Aalto Technical Services Catalogue 2012

Service and Hire Rates

• High Pressure—High Volume Jetting Unit

• 2000 Gall. Vacuumation Tanker

• CCTV Unit

• Pump Unit

Date: 01/05/12

AALTO TECHNICAL SERVICES LTD

Company Services Catalogue

2012

Aalto

2

Page 2

FOR FURTHER INFORMATION RING 0800 092 8265

Hire Rates.

Hire Conditions. Due to the nature of equipment hired from Aalto Technical Services Ltd. ex-

perienced, trained technicians are employed to safely operate the plant to

expedite work under your direction.

Any waste removed to appropriate disposal must be identified and accom-

panied by correct declarations, together with hazardous waste codes in

compliance with current waste disposal regulations. Hire will continue in

half-hour increments after leaving site until such a time that successful tip-

ping is accomplished.

Hourly Hire Rates. All equipment hired on an hourly basis is subject to a minimum hire period

of five hours.

Half Day Hire Rates. Half day hire rates include traveling time and attendance on site from either:

Mornings 08.30 hrs to 12.00pm

Afternoon 12:30 hrs to 16:00 hrs

Daily Hire Rates. Daily day hire rates include traveling time and attendance on site from:

08.30 hrs to 16.00pm

Including lunch break (normally between 12:00 and 12:30 pm.)

Note:

All terms and conditions including prices stated in this catalogue

are quoted in good faith, subject to VAT at the current rate and are

negotiable subject to circumstances that enable work to be en-

gaged on a pre-planned or repetitive Programme.

Ring– 0800 092 8265 For Further Information.

3


Page 3

Hourly Rates

High Pressure/ Volume Jetting Tanker &Operatives. Per Hour £106.24

Half Day Rate £531.20

Daily Rate £1062.34

2000 Gall. Vacuumation Tanker & Operatives Per Hour £112.38


Daily Rate £1120.00

Pump Unit & Operatives Per Hour £ 80.33


Daily Rate £803.30

CCTV Unit & Operatives Half Day Rate (Min 4hrs) £369.81

Daily Rate £850.00

DVD and Report £ 85.00


4

Page 4


Vacuumation Work

The prices quoted below are based on work done

within the Greater Manchester Area. From July 2005 Waste removed from surface water Interceptors was classi-

fied by the Environment Agency as hazardous waste and subsequently

premises producing in excess of 200 litres per Annum need to be registered

with the Environment agency and maintain a current hazardous premises

number before any waste can be removed.

Interceptor Cleaning Transport £337.17

Average disposal cost: £ 69.77p per Tonne

Waste Admin Charge £ 77.81

Septic Tank Cleaning Transport £269.76



Grease Trap Cleaning Transport £269.76



Note:

All terms and conditions including prices stated in this catalogue

are quoted in good faith and are negotiable subject to circumstanc-

es that enable work to be engaged on a pre-planned or repetitive

Programme.


5


Page 5

Spillage and High Pressure Cleaning

High Pressure Jetting We use high pressure jetting equipment which can deliver between 500 and

10,000 p.s.i of pressure with flow rates between 5 and 80 gallons per minute,

so we can clear any blockage effectively and quickly.

Fast and effective solutions

Our mobile units carry equipment to provide fast and effective solutions. we

use this method as an effective cleaning tool when other cleaning methods

fail. Restaurants, factories, working yards, car parks, public areas and

amenities benefit from jetting technology to effect stubborn cleaning opera-

tions.

User and Environment Friendly

All detergents used in our jetting operation are non-caustic and biological,

rendering their use both user and environment friendly and are available

from our sister company The Barrel Butler Co. Ltd

The use of this type of equipment is undoubtedly the fastest & most econom-

ical method of cleaning any surface or drain

All Work of this nature is unique to individual requirements

Ring– 0800 092 8265 for a quotation to meet your needs

6

We have on many occasions been asked to help with various

forms of emergencies. Our technicians are regularly called

out to assist in internal flood clean up exercises, working

both independently and in direct assistance to local Emer-

gency Services.

We can efficiently respond to any types of spills whether oil

or chemical. Using the latest technology and procedures our

emergency response teams are trained to handle a wide

range of problems.

Our Sister company spillwizard.com are in the process of

setting up a 24hr helpline to offer help and advice in the

event of emergencies and spillages.

We ourselves operate exclusively in the North West of Eng-

land but by registering with spillwizard.com you will have

24 hr. access to companies who specialize in flood and spill-

age remediation throughout the U.K. spillwizard.com will

also offer sound, site specific spill prevention advice free of

charge.


Flood & fire clean up operations.

Page 6


Helping out with the aftermath of floods and fire.

7


Page 7

Restoring vandalised property.

Vandalism Restorative Clean Up Work.

Unfortunately vandalism has become almost part of everyday

life. We are called on regularly to remove graffiti plastered on

walls, buildings and street furniture. Many substrates require

different cleaning methods in order not to damage the under-

lying surface. Our cleaning methods ensure that no surface

damage occurs as a result of cleaning.

Initially our technicians will visit any site of vandalism in order

to assess the problem thoroughly.

From there, in full joint discussion, we will agree together on

the best and most effective, economical way forward.

We operate and maintain high pressure power washing equip-

ment to suit all requirements, including removing graffiti from

concrete, bricks, pavement, stucco, steel, tin, and most other

surfaces.

All cleaning methods incorporate environmentally friendly

materials and procedures.

Ring– 0800 092 8265 for a quotation to meet your needs

8

Page 8


Environment Protection.

Pollution Clean Up

Here at Aalto Technical Services Limited we have devel-

oped services that offer tailored solutions to environmen-

tal challenges that could affect our customers in both the

private and the public sector.

Using appropriate methods of containment to reduce the

spread of pollution allows us to prevent further damage to

the local environment prior to cleaning.

Once the spread is contained, our Response Unit will set

about filtering the polluted water in order to restore it as

close as possible to its original condition.

Our Pollution Response includes the following:

Full clean up of the site, restoring the contaminated wa-ters to their original state.

The complete rejuvenation of the contaminated and sur-rounding area.

Full disposal of the pollutants in a safe and appropriate manner.

After care consulting and advice on preventative

measures to avoid further pollution.

For more information on our Pollution services call us

now.


9


Page 9

Oil Interceptors and Blocked Drains

Oil Interceptors

Oil Interceptors work underground and are normally

unseen by the general public. These are essential instal-

lations and service areas where fuels and oils (That could

wash off or leak from vehicles and machinery.) are pre-

sent - such as car parks, working areas and roads where

such liquids may come in to contact with the common

drainage system.

Oil interceptors work by preventing such liquid pollu-

tants from entering the common drainage system. Aalto

Technical Services Limited are specialists in Interceptor

installations and Maintenance, working in strict accord-

ance to criteria regulated by the Environment Agency.

Legal Obligation.

Did you know that there is a legal obligation to clean

interceptors at least twice a year.

If you don’t you risk being prosecuted by the Environ-

ment Agency!

If there are any doubts, ring us today for impartial ad-

vice and a cost effective solution.

Aalto Technical Services Limited are experienced waste

carriers and have been working within Environment

Agency guidelines many years. If you have any doubts

about your site give us a call and we will arrange for an

experienced waste management consultant to visit at

your convenience.


10

Page 10


Domestic Sewage & CCTV Surveys

No job too small We don’t just deal with the large, industrial jobs. If you have something as

small as a blocked toilet, or blocked drain, give us a call and one of our staff

will be on hand to advise or arrange for a technician to be with you quickly to

resolve your problems.

We specialise in unblocking toilets, cleaning septic tanks and clearing

blocked drains, solving domestic sewage problems in an instant.

CCTV Surveys

Closed Circuit Television has become an invaluable diagnostic tool for the

drainage industry. In recent years there have been technological advances

that enable high resolution, real time images to be viewed and recorded.

Aalto Technical Services Limited provide CCTV inspections and accurate di-

agnostic reports to pinpoint problems that cause the drain to block. With this

information: on the spot recommendations, together with estimated costs can

be assessed.

CCTV camera inspections and reports are thorough. The inspection is done

by transiting a camera into the plumbing system, and recording the results

on video. We can use this video report to produce a diagnosis of your sewer-

age system’s problems. The camera will clearly indicate any defects, broken

pipes, or tree root problems in storm water drains and sewer lines – eliminat-

ing the cost of excavation if there happens to be a problem.

Special Rates - We can offer discount rates to Insurance Companies, Mort-

gage lenders and Estate Agents for agreed bulk bookings. please Ring 0800

092 8265 for more details and a package that suits you.

Domestic CCTV Surveys.

Aalto offer economical rates for domestic CCTV surveys that don't break the

bank and give physical assurance that all is either well or subject to further

work.


11


Page 11

Domestic Sewage & CCTV Surveys (Cont.)

Pre-Purchase surveys Pre-Purchase House CCTV Surveys

Identify defects that indicate financial liability.

When houses are purchased, normally a mortgage lender will insist that a

survey of the property be carried out in order to identify defects that could

indicate financial liability prior to purchase.

Responsibility for drains could cost thousands of pounds.

However if they cannot survey the underground drains they simply can’t

identify defects that may well be there.

A property owners responsibility for their domestic drain ends at the con-

nection with the public sewer, wherever that may be!

Imagine, after buying a property finding there is a problem with the drain

under the road. The cost to dig the road up could run into thousands of

pounds.

Peace of Mind.

For peace of mind and in the interests of certainty, (If there is a problem

underground, at least you would be aware of it before you part with your

money.) We strongly advise that purchasers invest in a pre-purchase CCTV

survey before exchanging contracts.

Re-negotiation of Purchase price.

A video of the survey together with a comprehensive report will be sup-

plied. If the drains are clear, giving the buyer peace of mind. If there are

problems, we will identify them, recommend remedial work then supply a

quotation in order to present the buyer with grounds for re-negotiation of

the purchase price.


12

Page 12


Tank Cleaning and Removal

Working in Confined Spaces

All our Technicians are equipped, trained and qualified in safe

confined space working. We work regularly on projects that

require knowledge of safe man-entry techniques.

This operation (as does every task Aalto carry out) requires

physical discussion in order to formally identify and analyse

the level of any risk involved before deciding on site specific

actions aimed at reducing those risks to a minimum. This is

followed by a discussion on the method to be undertaken in

the expedition of the work. Once a safe working method is

agreed a working document entitled a ‘Method Statement’ is

issued which will become the technician’s ‘Bible’ for the dura-

tion of the task. The ’Method Statement’ will incorporate criti-

cal checks and balances to be conducted by a nominated

member of the team to ensure that the task is implemented to a

safe and satisfactory conclusion.

Previous tasks have involved:

Working inside tanks

Underground Operations (manholes)

Operations requiring full PPE gear

Working within complex sewage systems

General Repairs within confined spaces

Working between machinery etc.

Because we are a small organisation, we use more appropri-

ately ‘geared-up’ contractors for work that involves working in

seriously hazardous conditions. However our technicians are

fully trained and equipped with appropriate up to date safety

and emergency rescue equipment in recognition of the risks

and dangers of working in any confined space situation.

13


Page 13

Tank Cleaning and Removal

Working in Confined Spaces (Cont.) Confined space entry always involves a minimum of three fully trained

technicians for the following reasons.

No technician is allowed to work in a confined space for

more than 20 minutes in any single hour.

When a Technician is working in a confined space, a second

qualified person will monitor the atmosphere within the

space and observe the person working at all times. If diffi-

culties arise, he will be ready to evacuate the person in the

tank via pre-determined instructions, while the third person

will be nominated to summon aid in line with those pre-

determined contact instructions.

All tanks and confined spaces whether classified as low hazard or

high-risk, commercial or domestic are treated with the respect

they command and both our and your employees deserve.

If in any doubt, call us for a free no-obligation consultation.


14

Page 14


Preventative Maintenance

Pre-Planned Preventative Maintenance.

A way to reduce costs, spare commercial and industrial clients the embar-

rassment of drain break-down, unpleasant odours, or health hazards,

‘preventative' maintenance programme ensures that your drains reflect

your reputation. Keeping the system flowing.

Pre-planned maintenance is tailor-made to your individual requirements

taking care of your drains, sewers and associated pipework.

Keeping the system flowing freely, avoids problems associated with block-

ages and reduced flow. Pre-planned maintenance arrangements can be

applied to foul or surface drainage and process Pipework.

All Pipework is different. The frequency and type of service depends on

how busy the system is. Other factors like:

The substance being discharged.

The size of building.

The type and size of Pipework. Are all contributing factors to the effectiveness of the system.

Free no-obligation site inspection.

The first step is for our surveyor to carry out a free site inspection. We will

analyse previous problems and isolate areas of concern. We will then pro-

pose an initial ‘clean' that will return the Pipework to optimum performance.

From there, in consultation with you, a detailed program is prepared high-

lighting those parts of the system that need cleaning on a regular basis.

Then, at pre-determined times to suit you, our technicians will expedite the

scheduled work.

Preventative' maintenance helps to avoid problems that create

flooding which leads to damage of property and stock, which in turn brings

unbudgeted expenditure.


15


Page 15

Our Company’s Mission Statement.

Below are extracts from Aalto Technical Services

Ltd.’s Mission Statement.

Our expertise is second to none where issues of an environmental nature

are concerned. We are acutely aware of our industry and those engaged in

it.

Small in Stature: Huge in Knowledge. Often, because we are a small company, we may not necessarily be in a

position to involve ourselves directly. However, because of the recondite

experience inherent in our company it is likely that we can and will source

appropriate help in dealing with major spillages etc.

Recommend Specialists beyond our ability. Obviously we will be promoting our own companies goods and services

where we can help, but we will also recommend alternative companies,

particularly those who specialise in areas beyond our company’s ability

and operate away from the Northwest of England.

Here to Help! Either way, we are here to offer genuine assistance and by using it we as-

sure potential clients that there is no obligation to exclusively use our prod-

ucts or services.

The criterion is one of offering helpful assistance that can be addressed

safely, quickly and within the United Kingdom's environmental regulations.

Please feel free to call us in the event of any problems you may be experi-

encing, our help is free and completely without obligation.


16

Phone:0161 877 1881

Fax: 0161 877 5755

E-mail: [email protected]

Aalto House

Irmass Industrial Estate

Trafford Park Road

Manchester


Aalto

Documents

Aalto Technical Services Catalogue 2012