Upload
others
View
4
Download
0
Embed Size (px)
Citation preview
COMMERCIAL GAS WATER HEATERSInstruction Manual
PRINTED IN THE U.S.A. 0310 197373-005
PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.
����������� ������������������������������������������������������������������������������
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
MODELS BTH-300A/400A/500A SERIES 100 & 101
INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY
�����������������������������������!���"��#�$%�&�
ANSI / NSF 5ASME CRN
WARNING: If the information in theseinstructions is not followed exactly, a fireor explosion may result causing propertydamage, personal injury or death.
Do not store or use gasoline or otherflammable vapors and liquids in thevicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch any electrical switch; donot use any phone in your building.
Immediately call your gas supplierfrom a neighbor’s phone. Follow thegas supplier’s instructions.
If you cannot reach your gas supplier,call the fire department.
Installation and service must beperformed by a qualified installer,service agency or the gas supplier.
��
�
�
2
Supply Gas Line Installation ............................................................ 37Supply Gas Regulator Installation ................................................... 38'���������������� ............................................................................... 39
�����(�����!�������� ......................................................................39
'�� ��)*��� ���!����� ..............................................................................39
������+����!�������� .................................................................. 40�/��6��:��*������������� ............................................................... 40
TEMPERATURE REGULATION .......................................................... 41;������<��������+�<���!�����='!>? ............................................ 41����<�����!���� .......................................................................... 41
!>#�@>+�(B(�'C�>�'@��J># ...................................................... 42!�����(����<�#�:������ .............................................................. 42
����*������(����� .................................................................................42
(�����J��� ..............................................................................................43
K����(��������/�!�����(����<�C��� .......................................... 45Temperatures Menu ..................................................................................45
Heater Status Menu ..................................................................................46
Display Settings ........................................................................................47
Heater Information ....................................................................................47
!������V��� .............................................................................................48
V����;����� .............................................................................................48
V����>�������� ......................................................................................48
@������V������*������ ..........................................................................48
(��:����!������J���<���� .....................................................................49
START UP ............................................................................................ 50Initial Start Up .................................................................................. 50
(�����W�������������X��<��� .............................................................51
C�������W�������������X��<��� ..........................................................51
!������������V������@��� ................................................................ 52;������������J����������� ................................................................ 52
LIGHTING THE WATER HEATER ....................................................... 53Lighting & Operation Label .............................................................. 53
TROUBLESHOOTING ......................................................................... 54J�����������!�������� ........................................................................ 54(�\�����>��>������� ................................................................... 54(�\�����>��>��������V���!���� ................................................ 55Operational Problems ...................................................................... 56
@���(�������"�@���>������� ............................................................56
Momentary Ignition ...................................................................................56
Not Enough Or No Hot Water ...................................................................56
V��������������!������� ............................................................... 57V����!������� ........................................................................................57
������!������� ........................................................................................57
@���������!�����(����<�+���>�� ........................................................57
*���������!����� ....................................................................................57
V��������������C������� .........................................................................58
C�J#�'#�#!' ................................................................................... 60C�����������(������ .................................................................... 60
DIAGRAMS .......................................................................................... 63!!]�^�!�������!�����]����+��� ............................................... 63BTH 300 Wiring Diagram ................................................................. 64]�;�_��"������������*�����< ......................................................... 65!����������<���������*�����<� .................................................. 66Water Piping Diagrams .................................................................... 67
+JCJ�'*���@@�#�B .......................................................................... 74
TABLE OF CONTENTS(�V'�J#(��++��J>#"�K('��#*�('@6J!'.......................................... 3W'#'@�+�(�V'�B�J#V>@C��J># ...................................................... 4
��������� ........................................................................................ 4J#�@>*K!�J># .................................................................................... 6
`���������� ..................................................................................... 6�!>CCk�/�]�!����!<���� �� ....................................................... 6����������V������J���������� ........................................................... 6
V'��K@'(��#*�!>C�>#'#�( ......................................................... 7]�����>������� ................................................................................. 7���6��� ............................................................................................ 8(����6���� ......................................................................................... 9
J#(��++��J>#�!>#(J*'@��J>#( ................................................... 10Rough In Dimensions ...................................................................... 10@��:����!��������� ........................................................................ 10+�����������������;����� ...............................................................11
!�����������!< ��� ���C�������� ........................................................11
(��:����!�������� ....................................................................................11
Insulation Blankets .......................................................................... 12INSTALLATION REQUIREMENTS ...................................................... 13
Gas Pressure Requirements ........................................................... 13Supply Gas Line .............................................................................. 13Supply Gas Regulator ..................................................................... 13�����(���� .................................................................................. 13Mixing Valves ................................................................................... 14*�����������C������� .................................................................... 14!�����������(����<� .................................................................... 14Thermal Expansion .......................................................................... 14Temperature-Pressure Relief Valve ................................................. 15!���������*���� ............................................................................ 16Air Requirements ............................................................................. 17!<<����������C����������� ................................................... 20
VENTING INSTALLATION ................................................................... 21General Venting Information ............................................................ 21
!�������J6���������� ..............................................................................21
�����6����!�������� .........................................................................21
*������6����!�������� ..........................................................................21
W�������6�������J��������� ........................................................... 21Venting Requirements ..................................................................... 22
Maximum Equivalent Lengths ..................................................................22
Minimum Equivalent Lengths ...................................................................22
C�}�<<�#< ���>��'� �� ...................................................................22
6�������J�����������(�\���� ......................................................... 23�����6����J���������� .................................................................... 23*������6����J���������� ..................................................................... 236�����������<�������J���������� ....................................................... 24(�����������<�������J����������...................................................... 26!������������<�������J���������� .................................................. 27
C�������!������������<�������!���������� ...........................................30
C�������!������������<��������������<���� ........................................31
Venting Arrangements ..................................................................... 32���<�������!����������(�������������6��� ................................. 34���<�������!����������(��������*������6��� .................................. 35
WATER HEATER INSTALLATION ........................................................ 36!���������*�����J���������� ......................................................... 36
3
SAFE INSTALLATION, USE AND SERVICE
���������������������"�����������:������������������������������}���<�����<������������������������������������������C����������^��������<�������������������������:�� ������:�������������<����������������������������������������������������������������X������������@�������� ��������������<�����������������������������������<�������J�����:�����<����������������<���������������������<������������������ ������������������������"���"������:����������������������
�����������<������������������������������� �������������������"�������������������������������������������<������"�����������:����������������X�������!���������(����*�������������������}���'�����<����������\���������W:�������!������������ ��������������� ������������� �� ����(�������!��������� �������������"� ������������"�������� ��������:�����<"����� ��\����� ��������� �������������������}������������ ��������������������������������<����������������(�������!����������������������"� ������������"����������������:�����<�������������������������������:����}��������<��������� ��������������������������
DANGER
WARNING
CAUTION
CAUTION
DANGER indicates an imminentlyhazardous situation which, if not avoided,will result in injury or death.
This is the safety alert symbol. It is used to alert you topotential personal injury hazards. Obey all safetymessages that follow this symbol to avoid possibleinjury or death.
WARNING indicates a potentially hazardoussituation which, if not avoided, could resultin injury or death.
CAUTION indicates a potentially hazardoussituation which, if not avoided, could result inminor or moderate injury.
CAUTION used without the safety alertsymbol indicates a potentially hazardoussituation which, if not avoided, could result inproperty damage.
ASME CRN ANSI / NSF 5
APPROVALS
4
PRECAUTIONS*>�#>��K('��;J(����+J�#!'� JV��#B���@��;�(�]''#�K#*'@����'@��J<<����������������\����������:�����������������������������������������<�����������<������������������������� ����������}��J��������������}������������������"������������������������� ���� �������:�� ������ ��:�� ���� <���� �� �� \�����������:�����������
1. '}�����������
2. Damage.
3. V������������������
GROUNDING INSTRUCTIONS
����� ������ ������� <��� �� ������� ��� ���������� ����� ����#������� '���������� !��� ���)�� ����� ������ ������ <��� �����������������������V���������������������������������������<�������������������������������<��������������� ������ ������� <��� �� ��������� �� �� ������� <����"����<������������������<��������\��<�������������������<��� �� �������� ���� ������� ��������������������� �� �����\��<���������������<�������������������������������
HYDROGEN GAS FLAMMABLE
;��������������� ��������� �������������������<����:��� �� ��������������� ������������ �������� ����� ��������������<��=���������������������<��?��;���������������}���<������<<� �������������������������X����������������������"����������<<�������������������������������:��� ����������������� �� ������ ��� ��:����� <������ ����� ����� ���� ��������������������� ��������� �� ���� ��� ������ �����<�� J�� �������� ����������� ������ ����� �� � ��� �� ��� ����� ���� ���� ��� ����������������������������������������� ������������THERE (;>K+*� ]'� #>� (C>�J#W� >@� >�'#� V+�C'� #'�@� �;'�V�K!'������;'��JC'�J��J(�>�'#��
GENERAL SAFETY INFORMATION
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
Explosion Hazard
Overheated water can causewater tank explosion.
Properly sized temperature andpressure relief valve must beinstalled in the opening provided.
Verify the power to the water heater is turned off before performing any service procedures.
Improper installation, use and service may resultin property damage.
Do not operate water heater if flood damaged.Inspect and anode rods regularly, replace if damaged.Install in location with drainage.Fill tank with water before operation.Properly sized thermal expansion tanks are required on allclosed water systems.
Refer to this manual for installation and service.
CAUTION
Explosion Hazard
Flammable hydrogen gasesmay be present.
Keep all ignition sources awayfrom faucet when turning onhot water.
5
GENERAL SAFETY INFORMATION
Fire Hazard
Do not install water heater oncarpeted floor.Do not operate water heater ifflood damaged.
For continued protection againstrisk of fire:
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
Property Damage Hazard
All water heaters eventually leak.
Do not install without adequate drainage.
CAUTION
Fire and Explosion Hazard
Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.
Use joint compound or Teflon tapecompatible with propane gas.
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
Turn off power to the water heaterbefore performing any service.
Electrical Shock Hazard
Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.
Verify proper operation after servicing.
Failure to follow these instructions canresult in personal injury or death.
Jumping out control circuits or components canresult in property damage, personal injury or death.
Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.
Any bypass or alteration of the waterheater controls and/or wiring will result
in voiding the appliance warranty.
Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.
6
������B� ��� ���������� ����� ������ �������� �������� ��������������<���������"�����������:�������������� �����������:����
ABBREVIATIONS USED
� ��:�������������������J���������C��������������� �#(J�^��<�������#�������(���������J��������� �(C'�^��<�������(��������C����������'���������� W�C��^�W�������������C����������������������� #'!�^�#�������'����������!���� #V���^�#�������V������������������������ K+�^�K������������+� ������� !(��^�!��������(������������������
QUALIFICATIONS
QUALIFIED INSTALLER OR SERVICE AGENCYJ����������� ���� ���:���� �� ����� ������ ������� ��\����� � �������\�:������ �� ����� �� �� `�������������� =��� ������� ���#(J� ���?���������������:�:����J���������������������������< ���"����������"�:������"��������������������������������������\������������������������������������������������������<�������:����ANSI Z223.1 2006 Sec. 3.3.83:� �`������� �������� ^� ���������:����"���<"�������������<������������������������������������������������:������������������������������ ������=�?����� �����������"� ���������� �������<������������������� = ?� ������������"������������"��������"�������������:������������������������\��<��������������}��������������������������������<���������������������������\��������������������<���������������������\���<���������������������:����X�����������J�����������\�������=���������� ���#(J�� :�?���������������� ��������� ��� ��\����� �� ���� �������� ��:���� X������������ �����<� �� ��:��� ����� �� ��� ����<��� �� �����<� ���� �� ������������������� ��� ��� �����<������ J����������������������� �������������:��� ��� �����<��������������<��� �������<�����������������������������<�����
ICOMM™ & BACNET COMPATIBLE
����� ������ ������� ��� �<���� ��� ����� ���� �!>CCk� ��<���<�������� �����<�� ���� �!>CCk� �����<� ��������� ����<�������� � ���:���� ������������������������ J�� ����������� ��<����� ��������� ���������"� ���������� ���� ������� ����� �������<����������� ����������� �!>CCk� �����<� ���� ��<��������� ������ ������������������ :��� �<���� ���)�� �������� ����� ��}�� <�������� ��������������� ��<���������������������!�������������!>CCk������<��������������<���� ��������]�!�����<�����������:����� ������� ���� ������� <�����<���� �����<��� V��<�������<�����������������^$%���
PREPARING FOR THE INSTALLATION
1. @���������������<����� ���������<�������������������������������������������������������������������W�������(������J���<������������_�������� J��������� ����� ���������������"������������������<���������������������J���������������������<���"���X������)������������� <����� �������� ����������� ��� ���� �����������"��������"� ���� <����������� �� ���� ������ �������� J�� ������������ ��������� ������� ���� <����� ����� �� <������������ �������������������������������� �����������������������������������������������������������������������safety.
INTRODUCTION*��������������������������<����������������������<������������ ������<�� ����� ���:�� �� ��:���� ���� ���������� ����� ������������� J�� ��� ���������� ����� ���� :������"� ������ ������"� ���������������������� ������������������������������ ��������� ����� �� ��:��� �� ���� �������������� ����<<������ ��� ���� �������� ���������� ��� ���� �������������<�����������������������������������������������������������������������������������<�������������������������������������������V�����������!<��������������%���������<������K���������������������������������������:������<��������������������������(�������J�����������!��������������� �����������������_��]������������������������������<��� ��� �����<����<�������������� ��X��<����� ���� �:��� ����������� ���:����������� ;��:��"� ���:���� ���� ���������� ��������� ��������� �������<��� ����`�������(��:�����������NOTE:� !���� �� ������� ������������ ������ ���� ��� �:����������������<��������������
2. ]�� ���� �� ���� ��� ����� ����� ������� �� �� ����� ��������������������<���������������������#�:�������������������<�����������������������������������������������
3. ����������������<�������<�����������������������������������<��������������������������������:����X����������������� ������ �� ��������� ������� ��� ���� ������� ������������:���� X���������� ����� �� �������� ����� ������������ �����������������������\������������������<�����������������"����������������������J�� ����� �������� ���������"� ���� ������������<����<����������������������������������#�������V���W���!��"��#(J����$�&)#V����_���������#�������'����������!��"�#V���%����!�#)!(�^]&_��&"�����#������W��������������J�����������!��� ���� !(�� !���&"� ���� !�������� '���������� !���� ������<����� ���� �:���� ��� ��<� ���� !�������� (������������������"����&�'�������������6������@��"�!��:�����"�>;�__&$&��#V�����<��������������:���� �����<�����#�������V���� ��������� ���������"� &� ]������<����� ����"� `����"�MA 02269.
4. J�� ������ �������� ����� <����� �� ��:�� ���� \������� �� ����� ���������� ���� ������ �� ���� ����������"� ����� ���� ����������< ��������� �����:����� �����<����� ��� ����������������������J����������}������������\���"����������:����������C���"�(����������(�������< �����������������������������������������:���� �������������������������������<��������������������������������������������� ���
5. !������������� ���������<������ ������������������'}�<��������������������������������<�����������������\���<��������+�����������������;�������������&&���������@���J��Dimensions on page 10.
6. V�����������������!���������������������������<��� �� �������������������:�������������<:������������������\�����(��� ����������� ��� ������� ������������ ����������J���������� <��� �� ������� ��<� !��������� >����� �� ����(��������������"�&&���`�(�����"�(�����&��"�(����<���"�!��95811.
7. C������������ !��� ��\����� ����� ������ ������� �� ������������������������������C�������������_�^!C@�������(�������< ����!��������_�^!C@����(���!<<����������C����������������������
7
BASIC OPERATION
���� ������ �������� �:����� ��� ����� <����� ��:�� �� �������� �����������������}�������� ����� ���� <������ ��� ��������������������� ������ ��������� C���� ]����� ��� �� ������� ������� ����"� ������ <����� �� ���� ��� ���� ����� �������� ������ ���� ������}������������������������������� ��������� ���������������������� ������ ���� ����� �}�������� ����� �������� ���� �}��������������}����):��������������������������� ��<���������������������(���V�����&�����V�������
FEATURES AND COMPONENTS
BLOWERBURNERASSEMBLY
MAINBURNER(radial design)
HEATEXCHANGER
INTAKE AIR(combustion air)CONNECTION4 INCH PVC
HELICALCOIL
VENT (exhaust)OUTLET
Figure 1
BLOWER/BURNER ASSEMBLY DETAIL
HOT SURFACEIGNITER
COMBUSTIONBLOWER
FLAMESENSOR
MAINBURNER(radial design)
BLOWERFLANGE
INTAKE AIR(combustion air)CONNECTION4 INCH PVC
Figure 2
Hot Surface Igniter���������������<����������� ����;��(������ J������������&���6�!� ������ ���� �������� ���<� �� ������� ����� ���� �������� ������������������������������������"��&����V�=�����!?"����������the Main Burner. NOTE:�!����<��� ���������������������������������������:����breakage.*����� ���� �������� ���<� �� ������ ����� �� �������� ���� �����������<�<�����������������������������<�����������<���<<��������!��<������]�;�$���/�_���<�����������%��!��<������]�;�����<������(�������(�\�����>��>����������������_�Flame Sensor���������������<�����<������������<��������������<�����<��������������������C����]������J������<��������:�������������������������������������=$^��������?����������������<������ �<<��������� ��^��������� ���� �_� 6�!� W��� 6��:��� (��� ����(�\�����>��>��������V���!���������������
8
]����� ��� ��������� ��������� ���� ������ �����<� <������������������������������� ������������������� ��� ���������������� ������ ����� ���� !< ����� ]����� ��� ���������� ������ ���� ��<�� ������ �� �������� ������� (��� (�\����� >��Operation on page 54.
11. 6�������������=�}������� �?�^�_�������6!�12. !< �����]�����13. ]������'}�����=:���?���������#�<������������������������
��������������������������������������������������������'}����� =:���?����������������� �� ����������������� ���������������������������������<�<������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������
14. 6V*�=:���� ������\��������:�?� �����<������:���K������]�;�_�������]�;�����<���������
15. Temperature-Pressure Relief Valve. See Temperature-Pressure Relief Valve on page 15.
16. K�������<���������� �"�&����� ��<���������� ����������������������������������<�<������������� �������������������<�������������������������������������������������K�������<���������� ���������������'!>�=���������� �?� ������������� ��� �� ��� ��X��� ��� ����� ��<����������<��� ������������ '!>� ������� �������� ���� ��<����� �������������������������<��������������(���;������<��������+�<���!�����='!>?��������_&�
17. ��������������������&�&)���#���18. KJC�=���� ����������<���?������KJC� �������� ������������
������� ���"� ���� ������ �����<��� +!*� �������� �������������� ������K��������X���:����������������������:������������������<������(���!�����(����<�>��������on page 42.
TOP VIEW
3
2
4
5
6
7 9
11
13
12
2
14
15
17118
16
108
FRONT
TOP VIEW COMPONENTS1. ������;��������&���6�!��)����������2. ������� ����� ����� ���� ������ ��������� �:����� ��� �����
<����� ���� �\������ ����� ��� ������� =��� ����������?������������������:��������� ��� ���� �����������������<�������������<�������������������������������������������������� ���� ������ ���������� �� ����������:�����������������������������������������<�����������������:���������=������?������������������<������������������������
3. !������� !����� ]���� =!!]?� ��������� ����� ������������� ���� ������ �����<��� <���� ������� ����� ���� !!]���������� ������ ��<�������� ���� ������� ���� ������ ��������������"�����!�����(����<�>���������������_��
4. &���6�!� X������ }�� J��<��������������������������������������<����������(��������(������������&$�
5. J�������������������^�_�������6!�6. ]������ J������ ���� �������� #�<����� ������ �������� �����
���������������������������������������������������������=�< ����?� ���� �� ���� ������ ������� ��� ��� ������������ ���������������<�<������������������������������� ����������������������������������������������������������������
7. ����������������_�6�!�W���6��:��8. (����� ���� ����� ���������� (��� ���� ��\���<����� ��� ����
Supply Gas Line on page 13.9. +��W�������������������#�<���������������������������
���� ����� ������������������������ ������� �� ������������������������ ���� :��<���<<� ��\���<���������������������<�<������������������������������� ���������������������� �������������������������������������������(����� ���_���������W�����������@�\���<������������&$�
10. ]�������:�����������#�<�������������������������������������������������������������������������������!< �����
Figure 3
9
���������� ������K��������X���:����������������������:������������������<������(���!�����(����<�>��������on page 42.
11. Temperature-Pressure Relief Valve. See Temperature-Pressure Relief Valve on page 15.
12. ��<�������^��������@������6��:�����������������^������/��6��:��*��������������@�\���<�������������&��
13. +������<���������� �"�&����� ��<���������� ����������������������������������<�<������������� �������������������<��������������������������������������������
14. �����������������^�&�&)���#������������15. �������������������:��:��16. !< �����]�����17. 6�������������=�}������� �?�^�_�������6!�18. !��������� ����� ����� &)�� ����� �6!� ������ ���������� (���
V��������������&������!���������*����� J�������������page 36.
SIDE VIEWS
1. !������ ������� �����"� �:���� ������ ������� �������opening.
2. !!]���������^�����V�����$������������������������3. &���6�!� X������ }�� J��<������������������������
���������� ���� <���� ����� ^� ���� ��\���<����� ��� �����Supply on page 13.
4. J�������������������^�_�������6!�5. (������������������������(���(�����W���+�����������&$�6. +��W�����������������"���������������������V�����$���
��������(����� ���_���������W�����������@�\���<�������page 13.
7. ��������������_�6�!�W���6��:��8. ����������������^�&�&)���#������������9. 6V*� =:���� ��� ���\����� ���:�?� ����� <��� ���:�� ^� ^� ����
V�����$������������������������10. KJC�=���� ����������<���?������KJC� �������� ������������
������� ���"� ���� ������ �����<��� +!*� �������� ����
10
8 162 76
5
11
12
17
18 13
14
15
RIGHT SIDE
11
12
14
15
13
3
2
1
4
56
7
89
10
LEFT SIDE
Figure 4 Figure 5
10
STORAGE CAPACITIESTABLE 2
MODEL U. S. GALLONS LITERS
BTH 300 130 492
BTH 400 130 492
BTH 500 130 492
Figure 6
���������������<����������������������������������<�������#�������(�����������W���������;������"�6�<��JJJ"��#(J���&�&��$�)�!(��_�$���������<���������������������������������"�������<��������������������������
ROUGH IN DIMENSIONS
GAS LINE CONNECTION SIZETABLE 1
MODEL SERIES NATURAL GAS PROPANE GAS
BTH 300 100/101 &�&)_��#�� &�&)_��#��
BTH 400 100/101 &�&)_��#�� &�&)_��#��
† BTH 500 100/101 &�&)_��#�� &�&)_��#����������� �����������������������������]�;����������������<�������\����
��&�&)���<���<<����������������^������� ������������&$����<���<<���\���������������������������*��������������������������\�:������������"����)�������< ������������������������"�������������������������<�����:���� ������������ ���������<���<<���\�����������̂ �����W���+����(�������������$%�
TABLE 3U. S. GALLONS/HR & LITERS/HR AT TEMPERATURE RISE INDICATED
C��� Type ofGas
Input �V ���V $��V _��V ���V ���V %��V ���V ���V &���V &&��V &���V &$��V &_��V
Btu/hr kW �! &&�! &%�! ���! ���! $$�! $��! __�! ���! ���! �&�! �%�! %��! %��!
BTH 300Natural
$��"��� 88GPH 1746 1164 873 699 582 499 436 388 349 318 291 269 250
Propane LPH 6610 4406 3304 2644 2203 1888 1652 1469 1322 1201 1102 1017 945
BTH 400Natural
$��"��� 117GPH 2328 1552 1164 931 776 665 582 517 466 423 388 359 332
Propane LPH 8813 5875 4406 3525 2938 2518 2203 1958 1763 1602 1469 1356 1259
BTH 500Natural
_��"��� 146GPH 2878 1919 1439 1151 959 822 720 640 576 523 480 443 411
Propane LPH 10894 7263 5447 4358 3631 3113 2724 2421 2179 1981 1816 1676 1556
@��:������������������� ���������������<����������������]�;�$��"�]�;�_���������������<����������������]�;�����
INSTALLATION CONSIDERATIONS
35°
20°
70°
18°
45°
45°
CLEANOUT
T &P
VALVE
GAS
*1 1/2” NPTWATEROUTLET
FRONT
TOP
DR
AIN
V
ALVE
INTAKE AIR4 INCH PVC
VENT
4 IN
CHPV
C
FRONTBACK
CLEANOUT
T & P
3/4” NPTDRAIN
1 1/2” NPTWATER INLET
4” PVCVENT CONNECTION
(exhaust elbow)
4” PVCINTAKE AIR
CONNECTION1 1/4” SUPPLY GAS
CONNECTION
33.12” (84.1 cm)OUTSIDE
DIAMETER
4.86”(12.34 cm)
50.77”(129 cm)
75.50”(191.8 cm)
69”(175.3 cm)
69”(175.3 cm)
12”(30.5 cm)
* Center line of water outlet on top of the water heater is 7 inches from the front edge of the water heater.
WATEROUTLETHEIGHT
63 INCHES(160 cm)
CONDENSATEDRAIN CONNECTION
1/2 INCH PVC
RECOVERY CAPACITIES
11
LOCATING THE WATER HEATER
!�������� ����� �� ������� ��� ���� ���� ������ �������� ���������<���������:�����<������������������������������������������������������ ������������������<������<�������������������������
Property Damage Hazard
All water heaters eventually leak.
Do not install without adequate drainage.
CAUTION
����������������������}������������������������������������������������������������������ ���:�����������������������������1. �����������������<��� ���������������2. �����������������<������ ����������������������������������
��� X�����������������<���������3. +����������������������������������������������� X������
�����������<���� ����<:����:�������4. +����������������������������:����������5. +��������������������������������������������������������
����� �� ������� ����������������� ���������� ���� ���������������������� ��� ������ �����<���� �� �����������X���������������������������������������������������������������������������� ���:����"����������<<�������������<��������������"����\�������������"� �������������������������������
6. +����������������������������������������<�X�����������usage.
7. +����� ���������������������� ����&���6�!�������������(��������(������������&$������\���<�����
8. +����������������������������������\���������������������� ����< ���������:�������������� �� ��������(�������Requirements on page 17.
9. +��������������������������������:�������������������������"������ ���������"� ����� ��<���� ������� ���� <�}�<<� �\�:����������������������(���6�������@�\���<���������������
10. *� ��� ������ ���� ������ ������� ������ ����� =���� ������� !< ����� ]����?� ������ ��<��� �������� ����� �� X������ ��������X������������
11. *� ��� ������ ���� ������ ������� ������ ���� � ��\���������������� �� ���� :���� =�}����?� �� ������� ���� ���<������������ �� X������ ��� ��� �� ����� ��� ���� ���<������=�?����������������������������������������<�����������������(���6�������J�������������������&�
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
���������������������������� ����������������������������������������������<�"�����������������������������������"��������<<� ��� ��\���� �� ������� ���:��� �\��<���� �� :�������� ���������"���������������������V��<<� ���:������������:���������:�������������������<��� ���������� �������������������������������C����]�������<�����������������}������V��<<� ������<�"���������������������������������������������������������������<�����:��� ���������������X������������������heater.
CLEARANCE TO COMBUSTIBLE MATERIALS���� ������ �������� �:����� ��� ����� <����� ���� ����:��� ������������������< ��� ���������������������������< ��� �����������< ��� �������������<��������� ����� ��������� ���� ������������������������������������������������������������������:���������������������������:��NOTE:����\��������������������:����������� ��<������������������������������(���(��:����!��������� ����
TOP VIEW
0
00
ALCOVE
FRONT VIEW
CLEARANCES TO COMBUSTIBLEAND NON COMBUSTIBLE
CONSTRUCTION MATERIALS
WATERHEATERFRONT
TOP COVER
FRONT
Figure 7
SERVICE CLEARANCE�����:�����������������_��������=�&��<?������ ��<������������<� ���:���� ��� ������ ���� ��� �����/�� :��:�"� ������ �����<��<������"�����:��:�"���������������"�������:��:�"������:�������������=�}������� �?��������������������������+��:�����<��� �<� ��� ���� ��� � :�� ���� ������ ������� ���� ����� �����}������� �����������������(���V��������������&��INTAKE AIR AND VENT PIPE CLEARANCES����<���<<�������������<��< ��� ���<����������������:����=�}����?����������������������������� ������������6�����������������������������������������< ��� ������������������<��� ��������������=��X����?�
12
EXTENDED VENT TERMINATIONS
�������������������:����� �������<��������� �����������������_��������������������������������)��:�����������������<�}�<<���%���\�:�����������=�&�$�<?���������������������)��:��������������� ���}�����������&����\�:�����������=$����<?� ��������������������������(�������6�������@�\���<�������������������� ������ ������� ������ ��<� ���� ������� ����� ��� =�?� _� ��������<�������� ����� ���� _��� �6!� �� ��� ����� �� �� ���� �������������������������������������������:���������������������"��������������������������<��������<��� �������!�������������������� ��������������������������<����������< ���������������� �����:����������<����������������������<������=�?�
OPTIONAL CONCENTRIC TERMINATIONS
�������������������:����� �������<��������� �����������������*������6���������������������������������������<���������]�;� $��� <����� ���������� ����� _� ����� :���)������� ���� ��������������_�������������������<��������]�;�$���<�������������������� �� ����� :���)������� ���� ������� ��� ���� �� ����� �������������<�������� ]�;� _��� ���� ���� <����� <��� ��� ���� �� ��������������� ���<������� �� ���� �������������� (��� ���� 6�������@�\���<�������������������!������������<�������J�����������on page 27.!��������� ���<�������� <��� �� ������� ������������ !�������������������� ��������������������������<����������< ���������������� �����:����������<������������
�� _��!������������<������������������$������� ���!������������<������������������&__���
HARD WATER
������ ����� ������ ��������� �}���"� ������ ��������� �� ������������� ����� �� ������ �����<���� ��� ���<<������� ����� ���������������������������"����������"��������������"������������������������\��<����(���C����������������������������<����������<����������<:������������
CIRCULATION PUMPS
��������������<���������������������<���\�������������������������������������������������������X���������������������heater. See the Water Piping Diagrams beginning on page 67 for ���������������������������������<����(���!����������<���������*�����<����������������������������������<������J��������������������������������������������� ���� #������� '���������� !��"� #V��� %�� �� ���� !��������'����������!��"�!(��!���&����^ ����������������������<<�������������������<<���������������������(<��������������<�������<���������������������� ����������������� ��\���� ������� � ���������(<��������������<���<��� �� ������������ ������ @����� �� ���� �<�� <��������������������������� ����������\���<������
INSULATION BLANKETS
Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
J�������� �������������:���� ������������������ ��������}���������� �� ���� ������ �������� �� ���� ��� ���������� ����� �������������������������������������� ��������������������������� ������� �������������������������� ���������������������������������:����� �������<�����<�������}���������'����������������������������������������������������������� �������������\���<����"�<������������������ ������������������(���� �� ����� �� ������ ��� ��������� ������� �� �����������"� ������� ����� ������ ������������(��� ����V����������� !<������� ������� �� ����� <����� ��� ������������� ���<�������<�������� �����V��������������������������������������������������������\���������������< ����"���������������������������"������}�����"�����������������X�����������
�� DO NOT�������������������������������������������"������������������������������������������������ ���������< ���
�� DO NOT��:������������������<�+!*������������������heater.
�� DO NOT��:���������<�������^��������@������6��:���� DO NOT��:�����������������<���������������������������
����������������������� ���������������������� DO� ��������������������������������� ������<�����
<������������������<���������� ����������������:�������existing labels.
�� DO���������������������� ����������\��������<�������������������������"������ �� ����������< ������������
13
POWER SUPPLY
�������������������:����� ��� �����<����� ��\������&���6�!"�&��=������������?"���;�"�&���<�����������������<������� ���������������������������������������������������"��������� �����������������"����������#�������'����������!��"��#(J)#V���%��������!��������'����������!��"�!(��!���&�POWER FLUCTUATIONS AND ELECTRICAL NOISE���������� ��������� ������ �����<� ��\������� ������� ��� ���������������������������������������!������������������������������ ���������������������� X������������������:��������:���������������������������������'CJ�=�������<��������������������?���@VJ�=��������\�����������������?�<���������������������������<�������������<�����������������\����������������������)��������������������������+���� <���� ('+V)�^&�� (������ (!^+� �� �\�:������ <��� �������������������� :������������}�����!������������������������������< ���������������� �����:����������<��������<���information. NOTE:�C���������������� �������������������������������� ����������������������������������:�������������� ��<��������������DEDICATED POWER WIRING AND BREAKERS*��������� ����� ������ �����"� ����� ������� ���� ����������������� ����������������:���������������������������������� ���������������������������������������������POLARITY SENSITIVE���������������<����������������������:�������������<�������� �������� �������:��� ���������� ��<�� �������� ��\����� ���������������� ���� ������ �����<� ��� �����<<��� �� <����� �������<����������������J������;������#�������������������&���6�!������������������:�����"����������������<����������������V���������������������"���������������������� ������ ����������������������������������������������������������<��������������������!�@�:�������V����<�������������+!*�(���'������������������������$����������������������������
TABLE 4
MODEL�C�#JV>+*��@'((K@' �CJ#JCKC�(K��+B��@'((K@' �C� JCKC�(K��+B��@'((K@'
NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS
BTH 300 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?
BTH 400 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?
BTH 500 _�����!��=&������? &������!��=��_�����? ��������!��=&�������? &&�����!��=��%_����? &������!��=��_�����? &������!��=��������?
��C������������������������������������ ����������������������������@������������������ ��¡���$�����!���������������:��������������������������������������������������<�������������������������&�"����������V�����:������� :��&�"���������=$"�_��<�����?�����;������������J����������������������
��C���<<�������������������������������������������������������������=��������������?��#*��������������������=����<����������?��(�������������<�����:�������� ��������<���<<�:������(����������������������� ��<��������������������������������������������������<<��<���������������������������J���������������������<��������&�������!��������� ������������������������������<�=��������)�������?�<��� ��������������������������(����� �������������(�����W���@���������\���<����� �����(���(�����W���+����J������������������$%�����(�����W���@�������J������������������$���������������������������������������also.
��C�}�<<������������������������������������������������������������=��������������?��#*��������������������=����<����������?��(�������������<�����:����}����������<�}�<<�:����
SUPPLY GAS LINE
����������������������������������:�������������<�������\����������\����:�<���� ���������������������������� ���������������:�<������ ����� �� �������� ������"� ��������������������� ��������� J���������� ���� ������ ���� �������� DOES NOT� ������������ ��������� ���� :�<�� �� ���� �������� �� ���������������������<�����<���� ��������<�}�<<������������������������������ ���_������<���<<����������� ���������������� ����� �����<��� �� ���:�����������������������������������������\����:�<�����������������:������DO NOT������}� ���������������(������������������:����<���������������������<�����\���������������������������������������� ������(���W���+����(������on page 37.MINIMUM SUPPLY GAS LINE SIZETABLE 5
MODEL *NATURAL GAS PROPANE GASBTH 300 &�&)_��#�� &�&)_��#��BTH 400 &�&)_��#�� &�&)_��#��† BTH 500 &�&)���#�� &�&)_��#����#��������]�;����������������<�������\������&�&)���<���<<�����������
�����������*��������������������������\�:������������"����)�������< ������������������������"�������������������������<�����:���� ������������ ���������<���<<���\�������������������������� ���^�����W���+����(������on page 37.
SUPPLY GAS REGULATOR
����������������������������������:����� �������<�������\�������������������������� �������������������������������������:���������������������������������������(������������������������\������������������������������������������<���NOTE:�>��<�����������������������������������������������������������:������������������������������������������������������������������������:����������������������(������������������<��� �������������� :�����������]�)�����������������������������������������(��������������������������:��������������������������������������������<���<<�������������������������������������������������:��������������� ����������C�}�����$��^%+����\�:������������<<������See Supply Gas Regulator Installation on page 38.
INSTALLATION REQUIREMENTSGAS PRESSURE REQUIREMENTS
14
HOT WATEROUTLET
TO TANKINLET
CHECKVALVE
MIXINGVALVE
COLDWATERINLET
TEMPERED WATEROUTLET
12” TO 15”(30-38 cm)
CHECKVALVE
Figure 8
����#�������(���������V��������������<<�����������������&���V�=���!?�������������������������"�������������������� �� :���� ������� �� ����� ��� ���� ��� ����� ���� ������������� �������������������������������������������������� ��X������������:����&���V�=���!?�������������������������^���������������������<����������X��� ��� �� ���������� �� ���� ���� ���� :��:�� ���������� ��� �������������������������������������������<���#�:������������������������������������<���(��������������������*�����<��beginning on page 67.NOTE:����<���������#(V�(������������������������\���<��������� ��<��������������������<��� ��������������������������������� ������������������:��������������� :���������
CLOSED WATER SYSTEMS
������ ������ �����<�� <��"� ������ �� ���� ��\���<������� ���� ��������� ��� ����� ����� �������"� �<��� �����"� ��:������������ ��:����� ���� ��� �������� �������� :��:��"� ������:��:��"����� ����������:��������*�:��������������������������������������<��� ���������������<�
THERMAL EXPANSION
������������������"�����}������=����<����}������?��J���������������<�����:�<��������������������������� ������������������:�<��������������� ����������� ���� ������������ �����������������������������������<����}������������<����}�������������������<�����������������=�������?������������������������ ��� �:����� ����� ���� ��<����� ���������� ����<��� �}�������������������� �����<���������<�������^��������@������6��:����������� ������ ����������� ��<� ���� :��:�� ��� �� �}�����:���������� ���������������������������:����������������<���������������������<�������^��������@������6��:���������������������������������������������<����}��������� �������� ������ ����<��� �}������� ����� <��� �� ���������� ������ ������ �����<�� �� ������ ���� ���<��� �������� �� ����<����}��������!�������� �������< �������:����������� ����:��������<����}����������������������(���������+����!����������������_�����������������������Diagrams beginning on page 67.
MIXING VALVES
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
�������������������<�����������������������������������������"�������������"�������������������������������������������������<������ ��X��� ��� �������� (���� ��������� �������� ������������� ���<����������������������������<�����������������������������}��������������������������<���������������� ���������V�=&&�!?�(<�� ������ ���� <��� ������� �� �� ���<�������� ��X���� ����� ������ ����� ������������� ������� ���� �������"� ��������"� ��������<� ���� ���� ����������)<�������� ���� ������� ��� �� ����� ��������}�<���� ��<�^�^ ��� ������������ ��� ��<��� ����� ������J�� ������ ����� ��� ������ ��:����� �� ���� ������ ������� ������������������������������������������������������������������������������\������������������������<������������������������"������������������������<��� ��������J������������������������������� �����<������������������������������������<�����������������������C�}����6��:������� ��������������� �����������������=����V������?������ ��������������������������������������<���������<��������C�}����:��:��������:���� ��������< �����������������!������� `������� J��������� �� (��:���� �������� V���� <�}���� :��:��<��������������������������������������������:��:���TABLE 6
Water Temperature ��<��������������/�$��*������]�����������(���
&���V�=���!? Nearly instantaneous&%��V�=%%�!? Nearly instantaneous&���V�=%&�!? � ��&)�������&���V�=���!? � ��&^&)��������&_��V�=���!? +�����������������&$��V�=�_�!? � ��$��������&���V�=_��!? More than 5 minutes
DISHWASHING MACHINES
���� ������������ <�������� <������� ���� #������� (���������V���������\���<�������������������������������������������������� �������&�������������������\���������=&�$���������&%$����?��V������������� :���������������\���������=&%$����?"��� ����&������������\���������=&�$����?"����������������<�������������������������������������������������"����������������������������������������������:��:������� �� ���� ��� ���� &���V� =���!?� ����� �� ���� ������������ <���������������� ����X�����������:����������������� �������������limits.
15
Water Damage Hazard
Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.
CAUTION
T&P Valve Discharge Pipe Requirements:�� Shall not be smaller in size than the outlet pipe size of the
:��:�"�����:������������������������������������������� (�������� ����������� �������� (�������� ���}������������������<����������� (����� ����<��������������������������������� ������ (����� �������������������������<����������������� ���
������<�������^��������@������6��:��������������������pipe.
�� C������<��������<�}�<<�����}��������� :����������������}������������� ��������J���������<����"����������<<������������������������������ �����<����������������\��������������������� �������
�� (����������:������:��:��������� �������� ������������������:��:����������������
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
The Temperature-Pressure Relief Valve must be manually �������� ��� ������ ������ �� ������ !����� ����� �� ������ �������������=&?��������� ��� ������������������������� ������<�������^�������� @������ 6��:�� ���������� ����"� ���� =�?� ���������� <������� ����������� ����� ��� ����� ���� ����� ��X��� ���������� ��<���� ������ ���� ������ <��� �� �}���<���� ���� J�������� <������� ��������� ���� :��:�"� ��� ������ �� �<�������� ���������������������������������"��<<���������������������������������� �� ����������������"� ����� ������������� ����������� ��� �����<����"�������������������<�������^��������@������6��:����������������������)�������������NOTE: The purpose of a Temperature-Pressure Relief Valve is �����:�����}�����:����<������������������������������������������ ���� �/�� :��:�� ��� ��� ��������� ��� ���� �������� ������� ������<����}����������������������������<����}������������<��� �����������������������������<��������������<����}������"�����!�����������(����<����������<���'}��������������&_�J����������������������������������������:������\�����������������������<�������^��������@������6��:���������������������< ��� ������� �� ���� ���� �:��� �� ����� <����� ��� ���������������������
TEMPERATURE-PRESSURE RELIEF VALVE
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
����� ������ ������� ��� ��:����� ����� �� �������� �����)������ ������������� �< ������� ��<�������^�������� @������ 6��:�� =�/��:��:�?� ������<���������������:��:�������������� ���������������������������������� �����������<����������������������������� �������� �� ������� �\��<���� �� <��������� ��� <������� ������\���<����� ���@������6��:��� ���;��������(�����(����<�"��#(J���&������!(��_�_"���������������\���<��������(C'�J�� ��������"� ���� ���� �/�� :��:�� <��� <���� ���� ��\���<������� ����� ����"� �� ��� ����� ����� �� �< ������� ��<�������^�������� @������ 6��:�� �����)������ ���� ��������� ��� ���������� ������� � :�� ����������� ���� ���� :��:�� <��� �� <������ ����� ��<�}�<<� ���� �������� ��� �� �}����� ���� <������ ���������������������������������������������=&�������£�&"�$�����?��������������������������������������������������������]�)�����������������������������������������������<������������� ���NOTE:�J�����������������������������������<�������^��������@������6��:��������������������"��������<��������������������<��� ��������������������������������������������������<���������:�� ��������������������"� ��������������:�����<�������^�������� @������ 6��:�� ����������� !���� ���� ���� ����� ����������������������< ��� ������������� �����:����� �����<�������������������������������������������<�������^��������@������Valve for remote storage tanks.V���������������������������������"�������<�������^��������@������6��:��<������ ����<:�����<�������������������������� �������� ���� ��<�������^�������� @������ 6��:�� <��� ������������������������������������������������������������������������������:��:���J���������������������������������������������������}����������������������������=&�����<?�� :��������\������������"����}������� �� ���� �������� J���������<����� ��� ��� ���<<�������������� �����<����������������\��������������������� ��������]���������������������������<���������������:����������������������������������������<������ �� ������������������������������������<���������'}�����:��������"�:���$�������=��&_�<?"��������<������������� ��������������������������������������������������������������:��:��#� :��:�� �� ����� �������� ��� �� �� ������� ������� ������<�������^��������@������6��:����������������*��������������������� ������� ��������� �� ���� ������ ������ �� ��� =&���� �<?����� ���� ��� ��:������ �� ���:���� ����� ��X��"� ������� �� ����"� ������������<���"������������:��:��<��� ��������������������������� ������\����\��������� ����� ����<����������<����� J��������������������������������������������������������� ���<����"��������������<������������������<����
16
CONDENSATE DRAIN
���� ������ �������� �:����� ��� ����� <����� ���� ��������������������� ���� ��\���� �� ������� ������ �� �� ������� ��� �������}�<�����������������������������������������!������������������<��������������������������}������� ������������ ���� ��<����������� �������������������������� �����<��� ��� �� ���:����� � :�� ���� ���������� ������ �����������������������������"�����V�������� � J�� ��������������������� ������ �������� ��� ����� ���� �� ��� ���� �}����� =:���?� �� ������������� ��������� ��������� ������������������ ����]������'}������������������������������������������������������<�<������ ���� �������� ��������"� ��� ���� ]������ '}����� (���������������������� ���������������<������ �������������� ����������� ��������� ���� �]������ '}������ V���� <������� ����� �����������������������������<���+!*"�����V��������������!�������� �����������������%�NOTE: J�������]������'}�������V����<�����������:������������������������������<�+!*"��������������������������������������������������� ������
CONDENSATE DRAINLINE - FIELD INSTALLED
CONDENSATE DRAINLINE CONNECTION
EXHAUST (VENT)ELBOW
BUILDINGDRAIN
FACTORY INSTALLEDCONDENSATE TRAP
CLEANOUTPLUG ISREMOVEDTO CLEARDRAIN
Figure 9
CONDENSATE DRAIN WATER TRAP
Ensure a functioning water trap isinstalled in the condensate drain.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
*� ��� ��<:�� ���� ������� ���������� ���������� ����� ��� ���������"� ���� V����� ��� ���� ������ ��������� :���� ����� ��� ������� ������� �����:�� ������������� ������ ����� ���:����� ��� ��������<���������� ���� ���� �����������������(���!���������*�����Installation on page 36.CONDENSATE PH LEVEL���� ���������� ������� ��<� ���� ������ ��������� �:����� �������� <����� ��:�� �;� ��:���� ������� _�$� ���� ����� J������� ���<<����������:���� ������������������������\����� ������������NOTE:�+�����;���:����������������*�������������<���������������"� ���� ��� �����"� �� ���� ������ ������� ��� ����� ������� (���!���������*�����J������������������$��
COMBUSTIBLE MATERIAL STORAGE
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
����� ���������� ����� ������ ���� ����� �� �< ��� ��� <��������"��������������������<<� ���:�����������\����
CONTAMINATED AIR
Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
!������������������������:���������<�<������������������< ����� �������� �������� ���<����� :������ (��� �������<�����������������������������������}������!< ����� ���� ����� ��� ����<������� ���� �������� ��<������ ��������� ����� �� ���� ������ ������� ���� ������ ������� �<������������������������������������� ��������������������������������"� ����� ���� �������"� ������ �������� ���<������ �������<������������������������������������������������������������< ����"�:�������������< ������������������������<����*��������������������������������������������������������������� �������������������������������������������������������������������<�������J�����������"������<���������������� �� ���������<���<����������������������<����������������� :����� ����� ������� �� ������ ������� ��� ��� �� �� �����:����<�������� =(��� ��<����� ��������� ��� �<������ ���<�� ������������?�J������������������������ ��������� ���������"� �� �������"���������� ���� ����<����"� �� ����^���:���� ��������� ����� ��������������\��<���"���� ����<������:�����������������������=�?� �����������������*������6���������������������������������< ������������:��������������<�����������<����������������������intake air pipe. See Venting Installation on page 21.
17
UNUSUALLY TIGHT CONSTRUCTIONJ����������������� ��� �������"� �����������<��� �����\������ ��:���� ���� ��� �< ����"� :���������� ���� ������� �� ����������;��:��"���� ���������������������������������=����}�<���"� �������� ���������"� ���:���� ��������"� ������"� :���� ������"�����?���������������<��� ����:��������������<������������ ����������!������(�����������������������
CONFINED SPACE
��!������(����������������:�<��IS LESS THAN����� ������������&"����]�)���=_����<�������?����������������������������������������������������������������>��������<��� ����������������:������������������< ����"�:���������������������������������������������\��������������������������������������������<�������������:���������������������������������AND the total Btu/hr input rating of all ����������������������������������DIRECT VENT APPLIANCES��������������������������*������6�����������������������:��������������< �������<�����������<��������������������������������������������������������������������������������]�)�������������������������<�������������������������:����������������������������������EXHAUST FANS�������}�����������������������"��������������������� ����:������� �������� �����}���������������������}����� ���� ��� ������������� ���� ��<�� ������ ����� �� ������ ������"� ��������� �������� ����:���� ������ ���� <��� �� ��:����� ����� ���<<����� ������\���<�������������������������������<����������}����������K����������������������� ��������� �� �������� ���� ���� �<��������������������������:���������<������������< ������(����"���������<���������������������������������������������}������<����������J�������������������������������}������LOUVERS AND GRILLES��������������������������������������������������������������������������������������������������������:���"�������������������������������������� ��\����� ����� �� �������� ��� �< ����"� :���������� ��������������������� �� ��������������������������������������������������������������������������������:������������������������ ����"� ��� ������ �� ���� ��� ����������� ���� ����� �� ���������\���������:���������������������������������������:����������������������������������������������"� ��������� �����<������������:�����������:��������������������<������:�����������������������:��%��������������#��<��������:���������������������� ���}���������������������
AIR REQUIREMENTS
Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
V���������������������\�����������������������<���������������< ���������:����������<��� ����:�������������������������������������������������������< ������������ ��������� ��� ����<������� ����� <��� �� �������� ��������(���������������������������������������"��<���� �������<�"���������������������< ��������< ��"� �������������� �����������������������������}������*� ��� �������� ���� ������ ������� ��� �� ������� ������ ������ ������\��������������������< ���������:������������� �������� �� ����� ������ ����� ���� <������ ������ ��� ��� ���� !������(������������������������#�:��� ���������������:���������������J������:������� �����\�������������"����������������������V����������:���������������<������< �������������������������������}�������������������������<���"������� �������X�����������
UNCONFINED SPACE
���K��������(����������������:�<��IS NOT LESS THAN ���� ������������&"����]�)���=_���� ���<������������?�����������������������������������������������������������������@<���<<��������������������������������"����������������������������� ���������"� ������ �������� ��� ��������� ����� ���"� �����������������������������������������C����� ���� ��\���<����� ��� ���� �������� �� �}����� ����"���������:���������������<�"��������������������������������������� ������������ ��������<������ �������\�������������� ����:�����< ����"�:�������������������������
18
���������:����������������<������������"��<<��������������&���������=$���<<?�����������������������"������� ����:������(��� V����� &&�� ���� ������ ������� ������ ��:�� ����������� �� ���������&������=���<<?���<��������������� �����������������=����<<?���<������������������������������������������������������<<������������������������������<<���������������:����������������������� �� ����������������������� ��������<<���������������������������������:����<���<<�������������������������1. &��\�������������$����]�)���=%���<<��������?������������
��������������������������������������������������"����2. #�����������������<�������������������:����������������
����������
OUTDOOR AIR THROUGH TWO HORIZONTAL DUCTS
Figure 12
���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<�����������������������������������������<<�������������������������������(���V�����&��'�����������������������:����<���<<�������������&��\��������������"����]�)���=&&���<<��������?����������������������������������������������������������������������������������������"������������ ����������<��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������<���<<���<���������������������������������� ���������������$���������
FRESH AIR OPENINGS FOR CONFINED SPACES
���� �������� ����������� ������ �� ���� �� ��������� ���� ����"��< ��� ���� �����<���� �� �������� ��:������ ������ ���� ����< ����"� :���������� ���� ������� ��� ������� �������� ������������������������������������������<������������������������ ���� �������� ����� ��:���� ������ ���� ���� ������� �������only. DO NOT refer to these illustrations for the purpose of vent ������������� (��� 6������� J����������� �� ����� �&� ��� �<������:������������������������������
OUTDOOR AIR THROUGH TWO OPENINGS
Figure 10
���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<�����������������������������������<<�������������������������������(���V�����&��'�������������������:����<���<<�������������&��\�������������_"����]�)���=����<<��������?���������������������������������������������� ���������� ��� �������������'�������������������� ������������&����\�����������=�_���<�?��
OUTDOOR AIR THROUGH ONE OPENING
Figure 11
19
AIR FROM OTHER INDOOR SPACES
Figure 14
���� ������� ������ ������ �� ��:����� ����� ��� ���<�������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<����������������(���V�����&_�'���� ������� ������ �<<������� ��������� ����� ��� �����������<=�?������������:�<��������������< �����:�<���������������<������������������������K��������(�����'�������������������:����<���<<�������������&��\������������� &"���� ]�)��� =&&��� <<�� ���� ��?� �� ���� ���������� �������������������������������������������������������'�������������������� ������������&����\�����������=�_���<�?��
OUTDOOR AIR THROUGH TWO VERTICAL DUCTS
���� ������������ ����� ��� ����� ������� �� ���� <����� ���� ������������ ��� ���� �������� ����� ��:���� ������ ���� ���� ������������������DO NOT refer to these illustrations for the purpose of vent ������������� (��� 6������� J����������� �� ����� �&� ��� �<������:������������������������������
Figure 13
����������������������� ����:����������������<������:������������"�����<<��������������&���������=$���<<?������������������<<��������������&���������=$���<<?������� ��<��������������������:��������������������<<�������������������������������(���V�����&$�'�����������������������:����<���<<�������������&��\�������������_"����]�)���=����<<��������?�����������������������������������������������������������������������������������������"������������ ����������<��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������<���<<���<���������������������������������� ���������������$��������
20
COMMONWEALTH OF MASSACHUSETTS
V�������������������<������"������������:�����������:���"��������:���"�����������������:������������������������������������������:������������"� ������������������������������������������������������������"������������������������������ ������!<<���������������������������������}�����:�������<���������� ����� �������:���=%?� ������ :���������������� ��� ���������������:������"���������� �������<�����������������������"���������������\���<����������� �����������
INSTALLATION OF CARBON MONOXIDE DETECTORS
��� ���� ��<�� �� ������������ �� ���� ����� ����� ��������� :���������� �������\��<���"� ���� �������������< �������������������� ���:�� ����� �� ����� ������ ��� �� <�}���� �������� ����� �������<����� ������� ���^��������������������������:������������������\��<��������� �������������J���������"������������������< ��� �� ��������� ������ ���:�� ����� �� ������� �������� ���������������� ��<�}������������������������<���������������� ����� ���������� ��:��� �� ���� ��������"� ������� �� �����������:��� ������������������������:�����������������\��<�����J�������� ������������� ����������������������������������������:�������\��������������������������������������������������������������� ��<�}�������������
J�� ���� �:���� ����� ���� ����� ����� ����������� :������ ���� �������\��<��������������������������������������������"������������������� ��<�}���������������������<����� ������� ���^��<��� ��������������������}����X�����������:���
J�� ���� �:���� ����� ���� ��\���<����� �� ����� � ��:����� ���� ��� ��<������������<�����<��������������������"������������������:�� �� ������ �� ������� =$�?� ����� �� �<���� ����� ���� � :����\���<�������:����������������������������=$�?����������"��� ������������������ ��<�}������������������������<������� ������������
APPROVED CARBON MONOXIDE DETECTORS
'������� ��<�}�����������������\���������������������������� :����:�������������<���������#V���%������� ���#(J)K+���$_������������!(�����������
SIGNAGE
�� <����� �� �������� ������������� ������ ������ �� ���<��������<����� �� �����}�������� ���� ������������<���<<����������������=�?������� :�����������������������������������}�����:�������<�����������������������:�������������������������������������\��<������������������������"�����������������������������^�����=&)�?�������������"�“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS.”
INSTALLATION REQUIREMENTS - COMMONWEALTH OF MASSACHUSETTSINSPECTION
���� ������ �� ����� ���� ��������� �� ���� ����� ����� �����������:���������� �������\��<�����������������:�� ���� �����������������"� ��� ���������"� ���� ��������� ���:��� ��� ��<�}�����������������������������������������������������������:���������_��!C@�����=�?=�?�&�������_�
EXEMPTIONS
���� ���������\��<���� ����}�<��� ��<��_��!C@�����=�?=�?&�������_�
1. �����\��<��������������!�������&������������'\��<����#��@�\�������]��6��������������<�������������������#V����_����������� ������]��������
2. ����������:��� ����� ����� ����������� :������ ���� �������\��<��������������������<����������������������<�������������"� ������"� �� ������������ ���������� ��� ����� ����������������������
MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM PROVIDED
����� ���� <���������� �� ������ ����:��� ����� ���������������� :������ ���� �\��<���� ��:����� �� :������� �����<����������:������������<��<������������ �����\��<���"� �����������������:����� ������<���������� ��� �������������� �����\��<������������:������������<��������������
1. *��������������������������������������������:������������<��������������:������������<��<�����������
2. ���<������������������������:������������<����������:�������system.
MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM NOT PROVIDED
����� ���� <���������� �� �� ������ ����:��� ����� ����������������:���������� �������\��<�������������:���� ���������� ��� :������� ���� ��� �����"� �� ���������� ��������� :������������<�"�� ���� �������� ��\���<����� ������ �� ��������� �� ����<����������
1. ���� ����������� ��������� :������� �����<�� ����������� ������ �� �������� ����� ���� ���������� �� �\��<���� ����������� �����������������
2. �������������:������������<��������� ������������:��� ������]���"���������������������������������<����������������������������������������������������������������
�� ���� �� ���� ������������ ����������� ��� ���� ����������:������������������������:���������� �������\��<���"����� :�����������������"� ���� ������ ������ ��� :������� ����������"� ���)�� ����:������� ������� ����������� ������ ��<���� ����� ���� ���������� �� �\��<������������<�������������������������
21
��:���� ��� ���\���� ������ �� ������ ���� ���� ������ �������<��� �����������������*������6��������������
2. J�� ���� ������ ������� ��� �� �� ���������� ��� �� ����� ���"� �� ��� ���"� ��������� ���� ����<���"� �� ������� ����� ��������������\��<�������������������������<������������������<������:�� ����� ���� ������ ������=�?� �� ���������� ��� �� *������6���� ���������� �� ����� ���� ���� ��� �< ����� ��� ����:�����<�����������<�������
3. ����:��������������������������<������<�����������4. ����<���<<�������������<��< ��� ���<��������� ��� ����
:����=�}����?����������������������������� ������������6����������������������������< ��� ������������������<��� ��������������=��X����?�
5. �����������������<��� �������������<����������������������������������������
6. ����:����=�}����?������<������ ���< ���������������������������������������:���������<������<����
7. ���� ����������������<������ ���< ���������������� �����������������������������������������
8. +��������������������������������:����=�}����?������������������������������<���������������<�}�<<��\�:����������������������(���6�������@�\���<���������������
9. *����������������:�����������������������������<����������������������������� ������������������������
10. 6����������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�
11. *��������������:������ ������������������������������<��������"����������������������� �������������������������������������:����:� �������������<� ����������<������
12. K�����������:���:���)��������������������������<����������See Venting Requirements on page 22.
13. K������� ���������������:�������� �����������������������terminations. See the Venting Requirements on page 22.
14. *� ��� ������ ���� :���� =�}����?� �� ������� ���� ���<�������������� ����� ���� �� X������ ��� ��� �� ����� ��� �������<������=�?����������������������������������������<����������������
15. *������:����������������������������������������"�����<�"����� ������� ������� ���� ����� ������������ �� ��� �������@����������� �� ��� ������ ����� ����� �����"� ���<������������ �� ���� ����� �}�������� ���� ������ �� ���� �< ��������� ������� ������ ��:���� ���� ��������� �� ���:���� ���������������� �� ��� �����"� <�������� ��� <��� ��������� ������� ��� ��������������������������:�������<��������
16. *��������������:�������<�������:������ ���������������������������:������������������������������������
17. '������������������������������������������<�����������������������������������:���� ��������������:���������<�
18. (��������:�����������)������������ ������������������������� ���<������ ������������� J�� ������ ����� ���<��� ���� ���� �� ���������������������"���������������������<:��������������������������������"����������<��� ����������"������������<������������<��� ����<������������������������������}�������J��������������������<���<�����������������
19. !�����������������6�������@�\���<�������������������������������������6�������J�����������(�\�������������$�
VENTING INSTALLATION
Breathing carbon monoxide can cause brain damage or death.Always read and understand the instruction manual.
Install vent system in accordance with codes. Do not operate water heater if flood damaged.Special consideration must be taken with installationsabove 10,000 feet (3,048 m) refer to high altitudesection of this manual.
Breathing Hazard - Carbon Monoxide Gas
Do not operate if soot buildup.
Do not obstruct water heater air intake with insulatingjacket or blanket.
Do not place chemical vapor emitting products nearwater heater.
Gas and carbon monoxide detectors are available.
Never operate the heater unless it is vented to theoutdoors and has adequate air supply to avoid risksof improper operation, fire, explosion or asphyxiation.
Analyze the entire vent system to make sure thatcondensate will not become trapped in a section ofvent pipe and therefore reduce the open crosssectional area of the vent.
#�:���������������������������������������:������������������������������������������������������<�����<��� ������������:����������< �������������������������������(������������ ����� ������ �� ���� �< ����� ���< ��"� �������������� �����������������������������}������
GENERAL VENTING INFORMATION
���� ������ �������� �:����� ��� ����� <����� ���� �������������\�:������ �� !������� J6� ����������� ���� <��� �� ���������� �����������������6������*������6��������������CATEGORY IV APPLIANCE!������� J6� ����������� ������� ����� �� �����:�� :���� =�}����?�������������������������:�������� ��<��������� �������� �������������������������:�����������POWER VENT CONFIGURATION����� 6���� ����������� ����:�� ���� �< ����� ���� ��<� �����<� ������ ����� ���� ���������� ���� ���������� ���� ��� ������ ������������<������� ���������������:���� =�}����?������������:�����������������:�����:����������������������������������������������� �����<������������:��������������������������<�����(���V�����_������V�����_&��������$��DIRECT VENT CONFIGURATION*������6�������������������:�������< ��������������������<����� ���� ��<������� ������ �� ������� ������� ���� ����� �������������� ���� ��� ������ �� ���� ���� ��<������� ������ ���������:����=�}����?�������*������6�����������������:����������� ��������� �� ���� ������ ������"� ��� :���� ����� ���� ���������� ���� ������ *������ 6���� ����������� ���� �� ���<�����������������}������������������<������(���V�����_���������$��������V�����_%��������$$�
GENERAL VENTING INSTRUCTIONS
�����������������<��� ����������������������������1. DO NOT������������������������������������6��������������
������ ������ ��� ���\���� ������ �� ������ ���"� ���� � ����@�\���<������������&%��J�������������������������������
22
=�}����?����������������������������� ������������6�����������������������������������������< ��� ������������������<��� ��������������=��X����?�MINIMUM EQUIVALENT LENGTHSFour Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <���<<� ������� �� _� ����� ����� ��� ���� :���� =�}����?� �� &���\�:������ ����� =_��� <?�� ������ ��� �� <���<<� �\�:������ �����requirement for the intake air pipe.Six Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <���<<� ������� �� �� ����� ����� ��� ���� :���� =�}����?� �� %���\�:������ ����� =�&�$�<?�������� �����<���<<��\�:������ �����requirement for the intake air pipe.MAXIMUM NUMBER OF ELBOWS����:���������<�����:����<�}�<<�����}������� ������������������ ������� ���� ����� <��� ��:�� �� <�}�<<� �� ��}� ���� �� ��������������J'�������*������6������������������������������:��������}�=�?������� �����������������=�?�_����� ����\������=&?������� ���'���������� ������\�:���������������=&���<?��������������"�_����� ��������\�:�����������������=��%��<?���������������FACTORY SUPPLIED FITTINGS���� ������ ������� ������ ����� ��� =�?� ������� �������� _� ��������<�������� =�6!� _��� �� ��� ����� �� ���� ������?�� V�������������� :���� ���� ������� ���� ���<�������� �� �������������<�������� <��� �� ����� V������ �������� ���<�������� ����������������������=�}������� ������ �������������������?����������\�:�����������������:��������������������������NOTE:� $� ����� ������� ���� ���)�� :���� ���<�������� ���:��������������� �� ����� ]�;� $��)_��� <���� ������������� <��� ����������� ����� ������� �������� _� ����� �� �� ����� ���<�����������������������������������������TABLE 7
Number of 90° Elbows Installed
4 Inch Pipe 6 Inch PipeMaximum Feet (Meters) Maximum Feet (Meters)
>���=&? ��������=&����<�����? &&�������=$����<�����?
���=�? ��������=&����<�����? &&�������=$$���<�����?
������=$? ��������=&����<�����? &��������=$����<�����?
V��=_? ��������=&����<�����? &��������=$����<�����?
V�:��=�? _�������=&$�%�<�����? ��������=�����<�����?
(�}�=�? _�������=&����<�����? ��������=�%�_�<�����?
6 INCH EXTENDED VENT TERMINATIONS������� ����� �������������:��������� ��� ���������������������������<�������"��������������������������<��������<��� �������!�������������������� ��������������������������<����=������< ���������������� �����:����������<����?������������������<������=�?�OPTIONAL CONCENTRIC TERMINATIONS]�;� $��� <����� ���������� ����� _� ����� :���)������� ���� ��������������_�������������������<��������]�;�$���<�������������������� �� ����� :���)������� ���� ������� ��� ���� �� ����� �������������<�������� ]�;� _��� ���� ���� <����� <��� ��� ���� �� ������������������<���������������������������!�������������������� ��������������������������<����������< ���������������� �����:����������<������������
�� _��!������������<������������������$������� ���!������������<������������������&__���
VENTING REQUIREMENTS
APPROVED MATERIALS����:���:������������������������<��������������<��� �������������K������(������
�� �6!�(�������_��=�(�C�*���_&�)�!(��]&�&��"��(�C�*�&%���)�!(��]&$%�$
�� !�6!�(�������_��=�(�C�V^_&&�)�!(��]&$%��?�� �](�=�(�C�*^���&?
����:���:������������������������<��������������<��� ���������!������
�� K+!�(�$���6!�)�!�6!
FIELD SUPPLIED FITTINGSV�������������������������� ���\�:�������������������<�������� ����������������V��������������)��������������������������\�:�����������������:������ ��������������������� ���������� ���������������������)���������� �������� ���� ������� <��� �� �������� ���� �����\�:�����������������������
�� ������ ���=����������������?������\�:����������������������=&����<?���������
�� _����� ���=����������������?������\�:������������������������=%���<?��������
PRIMER AND CEMENT�������������� =�;V?� ���<��� ����� �� ���� �� �������� ������������������������������������:�������������J��!�6!����](�������������������������"������������������<����<��� ��������� ���� X����"� ��������� X������ ���� ����� �� ���� ������� ��:��������<�������� =�6!� <�������?�� �6!� C��������� ����� ����(�C�*^���_�W�����!�<�����!�6!�C������������������(�C�V^_�$�W����� !�<���� ���� �](� C��������� ����� ��� �(�C� *^��$��W�����!�<����PIPE SIZE REQUIREMENTS�������������������:�������������<������������������������������_������������������������:����=�}����?������������������������J�����������������\�:���������������������������������:���������������� ��%�������=�&�$�<?�������"�_�����������<��� �������J�����������������\�:������������������ ��<��������%�������=�&�$�<?"�������������<��� ������NOTE:�J�����������������������\�����������������������\�:���������������������������������������� J'��J�� ���� ��������������������� ��%���\�:��������������������������:��������������<��������%���\�:��������������������������������<��� �����������������_�������������������:����<��� �����������������������������MAXIMUM EQUIVALENT LENGTHSFour Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <�}�<<� ������� �� _� ����� ����� ��� ���� �}����� :��������������<���� �� %�� �\�:������ ����� =�&�$� <?�� ���� ���������<�}�<<� ���������_� ���������� ��� ������������������ �������%���\�:������ ����� =�&�$� <?�� J'�� >�� *������ 6���� ������������� ������������� ������%���\�:�����������=�&�$�<?��Six Inch Pipe���� ������ �������� �:����� ��� ����� <����� ���� ��������� ���� <�}�<<� ������� �� �� ����� ����� ��� ���� �}����� :��������������<���� �� &��� �\�:������ ����� =$���� <?�� ���� ���������<�}�<<��������������������������������������������������&����\�:������ ����� =$���� <?�� J'�� >�� *������ 6���� ������������� ������������� ������&����\�:�����������=$����<?�INTAKE AIR AND VENT PIPE CLEARANCES����<���<<�������������<��< ��� ���<����������������:����
23
�}������� ���������������������11. J�������������������������������������_����������������������
V����� &������� ����� ���������� _�� ����� ������� ���� �}������� �������������}�_��������������������� ��&���������=_���<?������������������
DIRECT VENT INSTALLATION
1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ������������������������������������� ��\���<�����<��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� *������ 6���������������
2. *����<���� ������ *������ 6���� �������<���� ����� �� ���� ������� ������������� ������ ���� ��}� =�?� *������ 6���� �������<���������"�����������$������$$�
3. *����<����:�������� ��������������������� �� ������ ��� ���������������������6�������@�\���<���������������
4. ��������������������:�������������������������� �����������<� ���� ���<������� ����� ����� �� ���� ������ ��������+���� ����:�������� ������������������ �������<���<<�������������� ���
5. J��������������<��������������J�� ��������� ���<�������� ���� ����� ���� ���� ���� ������� ������ :���� ������� ����� ���<������ :���������"� ������ �� ��"� ����6�����������<�������J�������������������_��J��������������<������������ ������������������������������:�������������������<����������������"�����������������"�����(�����������<�������J����������������������J�� �� ���������� ���<������=�?� ����� �� ���� ���� !���������Termination Installation on page 27.
6. ����� ������������ �� ���� ���<������=�?� ��� �<������ J�������������������������������������������������������������:����������� �����������������������
7. ���� ���������������:�����������<��� ���������������������:��� ��������� �������������������������<�������������<<��������������:�������������������������� �����������:�����������=&����<?���:����������������:����$������=�&��<?�of horizontal run.
8. *����������������:�����������������������������<����������������������������� ������������������������
9. ������������������������������������������������������� �����������������������������������������������������������������������<�������������:���������<������������������������� ��������� �}��������� ����� �<������� ���� ������ ��������� �� ����� ��������\���������������������� ��<����������������������������(���V�����&����������_�NOTE:�(��� ����������������������������������������������<�������������������}�����:���<���������������<������������<������������������<�����������<"��<�����������������������}�����:����������������������������������������������<���������<������������������<�������
10. ����:����=�}����?�������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�
11. J�� ����������� _� ����� :���� ����� ������� ���� :���� ����� �� �����}������� ���������������������
12. J�� ������������� �����:��������� ���������� ��_� ������������� �����}������� ���� ������������������������� ���V�����&������������ ����������_������� ������� �����}������� �������������}�_��������������������� ��&���������=_���<?���less in length.
VENTING INSTALLATION SEQUENCE
1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ��������������������������������� ���� ��\���<����� <��� �� ������� �� ����installations.
2. *����<���� �������� ���� ������ ������� ����� �� ���������� ����� ����� 6���� �� *������ 6���� ���������� ���� ������ :���������<��������<��������� ��������������������������(�������:�����:��������������<�������������$������$$�
3. �������������������� �������������������������������������������6����J�������������*������6����J�����������
POWER VENT INSTALLATION
1. @���� ���� W������� 6������� J���������� �� ����� �&� ����6�������@�\���<��������������� ������������������������������������� ��\���<�����<��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� ����� 6���������������
2. *����<���������������6�����������<��������� ������ ��������������������:����������������������<��������(���V�����_������V�����_&��������$��
3. *����<��������:��������������������������������"�����6�������Requirements on page 22.
4. ����� ���� ����� �� ���� :���� ������� ��������� ��<� �������<������� ����� ����� �� ���� ������ �������� +���� ����:������������������<���<<�������������� ���
5. J��������������<������������J������:�������������������<������:���������"�����������"�����6�����������<�������J�������������������_��J�� ���� :���� ������� ����� ���<������ ����������"� ������ ����������"�����(�����������<�������J���������������������
4” PIPE FIELDSUPPLIED
EXHAUST ELBOWVENT CONNECTIONFACTORY INSTALLED
6” PIPE FIELDSUPPLIED
6” x 4” REDUCERFIELD SUPPLIED
VENT (EXHAUST) CONNECTION
Figure 15
6. ����� ������������ �� ���� ���<������� ��� �<������ �����������������������������������������������:����������� �����������������������
7. ����:���������<��� ���������������������:��� ����������������������������������<�������������<<��������������:��������� �����������:�����������=&����<?���:����������������:����$������=�&��<?���������������
8. *����������������:����������������<����������������������������� ������������������������
9. ����:����=�}����?�������<��� ������������<���<<�����&)_������������� �����������������������=���������������������������?�
10. J�� ����������� _� ����� :���� ����� ������� ���� :���� ����� �� ����
24
14. ]�;�����#��K@�+�W�(�C>*'+(�>#+B�������������� ������������� =��<:��� ��� ���� ���:��� ����?� �� ���� J������ �������<�������������������������\�:���������������������������������������� ������������������*����������� �������������������������<�������������������������\�:���������������������������������������� ��<�����������������(���V�����&%�
15. J�������������_����������������������������������������������������������������������������������������������
16. J��������������������������������������������_������������������������������������ ������������������������� ���V�����&����������������������_������� ������������������������������������������}�_��������������������� ��&���������=_���<?�or less in length.
3” PIPE FACTORYINSTALLED
6” PIPE FIELDSUPPLIED
4” PIPE FIELDSUPPLIED
6” x 4” REDUCERFIELD SUPPLIED
4” x 3” REDUCERFACTORY INSTALLEDINTAKE AIR CONNECTION
INTAKE AIR CONNECTION
INTAKE AIR
COMBUSTIONBLOWER
Figure 18
VERTICAL TERMINATION INSTALLATION
1. *����<�������������������������<������=�?�2. J�� ��������������� ����:���� =�}����?� ������� ����������6����
���������� :���������� ������ ���� ���� ������ ����� �����}������ :�������� ���������� ��\���<����� ����� ��� V�����&������V���������������������� �����<������������������������������������������� ������������������������<��� ��<����������NOTE:�>��������������������������:�������<�������<��� ����<���<<����_��������=����<?�� :�������������"�:������������������������������&�������=$�<?�������������(���V�����20 on page 25.
3. J�� ����������� ��� ���������������:����������� �����*������6�������������� :���������� ������ ���� ���� ������ ����� �����}������ :�������� ���������� ��\���<����� ����� ��� V�����&������V���������������������� �����<������������������������������������������� ������������������������<��� ��<����������NOTE:�>������ ��� ������������� ���� ��������������� ����:�������<��������<��� ����<���<<����_��������=����<?�� :������ �������"� :�������� ����� �� �������� ������� &�� ����� =$� <?�������������(���V������������������
4. J�� ����������� ���� :���� ������� ��� �� ����� 6���� ����������:����������������������������������������������<��� �������������:�������<�������<��� ������������������������������������V�����&������V���������������������� ��<������������:�������<�������<��� ����<���<<���&���������=$���<?"�&���������=_���<?����!�����"�� :�������:���������}�������������:��������������V�����&��on page 25.
5. J�� ����������� ��� ���������������:����������� �����*������6����
INSTALL TEE FITTING AS CLOSE TO WATER HEATERINTAKE AIR CONNECTION AS POSSIBLE
INTAKE AIR CONDENSATE TEE INSTALLATION
FIELD SUPPLIED3” x 3” x 1/2” TEEWITH HOSE BARBFITTING INSTALLED
FACTORYINTAKE AIRCONNECTION
INTAKEAIR
PIPING
CONNECT FIELDSUPPLIED FLEXIBLEDRAIN HOSE TO BARBFITTING AND FORM ALOOP WATER TRAP INDRAIN HOSE
RUN DRAIN HOSETO SUITABLE FLOORDRAIN SEPARATELYFROM OTHERCONDENSATE DRAINS
Figure 16
13. '���������]�����������������J����������(������������J���������� !�������� ���� ��� ��<:��� ����� ���������� ��������������������������������������"�����V�����&%��
Do not obstruct water heater air intake.
Gas and carbon monoxide detectorsare available.
Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
NOTE:� *� ��� ���:�� ���� ������� ������� ���� J������ ������������� ��� *������ 6���� �������������� >���� ���� ������� ��������� ��� ���������� ���� ������� ����� �� ������� ��<� :���� ����<��� ��<���������������� ����:�����<�������������������<�������< �����
INTAKE AIR CONNECTION DETAIL
4” x 3” REDUCERCOUPLING - FACTORY INSTALLED
BALANCE PLATE(remove for Direct Vent)
(reinstall on the Intake Air Termination of500,000 Btu/hr natural gas models with
50 equivalent feet or less of intake air pipe)
INTAKE AIR SCREEN(remove for Direct Vent)
Figure 17
25
10. J����������������������������������������)��:�������<������=�?�������������������������������������������������� �������������V�����&��������������������������������������� ������������������������������ ����������������������������<������� <��� ��� �� �}�����:�� ��� ������������ �}������������� ���������������� ����<��� ������� �������=���<?"�����V�����&��
INTAKE AIR AND/OR VENTTERMINATION(S) MUST BE A MINIMUM OF 24 INCES (60 cm) ABOVE ANY PARAPET, VERTICALWALL OR STRUCTURE WITHIN10 FEET (3 m) HORIZONTALLY.
VERTICAL TERMINATION(S) FLAT ROOF CLEARANCEINTAKE AIR AND/OR VENT (EXHAUST)
24 INCHES (60 cm)MINIMUM HEIGHT ABOVE
IF LESS THAN
10 FEET (3 m)
Figure 20
11. @������������6����J�������������������$���*������6����J�������������������$����<��������������������������������������� ���)�� :���� ������� ������� ���� ���<������=�?� ���� �����������������
VERTICAL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS
24 INCHES (61 cm) MINIMUM48 INCHES (122 cm) IN COLDER CLIMATES
FACTORY SUPPLIEDSTANDARD TERMINATIONSPOINTED DOWNWARD
FIELDSUPPLIED90° ELBOW
VENT (EXHAUST)TERMINATION
INTAKE AIRTERMINATION
FIELD SUPPLIEDPLUMBINGROOF BOOTSOR FLASHINGS
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATED SNOW LEVEL.
Figure 21
���������� :���������� ������ ���� ��� ���� �������������������<��� ����������������������������:����������<�������������������<���������������������������V������&������������������������������:�������<��������<��� ��������������������������������������<����������������������V������&�on page 25.�������������������:�������<��������<�����:����<���<<��������������_��=�&��<?�<��������������������������������V������&������������ J�����������<������������������������� �����������������������_���������=&����<?����� ��<� ����� �� ���� ������� ���� ���� :���� ���<��������<��� ����<���<<���&���������=$���<?"�&���������=_���<?���� !�����"� � :�� ���� �:������ �� �}������� ���� ��:��� �����������V�����&������V������&�����������
6. ����� ���� ������� ���� ���)�� :���� ������� ��<� <������������� �������� ����� ���<������ ��� ���� ��<�� ������� ���� :�������<�������� ���� �� ������ �������� ��� ����� ��}�<���� ��������)��������J�������������<���������������� ��������������������������}�<������������)������������ ��������� ������� ���� ������� :���� ���� ������� �������<�������� <��� �� �� <���<<� �� �_� ������� =�&� �<?� �����������V������&��J�����������<������������������������� �����������������������_���������=&����<?�
7. !�����������=&$��<?����<������������_�������������%������=&���<?����<��������������������������������������=�?������pass through the roof.NOTE:�]�����������������������������������������������through the roof.
8. (������ ���� ����=�?� ������ ������� �� ���� ����� �������������<������������������\�:������������<��������������������V�����&��
2” (5 cm)MAXIMUM FACTORY SUPPLIED
STANDARD TERMINATIONPOINTED DOWN TOWARDS
THE GROUND
VERTICAL TERMINATION(S) INSTALLATIONINTAKE AIR AND/OR VENT (EXHAUST)
FIELDSUPPLIED90° ELBOW
FIELDSUPPLIEDSTRAP/SUPPORT
FIELD SUPPLIEDPLUMBINGROOF BOOTOR FLASHING
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL.
Figure 19
9. (����� �� ��� �� �� �\�:������ �������� :��� ���� ����� ������������� �����\�:�������������������=����V�����&�?���������������������������
26
SIDEWALL TERMINATION INSTALLATION
1. *����<�������������������������<������=�?�2. J�� ����������� ���� :���� =�}����?� ������� ��� �� ����� 6����
���������� ������ �� ���������� ������ ����� ���� �}���������������������������\���<����� ��� ���� ���<������"��������� V����� _�� �� ����� $_"� ���� ����� <����������� �������������������������������� ������������������������<��� ��<����������
3. J�� ����������� ��� ���������������:����������� �����*������6�������������� ������ �� ���������� ������ ����� ���� �}���������������������������\���<���������������<�������"���������V�����_���������$�"��������:����������������������<����������� �����<������������������������������������������� ������������������������<��� ��<�����������
4. J�� ����������� ��� ��� ������� ���� ���� :���� ���<������� ��� ��*������ 6���� ���������� ������ �� ��������� ������ <��� ����<���<<����_� ������� =�&��<?����������"�<��������� :�������� ������� ����"� ������� ���� ������� ���� ���� :�������<�������"�����V��������NOTE:�J�����������<������������������������� �������������� ��� ������ _�� ������� =&��� �<?� ������� ���� ������� ���� ����:�������<����������������������������:��������������������<�����^���������� �������������������������������� ���������� ������ �� ����� :��� ��<� ����� ������ ������ �}�����:�������������������������<�����������������<<���������!���������������������
5. J�� ����������� ������������������:�������<�������������*������6���� ���������� ������ �� ��������� ���� ������� ���� ����:���� ���<�������� <��� �� ���������� ��� ���� ��<�� ���:�����<������������������������������^�����V��������
VENT (EXHAUST)TERMINATION
INTAKE AIRTERMINATION
INSTALL ONELEVATION
CENTERLINE
24 INCHES (61 cm) MINIMUM
48 INCHES (122 cm) IN COLDER CLIMATES
KEEP INTAKE AND VENTTERMINATION SCREENS
CLEAR OF DEBRIS
SIDEWALL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS
Figure 22
6. ����� ���� ��������������)��:����������� ��<�<�����������������������������<���������������<�������������������������"����� :���� ���<�������� ���� �� ������ �������� ��� �������}�<���� ^� �� ������)�������� ���� ������� ���� ���<���������������� ��������������������������}�<����^���������)��������;��:��"�������������� ������������������:������������������� ���<��������<��� ����<���<<����_� ������� =�&��<?��J�����������<������������������������� �����������������������_���������=&����<?��(���V��������
7. !�����������=&$��<?����<������������_�������������%������=&���<?����<��������������������������������������=�?��������������������������NOTE:�]��������������������������������������������������������������
8. !�� �� ������=�?� �� ����� ����� ����������$��� ������� =���� �<?��������������=�_�&��<?����������������������������������������������(���V������$�NOTE:� 6���� ���<������� ¤� �}����� ������ �� ����� ����������������� ����������&_��V�� J���������<�����������:���� ��������}������������������������������������:��������������:�����}�������� �������������:�������������������������}������ ������� ��������� ���� :���� ���<������� ����� ��������� ������ ����� :���� ���� ���� ��������� �����������������������������'}�������������}�����:�����������������<�}�<<�������������=&�����<?����<����������������:������<� ����� �������� ����� �� ��������� ������ �� �:��� ������� ��<"�����:������������ �����<�������:����������������������"�����6�����������<�������J�������������������_�
9. !�<����������������������)��:�������<�������������������=�?���������������������������� :��(����
10. (�����������������<���������������=�?�:�����������=�?��������������� ���� ������� ���� ���)�� :���� ���<�������� ������ �<���������� �������� =����� �������?� �� ���� ���� �� ���� ����������=�?�����������������������
11. ������� ��<� �����"� ������ ���� ����� ���� ���<������=�?�����< ������������ :������������������������'������������<������=�?� ��� ������� ���� ������� ���� ������ (���V������$�
INTERIOR WALL EXTERIOR WALL
FROMWATERHEATER
COUPLING
SIDEWALL TERMINATION INSTALLATION INTAKE AIR AND/OR VENT (EXHAUST)
METAL PLATESINSTALL INSIDEAND/OR OUTSIDE
FACTORY SUPPLIEDSTANDARD TERMINATIONPOINTED DOWN TOWARDS THE GROUND
INCREASE EXPOSED VENTPIPING UP TO A MAXIMUMOF 6 INCHES (15.2 cm) FROM WALL TO HELP PREVENT VAPORFROM DISCOLORING THE WALLSURFACE IN COLDER CLIMATES
Figure 23
12. �������� ����������������������=������������?�������������� �������������������������=�?���������������������������������������� ���������������=�?����������
13. ������������������������������������������������14. ������� ��<� ���� ������������������������������������
���� ������ ���� ������������������=�?� ������ ��� ����������������������������������:���������������������=�?�
15. J������������������������������������=�?������������ ��������]����� ���� �������� �������� ���� ��<�� �� �<�������� ���� �������� ���� ������� ���� ������ ���� ���<������=�?� ��� �����������������������������������(���V������$�
16. @������������6����J�������������������$���*������6����J�������������������$����<��������������������������������������� ���)�� :���� ������� ������� ���� ���<������=�?� ���� �����������������
27
���<��������K�������(�������_���6!����}�����������������������������<������������ ���������� ���� ������� �� ���� ���<������� ���������<������ ���� ��� ���� ������� =������� ���?� ����� ������ !�� ������<���<��������������������<������=:���?������
10. *��������������������<������=�?���� �������������������_�J����!������������<�������J��������������������������J����!������������<�������J���������������������
CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL OR STRUCTURE.
4 INCH CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE
Figure 24
6 INCH CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE
CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL ORSTRUCTURE.
Figure 25
CONCENTRIC TERMINATION INSTALLATION
1. *����<�����������������������<������������ �������������]�;�$���<��������������������_������:���)�������������������������_�������������������<��������]�;�$���<���������������������������:���)���������������������������������������������<��������]�;�_�����������<�����<��������������������������� ���<������� �� ���� ������������"� ���� 6�������Requirements on page 22
2. *����<�������������������������<�������NOTE:�@�����<�������������������������������������������� �������<���"���������������������������������<�����������vent vapors are less visible.
3. �������������������������������<�������:����������������������������������������}������:��������������������\���<�������� �������������� ���<������"���������V������%���������������V�����$�����������"����� �����<������������������������������������������� ������������������������<��� ��<����������
4. �������������������������������<�������:������������������������"��������<���������:��������<��� ����<���<<���&�������=$�<?��������<������������"�:����������������������������������V������_�����V���������NOTE:�J���������\�������������������������"�:����������������������������� ��<���������"�������������<��������<��� �������(���6�����������<�������J�������������������_
5. �������������������������������<������������������������������� ����������}���������������������������\���<����� ������� ���<������"������ ���V�����_���������$�"����� �����<������������������������������������������� ������������������������<��� ��<����������
6. ����� ����������� <������� ���������� ���<�������� :���������������������������������������������������������������\���������������� ����������<����������������������<����������<������������<�����������(���������$������$&����more information.
7. !�� �� �� ����� =&$� �<?� ���<����� ���� ��� _� ����� �������������<�������� � �� %� ����� =&�� �<?� ���<����� ���� ��� �� ������������������<��������������������������������������������or roof.NOTE:�]�������������������������������������������������������������������
8. ����� ����������� <������� ���������� ���<�������� :���������������� ���� ��� ��� ������<�� ������� ���� ���<��������������� ���� ���������� ���<�������� <��� �� ��� ���� ��<�� �������<���������<�������(���C�������!������������<�������Arrangements on page 31.
9. *����<���� ��� ���� ���������� ���<������� ����� ����� �� ����������� �� ����������� �� ���<<����� ��\������������������������������:����������������������<�������������� ����������� <������� ���<�������� :���������� ������ ����������������<���������(���V����������������������V�������������������������<�}�<<�����<���<<�����������������������_������������������������������<������������� �}�������� ���� ������� �� �� ���������� ���<�������DO NOT� ��� ��������� ���� ��� �� �������� ����� ������������ ������ ���� ���<������� ���� <��� ����� �<�������< �������������<������������������������:����������<��� ���������������� ���������������� ������<�������<��������������}����������������������������<�������K��� ���� (*@^��� ����� �� �}����� ���� _� ����� ����������
28
4 INCH CONCENTRIC TERMINATION INSTALLATION
4 INCH CONCENTRIC TERMINATION KITFOUR PIECE KIT - FIELD ASSEMBLY REQUIRED
VENT PIPE
INTAKE AIR CONNECTION3 INCH PVC
VENT CONNECTION - 3 INCH PVC
INTAKE AIR PIPEY FITTING ASSEMBLY
VENT CAPVENT PIPE ASSEMBLY
VENT PIPE IS 2 1/2 INCH SDR-26 PIPESUPPLIED LENGTH 37 INCHES (94 cm)MAXIMUM ALLOWABLE LENGTH 73 INCHES (185 cm)MINIMUM ALLOWABLE LENGTH 25 INCHES (64 cm)
INTAKE AIR PIPE IS 4 INCH SDR-26 PIPESUPPLIED LENGTH 24 INCHES (60 cm)MAXIMUM ALLOWABLE LENGTH 60 INCHES (152 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)
VENT CAP
INTAKE AIR PIPE
3” x 3” x 4”Y FITTING
Figure 26
����< �������������������_�������������������<��������@�������V�������"�V������%�����V����������������������������1. !�<��������B������������������������<���������������������2. (�����������������������������B������������< �����<������������
������� ������ ����������� ��� ���� ���<������� ��� �������������������'������� �������<���������������� ������������<��������������������< ���
3. (��������������������B������������< ���������������������metal strapping or equivalent support materials.
4. >�� ������������� ���������� ������ ���� ��� ������ �� ���������������< ���� ���������������:������������������B������������< �������������������������
5. (���������������< ���� ���������������6. !�<��������:���������������:����������������������������^
������������������������������<��� ���������������������<������� �������������������������< ��� ����������� ������������������������<��� ����������������������������:������<���)���������������:�����������)��:���������
7. J�����������:�������):�������������< ����������������������B������������< ��"�'������<�������<�����:��������������<���������� ��<����������B��������
8. !�������������������������:�������������<������������������������_�������������������<�������������������������_��}�$���������������������������
9. @�������*������6����J�������������������$����<���������������������� �� ���� ������� ���� ���� :���� ������� ������� �����������������<����������������������������
NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.
ROOF FLASHING(field supplied)
STRAP(field supplied)
VENTPIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
4 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION
Figure 27
NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.
STRAP(field supplied)
VENTPIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
1 INCHMAXIMUM
4 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION
Figure 28
29
11. ��������:�������):�������������< ��� ���� ���� �����������B������������< ������������:�������������������������������������<����� �����������������'���������:��������� �����<�������� ���� �� ���^���� ������� ������ ���:����� ���������� �������B���������(���������:�������������������������������������������� ���������� ������ �������� J������� ���� ������� �������������^��������������������:�������� ���������������������������������<��� ���������� ��� ���� ���������������� �����:������<���)���������
NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.
ROOF FLASHING(field supplied)
STRAP(field supplied)
VENTPIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
6 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION
Figure 30
NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.
STRAP(field supplied)VENT
PIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
1 INCHMAXIMUM
6 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION
Figure 31
12. !�������������������������:�������������<��������������������������������������������<��������K����������������_�������������������}�_���������������������������
13. @�������*������6����J�������������������$����<���������������������� �� ���� ������� ���� ���� :���� ������� ������� �����������������<����������������������������
6 INCH CONCENTRIC TERMINATION INSTALLATION
6 INCH CONCENTRIC TERMINATION KITSEVEN PIECE KIT - FIELD ASSEMBLY REQUIRED
VENT PIPE
VENT PIPE IS 4 INCH SCHEDULE 40 PVCSUPPLIED LENGTH 46 1/2 INCHES (118 cm)MAXIMUM ALLOWABLE LENGTH 66 1/2 INCHES (169 cm)MINIMUM ALLOWABLE LENGTH 33 1/8 INCHES (84 cm)
INTAKE AIR PIPE IS 6 INCH SCHEDULE 40 PVCSUPPLIED LENGTH 25 3/8 INCHES (64 cm)MAXIMUM ALLOWABLE LENGTH 45 3/8 INCHES (115 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)
VENT CAPSTAINLESS STEEL
VENT TERMINALWITH SCREEN
INTAKE AIR PIPEINTAKE AIR CONNECTION6” or 4” PVC
VENTCONNECTION4” PVC
6” x 4” STANDARDREDUCER BUSHING
6” x 6” x 6”Y FITTING
6” x 4” NO STOP-LIPREDUCER BUSHING
INTAKE AIR PIPEY FITTING ASSEMBLY
VENT CAPVENT PIPE ASSEMBLY
Figure 29
����< ���������������������������������������<��������@�������V�������"�V�����$������V�����$&���������������������1. !�<��������B������������������������<���������������������2. !�<���� ���� ��� }� _�� �� ���^���� ������� ������ ���� ����
���������=:���?�����������B��������3. J������������������������ ������������������_����������"���<����
�������}�_������������������ ������ ���� ����������=����������?�����������B�������������������V��������
4. J������������������������ ���������������������������������������������}�_������������������ ������������� ������������������������������������������������������������������B��������
5. (��������������������B������������< �����<������������ ����������������������������������<�����������������������������'������� �������<���������������� ������������<��������������������< ���
6. (��������������������B������������< ���������������������metal strapping or equivalent support materials.
7. >�� ������������� ���������� ������ ���� ��� ������ �� ���������������< ���� ���������������:������������������B������������< �������������������������
8. (���������������< ���� ���������������9. (���������������:���������������_������:���������������<����
����:�������<���������������������:���������10. (���������:�������� ����������:���������������������������
:�������<������(���������:��������������:������������������������������������������� ������������� �����<��� �����������������������������:������<���)���������������:������������������������������������������ �����������:������������the terminal.
30
Four Concentric Terminations1. ��������������������������������<���������������������
���������������������������}�<���������<��� �������������������������������������������V�����$_�������������������������������V�����$��
2. V���������<�}�<<��< ������������������<�������������<��� �� ���������� ��� �� ���� ������ ���� ���<�������� ���� ����������}�<���������������V�����$_�
A
A
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
V�����$_
A B A
FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
B = 24 INCHES (61 cm)OR GREATER
CONCENTRICTERMINATION
CAPS END VIEW
V�����$�Groups Of Terminations1. ����� ����������� <������� ����� �� ���������� ���<��������
������������������������������ ����������}�<������������� �� ���������� ���� �������� ����� �� ��� ��� ����� ���V�����$���+����������������������������V�����$��<��� ����<�����:������� �������������������<���� ���<�������������������������:���� ���������
A
A B
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
EIGHT CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
B = 24 INCHES (61 cm)OR GREATER BETWEEN
GROUPS OF FOUR
V�����$�
MULTIPLE CONCENTRIC TERMINATION CLEARANCES ����������������<��������������������<��������:������������������ ��� �� ����������� ������ �� ��������� ������ ���� ��\���������������� =���������?� ������� ���<�������� ���� <�����������'����� <������� ���<�������� ���� ��������� �� ������ �����\�����NOTE:� ������ ����������� <��� �� <���������� �� ���:���� ������������������:����=�}����?�������������������������!��������������<������� ������������������������������������<����������������� �����������<����������������� ���<�������� �������� ����� ����������������� �������������������� ���V�����$��<��� ��<�����������(���C�������!������������<��������������<������������$&�Close Proximity & Standard Clearance1. �������������� �������<����������<������������<��� ����
�������=������?�����<�}�<<������������=���<?"���<��������̂ �V�����$�"������������������������������<������������������}�<�����(���V�����$%��������$&�
2. ���� ���������� ������� <������� ���<������� ����� <��� ����������������<���<<����_��������=�&��<?"���<������]�^�V�����$�"����������������������������}�<����=� :�?����������� �����������������������������������
A
OR
B
A = 0 - 2 INCHES (0 - 5 cm)
CONCENTRICTERMINATION CAPS
END VIEW
TWO CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
B = 24 INCHES (61 cm)OR GREATER
CLOSE PROXIMITY STANDARD CLEARANCE
Figure 32
Three Concentric Terminations1. �����������������������������������<�������������������
������������������� �������������<�������<��� ����������������������}�<����������������� ����<�����������V�����$$��
2. J�� ����� ��}�<���� ������������ �� ���� ������ ���<������� ��� ������� ��� �������������<�������<��� �� ������������� ���������� ����<������]����V�����$$�
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
THIRDTERMINATION
THREE CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
A
A B
B = 24 INCHES (61 cm)OR GREATER
V�����$$
31
Four Concentric TerminationsV���������������<��������<��� ����������������������}�<���������������V�����$���(���V�����$_�����V�����$���������$�������������� ����<���������������������������������������<����options.
SIDEWALL
ROOF
Figure 38
Eight Concentric Terminations'����� ���������� ���<�������� <��� �� ���������� ��� ��� ��������������� ��"� ��� �������}�<���"��������� ���V�����$���(���V�����$���������$������������������<�������������������+����������������������������V�����$���������$��<��� ����<�����:������� �������������������<�������<�������������������������:���� ���������
SIDEWALL
ROOF
Figure 39
MULTIPLE CONCENTRIC TERMINATION ARRANGEMENTS���� ������������ �� ����� ����� ���� �<�� �� ���� �������������������<����� ��� <������� ���������� ���<�������� ����� �����������(���C�������!������������<�������!�����������������$�������������� ����<���������������������������������������<����options.NOTE:� ����� <������� ���������� ���<�������� ���� ������������������������������<����������������<������������<��� �����������<���������<���������<�����������Two Concentric Terminations����������������<��������<��� ����������������������}�<������� ����� ��� V����� $%� �� ����� ��������� ����������� ����� ������������<�������������� ����(���V�����$���������$������������������<����� �� ������������ (��� V����� $$� �� ����� $�� �����������������������������������<��������
SIDEWALL
ROOF
Figure 37
32
VENTING ARRANGEMENTS
Power Vent VerticalFigure 40
Direct Vent VerticalFigure 42
Power Vent HorizontalFigure 41
Direct Vent HorizontalFigure 43
33
VENTING ARRANGEMENTS
Direct Vent Vertical Vent Horizontal IntakeFigure 44
Direct Vent Vertical ConcentricFigure 46
Direct Vent Horizontal Vent Vertical IntakeFigure 45
Direct Vent Horizontal ConcentricFigure 47
34
TERMINATION CLEARANCES SIDEWALL POWER VENT
V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED
v
v
A
GV
FIXEDCLOSED
FIXEDCLOSED
OPERABLE
OPERABLEV
C B B
BBF
B
V
V
A J
V
H
MX
XV
VK
B
E
D
L
POWER VENT(using room air for combustion)
EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION
Figure 48
������������ ������ �������������������������������������������� ��������������������������� ��������
CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2
A!���������� :�������"�:������"�����"�������� �����
&���������=$���<? &���������=$���<? H!������������������������������������}�������above meter/regulator assembly
$������=�&��<?�����������������&�������=_���<?�� :������<����) regulator assembly
$������=�&��<?�����������������&�������=_���<?�above the meter/regulator assembly*
B!���������������������������<��� �������
���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?���������������� :��&��"����]�)���=$����?
_������=&���<?� �����������������������&����=$���<?�� :��opening
I!��������������:����regulator vent outlet
$������=�&��<? $������=�&��<?�
C!��������������<�������������������
&���������=$���<?� &���������=$���<?� J!����������������<������������������������������ ����������< �����������������������������������
���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$���?"�$���������=�&�<?���������������� :��&��"����]�)���=$����?
_������=&���<?� �����������������������&���� =$���<?�� :���������
D
6��������������������:����������������������above the terminal ������������������������������������=�&��<?���<�����������������of the terminal
&���������=$���<?� &���������=$���<?� K!�������������<��������������������inlet
�������=&��$�<?
$������=�&��<?�� :������������&�������=$�<?�����������
E !������������:�������������� &���������=$���<?� &���������=$���<?� L
!���������� :����:����������������:������:��������������� �����������
%������=��&$�<?� %�������=��&$�<?
F !���������������������� �������=����<?� �������=����<?� M
!��������������:������"�����"�����"��� �����
&���������=$���<?�� &���������=$���<?��
G !����������������������� &���������=_���<?� &���������=_���<?�
&�J����������������������������!(��]&_��&"�#������W��������������J�����������!���
��J�����������������������������#(J����$�&)#V����_"�#�������V���W���!���
����:����������������<���������������� :�����������������:������:�������������������� �������������������<���������������������:��� �������������
�����<�������������:������"�����"�����"��� ����������������������<���<<������������ ��������������
��!�����������������������������������������������������������\���<�������������������������������<�����������������������������������
35
TERMINATION CLEARANCES SIDEWALL DIRECT VENT
V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED
v
v
A
GV
FIXEDCLOSED
FIXEDCLOSED
OPERABLE
OPERABLEV
C B B
BBF
B
V
V
A J
V
H
MX
XV
VK
B
E
D
L
DIRECT VENT(using outdoor air for combustion)
EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION
Figure 49
������������ ������ ����������� ������������������������ ������� ������������������������������� ��������
CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2
A!���������� :�������"�:������"�����"�������� �����
&���������=$���<? &���������=$���<? H!������������������������������������}�������above meter/regulator assembly
$������=�&��<?�����������������&�������=_���<?�� :������<����) regulator assembly
$������=�&��<?�����������������&�������=_���<?�� :������meter/regulator assembly*
B !���������������������������<��� �������
���������=&���<?�������������������&�"����]�)���=$���?"�&���������=$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?���������������� :��&��"����]�)���=$����?
���������=&���<?�������������������&�"����]�)���=$���?"����������=�$��<?��������������� �������&�"����]�)���=$���?�������"����]�)���=&����?"�&���������=$���<?���������������� :����"����]�)���=&����?
I !��������������:����regulator vent outlet $������=�&��<? $������=�&��<?�
C!��������������<�������������������
���������=&���<?� ���������=&���<?� J!����������������<������������������������������ ����������< �����������������������������������
���������=&���<?�������������������&�"����]�)���=$���?"�&��������� =$���<?��������������� �������&�"����]�)���=$���?�����&��"����]�)���=$����?"�$���������=�&��<?� ��������������� :��&��"����]�)���=$����?
���������=&���<?�������������������&�"����]�)���=$���?"����������=�$��<?��������������� �������&�"����]�)���=$���?�������"����]�)���=&����?"�&���������=$���<?���������������� :����"����]�)���=&����?
D
6��������������������:����������������������� :���������<�����������������������������������������=�&��<?���<��������������������������<����
&���������=$���<?� &���������=$���<?� K!�������������<��������������������inlet
�������=&��$�<? $������=�&��<?�� :������������&�������=$�<?�����������
E !������������:�������������� &���������=$���<?� &���������=$���<?� L
!���������� :����:����������������:������:��������������� �����������
%������=��&$�<?� %������=��&$�<?��
F !���������������������� �������=����<?� �������=����<?� M
!��������������:������"�����"�����"��� �����
&���������=$���<?�� &���������=$���<?���
G !����������������������� &���������=_���<?� &���������=_���<?�
&�J����������������������������!(��]&_��&"�#������W��������������J�����������!���
��J�����������������������������#(J����$�&)#V����_"�#�������V���W���!���
����:����������������<���������������� :�����������������:������:�������������������� �������������������<���������������������:��� �������������
�����<�������������:������"�����"�����"��� ����������������������<���<<������������ ��������������
��!�����������������������������������������������������������\���<�������������������������������<�����������������������������������
36
�����&)��������6!���������3. DO NOT���<:�"�<���������������������������������������INSTALLATION INSTRUCTIONS1. '�������������������������)��������������������������������2. J������� �� &)�� ����� �6!� ���������� ������ ����� ������� ����
�������������������������������!���������*�������������������� ��� ������������"�����V������������V������&�
3. ���<������������������������������������������� ��� :�������������'������������������������������}������������������������������<�����������������=&�����<?�� :�������� ��� ������������"����}������������� ������"�����V��������NOTE:� J���������<����� ��� ��� ���<<�������������������������� �����<���������������� �������������������� �������
4. '���������������������������������������:������ :�����������������������������������������"�����V������&�
5. ]��������������������������������������<��������������every three feet.
6. '����� ���� ���������� ������� ������� ������ ������ �"� ����Start Up on page 50.
WATER HEATER INSTALLATIONCONDENSATE DRAIN INSTALLATION
J����������� <��� ����<� ����� ������ ����������� ���� ����� ������������V�������������<�����������\���������������������������
�� ����:����6!���<���������6!����<����� &)��������6!������^�<���<<�����������\�����������������
���������������������������������� ��� ��������������� &)��������6!���������=�� ��������������?�������������
������������������������������� �����������!���������*��������������< ������������� ��� �������������
�� V���<���������������� ��������������������INSTALLATION NOTES1. ��������������������� ��<���������������������:����� ��
����� ������������:���;���:���� �������_�$���������� J����������<<����������:���� ������������������� �����\����� �������������+�����;���:����������������*�������������<��������������� ������ ����"� ���� ��� ������ ����"� �� ���� ������heater for this reason.
2. ���� ����� ���������� ���������� ������ ����� <��� ��� �� �����
CONDENSATE DRAINLINE - FIELD INSTALLED
DRAIN LINE TOTERMINATE NOMORE THAN 6INCHES (15.2 cm)ABOVE DRAIN
BUILDINGDRAIN
FACTORY INSTALLEDCONDENSATE TRAP
CLEANOUT PLUG SHOULDFACE TOWARDS THE FRONTOF THE WATER HEATER FORSERVICE ACCESS
EXHAUST (VENT)ELBOW
CONDENSATE TRAP DETAIL
PVC PIPE PLUG1 ¼” NPT
CLEANOUT PIPEPLUG SHOULDBE ORIENTED TOTHE FRONT OF THEWATER HEATER FORSERVICE ACCESS
PVC BUSHING1 ½” SLIP x 1 ¼” NPT
PVC BUSHING1 ½” SLIP x ½” SLIP
PVC TEE FITTING1 ½” SLIP x 1 ½” SLIP x ½” NPT
PVC PIPE NIPPLE½” NPT
½” PVC 90° ELBOWCONDENSATE DRAINCONNECTION. FIELDINSTALLED DRAINLINE CONNECTS HERE
½” PVC 90° STREET ELBOW
½” PVC PIPE NIPPLE
Figure 50
Figure 51
37
SUPPLY GAS LINE INSTALLATION
!��������������������������<���������������������\�������� ���:���� ��� �:���� ��� ���� �� ��:���� ������� ��� ����������������������������]�������������������<������������������������������������������������������������������������������������������\���<������� ���� ����� ���� ����� �\��<���� �������� �� ���� <������ J�� ��������<�����������������"����������<������������:��������������������������������<�����
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
C�������������������������<�����������������������������������rating label.�������������������:����� ��� �����<������������ ��������� ��������������������������&��������!��=��_�����?������������������� &����� ��� !�� =����� ���?� ��� ������� ���� ������ �������"������� ���_��������&$���������������������:�������������<�������\���� ������ ���� ��������� �� <�������� ��\����� ������ ������������� '}����� �� ������� ���� ������ �������� <��� �������<�����������������������������������������������}�������J��:�����������������������������������<����������������������������<��������������������������<������������������������ :��:�� <��� �� �������� ��� ����� �������� �� �� `�������(��:������������'�������������������:�������������������������:����:��:������������������������ �������������������<��������� �������������������<"���� ������������������6���� �������<��������������������<��J�� ��� �<������� �� ����� �������� ���� :��:�� ������ ��<�����<������������������������(���������<���������<�������������"��������}�������J���������������������������������<��� �������������������������������������������:����
REGULATED GASSUPPLY LINE
MAIN GASSHUTOFF VALVE
TEE FITTING
PIPE CAP
SEDIMENT TRAP(DIRT LEG)
Figure 52
'���������������������������������������� �������������������������������������������<������������������������������������<���������=��������?�<��� �����������������������V�����������������<��������� <��� �� �������� ������� ��� ���� ��� � X���� �� ������������������� J������� ��� ���������� ����� ���� ���<<��������� �����������������������<�����
GAS LINE SIZINGDO NOT������}� ���������������C���<<���\���������������������������������������� ������������&$��*�����������������:�������\�:����������������)�������< ������������������������������<<��<���"����������������������������<�����:���� ������������(���� ���������)<�������� ����=�?� �������������������� ��������� ����������:��������:�������� ����������� ����������������������������������������������¦����!��=&�����?������������"����������������������<����������������������<���#������������������������� ��������������������������������������������SUPPLY GAS LINE SIZING U. S. UNITSTABLE 8
LENGTHIN
V''�
#>@C�+��J@>#��J�'�(J�'(�=J#!;'(?INPUT IN THOUSANDS BTU/HR
&�&)_� &�&)�� �� ��&)�� $� _�10 1400 2100 3960 6300 11000 2300020 950 1460 2750 4360 7700 1580030 770 1180 2200 3520 6250 1280040 660 990 1900 3000 5300 1090050 580 900 1680 2650 4750 970060 530 810 1520 2400 4300 880070 490 750 1400 2250 3900 810080 460 690 1300 2050 3700 750090 430 650 1220 1950 3450 7200100 400 620 1150 1850 3250 6700125 360 550 1020 1650 2950 6000150 325 500 950 1500 2650 5500175 300 460 850 1370 2450 5000200 N/A 430 800 1280 2280 4600
SUPPLY GAS LINE SIZING METRIC UNITSTABLE 9LENGTH
INMETERS
#>@C�+��J@>#��J�'�(J�'(�=J#!;'(?INPUT IN kW
&�&)_� &�&)�� �� ��&)�� $� _�3.0 410 615 1160 1845 3221 67356.1 278 428 805 1277 2255 46269.1 225 346 644 1031 1830 374812.2 193 290 556 878 1552 319215.2 170 264 492 776 1391 284018.3 155 237 445 703 1259 257721.3 143 220 410 659 1142 237224.4 135 202 381 600 1083 219627.4 126 190 357 571 1010 210830.5 117 182 337 542 952 196238.1 105 161 299 483 864 175745.7 95 146 278 439 776 161053.3 88 135 249 401 717 146461.0 N/A 126 234 375 688 1347
38
GAS LINE CONNECTION1. �������������������:����� �������<�������������������<�
���� ��������������&�&)_�� ������������������"� ������ ���&��������&���(���������������������������������������������������������������������������������������������������_�6�!�W���6��:�������"�����V������$��!�����������������������������������������������_�6�!�W���6��:������������������������������� ��������������������������\���<������DO NOT������}� ���������������
2. ]�;����������������<����� =(������&��?� ��\������&�&)���<���<<�����������������������������������������:����� �������<�������\������&�&)_��<���<<����������� ������(���Table 5 on page 13.J����������������������&�&)���}�&�&)_��������������������&� &)_¦� ����� ������� �� ���<<����� ���� <���<<� ��\�����&�&)��� ���������� ������������� ���V������$���]�;����������������<�����=(������&��?�(���������������� ������������������������:�������������������Series number.
FACTORY INSTALLED1 1/4” x 1” REDUCERCOUPLING AND NIPPLE
SUPPLY GASCONNECTION
SUPPLY GAS LINE CONNECTION(500,000 BTU/HR MODEL SHOWN)
FIELD SUPPLIED 1 1/2” x 1 1/4”REDUCER COUPLING AND 1 1/4”PIPE NIPPLE INSTALLED ON 500,000 BTU/HR NATURALGAS MODELS
LOW GASPRESSURESWITCH
24 VACGAS VALVE
TO MAINBURNER
FLOW
Figure 53
3. ������ ������� �������� �<����� =����� ���)� ����� ����?�������������������������<�����������������������X������*�������������������<���������������������������K������������������������<��������� �������������������������������\���������<�=+�)������?�������
4. K����������<���X�����X��� ����������=���������<�����������?������ ������������ ����������_�6�!�W���6��:����������������������������������������������� ���������:��:���DO NOT���������������������������=(�������������?������<���������X������������<������<����������<��������:��:��
5. K��� �� ��������� ����� ������� =(������� ������?� ��� �� ���������������������������������������� :��������������������������������������� ��� �������������� ����� �����:���� �����_�6�!�W���6��:�����������������������<����������������installation.
6. �� ���:���� ��<���"� ����� <��� �� ������ ��� �� ������ ��<��� ��\�� ����� ���������� ���� ������ ���� ����� �� ������������������
7. J������� �� ����<���� ����� =����� ���?� ��� ����� ���V����������page 37.
8. Install a Main Gas Shutoff valve in the supply gas line as ��������V���������������$%�
NOTE:�(����:����������������������������������� ��������"������������C����W���(�����:��:���������������������
GAS LINE LEAK TESTING
Fire and Explosion Hazard
Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.
Use joint compound or Teflon tapecompatible with propane gas.
������<����������������������������������<������<����������������:����������� ���������������}������1. V�����������������}��������&)������=$�_�����?�����������
�������������������������C����W���(�����6��:����<���������������������������<��������������"�����V���������������$%���������������������<��� ����������������������������<������������������
2. V������������������&)������=$�_�����?�������"�������������������� ��� �� �����������"� �� <��� �� �������� ��<� ������������������� �������������C����W���(�����6��:��������testing.
3. �������������������������X�������������������������<����������������������������������������������������������������������] �������������������������*�������<������"��������"���<����������������������������������������
4. @���������������� �����������������������������������������
SUPPLY GAS REGULATOR INSTALLATION
�������������������:����� ��� �����<�����<�����:�������������� �������� ���������� ��� �������������� �������������� �� ������������������(�������J�����������@�\���<������������&$�1. �������������������������� ���������������������������������
��<����������������������������������2. (��������� ���������<��� �� ������������ :�� ���� �����
]�)�����������������������������������������3. (��������������������������:���������������������������
�����������������<���<<����������������������������������heater they supply. See Table 5 on page 13.The Maxitrol 325-7L supply gas regulator or equivalent is ���<<������
4. (����� ���� �������=�?� ������ �� ���������� �� ������ ����� $������=&�<����?��������������������&�������=$�<�����?���<�������������������������������������������
39
���������������:����������������<��������������Connecting An External Supervisory Control������� ��)���� ���������� ������������ ��<�����!!]���§�����������������!!]��������"�����V�����$����������������������!!]����������V�<����������������������������= ����?�X<������������������� ������������������&&�������§�����"�����V������&���������$�������������§������J���������������������������� ��)���� ����������1. ���� ��� ����� ��� ���� ������ ��������� �)��� ������� ���� ����
�����������������������������������������2. +���������!!]���������3. @�<:�� ���� ������� ��<� ���� !!]� �������� �:��� ����
�����������������!!]����������#���������������������������������������:����� ������������:����������������������������
4. ����:����������� ��)���� ���������������������(&�����������������!!]"�����V������&���������$���� ������(&��������������������������������� ������(&������������$������������������
5. +����� ���� ����� X<��������� �����������������&&�������!!]�§�����"�����V������&���������$�����V���������������64.
6. !������ �����X<����������������<������7. (���������}�<������&)��������������������<�������������
������ �����X<���������8. K��������������������� ���������������������������� ��
������������������ �����X<����������������������������������������������������������
9. �������������������������������!!]�������������������������������������������������������!!]����������:����'��������������������������������������������������:�����������������������'����������������� �������������
10. @�������������!!]����������:����������������������11. @������������������������������X������ }������������
����������������"�����V�����$����������������������X������ }��K�������:���� �������^�����������������������������X������ }�
12. J������� ����� ������������������������������� ��� ��\����� �� �������� ���� ����� ����� ������� ���� ������ ���������X������ }����� �����}������� ����:����� �������!�������������������<������}������������������������������������������X������ }�����������������������������������
13. !������ ���� ������ ������� �� �� ���� �� ���� �������� �� �����}��������������V��������������<�������������������������<����������������
14. @������������������������������NOTE:� �����:��� ���� �}������� ������ ����� ���� ���� �� ������������ ���"� �������� �������� ����� �� ���� ����� �����:��������}��������������������������������������������"����������������� ����� �� ��� ����� �� �������� ����� ���� ������� ��������:�����������<<��������������������������<��������������������������������������� �����(�������(�����J����������������in Table 11 on page 43.NOTE:� '����� ���� ������ ������� ��� ��������� ��<� �����������<��������� ����� �������� �������� ��� ���� ����� *�<���� ������������������������� �������������<����������������:����������������<��������������
ELECTRICAL WIRING
���� ����������� ���� <��� �� ���������� ��� ���������� ����� ����#������� '���������� !��"� �#(J)#V��� %�� �� ���� !��������'����������!��"�!(��!���&������������\���<�������������������"������������������<��� ���������������������������������������������������"��������� �����������������"����������#�������'����������!��"��#(J)#V���%��������!��������'����������!��"�!(��!���&�J����������������������������������������������������������<��� ����������"� ���<��� ����������������&���!���������������� �����\�:�����"��}������������ ������������J�������������������!������������<��� ������POWER SUPPLY CONNECTIONS@����������\���<�����������������(������������&$� ��������������������Correct Polarity:���� ������ ��������� ������ �����<� ��� �������� �������:�� ��������� �������������� ������������������� ��� �������������� ��������� ������ ��� ��:������� ���� ������ �����<� ����� �������� ������!� @�:������� V���� <������� �� ���� +!*������ &��� 6�!� ����������<����������������<���������������� �����������������X������ }���������&���6�!�������������<����������������������������������X������ }����������������������������������������<��� ��<��������������1. '����� ���� ����� ������ ��� ������ ��� ��� ���� ������� ��
�����������������2. @�<:������X������ }��:����(���V�����$�������������
X������ }���������3. !����������&���6�!�����������<����������������������
�����������������X������ }�����������������������������������������������������������������������������������������������������������(����������������<��V����������������_�����V������$�����������
4. !����������&���6�!���������������<����������������������������������������X������ }������������������������������������������������������(����������������<��V����������������_�����V������$�����������
5. !������ ���� ����� ����� ��<� ���� ����� ������ �� ������������ ��� ������� ���� X������ }��(����������������<��V����������������_�����V������$�����������
6. @������� ���� X������ }� �:��� ����� ���������� �����<������
NOTE:�*���������������������������������� ���������������������<�����������������������������������������������ENABLE/DISABLE CIRCUIT���� ������ �������� �:����� ��� ����� <����� ���� �\������ �������� ��� ��)���� ��� ������� ��� ��� ����� ����� �������� �}�����������:����� ������� ���� ��� ��<�� ������ �� ������� ]�������C�����<����(����<���������� ��)���� ����������<��� ������������ ����������������������������������������� ���������������������������������<������������������ ��� ���� ��� ��)���� ��� ������� ��� <��� ����� �� ����:����� ���������������(&��������������������������������!!]�=�������������� ���?"�����V������&���������$��V����������������������� ����� ���������� ������� �������������������!!]���������������������������=��:�����������?���������������������}��������������NOTE:����������������������� ��)���� ���������� ���������������������������*�����������}�������:������������������� ����=J'�� ������ ���?� �� ����� ������������������ ��<���� ����!!]��������
40
T&P VALVE DISCHARGE PIPE
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
����� ������ ������� ��� ��:����� ����� �� �������� �����)������ ��������������< ������� ��<�������� ^��������� =�/�?� �������:��:�� ������<�����������(�����<�������^��������@������6��:���������&���������<��������������<���������������\���<�����
Water Damage Hazard
Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.
CAUTION
J������������������������ ������������/��:��:����������������������� �� ���� ��� ��� ������� *� ��� ������� ���������� ���������������� �� ��������������������� =&�����<?��������� �����:�����������:���� �������X��"��������������"�������������<���"������������ :��:�� <��� �� ������� �� ���������� ������ ��� ���\����\������������������<����������<�����J��������������������������������������������������������� ���<����"��������������<������������������<����T&P Valve Discharge Pipe Requirements:
�� Shall not be smaller in size than the outlet pipe size of the :��:�"�����:�����������������������������������������
�� (�������� ����������� �������� (�������� ���}������������������<����������� (����� ����<��������������������������������� ������ (����� �������������������������<����������������� ���
������<�������^��������@������6��:��������������������pipe.
�� C������<��������<�}�<<�����}��������� :����������������}������������� ��������J���������<����"����������<<������������������������������ �����<����������������\��������������������� �������
�� (����������:������:��:��������� �������� ������������������:��:����������������
WATER LINE CONNECTIONS
�����������������������������<�������<������������������������ ������ ����������������� ��������������:���� X�����������W�������������\�����������������:��������� ����������@���� ���� ���:�� ���� ��\���<����� ��� ���� �������� �������� ������������������������������������ ������1. Mixing Valves on page 14.2. *�����������C���������������&_�3. Temperature-Pressure Relief Valve on page 15.4. !�����(����<����������<���'}��������������&_�5. V�� <������� ������ ������� ������������� ���� ������ �������
Diagrams beginning on page 67.WATER PIPING DIAGRAMS�����<�������:���������������������������������<�������������<���������������������������������������"������������������Diagrams beginning 67.�����������������<��� �� ���������� �� ������"�������������������������� ������ ����� ���� ����� �� ��������� ������� ����"� ��������������<��� ��������� �����:������ ��<������� ������������<����������������������<��������"� ��� ��� �<����������������������������������� ������������������������ ����<���<<����� ��������������������������������������������X��� ��� �� ���������� �� ���� ���� ���� :��:�� ���������� ��� �������������������������������������������<���#�:������������������������������������<���(��������������������*�����<��beginning on page 67.NOTE:�J�����������������������������������<�������^��������@������ 6��:�� =�/�� :��:�?� �� ���� ������ ������"� ����� ��<��������������������<��� �������������������������������������������������� <��� ���� ��:�� ���� ��� �������� �����"� ������ ��������:�����<�������^��������@������6��:�������������!���� ���� ���� ����� ����������������������< ��� ��������� ���� �����:����������<���������������������������������������/��valve for remote storage tanks.THERMOMETERS (NOT SUPPLIED)����<<������ ���� ���������� ��� ���� ������ ������� �����<� ��� ��<����������������� ���� ��<���������� �������������������������������������������������<��V�����������������<<����������� �� ����������������������(����������������*�����<����������%�WATER (POTABLE) HEATING AND SPACE HEATING1. ������������������<�����������������������������������
�������������������������������������������� ������ ��� �������������� ���������
2. �}��� ���<�����"� ���� ��� ����� ���� ��� ����� �����<���"�<���#'6'@� �������������������������<�
3. ���� ������ �������� �:����� ��� ����� <����� <��� ��:��� ����������� �������}��������������������<����<�����=�?����:����������������^��� ���������������������������
4. ����� ���� �����<� ��\����� ������ ��� ������ �������� ������}����� ����� ��<��������� ��� �<������ ������ �}����� ��<�}����:��:��<��� �����������"�����C�}����6��:����������&_�
41
(�����������>���������(�����������&���V�=_��!?��������������������� �� �������� (<�� (������ ��\���� ��������� ��� �������� �����temperatures.TABLE 10
Water Temperature ��<��������������/�$��*������]�����������(���
&���V�=���!? Nearly instantaneous&%��V�=%%�!? Nearly instantaneous&���V�=%&�!? � ��&)�������&���V�=���!? � ��&^&)��������&_��V�=���!? +�����������������&$��V�=�_�!? � ��$��������&���V�=_��!? More than 5 minutes
���� ������ �������� �:����� ��� ����� <����� ���� �\������ �����������������������������<��� �������� ���������� ��<�����������������������������������������������<����������<����������<� ��� ������� ���������� ��<���������� ��"���� ���������� ������� ����� ����������� ������������ ��������������� ���� ��<"�(���V�����$��������������V�����_������������������������ �>��������� (��� ������ ��� ��X����� �� �������� ��������<���������������������������������������������X��� ��������������� ��� ���������� �����<��� ���<���������C������������������ ������ �����<�<����������������� ������ ����KJC� =��������������<���?� ��������� ���� ������� ����������������"�����V������_�����>���������(�������������X��� �����<����V�=_��!?���&���V�=���!?������������������������&���V�=_��!?��(���>���������(������������*��������������X��<�����������_�������������������������X�������>���������(������������������������������(�������>���������(���������������������������������������������������� ��������������������������������������:��������<���������������������������HIGH TEMPERATURE APPLICATIONS;������ ��������� ��<��������� ����� <��� ����� �� ���� ���������������������������������������������������������������!������������������ �� �<���� ����� ������ ������� ��� ����� ��<�������������������"���������<<������������������"��������������������<����������<���������������<�������������������������������point of use temperature.!�������������������� ������������������������������������< ��� ������� �� ���� ���� �:��� �� ����� <����� ��� ����������������������������
Tank Temperature 103°FOperating Set Point 120°FStatus: Heating
MENU HELP
UP
DNGAS
OFFON
MANUFACTURER / MODEL INFORMATION
Figure 54
HIGH TEMPERATURE LIMIT CONTROL (ECO)
����������������������\��������������'!>�=������������?������X��� ����������<����������<���������������'!>��������<����������������������������=����:����?���������������<������������ '!>� ��� ������� ������� ���� K����� ��<�������� �� ��=������������?"�����V�����$������������� ������������'!>���������������������������������������� ��<��������������������}�<����������V� =�_�!?�����������������}�<������&_��V�=_��!?��J�� ���� '!>� ����:����� =�������� ���?� ��� �� � ��<����� ����������� ��<��������� ��� ����������� ����� ���������� �����<�������<<��������� ��^��������� ���� �_� 6�!� W��� 6��:�� ���� ���� �����������������������������������������<������¦�����¦����� ������������ �������� ��������� ���� ������ �����<� ����� �������� ����¦'������ !�� >�� ='!>?¦� V���� <������� �� ���� +!*� ��������J�� ��� �<������� ����� �� `������� (��:���������� �� ��������� �������<���������������������'!>�����:����� �������������������'!>��>������������������ ���������<����������������������'!>����� �����������������(��������'!>�����:���"�������������<��������<������� ����&_��V�=_��!?� ��������������������<����� ���������>����������������<����������������� ������������������������������������������������<��� ����������������������������������������������<�
THERMOSTAT CONTROL
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
;����������<�����������\����������<��������������������������������������������� ��������������������������������X��� ���)�� ������� �� ��� &�� ����� ���� ����}�<���� ��<�^�^ ��������������������<�������������������<�������������������X��������:��������������������������� ���� ������� �� �}������ ���� ������ �������� ��<�� ����������"������������������� ��������������������������������������<��J������������������������:����� ������������������� ������������������������������������������������������������������ ������ ���� ��\�������� �������������� ��<����������� �������������"������������������������<��� ��������J������������������������������� �����<������������������������������ ���� ��<���� �� ���� ����������� �� <�}���� :��:�� ���� ��������������������������������=����V��������������&_?��������������������������������������������<���������<��������#�:���������<������������������������������������������������� �����������#�:������:���������������� ������������������������� ���� �������������������������������� ��������������������������������������� �������������:�����������������<���������
TEMPERATURE REGULATION
42
THE DESKTOP SCREEN*����� ��<��� �������� ���� ������ �����<� ����� �������� ����¦*�����¦���������� ����+!*������� ��� ����������������������������������<������������������*����������������������������������:��V���� �������� ���������������� ���������� ������user input for several minutes.
�� C���������������������������<��������<���������������������������]�������������������*��������������C�������������������������������������]����������:�����������������������<�<����
�� �����������<�������������������*������������"��������<�������"����������<�����������������������������������������������������������
�� ������������<�������������������*�������������is the Operating Set Point. The Operating Set Point is the ��<��������������������������������<������<������������������������������������������
�� Beneath the Operating Set Point is the "Status" line. The (�����������������������������������������������������������<�����������<�"������� ���&���������__�����������������of the various operational states.
�� ����*�����������������������������<�����¦(�����J���¦�����:�����������������<����"������� ���&&��������_$����������������������(�����J����
OVERVIEW
�������������������:�������������<����������\�����������������������������������<�����������������������<������������������� ������� ������;������� ����������� ������������<������� ������ ������ �����<�� ���� '!>� =������� ��� �?"� ��<�� �����"������������������������<���������� �������<������� ������������ �����<�� ���� !< ����� ]����"� �������"� �_� 6�!� W���6��:������������������������������ �����������������<������ <���� �<������� �� ���� ������ �����<� ���� �� KJC� =��������������<���?�������!!]�=�������������� ���?������KJC������������������������������������������������������!!]����<���������������������������������������������:�����������(���V�����������!<��������������%�����������������������������������������<�������
CONTROL SYSTEM NAVIGATION
�������������� ����<������������������������������������������������� ��<� ����KJC������KJC������ ���������� �����<���+!*� =��\��� �������� �������?� ���� �:�� ����� ������� =<<������?����� ����� ������ ��� �"� ���� ���� ������ =$?� <���� ������������������� ����� ��������+!*"�����V��������User Input Buttons
�� �������������� �����������������:������<����������X�����������������
�� �������������� ��������������������)�}���<���"��������<������<�"�����:������X��<����<������������<������������������������������������������ ���������<�����������"������������������������������� ��������}������������������������� :������� ����������+!*���������
CONTROL SYSTEM OPERATION
Tank Temperature 103°FOperating Set Point 120°FStatus: Heating
MENU HELP
GAS
OFFON
MANUFACTURER / MODEL INFORMATIONLCD ScreenInformationDisplay
Status Icons
3 Operational buttons:enter/exit menus,select menu items,activate adjustment modes,confirm/cancel changes.
Up & Down buttons:navigate menus,adjust user settings
Title Bar
Operational buttons are multi functional. Their current function is defined bythe text that appears directly above each button on the LCD screen.
UIM (user interface module)Desktop Screen Shown
UP
DN
Figure 55
43
STATUS ICONS����(�����J������������������������*�������������������:�������������������������������<������������������������� ������������ ��� �����(���V���������������_����������(�\�����>��>����������������_��TABLE 11
Icon Description��������<��������������������������������(��������������������<���������<<�������������������������������������������������<���������������������������������������<�����K���������+������<���������� ����(���V�����$��������������V�����_������������������������<���������� ���
��������<������������������������������������>���������(������������������������<������������(���� ��<���
��������������� �����������������������������������������������������:�����V������������������������ �����������������<������������'�� ��)*��� ����������������������������V��<�������<���������'�� ��)*��� ���!�������������$��
����!< �����]�������� ���������������
����]�������:����������������������������:�������������������<�����������:���������<���������������������(���V�����$�������������]�������:���(�������������
����;��(������J���������� ����������������(���V��������������%����;��(������J��������������
���������������� ���������������������������������<������������������\�����<���<<���������������������������<�����������:���������<�������<���<<�����������������(�������(�\�����>��>����������������_����<���<<��������=�!��<��?�����<�����
GAS
OFFON
�����_�6�!�W���6��:����� ���������������
���������������<��������������<���������C����]�������<�������<���������(�������(�\�����>��>��������V���!�������������������V��������������%�
���������� �����<����������������V���� ������������<��� �� ���������)���:����� ����`�������(��:�����������V����<������������������� ��:�������������!������V����<����;���������������������� ����=�����?���������������������������������V�����������������������������������������<��� �����������������������������������������<��NOTE:�!�����������������������������������������<�������������������������������V����������� �������������
���������������<�����������������������������������<��� �����������)���:����� ����`�������(��:������������������������������������������������������������������������
44
OPERATING STATES�����������������������������������������������������������������*��������������������¦(�����¦������<<����������������������������� ������������ ��� ������(���V���������������_����������(�\�����>��>����������������_�TABLE 12
State Description(���� � ���������������������������������:�����������������J'�������������<����������������� :������>���������(��������
J����6��������� ���������������<�������������������������������������� ���������������������������
(����!�����*���� ���������������<��������������������^���������<�����������}����� �����������������������������������������:�����¦����^�������¦��������������������������������������<������������������;��(������J�����������!< �����]������NOTE:�J�����������������<�����������������������������������������*�����������������������������<���������<�����������������������������
Pre-Purge ����!< �����]�������������������������������������������<������< ��������< ������������������
Igniter Warm Up ����;��(������J���������������������������������������<����������������������������(�������(�\�����>��>����������������_����<���<<��������=�!��<��?�����<�����
J�����������:���� �����_�6�!�W���6��:��������������������������������������������������C����]�����
J�������6��������� ���������������<����<��������������<�����������������\�����<���<<���<�����������������(�������(�\�����>��>����������������_����<���<<���<�����������������=*!�<�����<��?�����<�����
Inter-Purge ����!< �����]������������������������������������������<������< ��������< ������������������������������<���
Heating J�������������������"���<��������������������� �������� ���������������������������������������� ������������
Post-Purge ����!< �����]�������������������������������������������<������< ��������< ��������������������������������
V��� ���������������<����������������V�������������;���������������������� �������������V�������������������������������������������������<��� �����������������������������������������<��NOTE:�!�����������������������������������������<�������������������������������V����������� �������������
CONTROL SYSTEM MENUSV�<�����*��������������������������>������������������� ����¦C��¦�������+!*������������������¦C����C��¦������������������������������<�<���������������������� ��� ���������� ������������������<�<����TABLE 13
Menu DescriptionTemperatures C����<<�������������<����!�����������>���������(������������*�������������������������
Heater Status �����<�������������������������������������������������������������'!>�=���)�����?�������)����������� ����!< �����]����"�����:��:�"��������"���<�����������������<���������������������<������������������������this menu.
Display Settings ��<�������������=�V����!?"�����+!*������������= ���������)�������?����� ���������������������X��� �������������������������������<���
Heater Information '������� ��<�����������"� ������������������� ��<�"������������������"����������� ��<������������KJC�����!!]�����������:���������� ��:��������������<���
!������V��� *���������������������������V����<��������
V����;����� ����������������<�<����������������������������������=�?�V��������������<�����������������<�����<���������������:���������������������������
V����>�������� ����������������<�<������������������������������<������<��������V�����������������������������������������������������������������
@������V������*������ ����������� �����<� ������������� �������� �� ������������� �����<�������������� �� ������ �������������� ����������*�������(���������������������@'�#>������������������������������������������
;����(������ ��}�� ���������������������������<������}���������������������������������"���:���������������������<�<������������������������
45
USER SETTINGS & CONTROL SYSTEM MENUSTEMPERATURES MENUOperating Set Point And Differential Adjustment����>���������(�������� �����X��� ��� ��<����V�=_��!?� ��&���V�=���!?������ ��������������� ���&���V�=_��!?������*������������ �����X��� �����<�����������������������������������������������������������������������<�������<���������<���������������������������������}�������������X������������������������:���������������������<�<���������������������<��������������� �����������������<���<��������=�������������?���<���������� ���������������>���������(�����������������������<�������������������������������������������������� ������:�����������������������������������<������������� ��������>���������(��������<��������*��������������������NOTE:� +���� *������������ ��������� <��� ����� �}�����:�� �������� ������� =����^�������?� ������ ���� ����� ���<����� ������� ���<�������������� ����;��(������ J��������(��� ����*��������������� ������������������������������������������� �������������������(�������>���������(��������������������������������������������������� ���������������������<���������������
DESCRIPTION/ACTION DISPLAYV�<�����*������������"�����������>����������]���������C'#K������¦C����C��¦������������� ������������
Tank Temperature 120°FOperating Set Point 120°FStatus: Standby
MENU HELP
MANUFACTURER / MODEL INFORMATION
����C����C���������������������������<�<��������������"������� ���&$��������__�������<���������������������������������������<�<�����K�������K������*���]�������:�������������������<�<������<�����C����C���
�������<���������<������������=��������������� ����?��������C����C���������"�����������>����������]����������('+'!�����������������<���������<���
J��������<���������<�������������������������K������*���]�������������������<������<�
TemperaturesHeater StatusDisplay SettingsHeater InformationCurrent Fault
SELECT BACK HELP
Main Menu
���������>���������(��������������������������<���������<��"�����������>����������]���������������!;�#W'��������:����������X��<����<�����������<������<�
J��>���������(������������������������������K������*���]�������������������<������<�
NOTE:�;��������<��������������������������������������������������(�������>���������(��������������������������������������������������� ��������������������������������������:��������<�������������������������������longer life.
Operating Set Point 120°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
CHANGE BACK HELP
Temperatures
�����������X��<����<����������>���������(������������:������������������ �����������������<��� ������������� �����������
K�������K������*���]���������������������������������
����������>����������]���������¦K�*��'¦�����:�����������������������������>����������]���������¦!�#!'+¦��������������������������������������:�������:�����������
NOTE:�K����������<�����������������������*�������������������������������X��� ����������������������������������<�menus.
Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
UPDATE CANCEL
Temperatures
46
TEMPERATURES MENU (CONT)
DESCRIPTION/ACTION DISPLAY�� Tank Temperature�^������X��� ���^������������<�
���������<��������=�:���������<�����������������<���������� ��?�
�� Upper Temperature�^������X��� ���^������������<����������<����������<�����K�������<���������� ��
�� Lower Temperature�^������X��� ���^������������<����������<����������<�����+������<���������� ��
�� (Heater Regulated to Tank)�^������X��� ���^���������������<�����
�� Upper Probe & Lower Probe Offset�^���X��� ��������������"�������^�����©���=�����������������?��NOTE:������������������������� ����������������������supply temperature varies greatly from the Operating Set Point setting. ����K���������+������ ��>��������������� ������ ����������������<���<�������������������������� �<��:�� �����������������<�������������� ���������������������������������������������������������� ���������<����������� ������� ������������ ���� =��� ������ ��������� �� ���������������?������<��������������������������������<������prematurely.'}�<����� J�� ���� ������� ������� ��<�������� ��<� ����<���������� �����&���V�=_��!?���������>������������������������ �������X���������:����������������"����������������<��������� ������� �������� ����������� ��<����������<������� �����������:��������������<���������;�������������� ���� �� ����:����� ���� ������:����� ����� �� �������� ������=�����?���<�����������������������������X��������������<������������ ����������>���������(������������*��������������X��<�����������45.
Top of Menu
Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
CHANGE BACK HELP
Temperatures
Bottom of Menu
Differential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°FLower Probe Offset 0°F
CHANGE BACK HELP
Temperatures
HEATER STATUS MENU
DESCRIPTION/ACTION DISPLAY(������ ;������ (����� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<���
�� Status�^���������������������>���������(����"������� ���&��on page 44.
�� ECO Contact"�Low Gas PS"�Blocked Inlet PS"�Blocked Outlet PS"�Blower Prover PS�^�������������������������������������������������������������
�� Blower On"�Igniter On"�Gas Valve On�^��������������������������������������<��������������������������������������������<������������£����������"���£���^����������
�� Igniter Current�^��������������������������������������<��������������������\�����<���<<�������"�����(�\�����>��>����������������_�
�� Flame Detected�^��������������������������������������<��������������C����]�������<������������������<�������<��������
�� External Input Enable�^���������������������������(&���������������:�� ������������������:����������� ��)���� ���������"�����'�� ��)*��� ���!�������������$��
�� Ignition Trials�^���������������������������(&���������������:�� �������������������&���$������������������� ������������������¦J�������V�����¦�V�����������"���������!!]�^�!�������!�����]����+������������$�
Top of Menu
Status StandbyECO Contact ClosedLow Gas PS ClosedBlocked Inlet PS ClosedBlocked Outlet PS ClosedBlower Prover PS OpenBlower On No
BACK HELP
Heater Status
Bottom of Menu
Blower On NoIgniter On NoIgniter Current NoGas Valve On NoFlame Detected NoExternal Input Enable NoIgnition Trials 3
BACK HELP
Heater Status
47
DISPLAY SETTINGS
DESCRIPTION/ACTION DISPLAY(������ *������� (�������� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<�������������X��� ��������������������:�����������<������� ���� KJC��� +!*� �������� K��� ���� K�� /� *��� ]����� ��navigate the menu.
�� Temperature Units�^���X��� ������������������������������<�����������������������!�������!���V�����������V�
�� Backlight Delay�^���X��� �������������������������<����������������KJC���+!*� �����������<��������<����������������������� ��������������:���� ������������������������>��"�&�"�$�������������������������>��
�� Contrast�^���X��� �������������������X�������KJC���+!*���������������� ���������}������ ��������NOTE: ������ ��������� ���� ��X����� ��� ���� ��<�� ���������� ��� ��� ���� >��������� (��� ����� ���� *��������������X��<�����������_��
Temperature Units °FBacklight Delay 30sContrast 60%
CHANGE BACK HELP
Display Settings
HEATER INFORMATION
DESCRIPTION/ACTION DISPLAY(������;������ J���<����� ��<� ����C����C������������� ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<�����
�� Elapsed Time�^���������<��������<�����������������<�=������������?����� ��������������
�� Burner On Time�^���������<��������<�����������������<����� ����������������������������������� ��������time.
�� Cycle Count ^���������<����������������������������� CCB Version ^�(�������:����������������������� ������ UIM Version ^�(�������:�����������������������<����
NOTE: ;������������������������������!!]���<�<����J�������!!]����������������������:�������������������������������!!]� ������������������� ���������������������������������������� ��������� �� ������ ������� ����������� ������� �� ���������������������'���������<�"�]�����>����<������!�����!���������������"���������������J�� ���� !����� !��� ���� ���� ��� ����� =��:���� ������ ���� ������� �������<������������������?��� ����������������� ��������=�����<���� ���������<�������<�����"���:���� ������� ��<�� ����� <������ �� ������ ���?� �������� ������� ����*������������ �������� �� �:��� ����� �������� ���� �}�����:���<����������"�����>���������(������������*��������������X��<�����������_������� ���������� ����� ���� ���� �� ���� �� ������� �����������<�������������������������������������<�������\��<������������:������������������������������������������������
Elapsed Time 10 day 0 hrs 0 minsBurner On Time 5 hrs 22 minsCycle Count 00000035CCB Version X.XXUIM Version X.XX
CHANGE BACK HELP
Heater Information
48
CURRENT FAULT
DESCRIPTION/ACTION DISPLAY(������ !������ V���� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� ���� ������� V���� �������� ����� <��������������<������V������������<������������������������������� ������� �������������������������������������������V������������ �������� �������� ���� ������ ��������� ���� >����������]���� ����� ¦�*6�#!'*¦� ����� ��:�� <��� ��������� ���:��������<����������� ����������� ��������� ��� ����V���������������������(���V��������������C���������������������<����������������<����������������������������J�� ������ �����V������������ ������������:�� �����<��������������������������<����"�¦=���?¦������ ���������}����!������V�����������C����<���
CHANGE BACK ADVANCED
Blocked ExhaustFault occurred 2 mins ago
The exhaust is blocked orrestricted. Ensurecondensate hose is draining.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
FAULT HISTORY
DESCRIPTION/ACTION DISPLAY(������ V���� ;������ ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� �� ����� �� ���� ����� ����� =�?� V���� ����������<�����������������<�����<���������������:�������������������������������������>����������]���������¦6J'�¦���:������������ ��������V������������<�������������
1: Blocked Air Intake (A7) 51 mins ago2: Blocked Exhaust (A8) 54 mins ago3: Low Gas Pressure (A6) 57 mins ago4: Blower Prover Failure (AC)
VIEW BACK HELP
Fault History
FAULT OCCURRENCE
DESCRIPTION/ACTION DISPLAY(������ V���� >��������� ��<� ���� C���� C��� ���� ������ ����>���������� ]���� ����� ¦('+'!�¦� �� ������ ����� <���� �����<����������������X��� �����������������<������K�������K��/�*���]���������:����������<�������� <��� �������� �� ������� ����� �� ��� <���� ��<��� �����V���� �������� ���� ������� ������ ���� ������ ������� ���� ���������������NOTE: ;��������� ����� ��� ������ ��� ���� !!]��� <�<���� J�� �����!!]����������������������:�������������������������������!!]� ����� �������������� �� �������������������� ��� ��������������� �������������������������������������������������������������
Ignition Failure 10ECO 0Low Gas Pressure 10Blocked Intake Air 0Blocked Exhaust 0Thermostat Input 4 0Blower Prover 3
BACK HELP
Fault Occurrence
RESTORE FACTORY DEFAULTS
DESCRIPTION/ACTION DISPLAY(������@������V������*���������<�����C����C�����������������>����������]���������¦('+'!�¦��������������<����� ������� ���� ��X��� ��� ���� ��������� �� ������ ������� ���������������� ������ ���� >���������� ]���� ���������� �B'(��������������� ����� ���� ��}�� ����<���� ���� ������� ������� �����������:�� ������������������ ���� >���������� ]���� ���������� �]�!��� �� �}��� ����@������V������*�������<���
YES NO
Restore Factory Defaults
Are you sure you want torestore the system to factorydefaults?
49
SERVICE CONTACT INFORMATION���������������<����������������<��������J�����������������������)�����:�����������������������������������������<�����������������<���������������������<���������� ���������������������V��������������<��������
DESCRIPTION/ACTION DISPLAYV�<�����*������(������=����V���������������_�?��������������� ���� ���� <������ =�<�����?� >���������� ]���� ��� $���������������������������������� ����� ������ �� ��������� <��� ������ ������������ �����������<��������� ����������K���������K������*>�#� ������������=��������������� ����?�����¦(���!������J���<����¦�<������<�
����������>����������]���������¦!;�#W'¦�������:����������X��<����<���������������<�����
Show Contact Information NoChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
CHANGE BACK HELP
Service Contact Information
�����������X��<����<������¦(���!������J���<����¦�����:������������������ �����������������<��� ������������� �����������
K�������K������*���]����������������������������<�¦#¦���¦B��¦���������������>����������]��������������¦K�*��'¦�����:������������������
NOTE:������������!���������� ��<�������(��:����!������J���<������������������<������������������������������������������������������������������<��������������through this menu item.
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
UPDATE CANCEL
Service Contact Information
K���������K������*>�#� ������������=��������������� ����?�����¦!������!������#�<�¦�<������<�
����������>����������]���������¦('+'!�¦�����������!������!������#�<��<���
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
SELECT BACK HELP
Service Contact Information
V�����������������������������������������<����������<��������<�����������������<�}�<<�������������������������������������
�����������������������>����������]����¦K�*��'¦�����:����������!������#�<������������������<���������������������������<���
Enter the service contact below:
NAME: _
Use the > and < keys to move betweencharacters. Use the UP and DOWN keys tochange the character.
- -
< > UPDATE- -K���������K������*>�#� ������������=��������������� ����?�����¦!������!����������¦�<������<���������������>����������]���������¦('+'!�¦�
V������������������������������������������!������������< �����������������>����������]���������¦K�*��'¦�����:����������������< ����
�������������!������#�<������!������������< �����:�� ��� ����������"�����������>����������]���������¦]�!�¦���������������*������������� BACK HELP
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:YOUR COMPANY NAME HERE(123) 456-7890Access Code
Service Contact Information
50
PRIOR TO START UP
J����������� ���� ������ �� �� ����� ������ ������� ��\����� � ��������������������\�:��������������������������������<�����������������:�:��"�����`��������������������*������������������������������������������������������ ��������� ������� J<<��������� ����� �� \������� ���:���� ����������� ���������� ������������������������������������������ ���������������<����������������������������� ����������������+����� ���� ������ ������� ��� ���������� ����� ���� +�������� ����>��������J����������� ����������������������������������<�����on page 53.���� ������ �������� �:����� �� ����� <����� ���� �\������ �����������������������������<�=����������_�?���������<�����������\������ ���� !< ����� ]����"� ���� ���� ���� ������� ������ �< ����� ���< ��"� ���� ;�� (������ J������"� ���� �_� 6�!�W���6��:�"�C����]������������"�������<��������������������������<����������������������������������������������<����]����� ����<������ ������ �"� �������� ����� ���� ��<��������������������������}����(�\�����>��>�������"�����������������(�\����� >�� >�������� �� ����� �_� ���� ���� (�\����� >��>��������V���!���������������]����������������������������������������������"���������������������<��������������������������������������������������������������������������������'���������������������:��:�����������FILLING THE WATER HEATERV������������������������������������������������������1. !���������������������:��:��2. >���������� ����������������������<�����������������������<�
���������3. V����������������������������:��:�������������������������
������������������������������4. !��������������������������������(����������������������
�����SUPPLY GAS LINE PURGING
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
To avoid risk of fire or explosion purge discharge must notenter into confined areas or spaces where ignition can occur.
The area must be well ventilated and all sources of ignitionmust be deactivated or removed.
Gas line purging is required with new piping or systems inwhich air has entered.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
1. !��������C����W���(�����6��:�"�����V���������������$%�2. ���������������<�������������������������������������������
Main Gas Shutoff Valve.
3. ����� ���� ���� ���� ���� ������ ��<� ���� ������ ���� ����"���������������������������������������
4. !�����������������"�����W���+����+�������������������$�"��������������������������
INITIAL START UP
REQUIRED TEST EQUIPMENT�� ���K^� ��<��<�����"����<<���������������^&_����!��
=�^$������?������^$�����!��=�^��%����?�������������������� �����������<��<���������� �����������������K^� ��
<��<�����������������������@��<<��������������^&_������©&_�������!��=�^$������?������������&����!�������^$�����!��=�^��%����?�����������&�����!�
NOTE:� ���� ����� �\��<���� <��� �� �����<����� �� �< �������<�������� ��������� �������������PREPARATION1. K��������������������<�<���"������������>���������(���
����� �� ���� ������ ��<���������������"�����>���������(������������*��������������X��<�����������_��
2. ������������������������)����������������������������3. !��������C����W���(���>���6��:�"�����V���������������$%�4. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ����
����������"�����V������������V������%����������&���������5. ������:��=�?�<���������������������������������6. !���������<��<�����=������������?�������:���� ��������
������ �������������� �������� ������������������������ �����&)�¦�#�����������������������������������������������+��W������������������������ ������������� �����_�6�!�W���6��:���������&)�¦�#���������������������
7. !���������<��<�����=����������?� ������<������������������� ���� ��� ���� ����� �� ���� �_� 6�!� W��� 6��:�"� ����V����������������&�����V������%���������������������
8. Open the Main Gas Shutoff Valve.9. C�������������������������������������"��������������������
������������������ ��������������� ����������������� ���������������X���������������������������������"�����(�����W�������������X��<������������&�
LIGHTING THE WATER HEATER1. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ���� ����
������"�����V������������V������%����������&��������2. ������������������������)���������������������������3. �����������������������<����<���������� ������\������
���� *������ ������� ������� ���� ������� >��������� (�������������������<������������� �����������������������������<���+!*���������� ������\���������<������
4. K����� ���� ������ �����<� <���� ���� KJC� =���� ����������<���?"������������>���������(�������������������������������� ����������� ����� ��<�������������������� ���������������<�+!*���������*��������������������������:�����������������������(���!�����(����<�>���������������_��
5. @����� ���� <������� ���� �������� ����� ���� �_� 6�!� W���6��:�� ��� ���������� ���� ���� C���� ]����� ��� �������"� �������<����� ���� :��:�� ���� ����� �� ���������� �� ���� *������������������������������<���+!*���������������������<����������������_�6�!�W���6��:�"������<�������<������������������ ����� C���� ]����� �������� ��� ��������"� ���� ����(�����J��������������������� ���&&��������_$�
START UP
51
�����<<������<��������������������������NOTE:�����������������<��������&�������!��=��$%����?����������C����]���������������������������������������\���������������������������������������������"���������������)���������������J����������<��������&�������!��=��$%����?�������������� �������� ����� ����� ���� C���� ]����� �������"� ���������� ������ ���� ������ ���� �������=�?� ���� �������� ������ ���������������(��� ���� ��\���<����� ���(�����W���@������� ����Supply Gas Line on page 13. See Supply Gas Line Installation on �����$%�����(�����W���@�������J������������������$���'�����������\���<������������������������������������<����������MANIFOLD GAS PRESSURE ADJUSTMENT
Fire and Explosion Hazard
Gas and carbon monoxide detectors areavailable.
Overfiring could result in fire orexplosion.
Under no circumstances should the input exceed the rate shown on the water heater’s rating label.
Breathing Hazard - Carbon Monoxide Gas
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.
Overfiring could result in damage tothe water heater and sooting.
Gas and carbon monoxide detectorsare available.
'���������¦����<��¦����������������������� :������<���<<���\���<���������� ���_��������&$� �����������X��<���������<����������<������������������������<��������X���<���������������������������������� ������������������������������� ��� :�������� ����� ���� ������ ���� �������� ������� ����<����(���(�����W�������������X��<����������������J�����������"���X�������<����������������������������1. V����������������������J�������(�����K���������������������
<��<������ �� ��������������<������������������� ����������������������������������
2. @�<:�� ���� <������� ���� �������� �������� �:��� �����"�����V������������������������V������%�����������
3. K��������<���������������������:�������������X��<������������������� �� ��������� <������� ���� �������� ���� ��������������������������<�������������������NOTE:� ���� ���� <������� ���� �������� ��X��<���� ��������� �<���� �����<����� =�� <��� ����� &)_� ���?� ���� ����� ����<������������������������ �����������:�����<������ �����<���������������X��<�����
4. @��������������������������������:���������5. !��������� ����������������:�������<�������������������
6. !<���������������<������������������������������������� :�� �� ���� ��\����� <���<<)<�}�<<� :����� ��:��� ����� ���_��������&$����X���<�������������������������������"������������������������������
7. @����� ���� ������ ���� �������� ����� ���� �_� 6�!� W���6��:�����������������������C����]��������������������������������<���� ���� �������� ��������� ������ ���� ������ ������� ���������
8. !<����� ���������� ������������������ �������� ���������� :�� �� ���� ��\����� <���<<)<�}�<<� :����� ��:��� ����� ���_��������&$����X���������������������������������"������������������������������
ON
OFF
HONEYWELL
MANIFOLD GASPRESSURE REGULATORCOVER SCREW
ALL 300,000 & 400,000 BTU/HR MODELS AND 500,000 BTU/HR PROPANE MODELS24 VAC GAS VALVE TOP VIEW
MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG
INLET OUTLET
GAS CONTROLKNOB
Figure 56
SUPPLY GAS PRESSURE ADJUSTMENT
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
(����������������������� ��<������������������������������������������=��������������?�AND�������������������������������������������������=����<����������?��J������������������������������������������������� �������������\�����<���<<�����<�}�<<�:�������:�������� ���_��������&$���X�����������������������������������������X������������������������=�?�����������������<������������������������������:��������\�����������������������<����������������������Multiple Appliance Installations:J�� <������� ������ ������� ������������� �� ��� ������������� ��������������������������������=�?����������<<������������<���������������������������������������������������������������� ��<�����������������������������������������������������������������������<<��<��������������������������>��<������������������������������������������������������������������� ����X���������:�����������������������������������������������<���<<�����<�}�<<�����������������\���<����������������� ���_��������&$���������������������������������������
52
ON OFF
MANIFOLD GAS PRESSUREREGULATOR COVER SCREW
500,000 BTU/HR NATURAL GAS MODELS 24 VAC GAS VALVE TOP VIEW
MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG
INLET
OUTLET
GAS CONTROLKNOB
Figure 57
CHECKING THE FIRING RATE
J�� ������ �������X��<���� ��� ��\����� ����� ������ ����������� �������<��������������������������������������������1. '�����������������������������������������������������
��������<���������������������������2. !���������������������� �������<����������������:���"� ���
]������� �����"�����������������3. !������ �� <��<����� �� ���� <������� ���� �������� �����
V����������������������J�������(�����K������������4. (��������������������������������������������5. !���������<������������������"����������� ���_��������&$�
�������������������(���C�������W�������������X��<������������&������X��<�����������������
6. +�������������<��������:���������������������7. ��<���������=���������?����������������� ������������
�� �������������������������������������������������������8. K���������<��� ���������������������<��������������<����
���������������������������������������� �������������������:����=]������� �����?�����������������
x H = Btu/hr3600T
x 1050 = 300,000 Btu/hr (87.9 kW)360012.6
Example:
�� $����£������������������� ��£���<�"����������"��� ������� �������������� ;�£���������:�������������]������� ��������� ]�)���£�������������������������������������
NOTE:�&����]������� ��������������������:�������������������(�������������������]�����������������]������� �������]��:�����<������������������������������������������:�������!�������������������������������<�����
TO TURN OFF GAS1. !������ ����>���������(�������� �� ���� ������ ��<��������
�������"�����>���������(������������*��������������X��<����on page 45.
2. ���������������������������<���������������������\������������������������� ��<��"�������������������������)����������������������������
3. ���� ��� ���� ���� ������ �� � ��������� ���� ���� �� ���� �����������"�����V����������������&�����V������%�������������
4. !��������C����W���(�����6��:�"�����V���������������$%�
HIGH ALTITUDE INSTALLATIONS
Fire and Explosion Hazard
Gas and carbon monoxide detectors areavailable.
Overfiring could result in fire orexplosion.
Under no circumstances should the input exceed the rate shown on the water heater’s rating label.
Breathing Hazard - Carbon Monoxide Gas
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.
Overfiring could result in damage tothe water heater and sooting.
Gas and carbon monoxide detectorsare available.
�������������������:����� �������<������������������������������<�������������������������&�"���������C�������������� �<���������^����� ���������� ����������������"�<���������������������������������������������������V�� ������������� � :�� &�"���� ����� ����� ���� ���������� ������������< ���������������� �����:����������<�������������������������������������!���������������������������<�������:������]������� ������������� �������������������������������������������:�����������<������:���� ���NOTE:�����������������������������������������<�������}��������� ����� ������� �� ���� ������ ��������� ������� �� ��� ����� ��������<��������NOTE:� *�� �� ���� ����� ������� �������� ��� ����� ��������"� �������� ������� �� ���� ���������� ��� ���� ������� ���� ����� ���<���������������������������������\��<�������������������
53
LIGHTING THE WATER HEATER
ON
OFF
Honeywell
IN1/2 PSI
GASCONTROLKNOB
FOR YOUR SAFETY READ BEFORE OPERATING
TO TURN OFF GAS TO APPLIANCE
OPERATING INSTRUCTIONS
Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.
IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
A.
B.
1.
2.
C.
D.
This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.
STOP! Read the safety information above on thislabel.
Do not try to light any appliance.
Do not touch any electrical switch; do not use any telephonein your building.
Immediately call your gas supplier from a neighbor’s
telephone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the firedepartment.
Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.
Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.
BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.
Set thermostat to lowest setting.
1. Set the thermostat to lowest setting.
9. Set thermostat to desired setting.
10. If the appliance will not operate, follow the instructions“To Turn Off Gas To Appliance” and call your servicetechnician or gas supplier.3. Turn off all electrical power to the appliance.
2. Turn off all electrical power to the appliance if service is to be performed.
8. Turn on all electrical power to the appliance.
7. Turn gas control knob counterclockwise to “ON”.
3. Push in gas control knob slightly and turn clockwise to “OFF”. Do not force.
4. This appliance is equipped with an ignition device whichautomatically lights the burner. Do not try to light theburner by hand.
5. Push in gas control knob slightly and turn clockwiseto “OFF”.
6.
“WHAT TO DO IF YOU SMELL GAS”
WARNING
LIGHTING & OPERATION LABEL
���������������� ��� ����������}�������������������������:����� �������<�����������������������<��� �����������������������������������������������������
54
SEQUENCE OF OPERATION
@���� ���� (�\����� �� >�������� ���� ����� ����<������ ��������� ���� ���������� �� ��<��� @����� �� ���� V������� ����!<������� ������� ��������� �� ����� %� ��� ���� ������� ��:����� ������ ������� �<������� ������ ��� ����� (��� ����(�\�����>��>��������V���!�������������������1. ��������������������<���������������"������� ���"���������
���������������������<���� ����<����������� ����������������������� ����<<����� ���������������<�+!*������� ���������� ���� KJC� =���� ���������� <���?� ����� �������� ���� ��������������������������¦*�����¦��������
2. J�� ���� ������ �����<� �����<����� ����� ���� ������ ��������<�������� ������� ���� ����� ��� ���� ���� �����<<���>���������(��������<��������*�������������������"������������������������:�����
3. ���������������<�����������<��������������������������<��������� ����� �������� ����<���� ���� ��� ���� �������"� ������ �}����"� ������ ������� ���� '!>� =������� ����?�������������������������������]�������:���(����������������������<�������
4. J��������������������������������������������"����������������<���������������!< �����]�����������^�����
5. ���������������<�<�������<�����]�������:���(�����������������������������!< �����]������������������
6. J�� ����]�������:���(������ ������������ ����<������������������������<���������������;��(������J�������������������������<^��������
7. ���� ������ �����<� <������ ���� �������� ������� ���� <�����������<���<<��������!��<������]�;�$���/�_���<�����������%��!��<������]�;�����<��������������������������<���������=&�^&%�������?�
8. J�� �������� �<������� ��� ����<��� ��� �� � :�� ���� ��\�����<���<<� ���� ������ �����<� ���������� ���� �_� 6�!� W���6��:�������������������������C����]������
9. ���������������<���^��������������;��(������J�������10. ���������������<�<������������<��������������<���
��<��������������������C����]������J������<��������:����������������� �����������������������������������<������ ���� ������������������<�����<����J����<��������� ��:������������������� ������� ��� �������"� ���������������<������ �����������������������J�������V�������V����<�������
11. J�� �� ��<�� ��� :������"� ���� ������ �����<� ����� ������ ������������<��������� �������� ��������������� �������������������>���������(��������������������������������"����������������<��������^��������������_�6�!�W���6��:�������������������^�����������=����}�<������$��������?�
12. ����!< �����]������������������������������������^����� ������ �� ����� ���� ������ ������� �� ���� �< �������������������������^���������������<�����"����� ����������^��������������������������������
13. ���� ������ �����<� ��� ������� ���� ����� �� <��� ��������������� �� <����� ���� ��������� ������� ����� ��������<�������� ���� ���� ������ �� ����� �����<� ��:������ J�� �����������<������������� ��������>���������(��������<��������*�������������������"������������������<�����������������(������������������������������������
TROUBLESHOOTINGINSTALLATION CHECKLIST
���� ����� ���� ������������<���� ����<��� ��������� ��������������\���<���������"������:������"������������ ��������������� ��<�"� ���� ��<�� ���� ��������� ������ �������<����� �������� ��� �� �<������ ������ ]����� �����<���� ���� �� ������������������ ��� ���� ����� ���� �� ������ ��� ������������ �������!���� �� ������� ������������ ������ ���� ��� �:����� ����� ������<����� ���������� '����� ���� ������������ ��\���<����� �����������������������<�������:�� ����<���������������������WATER HEATER LOCATION1. '����� ������ ����������� �� �< ��� ���� ���� <����������
�����������������������<������:����������������������(���!�����������������&&�
2. '�����������������������������:�����<�����������<<� ���<����������(������������������������&��
VENTING3. '�����������������������)��:����=�}����?����������������������
����� ��� ���� ���������� ��������(���6�������@�\���<�������page 22.
4. Ensure the maximum equivalent feet of pipe has not been �}����������������������������)��:����������(����� ���%���page 22.
5. '����� ���� <�}�<<� �< ��� �� �� ��� ���� ��� �����}������� ��� ���� ������� ���� ���)�� :���� ������ (��� 6�������Requirements on page 22.
6. '��������� �����������������������������������������<:�����<� ���� ������� ���� ��������� �� ���� ������ ������� ��������������������������������������*������6���������������(���V�����&%���������_�
7. '����� ���� �}������ ����������� ��� ���� ������� ���"� :���� �������������� ���<�������� ���� <����������� (��� 6�����������<������� J����������� �� ����� �_"� (�������� ���<�������J�������������������������!������������<�������J�������������������%���������������������������������� ������������������������<��� ��<����������
GAS SUPPLY AND PIPING8. '����������������� ������������ ���� ���������� ��������
������ �������� (��� ���� ��\���<����� ��� �� (����� W���@��������������&$�����(�����W���@�������J�����������on page 38.
9. '����� ���� ������ ���� ����� �� ����� ������ ������� <�����the minimum supply gas line size requirements. See the ��\���<����� ��� ����(�����W���+�����������&$����� ����������������������������������$%�����$��
CONDENSATE DRAIN10. '����� ���� ���������� ������ ��� �������� ��������� �� ����
�}����� �� �� �� ���� ������ ������� ����� �� ������ ����� �����:���� :���� ������ ��<� ��������� ���� ���� ���������� ���������������������������������� �������������(���V��������������&������!���������*�����J������������������$��
ELECTRICAL CONNECTIONS11. '�����������������������������������������������������
����������������(���������\���<�����������������(������������&$�����'������������������������$��
12. '�����������������������������������������V��<������������\�����������\����������������J�����������������������������������������������������J�������V������
55
SEQUENCE OF OPERATION FLOW CHART
YES NO
Water is heated to set point
24 VAC Gas Valvede-energized
30 secondInter-Purge cycle
24 VAC Gas Valvede-energized
Retries up totwo more times
30 secondPost-Purge cycle
Control System Locks Out
“Ignition Failure” Fault Msg is displayed
Water heater goes into standby mode
If tank temperature drops below Operating Set Point minus Differential setting a heating cycle is activated
Blower Prover switch contacts confirmed closed by control system
Igniter is energized for warm up period
24 VAC Gas Valve is energizedgas flows to Main Burner
Is flame sensed at the Main Burner?(control system monitors the flame sensor)
Control System Locks OutDisplays Fault MsgNO
Control System Locks Out“Blower Prover Open”Fault Msg is displayed
NO
Control System Locks Out “Low Igniter Current”
Fault Msg is displayedNO
Combustion Blower is energizedPre-Purge cycle
Does Control System sense minimum Igniter amps?
Control System performs diagnostic checksNormal State of all pressure switches and ECO are checked
Blower Prover pressure switch verified openAll other pressure switches and ECO are verified closed
2.0 minimum AC amps300,000 & 400,000 Btu/hr Models
2.7 minimum AC amps500,000 Btu/hr Models
Figure 58
56
�� '}�����:��<�������������������^������� ���_��������&$�����C�������W�������������X��<������������&�
�� 6����=�}����?������������������������:���������������������������<����������*������6�����������������^�����*������Vent Installation on page 23.
�� '}�����:���\�:������������������������������)��:����=�}����?������������������^�����6�������@�\���<�������page 22.
�� *� �����������) ����������������������������=�?�^�����V�����&%���������_�����V������������������
�� *� �����������) �����������C����]�����^�����V���������page 7.
MOMENTARY IGNITION
Burn Hazard
Do not reach into the burner housing orcombustion chamber if the water heateris still hot.
Allow the water heater to cool and always usegloves when handling the main burner.
The combustion chamber and burner sleeve and housing become very hot during operation.
CAUTION
J�� ���� C���� ]����� �������� <<��������� �� ���� ��� ��������������� ����� ���� ������ ������� �� ���� �� ������� �� �� ��� <�����<�������������������<����������������J�������V������V����<�������������������������������������<���+!*��J�����������������������}����������������������^�����@���(�������"�@���>���������������������V��<<����������������� ��<���������������������������������������
�� J��������<�������������������̂ ������� ���_��������&$�����C�������W�������������X��<������������&�
�� K�������������������������=���:�<�������������?�^�����Supply Gas Line on page 13.
�� (���������������������������������������������������\���<�����=������������������:�<�)��������?�^�����Supply Gas Regulator on page 13.
�� (������������������ ����������������������������������������������J�������V������V����<�����������������
�� *� �����������) ����������������������������=�?�^�����V�����&%���������_�����V������������������
�� *� �����������) �����������C����]�����^�����V���������page 7.
NOT ENOUGH OR NO HOT WATER�� #������������������������"������� ������"��������������
��������������)������������ ;��������������:��:�=�?����}������������� >���������(�������������������"�*���������������������������
��������(���!�����(����<�>���������������_���� K��������)��+������ ��>������������������������������
��������������������<���������<�������^�������<���������C���=���?��������_��
�� '����������������������}�����������:�����������=������������ ��)���� ���������?����� ����������������������(���'�� ��)*��� ���!�������������$��
�� �������������������������������������������� �����}������"����������������������� �����<������<����
OPERATIONAL PROBLEMS
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
������������������<������������������� �����������������������<<�������������� ��<�"��������������������:�����������������<��� �� � ��� �� ���:�� ���� ������� �������� �� ��<�� ������<���������������� ����������������� ����������� ������������������� ��� ��� ��^����� ������ �� �������� �������� ;��:��"� ����\����������:����������"��������������`�������������������"������ ����������� ����� �\��<���"� ����� �����<� ���� ���:���������������������������������NOTE:� !���� ���� ���������� ������ ����� �< ��� ������� �� ���� �����:����������<������������������������������������������������\����������:���������������������INSTALLATION ERRORS>������������ ��<��������������������������������������������������������\���<������������:�� ����:�������������������������� �<�������� J'�� �� ¦+�� W��� �������¦� V���� �����������<�������������� ��������������������������������������������:��+��W�������������������@���������������� ��������������������������� �������������������������������)������� ����������������������������������������������������� �� �����<���� ���� ���������� ������� �������� ���� ������������� ������������ �� ������ ���� ������������ ��\���<����� ��������������� ��:�� ���� <���������� ���� �������� (��� ����J�����������!�����������������_NOTE:�!���������������������������������������:����������������<��������������ROUGH STARTING, ROUGH OPERATION
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
�� K�������������������������=���:�<�������������?�^�����Supply Gas Line on page 13.
�� (���������������������������������������������������\���<�����=������������������:�<�)��������?�^�����Supply Gas Regulator on page 13.
�� '}�����:��������������������^������� ���_��������&$�����(�����W�������������X��<������������&�
57
ALERT CONDITIONS��������������������<����������������������������������������������������<������������������������<���+!*��������\������¦¶¦�<������������������������������������������������������������������ �� �����������������<��� �����:����� ����\����������:����������������������� ���RESETTING CONTROL SYSTEM LOCK OUTS�� ������ ���������������<� ��<��� ��������������� ���� �������������������������}�<������������������������� ���������������<�����������������������������������V����������� ������������"����������������<���������������������DIAGNOSTIC CHECKS
Turn off power to the water heaterbefore performing any service.
Electrical Shock Hazard
Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.
Verify proper operation after servicing.
Failure to follow these instructions canresult in personal injury or death.
������������������"�V��������������C�����������������"��������<��������<�����������������������<��������������������+!*���������������������������� ��<�����������������<���������������������������������V��������������<�������������� �������������� ��������������� ���������������������������������������>���� \������� ���:���� ������"� ��� ������� ��� `����������� ��������"����������������� ������\��<���"� ����������<��������:���������������������������������NOTE:� J�� �� ���� ��� \������� ���� ��������� �� ��������� �����\����� �� ��������������:���� X���������� �������<�����:�����������������<����������<��������������������������:������������������� ��������������������������J�����������������������������������������������������������������<����������<��������������!������������������������������< ���������������� �����:����� ����� <����� ��� ������� ���������� ����������� �� �� ������ ��\����������:���������������������
Jumping out control circuits or components canresult in property damage, personal injury or death.
Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.
Any bypass or alteration of the waterheater controls and/or wiring will result
in voiding the appliance warranty.
Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.
�� !��������<������������<��������������������������<����\������������������������������<��������
�� ;��������������������"�����������"��������������������valve leaking or open.
�� (���<��������<�����������<������<��� ����������������������������������(���C����������������������������<����������<����������<:������������
�� ������������������������������������������!�����<������������������"������������������������&��!����������������������������������������"��������������������������
WATER IS TOO HOT�� Operating Set Point is set too high. See Operating Set Point
����*��������������X��<�����������_���� K��������)��+������ ��>����������������<������������^�
������<���������C���=���?��������_���� J<�������������������^�����������<�� �����������������%�
NOISY OPERATION�� (���<��������<�����������<�����������������< �����
���������������������������������������(�������C�������������������������<����� ��������������������������<����������<����������<:������������
�� #�<�������������������������������<��������!< �����]����"��������<����<"��������������������
WATER LEAKAGE IS SUSPECTED�� '����������������������������:��:��������������������� !����������������������������^�����V�����_������������ !����������)������������������������������<���������� !�����������<�������^��������@������6��:��
�� '}�����:����������<���������� '}�����:������������������ *������:����<�������^��������@������6��:��
NOTE:�'}�����:�����������������������<����<<�����������<�������^�������� @������ 6��:�� ��������� '}�����:�� �����������<��������� ���<�������������� �� ¦����<����}������¦������¦�����������<�¦�(�������<���'}�����������!�����������Systems on page 14. The Temperature-Pressure Relief Valve is ����������������������������������������<����}���������<�������^��������@������6��:����������������������� ����������������������<���������������:��������<����}�����������������������������:����������������<�������������������<����}�������������<��� �����������������������������������<��REPLACEMENT PARTS@������<���� ������ <��� �� ������� ��<� ���� <���������"�������������:��������������������� ������������������������ ����������:�������<�������������������C����#< ��"�(������#< �������(������#< ����:���� ��������� ����<��������� ��������������������� ������}����������������������@����� �� ���� ������ ����� �������� ����� ���� ������ ������� ��<� ����������� ��� <��� ����<����� �� ����� ���� ������ ������<���� ������������������������< ���������������� �����:����������<��������������������������
FAULT AND ALERT CONDITIONS
FAULT CONDITIONS��������������������<������������V������������������������������V����<������������������������<���+!*����������}���<�����¦·¦� <��������� ������ �����<� ����� ���� �� ���� ���� ��� ���������������������������������������������������������������<��� �����:����� ����\����������:���������� ����������������� ����������
58
FAULT AND ALERT MESSAGES!������������������������������< ���������������� �����:����������������������������������������������\����������:����������in your area.
POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ������������������������������<�������������������:���������������
���������� ��������������������������������������������������������:����������������������<��������������������!�@�:�������V����<�������������+!*������������������(��������(�����!����������������$�����������������������������������������������������NOTE:�'�����������<������������\��������������������������������#*�����������������������������������������������C����]���������������������<��������:����������������� ������������ ���������������������������������������(�������J�������V������V����<�����������<����� ���� CHANGE BACK ADVANCED
AC ReversedFault occurred 2 mins ago
Power supply to water heaterhas reversed polarity.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<�������������������������C����]������� ���������������������������������"���������������������
������C����]�����^����������(�����!����������������$���� *����)���������<�������"���������<�����������������������
���=�������������<����?�^�����V��������������%��� +������������������������<���������� +�����������������������_�6�!�W���6��:���� �_�6�!�W���6��:���������� ��������¦��¦��������^�����V��������
��������&�����V������%������������� (�����������������"��������:�<��^����������$%��� J�������������)��:����������������������������<������������������^�
see Venting Installation on page 21.�� +������<�������������������������C����]�����^�����J�������
Start Up on page 50.
CHANGE BACK ADVANCED
Ignition FailureFault occurred 2 mins ago
The water heater has failed toignite the burner.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������+��W�����������(����������������������
�� +����������������������+��W�����������(������^�����V�����$��������������������
�� (�������������������� ����������\�����<���<<���������^�����Table 4 on page 13.
�� (����������������������������C����(�����6��:���� (����������������������������������������������������������
�����<<�������������������������������� +��:�<��������������^�����(�����W���+����J�������������
�����$%�����������\���<������������(�����W���+�����������&$�����Supply Gas Regulator on page 13.
CHANGE BACK ADVANCED
Low Gas PressureFault occurred 2 mins ago
The supply gas pressure to thewater heater is low.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������������=�!��<��?���<�����;��(������J�����������������������<�<�������������������������������������������V�������������������������������������� :�����������<<���<���<<���\���<����^���������(�\�����>��Operation on page 54 for minimum igniter amp requirements.
�� +����������������������;��(������J�������^�����V��������������%�������������������
�� *�<����"������������������;��(������J�������NOTE:�;�����������������������������������������������������������������������������������;��������������������� ��:������in the Heater Information menu - see Heater Information on page _%��J��������������*���������������������������������������������^�����>���������(������������*��������������X��<�����������_��
CHANGE BACK ADVANCED
Low Igniter CurrentFault occurred 2 mins ago
Igniter current is low.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������]������'}�����(����������������������
�� ����������������������� ������������������}������� �������������^���������������������������^�����V��������������&��
�� +����������������������]������'}�����(������^�����V�����$���������������������������
�� @���������) ������:�����������^�������������������������������� '}�����:���\�:�����������������"��}�����������<�}�<<��< ���
�������� �������������������������������:����������������<�^�see Venting Requirements on page 22.
�� '}�����:����������������������������:���������<���������� '}�����:��������:�������������������������������������
CHANGE BACK ADVANCED
Blocked ExhaustFault occurred 2 mins ago
The exhaust is blocked orrestricted. Ensurecondensate hose is draining.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
59
FAULT AND ALERT MESSAGES (CONT)!������������������������������< ���������������� �����:����������������������������������������������\����������:����������in your area.
POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ���������������<������������������]�������:���(������
��������������������������������� ������������� ���������������������������^���������(�\�����>��>����������������_�
�� �������)�������]�������:���(�������������^�����V�����$���������������������������
�� §<������������������������]�������:���(������^���<:��X<����������§<����������<�����:��� �����"�������������������on page 57.
�� '}�����:����������������������������:���������<���������� '}�����:��������:������������������������������������� CHANGE BACK ADVANCED
Blower Prover FailureFault occurred 2 mins ago
The blower prover switch isclosed out of sequence.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������]�������:���(��������������������<��������������������������������<�������������������!< �����]�����^���������(�\�����>��Operation on page 54.
�� +����������������������]�������:���(������^�����V�����$���������������������������
�� ]�������:���(������������������� �������������"�������"��������������������"���<���������������^������������������� ��
�� !< �����]����������������������������������� +������������������!< �����]������� +��"����"�����������������������6V*���]�;�_�������]�;�����
<�����̂ �����V�����$�������������������������������<�����������
CHANGE BACK ADVANCED
Blower Prover OpenFault occurred 2 mins ago
The blower prover switch remainsopen after the blower has beenenergized.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������]������J����������(����������������������
�� +����������������������]������J����������(������^�����V�����$���������������������������
�� '}�����:���\�:�����������������"��}�����������<�}�<<��< ����������� �������������������������������������������������system - see Venting Requirements on page 22.
�� ]����������������)�����������������������������<:��������������������������������������������������������������������������) ������������� ����^�����V�����&%���������_�
�� '}�����:��������:������������������������������������� CHANGE BACK ADVANCED
Blocked Air IntakeFault occurred 2 mins ago
The combustion air intake isrestricted.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<������������������'!>�=�����������?�(����������������������
�� ����'!>���������������<����������������������������������<������������������:�����}�����:����������<��������������������������������'!>����������������������K�������<���������� ��=������������?�^�����V�����$�������������K������� ���������
�� +����������������������'!>���������������K�������<���������� ��^��������������
�� J<�����������������<�����������)���}�����:���������������=�����������?������������<��������^����������������������Diagrams beginning on page 67.
CHANGE BACK ADVANCED
Energy Cut Out (ECO)Fault occurred 2 mins ago
Tank temperature is excessive.The water heater has beendisabled.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������<���������������������:��������<���������������������^�����V�����$��������������������
�� #���������������������������� +������������������������������������������������^�����
V�����$���������������������� �������������������������������������� ��������������������������������������^����������(�����
!����������������$���� +���������������������� ����������=$)_������ �����?����������������������������
��������������������������������������^��������������������������������������"������������<:��������������������� �����=�?�
CHANGE BACK ADVANCED
No Anode VoltageAlert:
Alert occurred 2 mins ago
No voltage detected fromPowered Anode(s).
Call a service professional:Your Company Name Here(press [DOWN] for more....)
60
MAINTENANCE SCHEDULE
TABLE 14
COMPONENT OPERATION INTERVAL REQUIREDTank (���<����
RemovalSemi Annually V������
Tank +�<��(�����Removal
Semi Annually UN-LIME®
�����@�� J���������!�������
Annually !�����(�����Deposits
T&P Valve Test Operation Semi Annually Test
Vent System J�������� Annually Termination (�������!����Reseal/Repair
DRAINING AND FLUSHING
J��������<<���������������������������������������� �������������� ������ �:���� �� <����� �� ������ ����<���� ������ ���������������������� ������������� ������������������������������<����������(���V�����������!<��������������%�����������������������������������<������������� ��� ����
Burn harzard.
Hot water discharge.
Keep hands clear of drainvalve discharge.
To drain the water heater storage tank:1. �����������������������������������������������2. Turn off the gas supply at the Main Gas Shutoff Valve if the
����������������������� �����������������}��������������3. '�������������������������:��:���������4. >���������� �����������������������������������������������
��������������������5. !�������������������������������������:��:���������<������
�����������\����������6. !������������������������:��:��7. >���������������������������:��:���������������������������
��������<�����������������8. !���� ���� ������ ������� ������ :��:�� ����� ���� ������ ��� ����
������������������������9. !��������������������������������(����_�10. J����������������������������� �����������������}�������
�����"�����������:��:������� �����������To Flush the tank perform the following steps:1. �����������������������������������������������2. '�������������������������:��:���������3. >���������� ����������� ���������� ���� ���������� ��������
������������������������������������������������������4. !������ �� ���� �� ���� ������ :��:�� ���� ���<������ ��� �� ���
���\����������
MAINTENANCEGENERAL
�������������������������������������<��< ��� ���<��������"��������������������<<� ���:�����������\�����(���+�������The Water Heater on page 11.������ ������� <����������� �������� �������� ����� ������� ������������"�������<:�������<������������������������������� ������������������X�������<���������������< ������(���J�������(�����K���������������������������������������:������������<������ ��<��������������"�������������������<�=�?������ �����������������������<��<��������������<<���������PRECAUTIONS
Do not operate the water heater if it has been exposed to or exhibits the following:
Flooding at or above the level of the burner or controls.External damage.Firing without water.Sooting.
Do not operate the water heater until all corrective stepshave been made by a qualified service agent.
CAUTION
#�:��� ������� ���������� ������������� ����� ����� �������� ��� ��������� ����� ������ ���� �� �������� ������ ���� ������ ��<�������^��������@������6��:�����������������������������:��:��������������� ������ �������� (��� ��<�������^�������� @������ 6��:�� ��page 15.
Explosion Hazard
Overheated water can causewater tank explosion.
Properly sized temperature andpressure relief valve must beinstalled in the opening provided.
(����:�������������������������������������������"�����������C����W���(�����:��:���(���V���������������$%������� ������� <����������� �������� �������� ����� ������� ������������"�������<:�������<������������������������������� ������������������X�������<���������������< ������@����������� �������� �� �������������� ������������ ����:������������<������ ��<��������������"�����������������������<������� �����������������������<��<���������������<<���������
61
TANKCLEANOUTOPENING
CLEANOUTCOVER
CLEANOUTGASKET
CLEANOUTACCESS PANEL
Figure 59
MANUAL LIME SCALE REMOVALNOTE:�!�������������������� ��������������������������<����������< ��������� �����:����������<���������������������������������;�:������������������:���� ��� �������<:����������������:������� ������� ������� ��� ����� ��� V����� ���� �� ��<:�� ��<��������<�����������������������������������������������1. �����������������������������������������������2. �����������������<��� ���������"�����*������������V�������
���������"��������������������������������������������heater.
3. @�<:����������������������������<������������������������������X������
4. @�<:��������������:�����<���������������5. @�<:�� ��<�"� ������ ���)�� ����<���� ����� ����� ��� ��
��<�������������^�������6. J��������������������������������\�����7. @���������������������:�����]���������������������������
����������������������������8. !���������������������������:��:��9. V���������������������̂ �����V�����������������;����������������10. ���������������������������������������������������� ����
in operation. See Initial Start Up on page 50.11. �������������������������<��������:����������������������
ensure it is operating properly.12. !����������������������13. @���������������������������������CHEMICAL LIME SCALE REMOVAL�������:��������<:��<����� �����<���������������"�K#^+JC'¹������������*���<�������� �������K#^+JC'¹������������*���<����������������������������������� ������ ����� ��<������ ������������ ��� ��<�� ������ ��<:�����<�������������������������\��<�����;���������� ����������<��� ��� �� ���� �� ����<�� ���� ������ �������� �:����� ��� �����manual.V���� ���� ����������� �� ���� K#^+JC'¹� �� ����<�� ���� ������heater.NOTE:� !���� ���� ������ ������<���� ����� �< ��� �� ���� �����:����� �����<����� �������K#^+JC'¹������������*���<����See TABLE 15 on page 62 for part numbers.
5. '����������������������������� ������������������������������������������V���������������<�������������<�������������������������������������������
6. >���������������������������:��:�������������������������7. V�������������������������������������<:������<��������
��������������������������������������8. !���������������������������:��:������������������<�������9. @�<:����������������10. V���������������������̂ �����V�����������������;����������������11. ���������������������������������������������������� ����
in operation. See Initial Start Up on page 50.12. �������������������������<��������:����������������������
ensure it is operating properly.
FILLING THE WATER HEATER
(���V�����������������;����������������
SEDIMENT REMOVAL
����� ���� �<����������������� ���������������� ���� ������������������������������<���������������<���������� ��<���the tank.V�� ��:�������"� ����<���� ��<:��� ���� ��<�� ������ ��<:�������� �������<������������<����<��
LIME SCALE REMOVAL
����������� ���������������:���<�������� ��� ����������������������<� ���� <������<� ��� ����� =��<�� �����?� ��<�� ������� ���� ��� ���� ������ ��<�������� ������ ������ <�������� ���������������������������������������� �<��� �� ��<�� ������ ��������� ��<� ������ ��� ��� �������������������������<�����������������������������������������<��������������������"�����<�����<�������������������������������������������������������������� ��<�����������<������������ ������<����������������� �����������<�"�������������������������<�����<�������������������������+�<������������������������������������ ������<������ ��������������� ��������;������� ��������� �������� ��<���������������<�� ������ �������� ������ ���������� ���� ����� �� ������� ���������� �������� +�<�� ������ �������� ���� ���� ����� �< �����������������������������<������������������������<����������������������������+�<�����������<������������������������������������������������V���������������������������������������<��������� ������������ ������ �� ��<�� ���<������ ��� ���� ��<� �� ���� ������������� ����� �� <������� ������������� J������� �� ��<:�������� ������� �:��� ���� �:���� �� <����� ��� ������ *���<����<����������� ����� ����� �� �����<��� ����� �� ���� ��<�� ������������&������=�����<?�����<�������<������������ ��<��������������������(���<����������<����������<:���<��� �����<��������<����������������������������������������������������������"�����V���������
62
DISCHARGE PIPE
TEMPERATURE-PRESSURERELIEF VALVE
V�������J�� ���� ��<�������^�������� @������ 6��:�� �� ���� ������ ������������� �� ����������� �����������"� ����� <��� �� ��� �� ����<���expansion.NOTE:�'}�����:�����������������������<����<<�����������<�������^�������� @������ 6��:�� ��������� '}�����:�� �����������<��������� ���<�������������� �� ¦����<����}������¦������¦�����������<�¦�(�������<���'}�����������!�����������Systems on page 14. The Temperature-Pressure Relief Valve is ����������������������������������������<����}���������<�������^��������@������6��:����������������������� ����������������������<���������������:��������<����}�����������������������������:����������������<�������������������<����}�������������<��� �����������������������������������<��DO NOT PLUG THE TEMPERATURE-PRESSURE RELIEF VALVE OPENING. THIS CAN CAUSE PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
VENT SYSTEM
'}�<��������:���������<��������������������������������������������1. !�������� ������������)�������������������������������
���)��:����������������������������������:�������<���������@��������<<����������������������
2. ���� �� ���� �������� ��� ���� ������� ���� ���� :���� ���<������������� �� ����� �� �������� �� ������� <�������� ���� ����(���V������������������NOTE:�*���������������������:�����������������������is in operation.
3. !���������:���������<�������������������������������������������������������
TABLE 15
UN-LIME® PROFESSIONAL DELIMERPart Number Description9005416105 _�^�&�������=����?9005417105 1 - 5 gallon
POWERED ANODE RODS
�� ������ �� ���"� �� ��^����� ��������� ����"� ���� ������ ���������:����� ��� ����� <����� ���� ������� �\������ ����� �� �����������������<��������������� =�?������������<����������������� �� ��� ����� ���������� ������ ��<������ J��������� ������������������ �������<��������������NOTE:�V������������������������������������������������������������������������@�<:���������������������<�����������heater by loosening the 3/4" NPT bushing that forms the top �� ���� ������� *� ��� �������< ��� ���� ���������� ��� ���� ��������<����� ��<� ���� ��� ������ ���������� ��� ���� ������ ������"� ����������� ��������� <��� ����� ������� ���� ������ @�<:�� ���� ���������������� ��<����������������������� �� �����������!����� ��������������������������������������������V���������������������������������������������������������������������
DRAIN VALVE AND ACCESS PANELS
�������������������:����� ��� �����<����������\�������������������:��:�"�����V�����������!<��������������%�������������������������������:�������������<��������������\������������� ������� ������� ��� ����<���� ���� ��<�� ������ ��<:���� (���V����������������&�
TEMPERATURE-PRESSURE RELIEF VALVE TEST
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
J�� ��� ���<<������ ����� ������<�������^��������@������6��:������� �� �������� �� ������ ����� ��� ��� ��� ��������� ��������every 6 months.��������������������<�������^��������@������6��:���������"�<�������������=&?�������������������������������������������<�������^��������@������6��:������������ ����"�����=�?� ����������������������������������������������������<���"��������������<��� ���}���<��������K����������������������:��:�����the valve may be hot.�� ������ ���� ������� :��:�"� ����� ���� ��:��� ��� ���� ���� �� ���� :��:����:�������<��"�����V�������������:��:������������������������operate freely.J��������<��������������������:��:�"�������������<������������������ �������� �� �������� �����"� �<<��������� ����� ���� ���������� ������ �� ��������������������������� ����������������"�����*������������ V������� �� ����� ���� @������� ������<�������^��������@������6��:����������������������)������������"�������<�������^��������@������6��:���������&�������������������������<����
63
DIAGRAMSCCB - CENTRAL CONTROL BOARD LAYOUT
1 Retry
Use Yes
Type Tstat
Spare
ExtInput
3Retries
No
Vent
Spare
OPE
N
1
2 3
4
3
2
1
6
5
4
9
8
7
12
11
10
15
14
13
J6
J7 3 24 1
1
2
J15
84
5
6
7
1
2
3
J13
3
4
1
2
J10
1
3
5
2
4
J1
1
3
4
2
J2
1
4
2 1
2
J3 J5 J4
S1 DIPSWITCH
J16
J9
J11
S1 DIPSWITCH DETAIL
CCB (CENTRAL CONTROL BOARD)
1 Retry
Use Yes
Type Tstat
Spare
ExtInput
3Retries
No
Vent
Spare
OPE
N
1
2 3
4
Dipswitch Operation:Along one side of the dipswitch array there are numbers, 1-4. On the other side of the dipswitchis the word “OPEN.” The dipswitches are rocker type switches, if one side of the rocker is down the other side will be up. Pressing a rocker down on the side of the array labeled “OPEN,” opens the switch.Pressing a rocker down on the side of the array labeled with the numbers 1-4 closes the dipswitch.
CHANGING NUMBER OF IGNITION TRIALS BEFORE LOCK OUT
NOTE: Always turn off power to the water heater before changing dipswitch settings.
Set dipswitch #4 to the open position for 1 trial for ignition before Ignition Failure lock out. Set dipswitch#4 to the closed position for 3 trials for ignition before Ignition Failure lock out.
Figure 61
64
BTH 300 WIRING DIAGRAM
2 GREEN
WHITE
RED BLACK
1
1
2
BLACK
3
WHITE
COMBUSTIONBLOWER
UPPER TEMPERATURE PROBE
1 RED (ECO)
4 RED (ECO)
2 BLACK3 BLACK
1 BLACK120 VAC HOT
3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC
4 YEL 24 VAC
LOWER TEMPERATURE PROBE
HOT SURFACE IGNITER
FLAME SENSOR
BLOCKED AIR INTAKE
BLOCKED EXHAUST
BLOWER PROVER
24 VAC GAS VALVE
B (C
EN
TR
AL C
ON
TR
OL B
OA
RD
)C
C6J
5J4J
7J51
J
61J
01J
31J
2J3J
1J
TRANSFORMER INSIDE CCBENCLOSURE50VA
GROUND STRIPBURNER GROUND(BURNER BOLT)
ON/OFFSWITCH
GROUND
120 VAC NEUTRAL
120 VAC HOT
LOW GASPRESSURE SWITCH
1 BLACK2 WHITE
RED
1 BLACK
2 BLACK
1 BLACK
2 WHITE
MU
SE
R IN
TER
FAC
E M
OD
ULE
IU
1
21541451067
8
13
11
LN
ANODE 1
ANODE 2
1 GREEN
2 BLUE
2 RED
GREENWHITE
NOIT
CN
UJX
OB
GREEN
NE
ER
G
NE
ER
G
ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG
120 VAC 1 Ø POWER
Figure 62
65
BTH 400, 500 WIRING DIAGRAM
12
56
WHITE
GREEN
BLACK
BLACK
WHITE
RED
COMBUSTIONBLOWER
NOTE: COMBUSTION BLOWER MOTORSON 400,000 & 500,000 Btu/hr MODELS ARETHREE PHASE (3Ø) MOTORS.
BLACK, WHITE AND RED WIRES MUST BEWIRED AS SHOWN OR THE MOTOR WILLTURN BACKWARDS. THIS MAY CAUSE THECONTROL SYSTEM TO LOCK OUT ON“BLOWER PROVER OPEN” FAULT.
WHITE/BLACK
WHITE/GREEN
WHITEWHITE/YELLOW
1T
2T
3T
LN
AI1
0V
+15V
L l1
2 GREEN
WHITE
RED BLACK
1
BLACK
3
WHITE
1 RED (ECO)
4 RED (ECO)
2 BLACK3 BLACK
BLOCKED INTAKE AIR
BLOCKED EXHAUST
BLOWER PROVER
24 VAC GAS VALVE
BC
C6J
5J4J
7J51
J
61J
01J
31J
2J3J
1J
TRANSFORMER50VA
GROUND STRIPBURNER GROUND(BURNER BOLT)
LOW GASPRESSURE SWITCH
1 BLACK
RED
2 WHITE
1 BLACK
2 BLACK
MIU
1
21541451067
8
13
11
LN
ANODE 1
ANODE 2
1 GREEN
2 BLUE
NOIT
CN
UJX
OB
RED
GREEN GREEN WHITE
NE
ER
G
NE
ER
G
NE
ER
G
GREEN
UPPER TEMPERATURE PROBE
1 BLACK120 VAC HOT
3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC
4 YEL 24 VAC
LOWER TEMPERATURE PROBE
HOT SURFACE IGNITER
FLAME SENSOR
(CE
NT
RA
L CO
NT
RO
L BO
AR
D)
INSIDE CCBENCLOSURE
GROUND
120 VAC NEUTRAL
120 VAC HOTU
SE
R IN
TER
FAC
E M
OD
ULE
ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG
VFDVARIABLEFREQUENCYDRIVE
ON/OFFSWITCH
Figure 63
66
CIRCULATION PUMP WIRING DIAGRAMS
Figure 64
Figure 65
CIRCULATING PUMP WIRING DIAGRAMSTORAGE TANK OR BUILDING RECIRCULATION
FIELD SUPPLIED TEMPERATURE CONTROLINSTALLED IN THE STORAGE TANKOR CIRCULATING LOOP RETURN LINE
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.
CIRCULATING PUMP WIRING DIAGRAMDISHWASHER LOOP WITH TOGGLE SWITCH
FIELD SUPPLIED TEMPERATURECONTROL INSTALLED IN THECIRCULATING LOOP RETURN LINE
DISHWASHERTOGGLESWITCH
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.
67
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
BU
ILD
ING
RE
CIR
CU
LAT
ION
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
EX
PAN
SIO
NTA
NK
HO
T W
ATE
R O
UTL
ET
PIP
E T
&P
TO
OP
EN
DR
AIN
CO
LDW
ATE
RS
UP
PLY
HO
T W
ATE
RR
ETU
RN
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
68
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
ON
E W
AT
ER
HE
AT
ER
, TW
O T
EM
PE
RA
TU
RE
WIT
H H
IGH
TE
MP
ER
AU
RE
LO
OP
RE
CIR
CU
LAT
ION
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
N
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
E
MIX
ING
VA
LVE
WA
RN
ING
: TH
IS D
RAW
ING
SH
OW
S S
UG
GE
STE
DP
IPIN
G C
ON
FIG
UR
ATIO
N A
ND
OTH
ER
DE
VIC
ES
;C
HE
CK
WIT
H L
OC
AL
CO
DE
S A
ND
OR
DIN
AN
CE
SFO
R A
DD
ITIO
NA
L R
EQ
UIR
EM
EN
TS.
HO
T W
ATE
R
OU
TLET
HO
12” T
O 1
5”M
INIM
UM
T
CO
LD
TEM
PE
RE
DW
ATE
RTO
FIX
TUR
ES
CO
LD W
ATE
RS
UP
PLYTE
MP
ER
ED
WAT
ER
RE
TUR
N
HO
T W
ATE
RR
ETU
RN
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
MIX
ING
VA
LVE
69
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
VE
RT
ICA
L S
TOR
AG
E T
AN
K F
OR
CE
D R
EC
IRC
ULA
TIO
NW
ITH
BU
ILD
ING
RE
CIR
CU
LAT
ION
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
ALT
. CO
LD W
ATE
RC
ON
NE
CTI
ON
PIP
E T
&P
TO
OP
EN
DR
AIN
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
TAN
K T
EM
PE
RA
TUR
EC
ON
TRO
L
NO
TE:
The
wat
er h
eate
r’s O
pera
ting
Set
Poi
nt s
houl
d be
set
5°
high
er th
an th
e Ta
nk T
empe
ratu
re C
ontro
l in
the
auxi
liary
sto
rage
tank
.
AOSSTORAGE TANK
70
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
HO
RIZ
ON
TA
L S
TO
RA
GE
TA
NK
FO
RC
ED
RE
CIR
CU
LAT
ION
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
N
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
E
MIX
ING
VA
LVE
WA
RN
ING
: TH
IS D
RAW
ING
SH
OW
S S
UG
GE
STE
DP
IPIN
G C
ON
FIG
UR
ATIO
N A
ND
OTH
ER
DE
VIC
ES
;C
HE
CK
WIT
H L
OC
AL
CO
DE
S A
ND
OR
DIN
AN
CE
SFO
R A
DD
ITIO
NA
L R
EQ
UIR
EM
EN
TS.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
ALT
ER
NA
TE T
AN
KTE
MP
ER
ATU
RE
CO
NTR
OL
LOC
ATI
ON
EX
PA
NS
ION
TAN
K
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
TAN
K T
EM
PE
RA
TUR
EC
ON
TRO
L
NO
TE:
The
wat
er h
eate
r’s O
pera
ting
Set
Poi
nt s
houl
d be
set
5°
high
er th
an th
e Ta
nk T
empe
ratu
re C
ontro
l in
the
auxi
liary
sto
rage
tank
.
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
AO
SS
TOR
AG
E T
AN
K
71
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
TW
O W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
72
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
TH
RE
E W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
73
4.
(��
�!�
����
(��
��<
����
����
��<
���'
}���
���
���
����
�&_
5.
(��
����
���+
����
!�
����
���
���
����
�_��
6.
J����
�<
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
�_�
����
����
���
7.
J����
�<
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�<
<��
����
����
����
�����
�����
���
����
���V
���
���_
���V
���
����
���
����
����
WAT
ER P
IPIN
G D
IAG
RA
MS
]��
���
����
����
����
���
����
����
����
��:�
�����
���
���
����
1.
See
Mix
ing
Valv
es o
n pa
ge 1
4.2.
(
���*
����
����
���C
����
����
���
����
&_�
3.
See
Tem
pera
ture
-Pre
ssur
e R
elie
f Val
ve o
n pa
ge 1
5.
FOU
R W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
74
LIMITED WARRANTY���>��(<����!�������"�������������"��}������������������+JCJ�'*���@@�#�B��������������������������������1. THE TANKJ�����������^����������������������������������������:������}�<������� �������������������:������������������������������<���� ����������������"�����������������;@''��������������������������������"����������������������������������<�������������� ���������������������<�������������>��(<��������������������\�:����������������������<����������������������������(<���:���<�������������������\��������������������������������������������������J�������:������������������ ������������<�������\�:������������������������"�����>��(<�����������:������<�����������<����������������������������������"����������������������<�������� ���������������������������������� �����������������������<����������������������������<������\��������������������������������<���������������������� ����<�������������}���������<������������������������2. ALL OTHER PARTS
J���������>#'���������������������������������������������������"��������������������������:������}�<������� ����������������� ���������:�����<�������������<������"�����������������������������������������������������������������3. !>#*J�J>#(��#*�' !'��J>#(������������������������������������������������������������������������������������������< �������� �����������"������������������������"��������������������������:����������������������������������������J���������"�����<���������������������������:��:�"���������� ��!(����������:��� �������<�������(��������C����������'��������"�<�����:�� ��������������� ����������������������������������������������������������� � =&?������ ������������������������ � =�?����������<�������������}������������<�}�<<�������������������<������ � =$?��������������������������}���������������������������������������������� � =_?�������������������������������<����������������������������������<<���� � =�?������������������������ ��������"��������������������������<����� � =�?������������^�����:��������^����<���������<�������� � =%?���������������������:�������=�?������������ � =�?������������������������������������ � =�?��������K������(�����"���������������������������"�����!������� � =&�?��������������������������������������������\�������<<���������������������� � =&&?� ����������������������������������� �����������"�������������<:����}����������\����� ���������������� � =&�?����������������������������������������������������������������������� � =&$?�<����������������������������������������������������������<������������������������������������ ���������������������������������"�����<����"�� ���=�����������������?�����������������"�����������������������<��������<"�����������<���
�������������������������:������������������ ��������������������:����������:���������������� ���������:��������:����=������:��:�������?���������������������������������������������������
����������"�����������������:��<���������������������<����}�������������������������������������=�?������������������������<��� � � ������<���������������������������:��:����������������������������not����������� ���<����� 4. ('@6J!'��#*�@'��J@�' �'#('(K�����������<����������������������������������:�����������������<���������������������������������������������������� ���������������������(��������<���������� �����������<�������� ���+� ����������������:������<:��"��������������������������������������������������<������������ ��(�������"�����:���"���������"�������<���������:�����������������������������������������������<�����������<������������������� ���������������
������������<����������:���������������������������� ���� �����������������������������������������<�����������)�����<������\���������������������������������<����5. LIMITATIONS ON IMPLIED WARRANTIESJ<����������������"�������������������������<�������� �������<���������������������������������������������������<����������=&?����������������������������������������������(<���������������������<���������������������<��������������������"�������� :����<�������<����������������6. !+�JC��@>!'*K@'���� ����<� ����� ���� ��������� ����� �� ���������� ����� ���� ������� ��� ���� ���� ������ ������"� �� ����� ���� ����� ������� ��������� ���� ���������� ��������J��������������������� ��"���������������������� K�(��!��<��� !��������!��<���� � � � � ���>��(<����!�������� ���>��(<����'�����������+���� � � � � ���������������������������� ���>��]}"�$&��^�%���'����(������ � � � � ��������!���"��#�$%�&�� (��������=>�����?��#�����$� � � � � ����������&^=���?^$�$^��$�� ����������&^=���?����^����� ������������������������������������<�����������������������<�������������������������������������������<������������������ ���� ���������������� ��*�������������<���������<����� X��������^���������:��������� �����������7. *J(!+�JC'@(#>�>�;'@�' �@'((���@@�#�B�;�(�]''#�>@��J++�]'�C�*'�J#�]';�+V�>V��;'���@@�#�>@��J�;�@'(�'!���>��;'�C'@!;�#��]J+J�B�>V���;'��;'��'@��>@��;'�J#(��++��J>#"�>�'@��J>#"�@'��J@�>@�@'�+�!'C'#��>V��;'����'@��;'��'@���;'���@@�#�>@�(;�++�#>��]'�@'(�>#(J]+'�V>@����'@�*�C�W'"�+>((�>V�K('�>V��;'�K#J�"�J#!>#6'#J'#!'"�+>((�>@�*�C�W'��>��'@(>#�+��@>�'@�B�>@�>�;'@�!>#('`K'#�J�+�*�C�W'���;'���@@�#�>@�(;�++�#>��]'�+J�]+'�]B�6J@�K'�>V��;J(���@@�#�B�>@�>�;'@�J('�V>@�*�C�W'��>��#B��'@(>#(�>@��@>�'@�B"��;'�;'@�*J@'!��>@�J#*J@'!�"��#*��;'�;'@��@J(J#W�J#�!>#�@�!��>@��>@��� ���(<������������������������}����������<������������������������������\���������<���"�������� :����<�����������}�������<����������������� ������������������:�������������������������"�������<���������:��������������������:������<���������������
V����������������������������������������Keep it���@�������������������������������������������<����������������< ���������������������������������������
*����J��������¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾C����#�¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾Serial No.¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾
*��������#�<� ¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾�����#�¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾
*���������������¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾!��������(����¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾����!��¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾¾
FILL IN WARRANTY AND KEEP FOR FUTURE REFERENCE.
75
���������������������������"���������!���"��#�$%�&�����������(���������^��%^&��$���������������^_$$^��_������V�}�����^�__^�$��
�������������<