Upload
hadang
View
259
Download
10
Embed Size (px)
Citation preview
23 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
OUTSIDEDIMENSIONS
COOLROOM +2ºC ROOM TEMP / 35 ºC AMBIENT
L X W2.4m Height
Int Volume m3
Product Load Kg / 24hrs
Room Usage
16/24 hr Watts
1.8 x 1.2 4.0 80Medium 1200
Heavy 1600
1.8 x 1.8 6.3 140Medium 1450
Heavy 2000
2.4 x 1.8 8.6 180Medium 1650
Heavy 2250
2.4 x 2.4 11.8 250Medium 2100
Heavy 2750
3.0 x 2.4 14.9 320Medium 2400
Heavy 3150
3.0 x 3.0 18.9 400Medium 2750
Heavy 3550
3.6 x 2.4 18.0 380Medium 2700
Heavy 3500
3.6 x 3.0 22.9 480Medium 3050
Heavy 4000
3.6 x 3.6 27.7 580Medium 3400
Heavy 4600
4.8 x 3.6 37.3 780Medium 4150
Heavy 5350
4.8 x 4.8 50.3 1050Medium 5150
Heavy 6500
**Allow an Additional 500W Per Glass Door Insert
COOLROOM QUICK SELECTION GUIDE
CAPACITIES BASED ON THE FOLLOWING:
Coolrooms 75mm Insulation with concrete floor / Freezers 150mm Insulation including floor.
Product entering 8deg above room temperature (Pre-frozen product only entering freezers)
Off-Cycle 'Air Defrost' for Coolrooms / 80mins per 24hrs total 'Electric Defrost' for Freezers.
FREEZER ROOM -18 ºC ROOM TEMP / 35 ºC AMBIENT
Int Volume m3
Product LoadKg / 24hrs
Room Usage
18/24 hr WattS
2.8 60Medium 1100
Heavy 1350
4.7 100Medium 1150
Heavy 1650
6.6 140Medium 1300
Heavy 1850
9.3 190Medium 1450
Heavy 2350
11.9 250Medium 1900
Heavy 2600
15.3 320Medium 2100
Heavy 2950
14.6 310Medium 2050
Heavy 2850
18.7 390Medium 2350
Heavy 3300
22.9 480Medium 2550
Heavy 3550
31.2 660Medium 3350
Heavy 4500
44.5 890Medium 3550
Heavy 5050
*Allow an Additional 600W Per Glass Door Insert
EQUIPMENT SELECTION NOTES
1) Select unit to best match required room capacity at most relevant evaporating and air-on ambient temperature.
32 & 35deg ambient rated capacity selection will be sufficient for most applications with good unit ventilation.
Use 40deg rated capacity selection for constant extreme ambient locations or where ventilation is poor.
For 36deg ambient ratings add 32 & 40deg ratings and divide by two.
2) Select Evaporator to match unit capacity at 32deg. Matching at 40deg unit capacity will mean the evaporator will be under-sized for most of the year - This may result in low room RH and drying out of sensitive products.
Select evaporator with 20 - 25% more capacity for high humidity applications.
Select evaporator with 30 - 35% less capacity for Low humidity applications.
3) Select Expansion valve and orifice to match unit capacity at desired evaporating temperature.
Use expansion valve with MOP function for low temp condensing unit applications (Not with CPR valve)
Use expansion valves that can operate at low superheat for high RH applications (see Honeywell range)
PLEASE CONTACT REALCOLD FOR ASSISTANCE WITH SELECTION OR IF YOU REQUIRE A QUOTATION.
COOLROOM SELECTION GUIDE
24 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
GUNTNER DROP IN
PART NO. DESCRPTION REFRIGERANT ROOM TEMP RANGE
CAPACITY @ RT+3 MT / -18 LT dBA @ 3m KG PRICE $
EXCL. GST
GEKN2001 GEKN.2001-DF, MT Drop-In Unit R134A +10 to -5oC 1840 55 107 5,870.00
GEKN3001 GEKN.3001-DF, MT Drop-In Unit R134A +10 to -5oC 2440 61 118 6,175.00
GEKT1501 GEKT.1501-DF, LT Drop-In Unit R404A -25 to -10oC 1500 59 117 6,460.00
GEK SERIES DROP-IN UNITS
HousingExtremely durable, robust, condenser housing made of galvanized steel sheet, white powder-coated to RAL 9003. Evaporator housing ALMg3, white powder-coated to RAL 9003.
CompressorSilent, hermetic, reciprocating compressor produced by well-known manufacturer, with motor protection.
EvaporatorHigh-capacity heat exchanger made of copper tubes with aluminium fins; Evaporator with optimised fin spacing (4mm for coolroom units, 7mm for freezer units) reduces ice-ups and ensures long defrost intervals. All models including 'med temp' include electric defrost allowing for lower room temperatures.
CondenserAircooled high-capacity heat exchanger made of copper tubes with aluminium fins; designed for maximum ambient temperatures of up to 45°C.
FansLow-noise EBM axial fans with IP44 Protection. Temperature range of use: -30°C to +40°C
Control
230V/50 Hz, programmable refrigeration controller with digital temperature display, time-contolled electical defrost via integrated heating rods, automatic defrost timer, display of excessive or insufficient room temp, operation signal lamps for the refrigeration units as well as the cold store light.
GEK FEATURES
GUNTNER GEK Drop-in refrigeration units offer a quick, easy and reliable method of adding refrigeration to small insulated coolrooms and freezer rooms. They are inserted into an opening that has to be made in the cold store ceiling. The size of this opening corresponds with the dimensions of the ventilator that is attached to the unit. The installation depth of the air cooler components is 100mm for normal coolers and 120 for deep coolers.
Capacity Ratings based at 38deg ambient temperaturePlease contact Realcold for ratings at other conditions
Front View Side View
Max Panel Thickness (A)
Med Temp units = 100mmLow Temp Units = 120mm
25 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
STOCK NO. MODELNOM
HPAMBIENT TEMP ˚C
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 5
CU0129A UNEK6144GK 1/532 300 360 425 490 565
785.0040 255 305 360 415 480
CU0130 UNEK6181GK 1/432 530 645 765 900 1040
895.0040 450 550 650 765 885
CU0133 UNEK6210GK 1/332 555 665 885 1030 1230
920.0040 470 565 750 875 1045
CU0135 UNEK6213GK 3/832 905 1065 1215 1350 1470
950.0040 770 905 1030 1150 1250
CU0138 UNT6217GK 1/232 930 1145 1365 1590 1820
1,095.0040 790 970 1160 1350 1550
CU0140 UNT6220GK 5/832 1025 1260 1505 1755 2010
1,350.0040 870 1070 1280 1490 1710
CU0144 UNT6226GK 3/432 1570 1880 2200 2525 2865
1,380.0040 1335 1600 1870 2145 2435
CU0144A UNJ9226GK 3/432 1535 1875 2225 2590 2965
1,555.0040 1305 1595 1890 2200 2520
CU0145 UNJ9232GK 1-1/432 1765 2125 2510 2900 3295
1,640.0040 1500 1805 2135 2465 2800
CU0148 UNJ9238GK 1-1/232 2300 2750 3155 3565 3985
1,750.0040 1955 2340 2680 3030 3385
High efficiency, low noise Embraco compressors
World renowned compressor reliability
Copper tube coil condenser on all models
Small footprint allows fitting in tight spots
Made with corrosion resistant materials
CONDENSING UNITS
EMBRACO HERMETIC
R404A - MED TEMPERATURE (1PH/240V)
Ratings based on 32k Return gas temperature / 8k SubcoolingFor 43deg ratings multiply 40deg by 0.95 / For 36deg ratings add 32 & 40deg and divide by two.All units suitable for use with either TX valve or capillary tube. (Remove Receiver for capillary application)
TECHNICAL DATA
UNIT MODELCOMPRESSOR COND FAN MOTOR AIR
VOLUME L/SEC
CONNECTIONS (FL) DIMENSIONS (mm)KG dB(A)
@3mHP DISP CC MOTOR MRA WATTS AMPS LIQUID SUCTION WIDTH DEPTH HEIGHT
UNEK6144GK 1/5 4.5 CSIR 2.4 38 0.25 85 1/4 3/8 306 435 254 17 43
UNEK6181GK 1/4 7.4 CSIR 3.5 60 0.42 165 1/4 3/8 340 465 296 21 46
UNEK6210GK 1/3 8.9 CSIR 3.8 60 0.42 165 1/4 3/8 340 465 296 21 47
UNEK6213GK 3/8 12.0 CSIR 3.9 60 0.42 165 1/4 3/8 340 465 296 21 50
UNT6217GK 1/2 14.5 CSIR 5.1 110 0.75 180 3/8 1/2 395 470 324 33 52
UNT6220GK 5/8 17.4 CSIR 5.6 110 0.75 180 3/8 1/2 395 470 324 33 52
UNT6226GK 3/4 22.4 CSR 6.8 110 0.75 195 3/8 5/8 405 500 390 35 53
UNJ9226GK 3/4 21.7 CSR 6.4 90 0.38 195 3/8 5/8 410 512 370 38 53
UNJ9232GK 1-1/4 26.1 CSR 7.8 90 0.38 400 1/2 5/8 440 600 370 42 54
UNJ9238GK 1-1/2 32.7 CSR 10.1 90 0.38 400 1/2 5/8 440 600 380 45 56
All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.
EMBRACO CONDENSING UNITS
26 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
STOCK NO. MODELNOM
HPAMBIENT TEMP ˚C
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -23.3 -20 -15
CU0116 UNE2125GK 3/832 205 285 375 405 470 580
835.0040 175 240 320 345 400 495
CU0117 UNE2134GK 1/232 235 335 455 500 595 735
935.0040 200 285 385 425 505 625
CU0118S UNEK2150GK 5/832 320 390 480 545 590 725
1,025.0040 270 330 410 465 500 615
CU0120S UNT2178GK 3/432 410 540 710 780 910 1165
1,195.0040 350 460 605 665 775 990
CU0123S UNT2180GK 132 425 570 750 830 970 1245
1,250.0040 360 485 635 705 825 1060
CU0126 UNJ2192GK 1-1/432 645 835 1060 1200 1325 1625
1,365.0040 550 710 900 1020 1125 1380
CU0128 UNT2212GK 1-3/832 825 1055 1335 1445 1670 2050
1,385.0040 700 895 1135 1230 1420 1740
CU0129 UNJ2212GK 1-1/232 885 1165 1480 1600 1825 2200
1,430.0040 750 990 1260 1360 1550 1870
R404A - LOW TEMPERATURE (1PH/240V)
Ratings based on 32k Return gas temperature / 8k SubcoolingFor 43deg ratings multiply 40deg by 0.95 / For 36deg ratings add 32 & 40deg and divide by two.All units suitable for use with either TX valve or capillary tube. (Remove Receiver for capillary application)
TECHNICAL DATA
UNIT MODELCOMPRESSOR COND FAN MOTOR AIR
VOLUME L/SEC
CONNECTIONS (FL) DIMENSIONS (mm)KG dB(A)
@3mHP DISP CC MOTOR MRA WATTS AMPS LIQUID SUCTION WIDTH DEPTH HEIGHT
UNE2125GK 1/3 8.8 CSIR 2.7 38 0.25 115 1/4 3/8 300 480 254 18 44
UNE2134GK 1/2 12 CSIR 3.4 65 0.42 165 1/4 3/8 340 465 296 20 48
NEK2150GK 5/8 12.1 CSR 3.8 65 0.42 130 1/4 3/8 340 467 296 20 50
UNT2178GK 3/4 17.4 CSR 3.9 65 0.42 130 1/4 3/8 340 476 296 33 51
UNT2180GK 1 20.4 CSR 4.5 65 0.42 130 1/4 3/8 340 476 296 29 52
UNJ2192GK 1-1/4 26.1 CSR 5.8 110 0.75 220 3/8 1/2 410 480 324 36 53
UNT2212GK 1-1/2 27.8 CSR 6.7 110 0.75 220 3/8 1/2 395 470 324 34 53
UNJ2212GK 1-1/2 34.4 CSR 8.1 110 0.75 220 3/8 5/8 410 480 324 37 55
All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.
EMBRACO CONDENSING UNITS
High efficiency, low noise Embraco compressors
World renowned compressor reliability
Copper tube coil condenser on all models
Small footprint allows fitting in tight spots
Made with corrosion resistant materials
CONDENSING UNITS
EMBRACO HERMETIC
27 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
STOCK NO. MODELNOM
HPAMBIENT TEMP ˚C
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 5
CU0103 UNE6170Z 1/432 335 440 535 640 755
850.0040 285 375 455 545 640
CU0105 UNE6187Z 1/332 490 615 750 900 1050
895.0040 415 520 635 765 890
CU0108 UT6213Z 3/832 650 815 995 1180 1380
1,045.0040 550 690 845 1005 1175
CU0110 UNT6215Z 1/232 720 925 1130 1340 1570
1,125.0040 610 785 960 1140 1335
CU0113 UNT6220Z 5/832 995 1255 1530 1845 2155
1,375.0040 845 1065 1300 1570 1830
CU0114 UNJ6220Z 3/432 1010 1260 1535 1850 2195
1,395.0040 860 1070 1305 1570 1870
CU0115 UNJ6226Z 132 1370 1685 2035 2420 2815
1,440.0040 1165 1430 1730 2055 2390
R134A - MEDIUM TEMPERATURE (1PH/240V)
Ratings based on 32k Return gas temperature / 8k SubcoolingFor 43deg ratings multiply 40deg by 0.95 / For 36deg ratings add 32 & 40deg and divide by two.All units suitable for use with either TX valve or capillary tube. (Remove Receiver for capillary application)
TECHNICAL DATA
UNIT MODELCOMPRESSOR COND FAN MOTOR AIR
VOLUME L/SEC
CONNECTIONS (FL) DIMENSIONS (mm)KG dB(A)
@3mHP DISP CC MOTOR MRA WATTS AMPS LIQUID SUCTION WIDTH DEPTH HEIGHT
UEMT6144Z 1/5 5.9 CSIR 1.7 38 0.25 85 1/4 3/8 306 430 226 17 44
UNE6170Z 1/4 8.9 CSIR 2.0 38 0.25 115 1/4 3/8 300 480 254 17 45
UNE6187Z 1/3 12.1 CSIR 3.2 65 0.42 165 1/4 3/8 340 465 296 21 46
UT6213Z 3/8 17.4 CSIR 4.5 65 0.42 165 1/4 3/8 353 476 296 23 49
UNT6215Z 1/2 20.4 CSIR 4.7 90 0.62 205 1/4 1/2 340 465 296 27 49
UNT6220Z 5/8 22.4 CSIR 5.5 110 0.75 180 3/8 1/2 395 470 324 34 50
UNJ6220Z 3/4 26.1 CSIR 5.9 110 0.75 180 3/8 1/2 410 480 324 35 52
UNJ6226Z 1 34.4 CSR 6.3 110 0.75 180 3/8 5/8 410 480 324 38 54
All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.
CONDENSING UNITS
EMBRACO HERMETIC
EMBRACO CONDENSING UNITS
High efficiency, low noise Embraco compressors
World renowned compressor reliability
Copper tube coil condenser on all models
Small footprint allows fitting in tight spots
Made with corrosion resistant materials
28 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
EMBRACO SPARES REFERENCE
MODEL NO STARTRELAY OVERLOAD
START CAPACITOR RUN CAPACITOR FANMOTOR FAN BLADE WATTS AMPS
MODEL MFD MODEL MFD
UNEK6144GK 2334122 2319069 2252347 43 - 53 - - 1450072 230mm 36 0.25
UNEK6181GK 2334121 2319093 2252347 43 - 53 - - 1450073 254mm 60 0.42
UNEK6210GK 2334105 2319095 2252346 53 - 64 - - 1450073 254mm 60 0.42
UNEK6213GK 2334119 2319080 2252346 53 - 64 - - 1450073 254mm 60 0.42
UNT6217GK 2334136 2319126 2252365 64 - 77 - - 1450054 275mm 110 0.75
UNT6220GK 2334101 2319118 2252364 88 - 108 - - 1450054 275mm 110 0.75
UNT6226GK 1253023 2289018 2252329 140 - 154 2253312 20 1450054 275mm 110 0.75
UNJ9226GK 1253009 2289020 2252269 88 - 108 2253312 20 153422 300mm 90 0.38
UNJ9232GK 1253007 2289028 2252269 88 - 108 2253314 30 153422 300mm 90 0.38
UNJ9238GK 1253007 2289029 2252274 140 - 154 2253313 25 153422 300mm 90 0.38
UNE2125GK 2965024 2316018 2252346 53 - 64 - - 1450072 230mm 38 0.25
UNE2134GK 2334011 2316018 2252346 53 - 64 - - 1450073 254mm 65 0.42
UT2155GK 1253012 INTERNAL 2252270 72 - 88 2253262 15 1450073 254mm 65 0.42
UT2168GK 1253022 INTERNAL 2252269 88 - 108 2253262 15 1450073 254mm 65 0.42
UT2178GK 1253012 INTERNAL 2252269 88 - 108 2253310 15 1450073 254mm 65 0.42
UNT2192GK 1253022 INTERNAL 2252269 88 - 108 2253310 15 1450054 275mm 110 0.75
UNJ2192GK 1253008 INTERNAL 2252269 88 -108 2253264 20 1450054 275mm 110 0.75
UNT2212GK 1253002 INTERNAL 2252269 88 - 108 2253312 20 1450054 275mm 110 0.75
UJ2212GK 1253010 INTERNAL 2252269 88 - 108 2253264 20 1450054 275mm 110 0.75
UEMT6144Z 2334132 2319087 2252347 43 -53 - - 1450072 230mm 38 0.25
UNE6170Z 2334117 2319069 2252347 43 - 53 - - 1450072 230mm 38 0.25
UNE6187Z 2334105 2319073 2252346 53 - 64 - - 1450073 230mm 65 0.42
UNT6213Z 2277011 2292086 2252216 88 - 108 - - 1450053 254mm 65 0.42
UNT6215Z 2334103 2319099 2252365 88 - 108 - - 1450074 254mm 90 0.62
UNT6220Z 1253022 2321105 2252269 88 - 108 2253311 17.5 1450054 254mm 110 0.75
UNJ6220Z 2302002 2289019 2252265 88 - 108 - - 1450054 254mm 110 0.75
UNJ6226Z 1253012 2289022 2252270 72 - 88 2253311 17.5 1450087 254mm 110 0.75
CONDENSING UNITS
EMBRACO SPARES
29 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A - LOW TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -23.3 -20 -15
RHA350L RHA(T)100S-1F-BR-L 1 1x30035 720 865 1035 1125 1245 1480
1,845.0040 615 730 920 970 1115 1330
RHA352L RHA(T)150S-1F-BR-L 1.5 1x35035 995 1215 1495 1575 1780 2155
2,215.0040 825 1035 1295 1410 1605 1900
RHA354L RHA(T)200S-1F-BR-L 2.0 1x35035 980 1370 1815 2015 2305 2840
2,815.0040 835 1200 1610 1740 2055 2545
RHA355LSA RHA(T)200S-2F-BR-LSA 2.0 2x35035 1055 1505 1920 2185 2560 3145
3,595.0040 870 1285 1760 1900 2240 2840
R404A - LOW TEMPERATURE (3PH/415V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -23.3 -20 -15
RHA358L RHA(T)250T-1F-BR-L 2.5 1x40035 1725 2165 2670 2925 3375 4090
3,480.0040 1480 1830 2370 2530 2935 3565
RHA360LSA RHA(T)250T-2F-BR-LSA 2.5 2x35035 1790 2230 2745 3005 3465 4195
3,845.0040 1550 1890 2445 2605 3025 3670
RHA362LSA RHA(T)400T-2F-BR-LSA 4.0 2x35035 2265 2890 3685 4070 4630 5685
4,995.0040 1880 2535 3270 3515 4135 5090
RHA364LSA RHA(T)550T-2F-BR-LSA 5.5 2x40035 3450 4320 5340 5685 6575 7965
5,610.0040 2960 3790 4735 5055 5870 7130
CONDENSING UNITS
REALCOLD HERMETIC
Built to Australian standards to suit Australian conditions
Reliable high efficiency Tecumseh compressors
Generously sized high ambient condensers
High efficiency, low noise external rotor fan motors
Dual pressure control fitted on all models
Liquid line drier & sight glass fitted on all models
Oil separator & Accumulator fitted on dual fan models
RHA(T) SERIES - HIGH AMBIENT
Y = R
134
A M
ED TEM
P
Z =
R4
04
A M
ED TEM
P
BR
= R
40
4A
LOW
TEMP
200
NO
MIN
AL H
P ÷
100
RHA
REA
LCO
LD
HIG
H A
MB
IENT U
NIT
T = TEC
UM
SEH
T = TH
REE P
HA
SE
S = SIN
GLE P
HA
SE
NU
MB
ER O
F FAN
S
2F BR
MODEL DESIGNATION
T
L = LL D
RIER
& S/G
ASS
S = O
IL SEPA
RA
TOR
A =
AC
CU
MU
LATO
R
LSA
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 28 for technical details
PEGO PRE-WIRED MINI-BOARDS AVAILABLE FOR 3PH UNITS
SEE PAGE 33
30 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A - MED TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RHA320L RHA(T)100S-1F-Z-L 1 1x30035 1320 1605 1880 2215 2495
1,675.0040 1175 1430 1715 1965 2260
RHA322L RHA(T)118S-1F-Z-L 1.18 1x35035 1560 1960 2350 2820 3245
1,805.0040 1410 1785 2140 2570 1250
RHA324L RHA(T)125S-1F-Z-L 1.25 1x35035 1875 2290 2695 3185 3620
1,875.0040 1710 2085 2450 2830 3280
RHA326L RHA(T)150S-1F-Z-L 1.5 1x40035 2495 3015 3640 4290 4850
1,965.0040 2230 2755 3320 3815 4405
RHA328L RHA(T)200S-1F-Z-L 2.0 1x40035 2895 3580 4345 5045 5880
2,820.0040 2575 3220 3830 4575 5210
RHA329LS RHA(T)200S-2F-Z-LS 2.0 2x35035 2975 3675 4450 5160 6015
3,390.0040 2655 3310 3930 4690 5340
RHA330L RHA(T)250S-1F-Z-L 2.5 1x40035 3615 4420 5260 6265 7120
3,100.0040 3205 3945 4725 5500 6415
RHA332LS RHA(T)250S-2F-Z-LS 2.5 2x35035 3720 4535 5395 6420 7295
3,475.0040 3310 4065 4860 5655 6595
R404A - MED TEMPERATURE (3PH/415V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RHA334L RHA(T)250T-1F-Z-L 2.5 1x40035 3615 4420 5260 6265 7120
3,095.0040 3205 3945 4725 5500 6415
RHA336L RHA(T)250T-2F-Z-LS 2.5 2x35035 3720 4535 5395 6420 7295
3,435.0040 3310 4065 4860 5655 6595
RHA338LS RHA(T)300T-2F-Z-LS 3.0 2x40035 5170 5955 7025 8210 9235
3,895.0040 4435 5315 6325 7225 8350
RHA340LS RHA(T)400T-2F-Z-LS 4.0 2x40035 5945 6850 8080 9440 10620
4,420.0040 5100 6110 7275 8310 9600
RHA342LS RHA(T)500T-2F-Z-LS 5.0 2x40035 6435 7685 9210 10920 12710
4,945.0040 5680 6840 8240 9795 11390
RHA344LS RHA(T)650T-2F-Z-LS 6.5 2x40035 8815 10560 12385 14785 16995
5,600.0040 7815 9460 11460 13375 15775
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 28 for technical details
CONDENSING UNITS
REALCOLD HERMETIC
Built to Australian standards to suit Australian conditions
Reliable high efficiency Tecumseh compressors
Generously sized high ambient condensers
High efficiency, low noise external rotor fan motors
Dual pressure control fitted on all models
Liquid line drier & sight glass fitted on all models
Oil separator fitted on all dual fan models
RHA(T) SERIES - HIGH AMBIENT
PEGO PRE-WIRED MINI-BOARDS AVAILABLE FOR 3PH UNITS
SEE PAGE 33
31 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R134A - MED TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RHA300L RHA(T)075S-1F-Y-L 0.75 1x30035 845 1150 1510 1865 2235 2610
1,780.0040 760 1060 1365 1690 2030 2375
RHA302L RHA(T)100S-1F-Y-L 1.0 1x30035 1220 1555 1935 2350 2740 3185
1,860.0040 1115 1430 1780 2170 2525 2940
RHA304L RHA(T)150S-1F-Y-L 1.5 1x40035 1505 2180 2885 3690 4450 5220
3,040.0040 1350 1960 2665 3350 4130 4845
RHA306LS RHA(T)150S-2F-Y-LS 1.5 2x35035 1535 2220 2940 3755 4530 5315
3,495.0040 1380 2005 2720 3415 4210 4935
RHA308L RHA(T)200S-1F-Y-L 2.0 1x40035 2365 3035 3895 4795 5765 6785
3,205.0040 2115 2790 3525 4435 5340 6290
RHA310LS RHA(T)200S-2F-Y-LS 2.0 2x35035 2415 3095 3970 4885 5870 6910
3,795.0040 2165 2850 3595 4525 5445 6410
R134A - MED TEMPERATURE (3PH/415V)
STOCK NO. MODELNOM
HPFans
AMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RHA312LS RHA(T)275T-2F-Y-LS 2.75 2x35035 2760 3720 4850 6000 7355 8780
4,540.0040 2470 3345 4375 5535 6790 7945
RHA314LS RHA(T)300T-2F-Y-LS 3.0 2x40035 3240 4285 5535 6945 8480 9915
4,830.0040 2895 3940 5100 6415 7845 9160
RHA316LS RHA(T)350T-2F-Y-LS 3.5 2x40035 3475 4550 5905 7355 9075 10730
4,995.0040 3120 4100 5335 6785 8395 9910
CONDENSING UNITS
REALCOLD HERMETIC
Built to Australian standards to suit Australian conditions
Reliable high efficiency Tecumseh compressors
Generously sized high ambient condensers
High efficiency, low noise external rotor fan motors
Dual pressure control fitted on all models
Liquid line drier & sight glass fitted on all models
Oil separator fitted on all dual fan models
RHA(T) SERIES - HIGH AMBIENT
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 28 for technical details
PEGO PRE-WIRED MINI-BOARDS AVAILABLE FOR 3PH UNITS
SEE PAGE 33
32 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
RHA(T) TECHNICAL DATA
STOCK N0UNIT MODEL
RHA(T)
COMPRESSOR COND FAN (ea) AIR VOLUME
L/SEC
CONN UNIT DIMENSIONSKG
dB(A) @3mMODEL PH HP DISP CC MRA QTY AMPS DIA LIQ SUCT WIDTH DEPTH HEIGHT
RHA300L 075S-1F-Y-L CAJ4492Y 1 0.75 26.0 6.4 1 0.4 300 380 3/8 1/2 430 495 360 40 51
RHA302L 100S-1F-Y-L CAJ4511Y 1 1.0 32.7 6.8 1 0.4 300 380 3/8 5/8 430 495 360 40 52
RHA304L 150S-1F-Y-L FH4518Y 1 1.5 53.2 9.9 1 1.0 400 980 3/8 5/8 600 600 560 72 61
RHA306LS 150S-2F-Y-LS FH4518Y 1 1.5 53.2 9.9 2 0.7 350 1335 3/8 5/8 1000 620 470 80 58
RHA308L 200S-1F-Y-L FH4525Y 1 2.0 74.3 13.2 1 1.0 400 980 3/8 7/8 600 600 560 72 62
RHA310L 200S-2F-Y-LS FH4525Y 1 2.0 74.3 13.2 2 0.7 350 1335 3/8 7/8 1000 620 470 80 60
RHA312LS 275T-2F-Y-LS TAG4534Y 3 2.75 100.7 6.0 2 0.7 350 1335 3/8 7/8 1000 620 470 102 62
RHA314LS 300T-2F-Y-LS TAG4537Y 3 3.0 112.5 6.5 2 1.0 400 2000 1/2 7/8 1080 650 565 107 63
RHA316LS 350T-2F-Y-LS TAG4543Y 3 3.5 124.4 7.3 2 1.0 400 2000 1/2 7/8 1080 650 565 112 64
RHA320L 100S-1F-Z-L CAJ9510Z 1 1.0 18.3 6.5 1 0.4 300 380 3/8 5/8 430 495 360 41 51
RHA322L 118S-1F-Z-L CAJ9513Z 1 1.18 24.2 8.1 1 0.7 350 625 3/8 5/8 510 615 450 45 57
RHA324L 125S-1F-Z-L CAJ4517Z 1 1.25 26.0 9.0 1 0.7 350 625 3/8 5/8 510 615 450 51 57
RHA326L 150S-1F-Z-L CAJ4519Z 1 1.5 34.5 12.0 1 1.0 400 980 3/8 5/8 600 600 560 72 60
RHA328L 200S-1F-Z-L FH4524Z 1 2.0 43.5 13.0 1 1.0 400 980 3/8 5/8 600 600 560 73 62
RHA329L 200S-2F-Z-LS FH4524Z 1 2.0 43.5 13.0 2 0.7 350 1335 3/8 5/8 1000 620 470 80 59
RHA330L 250S-1F-Z-L FH4531Z 1 2.5 56.7 16.7 1 1.0 400 850 1/2 7/8 600 600 560 76 63
RHA332LS 250S-2F-Z-LS FH4531Z 1 2.5 56.7 16.7 2 0.7 350 1335 1/2 7/8 1000 640 470 80 60
RHA334L 250T-1F-Z-L TFH4531Z 3 2.5 56.7 6.2 1 1.0 400 850 1/2 7/8 600 600 560 76 62
RHA336LS 250T-2F-Z-LS TFH4531Z 3 2.5 56.7 6.2 2 0.7 350 1335 1/2 7/8 1000 640 470 80 60
RHA338LS 300T-2F-Z-LS TFH4540Z 3 3 74.3 8.5 2 1.0 400 1835 1/2 7/8 1080 650 565 90 64
RHA340LS 400T-2F-Z-LS TAG4546Z 3 4 90.2 8.9 2 1.0 400 1665 1/2 7/8 1080 650 565 115 67
RHA342LS 500T-2F-Z-LS TAG4561Z 3 5 112.5 10.3 2 1.0 400 1665 1/2 1-1/8 1080 650 565 122 67
RHA344LS 650T-2F-Z-LS TAG4573Z 3 6.5 134.8 13.6 2 1.0 400 1665 1/2 1-1/8 1080 650 565 127 68
RHA350L 100S-1F-BR-L CAJ2446Z 1 1 26.2 5.9 1 0.4 300 380 3/8 1/2 430 495 340 39 53
RHA352L 150S-1F-BR-L CAJ2464Z 1 1.5 34.5 8.5 1 0.7 350 625 3/8 5/8 510 615 450 43 56
RHA354L 200S-1F-BR-L FH2480Z 1 2.0 53.2 11.5 1 0.7 350 625 3/8 5/8 510 615 450 60 58
RHA355LSA 200S-2F-BR-LSA FH2480Z 1 2.0 53.2 11.5 2 0.7 350 1335 3/8 5/8 1000 620 470 98 60
RHA358L 250T-1F-BR-L TFH2511Z 3 2.5 74.5 5.5 1 1.0 400 985 3/8 7/8 600 600 560 75 63
RHA360LSA 250T-2F-BR-LSA TFH2511Z 3 2.5 74.5 5.5 2 0.7 350 1335 3/8 7/8 1000 620 470 101 61
RHA362LSA 400T-2F-BR-LSA TAG2516Z 3 4 112.5 7.3 2 0.7 350 1335 1/2 7/8 1000 620 470 108 62
RHA364LSA 550T-2F-BR-LSA TAG2522Z 3 5.5 134.8 9.1 2 1.0 400 1835 1/2 1-1/8 1080 650 565 110 65
All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.Please contact Realcold for further details.
CONDENSING UNITS
REALCOLD HERMETIC
H
W
D
ATTRACTIVE OUTDOOR COVERS AVAILABLE SEE NEXT PAGE
33 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
RHA RANGE ACCESSORIES
PART NO. MODEL AMPS DESCRIPTION DIMENSIONSH X W X D
PRICE $EXCL. GST
G4932 5RSECP0501 4.5 - 6.3
Electrical box c/w Isolating switch, Compressor contactor & overload, 1ph Cond fan/Control circuit breaker
250 x 195 x 95
515.00
G4933 5RSECP0503 5.8 - 8.0 515.00
G4934 5RSECP0504 7 - 10 515.00
G4936 5RSECP0506 11 - 16 552.00
* Above electrical boxes made with self-extinguishing ABS plastic with IP65 protection rating.
PEGO ECP ELECTRICAL BOARDS
Pego Mini Boards provide a simple, compact and professional solution for safe control of RHA(T) and other 3phase Condensing units. These compact Electrical boxes come pre-wired, ready to be fitted, saving you time on site with all the necessary components to operate, switch and protect Compressor, Condenser fans and Control circuit.
PART NO. DESCRIPTION PRICE $EXCL. GST
G1277A Fan Speed Controller - Direct Mount, Range 10-25 Bar adjustable 349.00
G1255 Emerson PS2 Auto-Restet Dual Pressure Switch 195.00
G0069A Pressure Switch Hose 400mm 32.00
G0069B Pressure Switch Hose 600mm 35.00
W4707A 300mm external rotor fan motor 225.00
W4707B 350mm external rotor fan motor 295.00
W4707C 400mm external rotor fan motor 355.00
SPARE PARTS & ACCESSORIES
PART NO. MODEL SUITS RHA(T) DIMENSIONSW X D X H
PRICE $EXCL. GST
RHA371 RHAC300-1 1 x 300mm Fan Models 430 x 505 x 370 295.00
RHA371 RHAC350-1 1 x 350mm Fan Models 515 x 630 x 450 415.00
RHA372 RHAC400-1 1 x 400mm Fan Models 602 x 630 x 570 490.00
RHA373 RHAC350-2 2 x 350mm Fan Models 1025 x 640 x 475 620.00
RHA374 RHAC400-2 2 x 400mm Fan Models 1105 x 660 x 575 730.00
* Covers come in knock-down form and are quickly & easliy assembled on site.
WEATHER PROOF UNIT COVERS
RHA Series Weather-proof unit covers provide a simple and cost effect way of protecting RHA(T) series condensing units from the elements. These at-tractive covers are painted light grey over galvanised steel and come with rust-proof stainless steel fasteners.
G1277A
H
W D
H
W
34 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404 - WIDE RANGE (3PH/415V)
STOCK NO. MODELNOM
HPAMB
TEMP
CAPACITY IN WATTS (R404A) PRICE $EXCL. GST-25ºC -20ºC -15ºC -10ºC -5ºC 0ºC 5ºC
CUS0115 RST500T-2FSZ 535 4620 5710 6990 8480 10200 12200 14250
5,187.0040 4140 5120 4480 7640 9230 11050 13200
CUS0118 RST600T-2FSZ 6 35 5330 6600 8070 10150 12250 14300 16950
5,670.0040 4890 6190 7580 9200 11100 13250 15450
CUS0121 RST750T-2FSZ 7.535 5580 7510 9710 12300 14650 17250 20400
6,384.0040 4920 6360 8540 10800 13250 15950 18650
CUS0124 RST800T-2FSZ 8 35 6380 8470 10750 13200 16000 18800 22300
6,731.0040 5540 7590 9520 11850 14450 17350 20200
CUS0127 RST900T-2FSZ 935 8250 10250 12600 15300 18350 21900 25400
7,497.0040 7420 9270 11400 13850 16650 19850 23500
CUS0130 RST1000T-2FSZ 10 35 9460 11850 14600 17750 21300 24900 28900
7,970.0040 8330 10600 13150 16050 19300 23100 26800
CUS0133 RST1000T-2FSZ 1235 11070 13860 17080 20770 24920 29130 33810
9,345.0040 9750 12400 15390 18780 22580 27030 31360
CONDENSING UNITS
REALCOLD SCROLL
Built in our Australian factory to suit Australian conditions
High efficiency Copeland scroll compressor on all models
Generously sized high ambient condensers
High efficiency, low noise external rotor fan motors
Dual pressure control fitted on all models
Pre-wired to generously sized electrical box
Wide range of factory fitted accessories available
Ratings based on; 10k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg ratings by 0.95Condenser fans should be controlled for Low temp applications.Total suction superheat should be kept below 15kRefer to page 36 for optional fitted accessories.
RST SERIES - SCROLL TECH
STOCK NO. MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $EXCL. GST-15ºC -10ºC -5ºC 0ºC 5ºC 10ºC
CUS0150 RST500T-2FJ 535 4110 5160 6430 7890 9480 11300
4,578.0040 3850 4850 6120 7430 8920 10600
CUS0152 RST600T-2FJ 635 4820 6080 7500 9260 11150 13050
4,914.0040 4470 5660 7090 8660 10400 12350
CUS0154 RST750T-2FJ 7.535 5650 6990 8660 10450 12500 14800
5,996.0040 5300 6550 8110 9810 11750 14100
CUS0156 RST800T-2FJ 835 6240 7730 9590 11600 13900 16250
6,248.0040 5820 7220 8970 10850 13000 15400
CUS0158 RST900T-2FJ 935 7150 8950 10950 13450 16100 18850
6,594.0040 6680 8370 10400 12600 15100 17900
CUS0160 RST1000T-2FJ 1035 8300 10250 12700 15400 18450 21800
7,067.0040 7770 9720 11900 14600 17500 20700
CUS0162 RST1200T-2FJ 1235 9710 11990 14860 18020 21590 25510
7,896.0040 9090 11370 13920 17080 20480 24220
R134A - MED / HIGH TEMPERATURE (3PH/415V)
35 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A (3PH/415V)
STOCK N0 UNIT MODELCOMPRESSOR CONDENSER FAN AIR
VOLUME L/SEC
CONN DIMENSIONS (mm)KG
dB(A) @3mtrMODEL HP MRA PH AMPS DIA LIQ SUCT WIDTH DEPTH HEIGHT
CUS0115 RST500T-2FSZ ZB38KQE-TFD 5.0 12..8 1 0.95 2 x 400 1650 1/2” 7/8” 1060 660 660 81 58
CUS0118 RST600T-2FSZ ZB45KQE-TFD 6.0 13.1 1 0.95 2 x 400 1650 5/8” 1-1/8” 1060 660 675 87 59
CUS0121 RST750T-2FSZ ZB50KQE-TFD 7.5 14.6 1 0.95 2 X 400 1650 7/8” 1-1/8 1210 1010 760 98 60
CUS0124 RST800T-2FSZ ZB58KQE-TFD 8.0 15.4 1 0.95 2 x 400 1650 7/8” 1-1/8” 1210 1010 760 102 61
CUS0127 RST900T-2FSZ ZB66KQE-TFD 9.0 17.5 3 0.95 2 x 500 3500 7/8” 1-3/8” 1440 1060 805 114 62
CUS0130 RST1000T-2FSZ ZB76KQE-TFD 10 20.4 3 0.95 2 x 500 3500 7/8” 1-3/8” 1440 1060 805 119 63
CUS0133 RST1200T-2FSZ ZB88KQE-TFD 12 22.3 3 0.95 2 x 550 4300 7/8” 1-3/8” 1440 1060 1070 128 65
R134A (3PH/415V)
STOCK N0 UNIT MODELCOMPRESSOR CONDENSER FAN AIR
VOLUME L/SEC
CONN DIMENSIONS (mm)KG
dB(A) @3mtrMODEL HP MRA PH AMPS DIA LIQ SUCT WIDTH DEPTH HEIGHT
CUS0150 RST500T-2FJ ZB38KQE-TFD 5.0 12..8 1 0.95 2 x 400 1650 1/2” 7/8” 1060 660 565 65 58
CUS0152 RST600T-2FJ ZB45KQE-TFD 6.0 13.1 1 0.95 2 x 400 1650 1/2” 1-1/8” 1060 660 565 70 59
CUS0154 RST750T-2FJ ZB50KQE-TFD 7.5 14.6 1 0.95 2 X 400 1650 1/2” 1-1/8” 1060 660 675 75 60
CUS0156 RST800T-2FJ ZB58KQE-TFD 8.0 15.4 1 0.95 2 x 400 1650 1/2” 1-1/8” 1060 660 675 82 61
CUS0158 RST900T-2FJ ZB66KQE-TFD 9.0 17.5 1 0.95 2 x 400 1650 5/8” 1-3/8” 1060 660 660 90 62
CUS0160 RST1000T-2FJ ZB76KQE-TFD 10 20.4 1 0.95 2 x 400 1650 5/8” 1-3/8” 1060 660 675 95 62
CUS0162 RST1200T-2FJ ZB88KQE-TFD 12 22.3 1 0.95 2 x 400 1650 7/8” 1-3/8” 1210 1010 760 102 64
RST SERIES TECHNICAL DATA
All RST units come standard with 3phase compressors, fan motors phases as indicated.All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.Please contact Realcold for further details.
CONDENSING UNITS
REALCOLD SCROLL
S = R
40
4A
MED
TEMP
Z =
R4
04
A LO
W TEM
P
J = R
134
A M
ED TEM
P
200
NO
MIN
AL H
P ÷
100
RST
REA
LCO
LD
SC
RO
LL TECH
UN
IT
T = TH
REE P
HA
SE
S = SIN
GLE P
HA
SE
NU
MB
ER O
F FAN
S
2F SC
MODEL DESIGNATION
T
36 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
ELECTRICAL BOARDS - PEGO
PART NO. SUITS AMPS DESCRIPTION PRICE $EXCL. GST
G4944F RST500 - 600 7 - 10 Electrical box c/w Isolating switch, 3ph compressor circuit breaker, Compressor contactor & overload, 1ph cond fan/control circuit breaker, LED Indicator
lights
830.00
G4946F RST750 - 800 9 - 12.5 830.00
G4948F RST900 - 1000 14 - 20 1,045.00
* Above electrical boxes made with self-extinguishing ABS plastic with IP65 protection rating.
Please contact Realcold for pricing and availability of other fitted optional accessories.
OIL SEPARATORS
PART NO. DESCRIPTION PRICE $EXCL. GST
F0070F 1/2” Oil Separator c/w Oil Charge 515.00
F0072F 5/8” Oil Separator c/w Oil Charge 546.00
F0074F 7/8” Oil Separator c/w Oil Charge 620.00
SUCTION ACCUMULATORS
PART NO. DESCRIPTION PRICE $EXCL. GST
F0105F 5/8” Suction Accumulator 368.00
F0106F 3/4” Suction Accumulator 378.00
F0107F 7/8” Suction Accumulator 478.00
F0108F 1-1/8” Suction Accumulator 562.00
F0109F 1-3/8” Suction Accumulator 657.00
LIQUID LINE ASSEMBLIES
PART NO. DESCRIPTION PRICE $EXCL. GST
ULF003 3/8” Liquid Line c/w Sight Glass & 163 Drier 321.00
ULF006 1/2” Liquid Line c/w Sight Glass & 164 Drier 331.00
ULF011 5/8” Liquid Line c/w Sight Glass & 305 Drier 373.00
CONDENSER FAN CONTROLS
PART NO. SUITS DESCRIPTION PRICE $EXCL. GST
UPF016 All Models HP Fan Cycling Control 305.00
UFF001 All 1PH Fan Models Johnson 1ph Fan Speed control 604.00
UFF004 All 3PH Fan Models Saginomiya 3ph Fan Speed control 1,375.00
SOLENOID VALVES
PART NO. DESCRIPTION PRICE $EXCL. GST
USF001 3/8” E5 Solenoid valve c/w Coil 279.00
USF003 1/2” E6 Solenoid valve c/w coil 300.00
USF006 5/8” E10 Solenoid valve c/w Coil 342.00
CONDENSING UNITS
RST RANGE ACCESSORIES
37 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
FEATURES & INCLUSIONS
Compressor sets up to 20hp include standard:
All units have the above components as standard with the larger 20 to 35hp range having these additional components fitted.
A huge range of optional extras can be fitted at your request and include:
Liquid line drier and sightglass
(with internal or external oil floats)
SEMI-HERMETIC CONDENSING UNITS
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
FRASCOLD range of air-cooled semi-Hermetic condensing units are manufactured in our factory right here in Australia. They include internationally accepted Frascold semi-hermetic compressors, which are ideally suited for todays conscientious environment.
All our units are built to Australian standards, include only high quality components combined with high ambient air-cooled condensers. This ensures reliability, high performance and trouble free operation even during those hot summers months.
MODEL DESIGNATION
Q521
CO
MP
RESSO
R
MO
DEL
1760
CO
ND
ENSER
MO
DEL
40
FAN
DIA
METER
(CM
)
2
NU
MB
ER O
F FAN
S
.6
6 P
OLE FA
N M
OTO
RS
Z-Series Condensing Unit
Q-Series Condensing Unit
(Fitted with VSD Inverter)
Please contact your nearest Realcold branch or one of our applications engineers for other configurations that you may require. With a streamlined local manufacturing facility and motivated manufacturing team, Realcold can offer flexible design and fast turn around times.
38 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A - MED TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $
excl. GST-15 -10 -5 0 5
CUF0013-1PH A16-550-352 135 2320 2850 3390 4040 4770
4,998.0040 2100 2580 3130 3700
CUF0028-1PH A157-650-352 1.535 2940 3610 4340 5180 6150
5,166.0040 2680 3300 3980 4760
CUF0049-1PH B210-1000-402 235 4020 4960 5980 7220 8550
5,691.0040 3660 4530 5480 6560
R134A - MED TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $
excl. GST-15 -10 -5 0 5
CUF0014-1PH A16-550-352.6 135 1330 1690 2100 2580 3120
4,998.0040 1230 1570 1960 2420 2910
CUF0024-1PH A157-550-352.6 1.535 1700 2150 2670 3250 3910
5,135.0040 1560 2000 2490 3040 3670
CUF0044-1PH B210-550-352 235 2350 2990 3730 4560 5480
5,397.0040 2170 2770 3470 4250 5120
R404A - LOW TEMPERATURE (1PH/240V)
STOCK NO. MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $
excl. GST-35 -30 -25 -20 -15
CUF0014-1PH A16-550-352.6 135 820 1100 1420 1800 2210
4,998.0040 700 970 1280 1610 2010
CUF0024-1PH A157-550-352.6 1.535 1000 1340 1760 2190 2710
5,135.0040 860 1190 1560 1970 2450
CUF0044-1PH B210-550-352 235 1390 1850 2370 2990 3660
5,397.0040 1240 1660 2130 2680 3320
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
Ratings based on 20k suction superheat, 3k subcoolingFor 43deg ambient ratings multiply 40deg by 0.95Please refer to pages 50-54 for fitted optional accessories.
FRASCOLD CONDENSING UNITS
FEATURES
39 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A - MED TEMPERATURE (3PH/415V)
STOCK NO. MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $
excl. GST-15 -10 -5 0 5
CUF0013 A16-550-352 135 2320 2850 3390 4040 4770
4,683.0040 2100 2580 3130 3700
CUF0028 A157-650-352 1.535 2940 3610 4340 5180 6150
4,851.0040 2680 3300 3980 4760
CUF0049 B210-1000-402 235 4020 4960 5980 7220 8550
5,345.0040 3660 4530 5480 6560
CUF0058 D211-1000-402 235 4690 5750 6960 8320 9740
5,859.0040 4190 5210 6310 7560
CUF0074 D313-1400-402 335 5640 6960 8500 10150 11990
6,321.0040 5140 6370 7700 9300
CUF0086 D315-1400-402 335 6560 7990 9560 11320 13280
6,458.0040 5960 7200 8700 10300
CUF0103 D418-1700-402 435 7790 9470 11290 13460 15730
7,224.0040 7140 8680 10350 12340
CUF0112 Q521-1700-402 535 8640 10600 12790 15210 17710
8,316.0040 7680 9560 11560 13780
CUF0124 Q525-2200-402 535 10270 12530 15110 18040 21340
8,810.0040 9310 11370 13720 16390
CUF0133 Q728-2800-502 7.535 12610 14940 17970 21400 25220
9,786.0040 11080 13640 16420 19570
CUF0145 Q733-2800-502 7.535 13810 16970 20400 24010 28220
10,479.0040 12550 15290 18600 21880
CUF0157 S1242-3900-552 1235 17000 21080 25540 30610 36370
13,304.0040 15350 19120 23250 27990
CUF0169 S1552-4900-552 1535 22070 26660 32190 38220 45120
14,480.0040 20040 24720 29590 35170
CUF0181 S2056-4900-552 2035 24980 30140 36020 42730 50390
15,519.0040 22900 27340 33070 39260
CUF0193 V2059-5800-553 2035 24890 30890 37450 44930 53420
18,848.0040 22460 27980 34020 40950
CUF0208 V2571-7300-553 2535 30300 36730 45390 54390 64610
20,097.0040 27110 33680 41310 49630
CUF0217 V3084-7300-553 3035 35650 44010 53150 62950 74670
21,504.0040 32320 40010 48440 58080
CUF0219A V3293-9600-554 3035 38980 48670 59290 71370 85060
24,612.0040 34820 43670 53960 65170
CUF0225 Z35106-9600-554 3535 45540 56250 68000 80610 95750
27,185.0040 41260 51050 61810 74170
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
Ratings based on 20k suction superheat, 3k subcoolingFor 43deg ambient ratings multiply 40deg by 0.95Please refer to pages 50-54 for fitted optional accessories.
FRASCOLD CONDENSING UNITS
FEATURES
OPTIONAL PREWIRED SWITCHBOARD OR FITTED WITH VSD
40 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R404A - LOW TEMPERATURE (3PH/415V)
STOCK NO. MODEL HPAMBTEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -20 -15
CUF0014 A16-550-352.6 135 820 1100 1420 1800 2210
4,683.00 40 700 970 1280 1610 2010
CUF0024 A157-550-352.6 1.535 1000 1340 1760 2190 2710
4,819.00 40 860 1190 1560 1970 2450
CUF0044 B210-550-352 235 1390 1850 2370 2990 3660
5,082.00 40 1240 1660 2130 2680 3320
CUF0055 D211-650-352 235 1610 2140 2790 3530 4390
5,628.00 40 2910 1900 2490 3160 3890
CUF0066 D213-650-352 235 1980 2590 3300 4150 5080
5,712.00 40 3650 2340 3000 3720 4610
CUF0082 D315-1000-402 335 2280 3230 4100 5050 6290
6,006.00 40 2070 2920 3700 4570 5570
CUF0107 Q420-1200-402 435 2870 3810 4950 6240 7670
7,917.00 40 2550 3370 4410 5650 6960
CUF0120 Q525-1400-402 535 3530 4760 6150 7770 9630
8,190.00 40 3110 4190 5520 6990 8670
CUF0128 Q528-1700-402 5.535 4220 5620 7270 9100 11210
8,620.50 40 3740 5020 6450 8200 10120
CUF0137 Q533-1700-402 5.535 5180 6670 8420 10430 12620
8,988.00 40 4600 6020 7610 9450 11440
CUF0149 Q736-2200-402 7.535 6240 8080 10140 12510 15240
10,269.00 40 5570 7260 9130 11290 13780
CUF0151 S842-2800-502 835 6610 8850 11320 14130 17330
12,138.00 40 5760 7790 10140 12680 15570
CUF0163 S1052-3900-552 1035 8710 11260 14200 17600 21420
13,608.00 40 7810 10190 12910 16080 19600
CUF0174 S1556-3900-552 1535 9540 12460 15670 19570 23930
14,647.00 40 8390 11100 14200 17620 21840
CUF0187 V1559-4900-552 1535 10050 13070 16540 20600 25120
17,608.00 40 8880 11820 15060 18820 22990
CUF0199 V1571-4900-552 1535 11790 15360 19250 23970 29240
18,123.00 40 10360 13680 17450 21580 26680
CUF0214 V2084-5800-553 2035 12970 17150 22080 27530 33730
19,750.00 40 21520 15390 19830 24700 30230
CUF0218 V2593-5800-553 2535 13230 17920 23170 29240 36220
20,559.00 40 11520 15580 20590 26130 32500
CUF0223 Z25106-7300-553 2535 15900 21440 28090 35560 44190
24,076.00 40 14150 19170 24920 32030 39890
CUF0226 Z30126-7300-553 3035 18520 24780 31880 40140 46640
24,958.00 40 16410 21800 28520 35990 44590
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
20k suction superheat, 3k subcoolingFor 43deg ambient ratings multiply 40deg by 0.95Please refer to pages 50-54 for fitted optional accessories.
FRASCOLD CONDENSING UNITS
FEATURES
OPTIONAL PREWIRED SWITCHBOARD OR FITTED WITH VSD
41 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R134A - MED / HIGH TEMPERATURE (3PH/415V)
STOCK NO. MODEL HPAMBTEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 5 10
CUF0014 A16-550-352.6 135 1330 1690 2100 2580 3120 3710
4,683.00 40 1230 1570 1960 2420 2910 3500
CUF0024 A157-550-352.6 1.535 1700 2150 2670 3250 3910 4660
4,819.00 40 1560 2000 2490 3040 3670 4390
CUF0044 B210-550-352 235 2350 2990 3730 4560 5480 6520
5,082.00 40 2170 2770 3470 4250 5120 6110
CUF0055 D211-650-352 235 2640 3390 4260 5270 6410 7620
5,628.00 40 2430 3130 3950 4900 5920 7040
CUF0066 D213-650-352 235 3180 4020 5000 6090 7280 8600
5,712.00 40 2910 3720 4600 5620 6780 8080
CUF0082 D315-1000-402 335 3670 4720 5890 7250 8800 10500
6,006.00 40 3370 4370 5480 6770 8190 9790
CUF0107 Q420-1200-40-2 435 5000 6360 7950 9730 11750 14000
7,917.00 40 4600 5930 7450 9130 11120 13180
CUF0120 Q525-1400-40-2 535 6420 8080 9890 12060 14460 17190
8,190.00 40 5980 7510 9280 11330 13590 16170
CUF0137 Q533-1700-402 5.535 7760 9780 12100 14750 17680 20820
8,988.00 40 7260 9160 11340 13730 16570 19500
CUF0149 Q736-2200-402 7.535 9330 11840 14670 17760 21200 25010
10,269.00 40 8700 11030 13720 16770 20060 23690
CUF0150 S842-2200-402 835 10730 13610 16890 20590 24880 29810
11,445.00 40 9830 12560 15680 19190 23280 28010
CUF0162 S1052-2800-502 1035 12720 15930 19680 23840 28600 33990
12,821.00 43 11830 14890 18300 22370 26860 31950
CUF0173 S1556-2800-502 1535 14170 17760 21790 26410 31690 37400
13,629.00 40 13170 16590 20400 24770 29740 35140
CUF0186 V1559-3900-552 1535 15430 19340 23900 29170 35230 42140
17,136.00 40 14240 18080 22410 27410 33160 39450
CUF0198 V1571-3900-552 1535 18120 22650 27930 33800 40490 48060
17,546.00 40 16850 21170 26180 31720 38040 45200
CUF0211 V2084-4900-552 2035 19320 24910 31000 38270 46290 55350
18,522.00 40 17880 22930 28850 35720 43290 51880
CUF0212 V2593-4900-552 2535 23100 28920 35700 43240 51840 61180
19,131.00 40 21500 27050 33480 40610 48740 57550
CUF0220 Z25106-5800-553 2535 24330 30930 38650 47190 56880 67820
22,722.00 40 34060 28600 35480 43740 52800 63070
CUF0226 Z30126-7300-553 3035 29830 37970 47480 58500 70620 84330
24,959.00 40 27490 35150 44110 54510 65970 79000
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
Ratings based on 20k suction superheat, 3k subcoolingFor 43deg ambient ratings multiply 40deg by 0.95Please refer to pages 50-54 for fitted optional accessories.
FRASCOLD CONDENSING UNITS
FEATURES
OPTIONAL PREWIRED SWITCHBOARD OR FITTED WITH VSD
42 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
STOCK NO.COMPRESSOR CONDENSER UNIT DIMENSIONS CONNECTIONS
WEIGHTKG
dB(A) @3mtrMODEL HP DISP
M3hr MRA MODEL FANS PH AMPS (ea) L/Sec WIDTH DEEP HIGH DRW
NO.LIQUID SUCTION
240 VOLT COMPRESSOR
CUF0013-1PH A016 1 5.5 6.2 RAC550-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 57 49
CUF0014-1PH A016 1 5.5 6.2 RAC550-352.6 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 57 49
CUF0024-1PH A157 1.5 6.9 7.9 RAC650-352.6 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 58 50
CUF0028-1PH A157 1.5 6.9 7.9 RAC650-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 58 50
CUF0044-1PH B210 2 9.8 11.7 RAC550-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 3/4 65 51
415 VOLT COMPRESSOR
CUF0013 A016 1 5.5 3.5 RAC550-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 57 49
CUF0014 A016 1 5.5 3.5 RAC550-352.6 2 x 350 1 0.70 950 860 640 460 1 3/8 5/8 57 49
CUF0024 A157 1.5 6.9 4.5 RAC550-352.6 2 x 350 1 0.70 950 860 640 460 1 3/8 5/8 58 50
CUF0028 A157 1.5 6.9 4.5 RAC650-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 5/8 58 50
CUF0044 B210 2 9.8 6.7 RAC550-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 3/4 65 51
CUF0049 B210 2 9.8 6.7 RAC1000-402 2 x 400 1 0.95 1650 1060 660 565 1 3/8 3/4 68 51
CUF0055 D211 2 11.3 7.1 RAC650-352 2 x 350 1 0.70 1250 860 640 565 1 3/8 7/8 72 51
CUF0058 D211 2 11.3 7.1 RAC1000-402 2 x 400 1 0.95 1650 1060 660 565 1 3/8 7/8 78 51
CUF0066 D213 2 13.8 7.1 RAC650-352 2 x 350 1 0.70 1250 860 640 460 1 3/8 7/8 72 52
CUF0074 D313 3 13.8 8.8 RAC1400-402 2 x 400 1 0.95 1650 1060 760 660 1 3/8 1-1/8 74 52
CUF0082 D315 3 15.3 10.0 RAC1000-402 2 x 400 1 0.95 1650 1060 760 660 1 1/2 1-1/8 75 52
CUF0086 D315 3 15.3 10.0 RAC1400-402 2 x 400 1 0.95 1650 1060 760 660 1 1/2 1-1/8 75 52
CUF0103 D418 4 17.9 12.5 RAC1700-402 2 x 400 1 0.95 1650 1060 660 675 1 1/2 1-1/8 84 54
CUF0107 Q420 4 19.8 10.1 RAC1200-402 2 x 400 1 0.95 1650 1060 660 675 1 1/2 1-1/8 122 53
CUF0112 Q521 4 21.2 11.6 RAC1700-402 2 x 400 1 0.95 1650 1060 660 675 1 1/2 1-1/8 133 53
CUF0120 Q525 5 24.7 12.7 RAC1400-402 2 x 400 1 0.95 1650 1060 760 660 1 1/2 1-1/8 122 53
CUF0124 Q525 5 24.7 12.7 RAC2200-402 2 x 400 1 0.95 1650 1275 1100 740 1 1/2 1-1/8 139 53
CUF0128 Q528 5.5 27.9 14.0 RAC1700-402 2 x 400 1 0.95 1650 1060 660 675 1 1/2 1-3/8 133 56
CUF0137 Q533 5.5 32.7 14.4 RAC1700-402 2 x 400 1 0.95 1650 1060 660 675 1 1/2 1-3/8 122 58
CUF0133 Q728 7.5 27.9 17.6 RAC2800-502 2 x 500 3 0.95 3500 1475 1100 800 2 1/2 1-3/8 139 60
CUF0145 Q733 7.5 32.7 20 RAC2800-502 2 x 500 3 0.95 3500 1475 1100 800 2 1/2 1-3/8 140 61
CUF0149 Q736 7.7 35.9 19.4 RAC2200-402 2 x 400 1 0.95 1650 1275 1100 740 2 1/2 1-3/8 139 57
CUF0150 S842 8 41.3 20.3 RAC2200-402 2 x 400 1 0.95 1650 1275 1100 740 2 5/8 1-3/8 165 58
CUF0151 S842 8 41.3 20.3 RAC2800-502 2 x 500 3 0.95 3500 1475 1100 800 2 5/8 1-3/8 185 61
CUF0157 S1242 12 41.3 22.4 RAC3900-552 2 x 550 3 0.95 4300 1475 1100 1070 2 5/8 1-3/8 215 64
CUF0162 S1052 10 51.5 24.5 RAC2800-502 2 x 500 3 0.95 3500 1475 1100 800 2 5/8 1-3/8 205 62
CUF0163 S1052 10 51.5 24.5 RAC3900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 5/8 1-3/8 215 65
CUF0169 S1552 15 51.5 32.4 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 5/8 1-5/8 224 65
CUF0173 S1556 15 56.0 30.7 RAC2800-502 2 x 500 3 0.95 3500 1475 1100 800 2 5/8 1-5/8 210 63
CUF0174 S1556 15 56.0 30.7 RAC3900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 5/8 1-5/8 224 64
CUF0181 S2056 20 56.0 38.4 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 235 64
CUF0186 V1559 15 58.5 31.1 RAC3900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 254 65
CUF0187 V1559 15 58.5 31.1 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 265 65
CUF0193 V2059 20 58.5 35.3 RAC5800-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 1-5/8 270 66
CUF0198 V1571 15 70.8 32.2 RAC3900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 255 67
CUF0199 V1571 15 70.8 32.2 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 265 67
CUF0208 V2571 30 70.8 43.5 RAC7300-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 272 67
CUF0211 V2084 20 83.8 42.6 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 1-5/8 265 67
CUF0214 V2084 20 83.8 42.6 RAC5800-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 1-5/8 281 68
CUF0212 V2593 25 93.1 52.3 RAC4900-552 2 x 550 3 1.15 4300 1475 1100 1070 2 7/8 2-1/8 275 68
CUF0218 V2593 25 93.1 52.3 RAC5800-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 298 69
CUF0217 V3084 30 83.8 49.2 RAC7300-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 320 68
CUF0219A V3293 32 93.1 53.1 RAC9600-554 4 x 550 3 1.15 8500 2200 1470 1570 4 7/8 2-1/8 340 69
CUF0220 Z2593 25 93.1 52.3 RAC5800-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 298 69
CUF0223 Z25106 25 106.2 53.6 RAC7300-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 330 70
CUF0225 Z35106 35 106.2 60.2 RAC9600-554 4 x 550 3 1.15 8500 2200 1470 1570 4 7/8 2-1/8 345 71
CUF0226 Z30126 30 106.2 55.7 RAC7300-553 3 x 550 3 1.15 6400 2200 1100 1070 3 7/8 2-1/8 340 73
TECHNICAL DATA
All noise level pressure ratings are 'free field' based at a distance of 3meters and are given as a guide only.
43 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
Drawing 1
Drawing 2
Drawing 3
CONDENSING UNITS
FRASCOLD SEMI-HERMETIC
Drawing 4
DIMENSIONAL DRAWINGS
44 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
FEATURES & INCLUSIONS
Compressor sets up to 20hp include standard:
All units have the above components as standard with the larger 20 to 70hp range having these additional components fitted.
A huge range of optional extras can be fitted at your request and include:
(with internal or external oil floats)
MODEL DESIGNATION
REMOTE CONDENSING UNITS
CONDENSING UNITS
REMOTE SEMI-HERMETIC
FRASCOLD range of Remote semi-Hermetic condensing units are manufactured in our factory right here in Australia. They include internationally accepted Frascold semi-hermetic compressors, which are ideally suited for todays conscientious environment.
The large range extends from 1hp through to 70 hp with capacities from 3kw through to 130kw operating on R404A @ -5deg SST.
All our units are built to Australian standards and include only high quality components. This ensures reliability, high performance and trouble free
operation all year round.
Please contact your nearest Realcold branch or one of our applications engineers for other configurations that you may require. With a streamlined local manufacturing facility and motivated manufacturing team, Realcold can offer flexible design and fast turn around times.
REC
EIVER
MO
DELV
CO
MP
RESSO
R
SERIES
20
MO
TOR
HP
59
DISP
LAC
EMEN
T
M³/H
R
15-30
REC
EIVER
MO
DEL
Z-Series Remote Unit
45 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
STOCK NO. MODELNOM HP
COND TEMP
CAPACITY IN WATTS (R404A)PRICE $
excl. GST-15 -10 -5 0 5
CUF0503-1PH A16-RBF550 140 2380 2930 3560 4290 5110
4,190.00 50 1940 2410 2940 3540 4220
CUF0503 A16-RBF550 140 2380 2930 3560 4290 5110
3,413.00 50 1940 2410 2940 3540 4220
CUF0506-1PH A157-RBF550 1.540 3030 3740 4560 5500 6580
4,337.00 50 2470 3080 3770 4560 5450
CUF0506 A157-RBF550 1.540 3030 3740 4560 5500 6580
3,549.00 50 2470 3080 3770 4560 5450
CUF0512-1PH B210-RBF550 240 4140 5130 6280 7600 9110
4,589.00 50 3390 4200 5150 6250 7510
CUF0512 B210-RBF550 240 4140 5130 6280 7600 9110
3,812.00 50 3390 4200 5150 6250 7510
CUF0515 D211-RBF550 240 4900 6090 7470 9050 10860
4,337.00 50 3920 4900 6030 7340 8850
CUF0521 D313-RBF650 340 5760 7150 8760 10600 12710
4,589.00 50 4710 5840 7150 8660 10390
CUF0524 D315-RBF650 340 6830 8370 10150 12190 14530
4,830.00 50 5550 6800 8240 9910 11830
CUF0530 D418-RBF650 340 8090 9880 11930 14270 16920
5,229.00 50 7390 9010 10880 13020 15420
CUF0533 Q521/075-4 540 9040 11260 13790 16630 19830
6,227.00 50 7160 9000 11080 13430 16070
CUF0539 Q525/075-4 540 10700 13260 16230 19640 23540
6,531.00 50 8640 10740 13160 15970 19190
CUF0542 Q728/075-4 7.540 12550 15480 18860 22730 27130
7,224.00 50 10210 12620 15410 18620 22280
CUF0547 Q733/075-4 7.540 14500 17870 21770 26250 31370
7,791.00 50 11800 14570 17780 21470 25700
CUF0554 S1242/5-15 1240 17570 21890 26870 32570 39040
9,272.00 50 14020 17630 21830 26670 32200
CUF0560 S1552/5-15 1540 23730 28990 35080 42130 50270
9,975.00 50 19640 24050 29130 35000 41800
CUF0566 S2056/5-15 2040 26160 32040 38680 46480 55440
10,773.00 50 21470 26470 32090 38680 46210
CUF0572 V2059/15-30 2040 26670 32060 39490 47990 57600
11,865.00 50 20490 25850 32070 39180 47180
CUF0578 V2571/15-30 2540 30900 38530 47410 57610 69170
12,443.00 50 24810 31160 38540 46990 56520
CUF0584 V3084/15-30 3040 37580 46560 56940 68860 82440
12,884.00 50 30380 37830 46490 56490 67970
CUF0586 V3293/30-50 3040 39880 50070 61870 75420 90860
13,377.00 50 31850 40270 50090 61450 74480
CUF0588 Z35106-ALH64 3540 47530 58990 72350 87770 105420
15,246.00 50 38310 47670 58650 71430 86180
CUF0593 Z40126-ALH64 4040 55320 68850 84560 102620 123220
16,401.00 50 44350 55400 68350 83360 100630
CUF0600 Z50154-ALH64 5040 67520 83950 102950 124650 149070
22,470.00 50 54600 68330 84190 102280 122550
CUF0602 W60187-ALH130 6040 83770 104190 128040 155700 187530
26,880.00 50 67540 84220 103740 126460 152760
CUF0605 W70206-ALH130 7040 91990 113970 139390 168600 201960
27,930.00 50 74800 93150 114390 138900 167010
CONDENSING UNITS
REMOTE SEMI-HERMETIC
Ratings based on European standard EN12900; 20deg Suction gas temp / 0k SubcoolingD313 to D418 also available mounted on horizontal receiver 075-4Please refer to pages 50-54 for fitted optional accessories.
R404A - MED TEMPERATURE
46 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REMOTE SEMI-HERMETIC
Ratings based on European standard EN12900; 20deg Suction gas temp / 0k SubcoolingD315 also available mounted on horizontal receiver 075-4Please refer to pages 50-54 for fitted optional accessories.
R404A - LOW TEMPERATURE
Head Cooling fan required at these conditions.
STOCK NO MODELCOMP
HPCOND TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -20 -15
CUF0503-1PH A16-RBF550 140 810 1120 1480 1900 2380
4,190.00 50 590 860 1170 1530 1940
CUF0503 A16-RBF550 140 810 1120 1480 1900 2380
3,413.00 50 590 860 1170 1530 1940
CUF0506-1PH A157-RBF550 1.540 1030 1420 1880 2410 3030
4,337.00 50 750 1090 1480 1940 2470
CUF0506 A157-RBF550 1.540 1030 1420 1880 2410 3030
3,549.00 50 750 1090 1480 1940 2470
CUF0512-1PH B210-RBF550 240 1480 1970 2580 3290 4140
4,589.00 50 1210 1620 2110 2700 3390
CUF0512 B210-RBF550 240 1480 1970 2580 3290 4140
3,812.00 50 1210 1620 2110 2700 3390
CUF0515 D211-RBF550 240 1690 2300 3030 3890 4900
4,337.00 50 1260 1780 2390 3090 3920
CUF0518 D213-RBF550 240 2140 2830 3670 4660 5830
4,442.00 50 1750 2320 3010 3820 4800
CUF0524 D315-RBF650 340 3450 4400 5520 6830
4,830.00 50 2800 3580 4490 5550
CUF0532 Q420/075-4 440 3020 4040 5280 6740 8460
6,164.00 50 2340 3200 4230 5470 6940
CUF0539 Q525/075-4 540 3710 5050 6640 9510 10700
6,531.00 50 2900 3950 5290 6840 8640
CUF0541 Q528/075-4 540 4440 5960 7760 9870 12330
6,720.00 50 3440 4700 6190 7930 9960
CUF0543 Q533/075-4 5.540 5510 7230 9250 11630 14400
7,319.00 50 4450 5870 7540 9500 11800
CUF0544 Q736/075-4 7.540 6640 8660 11040 13810 17030
8,022.00 50 5520 6910 8890 11200 13900
CUF0551 S842/5-15 840 6860 9280 12080 15330 19080
9,104.00 50 5230 7240 9550 12220 15300
CUF0557 S1052/5-15 1040 9150 11920 15080 18770 23100
9,660.00 50 7140 9590 12330 15470 19150
CUF0563 S1556/5-15 1540 9750 12940 16650 20980 25990
10,364.00 50 7530 10290 13480 17210 21480
CUF0569 V1559/15-30 1540 10350 13610 17370 21860 27050
11,498.00 50 7980 10770 13990 17820 22240
CUF0575 V1571/15-30 1540 12030 15930 20480 25810 31900
11,865.00 50 9310 12680 16590 21150 26300
CUF0581 V2084/15-30 2040 13500 17990 23310 29560 36830
12,443.00 50 10750 14290 18490 23450 29270
CUF0583 V2593/15-30 2540 13680 18780 24810 31860 40070
12,989.00 50 10080 14320 19310 25150 31960
CUF0587 Z25106-ALH64 2540 16530 22510 29670 38150 48060
14,900.00 50 12870 17730 23570 30520 38710
CUF0590 Z30126-ALH64 3040 19490 26320 34480 44100 55350
17,273.00 50 15100 20660 27280 35120 44320
CUF0597 Z40154-ALH64 4040 26720 35280 45340 56970 70340
18,690.00 50 20810 28200 36840 46770 58120
CUF0602 W60187-ALH130 6040 39400 51750 66410 83770
26,880.00 50 30800 41200 53320 67540
CUF0605 W70206-ALH130 7040 43190 56960 73110 91990
28,035.00 50 33660 45420 59010 74800
47 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
STOCK NO MODELCOMP
HPCOND TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 5 10
CUF0503-1PH A16-RBF550 140 1320 1690 2120 2620 3210 3880
4190.0050 1110 1440 1830 2280 2800 3400
CUF0503 A16-RBF550 140 1320 1690 2120 2620 3210 3880
3413.0050 1110 1440 1830 2280 2800 3400
CUF0506-1PH A157-RBF550 1.540 1710 2190 2760 3420 4190 5070
4337.0050 1440 1880 2380 2970 3650 4440
CUF0506 A157-RBF550 1.540 1710 2190 2760 3420 4190 5070
3549.0050 1440 1880 2380 2970 3650 4440
CUF0512-1PH B210-RBF550 240 2390 3090 3910 4870 5960 7220
4589.0050 2000 2620 3340 4180 5150 6260
CUF0512 B210-RBF550 240 2390 3090 3910 4870 5960 7220
3812.0050 2000 2620 3340 4180 5150 6260
CUF0515 D211-RBF550 240 2670 3480 4440 5570 6870 8340
4337.0050 2200 2910 3760 4740 5870 7150
CUF0518 D213-RBF550 240 3260 4180 5270 6560 8060 9790
4442.0050 2740 3550 4500 5620 6940 8450
CUF0524 D315-RBF650 340 3680 4760 6030 7500 9210 11180
4830.0050 3030 4010 5140 6460 7980 9740
CUF0532 Q420/075-4 440 4680 6170 7980 10130 12650 15590
6164.0050 3810 5100 6680 8560 10780 13360
CUF0539 Q525/075-4 540 6520 8240 10280 12680 15470 18710
6531.0050 5570 7130 8940 11050 13520 16390
CUF0541 Q528/075-4 540 6620 8520 10810 13510 16670 20310
6720.0050 5590 7260 9270 11640 14410 18510
CUF0543 Q533/075-4 5.540 7850 10040 12600 15580 19050 24190
7319.0050 6770 8690 10910 13500 16510 20970
CUF0544 Q736/075-4 7.540 9470 12090 15130 18590 22480 26890
8022.0050 8150 10500 13230 16360 19890 23910
CUF0551 Q842/5-15 840 11040 14200 17950 22370 27540 33620
9104.0050 9090 11930 15330 19350 24060 29650
CUF0557 S1052/5-15 1040 13260 16800 20960 25840 31530 38110
9660.0050 11310 14490 18190 22510 27540 33360
CUF0563 S1556/5-15 1540 14730 18660 23250 28590 34810 42200
10364.0050 12530 16060 20170 24940 30490 37010
CUF0569 V1559/15-30 1540 15560 19750 24660 30350 36980 44850
11498.0050 13190 16960 21350 26440 32350 39310
CUF0575 V1571/15-30 1540 18510 23420 29140 35840 43640 52900
11865.0050 15740 20140 25280 31260 38230 46370
CUF0581 V2084/15-30 2040 19510 25350 32270 40390 49810 60840
12443.0050 16470 21520 27530 34600 42850 52570
CUF0583 V2593/15-30 2540 23750 30110 37570 46260 56370 68330
12989.0050 20250 25980 32700 40460 49470 60030
CUF0587 Z25106-ALH64 2540 24580 31830 40480 50660 62530 76480
14900.0050 20700 26790 34090 42740 52880 64880
CUF0590 Z30126-ALH64 3040 30140 39000 49480 61740 75370 92620
17273.0050 25150 32880 42040 52800 65340 80100
CUF0597 Z40154-ALH64 4040 36690 47240 59810 74620 91890 112200
18690.0050 30690 39800 50700 63600 78720 96620
CUF0602 W60187-ALH130 6040 46000 58860 73990 91600 111920 135160
26880.0050 38360 49790 63220 78870 96980 117750
CUF0605 W70206-ALH130 7040 49600 64530 82290 103150 127370 155210
28035.0050 41990 54930 70360 88540 109740 134200
CONDENSING UNITS
REMOTE SEMI-HERMETIC
Ratings based on European standard EN12900; 20deg Suction gas temp / 0k SubcoolingD315 also available mounted on horizontal receiver 075-4Please refer to pages 50-54 for fitted optional accessories.
R134A - MED TEMPERATURE
48 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REMOTE SEMI-HERMETIC
STOCK NO. UNIT MODEL
COMPRESSOR DIMENSIONS CONNECTIONSWEIGHT
KG
dB(A)
@ 3mtrMODEL HP DISP
M3hr MRA LRA DOL
LRA P/W
LENGTH(A) mm
DEEP(B) mm
HIGH(C) mm
IN OUT
240 VOLT COMPRESSOR
CUF0503-1PH A016-RBF550 A016 1 5.5 6.2 13.6 DOL 550 430 400 3/8 1/2 56 46
CUF0506-1PH A157-RBF550 A157 1.5 6.9 7.9 20.6 DOL 550 430 400 3/8 1/2 56 47
CUF0512-1PH B210-RBF550 B210 2 9.8 11.7 35.9 DOL 550 430 420 3/8 1/2 58 49
415 VOLT COMPRESSOR
CUF0503 A016-RBF550 A016 1 5.5 3.5 13.6 DOL 550 430 400 3/8 1/2 56 46
CUF0506 A157-RBF550 A157 1.5 6.9 4.5 20.6 DOL 550 430 400 3/8 1/2 56 47
CUF0512 B210-RBF550 B210 2 9.8 6.7 35.9 DOL 550 430 420 3/8 1/2 58 49
CUF0515 D211-RBF550 D211 2 11.3 7.1 24.9 DOL 550 430 420 3/8 1/2 65 50
CUF0518 D213-RBF550 D213 2 13.8 7.1 24.9 DOL 550 430 420 3/8 1/2 65 50
CUF0521 D313-RBF650 D313 3 13.8 8.8 43.7 DOL 650 460 445 3/8 1/2 69 51
CUF0524 D315-RBF650 D315 3 15.3 10 43.7 DOL 650 460 445 3/8 1/2 69 51
CUF0530 D418-RBF650 D418 4 17.9 12.5 52.0 DOL 650 460 445 3/8 1/2 71 53
CUF0532 Q420/075-4 Q420 4 19.8 10.1 53.0 DOL 1000 770 600 7/8 7/8 132 52
CUF0533 Q521/075-4 Q521 5 21.2 11.6 63.1 DOL 1000 770 600 7/8 7/8 137 53
CUF0539 Q525/075-4 Q525 5 24.7 12.7 63.1 DOL 1000 770 600 7/8 7/8 137 53
CUF0541 Q528/075-4 Q528 5.5 27.9 14.0 63.1 DOL 1000 770 600 7/8 7/8 137 55
CUF0543 Q533/075-4 Q533 5.5 32.7 14.4 63.1 DOL 1000 770 600 7/8 7/8 137 57
CUF0542 Q728/075-4 Q728 7.5 27.9 17.6 87.3 DOL 1000 770 600 7/8 7/8 137 55
CUF0547 Q733/075-4 Q733 7.5 32.7 20.0 87.3 DOL 1000 770 600 7/8 7/8 137 56
CUF0544 Q736/075-4 Q736 7.7 35.9 19.4 87.3 DOL 1000 770 600 7/8 7/8 137 57
CUF0551 S842/5-15 S842 8 41.3 20.3 90.3 52.7 1000 820 715 1-1/8 7/8 182 60
CUF0557 S1052/5-15 S1052 10 51.5 24.2 87.6 53.9 1000 820 715 1-1/8 7/8 185 62
CUF0554 S1242/5-15 S1242 12 41.3 22.4 102 59.1 1000 820 715 1-1/8 7/8 185 59
CUF0560 S1552/5-15 S1552 15 51.5 31.5 117.1 74.8 1000 820 715 1-1/8 7/8 192 59
CUF0563 S1556/5-15 S1556 15 56.0 30.7 117.1 74.8 1000 820 715 1-1/8 7/8 195 63
CUF0566 S2056/5-15 S2056 20 56.0 38.4 136.2 87.5 1000 820 715 1-1/8 7/8 197 61
CUF0569 V1559/15-30 V1559 15 58.5 31.1 117.1 74.8 1300 870 795 1-1/8 7/8 245 62
CUF0575 V1571/15-30 V1571 15 70.8 31.0 117.1 74.8 1300 870 795 1-1/8 7/8 245 62
CUF0572 V2059/15-30 V2059 20 58.5 35.3 136.2 87.5 1300 870 795 1-1/8 7/8 250 61
CUF0578 V2571/15-30 V2571 25 70.8 43.5 202.7 104.1 1300 870 795 1-1/8 7/8 258 61
CUF0581 V2084/15-30 V2084 20 83.8 42.6 145.2 89.9 1300 870 795 1-1/8 7/8 258 66
CUF0583 V2593/15-30 V2593 25 93.1 52.3 202.7 104.1 1300 870 795 1-1/8 7/8 265 66
CUF0584 V3084/15-30 V3084 30 83.8 49.2 186.2 118.3 1300 870 795 1-1/8 7/8 260 64
CUF0586 V3293/15-30 V3293 30 93.1 53.1 239.2 144.5 1300 870 795 1-1/8 7/8 265 64
CUF0587 Z25106-ALH64 Z25106 25 106.2 53.6 202.7 118.3 1390 940 880 1-3/8 1-3/8 298 69
CUF0590 Z30126-ALH64 Z30126 30 125.7 55.7 186.2 118.3 1390 940 880 1-3/8 1-3/8 306 70
CUF0588 Z35106-ALH64 Z35106 35 106.2 60.2 239.2 144.5 1390 940 880 1-3/8 1-3/8 300 65
CUF0593 Z40126-ALH64 Z40126 40 125.7 71.9 273.0 159.2 1390 940 880 1-3/8 1-3/8 317 66
CUF0597 Z40154-ALH64 Z40154 40 154.4 77.9 273.0 159.2 1390 940 880 1-3/8 1-3/8 324 71
CUF0600 Z50154-ALH64 Z50154 50 154.4 90.4 321.4 188.6 1390 940 880 1-3/8 1-3/8 330 67
CUF0602 W60187-ALH130 W60187 60 186.1 103.5 455 326 1600 800 1070 1 3/8 1 3/8 468 71
CUF0605 W70206-ALH130 W70206 70 205.8 116.8 548 390 1600 800 1070 1 3/8 1 3/8 482 72
TECHNICAL DATA
All noise level ratings are 'free field' based at a distance of 3meters and are given as a guide only.Refer to next page for dimensional drawings.
49 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
A,B & D SERIES
2 CYLINDER MODELS
Q,S,V & Z SERIES
4 & 6 CYLINDER MODELS
W-SERIES
8 CYLINDER MODELS
CONDENSING UNITS
REMOTE SEMI-HERMETIC
DIMENSIONAL DRAWINGS
50 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
LIQUID LINE ASSEMBLIES
STOCK NO SIZE CONNECTION PRICE $EXCL. GST
ULF003 3/8” Liquid Line c/w Sight Glass & 163 Drier 321.00
ULF006 1/2” Liquid Line c/w Sight Glass & 164 Drier 331.00
ULF008 1/2” Liquid Line c/w Sight Glass & 304 Drier 363.00
ULF011 5/8” Liquid Line c/w Sight Glass & 305 Drier 373.00
ULF014 5/8” Liquid Line c/w Sight Glass & 415 Drier 415.00
ULF016 7/8” Liquid Line c/w Sight Glass & 1 Drier Core 756.00
ULF019 7/8” Liquid Line c/w Sight Glass & 2 Drier Cores 819.00
ULF021 1-1/8” Liquid Line c/w Sight Glass & 1 Drier Core 777.00
ULF023 1-1/8” Liquid Line c/w Sight Glass & 2 Drier Cores 861.00
ULF025 1-3/8” Liquid Line c/w Sight Glass & 2 Drier Cores 882.00
CONDENSING UNITS
UNIT ACCESSORIES FITTED
OIL SEPARATOR - HELICAL INTERNAL FLOAT
STOCK NO MODEL PRICE $excl. GST
F0142F 1-1/8” HELICAL Oil Separator c/w Oil Charge 830.00
F0144F 1-3/8” HELICAL Oil Separator c/w Oil Charge 882.00
F0146F 1-5/8” HELICAL Oil Separator c/w Oil Charge 1,103.00
OIL SEPARATORS - STANDARD INTERNAL FLOAT
STOCK NO DESCRIPTION PRICE $excl. GST
F0070F 1/2” Oil Separator c/w Oil Charge 515.00
F0072F 5/8” Oil Separator c/w Oil Charge 546.00
F0074F 7/8” Oil Separator c/w Oil Charge 620.00
F0076F 1-1/8” Oil Separator c/w Oil Charge 662.00
F0078F 1-3/8” Oil Separator c/w Oil Charge 704.00
SOLENOID VALVE
STOCK NO DESCRIPTION PRICE $EXCL. GST
USF001 3/8” Solenoid valve c/w Coil 279.00
USF003 1/2” Solenoid valve c/w Coil 300.00
USF006 5/8” Solenoid valve c/w Coil 342.00
USF008 7/8” Solenoid valve c/w Coil 431.00
USF011 1-1/8” Solenoid valve c/w Coil 557.00
OIL SEPARATOR - HELICAL EXTERNAL FLOAT C/W TRAXOIL
STOCK NO MODEL PRICE $excl. GST
F0150F 1-1/8” HELICAL Oil Sep c/w TRAXOIL, Oil Charge & Level Sight Glases 1,875.00
F0152F 1-3/8” HELICAL Oil Sep c/w TRAXOIL, Oil Charge & Level Sight Glases 2,284.00
F0154F 1-5/8” HELICAL Oil Sep c/w TRAXOIL, Oil Charge & Level Sight Glases 2,468.00
51 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
SUCTION LINE ACCUMULATORS
STOCK NO DESCRIPTIONPRICE $
EXCL. GST
F0105F 5/8” Suction Accumulator 368.00
F0106F 3/4” Suction Accumulator 378.00
F0107F 7/8” Suction Accumulator 478.00
F0108F 1-1/8” Suction Accumulator 562.00
F0109F 1-3/8” Suction Accumulator 657.00
F0110F 1-5/8” Suction Accumulator 756.00
F0111F 2-1/8” Suction Accumulator 13,23.00
F0115F 2-5/8” Suction Accumulator 2,678.00
CONDENSING UNITS
UNIT ACCESSORIES FITTED
SUCTION LINE FILTER
STOCK NO SIZE CONNECTION PRICE $EXCL. GST
ULF030 1-3/8” 1 Core Suction Line Filter 756.00
ULF031 1-5/8” 1 Core Suction Line Filter 788.00
ULF032 2-1/8” 1 Core Suction Line Filter 819.00
ULF033 2-5/8” 2 Core Suction Line Filter 1,596.00
SUCTION LINE ACCUMULATORS C/W LIQUID LINE HEAT EXCHANGERS
STOCK NO DESCRIPTION PRICE $EXCL. GST
F0168F 1-1/8” Suction Accumulator / Heat Exchanger 1,280.00
F0170F 1-3/8” Suction Accumulator / Heat Exchanger 1,280.00
F0171F 1-5/8” Suction Accumulator / Heat Exchanger 1,380.00
F0172F 2-1/8” Suction Accumulator / Heat Exchanger 1,760.00
F0173F 2-5/8” Suction Accumulator / Heat Exchanger 2,660.00
CRANK CASE PRESSURE REGULATORS
STOCK NO DESCRIPTION PRICE $EXCL. GST
UCF002 7/8” Crank Pressure Reg Valve 609.00
UCF003 1-1/8” Crank Pressure Reg Valve 630.00
UCF004 1-3/8” Crank Pressure Reg Valve 662.00
Accumulators with 'Liquid HE's' offer heat transfer between return suction gas and the liquid line.This helps boil off any liquid build up in the accumulator and provides additional liquid subcooling.
OIL LEVEL SAFETY SWITCH FOR INTERNAL FLOAT SYSTEMS
STOCK NO MODEL PRICE $excl. GST
F0992F TRAXOIL OW3 Oil Watch Fitted 394.00
Oil Watch offers protection against low compressor oil level by monitoring the oil sump and sending a signal if the oil level falls too low. Signal can provide alarm functionality or shut down the compressor.
52 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSER FAN SPEED CONTROLS
PART NO. SUITS DESCRIPTION PRICE $EXCL. GST
UFF001 1ph Fan Models Johnson 1ph Fan Speed Control 604.00
UFF004 3ph Fan Models Saginomiya 3ph Fan Speed Control 1,375.00
ADDITIONAL PRESSURE CONTROLS
STOCK NO DESCRIPTION PRICE $EXCL. GST
UPF016 Single HP Auto Reset - Single Cond Fan Cycling 305.00
UPF006 Dual HP Auto Reset - Twin Cond Fan Cycling 399.00
UPF008 LP Manual Reset 326.00
UPF011 LP Auto Reset 305.00
UPF014 HP Manual Reset 326.00
CONDENSING UNITS
UNIT ACCESSORIES FITTED
HEAD COOLING FANS - 1PH
STOCK NO.FRASCOLD ITEM NO
ITEM SUITS SERIES PRICE $excl. GST
R0744F S2-FM1 Head Cooling Fan A-F A, B, D & F 668.00
R0745F S2-FM9 Head Cooling Fan Q Q Series 693.00
R0746F S2-FM2 Head Cooling Fan S-V S & V 845.00
R0747F S2-FM3 Head Cooling Fan Z Z Series 845.00
PLEASE CONTACT REALCOLD TO DISCUSS OTHER ACCESSORY REQUIREMENTS YOU MAY HAVE
START UNLOADER HEAD - REDUCED START CURRENT
STOCK NO DESCRIPTION PRICE $EXCL. GST
UUF000 Start Unloader Head Fitted - Q Series 504.00
UUF000A Start Unloader Head Fitted - S Series 578.00
UUF000B Start Unloader Head Fitted - V, W, Z Series 651.00
Start unloader heads are specifically designed to reduce start current and offer a further reduction in compressor start current draw when used in conjunction with PWS starting.
CAPACITY CONTROL & START UNLOADER HEAD
STOCK NO DESCRIPTION PRICE $EXCL. GST
UUF000C Capacity Control Head Fitted - Q Series 504.00
UUF000D Capacity Control Head Fitted - S Series 578.00
UUF001 Capacity Control Head Fitted - V, W, Z Series 651.00
53 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
FITTED ELECTRICAL BOARDS & VSD's
PEGO ELECTRICAL BOARDS FITTED
Made made with self-extinguishing ABS plastic
IP65 protection for dusty or moist environments
Pre-fitted in our factory to save you time on site
High quality components and switchgear
Schneider/Telemecanique contactors & overloads
Custom boards available upon request
PART NO. MODEL MAXHP AMPS COND
FANS DESCRIPTION DIMENSIONSW X H X D
PRICE $EXCL. GST
G4942F ECP04E 4.5-6.3 2 4.5-6.3 1PH Electrical box c/w Isolating switch, 1 x 3ph circuit- breaker, Compressor contactor & overload, 1ph Cond fan/Control circuit breaker, LED status lights
210 x 260 x 145 1245.00
G4944F ECP04E 7-10 3 7-10 1PH 210 x 260 x 145 1245.00
G4946F ECP04-E 9-12.5 5 9-12.5 1PH 210 x 260 x 145 1245.00
G4948F ECP07E 14-20 8 14-20 1PH 210 x 260 x 145 1,590.00
G4948AF ECP10S 18-25 10 18-25 3PH *Condenser fan contactors & overloads also included on ECP10S Boards
*Separate condenser fan circuit breaker also included on ECP15S Boards
290 x 340 x 145 1,935.00
G4948BF ECP10S 27-32 15 27-32 3PH 290 x 340 x 145 2,080.00
G4949F ECP15S 18-25 10 18-25 3PH 350 x 450 x 160 2,255.00
G4951F ECP15S 28-40 20 28-40 3PH 350 x 450 x 160 2,435.00
* Above electrical boxes made with self-extinguishing ABS plastic with IP65 protection rating.
PEGO ECP ELECTRICAL BOARDS
VARIABLE SPEED DRIVES FITTED
LENZE SMV SERIES (IP65 With Input Filters)
Integrated soft-start offers reduced compressor start up current
Easy to program interface allows for quick set up of target pressure
Once set Compressor will ramp up and down to maintain set point
Less compressor starts reduces mechanical stresses and wear
Stable suction pressure - better control and less risk of liquid slug
Ideal for applications with multiple loads such as pubs & clubs
Improved energy efficiency resulting in reduced energy costs
All below models include internal EMC filters
PART NO. MODELRATED DIMENSIONS
W X H X DPRICE $
EXCL. GSTKW HP AMPS
R0787F ESV222N04TFC 2.2 3 5.5 203 x 160 x 160 2,595.00
R0799F ESV302N04TFC 3.0 4 7.6 203 x 160 x 160 2,735.00
R0800F ESV402N04TFC 4.0 5.5 9.4 254 x 228 x 203 2,995.00
R0802F ESV552N04TFC 5.5 7.5 12.6 254 x 228 x 203 3,525.00
R0804F ESV752N04TFD 7.5 10 16.1 254 x 204 x 203 3,825.00
R0806F ESV113N04TFD 11 15 24 368 x 240 x 241 5,480.00
R0808F ESV153N04TFD 15 20 31 368 x 240 x 241 6,540.00
R0810F ESV183N04TFD 18.5 25 39 368 x 240 x 241 7,055.00
R0812F ESV223N04TFD 22 30 46 470 x 240 x 241 7,650.00
* Above VSD enclosures made with ABS plastic. IP65 enclosure classification.
Realcold recommends selecting VSD one size above application compressor HP.
54 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
ELECTRICAL BOARDS FITTED
DOL COMPRESSOR / 1PH COND FANS
PART NO. SUITS AMPS DESCRIPTION PRICE $EXCL. GST
CUE100F 1 - 4HP 10 Electrical Board Fitted & Wiredc/w Isolating switch, 3ph compressor circuit breaker,DOL Compressor contactor & overload, 1ph Condenser fans wired
1,665.00
CUE102F 5 - 12HP 25 1,938.00
ELECTRICAL BOARDS FOR FRASCOLD UNITS
PWS COMPRESSOR / 3PH COND FANS
PART NO. SUITS AMPS DESCRIPTION PRICE $EXCL. GST
CUE110F 15 - 20HP 32 Electrical Board Fitted & Wiredc/w Isolating switch, 3ph compressor circuit breaker,PWS Compressor contactors & overloads, 2 x 3ph Condenser fan contactors and overloads
3,339.00
CUE112F 20 - 25HP 50 3,455.00
CUE114F 25 - 35HP 63 3,665.00
ELECTRICAL BOARDS FOR REMOTE UNITS
PART NO. SUITS AMPS START FANS DESCRIPTION PRICE $EXCL. GST
CUE120F 1 - 4HP 10 DOL 1PHElectrical Board Fitted & Wiredc/w Isolating switch, 3ph compressor circuit breaker, Compressor contactors & overloads, 2 x 3ph cond fan contactors & overloads fitted
(*Fan contactors fitted - Must be wired to fans on site
1,848.00
CUE122F 5 - 12HP 25 DOL 1PH 2,289.00
CUE124F 5 - 12HP 25 DOL 3PH 2,604.00
CUE126F 15 - 20HP 32 DOL 3PH 3,665.00
CUE128F 15 - 20HP 32 PWS 3PH 3,770.00
CUE130F 20 - 25HP 50 PWS 3PH 3,870.00
CUE132F 25 - 35HP 63 PWS 3PH 4,043.00
Wired in Australia to Australian standards & regulations.
Industrial quality steel enclosure - IP65 protection
Pre-fitted in our factory to save you time on site
High quality components and switchgear
Locally supplied switchgear readily available
Schneider/Telemecanique contactors & overloads
Custom boards available upon request
DOL COMPRESSOR / 3PH COND FANS
PART NO. SUITS AMPS DESCRIPTION PRICE $EXCL. GST
CUE104F 1 - 4HP 10 Electrical Board Fitted & Wiredc/w Isolating switch, 3ph compressor circuit breaker,DOL Compressor contactor & overload, 2 x 3ph Condenser fan contactors and overloads
2,095.00
CUE106F 5 - 12HP 25 2,468.00
CUE108F 15 - 20HP 32 2,825.00
OPTIONAL EXTRAS FITTED
PART NO. DESCRIPTION PRICE $EXCL. GST
CUE150F Additional condenser fan contactor 231.00
CUE152F Traxoil wired with transformer 331.00
CUE154F Anti short cycle timer 289.00
CUE156F MP15 Phase protection 289.00
CUE158F Switchboard cooling fan 310.00
55 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
FEATURES & INCLUSIONS
Compressor sets include standard:
Stepped available on request
CONDENSING UNITS
FRASCOLD SCREW PACK
MODEL DESIGNATION
CX
CO
MP
RESSO
R
SERIES
80
MO
TOR
HP
298
DISP
LAC
EMEN
T
M³/H
R
ALH
REC
EIVER
TYPE
130
REC
EIVER
CA
PA
CITY
KG
AT 8
0%
FULL
A huge range of optional extras can be fitted at your request
and include:
FRASCOLD CX range of Screw-Pack units are manufactured in our factory right here in Australia. They include internationally accepted Frascold CXHO Series screw compressors, which are ideally suited for energy efficient Air-conditioning and chiller applications.
The large range extends from 50hp through to 120 hp with capacities on R134A @ +7deg SST ranging from 135kw through to 240kw on standard models with larger models up to 210hp available upon request.
All our CX Series units are built to Australian standards and include only high quality components. This ensures reliability, high performance and trouble free operation all year round.
CX-Series Screw-Pack
(Fitted with VSD Inverter)
CX-Series Screw-Pack
Please contact your nearest Realcold branch or one of our applications engineers for other configurations that you may require. With a streamlined local manufacturing facility and motivated manufacturing team, Realcold can offer flexible design and fast turn around times.
56 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
AIR-CONDITIONING - R134A
STOCK NO. MODELNOM HP
AMPSMRA
DISPm3/HR
ECONOMISER WATTS @ +5 SST (R134A) PRICE $ excl. GSTKW KIT W/OUT ECO ECONOMISER
CUF0625 CX50L-199-ALH130 50 80 199 23 1 110600 132500 P.O.A
CUF0630 CX60L-230-ALH130 60 98 230 27 2 132700 155000 P.O.A
CUF0635 CX70L-264-ALH130 70 125 264 30 2 150200 171300 P.O.A
CUF0640 CX80L-298-ALH130 80 145 298 34 3 172400 197600 P.O.A
CUF0642 CX90L-340-ALH130 90 160 340 38 3 192300 187230 P.O.A
CUF0644 CX100L-370-ALH130 100 175 370 42 4 209300 235100 P.O.A
CUF0646 CX110L-398-ALH130 110 180 398 48 4 241700 275800 P.O.A
FRASCOLD CX SCREW-PACK UNITS
CONDENSING UNITS
FRASCOLD SCREW PACK
AIR-CONDITIONING - R407C
STOCK NO. MODELNOM HP
AMPSMRA
DISPm3/HR
WATTS @ +5 SST (R407C) PRICE $ excl. GSTW/OUT ECO
CUF0650 CX70H-199-ALH130 70 128 199 156400 P.O.A
CUF0652 CX80H-230-ALH130 80 145 230 180500 P.O.A
CUF0654 CX90H-264-ALH130 90 160 264 209300 P.O.A
CUF0656 CX100H-298-ALH130 100 175 298 237300 P.O.A
CUF0658 CX110H-316-ALH130 110 184 316 267700 P.O.A
Stepped available on request
FEATURES
ECONOMISER KITS
STOCK NO KIT NO. DESCRIPTIONPRICE $
EXCL. GST
CUF0670 1 Fitted Economiser Kit R134A - 50hp 3,500.00
CUF0671 2 Fitted Economiser Kit R134A - 60, 70hp 3,810.00
CUF0672 3 Fitted Economiser Kit R134A - 80, 90hp 3,825.00
CUF0673 4 Fitted Economiser Kit R134A - 100, 110hp 4,235.00
Economiser Kits Include - Heat Exchanger, TX Valve, Solenoid Valve
Inter-Stage Economiser/SubcoolerIncreases Capacity & Efficiency
Ratings based on European standard EN12900 and at 50deg Condensing temperature / 10deg Suction gas superheating.
Due to the high intermediate suction pressure on R407C at above conditions, standard economiser kits are not available.
CXH Compressors are also suitable for operation with R404A/R507C & R134A for medium temperature applications.
Please refer to Frascold selection software or contact Realcold for ratings at other conditions.
57 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
FEATURES & INCLUSIONS
Semi-Hermetic Reciprocating Rack Systems
(Suction filters not fitted on Low-line series)
Screw Compressor Rack Systems
A huge range of optional extras can be fitted at your request
FRASCOLD MULTI-COMP RACK SYSTEMS
CONDENSING UNITS
RACK SYSTEMS
FRASCOLD Multi-Compressor Rack Systems are manufactured in our factory right here in Australia. They include internationally accepted Frascold semi-hermetic compressors, which are ideally suited for todays conscientious environment.
All our rack systems are built to Australian standards, include only high quality components and are designed by our team of accomplished applications engineers. This ensures reliability, high performance and energy efficiency while also offering years of trouble free operation.
Mini Rack System
(Fitted with Air-Cooled Condenser)
Reciprocating Rack System
(Low-Line Series)
Please contact one of our helpful applications engineers for more details or to discuss your project requirements. With the utilisation of world class manufacturing technology and a highly experienced engineering team, Realcold can offer you the right solution with flexible design and fast turn around times.
Screw Compressor Rack System
(Fitted with Electrical Panel)
58 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
FEATURES & INCLUSIONS
Includes control panel with digital display
V.TEQ Mini Rack
MODEL DESIGNATION
V.TEQ
VA
RIA
BLE SP
EED
TWIN
CO
MP
RESSO
R
ENER
GY EFFIC
IENT
Q-SER
IES MIN
I-RA
CK
736
CO
MO
PR
ESOR
MO
DEL (X
2)
752
VA
RIA
BLE SP
EED D
RIV
E
MO
DEL
AR..
REC
EIVER
& B
ASE
MO
DEL
V.TEQ SERIES - MINI RACK SYSTEMS
Stable Suction Presure with VSD
V.TEQ Series mini-racks are manufactured in our factory right here in Australia. They include two Frascold Q-series compressors and come fully wired with lead compressor controlled via Lenze variable speed drive (VSD) and second compressor staged on demand.
This combination of the already efficient Q-Series compressors coupled with VSD on the lead compressor, provides tight control of a wide capacity range to handle both peak & low loads with very high energy efficiency.
V.TEQ Series units are ideally suited for applications with multiple and fluctuating loads such as pubs, clubs and small supermarkets or any other application where wide capacity range with close capacity control and a reduction in energy costs is needed.
CONDENSING UNITS
V.TEQ MINI RACK SYSTEMS
Please contact one of our helpful applications engineers for more details or to discuss your project requirements. With the utilisation of world class manufacturing technology and a highly experienced engineering team, Realcold can offer you the right solution with flexible design and fast turn around times.
D W
H
Width = 1100 mm
Depth = 500 mm
Height = 700 mm
59 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R134A - MED TEMPERATURE
STOCK NO. MODELNOM
HPCONDTEMP
CAPACITY RANGE IN KW (MIN - MAX) PRICE $
excl. GST-15 -10 -5 0 +5
VTQ100V.TEQ
420-402-AR1272 x 4
40 2.6 - 12.2 3.4 - 15.8 4.3 - 20.1 5.4 - 25.2 6.6 - 31.1P.O.A
50 2.2 - 10.3 2.9 - 13.5 3.7 - 17.5 4.7 - 22.1 5.8 - 27.4
VTQ102V.TEQ
528-552-AR1272 x 5
40 3.4 - 16.0 4.4 - 20.1 5.6 - 26.4 7.1 - 33.2 8.8 - 41.2P.O.A
50 2.9 - 13.4 3.8 - 17.6 4.8 - 22.7 6.1 - 28.8 7.6 - 35.9
VTQ104V.TEQ
736-752-AR1272 x 7.5
40 4.9 - 22.9 6.3 - 29.4 7.9 - 37.0 9.7 - 45.7 11.8 - 55.6P.O.A
50 4.2 - 19.6 5.4 - 25.5 6.9 - 32.4 8.6 - 40.5 10.5 - 49.6
R404A - MED TEMPERATURE
STOCK NO. MODELNOM
HPCOND TEMP
CAPACITY RANGE IN KW (MIN - MAX) PRICE $
excl. GST-15 -10 -5 0
VTQ106V.TEQ
521-552-AR1272 x 5
40 4.6 - 19.8 5.8 - 25.1 7.2 - 31.1 8.8 - 38.0P.O.A
50 3.6 - 15.6 4.6 - 20.0 5.8 - 25.1
VTQ108V.TEQ
525-552-AR1272 x 5
40 5.4 - 23.5 6.8 - 29.5 8.5 - 36.2 10.4 - 44.8P.O.A
50 4.4 - 18.9 5.5 - 24.2 6.9 - 30.2
VTQ110V.TEQ
736-752-AR1272 x 7.5
40 6.4 - 27.5 8.0 - 34.5 9.8 - 42.5 12.0 - 51.9P.O.A
50 5.2 - 22.3 6.5 - 28.1 8.1 - 35.2
R404A - LOW TEMPERATURE
STOCK NO. MODELNOM
HPCONDTEMP
CAPACITY RANGE IN KW (MIN - MAX) PRICE $
excl. GST-35 -30 -25 -20
VTQ100V.TEQ
420-402-AR1272 x 4
40 1.4 - 6.2 2.0 - 8.5 2.6 - 11.3 3.4 - 14.6 P.O.A
50 1.1 - 4.7 1.5 - 6.5 2.1 - 8.9 2.7 - 11.7
VTQ102V.TEQ
528-552-AR1272 x 5
40 2.1 - 9.2 2.9 - 12.5 3.8 - 16.5 4.9 - 21.3 P.O.A
50 1.6 - 6.9 2.2 - 9.6 3.0 - 13.0 3.9 - 16.9
VTQ104V.TEQ
736-752-AR1272 x 7.5
40 2.9 - 12.4 3.9 - 16.9 5.2 - 22.3 6.6 - 28.7 P.O.A
50 2.1 - 9.2 3.0 - 12.9 4.0 - 17.3 5.2 - 22.7
CONDENSING UNITS
V.TEQ MINI RACK SYSTEMS
FRASCOLD V.TEQ MINI-RACKS
FEATURES
Please contact Realcold for further information or technical data.
Ratings based on 20k suction superheat, 3k subcooling and below operation:
Min with 1 compressor only at 25hz / Max with 2 Compressors - Lead compressor at 70hz
Min with 1 compressor only at 25hz / Max with 2 Compressors - Lead compressor at 60hz
Due to wide varying capacity and subsequent HOR range, it is recommended either fan speed controller or VSD is used to control fan speed and maintain stable and constant condensing pressure at varying conditions and loads.
Head Cooling fans required at these low temp conditions.
60 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK S-SERIES
Ratings based on; 10k Suction superheat / 3k liquid subcoolingFor best performance, total suction superheat should be below 15kFor 43deg ambient ratings - multiply 40deg by 0.95
REALPACK S-SERIESSCROLL TECHNOLOGY
R404A - WIDE TEMPERATURE RANGE (1PH/240V)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-25 -20 -15 -10 -5 0 +5
RP1240 RP200S1-06-4P 235 1660 2140 2690 3300 4000 4800 5580
5,400.0040 1390 1840 2410 2990 3630 4260 5080
RP1242 RP300S1-10-4P 335 2750 3440 4220 5110 6140 7210 8510
5,940.0040 2440 3100 3810 4620 5560 6630 7710
RP1244 RP350S1-12-4P 3.535 3250 4050 4930 5970 7170 8560 10050
6,140.0040 2920 3650 4460 5460 6570 7790 9280
Noise level (dBA) ratings are given as a guide onlyRefer to page 63 for dimensional drawings.
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP M3hr MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RP200S-06-4P ZB15 2 5.92 16.5 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 50
RP300S-10-4P ZB21 3 8.6 19.5 2 x 350mm 0.7 1760 3/8” 7/8” 1385 580 1000 110 52
RP350S-12-4P ZB26 3.5 9.9 22.5 2 x 350mm 0.7 1640 3/8” 7/8” 1385 580 1000 125 53
R134A - MED / HIGH TEMPERATURE (1PH/240V)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1240 RP200S1-06-4P 235 1690 2130 2620 3220 3870 4610
5,400.0040 1580 2000 2460 3030 3640 4390
RP1242 RP300S1-10-4P 335 2460 3100 3860 4690 5700 6780
5,940.0040 2300 2910 3620 4400 5360 6380
RP1244 RP350S1-12-4P 3.535 2880 3620 4450 5480 6660 7920
6,140.0040 2700 3400 4180 5150 6270 7460
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Safety Controls, Isolating switch
Reliable high efficiency Copeland scroll compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
61 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK S-SERIES
Ratings based on; 10k Suction superheat / 3k liquid subcoolingFor best performance, total suction superheat should be below 15kFor 43deg ambient ratings - multiply 40deg by 0.9
R404A - WIDE TEMPERATURE RANGE (3PH/415V)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-25 -20 -15 -10 -5 0 +5
RP1250 RP200S3-06-4P 235 1660 2140 2690 3300 4000 4800 5580
5,400.0040 1390 1840 2410 2990 3630 4260 5080
RP1254 RP300S3-10-4P 335 2750 3440 4220 5110 6140 7210 8510
5,940.0040 2440 3100 3810 4620 5560 6630 7710
RP1256 RP350S3-12-4P 3.535 3250 4050 4930 5970 7170 8560 10050
6,140.0040 2920 3650 4460 5460 6570 7790 9280
RP1258 RP400S3-12-4P 435 3700 4580 5620 6820 8220 9660 11500
6,740.0040 3290 4090 5030 6140 7430 9140 10450
RP1060 RP500S3-14-4P 535 4640 5730 7010 8510 10250 12000 14250
6,870.0040 4140 5120 6290 7640 9230 11050 12950
RP1262 RP600S3-15-4P 635 5440 6730 8230 9980 12000 14050 16650
7,230.0040 4890 6050 7410 9000 10850 13000 15150
RP1268 RP800S3-24-4P 835 6380 8470 10750 13200 15900 18800 22300
10,980.0040 5540 7360 9520 11850 14450 17350 20200
RP1270 RP900S-24-4P 935 8090 1050 12350 15000 18000 21100 24900
11,420.0040 7250 9070 11150 13550 16300 19400 22500
RP1272 RP1000S-27-4P 1035 9460 11850 14450 17600 20900 24700 28900
11,850.0040 8340 10600 13150 16050 19100 22600 26500
RP1276 RP1300S-27-4P 1335 10550 13700 16850 20500 24500 31500
12,930.0040 8770 11600 14700 18350 22100 26300
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP M3hr MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RP200S3-06-4P ZB15 2 5.9 4.9 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 50
RP300S3-10-4P ZB21 3 8.6 7.2 2 x 350mm 0.7 1760 3/8” 7/8” 1385 580 1000 110 52
RP350S3-12-4P ZB26 3.5 9.9 8.9 2 x 350mm 0.7 1640 3/8” 7/8” 1385 580 1000 125 53
RP400S3-12-4P ZB29 4 11.1 10.3 2 x 350mm 0.7 1640 1/2” 7/8” 1385 580 1000 150 55
RP500S3-14-4P ZB38 5 12.8 12.8 2 x 350mm 0.7 1530 1/2” 7/8” 1385 580 1000 155 55
RP600S3-15-4P ZB45 6 17.2 13.1 2 x 350mm 0.7 1450 1/2” 7/8” 1385 580 1000 160 56
RP800S3-24-4P ZB58 8 22.1 15.4 2 x 500mm 2.0 3440 5/8” 1-1/8” 1405 855 1130 270 62
RP900S3-24-4P ZB66 9 25.7 17.6 2 x 500mm 2.0 3440 5/8” 1-3/8” 1405 855 1130 270 62
RP1000S3-27-4P ZB76 10 28.8 20.4 2 x 500mm 2.0 3200 5/8” 1-3/8” 1405 855 1130 275 63
RP1300S3-27-4P ZB95 13 36.4 30.7 2 x 500mm 2.0 3200 5/8” 1-3/8” 1405 855 1130 275 65
Noise level (dBA) ratings are given as a guide onlyRefer to page 63 for dimensional drawings.
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency Copeland scroll compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
REALPACK S-SERIESSCROLL TECHNOLOGY
62 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK S-SERIES
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency Copeland scroll compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable componentsR134A - MED / HIGH TEMPERATURE (3PH/415V)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1250 RP200S3-06-4P 235 1690 2130 2620 3220 3870 4610
5,400.0040 1580 2000 2460 3030 3640 4390
RP1254 RP300S3-10-4P 335 2460 3100 3860 4690 5700 6780
5,940.0040 2300 2910 3620 4400 5360 6380
RP1256 RP350S3-12-4P 3.535 2920 3690 4610 5670 6880 8230
6,140.0040 2750 3470 4350 5350 6500 7780
RP1258 RP400S3-12-4P 435 3340 4200 5170 6280 7640 9090
6,740.0040 3130 3940 4850 5970 7180 8550
RP1260 RP500S3-15-4P 535 4110 5160 6430 7890 9480 11300
6,870.0040 3850 4850 6050 7430 8920 10600
RP1262 RP600S3-15-4P 635 4890 6160 7630 9370 11400 13350
7,230.0040 4610 5740 7190 8900 10700 12700
RP1268 RP800S3-24-4P 835 6320 7940 9830 11900 14400 17050
10,980.0040 5990 7430 9220 11300 13550 16050
RP1270 RP900S-24-4P 935 7340 9070 11250 13600 16500 19550
11,420.0040 6870 8480 10550 12950 15500 18350
RP1272 RP1000S-27-4P 1035 8520 10700 13300 16150 19550 23300
11,850.0040 7980 10050 12450 15300 18450 22100
RP1276 RP1300S-27-4P 1335 10500 13350 16450 20000 24100 30300
12,930.0040 9550 12300 15450 18900 22800 27000
Ratings based on; 10k Suction superheat / 3k liquid subcoolingFor best performance, total suction superheat should be below 15kFor 43deg ambient ratings - multiply 40deg ratings by 0.95
Noise level (dBA) ratings are given as a guide onlyRefer to page 63 for dimensional drawings.
REALPACK S-SERIESSCROLL TECHNOLOGY
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP M3hr MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RP200S3-06-4P ZB15 2 5.9 4.9 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 50
RP300S3-10-4P ZB21 3 8.6 7.2 2 x 350mm 0.7 1760 3/8” 7/8” 1385 580 1000 110 52
RP350S3-12-4P ZB26 3.5 9.9 8.9 2 x 350mm 0.7 1640 3/8” 7/8” 1385 580 1000 125 53
RP400S3-12-4P ZB29 4 11.1 10.3 2 x 350mm 0.7 1640 1/2” 7/8” 1385 580 1000 150 55
RP500S3-14-4P ZB38 5 12.8 12.8 2 x 350mm 0.7 1530 1/2” 7/8” 1385 580 1000 155 55
RP600S3-15-4P ZB45 6 17.2 13.1 2 x 350mm 0.7 1450 1/2” 7/8” 1385 580 1000 160 56
RP800S3-24-4P ZB58 8 22.1 15.4 2 x 500mm 2.0 3440 5/8” 1-1/8” 1405 855 1130 270 62
RP900S3-24-4P ZB66 9 25.7 17.6 2 x 500mm 2.0 3440 5/8” 1-3/8” 1405 855 1130 270 62
RP1000S3-27-4P ZB76 10 28.8 20.4 2 x 500mm 2.0 3200 5/8” 1-3/8” 1405 855 1130 275 63
RP1300S3-27-4P ZB95 13 36.4 30.7 2 x 500mm 2.0 3200 5/8” 1-3/8” 1405 855 1130 275 65
63 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK S-SERIES
DIMENSIONAL DRAWINGS
2 X 350MM FAN MODELS
2 X 500MM FAN MODELS
Sight Glass
Connections
Sight Glass
Connections
Sight Glass
Connections
REALPACK S-SERIES
1 X 350MM FAN MODELS
64 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK R-SERIES
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency Reciprocating compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
R404A - MED TEMPERATURE
STOCK NO MODELNOM
HPPHASE
AMBTEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RP1280 RPM125.R1Z-04-4P 1.25 135 1875 2290 2695 3185 3620
5,270.0040 1710 2085 2450 2830 3280
RP1281 RPM150.R1Z-06-4P 1.5 135 2495 3015 3640 4290 4850
5,510.0040 2230 2755 3320 3815 4405
RP1282 RPM200.R1Z-06-4P 2.0 135 2895 3580 4345 5045 5880
6,020.0040 2575 3220 3830 4575 5210
RP1283 RPM250.R1Z-06-4P 2.5 135 3615 4420 5260 6265 7120
6,300.0040 3205 3945 4725 5500 6415
RP1284 RPM250.R3Z-10-4P 2.5 335 3795 4640 5525 6580 7475
7,290.0040 3365 4140 4960 5775 6735
RP1285 RPM300.R3Z-10-4P 3.0 335 5170 5955 7025 8210 9235
7,470.0040 4435 5315 6325 7225 8350
RP1286 RPM400.R3Z-10-4P 4.0 335 5945 6850 8080 9440 10620
7,720.0040 5100 6110 7275 8310 9600
RP1287 RPM500.R3Z-15-4P 5.0 335 6755 8070 9670 11465 13345
8,990.0040 5965 7180 8650 10285 11960
RP1288 RPM650.R3Z-15-4P 5.0 335 8640 10350 12140 14490 16655
9,310.0040 7660 9270 11230 13105 15460
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL PH HP MRA QTY / DIAAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RPM125.R1Z-04-4P CAJ4517Z 1 1.25 9.0 1 x 350mm 0.7 940 3/8” 5/8” 995 545 800 85 51
RPM150.R1Z-06-4P CAJ4519Z 1 1.5 12.0 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 51
RPM200.R1Z-06-4P FH4524Z 1 2.0 13.0 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 52
RPM250.R1Z-06-4P FH4531Z 1 2.5 16.7 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 52
RPM250.R3Z-10-4P TFH4531Z 3 2.5 6.2 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 54
RPM300.R3Z-10-4P TFH4540Z 3 3 8.5 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 55
RPM400.R3Z-10-4P TAG4546Z 3 4 8.9 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 56
RPM500.R3Z-15-4P TAG4561Z 3 5 10.3 2 x 350mm 0.7 1450 1/2” 7/8” 1385 580 1000 160 57
RPM650.R3Z-15-4P TAG4573Z 3 6.5 13.6 2 x 350mm 0.7 1450 1/2” 7/8” 1385 580 1000 160 59
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg ratings by 0.95
REALPACK R-SERIESRECIPROCATING COMPRESSOR
Noise level (dBA) ratings are given as a guide onlyRefer to page 71 for dimensional drawings.
65 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg ratings by 0.95
R404A - LOW TEMPERATURE
STOCK NO MODELNOM
HPPHASE
AMBTEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -20 -15
RP1290 RPL150.R1Z-04-4P 1.5 135 995 1215 1495 1780 2155
5,420.0040 825 1035 1295 1605 1900
RP1291 RPL200.R1Z-04-4P 2.0 135 980 1370 1815 2305 2840
6,030.0040 835 1200 1610 2055 2545
RP1292 RPL250.R3Z-06-4P 2.5 335 1790 2230 2745 3465 4195
6,610.0040 1550 1890 2445 3025 3670
RP1293 RPL400.R3Z-10-4P 4.0 335 2055 2960 3950 5015 6050
7,960.0040 1735 2620 3485 4510 5450
RP1294 RPL550.R3Z-10-4P 5.5 335 3450 4320 5340 6575 7965
8,240.0040 2960 3790 4735 5870 7130
Robust & aesthetically pleasing, powder coated enclosure.
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency Reciprocating compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
CONDENSING UNITS
REALPACK R-SERIES
REALPACK R-SERIESRECIPROCATING COMPRESSOR
Noise level (dBA) ratings are given as a guide onlyRefer to page 71 for dimensional drawings.
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL PH HP MRA QTY / DIAAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RPL150.R1Z-04-4P CAJ2464Z 1 1.5 8.5 1 x 350mm 0.7 940 3/8” 5/8” 995 545 800 85 51
RPL200.R1Z-04-4P FH2480Z 1 2.0 11.5 1 x 350mm 0.7 940 3/8” 5/8” 995 545 800 85 52
RPL250.R3Z-06-4P TFH2511Z 3 2.5 5.5 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 53
RPL400.R3Z-10-4P TAG2516Z 3 4 7.3 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 57
RPL550.R3Z-10-4P TAG2522Z 3 5.5 9.1 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 59
66 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK R-SERIES
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency Reciprocating compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control for improved efficiency & sound levels
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
R134A - MED TEMPERATURE
STOCK NO MODELNOM
HPPHASE
AMBTEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1296 RPM150.R1Y-04-4P 1.5 135 1505 2135 2830 3550 4210 4940
5,900.0040 1315 1960 2550 3215 3885 4560
RP1297 RPM200.R1Y-06-4P 2.0 135 2365 3035 3895 4795 5765 6785
6,590.0040 2115 2790 3525 4435 5340 6290
RP1298 RPM275.R3Y-06-4P 2.75 335 2760 3720 4850 6000 7355 8780
6,840.0040 2470 3345 4375 5535 6790 7945
RP1299 RPM300.R3Y-10-4P 3.0 335 3305 4375 5750 7210 8800 10485
7,710.0040 2965 4025 5210 6545 8005 9535
RP1300 RPM350.R3Y-10-4P 3.5 335 3550 4645 6015 7625 9415 11340
8,150.0040 3190 4280 5565 7065 8565 10320
Ratings based on Asercom; 20deg return gas / 0k SubcoolingFor 43deg ambient ratings - multiply 40deg by 0.95
REALPACK R-SERIESRECIPROCATING COMPRESSOR
Noise level (dBA) ratings are given as a guide onlyRefer to page 71 for dimensional drawings.
TECHNICAL DATA
UNIT MODELCOMPRESSOR FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL PH HP MRA QTY / DIAAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RPM150.R1Y-04-4P FH4518Y 1 1.5 9.9 1 x 350mm 0.7 940 3/8” 5/8” 995 545 800 85 52
RPM200.R1Y-06-4P FH4525Y 1 2.0 13.2 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 53
RPM275.R3Y-06-4P TAG4534Y 3 2.75 6.0 1 x 350mm 0.7 880 3/8” 7/8” 995 545 800 85 55
RPM300.R3Y-10-4P TAG4537Y 3 3.0 6.5 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 55
RPM350.R3Y-10-4P TAG4543Y 3 3.5 7.3 2 x 350mm 0.7 1760 1/2” 7/8” 1385 580 1000 110 57
67 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK F-SERIES
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency FRASCOLD compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control fitted on models up to 500mm fans
HP fan cycling control fitted on 630mm fan models
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
Ratings based on; 20k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 71 for dimensional drawings.
REALPACK F-SERIES FRASCOLD COMPRESSOR
R404A - MED TEMPERATURE (TWIN COIL MODELS)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RP1320 RPM525F-24T-4P 535 10370 12790 15420 18400 21770
13,500.0040 11760 11500 14030 16760 19850
RP1321 RPM728F-24T-4P 7.535 11920 14650 17630 20100 24510
13,840.0040 10840 13350 16080 19160 22350
RP1322 RPM733F-27T-4P 7.535 13790 16760 20130 23960 28000
14,690.0040 12540 15240 18320 21820 25780
RP1324 RPM1242F-31T-4P 1235 16440 20200 24520 29200 34390
16,380.0040 14800 18260 22250 26540 31440
RP1325 RPM1552F-45T-6P 1535 22650 27360 32720 38860 45860
22,130.0040 20750 25080 30020 35680 42170
RP1326 RPM2056-45T-6P 2035 24750 29870 35700 41960 49040
22,980.0040 22670 27380 32740 38490 45460
RP1327 RPM2571-54T-6P 2535 29020 35580 43120 51210 60350
29,750.0040 26170 32160 39070 46490 54940
RP1328 RPM3084-64T-4P 3035 35280 43120 51570 61730 72580
31,700.0040 31950 39130 46880 56270 66360
R404A - MED TEMPERATURE (SINGLE COIL MODELS)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RP1310 RPM157F-06-4P 1.535 2880 3570 4220 5050 5930
7,290.0040 2620 3190 4000 4620 5490
RP1311 RPM210F-10-4P 235 4020 4960 5980 7220 8550
8,350.0040 3660 4530 5480 6560 7720
RP1312 RPM211F-10-4P 235 4690 5750 6960 8320 9740
8,720.0040 4190 5210 6310 7560 8730
RP1313 RPM313F-12-4P 335 5470 6760 8180 9680 11430
9,030.0040 4980 6110 7390 8830 10440
RP1314 RPM315F-15-4P 335 6560 7920 9460 11210 14340
10,080.0040 5900 7200 8600 10180 11940
RP1315 RPM521F-15-4P 535 8350 10250 12380 14570 16980
11,900.0040 7490 9220 11150 13300 15510
SELECT MODELSALSO AVAILABLEFITTED WITH VSD
68 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK F-SERIES
R134A - MED TEMPERATURE (SINGLE COIL MODELS)
MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1330 RPL157F-04-4P 1.535 1670 2110 2630 3200 3830 4810
7,200.0040 1550 1970 2460 3000 3620 4290
RP1331 RPL210F-06-4P 235 2370 3010 3760 4590 5520 6570
7,540.0040 2170 2770 3470 4280 5160 6150
RP1332 RPL211F-06-4P 235 2600 3330 4200 5150 6210 7330
7,910.0040 2380 3070 3880 4770 5770 6870
RP1333 RPL213F-06-4P 235 3090 3910 4840 5860 7000 8280
8,100.0040 2850 3620 4490 5440 6560 7700
RP1335 RPL315F-10-4P 335 3670 4720 5890 7250 8800 10500
8,880.0040 3370 4370 5480 6770 8190 9790
RP1337 RPL420F-10-4P 435 4880 6220 7730 9470 11360 13450
10,300.0040 4520 5740 7220 8860 10640 12620
RP1338 RPL525F-15-4P 535 6470 8080 9960 12140 14560 17300
12,180.0040 5980 7560 9350 11410 13690 16280
RP1340 RPL533F-15-4P 535 7620 9630 11840 14350 17180 20240
12,610.0040 7120 8940 11080 13420 16070 18920
RP1341 RPL736F-15-4P 7.535 8970 11270 13900 16880 19930 23240
12,910.0040 8370 10560 13060 15770 18750 22000
Ratings based on; 20k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 71 for dimensional drawings.
REALPACK F-SERIES FRASCOLD COMPRESSOR
R134A - MED TEMPERATURE (TWIN COIL MODELS)
MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1345 RPL736F-24T-4P 7.535 9400 11930 14760 17980 21460 25300
14,240.0040 8760 11120 13900 16990 20320 23980
RP1346 RPL842F-24T-4P 835 10830 13720 17030 20900 25400 30400
15,340.0040 9930 12680 15810 19500 23810 28620
RP1347 RPL1052F-27T-4P 1035 13000 16200 20000 24200 29100 34300
15,780.0040 12000 15100 18700 22700 27300 32200
RP1349 RPL1556F-31T-4P 1535 14280 17890 22100 27140 32120 37910
17,460.0040 13280 16720 20710 25130 30180 35640
RP1351 RPL1571F-45T-6P 1535 18240 22970 28320 34490 41310 49020
25,960.0040 16990 21500 26760 32190 38860 46150
RP1352 RPL2084F-45T-6P 2035 19160 24500 30750 3770 45610 54180
26,170.0040 17720 22740 28620 35160 42640 51130
SELECT MODELSALSO AVAILABLEFITTED WITH VSD
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency FRASCOLD compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control fitted on models up to 500mm fans
HP fan cycling control fitted on 630mm fan models
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
69 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK F-SERIES
R404A - LOW TEMPERATURE (SINGLE COIL MODELS)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -20 -15
RP1330 RPL157F-04-4P 1.535 1000 1350 1760 2210 2710
7,200.0040 860 1190 1580 2000 2450
RP1331 RPL210F-06-4P 235 1400 1850 2400 3020 3700
7,540.0040 1260 1670 2150 2710 3360
RP1332 RPL211F-06-4P 235 1570 2110 2730 3450 4240
7,910.0040 1370 1870 2430 3080 3800
RP1333 RPL213F-06-4P 235 1950 2540 3200 3970 -
8,100.0040 1740 2270 2890 3590 -
RP1334 RPL213F-10-4P 235 2050 2700 3520 4360 5390
8,720.0040 1840 2430 3170 3970 4910
RP1335 RPL315F-10-4P 335 - 3230 4100 5050 6290
8880.0040 - 2920 3700 4570 5570
RP1337 RPL420F-10-4P 435 2800 3730 4790 5980 7360
10,300.0040 2480 3280 4240 5390 6650
RP1338 RPL525F-15-4P 535 3530 4760 6150 7850 9630
12,180.0040 3110 4250 5520 6990 8670
RP1339 RPL528F-15-4P 535 4220 5550 7190 9000 10970
12,280.0040 3690 4960 6370 8000 9880
RP1340 RPL533F-15-4P 535 5060 6530 8230 10100 -
12,610.0040 4550 5880 7350 9120 -
SELECT MODELSALSO AVAILABLEFITTED WITH VSD
REALPACK F-SERIES FRASCOLD COMPRESSOR
R404A - LOW TEMPERATURE (TWIN COIL MODELS)
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-35 -30 -25 -20 -15
RP1344 RPL533F-24T-4P 535 5300 6900 8780 10880 13430
13,930.0040 4770 6240 7960 9880 12090
RP1345 RPL736F-24T-4P 7.535 5740 7590 9780 12210 15020
14,240.0040 5060 6750 8640 10980 13540
RP1346 RPL842F-24T-4P 835 6440 8640 11060 13810 16740
15,340.0040 5680 7690 9870 12360 15180
RP1348 RPL1052F-27T-4P 1035 8500 11000 13800 16800 20400
16,580.0040 7600 9800 12300 15200 18600
RP1349 RPL1556F-31T-4P 1535 9310 12060 15190 18800 22770
17,460.0040 8150 10820 13710 17030 20660
RP1350 RPL1559F-45T-6P 1535 9930 12800 16380 20410 24890
25,560.0040 8880 11680 14890 18610 22750
RP1351 RPL1571F-45T-6P 1535 11650 15200 19050 23500 28670
25,960.0040 10360 13510 17250 21340 26110
RP1353 RPL2084F-54T-6P 2035 12970 16970 21850 27220 33330
29,630.0040 11510 15230 19600 24380 29820
Ratings based on; 20k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg by 0.95Refer to page 71 for dimensional drawings.
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Reliable high efficiency FRASCOLD compressors
Large high ambient condenser coils with treated fins
High efficiency, low noise external rotor fan motors
Fan speed control fitted on models up to 500mm fans
HP fan cycling control fitted on 630mm fan models
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
Easy access to all serviceable components
70 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
Noise level (dBA) ratings are given as a guide onlyRefer to page 71 for dimensional drawings.
R134A MED / R404A LOW
UNIT MODELCOMPRESSOR (3PH) FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RPL157F-04-4P A157Y 1 4.5 1 x 350 0.7 940 3/8” 5/8” 1205 545 800 94 51
RPL210F-06-4P B210Y 2 6.7 1 x 350 0.7 880 3/8” 7/8” 1635 580 1000 100 50
RPL211F-06-4P D211Y 2 7.1 1 x 350 0.7 880 3/8” 7/8” 1205 545 800 107 50
RPL213F-06-4P D213Y 2 7.1 1 x 350 0.7 880 3/8” 7/8” 1635 580 1000 107 50
RPL213F-10-4P D213Y 2 7.1 2 x 350 0.7 1760 3/8” 7/8” 1635 580 1000 127 52
RPL315F-10-4P D315Y 3 10.0 2 x 350 0.7 1760 3/8” 7/8” 1635 580 1000 131 52
RPL420F-10-4P Q420Y 4 10.1 2 x 350 0.7 1760 3/8” 7/8” 1635 580 1000 156 52
RPL525F-15-4P Q525Y 5 12.7 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 194 56
RPL528F-15-4P Q528Y 5 14.0 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 194 56
RPL533F-15-4P Q533Y 5 14.4 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 194 56
RPL736F-15-4P Q736Y 7.5 19.4 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 194 57
RPL533F-24T-4P Q533Y 5 14.4 2 x 500 2.0 3440 5/8” 1-3/8” 1665 900 1065 292 62
RPL736F-24T-4P Q736Y 7.5 19.4 2 x 500 2.0 3440 5/8” 1-3/8” 1665 900 1065 292 62
RPL842F-24T-4P S842Y 8 20.3 2 x 500 2.0 3440 5/8” 1-3/8” 1665 900 1065 330 63
RPL1052F-27T-4P S1052Y 10 24.5 2 x 500 2.0 2980 5/8” 1-3/8” 1665 900 1065 333 63
RPL1556F-31T-4P S1556Y 15 30.7 2 x 500 2.0 2980 7/8” 1-5/8” 1665 900 1065 346 64
RPL1559F-45T-6P V1559Y 15 31.1 2 x 630 3.6 5000 7/8” 1-5/8” 2400 1000 1205 500 63
RPL1571F-45T-6P V1571Y 15 32.2 2 x 630 3.6 5000 7/8” 1-5/8” 2400 1000 1205 505 63
RPL2084F-45T-6P V2084Y 20 42.6 2 x 630 3.6 5000 7/8” 1-5/8” 2400 1000 1205 520 64
RPL2084F-54T-6P V2084Y 20 42.6 2 x 630 3.6 4500 7/8” 1-5/8” 2400 1000 1205 530 64
R404A MED TEMP
UNIT MODELCOMPRESSOR (3PH) FAN MOTORS (1PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RPL157F-06-4P A157Y 1.5 4.5 1 x 350 0.7 880 3/8” 7/8” 1205 545 800 96 50
RPL210F-10-4P B210Y 2 6.7 1 x 350 0.7 1760 3/8” 7/8” 1635 580 1000 122 52
RPL211F-10-4P D211Y 2 7.1 2 x 350 0.7 1760 3/8” 7/8” 1635 580 1000 127 52
RPM313F-12-4P D313Y 3 8.8 2 x 350 0.7 1640 1/2” 7/8” 1635 580 1000 160 55
RPM315F-15-4P D315Y 3 10.0 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 169 56
RPM521F-15-4P Q521Y 5 11.6 2 x 350 0.7 1450 1/2” 7/8” 1635 580 1000 194 56
RPM525F-24T-4P Q525Y 5 12.7 2 x 500 2.0 3440 5/8” 1-3/8” 1665 900 1065 292 62
RPM728F-24T-4P Q728Y 7.5 17.6 2 x 500 2.0 3440 5/8” 1-3/8” 1665 900 1065 292 62
RPM733F-27T-4P Q733Y 7.5 20.0 2 x 500 2.0 3200 5/8” 1-3/8” 1665 900 1065 294 63
RPM1242F-31T-4P S1242Y 12 22.4 2 x 500 2.0 2980 7/8” 1-5/8” 1665 900 1065 345 63
RPM1552F-45T-6P S1552Y 15 32.4 2 x 630 3.6 5000 7/8” 1-5/8” 2400 1000 1205 316 61
RPM2056-45T-6P S2056Y 20 38.4 2 x 630 3.6 5000 7/8” 1-5/8” 2400 1000 1205 462 62
RPM2571-54T-6P V2571Y 25 43.5 2 x 630 3.6 4500 7/8” 1-5/8” 2400 1000 1205 534 64
RPM3084-64T-4P V3084Y 30 49.2 2 x 630 3.6 6500 7/8” 1-5/8” 2400 1000 1205 550 69
CONDENSING UNITS
REALPACK F-SERIES
TECHNICAL DATA
71 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK R & F-SERIES
DIMENSIONAL DRAWINGS
2 X 500MM FAN MODELS
2 X 630MM FAN MODELS
REALPACK R & F-SERIES
350MM FAN MODELS
Sight Glass
Connections
488 / 540
495 / 530
545 / 580
Sight Glass
Connections
Sight Glass
Connections
2 FAN MODELS
1 FAN MODELS
72 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK GF-SERIES
Ratings based on; 20k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg by 0.95
R404A - MED TEMPERATURE
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R404A) PRICE $excl. GST-15 -10 -5 0 +5
RP1370 RGF1242-052D-NS 1235 17000 21100 25500 30600 36400
23,400.0040 15400 19100 23300 28000 33400
RP1372 RGF1552-052D-ND 1535 22900 27600 33300 39200 46300
24,300.0040 21000 25300 30300 36000 42600
RP1374 RGF2056-052D-ND 2035 25000 30100 36000 42700 49900
25,600.0040 22900 27700 33100 39300 45900
RP1376 RGF2571-067C-LD 2535 29300 36300 44000 52300 62200
33,800.0040 26500 32900 40000 48100 56700
RP1378 RGF3084-067C-ND 3035 36400 44500 53700 64200 76100
35,300.0040 32700 40500 49000 58700 69800
RP1380 RGF35106-067D-ND 3535 45500 55700 67300 80600 94800
40,500.0040 41300 50500 61100 73400 87400
RP1382 RGF40126-067D-ND 4035 51900 63600 77000 91300 107500
41,500.0040 46800 57400 69600 83600 98600
R134A - MED TEMPERATURE
STOCK NO MODELNOM
HPAMB TEMP
CAPACITY IN WATTS PRICE $excl. GST-15 -10 -5 0 +5 +10
RP1386 RGF1052-052D-NS 1035 13300 16700 20600 25100 30200 35900
23,600.0040 12400 15500 19300 23600 28300 33800
RP1388 RGF1556-052D-NS 1535 14500 18100 22400 27300 32800 38900
24,700.0040 13500 17000 21000 25700 30800 36700
RP1390 RGF1571-067C-LS 1535 18200 23000 28300 34300 41300 48700
33,100.0040 17000 21300 26400 32200 38600 45800
RP1392 RGF2084-067C-LS 2035 19200 24500 30800 37700 45600 54200
33,500.0040 17700 22700 28600 35200 42600 50800
RP1394 RGF25106-067C-LD 2535 23900 30400 38000 46400 55500 65700
36,900.0040 22100 28100 35200 42600 51500 61500
RP1396 RGF30126-067C-NS 3035 29300 37000 46300 56300 68000 80800
38,700.0040 26700 34200 42600 52300 63400 75500
Powered by reliable/high efficiency FRASCOLD compressor
EBM High efficiency, low noise external rotor fan motors
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Large V-block condenser coil with epoxy coated fins
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
HP fan cycling to maintain condenser pressure
Easy access to all serviceable components
REALPACK GF-SERIES PACKAGE
SELECT MODELSALSO AVAILABLEFITTED WITH VSD
POWERED BY
73 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
CONDENSING UNITS
REALPACK GF-SERIES
Powered by reliable/high efficiency FRASCOLD compressor
EBM High efficiency, low noise external rotor fan motors
Robust & aesthetically pleasing, powder coated enclosure
Fully wired including; Contactors, Overloads, Safety Controls, phase protection and Isolating switch
Large V-block condenser coil with epoxy coated fins
Oil separator & suction accumulator fitted on all models
Dual pressure safety control fitted on all models
HP fan cycling to maintain condenser pressure
Easy access to all serviceable components
REALPACK GF-SERIES PACKAGE
R404A - LOW TEMPERATURE
MODELNOM
HPAMB TEMP
CAPACITY IN WATTS (R134A) PRICE $excl. GST-35 -30 -25 -20 -15
RP1386 RGF1052-052D-NS 1035 8800 11400 14300 17800 21600
23,600.0040 7900 17800 13000 16200 19800
RP1388 RGF1556-052D-NS 1535 9500 12500 15700 19600 23900
24,700.0040 8400 11100 14200 17600 21800
RP1390 RGF1571-067C-LS 1535 11800 15400 19500 24000 29500
33,100.0040 10500 13800 17400 21800 26700
RP1392A RGF2084-067C-LD 2035 13000 17200 22100 27800 34100
33,500.0040 11700 11730 20000 24700 30600
RP1396 RGF25106-067C-LD 3035 15700 21000 27200 34400 42200
36,900.0040 13800 18700 24300 30800 37900
RP1398 RGF30126-067C-NS 3035 18300 24500 31500 39700 48500
38,700.0040 16200 21800 28200 35500 43400
SELECT MODELSALSO AVAILABLEFITTED WITH VSD
Ratings based on; 20k Suction superheat / 3k liquid subcoolingFor 43deg ambient ratings - multiply 40deg by 0.95 POWERED BY
H
W
L
74 For more information visit our website at www.realcold.com.auPrices subject to change without notice and are exclusive of GST
R134A MED / R404A LOW
UNIT MODELCOMPRESSOR (3PH) FAN MOTORS (3PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RGF1052-052D-NS S1052Y 10 24.5 2 x 500 0.95 3530 5/8” 1-3/8” 2272 1140 986 515 56
RGF1556-052D-NS S1556Y 15 30.7 2 x 500 0.95 3530 5/8” 1-5/8” 2272 1140 986 525 56
RGF1571-067C-LS V1571Y 15 32.2 2 x 650 0.81 4575 7/8” 2-1/8” 2695 1500 1480 690 59
RGF2084-067C-LS V2084Y 20 42.6 2 x 650 0.81 4575 7/8” 2-1/8” 2695 1500 1480 700 59
RGF2084-067C-LD V2084Y 20 42.6 2 x 650 1.50 5780 7/8” 2-1/8” 2695 1500 1480 700 61
RGF25106-067C-LD Z25106Y 25 53.6 2 x 650 1.50 5780 7/8” 2-1/8” 2695 1500 1480 750 66
RGF30126-067C-NS Z30126Y 30 55.7 2 x 650 2.50 6890 7/8” 2-1/8” 2695 1500 1480 780 67
R404A MED TEMP
UNIT MODELCOMPRESSOR (3PH) FAN MOTORS (3PH) AIR
VOLUME L/SEC
CONNECTIONS DIMENSIONS (mm)KG dB(A)
@ 3mMODEL HP MRA QTYAMPS(ea)
LIQUID SUCTION LENGTH WIDTH HEIGHT
RGF1242-052D-NS S1242Y 12 22.4 2 x 500 0.95 3530 5/8” 1-3/8” 2272 1140 986 515 56
RGF1552-052D-ND S1552Y 15 32.4 2 x 500 1.35 4475 5/8” 1-5/8” 2272 1140 986 520 61
RGF2056-052D-ND S2056Y 20 38.4 2 x 500 1.35 4475 5/8” 1-5/8” 2272 1140 986 530 61
RGF2571-067C-LD V2571Y 25 43.5 2 x 650 1.50 5780 7/8” 2-1/8” 2695 1500 1480 700 61
RGF3084-067C-ND V3084Y 30 49.2 2 x 650 2.50 6890 7/8” 2-1/8” 2695 1500 1480 730 70
RGF35106-067D-ND Z35106Y 35 60.2 2 x 650 4.30 8820 7/8” 2-1/8” 2695 1500 1480 780 70
RGF40126-067D-ND Z40126Y 40 71.9 2 x 650 4.30 8820 7/8” 2-1/8” 2695 1500 1480 810 70
CONDENSING UNITS
REALPACK GF-SERIES
TECHNICAL DATA
Noise level (dBA) ratings are given as a guide only