For Model G39, G78, G105

EXQUISITE PRODUCT MFG. (M) SDN BHD

For Model G39, G78, G105

Contents

• Feature Chart

• Specifications

• Installation

• Operation

• Care and Cleaning

• Important Warning

• Troubleshooting Guide


8

9

7

6

5

4 3 2

1

FEATURE CHART

Part List

1. Internal Light

2. ON / OFF Light Switch

3. Thermometer

4. Temperature Control Knob

5. Door Gasket

6. Glass / Solid Door

7. Adjustable Wooden Shelves

8. Adjustable Steel Shelves

9. Adjustable Food Stand

10. Condenser Coil

11. Drain Water Pan

12. Power Cord

13. Compressor


SPECIFICATIONS

G39 / S39

GROSS VOLUME (litres) 170

CAPACITY STORAGE (750ml.type) 39 bottle

EXTERNAL DIMENSION (mm) 595(w), x 825(h) x 600(d)

INTERNAL DIMENSION (mm) 490(w), x 670(h) x 445(d)

NET. WEIGHT (kg) 56

DOOR Glass / Solid door

TEMPERATURE RANGE 9°C to 18°C

TEMPERATURE CONTROL Dial Auto

INSULATION TYPE 40mm Polyurethane R141b

WOODEN SHELVES 2pcs

STEEL SHELVES 1pcs

THERMOMETER Digital

INPUT VOLTAGE / FREQUENCY 220-240V / 1 phase AC / 50 Hz

• 60 Hz available upon request

• All specifications are subject to change without prior notice.


SPECIFICATIONS

G78





NET. WEIGHT (kg) 95

DOOR Glass




WOODEN SHELVES 6pcs

STEEL SHELVES 1pcs

THERMOMETER Digital



• All specifications are subject to change without prior notice


SPECIFICATIONS

G105





NET. WEIGHT (kg) 120

DOOR Glass




WOODEN SHELVES 8 pcs

STEEL SHELVES 1 pcs

THERMOMETER Digital



• All specifications are subject to change without prior notice


INSTALLATION

Before using your wine chiller, remove the exterior and interior packing.

• Place your wine chiller at a convenient location.

• Keep 50 mm of space between the back of the appliance and the wall because air

must circulate properly at the back of the wine cooler to ensure efficient

operation.

• Avoid location the appliance in moist areas.Too much moisture in the air will

cause its metal part rusty. Do not spray water to the appliance, this will cause

electricity shock.

• Locate the wine chiller away from direct sunlight and source of heat (stove,

heater, radiator, etc). Direct sunlight may affect the acrylic coating and heat

sources may increase electrical consumption. Due to varying climatic conditions,

water condensation on glass door can sometime occur. (Glass door application

only)

• To avoid vibrations, the wine chiller has to be place on a leveled surface and on a

floor that is strong enough to support the wine chiller when it is fully loaded. Do

not place the wine chiller on any soft material such as foam plastic, etc. Do not

place anything that can make echo near the wine chiller. To level your wine

chiller, adjust the front food stand (Part list 9) at the front of the wine chiller. Tilt

it slightly backward by a few centimeters to ensure stability of the chiller. (esp.

when the glass door is opened).

• Connect the power supply cord to the outlet.

DON’T plug other appliance to the same outlet.

• Opening direction of door must be clear without any obstructing materials.

• Be sure the wine chiller stays in the upright position during transportation.


OPERATION

Temperature Control

• For the first time, set the temperature control to position 3.

• Turn the wine chiller on for 12 hour without storing any wines. This is to ensure

that the cold air in the wine chiller is maintained at a suitable temperature for the

wines.

• Preferably, load the wine on the next day with a maximum of 12 bottles at a time

in an interval of every 1- hour, to the fullest capacity storage recommended.

• To turn the wine chiller off, turn the temperature control to ‘OFF’.

NOTE :

• Turning the temperature control to “OFF” position stops the cooling cycle, but

does not shut off the power to the wine chiller.

• If the unit is unplugged, lost of power, or turned off; you must wait 5 to 10

minutes before restarting the unit. If you attempt to restart before this time delay,

the wine chiller will not start.

• The door must remain closed at all times except retrieving or storing wine. This is

to ensure that the cold air in the wine chiller is maintained at temperature suitable

for storage of wine. As a result, chilled wine can preserve its freshness and taste

for a longer period.

Thermostat

• The temperature in the chiller is automatically controlled by the adjustable

thermostat

Temperature Control Indicator


CARE AND CLEANING

Care

Usually after the wine chiller has been operating for a few months, it is necessary to clean

the body periodically using a soft cloth and mild soap or detergent in order to remove

impurities.

Cleaning Interior of Chiller

• Complete cleaning will be necessary if the impurities are too thick and avoid

possible formation of bad odors.

• Remove all the chilled wines.

• Turn the control knob and main switch to “OFF”.

• Keep the door open

• Allow half an hour for the wine chiller temperature to rise to room temperature

Cleaning External of Chiller

• Use a lukewarm solution of mild soap or detergent to clean the surface. Wipe with

a clean, damp cloth, then allow to dry.

• Use a lukewarm solution of mind soap or detergent to clean the durable finish of

your wine chiller. Wipe with a clean, damp cloth, then dry.

• Never use flammable or toxic cleaning liquids.

• DO NOT USE metallic scouring pads, brushes, coarse abrasive cleaners or strong

alkaline on any surface of the wine chiller.

Cleaning Caution

• Always remove the power cord from the electrical outlet before cleaning near the

electrical parts.

• When not in use:

Disconnect the power cord and leave the door open. This will prevent odors.

• When moving:

Secure all loosen items by taping them in place to prevent from being

damage.

• Do not spray water on the wine chiller, the water will cause the metal parts rusty

and weaken insulation.

• The following thing will damage the lacquer coat and plastics, so do not use hot

water, diluents, petrol, alcohol, kerosene, washing powder, cleanser, alkaline

detergent, acid, chemical cloth, etc. to clean the wine chiller.


IMPORTANT WARNING

Connect the wine chiller to its individual electrical outlet in order to avoid an overload

caused by another appliances or household light that might interrupt the electrical current.

If the power cord of the wine chiller is damaged, have it replaced by a qualified service

person.

About Groundings (Earthing)

• Grounding (earthing) reduces the risk of electric shock by providing an escape

wire for the electric current in case of an electric short circuit.

CAUTION : THIS APPLIANCE MUST BE GROUNDED

• Improper use of the grounding plug may cause an electric shock. Check with a

qualified electrician or a service person if the grounding instructions are not

understood, or if doubts on whether the appliance is properly grounded.

DO NOT STROE INFLAMMABLE MATERIALS

EXPLOSIVES OR CHEMICALS IN THE WINE CHILLER


TROUBLE SHOOTING GUIDE

You can solve many common wine chiller problems easily, saving you the cost of

possible service call. Try the suggestion below to see if you can solve the problem before

calling the service.

Wine Chiller does * Not plugged in.

not operate. * The circuit breaker tripped or blown fuse.

* The wine chiller temperature control is

set at “OFF”.

Wine chiller is too cold. * The temperature control dial may be set to high.

Wine chiller is not cold * Check to be sure the temperature control setting

Enough. is “NORMAL”.

* External environment may require a higher

setting.

* The door is opened too often.

* The door is not closed completely.

* The door gasket does not seal properly.

* The wine chiller does not have the correct

clearances for ventilation.

The condensation water * Check if the drain pipe is faulty.

Flow onto the floor. * Check if the drain pan is full.

A sound of flow can be * If you heard the sound of refrigerant flowing,

heard. that is not a fault.

Condensation form on the * Condensation will forms on the outside of the

outside of the wine chiller wine chiller if it operates in moist areas, just

wipe it dry.

The wine chiller seems to * The wine chiller is not level.

make too much noise. * The wine chiller leaning against the wall.

In summer, the wine chiller * The temperature control dial may be set too low.

operates continuously. * There is bad ventilating around the wine cooler.

* The door is not closed properly.

* The door gasket does not sealed properly.

* The door is opened too often.

Documents

For Model G39, G78, G105