2
8/20/2019 Brosur Deltagrout CG http://slidepdf.com/reader/full/brosur-deltagrout-cg 1/2

Brosur Deltagrout CG

Embed Size (px)

Citation preview

Page 1: Brosur Deltagrout CG

8/20/2019 Brosur Deltagrout CG

http://slidepdf.com/reader/full/brosur-deltagrout-cg 1/2

Page 2: Brosur Deltagrout CG

8/20/2019 Brosur Deltagrout CG

http://slidepdf.com/reader/full/brosur-deltagrout-cg 2/2

C O N S T R U C T I O N P R O D U C T S

PT. DELTACRETINDO WIRA MANDIRI

Jalan Pintu Air IV No. 41A, Jakarta Pusat - Indonesia

  Email : [email protected] Website : www.deltacretindo.com■ ■

Disclaimer :

The information detailed in this brochure is liab le to modification from time to time inthe light of experience and of normal product application, and before using orapplying the product in site, the customer are strongly advised to contact Deltacretefor further more detailed technical guidance. All data shown in the brochure aretypical laboratory result achieved in ideal conditions, site results could be different.Because Deltacrete has no direct or continuous control over where or how itsproducts are applied, Deltacrete can not accept any liability either directly orindirectly arising from the use of its product, whether or not in accordance with anyadvice, specification, recommendation or information given by it.

  Telp. +62 21 344 2919 Fax. + 62 21 351 1428■  ■

CuringWhen the grouting operation completed, exposed areas should be completely cured, this should be

done by continuous application of water and or wet hessian.

SUPPLYDeltagrout CG is supplied in 25 kg plastic bag.

YIELDThe approximate yield per 25 kg bag is depending on the consistency of the grout.

Yield for trowel able grout is 12 litres, and yield for flow able grout is 13.25 litres.

STORAGE

Deltagrout CG has a shelf life of 12 months if kept in a dry condition and stored in sealed bags. Ifstored in high temperature and high humidity locations the shelf life will be reduced.

TECHNICAL DATA

The following results were obtained at water to powder ratio of 0.19 and temperature of 26 ºC.Compressive strength (BS 1881 part 116 1983) 24 N/mm2 @ 1 day

50 N/mm2 @ 7 days

60 N/mm2 @ 28 days

Flexural strength (BS 4551 1980) 5 N/mm2 @ 1 day

9 N/mm2 @ 7 days

11 N/mm2 @ 28 days

Time for expansion Start 15 minutes

Finish 2 hours

Fresh wet density (depending on actual consistency) Approximately 2170 kg/m3

Modulus of elasticity (ASTM C469-83) 28,000 MPaExpansion characteristic (ASTM C940) Up to 2% @ 24 hours

LIMITATIONS

Grouts should not be placed in any unrestrained situation, failure to comply may lead to crackdevelopment in the hardened grout.

FIREDeltagrout CG is non-flammable material.

CODE B1 - DC 08/2010