GIF++ Control System (GCS)

12.02.2014 Gilles MAIRE PH-DT-DI 1

Goal of GCS

12.02.2014 Gilles MAIRE PH-DT-DI 2

Give an overview of GIF++ (PVSS Application)• SPS Beam • Cosmic & Beam Trigger• Gas• Access• Environment Sensors• Ramses • Rack Status• Irradiator (Source & Filters)• Radiation

Record all data Produce Warning & Alarms

Gilles MAIRE PH-DT-DI 312.02.2014

GCS Architecture

Gilles MAIRE PH-DT-DI 412.02.2014

SPS Beam

Information from SPS Beam by SoftwareSPS Beam Status, ON or OFFSPS Beam IntensitySPS Beam Type

Gilles MAIRE PH-DT-DI 512.02.2014

Cosmic & Beam Trigger

Information from Cosmic & Beam Trigger (Software by DIP)Cosmic & Beam Trigger Status, ON or OFFCosmic & Beam IntensityCosmic & Beam Trigger TypeDetector on data takingInformation to Cosmic & Beam Trigger (Hardware 6 DO)Interlock in case of Gas Fault

Gilles MAIRE PH-DT-DI 612.02.2014

Gas

Information from Gas (Hardware 6 DI)Gas Fault StatusInformation from Gas (Software by DIP)Primary gases consumptionRunning SystemCirculation flows

Gilles MAIRE PH-DT-DI 712.02.2014

ACCESS

Information from Access (Software by DIP)3 doors status

Gilles MAIRE PH-DT-DI 812.02.2014

ENVIRONMENT Sensors

Information from environment sensors by hardware (5 AI)1 atmospheric pressure sensor2 temperature sensors (inside & outside bunker)2 humidity sensors (inside & outside bunker)

Gilles MAIRE PH-DT-DI 912.02.2014

RAMSES

Information from RAMSES by software (DIP)3 radiation sensors

Gilles MAIRE PH-DT-DI 1012.02.2014

Rack Status

Information from Rack Status by hardwareTemperature Monitoring InterlockReset

Gilles MAIRE PH-DT-DI 1112.02.2014

NA62 Rack Status3U chassis

Equipmentto be protected

CAEN, WIENER

Temperature Controller

Interlocks SignalsFree Contact

Gilles MAIRE PH-DT-DI 1212.02.2014

SOURCE

Information from source by hardware (8 DI)Access Veto 1 & 2 StatusStart & Stop StatusReady StatusMoving StatusFault StatusLocal Emergency Stop Status

Gilles MAIRE PH-DT-DI 1312.02.2014

2 FILTERS

Information from Filters by hardware (2 DI)Idle Status (set position = position)Information from Filters by software (TCPIP)Command (Attenuation Setting)Status (Encoders, End Switches, Local Remote Status)

Gilles MAIRE PH-DT-DI 1412.02.2014

RADIATION Sensors

Information from Radiation Sensors by software (RS485/Sub D9 connector)8 radiation sensors

Gilles MAIRE PH-DT-DI 1512.02.2014

cRIO from NI

16AI

32DI

32DO

RS485

5 Analog Input

16 Digital Input

12 Digital Output

8 Radiation Sensors

Filter 1 Filter 2

ApplicationNA62 Detector Safety System with PVSS supervisorMSS2 for the Magnet Safety (LHC Experiments, M1, Compass)

TCPIP Technical Network

TCPIP Local Network

Real TimeController

FPGA on backplane

Gilles MAIRE PH-DT-DI 1612.02.2014

Cost

cRio & Redundant Power Supplies 14kchfUPS for GCS & PLC Gas 2kchfDistribution Power Supplies 2kchfComputer 4kchfPVSS License 7kchfCable 3kchfFSU 15kchfTOTAL 47kchf 3U chassis 1,5kchf per chassis