Upload
others
View
4
Download
0
Embed Size (px)
Citation preview
Global and Turkish Perspectives of Thorium Fuel for Nuclear Energy
Prof. Dr. Muammer Kaya Osmangazi University
Mining Engineering Department, Eskişehir-Turkey
Natural Properties of Thorium (Th) (Earth’s Forgotten Treasure)
• Occurs naturally,
• Identified almost two centuries ago,
• Exists in nature almost entirely as stable Th-232 isotope,
• Th itself cannot sustain a nuclear chain reaction,
• Is a lustrous silvery-white metal,
• Is dense and only slightly radioactive actinides, you can carry a lump of it in your pocket without harm (less radiotoxic),
• Th is fertile material, accept a neutron and transmute into fissile U-233 and decays to stable Pb-208.
• Th is usually a by-product of the REE containg monazite or bastnasite minerals.
THORIUM BASICS (New Green Nuke Nuclear Renaissance)
• Is plentiful in nature and virtually inexhaustable fuel. • Is a thermal breeder (i.e. creates enough new fuel as it breaks down to sustain a high-temperature chain
reaction indefinitely). • It is impossible to make nuclear weapons and/or bombs from Th by terrorists (i.e. peaceful) • Nuclear power without proliferation has obvious political appeal for governments. • Has a high heat capacity (i.e. smaller reactors) • Does not require costly mining and mineral processing methods (i.e. less expensive), • Is extraordinally efficient nuclear fuel (i.e. allows longer fuel burn-up) • Produces more neutrons per collision; thus 20-40 times more energy is generated, less fuel consumed and 47
times less radioactive nasties left behind. • Th fuel is completely used up in the reactor; thus, there is relatively little nuclear waste. • Th waste needs to be stored for only few hundred years (as long as 300 years) not for a few thousand (10000
years) like U wastes. • Th reactors has zero risk of melt down as opposed to U reactors. • Th reactors can use liquid fuel which has significant advantages in operation, control and processing over
solid fuels. • Liquid fuels works at high temperature without pressurization.
“Th should be heart of the nations’ atomic power effort”
WHY Thorium ? (New Era of Safe, Clean and Affordable Energy)
There is a treat of climate change, There is an urgent demand for carbon-free energy/electricity.
• Th is 3-4 times more abundant than U in nature and distrubuted evenly in most
countries in the world. • Th can be mined with relatively low-cost and environment friendly mining
methods from high grade alluvial deposits. • Th extraction is relatively straightforward. • Th has a better radiation stability and longer fuel cycle. • Th has a higher energy density and fuel economy. • Th wastes have a less radiotoxic period due to absence of transuranic wastes
(i.e. Pu, Np, Ce and Am). • Th mixed oxide (TMOX (Pu+Th)) fuel can be burned in any reactor that is
lisenced to use MOX. • There is a huge spent toxic material/plutonium that has being piled up from U-
fuel. Th fuel can be used to safely incinerate these unwanted stockpiles. Global energy needs for one year can be supplied by approximately 6600 tons of Th.
URANIUM
(Today’s problematic nuclear fuel)
• Today’s prefered fuel in commercial reactors, • U has been adequate to meet today’s supply needs, • Reserve: 5.5*106 tons; Yearly Production: 65*103 tons, • Producers: 19; Life Expectancy: 50-60 years • U ores are generally not harmful, but is dangerously toxic to humans if
ingested, inhaled or even of prolonged contact. • Reactors requires exteremely rare 235U (0.7%) which must be purified/
enriched from natural 238U. • U mining, enrichment and extraction are expensive and complex, • U-fuel leaves large amount of toxic wastes containing Pu-239 that can be
used in making bombs and weapons, • The used/depleted fuel can be reprocessed by expensive Pu-U extraction
(Purex) process to remove fissile material and refabricate new fuel elements,
R&D on U will fade away in favour of Th.
Country RAR Th
(tonnes)
EAR Th
(tonnes)
Brazil 606,000 700,000
Turkey 380,000 500,000
India 319,000 -
United States 137,000 295,000
Norway 132,000 132,000
Greenland 54,000 32,000
Canada 45,000 128,000
Australia 19,000 -
South Africa 18,000 -
Egypt 15,000 309,000
Other
Countries
505,000 -
World Total 2,230,000 2,130,000
Reasonably Assured Reserves (RAR) and Estimated Additional Reserves (EAR) of thorium by OECD/NEA, Nuclear Energy, "Trends in Nuclear Fuel Cycle",
Paris, France (2001). (http://en.wikipedia.org/wiki/Thorium)
Th containing Rare Earth Elements (REE)s
• Phosphate Mineral Formula Density (g/cm3) Magnetic Property Weight (%)
• REO ThO2 UO2
• Monazite (Ce) (Ce, La, Nd, Th)PO4 4.98-5.43 Paramagnetic 35-71 0-20 0-16
• Monazite (La) (La, Ce, Nd, Th)PO4 5.17-5.27 Paramagnetic 35-71 0-20 0-16
• Monazite (Nd) (Nd, Ce, La, Th)PO4 5.17-5.27 Paramagnetic 35-71 0-20 0-16
• Silicate Mineral Formula Density (g/cm3) Magnetic Property Weight (%)
• REO ThO2 UO2
• Thorite (Th, U) SiO4 6.63-7.20 Paramagnetic <3 - 10-16
• Carbonate Mineral Formula Density (g/cm3) Magnetic Property Weight (%)
• REO ThO2 UO2
• Basnasite (Ce) (Ce, La,Th)(CO3)F 4.90-5.20 Paramagnetic 70-74 0-0.3 0.09
• Basnasite (La) (La, Ce, Th)(CO3)F Paramagnetic 70-74 0-0.3 0.09
• Basnasite (Y) (Y)(CO3)F 3.90-4.00 Paramagnetic 70-74 0-0.3 0.09
MONAZITE (REE-Th PO4)
• A phosphate mineral with Rare Earth Oxide (REO) content of 70% (Ce, La, Pr and Nd).
• Monazite is found in granites, syanites, pegmatites, beach sands etc.
• World monazite resources are estimated to be about 12 million tons.
• Includes 3-14% Th and variable amount of U.
• Found in placer deposites, beach sands and is also a component of the Bayan Obo deposit in China.
• World monazite production is between 5000-6000 tons/y.
• Major Monazite producers are Mt Weld (Australia), (Andhra Pradesh, Tamil Nuda, Odisha) India and Guandong (China), Malaysia and Brazil.
ThO2 Mining from Monazite
• Th from monazite deposits can be mined with realtively low-cost and environment friendly mining methods, because it exists in high concentrations and in high-grades at the surface or in beach sands.
• The ore/sand can be skimmed off the surface by dredge mining.
• Monazite mining is more economical due to presence of Th as a by-product in the REE ore.
• U mine can be developed in 10-15 years, Th mine can be developed in 2-3 years due to less requlatory scrutiny.
• ThO2 is liberated from monazite by gravitational, magnetic and electrostatic concentration methods, employing a minimum of dangerous chemicals (i.e. acids). Whereas U is mined by expensive underground mining and in-situ acid leaching methods.
BEACH SAND (Quartz, Garnet, Magnetite, Zircon, Ilmenite, Rutile, Monazite)
Quartz: 2.7 (L) Garnet:3.5 (L) Magnetite: 5.5-6.5 (D, F) Zircon: 4.6-4.7 (D, NM, P) Rutile: 4.2 (D, NM, T) Ilmenite: 4.5-5.0 (D, M, T) Monazite: 4.9-5.2 (D, M, P)
L: light D: Dense F: Ferromag. NM: Nonmag. M: Mag. T:Thrown P: Pinned
Typical beach sand treatment flowsheet.
ligth
heavy
REEs+Th
BASTNASITE (REE-ThFCO32)
• A fluorocarbonate mineral with a REO content of approximately 70% (Ce, La, Pr and Nd).
• Basnasite is the primary source of ligth REOs and accounts for 80% of the overall amount of REO in the world.
• In the last 50 years basnasite replaced monazite as a chief mineral source of REEs.
• Basnasite has been extracted on a large scale only in Mountain Pass, USA and Bayan Obo, China (supply 45% of world demand).
• Expensive underground mining methods are used.
• Processing depends on fine grinding; gravity, magnetic and flotation separations; calcination, HCl leaching and solvent extraction steps.
Uranium and Thorium Deposits of Turkey
Black Sea
Mediterranean Sea
Ankara
Eskisehir
Sivrihisar-Eskisehir Ligth REE+Th
Deposit
Typical TREO content
1
10
100
1000
10000
100000B
ayan
Obo
Nio
be
c
Kva
ne
fje
ld
Ne
cha
lach
o
Ng
ua
lla
Mo
ntv
iel
Stra
ng
e L
ake
Eld
or
Mt W
eld
…
Mt
Pa
ss
Esk
ise
hir
Za
nd
kop
sdri
ft
Be
ar
Lod
ge
No
lan
s
Du
bb
o
Two
To
m-…
Mt W
eld
…
No
rra
Ka
rr
Ara
xa
Sarf
art
oq
Ka
ng
an
kun
de
TR
E
Kip
aw
a-Z
eu
s
Foxt
rot
Cu
mm
ins …
Wig
u H
ill
Ha
stin
gs
Bu
ckto
n
Ho
ida
s La
ke
Eco
Rid
ge
Cla
y H
ow
ell
s
Ku
tess
ay
II
La P
az
Ca
na
kli I
Na
rra
bu
rra
Ste
en
kam
ps…
Bo
kan
Xilu
vo
Ela
ine
-Ma
ry …
TR
EO
Co
nte
nt
(Kt)
Kaynak: Greenfields Research Ltd; (Data: Company websites)
1st Quartile
Comparison of some REO Deposits according to Reserve Size
13
11.
Reserve Development Studies in Eskişehir-Sivrihisar-Kızılcaören Light REEs+Th Field
• First reserve calculations depended on 50-200 m deep drilling studies in 1959. • In 2011, two 500 m deep drilling bores were opened. • Analyses showed further reserves at deeps. •In 2012; 10,000 m drilling were performed at 38 locations . •Between 2014 and 2017; 116,000 m drilling will be performed at 289 locations. •45,000 samples will be taken for geochemical and 1,000 samples will be taken by XRD analyses.
15
Exploration with drilling
Drilling cores
Eti Mines Eskişehir-Sivrihisar Deposit’s Operation Plan
• Mineral: Bastnasite
• Ore Charecteristic: Complex, finely disseminated,
• Ores: Layers, lenses and veins besides impregnation and brecciated zones (Hydrothermal deposit).
• Area: 1,758 hectare
• Reserve: 30,358,268 ton
• Mineral Grade Distribution:
• 37.44 % CaF2,
• 31.04 % BaSO4 and
• 3.14 % REE (Ce (2.01%)+La (1.5%)+ Nd (0.39))
• 0.21% ThO2
• Along with psilomelan, ilmenite, rutil and some mica minerals.
• Proved + Probable Mineral Reserve (1977) Distribution (ton)
• Florite: 11,366,135 tons
• Barite : 9,424,424 tons
• REE: 953,587 tons (CeO2+La2O3+Nd2O3)
• Thorium: 380,000 tons
• Gangue: 8,612,182 tons.
• Eti Mine prepared a feasibility report for;
• 10,000 ton/y REO
• 72,000 ton/y Barite
• 70,000 ton/y Florite
• 250 ton/y Thorium production.
• Mining: Open pit mining will be carried out by Eti Mines of Turkey
• Mineral Processing/Enrichment: Performed by Domestic and/or Foreign private expert company with service procurement tender for 10 years.
• Products: Marketed by Eti Mines. ThO2 will be stored.
16
Operating license owned by Turkish Government Mining Company of Eti Mines for 10 years
Deposit discovered using air prospecting survey by General Directorate of Mineral Research and Exploration of Turkey
(MTA) in 1959.
Ore Properties Production Plan
MONOZITE CRACKING/OPENING WITH HOT CONCENTRATED H2SO4
Th has been extracted from monazite through a complex multi-stage process (AMEX). Monazite is dissolved in 120-150 oC hot concentrated H2SO4 for several hours. Th is extracted as an insoluable residue into an organic phase containg an alkyl amine. Then it is separated/ stripped using an ion such as nitrate, chloride, hydroxide or carbonate returning Th to an aqueous phase. Finally Th is precipiteted and collected.
Th extraction is a complex process because of similar chemical properties with REOs.
Ammonium oxalate
Th+REOs
RE oxalates Filtering
THORIUM CONCENTRATION FLOWSHEET
• ORE
• HNO3 or H2SO4 LEACHING (pH:1.2)
• Precipitation of some impurities
• Solvent Extraction (SX) or Ion Exchange (IE)
• Th(NO3)4.nH2O
• Drying (105 oC, 20h) Water
• Th(NO3)4
• Calcination (575oC)
• ThO2 concentrate
ION EXCHANGE RESINE BEADS
EFFECTS OF ROASTING and THIOUREA ADDITION on BASTNASITE LEACHING
(Yörükoğulları, Obut, Girgin, 2002 and 2003)
1. Pre-concentration Scrubbing (75% solids, N: 2060 rpm, t: 15 min.) BaSO4 Flotation Pre-Concentrate (21.3% REO) CaF2 Flotation
2. Bastnasite Pre-Concentrate Leach Particle Size: 0.053 mm N: 450 rpm REEs in solution were analysed by ICP spectrometer. Ba and high S/L: 1/20 g/mL t: 6 hours concentration REE were anaysed by gravimetric methods based
on sulphate and oxalate precipitation.
2a. Leaching without Roasting using Concentrated Acids 8M HNO3 70oC 100% total REE dissolution
15 M H2SO4 25oC 89.25% 2.5M HCl 55oC 82.2% 2b. Roasting+Dilute Acid Leaching After roasting at 750oC for 1 h, leaching with 1-3M H2SO4 at 25oC. (Roasting decomposes carbonates and oxidize Ce). Total REE contents for unroasted: 18.59%, roasted: 22.00% and roasted+leached 47.4%. 2c. Roasting+Dilute Acid Leaching and Thiourea Addition (extracting agent for Au, Ag and REE) Thiourea conc.: 0-2 M and 1-3 M H2SO4 Roasted without thiourea: 17.6% REE dissolution Roasted with thiourea: 89.0% dissolution
(at 3M H2SO4 and 1M thiourea)
3. Hydroxide-Oxalate Mixture Precipitation (Mish metal) from Leach Solution+ Heating to 900oC for 2 hours Total REE 93.6%, REO: 92.6%
EFFECTS OF ROASTING and THIOUREA ADDITION on BASTNASITE LEACHING
(Yörükoğulları, Obut, Girgin, 2002 and 2003)
• Roasting decomposes the flurocarbonate structure of REEs in the preconcentrate with the formation of fluocerite and cerianite as new phases (XRD results).
• This change in composition increases the selective dissolution of lanthanum and neodymium in H2SO4 solution causing 5.6 times increase in the total REs dissolution.
• Addition of thiourea (CS(NH2)2) to the leaching medium increases the dissolution of total REEs in the unroasted and especially in the roasted pre concentrate reaching a dissolution of 89%.
• 92.6% mixed REO precipitation with H2SO4-thiourea medium was achived.
PİLOT SCALE ACID LEACH and SOLVENT EXTRACTION TESTS
for REEs and Th from ESKISEHIR ORE by MTA (2004)
Particle size: - 1mm; Oxidizing Roasting Temperature: 600-900oC; t: 1-6 hours Leach: 3 M H2SO4 REE dissolution: 86% (Ce, La, Nd ve Th) and 3 M HCl REE dissolution: 92% (Ce, La, Nd ve Th) (89% REO mishmetal) Oxalate Precipitation: Th Grade: 98.7% , Th Recovery: 98%
Blending
Jaw Crusher
Cone Crusher
Roll Crusher
Rotating Furnace
Oxidizing Roasting
3M HCl acid leach
Filtration
Cake Filtrate Solution
Flotation Oxalate precipitation
REOs+ThO2
Run-of-mine ores from 3 districts
93% BaSO4
84% CaF2
98.7% Th(N03)4
84.2% Ln(OH)3
84%CeO2
The Effects of Particle Size and Roasting Time on Thorium Recovery during H2SO4 and HCl Leaching (Yorukoglu et.al., 2012)
• Sample: 3 t representative homogenized
• Particle Sizes Tested: 0.065, 0.2, 1 and 3 mm
• Oxidizing Roasting Temp. and Time: 900 oC and 1, 3 and 6 hours
• Leaching: 3 M H2SO4 and 3 M HCl, 3 h, 25oC, separately
• Leaching Recovery: (REEs + Th) %
R = 79%, 1 mm, 1h R = 73%, 1 mm, 3 h
3 M H2SO4
3 M HCl
The Effects of Particle Size and Roasting Time on Thorium Recovery during H2SO4 and HCl Leaching (Yorukoglu et.al., 2012)
• 3 M H2SO4 gives better leaching recovery than HCl.
• H2SO4 is cheaper than HCl.
• Oxidizing roasting at 900 oC at 1 hour, before athmosferic leaching is necessary.
• The best particle size for leaching is 1 mm.
• 79% (REEs+Th) dissolution can be achieved.
CONCLUSIONS from TURKEY’S POINT OF VIEW
• Energy is major concern for developing Turkish society. Turkey today exports more than 70% of its energy as fossil fuels. In the last 50 years, Turks are sceptical, anxious and indecisive about having nuclear energy.
• In the last 10 years, we are bringing Th into Turkish government’s attention and national discussion as a new, safe, clean, affortable, CO2-free, alterternative, strategic and domestic nuclear energy fuel.
• In Turkey, we are trying to find funds to support education and R&D on Th. We are expecting to establish Thorium Research Center /ThoReC) in Turkey for Th mining+enrichment+extraction+fuel fabrication+prototype reactor testing+nuclear fuel cycle testing.
• Turkey recently contacted four VVER-1200 type Russian Nuclear Power Reactors using U as a fuel in Akkuyu (Rosatom) and another four units will be established in Sinop in the next decade by Japan (Mitsubishi-Westinghouse). We will enforce government to use Th along with U as an alternative fuel in the new reactors.
• If Turkey can process it’s important domestic low grade bastnasite resource in Eskisehir for Th, it can suppy its own Th fuel for more than 100 years and become self-sufficient in energy sources.
Comparing Reactors
U Fueled Light Water Reactor
U+Th Seed and Blanket Reactor
Th Liquid Fluoride Reactor
Fuel U fuel rods Th+U oxide rods Th+U fluoride solution
Fuel input per GW output *
250 tons raw U 2.4 tons raw Th + 177 tons raw U
1 ton raw Th
Annual fuel cost for 1 GW reactor
$50-60 million $50-60 million $10000
Coolant Water Water Self requlating (FLiNaK) salt/gas
Proliferation potential
Medium None None
Footprint 200000-300000 ft2 surrounded by a low-density population zone
200000-300000 ft2 surrounded by a low-density population zone
2000-3000 ft2
With no need for a buffer zone.
Richard Martin (2009) * equvalent energy from 3.5 million tons of coal
Dünya enerji ihtiyacını toryum tek başına 6600 ton ile karşılayabilecektir.
MINERAL GRAIN SIZE (micron) CONTENT (%)
Fluorite 2-4000 38-45
Barite 10-1400 19-36
Bastnasite 7-26 7-26
Opak Minerals 12-1200 20-22
REE and Th are in fine size fraction
HCl Leaching of Sivrihisar Bastnasite Ore (Gülmez et.al., 2012)
• Sample: 3 t representative homogenized
• Particle Sizes Tested: 0.065, 0.2, 1 and 3 mm
• Leaching: 3 M H2SO4 and HCl, 3 h, 25oC, separately
• Leaching Recovery: 92.09 % ( REE + Th)
• Mishmetal concentrate: 73.8% REE/89.4%REO (saleable)
F BaO CeO2 La2O3 Nd2O3 ThO2 SO3 Ca
20.80 20.80 2.01 1.5 0.4 0.1 12.1 20.3
F BaO CeO2 La2O3 Nd2O3 ThO2 SO3 Fe2O3
25.10 22.30 0.50 0.40 0.10 0.013 13.6 3.60
HCl Leaching Tailing Chemical Analyses
Chemical Analyses of Composite Sample
MONAZITE ALKALINE CRACKING and AUTOCLAVING WITH NaOH
Hot 73% NaOH solution is used to crack/open monazite sand. After addition of cold water Na-phosphate is removed from the solution. REO and Th(OH)4 in solid residue were leached with HCl (pH: 3-4) . Dewatered mishmetal RE chlorides are produced with electrolitic reduction. Using liquid-liquid extraction with Chelating reagents can give 99.99% pure products.
Th recovery from monazite usually involves leaching with NaOH at 140oC followed by complex processes to precipitate pure ThO2
THORIUM CONCENTRATION STUDIES
BEDRI IPEKOGLU (Ph.D Thesis, 1983)
SİVRİHİSAR-ESKISEHIR
ORE
GRAVITY CONCENTRATION
MAGNETIC CONCENTRATION
FLOTATION
ACID LEACHING
Optimum Conditions:
HCl dosage: 200kg/t
Leaching Time: 3 hours
Th Grade: %99
ACID TOREX PROCESS
ThO2 recovery from used (U233/Th) fuel
Hot acid leach
(13M HNO3, 0.05M HF, 0.1M Al nitrat at boiling temperature)
Centrifuging Solid residue
Th(NO3)4 + UO2(NO3)2
Solution
SX Columns
Purification
Tributyl phosphate (TBP)