW-Yellow J1939 CABLE 2000 J1939 CAN POS AT107 YW-Yellow J1939 CABLE 3000 J1939 CAN POS AT108 DKGN-Dark Green J1939 CABLE 2000 J1939 CAN NEG AT108 DKGN-Dark Green J1939 CABLE 3000 J1939 CAN NEG AT109 GY-Gray 2000 TCM CLEAN GND AT109 GY-Gray 3000 TCM CLEAN GND AT110 PK-Pink 2000 TCM CLEAN PWR AT110 PK-Pink 3000 TCM CLEAN PWR AT111 OE-Orange 2000 HSD 1 AT111 OE-Orange 3000 HSD 1 AT112 PK-Pink 2000 SENSOR SUPPLY (+5VDC) AT112 PK-Pink 3000 SENSOR SUPPLY (+5VDC) AT113 YW-Yellow 2000 AT113 AT113 YW-Yellow 3000 OUTPUT FUNC 8 AT114 GY-Gray 2000 INTER MODE SIG SW C AT114 GY-Gray 3000 INTER MODE SIG SW C AT115 WE-White 2000 PCS 5 AT115 WE-White 3000 PCS 5 AT116 BE-Blue 2000 OIL LEVEL SEN AT116 BE-Blue 3000 OIL LEVEL SEN AT117 BE-Blue 2000 AUTOMATIC NEUTRAL AT117 BE-Blue 3000 AUTOMATIC NEUTRAL AT118 OE-Orange 3000 FILTER MONITOR AT119 BE-Blue 2000 PCS 7 AT119 BE-Blue 3000 PCS 7 AT120 BE-Blue TWP-26 2000 TURBINE SPEED LOW AT120 BE-Blue TWP-26 3000 TURBINE SPEED LOW AT121 GN-Green 2000 ABS RESPONSE AT121 GN-Green 3000 ABS RESPONSE AT122 YW-Yellow 2000 PUMP ENABLE AT122 YW-Yellow 3000 PUMP ENABLE AT123 GN-Green 2000 PUMP MODE AT123 GN-Green 3000 PUMP MODE


CIRCUIT NUMBERS


AT123 GN-Green 3500 DISPLAY BLANKING AT124 YW-Yellow 2000 RANGE INHIBITED INDIC AT124 YW-Yellow 3000 RETARDER INDICATOR AT125 TN-Tan 2000 SPEEDOMETER SIGNAL AT125 TN-Tan 3000 SPEEDOMETER SIGNAL AT126 YW-Yellow 2000 J2284 CAN POS AT126 YW-Yellow 3000 J2284 CAN POS AT127 DKGN-Dark Green 2000 J2284 CAN NEG AT127 DKGN-Dark Green 3000 J2284 CAN NEG AT128 YW-Yellow J1939 CABLE 2000 J1939 CAN POS AT128 YW-Yellow J1939 CABLE 3000 J1939 CAN POS AT129 GN-Green 2000 CHECK TRANS LT AT129 GN-Green 3000 CHECK TRANS LT AT130 WE-White 2000 PTO ENABLE AT130 WE-White 3000 PTO ENABLE AT131 YW-Yellow 2000 HSD 3 AT131 YW-Yellow 3000 HSD 3 AT132 WE-White TWP-25 2000 J1587 CAN HIGH AT132 WE-White TWP-25 3000 J1587 CAN HIGH AT133 YW-Yellow 2000 SSS-2 AT133 YW-Yellow 3000 PCS 3 AT134 WE-White 2000 INTERNAL MODE SW PB AT134 YW-Yellow 3000 DIRECTION SIGNAL AT135 BE-Blue 2000 WATER TEMP AT135 BE-Blue 3000 WATER TEMP AT136 OE-Orange 2000 PCS 2 AT136 OE-Orange 3000 PCS 1 AT137 WE-White 2000 TORQUE CONVERTER CLUTCH AT137 WE-White 3000 TORQUE CONVERTER CLUTCH AT138 OE-Orange 2000 INTERNAL MODE SW NS AT138 TN-Tan 3000 SS-P AT139 OE-Orange TWP-27 2000 ENGINE SPEED LOW AT139 OE-Orange TWP-27 3000 ENGINE SPEED LOW AT140 GN-Green TWP-28 2000 OUTPUT SPEED LOW AT140 GN-Green TWP-28 3000 OUTPUT SPEED LOW AT141 TN-Tan 2000 NEUTRAL START AT141 TN-Tan 3000 NEUTRAL START AT142 WE-White 2000 SECONDARY MODE AT142 WE-White 3000 PTO REQUEST/AUX RANGE AT143 BE-Blue 2000 PTO INPUT AT143 BE-Blue 3000 PTO REQUEST AT144 BE-Blue 2000 TPS AT144 BE-Blue 3000 TPS AT145 OE-Orange 2000 RANGE INDICATOR AT145 OE-Orange 3000 RANGE INDICATOR AT147 DKGN-Dark Green 2000 J2284 CAN NEG


CIRCUIT NUMBERS


AT147 DKGN-Dark Green 3000 J2284 CAN NEG AT148 YW-Yellow J1939 CABLE 2000 J1939 CAN POS AT148 YW-Yellow J1939 CABLE 3000 J1939 CAN POS AT149 SD-Shield Drain J1939 CABLE 2000 J1939 SHIELD AT149 SD-Shield Drain J1939 CABLE 3000 J1939 SHIELD AT150 PK-Pink 2000 PTO ENABLE AT150 PK-Pink 3000 OUTPUT FUNC 7 AT151 YW-Yellow 2000 SSS 3 AT151 WE-White 3000 SS 1 AT152 GN-Green 2000 SSS 1 AT152 GN-Green 3000 PCS 2 AT153 YW-Yellow 2000 INTERNAL MODE SIG SW 8 AT153 GN-Green 3000 SS-2 AT154 TN-Tan 2000 SUMP TEMP SENSOR AT154 TN-Tan 3000 SUMP TEMP SENSOR AT155 WE-White 2000 PCS 1 AT155 WE-White 3000 PCS 4 AT156 WE-White 2000 RMR AT156 WE-White 3000 RMR AT157 WE-White 2000 ENG BRK NEG PRESECT AT157 WE-White 3000 ENG BRK NEG PRESECT AT158 GN-Green 2000 ANALOG GROUND AT158 GN-Green 3000 ANALOG GROUND AT159 TN-Tan TWP-27 2000 ENGINE SPEED HIGH AT159 TN-Tan TWP-27 3000 ENGINE SPEED HIGH AT160 YW-Yellow TWP-28 2000 OUTPUT SPEED HIGH AT160 YW-Yellow TWP-28 3000 OUTPUT SPEED HIGH AT161 OE-Orange 2000 OVERDRIVE DISABLE AT161 OE-Orange 3000 RETARDER ENABLE AT162 YW-Yellow 2000 SERVICE BRK STATUS AT162 YW-Yellow 3000 SERVICE BRK STATUS AT163 YW-Yellow 2000 IGNITION SIG AT163 YW-Yellow 3000 IGNITION SIG AT164 BE-Blue 2000 RET TEMP/SERV IND AT164 BE-Blue 3000 RET TEMP/SERV IND AT165 TN-Tan 2000 REVERSE WARNING AT165 TN-Tan 3000 REVERSE WARNING AT166 YW-Yellow 2000 J2284 CAN HIGH AT166 YW-Yellow 3000 J2284 CAN HIGH AT167 SD-Shield Drain 2000 J2284 SHIELD AT167 SD-Shield Drain 3000 J2284 SHIELD AT168 DKGN-Dark Green J1939 CABLE 2000 J1939 CAN LOW AT168 DKGN-Dark Green J1939 CABLE 3000 J1939 CAN LOW AT169 GY-Gray 2000 TCM CLEAN GND AT169 GY-Gray 3000 TCM CLEAN GND AT170 PK-Pink 2000 TCM CLEAN PWR


CIRCUIT NUMBERS


AT170 PK-Pink 3000 TCM CLEAN PWR AT171 YW-Yellow 2000 HSD 2 AT171 YW-Yellow 3000 HSD 2 AT172 BE-Blue TWP-25 2000 J1587 CAN LOW AT172 BE-Blue TWP-25 3000 J1587 CAN LOW AT173 BE-Blue 2000 INTERNAL MODE SIG SW A AT173 OE-Orange 3000 SS-1 AT174 BE-Blue 2000 MAIN MODE AT174 BE-Blue 3000 MAIN MODE AT175 OE-Orange 2000 RETARDER TEMP SENSOR AT175 OE-Orange 3000 RETARDER TEMP SENSOR AT176 YW-Yellow 2000 TRANS ID AT176 YW-Yellow 3000 TRANS ID AT177 GN-Green 2000 PS-4 AT177 GN-Green 3000 PS 1 AT178 WE-White 2000 TORQUE CONVERTER CLUTCH AT179 PK-Pink 2000 PS-2 AT179 PK-Pink 3000 INPUT FUNC 11 AT180 OE-Orange TWP-26 2000 TURBINE SPEED HIGH AT180 OE-Orange TWP-26 3000 TURBINE SPEED HIGH AT181 BE-Blue 2000 SPARE 1 AT181 BE-Blue 3000 SPARE 1 AT181 BE-Blue 3500 SPARE 1 AT182 WE-White 2000 SPARE 2 AT182 WE-White 3000 SPARE 2 AT182 WE-White 3500 SPARE 2 AT183 GN-Green 2000 SPARE 3 AT183 GN-Green 3000 SPARE 3 AT183 GN-Green 3500 SPARE 3 CT099 BN-Brown CURRENT DRV RET CT101 RD-Red TCM PWR CT121 YW-Yellow REVERSE IND CT166 YW-Yellow OUTPUT SPD IND CT229 BK-Black TCM GND CT234 BK-Black TCM SENS RETURN CT249 BK-Black J1939 J1939 SHD CT381 PE-Purple PTO ENABLE OUT CT472 YW-Yellow TRANS TEMP LT CT473 YW-Yellow CHECK TRANS LT CT710 BE-Blue ENG START IN CT793 BE-Blue TWP-06 J1587 NEG CT794 YW-Yellow TWP-06 J1587 POS CT900 YW-Yellow J1939 J1939 POS CT906 BN-Brown TCM IGN CT921 PK-Pink HOLD GEAR CT924 OE-Orange RTRDR PWM


CIRCUIT NUMBERS


CT938 YW-Yellow AUTO NEUTRAL 2 CT939 PE-Purple RTRDR LO/HI SW CT942 OE-Orange AUTO NEUTRAL CT944 BE-Blue SPD ENABLE OUT CT945 BE-Blue GEAR ENABLE OUT CT946 BN-Brown RTRDR SHIFT EN CT947 OE-Orange DRV LN PTO REQ IN CT948 OE-Orange GEN PUR OUT 2 CT949 YW-Yellow GEN PUR OUT 3 CT964 BN-Brown RTRDR MED SW CT976 YW-Yellow PARK BRK CT981 OE-Orange QUICK GEAR LIM CT982 BE-Blue CAT NEU TO GEAR INHIBIT CT983 PE-Purple DIR CHG INHIBIT CT990 GN-Green J1939 J1939 NEG CT992 PE-Purple SVC BRK CT994 BN-Brown STARTER LOCK CT998 BE-Blue PTO ENABLE CT999 GN-Green DRV LN PTO SW DD555 WE-White PSG MODE LT EN001 RD-Red GRID HTR 1 PWR EN002 OE-Orange GRD HTR 1 FEED EN003 PK-Pink GRID HTR 1 SIG EN004 RD-Red GRID HTR 2 PWR EN005 OE-Orange GRD HTR 2 FEED EN006 PK-Pink GRID HTR 2 SIG EN007 RD-Red F/PUMP FEED EN008 RD-Red F/PUMP RLY PWR EN009 BK-Black F/PUMP GND EN010 RD-Red F/PUMP PWR EN011 GY-Gray BRAKE SW SIG EN012 GY-Gray CLUTCH SW SIG EN013 GY-Gray DIAGN ON/OFF EN014 GY-Gray ENG BRK ON/OFF EN015 PK-Pink ENG BRK ENABLE EN016 GY-Gray ENG FLUIDS SIG EN017 GY-Gray ENG STOP SIG EN018 PK-Pink FAN CLUTCH EN019 GY-Gray FUEL SHUTOFF EN020 GY-Gray OFF IDLE SIG EN021 GY-Gray IDLE SIG EN022 GY-Gray IDLE DECR SIG EN023 GY-Gray IDLE INCR SIG EN024 GY-Gray THROT INTERLOC EN025 PE-Purple COOL LVL RTN EN026 PK-Pink COOL LVL POS


CIRCUIT NUMBERS


EN027 PE-Purple COOL LVL SPLY EN028 GY-Gray COOL LVL NEG EN029 GY-Gray FAN CLUTCH IN EN030 GY-Gray A/C PRESS SIG EN031 GY-Gray REM PTO ON/OFF EN032 GY-Gray REMT THROT SIG EN033 PK-Pink REMT THROT 5V EN034 PK-Pink TPS 5V EN035 GY-Gray WIF SENSOR EN036 PE-Purple REM THROT/WIF EN037 GY-Gray WT TO ST LT EN038 GY-Gray WIF LIGHT EN039 PE-Purple ANALOG TORQUE EN040 WE-White ECM COM SW RET EN041 PK-Pink ABM AIR SIG EN042 TN-Tan ABM AIR RET EN043 GY-Gray FAN SIG RET EN044 GY-Gray ALTERNATE RET EN045 BK-Black ECU RET 1 EN046 BK-Black ECU RET 2 EN047 PK-Pink ENG BRK RLY EN048 GY-Gray ENG BRK RET EN049 GY-Gray CAB GOV SW EN050 RD-Red OIL LVL PWR EN051 PK-Pink OIL LIGHT PWR EN052 BE-Blue OIL LIGHT SIG EN053 GY-Gray OIL TEST SIG EN054 GY-Gray OIL TEMP EN055 GY-Gray REMOTE ACCEL ON/OFF EN056 PK-Pink OIL PRESSURE SIGNAL EN057 TN-Tan TWO SPEED AXLE EN058 YW-Yellow TWT-15 ACCRTN POSN SEN 1 SCE EN059 GY-Gray TWT-15 ACCRTN POSN SEN 1 EN060 BK-Black TWT-15 ACCRTN POSN SEN 1 RET EN061 OE-Orange TWT-16 SENSOR SUPPLY 5 V EN062 BE-Blue TWT-16 ACCRTN POSN SEN 2 EN063 BK-Black TWT-16 ECM RETURN SEN EN064 BK-Black ECM RET TEMP LVL D EN065 BK-Black ECM RET GEN E EN066 BK-Black ECM RET GEN F EN067 PK-Pink PFT SENSOR 1 INLET EN068 YW-Yellow PFT SENSOR 2 MID EN069 BE-Blue PFT SENSOR 3 OUTLET EN070 PE-Purple CSF DELTA PRESS SEN SIG EN071 WE-White AFT 5V SEN SUP EN072 GN-Green AFT ANALOG SEN RET


CIRCUIT NUMBERS


EN073 PK-Pink PFT TRAP #1 DIFF PRESS EN074 YW-Yellow PFT TRAP #1 INTAKE TEMP EN075 PE-Purple PFT TRAP #1 OUTLET TEMP EN076 BE-Blue AFT TEMP SEN RET EN077 OE-Orange AFT IGN CLEAN PWR EN078 RD-Red EMP EN079 PK-Pink CAT THROT INPUT CONTR EN080 BK-Black ECU GND TO ENG EN081 BK-Black MAIN PWR RELAY ENABLE EN082 BK-Black ENG CRANK INHIBIT EN083 PK-Pink BRAKE PRESS SW EN084 BK-Black RADIATOR SHUTTER ENABLE EN085 OE-Orange EXH GAS RECIR POS EN086 BK-Black MASS AIR FLOW SEN GND EN087 GY-Gray MASS AIR FLOW SEN EN115 PK-Pink COOLANT LEVEL EN150 WE-White BATT NEG EN151 WE-White BATT NEG EN240 RD-Red BATT POS EN241 RD-Red BATT POS EN242 RD-Red BATT POS EN243 RD-Red BATT POS EN244 RD-Red BATT POS EN245 RD-Red BATT POS EN246 RD-Red BATT POS EN247 RD-Red BATT POS EN340 RD-Red BATT FUSE PWR EN341 RD-Red BATT FUSE PWR EN342 RD-Red BATT FUSE PWR EN343 RD-Red BATT FUSE PWR EN344 RD-Red BATT FUSE PWR EN350 RD-Red BATT FUSE SW PWR EN351 RD-Red BATT FUSE SW PWR EN352 RD-Red BATT FUSE SW PWR EN353 RD-Red BATT FUSE SW PWR EN354 RD-Red BATT FUSE SW PWR EN416 RD-Red SENSOR SUPPLY EN417 PK-Pink TWT-01 THROT SIG EN419 PK-Pink CHECK ENG LT EN420 PK-Pink DCHARGE +5V EN421 BK-Black DCHARGE GND EN422 GY-Gray DCHARGE SIG EN423 PK-Pink INTAKE +5V EN424 BK-Black INTAKE GND EN425 GY-Gray INTAKE SIG EN439 PK-Pink CLEAN IGN


CIRCUIT NUMBERS


EN440 RD-Red BATT POS EN451 GY-Gray DIAGN REQUEST EN452 BK-Black SENSOR RETURN EN499 GY-Gray PSG ACTIVE LT EN505 PK-Pink TACHOMETER EN509 GY-Gray STOP ENG LT EN510 PK-Pink VAR SPEED THRT EN523 GY-Gray PSG MODE EN524 GY-Gray THROT INHIBIT EN525 PK-Pink REMOTE THROTTLE EN528 GY-Gray VSG INHIBIT EN531 GY-Gray PARK BRAKE EN532 PK-Pink TURBO / TEMP SENSOR EN533 GY-Gray REMOTE PTO / HIGH IDLE EN540 GY-Gray JAKE DISABLE EN541 GY-Gray SET/DECREASE EN542 GY-Gray ALT MIN VSG EN543 GY-Gray PSG ACTIVE EN544 PK-Pink CRUISE ENABLE EN545 GY-Gray RESUME/INCREASE EN555 PK-Pink ENG OIL TMP LT EN556 PK-Pink VSS POS EN557 GY-Gray VSS NEG EN563 GY-Gray COOLANT LEVEL EN564 PK-Pink START LOCKOUT EN565 GY-Gray FAN CONTROL #1 EN566 GY-Gray A/C STATUS EN583 GY-Gray ENG BRAKE MED EN749 PK-Pink PUMP SEN SUP EN801 OE-Orange DPF LAMP EN802 GY-Gray DPF SWITCH EN803 PE-Purple MIL LAMP EN804 BN-Brown HET LAMP EN805 YW-Yellow PV HIGH SIDE SUP EN806 BE-Blue SENSOR GND EN807 GN-Green SENSOR GND EN808 PK-Pink DPF SEN TEMP BEFORE TRAP EN809 YW-Yellow DPF SEN TEMP INLET TRAP EN810 BE-Blue DPF TEMP AFTER TRAP EN811 WE-White DPF SEN SUPPLY EN812 PE-Purple DPF SEN EXH PRESS AFTER FILTER EN813 TN-Tan DPF SEN EXH PRESS BEFORE FILTER EN814 GY-Gray MAN REG SW EN905 YW-Yellow AMBIENT AIR TEMP EN908 PK-Pink PWM #1 EN916 PK-Pink TWT-01 SENSOR SPLY +5V


CIRCUIT NUMBERS


EN952 GY-Gray TWT-01 SENS RETURN (-) EN953 BK-Black BATT NEG EN976 PK-Pink RELATIVE HUMIDITY EN979 GY-Gray ENG BRAKE LOW EN985 BE-Blue TPS +8V EN988 WE-White ENG BRK ACTIVE EN990 PK-Pink RLY TO HEAT 1 EN991 PK-Pink RLY TO HEAT 2 EN992 PK-Pink TWT-17 COOL SENS SUPPLY EN993 TN-Tan TWT-17 COOL SENS SIGNAL EN994 BK-Black TWT-17 COOL SENS RETURN EN995 OE-Orange TWT-18 SENSOR SUPPLY 5V EN996 PK-Pink TWT-18 REMOTE THROTTLE EN997 BK-Black TWT-18 ECM RETURN SEN EN998 PK-Pink TWP-35 FAN CONTROL OUTPUT EN999 BK-Black TWP-35 ECM RET GEN E EN1000 PK-Pink TWP-36 INTAKE AIR HTR EN1001 BK-Black TWP-36 ECM RET GEN F EN1002 PK-Pink TWP-37 AUX BRAKE LAMP EN1003 BK-Black TWP-37 ECM RET GEN E EN1004 PK-Pink TWP-38 STARTER LOCKOUT EN1005 BK-Black TWP-38 ECM RET GEN F EN1006 OE-Orange TWT-19 SENSOR SUPPLY 5V EN1007 PE-Purple TWT-19 CSF DELTA PRESS SEN SIG EN1008 BK-Black TWT-19 ECM RET SEN EN1009 BK-Black ECM RETURN (SWITCH) EN1010 BK-Black ECM RETURN (SENSOR) EN1011 OE-Orange SENSOR SUPPLY 5V EN1012 RD-Red TAILPIPE NOx BATT POS EN1013 RD-Red DCU BATT POS EN1014 PK-Pink DCU IGN EN1015 BE-Blue HH RELAY CNTRL POS EN1016 BK-Black HH RLY CNTRL NEG EN1017 GN-Green HH1 SUPPLY EN1018 BK-Black HH1 RETURN EN1019 YW-Yellow HH2 SUPPLY EN1020 BK-Black HH2 RETURN EN1021 OE-Orange HH3 SUPPLY EN1022 BK-Black HH3 RETURN EN1023 YW-Yellow TWP-42 METERING VLV HIGH EN1024 BK-Black TWP-42 METERING VLV LOW EN1025 OE-Orange TANK HTR HIGH EN1026 BK-Black TANK HTR LOW EN1027 PE-Purple TNK LVL SENS SIG EN1028 BK-Black TNK LVL SENS RTN EN1029 TN-Tan TNK TMP SENS SIG


CIRCUIT NUMBERS


EN1030 BK-Black TNK TMP SENS RTN EN1031 GN-Green PMP MOTOR SUPPLY EN1032 BK-Black PMP MOTOR RETURN EN1033 PE-Purple PMP MOTOR PWM EN1034 GN-Green REVERTING VLV SIG EN1035 BK-Black REVERTING VLV RTN EN1036 BK-Black PSI SENS RETURN EN1037 PK-Pink PSI SENS SUPPLY 5V EN1038 TN-Tan PSI SENS SIG EN1039 WE-White ELEC HTR SUPPLY EN1040 BK-Black ELEC HTR RETURN EN1041 TN-Tan PFT FILTER OUTLET PSI SIG EN1042 PK-Pink TWT-22 FAN SPD SENS SUPPLY EN1043 OE-Orange TWT-22 FAN SPD SENS SIG EN1044 BK-Black TWT-22 FAN SPD SENS RETURN EN1045 BK-Black TWQ-1 ECU RETURN SENSOR EN1046 TN-Tan TWQ-1 DPF DELTA PRESSURE EN1047 PE-Purple TWQ-1 DPF OUTLET PRESSURE EN1048 OE-Orange TWQ-1 SENSOR SUPPLY 5V EN1049 WE-White DOC OUTLET TEMP EN1050 BK-Black ECU RETURN SWITCH EN1051 YW-Yellow DOC INLET TEMP EN1052 BE-Blue DPF OUTLET TEMP EN1053 BK-Black ECU RETURN SENSOR EN1054 PE-Purple SCR OUTLET TEMP EN1055 YW-Yellow SCR INLET TEMP EN1056 GY-Gray DPF MANUAL REGEN EN1057 GY-Gray DPF REGEN INHIBIT EN1058 PK-Pink TNK SENS SUPPLY 12V EN1059 RD-Red ENG NOx BATT POS EN1060 WE-White TWP-46 AMBIENT AIR TEMP SEN EN1061 BK-Black TWP-46 AMBIENT AIR TEMP SEN RET EN1062 YW-Yellow TWP-53 DATALINK HIGH EN1063 GN-Green TWP-53 DATALINK LOW FW078 BN-Brown DEAD BOLT OUTPUT FW079 OE-Orange DEAD BOLT RIGHT FW080 BN-Brown DOOR LOCK OUTPUT FW081 GY-Gray DOOR LOCK LEFT FW129 OE-Orange DOOR LOCK LC101 GY-Gray TYPE 1 GROUND LC102 YW-Yellow IGN ACTIVE POWER LC103 PK-Pink BATTERY DIRECT LC104 YW-Yellow IGN ACTIVE LC105 GY-Gray TYPE 1 LC106 WE-White PTO ENABLE LC107 OE-Orange EXHAUST BRAKE ENABLE


CIRCUIT NUMBERS


LC108 WE-White AUTO NEUTRAL LC109 WE-White PLUG LC110 YW-Yellow SEC. SHIFT SCHDULE LC111 GN-Green AUX. RANGE INHIBIT LC112 BE-Blue RETARDER ENABLE LC113 PK-Pink ABS LC114 OE-Orange SERVICE BRAKE STATUS LC115 PLUG LC116 PLUG LC117 PLUG LC118 PLUG LC119 WE-White PTO OUTPUT LC120 OE-Orange EXHAUST BRAKE OUTPUT LC121 WE-White RANGE IDICATOR LC122 BE-Blue OUTPUT SPEED INDICTR LC123 PK-Pink RANGE INHIBIT LC124 WE-White RETARDER INDICATOR LC125 GN-Green CHECK TRANS LC126 TN-Tan SPD SIG NON-ZERO CROSS LC127 TN-Tan SPD SIG ZERO CROSS LC128 YW-Yellow SIGNAL RETURN LC129 RD-Red J1939+ LC130 PLUG LC131 GN-Green SHIELD LC132 BK-Black J1939- LC201 BE-Blue PRESSURE SWITCH C LC202 PK-Pink PRESSURE SWITCH D LC203 WE-White PRESSURE SWITCH E LC204 GN-Green PRESSURE SWITCH R LC205 BE-Blue NSBU SWITCH A LC206 YW-Yellow NSBU SWITCH B LC207 GY-Gray NSBU SWITCH C LC208 WE-White NSBU SWITCH P LC210 TN-Tan SUMPTEMP LC213 OE-Orange TWP-21 TURBINE SPEED HI LC214 BE-Blue TWP-21 TURBINE SPEED LO LC215 YW-Yellow TWP-22 OUTPUT SPEED HI LC216 GN-Green TWP-22 OUTPUT SPEED LO LC217 TN-Tan TWP-23 ENGINE SPEED HI LC218 OE-Orange TWP-23 ENGINE SPEED LO LC220 GN-Green COMMON RETURN LC221 YW-Yellow TRANS ID LC222 YW-Yellow SOL A RETURN LC223 WE-White SOL A LC224 PK-Pink SOL B LC225 OE-Orange SOL B RETURN


CIRCUIT NUMBERS


LC226 GN-Green SOL C ON/OFF LC227 BE-Blue SOL D ON/OFF LC228 GY-Gray SOL E ON/OFF LC229 WE-White SOL F LOCKUP LC230 BE-Blue MOD MAIN PSI LC231 TN-Tan SOL C, D, E RETURN LC232 GN-Green SOL F RETURN RB008 PE-Purple REAR WARN LTS RB016 WE-White BODY OPEN DOOR LT RB021 RD-Red IGNITION RB024 RD-Red PUMP SHIFT POWER RB033 WE-White OK TO PUMP (+) RB061 WE-White SPARE RB062 WE-White SPARE RB065 GN-Green PUMP ENGAGED RB070 BK-Black COMMON GND RB080 WE-White PTO PUMP AND ROLL RB091 WE-White SPARE RB092 WE-White SPARE RB094 WE-White PARK BRAKE RB106 BE-Blue ROAD MODE RB118 GN-Green PUMP MODE RB123 YW-Yellow PUMP MODE POS INPUT RB124 RD-Red SPEED CONTROL FUSED PWR RB133 GY-Gray OK TO PUMP (-) RB170 BK-Black SPEED CONTROL BATT GND RB178 OE-Orange REAR BEACONS RB302 WE-White TWP-40 J1587 POSITIVE RB303 BE-Blue TWP-40 J1587 NEGATIVE RB304 RD-Red THROTTLE +5V RB305 BK-Black THROTTLE RETURN RB306 GN-Green THROTTLE SIGNAL RB346 PE-Purple ECM HIGH IDLE ENABLE

RR0001 GN-Green C/S DR SW RR0002 GN-Green #6 COMP SW RR0003 GN-Green #6.5 COMP SW RR0004 GN-Green #8 COMP SW RR0005 BN-Brown #8-7 SCENE RR0006 PE-Purple FT LT BAR RR0007 YW-Yellow BENCH LT RR0008 OE-Orange #6.5 COMP LT RR0009 OE-Orange #6 SCENE LT RR0010 PE-Purple AUX DOME LT RR0011 RD-Red DOME LT TMR TRIG GND RR0012 BN-Brown OEM TAP RR0013 WE-White SIREN HORN


CIRCUIT NUMBERS


RR0014 WE-White EXTRA RR0015 RD-Red DRL CUTOUT RR0016 GY-Gray DRL 1 RR0017 PE-Purple DRL 2 RR0018 RD-Red HEAT VALVE RR0019 YW-Yellow SIREN SPEAKER 1 + RR0020 BK-Black SIREN SPEAKER 1 - RR0021 OE-Orange SIREN SPEAKER 2 + RR0022 BK-Black SIREN SPEAKER 2 - RR0023 BE-Blue HORN RING RR0024 GY-Gray CHASSIS HORN RR0025 RD-Red INTERSECTION LT RR0026 PE-Purple GRILL LT RR0027 YW-Yellow CAB DOOR RR0028 WE-White E BRAKE RR0029 PE-Purple REAR SCENE LTS RR0030 PE-Purple SUCTION RR0031 YW-Yellow COT LTS RR0032 BE-Blue ATTENDANT LT RR0033 BE-Blue HI BEAM FLSHR RR0034 WE-White HI BEAM IND RR0035 BN-Brown EXHAUST FAN RR0036 GN-Green REAR DR SW RR0037 GN-Green SIDE DR SW RR0038 WE-White O2 LIGHT RR0039 WE-White O2 SOLENOID RR0040 OE-Orange ADDL RR0041 RD-Red HD LT FD RR0042 RD-Red FLASHER A RR0043 WE-White FLASHER B RR0044 BK-Black FLASHER C RR0045 BE-Blue REAR LIGHT BAR RR0046 GN-Green #1 COMPT SW RR0047 OE-Orange #1 COMPT LT RR0048 GN-Green #2 COMPT SW RR0049 OE-Orange #2 COMPT LT RR0050 GN-Green #3 COMPT SW RR0051 OE-Orange #3 COMPT LT RR0052 GN-Green #4 COMPT SW RR0053 OE-Orange #4 COMPT LT RR0054 GN-Green #5 COMPT SW RR0055 OE-Orange #5 COMPT LT RR0056 YW-Yellow DRIVING LT RR0057 RD-Red SWITCH PANEL FD RR0058 BE-Blue LOW VOLTAGE IND RR0059 OE-Orange OPEN DOOR IND


CIRCUIT NUMBERS


RR0060 OE-Orange OPEN COMPT IND RR0061 OE-Orange MOD DISC IND RR0062 BE-Blue SS GEN RR0063 BE-Blue SS AMB RR0064 BE-Blue SS RED RR0065 BE-Blue SS BUZZER RR0066 OE-Orange #6 COMP LT RR0067 OE-Orange #8 COMP LT RR0068 YW-Yellow #1-2 SCENE RR0069 PE-Purple #4-5 SCENE RR0070 OE-Orange #3 SCENE RR0071 OE-Orange PARK SIGNAL RR0072 PE-Purple FLASH PRIM TRIG RR0073 YW-Yellow FLASH SEC TRIG RR0074 OE-Orange CLIMATE FAN HI RR0075 OE-Orange CLIMATE FAN LO RR0076 GN-Green #7 COMPT SW RR0077 OE-Orange #7 COMPT LT RR0078 OE-Orange CLIMATE FAN MED RR0079 OE-Orange CLIMATE CONTROL FD RR0080 RD-Red INVERTER REMOTE RR0081 WE-White INVERTER REMOTE RR0082 OE-Orange SS REAR SCENE LT RR0083 OE-Orange CS REAR SCENE LT RR0084 GN-Green FLSHR/BRK RR0085 GN-Green COMPT #8 SW RR0086 OE-Orange COMPT #8 LT RR0087 GN-Green COMPT #6 SW RR0088 OE-Orange COMPT #6 LT RR0089 WE-White MODEM RING RR0090 BK-Black MODEM TIP RR0091 BN-Brown OEM MRKR TAP RR0092 PK-Pink OEM STOP TAP RR0093 YW-Yellow OEM LEFT TURN TAP RR0094 DKGN-Dark Green OEM RIGHT TURN TAP RR0095 GY-Gray OEM E-BRAKE TAP RR0096 OE-Orange OEM PARK/NEU TAP RR0097 WE-White OEM REV TAP RR0098 PK-Pink OEM IGN TAP RR0099 PK-Pink OEM ACC TAP RR0100 RD-Red REAR SCENE LTS RR0101 OE-Orange FLSHR PRI TRIG RR0102 GY-Gray FLSHR SEC TRIG RR0103 GY-Gray TIMER CUT-OUT RR0104 OE-Orange DUMP ENABLE RR0105 PE-Purple SUCTION PUMP


CIRCUIT NUMBERS


RR0106 RD-Red MUX NODE PWR RR0107 PK-Pink MUX NODE IGN RR0108 RD-Red MOD IGN PWR RR0109 RD-Red CLIMATE MOD PWR RR0110 RD-Red CURRENT MOD PWR RR0111 RD-Red O2 MOD PWR RR0112 RD-Red 1660 FLSHR PWR RR0113 RD-Red MED ISO PWR RR0114 RD-Red MED ISO OUTLET PWR RR0115 RD-Red DOME LT MOD PWR RR0116 RD-Red 12V OUTLET PWR RR0117 RD-Red DOOR LOCK PWR RR0118 RD-Red CABNT LOCK PWR RR0119 RD-Red FSP PWR RR0120 RD-Red RSP PWR RR0121 OE-Orange WARN 1A PWR RR0122 BE-Blue WARN 1A RTN RR0123 OE-Orange WARN 2A PWR RR0124 BE-Blue WARN 2A RTN RR0125 OE-Orange WARN 3B PWR RR0126 BE-Blue WARN 3B RTN RR0127 OE-Orange WARN 4A PWR RR0128 BE-Blue WARN 4A RTN RR0129 OE-Orange WARN 5A PWR RR0130 BE-Blue WARN 5A RTN RR0131 OE-Orange WARN 6A PWR RR0132 BE-Blue WARN 6A RTN RR0133 OE-Orange WARN 7B PWR RR0134 BE-Blue WARN 7B RTN RR0135 OE-Orange WARN 8A PWR RR0136 BE-Blue WARN 8A RTN RR0137 OE-Orange WARN 9C PWR RR0138 BE-Blue WARN 9C RTN RR0139 OE-Orange WARN 10A PWR RR0140 BE-Blue WARN 10A RTN RR0141 OE-Orange WARN 11A PWR RR0142 BE-Blue WARN 11A RTN RR0143 OE-Orange WARN 12B PWR RR0144 BE-Blue WARN 12B RTN RR0145 OE-Orange WARN 13A PWR RR0146 BE-Blue WARN 13A RTN RR0147 OE-Orange WARN 14A PWR RR0148 BE-Blue WARN 14A RTN RR0149 OE-Orange WARN 15A PWR RR0150 BE-Blue WARN 15A RTN RR0151 OE-Orange WARN 16C PWR


CIRCUIT NUMBERS


RR0152 BE-Blue WARN 16C RTN RR0153 OE-Orange WARN 17C PWR RR0154 BE-Blue WARN 17C RTN RR0155 OE-Orange WARN 18C PWR RR0156 BE-Blue WARN 18C RTN RR0157 OE-Orange WARN 19C PWR RR0158 BE-Blue WARN 19C RTN RR0159 RD-Red TWT-23 CUR SENS PWR RR0160 BE-Blue TWT-23 CUR SENS SIG RR0161 BK-Black TWT-23 CUR SENS RTN RR0162 RD-Red TWT-24 O2 SENS PWR RR0163 BE-Blue TWT-24 O2 SENS SIG RR0164 BK-Black TWT-24 O2 SENS RTN RR0165 PK-Pink OEM ACC RR0166 PK-Pink OEM IGN RR0167 PK-Pink HEAT PUMP RR0168 RD-Red FLSHR PWR RR0169 PK-Pink AUTO EJECT SIG RR0170 GN-Green MOD PWR SW SIG RR0171 RD-Red FSP PWR RR0172 RD-Red RSP PWR RR0173 RD-Red PWR DOOR LOCKS RR0174 RD-Red TIME DELAY PWR RR0175 BE-Blue DOME LT TMR TRIG +12V RR0176 RD-Red TWT-25 INT TMP SEN POS RR0177 WE-White TWT-25 INT TMP SEN SIG RR0178 BK-Black TWT-25 INT TMP SEN NEG RR0179 RD-Red TWT-26 EXT TMP SEN POS RR0180 WE-White TWT-26 EXT TMP SEN SIG RR0181 BK-Black TWT-26 EXT TMP SEN NEG RR0182 PK-Pink CS SCENE LTS RR0183 PK-Pink SS SCENE LTS RR0184 RD-Red SER RX RR0185 WE-White SER TX RR0186 BK-Black SER GND RR0187 RD-Red COT LTS HI RR0188 RD-Red COT LTS LO RR0189 RD-Red BENCH LTS HI RR0190 RD-Red BENCH LTS LO RR0191 RD-Red DOME LTS HI RR0192 RD-Red DOME LTS LO RR0193 RD-Red SIREN/HORN PWR RR0194 GN-Green #8.5 COMP SW RR0195 OE-Orange #8.5 COMP LT RR0196 RD-Red STEP WELL LT PWR RR0197 PK-Pink CLK ILLUM PWR


CIRCUIT NUMBERS


RR0198 GY-Gray FLASHER PRIM/SEC RR0199 RD-Red LT BAR FLASH PRIM/SEC RR0200 PK-Pink LT BAR PRI SW RR0201 OE-Orange LT BAR PRI SEC SW RR0202 RD-Red MOD POWER RR0203 RD-Red COTS LTS RR0204 RD-Red BENCH LTS RR0205 PK-Pink REAR FLOOD ENABLE RR0206 RD-Red REAR DOOR PWR RR0207 RD-Red SIDE DOOR PWR RR0208 BE-Blue PWR DR SW LK RR0209 OE-Orange PWR DR SW UNLK RR0210 GN-Green PWR DR LK RR0211 WE-White PWR DR UNLK RR0212 RD-Red O2 LIFT 1 RR0213 YW-Yellow O2 LIFT 2 RR0214 RD-Red HEAT PAD RLY RR0215 PK-Pink HEAT PAD RR0216 BK-Black THERMOSTAT RR0217 RD-Red RECTIFIER PWR RR0218 OE-Orange CABINET LT RR0219 BK-Black FLASHER BRAKES GND RR0220 OE-Orange WARN 20A PWR RR0221 BE-Blue WARN 20A RTN RR0222 OE-Orange WARN 21A PWR RR0223 BE-Blue WARN 21A RTN RR0224 OE-Orange WARN 22A PWR RR0225 BE-Blue WARN 22A RTN RR0226 OE-Orange WARN 23A PWR RR0227 BE-Blue WARN 23A RTN RR0228 OE-Orange WARN A PWR RR0229 BE-Blue WARN A RTN RR0230 OE-Orange WARN B PWR RR0231 BE-Blue WARN B RTN RR0232 OE-Orange WARN C PWR RR0233 BE-Blue WARN C RTN RR0234 GY-Gray FLSHR BRK TRIG RR0235 OE-Orange WARN 24A PWR RR0236 BE-Blue WARN 24A RTN RR0237 YW-Yellow PWR DR LK RR0238 BN-Brown PWR DR UNLK RR0239 GY-Gray ANTI THEFT SP001 PK-Pink HDLP SW TO MKR SP002 RD-Red ABS BATT PWR SP003 BK-Black ABS LIGHT GND SP004 RD-Red IGN TO ABS ECU


CIRCUIT NUMBERS


SP005 PK-Pink ABS RELAY SP006 BK-Black COMMON GND SP007 RD-Red AC CLT SW PWR SP008 RD-Red MRKR LT PWR FT SP009 RD-Red DSH LP PWR SP011 RD-Red AIR DRYER PWR SP012 RD-Red BATT SENSE SP013 PK-Pink IGN ACT TO ALT SP014 RD-Red B/UP LIGHT PWR SP015 PK-Pink B/UP LT ACTIVE SP016 GY-Gray OIL PRS SW NEG SP017 GY-Gray COL TMP SW NEG SP018 GY-Gray LO AIR SW1 NEG SP019 GY-Gray LOW COL LT NEG SP020 RD-Red INSTRUMENT PWR SP021 GY-Gray LO COOL SNDR SP022 GY-Gray IGN START GND SP023 TN-Tan COOL TEMP SNDR SP024 PK-Pink STP PRS SW1 SP025 RD-Red STP CIR FT PWR SP026 GY-Gray NEUTRAL SIGNAL SP027 PE-Purple CRCONT JUMPER SP028 GY-Gray CRCONT SET SW SP029 GY-Gray CRCONT SET DSH SP030 GY-Gray CRCONT RESUME SP031 PK-Pink CRUZ ACTIVE SP032 GY-Gray CRUZ MTR NEG SP033 PK-Pink CRUZ MTR POS SP034 GY-Gray CRUZ CLT NEG SP035 PK-Pink CRUZ CLT POS SP036 RD-Red CRUZ POWER SP037 RD-Red CRUZ PWR - ECU SP038 PK-Pink EXH BRK ACTIVE SP039 RD-Red ENG BRK POWER SP040 TN-Tan FUEL SNDR SIG SP041 RD-Red HZD/TRNSIG PWR SP042 RD-Red FLASHER OUTPUT SP043 RD-Red CORNER LT PWR SP044 YW-Yellow LEFT TURN SIG SP045 DKGN-Dark Green RIGHT TURN SIG SP046 RD-Red REAR TURN PWR SP047 DKGN-Dark Green RIGHT TRN REAR SP048 YW-Yellow LEFT TURN REAR SP049 RD-Red HORN POWER SP050 PK-Pink HRN RLY TO HRN SP051 GY-Gray HORN BUTTON


CIRCUIT NUMBERS


SP052 GY-Gray HOURMETER SNDR SP053 RD-Red BATTPOS/IGN SW SP054 PK-Pink IGN SW/ACC RLY SP055 PK-Pink IGNITION SW SP056 PK-Pink START SIGNAL SP057 PK-Pink START RELAY SP058 RD-Red HDLMP PWR SP059 RD-Red HIGH LOW SW SP060 RD-Red HDLP LO BM PWR SP061 RD-Red HDLP HI BM PWR SP062 BK-Black DOME LT SW GND SP063 RD-Red MARKER LIGHTS SP064 BN-Brown R MRKR LT PWR SP065 BN-Brown REAR MRKR RLY SP066 RD-Red MOIST EJCT PWR SP067 TN-Tan OIL PRESS SNDR SP068 GY-Gray PARK BRK LIGHT SP069 RD-Red PREHT CONT PWR SP070 GY-Gray PRHT START SIG SP071 BK-Black FT ECU GND ABS SP072 RD-Red START RELAY SP073 RD-Red STARTER SOL SP074 RD-Red STRT TO FL SOL SP075 RD-Red STOP LIGHT PWR SP076 RD-Red STP LT-RLY/LT SP077 PK-Pink TWP-05 TACH GAUGE POS SP078 GY-Gray TWP-05 TACH GAUGE NEG SP079 TN-Tan TRANS TEMP SIG SP080 BN-Brown LVL JK FLT SW SP081 LTBE-Light Blue LVL JK MTR SOL SP082 DKGN-Dark Green LVL JK DMP VLV SP083 YW-Yellow LVL JK LEFT SP084 OE-Orange LVL JK RIGHT SP085 PE-Purple LVL JK FRONT SP086 RD-Red ACC PWR TO LEVEL CONT SP087 GY-Gray LEVEL CONT NEG SP088 PK-Pink LEVEL CONT POS SP089 GY-Gray LEVEL WARN LT SP090 RD-Red TOW VEH POWER SP091 PK-Pink HOOD LIGHTS SP092 RD-Red DRIVER ST PWR SP093 RD-Red CAPT SEAT PWR SP094 RD-Red WIPER POWER SP095 PE-Purple WIPER LOW SP096 GY-Gray WIPER HIGH SP097 TN-Tan WIPER INTRM


CIRCUIT NUMBERS


SP098 RD-Red WASHER SP099 RD-Red HOOD LIGHT PWR SP100 GY-Gray MRKR FLASH SW SP101 RD-Red TURN SIGNAL PWR SP102 BK-Black DAYTIME LT PWR SP103 RD-Red CIGAR LTR PWR SP104 RD-Red SPOTLIGHT PWR SP105 RD-Red BLWR MTR PWR SP106 RD-Red CNDSR FAN PWR SP107 RD-Red FOG LMP PWR SP108 BK-Black FOG LMP SW/LTS SP109 RD-Red DOCK LT PWR SP110 PK-Pink DOCK LIGHTS SP111 RD-Red PWR BMNT LT SW SP112 BK-Black BASEMENT LIGHT SP113 RD-Red DASH FAN PWR SP114 BK-Black DASH FAN PWR SP115 BK-Black DASH FAN PWR SP116 BK-Black DASH FAN PWR SP117 BK-Black DASH FAN PWR SP118 RD-Red PWR AUX ST SW SP119 RD-Red AUX START PWR SP120 RD-Red PWR TO STEP SW SP121 RD-Red STEP SW PWR SP122 BK-Black HORN SOLENOID SP123 RD-Red RADIO SW PWR SP124 RD-Red PWR - RADIO SW SP125 RD-Red RADIO POWER SP126 RD-Red MEMORY POWER SP127 RD-Red CB POWER SP128 RD-Red REAR AUTO HTR SP129 RD-Red HEATER RELAY SP130 BK-Black RLY - COND MTR SP131 BK-Black RADIO GND SP132 RD-Red MIRROR PWR SP133 PK-Pink RT MIRROR SIG SP134 PK-Pink RT MIRROR SIG SP135 PK-Pink MIRROR SIGNALS SP136 PK-Pink SPEED SW POS SP137 GY-Gray SPEED SW NEG SP138 RD-Red HTD MIRROR PWR SP139 PK-Pink RT HTD MIRROR SP140 RD-Red REAR CAM PWR SP141 RD-Red DOME LIGHT PWR SP142 RD-Red DOME LIGHT PWR SP143 BK-Black LFT CRNRING LT


CIRCUIT NUMBERS


SP144 BK-Black RT CRNRING LT SP145 BK-Black DUMP VLV RT SP146 GY-Gray DUMP VLV COM SP147 YW-Yellow DUMP VLV LEFT SP148 LTGN-Light Green AIR DUMP SP149 LTBE-Light Blue AIR FILL SP150 GY-Gray MIR - MIR CONT SP151 BK-Black DOME LMP NEG SP152 PK-Pink DOME SW TO RLY SP153 GY-Gray LOW FUEL WARN SP154 TN-Tan KYSR OIL HI SP155 TN-Tan KYSOR OIL TEMP SP156 TN-Tan KYSOR COOL LOW SP157 TN-Tan KYSOR COOL HI SP158 TN-Tan KYSON OIL LOW SP159 GY-Gray NEUTRAL SW RET SP160 PK-Pink TWT-14 THROTTLE POS SP161 GY-Gray TWT-14 THROTTLE NEG SP162 TN-Tan TWT-14 THROTTLE SIG SP163 PK-Pink IDLE SW N.OPEN SP164 GY-Gray IDLE SW N.CLS SP165 GY-Gray ENG BRK SIGNAL SP166 GY-Gray CRUZ SW ON SP167 GY-Gray CRUZ SET SP168 GY-Gray CRUZ RESUME SP169 GY-Gray CHECK ENG SP170 GY-Gray STOP ENG SP171 GY-Gray IDLE INCREMENT SP172 GY-Gray IDLE DECREMENT SP173 GY-Gray BRAKE SWITCH SP174 GY-Gray DIANOSTIC TEST SP175 PK-Pink LEVEL SENSOR C SP176 GY-Gray LEVEL SENSOR B SP177 WE-White LEVEL SENSOR D SP178 TN-Tan LEVEL SENSOR A SP179 WE-White FAN CLUTCH NEG SP180 GY-Gray AC PRS SW N CL SP181 PK-Pink ENGINE BRAKE 1 SP182 PK-Pink ENGINE BRAKE 2 SP183 RD-Red CLEAN PWR SP184 RD-Red BATTERY PWR SP185 BK-Black CLEAN GND SP186 ----- J1939-11 CABLE J1939-11 SHLD DRN SP187 YW-Yellow J1939-11 CABLE J1939-11 POS SP188 DKGN-Dark Green J1939-11 CABLE J1939-11 NEG SP189 RD-Red BCC IGN PWR


CIRCUIT NUMBERS


SP190 RD-Red CUST BATT SP191 RD-Red CUST IGN SP192 RD-Red CUST ACC SP193 BK-Black MKR RLY FL RLY SP194 BN-Brown MKR RLY FL RLY SP195 GY-Gray JAKE RLY TO SW SP196 YW-Yellow L STP COL-RLY SP197 DKGN-Dark Green R STP COL-RLY SP198 YW-Yellow L STP RLY - LT SP199 DKGN-Dark Green R STP RLY - LT SP200 BK-Black HDLP SW FL RLY SP201 GY-Gray ATC SW TO ECU SP202 GY-Gray ENG PROT SP203 GY-Gray OIL SW HR MTR SP204 TN-Tan 2ND COOL GA SP205 TN-Tan 2ND OIL PRS TO GA SP206 DR INTRLCK SIG SP207 BE-Blue BAV SP208 BN-Brown BAV SP209 PK-Pink TWP-06 J1587 POS SP210 GY-Gray TWP-06 J1587 NEG SP211 GY-Gray BRK FLUID LVL SP212 GY-Gray ECU TO ATC LT SP213 TN-Tan AIR 1 TO GA SP214 TN-Tan AIR 2 TO GA SP215 RD-Red BATT TO FUSES SP216 PK-Pink RLY 1 TO RLY 2 SP217 RD-Red BATT TO FUSES SP218 RD-Red FRT BATT PWR SP219 RD-Red REAR BATT PWR SP220 PK-Pink IGN RLY TO FUS SP221 GY-Gray AUD ALRM NEG SP222 PK-Pink IGN RLY TO FUS SP223 PK-Pink FUSE TO J BLK SP224 RD-Red FRT ACC PWR SP225 PK-Pink ACC RLY TO FUS SP226 DKGN-Dark Green RIGHT STOP/TURN SP227 YW-Yellow LEFT STOP/TURN SP228 SP229 GY-Gray PHT TMP RET SP230 GY-Gray PHT OIL PRS SW SP231 PK-Pink PHT FL SOL PWR SP232 PK-Pink PHT RLY ACTIVA SP233 PK-Pink ST RLY - STRTR SP234 PK-Pink LR JACK EXTEND SP235 GY-Gray LR JACK LIMIT


CIRCUIT NUMBERS


SP236 PK-Pink LR JACK RETRCT SP237 PK-Pink RR JACK EXTEND SP238 GY-Gray RR JACK LIMIT SP239 PK-Pink RR JACK RETRCT SP240 BK-Black TWP-07 ABS 1 SENS L2 SP241 BN-Brown TWP-07 ABS 1 SENS L1 SP242 BN-Brown TWP-08 ABS 1 SENS R1 SP243 BK-Black TWP-08 ABS 1 SENS R2

SP244 GN/YW-

Green/Yellow TWT-05 ABS 1 VLV COM L SP245 BN-Brown TWT-05 ABS 1 VLV I/L L SP246 BE-Blue TWT-05 ABS 1 VLV O/L L

SP247 GN/YW-

Green/Yellow TWT-06 ABS 1 VLV COM R SP248 BN-Brown TWT-06 ABS 1 VLV I/L R SP249 BE-Blue TWT-06 ABS 1 VLV O/L R SP250 YW-Yellow L STP/TRN OUT SP251 DKGN-Dark Green R STP/TRN OUT SP252 BN-Brown TWP-09 ABS 2 SENS L1 SP253 BK-Black TWP-09 ABS 2 SENS L2 SP254 BN-Brown TWP-10 ABS 2 SENS R1 SP255 BK-Black TWP-10 ABS 2 SENS R2

SP256 GN/YW-


SP259 GN/YW-

Green/Yellow TWT-08 ABS 2 VLV COM R SP260 BN-Brown TWT-08 ABS 2 VLV I/L R SP261 BE-Blue TWT-08 ABS 2 VLV O/L R SP262 PK-Pink RF JACK EXTEND SP263 GY-Gray RF JACK LIMIT SP264 PK-Pink RF JACK RETRCT SP265 PK-Pink LF JACK EXTEND SP266 GY-Gray LF JACK LIMIT SP267 PK-Pink LF JACK RETRCT SP268 PK-Pink DRVG LT SW FD SP269 WE-White DRVG LTS ACT SP270 BK-Black INSTRUMENT GND SP271 RD-Red 24V SUPPLY SP273 TN-Tan ECAS DR INPUT SP274 TN-Tan TWP-15 SENS RR ECAS SP275 RD-Red 24V IGNITION SP276 TN-Tan ECAS DSH SOUND SP277 TN-Tan ECAS EXT SOUND SP279 TN-Tan LOW RIDE ECAS SP281 TN-Tan HI RIDE SWITCH


CIRCUIT NUMBERS


SP282 TN-Tan SHPNG LVL SW SP283 TN-Tan KNEELING LIGHT SP284 TN-Tan LO RIDE SWITCH SP285 TN-Tan AUTO KNEEL SW SP286 TN-Tan MAN KNEEL SW SP287 BK-Black TWP-16 SENS RL ECAS SP288 TN-Tan TWP-14 SENS F ECAS SP289 BK-Black TWP-14 24V GND-ECAS SP292 TN-Tan FAULT LIGHT SP293 TN-Tan 24V NEUT GND SP294 TN-Tan ECAS PARK BRK SP295 TN-Tan HI RIDE LT ECAS SP296 BK-Black TWP-18 ABS 3 SENS L2 SP297 BN-Brown TWP-18 ABS 3 SENS L1 SP298 BN-Brown TWP-17 ABS 3 SENS R1 SP299 BK-Black TWP-17 ABS 3 SENS R2

SP300 GN/YW-


SP303 GN/YW-

Green/Yellow TWT-09 ABS 3 VLV COM R SP304 BN-Brown TWT-09 ABS 3 VLV I/L R SP305 BE-Blue TWT-09 ABS 3 VLV O/L R SP308 BN-Brown TWP-15 ECAS SENS RR COM SP309 BN-Brown TWP-16 ECAS SENS RL COM SP310 TN-Tan RTRDER BRK SIG SP311 TN-Tan FUEL HTR POS SP312 TN-Tan CHARGE LIGHT SP315 RD-Red BAT - PHT FUSE SP316 RD-Red BAT - PHT FUSE SP317 RD-Red PHT FSE TO RLY SP318 RD-Red PHT FSE TO RLY SP319 RD-Red BAT TO FL RLY SP320 RD-Red R STP/TRN PWR SP321 RD-Red FUS TO IGN RLY SP322 RD-Red HDLT FLSH COL SP323 YW-Yellow CUSTOMER 1 SP324 YW-Yellow CUSTOMER 2 SP325 YW-Yellow CUSTOMER 3 SP326 YW-Yellow CUSTOMER 4 SP327 YW-Yellow CUSTOMER 5 SP328 YW-Yellow CUSTOMER 6 SP329 YW-Yellow CUSTOMER 7 SP330 YW-Yellow CUSTOMER 8 SP331 BN-Brown TWP-19 VIP DATA LINK (-)


CIRCUIT NUMBERS


SP332 YW-Yellow TWP-19 VIP DATA LINK (+) SP333 GY-Gray VIP MKR LMP OF SP334 GY-Gray VIP MKR LMP ON SP335 GY-Gray VIP HD LMP WPR SP336 GY-Gray VIP HD LMP OFF SP337 GY-Gray VIP HD LMP ON SP338 GY-Gray HDLT FLASH SP339 GY-Gray MKR LT FLASH SP340 RD-Red GENER START SP341 RD-Red VAC PUMP PWR SP342 BK-Black AUTO STEP A SP343 BK-Black AUTO STEP B SP344 RD-Red FAN SOL PWR SP345 BK-Black FAN SOL GND SP346 TN-Tan FAN THERM SIG SP347 BK-Black FAN THERM GND SP348 RD-Red FAN POWER SP349 RD-Red FAN POWER-12V SP350 GY-Gray FAN OVER-RIDE SP351 GY-Gray RETRDR IND LT SP352 PK-Pink TWP-20 SPEEDO POS SP353 GY-Gray TWP-20 SPEEDO NEG SP354 RD-Red SPD GENER PWR SP355 GY-Gray TRANS TEMP SW SP356 PK-Pink LVL JACK CONT POS BATT SP357 RD-Red SLIDE OUT PWR SP358 PK-Pink KNEEL VLV FILL SP359 RD-Red KNEEL VLV PWR SP360 PK-Pink TAG DUMP SP361 RD-Red DRV LGT PWR SP362 PE-Purple SW DRV LGT SP363 GY-Gray H'MAX FLOW SW SP364 GY-Gray H'MAX WRNG LMP SP365 GY-Gray H'MAX PUMP SIG SP366 GY-Gray H'MAX PUMP POS SP367 RD-Red H'MAX RLY FEED SP368 RD-Red DDEC BUZZER SP369 PK-Pink PSG INTRLK POS SP370 GY-Gray PSG INTRLK NEG SP371 GY-Gray LO AIR 2 SW SP372 RD-Red FL PRMR PWR SP373 PK-Pink PRMR SW TO PMP SP374 RD-Red SHUTDOWN PWR SP375 PK-Pink SHTDN SW - SOL SP376 TN-Tan FAST IDLE MAN SP377 TN-Tan DISABLE MAN


CIRCUIT NUMBERS


SP378 PE-Purple TAG STEER LOCK SP379 PK-Pink TAG PRESS SW SP380 PK-Pink FAST IDLE SW SP381 GY-Gray HIGH IDLE LAMP SP382 GY-Gray SIREN BRAKE SP383 GY-Gray SIREN RELAY SP384 GY-Gray WIPER PARK L SP385 GY-Gray WIPER PARK R SP386 GY-Gray RIGHT WIPER LO SP387 GY-Gray RIGHT WIPER HI SP388 WE-White EXTERIOR TEMP SP389 PK-Pink DIAGN TOOL PWR SP390 GY-Gray TRANS ENGAGED SP391 PK-Pink LVL JACKS SP392 PK-Pink DOOR RLTC SP393 GY-Gray HNDL SENS SP394 GY-Gray RLR SENS SP395 PK-Pink LTCH JMP SP396 RD-Red LVL JACK BATT SP397 PK-Pink LFT SD WARNING SP398 PK-Pink RT SD WARNING SP399 PK-Pink RT LWR WRNING SP400 PK-Pink LT LWR WRNING SP401 PK-Pink SD WRN RLY SP402 RD-Red SD WARN SW SP403 RD-Red SD WARN PWR SP404 PK-Pink INTERLOCK SP405 RD-Red MAP LT SP406 PK-Pink LFT WARNING LT SP407 PK-Pink RT WARNING LT SP408 RD-Red FRT WARN PWR SP409 RD-Red CRTSY LMP PWR SP410 RD-Red BEACON SP411 RD-Red BEACON PWR SP412 RD-Red BEACON SWITCH SP413 RD-Red ALT LT PWR SP414 PK-Pink WRN LT RLY SP415 PK-Pink WARN LT SW SP416 RD-Red SIREN PWR SP417 RD-Red OPN DR BEAC PW SP418 PK-Pink P-MODE SHIFT SP419 RD-Red DEFROST FAN SP420 PK-Pink BRKR TO RLY SP421 RD-Red RLY TO BUS BAR SP422 RD-Red BRKR - AC BLWR SP423 RD-Red BRKR - AC BLWR


CIRCUIT NUMBERS


SP424 GY-Gray DOME LT LFT SP425 GY-Gray DOME LT RT SP426 GY-Gray DUMP VLV OFF SP427 PK-Pink DUMP VLV ON SP428 RD-Red HTR PWR SP429 RD-Red HTR PWR SP430 RD-Red HTR PWR SP431 GY-Gray ABS WARN SP433 RD-Red FRT WARN FLSHR SP434 RD-Red MSTR WARN SW FEED SP435 RD-Red MSTR WARN SW PWR SP436 GY-Gray N TO R INHIBIT SP437 GY-Gray 4TH RANGE IND SP438 RD-Red LEFT SPOT LT SP439 RD-Red RIGHT SPOT LT SP440 RD-Red RELAY 1 PWR SP441 PK-Pink RELAY 1 NC SP442 PK-Pink RELAY 1 NO SP443 RD-Red RELAY 2 PWR SP444 PK-Pink RELAY 2 NC SP445 PK-Pink RELAY 2 NO SP446 RD-Red RELAY 3 PWR SP447 PK-Pink RELAY 3 NC SP448 PK-Pink RELAY 3 NO SP449 RD-Red RELAY 4 PWR SP450 PK-Pink RELAY 4 NO SP451 RD-Red RELAY 5 PWR SP452 PK-Pink RELAY 5 NO SP453 GN-Green SEAT AIR 1 SP454 GN-Green SEAT AIR 2 SP455 YW-Yellow DR SW TO AUX SP456 RD-Red SW BRKR PWR SP457 RD-Red LIVE BRKR PWR SP458 RD-Red IGN PWR SP459 RD-Red MAST PWR SP460 RD-Red IGN PWR SP461 RD-Red CO ALARM PWR SP462 RD-Red LP ALARM PWR SP463 RD-Red MONITOR PWR SP464 PK-Pink HEATED MIRROR SP465 RD-Red HTD MIRROR PWR SP466 RD-Red POWER MIRROR SP467 GY-Gray DOOR WARNING SP468 PK-Pink RT LOW WARN LT SP469 PK-Pink LF LOW WARN LT SP470 PK-Pink DIFF LOCK LT


CIRCUIT NUMBERS


SP471 GY-Gray RACOR ALARM SP472 RD-Red CAB FEED POS SP473 PK-Pink FUEL HEAT SW SP474 RD-Red START SOL #2 SP475 PK-Pink FRT STROBE RLY SP476 PK-Pink SIDE STROBE RY SP477 PK-Pink FRT STROBE SW SP478 PK-Pink SIDE STROBE SW SP479 RD-Red GROUND LT PWR SP480 PK-Pink ENG SD SIG POS SP481 GY-Gray ENG SD SIG NEG SP482 PK-Pink THRTL COM POS SP483 GY-Gray THRTL COM NEG SP484 RD-Red ALTERNATOR OUT SP485 RD-Red BAT POS TO STR SP486 RD-Red PTO POWER SP487 PK-Pink LEFT SCENE LT SP488 PK-Pink RIGHT SCENE LT SP489 PK-Pink CAB TILT SOL. TO ALARM SP490 RD-Red FLOOD LT POWER SP491 PK-Pink RT FLOOD LIGHT SP492 PK-Pink LT FLOOD LIGHT SP493 RD-Red OPTICOM POWER SP494 RD-Red OPTICOM SWITCH SP495 PK-Pink PTO CLUTCH SW SP496 GY-Gray PTO IND LIGHT SP497 PK-Pink RELAY TO A/C CONDNSR SP498 RD-Red BREAKER TO A/C COND RY SP499 GY-Gray A/C EVAP TO COND SP500 RD-Red LOAD MGR PWR SP501 PK-Pink LOAD MGR #1 SP502 PK-Pink LOAD MGR #2 SP503 PK-Pink LOAD MGR #3 SP504 PK-Pink LOAD MGR #4 SP505 PK-Pink LOAD MGR #5 SP506 PK-Pink LOAD MGR #6 SP507 PK-Pink LOAD MGR #7 SP508 PK-Pink LOAD MGR #8 SP509 PK-Pink LOAD MGR #9 SP510 PK-Pink LOAD MGR #10 SP511 PK-Pink LOAD MGR #11 SP512 PK-Pink LOAD MGR #12 SP513 RD-Red SCENE LT PWR SP514 BK-Black SWITCHED GND SP515 GN-Green ABS BLINK IN SP516 YW-Yellow ABS BLINK OUT


CIRCUIT NUMBERS


SP517 RD-Red IGN TO ABS ECU SP518 RD-Red RELAY TO WARN LT SP519 GY-Gray FUEL PRESS SNDR SP520 NSBU ACC FEED SP521 BE-Blue REV ACTIVE SP522 PARK ACTIVE SP523 GY-Gray Left Mirror Heat (-) SP524 GY-Gray Left Mirror Heat (+) SP525 GY-Gray Left Mirror Adj. SP526 GY-Gray Left Mirror Adj. SP527 GY-Gray Left Mirror Adj. SP528 RD-Red DATALINK PWR SP529 PK-Pink AMMETER POS SP530 GY-Gray AMMETER NEG SP531 RD-Red PWR VENT SW SP532 RD-Red PWR VENT PWR SP533 RD-Red PWR VENT SP534 PK-Pink SEC SIG STP LT RLY SP535 BK-Black PROP VALVE SP536 PK-Pink PROP VALVE SP537 PK-Pink COOLANT TEMP (+) SP538 BK-Black COOLANT TEMP (-) SP539 OE-Orange MC PWR CONTR SP540 PK-Pink TWP-31 INSTR DATA + SP541 GY-Gray TWP-31 INSTR DATA - SP542 PK-Pink GAUGE DATA SP543 RD-Red VDC PWR SP544 PK-Pink VDC IGN SP545 GY-Gray VDC ACT SP546 BN-Brown FT MRKR LT SP547 GY-Gray AIR FILTER SP548 GY-Gray CAB AJAR SP549 PK-Pink TV FUSE TO RLY SP550 PK-Pink TV PWR FROM RLY SP551 RD-Red BACK LT PWR SP552 BN-Brown BACK LT SP553 PK-Pink TAG LFT LGHT ACTIVE SP554 GY-Gray REVERSE OUTPUT SIG(GRD) SP555 PK-Pink CLN IGN FRM FUSE SP556 PK-Pink CUST IGN FRM FUSE SP557 RD-Red AUD ALRM POS SP558 PK-Pink AUX BRK SIG SP559 PK-Pink AUX BRK IND SP560 RD-Red CUST ACC FRM FUSE SP561 RD-Red LTBAR PWR 1 SP562 RD-Red LTBAR SYS 1


CIRCUIT NUMBERS


SP563 RD-Red LTBAR PWR 2 SP564 RD-Red LTBAR SYS 2 SP565 RD-Red LTBAR SW 1 SP566 RD-Red LTBAR SW 2 SP567 DKGN-Dark Green R TURN SIG FROM SW TO FR RLY SP568 YW-Yellow L TURN SIG FROM SW TO FR RLY SP569 DKGN-Dark Green R TURN FROM RLY TO LTS SP570 YW-Yellow L TURN FROM RLY TO LTS SP571 PK-Pink FAN ON/OFF SP572 PK-Pink FAN HIGH/LOW OFF SP573 TN-Tan FAN VARIABLE SP574 BK-Black FAN SIG RTN SP575 PE-Purple TWP-24 PRIVATE DATABUS (+) SP576 GN-Green TWP-24 PRIVATE DATABUS (-) SP577 RD-Red CNDSR PWR FRM SW TO FAN SP578 GY-Gray TRIP RESET SP579 GY-Gray ENGLISH/METRIC SP580 RD-Red MASTER SW SP581 RD-Red SMRT WHEEL/VIP B (+) SP582 RD-Red ROAD RELAY B (+) SP583 GY-Gray WASHER SIGNAL (-) SP584 GY-Gray WIPER SW LOW SP585 GY-Gray WIPER SW HIGH SP586 BK-Black BACK LT GND SP587 RD-Red CAB SPOT LT PWR SP588 PK-Pink RELAY 4 NC SP589 PK-Pink RELAY 5 NC SP590 RD-Red RELAY 6 PWR SP591 PK-Pink RELAY 6 NC SP592 PK-Pink RELAY 6 NO SP593 RD-Red RELAY 7 PWR SP594 PK-Pink RELAY 7 NC SP595 PK-Pink RELAY 7 NO SP596 RD-Red RELAY 8 PWR SP597 PK-Pink RELAY 8 NC SP598 PK-Pink RELAY 8 NO SP599 RD-Red RELAY 9 PWR SP600 PK-Pink RELAY 9 NC SP601 PK-Pink RELAY 9 NO SP602 RD-Red RELAY 10 PWR SP603 PK-Pink RELAY 10 NC SP604 PK-Pink RELAY 10 NO SP605 RD-Red RELAY 11 PWR SP606 PK-Pink RELAY 11 NC SP607 PK-Pink RELAY 11 NO SP608 RD-Red RELAY 12 PWR


CIRCUIT NUMBERS


SP609 PK-Pink RELAY 12 NC SP610 PK-Pink RELAY 12 NO SP611 YW-Yellow CUSTOMER 9 SP612 YW-Yellow CUSTOMER 10 SP613 YW-Yellow CUSTOMER 11 SP614 YW-Yellow CUSTOMER 12 SP615 WE-White TELMA LT 1 SP616 WE-White TELMA LT 2 SP617 WE-White TELMA LT 3 SP618 WE-White TELMA LT 4 SP619 WE-White TELMA RELAY 1 SP620 WE-White TELMA RELAY 2 SP621 WE-White TELMA RELAY 3 SP622 WE-White TELMA RELAY 4 SP623 WE-White TELMA THRTLE ACT 1 SP624 WE-White TELMA THRTLE ACT 1 SP625 RD-Red TELMA POWER SP626 WE-White TELMA BRAKE LT SP627 WE-White TELMA ABS SP628 WE-White TELMA STAGE 1 SP629 WE-White TELMA STAGE 2 SP630 WE-White TELMA STAGE 3 SP631 WE-White TELMA STAGE 4 SP632 RD-Red INSTRUMENT (B+) SP633 PE-Purple TIRE CHAIN SW TO SOL SP634 RD-Red LUG LOCK PWR SP635 RD-Red BATT TO IGN RLY SP636 PK-Pink IGN PWR TO FUSES SP637 RD-Red BATT TO IGN RLY SP638 PK-Pink IGN PWR TO FUSES SP639 RD-Red BATT TO IGN RLY SP640 PK-Pink IGN PWR TO FUSES SP641 RD-Red BATT TO IGN RLY SP642 PK-Pink IGN PWR TO FUSES SP643 RD-Red BATT TO IGN RLY SP644 PK-Pink IGN PWR TO FUSES SP645 RD-Red BATT TO ACC RLY SP646 PK-Pink ACC PWR TO FUSES SP647 RD-Red BATT TO ACC RLY SP648 PK-Pink ACC PWR TO FUSES SP649 RD-Red BATT TO ACC RLY SP650 PK-Pink ACC PWR TO FUSE SP651 BK-Black COMMON GND SP652 BK-Black COMMON GND SP653 BK-Black COMMON GND SP654 BK-Black CLEAN GND


CIRCUIT NUMBERS


SP655 BK-Black CLEAN GND SP656 RD-Red GPS BATT (+) SP657 RD-Red FUEL/WATER SEP (+) SP658 WE-White STATE OF ABS LT SP659 PK-Pink SUN VISOR IGN PWR SP660 BK-Black LVL JK GND SP661 PK-Pink NT VISION SW IGN SP662 GN-Green ADCAN SP663 SD-Shield Drain SHIELD SP664 BK-Black CAN L SP665 WE-White CAN H SP666 RD-Red SLU BATT (+) SP667 PK-Pink SLU WAKE-UP (EREV0) SP668 WE-White DIAG CN (EREV1) SP669 RD-Red MCU BATT (+) SP670 RD-Red NODE BATT (+) SP671 RD-Red NODE IGN (+) SP672 PK-Pink NODE IGN RLY CONTROL SP673 OE-Orange DIAG K LINE SP674 GY-Gray DIAG L LINE SP675 OE-Orange STP MTR BI-DIRECT SP676 YW-Yellow STP MTR BI-DIRECT SP677 RD-Red STEP LIGHT SP678 GY-Gray ACCESSORY SIG (-) SP679 GY-Gray IGNITION SIG (-) SP680 GY-Gray START SIG (-) SP681 GY-Gray BATT BOOST SP682 WE-White DOOR LOCK SP683 BE-Blue DOOR STP OVR RIDE SP684 RD-Red AIR HORN PWR SP685 PK-Pink AIR HORN SOL SW SP686 PK-Pink SIREN SW PWR SP687 OE-Orange ANALOG SIG SP688 RD-Red SENSOR PWR SP689 BK-Black SENSOR GND SP690 CR-Clear SHIELD CABLE MUX HIGH SP691 BK-Black SHIELD CABLE MUX LOW SP692 SD-Shield Drain SHIELD CABLE MUX SHIELD SP693 PK-Pink PARK BRAKE POS SP694 RD-Red FAN PWR FT SP695 RD-Red FAN PWR RR SP696 RD-Red LT BAR A SP697 RD-Red LT BAR B SP698 RD-Red LT BAR C SP699 RD-Red LT BAR D SP700 RD-Red HDLT SW PWR


CIRCUIT NUMBERS


SP701 OE-Orange EVAP THERM SP702 PK-Pink COND FAN CONTR SP703 DKGN-Dark Green RIGHT TURN ENABLE SP704 YW-Yellow LEFT TURN ENABLE SP705 RD-Red MAST PWR FUSE SP706 RD-Red MUX PWR SP707 PK-Pink PUMP W/ PARK SP708 BE-Blue NGI PWR +7.6V SP709 BE-Blue TRAILER BRAKE SP710 PE-Purple SEAT BELT IND SP711 PK-Pink ISS INDICATOR LT SP712 WE-White PSG INTRLK SP713 RD-Red STROBE POWER SP714 BE-Blue FRNT STROBE SW SP715 GN-Green SIDE STROBE SW SP716 PK-Pink CLEAN IGN PWR SP717 PK-Pink RADIO IGN SP718 PK-Pink A/C THERM TO PRS SW SP719 RD-Red COOLANT LVL PWR SP720 RD-Red LF VLV POS SP721 BK-Black LF VLV NEG SP722 RD-Red RF VLV POS SP723 BK-Black RF VLV NEG SP724 RD-Red LR VLV POS SP725 BK-Black LR VLV NEG SP726 RD-Red RR VLV POS SP727 BK-Black RR VLV NEG SP728 RD-Red TAG LR VLV POS SP729 BK-Black TAG LR VLV NEG SP730 RD-Red TAG RR VLV POS SP731 BK-Black TAG RR VLV NEG SP732 RD-Red TWT-11 FRT VERT SENS POS SP733 BK-Black TWT-11 FRT VERT SENS NEG SP734 TN-Tan TWT-11 FRT VERT SENS SIG SP735 RD-Red TWT-12 RR VERT SENS POS SP736 BK-Black TWT-12 RR VERT SENS NEG SP737 TN-Tan TWT-12 RR VERT SENS SIG SP738 RD-Red TWT-13 LATL SENS POS SP739 BK-Black TWT-13 LATL SENS NEG SP740 TN-Tan TWT-13 LATL SENS SIG SP741 OE-Orange FAULT IND SP742 BE-Blue HARD/SOFT IND

SP743 BE-Blue LEONI CABLE 2 WIRE ABS ATC VLV APLY

SP744 BN-Brown LEONI CABLE 2 WIRE ABS ATC VLV COM


CIRCUIT NUMBERS


SP745 PK-Pink SAR IGN POS SP746 GY-Gray INTER SW TO LT SP747 PK-Pink INTER BRKR TO SW SP748 PK-Pink INTER SW TO SOL SP749 PK-Pink DCDL SW TO SOL SP750 PK-Pink DCDL BRKR TO SW SP751 BE-Blue LP SIGNAL SP752 PE-Purple ZF EASY STRT SIG

SP753 BE-Blue LEONI CABLE 2 WIRE ZF EASY STRT SOL APLY

SP754 BN-Brown LEONI CABLE 2 WIRE ZF EASY STRT SOL COM

SP755 GN-Green ZF ZF EASY STRT BRK SIG SP756 RD-Red ZF 24V BATT POS SP757 PK-Pink ZF 24V IGN SP758 RD-Red ZF 12V BATT POS SP759 YW-Yellow ENGINE BRAKE 3 SP760 YW-Yellow SHUTDOWN DELAY SP761 PK-Pink PWR COL TILT U SP762 GY-Gray PWR COL TILT D SP763 PK-Pink PWR COL TELE F SP764 GY-Gray PWR COL TELE R SP765 BN-Brown MRKR LT SP766 BN-Brown TRLR MRKR LT SP767 RD-Red ADJ PEDAL PWR SP768 PK-Pink CONTROLLER IGN SP769 PK-Pink MEM CTRL IGN PWR SP770 TN-Tan MEM MAN HOME SP771 LTBE-Light Blue MEMORY SW 2 SP772 OE-Orange MEMORY SW 1 SP773 YW-Yellow MEMORY SET SP774 GY-Gray MEMORY SW COMMON SP775 BK-Black ENGINE LT SIG SP776 PK-Pink ENGINE LT SW PWR SP777 RD-Red MEMORY PWR 1 SP778 RD-Red MEMORY PWR 2 SP779 PK-Pink POTENTIOMETER POS SP780 BK-Black POTENTIOMETER NEG SP781 WE-White POTENTIOMETER SENS SP782 YW-Yellow SET RIDE HT SP783 PE-Purple RAISE RIDE HT SP784 GN-Green LOWER RIDE HT SP785 OE-Orange HADLEY LIGHT + SP786 WE-White HADLEY LIGHT - SP787 BK-Black SWITCH RETURN SP788 PK-Pink L WARN LT


CIRCUIT NUMBERS


SP789 PK-Pink R WARN LT SP790 RD-Red SEAT FRT UP INPUT SP791 BE-Blue SEAT FRT DN INPUT SP792 RD-Red SEAT REAR UP INPUT SP793 GN-Green SEAT REAR DN INPUT SP794 RD-Red SEAT BASE FWD INPUT SP795 WE-White SEAT BASE RWD INPUT SP796 RD-Red SEAT BACK FWD INPUT SP797 YW-Yellow SEAT BACK RWD INPUT SP798 WE-White SEAT FRT POT 5V SEN SP799 WE-White SEAT REAR POT 5V SEN SP800 WE-White SEAT BASE POT 5V SEN SP801 WE-White SEAT BACK POT 5V SEN SP802 WE-White THROT POT 5V SEN SP803 WE-White PWR COL TILT PT 5V SEN SP804 WE-White PWR COL TELE PT 5V SEN SP805 RD-Red MIRROR UP INPUT SP806 OE-Orange MIRROR DN INPUT SP807 WE-White MIR DRV PT 5V SEN UP/DN SP808 BN-Brown MIRROR LT INPUT SP809 TN-Tan MIRROR RT INPUT SP810 WE-White MIR DRV PT 5V SEN LFT/ RT SP811 GN-Green MIR PAS SIDE UP INPUT SP812 DKBE-Dark Blue MIR PAS SIDE DN INPUT SP813 WE-White MIR PAS PT 5V SEN UP/DN SP814 YW-Yellow MIR PASS SIDE LT INPUT SP815 OE-Orange MIRROR PAS SIDE RT INPUT SP816 WE-White MIR PASS PT 5V SEN LT/RT SP817 GY-Gray MIR SEL DRV / PAS SP818 RD-Red REFRIG 1 SP819 RD-Red REFRIG 2 SP820 RD-Red SEAT MTR FRONT UP SP821 BE-Blue SEAT MTR FRONT DN SP822 RD-Red SEAT MTR REAR UP SP823 GN-Green SEAT MTR REAR DN SP824 RD-Red SEAT MTR BASE FWD SP825 WE-White SEAT MTR BASE RWD SP826 RD-Red SEAT MTR BACK FWD SP827 YW-Yellow SEAT MTR BACK REAR SP828 RD-Red MIR MTR DRVS UP SP829 OE-Orange MIR MTR DRVS DN SP830 BN-Brown MIR MTR DRVS. LFT SP831 TN-Tan MIR MTR DRVS. RT SP832 DKGN-Dark Green MIR MTR PASS UP SP833 DKBE-Dark Blue MIR MTR PASS DN SP834 YW-Yellow MIR MTR PASS LFT


CIRCUIT NUMBERS


SP835 OE-Orange MIR MTR PASS RT SP836 RD-Red WINDOW PWR SP837 PK-Pink DRV MTR PWR SP838 WE-White DRV MTR RET SP839 PK-Pink DRV RR MTR PWR SP840 WE-White DRV RR MTR RET SP841 PK-Pink OFCR MTR PWR SP842 WE-White OFCR MTR RET SP843 PK-Pink OFCR RR MTR PWR SP844 WE-White OFCR RR MTR RET SP845 PK-Pink WINDOW MTR PWR SP846 WE-White WINDOW MTR RET SP847 RD-Red HADLEY IGN PWR SP848 RD-Red MEMORY PWR 3 SP849 RD-Red CNVX MIRROR UP INPUT SP850 OE-Orange CNVX MIRROR DN INPUT SP851 WE-White CNVX MIR DRV PT 5V SEN UP/DN SP852 BN-Brown CNVX MIRROR LF INPUT SP853 TN-Tan CNVX MIRROR RT INPUT SP854 WE-White CNVX MIR DRV PT 5V SEN LFT/RT SP855 GN-Green CNVX MIR PAS SIDE UP INPUT SP856 DKBE-Dark Blue CNVX MIR PAS SIDE DN INPUT SP857 WE-White CNVX MIR PAS PT 5V SEN UP/DN SP858 YW-Yellow CNVX MIR PASS SIDE LT INPUT SP859 OE-Orange CNVX MIR PAS SIDE RT INPUT SP860 WE-White CNVX MIR PASS PT 5V SEN LT/RT SP861 GY-Gray CNVX MIR SELECT DRV / PASS SP862 RD-Red CNVX MIR MTR DRVS UP SP863 OE-Orange CNVX MIR MTR DRVS DN SP864 BN-Brown CNVX MIR MTR DRVS LFT SP865 TN-Tan CNVX MIR MTR DRVS RT SP866 DKGN-Dark Green CNVX MIR MTR PASS UP SP867 DKBE-Dark Blue CNVX MIR MTR PASS DN SP868 YW-Yellow CNVX MIR MTR PASS LFT SP869 OE-Orange CNVX MIR MTR PASS RT SP870 RD-Red BKUP ALRM PWR SP871 OE-Orange BLKOUT LT PWR SP872 RD-Red BLKOUT SWD PWR SP873 GN-Green HDLP SW TO BO LT SP874 RD-Red RED BACKLIGHT SP875 YW-Yellow WIPER DELAY A SP876 OE-Orange WIPER DELAY B SP877 GN-Green WIPER DELAY C SP878 PK-Pink NEUTRAL SIG POS SP879 GY-Gray NEUTRAL SIG NEG SP880 WE-White NEUTRAL SIG POS / NEG


CIRCUIT NUMBERS


SP881 PK-Pink T-CASE AWD ENABLE SP882 TN-Tan ANT UP WARNING SP883 TN-Tan JACK DOWN WARNING SP884 PK-Pink CUSTOMER 1 SP885 RD-Red CUSTOMER 2 SP886 BE-Blue CUSTOMER 3 SP887 YW-Yellow CUSTOMER 4 SP888 OE-Orange CUSTOMER 5 SP889 GN-Green CUSTOMER 6 SP890 BN-Brown CUSTOMER 7 SP891 PE-Purple CUSTOMER 8 SP892 BK-Black CUSTOMER 9 SP893 WE-White CUSTOMER 10 SP894 TN-Tan CUSTOMER 11 SP895 LTBE-Light Blue CUSTOMER 12 SP896 DKBE-Dark Blue CUSTOMER 13 SP897 LTBE-Light Blue CUSTOMER 14 SP898 LTGN-Light Green CUSTOMER 15 SP899 DKGN-Dark Green CUSTOMER 16 SP900 PK-Pink BRAKE CNTRL SP901 WE-White BLKOUT STP LT SP902 PK-Pink T-CASE LO ENABLE SP903 GY-Gray T-CASE LO LT SP904 PK-Pink TRW IGN SP905 RD-Red TRW BATT SP906 PK-Pink DIFF LOCK ENABLE SP907 BE-Blue AWD CONTROL LOGIC SP908 GN-Green DIFF CONTROL LOGIC SP909 YW-Yellow T-CASE CONTROL LOGIC SP910 GY-Gray AWD LT SP911 PK-Pink CUSTOMER 17 SP912 RD-Red CUSTOMER 18 SP913 BE-Blue CUSTOMER 19 SP914 YW-Yellow CUSTOMER 20 SP915 GY-Gray SLS 5 VDC REG SP916 BN-Brown SLS RAISE / ARROW 1 GN LED SP917 PK-Pink SLS LOWER / ARROW 1 YW LED SP918 OE-Orange SLS RIDE HEIGHT / ARROW 2 GN LED SP919 DKGN-Dark Green SLS SUSP / ARROW 2 YW LED SP920 DKBE-Dark Blue SLS AIR PRES / SET LED SP921 PE-Purple SLS BANK SEL LOW / BANK SEL HIGH SP922 WE-White SLS BANK SEL HIGH / BANK SEL LOW SP923 TN-Tan SLS ENABLE SP924 RD-Red SLS SET SP925 YW-Yellow SLS STD RIDE SP926 LTGN-Light Green SLS LOWER


CIRCUIT NUMBERS


SP927 LTBE-Light Blue SLS RAISE SP928 BK-Black SLS TOUCH PAD GROUND SP929 RD-Red HDLP SW TO IR LT SP930 RD-Red IR LT PWR SP931 BE-Blue LT AND ALARM DIS SP932 WE-White SPD/NEU LOCK POS SP933 WE-White SPD/NEU LOCK NEG SP934 RD-Red DC CONVERTOR PWR (24V) SP935 PK-Pink CREW DOME LT PWR SW SP936 PK-Pink CREW DOME LT RD/WE SW SP937 WE-White WHITE DOME LT PWR SP938 RD-Red RED DOME LT PWR SP939 RD-Red DOOR SW PWR SP940 PK-Pink DOOR SW TO DOME LT RLY SP941 PK-Pink FAN HIGH SPEED SP942 OE-Orange FAN MED SPEED SP943 BE-Blue FAN LOW SPEED SP944 PK-Pink A/C RECIRC SIG SP945 PK-Pink A/C DEFROST SIG SP946 PK-Pink A/C HEAT VALVE SIG SP947 PK-Pink A/C FACE SIG SP948 RD-Red DC CONVERTOR PWR (12V) SP949 GY-Gray GAUGE ALARM DISABLE SP950 PE-Purple HDLP LOW BEAM SIG SP951 BE-Blue HDLP HIGH BEAM SIG SP952 GN-Green WINCH POWER IN SP953 WE-White WINCH COMMON SP954 BK-Black WINCH POWER OUT SP955 RD-Red SPOT LT CONTROL 1 SP956 WE-White SPOT LT CONTROL 2 SP957 BK-Black SPOT LT CONTROL 3 SP958 BN-Brown SPOT LT CONTROL 4 SP959 GN-Green SPOT LT CONTROL 5 SP960 YW-Yellow SPOT LT CONTROL 6 SP961 BE-Blue SPOT LT CONTROL 7 SP962 PE-Purple SPOT LT CONTROL 8 SP963 BE-Blue INVERTER ON-OFF SW SP964 BE-Blue ABS RSC VALUE APPLY SP965 BN-Brown ABS RSC VALUE COM SP966 YW-Yellow TRLR L STOP/TURN SP967 DKGN-Dark Green TRLR R STOP/TURN SP968 PK-Pink TIRE PRESSURE IGN SP969 PK-Pink COMPASS MODULE IGN SP970 PK-Pink JUNIOR MODULE IGN SP971 PK-Pink A/C CLUTCH CONTROL SP972 RD-Red TRLR BATT CHARGE


CIRCUIT NUMBERS


SP973 RD-Red HDLP HIGH BEAM / L FLASH SP974 RD-Red HDLP HIGH BEAM / R FLASH SP975 RD-Red PWR POINT LIVE SP976 RD-Red PWR POINT MASTER SP977 RD-Red REMOTE BATT DIS PWR SP978 PK-Pink REMOTE BATT DIS SIG SP979 LTGN-Light Green SPARTAN DATA BUS SP980 WE-White TWP-29 J1587 POS SP981 BE-Blue TWP-29 J1587 NEG SP982 RD-Red BATT POS SP983 RD-Red BATT POS SP984 RD-Red BATT POS SP985 RD-Red CLN BATT POS SP986 RD-Red CLN BATT POS SP987 RD-Red CLN BATT POS SP988 GY-Gray GND LT NEG SP989 GY-Gray SCNE LT NEG SP990 PK-Pink IGN SIG SP991 RD-Red PUMP POWER SP992 PK-Pink PUMP SWITCH SP993 BE-Blue PUMP MODE REQUESTED SP994 OE-Orange PUMP ENGAGED SP995 RD-Red OK TO PUMP SP996 PE-Purple THROTTLE READY SP997 OE-Orange TWT-02 LIN POWER SP998 WE-White TWT-02 LIN GROUND SP999 PE-Purple TWT-02 LIN COMM

SP1000 GY-Gray TWP-54 SRS WARN LT SP1001 OE-Orange ELECT PUMP SOL SP1002 WE-White SPARE 1 SP1003 BE-Blue SPARE 2 SP1004 GN-Green SPARE 3 SP1005 YW-Yellow SPARE 4 SP1006 PK-Pink SPARE 5 SP1007 BE-Blue DC CURRENT SEN SP1008 GY-Gray AUD ALARM NEG INPUT SP1009 GY-Gray AUD ALARM NEG OUTPUT SP1010 BK-Black MUX GND SP1011 DKGN-Dark Green MRKR - R TURN SIG SP1012 YW-Yellow MRKR - L TURN SIG SP1013 GY-Gray SEC BRK INPUT 1 SP1014 GY-Gray SEC BRK INPUT 2 SP1015 PK-Pink SEC BRK OUTPUT 1 SP1016 PK-Pink SEC BRK OUTPUT 2 SP1017 RD-Red STEERING COL PWR SP1018 TN-Tan TWP-34 ICSP PGD


CIRCUIT NUMBERS


SP1019 RD-Red TWP-34 ICSP PGC SP1020 BE-Blue ICSP PGM SP1021 OE-Orange ICSP RESET SP1022 PK-Pink ICSP 5V+ SP1023 PK-Pink PUMP ROAD MODE SP1024 DKBE-Dark Blue TWP-32 PYRO BELT (+)

SP1025 DKBE/WE-Dark

Blue/White TWP-32 PYRO BELT (-) SP1026 BN-Brown TWP-33 PYRO CURT (+)

SP1027 BN/WE-

Brown/White TWP-33 PYRO CURT (-) SP1028 RD-Red TRAILER ABS PWR SP1029 GN-Green TRAILER ABS LT SP1030 YW-Yellow SPARE 0 SP1031 YW-Yellow SPARE 1 SP1032 YW-Yellow SPARE 2 SP1033 YW-Yellow SPARE 3 SP1034 YW-Yellow SPARE 4 SP1035 YW-Yellow SPARE 5 SP1036 YW-Yellow SPARE 6 SP1037 YW-Yellow SPARE 7 SP1038 YW-Yellow SPARE 8 SP1039 YW-Yellow SPARE 9 SP1040 PE-Purple TC NEU CONTROL LOGIC SP1041 GY-Gray TCASE NEU LT SP1042 PK-Pink TCASE NEU ENABLE SP1043 GY-Gray CLEAN GND SW SP1044 PK-Pink PUMP SHIFT SW SP1045 RD-Red IR LT HI BM PWR SP1046 RD-Red IR LT LO BM PWR SP1047 WE-White ENGINE RUNNING SP1048 RD-Red EVAP POWER SP1049 RD-Red COND POWER SP1050 BE-Blue CREW OVERRIDE SW SP1051 PK-Pink SW IGN TO A/C SP1052 PK-Pink BO MRKR LT PWR SP1053 BN-Brown 3000 MRKR LTS FRNT SP1054 BN-Brown MRKR LTS REAR SP1055 BN-Brown SMRT WHL SWITCH SP1056 YW-Yellow SMRT WHL BANK SP1057 OE-Orange AMBNT LT SENSOR SP1058 GN-Green AUTO WIPER SENSOR SP1059 PE-Purple AUTO WIPER DISABLE SP1060 YW-Yellow TAG DMP SW SP1061 BE-Blue BK LT INC SP1062 OE-Orange BK LT DEC


CIRCUIT NUMBERS


SP1063 GY-Gray ICC BLINK SP1064 RD-Red HDLP L HI BEAM SP1065 RD-Red HDLP L LO BEAM SP1066 RD-Red HDLP R HI BEAM SP1067 RD-Red HDLP R LO BEAM SP1068 RD-Red FOG LT LEFT SP1069 RD-Red FOG LT RIGHT SP1070 WE-White TAG SW AUTO SP1071 YW-Yellow TAG SW MANUAL SP1072 WE-White 3000 TELMA THRTLE ACT 3 SP1073 WE-White TELMA THRTLE ACT 4 SP1074 BE-Blue VENT FAN SW FEED SP1075 BE-Blue VENT FAN SW RTN SP1076 YW-Yellow LEFT TURN TO GAUGE SP1077 DKGN-Dark Green RIGHT TURN TO GAUGE SP1078 RD-Red HIGH BEAM TO GAUGE SP1079 GY-Gray MRKR LMP SW SP1080 PE-Purple HDLP SW SP1081 RD-Red STOP LTS SP1082 DKGN-Dark Green TRLR R TURN SIG SP1083 YW-Yellow TRLR L TURN SIG SP1084 RD-Red TRIP COMPUTER PWR SP1085 RD-Red TRLR STOP LT SP1086 DKGN-Dark Green RIGHT TRN SIG FROM SW SP1087 YW-Yellow LEFT TRN SIG FROM SW SP1088 DKGN-Dark Green TRLR R STP/TRN OR TRN SP1089 YW-Yellow TRLR L STP/TRN OR TRN SP1090 DKGN-Dark Green INPUT R STP/TRN OR TRN SP1091 YW-Yellow INPUT L STP/TRN OR TRN SP1092 OE-Orange B/UP ALARM SP1093 PK-Pink HORN OUTPUT SP1094 OE-Orange SCM OUTPUT SPEED INDIC SP1095 PK-Pink MARKER SWITCH SIGNAL SP1096 GY-Gray STP SW TO SCM

SP1097 RD-Red WABCO CABLE 449 362 XXX 0 WABCO POWER

SP1098 BN-Brown WABCO CABLE 449 362 XXX 0 WABCO GROUND

SP1099 BE-Blue WABCO CABLE 449 362 XXX 0 WABCO CAN HIGH

SP1100 YW-Yellow WABCO CABLE 449 362 XXX 0 WABCO CAN LOW

SP1101 RD-Red WABCO CABLE 449 722 XXX 0 WABCO SENSOR POWER

SP1102 BN-Brown WABCO CABLE 449 722 XXX 0 WABCO SENSOR GROUND

SP1103 GN-Green WABCO CABLE 449 WABCO SENSOR SIGNAL


CIRCUIT NUMBERS


722 XXX 0 SP1104 GY-Gray TORQUE LIMIT SW SP1105 RD-Red SIREN BRAKE PWR SP1106 BE-Blue FRT AXLE BRK VLV APLY SP1107 BN-Brown FRT AXLE BRK VLV COM SP1108 RD-Red IR SPOTLIGHT PWR SP1109 OE-Orange ACD HARD/SOFT SELECT SP1110 RD-Red DOOR LOCK POWER B+ SP1111 BK-Black DOOR LOCK GROUND SP1112 RD-Red COMPARTMENT LOCK OUTPUT SP1113 GN-Green EMS COMPARTMENT LOCK OUTPUT SP1114 BE-Blue COMPARTMENT UNLOCK OUT SP1115 OE-Orange EMS COMPARTMENT UNLOCK OUT SP1116 GY-Gray DOME LIGHT INPUT SP1117 BE-Blue CAB UNLOCK OUTPUT SP1118 GN-Green CAB LOCK OUTPUT SP1119 GY-Gray COURTESY LIGHT OUTPUT SP1120 TN-Tan CAB UNLOCK INPUT SP1121 BN-Brown CAB LOCK INPUT SP1122 TN/WE-Tan/White COMPARTMENT UNLOCK INPUT

SP1123 BN/WE-

Brown/White COMPARTMENT LOCK INPUT SP1124 GN-Green APPARATUS LOCK OUTPUT SP1125 YW-Yellow APPARATUS UNLOCK OUTPUT SP1126 PK-Pink CRN LOCKOUT PWR SP1127 GN-Green STEER FLUID SENS OUT SP1128 WE-White BOOM UP SP1129 WE-White BOOM DOWN SP1130 WE-White SWING LEFT SP1131 WE-White SWING RIGHT SP1132 PK-Pink FT DIFF LOCK EN SP1133 PK-Pink RR DIFF LOCK EN SP1134 PK-Pink CRANE ON SIG SP1135 GY-Gray FT AXLE DIFF LT SP1136 GY-Gray RR AXLE DIFF LT SP1137 GY-Gray MID AXLE DIFF LT SP1138 RD-Red PERSONNEL HEATER SP1139 RD-Red RADIO/INTERCOM SP1140 RD-Red LITTER MOTOR SP1141 RD-Red GYROCAM SP1142 RD-Red DVE/CREW2/DAGR SP1143 RD-Red AN/GRC-213 SP1144 RD-Red HELIOS/LITTER ELEC SP1145 RD-Red CROWS SP1146 RD-Red FBCB2 SP1147 RD-Red FIRE SUPRESSION


CIRCUIT NUMBERS


SP1148 RD-Red NATO SLV PWR SP1149 RD-Red VEHICLE BATT PWR SP1150 RD-Red ALT REG STRTR V SP1151 RD-Red ALT REG MISS V SP1152 PK-Pink LT FUEL PUMP SP1153 PK-Pink RT FUEL PUMP SP1154 PK-Pink FUEL SENDER PWR SP1155 PK-Pink AWD/DIFF PWR SP1156 PK-Pink TCASE/DIFF LT PWR SP1157 PK-Pink LOUDSPEAKER SP1158 PK-Pink CREW2 SP1159 PK-Pink COM POST 1 SP1160 PK-Pink COM POST 2 SP1161 PK-Pink EPLRS SP1162 BK-Black FUEL SNDR RTN SP1163 RD-Red A/C WATER PUMP SP1164 YW-Yellow PROGRAM 1 SP1165 YW-Yellow PROGRAM 2 SP1187 YW-Yellow J1939-15 CABLE J1939-15 POS SP1188 DKGN-Dark Green J1939-15 CABLE J1939-15 NEG SP1189 RD-Red STRTR BATT PWR SP1190 PE-Purple REV BATT V PROTECT SP1191 PK-Pink STRTR IGN PWR SP1192 RD-Red AUX TOW PWR SP1193 YW-Yellow NVD COMPAT BKLT SP1194 GN-Green TOW MODE INTERLOCK SP1195 RD-Red LRAS3/TOW-ITAS SP1196 BE-Blue 4x4 HIGH SP1197 WE-White 4X4 LOW SP1198 OE-Orange 4X4 VALVE SP1199 BN-Brown 2 SPD REAR AXLE INPUT SP1200 TN-Tan 4X4 LT SP1201 BN-Brown 2X4 LT SP1202 YW-Yellow 4X4 ENGAGE SP1203 WE-White F DIFF CONTROL LOGIC SP1204 GN-Green R DIFF CONTROL LOGIC SP1205 PK-Pink AWD SEL LT SP1206 PK-Pink R DIFF SEL LT SP1207 PK-Pink F DIFF SEL LT SP1208 PK-Pink TC LO SEL LT SP1209 PK-Pink TC NEU SEL LT SP1210 RD-Red TILT PUMP POWER SP1211 GN-Green WINSHIELD WASHER SENSOR SP1212 GN-Green POWER STEERING SENSOR SP1213 PK-Pink AIR HORN SWITCH SP1214 BE-Blue CAB TILT UP


CIRCUIT NUMBERS


SP1215 RD-Red CAB TILT DOWN SP1216 RD-Red FRONT DOME LT SP1217 RD-Red REAR DOME LT SP1218 RD-Red CLEAR WARNING LT SP1219 PK-Pink SIREN BRAKE SP1220 PK-Pink MASTER SW SIG SP1221 GN-Green TWP-39 400A ALT REG A SP1222 WE-White TWP-39 400A ALT REG B SP1223 BE-Blue 400A ALT REG C SP1224 GN-Green CRUISE SET SP1225 YW-Yellow CRUISE RESUME SP1226 BN-Brown CRUISE ON SP1227 GY-Gray SIREN SWITCH SP1228 RD-Red SLAVE SW PWR SP1229 PK-Pink SLAVE SW SIG SP1230 RD-Red BUS SW PWR SP1231 PK-Pink BUS SW SIG SP1232 RD-Red STRTR BATT PWR SP1233 RD-Red VHCL BATT PWR SP1234 RD-Red SLAVE PWR SP1235 PK-Pink STRT DIS SOL TRIG SP1236 PK-Pink VEH DIS SOL TRIG SP1237 PK-Pink SLV DIS SOL TRIG SP1238 PK-Pink BUS CON SOL TRIG SP1239 RD-Red BATT SWAP PWR SP1240 GY-Gray BATT SWAP COIL SIG SP1241 PK-Pink PTO REQUESTED SP1242 PK-Pink PTO ENGAGED SP1243 PK-Pink SERV BRK STATUS SP1244 PK-Pink NEU ACTIVE SP1245 PK-Pink OIL PRESS OK SP1246 PK-Pink LOW SPEED SP1247 PK-Pink STARTER INTERLOCK SP1248 PK-Pink ENG STOP REQ SP1249 PK-Pink STARTER REQUEST SP1250 PK-Pink KNEEL INTERLOCK SP1251 PK-Pink START REQUEST SP1252 RD-Red T-CASE HI ENABLE SP1253 TN-Tan STR WHL EFFORT CNTRL SP1254 BE-Blue AMMETER 1 SIG SP1255 YW-Yellow AMMETER 2 SIG SP1256 OE-Orange TWP-41 BATT TEMP SENSE SIG SP1257 BE-Blue TWP-41 BATT TEMP SENSE RTN SP1258 PK-Pink LFT FRT SCN LT PWR SP1259 BK-Black LFT FRT SCN LT RTN SP1260 PK-Pink FRT SCN LT PWR


CIRCUIT NUMBERS


SP1261 BK-Black FRT SCN LT RTN SP1262 PK-Pink RGT FRT SCN LT PWR SP1263 BK-Black RGT FRT SCN LT RTN SP1264 PK-Pink LFT REAR SCN LT PWR SP1265 BK-Black LFT REAR SCN LT RTN SP1266 PK-Pink REAR SCN LT PWR SP1267 BK-Black REAR SCN LT RTN SP1268 PK-Pink RGT REAR SCN LT PWR SP1269 BK-Black RGT REAR SCN LT RTN SP1270 PE-Purple FLSHR RESISTOR SP1271 RD-Red 24V METER

SP1272 GN/YW-

Green/Yellow ABS 2 VLV COM L RR AXL SP1273 BN-Brown ABS 2 VLV I/L L RR AXL SP1274 BE-Blue ABS 2 VLV O/L L RR AXL

SP1275 GN/YW-

Green/Yellow ABS 2 VLV COM R RR AXL SP1276 BN-Brown ABS 2 VLV I/L R RR AXL SP1277 BE-Blue ABS 2 VLV O/L R RR AXL SP1278 YW-Yellow CAB LOWER SP1279 YW-Yellow CAB LOWER VALVE SP1280 BE-Blue CAB TILT LIMITED SW SP1281 PK-Pink 4X4 SW PWR SP1282 RD-Red MAST CUST BATT SP1283 GY-Gray SENSOR RETURN SP1284 PE-Purple COMM ERROR SP1285 PK-Pink 4X4 LOW LIGHT SP1286 PK-Pink 4X2 VALVE SP1287 OE-Orange SEAT BELT SW A SP1288 PE-Purple SEAT OPTION SW A SP1289 OE-Orange SEAT BELT SW B SP1290 PE-Purple SEAT OPTION SW B SP1291 OE-Orange SEAT BELT SW C SP1292 PE-Purple SEAT OPTION SW C SP1293 OE-Orange SEAT BELT SW D SP1294 PE-Purple SEAT OPTION SW D SP1295 OE-Orange SEAT BELT SW E SP1296 PE-Purple SEAT OPTION SW E SP1297 OE-Orange SEAT BELT SW F SP1298 PE-Purple SEAT OPTION SW F SP1299 OE-Orange SEAT BELT SW G SP1300 PE-Purple SEAT OPTION SW G SP1301 OE-Orange SEAT BELT SW H SP1302 PE-Purple SEAT OPTION SW H SP1303 OE-Orange SEAT BELT SW J SP1304 PE-Purple SEAT OPTION SW J


CIRCUIT NUMBERS


SP1305 OE-Orange SEAT BELT SW K SP1306 PE-Purple SEAT OPTION SW K SP1307 PK-Pink KNEELING SW PWR SP1308 PK-Pink KNEELING IND LT SP1309 PK-Pink KNEELING ACTIVATION SP1310 PK-Pink KNEELING AIR SOL SP1311 RD-Red SBW BATT PWR 1 SP1312 RD-Red SBW BATT PWR 2 SP1313 GN-Green SBW MOTOR 1A SP1314 YW-Yellow SBW MOTOR 1B SP1315 BE-Blue SBW MOTOR 2A SP1316 OE-Orange SBW MOTOR 2B SP1317 PK-Pink TWT-20 SBW POS SENS PWR 1A SP1318 BE-Blue TWT-20 SBW POS SENS SIG 1B SP1319 GY-Gray TWT-20 SBW POS SENS GND 1C SP1320 PK-Pink TWT-21 SBW POS SENS PWR 2A SP1321 OE-Orange TWT-21 SBW POS SENS SIG 2B SP1322 GY-Gray TWT-21 SBW POS SENS GND 2C SP1323 RD-Red VDR POWER SP1324 PK-Pink BED LIGHT PWR SP1325 YW-Yellow 12V L STP/TRN SP1326 GN-Green 12V R STP/TRN SP1327 PK-Pink 12V AUX PWR SP1328 RD-Red 12V STOP LT

SP1329 RD-Red

120 ohm Impedance (120 ohm , 0.8m, 19 Strand) 120 OHM JUMP WIRE

SP1330 GY-Gray AIR DUMP ENGAGED SP1331 PK-Pink TILT ENABLE SOL SP1332 PK-Pink CAB TILT MOTOR SOL SP1333 PK-Pink CAB TILT DN SP1334 PK-Pink CAB LOCKED DN SP1335 GY-Gray CAB TILT LIMIT SW SP1336 OE-Orange KNEEL ON SP1337 DKBE-Dark Blue KNEEL OFF SP1338 PE-Purple KNEEL DEACTIVATION SP1339 PK-Pink KNEEL OFF SW PWR SP1340 PK-Pink FRONT BMPR WARN LT SP1341 PK-Pink SIDE BMPR WARN LT SP1342 PK-Pink SIREN ENABLE SP1343 CPR-Copper SPEAKER PWR 1 SP1344 CR-Clear SPEAKER GND 1 SP1345 CPR-Copper SPEAKER PWR 2 SP1346 CR-Clear SPEAKER GND 2 SP1347 PK-Pink CAB WARN LT SP1348 PK-Pink PTO RELAY


CIRCUIT NUMBERS


SP1349 RD-Red IR REMOTE POS SP1350 BK-Black IR REMOTE NEG SP1351 GY-Gray METZ SPARE 1 SP1352 YW-Yellow RKR SW LT SP1353 GY-Gray ENG RPM SET SPD A SP1354 GY-Gray ENG RPM SET SPD B SP1355 RD-Red TWP-43 CAMERA POWER SP1356 BK-Black TWP-43 CAMERA RTN SP1357 BE-Blue CAM CTL BIT 0 SP1358 GN-Green CAM CTL BIT 1 SP1359 OE-Orange CAM CTL BIT 2 SP1360 YW-Yellow CAM CTL BIT 3 SP1361 BN-Brown CAM CTL BIT 4 SP1362 PE-Purple CAM CTL BIT 5 SP1363 WE-White CAM CTL SPARE SP1364 BK-Black CAM CTL RTN SP1365 RD-Red TWP-44 DEBRIS SHLD PWR SP1366 BK-Black TWP-44 DEBRIS SHLD GND SP1367 BK-Black RG-179 CABLE CAM VID SIGNAL SP1368 YW-Yellow J1939-11 CABLE ARV CAN BUS + SP1369 DKGN-Dark Green J1939-11 CABLE ARV CAN BUS - SP1370 ----- J1939-11 CABLE ARV CAN BUS SHIELD SP1371 RD-Red TETHER PWR SP1372 BK-Black TETHER RTN SP1373 YW-Yellow TWP-45 TETHER DATA + SP1374 DKGN-Dark Green TWP-45 TETHER DATA - SP1375 OE-Orange SEAT BELT SW 11 SP1376 PE-Purple SEAT OPTION SW 11 SP1377 OE-Orange SEAT BELT SW 12 SP1378 PE-Purple SEAT OPTION SW 12 SP1379 GY-Gray GEN SIG NEG SP1380 RD-Red GEN SIG POS SP1381 GY-Gray TIRE CHAINS ENGAGED SP1382 YW-Yellow J1939-15 CABLE J1939-15 POS SP1383 DKGN-Dark Green J1939-15 CABLE J1939-15 NEG SP1384 BE-Blue FRONT AXLE ENGAGE SP1385 YW-Yellow FRONT AXLE ENGAGE LT SP1386 GN-Green INTER AXLE LOCK SP1387 TN-Tan INTER AXLE LOCK LT SP1388 OE-Orange ROAD MODE SP1389 PE-Purple ROAD MODE LT SP1390 WE-White PTO MODE SP1391 BN-Brown PTO MODE LT SP1392 BE-Blue COAX SHLD SP1393 WE-White COAX SIGNAL SP1394 PE-Purple RTRDR DISABLE FROM ABS


CIRCUIT NUMBERS


SP1395 TN-Tan THROTTLE POSITION SP1396 PK-Pink THROTTLE 12V SP1397 GY-Gray THROTTLE GND SP1398 GN-Green T-CASE TEMP SW SP1399 BE-Blue T-CASE LOW PRESS SW

SP1400 GN/YW-

Green/Yellow TURN SIGNAL SP1401 BE-Blue COOL HTR DIAG SP1402 BK-Black COOL HTR GND SP1403 YW-Yellow COOL HTR SWITCHED PWR SP1404 RD-Red COOL HTR PWR SP1405 GY-Gray REAR STEER FAULT SP1406 GY-Gray REAR STEER LOCK SP1407 OE-Orange REAR STEER PWR SP1408 OE-Orange REAR STEER RTN SP1409 PK-Pink UNLOAD COIL PWR SP1410 GY-Gray UNLOAD COIL RTN SP1411 GN-Green METZ PTO SW REQ SP1412 DKGN-Dark Green METZ PTO SW REQ SIG SP1413 OE-Orange SLF RECOVERY SW SP1414 BK-Black T-CASE GND SP1415 PK-Pink INT DIFF LOGIC SP1416 OE-Orange INT DIFF ENABLE SP1417 BK-Black COMP DRIVE SP1418 RD-Red REAR AIR SP1419 PK-Pink INT AXLE SEL LT SP1420 GY-Gray INT AXLE DIFF LT SP1421 RD-Red IGNITION SW SP1422 BK-Black LOW PRESSURE OUT SP1423 OE-Orange LOW PRESSURE IN SP1424 PK-Pink TWP-30 DATA LINK POS SP1425 GY-Gray TWP-30 DATA LINK NEG SP1426 RD-Red HYD COOL FAN PWR SP1427 PK-Pink HYD COOL FAN IGN SP1428 CPR-Copper SPEAKER PWR 3 SP1429 CR-Clear SPEAKER GND3 SP1430 CPR-Copper SPEAKER PWR 4 SP1431 CR-Clear SPEAKER GND 4 SP1432 OE-Orange RADIO BACKLIGHTING SP1433 PK-Pink SEAT HEAT 1 SP1434 PK-Pink SEAT HEAT 2 SP1435 RD-Red IGN ACC PWR SP1436 PK-Pink POS DISABLE INPUT SP1437 GY-Gray NEG DISABLE INPUT SP1438 GN-Green NIGHT LIGHT SP1439 BK-Black COMP DRIVE ENGAGED


CIRCUIT NUMBERS


SP1440 OE-Orange COMP TEMP SW SP1441 GN-Green COMP DRIVE DISENGAGED SP1442 OE-Orange COMP DRIVE ENGAGED SP1443 RD-Red LCD CONTROLLER SP1444 RD-Red EVAP CONTROL PWR SP1445 WE-White HIGH PRESS FEED BACK SP1446 WE-White LOW PRESS FEED/CLUTCH SP1447 WE-White TWP-47 OUTSIDE SENDOR POS SP1448 BK-Black TWP-47 OUTSIDE SENDOR NEG SP1449 WE-White CLUTCH OUTPUT SIG SP1450 GN-Green TWP-48 DATA LINK POS SP1451 WE-White TWP-48 DATA LINK NEG SP1452 BE-Blue A/C CLUTCH SIG SP1453 RD-Red EVAP FAN MOTOR PWR SP1454 WE-White LOW PRESS FEED/CLUTCH SP1455 WE-White TWP-49 LF SPEAKER POS

SP1456 WE/BK-

WHITE/BLACK TWP-49 LF SPEAKER NEG SP1457 GY-Gray TWP-50 RF SPEAKER POS

SP1458 GY/BK-

GREY/BLACK TWP-50 RF SPEAKER NEG SP1459 GN-Green TWP-51 LR SPEAKER POS

SP1460 GN/BK-

GREEN/BLACK TWP-51 LR SPEAKER NEG SP1461 PE-Purple TWP-52 RR SPEAKER POS

SP1462 PE/BK-

PURPLE/BLACK TWP-52 RR SPEAKER NEG SP1463 PK-Pink FRT WARN LT SP1464 PK-Pink SD WARN LT SP1465 PK-Pink FRT CLR WARN LT SP1466 PK-Pink SD CLR WARN LT SP1467 GY-Gray FUEL HT SW NEG SP1468 BN-Brown TWP-58 MID FWD BELT (-) SP1469 BN-Brown TWP-58 MID FWD BELT (+) SP1470 BN-Brown TWP-59 DRVR/OFCR RR FWD BELT (-) SP1471 BN-Brown TWP-59 DRVR/OFCR RR FWD BELT (+) SP1472 DKBE-Dark Blue TWP-60 DRVR/OFCR RWD CRTN (-) SP1473 DKBE-Dark Blue TWP-60 DRVR/OFCR RR FWD CTRN (+) SP1474 BN-Brown TWP-61 MID RR BELT (-) SP1475 BN-Brown TWP-61 MID RR BELT (+) SP1476 BN-Brown TWP-62 DRVR/OFCR RR BELT (-) SP1477 BN-Brown TWP-62 DRVR/OFCR RR BELT (+) SP1478 DKBE-Dark Blue TWP-63 DRVR/OFCR RR CTRN (-) SP1479 DKBE-Dark Blue TWP-63 DRVR/OFCR RR CRTN (+) SP1480 DKGN-Dark Green TWP-64 DRVR/OFCR FT BELT (-) SP1481 DKGN-Dark Green TWP-64 DRVR/OFCR FT BELT (+) SP1482 DKBE-Dark Blue TWP-65 DRVR/OFCR FT CTRN (-)


CIRCUIT NUMBERS


SP1483 DKBE-Dark Blue TWP-65 DRVR/OFCR FT CTRN (+) SP1484 TN-Tan TWP-54 SRS DRAIN WIRE SP1485 BK-Black TWP-56 SRS WARN LT GND SP1486 RD-Red TWP-55 SRS IGN PWR SUP IN SP1487 BK-Black TWP-55 SRS CLEAN GND IN SP1488 RD-Red TWP-56 SRS IGN PWR SUP OUT SP1489 BK-Black SRS CLEAN GND OUT SP1490 BE-Blue TWP-57 SRS COMM (+) SP1491 YW-Yellow TWP-57 SRS COM (-) SP1492 BK-Black LF DOOR SW GND SP1493 BK-Black LR DOOR SW GND SP1494 BK-Black LMID CAB COMPART SW GND SP1495 BK-Black LR CAB COMPART SW GND SP1496 BK-Black RF DOOR SW GND SP1497 BK-Black RR DOOR SW GND SP1498 BK-Black RMID CAB COMPART SW GND SP1499 BK-Black RR CAB COMPART SW GND SP1500 BN-Brown WINDOW UP SP1501 WE-White WINDOW DWN WT101 BE-Blue N SOL, LOW WT102 OE-Orange SOL SPLY A,D,J WT103 GN-Green C SOL LOW WT104 WE-White G SOL LOW WT105 GN-Green TRAN OVRTP NEG WT106 PK-Pink TRANS TO ECU WT107 GN-Green SOL SUPPLY F WT110 WE-White F SOL, LOW WT111 GN-Green J SOL, LOW WT112 TN-Tan ENG OVRSPD RLY WT113 WE-White REV IND RLY WT114 WE-White RNG IND RLY WT115 GN-Green CHK TRANS LMP WT116 YW-Yellow RTRDR SOL SPLY WT117 WE-White GEN PUR IN 8 WT118 WE-White AUTO NEUTRAL WT119 YW-Yellow EXH BRK INPUT WT120 WE-White A SOL, LOW WT121 TN-Tan SOL SPLY B,E WT123 TN-Tan NEU SFTY POS WT124 PK-Pink ECM TO SHFTR WT125 WE-White GEN PUR OUT 4 WT126 YW-Yellow GEN PUR IN 9 WT127 WE-White H SOL, LOW WT128 OE-Orange B SOL, LOW WT129 TN-Tan E SOL, LOW WT130 YW-Yellow SOL SPLY C, G


CIRCUIT NUMBERS


WT131 BE-Blue D SOL, LOW WT132 OE-Orange EXH BRK RLY WT135 GN-Green ANALOG GND WT136 PK-Pink ECU POWER WT137 OE-Orange SERV BRK STAT WT138 OE-Orange RTRDR TMP SENS WT139 YW-Yellow TWP-11 OTPT SPD SENS WT140 BE-Blue TWP-12 TURB SPD LO WT141 TN-Tan TWP-13 ENG SPD SEN,HI WT142 WE-White SERIAL COM POS WT143 GY-Gray ECU GROUND WT144 GY-Gray CHASSIS GND WT146 YW-Yellow IGN SW WT147 TN-Tan SMP TMP SEN IN WT148 GN-Green TWP-11 OTPT SPD SENS WT149 OE-Orange TWP-12 TURB SPD HI WT150 OE-Orange TWP-13 ENG SPD SEN LO WT151 BE-Blue J1587 POS WT153 YW-Yellow AUTO NEUT INPUT WT154 WE-White ABS INPUT NEG WT155 GN-Green NEU RNG INH SW WT156 BE-Blue THRTL POS SENS WT157 TN-Tan SPEEDO SIG POS WT158 GY-Gray LIGHT SWITCH WT159 TN-Tan COMMUNICATION WT160 PK-Pink REMT SHFTR POS WT161 YW-Yellow SIG GND WT162 WE-White C-3 PRES SW IN WT163 BE-Blue RTRDR SW WT164 YW-Yellow RTRDR MOD REQ WT165 BE-Blue OIL LVL SENS WT166 TN-Tan GEN PUR OUT 7 WT167 WE-White GEN PUR OUT 8 WT168 GY-Gray REMT SHFTR NEG WT169 BE-Blue ENGINE BRAKE WT170 OE-Orange SHFT SEL BIT 1 WT171 GN-Green SHFT SEL BIT 2 WT172 BE-Blue SHFT SEL BIT 4 WT173 YW-Yellow SHFT SEL BIT 8 WT174 TN-Tan SHFT SEL PAR WT175 GN-Green SHF SEL MD IN WT176 OE-Orange GENERL OUT NEG WT177 TN-Tan GEN PUR OUT 10 WT178 OE-Orange GEN PUR IN 11 WT179 BE-Blue ENG H2O TEMP WT180 BE-Blue SHIFT SEL DISP


CIRCUIT NUMBERS


WT186 WE-White DIMMER A WT187 YW-Yellow DIMMER B WT188 GY-Gray DIMMER GND WT190 OE-Orange SEC SHFT BIT 1 WT191 GN-Green SEC SHFT BIT 2 WT192 BE-Blue SEC SHFT BIT 4 WT193 YW-Yellow SEC SHFT BIT 8 WT194 TN-Tan SEC SHFT PAR WT195 YW-Yellow TRANS ID

DRAWN BY

ENGINEER

CHECKED BY

REVISIONS E.C.R. DATE BY CHECKEDBY

APPROVEDBY

DATE

DATE

DATE

A

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE

E.C.R. DATE BY CHECKEDBY

APPROVEDBY

Spartan Chassis, Inc.

DWG. NUMBER

TITLE

1 OF 1

SHEET FORMAT REV: BDATE: 05/19/2010

CAGE CODE

DATE

2009-10 ENTEGRA COACH MMGT MODULAR LAYOUT

FRONT LEFT FRONT RIGHTABS VALVEABS VALVE

CUMMINS RUN/START3093-GG5

ITEM: 1

23-WAYDEUTSCH

3086-GG5CAB HARNESS

14-WAY

ITEM: 8

FCI

BACKBONE HARNESS

2666-GG5REAR RIGHTWABCO MODULAR ABS MODULE, REAR AXLEABS VALVE

DEUTSCH (BLACK)12-WAY

ITEM: 5

ITEM: 6

12-WAYDEUTSCH (GREEN)

ABS CONNECTOR

ABS CONNECTOR

WABCO MODULAR ABS MODULE, FRONT WHEELS

RUN INTERCONNECT

23-WAY

ITEM: 2

DEUTSCH

2665-GG5

FRONT PDC ASSY2969-GG5-001

MODULEABS

DEUTSCH12-WAY

ABS CONNECTORITEM: 85

ITEM: 97ENGINE BACKBONE INTERFACE

14-WAYFCI (BLACK)

CHASSIS INTERFACEITEM: 97

3064-GG5

ENGINE ECM2961-GG5-003

3060-GG5MAIN CHASSIS

14-WAY

FRT HARNESS INTERFACE AFCI

ITEM: 8

ITEM: 53 REAR HARNESS INTERFACE

2888-GG5REAR CHASSIS

CHASSIS INTERFACE A ITEM: 53

REAR CHASSIS DROPS

PDC ASSEMBLY

14-WAYFCI (LT GRAY)

14-WAYFCI APEX (LT GY)

ITEM: 13 J4 PDC INTERCONNECT

23-WAYDEUTSCH

ITEM:


ITEM:

BUSSMANNTCM INTERFACE

REAR LIGHTING INTERFACEFCI APEX (LT GN)

10-WAY

ITEM: 96

10-WAY

ITEM: 96

ABS HARNESS, TAG AXLE2664-GG5

ABS CONNECTORDEUTSCH (BROWN)

ITEM: 5

12-WAY

ABS VALVERIGHT TAGABS VALVE

LEFT TAG

16-WAYDEUTSCH

ITEM: 17FRT CHASSIS INTERFACE

10-WAYFCI

CHASSIS INTERFACE

FRT HARNESS INTERFACE A

CAB INTERFACE

CAB INTERFACE

24-WAY

ITEM: 16

AMPJ1 PDC INTERCONNECT


14-WAYAMP

16-WAYDEUTSCH

24-WAYDEUTSCH

14-WAY

REAR LEFTABS VALVE

FCI APEX (LT GN)REAR LIGHTING INTERFACE

FCI (BLACK)

ITEM: 98ENGINE BACKBONE INTERFACE

14-WAYFCI (NAUTRAL)

CHASSIS INTERFACEITEM: 98

14-WAYFCI (NAUTRAL)

FRT HARNESS INTERFACE DITEM: 9

FCI14-WAY

FRONT CHASSIS3070-GG5 3326-GG5

WIPER RELAY

ITEM: 17FRT CHASSIS INTERFACE

10-WAYFCI

OUTPUT FROM CHASSIS INTERFACEITEM: 2

FCI14-WAY 14-WAY

ITEM: 1

FCIINPUT FROM CHASSI INTERFACE

14-WAY

ITEM: 9

FCIFRT HARNESS INTERFACE D

ATCDROP

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

ABS ECU

ABSCONNECTOR

2666-GG5

LEFT REAR

(GN/YW-16GA) SP259

(BN-16GA) SP260

(BE-16GA) SP261

(BN-16GA) SP257

(BE-16GA) SP258

ABS VALVERIGHT REAR

ABS VALVE

2

1

3

(BK-18GA) SP253

(BN-18GA) SP254

(BK-18GA) SP255

(GN/YW-16GA) SP256

SENSORWHEEL SPEEDB

A

WHEEL SPEEDSENSOR

A

11

3

4

1

12

8

SP257 (BN-16GA)

SP261 (BE-16GA)

SP260 (BN-16GA)

SP258 (BE-16GA)

SP259 (GN/YW-16GA)

SP253 (BK-18GA)

SP256 (GN/YW-16GA)

SP255 (BK-18GA)

SP254 (BN-18GA)

7

10

9

B(BN-18GA) SP252

SP252 (BN-18GA)2

ABS HARN. (REAR)

ABS 2 SENS L2

ABS 2 SENS L1

ABS 2 VLV O/L L

ABS 2 VLV I/L L

ABS 2 VLV COM L

ABS 2 VLV O/L R

ABS 2 VLV I/L R

ABS 2 VLV COM R

ABS 2 SENS R2

ABS 2 SENS R1

1

2

3

4

ABS 2 SENS L2

ABS 2 SENS L1

ABS 2 VLV O/L L

ABS 2 VLV I/L L

ABS 2 VLV COM L

ABS 2 VLV O/L R

ABS 2 VLV I/L R

ABS 2 VLV COM R

ABS 2 SENS R2

ABS 2 SENS R1

6

1

98

MAIN CHASSIS3060-GG5

GN

1

2

3

3064-GG5BACKBONE ENGINE

16

3086-GG5CAB HARNESS

(BK-18GA) SP240

(BN-18GA) SP241

(BE-16GA) SP246

(BN-16GA) SP245

(GN/YW-16GA) SP244

(GN/YW-16GA) SP247

(BN-16GA) SP248

(BE-16GA) SP249

SP299 (BK-18GA)

SP248 (BN-16GA)

SP246 (BE-16GA)

SP245 (BN-16GA)

SP244 (GN/YW-16GA)

SP241 (BN-18GA)

SP240 (BK-18GA)

ABS HARN. (FRONT)

SP249 (BE-16GA)

SP247 (GN/YW-16GA)

SP243 (BK-18GA)

SP242 (BN-18GA)

2665-GG5

ABS 1 SENS L2

ABS 1 SENS L1

A

B

4

ABS 1 VLV COM L

ABS 1 VLV I/L L

ABS 1 VLV O/L L

3

2

1

3

ABS SENSORLEFT FRONT

ABS VALVELEFT FRONT

ABS 1 VLV COM R

ABS 1 VLV I/L R

ABS 1 VLV O/L R

3

2

21

ABS 3 SENS R2

ABS 3 SENS R1

1

B

A

ABS VALVERIGHT FRONT

SPD SENSORRIGHT TAG WHEEL

ABS 1 VLV I/L R

ABS 1 VLV I/L L

ABS 1 SENS L2

ABS 1 SENS L1

ABS 1 VLV COM L

ABS 1 VLV O/L L

8

7

11

2

10

ABS 1 SENS R1

ABS 1 VLV O/L R

ABS 1 VLV COM R

ABS 1 SENS R2

CONNECTOR

4

9

3

6

5

5ABS BK

2969-GG5-001

(RD-14GA) SP004B

(BK-14GA) SP185U

(BK-14GA) SP185T

10

11

12

2

9

1

4

+A

-

CONNECTORABS

(PK-18GA) SP209D

(GY-18GA) SP210D

(RD-14GA) SP004A

(GN-18GA) SP515

A

60

85

(RD-10GA) SP183B AB

61

64 64

63

J1587 POS

J1587 NEG

CLEAN GROUND

CLEAN GROUND

ABS BLINK IN

IGN TO ABS ECU

20A

IGN TO ABS ECU

98

SP183A (RD-10GA)

ABS IGN

BUSSMANN2961-GG5-003

F

81B

A

15A

10A

ABS IGN

ABS IGN

SP006D

(RD-10GA) SP183B C

(BK-18GA)START/CHARGESEE IGN/

(RD-14GA)SP004B

(RD-14GA)

(PK-18GA)SP055

SP004A

SP185N (BK-8GA)

(DKGN-20GA) SP1188F

(YW-20GA) SP1187F

6

7

SEE DATALINK/DIAGNOSTIC J1939-15 NEG

J1939-15 POS

FRONT PDC ASSY.

85

86

87A30

87

78

(GY-18GA) SP201 3 ATC SW TO ECU

79BE

IGN SOURCEPOWERTRAIN

SPL-3026

26

21

(GY-

18GA) SP201

(RD-18GA) SP460ASR

3A

55

SP201

SP201

(GY-

18GA)

SP201 (GY-

18GA)

(RD-10GA) SP183A

+-

BATTERY CABLE

ABS HARN. (TAG AXLE)2664-GG5

5

5

6

SP298 (BK-18GA)

(BK-18GA) SP299

(BK-18GA) SP298

(BK-18GA) SP243 RIGHT FRONTABS SENSOR

A

B(BN-18GA) SP242

1

ABS 1 SENS R2

ABS 1 SENS R1

ABS 3 SENS R2

ABS 3 SENS R1

CONNECTORABS

SP305 (BE-16GA)ABS 3 VLV O/L R

ABS 3 VLV COM R

2

2

1

ABS VALVERIGHT TAG SP303 (GNYW-16GA)

ABS 3 VLV I/L R 3 SP304 (BN-16GA)

(BE-16GA) SP305

(GNYW-16GA) SP303

(BN-16GA) SP304

7

8

9

ABS 3 VLV O/L R

ABS 3 VLV COM R

ABS 3 VLV I/L RABS 3 VLV O/L L

ABS 3 VLV COM L

3

2

1

ABS VALVELEFT TAG

ABS 3 VLV I/L L 3

ABS 3 SENS L2

ABS 3 SENS L1

4

B

A

SPD SENSORLEFT TAG WHEEL

SP302 (BE-16GA)

SP300 (GNYW-16GA)

SP301 (BN-16GA)(BE-16GA) SP302

(GNYW-16GA) SP300

(BN-16GA) SP301

10

11

12

(BK-18GA) SP296

(BN-18GA) SP297

3

4

SP296 (BK-18GA)

SP297 (BN-18GA)

ABS 3 VLV O/L L

ABS 3 VLV COM L

ABS 3 VLV I/L L

ABS 3 SENS L2

ABS 3 SENS L1

BN

BATTERY CABLE

E

ABS RESISTOR 82E

1K OHM 0.25 WATT

SP515 (GN-18GA)

1

CLEANSEE

POWER

GY

RD

BK

31WABCO ASR

109 SP460 (RD-18GA)

SP212 (GY-18GA)

(GY-18GA) SP212

SP201 (GY-18GA)

SP009CE (RD-18GA)

BACKLIGHTINGSEE

(BK-18GA) SP006CE

(BK-18GA) SP185L

NL

NL

GY

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

O

14 CAV

14 CAV

102 CAV

102 CAV

RIGHT REAR

LEFT REAR

SP009CD (RD-18GA)

23

(BK-18GA) SP006CD

7 8 BACKLIGHTINGSEE

5 SP743 (BE-16GA)

SP744 (BN-16GA)6

(BE-16GA) SP743 1

2(BN-16GA) SP744

5

ABS ATC VLV APLY

ABS ATC VLV COMABSVALVE

ABS ATC VLV APLY

ABS ATC VLV COM

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

START/RUN HARNESS3093-GG5

1


SP054 (PK-16GA)

SP053 (RD-14GA)

START

IGN

G-2

IGN

SOL

ACC

BAT

G-1

ACC

KEY SWITCH

1(RD-14GA) SP053(RD-14GA)

(PK-16GA) SP054

SP053 L

Q

L

Q

SP053 (RD-14GA)

SP054A (PK-16GA)

3086-GG5CAB HARNESS

BACKBONE ENGINEBATTERY CABLE

BATTERY CABLEBATTERY CABLE

+

STARTER MOTOR SOLENOID

-

(RD-14GA)

(RD-8GA)SOURCE

A

+-

(RD-14GA)SP053

3064-GG5

2961-GG5-003

SP184E

SP053

C

C

BK

15A

BUSSMANN

KEY SW

+-

BATTERY CABLE

BATTERY CABLE

POWERSEE CLEAN

COMMON POWER

3

1

76

71

B SP184E (RD-8GA)

27

50A

A(RD-8GA) SP184D

S

21 97

6

97

SPL-18

123SP054C

(PK

-16GA)

23 1

(PK-

16GA) SP054A

(PK-16GA) SP054C 19

16

2969-GG5-001FRONT PDC ASSY.

86

85

30 87

ACC RLY 1

86

85

30 87

ACC RLY 2

14

(PK-

16GA)SP054B

18B2

ACCESSORY SWITCH

SPARTAN CONTROL MODULEINTERFACE P2 KEYING B

BN

(RD-14GA)SP192A13

75

CUST ACCCUSTOMER A N

13 CUST ACC 2

10A

SP086C3

39

ACC PWR TO LEVEL CONJACK CONTROL (RD-14GA)

SPL-30

O(RD-14GA) SP086A

LVL CNTRL

10A

SP086B (RD-14GA)8

118A

L(RD-12GA) SP192ACUST ACC

20A

POWERBATTERY

DISCONNECT

30BREAKER

150ABK BK

SEE

86

85

30 87

WIPER RLY 10

(PK-16GA) SP054B 4

15

SPL-12

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

S

20A

WIPERBREAKER

(RD-14GA) SP094ASEE WIPER

14 CAV 14 CAV23 CAV23 CAV

102 CAV

102 CAV

40 CAV

3 CAV

15 CAV

14 CAV

ACC PWR TO LEVEL CONINTERFACEHADLEY SLS

PLUG

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

1

CAB HARNESS3086-GG5


9797

SP767A (RD-14GA)

MOTORADJUSTABLE PEDALS

SP482 (PK-16GA)

83

- +(GY-16GA) SP483 12 M

1

SP767 (RD-

14GA)

B2

SP767 (RD-14GA)1

28ADJUSTABLEPEDALS

ADJ PEDAL PWRSPARTAN CONTROL MODULEINTERFACE P2 KEYING B

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

O

40 CAV

102 CAV

102 CAV

5

2

6

3

1

4

SP006AE (BK-16GA)

SP767C (RD-16GA)

SP767B (RD-16GA)

SP006AF (BK-16GA)SPL-42

SP006AF (BK-16GA)

(PK-16GA) SP482

(GY-16GA) SP483

SPL-18

7

8

29

SP006CF (BK-18GA)7

TAG DUMP

8 CAV

35A

SP006CG (BK-18GA)2

2 CAV

(BK-18GA) SP006CG

(BK-18GA) SP006CF

(RD-18GA) SP009CG

(RD-18GA) SP009CF

65

SP009CG (RD-18GA)AAUTO WIPER

3 CAV

DISABLE SWITCH

SP009CF (RD-18GA)8

MARKER FLASH

34

(RD-16GA) SP767D A

1 CAV

ADJ PEDAL PWR

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

3064-GG5

87A

86

85

3087

2961-GG5-003BUSSMANN

WIF/AIR DRYER

AIR DRYER

10A

BACKBONE ENGINE

H

E

F

(BK-18GA) SP006D

(PK-18GA) SP055

50A

SEE IGN/START/CHARGE

(RD-8GA) SP184E CA B

SP006B

SP184ESP184D

(BK-16GA) (RD-16GA) SP011

(RD-8GA)

AIR DRYER

POWER SOURCECOMMON BK

BE

SP011 (RD-16GA)

AB

BATTERY CABLE

(RD-8GA)

-

+

BATTERY CABLE

SOLENOID

+

-

BATTERY CABLE

+-

+

POWERSEE CLEAN

-


STARTER MOTOR BATTERY CABLE

SPL-13

SP006A (BK-10GA)

A

BATTERY C

ABLE

2729

27

S

A

41

A

79

76

72

12

DISCONNECT

30

BREAKER

150A

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

3086-GG5CAB HARNESS

29TAG DUMP AUTO/DISABLE/MANUAL

SP149B (LTBE-16GA)2

38SP148B (LTGN-16GA)1

AIR DUMP

11

8888

8787

(YW-18GA) SP1071

(WE-18GA) SP1070

3838

3939(LTBE-16GA) SP149A

(LTGN-16GA) SP148A

118A3

4(LTBE-16GA) SP149B

(LTGN-16GA) SP148B

DK GY


AIR DUMP

AIR FILLHADLEY SLSINTERFACE

(BK-18GA) SP006G

(LT GN-16GA) SP148

B AIR DUMPAIR DUMP

22

A

COMMON GROUND

AIR FILLA

23

B AIR FILL(LT BE-16GA) SP149

COMMON GROUND(BK-18GA) SP006H

SP149 (LTBE-16GA)

SP148 (LTGN-16GA)

8

53GY

(PK-

14GA) SP360

12

A1

MODULE INTERFACEP1 KEYING A

TAG DUMP (+)(PK-14GA) SP360

37 TAG DUMP SW (AUTO)

SP1071 (YW-18GA)

SP1070 (WE-18GA)

(WE-18GA) SP1070

B2

MODULE INTERFACEP2 KEYING B

13 TAG DUMP SW (MAN)(YW-18GA) SP1071

TO JACKCONTROLLER

SPARTAN CONTROL

SPARTAN CONTROL

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

I

O

102 CAV102 CAV 2 CAV

2 CAV

40 CAV

40 CAV

14 CAV

4 CAV

SP360A (PK

-14GA)

53

(BK-18GA) SP006C

(PK-16GA) SP360C

(PK-16GA) SP360B

(BK-18GA) SP006B

TAG DUMP

10

TAG DUMP

COMMON GROUND

CURB SIDETAG DUMP

A

B

COMMON GROUNDBTAG DUMP DRIVERS SIDEA

11

SPL-1

REAR CHASSIS2888-GG5

GY

SPL-13

8

14 CAV

2 CAV

2 CAV

16 CAV

23

(WE-18GA) SP1070SP1071 (YW-18GA)

(BK-16GA) SP006P

8(RD-18GA) SP009CE

(RD-18GA) SP009CF

SPL-16

7 SP006CE (RD-18GA)

SP006CF (RD-18GA)

AIR DUMP

AIR FILL

AIR DUMP

AIR FILL SP149A (LTBE-16GA)2

SP148A (LTGN-16GA)1

8

7(BK-18GA) SP006CE

(RD-18GA) SP009CEADJUSTABLEPEDALS

10 CAV

DSH LP PWR

COMMON GROUND

8

7(BK-18GA) SP006CF

(RD-18GA) SP009CF

8 CAV

DSH LP PWR

COMMON GROUNDVC1

28

31

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE



(RD-8GA)30 C SP184E87

86

85

SP055F (PK-18GA)


WIF/AIR DRYER

87A

SP006D (BK-18GA)

SP184E(RD-8GA)

50A

B SP184DA (RD-8GA)

SP006A (BK-10GA)

POWER SOURCECOMMON

BK+

-

BATTERY CABLE

BATTERY CABLE

+

BATTERY CABLE

+

STARTER MOTOR

-

SOLENOID

-

BATTERY CABLE

POWERSEE CLEAN

+-

BATTERY CABLE

BATTERY CABLE

SPL-13

BATTERY C

ABLE

79

76

2728

27

A

A

S

41B

72WIF

7.5A

PLUG

E

BE

GN

DISCONNECT

30BREAKER

150A

A

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

73

1

3086-GG5CAB HARNESS


HI/OFF/LOW

21

AUX BRAKE

1(GY-18GA) SP1013A

74(GY-18GA) SP1014A

73

74

SP1013 (GY-18GA)

SP1014 (GY-18GA)

25

35

B2


AUX BRAKE INPUT A

AUX BRAKE INPUT B

(GY-18GA) SP1013

(GY-18GA) SP1014

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

I


5

2

6

3

7 8

SP1013D (GY-18GA)

SP1013C (GY-18GA)

SP1014B (GY-18GA)

SP009CB (RD-18GA)

SP009CA (RD-18GA)

(BK-18GA) SP006BA

(BK-18GA) SP006BB

(BK-18GA) SP006BC

(BK-18GA) SP006CA

(BK-18GA) SP006CB

(BK-18GA) SP006BB

7 SP006CA(BK-18GA)

7

19ISX OFF/ONSP006CB (BK-18GA)

8 CAVISM &

2 SP006BC (BK-18GA)

18VGT OFF/ONCOMMON GROUND

8 CAV

2 SP006BA (BK-18GA)COMMON GROUND8 SP009CA (RD-18GA)DSH LP PWR

COMMON GROUND

COMMON GROUND

DSH LP PWR 8 SP009CB (RD-18GA)

3

20

LOW/MED/HIGH

SP1014A (GY-18GA)

8 CAVISM & ISX

3 SP1014B (GY-18GA)

3 SP1013D (GY-18GA)SEC BRK INPUT 1

SEC BRK INPUT 2

SEC BRK INPUT 21 SP1013A (GY-18GA)SEC BRK INPUT 1

6 SP1013C (GY-18GA)SEC BRK INPUT 1

SP1013B (GY-18GA)

SP1013B (GY-18GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

AMTEK LMCINSTRUMENT PANELDSH LMP PWR

6(RD-18GA) SP009BC

2CUSTOMER A DSH LMP PWR

8

HIGH/OFF/LOWISC/L/M/X SP009CA (RD-18GA)

ADJUSTABLE8

PEDALS

SP009 (RD-18GA)(RD-18GA) SP009B H H (RD-18GA) SP009 3DSH LMP PWR

TO TRANSSHIFT PAD

CAB HARNESS3086-GG5 3060-GG5

MAIN CHASSIS3093-GG5START/RUN

SP009CF (RD-18GA)

TAG DUMP

29

212

28

21

75A

52SP009CB (RD-18GA)

SP009CG (RD-18GA)

19 19

11

(RD-16GA) SP009B

SP009BD (RD-14GA)

WABCO ASR SP009CD (RD-18GA)DSH LMP POWER

8

31

HEADLIGHTSP006KA (BK-16GA)

COMMON GND7

90

SWITCH

(RD-18GA) SP009CG A

65A

SP009C (RD-16GA)

SPL-9

(RD-16GA) SP009A

SPARTAN CONTROLLER MODULE

BAC

KLIGHT11

INTERFACE P2 KEYING B

B2

61 61

62 62

(RD-18GA) SP551

(BK-18GA) SP586

COLUMNBACK LT PWR

S

77

BACK LT GND

R SP551 (RD-18GA)

SP586 (BK-18GA)

81 81

82 82(OE-18GA) SP1062

(BE-18GA) SP1061

SP586 (BK-18GA)

SP551 (RD-18GA)

SP551 (RD-18GA)

SPARTAN CONTROLLER MODULE

STEER WHEEL PW

R32

INTERFACE P1 KEYING A

A1

SP586 (BK-

18GA)STEER W

HEEL GRND21

INCREM

NT BKLIGHTING

16

DECREM

NT BKLIGHTING

26

SP1062 (OE-18GA)

SP1061 (BE-18GA)

(OE-18GA) SP1062

(BE-

18GA) SP1061

89

SWITCH

DISABLE SWITCHAUTO WIPER

(BLUNT)

DIMMER

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I I

O

OO

102 CAV102 CAV

40 CAV

40 CAV

23 CAV 23 CAV

13 CAV

11 CAV

11 CAV

12 CAV

16 CAV

12 CAV

15 CAV

30 CAV

16 CAV

23

1

7

8

SP1061 (BE-18GA)

SP1062 (OE-18GA)

SP009AB (RD-16GA)

SP009AA (RD-16GA)

(BK-16GA) SP006KA

(BK-16GA) SP006DB

(BK-16GA) SP006DC

SP006DB (BK-16GA)5COMMON GND

SP009CE (RD-18GA)

DSH LMP PWR

DSH LMP PWR

DSH LMP PWR8(RD-18GA) SP009CE

(RD-18GA) SP009CF

FOG LAMPSWITCHDSH LMP PWR

2(BK-16GA) SP006DC

8812 CAV

8(RD-16GA) SP009ABDSH LMP PWR

SPL-14

20 14 CAV

DSH LMP PWR8(RD-18GA) SP009CC

(RD-18GA) SP009CD HIGH/MED/LOWISM/ISX

19 10 CAV

DSH LMP PWR8(RD-18GA) SP009CC

ON/OFFISM/ISX

(RD-18GA) SP009CB

VGTON/OFF

8 SP009C (RD-18GA)

18

SP009CA (RD-18GA)

11 CAV

DSH LMP PWR

SP006DB (BK-16GA)8DSH LMP PWR

TRIP COMPUTER

F SP099B (RD-18GA)

36 5 CAV

DSH LMP PWR

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

BATTERY CABLE BA


POWER

30A

SEE IGN/START/

C C

15A

KEY SW

STOP/TURN

TYPE 4

31

77 71


AB

SP184A (RD-10GA)

(RD-

10GA) SP184B

SP184B

(RD-10GA)

SP053 (RD-

14GA)

3087

85

86

GRID HTR/TAG87A

GY

POWER

50A

27

AB

SP184D (RD-8GA)

LIGHTS

SOLENOIDTRLR MARKER

WARNING

76 CSP184E (RD-8GA)

COM

MON

TRLR REVERSE

TRLR BRAKE

START

TRLR LEFT

COOLING FAN87

86

30

85

87

86

30

85

87

86

30

85

87

86

30

85

87

86

30

85

87

86

30

85

BK

27

28

31

32

LIGHTS

STOP/TURNTRLR RIGHT

87

86

30

85

AIR/WIF/

A/C CLUTCH87

86

30

85

3086-GG5CAB HARNESS

2969-GG5A-001FRONT PDC ASSY.

30A

CUST BATTA

14

B

C

D

E

30A

MEM 2

30A

BRK CNTRL

30A

DRV SEAT

30A

PASS SEAT

E

13

F

G

H

5A

STEP PWR

P

15A

JACKS

15A

MEM 1

15A

DRVR SEAT AIR

15A

PASS SEAT AIR

ACC 2

86

85

3087


13SP681 (GY-

18GA)

98 13

C 72GNSP

681 (GY-

18GA)

DPLUG

BN

14

1SP681 (GY-18GA)

(GY-

18GA) SP681

INDICATIONENG RUN

87

86

30

85

98

ACC 1

86

85

3087

IGN 2

86

85

3087

IGN 1

86

85

3087

SEEACC PWRTO FUSES

SEEIGN PWRTO FUSES

SEEIGN PWRTO FUSES

SEEIGN/STARTCHARGE

M

SP900A (PK-10GA)

SP778 (RD-12GA)

SP092 (RD-10GA)

SP093 (RD-10GA)

SP848 (RD-12GA)

SP356 (PK-14GA)

SP777 (RD-14GA)

L SP192A (RD-12GA)

20A

CUST ACC

10A

CUST ACC 2

N

O10A

LVL CNTRL

SP086A (RD-14GA)

15A

MEM 3

SEETOW VEHICLE/HOOD LIGHT

SEECPTN'S & DRVR'SSEAT PWR/AIR

SEECUSTOMERCONNECTORS

SEEPRK BRK/LVL CNTRL

SEEPRK BRK/LVL CNTRL

PASS THROUGHPOWER STUD

-S+


BATTERY CABLE

BATTERY C

ABLE

CHARGE

78 C

BK SP183B

(RD-10GA)

3087

85

86

ABS87A

ENG/TRANS IGN87

86

30

85

A 75

SP183H

(RD-8GA)

C

GY

SEECLEANPOWER

SP183J (RD-18GA)

E

10A

TCM BATT

10A

BATTERYDATALINK

G

H

F

E

79BE

80YW

10A

BATTERYSHIFT SEL

D

81RD

10A

BATTERYCAB INSTRMNT

C

30A

ECM BATT

F

E

74OE

30A

CHARGETRLR BATT

AT110A (PK-12GA)

AT170A (PK-12GA)

SP528B (RD-16GA)

SP528A (RD-16GA)

SP183P (RD-10GA)

AT110D (PK-16GA)

EN240B (RD-10GA)

EN240A (RD-10GA)

SEECLEANPOWER

SEEDATALINK/DIAGNOSTIC

SEECLEANPOWER

SPL-14

4BATTERY POS

CONNECTOR 23

1CLEAN GROUND

EN240C (RD-12GA)

SP655A (BK-12GA)

ENGINE POWER

+

-

+

-

BATTERY CABLE

BATTERY CABLE

BATTERY C

ABLE

BATTERY CABLE

SEE TOWVEHICLE

SP972A (RD-10GA)

DISCONNECT

30

BREAKER

150A

86

85

3087

SEEACC PWRTO FUSES

20A

WIPERBREAKER

WIPER

14 CAV

14 CAV

NL

NL

102 CAV

4 CAV

8MEM

ORY PW

R 1

MEMORY

10

INTERFACE

15 CAV

4MEM

ORY PW

R 3

9MEM

ORY PW

R 2

SP778 (RD-

12GA)

SP848 (RD-

12GA)

SP777 (RD-

14GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG5

(RD-10GA) SP092

(RD-10GA) SP093SP093 (RD-10GA)

SP092 (RD-10GA)1

8

1717

FRONT CHASSIS3070-GG5

1

8(RD-10GA) SP093

(RD-10GA) SP092

CAPTAIN'S SEAT ACOMMON GROUND

CAPT SEAT PWR B

6

SP006E (BK-10GA)

SP093 (RD-10GA)

DRIVER'S SEATDRIVER ST PWR

COMMON GROUND

7

A

B

SP006C (BK-10GA)

SP092 (RD-10GA)

LT GY LT GY14

E

D

13

F

P

PASS SEAT

30A

30A

DRV SEAT

15A

PASS AIR

DRV AIR

15A


BATTERYSEE

POWER

21 CAV21 CAV

PLUG

PLUG

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

SPL-48

(BK-14GA)

(BK-14GA) SP185T

SP185U

11

12

85

ABS

(BK-16GA) ASP185A

1

DIAGNOSTICPORT

GY

ECMGROUND

ENGINE POWERCONNECTOR

SP655A A

20

(BK-12GA)

1

23

SP655A(BK-12GA)

15 12SP185C

(BK-

18GA)

COMPASSMODULE

B

69A

SP185J(BK-18GA)

WABCOATC

2

31

SP185L(BK-18GA)

CONNECTORDIAGNOSTIC A

57

SP185E (BK-16GA) 48

51

48SP185B(BK-10GA)

51SP185AA(BK-18GA)

HADLEYSET RIDEA

55A

SP185N(BK-18GA)

HEIGHT

3SP185G

(BK-

12GA)

64A

3SP185H

(BK-

12GA)

64B

A64C

SP185G (BK-16GA)

SP185C (BK-10GA)

1 1


CAB HARNESS3086-GG5

BLUNT

SP185N (BK-8GA)

SP185A (BK-16GA)

SP185P (BK-10GA)

BRAKE CONTOLLERELECTRONIC TRAILER

SPL-24

SPL-19

BACKBONE HARNESS3064-GG5

INSTRUMENTPANEL

14

52

SP185AA (BK-18GA)LMC

AT109A (GY-14GA)

AT169A (GY-14GA)

AT169D (GY-16GA)

INTERFACE

9

84

69TCM

AT169(GY-16GA)

SPL-49

(GY-18GA) AT169B

(GY-18GA) AT109B TCM CLEAN GROUND

TCM CLEAN GROUND

RUN/START3093-GG5

2EAT169

(GY-

16GA)

SHIFT PAD

5AT169

(GY-

18GA)

TO TRANS

TCM C

LEAN GRO

UND

SPL-30SP185R (BK-12GA)77

97 97

SP185A(BK-10GA)

77

SWITCHSTOP BRAKE A

7

SP185L (BK-18GA)

INTERFACE P1 KEYING ASPARTAN CONTROL MODULE

13A1

SP185B

(BK-16GA)

E 1

2

SENDERJUNIOR AIR B

3

SP185J

(BK-

16GA)

23SP185D

(BK-

16GA)

25SP185K

(BK-

18GA)

INTERFACE P2 KEYING BSPARTAN CONTROL MODULE

14B2

SP185E

15SP185F

(BK-

16GA)

(BK-

16GA)

118ADK GY

11 SP185M (BK-16GA)

2969-GG5A-001FRONT PDC ASSY.

87

86

30

85

LOCKOUT (-)SPEED

+-

A

60

+-

BATTERY CABLE

BATTERY CABLE

BK BK

98 98NL NL

40 CAV 40 CAV

14 CAV14 CAV

14 CAV14 CAV

23 CAV

23 CAV

2 CAV

6 CAV

102 CAV102 CAV

80 CAV

12 CAV

9 CAV

4 CAV

30 CAV

9 CAV

14 CAV

2 CAV

12 CAV

4 CAV

23 CAV

SPL-62

HADLEY SLSINTERFACE

36

A SP185F (BK-18GA)

5 CAV

TRIPCOMPUTER

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE


5

RUN/START3093-GG5

97B B

2AT110 (PK-16GA)TO TRANS TCM CLEAN POWER 13

2 1AT110 (PK-18GA)

SHIFT PAD(PK-18GA) AT110

1

(PK-16GA) AT110

SPARTAN CONTROL MODULE4

B2

INTERFACE P2 KEYING B(RD-14GA) SP183B

SPL-23

49491

1

(RD-

10GA) SP183C

CAB HARNESS3086-GG5

P14

SP183 (RD-

10GA)


(RD-

10GA) SP183

86

85

30 87

CLEAN IGN

IGN/START/CHARGE

SEE

IGN/START/CHARGE

SEE

3A

BRK SIG

13 215

(RD-

18GA) SP632

3A

GAUGES

10

16

21

3

24

12

A(RD-

14GA) SP020A

SP904 (PK-18GA)

SP460 (RD-18GA)

SP970 (PK-16GA)

SP969 (PK-18GA)

3A

COLUMN

3A

TIRE PRESS3A

ASR

5A

JR/CMPSS

10A

POWERINSTRMNT

STEER

START/CHARGESEE IGN/

PRESSURE/ASRSEE TIRE

INSTRUMENTSEE

POWER

INSTRUMENTPOWER

SEE

BK

98(RD-10GA) SP183A

40 CAV

NL14 CAV

14 CAV

102 CAV

102 CAV

23 CAV23 CAV16 CAV

BACKBONE ENGINE3064-GG5

(RD-10GA) SP183B B SP183A (RD-10GA)A

C

86

85

3087

87A

86

85

3087


(RD-10GA) SP183B

ABS

BATTERY CABLE

BATTERY CABLE

STARTER MOTOR

+

-

SOLENOID

SEE BATTERY

BATTERY CABLE

POWER

BATTERY CABLE

+-

+-

BATTERY CABLE

A

30A

ECM BATT

(RD-8GA) SP183D A SP183E (RD-8GA)B

10A

TCM BATT

10A

BATT

5A

(RD-

10GA) EN240A

E

(RD-

16GA) SP528B

F

(PK-

16GA) AT110D

D

(RD-

10GA) EN240B

F

(PK-

12GA) AT110A

G

(PK-

12GA) AT170A

H

(RD-

16GA) SP528A

E

A SP183H (RD-8GA)

DATALINK

SELECTORSHIFT

ENGINEECM

SEEDATALINK/DIAGNOSTICS

SEE

SP183F (RD-4GA)

SP183G (RD-4GA)

YW RD


BATT SOURCEPOWERTRAIN

SPL-27

SPL-26

75

818074

66

6767

60A

S

78 ECM/TRANS IGN

63

6464

20A

61

TCM TCM CLEAN POWER 10

84

TCM CLEAN POWER 70INTERFACE

AT110B (PK-18GA)

AT170B (PK-18GA)

SPL-47

SPL-46

5 AT110D (PK-16GA)

79

98

(RD-

10GA) SP183P

C

1 SP183R (RD-12GA)

15A

BATTERYINSTRUMENTATION

CAB

SPL-28

C SP183J (RD-8GA)

72

E

30A

CHARGETRLR BATT

(RD-

10GA) SP972A

GNBEOE

BK

GY

TOW VEHICLE/HOOD LIGHT

SEE

NL

97BK

I

I

14-CAV

14-CAV

80-CAV

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGENDSPL-61

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

SP007B


(RD-16GA)

A/C PRESSURE SIGAEN030A(GY-18GA)

BEN030A(GY-18GA) A/C PRESSURE SIG

5A

A/C PRESSURE SW

NOTE: ATTACH ITEM 5ATO ITEM 5

(GY-18GA) EN030 EN045 (BK-18GA)B

A/C PRESSURE5

SWITCHA(GY-18GA)

A/C PRESSURE SIGEN03010

ENGINE ECM

24

SPL-5

DIODE 1

SPL-4

17

3 (RD-16GA) SP341 VACUUMVAC PUMP PWRAPOWER

11

FRONT CHASSIS3070-GG5

LT GY

1N4005

A+

BATTERY CABLE

-

BATTERY CABLE

S

BATTERY CABLE

BATTERY CABLE

+

+

SEE CLEANPOWER

+

BATTERY CABLE

BATTERY CABLE


-

- -

SEE COMMONGROUND

41

A

ECU RET 1(BK-18GA)41 EN045

6

BSP007C

(RD-

16GA)

ASP006K

(BK-

16GA)

A/C CLUTCH

AC C

LT SW PWR

COM

MON

GRO

UND

71

E

BN

A3

98983

3060-GG5MAIN CHASSIS 2961-GG5-003

BUSSMANN

SP007A(RD-18GA)SP007A (RD-18GA)SP007(RD-16GA)

142 42 SP007 (RD-16GA)

CAB HARNESS3086-GG5

SP007A(RD-14GA)

CUSTOMER B

AC CLT SW PWR1

75A

SP007A (RD-14GA)

1

17LT GY

3


25A

CNDSR

25A

BLOWER

VAC PWR

30A

14

G

H

K

SP341 (RD-14GA)

SP105A (RD-12GA)

SP106A (RD-12GA)

TO FUSESIGN POWER

SEE

BLOWER MTR PWR14 SP105A (RD-12GA)

A/C CLUTCH

7.5A

A/C CLUTCH87

86

30

85

79BE

ESP006D(BK-18GA)

76BK

CSP184E(RD-8GA)SEE BATTERYPOWER

102 CAV102 CAV 14 CAV 14 CAV

NLNL

2 CAV

2 CAV

50 CAV

15 CAV

(BK-16GA) SP006V VACUUMCOMMON GROUNDAGROUND

12

6 6

(BK-

14GA) SP006R

CNDSR FAN PWR15 SP106A (RD-12GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG5

LMC INSTRUMENT

PARK BRAKE

PANEL

SWITCH

SP006AB (BK-18GA)

SP006AA (BK-14GA)

527

50A

SPL-18

28

SP006A(BK-6GA)

SPL-16

(BK-10GA) SP006S

DISABLEAUTO WIPER

65A(BK-18GA) SP006N

COLUMN

77C

F

G

(BK-18GA) SP006G

(BK-18GA) SP006H

(BK-18GA) SP006J

FOG LAMP

88

SWITCH

HEADLIGHTSWITCH

90

(BK-16GA) SP006D

(BK-16GA) SP006DA

(BK-16GA) SP006DB

(BK-16GA) SP006DA

DIMMER

892

7(BK-16GA) SP006DB

(BK-16GA) SP006DC

(BK-16GA) SP006KA

SWITCH


13

V

(BK-

14GA) SP006F

87

86

30

85

CLEAN IGN87

86

30

85

IGN RELAY 187

86

30

85

IGN RELAY 287

86

30

85

ACC RELAY 187

86

30

85

ACC RELAY 2

43

1

43 SP006A (BK-6GA)


87

86

30

85

WIPER

3070-GG5FRONT CHASSIS

(BK-18GA) SP006H B

23AIRFILL

(BK-14GA) SP006F

(BK-18GA) SP006G B

22

2

15

(BK-14GA) SP006E

(BK-14GA) SP006D

2

14

132

EJECTOR

DUMPAIR

EJECTORMOISTURE

EJECTOR

MOISTURE

MOISTURE

SP006B

(BK-

10GA)

SP006C

(BK-

10GA)

9 68 1

A

4

17

14SP006L (BK-

10GA)

11SP006K (BK-

10GA)

5

PASS

SEE PAGE 2

17

SP006V (BK-16GA)6

SP006C (BK-10GA)4

SP006E (BK-10GA)10

SEATCAPTAIN'S

SEATDRIVER'S

(BK-10GA) SP006E A

6

(BK-10GA) SP006C

7A

VACUUMGROUND

(BK-16GA) SP006V

12A

(BK-14GA) SP006R

(BK-10GA) SP006L

(BK-10GA) SP006M

6

4

10

2

TAG DUMPSP006P (BK-16GA)

292

7 SP006CE (BK-18GA)

SP006CF (BK-18GA)

SP006BB (BK-18GA)

SP006BB (BK-18GA)

SP006CA (BK-18GA)

SP006BA (BK-18GA)

SP006BC (BK-18GA)

2

21

5

SP006CB (BK-18GA)

7

HIGH/OFF/LOWAUXILIARY BRAKE

SP006AF (BK-16GA)

SP006AF (BK-18GA)

SP006CG (BK-18GA)

SP006AE (BK-18GA)

1

6

SP006CF (BK-18GA)

7PEDALS

ADJUSTABLE

WABCOASR

SP006CD (BK-18GA)

317

SP006CE (BK-18GA)

2

5

7(BK-16GA) SP006K

(BK-16GA) SP006KA

(BK-16GA) SP006DC

(BK-16GA) SP006DD

(BK-16GA) SP006DE

(BK-16GA) SP006DD

2

7

ISM/ISX

19

ON/OFF

(BK-18GA) SP006BC

(BK-18GA) SP006CB

(BK-18GA) SP006CC

(BK-18GA) SP006BD

2

7

VGT

18

ON/OFF

2

7

SP006B (BK-16GA)

SP006C (BK-18GA)

SP006CA (BK-18GA)

SP006BA (BK-18GA)

MARKERFLASH

SP006CG (BK-18GA)

35A2

SP006BD (BK-18GA)

SP006CC (BK-18GA)

SP006BE (BK-18GA)

SP006BE (BK-18GA)

2

20

5

SP006CD (BK-18GA)

7

HIGH/MED/LOWISM/ISX

3

(BK-16GA) SP006DE9 98 61 14 11

(BK-

10GA) SP006A

(BK-

12GA) SP006D

(BK-

12GA) SP006L

(BK-

12GA) SP006R

1

SPL-2

SIDE HEADLAMP

SP006B (BK-12GA)

281

9 SP006R (BK-12GA)PASSENGER'S

251

9

5BA

SPL-1

SP006H (BK-14GA)GROUNDAIR HORN

SP006S (BK-12GA)

SP006L (BK-12GA)(LEFT) HEADLAMPDRIVER'S SIDE

MARKER FLASHCAP

SP006CH (BK-18GA)

35B2

BLUNTWIRES

SP006CH (BK-18GA)

35C2

SWITCHCRUISE

78A2(BK-16GA) SP006E

THROUGH STUD

A

3B

E

2(BK-14GA) SP006W

(BK-16GA) SP006T

MOTORWIPER

MOTORWASHER

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE


TAG DUMP

SP006J (BK-10GA)

SP006K (BK-12GA)

SP006C (BK-18GA)

CONNECTORTAIL LIGHT

5

32

TOW POWER

TAGDUMP

B

27

B

11

SPL-13

SP006B (BK-18GA)CURB SIDE


10B

B

49

LEFT MRKR B

50

LIGHTS

RIGHT MRKRLIGHTS

SP006E (BK-18GA)

SP006D (BK-18GA)

SP006L (BK-12GA)12

(BK-16GA) SP006J

SPL-13

(BK-16GA) SP006B B

IN4005CONTROL

SEE CLIMATE

AIR DRYER

BATTERY CABLE

SP006D (BK-18GA)

(BK-16GA) SP006B

2/0 BATTERY C

ABLE

LEFT FRAME RAIL

(BK-16GA) SP006K

DIODE 1

A

CHASSISGROUND

A

SPL-4

A/C CLUTCH

RIGHT FRAME RAIL

A

(BK-10GA) SP006A

- S +

30

86

8587

87A

ABS


BATTERY CABLE

BATTERY CABLE

85

86

ENG/TRANS IGN8730

(BK-18GA) SP006R REVERSEB WARNINGALARM

85

86

NEU. SAFETY8730

+-

+-

BATTERY CABLE

BATTERY CABLE

BATTERY CABLE

85

86

INDICATION8730

ENG RUN

85

86

SOLENOID8730

START

85

86

GRD HTR/TAG8730

AIR/WIF

85

86

A/C CLUTCH8730

85

86

MRKR LTS8730

TRAILER

85

86

L STP/TRN8730

TRAILER

85

86

R STP/TRN8730

TRAILER

9

12

6

12

41

79E

SPL-5

2 CAV

2 CAV

8-CAV

2 CAV


SEE PAGE 1BATTERY CABLE

COMMONGROUND

(BK-

18GA) SP006A

A

12

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

64 EN544 (PK-18GA)

EN545 (GY-18GA)65

EN541 (GY-18GA)63


1

CAB HARNESS3086-GG5

1(GY-18GA) EN541

SPARTAN CONTROL MODULE

CRUISE SET

A1

INTERFACE P1 KEYING A

19

(PK-18GA) EN544 CRUISE ON/OFF29

(GY-18GA) EN545 28 CRUISE RESUME

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

I

I

75

62

76

61

75

62

76

61

34

33

21

32

(YW-18GA) SP1056

CLOCK SPRING:

4 BANDRIBBONVIP WHEEL

WHEELV4 OR V44SWITCH POD

YELLOW

GRAY

BLACK

GREEN

YELLOW

GRAY

BLACK

GREEN

A A

B B

C C

D D

MPX SIG (YW)

COLUMNSTEERING

MPX GND (BN)

A

B

C

D

PNL LTS GND (GRN)

PNL LTS PWR (RD)

N

P

S

R

N

P

S

R

77SP1056 (YW-18GA)

SP1055 (BN-18GA)

SP586 (BK-18GA)

SP551 (RD-18GA)

(BN-18GA) SP1055

(BK-18GA) SP586

(RD-18GA) SP551

SMART WHEEL SWITCH

SMART WHEEL BANK

BACK LIGHT GROUND

BACK LIGHT POWER

I

I

O

O

(YW-18GA) SP1056

(BN-18GA) SP1055

(BK-18GA) SP586

(RD-18GA) SP551

SP1056 (YW-18GA)

SP1055 (BN-18GA)

SP586 (BK-18GA)

SP551 (RD-18GA)


16 CAV

(GY-18GA) EN541

(PK-18GA) EN544

(GY-18GA) EN545

64

65

63

78A4 CAV 3EN545

(GY-

18GA)

1EN544

(PK-

18GA)

4EN541

(GY-

18GA)

CRUISESWITCH

RESUME/ INC

REASE

SET/ DEC

REASE

CRU

ISE ENAB

LE

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG5

CUSTOMER A

SP007A (RD-14GA)1

75A

2 SP009BD (RD-14GA)

4

3

AT125A (TN-18GA)

SP006AC (BK-14GA)

7

8

6

5

SP569A (DKGN-18GA)

SP570A (YW-18GA)

SP051C (GY-18GA)

SP068B (GY-18GA)

12 SP015A (PK-18GA)

11

13

10

14

9

SP883B (TN-16GA)

SP192A (RD-12GA)

SP882A (TN-18GA)

SP105A (RD-12GA)

SP191A (RD-12GA)

SEE

SEE CLIMATECONTROLS

LEVEL CONTROLSEE PARK BRAKE/

REVERSE LIGHTSSEE STOP/

SEE HDLP/TURN/MRKR

SEE HDLP/TURN/MRKR

PANELLMC INSTRMNT

(TN-

18GA) SP883A

(TN-

18GA) SP882

JACK

DWN

WRN

G

ANT UP

WRN

G

52

16 15

SEE CLIMATECONTROLS

REVERSE LIGHTSSEE STOP/

118A

(TN-16GA) SP883D 12

14

N

13

CUST ACC 2

10A

L(RD-12GA) SP192ACUST ACC

20A


J

F

A

CUST IGN

30A

CUST BATT

30A

CUST IGN 2

7.5A

(RD-12GA) SP191A

V(BK-14GA) SP006F

SEE IGN POWERTO FUSES

SEE ACC POWERTO FUSES

SEE BATTERYPOWER

AMTEK

BACKLIGHTING

15 CAV

14 CAV

30 CAV

JACK DOWN WARNINGINTERFACEHADLEY SLS

15 SP106A (RD-12GA)

AC CLT SW PWR

DSH LP PWR

SPEEDOMETER SIGNAL

COMMON GND

L TURN FROM RLY TO L

PARK BRK LIGHT

CUST ACC

B/UP LT ACTIVE

ANT UP WARNING

JACK DOWN WARNING

BLWR MTR PWR

CUST IGN

HORN BUTTON

R TURN FROM RLY TO L

CNDSR FAN PWR

SEEINSTRUMENT PWR

PLUG

SPL-36

SEE CLEANGROUND

PLUG

PLUG

1

2

4

3

7

8

6

5

12

11

13

10

14

9

15

75BA

A

A

A

A

A

A

A

A

A

A

A

A

A

A

75C 15 CAV15 CAV

BLUNT CUTCUSTOMER

(RD-16GA) SP007B

(RD-14GA) SP009BE

(RD-14GA) SP006AD

(TN-18GA) AT125B

(GY-18GA) SP068F

(GY-18GA) SP051D

(DKGN-18GA) SP569B

(YW-18GA) SP570B

(RD-12GA) SP191B

(TN-18GA) SP882B

(TN-16GA) SP883C

(PK-18GA) SP015B

(RD-12GA) SP192B

(RD-12GA) SP105B

(RD-12GA) SP106B

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

98

10

9


98

6

12

11


(YW-18GA) SP1187A

(DKGN-18GA) SP1188A

(PK-18GA) SP209A

(GY-18GA) SP210A

(RD-16GA) SP528

SPL-13

(PK-

18GA) SP209B

(GY-

18GA) SP210B

DC

AIR SENDERJUNIOR

J1587 NEGATIVE

J1587 PO

SITIVE

3

SPL-101

SPL-102

(DKG

N-18GA) SP1188D

(YW-18GA) SP1187D

28 28

1

CAB HARNESS3086-GG5

SP528 (RD-16GA)

29 29

30 30 SP210C (GY-18GA)

SP209C (PK-18GA)

1

2

RR

SS

SP1188B (DK

GN-18GA)

SP1187B (YW-18GA)

WW

SP1187C (YW-18GA)

46 46 SP1187E (YW-18GA)

1

47 47 SP1188E (DKGN-18GA)

SPL-12

XX

SP1188C (DK

GN-18GA)

SHIFT PADTO TRANS 2

(YW-18GA) SP1187C

(DKG

N-18GA) SP1188C

(DKG

N-18GA) SP1188A

(YW-18GA) SP1187A

SPL-3

SPL-2

SP1187B (YW-18GA)8

SP1188B (DKGN-18GA)15J1939-15 NEGATIVE

J1939-15 POSITIVE

3093-GG5RUN/START

77 77 SP979 (LTGN-18GA)

J1939-

15 P

OS

MODULE INTERFACE

14A1

P1 KEYING A

SP1187F (YW-18GA)

2435361626

SP1188F (YW-18GA)

SP979 (LTGN-

18GA)

67 67

68 68

69 69

SP997 (OE-18GA)

SP998 (WE-18GA)

SP999 (PE-18GA)

SP997 (OE-

18GA)

SP998 (WE-

18GA)

SP999 (PE-

18GA)

J1939-

15 N

EG

SPARTAN D

ATAB

US

LIN P

OWER

LIN C

OMM

BA

VORADJ1939 FOR

J1939-

15 N

EGATIVE

J1939-

15 P

OSITIVE

101

(YW-18GA) SP1187A

(DKGN-18GA) SP1188A

(PK-18GA) SP209A

(GY-18GA) SP210A

(RD-16GA) SP528

(LTGN-18GA) SP979

(OE-18GA) SP997

(WE-18GA) SP998

(PE-18GA) SP999LIN GROUND

LIN POWER

LIN COMM

AUTO WIPER/ LIGHTS

3

2

1

4AINPUT INTERFACESP997 (OE-18GA)

SP998 (WE-18GA)

SP999 (PE-18GA)

SPL-2

SP1187C (YW-18GA)

SP1188C (DK

GN-

18GA)

SPL-34SPL-35

SP1187E (YW-18GA)

SP1188E (DKG

N-18GA)

SPL-4SPL-3

SP1187G (YW-18GA)

SP1188G (DKG

N-18GA)

SPL-8

SPL-7

SP1187J (YW-18GA)

SP1188J (DKGN-18GA)

SPL-10SPL-9

J1939-15 NEGATIVE

J1939-15 POSITIVE

J1939 NODAL DROP

B

A

3ATO TRIP COMPUTERSP1187F (YW-18GA)

SP1188F (DKGN-18GA)

J1939-15 NEGATIVE

J1939-15 POSITIVE

AMTEK LMC

30

29

52INSTRUMENT PANEL

SP1187D (YW-18GA)

SP1188D (DKGN-18GA)

28

27

J1939-15 NEGATIVE

J1939-15 POSITIVE

DIAGNOSTIC

D

C

57CONNECTOR

SP1187H (YW-18GA)

SP1188H (DKGN-18GA)

B SP528 (RD-16GA)DATALINK POWER

J1939-15 NEGATIVE

J1939-15 POSITIVE

TRW POWER

3

2

71ACOLUMNSP1187K (YW-18GA)

SP1188K (DKGN-18GA)

SPL-17

SPL-11

SP209D (PK-18GA)

SP210D (GY-18GA)

SP209B (PK-18GA)

SP210B (GY-18GA)G

F

J1587 NEGATIVE

J1587 POSITIVE

J1587 NEGATIVE

J1587 POSITIVE

A

RESISTOR

B

J1939 TERMINATING

76BA

B

76A(YW-18GA) SP1187L

(DKGN-18GA) SP1188L

(YW-18GA) SP1187B

(DKGN-18GA) SP1188B

(LTGN-18GA)

SP209E (PK-18GA)

SP210E (GY-18GA)

69A

C

DMODULECOMPASS

2

SP209 (PK-16GA)CJ1587 POS C

50DDJ1587 NEG SP210 (PK-16GA)

COMPASS MODULE HARNESS2689-GG5-013

LIN G

ROUND

PRK BRK/SEE

LVL CNTRL14 CAV14 CAV

NL NL

102 CAV 102 CAV

6 CAV 3 CAV

40 CAV

SPARTAN CONTROLLER23 CAV

23 CAV

4 CAV4 CAV

3 CAV

30 CAV

9 CAV

3 CAV

3 CAV

16 CAV

SP210F (GY-18GA)

SP209F (PK-18GA)

SP1188J (DKGN-20GA)

SP1187J (YW-20GA)


10A

DATALINK BATT(RD-16GA) SP528A

80E

(RD-8GA) SP183H

75A

J1939-15 POSITIVE

J1939-15 NEGATIVE

J1587 POSITIVE

J1587 NEGATIVE

DATALINK POWER

CLEAN GROUND

DIAGNOSTICG(GY-18GA) SP210A

(DKGN-20GA) SP1188A

(YW-20GA) SP1187A

(RD-16GA) SP528B

(BK-16GA) SP185A

(PK-18GA) SP209A

B

D

C

A

F

1

NEGATIVE J1939-15

POSITIVE J1939-15

J1587 NEGATIVE

J1587 POSITIVE

POSITIVE J1939-15

NEGATIVE J1939-15

ABS BLINK IN

ABS ECU (GRAY)

ENGINE ECM

(DKGN-20GA) SP1188D

(YW-20GA) SP1187D

21

1

(GY-18GA) SP210D

(PK-18GA) SP209D

(GN-18GA) SP515

24

4

9

10

(DKGN-20GA) SP1188F

(YW-20GA) SP1187F 7

6

85

SPL-44

SPL-45

SPL-41

SPL-42

SP1187G (YW-20GA)

SP1188G (DKG

N-20GA)

SPL-12

SPL-11

SP1188E (DKG

N-20GA)

SP1187E (YW-20GA)

SP1187C (YW-20GA)

SP1188C (DK

GN-20GA)

SPL-2

SPL-3

SPL-22

SPL-21

YW

SEE ABS

A

RESISTOR

B

J1939 TERMINATING

11

(YW-20GA) SP1187B A

B(DKGN-20GA) SP1188B

10

SP528A (RD-16GA)

(RD-16GA) SP528B F

SP183G (RD-4GA)

SPL-27

SPL-26

J1939 CAN POS

J1939 CAN NEG

TCM INTERFACE

8

28

84(YW-20GA) AT128

(DKGN-20GA) AT108

SP185A (BK-16GA)

(RD-8GA) SP183D A

67

B SP183E (RD-8GA)

60A

67

66

BATT SOURCEPOWERTRAIN+

A-

A

60

61+

-

BATTERY CABLE

BATTERY CABLE

(RD-8GA) SP183J C(RD-4GA) SP183F

SPL-28

10

12

11

29

39

(GY-18GA) SP210C

(PK-18GA) SP209C

NEGATIVE J1587

POSITIVE J1587

80-CAV

12-CAV

60-CAV

9-CAV

9

6

2

INTERFACE

SPARTAN D

ATAB

US

10

SP979

15 CAV

MEMORY

SPL-1SPL-14

SPL-10

COMPUTERTRIP

36

SP209C (PK-18GA)EJ1587 POS

DJ1587 NEG SP210C (GY-18GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE


START/RUN3093-GG5

97 2 1 THROTTLED

CUMMINS4

ECM RETURN SENESENSOR SPLY +5VO

K

O

K

11

13

EN061

EN063

(OE-18GA)

(BK-18GA)

EN061

EN063

(OE-18GA)

(BK-18GA)

EN061

EN063

(OE-18GA)

(BK-18GA)

EN061

EN063

BK14 CAV 23 CAV 23 CAV 6 CAV


41 (BK-18GA)ECU RET 1 EN045

START LOCKOUT

CLEAN IGN

ECM RET GEN E

J1939-15 NEGATIVE

J1939-15 POSITIVE

ACCRTN POSN SEN 2

ACCRTN POSN SEN 1 SCE

ACCRTN POSN SEN 1

ACCRTN POSN SEN 1 RET

ENGINE ECM

(GY-18GA)

(PK-18GA)

(YW-20GA)

(BK-18GA)

(PK-18GA)

(PK-18GA)2

45

32

EN1004

EN439

EN999

21

1

29

39

SP1188D

SP1187D

(BK-18GA)

(YW-18GA)

(GY-18GA)

(BE-18GA)

27

25

35

EN058

EN062

EN059

28 EN060

24

SEETHROTTLE

SP209C

SP210C

J1587 POSITIVE

J1587 NEGATIVEDATALINK/DIAGNOSTIC

SEE

EN99360 (TN-18GA)COOL SENS SIGNAL

EN994

EN993(TN-18GA)

(BK-18GA)PROBE

COOL SENS RETURN

COOL SENS SIGNAL

C

B

LOW COOLANT3

4 (RD-12GA)BATT POS EN240C

CLEAN GND SP655A1 (BK-12GA)

CLEAN GND A SP655A (BK-12GA)

ENGINE POWER 23

20

CONNECTOR

ECMGROUND

(DKGN-20GA)

EN030 (GY-18GA)10A/C PRESS SIG CONTROLSSEE CLIMATE

COOL SENS SUPPLYAEN992(PK-18GA)

EN1011 (OE-18GA)26SENSOR SPLY 5V

F

81

(PK-18GA) EN439

RD

F

74

(RD-10GA)

(RD-10GA)

EN240A

EN240B

OE

SPL-14

E(BK-18GA) SP006D

79

SOURCE

A SP183H (RD-8GA)

SP183F (RD-4GA)

SP183G (RD-4GA)

SPL-27

B(RD-8GA) SP183E

75

78

67

66

67

A SP183D (RD-8GA)

C SP183B (RD-10GA) B(RD-10GA) SP183B

64

63

64

A SP183A (RD-10GA)

20A

SPL-26

BATTERY CABLEBB A SP184D (RD-8GA) A

50A

28

60A


COMMON PWR

BATT SOURCE

IGN SOURCE

POWERTRAIN

POWERTRAIN

40

9

34

38

49

45

PARTICULATE FILTERINTERFACE

4

6

3

2

1

7

5

SPL-20

SPL-19

CSF DELTA PRESS SEN

(PE-18GA)EN1007

(BK-18GA)EN064

(BE-18GA)EN069

(YW-18GA)EN068

(PK-18GA)EN067

CSF DELTA PRESS SEN

EN1007

EN064

EN069

EN068

EN067

(PE-18GA)

(BK-18GA)

(BE-18GA)

(YW-18GA)

(PK-18GA)

EN1008(BK-18GA)

EN1006(OE-18GA)

ECM RET TEMP LVL D

PFT SEN 3 OUTLET

PFT SEN 2 MID

PFT SEN 1 INLET

ECM RET SEN

SENS SPLY 5V

ECM RET TEMP LVL D

PFT SEN 3 OUTLET

PFT SEN 2 MID

PFT SEN 1 INLET

9711

13

EN061

EN063

(OE-18GA)

(BK-18GA)

SPL-28

C SP183J (RD-8GA)

76

C SP184E (RD-8GA)

E

(PK-18GA) EN1004

73

C

72

F(BK-18GA) EN1005

BK

GN

BE

BK

BK

GY85

86

STRTR LOCKOUT

3087A

87

87

86

30

85

NEU SAFETY

ECM BATT

30A

ECM IGN

5A

87

86

30

85

ENG/TRANS IGN

87

86

30

85

RUN INDICATIONENGINE

C(GY-18GA) SP681

F(PK-18GA) SP055

SEEBATTERY


87

86

30

85

START SOLENOID

10A

71F SP073 (RD-16GA)

BN

27 27


POWER

DISCONNECT

30BREAKER

150A

BK

FAN CONTROL OUTPUT (PK-18GA)52 EN998

22 EN1010 (BK-18GA)ECM RETURN (SENSOR)

SPL-16

53(BK-18GA)

GRID HEATERSOLENOID 1

EN1001

52EN1000 (PK-18GA)1

1

2 (BK-18GA)ECM RET GEN E EN999

FAN CNTRL OUTPUT EN9981 (RD-18GA)

VARIABLE SPEED 4HYD. FAN

EN1000 (PK-18GA)54INTAKE AIR HTR

EN066A44ECM RET GEN F (BK-18GA)

61

BATTERY CABLE

BATTERY CABLE

+

+

STARTER MOTOR

-

SOLENOID

-

+-

S

BATTERY CABLE

BATTERY CABLE

A

BATTERY CABLE

SP183D (RD-8GA)

SP183A (RD-10GA)

START SOLENOID

O

I

I

I

O

O

I

3-CAV

60 CAV

8-CAV

4-CAV

14-CAV

2-CAV

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

1-CAV

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE


53GY

A1

SPARTAN CONTROL MODULEINTERFACE P1 KEYING A

11

34 34

4(YW-14GA) SP044A

SPL-11

SP044C (YW-14GA) (YW-10GA) SP048

3

6

2

5

11

(DKGN-10GA) SP047

SPL-15

35 SP045C (DKGN-14GA)

5(DKG

N-14GA) SP045A

20(YW-14GA) SP227

(YW-14GA) SP227

B231


(DKG

N-14GA) SP226

(DKGN-14GA) SP226

89 89 SP951 (BE-18GA)

33(BE-

18GA) SP951

1(BN-

14GA) SP1054A

SPL-17

(BN-10GA) SP1054B

SP1053C (BN-14GA)98 98

SPL-3

7(BN-

14GA) SP1053A

2(RD-

14GA) SP1064

10(RD-

14GA) SP1065

17(RD-

14GA) SP1066

21(RD-

14GA) SP1067

8(RD-

14GA) SP1068A

SPL-8

9(RD-

14GA) SP1069

70 70 SP1079 (GY-18GA)

38(GY-

18GA) SP1079

85 85

84 84

3623

(YW-18GA) SP1087

(DKG

N-18GA) SP1086

SP1087 (YW-18GA)

SP1086 (DKGN-18GA)

91 91

92 92

93 93

80 80

SP1076 (YW-18GA)

SP1077 (DKGN-18GA)

SP1078 (RD-18GA)

SP1080 (PE-18GA)

(YW-18GA) SP1076

(DKG

N-18GA) SP1077

(RD-

18GA) SP1078

(PE-

18GA) SP1080

278153

35

71 71

22(BK-

18GA) SP108

SP108 (BK-18GA)

SP107 (RD-18GA)86 86

(YW-14GA) SP044

10 5 6

(DKGN-14GA) SP045

SP044 (YW-14GA)

SP045 (DKG

N-14GA)

3086-GG5CAB HARNESS

23

88

HEADLIGHT SWITCH

SP006DA (BK-16GA)

SP1080 (PE-18GA)

SP1079 (GY-18GA)

SP006DA (BK-18GA)

SP006D (BK-16GA)

3

2

6

5

90(YW-18GA) SP1076

(DKGN-18GA) SP1077

(RD-18GA) SP1078

(PE-18GA) SP1080

(BK-18GA) SP108

(DKGN-18GA) SP1086

(YW-18GA) SP1087

(GY-18GA) SP1079

(BE-18GA) SP951

(BN-14GA) SP1053

(RD-16GA) SP107

97

10

52

412 5

AMETEK LMCINSTRUMENT PANEL

L TURN

TO

GAUG

E

R TURN

TO

GAUG

E

HIGH

BEAM TO

GAUG

E

(YW-18GA) SP1076

(DKG

N-18GA) SP1077

(RD-

18GA) SP1078

77

J

L

SP1086 (DKGN-18GA)

SP1087 (YW-18GA)

SWITCH

SP108 (BK-16GA)

SP107 (RD-16GA)

E SP951 (BE-18GA)

7SP1053 (BN-

14GA)

(BK-18GA) SP006DD

(BK-18GA) SP006DC

SP006DE (BK-16GA)(BK-18GA) SP006DD

LEFT TUR

N SIG

RIGH

T TURN

SIG

LEFT STOP TURN

RIGH

T STOP

/TUR

N

HIGH

BEAM

MRK

R LAMPS REAR

MRK

R LAMPS FRO

NT

HDLP L H

I BEAM

HDLP L LO

BEAM

HDLP R H

I BEAM

HDLP R LO

BEAM

FOG LAMPS LEFT

FOG LAMPS RIGHT

MRK

R LAMP SW

LEFT TUR

N

RIGH

T TURN

HDLP SW

HIGH

BEAM TO

GAUG

E

RIGH

T TURN

TO

GAUG

E

LEFT TUR

N TO GAUGE

FOG LAMPS

COLUMNHARNESS

LEFT

RIGHT

TURN SIGNAL SWITCH

71 YW F

13 GN L

12 RD

J

294 BK

G

HI/LO SWITCH

C

E

C

F

G

SP006G (BK-18GA)

SP006F (BK-18GA)

SP006J (BK 18GA)

SPL-16

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

OO

O

OO

OO

O OO

O

II

II

I

I

OO

OO

I

II

40 CAV 40 CAV

102 CAV 102 CAV

14 CAV

15 CAV

30 CAV

16 CAV

53GY


11

SP047A (DKGN-10GA)

SP048A (YW-10GA)

SP1054A (BN-10GA)

SEEPAGE 2

14 CAV

SP226A (DKGN-14GA)

SP227A (YW-14GA)3

6

2

5

MEMORYINTERFACE

RIGH

T TURN

SIG

LEFT TUR

N SIG

MRK

R LTS FRNT

83 SP1063 (GY-18GA)

19(GY-

18GA) SP1063

ICC B

LINK


8814 CAV 14 CAV

SP044 (YW-14GA)

SP045 (DKGN-14GA)

SP1067 (RD-14GA)

SP1069 (RD-14GA)

SP1068 (RD-14GA)

SP1064 (RD-14GA)

SP1066 (RD-14GA)

SP1065 (RD-14GA)

SP1053A (BN-14GA)7

12

5

4

6

13

10

11

3

(RD-14GA) SP1069

(RD-14GA) SP1068

(DKGN-14GA) SP045

(RD-14GA) SP1067

(YW-14GA) SP044

(RD-14GA) SP1064

(BN-14GA) SP1053B

(RD-14GA) SP1066

(RD-14GA) SP1065

7

12

5

4

6

13

10

11

3

SIDE HEADLAMP

(RD-14GA) SP1069

(RD-14GA) SP1067

HDLP R HI BEAM

HDLP R LO BEAM7

5

28

MARKR LTS FRNT3(BN-14GA) SP1053R

RIGHT TURN SIG2(DKGN-14GA) SP045

10 CAV PASSENGER'S

(LEFT) HEADLAMP

(RD-14GA) SP1064

(RD-14GA) SP1065

HDLP L HI BEAM

HDLP L LO BEAM6

5

25

MRKR LTS FRNT3(BN-14GA) SP1053L

LEFT TURN SIG2(YW-14GA) SP044

10 CAV DRIVER'S SIDE

(RD-14GA) SP1066FOG LT RIGHT

6

(RD-14GA) SP1068FROG LT LEFT

7

SPL-3

SPL-32

SPL-33

MARKERFLASH

1 SP1063A (GY-18GA)

35A 2 CAV

ICC BLINK

1 SP1063B (GY-18GA)

35B 2 CAV

ICC BLINK

BLUNTWIRES

1

35C 2 CAV

ICC BLINK

83(GY-18GA) SP1063A

CAP

SP1063B (GY-18GA)

MARKERFLASH

SPL-16

SP006DB (BK-16GA)

FOG LAMP(BK-16GA) SP006DE

DIMMERCONTROLLER

2

89 8 CAV

COMMON GROUNDSP006DC (BK-18GA)

SP006DB (BK-16GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

96LT GN 7 39 4 10 8

(BN-

18GA) SP1054

(YW-18GA) SP1091

(DKG

N-18GA) SP1090

(BN-

14GA) SP766

(DKG

N-14GA) SP1088

(YW-14GA) SP1089 3064-GG5

BACKBONE HARNESS

2961-GG5-003BUSSMANN82

GY

B

A

79BE

(YW-18GA) SP1091

H

G

(DKGN-14GA) SP1088

(YW-14GA) SP1089

(DKGN-18GA) SP1090

C(BN-18GA) SP1054

B(BN-14GA) SP766

87

86

30

85

STOP/TURNTRLR RIGHT

TRLR RIGHTSTOP/TURN

7.5A

87

86

30

85

STOP/TURNTRLR LEFT

TRLR LEFTSTOP/TURN

7.5A

TRAILERMRKR LTS

15A

87

86

30

85

TRAILERMRKR LTS

C

77GY

(RD-10GA) SP184BSEEBATTERYPOWER

E(BK-18GA) SP006D

10 CAV


96LT GN

SP047A (DKGN-10GA)

SPL-4

SP048A (YW-10GA)

SPL-5

SP1054A (BN-10GA)SPL-3

32

RIGHT TURN REAR8

CONNECTORTAIL LIGHT

(DKGN-10GA) SP047B

49

LEFT MARKER LIGHTS

50

RIGHT MARKER LIGHTS

C(BN-18GA) SP1054B MRKR LIGHTS REAR

C(BN-18GA) SP1054CMRKR LIGHTS REAR

LEFT TURN REAR14(YW-10GA) SP048B

MRKR LIGHTS REAR3(BN-10GA) SP1054D

SP1054E (BN-

18GA)

SP1091 (YW-18GA)

SP1090 (DK

GN-18GA)

27

TOW PLUGTRLR MARKER LTF(BN-12GA) SP766

SP766 (BN-

12GA)

4 10

SEEPAGE 1

10 CAV

3 CAV

3 CAV

14 CAV

7 CAV

D

G

SP1089 (YW-12GA)

SP1088 (YW-12GA)

(YW-12GA) SP1089

(YW-12GA) SP1088 TRLR R STP/TRN OR TR

TRLR R STP/TRN OR TR

ALEFT TURN REAR

(BN-18GA) SP048C

A(DKGN-18GA) SP047C RIGHT TURN REAR

SP226A (DKGN-14GA)

SP227A (YW-14GA)

RIGHT STOP/ TURN1(DKGN-14GA) SP226B

7(YW-14GA) SP227B LEFT STOP/ TURN

SPL-6

SPL-7

7 39 8

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG53060-GG5

MAIN CHASSIS

66

1166 SP051A (GY-18GA)

72 72 SP122 (BK-14GA)

100 100 SP1093 (PK-14GA)SPARTAN CONTROL MODULEINTERFACE P2 KEYING B

HORN BUTTON 39

B2SP051 (GY-18GA)

2

8

(GY-18GA) SP051

(BK-14GA) SP122

SP122 (BK-14GA)

(PK-14GA) SP1093C

SPL-2

SP1093A (PK-16GA)6HORN OUTPUT

SP1093B (PK-16GA)8

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

O

I

40 CAV

14 CAVBK

102 CAV 102 CAV


8BK

14 CAV

2

8(PK-16GA) SP1093A

(BK-14GA) SP122

POWER 5A

HOLE SOLENOID A SP122 (BK-14GA)

1 CAV

POWER 43

HORN OUTPUT A SP1093A (PK-16GA)

2 CAV

42

HORN OUTPUT 1 SP1093B (PK-16GA)

1 CAV

AIR HORN

AIR

SP1093B (PK-16GA)

POWERHORN

COLUMN

77

HORN BUTTONB(GY-18GA) SP051B

16 CAV

A

75A6(GY-18GA) SP051C

15 CAV

30

HORN OUTPUTA(PK-14GA) SP1093

1 CAV

CUSTOMER

33

HORN SOLENOIDA(PK-14GA) SP122

1 CAV

HORN BUTTON

HORN

HORNAIR

SPL-15

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

1


2

4

6

98

(PK-18GA) SP056

(RD-14GA) SP053

(YW-18GA) AT163

(PK-16GA) SP055B

START

IGN

G-2

IGN

SOL

ACC

BAT

G-1

ACC

KEY SWITCH

6

SP053 (RD-14GA)

SP054 (PK-16GA)

SP055 (PK-14GA)

SP056 (PK-14GA) (PK-14GA) SP056

(RD-14GA) SP053

(PK-14GA) SP055

N SP056 (PK-18GA)N

SP053 (RD-14GA)LL

SP055A (PK-16GA)M

2

M

1

31

1

SP055C (PK-16GA)

3086-GG5CAB HARNESS

3093-GG5START/RUN

SPL-34


(PK-16GA) SP055A 31

DD AT163 (YW-18GA)

AT163 (YW-18GA)

SHIFT PADTO TRANS

IGNITION

SIG

122

(YW-18GA) AT163

1

3

5

2

IGN

SWITCH

28

B2

INTERFACE P2 KEYING BSPARTAN CONTROL MOD.

(PK-

16GA) SP055D

2323(PK-16GA) SP054A SP054C (PK-16GA)

SPL-18

ACCESSORY SWITCH

18(PK-

16GA) SP054B

QQ SP054A (PK-16GA)(PK-16GA) SP054 13

14

(GY-18GA) SP681

SP681 (GY-18GA)

1

SEEPAGE 2

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

97

SP073

(RD-10GA)

(RD-16GA)

START SOLENOID

A

+S-

A

(RD-

16GA)

36

BATTERY CABLE

SP183A

61A

+

SP073A

-

A

(RD-10GA) SP183A A

20A

DISCONNECT

+

BATTERY CABLE

BATTERY CABLE

B

A-

A

(RD-8GA)

28

50A

COMMON PWR

64

SP184D A

63B

BATTERY CABLE

SP183BB (RD-10GA)

(PK-18GA)SP056

SP053 (RD-14GA)

SP055 (PK-18GA)

(RD-8GA)

64

SP184E

98

(RD-

10GA)SP183B

(RD-

8GA)

SP184E

+-

A

BATTERY CABLE

TO (+) PASSBATTERY CABLE

BATTERY CABLE

AT163D (YW-18GA)

(RD-16GA) SP073

(RD-14GA) SP053

(BK-

18GA) SP006D

(YW-18GA) AT163A63 AT163A (YW-18GA)

84

IGNITION SIGNAL

TCM INTERFACE AT163D(YW-18GA)

30

2727



C76 C

F

71

E79

81

G

H

BK

RD

C

G(PK-18GA) SP056

FSP055

(PK-

18GA)

78

SOURCE

F

45(PK-18GA) EN439

24

CLEAN IGN

ENGINEECM

(PK-18GA) EN439

2(PK-18GA) EN1004 STARTER LOCKOUT

C(PK-18GA) EN1004

73BK

BE

BN

BK

DPLUG

KEYSWITCHBATTERY

15A

H

NEUTRAL SAFTEY87

86

30

85

BSEENEUTRAL

STR LOCKOUT

85

86

3087A

87

F

72

D

GN

START SOLENOID87

86

30

85

STARTERSOLENOID

10A87

86

30

85

ENG/TRANS IGN

ABS

85

86

3087A

87

87

86

30

85

INDICATIONENG RUN

C

(TN-18GA) AT141

SHIFTSEL IGN

2ATCM IGN

10AECM IGN

5A

(GY-18GA) SP681

PLUG(BK-18GA) EN1005

(BK-18GA) EN066A 44 ECM RET GEN F

SP681 (GY-18GA)

NL

SIGNAL


SEE ABS

THROUGH STUD

BREAKER

150A

97BK

SPL-16

PLUG

I

14-CAV

14-CAV

80-CAV

60-CAV

NL

BK

14-CAV

14-CAV

1

2

4

6

13

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

3086-GG5CAB HARNESS

(PK-16GA) SP055A

9 15 23 16

F

14

19

(PK-16GA) SP054A

(PK-

16GA) SP054C

(PK-

18GA) SP055B

(PK-

18GA) SP055C


TRW IGNITION1

71A

(PK-18GA) SP904 TRW POWERCOLUMN

10(PK-

18GA) SP904

SPL-19

30A

STEER COLUMN

3A

87 30

86

85

ACC RLY 2

87 30

86

85

IGN RLY 187 30

86

85

IGN RLY 2

87 30

86

85

ACC RLY 1

87 30

86

85

CLEAN IGN

IGN POWERTO FUSES

SEE

ACC POWERTO FUSES

SEE

SPD LOCKOUT (-)

86

85

3087

P SP183 (RD-10GA)

CLEANPOWER

SEE

PAGE 1SEE

13

V

1224

JR/COMPASS

5A

3

TIRE PRESS

3A

21

ASR

3A

6 812

A

(GY-

16GA) SP137

(OE-

18GA) SP1094B

(RD-

18GA) SP460

(PK-

16GA) SP970

(PK-

18GA) SP969

(BK-

16GA) SP185C

SP020A (RD-14GA)

SP006F (BK-14GA)

INSTRUMENTPOWER

SEE

SEE

INSTRMNT PWR

10A

PRK BRK/SEE

TRANSMISSIONECU

INSTRUMENTPOWER

SEE

TIRE PRESSURE/ASR

SEE

BRAKE SIG

3A

2

GAUGES

3A

(RD-

18GA) SP632

INSTRUMENTPOWER

SEE

4

WIPER

86

85

3087

20A

WIPERBREAKER

BATTERYSEE

POWER

(PK-

16GA) SP054B

S

SPL-21

SP094A (RD-14GA)WIPERSEE

10 CAVLVL CNTRL

CUST IGN

CUST IGNITION9

75A

CUSTOMER B

15 CAV

SP191A (RD-12GA) (RD-12GA) SP191A

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

3086-GG5CAB HARNESS 2969-GG5-001

FRONT PDC ASSY.

IGN 1

30

IGN 2

85

86

87

87

86

85

30

7.5A

CUST IGN 2

25A

BLOWERH

14

J

13

30A

CUST IGN

30A

VAC PWR

20A

MST EJECT

25A

CNDSR

F

G

K

J

SP341(RD-14GA)

SP191A(RD-12GA)

SP105A(RD-12GA)

SP106A(RD-12GA)

(RD-10GA) SP066


17

SP341

SP105A

SP066

(RD-14GA)

(RD-

12GA)

(RD-10GA)

14

3

6

CONDENSER15

BLWR MTR PWR

FAN POWERBLUNT

SP106A

(RD-

12GA)

75

CUSTOMER B

SP191A

(RD-

12GA)

4CUST IGN

1

17

1

3

6SP066A(RD-10GA)


SP341(RD-16GA)

AVAC PUMP POWER

11

VACUUM POWER

SEEBATTERYPOWER

SEEIGN/START/CHARGE

102 CAV 102 CAV

15 CAV

21 CAV21 CAV

SP341 (RD-16GA)

SEE MOISTUREEJECTORS

PLUG

75A

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

INSTRUMENT (B+)

CLEAN GROUND

JACK DWN WRNG 15

13

14

AMETEK LMC

6

COMMON GROUND

DSH LMP PWR

INSTR PWR

PARK BRK LT

HIGH BEAM TO GAUGE

10

12

9

7

R TURN TO GAUGE

L TURN TO GAUGE 5

4

52

SP883A (TN-18GA)

SP632 (RD-18GA)

SP185AA (BK-18GA)

SP009BC (RD-18GA)

SP020C (RD-18GA)

SP1078 (RD-18GA)

SP068D (GY-18GA)

SP006AB (BK-18GA)

SP1076B (YW-18GA)

SP1077B (DKGN-18GA)

SP882A (TN-18GA)16ANT UP WRNG

SP209D (PK-18GA)J1587 POS 27

SP270 (BK-18GA)

SP388 (WE-18GA)

SP040 (TN-18GA)22

25

26INSTR GND

FUEL SNDR SIG

EXTERIOR TEMP

SP1188D (DKGN-18GA)

SP1187D (YW-18GA)

SP210D (GY-18GA)

J1939-15 NEG

J1939-15 POS

J1587 NEG 28

30

29

MODULECOMPASS

2

COMPASS MODULE IGN

CLEAN GND B

A SP969 (PK-16GA)

SP185 (BK-18GA)

SP209 (PK-16GA)CJ1587 POS


CUSTOMER A

75A

ANT UP WRNG

JACK DWN WRNG 11

10 SP882A (TN-18GA)

SP883B (TN-16GA)

TURN/MRKRSEE HDLP/

SEE

SEE PARK BRAKE/LEVEL CONTROL

DIAGNOSTICSSEE DATALINK/

SPL-54

SEE CUSTOMERCONNECTORS

C

D SP210E (GY-18GA)

SP209E (PK-18GA)

A

B SP185J (BK-18GA)

SP969 (PK-18GA)

69A

DIAGNOSTICSDATALINK/

SEEC

B

A

50

DDJ1587 NEG SP210 (PK-16GA)

COMPASS MODULE HARNESS2689-GG5-013

INSTRUMENT PANEL

SP883C (TN-18GA)

A

13


(RD-14GA) SP020A

2

15(RD-18GA) SP632

(TN-18GA) SP040 22

1

CAB HARNESS3086-GG5

(BK-18GA) SP270

(WE-18GA) SP388 45

27

22

45

27

12

16(PK-18GA) SP969

18 18

24(PK-16GA) SP970

(PK-16GA) SP970

JR/COMPASS

5A

INSTR PWR

10A

BRK SIG

3A

SEECLEAN

1

SP040 (TN-18GA)

SP270A (BK-14GA)

SP388 (WE-18GA)

SP970 (PK-16GA)

FUEL SENDER

32

AMBIENTTEMP SENSOR(WE-18GA) SP388 A

(BK-18GA) SP270E B

EXTERIOR TEMP

16

21

SPL-20

SP270D (BK-18GA)

INSTRUMENT GND

(TN-18GA) SP040

J1587 NEG

J1587 POSC

D(GY-18GA) SP210B

(PK-18GA) SP209B

CLEAN GND

JUNIOR MODULE IGNA

B(BK-16GA) SP185J

(PK-16GA) SP970

3

SENDER

DIAGNOSTICSDATALINK/

SEE

AIRJUNIOR

(TN-18GA) AT125A 13 13


2

97 97

AT125 (TN-18GA)

(TN-18GA) AT125 TCM INTERFACE

84

SPEEDOMETER SIG252 (TN-18GA) AT125AT125 (TN-18GA)

POWER

BK BK

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

PLUG23STR WHL EFFORT CNTRL

I

I

I

I

I

I

102 CAV102 CAV

6 CAV

2 CAV

14 CAV14 CAV 80 CAV

15 CAV

30 CAV

4 CAV4 CAV

TRIPCOMPUTER(RD-16GA) SP582 B

(RD-18GA) SP020 C

ROAD RELAY B (+)

36

INSTRUMENT PWR

5 CAV

STEP PWR

5A

GAUGES

3A

T(RD-18GA) SP025

3(RD-16GA) SP582

SPL-31

BACKLIGHTING

(RD-18GA) SP025 59 59 PLUG

SPEEDOMTER SIG 4 AT125A (TN-18GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

COMMON GROUND 2MST EJT PWR

141 SP066C (RD-14GA)

SP006E (BK-14GA)


EJECTOR

6 6(RD-10GA) SP066A

20A

MST EJECTSEE IGN POWERSP066 (RD-14GA)

TO FUSES

MST EJT PWR

COMMON GROUND 2

1

13

SP006D (BK-14GA)

SP066B (RD-14GA)

COMMON GROUND

MST EJT PWR2

1

15SP066D (RD-14GA)

SP006F (BK-14GA)

MOISTURE

MOISTUREEJECTOR

EJECTORMOISTURE

SPL-39

14J

3086-GG5CAB HARNESS

1 1


(RD-14GA) SP066

102 CAV 102 CAV

2 CAV

2 CAV

2 CAV

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG5

10

NEUTRAL SIG POS 1

39A

CONTROLJACK SP878B (PK-18GA) 11(PK-18GA) SP878B


56

156

1

(PK-18GA) SP878A

(PK-18GA) SP878A

57

SP878 (PK-18GA)

SP879 (GY-18GA)NEUTRAL SIG POS39

A1

SPARTAN CONTROL MODULEINTERFACE P1 KEYING A31 NEUTRAL SIG NEG

(PK-18GA) SP878

(GY-18GA) SP879


84

ECUTRANSMISSION

71 NEU SFTY87

86

30

85

BN

(TN-18GA)

SP056(PK-18GA)

B

G

AT141

41AT141 (TN-

18GA)

NEUTRAL START

SEEIGN/START/CHARGE


79BE

E(BK-18GA) SP006D

2

982

98SP056 (PK-18GA)SP056(PK-18GA)

RUN/START3093-GG5

N

2N

1SP056 (PK-18GA)SP056 (PK-14GA)

START

IGN

G-2

IGN

SOL

ACC

BAT

G-1

ACC

KEY SWITCH

6

SP055

2

5

SP054 (PK-16GA)

SP053 (RD-14GA)

3

1 SEE IGN/START/CHARGE

(PK-14GA)

SEE ACCESSORYPOWER TO FUSES

SEE IGN/START/CHARGE I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

O

O

O


23 CAV

14 CAV 14 CAV

NLNL

23 CAV80 CAV

3 CAV 15 CAV

SP056

NEUTRAL SIG POS INTERFACEMEMORY

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

3086-GG5CAB HARNESS

SP086C (RD-14GA)

SP068K (GY-18GA)

3LEVEL CONT PWR

39A2

529 SP068D (GY-18GA)

AMETEK LMCINSTRUMENT PANEL

JACK CONTROLPARK BRK LIGHT

PARK BRK LIGHT

B SP068A (GY-18GA)A

50PARK BRAKE

SET(BK-18GA) SP006AA

SPL-28

CUSTOMERINTERFACE B

75A

PARK BRK LIGHT5 SP068B (GY-18GA)

SP185N (BK-18GA)

SP782 (YW-18GA)

ACLEAN GND

55ABSET RIDE HEIGHTHADLEY SET

RIDE HEIGHT

SPL-30

118A

8

1

2

14

12

11

10

4

3

5

6

(GY-18GA) SP068E

(YW-18GA) SP782

(RD-14GA) SP086B

(GY-16GA) SP137

(PK-14GA) SP356

(TN-16GA) SP883D

(BK-14GA) SP185M

(YW-18GA) SP1187B

(DKGN-18GA) SP1188B

(LTBE-16GA) SP149B

(LTGN-16GA) SP148B

10

SP068J (GY-18GA)

13 GSP356 (PK-

14GA)

DK GY

FRONT PDC ASSY2969-GG5-001

3

15

11JACK DWN WARNING

JACK DWN WARNINGSP883A (TN-18GA)

SP883B (TN-18GA)

16 8SP137 (GY-

16GA)

1 2AIR DU

MP

38

AIR FILL

SP149B

(LTBE-

16GA)

SP148B

(LTGN

-16GA)

AIR DUMP

DATALINK/SEE

DIAGNOSTICS

15A

JACKS

87

86

30

85

SPD LOCKOUT (-)

LVL CONTROL

10A6

SP1094B (OE-18GA)

15 12SP185C

(BK-

16GA)

OSP086A (RD-14GA)

SPL-20

SP1094A (OE-

18GA)

TRANSMISSIONSEE

ECU

SPL-36

781

7813060-GG5

MAIN CHASSIS

(GY-

18GA) SP068

SP068C

(GY-18GA)

PARK

BRAKE

SPARTAN CONTROL MODULE

B2

INTERFACE P2 KEYING B

SP068 (GY-

18GA)

34

POWER TO FUSESSEE ACCESSORY

POWERSEE BATTERY

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

I

I

I

I

I

I

102 CAV

102 CAV

40 CAV

4 CAV

3 CAV

30 CAV

15 CAV

2 CAV

14 CAV

15 CAV

HADLEY SLSINTERFACE

SET RIDE HT

PARK BRK LIGHT

ACC PWR TO LEVEL CON

LVL JACK CONT POS BA

JACK DOWN WARNING

SPEED SW NEG

CLEAN GND

J1939-15 POS

J1939-15 NEG

AIR FILL

AIR DUMP

PARK BRAKE LIGHTMEMORYINTERFACE

87

86

30

85

SPD LOCKOUT (+)

11146

SP1094C (OE-18GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

BLUNTSP751 (BE-16GA)

BLUNT(BE-16GA) SP751 AA

LPSIGNAL

3 10

24SP1032(YW-18GA)SPARE 2 (BLUNT)

3086-GG5CAB HARNESS

A

32 1

4

9

SP1035

SP1033(YW-14GA)

(YW-10GA)

POWERTOW VEHICLE

SP1033 (YW-14GA)A

SP1035 (YW-10GA)A

63

SPARE 3 (BLUNT)

SPARE 5 (BLUNT)

102SP1036(YW-14GA)SPARE 6 (BLUNT)

A

1


24

4

9

102

SP1032

SP1035

SP1033

SP1036

(YW-18GA)

(YW-14GA)

(YW-10GA)

(YW-14GA)

3064-GG5BACKBONE HARNESS

98 9814SP1032(YW-18GA)

53

14SP1035(YW-10GA)

13

3093-GG5RUN/START

14SP1031(YW-18GA)

AA2

1

SP1031

(YW-18GA)

9SP1036

(YW-14GA)

SPARE 6

MODULE INTERFACE

A1

P1 KEYING A

SP1033(YW-14GA)

SPARTAN CONTROL

24SP1037(YW-14GA) SPARE 7 MODULE INTERFACE

B2

P2 KEYING B

SPARTAN CONTROL

14SP1037(YW-14GA) SPARE 7 INTERFACE D

9FRONT HARNESS

14

14

SP1032

SP1031

(YW-18GA)

(YW-18GA)

(BLUNT) SPARE 1A

2

(BLUNT) SPARE 2B

4SP1034(YW-10GA)

9SP1034(YW-10GA) SPARE 4 INTERFACE A

8FRONT HARNESS

SP1031

(YW-18GA)

3 A


BLUNT SPARE

SPARE

GY

NOTE: LOCATED NEAR HARNESS BREAKOUT BEFOREDIAGNOSTIC CONNECTOR TUCKED IN HARNESS LOOM.

NOTE: LOCATED BEFORE TRANSMISSIONSHIFT PAD TUCKED IN LOOM.

NOTE: LOCATED IN CAB NEARENGINE BRAKE SWITCH.

NOTE: TAPED BACK WITH ELECTRONICBRAKE CONTROLLER.

97 97

102 CAV102 CAV

40 CAV

14 CAV

14 CAV

14 CAV

NL

BK BK

NL

14 CAV

14 CAV

14 CAV

BK

14 CAV

NL

40 CAV

23 CAV

23 CAV


53

14

13

4

SP1035

SP1033

(YW-10GA)

(YW-14GA)

SP1034 (YW-10GA)

(BLUNT) SPARE 5A1

GY

NOTE: TAPED BACK ON LOOM NEAR TOW PLUG.

A

28

14 CAV

(BLUNT) SPARE 3

SPARE 411 TAIL LIGHTCONNECTOR

32

SPARES

SP1034(YW-10GA)

SP1035

SP1033

(YW-10GA)

(YW-14GA)

(BLUNT) SPARE 1

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE


96

5 6 7 8 9 10

LT GN


1

53

3

6

1

10

B A

6STOP

PRESSURESWITCH

STOPBRAKE

7

B ASWITCH

GY

(RD-10GA) SP1081B

(YW-14GA) SP227

(DKGN-14GA) SP226

(BE-10GA) SP709

INTERFACE P2 KEYING BCONTROLLER MODULE

B2

31RIGHT STOP/TURN SP226 (DKGN-14GA)

INTERFACE P1 KEYING ACONTROLLER MODULE

A1

20LEFT STOP/TURN SP227 (YW-14GA)

CAB HARNESS3086-GG5

881

1

SP709 (BE-

10GA)

40 SP1081A (RD-14GA)

SPL-16

STOP LIGHTS

5858

SP1081C (RD-18GA)

29BRAKE SWITCH SP1096A (GY-18GA)

SP1096A (GY-18GA)(GY-18GA) SP1096B

(GY-18GA) SP1096B SP185L (BK-18GA)

(BE-

10GA) SP709A

(RD-

16GA) SP024A

SP024A (RD-16GA)

64A

55(RD-16GA) SP024B

64B

BLUNT

64C

BRAKE CONTROLLERELECTRONIC TRAILER

NOTE: CONNECT ITEM 64B TO ITEM 64A.

A

B/UP LT ACTIVECUSTOMER A 12 SP015A (PK-18GA)

75A

(PK-

18GA) SP015A

5353

SP015 (PK-

18GA)

30REVERSE LIGHTS SP015 (PK-18GA)

44BLUNT A SP709A (BE-10GA)(BE-10GA) SP709B

(YW-18GA) SP1091

(YW-14GA) SP1089

(DKG

N-18GA) SP1090

(DKG

N-14GA) SP1088

(PK-

14GA) SP015

(RD-

14GA) SP1085

(RD-

18GA) SP1081


(PK-14GA) SP015 C

82GY

H(DKGN-14GA) SP1088

B(DKGN-18GA) SP1090

G(YW-14GA) SP1089

A(RD-14GA) SP1085

A

D

79BE

(YW-18GA) SP1091

(RD-18GA) SP1081

15A

7.5A

STOP/TURNTRLR RIGHT

87

86

30

85

STOP/TURNTRLR RIGHT

87

86

30

85

STOP/TURNTRLR LEFT

87

86

30

85

WARNINGTRLR REV

STOP/TURN

7.5A

TRLR LEFT

B

C

TRLR MRKR LTS

15A

87

86

30

85

MRKR LTSTRAILER

D

F

E

C

77GY

(RD-10GA) SP184BSEEBATTERYPOWER

(TN-18GA) AT165

(BK-18GA) SP006D

(BN-18GA) SP1054

(BN-14GA) SP766

(PK-18GA) SP055SEE IGN/START/CHARGE

4

(BN-

18GA) SP1054

(BN-

14GA) SP766

3

REVERSE WARNING

TCM

65 84

AT165 (TN-

18GA)

INTERFACE

BK-UP ALARMREVERSE LTS,

TRLR & CHASSIS

F

COM

MON

GRO

UND

B/U

P ALARM

B ASP1092

SP006R

WARNING ALARMREVERSE

(BK-

18GA)

(OE-

18GA)

9

SP1092(OE-18GA)

NOTE: INSTALL ITEM 9A (CAP) TO ITEM 9.

SPARTAN CONTROLLER

SPARTAN CONTROLLER

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

O

O

O

O

I 14 CAV

40 CAV

40 CAV

102 CAV

102 CAV 10 CAV

80 CAV 2 CAV

7 8 9 10

10

43

3

6

53GY

14 CAV

SP1081 (RD-10GA)

SP709 (BE-10GA)

SP226A (DKGN-14GA)

SP227A (YW-14GA)

27

TOWPLUG

TAIL LIGHTCONNECTOR

32

BACK/UP LIGHT ACTIVE

STOP LIGHTS9

13

(RD-10GA) SP1081

(PK-14GA) SP015C

(PK-14GA) SP015D B/UP LT ACTIVEA

G TRLR L STP/TRN OR TR(YW-12GA) SP1089

(BE-10GA) SP709 TRAILER BRAKEC

(DKGN-12GA) SP1088 TRLR R STP/TRN OR TRD

F TRLR MRKR LT(BN-12GA) SP766

7

1(DKGN-14GA) SP226B

(YW-14GA) SP227B L STOP/TURN

R STOP/TURN

14 CAV

7 CAV

SP1054E (BN-

18GA)

SP766 (BN-

12GA)

SP1091 (YW-18GA)

SP1089 (YW-12GA)

SP1090 (DK

GN-

18GA)

SP1088 (DK

GN-12GA)

SP015A (PK

-14GA)

96LT GN

10 CAV

SEEHDLP/TURNMARKER

SPL-14

SPL-6

SPL-7

1


1

15 CAV

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

MAIN CHASSIS3060-GG5 3064-GG5

BACKBONE ENGINESTART/RUN3093-GG5

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

28

27

35

ENGINE ECM25

EN062 (BE-18GA)

EN058 (YW-18GA)

EN061 (OE-18GA)

EN059 (GY-18GA)

EN060 (BK-18GA) ACC RTN POSN SEN 1 RET

ACC RTN POSN SEN 1

ACC RTN POSN SEN 1 SCE

ACC RTN POSN SEN 2(BE-18GA) EN062 12

(GY-18GA) EN059

(BK-18GA) EN060

(YW-18GA) EN058

(OE-18GA) EN061

9

11

8

10

EN062 (BE-18GA)PP

O

U

G

T

EN061 (OE-18GA)

EN058 (YW-18GA)

EN059 (GY-18GA)

EN060 (BK-18GA)

U

O

G

T

1 297 97 24

EN061 (OE-18GA)

EN058 (YW-18GA)

EN059 (GY-18GA)

EN060 (BK-18GA)

(BK-18GA) EN063

(GY-18GA) EN059

(BK-18GA) EN060

(YW-18GA) EN058

(OE-18GA) EN061

SEE ENGINEECM/FAN

BK BK

(YW-18GA) EN058

(GY-18GA) EN059

(BK-18GA) EN060

(BE-18GA) EN062

BK BK

13

12

9

11

8

10

13

KK

(BK-18GA) EN063

EN063 (BK-18GA)(BE-18GA) EN062 22 ECM RETURN (SENSOR)

SPL-19

(BK-18GA) EN1010

EN063 (BK-18GA)

THROTTLE

A

C

B

4

CUMMINS

D

O

23 CAV23 CAV

14 CAV14 CAV 50 CAV

EN062 (BE-18GA)

EN063 (BK-18GA)

F

E

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

CAB HARNESS3086-GG5

16


21

3

ASR

3A

TIRE PRESS

3A

CLEANSEE

POWER

BACKLIGHTINGSEE


85(GY-18GA) SP201 3 ATC SW TO ECU

(RD-18GA) SP460


1 1 9826 26 5SP201 SP201(GY-18GA) 5(GY-18GA)

98(GY-18GA) SP201 ABSSP201 (GY-18GA)

102 CAV102 CAV 14 CAV 14 CAV

NL NL

12 CAV2

3

31

WABCO ASR

10 SP460 (RD-18GA)

SP201 (GY-18GA)

9

SP212 (GY-18GA)

(GY-18GA) SP212

(BK-18GA) SP185L

7(BK-18GA) SP006CE

(BK-18GA) SP006CD

8 SP009CD (RD-18GA)

SP009CE (RD-18GA)

(PK-18GA) SP968

42A 3 CAVMONITOR

TIRE PRESSURE

TIRE PRESSURE IGN

CLEAN GROUND

DSH LP PWR

A SP968 (PK-18GA)

B SP185K (BK-18GA)

C SP009BF (RD-18GA)

SPL-24

SPL-14

BACKLIGHTINGSEE

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

4

96

3064-GG5BACKBONE HARNESS

2

10

8

LT GN

7

3

9

(BN-18GA) SP1054

(YW-18GA) SP1091

(DKGN-18GA) SP1090

(BN-14GA) SP766

(DKGN-14GA) SP1088

(YW-14GA) SP1089


82GY

B

A

79BE

(YW-18GA) SP1091

H G

SP1088 (DK

GN-14GA)

SP1089 (YW-14GA)

SP1090 (DK

GN-18GA)

C(BN-18GA) SP1054

B(BN-14GA) SP766

87

86

30

85

STOP/TURNTRLR RIGHT

TRLR RIGHTSTOP/TURN

7.5A

87

86

30

85

STOP/TURNTRLR LEFT

TRLR LEFTSTOP/TURN

7.5A

TRAILERMRKR LTS

15A

87

86

30

85

TRAILERMRKR LTS

FCD

86

85

30 87

REV WARNINGTRAILER

BK-UP ALARM

15A

REVERSE LTS,TRLR & CHASSIS

E

F

72GN

E

SP972B(RD-12GA)

SP972A

(RD-

10GA)

30A

CHARGETRLR BATT

A

75GY

C(RD-8GA) SP183J

(RD-8GA) SP183H

SP1092 (OE-18GA)

SP015 (PK-

14GA)

AT165 (TN-

18GA)

(PK-18GA) SP055

(BK-18GA) SP006D

1(PK-14GA) SP015

AT165 (TN-18GA)65

84TCM INTERFACE

REVERSE WARNING

COMMON GROUND

B/UP ALARMB

A SP1092

SP006R

WARNING ALARMREVERSE

(BK-18GA)

(OE-18GA)

9

SEE CLEANPOWER


C SP184B (RD-10GA) SEEBATTERYPOWER

77GY

A

6(RD-14GA) SP1085

SP1085 (RD-14GA)

O = POSITIVE OUTPUT

O = NEGATIVE OUTPUT

I = POSITIVE INPUT

I = NEGATIVE INPUT

LEGEND

O

D(RD-18GA) SP1081

5SP1081(RD-18GA)

86

85

30 87

BRAKE

53GY

3060-GG5MAIN CHASSIS HARN

11(BN-10GA) SP1054B

1(RD-10GA) SP1081BSP1081C (RD-18GA)

10(BE-10GA) SP709SP709 (BE-10GA)

3086-GG5CAB HARNESS

58 58

8 8

1 1 SPL-17

A1

MRKR LIGHTS REAR1

SPARTAN CONTROL MOD.INTERFACE P1 KEYING A

(BN-18GA) SP1054ASMART WHEEL SWITCH33

75 75

(BN-18GA) SP1055

SP1055 (BN-18GA)

SPL-16

STOP LTS40(RD-14GA) SP1081A

(PK-16GA) SP024B

(BE-10GA) SP709

(BN-18GA) SP1055

33

4

5

6

4

5

6

SP709A (BE-10GA)

SP185G (BK-12GA)

SP024A (PK-16GA)

SP900A (PK-10GA)

ELECTRONIC TRAILERBRAKE CONTROLLER

NOTE: CONNECT ITEM 64B TO ITEM 64A

SP709B (BE-10GA)A (BE-10GA) SP709B

(PK-10GA) SP900B

(BK-12GA) SP185H

(PK-16GA) SP024B

64A64B

TRAILER BRAKE (BLUNT)

64C

BRAKE CNTRL (BLUNT)

CLEAN GROUND (BLUNT)

STP PRS SW1 (BLUNT)

SP900B (PK-10GA)

SP185H (BK-12GA)

SP024B (PK-16GA)

A

A

A

B

14SP900A (PK-10GA)

BRK CNTRL

30A

V


SP006F (BK-14GA)

P

77COLUMN

SMART WHEEL SW SP1055 (BN-18GA)

O

O

I


40 CAV

10 CAV

2 CAV

80 CAV

16 CAV

6 CAV16 CAV

4

2

8

7

3

9

1

11

1

10

10

96LT GN

53GY

10 CAV

14 CAV

SP1054A (BN-10GA)

SP1081 (RD-10GA)

SP709 (BE-10GA)

SP1054E (BN-18GA)

SP1091 (YW-18GA)

SP1090 (DKGN-18GA)

SP766 (BN-12GA)

SP1088 (DKGN-12GA)

SP1089 (YW-12GA)

SP972 (RD-10GA)

SP015A (PK-14GA)

SEE STOP/REV LIGHTS

SEE HDLP/TURN/MARKER LIGHTS

SEE HDLP/TURN/MARKER LIGHTS

27TOW POWER

TRAILER BRAKEC

7 CAV

TRLR L STP/TRN OR TRG

COMMON GROUNDB(BK-10GA) SP006K

(DKGN-12GA) SP1088

(YW-12GA) SP1089TRLR R STP/TRN OR TRD

SP972(RD-10GA)TRLR BATT CHARGEE

(PK-14GA) SP015DTRLR R STP/TRN OR TRA

(BE-10GA) SP709

(BN-12GA) SP766 FTRLR MARKER LIGHT

SPL-14PLUG

PLUG


SPL-60

SPL-16

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

97

2

7

6

3

5

D

E

C

2

E

D

C

BB

AT134 (YW-18GA)

AT169 (GY-16GA)

AT163 (YW-18GA)

AT110 (PK-16GA)

(YW-18GA) AT134

(GY-16GA) AT169

(YW-18GA) AT163

(PK-16GA) AT110

1(YW-18GA) AT134

(GY-18GA) AT169

(YW-18GA) AT163

(PK-18GA) AT110

TCM C

LEAN POW

ER

IGNITION

SIG

DIRECTION

AL SIGNAL

TCM C

LEAN GND

J1939-

15 N

EG

SHIFT PAD

2 131211 515

AT163 (YW-18GA)

AT110 (PK-

18GA)

SP1188B (DK

GN-18GA)

AT169 (GY-

18GA)

AT134 (YW-18GA)

TRANSMISSION

J1939-

15 POS

DSH

LP POW

ER3 8

SP009 (RD-

18GA)

SP1187B (YW-18GA)

DATALINK/DIAGNOSTIC

BACK-

3093-GG5START/RUN

1313 AT125 (TN-18GA)

1(TN-18GA) AT125

3086-GG5CAB HARNESS

75A

SPEEDOMETER SIGCUSTOMER A AT125 (TN-18GA)4

(TN-18GA) AT125


SEE

LIGHTING

SEE

16

8 SP137 (GY-16GA)87

86

30

85

SPD LOCKOUT (-)

6 SP1094B (OE-18GA)

1512(BK-18GA) SP185C

SPL-20

(OE-18GA) SP1094A

1

52

PRK BRK/SEE


START/SEE IGN/

CHARGE

BK

4(OE-18GA) AT105

52 AT105 (OE-18GA)

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

I

102 CAV102 CAV

14 CAV

23 CAV23 CAV

15 CAV

16 CAV

10

9

TCM CLEAN PWR

TCM CLEAN GND

28

8

84

39 ENGINE SPEED LOW

40

41

OUTPUT SPEED LOW

NEUTRAL START

25

34 DIRECTIONAL SIGNAL

SPEEDOMETER SIGNAL

59

60 OUTPUT SPEED HIGH

ENGINE SPEED HIGH

J1939 CAN POS

J1939 CAN NEG

TCM INTERFACE

(YW-20GA) AT128

(DKGN-20GA) AT108

(GY-18GA) AT109B

(PK-18GA) AT110B

(OE-18GA) AT139

(YW-18GA) AT134

(TN-18GA) AT125

(TN-18GA) AT141

(TN-18GA) AT159

(GN-18GA) AT140

(YW-18GA) AT160

(GY-18GA) AT169B

(YW-18GA) AT163A

TCM CLEAN GND

IGNITION SIG63

69

(TN-18GA) AT165 65 REVERSE WARNING

(PK-18GA) AT170BTCM CLEAN PWR70

12

11

SENSOR SUPPLY (+5VDC)

HSD1

31 HSD333

36PCS3

PCS1

16 OIL LEVEL SEN

51

52 PCS2

SS1

37 TORQUE CONVERTER CLUTCH

(OE-18GA) AT111

(PK-18GA) AT112

(YW-18GA) AT131

(BE-18GA) AT116

(OE-18GA) AT136

(WE-18GA) AT137

(WE-18GA) AT151

(YW-18GA) AT133

(GN-18GA) AT152

(TN-18GA) AT154

(WE-18GA) AT155SUMP TEMP SENSOR

PCS455

54

(GN-18GA) AT158 58 ANALOG GND(BE-18GA) AT174 74 MAIN MODE(YW-18GA) AT176 76 TRANS ID(GN-18GA) AT177

PS177

(YW-18GA) AT171 71 HSD2

PCS2

SUMP TEMP SENSOR

SS1

TORQUE CONVERTER CLUTCH

PCS3

PCS1

HSD3

OIL LEVEL SEN

SENSOR SUPPLY (+5VDC)

HSD1

INTERFACE

94

1

5

18

10

12

9

4

11

15

16

AT152 (GN-18GA)

AT154 (TN-18GA)

AT131 (YW-18GA)

AT136 (OE-18GA)

AT133 (YW-18GA)

AT137 (WE-18GA)

AT151 (WE-18GA)

AT111 (OE-18GA)

AT112 (PK-18GA)

AT116 (BE-18GA)

TRANSMISSION

PCS4

ANALOG GNDAT158 (GN-18GA)19

2 AT155 (WE-18GA)

MAIN MODE8 AT174 (BE-18GA)

TRANS ID

HSD2

PS1AT177 (GN-18GA)3

6 AT171 (YW-18GA)

20 AT176 (YW-18GA)

SEE DATALINK/DIAGNOSTIC


A

ENGINE

AT159 (TN-

18GA)

AT160 (YW-18GA)

AT140 (GN-

18GA)

OUTPUT SPEED LOW

OUTPUT SPEED H

IGH

OUTPUTSPEED

A

93

B

AT139 (OE-

18GA)

ENGINE SPEED LOW

ENGINE SPEED H

IGH

SPEED

B

91

SEENEUTRAL SIGNAL

SEE STOP/REVERSE

SPL-48SPL-30

(GY-14GA) AT109A

SPL-49

(GY-14GA) AT169A(BK-14GA) SP185T

(BK-14GA) SP185U

(GY-16GA) AT169D

2

97

6

7

3

5

AT125 (TN-18GA)

AT134 (YW-18GA)

AT169D (GY-16GA)

AT163D (YW-16GA)

AT110D (PK-16GA)


20 TURBINE SPEED LOW80 TURBINE SPEED HIGH

(BE-18GA) AT120

(OE-18GA) AT180

18 FILTER MONITOR(OE-18GA) AT118

FILTER MONITOR17 AT118 (OE-18GA)

AT110A (PK-12GA)G

79BE

AT170A (PK-12GA)H10A

TCM BATT

E

F

AT163A (YW-18GA)G

81RD

H

D AT110D (PK-16GA)

AT163D (YW-16GA)

SP006D (BK-18GA)

EN439 (PK-18GA) SEE ENGINEECM/FAN

SP055 (PK-18GA)F SEE IGN/START/CHARGE

SP183B (RD-10GA)C

78BK

SEE CLEANPOWER

SP183J (RD-8GA)C

75GY

SEE CLEANPOWER

86

85

30 87

ENG/TRANS IGN

A SP183H (RD-8GA)

SPL-47

SPL-46

10A

SHIFT SEL BATT

5A

ECM IGN10A

TCM IGN2A

SHIFT SEL IGN

BK

13

14 AT120 (BE-18GA)

AT180 (OE-18GA)TURBINE SPEED LOW

TURBINE SPEED HIGH

I

I

O

O

O

O

O

O

O

O

O

O

O

O

O

I

I

I

10-CAV

20-CAV 80-CAV

SENSORSENSOR

2-CAV 2-CAV

PLUG

LVL CNTRL6

14

11

87

86

30

85

SPD LOCKOUT (+)

SP1094C (OE-18GA)

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

C

77

E

F

G

J

L

SP006G (BK-18GA)

SP951 (BE-18GA)

SP006H (BK-18GA)

SP006J (BK 18GA)

SP1086 (DKGN-18GA)

SP1087 (YW-18GA)

SPL-16


1 1

SP951(BE-18GA)

SP1086(DKGN-18GA)

SP1087(YW-18GA)

SP1056(YW-18GA)

SP1055(BN-18GA)

89

84

85

76

75

89

84

85

76

75

61

62

61

62

SP551(RD-18GA)

SP586(BK-18GA)

SP551

SP586

SP1056

SP1055

SP1086

SP1087

SP951

(RD-18GA)

(BK-18GA)

(BE-18GA)

(DKGN-18GA)

(YW-18GA)

(BN-18GA)

(YW-18GA)

STEERING

WHL GRO

UND

21

SPARTAN CONTROL MOD.INTERFACE P1 KEYING A

SP586

(BK-

18GA)

SP551

(RD-

18GA)

STEERING

WHL POW

ER32

HIGH

BEAM

33


A1

B2

RIGH

T TURN

23

LEFT TUR

N36

SP1086

SP1087

SP951

(BE-

18GA)

(DKG

N-18GA)

(YW-18GA)

STEER WHL B

NK VALUE

34STEER WHL SW VALUE

33

SP1056

SP1055

(YW-18GA)

(BN-

18GA)

TRW IGN

TRW POWER COLUMN

1

71A

10

16

SP904 (PK-18GA)

STR COLUMN

3A

SEECLEANPOWER

SP904(PK-18GA)


SPL-10SPL-9

J1939-15 NEGATIVE

J1939-15 POSITIVE3

2 SP1187K (YW-18GA)

SP1188K (DKGN-18GA)

A

RESISTOR

B

J1939 TERMINATING

76BA

B

76A(YW-18GA) SP1187L

(DKGN-18GA) SP1188L

SP1188J (DKGN-18GA)

SP1187J (YW-18GA)SEE

DATALINK/DIAGNOSTICS

27 27 (BK-14GA)SP270ASP270(BK-18GA) SEEINSTRUMENT

POWER

26

52

(BK-18GA) SP270

COLUMNHARNESS

LEFT

RIGHT

TURN SIGNAL SWITCH

71 YW F

13 GN L

12 RD

J

294 BK

G

HI/LO SWITCH

C

ESEE

CRUISECONTROL

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

IIOO

II

I

102 CAV102 CAV

40 CAV

40 CAV

30 CAV

3 CAV

16 CAV

3086-GG5CAB HARNESS

INSTRUMENT GROUND AMETEX LMCINSTRUMENT PANEL

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

(RD-16GA) SP098

(PE-14GA) SP095R

(RD-14GA) SP094R

(GY-14GA) SP096R

4

8

1

10

(PE-14GA) SP095L

(GY-14GA) SP096L

(RD-14GA) SP094L

9

3

9

2


NL

1

99 99

1

SP094R (RD-14GA)

SP094L (RD-14GA)

94 94

B2

(RD-

16GA) SP098

32WASHER

5(PE-

14GA) SP095L

WIPER LOW

95 SP095C (RD-14GA)

SPL-5

7WIPER LOW

(PE-

14GA) SP095A

96

SPL-6

SP096C (GY-14GA)

2010

(GY-

14GA) SP096B

(GY-

14GA) SP096A

WIPER H

IGH

WIPER H

IGH

2WIPER H

IGH

3WIPER H

IGH

SPL-7

(GY-

14GA) SP096E

(GY-

14GA) SP096D

16 13SP130 (BK-14GA) (BK-14GA) SP130

101 SP385C (GY-14GA) 12(GY-16GA) SP385B

37WIPER PARK

R

SPL-4

(GY-

16GA) SP385A

(GY-16GA) SP384 5

27WIPER PARK

L(GY-

16GA) SP384

79 79

12

SP1059 (PE-18GA)

(PE-

18GA) SP1059

AUTO W

IPER DISAB

LE

INTERFACE P2 KEYING BSPARTAN CONTROL MODULE

3086-GG5CAB HARNESS

(PE-18GA) SP1059

(RD-14GA) SP094R

(RD-14GA) SP094L

SPL-29

AUTO WIPER DISABLE (BLUNT)

65

A

DISABLE SWITCHAUTO WIPER

SP1059 (PE-18GA)

A SP006N (BK-18GA)

A SP009CG (RD-18GA)

COMMON GROUND (BLUNT)

DSH LP PWR (BLUNT)BACKLIGHTING

SEE

3326-GG5WIPER RELAY

1NL

14 CAV.

4

1

3

2

5

PLUG

PLUG

PLUG

PLUG

PLUG

SP098 (RD-16GA)

SP095A (PE-18GA)

SP096A (GY-18GA)

SP094A (RD-14GA)

SP384A (GY-16GA)

6 SP006A (BK-12GA)

SPL-3

(BK-10GA) SP006C 6

PLUG

PLUG

PLUG

PLUG

14 CAV.

I + INPUT

- INPUT

+ OUTPUT

- OUTPUT

O

I

O

LEGEND

O O O

I

O O O

O

I

I

102 CAV. 102 CAV.

40 CAV.

14


SP094A (RD-14GA)S

20A

WIPERBREAKER

86

85

30 87

WIPER

BATTERYSEE

POWER

15SP054B (PK-16GA)4

13SP006F (BK-14GA)V

IGN/START/SEE

CHARGE

87A

86

85

3087

87A

86

85

3087

3

4

RELAY BASEHIGH/LOW

RELAY BASELOW/PARK

ITEM 6 / DETAIL ASEALED RELAY/DIODE MODULE

PAGE 2SEE

2NL

14 CAV.

(BK-12GA) SP006B

(RD-16GA) SP098

(GY-12GA) SP384B

(RD-14GA) SP094B

(PE-12GA) SP095B

(GY-12GA) SP096B

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

2

6(BK-12GA) SP006B

14 CAV

4(RD-16GA) SP098

5(GY-12GA) SP384B

(RD-14GA) SP094B 1

(PE-12GA) SP095B 2

(GY-12GA) SP096B 3


3171-GG5WIPER RELAY

6

4

5

1

2

3

9 14 CAV

SP098 (RD-16GA)

SP094 (RD-14GA)

SP095 (PE-12GA)

SP096 (GY-14GA)

SP384 (GY-14GA)

SP006D (BK-12GA)

PAGE 1SEE

ASP098(RD-16GA) WASHER

3A40 CAV

2C

D

A

(GY-14GA) SP384

(RD-14GA) SP094

(PE-12GA) SP095

B(GY-14GA) SP096

SPL-1

WASHERMOTOR

WIPERMOTOR

WIPER PARK L

WIPER POWER

WIPER LOW

WIPER HIGH

5 CAV

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

- -

-

-30A SPST-

NO RLY

-

-

86

30 85

87

-

-5

-

-3

-

-VAR

-

-

5A SPDT RLY

-

-

-

8530

86 87

87a

-

-10A

-

--

-

-

8530

86 87

87a

-

--

-

-

8530

86 87

87a

-

--

-

86

30 85

87

- -

-

-

5A SPST-

NO RLY

-

-

86

30 85

87

3VAR

-

--

-

-

8530

86 87

87a

-

-

-

-

-

-35

-

-

- -

5A

3A

3A

3A

3A

3A

3A

10A

3A

30A

3A

3A 5A 5A

3A

5A

10A

5A

5A

1A 5A

3A

5A

1A 5A

1A 5A

5A

1A

1A

10A

1A

10A

5A SPDT RLY

5A SPDT RLY

5A SPST-

NO RLY

30A SPDT RLY

-

-30

-

-30

-

-30

30A

30A

30A

B+

GND

-

-3

3A

-

-3

3A 5A

1A

10A

J4/V

J2/10

J2/11

J2/13

J2/14

J1/1

J1/13

J2/3

J4/T

J2/2

J3/P

J1/22

J1/2

J1/24

J1/12

J1/3

J1/21

J1/10

J4/A

J2/12

J1/8

J1/6

J1/5

J1/17

J1/23

J2/9

J1/18

J2/5

J2/8

J1/15

J2/6

J1/11

J1/14

J1/4

J4/B

J1/7

J4/C

J4/D

J3/A

J3/B

J3/C

DIODE 1

DIODE 3

DIODE 2

FUSE 5

FUSE 6

FUSE 8

FUSE 9

FUSE 3

FUSE 2

FUSE 4

FUSE 1

FUSE 29

BREAKER 1

FUSE 30

FUSE 7

FUSE 36

RLY 1 RLY 2 RLY 3 RLY 4 RLY 5 RLY 6 RLY 7

-

-30

-

-VAR

-

--

-

86

30 85

87

-

-15

-

--

-

86

30 85

87

-

-VAR

30A

30A

30A

1A 30A

1A 15A

-

-70A SPST-

NO RLY

-

-

86

30 85

87

IGN RLY 1-

-70A SPST-

NO RLY

-

-

86

30 85

87

IGN RLY 2

-

-30

-

-20

-

-VAR

-

-30

-

-VAR

-

-10

-

-25

30A

30A

30A

20A

7.5A

10A

25A

-

-30A SPST-

NO RLY

-

-

86

30 85

87

ACC RLY 1-

-30A SPST-

NO RLY

-

-

86

30 85

87

ACC RLY 2

1A

-

-15

-

-10

-

-2

2A

15A

10A

-

-VAR

-

-10

-

-VAR

-

-30A SPST-

NO RLY

-

-

86

30 85

87

-

-VAR

10A

10A

20A

25A

25A

1A

-

--

-

86

30 85

87

-

-VAR

15A

1A 15A

1A

-

-VAR

-

-VAR

-

-VAR

15A

15A

15A

30A SPST-

NO RLY

30A SPST-

NO RLY

30A SPST-

NO RLY

-

-VAR

15A

15A

J4/E

J4/F

J4/G

J4/H

J3/D

J3/E

J4/J

J3/F

J3/G

J4/K

J3/H

J3/J

J3/K

J1/19

J2/1

J4/L

J4/M

J4/N

J4/O

J3/L

J3/M

J3/N

J1/9

J3/R

J2/4

J3/S

J4/P

J4/Q

J1/20

J4/R

J1/16

J2/7

J4/S

FUSE 24

FUSE 25

FUSE 28

FUSE 26

FUSE 17

FUSE 20

FUSE 21

FUSE 18

FUSE 19

FUSE 22

FUSE 23

FUSE 11

FUSE 12

FUSE 10

FUSE 13

FUSE 14

FUSE 15

FUSE 16 FUSE 27

FUSE 31

FUSE 32

FUSE 33

FUSE 34

RLY 10 RLY 12RLY 9RLY 11

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

LOADING continued...COMPONENT NUMBER AMPERAGE LABEL

FUSE 28 --- ---FUSE 29 30A CUST BATTFUSE 30 30A MEM 2FUSE 31 5A STEP PWRFUSE 32 15A PASS SEAT AIRFUSE 33 15A JACKSFUSE 34 15A MEM 1FUSE 35 --- ---FUSE 36 --- ---RELAY 1 CLEAN IGN CLEAN IGNRELAY 2 SPD LCKOUT (-) SPD LCKOUT (-)RELAY 3 --- ---RELAY 4 --- ---RELAY 5 --- ---RELAY 6 SPD LCKOUT (+) SPD LCKOUT (+)RELAY 7 --- ---RELAY 9 --- ---RELAY 10 WIPER WIPERRELAY 11 --- ---RELAY 12 --- ---

IGN RELAY 1 IGN RELAY 1 IGN RELAY 1IGN RELAY 2 IGN RELAY 2 IGN RELAY 2ACC RELAY 1 ACC RELAY 1 ACC RELAY 1ACC RELAY 2 ACC RELAY 2 ACC RELAY 2

CIRCUIT BREAKER 1 30A BRK CNTRLCIRCUIT BREAKER 2 20A WIPER

LOADINGCOMPONENT NUMBER AMPERAGE LABEL

DIODE 1 --- ---DIODE 2 --- ---DIODE 3 --- ---FUSE 1 5A TRIPTEKFUSE 2 3A BRK SIGFUSE 3 3A GAUGESFUSE 4 --- ---FUSE 5 5A JR/CMPSSFUSE 6 3A TIRE PRESSFUSE 7 3A ASRFUSE 8 3A STEER COLUMNFUSE 9 10A INSTR PWRFUSE 10 --- ---FUSE 11 --- ---FUSE 12 --- ---FUSE 13 10A CUST ACC 2FUSE 14 10A LVL CNTRLFUSE 15 20A CUST ACCFUSE 16 15A MEM 3FUSE 17 30A CUST IGNFUSE 18 30A VAC PWRFUSE 19 25A BLOWERFUSE 20 20A MST EJECTFUSE 21 7.5A CUST IGN 2FUSE 22 --- ---FUSE 23 25A CNDSRFUSE 24 30A DRV SEATFUSE 25 30A PAS SEATFUSE 27 15A DRV AIR

TOP VIEWBUS BAR

BUS BAR

FAN

RLY 11

RLY 10

RLY 7

ACC RLY 2

RLY12

IGN RLY 1

RLY 1

RLY 9

IGN RLY 2

ACC RLY 1

RLY 5

RLY 4

RLY 2

RLY 6

F29

F30

F31

F34

F24

F25

F27

F28

F16

BREAKER 2

F36

F4

F5

F6

F7

F8

F9F12

F11

F19

F20

F23

F3

F2

F22

F18

F17

F10

F13

F14

F15

BREAKER 1

F21RLY 3

F1

F33

F32

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

11B 4G

RELAY 2

LA4

ABS

LC4

MICRO-RELAY

LC3

LA3

MICRO-RELAY

RC5

RA5

2G1D1C

RC6

RB6

RA6

COOLING FANRELAY 7

CLEAN BATT PWR (+)

COMMON PWR (+)

CLEAN BATT PWR (+)

COMMON PWR (+)

8C

7C

6C

5C

F11

-LF3

LE3

12C

TRAILER

RELAY 10

LE6

REVERSE WARNING

LF6

MICRO-RELAY

LF5

LE5

86

30 85

87

F21

-LH6

LG6

9B9C

TRAILER

RELAY 3

LA6

MARKER LTS

LB6

MICRO-RELAY

LB5

LA5

86

30 85

87

F5 -LD7

LC7

12A9D

TRAILER

RELAY 4

LA8

BRAKE LTS

LB8

MICRO-RELAY

LB7

LA7

86

30 85

87

F6 -LD8

LC8

12G9A

TRAILER

RELAY 8

LC6

LEFT STOP/TURN

LD6

MICRO-RELAY

LD5

LC5

86

30 85

87

F22

-LH7

LG7

12H12B

TRAILER

RELAY 11

LE8

RIGHT STOP/TURN

LF8

MICRO-RELAY

LF7

LE7

86

30 85

87

F23

-LH8

LG8

12D12F 9H9G

LC1

LD1-

-F4

LC2

10E

LD2

11D

F9

LF1

LE1-

-F10

LF2

11C

LE2

4A

RB7

RA7-

-F2

RB8

4B

RA8

4C

RC7

RD7-

-F8

RC8

4E

RD8

4F4D11E

RELAY 1

LA2

ENG/TRANS IGN

LB2

MICRO-RELAY

LB1

LA1

86

30 85

87

F17

-LH1

LG1

NOTUSED

8530

86 87

87a

11A

F12

-LF4

LE4

12E

RE1 1K

LH5

LG5

11F

-LH2

LG2

11G

F19

-LH3

LG3

11H

F20

-LH4

LG4

RELAY 6

RA4

COOLING FAN

RB4

MICRO-RELAY

RB3

RA3

86

30 85

87 87

NOTUSED

86

87a

30 85

F15

-RF7

RE7

4H 2H

RELAY 5

RA2

AIR/WIF/GRID HTR/TAG

RC2

MICRO-RELAY

RC1

RA1

F16

-RF8

RE8

NOTUSED

8530

86 87

87a

2B

F26

RH7

RG7

2A

F27

-RH8

RG8

F13

RF1

RE1-

1F

RELAY 9

RC4

START SOLENOID

RC3

F25

-RH2

RG2

NEUTRAL

RELAY 14

RG4

SAFETY

RH4

MICRO-RELAY

RH3

RG3

86

30 85

87

1B1H 2D

87

NOTUSED

86

87a

30 85

2F

RD6

RF6

MICRO-RELAY

RF5

RD5

MICRO-RELAY

RE6 RB2

9F9E

86

30 85

87

STARTER

RELAY 13LOCKOUT

3C

F3 F1 F7

F18

1G

RG6

RH6

MICRO-RELAY

RH5

RG5

86

30 85

87

2C

RELAY 15ENG RUN INDICATION

1E

RELAY 12

RE3

A/C CLUTCH

RE2

F24

-RH1

RG1

MICRO-RELAY

86

30 85

87

1A

LB3

LB4

RD4RD3 RF3RF2

RB1

10F

CLEAN BATT PWR (+)5A

2E

RF4

RE4-F1

4

RD2

-

ORA

NGEBLUE

BROWN GREENX XX

GREYX XX

REDXX

YELLOW

R5 R7

R13

R6

R9

R12

R14 R15

F1 F2

F7 F8

F15 F16

F26 F27F24 F25F22 F23

F5 F6F3 F4

F11 F12F9 F10

RE1 F21F19 F20F17 F18

F13

R2

R1 R3 R4

R8

R10 R11

BLACK GREYBLACK GREY

BLAC

K

F14

R5 R7

R13

R6

R9

R12

R14 R15

F1 F2

F7 F8

F15 F16

F26 F27F24 F25F22 F23

F5 F6F3 F4

F11 F12F9 F10

RE1 F21F19 F20F17 F18

F13

R2

R1 R3 R4

R8

R10 R11 F14

1 2 3 4 5 6 7 8

A

B

C

D

E

F

G

H

1 2 3 4 5 6 7 8

A

B

C

D

E

F

G

H

RELAY AND FUSE GRID LOCATION EXAMPLEFUSE #5 IS LOCATED IN LC7 AND LD7.

RELAY AND FUSE GRID LOCATION EXAMPLEFUSE #24 IS LOCATED IN RG1 AND RH1.

DVEC

CONNECTOR NUMBER CONNECTOR COLOR

1 BROWN

2 GREEN

3 BLACK

4 ORANGE

5 GREY

6 BLACK

7 GREY

8 BLACK

9 BLUE

10 YELLOW

11 RED

12 GREY

L R

DRAWN BYENGINEER

CHECKED BY

REV. REVISIONS

PAGE


APPROVEDBY


DWG. NUMBER

TITLE

1 OF 1


CAGE CODE

DATE

2961-G

G5C-

001

LR-0

Bussm

ann

32179-0

15F13

F267.5

F247.5

F2510

F185

F1910

F202

RE1 F2115

F227.5

F237.5

R7

R13

R5R2 R6

R9

R12

R14 R15

15F11

10F12

R1 R3

R10 R11

R8F4(10)

F10(15)

F5(15)

F15(10)

30F8

10F16

10F3

10F9

1K

F14(30)

MINI-FUSES RELAYS

RELAYS

2961-GG5C-00132179-0 LR-0

RE1 - ABS (1K OHM 0.25 WATT)RESISTORS

F14 - TRLR BATT CHARGE (30A)

F4 - DATALINK BATT (10A)

F18 - ECM IGN (5A)

F24 - A/C CLUTCH (7.5A)

F8 - ECM BATT (30A)F7 - NOT USED

F2 - NOT USEDF1 - NOT USED

F10 - CAB INSTRUMENTATION BATT (15A)F9 - SHIFT SELECTOR BATT (10A)

F3 - TCM BATT (10A)

F23 - TRLR RIGHT STOP/TURN (7.5A)F22 - TRLR LEFT STOP/TURN (7.5A)

F6 - NOT USEDF5 - TRLR MRKR LTS (15A)

F27 - NOT USEDF26 - WIF (7.5A)

F16 - AIR DRYER (10A)

F25 - START SOLENOID (10A)

F15 - COOLING FAN CLUTCH (10A)

F20 - SHIFT SELECTOR IGN (2A)F19 - TCM IGN (10A)

F17 - NOT USED

F12 - ABS IGN (10A)F11 - ABS IGN (15A)

F13 - KEYSWITCH BATT (15A)

F21 - TRLR & CHASSIS REVERSE LTS, BK-UP ALARM (15A)

R8 - TRLR LEFT STOP/TURN

R15 - BATT BOOST

R11 - TRLR RIGHT STOP/TURN

R4 - NOT USED

R10 - TRLR & CHASSIS REVERSE LTS, BK-UP ALARM

R3 - TRLR MARKER LIGHTS

R5 - WIF/AIR DRYER

R9 - STARTER SOLENOID

R13 - STARTER LOCKOUTR14 - NEUTRAL SAFETY

R7 - COOLING FAN N.C.R6 - COOLING FAN N.O.

R1 - ENG/TRANS

R12 - A/C CLUTCH

R2 - ABS

ITEM: 71BUSSMANN BOX

32006-H22 (BROWN)

BUSSMANN

OPT: ALLMAP: E46

CAV CIRCUIT SIZE (mm²)

MAT. COLOR DESCRIPTION WIRES NOTE

A SP007A 0.8 GXL RD AC CLT SW PWR ---

B AT141 0.8 TXL TN NEUTRAL START ---

C SP053 2.0 GXL RD BATTPOS/IGN SW ---

D PLUG --- --- --- --- ---

E SP007B 1.0 GXL RD AC CLT SW PWR ---

F SP073 1.0 GXL RD STARTER SOL ---

G SP056 0.8 GXL PK START SIGNAL ---

H PLUG --- --- --- --- ---NOTES: 32006-TP2


32006-B22 (GRAY)

BUSSMANN

OPT: ALLMAP: D48



A SP1085 2.0 GXL RD TRLR STOP LT ---

B SP1090 0.8 GXL DKGN INPUT R STP/TRN OR T ---

C SP015 2.0 GXL PK B/UP LT ACTIVE ---

D AT165 0.8 TXL TN REVERSE WARNING ---

E SP515 0.8 GXL GN ABS BLINK IN ---

F SP1092 0.8 GXL OE B/UP ALARM ---

G SP1089 2.0 GXL YW TRLR L STP/TRN OR TR ---

H SP1088 2.0 GXL DKGN TRLR R STP/TRN OR TR ---

NOTES: 32006-TP2

ITEM: 81BUSSMANN BOX32006-F22 (RED)

BUSSMANN

OPT: ALLMAP: D49



A SP004A 2.0 GXL RD IGN TO ABS ECU ---

B SP004B 2.0 GXL RD IGN TO ABS ECU ---

C SP183P 5.0 TXL RD CLEAN PWR ---

D AT110D 1.0 GXL PK TCM CLEAN PWR ---

E PLUG --- --- --- --- ---

F EN439 0.8 GXL PK CLEAN IGN ---

G AT163A 0.8 TXL YW IGNITION SIG ---

H AT163D 0.8 GXL YW IGNITION SIG ---NOTES: 32006-TP2

ITEM: 75BUSSMANN BOX32004-B2 (GRAY)

BUSSMANN

OPT: ALLMAP: D43



A SP183H 8.0 GXL RD CLEAN PWR ---

C SP183J 8.0 GXL RD CLEAN PWR ---NOTES: 32004-TP2


32004-A2 (BLACK)

BUSSMANN

OPT: ALLMAP: D46



A PLUG --- --- --- --- ---

C SP184E 8.0 GXL RD BATTERY PWR ---NOTES: 32004-TP2

ITEM: 77BUSSMANN BOX32004-B2 (GRAY)

BUSSMANN

OPT: ALLMAP: D48



A PLUG --- --- --- --- ---

C SP184B 5.0 TXL RD BATTERY PWR ---NOTES: 32004-TP2


32006-D22 (BLUE)

BUSSMANN

OPT: ALLMAP: D51



A SP1091 0.8 GXL YW INPUT L STP/TRN OR T ---

B SP766 2.0 GXL BN TRLR MRKR LT ---

C SP1054 0.8 GXL BN MRKR LTS REAR ---

D SP1081 0.8 GXL RD STOP LTS ---

E SP006D 0.8 GXL BK COMMON GND ---

F SP055 0.8 GXL PK IGNITION SW ---

G AT110A 3.0 GXL PK TCM CLEAN PWR ---

H AT170A 3.0 GXL PK TCM CLEAN PWR ---NOTES: 32006-TP2


32006-E22 (YELLOW)

BUSSMANN

OPT: ALLMAP: D51



A PLUG --- --- --- --- ---

B PLUG --- --- --- --- ---

C PLUG --- --- --- --- ---

D PLUG --- --- --- --- ---

E SP528A 1.0 GXL RD DATALINK PWR ---

F SP528B 1.0 GXL RD DATALINK PWR ---

G PLUG --- --- --- --- ---

H PLUG --- --- --- --- ---NOTES: 32006-TP2


32006-A22 (BLACK)

BUSSMANN

OPT: ALLMAP: D43



A PLUG --- --- --- --- ---

B PLUG --- --- --- --- ---

C EN1004 0.8 GXL PK STARTER LOCKOUT TWP-38

D PLUG --- --- --- --- ---

E PLUG --- --- --- --- ---

F PLUG --- --- --- --- ---

G PLUG --- --- --- --- ---

H PLUG --- --- --- --- ---NOTES: 32006-TP2


32004-A2 (BLACK)

BUSSMANN

OPT: ALLMAP: C49



A PLUG --- --- --- --- ---

C SP183B 5.0 TXL RD CLEAN PWR ---NOTES: 32004-TP2


32006-G22 (ORANGE)

BUSSMANNOPT: -009, -010, -011, -012, -013, -014

MAP: D41CAV CIRCUIT SIZE

(mm²)MAT. COLOR DESCRIPTION WIRES NOTE

A PLUG --- --- --- --- ---

B PLUG --- --- --- --- ---

C PLUG --- --- --- --- ---

D PLUG --- --- --- --- ---

E EN240A 5.0 TXL RD BATT POS ---

F EN240B 5.0 TXL RD BATT POS ---

G EN998 0.8 GXL PK FAN CONTROL OUTPUT TWP-35

H EN999 0.8 GXL BK ECM RET GEN E TWP-35NOTES: 32006-TP2


32006-C22 (GREEN)

BUSSMANNOPT: -009, -010, -011, -012, -013, -014

MAP: D44CAV CIRCUIT SIZE

(mm²)MAT. COLOR DESCRIPTION WIRES NOTE

A PLUG --- --- --- --- ---

B PLUG --- --- --- --- ---

C SP681 0.8 GXL GY BATT BOOST ---

D PLUG --- --- --- --- ---

E SP972A 5.0 TXL RD TRLR BATT CHARGE ---

F EN1005 0.8 GXL BK ECM RET GEN F TWP-38

G SP571 0.8 GXL PK FAN ON/OFF ---

H SP011 1.0 GXL RD AIR DRYER PWR ---NOTES: 32006-TP2

Documents

4) SCHEMATICS...1) ABBREVIATIONS 2) WIRE LIST 3) SYMBOLS 4) SCHEMATICS MODULAR LAYOUT 0233-GG9-000 ABS 0233-GG9-002 ACCESSORY POWER TO FUSES 0233-GG9-004 ADJUSTABLE PEDALS 0233-GG9-006