Upload
others
View
1
Download
0
Embed Size (px)
Citation preview
California Environmental Protection Agency EXECUTIVE ORDER U-R-004-0495JOHN DEERE POWER SYSTEMS New Off-RoadAir Resources Board Compression-Ignition Engines
Pursuant to the authority vested in the Air Resources Board by Sections 43013, 43018, 43101, 43102, 43104 and 43105 of the Health and Safety Code; and
Pursuant to the authority vested in the undersigned by Sections 39515 and 39516 of the Health and Safety Code and Executive Order G-14-012;
IT IS ORDERED AND RESOLVED: That the following compression-ignition engines and emission control systems produced by the manufacturer are certified as described below for use in off-road equipment. Production engines shall be in all material respects the same as those for which certification is granted.
MODEL DISPLACEMENT USEFUL LIFEENGINE FAMILY FUEL TYPEYEAR (liters) (hours)
2015 FJDXL09.0301 9.0 Diese 800
SPECIAL FEATURES & EMISSION CONTROL SYSTEMS TYPICAL EQUIPMENT APPLICATION
Charge Air Cooler, Oxidation Catalyst, Electronic Direct Injection, Electronic Control Module, Exhaust Gas
Tractor, Loaders, Dozer, Pump, Compressor, Generator Set,Recirculation, Periodic Trap Oxidizer, Turbocharger, Other Industrial EquipmentSelective Catalytic Reduction-Urea, Ammonia Oxidation
Catalyst
The engine models and codes are attached.
The following are the exhaust certification standards (STD), or family emission limit(s) (FEL) as applicable, and certification levels (CERT) for hydrocarbon (HC), oxides of nitrogen (NOx), or non-methane hydrocarbon plus oxides of nitrogen (NMHC+NOx), carbon monoxide (CO), and particulate matter (PM) in grams per kilowatt-hour (g/kw-hr), and the opacity-of-smoke certification standards and certification levels in percent (%) during acceleration (Accel), lugging (Lug), and the peak value from either mode (Peak) for this engine family (Title 13, California Code of Regulations, (13 CCR) Section 2423):
RATED EMISSION EXHAUST (g/kw-hr) OPACITY (%) POWER STANDARD NMHC NOx NMHC+NOx CO PM ACCEL LUG PEAKCLASS CATEGORY
130 < KW < 560 Tier 4 Final STD 0.19 0.40 N/A 3.5 0.02 N/A N/A N/A
FEL 0.01
CERT 0.003 0.14 0.04 0.004
BE IT FURTHER RESOLVED: That the family emission limit(s) (FEL) is an emission level declared by the manufacturer for use in any averaging, banking and trading program and in lieu of an emission standard for certification. It serves as the applicable emission standard for determining compliance of any engine within this engine family under 13 CCR Sections 2423 and 2427.
BE IT FURTHER RESOLVED: That for the listed engine models, the manufacturer has submitted the information and materials to demonstrate certification compliance with 13 CCR Section 2424 (emission control labels), and 13 CCR Sections 2425 and 2426 (emission control system warranty).
Engines certified under this Executive Order must conform to all applicable California emission regulations.
This Executive Order is only granted to the engine family and model-year listed above. Engines in this family that are produced for any other model-year are not covered by this Executive Order.
Executed at El Monte, California on this 2 day of October 2014.
however Annette Hebert, Chief
Emissions Compliance, Automotive Regulations and Science Division
R/c 12- 29-15
EO #: U- R- 004_ 0495
Attachment : Page lof 2
Engine Model Summary Form Manufacturer John Deere Power Systems Engine category. Nonreed Cal
EPA Engine Family: FJDXL09.030 My Family Name: Process Cock Running Change
1 KNO RPM 4. Fuel Rate 5. Full Rate
mmbroke@peak KW (high)@peak low 6 Torque [Nim) 7. FUN Rate:
mm/stoke@peak 8. Fuel Rate Emission Control
Device Per otbif DYS 1. Engine code 8090HOW18A
2. Engine Mode (SAE Guess)
27202100 (for diesel only)
174062100 [For Sherpais only)
65.802100 (SEA Grass) 1621@1500
tongue 227.101500
(Kowother)@peak torque
52.1@1500 EGR EC PTOX OG SCRC NHIOC DFI TC CAC 6090HOW108
6000HOW19 22402100
22402100 164 9@ 2100 44 902100 45.502100
1435@1500142501500
201.1@1500 201 1G 1500
46 20 1500 61 20 1500
EGR EC PTOX OC SCRE NHBOC OFI TO CAC
9090HOW20 27202100 174 062100 95 902100 162161500 227-1@1500 52 10 1500 CHO NH30 168 9@1300 4.6G 1600 201.1@1500 201500 EGR EC PTOX OC HBOC OFI TC CAC
317@2200 9802200
100. 9@:2200
186.242200 67 602200 62.7@2200
685@1600 1456-1090
234 8@ 1500
234 4 5800 57 4@1600 57 20 1800
EGR EC PTOX OC SC HIOC DFI TC CAC EGR EC PTOK OC CRC NHAC DFI TC CAC
BOSCHFCORC 17@2200 207.5@2200 68 802200 1750@1600 EGR EC PTOX OC GOROHFCORD
BOOCHFCODE POG 2000
260@2200 173.6@2200 1671@1600 23120150
232 5@ 1800
GR BC PTOX OC S EGR EC PTOX OC 80
HOG DFI TC CAC
58 502200 1671@1600 EGR BC P
26002000 187.56 2060 57 4G2000 1563015
21430 6090HFCOM 6090 26102200 560.302230 53 9@ 2200 52 7@ 1500
172.7@2000 52 80 2000 605@1500 233.1@1500 53 40 1500 GOSOHFCOSK
6090 242G2200 24262200
$48.702200 149.502200
50 0G 2200 200 10 45 PG 1500 48 1@1500 ITC CAC
6090HFCOOM 242G2000 160.502000 1595@1500 223 5@15 513@1500 137 502200 48 3022 134101500 42401500
274G2200 134 0@2200 148.802000 65 5020
1345@1500
1477@1500 184 641500 104.1@1500
126.6@2200 42 68 2200 1228@1500 170@ 1500 39 9031500
208G:2000 147 62200
125.602200 136 902000 196.902200 39.3032200
122801500 136 9@ 1500 1120@ 1500
se @1 500 156 101500 153 601500
427@1900
36 20 1500 GR EC PTOK O
GOSOHFCORY 187 G2000
328@1800
297 61800
117 202200 125.5@2000
245 0@ 1600 219 20 1800
39 40 2206 36.46 2000 67.46 1830
1120@1500 1230G 1500
153.7@1500 89.801500
MIA 35 201500 38 PG-1500
NA 273@1600 202 1@1800
6090 345@1800 174 0@ 1800
265 501800 6090 6090 25842200
202 DG 2200 158 902200
50.202200 53.502200
1750G-5800
1821@1500 240 60 1500 227.101500
20301500 52. 101500
TO GAG
320@2200 200 1@2200 67.302200 1750@ 5800 2431@ 1600 59 50 1600 60901-H0198 25842200 150 802200 53.802200 1821@150 225 3@1500 51.7@1500
BODOHNOOT
GOOCHPRINT4
6090 6090
25092200 26802200
159 802200 157.8@2200
215.602200
53.802200
72 56 2608
162101500
184301600
725 201500 226@1500
206 701500
51.7@1500
51801 65201600
GO90HT 012 6090 2829 1 900 196 0@ 1900 56 9@1900 1621@1500 22531500 51 60 1500 DFI TO GAC 6090HT 014 28201900 196 0@ 1800 56 30 10100 162101500 225@1500 51.60 1500 SCRC NHIOC DFI TC CAC
* News ratings added per running . Change
R/C 12- 29- 15
EO #: 4- R- 004-0495
A H auchment : Page 2of 2
Engine Model Summary Form Manufacturer: John Deere Power Systems
Engine cinegory. Narutoad Ci
EPA Engine Family. FJDXL09.0301 Mt Family Name
Process Code: Running Change
2. Engine Model
3. KWGRPM
(8AE Gross)
4 Fuel Rate: mmistake@peak KW
(for diesel only)
5. Fuel Rate
(for diesels only)
6. Torque [Nim)
GRAM SEA GIGes!
7. Fuel Rate 8. Fuel Rate
(Kwon)@ peak torque
9. Emission Control
SAE J1930
164 502000 57.782000 1521@1900 225 6@ 1500 51.7@1500 EGR EC PTOX OC SCRC NHJOC DFI TO CAC 6090-2015 207 502100 56.60 2100 1750@1600 246 501600 60 3@ 1600 EGR EC PTOX OC BCRC NHIOC DFI TC CAC
202 802200 68.202200 1750@1600 346 60 9800 60 30 1500 EGR EC PTOK OC SCRC NH
6090-42018 6090 25182200 150 9@2200 53.5@2200 1621@1500 227.1@1500 52 1@ 1500 EGR EC PTOXTOK OC SCRC NH30 DFI TC CAC
6080RY430 6090 27242100 171.802160 55.102100 1621@1500 224 5@1500 515@1500 EGR EC PTOX OC SCRC NHIOC DFI TO CAG
9090RW431 5090 27202100 171.0@2100 55. 102100 1621G-1500 224 5@ 1500 615G 1500 EGR EC PTOX OC SCRC NHIOC DFI TC CAC 8060RW440 31702100 07.502100 68 802100 1750@ 1600 248 5@ 1800 60 3@ 1500
27202100 174 DG 55902100 162131500 227.181500
317 2100 5090RW4410 27242100 174 0@2100 55902100 162191500 227.1@150 52 1@ 1500 EGR EC PTOK OC DFI TC CAC
DORORW643 60WORW 414
6090 272@2100 27292100 17202100
1740@2100 174 0@2100 1740G2190
53.20)2100 65902100
162101800
162101500 162101500
227.1@150 227.161506 227.1@150
521@ 1500 52 1@1500 52 1@1500
FOR EC PTOK OC SCAC
EGR EC PTOK DC FOR EC PTOK OC SC
C DFI TC CAC C DFI TC CAC
DFI TC CAC
GOPORW448A
27202100 31702100
174 062100 207 5@2100
53 20)2100 65.60)2100
162101500 1750 1600
52 1@1900 60.201600
EGR EC PTOX DC ITC CAC ITC CAC
8950RW4488 GOPORWSPA
27202100 31702100
1740@2100
207 50 55 9@2100 66 6G 2100
1625@1500
1750@ 1600 227.1@1500 C PTOK OC
6080RW4498 6030 27262100 55 9@2100 1621@1500 227.1@1506 52 1@1500
6090 317@2100 27262100 174.0@2900
56 6G2100 55 9@2100
1750@ 1509 1621@1500
246 5@1600 227.1@1500 52 101 OFI TC CAC
AGORW451A 6090 207 5@:2900 56 602100 1750@1500 245 51600 803010 FITC CAC BOWORW4518 27202100 174.002100 56 902100 227.101500 12 101
6090 27202100 174.092100 56.90)2100 152301500 237.101500 52.1015 FITO CAC 6090RW432A 6090 17@2100 203.902100 68 5@2100 1760 1800 243.0@1600 59.60316 ATC CAC
6020RW4528 52100 174.0632100 227, 101500 6090ROW 453
6090RW-48:3A
GO90RV 4538
6090 8090 6090 6090
72@2130
31702100 272@2100 27202100
174.092100
174002109 174.0@2100
56 9021 68 502100 55 PG 2100
1750@ 1600
1625@ 1500
82101500
227.1@1506 243.0@1600 227.181500 227.3@1500
62 1015
62 101 $2. 101506
EGR EC PTOX OC S
EGR EC PTOK OC S
OFI TC CAC OFI TC CAC
6090RW455 174 092100 1621@ 1500 52 18 1500 EGR EC PTOX OC SCRC NHJOC DFI TO CAC 6000RW-458
5090RW-457 2 609097 482 6060
272@2100 272@2100 250@2100
174002100 174 0032100 160402100
35.9 2100 51.502100
18210 1500 1621@1500 1452@1500
227.5@1506
206 2631500
EGR EC PTOX OC SCRC NHI DFI TO CAC EGR EC PTOK OC SCRC NHJOC DFI TC CAC EGR EC PTOX OC SCRC NHIOC DFI TC CAC
250@2100 160 402100 51.5@2100 1452@1500 205 201500 47 0@ 1500 EGR BC PTOK OC SCRC NHJOG DFI TC CAC
" New rating's added per Running Change