AOC+Service+Manual+HP-F1905E_A00+monitor+lcd.pdf

  • View
    28

  • Download
    13

Embed Size (px)

Text of AOC+Service+Manual+HP-F1905E_A00+monitor+lcd.pdf

  • HP F1905E

    SERVICE MANUAL

    19LCD Monitor F1905E Series

    THESE DOCUMENTS ARE FOR REPAIR SERVICE INFORMATION ONLY. EVERY

    REASONABLE EFFORT HAS BEEN MADE TO ENSURE THE ACCURACY OF THIS MANUAL; WE CANNOT GUARANTEE THE ACCURACY OF THIS INFORMATION AFTER THE DATE OF PUBLICATION AND DISCLAIMS RELIABILITY FOR CHANGES, ERRORS OR OMISSIONS.

  • HP F1905E

    2

    Table of Contents

    Table of Contents ---------------------------------------------------------------------------------- 02

    Revision List ---------------------------------------------------------------------------------------- 04

    1.Product Feature --------------------------------------------------------------------------------05

    2.LCD Monitor Description -----------------------------------------------------------------------05

    3.Operation Instructions --------------------------------------------------------------------------06

    3.1 General Instructions -----------------------------------------------------------------------06

    3.2 Control Button -------------------------------------------------------------------------------07

    3.3 Adjusting The Picture ---------------------------------------------------------------------08

    4. Input/Output Specification ---------------- --------------------------------------------------- 09

    4.1 Input Signal Connector --------------------------------------------------------------------09

    4.1.1 Analog D-SUB Connector --------------------------------------------------------09

    4.1.2 DVI-D Digital connector -------------------------------------------------------------09

    4.2 Factory Preset Display Modes ----------------------------------------------------------10

    4.3 Power Supply Requirements ------------------------------------------------------------11

    5.Panel Specification ---------------------------------------------------------------------------11

    5.1 General Feature ----------------------------------------------------------------------------11

    5.2 Optical Characteristics --------------------------------------------------------------------12

    6. Block Diagram -----------------------------------------------------------------------------------13

    6.1 Monitor Exploded View ------------------------------------------------------------------13

    6.2 Software Flow Chart -----------------------------------------------------------------------14

    6.3 Electrical Block Diagram -----------------------------------------------------------------16

    6.3.1 Scalar Board ---------------------------------------------------------------------------16

    6.3.2 Inverter/Power Board ----------------------------------------------------------------17

  • HP F1905E

    3

    7. Schematic -----------------------------------------------------------------------------------------19

    7.1 Main Board -----------------------------------------------------------------------------------19

    7.2 Inverter/Power Board -------------------------------------------------------------------23

    8. PCB Layout ---------------------------------------------------------------------------------------26

    8.1 Main Board -----------------------------------------------------------------------------------26

    8.2 Inverter/Power Board ----------------------------------------------------------------------27

    8.3 Keypad Board -----------------------------------------------------------------------------30

    9. Maintainability ------------------------------------------------------------------------------------31

    9.1 Equipments and Tools Requirements -------------------------------------------------31

    9.2 Trouble Shooting ---------------------------------------------------------------------------32

    9.2.1 Main Board ------------------------------------------------------------------------32

    9.2.2 Power/Inverter Board -------------------------------------------------------------35

    9.2.3 Key Pad Board -----------------------------------------------------------------------37

    10. White-Balance, Luminance Adjustment ----------------------------------------------- 38

    12. Check List After Replacing LCD Main Board ---------------------------------------------40

    13. EDID Content -----------------------------------------------------------------------------------44

    14. BOM List -----------------------------------------------------------------------------------------45

  • HP F1905E

    4

    Revision List

    Revision Date TPV model name A00 May.-09-06 T986KAVDKHHPAP

  • HP F1905E

    5

    1. Product Feature 48.3 cm (19) a-si TFT Active matrix LCD panel, 0.294mm dot pitch Scalar chipset: Genesis GM5321 Microprocessor controlled scan technology Both VGA analog and DVI-D digital signal video inputs supported 450:1 Typical Contrast Ratio and 250-nits typical Brightness Response time 20ms and Viewing Angle 140(Horizontal) and 120(Vertical) 15 factory presets, 10 user modes Vertical refresh rate 50Hz to 76Hz; Horizontal frequency 30kHz to 83kHz Resolutions: 640 x 480 up to 1280x1024, Max Pixel Modes: 140 MHz Power Internal AC100V-240V Tilt -5 to 35 CE mark TCO 03 mark VESA DPMS compliant VESA DDC2B compliant and DDC/CI interface.

    2. LCD Monitor Description The LCD Monitor will contain main board, power board, key board which house the flat panel control logic, brightness control logic and DDC. The power board will provide AC to DC Inverter voltage to drive the backlight of panel and the main board chips each voltage.

    Video signal, DDC

    Power Board

    Flat Panel and

    CCFL backlight

    Main Board

    Keyboard

    RS232 Connector

    For white balance

    adjustment in

    factory mode

    HOST Computer

    CCFT Drive.

    AC-IN

    100V-240V

    Monitor Block Diagram

  • HP F1905E

    6

    3. Operation Instructions 3.1 General Instructions

    Press the power button to turn the monitor on or off. The other control buttons are located on the side of the front panel. By changing these settings, the picture can be adjusted to your personal performance. - The power cord should be connected and insert to adaptor. - Connect the video cable from the monitor to the computer VGA card. - Press the power button to turn on the monitor, the power indicator will light up to Green.

  • HP F1905E

    7

    3.2 Control Buttons

  • HP F1905E

    8

    3.3 Adjust the Picture

    1. Brightness Adjust the brightness.

    2. Contrast Adjust the contrast

    3.

    Image Control

    Adjust the: z Auto Adjustment: Adjusts the main settings and produces a stable, centered

    image. z H-Position: horizontal position of the screen image. z V-Position: vertical position of the screen image. z Clock: frequency of the pixel clock to minimize vertical bar. z Phase: phase value to minimize horizontal jitters.

    4. Color

    z 9300K: recall 9300K color z 6500K: recall 6500K color z SRGB: recall SRGB color z Custom Color: adjusts the color tint of white, and the red, green, and blue (RGB)

    mix for colors.

    5. Language Shows the language of the OSD window.

    6. Management

    z Power Saver: enable/disable power saving z Power On Recall: enable/disable power recall z Mode Display: enable/disable mode display z Sleep Timer: set sleep timer z Basic Menu: set to basic menu

    7. OSD Control OSD (on Screen Display) settings: adjusts the H/V position, timeout, On Screen Display window.

    8. Information Current setting, recommended setting, serial number, total hours, backlight hours, Exit.

    9. Factory Reset Resets the display to original factory settings for color, brightness, phase, and clock.

    10. Exit Exit the current OSD window.

  • HP F1905E

    9

    4. Input/Output Specification 4.1 Input Signal Connector

    4.1.1 Analog D-SUB Connector PIN MNEMONIC SIGNAL PIN MNEMONIC SIGNAL

    1 RV Red Video 9 +5 V +5 V (from PC)

    2 GV Green Video 10 SG Sync Ground

    3 BV Blue Video 11 NC None (Reserved for Factory Use)

    4 NC None 12 SDA DDC Data

    5 GND Ground (DDC Return) 13 HS Horizontal Sync

    6 RG Red GND 14 VS Vertical Sync

    7 GG Green GND 15 SCL DDC Clock

    8 BG Blue GND

    VGA connector layout

    PIN 1 PIN 5

    PIN 11

    4.1.2 DVI-D Digital connector

    PIN MNEMONIC SIGNAL PIN MNEMONIC SIGNAL

    1 TX 2 - TMDS Data 2 - 13 TX 3 + TMDS Data 3 +

    2 TX 2 + TMDS Data 2 + 14 +5V +5V Power (from PC)

    3 SHLD 2 / 4 TMDS Data 2 / 4 Shield 15 GND Ground (Return for +5V)

    4 TX 4 - TMDS Data 4 - 16 HPD Hot Plug Detect (connect internally to

    pin-14)

    5 TX 4 + TMDS Data 4 + 17 TX 0 - TMDS Data 0 -

    6 DDC Clk DDC Clock 18 TX 0 + TMDS Data 0 +

    7 DDC Data DDC Data 19 SHLD 0 / 5 TMDS Data 0 / 5 Shield

    8 N/C No Connect 20 TX 5 - TMDS Data 5 -

    9 TX 1 - TMDS Data 1 - 21 TX 5 + TMDS Data 5 +

    10 TX 1 + TMDS Data 1 + 22 TX CLK SHLD TMDS Clock Shield

    11 SHLD 1 / 3 TMDS Data 1 / 3 Shield 23 TX CLK + TMDS Clock +

    12 TX 3 - TMDS Data 3 - 24 TX CLK - TMDS Clock -

  • HP F1905E

    10

    DVI-D digital connector layout

    4.2 Factory Preset Display Modes

    Factory Pre-set Video Input Modes

    Pre-set Pixel Format Horizontal

    Frequency (kHz)

    Vertical Frequency

    (Hz)

    1 640 x 480 31.5 60.0

    2 640 x 480 37.9 72.0

    3 640 x 480 37.5 75.0

    4 720 x 400 31.5 70.0

    5 800 x 600 37.9 60.0

    6 800 x 600