20
COPYRIGHT by BRIGGS & STRATTON DAIHATSU LLC All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permission in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT. 2 OF SERVICE MANUAL 58A400 to 58A499 Illustrated Parts List Model Series 58A400 to 58A499 TURBO DIESEL TYPE NUMBERS 0205, 0209, 0210, 0231. TO FIND THE CORRECT NUMBER OF THE PART YOU NEED: FOLLOW THE INSTRUCTIONS BELOW A. Refer to Model, Type and Code Number that is located on the engine. Engine type numbers such as 0123 01 are listed only as 0123 in most instances. The two digits (01or 02, etc.) to the right of the space may be required for more accurate parts identification in some instances. Select the Illustrated Parts List covering the correct Model Series and Type Number. B. Refer to the Illustrations and compare the original part with Illustration. The number next to the illustration is the Reference Number. Assemblies include all parts shown in frames. All parts shown in assembly frames having individual reference numbers can be purchased separately. C. After the Reference Number has been identified, refer to the Numerical text, where Reference and Primary Part Number are listed. THE PRIMARY PART IS USED ON ALL TYPE NUMBERS EXCEPT THOSE TYPE NUMBERS UNDER “NOTE”. D. If a “Note” appears below the Primary Part Number, it means that this part differs from the Primary Part for certain types. If your Type number is listed under “Note”, order the part referred to at the “Note”. E. If your Engine Type Number does not appear after any part number listed under “Note”, use the Primary Part Number. F. For Engine Type Numbers not covered by this book, check other Parts Lists having the same engine model or contact your source of supply. G. REFER TO REPAIR MANUAL MS 1055 FOR ASSEMBLY AND/OR TORQUE REQUIREMENTS. PRINTED IN U.S.A.

58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

  • Upload
    buitram

  • View
    213

  • Download
    0

Embed Size (px)

Citation preview

Page 1: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

COPYRIGHT by BRIGGS & STRATTON DAIHATSU LLCAll rights reserved. No part of this material may be reproduced or transmitted,in any form or by any means, electronic or mechanical, including photocopying,recording or by any information storage and retrieval system, without permissionin writing from Briggs & Stratton DAIHATSU LLC.

FORM MS–5473–12/1/2003REPLACES FORM MS 5473 7/1/2003

FILE IN SECT. 2 OF SERVICE MANUAL

58A400 to 58A499

Illustrated Parts ListModel Series

58A400 to 58A499TURBO DIESEL

TYPE NUMBERS0205, 0209, 0210,

0231.

TO FINDTHE CORRECT NUMBER OF THE PART YOU NEED:

FOLLOW THE INSTRUCTIONS BELOW

A. Refer to Model, Type and Code Number that is located on the engine. Engine type numbers suchas 0123 01 are listed only as 0123 in most instances. The two digits (01or 02, etc.) to the right ofthe space may be required for more accurate parts identification in some instances.Select the Illustrated Parts List covering the correct Model Series and Type Number.

B. Refer to the Illustrations and compare the original part with Illustration. The number next to theillustration is the Reference Number. Assemblies include all parts shown in frames. All parts shownin assembly frames having individual reference numbers can be purchased separately.

C. After the Reference Number has been identified, refer to the Numerical text, where Reference andPrimary Part Number are listed. THE PRIMARY PART IS USED ON ALL TYPE NUMBERSEXCEPT THOSE TYPE NUMBERS UNDER “NOTE”.

D. If a “Note” appears below the Primary Part Number, it means that this part differs from the PrimaryPart for certain types. If your Type number is listed under “Note”, order the part referred to at the“Note”.

E. If your Engine Type Number does not appear after any part number listed under “Note”, use thePrimary Part Number.

F. For Engine Type Numbers not covered by this book, check other Parts Lists having the sameengine model or contact your source of supply.

G. REFER TO REPAIR MANUAL MS 1055 FOR ASSEMBLY AND/OR TORQUE REQUIREMENTS.

PRINTED IN U.S.A.

Page 2: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–2 Assemblies include all parts shown in frames. 12/1/20032

1300

415

1069

718

718A

718A 718B

713

1080

724

50820

1028

493

1027

718

1271

415A 415B 1262

493A

318693

239

525

292

1084

523890

525A

523A

524

1 825496 Cylinder Assembly20 �821073 Seal–Oil

(PTO Side)127 820004 Plug–Welch239 825000 Switch–Oil Pressure292 820662 Collar–Dipstick Tube318 820176 Screw

(Mounting Bracket)415 821069 Plug

(Camshaft)415A 820375 Plug

(Cylinder)415B 820182 Plug

(Cylinder)Used on Type No(s).0209.

493 820170 Bracket–Mounting493A 820147 Bracket–Mounting

508 820031 Screw(Seal Retainer)

523 820103 Dipstick523A 820643 Dipstick

Used on Type No(s).0231.

524 820654 Seal–Dipstick TubeUsed on Type No(s).0231.

525 820144 Tube–Dipstick525A 820666 Tube–Dipstick

Used on Type No(s).0231.

693 820373 Module–Pre Heat

713 820129 Bushing–Camshaft718 820063 Pin–Locating

718A 820062 Pin–Locating718B 820061 Pin–Locating

724 820146 Retainer–Seal890 820238 Bracket–Support

1027 820314 Filter–Oil1028 820851 Adapter–Oil Filter1069 820102 Nozzle–Oil1080 �820145 Gasket–Seal Retainer1084 825154 Connector–Terminal

(Oil Pressure Switch)1262 821009 Line–Water1300 820042 Screw

(CrankshaftBearing Cap)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 3: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–3 Assemblies include all parts shown in frames. 12/1/20033

598

26

718C653

10751072

1073

746

900

1076

1243

271355

23

27

25 29

161044

32

12421356

16 825494 Crankshaft23 825303 Flywheel25 825626 Piston Assembly

(Standard)––––––– Note –––––825628 PistonAssembly(.010” Oversize)

26 825512 Ring Set(Standard)––––––– Note –––––825514 Ring Set(.010” Oversize)

27 820926 Lock–Piston Pin29 825502 Rod–Connecting32 820928 Screw

(Connecting Rod)

598 820140 Shim–Endplay(Crankshaft) (Standard)––––––– Note –––––820139 Shim–Endplay(Crankshaft)(.005” Oversize)

653 820079 Screw(Crankshaft Pulley)

718C 820059 Pin–Locating746 820611 Gear–Idler900 820116 Shaft–Gear

1044 820080 Screw(Flywheel)

1072 820081 Screw(Idle Gear Plate)

1073 820117 Plate–Idle Gear1075 820236 Pulley–Crankshaft1076 820142 Bearing/STD–Rod1242 825504 Bearing Set/STD–Rod

(Standard)1243 825506 Bearing Set/010–Rod

(.010” Undersized)1355 825510 Bearing Set/STD–Main1356 825508 Bearing Set/010–Main

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 4: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–4 Assemblies include all parts shown in frames. 12/1/20034

7

13

127

773

1022

127A

812276

350

1130

151

215

1023

871

1077

151A

806

11

1054

5 825516 Head–Cylinder7 �∆820930 Gasket–Cylinder Head

11 820932 Tube–Breather13 820934 Screw

(Cylinder Head)(10 mm)

21 825024 Cap–Oil Fill127 820004 Plug–Welch

127A 820005 Plug–Welch

151 820997 Stud(Exhaust Manifold)

151A 820999 Stud(Exhaust Manifold)

276 �∆820064 Washer–Sealing(Rocker Cover)

350 820078 Stud(Water Pump)

773 820130 Retainer806 820212 Screw

(Lifting Bracket)

812 820071 Nut(Rocker Cover)

871 825030 Bushing–Valve Guide1022 �∆820150 Gasket–Rocker Cover1023 825088 Cover–Rocker1054 280275 Tie–Cable1077 820254 Bracket–LIfting1130 820015 Stud

(Intake Manifold)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 5: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–5 Assemblies include all parts shown in frames. 12/1/20035

1109

1109A

1109B

1166

11631164743

890

652A1111

1108

1106

267265

1107

1008

1105

813 1165

259

1110

652890A

1162

240A

241

1103

240

1084A

940

1084B

1084C

1112

12191220

187

377

187 825179 Line–Fuel240 825219 Filter–Fuel

240A 820311 Filter–Fuel(IncludesReference 1162)

241 820344 Cover–Fuel Filter(IncludesReference 1112)

259 820634 Bracket–Casing Clamp265 691024 Clamp–Casing267 820012 Screw

(Casing Clamp)377 821064 Key–Woodruff652 820593 Screw

(Support Bracket)652A 820272 Screw

(Support Bracket)743 820619 Gear–Drive

(Injection Pump)813 825197 Clamp890 820415 Bracket–Support

890A 820479 Bracket–Support

940 820640 Screw(Casing ClampBracket)

1008 820467 Clamp–Swivel1084A 825266 Connector–Terminal

(Injection Pump)1084B 825157 Connector–Terminal

(Fuel Filter)1084C 825156 Connector–Terminal

(Fuel Filter)1103 820347 Sensor–Fuel Filter

(IncludesReference 1162)

1105 825176 Plug–Glow1106 820409 Strap–Glow Plug1107 825178 Nozzle–Injector1108 820411 Seat–Injector

1109 825194 Pipe–Injector #11109A 825195 Pipe–Injector #21109B 825196 Pipe–Injector #3

1110 825606 Pump–Injection1111 820412 Pipe–Fuel Return1112 825198 Plug–Vent1162 820348 Seal–O Ring

(Fuel Filter Sensor)1163 820414 Seal–O Ring

(Injection Pump)(Shaft)

1164 820419 Nut(Injection Pump)

1165 820031 Screw(Clamp)

1166 820417 Nut(Injection Pump)

1219 820829 Nut(Injector Nozzle)

1220 820831 Washer(Injector Nozzle)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 6: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–6 Assemblies include all parts shown in frames. 12/1/20036

46

1074

1178371 1026

1029

1290

146

1030

773A

668

10601180

34

553

868

40

42

35

238

33

45

1179

773A

1014

192

1031

42A

36

773A

830

33 820404 Valve–Exhaust34 820403 Valve–Intake35 820406 Spring–Valve

(Intake)36 820406 Spring–Valve

(Exhaust)40 820111 Retainer–Valve42 825042 Keeper–Valve

(Contains 1 Set)42A 825082 Keeper–Valve

(Contains 6 Sets)45 820110 Tappet–Valve46 820936 Camshaft

146 691639 Key–Timing192 825041 Adjuster–Rocker Arm238 820113 Cap–Valve371 820613 Gear–Cam553 820112 Retainer–Valve Spring668 820065 Spacer

(Rocker Arm Shaft)773A 820003 Retainer

830 820076 Stud–Rocker Arm868 ∆820405 Seal–Valve

1014 820105 Screw(Rocker Arm Support)

1026 820422 Rod–Push1029 820387 Arm–Rocker

1030 820106 Support–Rocker Arm1031 825093 Shaft–Rocker Arm1060 820044 Spring–Rocker Shaft1074 820118 Retainer–Camshaft1178 820032 Screw

(Camshaft Retainer)1179 820177 Washer

(Rocker Arm Support)1180 820070 Nut

(Rocker Arm Support)1290 820075 Screw

(Cam Gear)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 7: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–7 Assemblies include all parts shown in frames. 12/1/20037

1039 952

941

1041

848 479

1017

818

276A

1078

1088

15

15 825278 Plug–Oil Drain(16 mm)

276A �820582 Washer–Sealing(Oil Drain Plug)(16 mm)

479 820034 Screw(Oil Pump Screen)

818 820016 Stud(Oil Pump Screen)

848 820069 Nut(Oil Pump Screen)

941 820017 Stud(Oil Pan)

952 820068 Nut(Oil Pan)

1017 825089 Screen–Oil Pump1039 820034 Screw

(Oil Pan)1041 �820104 Gasket–Oil Pump

Screen1078 �820137 Gasket–Oil Pan1088 825285 Pan–Oil

(Dual Drain)(16 mm)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 8: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–8 Assemblies include all parts shown in frames. 12/1/20038

3

88

85B

85B

85

85A

85B

1173

86

85A

1173

85

3 �821071 Seal–Oil(Magneto Side)

85 820425 Screw(Gear Cover to GearReduction Case)

85A 820029 Screw(Gear Cover to GearReduction Case)

85B 820027 Screw(Gear Cover to GearReduction Case)

86 825185 Cover–Gear88 �820377 Gasket–Gear

Reduction Cover1173 820069 Nut

(Gear Cover)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 9: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–9 Assemblies include all parts shown in frames. 12/1/20039

88

743A

1190

1191A

1189 1191

88A

249

1199115

1189A

88 �820377 Gasket–GearReduction Cover

88A �820155 Gasket–GearReduction Cover

115 825186 Housing–Gear249 825032 Valve–Pressure Relief

743A 820615 Gear–Drive(Gear Housing)

1189 820156 Stud(Gear Housing)

1189A 820016 Stud(Gear Housing)

1190 820180 Screw(Drive Gear)

1191 820030 Screw(Gear Housing)

1191A 820033 Screw(Gear Housing)

1199 820426 Stud(Injection Pump)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 10: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–10 Assemblies include all parts shown in frames. 12/1/200310

849

477

23A1096A

747A

1096

1096

718D

1089

1089

SAE

SAE 718D

1096

1044

1096

1047

HOUSING

1089

1010

FLYWHEEL1009

1009

1009

747 1096A

23A 825071 Flywheel477 820199 Screw

(Bearing Retainer)718D 820264 Pin–Locating

747 825098 Housing–Flywheel(KTR�)(Small Pilot, 2 Holes)––––––– Note –––––825113 Housing–Flywheel(KTR�)

747A 820248 Housing–Flywheel(SAE)

849 820212 Screw(Stub Shaft)

1009 820451 Screw(Starter Motor)(Mount Starter ToSAE Housings)––––––– Note –––––820265 Screw(Starter Motor)(Mount Starter toGeneral Housings)

1010 825079 Retainer–Bearing1044 820080 Screw

(Flywheel)

1047 825268 Shaft–Stub(1 1/8” Diameter Shaft)(3 3/4” Length)––––––– Note –––––825078 Shaft–Stub(1 7/16” DiameterShaft)825123 Shaft–Stub(1” Diameter Shaft)825269 Shaft–Stub(1 1/8” Diameter Shaft)(4 1/5” Length)

1089 820070 Nut(Flywheel Housing)

1096 820241 Screw(Flywheel Housing)

1096A 820450 Screw(Flywheel Housing)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 11: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–11 Assemblies include all parts shown in frames. 12/1/200311

1067

1187

11861188

1185

415C

1062

519

323

1063

415B

1062 1062

1193

1065

1065

368

1064

1084D

1087

1066

839

291

601A734

194 415D

601

601

1068B

1068A

601

1068

519

839A

668

194 825645 Radiator291 825064 Thermostat323 821075 Belt–Vee

(940 mm)368 820208 Switch–Water

Temperature415B 820182 Plug

(Water Pump)415C 820052 Plug

(Outlet Housing)415D 825075 Plug

(Radiator)519 820030 Screw

(Radiator Fan)Used on Type No(s).0209, 0210.––––––– Note –––––820034 Screw(Radiator Fan)Used on Type No(s).0205, 0231.

601 820256 Clamp–Hose601A 820201 Clamp–Hose668A 821218 Spacer

(Radiator Fan)734 820258 Cap–Radiator839 825446 Fan–Radiator

Used on Type No(s).0210.

839A 821013 Fan–RadiatorUsed on Type No(s).0205, 0231.

1062 �820093 Gasket–OutletHousing

1063 820095 Pulley–Pump1064 825519 Housing–Outlet1065 �820098 Gasket–Inlet Housing1066 825520 Housing–Inlet1067 �∆820100 Gasket–Water Pump

1068 825045 Hose/Clamp Assembly1068A 825557 Hose/Clamp Asembly1068B 825133 Hose/Clamp Asembly1084D 825160 Connector–Terminal

(Water TemperatureSwitch)

1087 825522 Pump–Water1185 820031 Screw

(Outlet Housing)1186 820022 Screw

(Water Pump)1187 820181 Nut

(Water Pump)1188 820031 Screw

(Inlet Housing)1193 820185 Screw

(Thermostat)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 12: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–12 Assemblies include all parts shown in frames. 12/1/200312

445

445

536

536A

582

1315

1315A

1315B

532A

493C

534

318B

253 1931237

10971068C

493B

532

318C

193 820597 Hose–Reserve Tank(660 mm Hose)

253 825462 Tank–Reserve318B 820212 Screw

(Mounting Bracket )318C 820034 Screw

(Mounting Bracket)445 820263 Filter–Air Cleaner

Cartridge493B 825106 Bracket–Mounting

(Reserve Tank)493C 820195 Bracket–Mounting

(Air Cleaner)532 820011 Nut

(Mounting Bracket)532A 820070 Nut

(Mounting Bracket)

534 820273 Screw(Air Cleaner)

536 825117 Cleaner–Air(With Vacuum Adaptor)

536A 825118 Cleaner–Air(90 Degree Elbow WithVacuum Adaptor)

582 820230 Clamp–Air Cleaner

1068C 825478 Hose/Clamp Assembly1097 820287 Cap–Surge Tank1237 825461 Cap/Hose–Reserve

(660 mm Hose)1315 820554 Adapter–Air Cleaner

(90 Degree)1315A 820555 Adapter–Air Cleaner

(Straight)1315B 820556 Adapter–Air Cleaner

(180 Degree)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 13: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–13 Assemblies include all parts shown in frames. 12/1/200313

883A

883

436

50

51

54A

54

1174

1174

1176

1177

855811

828

1068D

1260

1259

1281

962

601C

1261

1282

1258 864 264

1281

1289

1289A 1289B

1289C

415E

601D

918

1289A

962

1261

1289D

1177

883B

264A613

50 825530 Manifold–Intake51 �∆820407 Gasket–Intake54 820031 Screw

(Intake Manifold)54A 820408 Screw

(Intake Manifold)264 820969 Nut

(Muffler Adapter)264A 820178 Nut

(Muffler Adapter)415E 820995 Plug

436 825531 Manifold–Exhaust601C 820944 Clamp–Hose601D 820993 Clamp–Hose

613 820023 Screw(Muffler)

811 825533 Charger–Turbo828 825536 Pipe–Air Inlet

855 820942 Adapter–Air Cleaner864 825537 Adapter–Muffler883 �∆820817 Gasket–Exhaust

(Manifold)883A �820967 Gasket–Exhaust

(Turbo Charger)883B 821001 Gasket–Exhaust

918 825542 Hose–Vacuum962 820988 Gasket–Air Inlet Pipe

1068D 825543 Hose/Clamp Assembly1174 820069 Nut

(Intake Manifold)1176 820178 Nut

(Exhaust Manifold)1177 820178 Nut

(Muffler)1258 820990 Gasket–Muffler

Adapter

1259 825535 Pipe–Oil Outlet1260 820975 Seal–O Ring

(Oil Outlet Pipe)1261 820973 Gasket–Oil Outlet1281 820181 Nut

(Air Inlet Pipe)1282 820971 Screw

(Oil Outlet Pipe)1289 820981 Stud

(Turbo Charger)1289A 820553 Stud

(Turbo Charger)1289B 820983 Stud

(Turbo Charger)1289C 820985 Stud

(Turbo Charger)1289D 820982 Stud

(Turbo Charger)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 14: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–14 Assemblies include all parts shown in frames. 12/1/200314

1283 1284

1285

1268 276B

276C

1262A

601E

601E

698

1262B

656

601E

1286

1287

276B �820950 Washer–Sealing(Oil Inlet Pipe)

276C �820952 Washer–Sealing(Oil Inlet Pipe)

601E 820960 Clamp–Hose656 820962 Gasket–Water Pipe698 825558 Pipe–Water

1262A 825540 Line–Water1262B 825541 Line–Water

1268 825539 Pipe–Oil Inlet1283 820954 Screw

(Oil Inlet Pipe)1284 820948 Screw

(Oil Inlet Pipe)

1285 820023 Screw(Oil Inlet Pipe)

1286 820069 Nut(Water Pipe)

1287 820023 Screw(Water Pipe)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 15: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–15 Assemblies include all parts shown in frames. 12/1/200315

801

1112A

802

310

1291

1291

697

647

502

1207

438

683A

683

1009

413

309544

920

803

671

256510 692

712

1.2 KW

256 820767 Gear–Starter Drive309 825222 Motor–Starter

(1.2 KW)310 820773 Bolt

(Starter Motor)413 820067 Nut

(Starter Motor)438 820725 Boot–Terminal502 820763 Screw

(Solenoid Cover)510 825406 Drive–Starter544 825404 Armatutre–Starter

647 820719 Gasket–SolenoidCover

671 825422 Cover–Solenoid683 820723 Nut

(Starter Solenoid)(Terminal)

683A 820721 Nut(Starter Solenoid)(Terminal)

692 825402 Spring–Detent697 820777 Screw

(Drive Cap)

712 825401 Roller–Clutch801 825408 Cap–Drive802 820771 Cap–End803 825423 Housing–Starter

(Includes Brush Set)920 825410 Solenoid–Starter

1009A 820019 Screw(Starter Motor)

1112A 820779 Plug–Vent1207 820775 Screw

(End Cap)1291 820769 Seal–O Ring

(Starter Housing)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 16: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–16 Assemblies include all parts shown in frames. 12/1/200316

1207A

310A

802A

1112B

502A

683A

683

697A

801A

647A

438

413

1009

892

1084A

1082

803A309A

544A

920A

671A

256A

712A

692A510A

1.0 KW

256A 820745 Gear–Starter Drive309A 825083 Motor–Starter

(1.0 KW)310A 820755 Bolt

(Starter Motor)413 820067 Nut

(Starter Motor)438 820725 Boot–Terminal

502A 820739 Screw(Solenoid Cover)

510A 825394 Drive–Starter544A 825392 Armature–Starter647A 820733 Gasket–Solenoid

Cover671A 825400 Cover–Solenoid

683 820723 Nut(Starter Solenoid)(Terminal)

683A 820721 Nut(Starter Solenoid)(Terminal)

692A 825425 Spring–Detent697A 820751 Screw

(Drive Cap)712A 825424 Roller–Clutch

801A 825396 Cap–Drive802A 820743 Cap–End803A 825399 Housing–Starter

(Includes Brushes,Springs and BrushRetainer)

892 692318 Switch–Key920A 825398 Solenoid–Starter

1009A 820019 Screw(Starter Motor)

1082 820455 Relay–Starter1084A 825266 Connector–Terminal

(Starter Terminal)1112B 820737 Plug–Vent1207A 820754 Screw

(End Cap)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 17: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–17 Assemblies include all parts shown in frames. 12/1/200317

636

890C

652B1119A

11191150

606 1084B

668B

3121202

1201

314

1204

1203

1206

1205

1090

526

1202A

475

501

1010 699

910

379

474 530

40 AMP

312 820938 Housing–Brush End314 820711 Pulley–Alternator379 820703 Cover–Brush474 825524 Alternator

(40 Amp)475 825385 Rectifier501 825388 Regulator526 820702 Screw

(Regulator)530 825526 Housing–Drive End606 820819 Strap–Adjusting636 820069 Nut

(Starting Switch)652B 820275 Screw

(Support Bracket)

668B 820713 Spacer699 825390 Rotor Assembly

890C 820213 Bracket–Support910 820690 Stud

(Alternator)1010A 825384 Retainer–Bearing1084B 825157 Connector–Terminal

1090 825387 Retainer–Brush1119 820483 Screw

(Alternator)1119A 820270 Screw

(Alternator)1150 820023 Screw

(Adjusting Strap)

1201 820715 Screw(Brush Cover)

1202 820701 Screw(Brush Retainer)

1202A 820702 Screw(Brush Retainer)

1203 820702 Screw(Stator Wire)

1204 820705 Nut(Alternator Pulley)

1205 820707 Screw(Brush End Housing)

1206 820709 Nut(Brush End Housing)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 18: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–18 Assemblies include all parts shown in frames. 12/1/200318

493E

493D 493G

493G

318E SAE

465

465

493F

493F

GENERAL MOUNTING SAE MOUNTING494A

318E

318D

494

318D

318D 820024 Screw(Mounting Bracket)(Used With EngineMounts Only)––––––– Note –––––820023 Screw(Mounting Bracket)(Use Only When FrontEngine Mounts AndRadiator Brackets AreInstalled)

318E 820306 Screw(Mounting Bracket)

465 820449 Washer(Mounting Bracket)

493D 820835 Bracket–Mounting(Right Front)(General and SAE)

493E 820832 Bracket–Mounting(Left Front)(General and SAE)

493F 820833 Bracket–Mounting(Rear General)

493G 820834 Bracket–Mounting(Rear SAE)

494 825214 Mount–Engine(General Mounting)

494A 825215 Mount–Engine(SAE Mounting)

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 19: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–19 Assemblies include all parts shown in frames. 12/1/200319

358 ENGINE GASKET SET

1080

3

276A

1078

1041

20

88

276

1022

7

1067

1065

1062

883A

883

51

88A

868276B

276C

1095 VALVE GASKET SET

7 1022

51883

868

276

1067

656

1261

962

1258

883B

3 �821071 Seal–Oil(Magneto Side)

7 �∆820930 Gasket–Cylinder Head20 �821073 Seal–Oil

(PTO Side)51 �∆820407 Gasket–Intake88 �820377 Gasket–Gear

Reduction Cover88A �820155 Gasket–Gear

Reduction Cover

276 �∆820064 Washer–Sealing(Rocker Cover)

276A �820582 Washer–Sealing(Oil Drain Plug)(16mm)

276B �820950 Washer–Sealing(Oil Inlet Pipe)

276C �820952 Washer–Sealing(Oil Inlet Pipe)

358 825527 Gasket Set–Engine656 �820962 Gasket–Water Pipe868 �∆820405 Seal–Valve883 �∆820817 Gasket–Exhaust

(Manifold)883A �820967 Gasket–Exhaust

(Turbo Charger)883B �821001 Gasket–Exhaust

962 �820988 Gasket–Air Inlet Pipe1022 �∆820150 Gasket–Rocker Cover1041 �820104 Gasket–Oil Pump

Screen1062 �820093 Gasket–Outlet

Housing1065 �820098 Gasket–Inlet Housing1067 �∆820100 Gasket–Water Pump1078 �820137 Gasket–Oil Pan1080 �820145 Gasket–Seal Retainer1095 825528 Gasket Set–Valve1258 �820890 Gasket–Muffler

Adapter1261 �820973 Gasket–Oil Outlet

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Page 20: 58A400 to 58A499 TURBO DIESEL - M-and-D.com · 2006-05-26 · in writing from Briggs & Stratton DAIHATSU LLC. FORM MS–5473–12/1/2003 REPLACES FORM MS 5473 7/1/2003 FILE IN SECT

58A400 to 58A499

5473–20 Assemblies include all parts shown in frames. 12/1/200320

1040

1319

DM950DT

10361019

1058 OPERATOR’S MANUAL

1330 REPAIR MANUAL

1019 825634 Kit–Label 1036 825636 Label–Emissions(Used After Code Date02123100).––––––– Note –––––825635 Label–Emissions(Used Before CodeDate 03010100).

1040 820290 Plate–Trim1058 820853 Operator’s Manual1319 820891 Label–Warning1330 MS1055 Repair Manual

� Engine Gasket Set – Reference 358∆ Valve Gasket Set – Reference 1095

REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION