HCD-GN88D - Diagramas Electrónicos Para Reparararchivos.diagramas.mx/audio/HCD-GN88D-1.3.pdfMiNi Hi-Fi COMPONENT SYSTEM E Model Australian Model HCD-GN88D Ver 1.3 2004.06 9-877-457-04

SERVICE MANUAL

Model Name Using Similar Mechanism NEW

DVD DVD Mechanism Type CDM74D-DVBU23

Section Base Unit Name DVBU23

Optical Pick-up Name TDP022W

TAPEModel Name Using Similar Mechanism HCD-GN800

Section Tape Transport Mechanism Type CWM43RR23

MiNi Hi-Fi COMPONENT SYSTEM

E ModelAustralian Model

HCD-GN88DVer 1.3 2004.06

9-877-457-04 Sony Corporation2004F02-1 Home Audio Company

C 2004.06 Published by Sony Engineering Corporation

SPECIFICATIONS

HCD-GN88D is the amplifier, DVDplayer, tape deck and tuner section inMHC-GN88D.

– Continued on next page –

Amplifier sectionThe following are measured at AC 120, 127, 220, 240V 50/60 HzDIN power output (rated)Front speaker: 185 + 185 watts

(6 ohms at 1 kHz, DIN)Center speaker: 50 watts

(8 ohms at 1 kHz, DIN)Surround speaker: 50 + 50 watts

(8 ohms at 1 kHz, DIN)

Continuous RMS power output (reference)Front speaker: 235 + 235 watts

(6 ohms at 1 kHz, 10% THD)Center speaker: 70 watts

(8 ohms at 1 kHz, 10% THD)Surround speaker: 70 + 70 watts

(8 ohms at 1 kHz, 10% THD)InputsGAME (VIDEO): 1 Vp-p, 75 ohms(phono jack)GAME (AUDIO): Voltage 250 mV,(phono jacks) impedance 47 kilohmsMD/VIDEO (AUDIO) IN: voltage 450 mV/250 mV,(phono jacks) impedance 47 kilohmsMIC: sensitivity 1 mV,(phone jack) impedance 10 kilohms

OutputsAUDIO OUT: Voltage 250 mV(phono jacks) impedance 1 kilohmsVIDEO OUT: max. output level 1 Vp-p,(phono jack) unbalanced, Sync.

negative load impedance75 ohms

COMPONENT VIDEOOUT: Y: 1 Vp-p, 75 ohms

PB/CB: 0.7 Vp-p, 75 ohmsPB/CR: 0.7 Vp-p, 75 ohms

S VIDEO OUT(4-pin/mini-DIN jack): Y: 1 Vp-p, unbalanced,

Sync negativeC: 0.286 Vp-p loadimpedance 75 ohms

PHONES: accepts headphones of(stereo mini jack) 8 ohms or moreFRONT SPEAKER: accepts impedance of 6 to 16 ohmsSUBWOOFER OUT: Voltage 250 mV(phono jack) impedance 1 kilohmsSURROUND SPEAKER: accepts impedance of

8 ohms to 16 ohms

CENTER SPEAKER: accept impedance of8 ohms to 16 ohms

HCD-GN88D

2

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

Flexible Circuit Board Repairing• Keep the temperature of the soldering iron around 270 ˚C dur-

ing repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous ra-diation exposure.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTEDLINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMSAND IN THE PARTS LIST ARE CRITICAL TO SAFEOPERATION. REPLACE THESE COMPONENTS WITHSONY PARTS WHOSE PART NUMBERS APPEAR ASSHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-LISHED BY SONY.

This appliance is classified asa CLASS 1 LASER product.The CLASS 1 LASERPRODUCT MARKING islocated on the rear exterior.

Disc player sectionLaser Semiconductor laser

(DVD: λ = 650 nm, CD: λ = 780 nm)Emission duration: continuous

Frequency response DVD (PCM 48 kHz): 2 Hz – 22 kHz = (±1dB)CD: 2 Hz – 20 kHz (±0.5 dB)

Video color system format NTSC, PAL(except Latin American models)DVD DIGITAL OUT (OPTICAL)(Square optical connector jack, rear panel)Wave length 660 nm

Tape player sectionRecording system 4-track 2-channel stereoFrequency response 50 – 13,000 Hz (±3 dB), using Sony TYPE I

cassette

Tuner sectionFM stereo, FM/AM superheterodyne tuner

FM tuner sectionTuning range 87.5 – 108.0 MHzAntenna FM lead antennaAntenna terminals 75 ohm unbalancedIntermediate frequency 10.7 MHz

AM tuner sectionTuning rangeNorth and Latin American models:

530 – 1,710 kHz(with the interval set at 10 kHz)531 – 1,710 kHz(with the interval set at 9 kHz)

Saudi Arabian models: 531 – 1,602 kHz(with the interval set at 9 kHz)

Other models: 531 – 1,602 kHz(with the interval set at 9 kHz)530 – 1,710 kHz(with the interval set at 10 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz

GeneralPower requirementsMexican models: 127 V AC, 60 HzArgentina models: 220 V AC, 50/60 HzAustralia models: 230 - 240 V AC, 50/60 HzSaudi Arabian Models: 120 - 127 V, 220 V or 230 - 240 V AC, 50/60 Hz

Adjustable with voltage selectorThai models: 220 V AC, 50/60 HzOther models: 120 V, 220 V or 230 - 240 V AC, 50/60 Hz

Adjustable with voltage selector

Power consumption 320 watts

Dimensions (w/h/d) Approx. 280 x 360 x 386.5 mm

Mass : Approx. 15.2 kg

Design and specifications are subject to change without notice.

Unleaded solderBoards requiring use of unleaded solder are printed with the lead-free mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size.)

: LEAD FREE MARK

Unleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40°C higher

than ordinary solder.Ordinary soldering irons can be used but the iron tip has tobe applied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be setto about 350°C.Caution: The printed pattern (copper foil) may peel away ifthe heated tip is applied for too long, so be careful!

• Strong viscosityUnleaded solder is more viscous (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded soldermay also be added to ordinary solder.

HCD-GN88D

3

TABLE OF CONTENTS

1. SERVICING NOTES ................................................ 4

2. GENERALLocation of Controls ....................................................... 5

3. DISASSEMBLY3-1. Case ................................................................................. 83-2. Loading (Panel) ............................................................... 83-3. Front Panel Assy ............................................................. 93-4. Tuner Pack, Sub Trans Board ......................................... 93-5. DVD Mechanism Deck ................................................... 103-6. Game In Board, Tape Mechanism Deck ......................... 103-7. CD Switch Board, Display Board .................................. 113-8. Volume Board .................................................................. 113-9. Back Panel, Subwoofer Board ........................................ 123-10. Main Board ...................................................................... 123-11. Power Amp Board ........................................................... 133-12. Video Board, DMB03 Board, Regulator Board ............. 133-13. SW Board, Driver Board ................................................ 143-14. RF Board, Pick-up Unit .................................................. 143-15. Sensor Board ................................................................... 153-16. Motor (TB) Board ........................................................... 153-17. Motor (LD) Board ........................................................... 16

4. TEST MODE .............................................................. 17

5. MECHANICAL ADJUSTMENTS ....................... 19

6. ELECTRICAL ADJUSTMENTSDeck section .................................................................... 19Video Section .................................................................. 22

7. DIAGRAMS7-1. Circuit Board Location ................................................... 247-2. Block Diagram – DVD DSP (1/2) Section – ................ 26

Block Diagram – DVD DSP (2/2) Section – ................ 27Block Diagram – Tuner/Tape Deck Section – ............... 28Block Diagram – Main Section – .................................. 29Block Diagram – Amp Section – ................................... 30Block Diagram – Display Section – .............................. 31

7-3. Printed Wiring Board – RF Board – .............................. 327-4. Schematic Diagram – RF Board – ................................. 337-5. Printed Wiring Board – DVD Mechanism Board – ...... 347-6. Schematic Diagram – DVD Mechanism Board – ......... 35

7-7. Printed Wiring Board – DMB03 Board (Side A)– ........ 36Printed Wiring Board – DMB03 Board (Side B)– ........ 37

7-8. Schematic Diagram – DMB03 Board (1/8) – ................ 387-9. Schematic Diagram – DMB03 Board (2/8) – ................ 397-10. Schematic Diagram – DMB03 Board (3/8) – ................ 407-11. Schematic Diagram – DMB03 Board (4/8) – ................ 417-12. Schematic Diagram – DMB03 Board (5/8) – ................ 427-13. Schematic Diagram – DMB03 Board (6/8) – ................ 437-14. Schematic Diagram – DMB03 Board (7/8) – ................ 447-15. Schematic Diagram – DMB03 Board (8/8) – ................ 457-16. Printed Wiring Board – Video, Regulator Board – ....... 467-17. Schematic Diagram – Video, Regulator Board – .......... 477-18. Printed Wiring Boards – Main Board – ......................... 487-19. Schematic Diagram – Main Board (1/4) – .................... 497-20. Schematic Diagram – Main Board (2/4) – .................... 507-21. Schematic Diagram – Main Board (3/4) – .................... 517-22. Schematic Diagram – Main Board (4/4) – .................... 527-23. Printed Wiring Boards

– Game In, CD Switch Board – ...................................... 537-24. Schematic Diagram

– Game In, CD Switch Board – ...................................... 547-25. Printed Wiring Board – Display Board – ...................... 557-26. Schematic Diagram – Display Board – ......................... 567-27. Printed Wiring Board – Power Amp Board – ................ 577-28. Schematic Diagram – Power Amp Board – .................. 587-29. Printed Wiring Board – Surround Board – .................... 597-30. Schematic Diagram – Surround Board – ....................... 607-31. Printed Wiring Boards – Trans Board – ........................ 617-32. Schematic Diagram – Trans Board – ............................. 627-33. IC Block Diagram ........................................................... 637-34. IC Pin Function Description ........................................... 68

8. EXPLODED VIEWS8-1. Case, Back Panel DMB03 Board Section ...................... 798-2. Front Panel Section ......................................................... 808-3. Chassis Section ............................................................... 818-4. DVD Mechanism Deck Section-1

(CDM74D-DVBU43) ..................................................... 828-5. DVD Mechanism Deck Section-2

(CDM74D-DVBU43) ..................................................... 83

9. ELECTRICAL PARTS LIST ............................... 84

4

HCD-GN88DSECTION 1

SERVICING NOTES

NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT

The laser diode in the optical pick-up block may suffer electro-static break-down because of the potential difference generatedby the charged electrostatic load, etc. on clothing and the humanbody.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focusedon the disc reflective surface by the objective lens in the opticalpick-up block. Therefore, when checking the laser diode emis-sion, observe from more than 30 cm away from the objective lens.

LASER DIODE AND FOCUS SEARCH OPERATIONCHECKCarry out the “S curve check” in “CD section adjustment” andcheck that the S curve waveforms is output three times.

• MODEL IDENTIFICATION– Back Panel –

MODEL PART No.

E3, E15 models 4-246-186-0[]

SP model 4-246-186-1[]

MY model 4-246-186-2[]

EA model 4-246-186-3[]

E51 model 4-246-186-4[]

MX model 4-246-186-5[]

TH model 4-246-186-6[]

AUS model 4-246-186-7[]

PH model 4-246-186-8[]

• AbbreviationAUS : Australian modelE3 : 240 V AC Area in E modelEA : Saudi Arabia modelE15 : Iran modelE51 : Chilean and Peruvian modelMX : Mexican modelPH : Philippines modelSP : Singapore modelMY : Malaysia modelTH : Thai model

PART No.

DVD TRAY LOCK MODE• This mode let you lock the disc trays. When this mode is acti-

vated, the disc tray will not open when Z OPEN/CLOSE but-

ton or [DISC SKIP/EX-CHANGE] button is pressed. The mes-sage “LOCKED” will be displayed in the will be displayed onthe fluorescent indicator tube.

Procedure:1. Press ?/1 button to turn the set ON.2. Select DVD function.

3. Press x button and Z OPEN/CLOSE button simultaneouslyand hold down until “LOCKED” or “UNLOCKED” displayedon the fluorescent indicator tube (around 5 seconds).

NOTES ON DMB03 BOARD EXCHANGEIf a DMB03 board is exchanged, “DRIVE AUTO ADJUSTMENT”may be unable to be performed. In this case, initialize a memory inthe following procedure.

1. Starting Test Mode (see Supplement-1 page 2).2. Press the 2 button of remote commander to set the Drive

Manual Operation (see Supplement-1 page 4).3. Press the 6 button of remote commander to set the Memory

Check (see Supplement-1 page 6).4. Press the [CLEAR] button of remote commander to initialize

a memory.

Ver 1.3

5

HCD-GN88DSECTION 2GENERAL

ALBUM +/– qgAMP MENU rhCD SYNC qkDECK A e;DECK B wfDIRECTION9DISC 1~3 3DISC SKIP EX-CHANGE 4Disc tray 6DISPLAYrfDisplay 2DVD rdDVD MENU qjDVD TOP MENU 9

ECHO LEVEL whEFFECT ON/OFF rj FM MODE 8GAME elGAME EQ edGAME INPUT (jacks) wlGAME MIXING ejGROOVEeg

ILLUMINATION eaIR (receptor) rgKARAOKE/MPX ehMD (VIDEO) r;MIC (jack) wkMIC LEVEL wjMOVIE EQ qhMULTI CHANNEL DECODING

(indicator) rkMUSIC EQ ek

ALPHABETICAL ORDER

A - D

wl

r;

e;

ra

eaes

ed

ejeh

efeg

elek

rg

rsrd

rf

rjrk

rh

wgwhwjwk

qsqdqf

qgqh

qkqj

w;ql

waws

wd

wf

0qa

45 61 2 3

78

9

Main unit

O - R

E - G

OPEN/CLOSE Z5P FILE wsPHONES (jack) wgPLAY MODE 7Power illuminator esPUSH ENTER q;REC PAUSE/START qlREPEAT8

SOUND FIELD waTAPE A/B raTUNER/BANDrsTUNER MEMORY7VOLUME wd

SYMBOLS

@/1 (power) 1hH (play) qax (stop) qsX (pause) qd– . (go backward) qf> + (go forward) qfm (rewind) qgM (fast forward) qgV/v/B/b q;A A (Deck A) efA B (Deck B) w;

H - M

S - Z

This section is extracted frominstruction manual.

6

HCD-GN88D

Remote Control

0

6

qs

9

qa

78

12 345

qd

qg

ql

qf

qh

qk

w;

wfwg

wh

wkwl

e;

ea

eg

es

ef ed

ek

eh

elr;

rfrd

rs

rgrh

ej

ra

wd

wj

wswa

qj

rjrlrk

ALBUM +/– egAMP MENU rdANGLE wdAUDIO wfCLEAR qdCLOCK/TIMER SELECT 2CLOCK/TIMER SET 3D.SKIP qaDISPLAY rfDVD rkDVD DISPLAY rsDVD MENU edDVD SETUP r;DVD TOP MENU ef

EFFECT ON/OFF waENTER eaGAME rjGAME EQ e;GAME MIXING rhGROOVE qlKEY CONTROL #/2 wjMD (VIDEO) rgMUSIC EQ esMOVIE EQ wgNEXT ejNumeric button q;

P FILE wkPLAY MODE qfPRESET + ejPRESET – ekPREV ekREPEAT qsRETURN O el

SELECT qgSOUND FIELD w;SUBTITLE wsSLOW / qjSLEEP1

A - D

ALPHABETICAL ORDER

SYMBOLS

@/1 (power)5x (stop) qkX (pause) qhnN (play) qg> (go backward) ej. (go forward) ekM/m (fast forward/ rewind) eh

M/m/</, wl>10 ra

TAPE A/B 6TUNER BAND rlTUNING +/– ehTV CH +/– 8TV VOL +/– 7TV/VIDEO9TV :/1 4VOL +/– wh

E - N

O - S

T - Z

This section is extracted frominstruction manual.

7

HCD-GN88D

• This set can be disassembled in the order shown below.

SECTION 3DISASSEMBLY

CASE

LOADING (PANEL)

SET

FRONT PANEL ASSY

CD SWITCH BOARD,DISPLAY BOARD

RF BOARD, PICK-UP UNIT

VOLUME BOARD

SW BOARD,DRIVER BOARD

DVD MECHANISM DECK GAME IN BOARD, TAPE MECHANISM DECK

TUNER PACK,SUB TRANS BOARD

BACK PANELSURROUND BOARD

MAIN BOARD

POWER AMP BOARD

VIDEO BOARD,DMB03 BOARD,

REGULATORBOARD

8

HCD-GN88D

Note: Follow the disassembly procedure in the numerical order given.

3-1. CASE

3-2. LOADING (PANEL)

1 Three screws (case 3 TP2)

2 Five screws (+BVTT3 x 6)

7 Case

5 Slightly push down the edge of front panel not to break the catcher.

6

4

1 Three screws (case 3 TP2)

3 Two screws (+BVTT3 x 6)

Catcher

CD mechanismdeck (CDM74-K6BD47S)1 Turn the pulley to the arrow direction.

Front side

Pulley

4 Loading (panel)

3

2 Pull out disc tray

9

HCD-GN88D

3-3. FRONT PANEL ASSY

3-4. TUNER PACK, SUB TRANS BOARD

3 Screw (BVTP3 x 10)

2 Four screws (BVTP3 x 10)

8 Front panel ASSY

5 From CN606 on Game in board

4 From deck B head

CN402

CN304

6 From deck A head

7 From CN607 on Game in board

1 Two wires (flat type)

3 Screw (BVTP3 x 10)

MAIN board

8 Sub trans board

4 CN971

5 CN9746 CN976

1 Wire (flat type) (11 core)

3 Tuner pack 2 Two screw (BVTP3 x 10)

7 Three screws (BVTP3 x 10)

10

HCD-GN88D

3-5. DVD MECHANISM DECK

3-6. GAME IN BOARD, TAPE MECHANISM DECK

qs DVD mechanism deck


5 Connector (CN711)

3 Two screws (BVTP3 x 10)

1 Three screws (BVTP3 x 10)

2 Three screws (BVTT3 x 6)

6 Connector (CN710)

MAIN board

CN206

CN202

CN203

CN201

qa Connector

q; Connector

9 Connector (CN713)

8 Connector (CN714)


8 Tape mechanism deck

7 Three screws (+BVTP2.6 x 8)

Shield plate (GHX)

2 Screw (+PTT2 x 4)

2 Screw (+PTT2 x 4)

4 Two screws (+BVTP2.6 x 8)



6 GAME IN board

1 Two knobs (MIC)

11

HCD-GN88D

3-7. CD SWITCH BOARD, DISPLAY BOARD

3-8. VOLUME BOARD

1 Six screws (+BVTP2.6 x 8)

4 Five screws (+BVTP2.6 x 8)

3 Wire (flat type) (17 core) from CN604

5 DISPLAY board

4 Five screws (+BVTP2.6 x 8)

2 CD SWITCH board

1 Knob (VOL)

5 VOLUME board3 Three screws (+BVTP2.6 x 8)

3 Three screws (+BVTP2.6 x 8)

4 Four claws

2 Hexagonal nut

12

HCD-GN88D

3-9. BACK PANEL, SUBWOOFER BOARD

3-10. MAIN BOARD

3 Four screws (+BVTP3 x 10)

2 Two screws (+BVTP3 x 10)

1 Two screws (+BVTT3 x 6)

4 Three screws (+BVTP3 x 10)

5 Connector

CN851

MAIN board

6 Back panel with fan

qa Screw (+BVTP3 x 10)

7 Connector

9 Connector

CN303

CN304

8 Connector

qd SURROUND board

qs Bracket (IC)

q; Two screws (+BVTP3 x 16)

CN205


2 Screw (+BVTP3 x 10)

1 Connector

6 MAIN board

MAIN board(CN901, 902)

POWER AMP board(CN503, 504)

Lug

5

4

CN998

TRAN board

13

HCD-GN88D

3-11. POWER AMP BOARD


3 Bracket (HS)



5 Three screws (+BVTP3 x 10)

7 POWER AMP board

1 Connector from CN997

3-12. VIDEO BOARD, DMB03 BOARD, REGULATOR BOARD

1 Flat type wire (CN208)


DVD mechanism deck(bottom view)

2 Flat type wire (CN712, CN105)

8 Two screws (BVTP 3 × 8)

qs Two screws (BVTT 3 × 6)

qdREGULATOR board


3 Three screws (BVTP 3 × 8)

4VIDEO board

5Connector (CN102)

0 Heat sink (DVD)

qa DMB03 board

9 Two screws (BVTP 3 × 8)

14

HCD-GN88D

3-13. SW BOARD, DRIVER BOARD

3-14. RF BOARD, PICK-UP UNIT

9DRIVER board5SW board

6CN704

7CN703

0CN702 (flat type)

8Two screws (+BTTP (M2.6))

4 Screw (+BTTP (M2.6))

1 Screw (+BVTP 3x8)3 Bracket DVD

2 Two screws (+BVTP 3x8)

1 Screw (+BVTP 3x8)

qs Insulator

7

qd Insulator

qa Insulator

qgHolder (DBU) assy

3Flat type wire

4Flat type wire

2Two screws (+BTTP 2.6)5RF board

1Flat type wire

9 Step screw (M)

0 Step screw (M)

6 Floating screw (PTPWH M2.6)

8 Step screw (M)

qf Pick-up unit

15

HCD-GN88D

3-15. SENSOR BOARD

3-16. MOTOR (TB) BOARD

2 Tray

3 Belt (table)

5 Pulley (table)

8 Screw (+BTTP (M2.6))

9 SENSOR board

7 Gear (geneva)

0 CN731

1 Floating screw (+PTPWH M2.6)

6 Floating screw (+PTPWH M2.6)

4 Foating screw (+PTPWH M2.6)

5 Remove the two solderings of motor.

4 MOTOR (TB) board

2 CN742 (flat type)

6 Table motor ASSY (M741)

3 Two screws (+BTTP (M2.6))

1

16

HCD-GN88D

3-17. MOTOR (LD) BOARD

4 Remove the two solderings of motor.3 MOTOR (LD) board

1 Belt (loading)

5 Loading motor ASSY (M751)

2 Two screws (+BTTP (M2.6))

17

HCD-GN88DSECTION 4TEST MODE

[GC TEST MODE]• This mode is used to check the fluorescent indicator tube, LED,

model, destination, software version, volume, key and VACSlevel.

Procedure:

1. Press x button, [AMP MENU] button and [DISC 2] buttonsimultaneously.

2. All LEDs and segments in fluorescent indicator tube are lightedup.

3. When you want to enter the software version display mode,press [DISC 1] button. The model and destination are displayed.

4. Each time [DISC 1] button is pressed, the display changes fromMC version, GC version, CD version, ST version, TA version,TM version and TC version in this order, and returns to the MCversion display.

5. When [DISC 3] button is pressed while the version numbersare being displayed except model and destination, the date ofthe software creation appear. When [DISC 3] button is pressedagain, the display returns to the software version display. When[DISC 1] button is pressed while the date of the software creationis being displayed, the date of the software creation is displayedin the same order of software version display.

6. Press [DISC 2] button, the key check mode is activated.7. In the key check mode, the fluorescent indicator tube displays

“K 0 V 0”.Each time a button is pressed, “K” value increases. However,once a button has been pressed, it is no longer taken into account.“V” value increases in the manner of 0,1, 2, 3 ... if [VOLUME]knob is turned clockwise, or it decreases in the manner of 0, 9,8,7 ... if [VOLUME] knob is turned counter-clockwise.

8. When [DISC 3] button is pressed after all LEDs and segmentsin fluorescent indicator tube light up, the fluorescent indicatortube displays “VACS A + B”. A is VACS level which is triggerby signal level while B is VACS level which is trigger by thermal.Total VACS value would be the sum of A and B.

9. When [DISC SKIP/EX-CHANGE] button is pressed after allLEDs and segments in fluorescent indicator tube light up,alternate segments in fluorescent indicator tube would light up.If you press [DISC SKIP/EX-CHANGE] button again, anotherhalf of alternate segments in fluorescent indicator tube wouldlight up. Pressing [DISC SKIP/EX-CHANGE] button againwould case all segments lights up.

10. To release this mode, press three buttons in the same manner asstep 1, or disconnect the power cord.

[MC TEST MODE]• This mode is used to check operations of the respective sections

of Amplifier, Tuner, and Tape.

Procedure:* To enter MC Test Mode

1. Press x button, [AMP MENU] button and [DISC 3] buttonsimultaneously.

2. The TAPE A and TAPE B segments flash on the fluorescentindicator tube. The function is changed to VIDEO.

* Check of Amplifier

1. When V button is pressed, GEQ increases to its maximum anda message “GEQ MAX” appears on the fluorescent indicatortube.

2. When v button is pressed, GEQ decreases to its minimum anda message “GEQ MIN” appears on the fluorescent indicatortube.

3. When B button or b button is pressed, GEQ is set to flat anda message “GEQ FLAT” appears on the fluorescent indicatortube.

4. When the [VOLUME] knob is turned clockwise even slightly,the sound volume increases to its maximum and a message“VOLUME MAX” appears for two seconds, then the displayreturns to the original display.

5. When the [VOLUME] knob is turned counter-clockwise evenslightly, the sound volume decreases to its minimum and amessage “VOLUME MIN” appears for two seconds, then thedisplay returns to the original display.

* Check of clock frequency1. To check the frequency of clock used to run the clock of the

system, the clock output is available at IC501 pin el (CLOCK-OUT) on the MAIN board during MC test mode.

2. The frequency is 32.768 kHz.

* Tape function1. When a tape is inserted in Deck B and recording is started, the

function is changed to VIDEO automatically. When [CD SYNC]button is pressed during recording in function, ALC (AutomaticLogic Control) is turned on.

2. After recording is stopped by pressing x button, press mbutton will change the function to TAPE B and rewind Tape Buntil the recording start position and playback of Tape B isstarted. If the [REC PAUSE/ START] button is pressed for apause and pressed again to resume recording during recordingtime, when tape deck B is rewind, tape deck B will be rewinduntil the position where the pause is applied.

* AMS Test Mode1. Select the function “TAPE A” or “TAPE B”.2. Select Loop or Relay direction mode by pressing the

[DIRECTION] button. Insert a test tape AMS-110A or AMS-120 to selected tape deck.

3. Press the [AMP MENU] button to enter the AMS test mode.4. After the test tape is rewind to the beginning of the tape, the

AMS+ is checked, and the mechanism is shut off after detectingthe AMS signal twice.

5. Then the AMS- is checked and the mechanism is shut off afterdetecting the AMS signal twice.

6. When the check is complete, a message of either OK or NGappears.

* To release MC Test mode.

1. To release this mode, press ?/1 button.2. The cold reset is enforced at the same time.

18

HCD-GN88D

[COLD RESET]• The cold reset clears all data including preset data stored in the

RAM to initial conditions. Execute this mode when returningthe set to the customer.

Procedure:

1. Press x button, [AMP MENU] button, and ?/1 buttonsimultaneously.

2. The fluorescent indicator tube becomes blank for a while, andthe set is reset.

[VACS ON/OFF]• This mode is used to switch ON and OFF the VACS (Variable

Attenuation Control System).

Procedure:1. Press ?/1 button to turn the set ON.

2. Press [AMP MENU] button and [GAME MIXING] buttonsimultaneously. The message “VACS OFF” or “VACS ON”appears.

[TUNER STEP CHANGE]• The step interval of AM channels can be toggled between 9 kHz

and 10 kHz.

Procedure:1. Press ?/1 button to turn the set ON.

2. Press [TUNER/BAND] button to select the “AM”.

3. Press ?/1 button to turn the set OFF.

4. Press [AMP MENU] button and ?/1 button simultaneously.The system will turn ON automatically. The message “AM 9kSTEP” or AM 10k STEP” appears and thus the channel step ischanged.

[DVD REPEAT 5 LIMIT OFF MODE]• The number of repeat for DVD playback is 5 times when the

repeat mode is “REPEAT ALL”. This mode enables DVD torepeat playback for limitless times.

Procedure:1. Press ?/1 button to turn the set ON.2. Select CD function.

3. Press x button, [REPEAT] button and [DVD] buttonsimultaneously to enter the DVD repeat 5 limit off mode.

4. To release this mode, operate the cold reset. (Refer to the “MCCOLD RESET”)

[DVD SHIP MODE (WITH MEMORY CLEAR)]• This mode moves the optical pick-up to the position durable to

vibration and clears all data including preset data stored in theRAM to initial conditions. Use this mode when returning theset to the customer after repair.


3. Press x button, [AMP MENU] button and [GAME] buttonsimultaneously. The set will power off automatically.

4. After the “STANDBY” blinking display finish, a message“LOCK” is displayed on the fluorescent indicator tube and theDVD ship mode is set.

[DVD SHIP MODE (WITHOUT MEMORY CLEAR)]• This mode moves the optical pick-up to the position durable to

vibration. Use this mode when returning the set to the customerafter repair.


3. Press [DVD] button and ?/1 button simultaneously. The setwill power off automatically.

4. After the “STANDBY” blinking display finish, a message“LOCK” is displayed on the fluorescent indicator tube and theDVD ship mode is set.

[DVD POWER MANAGE]• This mode let you switch on or off power supply to the BU

during TUNER function.• When DVD POWER is set to OFF, the power supply to the BU

is cut off during TUNER function. It will increase the time takento access DVD when function change from TUNER to DVDbut it will improve tuner reception.

• When DVD POWER is set to ON, the power supply to the BUis not cut off during TUNER function. It will reduce the timetaken to access DVD when function change from TUNER toDVD but it will decrease tuner reception performance.


3. Press ?/1 button to turn the set OFF.

4. Press x button and ?/1 button simultaneously. The set willpower on automatically.

5. The message “DVD POWER ON” or “DVD POWER OFF”will be displayed on the fluorescent indicator tube.

[DVD TRAY LOCK MODE]• This mode let you lock the disc trays. When this mode is acti-

vated, the disc tray will not open when Z OPEN/CLOSE but-

ton or [DISC SKIP/EX-CHANGE] button is pressed. The mes-sage “LOCKED” will be displayed in the will be displayed onthe fluorescent indicator tube.


3. Press x button and Z OPEN/CLOSE button simultaneouslyand hold down until “LOCKED” or “UNLOCKED” displayedon the fluorescent indicator tube (around 5 seconds).

[MD/VIDEO SWITCHING]• This mode let you switch from MD to VIDEO and vice-versa.

Procedure:1. Press ?/1 button to turn the set ON.2. Select MD function.

3. Press [MD $VIDEO%] button and ?/1 button simultaneously.The function will change to VIDEO. Press the same buttonsagain to change from VIDEO to MD.

19

HCD-GN88D

SECTION 5MECHANICAL ADJUSTMENTS

SECTION 6ELECTRICAL ADJUSTMENTS

Precaution1. Clean the following parts with a denatured alcohol-moistened

swab:record/playback heads pinch rollerserase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, apply suitable locking compound to the

parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

Torque Measurement

3.06 N • m to 6.96 N • m31 to 71 g • cm

(0.43 – 0.98 oz • inch)

0.19 N • m to 0.58 N • m2 to 6 g • cm

(0.02 – 0.08 oz • inch)

3.06 N • m to 6.96 N • m31 to 71 g • cm

(0.43 – 0.98 oz • inch)

0.19 N • m to 0.58 N • m2 to 6 g • cm

(0.02 – 0.08 oz • inch)

6.96 N • m to 14.02 N • m71 to 143 g • cm

(0.98 – 1.99 oz • inch)

9.80 N • m100 g or more

(3.53 oz or more)

9.80 N • m100 g or more

(3.53 oz or more)

Mode Torque meter

CQ-102C

CQ-102C

CQ-102RC

CQ-102RC

CQ-201B

CQ-403A

CQ-403R

Meter reading

FWD

FWD

back tension

REV

REV

back tension

FF/REW

FWD tension

REV tension

0 dB=0.775 VDECK SECTION

1. Demagnetize the record/playback head with a headdemagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.3. After the adjustments, apply suitable locking compound to the

parts adjust.4. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.5. The adjustments should be performed in the order given in this

service manual. (As a general rule, playback circuit adjustmentshould be completed before performing recording circuitadjustment.)

6. The adjustments should be performed for both L-CH and R-CH.

7. Switches and controls should be set as follows unless otherwisespecified.

• Test Tape

RECORD/PLAYBACK HEAD AZIMUTH ADJUST-MENT

DECK A DECK B

Note: Perform this adjustments for both decksProcedure:1. Mode: Playback

Tape Signal Used forP-4-A100 10 kHz, –10 dB Azimuth Adjustment

WS-48B 3kHz, 0dB Tape Speed Adjustment

set

MAIN boardCN301Pin 1 (L-CH)Pin 3 (R-CH)

MAIN boardCN301Pin 2 (GND)

+–

level meter

test tapeP-4-A100(10 kHz, –10 dB)

20

HCD-GN88D

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 1dB of peak.

3. Mode: Playback

4. After the adjustments, apply suitable locking compound to thepats adjusted.

Adjustment Location: Playback Head (Deck A).Record/Playback/Erase Head (Deck B).

Screwposition

L-CHpeak

within1dB

Outputlevel

L-CHpeak

R-CHpeak

within1dB

Screwposition

R-CHpeak

MAINboardCN301set

test tapeP-4-A100(10 kHz, –10 dB)

pin 3

oscilloscope

L-CH

R-CH

V H

waveform of oscilloscope

in phase 45° 90° 135° 180°

good wrong

pin 2

pin 1

L

R

forward reverse

set

MAIN boardAUDIO OUT jack (J730)L-CH, R-CH

+–

frequency counter

test tapeWS-48B(3 kHz, 0 dB)

1. Insert the WS-48B into the deck B.2. Press the H button on the deck B.3. Adjust the tape speed adjustment control inside motor so that

frequency counter reads 3,000 ± 90Hz.

Sample value of wow and flutter W.RMS (JIS) less than 0.3%WS-48B

Adjustment Location:

Tape speed Adjustment

Tape speed adjustmentcontrol inside motor

Tape Speed Adjustment DECK BProcedure:Mode: Playback

21

HCD-GN88D

– MAIN BOARD (Component Side) –

REC LEVELADJUSTMENT

REC BIAS ADJUSTMENT

CN301

IC301

3 1

(R-CH)

(R-CH)

(L-CH)

(L-CH)

RV301

RV351

RV304 RV354

6. Confirm the playback signal recorded in step 3 becomesadjustable level as follows.If these levels are not adjustable level, adjust the RV304 (L-CH) and RV354 (R-CH) on the MAIN board to repeat steps 4and 5.

Adjustable level: Playback output of 315 Hz to playback outputof 10 kHz: ±1.0 dB

Adjustment Location: MAIN board

REC LEVEL ADJUSTMENT DECK B

Procedure:In the MC test mode, the “REC memory mode” is convenient forthis adjustment. In the “REC memory mode” , when the REC startsthe input signal FUNCTION is switched to VIDEO automatically.When the REC stops, the tape returns near to the recording startposition.

1. Press MD (VIDEO) button to select VIDEO. (This step is notnecessary if the above test mode has already been set)

2. Insert a tape into deck B.3. After press [REC PAUSE/START] button, press [REC PAUSE/

START] button, then recording start.

set

MAIN boardMD/VIDEO (AUDIO) IN (J117) 315 Hz, 50 mV (–23.8 dB)

blank tapeCS-123600 Ω

attenuator

AF OSC

+–

set

recordedportion

MAIN boardCN301 Pin 2 (GND)


level meter

5. Mode: Playback

+–

set

recordedportion

MAIN boardCN301 Pin 2 (GND)


level meter

4. Mode: Record

5. Mode: Playback

6. Confirm the play back signal recorded in step 3 becomesadjustable level as follows.If these levels are not adjustable level, adjust the RV301 (L-CH) and RV351 (R-CH) on the MAIN board to repeat steps 4and 5.

Adjustable level:CN301 PB level: 47.2 to 53.0 mV (–24.3 to –23.3 dB)Adjustment Location: MAIN board

REC BIAS ADJUSTMENT DECK B

Procedure:In the MC test mode, the “REC memory mode” is convenient forthis adjustment. In the “REC memory mode” , when the REC startsthe input signal FUNCTION is switched to VIDEO automatically.When the REC stops, the tape returns near to the recording startposition.

1. Press MD (VIDEO) button to select VIDEO. (This step is notnecessary if the above test mode has already been set)

2. Insert a tape into deck B.3. After press [REC PAUSE/START] button, press [REC PAUSE/

START] button, then recording start.4. Mode: Record

attenuator

set

MAIN boardMD/VIDEO (AUDIO) IN (J117)

1) 315 Hz2) 10 kHz

50 mV (–23.8 dB)

600 Ω

blank tapeCN-123

AF OSC

22

HCD-GN88D

VIDEO SECTION

Note :1. VIDEO board is basically designed to operate without adjust-

ment. Therefore, check each item in order given.2. Use DVD reference disc unless othermise indicated.

[DVD reference disc]• LUV-P01 (4-999-032-01) (CD)•TDV-540C (J-2501-235-A) (DVD-DL)• TDV-520CSO (J-2501-236-A) (DVD-SL)

3. Use an oscilloscope with more than 10MΩ impedance.4. Clean the object lens by an applicator with neutral detergent

when the signal level is low than specified value with thefollowing checks.

Video Level Check (VIDEO BOARD)PurposeThis adjustment is made to satisfy the NTSC standard, and if notadjusted correctly, the brightness will be too large or small.

Procedure:1. Connect oscilloscope to VIDEO output.2. Load a DVD reference disc playback.3. Check the video signal level is 1.00±0.05Vp-p.

J711VIDEO OUTPUT

75 Ω

Oscilloscope

set

1.00 ± 0.05 Vp-p

(WHITE 100%)

RE-ADJUSTMENT OF THE SERVO CIRUITThe re-adjustment of the servo circuit is necessary whenthe part which relates to the servo circuit is replaced.Referring to SUPPLEMENT-1 “1. DRIVE AUTO ADJUSTMENT”(see page 3).Choose ALL and do the re-adjustment of each item ofDVD-SL, CD and DVD-DL.

THE PART THAT THE RE-ADJUSTMENT OF THE SERVO CIRCUIT IS NECESSARY.

1. Optical pick-up2. RF AMP (IC001)3. DSP IC (IC509)4. Motor driver IC (IC501)5. EEPROM (IC204)

Ver 1.3

RFMON Level CheckPerform a RFMON level check before exchanging optical pick-up.Connection:

RFMON signal waveform

• Standard value

Test DiscRFMON level

Standard Value

DVDTDV-520CSO

1.09±0.2Vp-p(J-2501-236-A)

CDLUV-PO1

1.05±0.2Vp-p(4-999-032-01)

VOLT/DIV: 200 mVTIME/DIV: 500 ns

RFMON level

IC001

JL005(RFMON)

VC

VC

+–

JL005(RFMON)

oscilloscope

–RF board (side B) –

23

HCD-GN88D

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• 2 : nonflammable resistor.• 5 : fusible resistor.

Note on Printed Wiring Boards:• X : parts extracted from the component side.• : Pattern from the side which enables seeing.

(The other layers´ Patterns are not indicated.)

Caution:Pattern face side: Parts on the pattern face side seen from the(Side B) pattern face are indicated.Parts face side: Parts on the parts face side seen from the(Side A) parts face are indicated.

• Indication of transistor.

• C : panel designation.• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Voltages and waveforms are dc with respect to ground

under no-signal conditions.RF, DMB03, VIDEO, REGULATOR boards section no mark: DVD PLAYOther board section no mark: TUNER (FM/AM) ( ): DVD PLAY < >: TAPE PLAY [ ]: TAPE REC

• Voltages are taken with a VOM (Input impedance 10 MΩ).Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

F : TUNER (FM/AM)E : TAPE PLAY (DECK A)d : TAPE PLAY (DECK B)G : RECORDJ : DVD PLAYc : DVD PLAY (DIGITAL OUT)q : MD/VIDEO (AUDIO) INj : GAME IN (AUDIO)k : GAME IN (VIDEO)N : MIC INPUT

Note:The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified. C

B

These are omitted.

E

Q

B

These are omitted.

C E

Q

B

These are omitted.

C E

Q

SECTION 7DIAGRAMS



24

HCD-GN88D

7-1. CIRCUIT BOARD LOCATION

TUNER PACK

SUB TRANS board

SURROUND board

POWER AMP board

TRANS board

DISPLAY board

VOLUME board

GAME IN board

MOTOR (LD) board

SW board

SENSOR board RF board

MOTOR (TB) board

DRIVER board

MAIN board

CD SWITCH board

DMB03 board

REGULATORboard

VIDEO board

HCD-GN88D

2525

IC207 VDAC_4T301 5

r WAVEFORMS

1 IC501 qa XC-OUT

2

3

IC501 qd X-OUT

T301 4

4

– MAIN BOARD – – DMB03 BOARD –

IC906 8 XTO2

IC901 r; XTAL1

IC906 0 SO23

– DISPLAY BOARD –

IC601 is X OUT1

3.0Vp-p

32KHzVOL/DIV : 1V ACTIME/DIV : 10µsec

VOL/DIV : 1V ACTIME/DIV : 50nsec

2.0Vp-p

16MHz

240Vp-p

13µsecVOL/DIV : 50V ACTIME/DIV : 10µsec

TAPE REC only

VOL/DIV : 50V ACTIME/DIV : 10µsec

TAPE REC only

64Vp-p

13µsec

4MHz

2.4Vp-p

VOL/DIV : 1V ACTIME/DIV : 0.2µsec




3.3 Vp-p

20 MHz

3.5 Vp-p

27 MHz

4 Vp-p

30nsec

IC906 qd SO34


4 Vp-p

30nsec

IC207 VDAC_16

IC207 VDAC_05

IC207 VDAC_27

VOL/DIV : 0.5V ACTIME/DIV : 20 µsec



8


131

1Vp-p

1H

128

976 mVp-p1H

125

1 Vp-p

1H

IC207 VDAC_3122

1H

750mVp-p

9


119

1H

750mVp-p

– RF Board –

IC001 1 DVD RFP1

IC001 el TE2

IC001 r; FE3

IC001 tj RFAC4

0.7Vp-p0.2V/div100nsec/div

1.8Vp-p

0.5V/div1msec/div

0.1V/div1msec/div

0.3Vp-p

1.2Vp-p0.5V/div100nsec/div

HCD-GN88D

2626

7-2. BLOCK DIAGRAM – DVD DSP (1/2) Section –

OPTICAL PICK-UPBLOCK

(TDP022W)

A +5V

Q001

IC001DVD/CD RF AMP

VC

CD A16CD B15CD C

SDEN

PI/CE

DATA RFCLK RF

MIRR

FFDR

VC

FRDR

TFDRTRDR

SPIN

1413171820

1

21

CD D

A12B11C10

9 D

CD FCD E

DVD LD

A23B24C25

6 D2

DVDLD

PD

FCS+FCS-

TRK+TRK-

SW

DVDRFP

INLIM

IC501MOTOR/COIL DRIVE

36DO1-DO1+

DO2+

DO2-

DO3+DO3-DO4+DO4-

37

3435

32

19202122

30

DO5+27

IN6-46

IN6+47

29

DO5-28

31

481

40

34

10

7

13

3132

44

SLEDMOTOR

SPINDLEMOTOR

IN1+

IN1-

IN2+

IN2-

IN3-

IN4-

IN5-

VC VC

45OUT6

SPO

SLED

_B

62

FG

7

FCS_

JMP_

1

8

FCS_

JMP_

2

61

SLED

26

SCOR

6M

NT1

22

INIT

0_DV

D

23

INIT

1_DV

D

84

XWR

85

XRD

12

XCS_

DVD

25

XRST

_188

2

14-21D0-D7

89-96A0-A7

52

SQSO

54

SQCK

SLED

_A

TRDRTFDR

3334 FRDR

FFDR

IC901(1/2)MECHANISMCONTROLLER

57RFAC

40FE

VC

VCC

BADCE

F

RF

GND

39TE

42

36

MNTR

VI25

39 FE

41 TE40 SE

434238

RFDCCEVC

RFIN

48SDEN47SDATA46SCLK

2

SDEN

40 XTALX901

20MHz 41 EXTAL

83

SDAT

A_RF

82

SDCL

K_RF

27MIRR

26LDON LDON

DOUT

I/O0-I/O15

768FS-2768FS-1

IC70616M DRAM

A0-A11

IC701DVD DECODER

IC509CD DECODERSERVO DSP

MD0-MD9,MDA-MDF

MA0-MA9

XMWR WEXRAS RAS

XOE OEXCAS

MA11/MNT2

D0-D7 A0-A7

UCASLCAS

SLEDA+SLEDA-SLEDB+SLEDB-

SPDL+

SPDL-

12

16

Q901

LDDRIVE

22 CD LD

23 DVDPD24 CDPD

CDLDLD GND

M

M

66

PI

50 RFAC 64DOUT

65LRCK66PCMD67BCK

71XTAI

76

SQSO

77

SQCK

79SBSO80EXCK

4

DATA

5

XLAT

6

CLOK

7

SENS

8

49 27 50 9 72

SCLK

DATA

_CD

LAT_

CDCL

OK_C

DSE

NS_C

DSC

LK_C

D

71

GFS_

CD

30

COUT

_CD

74

FOK_

CD

75

LOCK

_CD

31

INLI

M

10WFCK

13

GFS

14C2PO15SCOR17WDCK

19CO

UT22

FOK

24

LOCK

768F

S

25MDP

26

SSTP

MUT

E12

MUT

E34

MUT

E5TS

D-M

2957

6SFDR

30 SRDR

28

LDON

20 MIRR

76

LDSE

L

73

TSD-

M

63

SP_O

N

60

MUT

E_2D

43

135

164

MDIN2137

117

LRCK163

65

TE

67

FE

29

MIR

R

Q002LD

DRIVE

IC503AMP

5 SDASCLWP

SDA_EEPSCL_EEPWP_EEP 7

65

99100

IC903EEPROM

IC703(2/2)AMP

IC703(1/2)AMP

MDAT160

APE0109 GFS 107

171

BCLK158SBIN148EXCK147

3

MUT

E

59

MUT

E_CD

2

XRST

98

XDRS

T

WFCK151C2PO155SCOR150GSCOR146

46HDRQ XSAK

HDB-DATA

48XHWR

XSAKXDCK XSDCK

49XHRD NC

53XHAC XSRQXSRQ

XTL1

45

SCK_

DSD

58

GFS_

DVD

64

JIT

3

DOCT

RL/IS

BTES

T

63

MD2

76

172-1761,2,4

5,7,9-14

17187833943435

95

XRD

17

XWR

18

XCS

19

XINT

0

20

XINT

1

21

HDB0-HDB8

MA10/MNT1 92

93

44,41,39,3532,30,27,24,26

66-69,71,73-75,

96,97,99,101,102,104-106

2-5,7-10,41-44,46-49

79,80,82-87,89,91

21-24,27-32,20,19

8 8

XRST

XRST

B

A DVD DSP (2/2)SECTION(Page 27)

DRV

DRV

DRV

DRV

42

43

DVD DSP (2/2)SECTION(Page 27)

• Signal Path

: DVD

: DIGITAL OUT

HCD-GN88D

2727

– DVD DSP (2/2) Section–

D-SENS 41

EJECTSW

Q731

S751(LEVER) D+3.3V

M-REQVMUTEVMUTE2

42

3

4

1

2

IC731TABLE SENSOR

IC901 (2/2)MECHANISMCONTROLLER

IC501 (1/5)SYSTEM

CONTROL

131VDAC 0 VCY

CB/RCR/B

I2C-DA

D +3.3V

I2C-CL

IIC-DATA

IIC-CLK

SYS-RESET

156IEC958

109CDSEL

125VDAC 2128VDAC 1

122VDAC 3

34,33,31

29 56

119

HA1-22

HA4-22

HA1-3

HA1-3

HAD0

-15

VDAC 4WIDE107VS

190ALE195HCS025WEH.UDS27HEL.LDS

IC207DVD SYSTEM PROCESSOR

IC216ADDRESS LATCH

184

HIRQ

1DR

VIRQ

36

191

RST_

SPC

RST

38

DRVR

DY

37

161

I2C

DAI2

C_SI

O

78

160

I2C

CLI2

C_SC

L

79

202

RESE

T

185

DRVC

LKSC

K_ZI

VA

35

186

DRVT

XSO

_ZIV

A

34

187

DRVR

XSI

_ZIV

A

33

162

CS (Z

IVA_

E2P)

165

WRI

TE_C

TRL

(ZIV

A_E2

P)

116

HIRQ

2

188 DRVRDY

D+3.3VAUDIO+5V

CS_Z

IVA

32

DVD-

MUT

E(D

VD-A

-MUT

E)

25

VMUT

E

33

M-R

EQ

34

VMUT

E2

32

VIDE

O OU

T

81

SYS-

RESE

T

40

3 MO1MO2MO3

27MM768FS768FS768FS-2

768FS-1 1310

IC906CLOCK GENERATOR

6CLR

CKQ3 1

21

4

IC904FF

IC902GATE

5DI4SK3CS1R/B

DOWC 8

6

IC204EEPROM

HDB-DATA

DOUT DOUTDOUT

SDEN179X SAKSDCLK183X DCK

X SRQ SDREQ178

139XIN

IC203SDRAM

DQ0-DQ31

A0-A9,A10/AP,NC

MD0-MD31

SDDATA0-SDDATA7,SDERROR

MA0-MA11

HAD0-HAD15

MDQM0-MDQM3DQM0-DQM3MWEWEMCASCASMRASRASMCS0CS

12

32

8

4

5316,71,28,59

1718 5219 5120 49

BA0BS0 22 48BA1BS1 23

1 3

47

57-6064-7175-7881-8488-95

99-102

55,54,52,51,49-47,45-40,38-36

2,3,5,6,8-1012-17,19-21,

23,24,26

2,4,5,7,8,10,11,13,74,76,77,79,80,82,83,85,31,33,34,36,37,39,40,42,45,47,48,50,51,53,54,56

42-3345,46

22,19-14,11-3

HA1-HA3 2,207,206

177-174171-168,182

25-2760-6624,21

150DATA0(DM)151DATA1(FLR)154DATA2(SLR)155DATA3(CSW)

149BCK148LRCK147XCK

CDSEL

110MREQMREQ

BCK-ZIBALRCK-ZIBA

XCK

113MDI114MC115ML

MDIMCML

MDI

RSTAUDIOD +3.3V

MCML

Q202

1LE,2LE

IC302D/A CONVERTER

IC201

DATA3DATA2DATA1DATA4BCK

VOUT7

OPTICALDIGITAL

OUT

IC392

+3.3VREG.

A3V-2D +5V 1 3

IC907

+3.3VREG.

ZIVAD +3.3V

ZIVAD +1.8V

1 3

IC211

+1.8VREG.

VOUT8DOWNMIX-LDOWNMIX-R

SURROUND-LSURROUND-R

SW (LFE)

FRONT-LFRONT-R

CENTER

MUTEQ215,216

MUTEQ217,218

MUTEQ219

MUTEQ220,221

MUTEQ222

VOUT1VOUT2

VOUT5

VOUT3VOUT4

VOUT6

LRCKSCKI

47464531404138

1620

1413

10

1211

9

363534

37

62,73,86,97

DATA1DATA0

DATA2DATA3IEC958

26 CE

DQ0-DQ15

A0-A21

HAD0-15

HAD0-15

11 WE28 OE

IC206RAM

29-36,38-45

25,24,23,22-18,8-1,48,17,16,9,

10

7XTIX902

27MHz8XTO

M DISPLAYSECTION(Page 31)

D DISPLAYSECTION(Page 31)

BDVD DSPSECTION(Page 26)

CMAIN

SECTION(Page 29)

ADVD DSP (1/2)SECTION(Page 26)

Q903

Q904

30V-OUT.A4 V-INV

6 Y-INY2 C-INC

14

16

CB-INCB/R

CR-IN

15 MUTE2

3 MUTE1

12 CY-IN

CR/B

WIDE

V-OUT.BC-OUT

3133

IC711VIDEO AMP/BUFFER IC710

VIDEO SELECTOR

27Y-OUT.AY-OUT.B 28

24CY-OUT.ACY-OUT.B 25

21CB-OUT.ACB-OUT.B 22

18CR-OUT.ACR-OUT.B 19

VIDEOOUTVIDEO

J711

CD DIGITAL OUTOPTICAL

COMPONENTVIDEO OUT

J710

S VIDEOOUT

J712C Y

73

1

2

Y

PB/CB

PR/CR

Q701,711

BUFFER

Q223,224

IC252DATA OUT SELECTOR

52

16

GAMEINPUTVIDEO

J601 (1/2)

LMF 46

LMR 47

44

TM-R

E-1

E-2

E-3

45

21

22

43

TM-F

RINFIN

97

MOTORDRIVE 4

297

42MOTOR

DRIVE

OUT1OUT2

OUT1OUT2

RINFIN

IC712MOTOR DRIVERRE701

ROTARYENCODER

IC701MOTOR DRIVER

M751(LOADING)

M

M M741(TABLE)

• Signal Path

: DVD

: DIGITAL OUT

: VIDEO

: GAME IN (VIDEO)

HCD-GN88D

2828

TAPE L-CH

TESTCONNECTOR

CN301

R-CH R

L

EMAIN

SECTION(Page 29)

TUNER L – CHF

MAIN SECTION(Page 29)

REC L-CHG

MAINSECTION(Page 29)

PBHEAD

DECK-A

DECK-B

TC BLOCK

32

BIAS OSCQ302, 303

RIPPLEFILTERQ301

A TRIGDRIVE

• SIGNAL PATH

: PLAYBACK (DECK A): PLAYBACK (DECK B): RECORD

: TUNER (FM/AM)

R-CH

FM/AM TUNER UNIT

CN304

ANTENNA

ST-L

FM ANT

AM ANT

AM ANT

ST-R

ST-MUTESTEREOTUNED

ST-DOUT/MC-DINST-DIN/MC-DOUT

ST-CLKST-CE

FM 75ΩCOAXIAL

CAP M+

BTRGM+

ATRGM+

AHALFBHALFAPLAYBPLAY

BSHUTASHUT

REC(FWD)REC(REV)

CAPM-CTRL

B-TRIG

A-TRIGTC-RELAY

A-HALFB-HALFA-PLAYB-PLAY

B-SHUTA-SHUT

A REC, FWDB REC, REVREC BIASPB-A/B

ALCREC-MUTETC-MUTEAMS-IN

AM

• R-ch is omitted due to same as L-ch.

93EQ OUT1

A

B

120

ST-MUTESTEREOTUNED

ST-DINST-DOUTST-CLKST-CE

BIASTRAP

RECBIAS(L)

34

1

2

3

4

28 27 26

2421

5653

54EQ-H/N65

515263

6066

9089616991675559

B TRIGDRIVE 58

CAP MOTORDRIVE 57

10012

9787

6588

13 12 11 15 14

BUFFERQ304,305

HPFR-CH

PB OUT1TAI1

REC IN1

MUTEQ306,389

AMS DETECTQ390, 398, 399

R-CH

R-CH

L – CH

R – CH

R-CH

R-CHSWP1

GND

SWR1

AIN1

BIN1

RV304

REC(L)LEVEL

RV301

C332, 333

TC A+9V

REC/PB SWITCHIC302

REC/PBHEAD

ERASEHEAD

A/B

NORM

/HIG

H SP

EED

ALC

ON/O

FF

REC

MUT

E ON

/OFF

MUT

E ON

/OFF

IC303

DECK A/B SELECTPB/REC EQUALIZER AMP

IC301

Q307,310

T301

Q391, 392

Q395, 396

Q393,394

SYSTEM CONTROL(CD/TAPE MECHANISM CONTROL)

IC501(2/5)

REC-OUT1

+

L – CH

R – CH

EQ

– TUNER/TAPE DECK Section –

HCD-GN88D

2929

J117

J601 (2/2)

E(Page 28)

(Page 28)

G (Page 28)

F

R-CH

VOLUMECONTROL

CPUINTERFACEINPUT

SELECTSWITCH

SURROUND ORDPL BUFFER

MID/BASS &TREBLE

R-CH

R-CH

COMMAND

F OUT2OUT1

VLIN1

+

Q101

R-CH

R-CH

SPEANA

D130 DBFBF/B

F-R

F-L

REAR-L

CENTER-L

REAR-R

AC CUT DETECT

+

+

+

RV722

MIC AMPIC722 (2/2)

INPUT SELECT SWITCH,GRAPHIC EQUALIZER CONTROL,

ELECTRICAL VOLUMEIC102

AUDIO OUTSWITCHIC730

SYSTEM CONTROLIC501(3/5)

SURROUNDVOL CONTROL

IC103

INA1

INEX1

SUR1

IND1

L+R DATA

CLK

BB-A

1

BB-B

1

SWOUT

REC-L

R-CH

TAPE L-CHTUNER/TAPE

SECTION

TUNER/TAPESECTION

TUNER L-CH

DOWNMIX-L

DOWNMIX-R

FRONT-L

FRONT-R

CENTER

SURROUND-L

SURROUND-R

SW (LFE)

DATA CLOCK

VOLU

ME-

DATA

VOLU

ME-

CLK

LINE

MUT

E

MIC

DET

ECT

SPEA

NA M

UTE

AUDI

O-DA

TA

AUDI

O-CL

K

AUDI

O OU

T

SW-R

ELAY

R-CH

R-CH

Q730

R-CH

J721

L

R

MD/VIDEO(AUDIO)

IN

L

RAUDIO

LPFI/F

R-CH

GAMEINPUT

J730

AUDIO OUT

RY701

2

14 15

24

4

2

3

1

13

5

18

22 1621

5

36

INB1INC1

4

L

R

J716

SUBWOOFER

19

41

40

37

39

38

DVD DSP(2/2)

SECTION

MICMIC AMP

IC722(1/2)

ECHO LEVELRV721

MIC LEVEL

VC (+5V)

C(Page 27)

17

8

MIC

RECB

1

7

42

MIC OUT

VC(+5V)

A+9V

CAB

CAB

SUR2

A+9V

41

34

2 33

32

+

1 8DIGTALECHO

IC721LPF2OUT

LPF1IN

• R-ch is omitted due to same as L-ch.

+5V REG.Q721

VC (+5V)

13 12

6 5

10 9

15 24

14

86 87 79 80 82 7071 6877

+

AMPSECTIONJ

K

I

H

(Page 30)

AMPSECTION(Page 30)

DISPLAYSECTION

TUNER/TAPESECTION

(Page 31)

AMPSECTION(Page 30)

11

431

25

30

29

87

23

2827

26

22

3

MUTEQ620, 670

MUTEQ799

Q802 Q803

Q105MUTE

MUTEQ800

Q650,651BUFFER

MUTEQ801

MUTEQ798

17 18RELAY DRIVE

Q701, 702

• SIGNAL PATH: TUNER (FM/AM)

: DVD: TAPE PLAY

: GAME IN (AUDIO)

: RECORD: MIC INPUT

: MD/VIDEO (AUDIO) IN

– MAIN Section –

HCD-GN88D

3030

– AMP Section –

IC501POWER AMP

IC301POWER AMP

IC502OVER CURRENT

PROTECTOR

: TUNER (FM/AM)

MUTINGQ503, 504, 581

F-R

DBFBF/B

F-L

REAR-R

CENTER

REAR-L

75 78

STK-

MUT

E

72

VACS

IN

PROT

ECTO

R

STK-

MUT

E

10

15

14

4

3

12

STK MUTE

FAN DETFAN-ONFAN-K

OVER LOADDETECT

Q501, 551

+ +

+

+

MUTINGQ621, 671

MUTINGCONTROL

Q652

F-RE

LAY

HP-D

ET

HP-M

UTE

FAN-

K

50

HP-D

ETEC

T

76

HP-M

UTE

83

FRON

T-RE

LAY

88

FAN

KICK

OVER LOAD DETECT

Q301, 341, 351

RELAY DRIVEQ516, 517

H/P

DET

F-RE

LAY

HP-MUTE

+-

-+

FRONT SPEAKERIMPEDANCEUSE 6-16Ω

SURROUNDSPEAKER

IMPEDANCEUSE 8Ω

CENTERSPEAKER

IMPEDANCEUSE 8Ω

L

R

PHONESJ631

RY501

D+3.9V

SYSTEM CONTROLIC501 (4/5)

TM501(1/2)


JMAINSECTION(Page 29)

MFAN MOTOR

DRIVEQ851-854

DC FANM891

AC CUT DETECT

AC CUT DETECT

TH502

TH501

Q518

THERMALDETECT

Q505, 506

THERMALDETECT

Q514

Q602VACS

CONTROL

+

+

+

85

CENT

ER-R

ELAY

84

LINE

-REL

AY(R

EAR

L/R

SURR

RLA

Y)RY381

RY382

TM501 (2/2)

L

R



I


K

DISPLAYSECTION(Page 31)

L

5

18

6

OVERLOAD

DC DETVP

OCP

CT

OUT D502

D391

2

1

D509

PROTECTSWITCH

Q511

Q510

PROTECTSWITCH

Q385

18 10

14 9

-

-

-

• R-ch is omitted due to same as L-ch.• SIGNAL PATH

HCD-GN88D

3131

– DISPLAY Section –

FL601FLUORESCENT

INDICATOR TUBE

8 –

10, 1

2 –

22,

24 –

41,

43

– 46

7 –

1, 1

00 –

95,

92 –

87

P1 –

36

G1 –

13,

G16

– 21

64 –

66

SUPER LOW FREQUENCY (BPF0)

2

BPF, RECTIC101

BPF, RECTIC102 67

7012

76 69

68

48

93

72

94

BPF3

BPF1

BPF2

VKK

SELECTOR

G15G15

G14G14

G1 – 13, 16 – 21

6

1

7

80 VOL 1A79 VOL 1B

ROTARYENCODER

S748VOLUME

XMAINSECTION(Page 29)

H

DVD DSP(2/2)SECTION(Page 27)

D

AMPSECTION(Page 30)

L

SPEANA

P1 – 36

VF1VF2

D610

D101

D102

-VG(-32V)

X6014MHz

83 X1

82 X0

52 –

59,

73

LED DRIVEQ602 – 604,

Q1001 – 1006

D603, 605, 601D1002, 1004, 1006D1008, 1010, 1012

D602, 606, 604D1001, 1003, 1005,D1007, 1009, 1011

M+9V

Q606

Q601

Q605

Q707

D748

KEY2 |

KEY0

S781 – 787, 788 - 792S765 – 772, 773S751 – 758, 759 - 763

60IIC DATA

MCU VCC

CN501

D+3.3V

IIC-CLK

IIC-CLK

IICPROGRAM

IIC-DATA

IIC-DATA

3

2

4

61IIC CLK77RESET

30 IIC-DATA29 IIC-CLK41

31

9

GC-RESET

TXD1TXD1

CNVSSCNVSS

MCU VCC

CN502

CNVSS

TXD1TXD1

RTS1

ON BOARDPROGRAM

CLK1

RXD1

RESET

MCU VCC

CN VSS

VMUTEM-REQSQ-DATA

74 POWER-KEY

73 DISPLAY-KEY

S749

S750DISPLAY

48 STBY-LED

4 SIRCS

X50216MHz

15 X-IN

13 X-OUT

X50132.768kHz

10 XC-IN

11 XC-OUT

23DVD-POWER(SYS POWER)

95DVD POWER CHK

SYSTEM CONTROLIC501 (5/5)

27STBY-RELAY

12RESET

98VREF VREF

20AC-CUT

B+ SWITCHQ904, 905

RECTD901

+5VREGULATOR

IC905

+3.3VREGULATOR

IC907

+5VREGULATOR

IC906

M +9V

A +9VTC +9V

D502 D504

D501 D503

+3.9VREGULATOR

IC904

+3.9VREGULATOR

IC971

D +3.9V

+9VREGULATOR

IC903

+9VREGULATOR

IC901

+12VREGULATOR

IC902M+12V

LEVELDETECTIC601 D505

RECTD902

RECTD972 – 975

LED DRIVEQ748

T972SUB POWER

TRANSFORMER

RECTD541

RECTD543

+VL

AC CUTDETECT

F974 VL

VL

VH

VH

VP

VF

VF

AC3

AC4

AC4

AC3

GNDF975

F976

F977

F978

R941

–VL

+VH

–VH

– 33VREGULATOR

Q903

POWER ON/OFFRELAY DRIVE

Q971

– VG(-32V) D977

RECT

D508

D509

VF1

VF2

RY971

AC IN

T910MAIN POWER

TRANSFORMER

RESETSWITCH

Q601

REMOTE CONTROLRECEIVER

IC603

TO FLUORESCENTINDICATOR TUBE

FL601

MCU VCCVREF

EVER +3.9V

S901

S901

E3, E15, E51, EA, PH, SP,MY

AUS, MX, TH

120V|

220V|

230 – 240V

DISPLAY CONTROLKEY CONTROL

IC601

BUFFERQ807, 808

Q903, 906

Q909, 910

D103

D104

BAFFER, RECTQ100, D105

71 ALL_BAND

3

2

6

9

7

5

8 R952

DVD DSP(2/2)SECTION(Page 27)

M

VOLTAGESELECT

ZIVAAUDIO+5V

ZIVAD+3.3V

ZIVAD+5V

BUFFER

B+SWITCH

94I-HOLD

LED

13 • Abbreviation AUS: Australian model E3 : 240 V AC Area in E model EA : Saudi Arabia model

E15 : Iran model E51 : Chilean and Peruvian model MX : Mexican model

PH : Philippines modelSP : Singapore modelMY : Malaysia modelTH : Thai model

HCD-GN88D

3232

7-3. PRINTED WIRING BOARD – RF Board – • See page 24 for Circuit Boards Location.

• SemiconductorLocation

D001 B-5D002 B-5

IC001 A-5

Q001 B-3Q002 C-3

Ref. No. Location

IC001(Page 36)

ATO

DMB03 BOARD

(TDP022W)

(TDP022W)

HCD-GN88D

3333

7-4. SCHEMATIC DIAGRAM – RF Board –

JL001

JL003

JL006

C002 C004

C005

C006

C008

C009

C010 C011

C012

C013

C014

C015

C016

C017

C018

C019

C024

C029

C030

C031

C033

C035

C040

C041

C001

C003

C027

JL002

JL004

C020

C021

C022

C023

C037

C042

IC001

L001 L002

Q001 Q002

R003

R005

R006

R007

R009

R010

R011

R012

R013

R014

R015

R016

R017

R018

R021

R024

R025

R026

R027

R028

R029

R033

R034

IOP1IOP2

JL005

JL007

C036

R022

R023

D001 D002

R032 C049

C025

C026

R001

CN001

CN003

C039 C038

CN002

C032

C034

C028

R008R004

R035

R041 R019 R020

16V 16V

10V

10V

B

B

1000pCH 1000p

CH

B

B

2200p B

2200p B

2200p B

2200p B

5600p B

5600p B

B

B

B

1000pCH

B

B

B

B

6.3V

6.3V

B

22p

CH

22p

CH

22p

CH

22p

CH

330pCH

180p CH

SP3723BDA0PM

2SB1132-T100-QRLD DRIVE LD DRIVE

2SB1132-T100-QR

33

47k

470

33

47k

470

0

0

0

0

0

0

0

0

0

0

100

12kE

0

0

0

0

10M

B

220

820

1SS355TE-17 1SS355TE-17

100 B

B

B

100 E

24P

9P

29P

B

B

B

3333

0

1k

0 0

DVD/CD RF AMP

ATO

DMB03BOARD

(2/8)(Page 39)

(TDP022W)

(TDP022W)

HCD-GN88D

3434

7-5. PRINTED WIRING BOARDS — DVD MECHANISM Board — • Refer to page 24 for Circuit Boards Location.

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14 15

CN751

S751

IC731

CN731

CN741

CN74

2

C715

C731

C735

C736

R70

1

R711

R731

R721

R722

R723

R73

5

R73

2

R733

R73

4

D70

1

D71

1

Q731

C751

IC71

2

IC70

1

CN704

C737

R71

3

R712

C741

R70

2

JW702

JW703

JW704

JW705

JW706

JW707

JW70

8

JW711

CN70

3

CN702CN705

R751

C752

CN70

1

JW712

JW701

JW70

9

JW710

JW713

JW714

CN72

1

MAINBOARD

(Page 48)

Ref. No. Location

D701 D-6D711 D-7

IC701 F-6IC712 F-7IC731 E-11

Q731 C-9

• Semiconductor Location

HCD-GN88D

3535

7-6. SCHEMATIC DIAGRAM – DVD MECHANISM Board –

MAINBOARD

(4/4)(Page 52)

R701

D701

R712R711

R721

C735 C736

R722

C737

R723

R733

R734R735

C741

CN731 CN741

CN742

CN702

CN703 CN751

M751

CN704CN721C751

R751

C752

CN705 CN751

R732R731

M741

CN701

IC731

E-1E-2E-3

Q731

D711

R713

C731

C715

S751

R702

470

MTZJ-T-77-5.1B

4.7k1k

4.7k

0.1 0.1

4.7k

0.1

4.7k

1k

12k100

0.01

3P 3P

5P

5P

4P 4P

(LD)

2P2P0.01

4.7k

0.1

2P 2P

10k100

(TBL)

12P

RPI-576TABLE

SENSOR

DTC114ESATBL ADDRESSENS SWITCH

MTZJ-T-77-3.6B

22k

1050V

10016V

(LEVER SW)

100

VR

EF

OU

T2

RN

F

OU

T1

VM

VC

C

FIN

GN

D

RIN

IC701BA6956AN

LD MOTORDRIVER

VR

EF

OU

T2

RN

F

OU

T1

VM

VC

C

FIN

GN

D

RIN

BA6956AN

DRIVER

IC712

TBL MOTOR

RE701ROTARY

ENCODER

HCD-GN88D

3636

7-7. PRINTED WIRING BOARDS – DMB03 Board (SIDE A) – • See page 24 for Circuit Boards Location. : Uses unleaded solder.

Ref. No. Location


D202 C-5D901 D-2D1301 A-2D1302 A-2D1303 B-1D1304 B-1D1305 C-1D1306 C-1D1307 A-2D1308 A-2D1801 D-5D1802 D-5D1805 D-3D1806 D-3

IC207 B-6IC211 C-4IC216 D-7IC302 B-1IC503 C-4IC509 D-4IC701 D-6IC901 C-2IC902 C-6IC904 C-6IC906 C-5

Q903 A-2Q904 A-2

IC701

IC207

IC509

IC901

IC906 IC90

4

IC902IC211

IC503

IC216

VIDEO BOARD

MAIN BOARD

(Page 46)

(Page 48)

REGULATOR BOARD

(Page 46)MAIN BOARD(Page 48)

VIDEO BOARD(Page 46)

RF BOARD

(Page 32)

IC302

1

2

3

1 7

C325

C321C302

FL302

R314

FL303

R285

C304

C305C303

C306

1

12

36

25

13 24

48 37

R574

JW801JW802JW803JW804JW805JW806

R805

1

80

61

21

40

20

6041

FORCHECK

E

E

RB202

RB203

RB204

C716

1617

D180

1D1

802

D130

2D1

301

D1308D1307

D130

3

D130

4D1

305

D130

6

AVW

S

X P

67

2425

12

1 9 10 13

1 3

2

NOT USE

4

D1806D1805

HCD-GN88D

3737

PRINTED WIRING BOARDS – DMB03 Board (SIDE B) – • See page 24 for Circuit Boards Location.

Ref. No. Location


D392 D-6D393 D-7D394 D-7D1101 D-6D1102 D-6D1803 C-1D1804 C-1

IC203 B-1IC204 B-2IC206 D-1IC252 B-4IC392 D-7IC501 D-4IC703 D-3IC706 D-2IC903 C-5IC907 D-6

Q202 B-2Q901 D-6

: Uses unleaded solder.

IC39

2IC

907

IC903

IC20

4

IC501

IC252

IC703

IC70

6

IC20

6IC

203

D180

4D1

803

R307R306

R313

R303R305

R304R302

C307

C326

C324

C323

C322

D110

2D1

101

1

2

3

1

2

3

1

4 5

8

R367

HCD-GN88D

3838

7-8. SCHEMATIC DIAGRAM – DMB03 Board (1/8) –

C394

R1301

R1303

JW392

CN107

D1303

D1304

D1301

D1302

D1305

D1307

D1306

D1308

C321

C322

R302

R303

R304

R305

R306

R307

R308

R309

C302

C303

C304

C305

C306

C307

C308

C309

SL302

R310

R311

R312

R314

C325FL302

D392

C393

SL392

R313

D394D393

C326

C323

C324

R392

C392

R367

IC302

IC392

FL303

2204V

0.1

0.1

0

13P

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1006.3V

0.1

220

220

220

220

220

220

220

220

0.01

0.01

0.01

0.01

0.01

0.01

100p

100p

DAC_RST

100

100

100

22

1004V

0UH

1SS355TE-17

0.01

10k

1SS355TE-171SS355TE-17

0.01

0.1

0.1

10

2216V

0

PCM1609KPTR+3.3V REG

0UH

PCM_5.1CH_BUS_B

DAC_CTRL_BUS

AUDIO_5V

AUDIO_AGND

AUDIO_DGND

DOUT

SG1

SG2

MDI

MC

ML

MCK-B

BCK-B

LRCK-B

FLR-B

SLR-B

CSW-B

DMX-

B

D/A CONVERTER

µPC2933T-E2

HCD-GN88D

3939

7-9. SCHEMATIC DIAGRAM – DMB03 Board (2/8) –

C516

C517

C518

C522

FL501

FL502

C592

R501

R502

R507

R508

R538

R539

R540

R541

R544

R555

R575

R576

R577

R578

R583

R585

R592R695

R696

R698

C502C501

C531 C533

C534 C535

C544

C543

C545

C590

C589

R550

R551

R552

R559

R563

R564

R587

C567

C568

R573

R694

R9988

R699

C569

C570

CL505

CL504

CL503

CL502

CL501

CL544

CL537

CL536

CL535

CL531

CL530

CL529

CL527

CL526

CL525

CL524

CL523

CL522

CL509

CL510

CL511

CL512

CL513

CL514

CL515

CL516

CL517

CL518

CL519

CL520

CL521

CL508CL507

CL506

R536

R537

R503 R504

R506

R505

R558

SL502

R561

R562

C588

R588

R593

R584

C556

C558R601

C548

C551

C561

C552

R572

R571C565

R568

C563

C560

R567

C559

R565

R566

C547

C553

C573

R615

R629

CN501

IC503

SL501R560

R599

IC509

R548

R545

0.002250V

B

1010

VF

0.01

50V

F

0.16.3V

B

0UH

0UH

1016V

0

0

0

000000

0

0

0

0

0

0

0

0

0

0

0

0.010.01

0.047 0.0022

0.022 0.0022

0.1

0.1

10

0.0022

0.0022

1k

1k

1k

1k

1k

1k

0

0.1

10

10k

10k

0

0

0.1

10

10k

68k

47k 47k

47k

47k

47k

1k

1k

0.0022

10k

100k

33k

10

1004V0

0.01

0.47

0.1

0

470k

1M0.1

1M

100p

0.0015

3.3k

0.1

1k

10k

0.1

0.0033

100p

0

0

29P

NJM3404AV(TE2)

1k

1k

CXD3068Q

10k

10k

DGND

ANALOG BUS

D3V

CD O

UT

B22

20 21 25 29 3018 19

B27

B282423B1

7

B11

7

5

4

3

2

1

B12

B6

PI

TE

FE

FE

TE

RFAC

RFAC

MIRR

DATA_RF

EXCK

SBSO

WFC

K

GSCO

R

SQCK

SQSO

FOK

LOCK

XRST

_CD

DATA

XLAT

CLOK

SENS

SCLK

COUT

MIR

R

MD2

SCOR

RF_A

C

MDP

MUT

E_CD

C2PO

LDON

FETE

SDEN

CLK_RF

SLEDA-

SLEDA+

SPDL+

SPDL-

PI

SLEDB+

SLEDB-

TFDR

TRDR

FFDR

FRDR

PI

INLIM

RFM

ON

SLEDCTRL

GFS_

CD

SPIN

FCS+

FCS-

TRK+

TRK-

CDSP2

MDAT

LRCK

BCLK

768FS

HCD-GN88D

4040

7-10. SCHEMATIC DIAGRAM – DMB03 (3/8) Boards – • See page 71 for Pin Function Description.

C764

R746

R745

C762

C730

C740

C741

C743

C744

C745

C723

C722

C714

C713

C718

C716

C708

C717

C712C709

C772

C770

C769

C767

C773

C771

R721C720

R724

R726R725

R720

C760C763

C765

C768

C715

C706

R767

R765

C774

C775

R732

R737

R735

C776

C742

R758

C778C777

C721

C726

C766

C725

C752

R780

R781

R728

R727

C728

C783

R799

C703

C729

C702

C780 C779

C727

C705

C701

R738

R736

R734

R733

R9986

R9987

C724

R716

R718

R717

R719

R713

R712R711

R710

R709

R708

R707

R764R763

R762

R769

R750

R714

R778

FL704

FL701

FL703

FL702

FL705

R741

R742

R743

R744

R757

R759

R755

R754

R753

R752

R766

R756

R731

R730

R777

R776

C782

FL706

R770

R748

R747

R784

R700

R788

R789

TP703

CL703

SL703

CL791

CL787

CL786

CL785

R715

TP701

CL701

C761

R785

R786

R787

C781

R751

IC703(1/2)

IC706

C711

IC703(2/2)

IC701

0.1

47k

47k

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.47

0.01

0.01

100p0.1

0.1

0.1

0.1

0.1

0.47

0.047

33k0.1

1k

100k1.8k

1k

0.10.1

0.1

0.1

0.0015

0.1

47k

22k

0.0047

0.1

10k

10k

10k

0.1

0.1

0

0.10.1

0.1

0.1

100p

0.1

0.1

00

10k

3.3k

0.1

0.001550V

B

0

0.1

1010V

F 10

10 10

10

0.01

16V

B

1004V

10k

10k

10k

10k

0

0

0.1

100

10k

100k

1k

10k10k

2.2k

10k

150k

470k

100

1M8.2k

22k

2.2k

10k

10k

100k

0UH

0UH

0UH

0UH

0UH

22

22

22

22

0

0

0

0

0

0

0

0

22

22

0

0

0.0015 50V B

0UH

0

33k

33k

0

8.2k

100k

100k

10k

0.1

10k

100k

100k

150

0

NJM3404AV(TE2)

MSM51V18165F-60TSKR1

NJM3404AV(TE2)

TMC5792GF-RDP

ANAL

OG_B

US

1.65V

DRAM_BUS

ANALOG_BUS

SIGNAL_BUS

B11

B12

1

2

3

4

5

7

B6

B32

35 36

B37 B3

8

31 B34

B33

SD7

SDEF

SD6

SD5

SD4

SD3

SD2

SD1 SD

0

BD0

BD1

BD2

BD3

BD4

BD5

BD6

BD7

WE

RAS

MA0

MA1

MA2

MA3

MA8

XMOE

XCAS

BD8

BD9

BDA

BDB

BDC

BDD

BDE

BDF

LRCK

XCAS

XMOE

MA4

MA5

MA6

MA7

XSAK

XDCK

XSHD

D4

D3

D2

D1

D0

INIT

1

XINI

T0

XCS1

882

XHW

R

XHRD

A7A6A5A4A3A2A1A0D7D6D5

RF_A

C

JIT

SPIN

SCOR

GSCOR

EXCK

SBSO

WFCK

C2PO

GFS_DVD

BCLK

MDAT

MA9

MDP

MDIN

MDIN

JITO

FF

MNT1

XSRQ

MA0

MA1

MA2

MA3 MA4

MA5

MA6

MA7

MA8

MA9

RAS

WE

BD0

BD1

BD2

BD3

BD4

BD5

BD6

BD7 BD8

BD9

BDF

BDE

BDD

BDC

BDB

BDA

*1

*1 C711

0.01

0.047

TH

EXCEPT TH

HCD-GN88D

4141

7-11. SCHEMATIC DIAGRAM – DMB03 (4/8) Boards –

CN102

C101

C151

D901

C927

C926

R535

R579

R534

R533

C514

R532

R530 R531

R529C512

R528

R527C510

R525

R524

R521

R523

R586

R519

R520C508

R517

R522C509

C506R516

R512

C503

C504

R513

C525

C528C529

R554

R553

R510

R511

C526C527

JL521

R543 R547 R581

R589

C519

R580

C925

C928

D1101

D1102

R1101

IC501

IC907µPC2933T-E2

+3.3V REGULATOR

R597

13P

2204V

1006.3V

1SS3

55TE

-17

0.0150V

F

2204V

0

8.2k

56k

33k

0.01

0

56k 0

33k0.01

0

2.2k0.001

10k

10k

100k

10k

200k

100k

10k0.001

2.2k

4.7k330p

330p4.7k

56k

33000p

3300

0p

56k

0.01

2216V

0.01

0 0

150k

150k

2216V

0.0150V

F

0 0 12k

10k

0.01

33k

22 16V

10

1SS355TE-17

1SS355TE-17

0.1

FAN8035L

0

M12V

M5V

MGND

V5V

VGND

AUDIO_5V

AUDIO_AGND

AUDIO_DGND

SG1

D3V

DGND

D5V

A3V-2

54

55

56

B22

20 21 25 29 3018 19 B27

B28

2423B17

MUT

E_2D

SPDL-

SPDL+

SLEDB-

SLEDB+

SLEDA-

SLEDA+

TRK+

FCS+

FCS-

TRK-

TFDR

TRDR

SLED

SP_O

N

SLED

B

SLED

A

FFDR

FRDR

SPFG

TSD-

M

SLEDCTRL

LDSE

L

DSAV

E

FJM

P1

FJM

P2

HCD-GN88D

4242


C918

R913

CL910

CL909

CL908

CL907

CL906

C924

R970

FL901 C902

C901

R958

R918

R919

R949

R948

R947

JL910

R962

R901

R902

C906 R9

78

R905

R906

R907

R911

R912

CL922

R991

R992

R974

R915

FL908

C909C903C904

JL967

JL966

JL965 R988

R916

C908

R917

R994R995

CL934

JL957

JL956

R996

R997

R998

C913

R920

R990

R984

R935

R925

R904

R926

R930

C905

R971

C910

R940

R910

R921

R973

R976

R942R943

X901

R931

R927X902

C916C917

L90147µH

FL903

CL913

FB903

R932

R933

CL904

FB902

CN901

CL954

CL959

CL955

CL950

CL951

CL952

CL953

R908

R975

Q904

Q903

Q901

IC901

CN101

C915

C914

R964

R923

IC902

IC904

C907

IC906

IC903

0.01

10k

0.01

0

0UH0.01

1004V

22

22

0

0

0

0

10k

22 22 0.01 10

k

22 22 22

10k

10k

0

0

0

100

0UH

100p1004V0.01

0

1k

100p

1k

00

0

0

0

33000p

100

0

10k

4.7k

100

10k

100

100

0.0100.01100

0100

00100

100

20MHz

22

1M27MHz

1004V0.010UH

0UH

22

220UH

7P

10k

10k

2SK1828TE85L

2SK1828TE85L

DTC114TE-TL

CXP973064-226R

7P

7p

7p

10k

220

TC7S32FU-TE85L

TC7W74FK-TE85L

0.01

SM8707GV-G-E2

BR24C16F-E2

768FS

ANALOG_BUS

AGND

DSP_BUS

AGND

A3V

3V-D

I2C-SIO

I2C-SCL

SPC9

70_B

US

768FS

DGND

ZIVA_CTRL_BUS

VMUTE

VIDEO_SW

54

55

5636 35B3

2

B33

B34

B37

B38

31

A0A1A2A3A4A5A6A7

XINIT0

XINIT1

D0

D1

D2

D3

D4

D5

D6

D7

XCS1882

XHRD

XHW

R

CLK_

RF

DATA

_RF

SENS

XLAT

TXD

RXD

MD2

PI

JIT

FJMP1

FJMP2

SLED

A

SLED

B

LOCK

FOK

SCLK

GFS_CD

SP_ON

SPFG

SLED

MUTE_2D

MUTE_CDGFS_DVD

TSD-M

LDON

RST_SPC

I2C_SIOI2C_SCL

SDEN

SCOR

DRVR

X

DRVT

X

DRVC

LK

DRVI

RQ

DATA

CLOK

SQSO

SQCK

XRST

_CD

768F

S

COUT

MIR

R

INLI

M

JITO

FF

DSAV

E

27M

DRVR

DY

DRVC

LK

CS_S

PC

CS_S

PC

LDSEL

WP

SCL

SCL

WP SDA

SDA

MNT1

RXD

TXD

CDSP2

FE

TE

RFMON

RF_AC

I2C_SIO

I2C_SCL

MREQ

SYS_RST

JIG_MOD

HCD-GN88D

4343


CL21

4

CL21

3

CL21

2

CL21

1

CL21

0

CL20

9

CL20

8

CL20

7

CL20

6

CL20

4

R201

R202R281R280R279R278

L412 L416L415L414L413

R219

R220

R221

R217

R223

R224

R9994

R9981

R9998

R9999

R9980

R218

R222

C415C414C413C412

L402 L403 L404 L405 L406

C416

R1201

R1801

D1802D1801

D1803

D1804

D1805

D1806

R1202

R1802

R1803

R270

JW801

JW802

JW803

JW804

JW805

JW806

JW601

JW602

JW603

JW604

JW606

JW605

JW607

CN105

R9993

CN202

RB204

RB203

RB202

0

7575757575

0 0000

0

0

0

0

0

0

0

0

0

0

0

0

0

0000

0 0 0 0 0

0

0.1 25V F

0.1

1SS355TE-171SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

0

0.1

0.1

0

0

0

0

0

0

0

0

0

0

0

0

0

0

17P

0

4P

0

0

0

SIGNAL_BUS

DGND

SG2

VGND

V5V

PCM_5.1CH_BUS_B

SG1

VMUTE

VIDEO_SW

B1

63 64 66 67 70 7172 73 76 77 78 79 80 81 82 83 84 85 86 87B68

SD7

SD6

SD5

SD4

SD3

SD2

SD1

SD0

XSAK

SDEF

XDCK

AV7

AV6

AV5

AV4

AV3

AV2

AV1

AV0

XSAK#

SDEF#

XDCK#

XSRQ XSRQ_ZIVA

LRCK-ZIVA

XCK2

DATA1(SEL)

BCK-ZIVA2

DATA1(SEL)

XCK2

BCK-ZIVA2LRCK-ZIVA

DATA3

DATA2

FLR-A

SLR-A

CSW-A

LRCK-A

BCK-A

MCK-B

BCK-B

LRCK-B

CSW-B

SLR-B

FLR-B

DMX-B DMX-A

MCK-A MCK-A

BCK-A

LRCK-A

CSW-A

SLR-A

FLR-A

DMX-A DATA0

(CHASSIS)

HCD-GN88D

4444


R207

R213

C213C215C214

C216

R273

R274 R2

75

R276

R277

R284

R269

R10

R11

R12

R13

R14

R15

R100

0

C244

C260

C251

C257

C267

C268

C269

C270

C271

C263

C261

C253

C248

C242

C241

C238

C236

C262

C272

C252

C229

C247

C226

C256

FL205 C266C2

30

C231

C232

C233

C234

C237

FL206

R232

R231R230

R233

R234

C265

C204

R227

R245

R248

R255

R257

R254

R243

R244

R246

R247

R259

R261

R260

R251

R283

RB18

RB19

RB20 RB21

JL21

4

JL21

3

JL21

2

R258

JL21

1

JL21

0

JL20

9

JL20

8

JL20

7

R263 R264 R265 R266 R267

JL20

6

JL20

5

JL20

4

JL20

3

R253

JL217

JL216

JL218

JL202

CL25

1

CL25

2

CL25

3CL

254

CL25

5

CL25

6

CL257

R240

Q202

D202

IC207

R805

C288

R1001R574

TP252

TP253C289

R288

IC252

R268

R239

IC204

IC211µPC2918T-E1

0

68

1004V0.010.01

0.01

0 0 0

0 0

180

0

22 22

22

22

22

22

4.7k

0.01

0.01

0.01

0.01

0.01 0.01 0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.1

0.01

0UH 0.010.

01 0.01

0.01

0.01 0.01

0.01

0UH

33

3333

0

10k

10

0.0150V

F

4.7k

4.7k

4.7k

0

4.7k

4.7k

0

1k

10k

1k

4.7k

4.7k

4.7k

0

1k

33

33

33 33

75 75 75 75 75

4.7k

47k

DTC114TE-TL

1SS355TE-17

ZIVA5X-C1F

0

0.01

0330

DOUT-MUTE

DOUT-SELECT0.01

0

TC7WH157FK(TE84R)

0

100

BR9040F-WE2

DAC_CTRL_BUS

A3V-2

DGND

D5V

D3V

CD O

UT

DOUT

ZIVA_CTRL_BUS

42

41

43

40

44

45

46

5047 48

B1

63 64 66 67 70 71 72 73 76 77 78 79 80 81 82 83 84 85 86 87B68

MD0

MD1

MD2

MD3

MD4

MD5

MD6

MD7

MD8

MD9

MD10

MD11

MD12

MD13

MD14

MD15

MD16

MD17

MD18

MD19

MD20

MD21

MD22

MD23

MD24

MD25

MD26

MD27

MD28

MD29

MD30

MD31

MWE

HAD0

HAD1

HAD2

HAD3

HAD4

HAD5

HAD6

HAD7

HAD8

HAD9

HAD1

0

HAD1

1

HAD1

2

HAD1

3

HAD1

4

HAD1

5

DRVCLK

DRVTX

DRVRX

DRVRDY

DRVIRQ

RST_SPC

MCLK

I2C_SIO

I2C_SCL

HA1

HA2

HA3

MDQM0

MDQM1

MDQM2

MDQM3

SYS_RST

CS_S

PC

SYS_

RST

AV7

AV6

AV5

AV4

AV3

AV2

AV1

AV0

XSRQ_ZIVA

XSAK#

SDEF#

XDCK#

ML

MC

MDI

MRE

Q

MRE

Q

MRE

Q

27M

MA0

MA1

MA2

MA3

MA4

MA5

MA6

MA7

MA8

MA9

MA1

0

MA1

1

MCA

S

MRA

S

MCS

O

BA0

BA1

DATA

0

DATA

2

DATA

3

CDSE

L

CDSE

L

JIG_

MOD

IEC9

58

IEC9

58

SELECTORDATA OUT

HCD-GN88D

4545


R214

R215

C254

C259C258

C205

R250

C275

FL204FL203

C250

C246

C243

C240

C235

C220

C218

C227

C239

C245

C249

C282

C281

C315

C316

CL390

CL389

CL388

CL387

CL386

CL385

CL384

CL383

CL382

CL381

CL380

CL379

CL378

CL377

CL376

CL375

CL374

CL373

CL372

CL371

CL350

CL351

CL352

CL353

CL354

CL355

CL356

CL357

CL358

CL359

CL360

CL361

CL362

CL363

CL364

CL365

CL366

CL367

CL368

CL369

CL370

R262

C255

RB10

RB11

RB14

RB15 RB17

RB16

RB13

RB12

R301

IC206

IC203

IC216

C264

0

0

0.01

0.0110

0.01

0

0.01

0UH0UH

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0.01

0

10 10V F

68

68

68

68 68

68

68

68

1k

MBM29DL324BE-90PFTN

MT48LC4M32B2TG-6

SN74ALVCH16841DGGR

0.01

40

44

45

46

47

48

50

41

42

43

HA5

HA6

HA7

HA8

HA9

HA10

HA11

HA12

HA13

HA14

HA15

HA16

HA17

HA18

HA19

HA20

HA2

HA3

HAD0

HAD1

HAD2

HAD3

HAD4

HAD5

HAD6

HAD7

HAD8

HAD9

HAD10

HAD11

HAD12

HAD13

HAD14

HAD15

HA21

MA0

MA1

MA2 MA3

MA4

MA5

MA6

MA7

MA8

MA9

MA10

MDQM0 MDQM1

MDQM2 MDQM3

BA0

BA1

MWE

MCLK

HA3

HA4

HA4

HA5

HA6

HA7

HA8

HA9

HA10

HA11

HA12

HA13

HA14

HA15

HA16

HA17

HA18

HA19

HA20

HA21

MCAS

MRAS

MCSO

MA11

HA22

HA22

MD0

MD1

MD2

MD3

MD4

MD5

MD6

MD7MD8

MD9

MD10

MD11

MD12

MD13

MD14

MD15

MD16

MD17

MD18

MD19

MD20

MD21

MD22

MD23 MD24

MD25

MD26

MD27

MD28

MD29

MD30

MD31

HAD0

HAD1

HAD2

HAD3

HAD4

HAD5

HAD6

HAD7

HA2

HA1

HAD15

HAD14

HAD13

HAD12

HAD11

HAD10

HAD9

HAD8

SYS_RST

HCD-GN88D

4646

7-16.PRINTED WIRING BOARD – VIDEO, REGULATOR Boards – • See page 24 for Circuit Boards Location.

D710 E-4D711 E-3

IC710 E-4IC711 D-3IC901 B-7IC902 B-7IC903 B-8IC904 B-8IC905 B-9IC906 B-9

Q215 B-4Q216 B-3Q217 B-4Q218 A-4Q219 B-3Q220 A-3Q221 B-3Q222 A-3Q710 F-5Q711 E-5Q903 C-8Q904 C-10Q905 B-10Q906 C-8


Ref. No. Location

R227

R228

R218

R219

R239R237

R235

R242

R220

R221

R222

Q218

C848

Q215Q216

Q217

R225

Q219

Q220

Q221

Q222

R229

R230R231

R232

R215R216

R217

R236

R238

R241

R240

IC711

C738

JR716 R720C739 FB715

R718R717

JR717

R721

Q711

Q710

R719

C722

IC710

D710

C713

D711

JR720

C740 R711

R712

C723

R716

FB714

FB713

R715R714

FB712

FB711

FB710

R713

C736

C735C734

JR713C737

C709

JR721R710

C910C923

C921C915C925C912

Q904

R901

R902

R905

Q903

Q906

R906

C918

FB205

C919

FB798

R226

R903

JW713

JW71

8

JW716

JW710JW711

JW714

JW717

JW72

0

JW730

JW731

JW732

JW70

0

JW70

6

JW70

7

JW708 JW709

JW702

JW704

JW70

5

JW715JW721

JW722

JW72

3

JW724

CLP001

CLP003

JW725

JW72

6

JW701

JW703

JW73

6

JW73

7JW

738

JW739JW740

JW741

JW74

2

JW727

JW75

0

CLP004

CLP005

JW751JW752

CLP006GN88D

CLP007

JW75

4

CLP008

C849

CN20

8

JW799

JW798 C215 C216

C217C218

C219 C220

C221 C222

CN712

C742C721

C710

C711C714

L710

C712

EPT702

C715

C716

C717C718

C741C720C719

C733

C732

C726

C725

C728C727

C729C731

C730

L711

C724

CN711

JW71

9IC903 Q905IC904 IC906IC901

C922

CN714

IC902

C926

C917

C924

CN713

C911

C913

IC905

JW904

JW728

JW729

JW743

JW744

JW745JW746

JW733

CN715

CN71

0

CN207

1 2

1 2

1

20 21

2

25 24

16 17

17 1

18 34

11(11)

1-688-164-

11(11)1-688-163-

VIDEO BOARD REGULATOR BOARD

1313131313 14 E C B

111 10

44

E

E

E

E

E E E

EE

E

E

14

5 8

J712S–VIDEO

OUT

C Y

VIDEOOUT

COMPONENTVIDEO OUT

PR/CR

J710

J711

PB/CBY

Q

C

MAINBOARD

(Page 48)

GAME INBOARD

(Page 53)

RMAIN

BOARD(Page 48)

S

DMB03BOARD

(Page 36)

PDMB03BOARD

(Page 36)

TMAIN

BOARD(Page 48)

UMAIN

BOARD(Page 48)

VDMB03BOARD

(Page 36)

2 3 4 5 6 7 8 9 10 11

A

1

B

C

D

E

F

G

HCD-GN88D

4747

7-17. SCHEMATIC DIAGRAM – VIDEO, REGULATOR Board –

TP710

TP711

TP712

TP713

Q904

R901

C714

C717

C724

C726

C728

C730

C731

C732

C733

C737

C738C739

C742

CN712

D710

D711

J711

L710

R710

R712

R713

R714

R715

R716

R718

R719

R721

J710

FB710

FB711

FB712

FB713

FB714

FB715

C713

CN713

JR716JR717

C741

TP714

R720

R905

R906

C712

IC905

C709

C918

C919

C922

CN714

C926

C917

C924

C848

TP798

TP799

CN207

CN208

R225

R226

R227

R228

R229

R230

R231

R232

TP804

Q215

Q216

Q217

Q218

Q219

Q220

Q221

Q222

C215 R215

C216 R216

C217 R217

C218 R218

C219 R219

C220 R220

C221 R221

C222 R222

JW799

TP805

TP806

JW798

FB798

CN715

FB205

CN711JR720

JR721

CN710

C913

R717

C735C734C736

C715

C716

C721

C722

R711 C723

C740

JW719

L711

R902

IC904

IC906

IC903

C911

C912

IC901

R903

C849

C711

C923

C910

C925

C915

C921

IC711

C729

C727

C725

Q710

Q711 J712

IC710

R235

R236

R237

R238

R239

R240

R241

R242

Q903

Q906

IC902

Q905

C718

C719

C720

C710

FA1A4M

2.7k

10016V

150V

470 6.3V

470 6.3V

470 6.3V

100 16V

22 50V

100 16V

22 50V

220p

22p50V

22p50V

47 16V

17P1MM

1SS355

1SS355

1P

10k

75

75

75

75

75

100k

10k

10k

0PJACK 3P (V)

0

0

0

0

0

0

0.01

10P2.5MM

00

22 50V

75

10k

10k

1000 10V

TA7805LS

100p

0.1

0.1

22006.3V

4P2.5MM

47010V

4706.3V

4706.3V

0.1

21P1MM

25P1MM

10k

10k

10k

10k

10k

10k

10k

10k

2SC3661

2SC3661

2SC3661

2SC3661

2SC3661

2SC3661

2SC3661

2SC3661

10 50V 1k

10 50V 1k

10 50V 1k

10 50V 1k

10 50V 1k

10 50V 1k

10 50V 1k

10 50V 1k

MT

MT

0

4P2.0MM

0

2PAMP-L

0

0

4PAMP-L

220016V

68

22p50V

22p50V

22p50V

1 50V

1 50V

100 16V

0.1 25V

10k 0.1

0.1

2.2k

TA7804LS

TA7805LS

TA7809LS

47010V

0.1

TA7809LS

2.2k

10006.3V

1050V

0.1

0.1

0.1

0.1

0.1

MM1568AJ

22 25V

22 25V

22 25V

FN1F4M

FA1A4M

NJM2244M

10k

10k

10k

10k

10k

10k

10k

10k

FA1A4M

FA1A4M

PQ12RF21

2SB1375

150V

150V

150V

1050V

VIDEO OUT

COMPONENT VIDEO-OUT

9V REGULATOR

VIDEO AMP/BUFFER

BUFFER

BUFFER S VIDEO OUT

VIDEO SELECTOR

MUTEQ215-222

BUFFER

BUFFER+9V REGULATOR

+12V REGULATOR

+3.9V REGULATOR

+5V REGULATOR

+5V REGULATOR

+B SWITCH

+B SWITCH

HCD-GN88D

4848

7-18.PRINTED WIRING BOARD – MAIN Board – • See page 24 for Circuit Boards Location.

Q302 I-4Q303 I-4Q304 H-3Q305 H-3Q306 F-3Q307 I-5Q310 I-5Q389 F-3Q390 F-5Q391 E-3Q392 E-3Q393 E-4Q394 E-3Q395 E-4Q396 E-5Q398 F-5Q399 F-4Q601 B-5Q602 D-3Q620 H-10Q621 I-2Q650 H-9Q651 H-9Q652 I-2Q670 G-10Q671 I-2Q701 G-10Q702 G-10Q730 I-10Q798 C-8Q799 C-8Q800 D-9Q801 D-8Q802 E-8Q803 E-8Q851 G-10Q852 H-10Q853 H-10Q854 H-10Q903 G-6Q909 G-7Q910 G-7

Ref. No. LocationRef. No. Location

D130 H-9D201 B-7D202 B-7D392 E-4D393 E-4D394 E-4D501 B-2D502 B-2D503 B-2D504 B-2D505 B-2D508 B-2D509 B-2D517 D-5D601 B-5D602 B-5D603 B-5D701 G-10D851 G-10D852 H-10D901 I-7D902 H-7D917 G-6D941 G-6

IC102 E-9IC103 C-9IC201 B-11IC301 G-3IC302 H-4IC303 F-4IC501 C-4IC502 I-8IC601 B-5IC730 I-10IC907 G-7

Q101 D-8Q105 D-6Q151 G-9Q223 B-9Q224 A-9Q301 H-5


JR138

Y8

Y9

JR002

JR003

JR006

JR009

31 30

80 81

1100

5051

Y2

Y4

Y6

Y5

JR005

JR004

C360

C398

R107

R40

1

R501

C502

R50

2

R402

C503 R50

3R504

IC303

R505R506

R507

R509

R511

C510

C511 C512R513

C416

R51

7

R419

R519

R420

R522

R311

C498

R429

R430R810

IC102

R808

D20

1

R365

Q389R314

R334

R395

R315

R397

R307

Q399

R396

R355

C399

R302

R398

C805

R805

C802

C844

R809

R600

R540

R54

1

R442

R44

3

R444R445

R44

6

R447

R448 IC601R450

R549

R55

0

R542

R543

R54

4

R54

5

Q80

0

Q392

R394

Q394

Q395

R392

R330

D392

D393

D394

C807C812

R59

1

R59

0

R529

R589

R581

R582

R583

R584

R585

R58

6

R587R580

R579

R578

R477

R577

R576

R575

R574

R474

R473

R573

R57

2

R832

C843

R56

9

R567

R566

C564

R560R561

R603

R114

R521R604

D603

Q601R601

R602

D505 D601

D602

R373

R399

R364R360

R361

Q398

R378R377

R376

R375

R374

R369R368

R367

C334

R304

C810

R380

Q910

C200

FB117

IC30

1

R67

6

Q621Q67

1

R656

R625R67

5

FB167

C168

C118

R168

R118

R11

7

R167

R157

Q909R921

Q224

C223

C213

R234R235

R598

Q802

R812

R329

D85

1

D517

IC730

R772

R771

R721

R722

C772

C722

R305

C321

R303 C395

R312

JR390

R306

C364

R310R308

R30

9

R387

R354

R35

2

C326

R35

1

C731

R720 R770

R730

R62

6

C376

Q730

R848

R917

R915

R233

R150

R104

R101R102

Q803

R316

R166

R116

R857

R92

3

R922

R478

R121

C121

R122

C122

R154R151

R152

R156

R155

Q151

R112

R48

8

R702

C847

R654R655

Q652

R653

D941

R90

4

R313

R905R906

C202

R588

R850

R814

C384

R530

C333

C383

R379

R388

R342

R345

R393

R328

Q305

Q310

R811

R843

R421R422

R849

D501D502

D50

3

D50

4

R362

D50

8

D50

9

R813

C814

R844

IC502

R825

R845

C855

R847

C816

R370

R106

R563

R105

Q101

R132

R818

R802

R131

R130

R133

R815

R390

Q670

R353

D130

R110

C836

C851

Q853

D852

Q854

R85

1

R852

R854

R327

R83

1

Q799

R838

R837R841

R84

2

R833

R391

Q798

R834

R800R801

C835 R828

Q602 R846

C596

R670 R671

R672

R62

0

R621

R622

Q620

R623

R673

R650

Q650

Q651

R652

IC103

D701

R333

Q306

R798

R79

9

R816

C801

Q223

R823

R827

R840

R821

JR731

R835

Q702

R822

R81

7

Q701

C840

R826

R836

C839

R861

Q390

R301

R33

2

C115

C211

R807

R803

R804

R829

R806

R347

R382

R366

R523

C314

R651

Q307

R34

6

R317

Q304

R830

Q801R824

R839

C846

C371

Q301

R372

C387

R594

C386

R363

R320

R371

D20

2

C852

R863

R860

R862

Q852

R916

R856

R858R859

FB516

R81

9

FB562

FB204

R103

R153

R82

0

R134

R593R493

R492R592

IC50

1

JR104

JR015

R853

R495

R595

C595

JR008

Y10

Y11

Q105

R149

JR10

R62

9

R63

0

JR011

FB716

JW399

JW018

JW00

1

JW00

2

JW00

7

JW00

8

JW01

2

JW01

3

JW01

4

JW03

2

JW034

JW035

JW03

6

JW03

7

JW04

1

JW04

3

JW04

5

JW057

JW058

JW059

JW060

JW073

JW074

JW075

JW076

JW077

JW078

JW079

JW081

JW09

6

JW09

7

JW09

8

JW10

5

JW10

6

JW10

7

JW10

8

JW112

JW11

7

JW11

8

JW11

9

JW120

JW121

JW12

2

JW12

3

JW12

4

JW12

5

JW12

6

JW12

7

JW12

8

JW129

JW130

JW131

JW132JW135

JW136

JW137

JW138

JW14

1

JW14

2JW

143

JW14

4

JW14

5

JW14

6

JW14

7

JW176

JW194JW196

JW19

9

JW20

3

JW20

4

JW20

5

JW20

6

JW20

7

JW20

8

JW21

3

JW23

3

JW23

4

JW23

5

JW37

3

JW362

JW35

2

JW35

3

JW038

JW039

JW03

3

JW031

JW030

JW02

5

JW02

7

JW02

2

JW02

3

JW02

8

JW02

9

JW01

5

JW019

JW010JW009

JW00

6

JW00

5

JW00

4

JW052

JW053

JW054

JW055

JW056

JW06

2

JW071

JW068

JW067

JW069

JW158

JW159

JW11

0

JW10

9

JW15

0

JW29

6

JW29

8

JW29

9

JW30

0

JW30

1

JW30

2

JW30

4

JW309

JW29

0

JW28

6

JW33

6

JW09

5

JW16

9 JW168

JW167

JW28

0

JW166

JW165

JW161

JW151

JW17

1

JW17

2

JW17

3

JW17

4

JW17

5

JW177

JW178

JW179

JW180

JW181

JW21

2

JW21

4

JW21

5

JW23

6

JW23

2

JW23

1

JW23

0

JW268

JW269

JW267

JW270

JW258

JW257

JW255

JW249

JW250

JW21

1

JW139

JW140

JW134

JW133

JW38

8

JW38

7

JW082JW083

JW080

JW072

JW05

1

JW011

JW003

JW325

JW326

JW274

JW273

JW272

JW37

5

JW37

6

JW365JW02

4

JW225

JW28

9

JW374

JW36

7

JW36

9JW

187 JW366

JW21

8

JW38

0

JW224

JW28

8

JW22

8

JW22

6

JW28

2

JW28

1

JW310

JW293

JW06

1

JW10

2

JW182

JW27

6

JW198

JW29

5

JW22

9

JW264

JW08

5

JW08

6

JW08

7

JW08

8

JW08

9

JW09

0

JW09

1

JW09

3

JW09

4

JW111

JW33

8

JW33

9

JW34

0

JW07

0

JW04

7

JW04

8

JW34

1

JW34

8

JW34

7

JW33

0

JW33

5

JW36

8

JW219

JW364

JW38

2

JW35

5JW

287

JW30

5

JW30

3

JW320

JW319

JW316

JW311

JW370

JW389JW38

5

JW275

JW271

JW244

JW383

JW156

JW157

JW29

4

JW251

JW26

1

JW28

5

JW28

4

JW28

3

JW16

4JW162

JW14

9

JW160

JW152

JW153

JW09

9

JW050

JW10

4

JW10

3

JW04

4

JW37

1

JW37

2

JW260

JW259

JW190

JW191

JW317

JW35

6

JW401

JW403

IC201

J117

J730

CN502

C102

C307

CN501

X501

X502

C516

C621

C811

C809

C808

C390 C396

C397

C365

C603

C831

Q393

C315

C813

CN304

C562

C602

C601

Q851

C905C904

C201

C671

R62

4R67

4

C351

C903

C854

D917

C902

IC907

C909

R701

C651

C391

NO901

C316

EPT901

C309

C721

C306

C304

C771

C353

C305

C310

C359

C730

C308

C355

C354

C301

C385

C150

J716

C833

C167

C117

C101

C103C104

C105

C106

C107

C108

C109C111

C112

C113C114

C335

D902

L201

OUT

3.3V

GND

CN702

C214

C331

FB203

C901

C152

C153

C155

C156

C157

C158 C159

C161

C162

C163

CN85

1

C920

C832

NO905

Q903

IC302NO303

NO302

CN301

CN202

C822

C203

C336

C342

L302

T301

Q30

3

C341

R343R344

C382

C340

C338

Q302

C337

C339

RV304

RV351

L351

C356

RV301

CN902

CN205

C303

CN901

C838

C824

Q396

C821

C827

C154

C212

C829

C800

C817

C908

C116

C130

C823

C819C803

NO781

Q391

C842

C834

C670

RV354

C620

C650

C804C818

CN40

2 C841

C845

C828

C837

C830

C825

C826

C815

C906

C311

C361

C806

C312

C921

C820

C140

NO904

NO204

C911

C110

C160

JW238

JW90

4

JW90

5

JW90

6

JW907

JW243

JW240

JW241

JW242

C131

JW901

JW359

JW34

3

JW34

2

JW345

JW334

JW332JW247

JW246 JW248

JW337

JW357

JW405

JW04

9

JW40

2

CLP03

JW344

CLP04

CLP05

NO

903

JW19

3

JW113JW114

JW115

JW02

6 CLP02CLP01

JW90

3

JW262

JW32

9

JW36

1

C381

JW19

5

L301

JW148C332

JW333

JW322

RY701

JW04

6

JW021

JW01

7

JW01

6

JW020

JW34

6

JW404

JW10

1

JW040

JW18

5

JW084

JW263

JW18

6

JW18

8

JW256

JW381JW799

JW386

JW315

JW358

JW33

1

JW30

8

JW254

JW239

JW902

C919

JW314

JW312

JW318

JW163

JW154

JW10

0

C598

C149

JW192JW200

JW202

JW209

JW155

JW21

0

CN206

CN201

CLP0

6

L901

JW35

1

D901

CN203

JW360

JW116

C922

JW32

7

JW38

4

JW39

0

JW184

JW27

9

JW253

JW252

JW24

5

JW223

JW328

JW354

JW23

7

JW170

JW183

JW21

6

JW220CLP07

JW217

CD DIGITAL OUT

MD/VIDEO(AUDIO)IN

L

R

SUBWOOFER

AUDIO OUT

L

R

M891DC FAN

1

3

E

E

EE

E

E

E E E

E

EE

C

B

17

148

E

E

EE

E E

E

E

EE

E

E

E

E

E

E

E

E

EE

E

E

E

E

E

1 3

E

E

E

E

E

E

1

1

1

113

6

6

3

4

1 2 3 4 5

110

1

1

1

34

4

E

1 12

111 7

62

4 10

1 9

1

7

1

7

1

1

8

9

40 1

21 20

1110

3031

1 3

14

5 8

11

2

9

1213

121

4222

E

E

1

2 10

11 1 21

2 20

121

4222

RVIDEOBOARD

(Page 46)

GSURROUND

BOARD(Page 59)

WDMB03BOARD

(Page 36)B

DRIVERBOARD

(Page 34)

XDMB03BOARD

(Page 36)

(FOR CHECK) (FOR CHECK)

I

DISPLAYBOARD

(Page 55)

J

GAME INBOARD

(Page 53)

(FOR CHECK)

TAPE AHEAD

TAPE BHEAD

TAPEMECHANISM

DECK

EPOWER AMP

BOARD(Page 57)

DPOWER AMP

BOARD(Page 57) U

REGURATORBOARD

(Page 46) QVIDEOBOARD

(Page 46)HTRANSBOARD

(Page 61)FSUB TRANS

BOARD(Page 61)

TREGURATOR

BOARD(Page 46)

TUNERPACK

11(11)1-688-165-

MAIN BOARD

4

E

2 3 4 5 6 7 8 9 10 11 12

A

1

B

C

D

E

F

G

H

J

I

HCD-GN88D

4949

7-19. SCHEMATIC DIAGRAM – MAIN (1/4) Board –

C102 C103

C104

C105

C109

C111

C121

C122

C130

C131

C152 C153

C154

C155

C156

C157 C158

C159

C161 C162 C163

C620

C650

C670

C671

C901

CN402

CN851

CN901

CN902

D130

EPT901Q101

Q151

Q621

Q650

Q670

Q671

R101

R102

R104

R106

R121

R122

R132

R150

R151

R152

R154R156

R563

R620

R621

R622

R625R650

R651

R652

R670

R671

R672

R673

R674

R675

R854

C150

R906

Q651

R904

R905

C140

NO781

NO903

NO904

D902

D917

Q909

Q910

NO905

R131

C922

C101

R157

R107

Q852

Q853Q854

R851

R853

R852

R116

R166

D851

D852

D941

Q105

R115

FB203

C919

C116

C108

C106

C107

C112

C113

C115

R130

R155

R653R655

R654

R624C621

C651R656

R626

R676

R105

R149

C149

C902

C906

R923

L901100µH

R922

R921

C905

C904

C920

C921

C909

C908

R133

C851

R153

C160

R103

C110

C114

R114

Q602

Q652

IC907

D509

R623

Q620

C360

IC102

R134

R629

R630

Q851

C852

D901

Q903

IC502

1050V

1050V

1050V

1050V

150V

1050V

47p

47p

10 50V

0.4750V

1050V

1050V

1050V

1050V

0.02

250

VM

F

0.02

250

VM

F

0.03350VMF

150V

1050V

0.22MF

0.33MF

4.750V

150VBP

4.750V

4.7 100V BP

330025V

19PFFC-R

3P

6PB-TO-B

13PB-TO-B

1SS355

GND PLATE2SC1623

2SC1623

2SC3661

FN1F4M

2SC3661

2SC3661

2.2k

10k

1k

10k

100

100

1M

2.2k

2.2k

10k

1k10k

10k

10k

1k

47k

1k15k

470k

68k

10k

1k

47k

10k

680 2W

1k

4.7k

1050V

1k

FA1A4M

8.2k

8.2k

0.068

9P2MM

WIRE MT

7P2.5MM

WIRE MT

102.5MM

WIRE MT

D5SBA20

RK36

FA1A4M

FA1A4M

6P2.5MM

WIRE MT 2.2k

47025V

10010V

100

100

2SC1623

2SC1623FA1A4M

22k

100k

22k

100

100

UDZ-6.2B

UDZ-7.5B

UDZ-TE-17-33B

2SC1623

5.6k

JW

33006.3V

22010V

0.03

3

0.02

2

0.02

2

0.22

0.33

0.1

2.2k

47k

1k100k

100k

6802W

4.7100V

4750V 10k

56

56

47k

4.7k

1050V

2.250V

10016V

10k

47

820

0.01

0.01

1050V

10050V

0.1

0.1

100k

0.1

620

0.0068

620

0.00

68

1050V

0

FA1L3ZVACS

CONTROL

FN1F4M

SI-80333.3V REG

1SS355

10k

2SC3661

0

M61529FP-60G

470

470

2SD2525

0.1

D3SBA20-4101

2SB1375

RT8H015C-TH12-1

GC

B1

M+9V

TC+9V

B3

3.3V

EVER+3.9V

D+3.9V

ZIVA-D+3.3V

ZIVA

AUD

IO 5

V

ZIVA

V+5

V

A+9V

B4

AC C

UT D

ETEC

T

FAN

SUPP

LY

LINE

MUT

E

DBFB

F/B SW -B

GND

75

77

79

83

50

78

REC-

OUT-

RRE

C-OU

T-L

MD-

LM

D-R

TC-P

B-R

TC-P

B-L

DOW

N-M

IX-R

DOW

N-M

IX-L

SUR2

SUR1

SUR-

SW

SW-O

UT

LINK

-R

LINK

-LST-L

MIC

GAM

E-L

GAM

E-R

72

88

MIC

GAME-L

GAME-R

49

4

73

74

48

29

30

72

ST-R

71

23

80

76

68

*1

PROTECTEROVER CURRENT

DRIVEFAN MOTOR

Q851-854

MUTING

MUTING

MUTING

CONTROL

BUFFER

BUFFER

MUTE

MUTE

-33V REGULATOR

MUTING

SWITCH

SWITCH

B+ SWITCH

Q909,910

ELECTRICAL VOLUME

GRAPHIC EQUALIZER CONTROL,

INPUT SELECT SWITCH,

DC FAN

M891

v1 R134

3.3k

2.7k

TH

EXCEPT TH

HCD-GN88D

5050


L201100µH

IC201

R770

R720R721

R771

R722

R772C771

C721

Q730

C117

C167R168

R118

R117

R167

R365

R315

Q399R313

R314

C399

C398

C395

IC303(2/2)

C391

Q398

Q390

Q306

Q389

R333

JR731

C315

C365

C316

C817

C845

C801

C802

R802

R801

R800

C800

C803

R803

C804 C805

C807

R807

R806

R805R8

04

C806

C808

R808

C809C810

C812

R812

R811

R810

R809

C811

C813C814

C816

R815

R814

R813

C815

C818 R8

16

C819

C844

R832

R833

C843

R834

C842

C840

R829

R830

R831

C839

C841

C837

C836

R826

R827

C835

R828

C838

C834

R824

R825

C832 R8

23R8

22C8

30

R818

R817

R839R837R835 R840

C820 C823R838R836

R844

R845R849R850 R847

C824 C827R846R848

CN205

R798

R799

C846 C8

47

C213 C214

R857 R858

R860R861 R862

Q803

J730

J117

CN203

RY701

D701

R701

Q701

Q223

Q224

C212

C722

C772

R730

FB117

FB167

C396

R395

R394

C390

R398

R397

R327R396

R390

IC303(1/2)

C200

R388

R387

R334

Q798Q799 Q800 Q801

J716

C855

Q702

CN206

JR390

C397

R702

R841 R843R842

R863

R362

C854

C821

C822

C825

C826

C828

C829C8

31

C833 R821

R235

IC103

FB204

C223 R233R234

R819R820

JR008

Q802

IC730NO204

C730

C731

C201

C211

TOX141

1k

1k100k

100k

1k

1k2.250V

2.250V

FA1A4M

2.2 50V

2.2 50V1k

1k

100k

100k

10k

10k

2SC3624A1k

1k

0.01

0.01

22p

NJM4565M(TE2)

10016V

FA1A4M

FA1A4M

FA1A4M

FA1A4M

2.2k

0

1 50V

1 50V

1 50V

1050

V

1050

V

220p

220p

10k

470

47k

1050

V

1050

V 47k

10 50V 0.001

0.00

1

4.7k

2.2k

10k47

k

1050

V 1050

V47

k

1050V 0.001 0.

001

4.7k

2.2k

10k47

k

1050

V

1050V 0.001

0.00

1

4.7k

2.2k

10k

1050

V

1050

V

47k

150

V

220p

10k

470

220p

47k

1050

V

0.00

222.

2k2.

2k47

k

0.00

1

1050

V

1050

V

0.00

222.

2k2.

2k

0.00

1

47k

1050

V

100

10V

10k

1M10

50V

1M10

k10

50V

1k

2.2k

47k47k1k 1k

4.750V

4.725V

10k10k

10k

47k47k1k 1k

4.725V

4.725V

10k10k

7P2.0MM

PH

100

100

47p 47

p

0.1 10006.3V

0 0

47k10k 47k

2SC1623

2P

2P

9P2MMPH

SW RELAY

1SS355

2201/4W

FA1L3Z

FA1A4M

FN1F4M

1000 6.3V

220p

220p

10k

0

0

2250V

4.7k

10k

47010V

2.2M

15k

15k10k

10k

NJM4565M(TE2)

0.1

22k

10k

100k

2SC36612SC3661 2SC3661 2SC3661

1P

0.125V

2SC1623

21P1MM

0

1050V

3.3k

10k 10k10k

10k

10k

22010V

0.220.1

0.33

0.22

0.33

0.220.04

7

10010V

1M

470k

M61530FP-D60G

0

0.1 22k22k

620620

0

2SC1623

NJU4066BM4P2.0MM

1050V

0.1

100 10V

0.1

B1 B2

B3B4

63

3.3V

TC+9

V

TC M

UTEGN

D

ZIVA

-D+3

.3V

ZIVA

V+5

V

ZIVA

AUD

IO 5

V

25

AC C

UT D

ETEC

T

FAN

SUPP

LY

LINE

MUT

E

DBFB

F/BSW

A+9V

-B

82

86 87

84

85

DOW

N-M

IX-L

DOW

N-M

IX-R

FRON

T-L

FRON

T-R

SURR

OUND

-L

CENT

ER

SURR

OUND

-R

SW(L

FE)

REC-OUT-R

REC-OUT-L

MD-L

MD-R

AMS-L

AMS-R

DOW

N-M

IX-L

DOW

N-M

IX-R

SUR2

SUR1

SUR-

SW

DOW

N-M

IX-R

DOW

N-M

IX-L

SUR2

SUR1

SUR-

SW

DOW

N-M

IX-R

DOW

N-M

IX-L

SUR2

SUR1

SUR-

SW

DOWN-MIX-L

DOWN-MIX-R

FRONT-L

FRONT-R

CENTER

SURROUND-L

SW-O

UT

SUR-

L

SUR-

L

SUR-

R

SUR-

R

CENT

ER

CENT

ER

SW SW

81

SURROUND-R

SW(LFE)

70

LINK

-R

LINK

-L

SUB WOOFER

R

L

R

L

CD DIGITAL OUT

AUDIO OUT

MD/VIDEO(AUDIO)

IN

DRIVERELAY

Q701,702

CONTROLSURROUND VOL

MUTEQ798-801

SWITCH

SWITCH

MUTEQ306,389

IC303HPF

BUFFER

BUFFER

AMS DETECT

Q390,398,399

INVERTER

SWITCHAUDIO OUT

HCD-GN88D

5151


CN301

Q302

R347

C342

RV354

RV304C3

41

R393

R342

R392

L301

L351

C385

Q391

R360

Q396R364

Q395

Q393

R367

R366

R368

R369

R378

R377

R376

R375

R374

R373

R351

R352

R301

R302

C304

C354

R304

R354

C306

C356

R307

C308

R303

C310

R308

R309

R310

R312

Q310

R380

R382

R332

R305

C355

C305

R317

R316

D392

D393 D394

R311

R372

CN304

NO302

C333

C383

NO303

R361

Q392

R399

Q394

R353

R328

C321

C371C326

C376

C307

R320

R370

C364

C314

R391R371

R329

C331 C381

R379

C336

R345 C338

R346 C339

C340

C386

R363

C337

R344

R343

C332

C382

C384

C335

T301

L302100µH

C309

R306

C312

C361

C301

C303

C311

C359

C334

C351

C353

C387

R330

RV301

Q303

Q305

IC302µPC1330HA

IC301

Q307Q301

Q304

RV351

R355

3PMOLEX

2SC2001

3.3k

4716V

220k

220k

1050

V

4.7k

2.2k

2.2k

27mH

27mH

1050V

2SB1116

680

2SB1116680

FA1A4M

2SB1068

10k

680

10k

10k

10k

10k

10k

10k

10k

2.2k3.3k

4.7k

3.3k

4.7k

1050V

1050V

2.2k

2.2k

2.250V

2.250V

1M

47010V

10k

10 50V

100

4.7k

100

100

FA1A4M

22k

8.2k

8.2k

47k

150V

150V

10k

10k

1SS355

1SS355 1SS355

100

2.2k

13P

WIRE MT

330p

330p

WIRE MT

2.2k

FA1A4M

3.3k

FA1A4M

10k

2.2k

390p

390p

390p

390p

1050V

2.2k

2.2k

0.0022

0.0022

3.3k3.3k

10k

0.01 0.01

10k

2.250V

18k 0.0068

18k 0.0068

0.018

0.0047

2.2k

0.015

5.61/4W

5.61/4W

120p

120p

27p

0.01

BIAS TRANS

4716V

22k

1050V

1050V

0.01

0.1

1050V

4716V

27p

0.01

0.1

0.0047

22k

47k

2SC2001

FA1A4M

HA12237

2SA1162-G2SC3624A

FN1F4M

47k

47k

TC-PB-L

TC-PB-R

TC

B1

B2

3.3V

M+9V

TC+9V

TC MUTE

GND

55

54

53

52

51

57 58

56

69 67 61 6066

65

REC-OUT-R

TC-PB-R

TC-PB-R

TC-PB-L

TC-P

B-L

AMS-R

AMS-L

919089

59

REC-

OUT-

L

(FOR CHECK)

TAPE A

HEAD

HEAD

TAPE B

(R)

REC LEVEL

REC LEVEL

(L)

REC BIAS

(L)

REC BIAS

(R)

TAPE MECHANISM

DECK

OSCBIAS

OSCBIAS

BUFFER

BUFFER

REC/PB SWITCH

REC/PB EQUALIZER AMPDECK A/B SELECT

SWITCH

SWITCHRIPPLEFILTER

DRIVE DRIVE DRIVE

Q395,396B TRIG

Q396,394CAP MOTOR

Q391,392A TRIG

HCD-GN88D

5252

7-22. SCHEMATIC DIAGRAM – MAIN (4/4) Board – • See page 76 for Pin Function Description.

R509

C511

C510

R549

R543

R447

R544

R445

R444

R443

R540

R541

R589

R590

R591

D501

D502

D503D504

C601

R602

D505

R603

R604D603

R523

D508

R420

CN501

R504

CN502

R545

R446

R442

R550

R560

R561

R566

R567

R569

R450

R572

R581

R582

R583

R584

R473

R474

R448

R503

R505

R506

R507

R600

R501

R521

R522

R421

R422

R542

R594

R495

X501

R575

R519

R578

D602

R601

R579

R580

R585

R586

R587

R577

R588

R488

CN201

CN202

CN702

R915

R916

R917

C596 C498

C603

C602

D601

R430

R429R530 R529

C416

C512

R513R5

11

R502

R477

R478

R598

R595

R110

R112

R573

R574

C564C562

C502

R419

NO901

D201

D202

C202 C203R592 R492

FB51

6

FB562

R593

R493

C911D517

C503

R402R401

IC501

Q601

IC601

C598

R576

R517

C516

X50210k

15p

22p

10k

10k

100

10k

100

100

100

100

100

100

100

100

1SS355

1SS355

1SS355

1SS355

1050V

4.7k

1SS355

47k

47k1SS355

10k

1SS355

4.7k

4P

100

10P

10k

100

100

10k

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

100

10k

10k

10k

100

33k

32.7

68K

100

10k

100

1SS355

220

100

100

100

100

100

100

100

100

7P1MM

12PAMP-L

11PFFC-R

100k

100k

10k

0.1 0.1

0.1

0.1

1SS355

100

10010k 10k

0.1

0.1

0

330k

100

10k

10k

100

1k

0

0

10k

10k

0.01100 10V

0.022

100

4P2MM

WIRE MT

1SS355

1SS355

0.1 22010V

150 4.7k

0UH

0UH

2.250V1SS355

0.022

10k10k

M30620MCN-A27FP

2SC1623RESET

SWITCH

M62703MLLEVEL DETECT

100010V

220

10k

100010V

16MHz

GC

TC

63

3.3V

D+3.9V

EVER+3.9V

ZIVA-D+3.3V

GND

B4

25

M+9VB1

A+9V

5358 52 51545556

47

45

34

33

32

29 304

31P

31P

34P

34P

33P

33P

32P

32P

9P

12P

9P 12P

43

44

46

23

40

41

49

50

59 57606169 67 66

85

86

81

82

83

84

73

48

65

29

30

29

30

21 22

87

74

42

88

89

90

91

3 5 6 7100

1 2

100

1

7

6

5

3

2

42

43

44

45

32

33

40

34

29

30

42

41

43

22

21

44

45

46

47

ST-R

ST-L

757677787980 70 687172

*2

*1

*2 R593

1k

4.7k

E15,E3,E51,EA,MX

4.7k E15,E3,E51,EA,MX

*1 R493

0

TUNER

PACK

(FOR CHECK)

(FOR CHECK)

SYSTEM CONTROL

AU,PH,SP,MY

AU,PH,SP,MY,TH

HCD-GN88D

5353

V

V

V

V

CN606R604

C604

EP703

CN607JW607

CLP704

R742

J721

C741R737

C748

C742

JW60

2

R721 R7

40

JW60

3

R743

Q721

C737

R744

R734

C744

R739

R738

C717C718

C606

C635

R605

C749

CLP702

C716

JW60

9

J601JW601

C747

R746

R722

R602

R603

C715

JW605

C719 C723

R736

C729

C736

C738

JW60

4

R745

C739

C731

C728

C721

C722

C724

C727

C735

C726

C725

C733

C732

C730

C734

R727

R729

R730

R731

R747

R723

R733

R726

R724

R725

R728

D705

C740

R735

RV722

RV721

C743

IC722

IC721C6

30

C631

EP701

J631

JW764

JW61

3

C634

JW61

0

C720

R788 R789NO603 S790

R790

S789S788

D748

R748

S749

D748R749

Q748E

S792

R792

S791

R791

S762

S750S768

S767

R1001

S763

R762

R763D1003

Q1001Q1006

R1002

D1002

Q1002

R1003

R1004

JW10

02

S760

S761

D1001D1011

C751

C752

JW1001C750

312

JW1003

JW1018

R765

C615

IC603

C614

3 2 1

S769

CN605

R625

R750

S771

D1012

JW10

20

JW1007

JW1008

D1004

JW10

09JW

1010

JW1019

D1005R1005

JW10

05

JW10

04

R761

JW1014

E

E

E E

E

E

R1011

R759

S748

JW1016

R760

D1010

D1009

S772

Q1005R1009

R1010

JW10

15

S759

S766S765

R776

R777

R775

R774

S773

JW10

11 C100

0

R766

R1013

R768 R1

012

R769

R767

R770

Q1003 R1006

D1006

D1013R772

R773

R771

R100

7R1

008D1008

Q1004

S770

D1007

JW10

17

JW1013

JW1022

CLP703

VOLUME BOARD

GAME IN BOARD

CD SWITCH BOARD

11(11)1-686-936-

11(11)1-686-937-

11(11)1-686-935-

PUSHENTER

MOVIEEQ

EFFECTON/OFF

MUSICEQ

SOUNDFIELD

DVD TOP MENU/DIRECTION

FM MODEREPEAT

MULTI CHANNELDECODING

TUNER MEMORYPLAY MODE

AMP MENU DISPLAY

VOL 4

VOLUME

GROOVE

ILLUMINATION

VOL 11P.FILE GAME EQ

VOL 5

VOL 6VOL 7

VOL 8

VOL 9

DVD MENU

VOL 10

VOL 3

VOL 1

VOL 2

EX-CHANGEDISK SKIP

DISC 3 DISC 2 DISC 1ZOPEN/CLOSE

PHONES

MIC

GAME INPUT

MIC LEVEL

ECHO LEVEL

AUDIO

VIDEO

L

R

14

5 8

8

7

14

1

E

CL

REGULATORBOARD

(Page 46)DISPLAYBOARD

(Page 55)

JMAIN

BOARD(Page 48)

1

9

MDISPLAYBOARD

(Page 55)

2 3 4 5 6 7 8 9 10 11 12 13

A

1

B

C

D

E

F

G

H

I

7-23.PRINTED WIRING BOARD – GAME IN, CD SWITCH Board – • See page 24 for Circuit Boards Location.

D748 H-12D1001 E-9D1002 D-10D1003 D-10D1004 C-10D1005 C-9D1006 B-9D1007 C-8D1008 C-8D1009 D-8D1010 D-8D1011 E-8D1012 B-9D1013 C-9

IC603 B-11IC722 D-2

Q721 E-3Q748 H-11Q1001 D-9Q1002 D-10Q1003 C-9Q1004 C-8Q1005 D-8Q1006 D-8


Ref. No. Location

HCD-GN88D

5454

7-24. SCHEMATIC DIAGRAM – GAME IN, CD SWITCH Board –

R742

R738 R737

R739

R743

C747

C741 C739

R735IC722(1/2)

IC722(2/2)

C736

R736

R734

C737

C719R745

C715

J631

R602

R603

C604

C606

EP703

EP701

CN607

CLP702

RV722C738

R722

R721

C718 R746

R604

R605

C748

C744

C742

C740

C743

C749

C717

J721

C635

C634

C631C630

Q721

J601

CN606

IC721

C722

R723

C721

R724

C724

R725

C723

C725 C726

C727

R726

D705

R731

C732

C731

C730

R728

C729R730 R727

C728

R729

R747

C735

R733

RV721

C716

C734 C733

R740R744

R792 R791 R789R790 R788

D748

R748

Q748

R749

S791 S790S792 S788S789

S749

NO603

R773 R774 R775

R770R766 R771

R761R760R759

R625

R762

R767 R768 R769

R750

R765

R776 R777

R763

D100

5

R1005

Q1005 Q1004

R1004

D100

4

D100

3

Q1003

D100

2

R1002

Q1002 Q1001

R1001

D100

1

D101

0

R1010 R1009

D100

9

D100

8

R1008

D100

7

R1007

Q1006

R1006

D100

6

D101

1

R1011

CN605

CLP703

R1003S771

S769

S765

S770

S759 S761S760

C614

S762

S768

S767

S766

S750

S763

S748

C751C752

IC603

S773

C750

R772

S772

R1012

C1000

JW1010

D1013

D101

2

R1013

C615

1k

1k 22k

100k

10k

2.250V

0.1550V

47p50V

180kNJM4565D

NJM4565D

1050V

10k

100

1050V

2.250V100

47p

1k

1k

2.250V

2.250V

2P

50k2.250V

18k

10k

10010V 1k

100k

100k

0.022

0.001

47p

100p

470p

0.1

10010V

0.001

0.001

0.0010.001

2SC2785TPBIAS

3P

9P

M65850PECHO AMP

0.0068

15k

0.0015

15k

0.068

15k

150V

0.2250V

0.2250V

0.015

47k

MTZJ-T-72-5.1B

120k

0.068

0.0068

0.022

15k

150V

15k 15k

0.0015

15k

150

2.250V

15k

50k

0.1

4716V

16V10V

2.2k

100k

33k 22k 10k15k 6.8k

SELS5223SRED

330

BA1A4M

270

5PAMP-L

6.8k 10k 15k

2.2k680 3.3k

15k10k6.8k

47

22k

1k 1.5k 1.5k

270

470

22k 33k

33k

SLI-3

25UR

T31W

TRE

D

470

BA1A4M BA1A4M

470

SLI-3

25UR

T31W

TRE

D

SLI-3

25UR

T31W

TRE

D

BA1A4M

SLI-3

25UR

T31W

TRE

D

470

BA1A4M BA1A4M

470

SLI-3

25UR

T31W

TRE

D

SLI-3

25UR

T31W

TRE

D

470 470

SLI-3

25UR

T31W

TRE

D

SLI-3

25UR

T31W

TRE

D

470

SLI-3

25UR

T31W

TRE

D

470

BA1A4M

470

SLI-3

25UR

T31W

TRE

D

SLI-3

25UR

T31W

TRE

D

470

17PFFC-L

WIRE

470

0.001

VOLUME ENCODER

0.10.1

ROTARY SWITCH

0.1

4.7k

470

0.1

1SS133T

SEL5

E20C

-S-T

PBL

UE

10k

4716V

55 54 53 52 56 57

52 53 54 55 56 57

R

L

AUDIO

VIDEO

12

3

45

67

8

IC722MIC AMP

GAME INPUT

I/

I/

OPEN/CLOSE

EX-CHANGE

DISC SKIP

LED DRIVE

VOLUME

LED DRIVEQ1001-1006

HCD-GN88D

5555

7-25.PRINTED WIRING BOARD – DISPLAY Board – • See page 24 for Circuit Boards Location.

IC601

Y1

Y2

Q601

Q707

S758

R634

R635

R632

R633

D601

CN601

R631

JW701R636

R637JW70

2

Q606

S779

JW756

JW757

S755 S754

S753

S756

JW75

4

S757

JW709

JW71

5

JW71

6

R779

R654

R656R655

JW714

JW717

JW718

JW70

3

JW704JW705

Q605

JW707JW706

D106

JW71

3JW

724

JW71

9

JW72

1JW

722

JW72

0

JW72

3

D107

JW72

5

JW76

0

R758

JW71

2

JW710

JW708

C620

C619

C710

C618

C711

L602

JW749

CLP701

R753

R754

S751

S752

R657

JW752

R751 R752

NO60

2

JW751

L601

R755 R756

R757

C652

C651R647

C653

R645D610

R646

JW753 R821

FL601

X601

R660

C623

JW74

8

JW763

R817

R818

R819

R820

Q807Q808

JW75

9

JW700

R670

JW75

5

JW75

0

R663

R658

JW72

7

JW72

6

C622

R662

R661

JW72

9JW75

8

JW73

8JW

737

JW74

0JW

739

JW72

8

C105

JW733 JW734JW735

JW73

6

JW732C712

JW10

8R137

JW10

9 R140

JW10

7

R127D100 C115

R128

D105

C110C121

JW730

D102

R110

C106

C107

R108

R109

R105

R107

C109

C624

C625

C626

C627

C628

R808

R807

JW74

1JW74

5

JW74

7

JW76

2

R112

Q602

Q603

D605 R626

R627

D604

R628

D606

JW74

3JW

742

R130

S784

D603Q604

R106

R629

S783R630C122

R111R113

R785

S785

S787

S786

R786

R787

JW74

6

JW74

4

R117

R132

R133

R129

IC101

R104 C1

01

C102

C104

R102

R103 D101

R119R123R125

C120

S782

R783

C119

R781

R782

R784

R114

R115

R116

IC102

C112

C111

R121 C1

16

C117

R120

R122

JW76

1

R659

C123

R822

R823

R136 R1

38

R139Q100

JW10

6

C125

C152

C153

C118

JW11

3

C154

CN604

D602

JW10

5

JW102

R118

R124

C114

D103

D104

JW112

JW10

3R131

JW10

4R134C100

C124

JW10

1

C155C156

C157R6

53R6

52

DVD

TUNER/BAND

TAPE A/B

MD(VIDEO)

GAME

GAME MIXING

S781

KARAOKE/MPX

x

h h

X

>

M

>

M,ALBUM+

–,

,ALBUM–

CD SYNC

RECPAUSE/START

,+

E

E

E

E

E

E E

1 100

50 51

81

8030

31

14

5 8

11(11)1-686-934-

DISPLAY BOARD

MVOLUMEBOARD

(Page 53)

IMAIN

BOARD(Page 48)

LCD SWITCH

BOARD(Page 53)

E

E

E

85

14

JW731

2 3 4 5 6 7 8 9 10

A

1

B

C

D

E

F

G

D100 D-6D101 D-8D102 C-8D103 E-8D104 E-8D105 D-6D106 E-4D107 E-4D601 F-2D602 E-9D603 D-9D604 B-9D605 C-9D606 C-9D610 A-2

IC101 D-7IC102 F-9IC601 B-5

Q100 D-6Q601 G-2Q602 B-9Q603 C-9Q604 D-9Q605 F-2Q606 F-2Q707 G-2Q807 B-7Q808 B-7


Ref. No. Location

HCD-GN88D

5656

7-26.SCHEMATIC DIAGRAM – DISPLAY Board – • See page 78 for Pin Function Description.

MAINBOARD

(1/4)(Page 49)

CD SWITCHBOARD

(Page 54)

VOLUMEBOARD

(Page 54)

FL601

CN601

D106

D107

S758S756S754S753S752S751S779S782S783S784

S781

S785S786S787

CN604Q602Q603Q604

R632

R636

R634R633

R637

R635

R670

D604 D601D605D606D603D602

D101

D102

D103

D104

D100

R130

R129C122

R137

C124

R136

R139

C123R140

R138C118

D105

R127

R128

C121C120

R125

R124

C119

R123

C114

R118

R119R117

C115C110C105

R107 R113R111

R106 R112

C109C104

C107R110

IC101(2/2)

C106

R109

R108

R133

R132

R104C102C101

R102

R103IC101(1/2)

C653

C651

C652

R808 R807

C622

C712 C628

C627

C626

C625

C624

C711 C710L602

C618

C620

C619

C112

R116

C111

R114

R115

R131

R134

R120

R121

C116

IC102(2/2)

R122

C117

NO602

R105

R628 R626R627R629R630

R779R782 R781R783R784

KARAOKE/MPX

R785R786R787R631

R756R755 R757R754R753R752 R758R751

R662

R663

R655

R656

R661

R652

R658

R659

R657

R654 R822

R823

C623

IC601

R660

R818

R819

R820

R821

R817

R647R646

D610R645

C153

C154

C155

C156C157

C152

C125

S755S757

X601

L601R653

Q100

IC102(1/2)

Q807

Q808

Q707

Q601

Q605 Q606

C100

19PFFC-S

10EDB40

10EDB40

17PFFC-L BA1A4MBA1A4MBA1A4M

680

10k

10k680

10k

10k

JW

SEL5923AAMBER

SLR325VCRED

SEL5923AAMBER

SEL5923AAMBER

SEL5923AAMBER

SEL5923AAMBER

1SS1

33T-

72

1SS1

33T-

72

1SS1

33T-

72

1SS1

33T-

72

MTZ

J-T-

72-3

.3B

4.7k

4.7k1006.3V

22k

1050V

68k

330

10010V100

1.8k10

50V1SS133T-72

220

470k

4.750V

0.2250V

100k

100k

1050V

680

1050V

100k

100k680

0.2250V

0.2250V

0.2250V

100k 100k680

100k 100k

1050V

1050V

0.182k

NJM4565D

0.1

1.5k

1.5k

100k

100k

82k0.47

0.471.5k

1.5kNJM4565D

1050V

0.1

1050V

100k 100k

4.750V

0.01

0.01

0.01

0.01

0.01

0.01

0.01 0.01JW

0.01

0.01

4716V

0.022

82k

0.022

1.5k

1.5k

100k

100k

1.5k

1.5k

0.0022

NJM4565D

82k

0.0022

5PAMP-L

680

330 330330330330

4701k 6801.5k1.5k2.2k3.3k4.7k680

2.2k1.5k 3.3k1.5k1k680 4.7k470

10k

10k

100

100

10k

10k

15k

15k

15k

100 1k

1k

0.001

MB90M407PF-G-130-BND

1M

180

180

180

120

120

100100

MTZJ-T-72-5.1B10k

220p

220p

220p

220p220p

220p

0.150V

4MHz

JW10k

2SC3623BUFFER

NJM4565D

BA1L3Z

BA1L3Z

BA1A4MINV.

BA1A4MINV.

2SB1116SWITCH

2SB1116SWITCH

1050V

6665

48

60 61

69 70 71 7368

121314151617181920212224252627282930 10 9 8 7 6 5 4 3 2 1

100

99

9897

9695

94

66

79 80

77

77

93

8788

8990

9192

52 53 54 55 56 57 58 59

31

32

3334

3536

3738

3940

41

4344

6160

49 51

64

48

72

73

72

67

67686970 71

89101213141516171819202122242526272829303132333435363738394041444546

7 6 5 4 3 2 1 100

99 98 97 96 95 92 91 90 89 88 87

4546

43

59 58

93

94

79

65

80

52

53

54

5556

57

64

FLUORESCENT

INDICATORTUBE

REC

PAUSE/START

RECPAUSE/START

+

-ALBUM +

ALBUM -

DISPLAY

BUFFER

BUFFER

KEY CONTROLCONTROL,

LED DRIVEQ602-604

HCD-GN88D

5757

7-27.PRINTED WIRING BOARDS – POWER AMP Board – • See page 24 for Circuit Boards Location.

Q581

Q503E

EEQ504

C581 R561

R509

R559

C507

C508

C557

C558

TH501

Q514R531

R522

Q506Q505

D504

D503

R508

R558

Q501Q551

R555

IC501

C516

Q510

C517

Q511

C546C596

C542C592

D541

R519

R581

CN50

3

C551

R551

R552

C553

R553

C554

R518

C552

C503

R503

C504

C509

R512

R511

R547

R548

D507

D511

C559

Q516

Q517

C526

R564

R565

D508

D509

R591

R541

R527

R521

D543

R542

R507

R505

C512

EP502

R513

D581

R517R515

R514

R557

R592

CN

504

R570R569

R568

R572

R545

R546R582

R516

R528

R506

R556

R554

D551D501

R504

R529

R530D502

JW780

JW781

JW783

JW785

JW786

JW787JW788

JW79

0

JW79

1

JW79

2

JW79

3JW

794

JW795

JW79

6

JW797

JW79

8JW

799

JW800

JW801 JW802JW803

JW804JW805

JW806

JW807

JW80

9JW

810

JW81

1JW

812

JW81

3JW

814 JW816

JW817JW818

JW82

0JW

821

JW82

2JW

823

JW82

4

JW828

JW82

9

JW83

0JW

831 JW

832

JW83

3

JW83

4

JW835

JW836

JW83

7

JW838JW840JW841

JW842

JW843

JW844

JW84

7JW

848

JW84

9JW

850

JW85

1

JW85

2

JW85

3JW

854

JW85

5 JW85

6

JW85

7

JW858

JW85

9JW

860

JW861JW862

JW863

JW864

JW865

JW866

JW867

JW868

JW86

9

JW870

JW872

JW874

JW878

JW87

9 JW88

0JW

881

JW882

JW815

PL005

PL006 PL007

R501R502

C502

C501

JW819

RY501

D506

R539

C523

C524

C525

EP501

C527

1NO501

3

C513

JW89

5

JW893

C528

JW894

PL003

JW89

1JW

890

JW88

7JW

886

JW826JW827

JW876JW875

R520

R524

C541

C544

C545

JW78

9

C591

JW897

JW84

6JW

845

JW839

PL010

JW782

JW873

JW896

JW87

7

JW899

JW900

TH502

NO505

JW898

NO502

JW808

R523

R532

R533

R577

Q518R578

JW927

JW926

E

E

E E

E

E

E

E

11(11)1-686-932-

POWER AMP BOARD

FRONT SPEAKER(IMPEDANCEUSE 6–16Ω)

SURROUNDSPEAKER

(IMPEDANCE USE 8Ω)

CENTERSPEAKER

(IMPEDANCE USE 8Ω)

+ - + -LR

TM501

+ - + - + -LR

+–+

–N

SURROUNDBOARD

(Page 59)

1 8

D

E

MAINBOARD

(Page 48)

MAINBOARD

(Page 48)

1

6

OTRANSBOARD

(Page 61)

E

E

KSURROUND

BOARD(Page 59)

2 3 4 5 6 7 8

A

1

B

C

D

E

F

G

H

D501 E-3D502 D-2D503 D-4D504 D-5D506 C-7D507 B-5D508 H-2D509 H-2D511 B-5D541 G-3D543 H-4D551 E-3D581 F-2

IC501 D-4

Q501 E-4Q503 G-2Q504 F-2Q505 B-2Q506 B-2Q510 F-6Q511 F-6Q514 B-2Q516 H-5Q517 H-5Q518 B-2Q551 E-4Q581 F-2


Ref. No. Location

HCD-GN88D

5858

7-28. SCHEMATIC DIAGRAM – POWER AMP Board –

R501

R551

R504

D501

D551

R509

R559

R582

R581

C581

R561

Q506

Q505

R524

R520

C544

C545

R592

R533

R532

JW566

JW567

D506

Q510

R527

R528

R529

R530

C516

R539

D507

CN503

CN504

D502

R508

R558

NO502

R578

C502

C552

C501

C551

C554

C504

R512

R517

R516

R513 R515

R514

D581

R519

C559

C509

R521

R522

Q514

C512

RY501

R545

R548R547

D511

JW890

JW886

TH502

NO505

TH50

1

JW891

JW887

R577

JW92

7

D541

C596

R555

R556

R557

R507

Q501

Q551

IC501(2/2)

IC501(1/2)

D503

D504

C503

R503

R553

C553

R511

D543

C546

R542

EP501

C513

C542

R541

C592

R591

C591

C541

R523

R502

R552

R554R518

R506

JW92

6

R565 R564

D509 D508

C517R546

R570

R569

Q581

Q504

Q503Q517

Q516

R572

R568

Q518

C526

C507

C508

Q511

C558

C557

EP502

R505

JW872

JW895

C524 C523

C525

C527

C528

NO501

R531

1k

1k

47k

1SS1

33T

-72

1SS1

33T

-72

101/2W

101/2W

33k

33k

22 50V

1001/4W

FR

2SC2785

2SC2785

3.3k1W

3.3k1W

0.1100V

0.1100V

100k

47k

100k

1SS133T

2SC2785

56k

47k

22k

22k

10010V

6802W

1SS133T

13P

6P

1SS133T

0.15W

0.15W

560k

1000p

1000p

4.750V

4.750V

10010V

10010V

11/4W

FR

10k

10k

33k 22k

2.2k

1SS133T-72

68k

22100V

22100V

100k

100k

2SC2785

0.01

RELAY24V

1k

47k47k

1SS133T

8P

100

RBV-2506

2200100V

820

33k

100k

100k

2SC1841OVER LOAD

DETECT

2SC1841OVER LOAD

DETECT

STK412-150POWER AMP

STK412-150POWER AMP

MTZJ-T-72-18C

MTZJ-T-72-18C

220p

330

330

220p

1001/4W

FR

D5SBA20

2200100V

100k

TERMINAL, EARTH

0.01

330050V

100k

330050V

100k

0.1

0.1

100k

47k

47k

47k33k

33k

22k 22k

1SS133T 1SS133T

1050V 22k

10k

47k

2SC1841STANDBYSWITCH

2SC1841STANDBYSWITCH

2SA1207STANDBYSWITCH

2SA1175TP-HFE

2SC2785

100k

10k

2SC2785FAN MOTORON SWITCH

1050V

0.068

0.068

2SC2785RELAY

SWITCH

0.068

0.068

EARTH

820

0.01 0.01

0.01

0.01

0.01

3P

R CH

L CH

VH

VH

VL

VL

*1

-

+

-

+

-

+

-

+

R

L

R

L

(IMPEDANCE

FRONT SPEAKER

(IMPEDANCE

SURROUND SPEAKER

RELAY DRIVEFRONT SPEAKER

RELAY DRIVEFRONT SPEAKER

SWITCH

OVERLOAD

DETECT

SWITCHDETECT

Q505,506,514TEMPERATURE

-

+

(IMPEDANCE

CENTER SPEAKER

*1 R531

300k

330k

TH

EXCEPT TH

TM501 10P

HCD-GN88D

5959

7-29.PRINTED WIRING BOARDS – SURROUND Board – • See page 24 for Circuit Boards Location.

11(11)1-686-938-

SURROUND BOARD

NPOWER AMP

BOARD(Page 57)

KPOWERBOARD

(Page 57)

GMAIN

BOARD(Page 48)

1

8

(CHASSIS)

RY381

RY382

JW310JW311JW312

JW323

JW382

C352

JW334

JW30

8

R401

R344

R343

R342

R341

R351

C343

C342

NO30

2

7

1

R352

C304R303

JW338

JW305

R302

C302

JW306

R345

JW304

JW309

JW307

JW337

R309

R308 R307

R310

R331

R360 R349

R348

R350

D351 D341

R359

R357

R332

R396

R402

R395

R358

JW32

9JW

331

R388

JW38

3

D381

D382

JW316

D301C306

C307

JW32

05 1

CN304 JW31

9

JW31

8

EP30

1

Q384

JW33

6

R397

JW324JW381

JW322JW321

R387

D391

R319

R320

R305

R356

R301C301

JW30

2JW

301

R353

IC301

R361

R311

C308

C358

JW31

3

C354 C319C344

C341

C351

C357

C356

Q381

R390

C347C346

R304

R354

R347

E

E

E E

E

E

E

Q351

Q383

Q341

Q386

Q301

JW33

5

JW325

JW326

JW315

C353

1 18

C303

JW333

R399

Q385

JW31

4CN

303

CLP301

JW317

R333

CLP302

E

2 3 4 5 6 7

A

1

B

C

D

E


Ref. No. Location

D301 C-3D341 C-5D351 C-4D381 C-5D382 B-6D391 C-2

IC301 E-4

Q301 C-3Q341 C-6Q351 C-4Q381 B-2Q383 B-5Q384 C-5Q385 C-2Q386 D-6

HCD-GN88D

6060

7-30. SCHEMATIC DIAGRAM – SURROUND Board –

C301

D391

EP301

R301

R307

R311

R331

R332

R357

R361

R397

R399

Q384

R305

R356

Q385

CN304

D382

D381

R388

R395

R387

Q381

Q383

R401Q386

R347

R348

R345

R349

D351

R358

R359

Q351

D301

R308 Q301

R309

C302

C354

R302

R352

R304

C352

C341

C342

C353

C343

R341

R342

R344

C344

R343

R354

R353

C304

R303 R320

C303

IC301

R319

C308

C358

D341

Q341

R350

C347

C346

R360

C357

C356

JW331

C306

C307

R310

R390

JW30

8

JW329

NO302

JW38

3

JW382

JW381

R396

R402

R351C351

C319

R333

RY381

RY382

CN303

4.750V

1SS133T

GROUND PLATE

1k

1k

1001/4W

FR

47k

56k

1k

1001/4W

FR

1k

1k

BA1F4M-TP

0.225W

0.225W

2SC2785TP

5P

1SS133T

1SS133T

6802W10

k

680 2W

2SA1175TP

2SA1175TP

1kBATF4M-TP

1k27

k

0.225W

100k

1SS1

33T

27k

100k

2SC2785TP

1SS1

33T

27k

2SC2785TP

100k

220p

4710V

47k

47k

47k

220p

4.750V

220p

220p

220p

1k

47k

47k

4710V

330

47k330

4710V

330 1

1/4WFR

220p

STK443-090

20k

10063V

10063V

1SS1

33T

2SC2785

10

0.068

0.068

10

0.068

0.068

0.068

0.068

10

10k

7P

22k

22k

1k4.750V

0.01

68k

6P

RELAY DRIVE

OVER LOADDETECT

OVER LOADDETECT

OVER LOADDETECT

PROTECTSURROUND SPEAKER

Q381,383

RELAY DRIVEPROTECT

SURROUND SPEAKERQ384,386

OVER LOADDETECTSWITCH

SURROUND AMP

HCD-GN88D

6161

7-31.PRINTED WIRING BOARDS – TRANS Board – • See page 24 for Circuit Boards Location.

F978

F979

F975

F977

JW906

JW907

JW908JW909

F974

PL002

PL008

R941

D977

C941

CN997

CN998

F976

PL009

E3,E15,E51,EAPH,SP,MY

JW91

4

JW912

JW911

JW913

JW91

5

NO973

AUS,TH

AUS,MX,THE3,E15,E51,EA,PH,SP,MY

MX

JW928

JW929

C971T972

SUB POWER TRANSFORMERS901

IC971

D974

D975

C973

D971Q971

RY971CN974C975

C976

C977

JW92

1

D972

D973

C978

R974

R975

PL001PL004 JW920

JW92

4

JW92

2

JW92

3

JW925


AUS,THMX

B100

CN976

CN971

E

TRANS BOARD

SUB TRANS BOARD

11(11)1-686-930-

11(11)1-686-931-

EXCEPTMX

EXCEPT AUS,TH

1

2

3

4

AUS,MX,TH

E3,E15,E51,EA,PH,SP,MY

1

1

7

1

6

4

1 4

1

3

1

2

EXCEPTMX

AC IN

120V 220V 230-240Vt t

VOLTAGE SELECTOR

*

* NOT REPLACEABLE: BUILT IN TRANSFORMER

T910POWER TRANSFORMER

H

O

MAINBOARD

(Page 48)

POWER AMPBOARD

(Page 57)

FMAIN

BOARD(Page 48)

2 3 4 5 6 7

A

1

B

C

D

E

F


D971 B-4D972 B-6D973 B-6D974 C-6D975 C-6D977 D-3

IC971 A-5

Q971 B-4

Ref. No. Location

HCD-GN88D

6262

7-32. SCHEMATIC DIAGRAM – TRANS Board –

CN974

D975

D973 D972

D974

CN998

CN976

RY971

D971

C975

R975

C973R974

C978

C977 C976

C971

JW920

T972SUB POWER

TRANSFORMER

CN997

POWER AMPBOARD

(Page 58)

MAINBOARD

(1/4)(Page 49)

6P

7P

JW928

JW929

F976F977

F974 F975

C941F978

D977

JW92

4

JW92

3

JW922

JW925

S901

JW914

JW915

JW912

JW911

JW913

T910

IC971

Q971

CN971

NO973

R941

2PVH

11ES2

11ES2 11ES2

11ES21SS133T

220016V

10k

10016V

100k

0.1

0.1 0.1

10000p

T8.0AL/250VT8.0AL/250V

T6.3AL/250V

F9793.15A/250V

T6.3AL/250V

10063V

T4.0AL/250V

11ES2

TA7804LS+3.9V REG

2SC2785

1

*3

AUS,MX,TH

AUS,TH EXCEPT MX

MX

VOLTAGE SELECTOR

120V

220V

230-240V

MX

AUS,TH

EXCEPT MX

AUS,MX,TH



AUS,MX,TH


AUS, MX, TH


AUS,MX,TH


EXCEPT AUS, TH

POWERTRANSFORMER

BUILT IN TRANSFORMERNOT REPLACEABLE:

**

AC IN


*2 NO973

4P

2P


AUS,MX,TH

4PE3,E15,E51,EA,PH,SP,MY

MAINBOARD

(4/4)(Page 52)

2P

*3 CN971

RELAY DRIVEPOWER ON/OFF

63

HCD-GN88D

7-33. IC Block DiagramsIC252 TC7WH157FK (TE85R) (DMB03 BOARD)

11OE 56 1LELE

23

4

56

7

89

10

11121314

151617

18

192021

22

2324

25

2627

LATCH

LATCH

282OE 29 2LE

OE

LEOE

1D11D2

GND

1D31D4

VCC

1D51D6

GND

1D71D81D9

1D10

2D12D22D3

GND

2D42D52D6

VCC

2D72D8

GND

2D92D10

1Q11Q2

GND

1Q31Q4

VCC

1Q51Q6

GND

1Q71Q81Q91Q10

2Q12Q22Q3

GND

2Q42Q52Q6

VCC

2Q72Q8

GND

2Q92Q10

5554

53

5251

50

4948

47

46454443

424140

39

383736

35

3433

32

3130

SELECT116

ST117

A 1

2

3

A

B

Y5

Y

B

GND 4

VCC8

YEN G

Y

IC216 SN74ALVCH16841DGGR (DMB03 BOARD)

IC302 PCM1609KPTR (DMB03 BOARD)

SYSTEMCLOCK

MANAGER

FUNCTIONCONTROL

INTERFACE

SERIALINPUT

INTERFACE

4X/8XOVER SAMPLING

DIGITALFILTERWITH

FUNCTIONCONTROLLER

ENHANCEDMULTI-LEVELDELTA-SIGMA

MOJULE

ZERO DETECT

DAC LPF

DAC LPF

DAC LPF

DAC LPF

DAC LPF

DAC LPF

DAC LPF

DAC LPF

RST

SCKISCKO

BCK

TEST

VDD

DGND

DATA1DATA2DATA3

ZEROA

LRCK

37

3839

40

42

43

44

454647

48

41

ZERO

1/GP

O1

ZERO

2/GP

O2

ZERO

3/GP

O3

ZERO

4/GP

O4

ZERO

5/GP

O5

ZERO

6/GP

O6 NC NC

VOUT

6

VOUT

5

VOUT

4

VOUT

3

1 2 3 4 5 6 7 8 9 10 11 12

VOUT2

VOUT1

VCOM

VOUT7

AGND5VCC5AGND6

VOUT8

AGND4VCC4AGND3VCC3

13

14

15

16

171819

20

21222324

ML

MC

MDI

MDO

ZERO

8DA

TA4

ZERO

7

NC VCC1

AGND

1

VCC2

AGND

2

36 35 34 33 32 31 30 29 28 27 26 25

64

HCD-GN88D

IC706 MSM51V18165F-60TSKR1 (DMB03 BOARD)

NC

A9 A8 A7 A6 A5 A4 VSS

NC NC A0 A1 A2 A3

VDD

VDD

DQ1

DQ2

DQ3

DQ4

VCC

DQ5

DQ6

DQ7

DQ8

WE

RAS

3132 2930 262728

2019 2221 24 25232

VDD

1 43 65 87 109

VSS

DQ16

DQ15

DQ14

DQ13

VSS

DQ12

DQ11

DQ10

DQ9

4950 4748 4546 4344 4142 35

I/OSE

LECT

OR

OUTPUTBUFFER

INPUTBUFFER

OUTPUTBUFFER

INPUTBUFFER

SENSEAMPLIFIER

COLUMNDECODERS

MEMORYCELLS

WORDDRIVERS

ROWDECODERS

ON CHIPVBB GENERATOR

ON CHIPIVCC GENERATOR

COLUMNADDRESSBUFFERS

LCAS

34

UCAS

33

OE

I/OCONTROLLER

I/OCONTROLLER

17 1811 – 16

NC

40 – 36

ROWADDRESSBUFFERS

INTERNALADDRESSCOUNTER

REFRESHCONTROL

CLOCK

TIMINGGENERATOR

VCC VDD

VDD

VDD

IC509 CXD3068Q (DMB03 BOARD)

DOUT

LRCKPCMD

BCK

DVDD2ASYEMD2

EMPHXTSL

DVSS2XTAI

XTAO

SQSOSQCKSCSYSBSOEXCK

SOUTSOCKXOLT

SETEVCTES1TEST1DVSS1FRDR

FFDR

TRDR

TFDR

SRDR

SFDR

DVDD1FSTOSSTP

MDPLOCKPWMI

FOKDFCT

DIGITALCLV

PROCESSOR

OSC

DIGITALOUT

EFMDEMODULATOR

32KRAM

ERRORCORRECTOR

D/A DIGITALINTERFACE

MIRR, DFCT,FOK

DETECTORCPU

INTERFACE

SUBCODEPROCESSOR

SERVOAUTO

SEQUENCER

SERVO INTERFACE

DVDD

0

XRST

MUT

E

DATA

XLAT

CLOK

SENS

SCLK

ATSK

WFC

KXU

GFXP

CK GFS

C2PO

SCOR C4M

WDC

KDV

SS0

COUT

MIR

R

AVDD

0IG

ENAV

SS0

ADIO

RFDC

CE TEAVSS

1RF

ACAS

YIAS

YO

BIAS

AVDD

1PC

OFI

LIFI

LOCL

TV

V16M

VCTL

VPCO

59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

2122

232425

262728

29

30

31

32

33

34353637383940

8079787776

757473

7271706968

676665

64

636261

OPER

ATIO

NAL

AMPL

IFIE

R &

ANAL

OG S

WIT

CH

A/D

CONV

ERTE

R

FOCUSPWM

GENERATORTRACKING

PWMGENERATOR

SLEDPWM

GENERATOR

FOCUSSERVO

DSPTRACKING

SERVODSPSLED

SERVODSP

ASYMMETRYCORRECTOR

DIGITALPLL

CLOCKGENERATOR

60

65

HCD-GN88D

IC903 BR24C16F-E2 (DMB03 BOARD)

8VCC

7TEST

6SCL

5SDA

1 A0

2 A1

3 A2

4 GND

ADDRESSDECODER

SLAVE WORDADDRESS REGISTER

DATAREGISTER

16 K bit EEPROM ARRAY

CONTROL CIRCUIT

POWER SUPPLYVOLTAGE DETECTION

HIGHT VOLTAGEGENERATOR

11 bit 8 bit

11 bit

STOPSTART

ACK

IC906 SM8707GV-G-E2 (DMB03 BOARD)

VDD1

VSS1

MO1

NC

REFDiv.1

PHASEDETECTOR1

PHASEPUMP1

LPF

LOOPDiv.1

X'talOSC

CONTROLLOGIC

NC16

NC15

NC14

SO313

VDD312

VSS311

SO210SO19

4

3

VDD2

VSS2 6

XTI 7

XTO 8

5

1

2

VCO

66

HCD-GN88D

MUX ATT INPUTBIAS AGC

GCA

PROGRAMMABLEEQUALIZER

FILTERDIFFERENTIATOR

64 63 62 61 60 59 58 57 5156

12

FULL WAVERECTIFER

AGC CHARGEPUMP

+–

+–

++

+++

+

++

++

––

+–

+–

INPUTSEL ATT

2

4

2

2

INPUTIMPEDANCE

SEL

OFFSETCANSEL

MNTRCONTROL

SERIALPORT

REGISTER

4FROM

S-PORT

4FROM

S-PORT

INPUTIMPEDANCE

SEL

3FROM

S-PORT

CLAMP &ENVELOPE

LEVELDACSIGDET

AGCO

BUFFER

55 54 53 52 50 49

OUTPUTINHIBIT

FROM S-PORT

3

4

5

6

78

9

10

11

12

13

14

15

16

17

GCA

CD/DVD

4FROM

S-PORT

3FROM

S-PORT

MUX

3FROM

S-PORT

GCA

3FROM

S-PORT

3FROM

S-PORT

EQ

VC

COMPARATOR

PHASEDETECTOR

PHASEDETECTOR

A+D

B+D

++

A+C

B+C

GCAW/LPF

SUMAMP

18 19 20 21 22 24 2523 26 27 28 29 31 3230

GCAGCA

VCI FOR SERVO INPUT

VC = VPB/2

DUAL APC

LD H/LFROM S-PORT

APC SELDVD/CD

TOPHOLDGCA

TOPHOLD

GCA

41

48474645

GCAOFFSETCANSEL

5FROM

S-PORT

GCA 40

GCAOFFSETCANSEL

6FROM

S-PORT

3FROM

S-PORT

GCAGCA

CEFDBCP/CNLOW

IMPEDANCE

CD/DVD

SUBGCAMUX GCALPF

GCALPF

39

38

3736

OFFSETCANSEL

PEAK/BOTTOMHOLD

BOTTOMENVELOPE

INPUTBUFFER

5FROM

S-PORT

GCALPF

V25/2

TERST

35

34

33

FOR SERVOOUTPUT

PH

TOPHOLD

GCASEL

LINKEN

MUX

HOLDEN

+–

+–

COMPA-RATOR

INTERNALFDGHG

HYSTERESISTER& OFFSET

FROM S-PORT

MIRRCOMPARATOR

INPUT GAINFROM S-PORT

SEL

DAC

SINK CURRENTFROM S-PORT

2

AGCO

FAST ATTACK

AGCHOLD

BCADET

2FROMS-PORT

PH

2

2

INPUTIMPEDANCE

FROM S-PORT

4443

42

V33 FOROUTPUTBUFFER

PIFETECE

V25V125

V25/3

LPF ATTPOL SELBUFFER

CONTROLSIGNALSTO EACHBLOCK

3CE ATTCEPOL

D

C

B

A

CD F

CD E

VPB VC

DVDL

DCD

LD

CDPD

DVDP

D

LDONVN

B

MIR

R

MP

MB

MIN

MEV

O

MLP

F

CE

SDENSDATASCLKV33

FE

TE

PI

V25V125

TPH

DFT

LINK

LCPLCN

MNTR

DVDRFPDVDRFN

A2

B2

C2

D2

CPCN

D

C

B

A

CD D

CD C

CD B

CD A

RFDC

RFSI

N

ATOP

ATON

AIN

AIP

VPA

RFAC

VNA

BYP

DIN

DIP

FNP

FNN

MEV

RX

IC001 SP3723BDA0PM (RF BOARD)

67

HCD-GN88D

IC710 NJM2244M-TE2 (VIDEO BOARD)

IC711 MM1568AJBE (VIDEO BOARD)

2SW1

3VIN2

4SW2

1VIN1 8 GND

7 VOUT

6 V+

5 VIN3 (MUTE)

BIAS

75 ΩDRIVER

4dB

4dB

VCC2

75ΩDRIVERLPF

LPF

LPF

75ΩDRIVER

2dB4dB

2dB

75ΩDRIVER2dB

75ΩDRIVER2dB

4dB

75ΩDRIVER2dB

4dB

75ΩDRIVER

4dB2dB

CIN 2

VIN 4

MUTE1 3

YC MIX 5

YIN 6

BIAS 7

GND1 8

NC 9

GND1 10

NC 11

CYIN 12

CLP 13

CbIN 14

CrIN 16

GND2 17

MUTE2 15

VCC1 1 34

CrSAG18

CrOUT19

CbSAG21

GND220

CbOUT22

CYSAG24

GND223

GND226

CYOUT25

YSAG27

YOUT28

VSAG30

GND229

GND232

VOUT31

COUT33

+

BIAS

BIAS

BIAS

BIAS

BIAS

CLAMP

CLAMP

CLAMP

LPF

LPF

LPF

IC701, 712 BA6956AN (DRIVER BOARD)

1 2 3 4 5 6 7 8 9

CONTROL LOGIC

TSD

VREF

OUT2

OUT1

RNF

VM VCC

FIN

GND

RIN

IC721 M65850P (GAME IN BOARD)

OSCILLATOR

1/2 VCC

AUTORESET

LPF1

MAINCONTROL

A/D

20KBITSRAM

LPF2D/A

1 2 3 4 5 6 7

891014 13 12 11

CLOCK

RESETMO

MID1 DO0

DO1

VCC

CLOC

K

REF

OP2I

N

OP2O

UT

LPF2

IN

LPF2

OUT

LPF1

IN

LPF1

OUT

OP1O

UT

OP1I

N

CC1

CC2

GND

68

HCD-GN88D

7-34. IC Pin Function Description• IC207 ZIVA5X-C1F (DVD SYSTEM PROCESSOR)(DMB03 BOARD)

. 1 VDDP — Power supply terminal (+3.3V) (I/O signal)

2 HA1 I/O Address bus

3 to 11 HD15 to HD7 I/O Data bus (address signal multiplexed)

12 VDDP — Power supply terminal (+3.3V) (I/O signal)

13 GNDP — Ground terminal (I/O signal)

14 to 19 HD6 to HD1 I/O Data bus (address signal multiplexed)



22 HD0 I/O Data bus (address signal multiplexed)

23 HDTACK I/O Acknowledge signal input/output for host data transfer (not used)

24 HIRQ0 I Interrupt signal input for Medusa (not used)

25 WEH.UDS I/O Host upper data strobe signal output (not used)

26 WEL.LDS I/O Host lower data strobe signal output (not used)

27 HREAD I/O Read/write strobe signal output

28 GPIO0 I/O Jig detection port (pull-up)

29 GND — Ground terminal (inside core)

30 VDD — Power supply terminal (+1.8V) (inside core)

31 GND25 — Ground terminal (SDRAM I/O signal)

32 VDD25 — Power supply terminal (+3.3V) (SDRAM I/O signal)

33 to 42 MA9 to MA0 O SDRAM address bus



45, 46 MA10,MA11 O SDRAM address bus

47 BA1 O SDRAM bank select 1 signal output

48 BA0 O SDRAM bank select 0 signal output

49 MCS0 O SDRAM chip select 0 signal output

50 MCS1 O Not used

51 MRAS O SDRAM row address strobe signal output

52 MCAS O SDRAM column address strobe signal output

53 MWE O SDRAM write enable signal output (“H” : read, “L” : write)



56 MCLK O SDRAM Clock output

57 to 60 MD0 to MD3 I/O SDRAM data


62 MDQM0 O Byte read /write mask signal 0 output


















DescriptionPin NamePin No. I/O

69

HCD-GN88D

Pin NamePin No. I/O Discription



105 VCLK I/O System clock (not used)

106 XCK_I/O_SEL I/O 5.1ch/downmix switch signal output

107 VS O S1 signal output

108 I/P SW O Progressive/interlace switch signal output

109 CDSEL O CD-DA selection signal output

110 MREQ O Audio muting request signal output



113 MDI O Serial data output to the D/A converter

114 MC O Serial data clock output to the D/A converter

115 ML O Latch enable signal output to the D/A converter

116 HIRQ2_ I Busy signal input from the EEPROM

117 VDAC_4B — Video DAC bias bit 4 (connected to the ground)

118 VDAC_VDD4 — Power supply terminal (+3.3V) (Video DAC 4)

119 VDAC_4 O VDAC output 4













132 VDAC_DVSS — Ground terminal (Video DAC digital system)

133 VDAC_DVDD — Power supply terminal (+3.3V) (Video DAC digital system)

134 VDAC_REFVDD — Power supply terminal (Video DAC reference)

135 VDAC_REF I Reference voltage input terminal(for Video DAC)

136 VDAC_REFVSS — Ground terminal (Video DAC reference)

137 XVSS — Ground terminal (crystal oscillator)

138 XOUT O Crystal oscillation signal output

139 XIN I Crystal oscillation signal input

140 XVDD — Power supply terminal (crystal oscillator)

141 AVSS2 — Ground terminal (analog PLL)

142 AVDD2 — Power supply terminal (+3.3V) (analog PLL)

143 AVDD1 — Power supply terminal (+3.3V) (analog PLL)

144 AVSS1 — Ground terminal (analog PLL)



147 XCK O Audio system clock output

148 LRCK O LRCK signal output for audio

149 BCK O BCK signal output for audio

150 DATA0(DM) O Audio data(Down Mix signal) output

151 DATA1(FLR) O Audio data(Front L/R signal) output



154 DATA2(SLR) O Audio data(Rear L/R signal) output

155 DATA3(CSW) O Audio data(Center/Subwoofer signal) output

156 IEC958 O S/PDIF signal (not used)

157 DAI_DATA I Data input from ADC (not used)

70

HCD-GN88D


158 DAI_BCK I BCK signal input from ADC (not used)

159 DAI_LRCK I LRCK signal input from ADC (not used)

160 I2C_CL I/O I2C clock bus

161 I2C_DA I/O I2C data bus

162 CS(ZIVA_E2P) O Chip select signal output to the EEPROM (IC204)

163 RXD1 I Serial data input for check jig

164 TXD1 O Serial data output for check jig

165 WRITE_CTRL(ZIVA_E2P) O Write control signal output to the EEPROM (IC204)



168 SDDATA7 I SDBus data7 input










178 SDREQ O SDBus data request signal output

179 SDEN I SDBus data enable signal input



182 SDERROR I SDBus data error signal input

183 SDCLK I SDBus data clock input

184 HIRQ1 I Interrupt signal input from the mechanism controller (IC901)

185 DRVCLK I Serial data clock input from the mechanism controller (IC901)

186 DRVTX I Serial data input from the mechanism controller (IC901) and the EEPROM (IC204)

187 DRVRX I Serial data output to the mechanism controller (IC901) and the EEPROM (IC204)

188 DRVRDY O Ready signal input from the mechanism controller (IC901)

189 VNW — Power supply for 5V tolerance voltage input

190 ALE O Latch enable signal output for address data demux

191 RST_SPC O Reset signal output to the mechanism controller (IC901)

192 INT/EXT O Input selection signal output for SDBus or ADC (not used)

193 HCS2 O Chip select signal output for Medusa (not used)

194 HCS1 I/O Not used

195 HCS0 O Chip select signal output to the external ROM (IC206)


197 TRST I Reset signal input

198 TDO O Data output

199 TDI I Data input

200 TMS I TMS signal input

201 TCK I TCK signal input

202 RESET I ZIVA reset input

203 BUS CLK I/O Not used



206 HA3 I/O Address bus 3

207 HA2 I/O Address bus 2


71

HCD-GN88D

• IC701 TMC57929PGF-RDP (DVD DECODER) (DBM03 Board)

Pin No.

1, 2

3

4

5

6

7

8

9 to 14

15

16

17

18

19

20, 21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

I/O

I/O

—

I/O

I

—

I

—

I

—

O

I

I

I

O

—

I

O

—

O

O

—

O

O

O

O

—

O

O

—

O

—

O

O

O

—

O

O

O

O

—

O

O

—

O

—

I

O

O

I

Pin Name

D5, D6

VSS

D7

A0

VDD

A1

VDD5V

A2 to A7

VSS

XWAIT

XRD

XWR

XCS

XINT0, XINT1

VDD

XHRS

HDB7

VSS

HDB8

HDB6

VDDS

HDB9

HDB5

HDBA

HDB4

VSS

HDBB

HDB3

VDD

HDBC

VDDS

HDB2

HDBD

HDB1

VSS

HDBE

HDB0

HDBF

XSAK

VDDS

XDCK

XSHD

VDD

REDY

VSS

XHAC

HINT

XS16

HA1

Description

Two-way data bus with CXP973064-226R

Ground

Two-way data bus with CXP973064-226R

Address signal input from CXP973064-226R

Power supply (+3.3V)


Power supply (+5V)


Ground

Not used

Read strobe signal input from CXP973064-226R

Write strobe signal input from CXP973064-226R

Chip select signal input from CXP973064-226R

Interrupt signal output to CXP973064-226R


Not used

Stream data signal output to ZIVA5X-C1F

Ground

Error flag signal output to ZIVA5X-C1F


Power supply (+5V)

Not used


Not used


Ground

Not used



Not used

Power supply (+5V)


Not used


Ground

Not used


Not used

Serial data effect flag signal output to ZIVA5X-C1F

Power supply terminal (+5V) (digital system)

Serial data transfer clock signal output to ZIVA5X-C1F

Header flag signal (Not used)


Not used

Ground

DVD mode: Serial data request signal input from ZIVA5X-C1F

Not used (Pull up)

Not used (Pull up)

Not used (Pull up)

72

HCD-GN88D

Pin No.

57

58

59, 60

61

62, 63

64

65

66 to 69

70

71

72

73 to 75

76

77

78

79, 80

81

82 to 87

88

89

90

91

92

93

94

95

96, 97

98

99

100

101, 102

103

104 to 106

107

108

109

110

111

112

113, 114

115

116

117

118, 119

120

121

122, 123

124

125

126, 127

I/O

I/O

—

I

—

I

—

I/O

I/O

—

I/O

—

I/O

O

—

O

O

—

O

—

O

—

O

O

O

O

O

I/O

—

I/O

—

I/O

—

I/O

O

—

O

—

O

—

—

I

I

I

—

—

I

—

O

I

I

Pin Name

XPDI

VDDS

HA0, HA2

VSS

HCS0, HCS1

VDD

DASP

MDB0 to MDB3

VSS

MDB4

VDD5V

MDB5 to MDB7

XMWR

VDD

XRAS

MA0, MA1

VSS

MA2 to MA7

VDD

MA8

VSS

MA9/MNT0

MNT1/MNT1

MNT2/MNT2

XMOE

XCAS

MDB8, MDB9

VSS

MDBA

VDD

MDBB, MDBC

VDD5V

MDBD to MDBF

GFS

VSS

APEO

VDD

DASYO

GNDA5

ASF1, AFS2

DASYI

RFDCC

RFIN

VCCA5, VCCA4

VCOR1

VCOIN

GNDA4, GNDA3

LPF5

VC1

LPF2, LPF1

Description

Not used (Pull up)

Power supply (+5V)

Not used (Pull up)

Ground (open)

Not used


Not used

Two-way data bus with the D-RAM

Ground


Power supply (+5V)


Write enable signal output to the D-RAM


Row address strobe signal output to the D-RAM

Address signal output to the D-RAM

Ground




Ground


EEPROM ready signal output to CXP973064


Output enable signal output to the D-RAM

Column address strobe signal output to the D-RAM


Ground




Power supply (+5V)


Guard frame sync signal output to CXP973064-226R

Ground

Absolute phase error signal output


RF binary signal output

Ground

Filter connected terminal for selection the constant asymmetry compensation

Analog signal input after integrated from the RF binary signal

Input terminal for adjusting DC cut high-pass filter for RF signal

RF signal input from the DVD/CD RF amplifier


VCO oscillating range setting resistor connected

VCO input

Ground

Signal output from the operation amplifier from PLL loop filter

Middle point voltage (+1.65V) input

Inverted signal input to the operation amplifier from PLL loop filter

73

HCD-GN88D

Pin No.

128, 129

130

131

132

133, 134

135

136

137

138

139

140

141

142

143

144

145

146

147

148

149

150

151

152

153

154

155

156

157

158

159

160

161

162

163

164

165

166

167

168

169

170

171

172 to 176

I/O

—

O

I

O

—

O

I

I

I

—

O

—

O

—

O

I

I

O

I

—

I

I

—

I

—

I

—

O

I

O

I

—

O

I

I

I

I

I

—

O

I

—

I/O

Pin Name

VCCA3, VCCA2

PDO

PDHVCC

FDO

GNDA2, GNDA1

SPO

VC2

MDIN2

MDIN1

VCCA1

CLVS

VSS

MDSOUT

VDD

MDPOUT

DEFECT

GSCOR

EXCK

SBIN

VSS

SCOR

WFCK

VDD5V

XRCI

VDDS

C2PO

VDD

DBCK

BCLK

DDAT

MDAT

VSS

DLRC

LRCK

XRST

IFS0

IFS1

XTAL

VSS

XTA2

XTA1

VDD

D0 to D4

Description


Signal output from the charge pump for phase comparator

Middle point voltage input terminal for RF PLL

Signal output from the charge pump for frequency comparator

Ground

Spindle motor control signal output to FAN8035L

Middle point voltage (+1.65V) input

Spindle motor servo drive signal input

MDP input


Control signal output for selection the spindle control filter constant at CLVS

Ground

Frequency error output terminal of internal CLV circuit


Phase error output of internal CLV circuit

Defect signal input (Not used)

Guard subcode sync (S0+S1) detection signal input from CXD3068Q

Subcode serial data reading clock signal output to CXD3068Q

Subcode serial data input from CXD3068Q

Ground

Subcode sync (S0+S1) detection signal input from CXD3068Q

Write frame clock signal input from CXD3068Q

Power supply (+5V)

Not used (Pull down)

Power supply (+5V)

C2 pointer signal input from CXD3068Q


Bit clock signal (2.8224 MHz) output (Not used)

Bit clock signal (2.8224 MHz) input from CXD3068Q

PCM data (Not used)

Serial data input from CXD3068Q

Ground

L/R sampling clock signal (Not used)

L/R sampling clock signal (44.1 kHz) input from CXD3068Q

Reset signal input from CXP973064-226R “L”: reset

Not used (connected to ground)

Not used (connected to VDD)

33.8688 MHz clock signal input from SM8707GV

Ground

System clock output (33.8688 MHz)

System clock input (33.8688 MHz)


Two-way data bus with the CXP973064-226R

74

HCD-GN88D

• IC901 CXP973064-226R (MECHANISM CONTROLLER) (DBM03 Board)

Pin No.

1

2

3

4

5

6

7

8

9

10

11

12

13

14 to 21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43, 44

45

46

47

48

49

50

51

52

53

54

55

56

I/O

O

O

O

O

I/O

I

O

O

I

O

O

O

—

I/O

I

I

O

O

I

O

O

I

I

I

O

I

O

O

O

O

I

—

I

O

—

O

O

O

I

I

O

O

O

I

O

O

—

I

Pin Name

NO_USE

SDEN

DOCTRL/

ISBTEST

XRST_2753

SDA_EEP

MNT1

FCS_JMP_1

FCS_JMP_2

SENS_CD

CDSP2

CDSP4

XCS_DVD

VSS

D0 to D7

INIT0_DVD

INIT1_DVD

MSCK_SAMBA

XRST_1882

SCOR

LAT_CD

LD ON

MIRR

COUT_CD

INLIM

CS_ZIVA

SI_ZIVA

SO_ZIVA

SCK_ZIVA

DRVIRQ

DRVRDY

RST

VSS

XTAL

EXTAL

VDD

SLED_A, SLED_B

SCK_DSD

SDOUT_DSD

SDIN_DSD

READY_DSD

DATA_CD

CLOK_CD

XMSLAT

SQSO

MUTE_DSD

SQCK

VSS

CONTROL_2

Description

Not used (open)

Serial data enable signal output to CXD1881AR

Digital out on/off control signal output to CXD3068Q

Not used

Data bus with the EEPROM

EEPROM ready signal input from CXD1882R

Focus jump 1 signal output to the FAN8035L

Focus jump 2 signal output to the FAN8035L

Internal status (SENSE) signal input from CXD3068Q

Not used

Not used

Chip select signal output to CXD1882R

Ground

Two-way data bus with CXD1882R

Interrupt signal input from CXD1882R

Interrupt signal input from CXD1882R

Not used

Reset signal output to CXD1882R

Subcode sync (S0+S1) detection signal input from CXD3068Q

Serial data latch pulse signal output to CXD3068Q

Laser diode on/off control signal output to CXD1881AR

Mirror signal input from CXD1881AR

Numbers of track counted signal input from CXD1881AR

Detection signal input from limit in switch The optical pick-up is inner position when “H”

Chip select signal output to ZIVA5X-C1F

Serial data input from ZIVA5X-C1F

Serial data output to ZIVA5X-C1F

Serial data transfer clock signal output to ZIVA5X-C1F

Interrupt request signal output to ZIVA5X-C1F

Ready signal output to ZIVA5X-C1F

System reset signal input from ZIVA5X-C1F

Ground

System clock input terminal (20 MHz)

System clock output terminal (20 MHz)


Sled motor drive signal output to FAN8035L

Clock output to CXD1882R

Serial data output (Not used)

Serial data input (Not used)

Ready signal input (Not used)

Serial data output to CXD3068Q

Serial data transfer clock signal output to CXD3068Q

Serial data latch pulse signal (Not used)

Subcode Q data input from CXD1882R

Muting on/off control signal (Not used)

Subcode Q data reading clock signal output to CXD1882R

Ground

Not used

75

HCD-GN88D

Pin No.

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

81

82

83

84

85

86

87

88

89 to 96

97

98

99

100

I/O

I

I

O

O

I

I

O

I

I

I

I

—

I

—

I

O

O

I

I

O

O

I/O

I/O

I

O

O

I/O

O

O

—

—

—

O

O

O

O

O

Pin Name

CONTROL_1

GFS_DVD

MUTE_CD

MUTE_2D

SLED

FG

SP_ON

JIT

TE

PI

FE

AVSS

AVREF

AVDD

GFS_CD

SCLK_CD

TSD-M

FOK_CD

LOCK_CD

LDSEL

SACD/DVD

I2C_SIO

I2C-SCL

RXD

TXD

SDCLK_RF

SDATA_RF

XWR

XRD

(PWE)

VDD

VSS

A0 to A7

A8

XDRST

WP_EEP

CLK_EEP

Description

Not used (open)

Guard frame sync signal input from CXD1882R

Muting on/off control signal output to CXD3068Q

Muting on/off control signal output to FAN8035L

Sled motor servo drive PWM signal input from CXD3068Q

Spindle motor control signal input from CXD1881AR

Muting on/off control signal output to FAN 8035L

Jitter signal input

Tracking error signal input from CXD1881AR

Pull in signal input from CXD1881AR

Focus error signal input from CXD1881AR

Ground

Reference voltage input (for A/D converter)

Power supply (+3.3V) (for A/D converter)

Guard frame sync signal input from CXD3068Q

SENSE serial data reading clock signal output to CXD3068Q

Thermal shut down signal output to FAN8035L

Focus OK signal input from CXD3068Q

GFS is sampled by 460 Hz “H” input when GFS is “H”

Laser diode selection signal output

SACD/DVD selection signal output

Communication data bus input/output

Communication data reading clock signal input/output

Serial data input from the RS-232C (for check)

Serial data output to the RS-232C (for check)

Serial data transfer clock signal output to CXD1881AR

Two-way data bus with CXD1881AR

Write strobe signal output to CXD1882R

Read strobe signal output to CXD1882R

Not used


Ground

Address signal output to CXD1882R

Motor/coil driver power save control signal (Not used)

Reset signal output

Write protect signal output to the EEPROM

Clock signal output to the EEPROM

76

HCD-GN88D


1 STEREO I Stereo signal input from tuner–––––––––––––––––

2 TUNED I Tuned signal input from tuner

3 ST-CE O Tuner chip enable signal output

4 SIRCS I SIRCS input

5 ST-DOUT O Tuner data output

6 ST-DIN I Tuner data input

7 ST-CLK O Tuner clock signal output

8 BYTE — Not used (connected to ground)

9 CNVSS — Not used (Connected to ground with resistor)

10 XC-IN I Sub clock input (32.768KHz)

11 XC-OUT O Sub clock output (32.768KHz)

12 RESET I System reset input

13 X-OUT O Main system clock output (16MHz)

14 VSS — Ground

15 X-IN I Main system clock input (16MHz)

16 VCC — Power supply (+3.3V)

17 NMI I Not used (Pull up with resistor)

18 SOFT-TEST O Not used (open)

19 NO USE — Not used (open)

20 AC-CUT I AC cut check signal input

21 E-1 I DVD/CD turn table encoder signal input

22 E-2 I DVD/CD turn table encorder signal input

23 DVD-POWER (SYSPWR) O DVD power ON signal


25 DVD-MUTE (SYSPWR) O DVD mute signal output


27 STBY-RELAY O Standby relay driver signal output

28 NO USE I Not used (Connected to ground)

29 IIC-CLK I IIC serial clock input

30 IIC-DATA I IIC serial data input

31 TXD1 O Test TX data signal output (Not used)

32 VMUTE2 O Video mute 2 signal output

33 VMUTE O Video mute signal output

34 M-REQ I M request signal input

35 NO USE O Not used (open)

36 NO USE O Not used (open)



39 CLOCK-OUT O Not used (open)

40 SYS-RESET O DVD system reset signal

41 TBL-SENS I Table sensor signal input

42 OPEN SW I CDM eject switch signal input

43 E-3 I DVD/CD turn table encoder signal input

44 TM-F O DVD/CD turn table motor-F signal output

45 MT-R O DVD/CD turn table motor-R signal output

46 LMF O LD motor-F signal output

47 LMR O LD motor-R signal output

48 STBY-LED O Standby LED driver signal output

49 GC-RESET O Display control system reset signal output

50 HP DETECT I Headphone detect input

• IC501 M30620MCN-A27FP (SYSTEM CONTOL) (MAIN Board)

77

HCD-GN88D

Pin NamePin No. I/O Discription

51 REC-MUTE O REC mute signal output

52 TC-MUTE O TC line mute signal output

53 PB-A/B O TC A/B select signal output–––––––––––

54 ALC O ALC signal output

55 TC-RELAY O TC relay control signal output

56 REC BIAS O TC REC bias on/off signal output

57 CAPM-CONT O Capstan motor REV/FWD/STOP control signal output

58 B-TRG O TCM-B Trigger output

59 A-TRG O TCM-A trigger output

60 B-REC-REV I Record tab switch for SIDE-B signal input

61 B-PLAY I TCM-B play switch input

62 VCC — Power supply (+3.3V)–––––––––––––––––

63 AMS-IN I AMS signal input

64 VSS — Ground –––

65 EQ-H/N O EQ high/Normal signal output

66 A-REC-FWD I Record tab switch for SIDE-A signal input

67 A-HALF I A deck half detection signal input

68 SPEANA ATTN O Speana audio level control signal output

69 A-PLAY I TCM-A play switch input

70 SW RELAY O SW relay drive signal output

71 MIC DETECT I MIC detect signal input–––––––––––––––––

72 VACE IN I VACE control signal input

73 DISPLAY-KEY I Display key signal input

74 POWER-KEY I Power key signal input

75 STK-MUTE O Mute signal output to power IC––––––––––––––––––––

76 HP-MUTE O Headphone mute signal output

77 LINE-MUTE O TA LINE mute signal output––––––––––––––––––––––––––––

78 PROTECTOR I Speaker protection signal input

79 AUDIO-DATA O Audio input select data output

80 AUDIO-CLK O Audio input select clock output

81 VIDEO OUT O Video out select signal output

82 AUDIO-OUT O Audio out select signal output

83 FRONT-RELAY O Front speaker relay driver signal output

84LINK-RELAY

O Rear speaker relay driver signal output (REAR L/R SURR RLY)

85 CENTER-RELAY O Center speaker relay driver signal output

86 VOLUME-DATA O Volume level control data output

87 VOLUME-CLK O Volume level control clock output

88 FAN KICK O Fan motor control signal output

89 A-SHUT I TCM-A reel pulse input

90 B-SHUT I TCM-B reel pulse input

91 B-HALF I B deck half detection input

92 MODEL-IN I Model input

93 DEST-IN I Destination input

94 I-HOLD I Sub trans over valtage detect

95 DVD-POWER-CHK I DVD power D+3.3V voltage detect signal input

96 AVSS — Ground


98 VREF I Reference voltage input

99 AVCC — Power supply (+3.3V)

100 ST-MUTE O Tuner mute signal output

78

HCD-GN88D

• IC601 MB90M407PF-G-130-BND (DISPLAY CONTROL) (DISPLAY Board)


1 to 7 G7 to G1 O FLD grid output

8 to 10 P1 to P3 O FLD segment output

11 VSS-IO — Ground


23 VDD-FIP — Power supply (+3.3V)


42 VSS-IO — Ground


47 NO USED O Not used (connected to ground)

48 VKK — Power supply (-35V)

49 MD0 I Not used (pull up with resistor)

50 MD1/VDD-VFT I Not used (pull up with resistor)

51 MD2 I Not used (pull down with resistor)

52 VOLUME 5,6 LED O Volume level indicatior LED drive signal output



55VOLUME 11,MULT1

I Volume level indicatior LED drive signal outputCH LED

56 VOLUME 3,4 LED I Volume level indicatior LED drive signal output


58 TAPE A/B, TUNER LED O TAPE A/B indicatier LED drive signal output

59 GAME, MD/VIDEO LED O GAME, MD/VIDEO indicator LED drive signal output

60 I2C-DATA O IIC serial data output

61 I2C-CLOCK O IIC clock signal output

62 AVCC — Power supply (+3.3V)

63 AVSS — Ground

64 to 66 KEY0 to KEY2 I Key input (A/D port)

67 BPF3 I Spectrum analyzer BPF signal input



70SUPER LOW FQUENCY

I Spectrum analyzer BPF signal input (BPF0)

71 ALL BAND I L+R signal input

72 SELECTOR O LED group A/B select signal output

73CD/DVD, REC/PAUSE

O CD/DVD, REC/PAUSE indicator LED drive signal outputLED

74 to 76 NO USE O Not used (connected to ground)

77 RESET I Reset input

78 SOFT TEST O Not used (open)

79 VOL 1B I Volume encoder signal B input

80 VOL 1A I Volume encoder signal A input

81 VSS-CPU — Ground

82 XOUT O Crystal oscillator output (4MHz)

83 XIN I Crystal oscillator input (4MHz)

84 VCC-CPU — Power supply (+3.3V)

85 to 86 NO USED O Not used (open)

87 to 100 G21 to G8 O FLD grid output

79

HCD-GN88D

8-1. CASE, BACK PANEL, DMB03 BOARD SECTION

SECTION 8EXPLODED VIEWS

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

NOTE:• -XX and -X mean standardized parts, so they

may have some difference from the originalone.

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when orderingthese items.

• Accessories are given in the last of the elec-trical parts list.

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

1

M891

notsupplied

notsupplied

notsupplied

7

2

3

4

10

9

8

11

6

#1

#1

#1#1

#1#1

#1

#1#2

#1

#1

#1

#1

#1

#1

#1

#1

#1

#2

#2

#2

#2

#2

#2

#2

#1#1

2

notsupplied

notsupplied

notsupplied


1 4-244-102-61 LOADING PANEL2 3-363-099-41 SCREW (CASE 3 TP2)3 4-231-828-51 CASE4 A-4731-346-A SUB-TRANS BOARD, COMPLETE

(E15,E3,E51,PH,SP,MY)4 A-4734-889-A SUB-TRANS BOARD, COMPLETE (MX)

4 A-4734-967-A SUB-TRANS BOARD, COMPLETE (AUS)4 A-4747-641-A SUB TRANS BOARD, COMPLETE (EA)4 A-4749-091-A SUB TRANS BOARD, COMPLETE (TH)6 1-693-603-31 TUNER (FM/AM)7 3-067-237-11 EMBLEM (V), DVD

8 A-4732-884-A REGULATOR BOARD, COMPLETE (EXCEPT TH)8 A-4734-506-A REGULATOR BOARD, COMPLETE (TH)9 A-4732-903-A DMB03 BOARD, COMPLETE10 A-4732-883-A VIDEO BOARD, COMPLETE (EXCEPT TH)10 A-4734-505-A VIDEO BOARD, COMPLETE (TH)

11 1-775-165-11 WIRE (FLAT TYPE) (17 CORE) (220mm)M891 1-763-072-11 FAN, DC#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S#2 7-685-871-01 SCREW +BVTT 3X6 (S)

80

HCD-GN88D

8-2. FRONT PANEL SECTION


57 56 55 54

53

52

7776

79

78

75

62

62

62

74

62

71

6262

62

70

68

67

69

62

51

73

72

6466

65

80

80

80

64

63

62

61

58

59

60

supplied withS748

notsupplied

notsupplied

notsupplied

FL601

#4

#4

62

51 X-4955-539-1 FRONT PANEL ASSY52 4-225-252-01 CUSHION (FOOT)53 4-244-075-01 HOLDER (TC-R)54 4-244-093-01 SPRING LID55 4-244-072-01 LID TC

56 4-244-073-01 WINDOW TC57 4-244-090-01 COVER (AL-TC)58 4-244-074-01 HOLDER (TC-L)59 4-224-578-21 KNOB (MIC)60 4-244-097-01 KNOB (VOLUME)

61 4-244-089-21 COVER (AL-STR)62 4-951-620-01 SCREW (2.6X8), +BVTP63 4-963-404-21 EMBLEM (5-A), SONY64 4-224-104-11 DAMPER65 4-244-094-01 SPRING (L)

66 4-244-095-01 SPRING R67 1-686-936-11 CD SWITCH BOARD

68 A-4732-868-A VOLUME BOARD, COMPLETE (EXCEPT TH)68 A-4734-534-A VOLUME BOARD, COMPLETE (TH)69 4-244-096-01 KNOB CURSOR

70 1-773-040-11 WIRE (FLAT TYPE) (17 CORE) (120mm)71 A-4732-870-A DISPLAY BOARD, COMPLETE (EXCEPT TH)71 A-4734-535-A DISPLAY BOARD, COMPLETE (TH)72 4-231-581-01 HOLDER (FL)73 1-773-110-11 WIRE (FLAT TYPE) (19 CORE)

74 A-4732-871-A GAME IN BOARD, COMPLETE(EXCEPT TH)74 A-4734-533-A GAME IN BOARD, COMPLETE(TH)75 1-796-487-31 DECK, MECHANICAL (CDM43RR23)76 4-243-609-01 BELT (AF)77 4-243-610-01 BELT (AL)

78 4-243-608-01 BELT (BR)79 1-751-688-11 WIRE (FLAT TYPE) (13 CORE)80 3-378-434-01 CUSHION, SARANETFL601 1-518-862-11 INDICATOR TUBE, FLUORESCENT#4 7-685-781-09 SCREW +PTT 2X4 (S)

81

HCD-GN88D

8-3. CHASSIS SECTION


The components identified by mark 0 or dottedline with mark 0 are critical for safety.Replace only with part number specified.

102

107

108

103

104

105109

106

101

notsupplied

notsupplied

notsupplied

notsupplied

F976

T910

F977

F975

F978

F979

notsupplied

#5

#5#1

#1

#3

#1

#1

#1

#3

#1

#1

F974

101 1-686-930-11 TRANS BOARD102 A-4732-892-A SURROUND BOARD, COMPLETE (EXCEPT TH)102 A-4734-262-A SURROUND BOARD, COMPLETE (TH)

0103 1-696-847-21 CORD, POWER (AUS)0103 1-777-071-53 CORD, POWER (E51,EA,PH,SP,MY)

0103 1-824-818-11 CORD, POWER (TH)0103 1-827-226-11 CORD, POWER (E15,E3,MX)* 104 3-703-244-00 BUSHING (2104), CORD

(AUS,E51,EA,PH,SP,MY,TH)104 3-703-571-11 BUSHING (S) (4516), CORD (E15,E3,MX)105 A-4732-888-A MAIN BOARD, COMPLETE(E15,E3,E51,EA,MX)

105 A-4733-170-A MAIN BOARD, COMPLETE (AUS,PH,SP,MY)105 A-4734-508-A MAIN BOARD, COMPLETE (TH)106 4-225-252-01 CUSHION (FOOT)107 A-4732-900-A POWER BOARD, COMPLETE (EXCEPT TH)107 A-4734-623-A POWER BOARD, COMPLETE (TH)

108 4-943-687-01 HOLDER, PC BOARD* 109 4-988-533-01 HOLDER, PWB0F974 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V)0F975 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V)0F976 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250V)

0F977 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (T8AL 250V)0F978 1-533-471-11 FUSE, GLASS TUBE (DIA. 5) (T4AL 250V)0F979 1-533-470-11 FUSE, GLASS TUBE (DIA. 5) (T3.15AL 250V)0T910 1-439-741-11 TRANSFORMER, POWER

(AUS,E15,E3,E51,PH,SP,MY,TH)0T910 1-439-842-11 POWER TRANSFORMER (EA,MX)

#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S#3 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3#5 7-685-881-09 SCREW +BVTT 4X8 (S)

82

HCD-GN88D


8-4. DVD MECHANISM DECK SECTION-1(CDM74D-DVBU23)

151

152153

154

155155

156

156157

157

158

158159

151

156

162

163

164165160

161164

M741

chassis assy

151 4-218-253-21 SCREW (M2.6), +BTTP152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)153 1-687-134-11 MOTOR (TB) BOARD154 4-243-815-01 TABLE (LOADING)155 4-245-571-01 GEAR (STOPPER)

156 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING157 4-245-570-01 GEAR (JOINT)158 4-245-572-01 BUSHING (GEAR)159 1-687-132-11 SENSOR BOARD

160 4-243-820-01 GEAR (TABLE)

161 4-243-819-01 GEAR (GENEVA)162 4-243-816-01 TRAY163 4-243-823-01 BELT (TABLE)164 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING165 4-243-821-01 PULLEY (TABLE)

M741 A-4723-963-A MOTOR ASSY, TABLE

83

HCD-GN88D


8-5. DVD MECHANISM DECK SECTION-2(CDM74D-DVBU23)

201

202

202

202

203

204

205

206

207

208

210

211

212 213

214

215

216

217

219

222

222

224227

225228

226

223

223

222

223 229

209

220

230

218

205

205

205

M751

RE701

The components identified by mark 0 or dottedline with mark 0 are critical for safety.Replace only with part number specified.

201 1-687-135-11 DRIVER BOARD202 4-218-253-31 SCREW (M2.6), +BTTP203 1-687-669-11 SW BOARD204 4-244-034-01 BELT (LOADING)205 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING

206 4-225-844-01 GEAR (LOADING A)207 4-224-613-01 GEAR (SHAFT)208 1-687-133-11 MOTOR (LD) BOARD209 4-243-817-11 CHASSIS210 4-244-108-01 GEAR, SWING

211 4-224-609-01 GEAR (LOADING C)212 4-224-608-01 COLLAR, SWING213 3-016-533-01 WASHER (FR), STOPPER214 4-224-611-01 GEAR (LOADING B)215 4-224-606-01 GEAR (RV)

216 4-243-818-01 GEAR (U/D)

217 4-243-822-01 LEVER (LIFTER)218 X-4954-450-1 PULLEY (240) ASSY219 4-233-594-01 PULLEY (B) (DVD), CHUCKING220 X-4955-538-1 HOLDER (DBU) ASSY

222 3-053-847-31 INSULATOR223 4-981-923-01 SCREW (M), STEP224 4-218-252-51 SCREW (+PTPWH M2.6), FLOATING225 4-218-253-11 SCREW (M2.6), +BTTP226 1-775-265-11 WIRE (FLAT TYPE) (29 CORE)

227 1-824-106-12 CABLE, FLEXIBLE FLAT (24 CORE)228 A-4728-690-A RF BOARD, COMPLETE

0229 1-477-263-11 OPTICAL PICK-UP (TDPO22W)230 3-053-844-01 YOKEM751 A-4737-553-A MOTOR ASSY, LOADING

RE701 1-477-680-11 ENCODER, ROTARY

84

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks

HCD-GN88DSECTION 9

ELECTRICAL PARTS LIST


NOTE:• Due to standardization, replacements in the

parts list may be different from the parts speci-fied in the diagrams or the components usedon the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated when order-ing these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA. . : µA. . uPA. . : µPA. .uPB. . : µPB. . uPC. . : µPC. .uPD. . : µPD. .

• CAPACITORSuF: µF

• COILSuH: µH

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

When indicating parts by referencenumber, please include the board.

1-686-936-11 CD SWITCH BOARD**************

< DIODE >

D748 8-719-058-04 DIODE SEL5223S-TP15 (=/1)

< TRANSISTOR >

Q748 8-729-116-02 TRANSISTOR BA1A4M-TP

< RESISTOR >

R748 1-249-411-11 CARBON 330 5% 1/4WR749 1-249-410-11 CARBON 270 5% 1/4W FR788 1-249-427-11 CARBON 6.8K 5% 1/4W FR789 1-249-429-11 CARBON 10K 5% 1/4WR790 1-249-431-11 CARBON 15K 5% 1/4W

R791 1-249-433-11 CARBON 22K 5% 1/4WR792 1-249-435-11 CARBON 33K 5% 1/4W

< SWITCH >

S749 1-762-875-21 SWITCH, KEYBOARD (=/1)S788 1-762-875-21 SWITCH, KEYBOARD (ZOPEN/CLOSE)S789 1-762-875-21 SWITCH, KEYBOARD (EX-CHANGE/DISK SKIP)S790 1-762-875-21 SWITCH, KEYBOARD (DISC 3)S791 1-762-875-21 SWITCH, KEYBOARD (DISC 2)

S792 1-762-875-21 SWITCH, KEYBOARD (DISC 1)******************************************************

A-4732-870-A DISPLAY BOARD, COMPLETE (EXCEPT TH)A-4734-535-A DISPLAY BOARD, COMPLETE (TH)

*********************

4-231-581-01 HOLDER (FL)

< CAPACITOR >

C100 1-126-964-11 ELECT 10uF 20% 50VC101 1-137-194-81 FILM 0.47uF 5% 50VC102 1-137-194-81 FILM 0.47uF 5% 50VC104 1-126-964-11 ELECT 10uF 20% 50VC105 1-126-957-11 ELECT 0.22uF 20% 50V

C106 1-136-165-00 FILM 0.1uF 5% 50VC107 1-136-165-00 FILM 0.1uF 5% 50VC109 1-124-261-00 ELECT 10uF 20% 50VC110 1-126-957-11 ELECT 0.22uF 20% 50VC111 1-136-157-00 FILM 0.022uF 5% 50V

C112 1-136-157-00 FILM 0.022uF 5% 50VC114 1-126-964-11 ELECT 10uF 20% 50V

C115 1-126-957-11 ELECT 0.22uF 20% 50VC116 1-130-475-00 MYLAR 0.0022uF 5% 50VC117 1-130-475-00 MYLAR 0.0022uF 5% 50V

C118 1-126-964-11 ELECT 10uF 20% 50VC119 1-124-261-00 ELECT 10uF 20% 50VC120 1-126-957-11 ELECT 0.22uF 20% 50VC121 1-126-963-11 ELECT 4.7uF 20% 50VC122 1-124-584-00 ELECT 100uF 20% 10V

C123 1-104-665-11 ELECT 100uF 20% 10VC124 1-126-964-11 ELECT 10uF 20% 50VC125 1-164-159-21 CERAMIC 0.1uF 50V(TH)C125 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C152 1-162-286-21 CERAMIC 220PF 10% 50V(TH)

C152 1-162-286-31 CERAMIC 220PF 10% 50V(EXCEPT TH)

C153 1-162-286-21 CERAMIC 220PF 10% 50V(TH)C153 1-162-286-31 CERAMIC 220PF 10% 50V

(EXCEPT TH)C154 1-162-286-21 CERAMIC 220PF 10% 50V(TH)C154 1-162-286-31 CERAMIC 220PF 10% 50V

(EXCEPT TH)


(EXCEPT TH)C156 1-162-286-21 CERAMIC 220PF 10% 50V(TH)C156 1-162-286-31 CERAMIC 220PF 10% 50V

(EXCEPT TH)C157 1-162-286-21 CERAMIC 220PF 10% 50V(TH)

C157 1-162-286-31 CERAMIC 220PF 10% 50V(EXCEPT TH)

C618 1-162-306-11 CERAMIC 0.01uF 30% 16VC619 1-124-589-11 ELECT 47uF 20% 16VC620 1-162-306-11 CERAMIC 0.01uF 30% 16VC622 1-126-163-11 ELECT 4.7uF 20% 50V

C623 1-162-294-31 CERAMIC 0.001uF 10% 50VC624 1-162-306-11 CERAMIC 0.01uF 30% 16VC625 1-162-306-11 CERAMIC 0.01uF 30% 16VC626 1-162-306-11 CERAMIC 0.01uF 30% 16VC627 1-162-306-11 CERAMIC 0.01uF 30% 16V

C628 1-162-306-11 CERAMIC 0.01uF 30% 16VC651 1-164-159-21 CERAMIC 0.1uF 50V(TH)C651 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C652 1-124-261-00 ELECT 10uF 20% 50VC653 1-124-261-00 ELECT 10uF 20% 50V

C710 1-162-306-11 CERAMIC 0.01uF 30% 16V

CD SWITCH DISPLAY

• AbbreviationAUS : Australian modelE3 : 240 V AC Area in E modelEA : Saudi Arabia modelE15 : Iran modelE51 : Chilean and Peruvian model

MX : Mexican modelPH : Philippines modelSP : Singapore modelMY : Malaysia modelTH : Thai model

85


HCD-GN88D

DISPLAY

C711 1-162-306-11 CERAMIC 0.01uF 30% 16VC712 1-162-306-11 CERAMIC 0.01uF 30% 16V

< CONNECTOR >

* CN601 1-569-935-11 SOCKET, CONNECTOR 19PCN604 1-568-860-11 SOCKET, CONNECTOR 17P

< DIODE >

D100 8-719-109-66 DIODE MTZJ-T-77-3.3B (TH)D100 8-719-983-63 DIODE MTZJ-T-72-3.3B (EXCEPT TH)D101 8-719-991-33 DIODE 1SS133T-72D102 8-719-991-33 DIODE 1SS133T-72D103 8-719-991-33 DIODE 1SS133T-72

D104 8-719-991-33 DIODE 1SS133T-72D105 8-719-991-33 DIODE 1SS133T-72D106 6-500-522-01 DIODE 10EDB40-TA1B2 (TH)D106 6-500-522-11 DIODE 10EDB40-TA2B5 (EXCEPT TH)D107 6-500-522-01 DIODE 10EDB40-TA1B2 (TH)

D107 6-500-522-11 DIODE 10EDB40-TA2B5 (EXCEPT TH)D601 8-719-063-93 DIODE SLR325VC-N-T32 (REC PAUSE/START)D602 8-719-057-97 DIODE SEL5923A-TP15 (GAME)D603 8-719-057-97 DIODE SEL5923A-TP15 (MD(VIDEO))D604 8-719-057-97 DIODE SEL5923A-TP15 (DVD)

D605 8-719-057-97 DIODE SEL5923A-TP15 (TUNER/BAND)D606 8-719-057-97 DIODE SEL5923A-TP15 (TAPE A/B)D610 8-719-109-85 DIODE MTZJ-T-72-5.1B

< FLUORESCENT INDICATOR TUBE >

FL601 1-518-862-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC101 8-759-167-88 IC NJM4565DIC102 8-759-167-88 IC NJM4565DIC601 6-802-903-01 IC MB90M407PF-G-130-BND

< TRANSISTOR >

Q100 8-729-141-30 TRANSISTOR 2SC3623ATP-LKQ601 8-729-116-02 TRANSISTOR BA1A4M-TPQ602 8-729-116-02 TRANSISTOR BA1A4M-TPQ603 8-729-116-02 TRANSISTOR BA1A4M-TPQ604 8-729-116-02 TRANSISTOR BA1A4M-TP

Q605 8-729-140-04 TRANSISTOR 2SB1116-TP-LKQ606 8-729-140-04 TRANSISTOR 2SB1116-TP-LKQ707 8-729-116-02 TRANSISTOR BA1A4M-TPQ807 8-729-029-94 TRANSISTOR BA1L3Z-TPQ808 8-729-029-94 TRANSISTOR BA1L3Z-TP

< RESISTOR >

R102 1-249-419-11 CARBON 1.5K 5% 1/4W FR103 1-249-419-11 CARBON 1.5K 5% 1/4W FR104 1-249-440-11 CARBON 82K 5% 1/4WR105 1-249-415-11 CARBON 680 5% 1/4W FR106 1-249-441-11 CARBON 100K 5% 1/4W

R107 1-249-441-11 CARBON 100K 5% 1/4WR108 1-249-419-11 CARBON 1.5K 5% 1/4W FR109 1-249-419-11 CARBON 1.5K 5% 1/4W FR110 1-249-440-11 CARBON 82K 5% 1/4WR111 1-249-415-11 CARBON 680 5% 1/4W F


R114 1-249-419-11 CARBON 1.5K 5% 1/4W FR115 1-249-419-11 CARBON 1.5K 5% 1/4W FR116 1-249-440-11 CARBON 82K 5% 1/4W

R117 1-249-415-11 CARBON 680 5% 1/4W FR118 1-249-441-11 CARBON 100K 5% 1/4WR119 1-249-441-11 CARBON 100K 5% 1/4WR120 1-249-419-11 CARBON 1.5K 5% 1/4W FR121 1-249-419-11 CARBON 1.5K 5% 1/4W F

R122 1-249-440-11 CARBON 82K 5% 1/4WR123 1-249-415-11 CARBON 680 5% 1/4W FR124 1-249-441-11 CARBON 100K 5% 1/4WR125 1-249-441-11 CARBON 100K 5% 1/4WR127 1-249-409-11 CARBON 220 5% 1/4W F

R128 1-247-895-91 CARBON 470K 5% 1/4W(TH)

R128 1-247-895-00 CARBON 470K 5% 1/4W(EXCEPT TH)

R129 1-249-425-11 CARBON 4.7K 5% 1/4W FR130 1-249-425-11 CARBON 4.7K 5% 1/4W FR131 1-249-441-11 CARBON 100K 5% 1/4W

R132 1-249-441-11 CARBON 100K 5% 1/4WR133 1-249-441-11 CARBON 100K 5% 1/4WR134 1-249-441-11 CARBON 100K 5% 1/4WR136 1-249-439-11 CARBON 68K 5% 1/4WR137 1-249-433-11 CARBON 22K 5% 1/4W

R138 1-249-420-11 CARBON 1.8K 5% 1/4W FR139 1-249-411-11 CARBON 330 5% 1/4WR140 1-247-807-31 CARBON 100 5% 1/4WR626 1-249-411-11 CARBON 330 5% 1/4WR627 1-249-411-11 CARBON 330 5% 1/4W

R628 1-249-411-11 CARBON 330 5% 1/4WR629 1-249-411-11 CARBON 330 5% 1/4WR630 1-249-411-11 CARBON 330 5% 1/4WR631 1-249-415-11 CARBON 680 5% 1/4W FR632 1-249-415-11 CARBON 680 5% 1/4W F

R633 1-249-415-11 CARBON 680 5% 1/4W FR634 1-249-429-11 CARBON 10K 5% 1/4WR635 1-249-429-11 CARBON 10K 5% 1/4WR636 1-249-429-11 CARBON 10K 5% 1/4WR637 1-249-429-11 CARBON 10K 5% 1/4W

R645 1-249-429-11 CARBON 10K 5% 1/4WR646 1-247-807-31 CARBON 100 5% 1/4WR647 1-247-807-31 CARBON 100 5% 1/4WR652 1-249-429-11 CARBON 10K 5% 1/4WR653 1-249-429-11 CARBON 10K 5% 1/4W

R654 1-247-807-31 CARBON 100 5% 1/4WR655 1-247-807-31 CARBON 100 5% 1/4WR656 1-247-807-31 CARBON 100 5% 1/4WR657 1-249-431-11 CARBON 15K 5% 1/4WR658 1-249-431-11 CARBON 15K 5% 1/4W

R659 1-249-431-11 CARBON 15K 5% 1/4WR660 1-247-903-00 CARBON 1M 5% 1/4WR661 1-249-429-11 CARBON 10K 5% 1/4WR662 1-249-429-11 CARBON 10K 5% 1/4WR663 1-249-429-11 CARBON 10K 5% 1/4W

R751 1-249-413-11 CARBON 470 5% 1/4W FR752 1-249-415-11 CARBON 680 5% 1/4W FR753 1-249-417-11 CARBON 1K 5% 1/4W FR754 1-249-419-11 CARBON 1.5K 5% 1/4W FR755 1-249-419-11 CARBON 1.5K 5% 1/4W F

86


HCD-GN88D

DISPLAY

R756 1-249-421-11 CARBON 2.2K 5% 1/4W FR757 1-247-843-11 CARBON 3.3K 5% 1/4WR758 1-249-425-11 CARBON 4.7K 5% 1/4W FR779 1-249-413-11 CARBON 470 5% 1/4W FR781 1-249-415-11 CARBON 680 5% 1/4W F

R782 1-249-417-11 CARBON 1K 5% 1/4W FR783 1-249-419-11 CARBON 1.5K 5% 1/4W FR784 1-249-419-11 CARBON 1.5K 5% 1/4W FR785 1-249-421-11 CARBON 2.2K 5% 1/4W FR786 1-247-843-11 CARBON 3.3K 5% 1/4W

R787 1-249-425-11 CARBON 4.7K 5% 1/4W FR807 1-249-441-11 CARBON 100K 5% 1/4WR808 1-249-441-11 CARBON 100K 5% 1/4WR817 1-249-406-11 CARBON 120 5% 1/4W FR818 1-249-408-11 CARBON 180 5% 1/4W F

R819 1-249-408-11 CARBON 180 5% 1/4W FR820 1-249-408-11 CARBON 180 5% 1/4W FR821 1-249-406-11 CARBON 120 5% 1/4W FR822 1-249-417-11 CARBON 1K 5% 1/4W FR823 1-249-417-11 CARBON 1K 5% 1/4W F

< SWITCH >

S751 1-762-875-21 SWITCH, KEYBOARD (gG)S752 1-762-875-21 SWITCH, KEYBOARD (x)S753 1-762-875-21 SWITCH, KEYBOARD (X)S754 1-762-875-21 SWITCH, KEYBOARD (-,.)S755 1-762-875-21 SWITCH, KEYBOARD (>,+)

S756 1-762-875-21 SWITCH, KEYBOARD (MALBUM +)S757 1-762-875-21 SWITCH, KEYBOARD (m,,ALBUM -)S758 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)S779 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S781 1-762-875-21 SWITCH, KEYBOARD (KARAOKE/MPX)

S782 1-762-875-21 SWITCH, KEYBOARD (GAME MIXING)S783 1-762-875-21 SWITCH, KEYBOARD (GAME)S784 1-762-875-21 SWITCH, KEYBOARD (MD(VIDEO))S785 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)S786 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)

S787 1-762-875-21 SWITCH, KEYBOARD (DVD)

< VIBRATOR >

X601 1-577-358-21 VIBRATOR, CERAMIC (4MHz)******************************************************

A-4732-903-A DMB03 BOARD, COMPLETE (EXCEPT TH)A-4734-638-A DMB03 BOARD, COMPLETE (TH)

********************

< CAPACITOR >

C101 1-126-246-11 ELECT CHIP 220uF 20% 4VC151 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC204 1-164-947-11 CERAMIC CHIP 0.01uF 50VC205 1-164-947-11 CERAMIC CHIP 0.01uF 50VC213 1-126-209-11 ELECT CHIP 100uF 20% 4V

C214 1-164-947-11 CERAMIC CHIP 0.01uF 50VC215 1-164-947-11 CERAMIC CHIP 0.01uF 50VC216 1-164-947-11 CERAMIC CHIP 0.01uF 50VC218 1-164-947-11 CERAMIC CHIP 0.01uF 50VC220 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C226 1-107-820-11 CERAMIC CHIP 0.1uF 16VC227 1-164-947-11 CERAMIC CHIP 0.01uF 50VC229 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C230 1-164-947-11 CERAMIC CHIP 0.01uF 50VC231 1-164-947-11 CERAMIC CHIP 0.01uF 50V





C252 1-164-947-11 CERAMIC CHIP 0.01uF 50VC253 1-164-947-11 CERAMIC CHIP 0.01uF 50VC254 1-164-947-11 CERAMIC CHIP 0.01uF 50VC255 1-117-370-11 CERAMIC CHIP 10uF 10VC256 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C257 1-164-947-11 CERAMIC CHIP 0.01uF 50VC258 1-117-370-11 CERAMIC CHIP 10uF 10VC259 1-164-947-11 CERAMIC CHIP 0.01uF 50VC260 1-164-947-11 CERAMIC CHIP 0.01uF 50VC261 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C262 1-164-947-11 CERAMIC CHIP 0.01uF 50VC263 1-164-947-11 CERAMIC CHIP 0.01uF 50VC264 1-164-947-11 CERAMIC CHIP 0.01uF 50VC265 1-117-370-11 CERAMIC CHIP 10uF 10VC266 1-164-947-11 CERAMIC CHIP 0.01uF 50V



C289 1-164-947-11 CERAMIC CHIP 0.01uF 50VC302 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC303 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC304 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC305 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V

C306 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC307 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC308 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC309 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC315 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C316 1-164-947-11 CERAMIC CHIP 0.01uF 50VC321 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC322 1-107-820-11 CERAMIC CHIP 0.1uF 16V

DMB03

87


HCD-GN88D

C323 1-107-820-11 CERAMIC CHIP 0.1uF 16VC324 1-107-820-11 CERAMIC CHIP 0.1uF 16V

C325 1-126-209-11 ELECT CHIP 100uF 20% 4VC326 1-164-947-11 CERAMIC CHIP 0.01uF 50VC392 1-126-395-11 ELECT 22uF 20% 16VC393 1-164-947-11 CERAMIC CHIP 0.01uF 50VC394 1-126-246-11 ELECT CHIP 220uF 20% 4V

C412 1-216-864-11 METAL CHIP 0 5% 1/10WC413 1-216-864-11 METAL CHIP 0 5% 1/10WC414 1-216-864-11 METAL CHIP 0 5% 1/10WC415 1-216-864-11 METAL CHIP 0 5% 1/10WC416 1-216-864-11 METAL CHIP 0 5% 1/10W

C501 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC502 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC503 1-127-772-81 CERAMIC CHIP 33000PF 10% 10VC504 1-127-772-81 CERAMIC CHIP 33000PF 10% 10VC506 1-164-934-11 CERAMIC CHIP 330PF 10% 50V

C508 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50VC509 1-164-934-11 CERAMIC CHIP 330PF 10% 50VC510 1-164-937-11 CERAMIC CHIP 0.001uF 10% 50VC512 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC514 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V

C516 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50VC517 1-117-370-11 CERAMIC CHIP 10uF 10VC518 1-164-947-11 CERAMIC CHIP 0.01uF 50VC519 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC522 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3V

C525 1-164-947-11 CERAMIC CHIP 0.01uF 50VC526 1-126-395-11 ELECT 22uF 20% 16VC527 1-164-947-11 CERAMIC CHIP 0.01uF 50VC528 1-126-395-11 ELECT 22uF 20% 16VC529 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C531 1-119-923-11 CERAMIC CHIP 0.047uF 10% 10VC533 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50VC534 1-107-819-11 CERAMIC CHIP 0.022uF 10% 16VC535 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50VC543 1-107-820-11 CERAMIC CHIP 0.1uF 16V

C544 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC545 1-117-370-11 CERAMIC CHIP 10uF 10VC547 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16VC548 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC551 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V

C552 1-216-295-91 SHORT CHIP 0C553 1-164-940-11 CERAMIC CHIP 0.0033uF 10% 16VC556 1-117-370-11 CERAMIC CHIP 10uF 10VC558 1-126-209-11 ELECT CHIP 100uF 20% 4VC559 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C560 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50VC561 1-107-820-11 CERAMIC CHIP 0.1uF 16VC563 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC565 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC567 1-107-820-11 CERAMIC CHIP 0.1uF 16V

C568 1-117-370-11 CERAMIC CHIP 10uF 10VC569 1-107-820-11 CERAMIC CHIP 0.1uF 16VC570 1-117-370-11 CERAMIC CHIP 10uF 10VC573 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC588 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50V

C589 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50VC590 1-164-939-11 CERAMIC CHIP 0.0022uF 10% 50VC592 1-124-779-00 ELECT CHIP 10uF 20% 16V

C701 1-126-209-11 ELECT CHIP 100uF 20% 4VC702 1-117-370-11 CERAMIC CHIP 10uF 10V

C703 1-125-777-11 CERAMIC CHIP 0.1uF 10% 6.3VC705 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC706 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC708 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC709 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C711 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V(TH)C711 1-119-923-11 CERAMIC CHIP 0.047uF 10% 10V

(EXCEPT TH)C712 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC713 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC714 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C715 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50VC716 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC717 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16VC718 1-107-820-11 CERAMIC CHIP 0.1uF 16VC720 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V


C726 1-107-820-11 CERAMIC CHIP 0.1uF 16VC727 1-117-370-11 CERAMIC CHIP 10uF 10VC728 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC729 1-117-370-11 CERAMIC CHIP 10uF 10VC730 1-107-820-11 CERAMIC CHIP 0.1uF 16V


C745 1-107-820-11 CERAMIC CHIP 0.1uF 16VC752 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC760 1-107-820-11 CERAMIC CHIP 0.1uF 16VC761 1-107-820-11 CERAMIC CHIP 0.1uF 16VC762 1-107-820-11 CERAMIC CHIP 0.1uF 16V

C763 1-107-820-11 CERAMIC CHIP 0.1uF 16VC764 1-107-820-11 CERAMIC CHIP 0.1uF 16VC765 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC766 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC767 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C768 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC769 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC770 1-107-820-11 CERAMIC CHIP 0.1uF 16VC771 1-119-923-11 CERAMIC CHIP 0.047uF 10% 10VC772 1-107-820-11 CERAMIC CHIP 0.1uF 16V

C773 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC774 1-164-941-11 CERAMIC CHIP 0.0047uF 10% 16VC775 1-107-820-11 CERAMIC CHIP 0.1uF 16VC776 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10VC777 1-125-777-11 CERAMIC CHIP 0.1uF 10% 10V

C778 1-107-820-11 CERAMIC CHIP 0.1uF 16VC779 1-117-370-11 CERAMIC CHIP 10uF 10VC780 1-117-370-11 CERAMIC CHIP 10uF 10VC781 1-165-643-21 ELECT CHIP 150uF 20% 4VC782 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V

C783 1-164-938-11 CERAMIC CHIP 0.0015uF 10% 50V

DMB03

88


HCD-GN88D

C901 1-126-209-11 ELECT CHIP 100uF 20% 4VC902 1-164-947-11 CERAMIC CHIP 0.01uF 50VC903 1-126-209-11 ELECT CHIP 100uF 20% 4VC904 1-164-947-11 CERAMIC CHIP 0.01uF 50V

C905 1-164-947-11 CERAMIC CHIP 0.01uF 50VC906 1-164-947-11 CERAMIC CHIP 0.01uF 50VC907 1-164-947-11 CERAMIC CHIP 0.01uF 50VC908 1-164-874-11 CERAMIC CHIP 100PF 5% 50VC909 1-164-874-11 CERAMIC CHIP 100PF 5% 50V

C910 1-164-947-11 CERAMIC CHIP 0.01uF 50VC913 1-127-772-81 CERAMIC CHIP 33000PF 10% 10VC914 1-164-847-11 CERAMIC CHIP 7PF 0.50PF 50VC915 1-164-847-11 CERAMIC CHIP 7PF 0.50PF 50VC916 1-126-209-11 ELECT CHIP 100uF 20% 4V

C917 1-164-947-11 CERAMIC CHIP 0.01uF 50VC918 1-164-947-11 CERAMIC CHIP 0.01uF 50VC924 1-164-947-11 CERAMIC CHIP 0.01uF 50VC925 1-126-395-11 ELECT 22uF 20% 16VC926 1-126-246-11 ELECT CHIP 220uF 20% 4V

C927 1-164-947-11 CERAMIC CHIP 0.01uF 50VC928 1-117-370-11 CERAMIC CHIP 10uF 10V

< CONNECTOR >

CN101 1-784-366-21 CONNECTOR, FFC/FPC 7PCN102 1-815-954-21 PIN, CONNECTOR (PC BOARD) 13PCN105 1-784-376-11 CONNECTOR, FFC/FPC 17PCN107 1-784-382-21 CONNECTOR, FFC/FPC 25PCN202 1-784-364-21 CONNECTOR, FFC/FPC 4P

CN501 1-778-957-11 CONNECTOR, FFC/FPC 29PCN901 1-764-177-11 PIN, CONNECTOR (SMD)(1.5mm) 7P

< DIODE >

D202 8-719-988-61 DIODE 1SS355TE-17D392 8-719-988-61 DIODE 1SS355TE-17D393 8-719-988-61 DIODE 1SS355TE-17D394 8-719-988-61 DIODE 1SS355TE-17D901 8-719-988-61 DIODE 1SS355TE-17




D1806 8-719-988-61 DIODE 1SS355TE-17

< FERRITE BEAD >

FB902 1-500-284-21 FERRITE 0uHFB903 1-500-284-21 FERRITE 0uH

< FILTER >

FL203 1-234-177-21 FERRITE 0uHFL204 1-234-177-21 FERRITE 0uHFL205 1-234-177-21 FERRITE 0uHFL206 1-234-177-21 FERRITE 0uHFL302 1-234-177-21 FERRITE 0uH



FL903 1-234-177-21 FERRITE 0uHFL908 1-234-177-21 FERRITE 0uH

< IC >

IC203 6-704-069-01 IC MT48LC4M32B2TG-6IC204 8-759-668-01 IC BR9040F-D-E2IC206 6-803-640-01 IC MBM29PL32BM90TN-GYX0305IC207 6-703-540-01 IC ZIVA5X-C1FIC211 6-700-398-01 IC uPC2918T-E1

IC216 6-700-437-01 IC SN74ALVCH16841DGGRIC252 8-759-680-48 IC TC7WH157FK(TE85R)IC302 6-703-787-01 IC PCM1609KPTRIC392 8-759-583-47 IC uPC2933T-E2IC501 6-702-157-01 IC FAN8035L

IC503 8-759-058-43 IC NJM3404AV(TE2)IC509 8-752-408-73 IC CXD3068QIC701 6-703-552-01 IC TMC57929PGF-RDPIC703 8-759-058-43 IC NJM3404AV(TE2)IC706 8-759-564-30 IC MSM51V18165F-60TSKR1

IC901 8-752-937-30 IC CXP973064-226RIC902 8-759-058-64 IC TC7S32FU-TE85LIC903 8-759-641-86 IC BR24C16F-E2IC904 6-702-563-01 IC TC7W74FK-TE85LIC906 6-700-407-01 IC SM8707GV-G-E2

IC907 8-759-583-47 IC uPC2933T-E2

< WIRE JUMPER >

JW392 1-216-864-11 METAL CHIP 0 5% 1/10WJW601 1-218-990-11 SHORT CHIP 0JW602 1-218-990-11 SHORT CHIP 0JW603 1-218-990-11 SHORT CHIP 0JW604 1-218-990-11 SHORT CHIP 0

JW605 1-218-990-11 SHORT CHIP 0JW606 1-218-990-11 SHORT CHIP 0JW607 1-218-990-11 SHORT CHIP 0JW801 1-218-990-11 SHORT CHIP 0JW802 1-218-990-11 SHORT CHIP 0

JW803 1-218-990-11 SHORT CHIP 0JW804 1-218-990-11 SHORT CHIP 0JW805 1-218-990-11 SHORT CHIP 0JW806 1-218-990-11 SHORT CHIP 0

Ver 1.2

DMB03

89


HCD-GN88D

< COIL >

L402 1-216-296-11 SHORT CHIP 0L403 1-216-296-11 SHORT CHIP 0L404 1-216-296-11 SHORT CHIP 0L405 1-216-296-11 SHORT CHIP 0L406 1-216-296-11 SHORT CHIP 0

L412 1-216-296-11 SHORT CHIP 0L413 1-216-296-11 SHORT CHIP 0L414 1-216-296-11 SHORT CHIP 0L415 1-216-296-11 SHORT CHIP 0L416 1-216-296-11 SHORT CHIP 0

L901 1-412-031-11 INDUCTOR CHIP 47uH

< TRANSISTOR >

Q202 8-729-929-26 TRANSISTOR DTC114TE-TLQ901 8-729-929-26 TRANSISTOR DTC114TE-TLQ903 8-729-025-28 TRANSISTOR 2SK1828TE85LQ904 8-729-025-28 TRANSISTOR 2SK1828TE85L

< RESISTOR >

R10 1-216-801-11 METAL CHIP 22 5% 1/10WR11 1-216-801-11 METAL CHIP 22 5% 1/10WR12 1-216-801-11 METAL CHIP 22 5% 1/10WR13 1-216-801-11 METAL CHIP 22 5% 1/10WR14 1-216-801-11 METAL CHIP 22 5% 1/10W

R15 1-216-801-11 METAL CHIP 22 5% 1/10WR201 1-216-833-11 METAL CHIP 10K 5% 1/10WR207 1-216-864-11 METAL CHIP 0 5% 1/10WR213 1-216-807-11 METAL CHIP 68 5% 1/10WR214 1-216-864-11 METAL CHIP 0 5% 1/10W


R221 1-216-864-11 METAL CHIP 0 5% 1/10WR222 1-216-864-11 METAL CHIP 0 5% 1/10WR223 1-216-864-11 METAL CHIP 0 5% 1/10WR224 1-216-864-11 METAL CHIP 0 5% 1/10WR227 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R230 1-216-803-11 METAL CHIP 33 5% 1/10WR231 1-216-803-11 METAL CHIP 33 5% 1/10WR232 1-216-803-11 METAL CHIP 33 5% 1/10WR233 1-216-864-11 METAL CHIP 0 5% 1/10WR234 1-216-833-11 METAL CHIP 10K 5% 1/10W

R239 1-216-809-11 METAL CHIP 100 5% 1/10WR240 1-216-841-11 METAL CHIP 47K 5% 1/10WR243 1-216-864-11 METAL CHIP 0 5% 1/10WR244 1-216-821-11 METAL CHIP 1K 5% 1/10WR245 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R246 1-216-833-11 METAL CHIP 10K 5% 1/10WR247 1-216-821-11 METAL CHIP 1K 5% 1/10WR248 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR250 1-216-864-11 METAL CHIP 0 5% 1/10WR251 1-216-864-11 METAL CHIP 0 5% 1/10W

R253 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR254 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR255 1-216-864-11 METAL CHIP 0 5% 1/10WR257 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR259 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R260 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR261 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR262 1-216-864-11 METAL CHIP 0 5% 1/10WR263 1-218-285-11 METAL CHIP 75 5% 1/10WR264 1-218-285-11 METAL CHIP 75 5% 1/10W




R282 1-218-285-11 METAL CHIP 75 5% 1/10WR283 1-218-847-11 METAL CHIP 1K 0.5% 1/10WR284 1-218-829-11 METAL CHIP 180 0.5% 1/10WR288 1-216-864-11 METAL CHIP 0 5% 1/10WR301 1-216-821-11 METAL CHIP 1K 5% 1/10W




R502 1-216-864-11 METAL CHIP 0 5% 1/10WR503 1-216-841-11 METAL CHIP 47K 5% 1/10WR504 1-216-841-11 METAL CHIP 47K 5% 1/10WR505 1-216-841-11 METAL CHIP 47K 5% 1/10WR506 1-216-841-11 METAL CHIP 47K 5% 1/10W

R507 1-216-864-11 METAL CHIP 0 5% 1/10WR508 1-216-864-11 METAL CHIP 0 5% 1/10WR510 1-216-847-11 METAL CHIP 150K 5% 1/10WR511 1-216-847-11 METAL CHIP 150K 5% 1/10WR512 1-216-842-11 METAL CHIP 56K 5% 1/10W

R513 1-216-842-11 METAL CHIP 56K 5% 1/10WR516 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR517 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR519 1-216-845-11 METAL CHIP 100K 5% 1/10WR520 1-216-833-11 METAL CHIP 10K 5% 1/10W

R521 1-216-845-11 METAL CHIP 100K 5% 1/10WR522 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR523 1-216-833-11 METAL CHIP 10K 5% 1/10WR524 1-216-833-11 METAL CHIP 10K 5% 1/10WR525 1-216-833-11 METAL CHIP 10K 5% 1/10W

DMB03

90


HCD-GN88D

R527 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR528 1-216-864-11 METAL CHIP 0 5% 1/10WR529 1-216-839-11 METAL CHIP 33K 5% 1/10WR530 1-216-842-11 METAL CHIP 56K 5% 1/10WR531 1-216-864-11 METAL CHIP 0 5% 1/10W

R532 1-216-864-11 METAL CHIP 0 5% 1/10WR533 1-216-839-11 METAL CHIP 33K 5% 1/10WR534 1-216-842-11 METAL CHIP 56K 5% 1/10WR535 1-216-864-11 METAL CHIP 0 5% 1/10WR536 1-216-833-11 METAL CHIP 10K 5% 1/10W

R537 1-216-843-11 METAL CHIP 68K 5% 1/10WR538 1-216-864-11 METAL CHIP 0 5% 1/10WR539 1-216-864-11 METAL CHIP 0 5% 1/10WR540 1-216-864-11 METAL CHIP 0 5% 1/10WR541 1-216-864-11 METAL CHIP 0 5% 1/10W

R543 1-216-864-11 METAL CHIP 0 5% 1/10WR544 1-216-864-11 METAL CHIP 0 5% 1/10WR545 1-216-833-11 METAL CHIP 10K 5% 1/10WR547 1-216-864-11 METAL CHIP 0 5% 1/10WR548 1-216-833-11 METAL CHIP 10K 5% 1/10W

R550 1-216-821-11 METAL CHIP 1K 5% 1/10WR551 1-216-821-11 METAL CHIP 1K 5% 1/10WR552 1-216-821-11 METAL CHIP 1K 5% 1/10WR553 1-216-864-11 METAL CHIP 0 5% 1/10WR554 1-216-864-11 METAL CHIP 0 5% 1/10W


R562 1-216-821-11 METAL CHIP 1K 5% 1/10WR563 1-216-821-11 METAL CHIP 1K 5% 1/10WR564 1-216-821-11 METAL CHIP 1K 5% 1/10WR565 1-216-821-11 METAL CHIP 1K 5% 1/10WR566 1-216-833-11 METAL CHIP 10K 5% 1/10W

R567 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR568 1-216-857-11 METAL CHIP 1M 5% 1/10WR571 1-216-857-11 METAL CHIP 1M 5% 1/10WR572 1-216-853-11 METAL CHIP 470K 5% 1/10WR573 1-216-833-11 METAL CHIP 10K 5% 1/10W


R579 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR580 1-216-839-11 METAL CHIP 33K 5% 1/10WR581 1-216-834-11 METAL CHIP 12K 5% 1/10WR583 1-216-864-11 METAL CHIP 0 5% 1/10WR584 1-216-839-11 METAL CHIP 33K 5% 1/10W

R585 1-216-864-11 METAL CHIP 0 5% 1/10WR586 1-218-747-11 METAL CHIP 200K 5% 1/10WR587 1-216-864-11 METAL CHIP 0 5% 1/10WR588 1-216-833-11 METAL CHIP 10K 5% 1/10WR589 1-216-833-11 METAL CHIP 10K 5% 1/10W

R592 1-216-864-11 METAL CHIP 0 5% 1/10WR593 1-216-845-11 METAL CHIP 100K 5% 1/10WR597 1-216-864-11 METAL CHIP 0 5% 1/10WR599 1-216-821-11 METAL CHIP 1K 5% 1/10WR601 1-216-864-11 METAL CHIP 0 5% 1/10W

R615 1-216-864-11 METAL CHIP 0 5% 1/10WR629 1-216-864-11 METAL CHIP 0 5% 1/10WR694 1-216-833-11 METAL CHIP 10K 5% 1/10WR695 1-216-864-11 METAL CHIP 0 5% 1/10WR696 1-216-864-11 METAL CHIP 0 5% 1/10W

R698 1-216-864-11 METAL CHIP 0 5% 1/10WR699 1-216-864-11 METAL CHIP 0 5% 1/10WR700 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR707 1-216-809-11 METAL CHIP 100 5% 1/10WR708 1-216-853-11 METAL CHIP 470K 5% 1/10W

R709 1-216-847-11 METAL CHIP 150K 5% 1/10WR710 1-216-833-11 METAL CHIP 10K 5% 1/10WR711 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR712 1-216-833-11 METAL CHIP 10K 5% 1/10WR713 1-216-833-11 METAL CHIP 10K 5% 1/10W

R714 1-216-833-11 METAL CHIP 10K 5% 1/10WR715 1-216-833-11 METAL CHIP 10K 5% 1/10WR716 1-216-809-11 METAL CHIP 100 5% 1/10WR717 1-216-845-11 METAL CHIP 100K 5% 1/10WR718 1-216-833-11 METAL CHIP 10K 5% 1/10W

R719 1-216-821-11 METAL CHIP 1K 5% 1/10WR720 1-216-821-11 METAL CHIP 1K 5% 1/10WR721 1-216-839-11 METAL CHIP 33K 5% 1/10WR724 1-216-821-11 METAL CHIP 1K 5% 1/10WR725 1-216-824-11 METAL CHIP 1.8K 5% 1/10W

R726 1-216-845-11 METAL CHIP 100K 5% 1/10WR727 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR728 1-216-833-11 METAL CHIP 10K 5% 1/10WR730 1-216-801-11 METAL CHIP 22 5% 1/10WR731 1-216-801-11 METAL CHIP 22 5% 1/10W


R737 1-216-833-11 METAL CHIP 10K 5% 1/10WR738 1-216-833-11 METAL CHIP 10K 5% 1/10WR742 1-216-801-11 METAL CHIP 22 5% 1/10WR743 1-216-801-11 METAL CHIP 22 5% 1/10WR744 1-216-801-11 METAL CHIP 22 5% 1/10W




R763 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR764 1-216-857-11 METAL CHIP 1M 5% 1/10WR765 1-216-837-11 METAL CHIP 22K 5% 1/10WR766 1-216-864-11 METAL CHIP 0 5% 1/10WR767 1-216-841-11 METAL CHIP 47K 5% 1/10W

DMB03

91


HCD-GN88D

R769 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR770 1-216-864-11 METAL CHIP 0 5% 1/10WR776 1-216-864-11 METAL CHIP 0 5% 1/10WR777 1-216-864-11 METAL CHIP 0 5% 1/10WR778 1-216-845-11 METAL CHIP 100K 5% 1/10W

R780 1-216-864-11 METAL CHIP 0 5% 1/10WR781 1-216-864-11 METAL CHIP 0 5% 1/10WR784 1-216-864-11 METAL CHIP 0 5% 1/10WR785 1-216-833-11 METAL CHIP 10K 5% 1/10WR786 1-216-845-11 METAL CHIP 100K 5% 1/10W



R907 1-216-801-11 METAL CHIP 22 5% 1/10WR908 1-216-833-11 METAL CHIP 10K 5% 1/10WR910 1-216-864-11 METAL CHIP 0 5% 1/10WR911 1-216-833-11 METAL CHIP 10K 5% 1/10WR912 1-216-833-11 METAL CHIP 10K 5% 1/10W

R913 1-216-833-11 METAL CHIP 10K 5% 1/10WR915 1-216-809-11 METAL CHIP 100 5% 1/10WR916 1-216-821-11 METAL CHIP 1K 5% 1/10WR917 1-216-821-11 METAL CHIP 1K 5% 1/10WR918 1-216-801-11 METAL CHIP 22 5% 1/10W


R926 1-216-809-11 METAL CHIP 100 5% 1/10WR927 1-216-857-11 METAL CHIP 1M 5% 1/10WR930 1-216-809-11 METAL CHIP 100 5% 1/10WR931 1-216-801-11 METAL CHIP 22 5% 1/10WR932 1-216-801-11 METAL CHIP 22 5% 1/10W

R933 1-216-801-11 METAL CHIP 22 5% 1/10WR935 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR940 1-216-809-11 METAL CHIP 100 5% 1/10WR942 1-216-809-11 METAL CHIP 100 5% 1/10WR943 1-216-809-11 METAL CHIP 100 5% 1/10W



R975 1-216-833-11 METAL CHIP 10K 5% 1/10WR976 1-216-864-11 METAL CHIP 0 5% 1/10WR978 1-216-833-11 METAL CHIP 10K 5% 1/10WR984 1-216-833-11 METAL CHIP 10K 5% 1/10WR988 1-216-864-11 METAL CHIP 0 5% 1/10W


R996 1-216-864-11 METAL CHIP 0 5% 1/10WR997 1-216-864-11 METAL CHIP 0 5% 1/10WR998 1-216-864-11 METAL CHIP 0 5% 1/10WR1000 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1001 1-216-864-11 METAL CHIP 0 5% 1/10WR1101 1-164-156-11 CERAMIC CHIP 0.1uF 25VR1201 1-216-864-11 METAL CHIP 0R1202 1-216-864-11 METAL CHIP 0R1301 1-164-156-11 CERAMIC CHIP 0.1uF 25V

R1303 1-164-156-11 CERAMIC CHIP 0.1uF 25VR1801 1-164-156-11 CERAMIC CHIP 0.1uF 25VR1802 1-164-156-11 CERAMIC CHIP 0.1uF 25VR1803 1-164-156-11 CERAMIC CHIP 0.1uF 25VR9980 1-216-864-11 METAL CHIP 0 5% 1/10W


R9994 1-216-864-11 METAL CHIP 0 5% 1/10WR9998 1-216-864-11 METAL CHIP 0 5% 1/10WR9999 1-216-864-11 METAL CHIP 0 5% 1/10W

< NETWORK RESISTOR >

RB10 1-233-388-11 RES, NETWORK 68 (3216)RB11 1-233-388-11 RES, NETWORK 68 (3216)RB12 1-233-388-11 RES, NETWORK 68 (3216)RB13 1-233-388-11 RES, NETWORK 68 (3216)RB14 1-233-388-11 RES, NETWORK 68 (3216)

RB15 1-233-388-11 RES, NETWORK 68 (3216)RB16 1-233-388-11 RES, NETWORK 68 (3216)RB17 1-233-388-11 RES, NETWORK 68 (3216)RB18 1-234-524-21 RES, CHIP NETWORK 33RB19 1-234-524-21 RES, CHIP NETWORK 33

RB20 1-234-524-21 RES, CHIP NETWORK 33RB21 1-234-524-21 RES, CHIP NETWORK 33RB202 1-234-523-21 RES, CHIP NETWORK 0 (3216)RB203 1-234-523-21 RES, CHIP NETWORK 0 (3216)RB204 1-234-523-21 RES, CHIP NETWORK 0 (3216)

< VIBRATOR >

X901 1-781-945-21 VIBRATOR, CERAMIC (20MHz)X902 1-795-630-11 VIBRATOR, CRYSTAL (27MHz)

******************************************************

1-687-135-11 DRIVER BOARD************

< CAPACITOR >

C715 1-126-933-11 ELECT 100uF 20% 16VC731 1-126-964-11 ELECT 10uF 20% 50VC735 1-164-159-11 CERAMIC 0.1uF 50VC736 1-164-159-11 CERAMIC 0.1uF 50VC737 1-164-159-11 CERAMIC 0.1uF 50V

C741 1-162-306-11 CERAMIC 0.01uF 30% 16V

DMB03 DRIVER

92


HCD-GN88D

C751 1-162-306-11 CERAMIC 0.01uF 30% 16VC752 1-164-159-11 CERAMIC 0.1uF 50V

< CONNECTOR >

CN701 1-785-338-11 PIN, CONNECTOR(LIGHT ANGLE)12PCN702 1-784-766-11 CONNECTOR, FFC 5P

* CN703 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN704 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE)2P

< DIODE >

D701 8-719-947-16 DIODE MTZJ-T-72-5.1AD711 8-719-983-66 DIODE MTZJ-T-72-3.6B

< IC >

IC701 8-759-598-69 IC BA6956ANIC712 8-759-598-69 IC BA6956AN

< TRNSISTOR >

Q731 8-729-029-66 TRANSISTOR DTC114ESA

< RESISTOR >

R701 1-249-413-11 CARBON 470 5% 1/4W FR702 1-247-807-31 CARBON 100 5% 1/4WR711 1-249-417-11 CARBON 1K 5% 1/4W FR712 1-249-425-11 CARBON 4.7K 5% 1/4W FR713 1-249-433-11 CARBON 22K 5% 1/4W

R721 1-249-425-11 CARBON 4.7K 5% 1/4W FR722 1-249-425-11 CARBON 4.7K 5% 1/4W FR723 1-249-425-11 CARBON 4.7K 5% 1/4W FR731 1-247-807-31 CARBON 100 5% 1/4WR732 1-249-429-11 CARBON 10K 5% 1/4W

R733 1-249-417-11 CARBON 1K 5% 1/4W FR734 1-249-430-11 CARBON 12K 5% 1/4WR735 1-247-807-31 CARBON 100 5% 1/4WR751 1-249-425-11 CARBON 4.7K 5% 1/4W F

******************************************************

A-4732-871-A GAME IN BOARD, COMPLETE (EXCEPT TH)A-4734-533-A GAME IN BOARD, COMPLETE (TH)

*********************

< CAPACITOR >

C604 1-124-257-00 ELECT 2.2uF 20% 50VC606 1-124-257-00 ELECT 2.2uF 20% 50VC630 1-162-294-31 CERAMIC 0.001uF 10% 50VC631 1-162-294-31 CERAMIC 0.001uF 10% 50VC634 1-162-294-31 CERAMIC 0.001uF 10% 50V

C635 1-162-294-31 CERAMIC 0.001uF 10% 50VC715 1-162-215-31 CERAMIC 47PF 5% 50VC716 1-164-159-21 CERAMIC 0.1uF 50V(TH)C716 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C717 1-124-584-00 ELECT 100uF 20% 10V

C718 1-124-584-00 ELECT 100uF 20% 10VC719 1-124-257-00 ELECT 2.2uF 20% 50VC721 1-162-301-11 CERAMIC 0.0015uF 20% 16VC722 1-162-305-11 CERAMIC 0.0068uF 30% 16VC723 1-126-160-11 ELECT 1uF 20% 50V

C724 1-136-495-11 FILM 0.068uF 5% 50VC725 1-124-464-11 ELECT 0.22uF 20% 50V

C726 1-124-464-11 ELECT 0.22uF 20% 50VC727 1-136-155-00 FILM 0.015uF 5% 50VC728 1-162-301-11 CERAMIC 0.0015uF 20% 16V

C729 1-126-160-11 ELECT 1uF 20% 50VC730 1-161-494-00 CERAMIC 0.022uF 25VC731 1-162-305-11 CERAMIC 0.0068uF 30% 16VC732 1-136-495-11 FILM 0.068uF 5% 50VC733 1-124-589-11 ELECT 47uF 20% 16V

C734 1-124-589-11 ELECT 47uF 20% 16VC735 1-124-257-00 ELECT 2.2uF 20% 50VC736 1-124-261-00 ELECT 10uF 20% 50VC737 1-124-261-00 ELECT 10uF 20% 50VC738 1-124-257-00 ELECT 2.2uF 20% 50V

C739 1-162-215-31 CERAMIC 47PF 5% 50VC740 1-162-282-31 CERAMIC 100PF 10% 50VC741 1-124-250-11 ELECT 0.15uF 20% 50VC742 1-162-215-31 CERAMIC 47PF 5% 50VC743 1-162-290-31 CERAMIC 470PF 10% 50V

C744 1-162-294-31 CERAMIC 0.001uF 10% 50VC747 1-124-257-00 ELECT 2.2uF 20% 50VC748 1-161-494-00 CERAMIC 0.022uF 25VC749 1-164-159-21 CERAMIC 0.1uF 50V(TH)C749 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)

< CONNECTOR >

* CN606 1-564-725-11 PIN, CONNECTOR (SMALL TYPE) 9P

< DIODE >

D705 8-719-109-85 DIODE MTZJ-T-72-5.1B

< GROUND TERMINAL >

EP701 1-537-738-21 TERMINAL, GROUNDEP703 1-537-738-21 TERMINAL, GROUND

< IC >

IC721 8-759-450-96 IC M65850PIC722 8-759-167-88 IC NJM4565D

< JACK >

J601 1-764-592-11 JACK 3P (GAME INPUT)J631 1-794-702-11 JACK, HEADPHONE (PHONES)J721 1-817-630-11 JACK (LARGE TYPE) (MIC)

< TRANSISTOR >

Q721 8-729-119-79 TRANSISTOR 2SC2785TP-FEK

< RESISTOR >

R602 1-249-417-11 CARBON 1K 5% 1/4W FR603 1-249-417-11 CARBON 1K 5% 1/4W FR604 1-249-441-11 CARBON 100K 5% 1/4WR605 1-249-441-11 CARBON 100K 5% 1/4WR721 1-249-429-11 CARBON 10K 5% 1/4W


GAME INDRIVER

93


HCD-GN88D

MAIN


R733 1-249-431-11 CARBON 15K 5% 1/4WR734 1-247-807-31 CARBON 100 5% 1/4WR735 1-247-885-00 CARBON 180K 5% 1/4WR736 1-249-429-11 CARBON 10K 5% 1/4WR737 1-249-433-11 CARBON 22K 5% 1/4W

R738 1-249-417-11 CARBON 1K 5% 1/4W FR739 1-249-441-11 CARBON 100K 5% 1/4WR740 1-249-421-11 CARBON 2.2K 5% 1/4W FR742 1-249-417-11 CARBON 1K 5% 1/4W FR743 1-249-429-11 CARBON 10K 5% 1/4W

R744 1-249-441-11 CARBON 100K 5% 1/4WR745 1-247-807-31 CARBON 100 5% 1/4WR746 1-249-417-11 CARBON 1K 5% 1/4W FR747 1-249-407-11 CARBON 150 5% 1/4W F

< VARIABLE RESISTOR >

RV721 1-227-452-11 RES, VAR, CARBON 50K (ECHO LEVEL)RV722 1-227-452-11 RES, VAR, CARBON 50K (MIC LEVEL)

******************************************************

A-4732-888-A MAIN BOARD, COMPLETE (E3,E15,E51,EA,MX)A-4733-170-A MAIN BOARD, COMPLETE (AUS,SP,MY,PH)A-4734-508-A MAIN BOARD, COMPLETE (TH)

*******************

< CAPACITOR >

C101 1-104-665-11 ELECT 100uF 20% 10VC102 1-126-964-11 ELECT 10uF 20% 50VC103 1-126-964-11 ELECT 10uF 20% 50VC104 1-126-964-11 ELECT 10uF 20% 50VC105 1-126-964-11 ELECT 10uF 20% 50V

C106 1-136-157-00 FILM 0.022uF 5% 50VC107 1-136-157-00 FILM 0.022uF 5% 50VC108 1-136-159-00 FILM 0.033uF 5% 50VC109 1-126-960-11 ELECT 1uF 20% 50VC110 1-130-481-00 MYLAR 0.0068uF 5% 50V

C111 1-126-964-11 ELECT 10uF 20% 50VC112 1-136-169-00 FILM 0.22uF 5% 50VC113 1-136-171-00 FILM 0.33uF 5% 50VC114 1-126-791-11 ELECT 10uF 20% 16VC115 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C116 1-126-934-11 ELECT 220uF 20% 10VC117 1-126-961-11 ELECT 2.2uF 20% 50VC121 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC122 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC130 1-126-964-11 ELECT 10uF 20% 50V

C131 1-126-959-11 ELECT 0.47uF 20% 50VC140 1-136-495-11 FILM 0.068uF 5% 50VC149 1-126-964-11 ELECT 10uF 20% 50VC150 1-126-964-11 ELECT 10uF 20% 50VC152 1-126-964-11 ELECT 10uF 20% 50V

C153 1-126-964-11 ELECT 10uF 20% 50VC154 1-126-964-11 ELECT 10uF 20% 50VC155 1-126-964-11 ELECT 10uF 20% 50VC156 1-136-157-00 FILM 0.022uF 5% 50VC157 1-136-157-00 FILM 0.022uF 5% 50V

C158 1-136-159-00 FILM 0.033uF 5% 50VC159 1-126-960-11 ELECT 1uF 20% 50VC160 1-130-481-00 MYLAR 0.0068uF 5% 50VC161 1-126-964-11 ELECT 10uF 20% 50VC162 1-136-169-00 FILM 0.22uF 5% 50V

C163 1-136-171-00 FILM 0.33uF 5% 50VC167 1-126-961-11 ELECT 2.2uF 20% 50VC200 1-164-156-11 CERAMIC CHIP 0.1uF 25VC201 1-104-665-11 ELECT 100uF 20% 10VC202 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C203 1-126-934-11 ELECT 220uF 20% 10VC211 1-164-156-11 CERAMIC CHIP 0.1uF 25VC212 1-126-916-11 ELECT 1000uF 20% 6.3VC213 1-164-156-11 CERAMIC CHIP 0.1uF 25VC214 1-126-916-11 ELECT 1000uF 20% 6.3V

C223 1-164-156-11 CERAMIC CHIP 0.1uF 25VC301 1-130-483-00 MYLAR 0.01uF 5% 50VC303 1-136-165-00 FILM 0.1uF 5% 50VC304 1-126-964-11 ELECT 10uF 20% 50VC305 1-126-960-11 ELECT 1uF 20% 50V

C306 1-126-961-11 ELECT 2.2uF 20% 50VC307 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-935-11 ELECT 470uF 20% 10VC309 1-126-947-11 ELECT 47uF 20% 16VC310 1-126-964-11 ELECT 10uF 20% 50V

C311 1-126-964-11 ELECT 10uF 20% 50VC312 1-126-964-11 ELECT 10uF 20% 50VC314 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC315 1-126-960-11 ELECT 1uF 20% 50VC316 1-126-960-11 ELECT 1uF 20% 50V

C321 1-164-392-11 CERAMIC CHIP 390PF 10% 50VC326 1-164-392-11 CERAMIC CHIP 390PF 10% 50VC331 1-130-483-00 MYLAR 0.01uF 5% 50VC332 1-137-427-11 MYLAR 120PF 5% 50VC333 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C334 1-162-946-11 CERAMIC CHIP 27PF 5% 50VC335 1-137-150-11 MYLAR 0.01uF 5% 100VC336 1-126-961-11 ELECT 2.2uF 20% 50VC337 1-130-485-00 MYLAR 0.015uF 5% 50VC338 1-130-481-00 MYLAR 0.0068uF 5% 50V

C339 1-130-481-00 MYLAR 0.0068uF 5% 50VC340 1-130-486-00 MYLAR 0.018uF 10% 50VC341 1-126-964-11 ELECT 10uF 20% 50VC342 1-126-947-11 ELECT 47uF 20% 16VC351 1-130-483-00 MYLAR 0.01uF 5% 50V

C353 1-136-165-00 FILM 0.1uF 5% 50VC354 1-126-964-11 ELECT 10uF 20% 50VC355 1-126-960-11 ELECT 1uF 20% 50VC356 1-126-961-11 ELECT 2.2uF 20% 50VC359 1-126-947-11 ELECT 47uF 20% 16V

C360 1-216-864-11 METAL CHIP 0 5% 1/10WC361 1-126-964-11 ELECT 10uF 20% 50VC364 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC365 1-126-960-11 ELECT 1uF 20% 50VC371 1-164-392-11 CERAMIC CHIP 390PF 10% 50V

C376 1-164-392-11 CERAMIC CHIP 390PF 10% 50VC381 1-130-483-00 MYLAR 0.01uF 5% 50VC382 1-137-427-11 MYLAR 120PF 5% 50VC383 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC384 1-162-946-11 CERAMIC CHIP 27PF 5% 50V

GAME IN

94


HCD-GN88D

C385 1-126-964-11 ELECT 10uF 20% 50VC386 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC387 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC390 1-126-935-11 ELECT 470uF 20% 10VC391 1-126-933-11 ELECT 100uF 20% 16V

C395 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC396 1-126-965-91 ELECT 22uF 20% 50VC397 1-126-964-11 ELECT 10uF 20% 50VC398 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC399 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C416 1-164-156-11 CERAMIC CHIP 0.1uF 25VC498 1-164-156-11 CERAMIC CHIP 0.1uF 25VC502 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC503 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC510 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C511 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC512 1-164-156-11 CERAMIC CHIP 0.1uF 25VC516 1-126-926-11 ELECT 1000uF 20% 10VC562 1-104-665-11 ELECT 100uF 20% 10VC564 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C596 1-164-156-11 CERAMIC CHIP 0.1uF 25VC598 1-126-926-11 ELECT 1000uF 20% 10VC601 1-126-964-11 ELECT 10uF 20% 50VC602 1-136-165-00 FILM 0.1uF 5% 50VC603 1-136-165-00 FILM 0.1uF 5% 50V

C620 1-126-963-11 ELECT 4.7uF 20% 50VC621 1-107-721-11 ELECT 4.7uF 20% 100VC650 1-109-889-11 ELECT 1uF 20% 50VC651 1-107-717-11 ELECT 47uF 20% 50VC670 1-126-963-11 ELECT 4.7uF 20% 50V

C671 1-107-721-11 ELECT 4.7uF 20% 100VC721 1-126-961-11 ELECT 2.2uF 20% 50VC722 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC730 1-126-964-11 ELECT 10uF 20% 50VC731 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C771 1-126-961-11 ELECT 2.2uF 20% 50VC772 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC800 1-126-964-11 ELECT 10uF 20% 50VC801 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC802 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C803 1-126-964-11 ELECT 10uF 20% 50VC804 1-126-964-11 ELECT 10uF 20% 50VC805 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC806 1-126-964-11 ELECT 10uF 20% 50VC807 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C808 1-126-964-11 ELECT 10uF 20% 50VC809 1-126-964-11 ELECT 10uF 20% 50VC810 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC811 1-126-964-11 ELECT 10uF 20% 50VC812 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C813 1-126-964-11 ELECT 10uF 20% 50VC814 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC815 1-126-964-11 ELECT 10uF 20% 50VC816 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC817 1-126-964-11 ELECT 10uF 20% 50V

C818 1-126-964-11 ELECT 10uF 20% 50VC819 1-126-960-11 ELECT 1uF 20% 50VC820 1-126-963-11 ELECT 4.7uF 20% 50VC821 1-136-169-00 FILM 0.22uF 5% 50VC822 1-136-165-00 FILM 0.1uF 5% 50V

C823 1-126-963-11 ELECT 4.7uF 20% 50VC824 1-126-963-11 ELECT 4.7uF 20% 50VC825 1-136-171-00 FILM 0.33uF 5% 50VC826 1-136-169-00 FILM 0.22uF 5% 50VC827 1-126-963-11 ELECT 4.7uF 20% 50V

C828 1-136-171-00 FILM 0.33uF 5% 50VC829 1-136-169-00 FILM 0.22uF 5% 50VC830 1-126-964-11 ELECT 10uF 20% 50VC831 1-136-161-00 FILM 0.047uF 5% 50VC832 1-126-964-11 ELECT 10uF 20% 50V

C833 1-104-665-11 ELECT 100uF 20% 10VC834 1-104-665-11 ELECT 100uF 20% 10VC835 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC836 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC837 1-126-964-11 ELECT 10uF 20% 50V

C838 1-126-964-11 ELECT 10uF 20% 50VC839 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC840 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC841 1-126-964-11 ELECT 10uF 20% 50VC842 1-126-964-11 ELECT 10uF 20% 50V

C843 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC844 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC845 1-126-964-11 ELECT 10uF 20% 50VC846 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC847 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C851 1-164-156-11 CERAMIC CHIP 0.1uF 25VC852 1-164-156-11 CERAMIC CHIP 0.1uF 25VC854 1-126-934-11 ELECT 220uF 20% 10VC855 1-164-156-11 CERAMIC CHIP 0.1uF 25VC901 1-126-944-11 ELECT 3300uF 20% 25V

C902 1-126-961-11 ELECT 2.2uF 20% 50VC904 1-130-483-00 MYLAR 0.01uF 5% 50VC905 1-130-483-00 MYLAR 0.01uF 5% 50VC906 1-126-933-11 ELECT 100uF 20% 16VC908 1-136-165-00 FILM 0.1uF 5% 50V

C909 1-136-165-00 FILM 0.1uF 5% 50VC911 1-126-961-11 ELECT 2.2uF 20% 50VC919 1-117-251-51 ELECT 3300uF 20% 6.3VC920 1-126-964-11 ELECT 10uF 20% 50VC921 1-126-968-11 ELECT 100uF 20% 50V

C922 1-126-941-11 ELECT 470uF 20% 25V

< CONNECTOR >

CN201 1-779-544-21 CONNECTOR, FFC(LIF(NON-ZIF))7PCN202 1-785-338-11 PIN, CONNECTOR(LIGHT ANGLE)12P

* CN203 1-564-711-11 PIN, CONNECTOR (SMALL TYPE) 9P* CN205 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7P

CN206 1-779-558-21 CONNECTOR,FFC(LIF(NON-ZIF))21P

* CN301 1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P* CN304 1-569-930-11 SOCKET, CONNECTOR 13P* CN402 1-569-935-11 SOCKET, CONNECTOR 19P

CN501 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE)4PCN502 1-785-336-11 PIN, CONNECTOR(LIGHT ANGLE)10P

CN702 1-569-906-11 SOCKET, CONNECTOR 11PCN851 1-564-506-11 PLUG, CONNECTOR 3PCN901 1-770-726-11 CONNECTOR, BOARD TO BOARD 6PCN902 1-778-982-11 CONNECTOR, BOARD TO BOARD 13P

< DIODE >

D130 8-719-988-61 DIODE 1SS355TE-17

MAIN

95


HCD-GN88D

D201 8-719-988-61 DIODE 1SS355TE-17D202 8-719-988-61 DIODE 1SS355TE-17D392 8-719-988-61 DIODE 1SS355TE-17D393 8-719-988-61 DIODE 1SS355TE-17



D602 8-719-988-61 DIODE 1SS355TE-17D603 8-719-988-61 DIODE 1SS355TE-17D701 8-719-988-61 DIODE 1SS355TE-17D851 8-719-056-82 DIODE UDZ-TE-17-6.2BD852 8-719-056-84 DIODE UDZ-TE-17-7.5B

D901 8-719-028-23 DIODE D3SBA20-4101D902 8-719-500-60 DIODE D5SBA20D917 8-719-080-53 DIODE RK36LF-B3D941 8-719-977-81 DIODE UDZ-TE-17-33B

< FERRITE BEAD >

FB117 1-216-864-11 METAL CHIP 0 5% 1/10WFB167 1-216-864-11 METAL CHIP 0 5% 1/10WFB204 1-216-864-11 METAL CHIP 0 5% 1/10WFB516 1-414-772-11 FERRITE 0uHFB562 1-414-772-11 FERRITE 0uH

< IC >

IC102 6-703-650-11 IC M61529FP-D60GIC103 6-703-651-11 IC M61530FP-D60GIC201 8-749-019-25 IC TOTX141 (CD DIGITAL OUT)IC301 6-702-130-01 IC HA12237FIC302 8-759-143-54 IC uPC1330HA

IC303 8-759-710-97 IC NJM4565M(TE2)IC501 6-802-866-01 IC M30620MCN-A27FPIC502 6-703-610-01 IC RT8H015C-T112-1IC601 8-759-533-04 IC M62703ML-E1IC730 8-759-711-10 IC NJU4066BM-T2

IC907 6-700-813-01 IC SI-8033JF

< JACK)

J117 1-764-593-21 JACK 2P (MD/VIDEO(AUDIO) IN)J716 1-770-377-31 JACK, PIN 1P (SUBWOOFER)J730 1-764-593-21 JACK 2P (AUDIO OUT)

< JUMPER RESISTOR >

JR10 1-216-864-11 METAL CHIP 0 5% 1/10WJR002 1-216-864-11 METAL CHIP 0 5% 1/10WJR003 1-216-864-11 METAL CHIP 0 5% 1/10WJR004 1-216-296-11 SHORT CHIP 0JR005 1-216-864-11 METAL CHIP 0 5% 1/10W

JR006 1-216-864-11 METAL CHIP 0 5% 1/10WJR008 1-216-864-11 METAL CHIP 0 5% 1/10WJR009 1-216-864-11 METAL CHIP 0 5% 1/10WJR015 1-216-864-11 METAL CHIP 0 5% 1/10WJR104 1-216-296-11 SHORT CHIP 0

JR138 1-216-864-11 METAL CHIP 0 5% 1/10WJR390 1-216-864-11 METAL CHIP 0 5% 1/10W

< COIL >

L201 1-414-189-31 INDUCTOR 100uHL301 1-410-780-11 INDUCTOR 27mHL302 1-414-189-31 INDUCTOR 100uHL351 1-410-780-11 INDUCTOR 27mHL901 1-456-468-11 INDUCTOR 100uH

< TRANSISTOR >

Q101 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q105 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q151 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q223 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q224 8-729-113-69 TRANSISTOR FN1F4M-T1M32

Q301 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q302 8-729-142-46 TRANSISTOR 2SC2001TP-LKQ303 8-729-142-46 TRANSISTOR 2SC2001TP-LKQ304 8-729-113-69 TRANSISTOR FN1F4M-T1M32Q305 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q306 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q307 8-729-216-22 TRANSISTOR 2SA812-T1-M5M6Q310 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q389 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q390 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q391 8-729-140-04 TRANSISTOR 2SB1116-TP-LKQ392 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q393 8-729-116-57 TRANSISTOR 2SB1068TP-KQ394 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q395 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q396 8-729-140-04 TRANSISTOR 2SB1116-TP-LKQ398 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q399 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q601 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q602 8-729-014-97 TRANSISTOR FA1L3Z-T1B

Q620 8-729-802-80 TRANSISTOR 2SC3661-TBQ621 8-729-802-80 TRANSISTOR 2SC3661-TBQ650 8-729-113-69 TRANSISTOR FN1F4M-T1M32Q651 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q652 8-729-113-69 TRANSISTOR FN1F4M-T1M32

Q670 8-729-802-80 TRANSISTOR 2SC3661-TBQ671 8-729-802-80 TRANSISTOR 2SC3661-TBQ701 8-729-014-97 TRANSISTOR FA1L3Z-T1BQ702 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q730 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q798 8-729-802-80 TRANSISTOR 2SC3661-TBQ799 8-729-802-80 TRANSISTOR 2SC3661-TBQ800 8-729-802-80 TRANSISTOR 2SC3661-TBQ801 8-729-802-80 TRANSISTOR 2SC3661-TBQ802 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6

Q803 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q851 8-729-026-68 TRANSISTOR 2SD2525(TP)Q852 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q853 8-729-120-28 TRANSISTOR 2SC1623-T1-L5L6Q854 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q903 8-729-209-60 TRANSISTOR 2SB1375Q909 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q910 8-729-113-13 TRANSISTOR FA1A4M-T1L33

MAIN

96


HCD-GN88D

The components identified by mark 0 or dotted line with mark 0 are critical for safety.Replace only with part number specified.

< RESISTOR >

R101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR102 1-216-833-11 METAL CHIP 10K 5% 1/10WR103 1-220-373-11 METAL CHIP 620 5% 1/10WR104 1-216-821-11 METAL CHIP 1K 5% 1/10WR105 1-216-841-11 METAL CHIP 47K 5% 1/10W


R116 1-216-809-11 METAL CHIP 100 5% 1/10WR117 1-216-845-11 METAL CHIP 100K 5% 1/10WR118 1-216-821-11 METAL CHIP 1K 5% 1/10WR121 1-216-809-11 METAL CHIP 100 5% 1/10WR122 1-216-809-11 METAL CHIP 100 5% 1/10W

R130 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR131 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR132 1-216-857-11 METAL CHIP 1M 5% 1/10WR133 1-216-845-11 METAL CHIP 100K 5% 1/10WR134 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

(TH)

R134 1-216-826-11 METAL CHIP 2.7K 5% 1/10W(EXCEPT TH)

R149 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR150 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR151 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR152 1-216-833-11 METAL CHIP 10K 5% 1/10W

R153 1-220-373-11 METAL CHIP 620 5% 1/10WR154 1-216-821-11 METAL CHIP 1K 5% 1/10WR155 1-216-841-11 METAL CHIP 47K 5% 1/10WR156 1-216-833-11 METAL CHIP 10K 5% 1/10WR157 1-216-809-11 METAL CHIP 100 5% 1/10W


R235 1-216-853-11 METAL CHIP 470K 5% 1/10WR301 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR302 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR303 1-216-833-11 METAL CHIP 10K 5% 1/10WR304 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R305 1-216-841-11 METAL CHIP 47K 5% 1/10WR306 1-216-837-11 METAL CHIP 22K 5% 1/10WR307 1-216-857-11 METAL CHIP 1M 5% 1/10WR308 1-216-809-11 METAL CHIP 100 5% 1/10WR309 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R315 1-216-833-11 METAL CHIP 10K 5% 1/10WR316 1-216-833-11 METAL CHIP 10K 5% 1/10WR317 1-216-833-11 METAL CHIP 10K 5% 1/10WR320 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR327 1-216-835-11 METAL CHIP 15K 5% 1/10W

R328 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R329 1-216-833-11 METAL CHIP 10K 5% 1/10WR330 1-216-837-11 METAL CHIP 22K 5% 1/10WR332 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR333 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R334 1-216-845-11 METAL CHIP 100K 5% 1/10WR342 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

0R343 1-219-787-17 FUSIBLE 5.6 5% 1/4W0R344 1-219-787-17 FUSIBLE 5.6 5% 1/4W

R345 1-216-836-11 METAL CHIP 18K 5% 1/10W

R346 1-216-836-11 METAL CHIP 18K 5% 1/10WR347 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR351 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR352 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR353 1-216-833-11 METAL CHIP 10K 5% 1/10W

R354 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR355 1-216-841-11 METAL CHIP 47K 5% 1/10WR360 1-216-819-11 METAL CHIP 680 5% 1/10WR361 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR362 1-216-833-11 METAL CHIP 10K 5% 1/10W

R363 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR364 1-216-819-11 METAL CHIP 680 5% 1/10WR365 1-216-833-11 METAL CHIP 10K 5% 1/10WR366 1-216-819-11 METAL CHIP 680 5% 1/10WR367 1-216-833-11 METAL CHIP 10K 5% 1/10W

R368 1-216-833-11 METAL CHIP 10K 5% 1/10WR369 1-216-833-11 METAL CHIP 10K 5% 1/10WR370 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR371 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR372 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R373 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR374 1-216-833-11 METAL CHIP 10K 5% 1/10WR375 1-216-833-11 METAL CHIP 10K 5% 1/10WR376 1-216-833-11 METAL CHIP 10K 5% 1/10WR377 1-216-833-11 METAL CHIP 10K 5% 1/10W

R378 1-216-833-11 METAL CHIP 10K 5% 1/10WR379 1-216-833-11 METAL CHIP 10K 5% 1/10WR380 1-216-837-11 METAL CHIP 22K 5% 1/10WR382 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR387 1-216-833-11 METAL CHIP 10K 5% 1/10W

R388 1-216-837-11 METAL CHIP 22K 5% 1/10WR390 1-216-833-11 METAL CHIP 10K 5% 1/10WR391 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR392 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR393 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R394 1-216-833-11 METAL CHIP 10K 5% 1/10WR395 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR396 1-216-833-11 METAL CHIP 10K 5% 1/10WR397 1-216-835-11 METAL CHIP 15K 5% 1/10WR398 1-216-861-11 METAL CHIP 2.2M 5% 1/10W

R399 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR401 1-216-833-11 METAL CHIP 10K 5% 1/10WR402 1-216-833-11 METAL CHIP 10K 5% 1/10WR419 1-216-809-11 METAL CHIP 100 5% 1/10WR420 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R421 1-216-833-11 METAL CHIP 10K 5% 1/10WR422 1-216-833-11 METAL CHIP 10K 5% 1/10WR429 1-216-809-11 METAL CHIP 100 5% 1/10W

MAIN

97


HCD-GN88D

R430 1-216-809-11 METAL CHIP 100 5% 1/10WR442 1-216-809-11 METAL CHIP 100 5% 1/10W



R478 1-216-833-11 METAL CHIP 10K 5% 1/10WR488 1-216-809-11 METAL CHIP 100 5% 1/10WR492 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR493 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

(E3,E15,E51,EA,MX)R493 1-216-864-11 METAL CHIP 0 5% 1/10W

(AUS,SP,MY,PH,TH)



R513 1-216-864-11 METAL CHIP 0 5% 1/10WR517 1-216-833-11 METAL CHIP 10K 5% 1/10WR519 1-216-833-11 METAL CHIP 10K 5% 1/10WR521 1-216-809-11 METAL CHIP 100 5% 1/10WR522 1-216-809-11 METAL CHIP 100 5% 1/10W



R550 1-216-833-11 METAL CHIP 10K 5% 1/10WR560 1-216-809-11 METAL CHIP 100 5% 1/10WR561 1-216-809-11 METAL CHIP 100 5% 1/10WR563 1-216-833-11 METAL CHIP 10K 5% 1/10WR566 1-216-809-11 METAL CHIP 100 5% 1/10W



R580 1-216-809-11 METAL CHIP 100 5% 1/10W

R581 1-216-809-11 METAL CHIP 100 5% 1/10WR582 1-216-809-11 METAL CHIP 100 5% 1/10WR583 1-216-809-11 METAL CHIP 100 5% 1/10WR584 1-216-809-11 METAL CHIP 100 5% 1/10W


R590 1-216-809-11 METAL CHIP 100 5% 1/10WR591 1-216-809-11 METAL CHIP 100 5% 1/10WR592 1-216-811-11 METAL CHIP 150 5% 1/10WR593 1-216-821-11 METAL CHIP 1K 5% 1/10W

(E3,E15,E51,EA,MX)R593 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

(AUS,SP,MY,PH)


R601 1-216-813-11 METAL CHIP 220 5% 1/10WR602 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR603 1-216-841-11 METAL CHIP 47K 5% 1/10WR604 1-216-841-11 METAL CHIP 47K 5% 1/10WR620 1-216-833-11 METAL CHIP 10K 5% 1/10W

R621 1-216-821-11 METAL CHIP 1K 5% 1/10WR622 1-216-841-11 METAL CHIP 47K 5% 1/10WR623 1-216-833-11 METAL CHIP 10K 5% 1/10WR624 1-215-891-11 METAL OXIDE 680 5% 2WR625 1-216-821-11 METAL CHIP 1K 5% 1/10W



R670 1-216-833-11 METAL CHIP 10K 5% 1/10WR671 1-216-821-11 METAL CHIP 1K 5% 1/10WR672 1-216-841-11 METAL CHIP 47K 5% 1/10WR673 1-216-833-11 METAL CHIP 10K 5% 1/10WR674 1-215-891-11 METAL OXIDE 680 5% 2W

R675 1-216-821-11 METAL CHIP 1K 5% 1/10WR676 1-216-806-11 METAL CHIP 56 5% 1/10W

0R701 1-249-409-11 CARBON 220 5% 1/4W FR702 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR720 1-216-821-11 METAL CHIP 1K 5% 1/10W


R772 1-216-821-11 METAL CHIP 1K 5% 1/10W

MAIN


98


HCD-GN88D

R798 1-216-809-11 METAL CHIP 100 5% 1/10WR799 1-216-809-11 METAL CHIP 100 5% 1/10WR800 1-216-841-11 METAL CHIP 47K 5% 1/10WR801 1-216-817-11 METAL CHIP 470 5% 1/10W


R807 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR808 1-216-841-11 METAL CHIP 47K 5% 1/10WR809 1-216-841-11 METAL CHIP 47K 5% 1/10WR810 1-216-833-11 METAL CHIP 10K 5% 1/10WR811 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R812 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR813 1-216-833-11 METAL CHIP 10K 5% 1/10WR814 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR815 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR816 1-216-841-11 METAL CHIP 47K 5% 1/10W

R817 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR818 1-216-821-11 METAL CHIP 1K 5% 1/10WR819 1-220-373-11 METAL CHIP 620 5% 1/10WR820 1-220-373-11 METAL CHIP 620 5% 1/10WR821 1-216-857-11 METAL CHIP 1M 5% 1/10W

R822 1-216-833-11 METAL CHIP 10K 5% 1/10WR823 1-216-857-11 METAL CHIP 1M 5% 1/10WR824 1-216-833-11 METAL CHIP 10K 5% 1/10WR825 1-216-857-11 METAL CHIP 1M 5% 1/10WR826 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R827 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR828 1-216-841-11 METAL CHIP 47K 5% 1/10WR829 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR830 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR831 1-216-841-11 METAL CHIP 47K 5% 1/10W

R832 1-216-833-11 METAL CHIP 10K 5% 1/10WR833 1-216-817-11 METAL CHIP 470 5% 1/10WR834 1-216-841-11 METAL CHIP 47K 5% 1/10WR835 1-216-821-11 METAL CHIP 1K 5% 1/10WR836 1-216-833-11 METAL CHIP 10K 5% 1/10W




R852 1-216-837-11 METAL CHIP 22K 5% 1/10WR853 1-216-845-11 METAL CHIP 100K 5% 1/10WR854 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR857 1-216-864-11 METAL CHIP 0 5% 1/10WR858 1-216-864-11 METAL CHIP 0 5% 1/10W


R905 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR906 1-216-821-11 METAL CHIP 1K 5% 1/10WR915 1-216-845-11 METAL CHIP 100K 5% 1/10WR916 1-216-845-11 METAL CHIP 100K 5% 1/10WR917 1-216-833-11 METAL CHIP 10K 5% 1/10W

R921 1-216-820-11 METAL CHIP 820 5% 1/10WR922 1-216-805-11 METAL CHIP 47 5% 1/10WR923 1-216-833-11 METAL CHIP 10K 5% 1/10W

< VARIABLE RESISTOR >

RV301 1-238-019-11 RES, ADJ, CARBON 47K (REC LEVEL(L))RV304 1-241-768-11 RES, ADJ, CARBON 220K (REC BIAS(L))RV351 1-238-019-11 RES, ADJ, CARBON 47K (REC LEVEL(R))RV354 1-241-768-11 RES, ADJ, CARBON 220K (REC BIAS(R))RY701 1-755-267-11 RELAY

< TRANSFORMER >

T301 1-423-980-11 TRANSFORMER, BIAS OSCILLATION

< VIBRATOR >

X501 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)X502 1-781-107-21 VIBRATOR, SERAMIC (16MHz)

******************************************************

1-687-133-11 MOTOR (LD) BOARD****************

******************************************************

1-687-134-11 MOTOR (TB) BOARD***************

< CONNECTOR >

CN742 1-784-727-11 CONNECTOR, FFC 5P******************************************************

A-4732-900-A POWER AMP BOARD, COMPLETE (EXCEPT TH)A-4734-623-A POWER AMP BOARD, COMPLETE (TH)

************************

7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S

< CAPACITOR >

C501 1-126-963-11 ELECT 4.7uF 20% 50VC502 1-162-294-31 CERAMIC 0.001uF 10% 50VC503 1-162-286-31 CERAMIC 220PF 10% 50VC504 1-104-665-11 ELECT 100uF 20% 10VC507 1-136-495-11 FILM 0.068uF 5% 50V

C508 1-136-495-11 FILM 0.068uF 5% 50VC509 1-128-560-11 ELECT 22uF 20% 100VC512 1-162-306-11 CERAMIC 0.01uF 20% 16VC513 1-162-306-11 CERAMIC 0.01uF 20% 16VC516 1-104-665-11 ELECT 100uF 20% 10V

C517 1-126-964-11 ELECT 10uF 20% 50VC523 1-162-306-11 CERAMIC 0.01uF 30% 16VC524 1-162-306-11 CERAMIC 0.01uF 30% 16V

MAIN MOTOR (LD) MOTOR (TB) POWER AMP

99


HCD-GN88D

C525 1-162-306-11 CERAMIC 0.01uF 20% 16VC526 1-126-964-11 ELECT 10uF 20% 50V

C527 1-162-306-11 CERAMIC 0.01uF 20% 16VC528 1-162-306-11 CERAMIC 0.01uF 20% 16VC541 1-136-165-00 FILM 0.1uF 5% 50VC542 1-127-811-11 ELECT 3300uF 20% 50VC544 1-130-777-00 MYLAR 0.1uF 5% 100V

C545 1-130-777-00 MYLAR 0.1uF 5% 100VC546 1-137-843-11 ELECT 2200uF 20% 100VC551 1-126-963-11 ELECT 4.7uF 20% 50VC552 1-162-294-31 CERAMIC 0.001uF 10% 50VC553 1-162-286-31 CERAMIC 220PF 10% 50V

C554 1-104-665-11 ELECT 100uF 20% 10VC557 1-136-495-11 FILM 0.068uF 5% 50VC558 1-136-495-11 FILM 0.068uF 5% 50VC559 1-128-560-11 ELECT 22uF 20% 100VC581 1-126-965-91 ELECT 22uF 20% 50V

C591 1-136-165-00 FILM 0.1uF 5% 50VC592 1-127-811-11 ELECT 3300uF 20% 50VC596 1-137-843-11 ELECT 2200uF 20% 100V

< CONNECTOR >

CN502 1-564-509-11 PLUG, CONNECTOR 6P (TH)CN503 1-778-981-21 CONNECTOR, BOARD TO BOARD 13PCN504 1-770-722-11 CONNECTOR, BOARD TO BOARD 6P

< DIODE >

D501 8-719-991-33 DIODE 1SS133T-72D502 8-719-991-33 DIODE 1SS133T-72D503 8-719-947-70 DIODE MTZJ-T-72-18CD504 8-719-947-70 DIODE MTZJ-T-72-18CD506 8-719-991-33 DIODE 1SS133T-72

D507 8-719-991-33 DIODE 1SS133T-72D508 8-719-991-33 DIODE 1SS133T-72D509 8-719-991-33 DIODE 1SS133T-72D511 8-719-991-33 DIODE 1SS133T-72D541 8-719-060-53 DIODE RBV-2506

D543 8-719-500-60 DIODE D5SBA20D551 8-719-991-33 DIODE 1SS133T-72D581 8-719-991-33 DIODE 1SS133T-72

< EARTH TERMINAL >

* EP501 1-537-738-21 TERMINAL, EARTH* EP502 1-537-738-21 TERMINAL, EARTH

< IC >

IC501 8-749-017-06 IC STK412-150

< TRANSISTOR >

Q501 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ503 8-729-821-00 TRANSISTOR 2SA1207-AAQ504 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ505 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ506 8-729-119-79 TRANSISTOR 2SC2785TP-FEK

Q510 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ511 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ514 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ516 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ517 8-729-119-76 TRANSISTOR 2SA1175TP-HFE

Q518 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ551 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ581 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA

< RESISTOR >

R501 1-249-417-11 CARBON 1K 5% 1/4W FR502 1-249-437-11 CARBON 47K 5% 1/4WR503 1-249-409-11 CARBON 220 5% 1/4W FR504 1-249-437-11 CARBON 47K 5% 1/4WR505 1-249-416-11 CARBON 820 5% 1/4W F


0R508 1-234-798-11 ENCAPSULATED COMPONENTR509 1-260-076-11 CARBON 10 5% 1/2W

0R511 1-212-881-11 FUSIBLE 100 5% 1/4W

0R512 1-202-972-61 FUSIBLE 1 5% 1/4WR513 1-249-435-11 CARBON 33K 5% 1/4WR514 1-249-421-11 CARBON 2.2K 5% 1/4W FR515 1-249-433-11 CARBON 22K 5% 1/4WR516 1-249-429-11 CARBON 10K 5% 1/4W

R517 1-249-429-11 CARBON 10K 5% 1/4WR518 1-249-435-11 CARBON 33K 5% 1/4WR519 1-249-439-11 CARBON 68K 5% 1/4W

0R520 1-215-872-11 METAL OXIDE 3.3K 5% 1WR521 1-249-441-11 CARBON 100K 5% 1/4W


0R524 1-215-872-11 METAL OXIDE 3.3K 5% 1WR527 1-249-438-11 CARBON 56K 5% 1/4WR528 1-249-437-11 CARBON 47K 5% 1/4W


(TH)R531 1-247-891-00 CARBON 330K 5% 1/4W

(EXCEPT TH)R532 1-249-441-11 CARBON 100K 5% 1/4W

R533 1-249-437-11 CARBON 47K 5% 1/4W0R539 1-215-891-11 METAL OXIDE 680 5% 2W

R541 1-249-441-11 CARBON 100K 5% 1/4WR542 1-249-441-11 CARBON 100K 5% 1/4WR545 1-249-417-11 CARBON 1K 5% 1/4W F

R546 1-249-433-11 CARBON 22K 5% 1/4WR547 1-249-437-11 CARBON 47K 5% 1/4WR548 1-249-437-11 CARBON 47K 5% 1/4WR551 1-249-417-11 CARBON 1K 5% 1/4W FR552 1-249-437-11 CARBON 47K 5% 1/4W

R553 1-249-409-11 CARBON 220 5% 1/4W FR554 1-249-437-11 CARBON 47K 5% 1/4WR555 1-249-416-11 CARBON 820 5% 1/4W FR556 1-249-435-11 CARBON 33K 5% 1/4WR557 1-249-441-11 CARBON 100K 5% 1/4W

0R558 1-234-798-11 ENCAPSULATED COMPONENTR559 1-260-076-11 CARBON 10 5% 1/2W

0R561 1-212-881-11 FUSIBLE 100 5% 1/4WR564 1-249-433-11 CARBON 22K 5% 1/4WR565 1-249-433-11 CARBON 22K 5% 1/4W


POWER AMP

100


HCD-GN88D

R568 1-249-429-11 CARBON 10K 5% 1/4WR569 1-249-437-11 CARBON 47K 5% 1/4WR570 1-249-429-11 CARBON 10K 5% 1/4WR572 1-249-441-11 CARBON 100K 5% 1/4WR577 1-247-807-31 CARBON 100 5% 1/4W


< RELAY >

RY501 1-515-920-11 RELAY

< THERMISTOR >

TH501 1-807-796-11 THERMISTORTH502 1-807-796-11 THERMISTOR

< TERMINAL >

TM501 1-694-991-11 PUSH TERMINAL (10P)(FRONT/SURROUND/CENTER SPEAKER)

******************************************************

A-4732-884-A REGULATOR BOARD, COMPLETE (EXCEPT TH)A-4734-506-A REGULATOR BOARD, COMPLETE (TH)

************************

< CAPACITOR >

C910 1-164-156-11 CERAMIC CHIP 0.1uF 25VC911 1-126-935-11 ELECT 470uF 20% 10VC912 1-164-156-11 CERAMIC CHIP 0.1uF 25VC913 1-126-768-11 ELECT 2200uF 20% 16VC915 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C917 1-126-935-11 ELECT 470uF 20% 6.3VC918 1-164-156-11 CERAMIC CHIP 0.1uF 25VC919 1-164-156-11 CERAMIC CHIP 0.1uF 25VC921 1-164-156-11 CERAMIC CHIP 0.1uF 25VC922 1-104-656-11 ELECT 2200uF 20% 6.3V

C923 1-164-156-11 CERAMIC CHIP 0.1uF 25VC924 1-126-935-11 ELECT 470uF 20% 6.3VC925 1-164-156-11 CERAMIC CHIP 0.1uF 25VC926 1-126-935-11 ELECT 470uF 20% 10V

< CONNECTOR >

* CN713 1-564-525-11 PLUG, CONNECTOR 10P* CN714 1-564-519-11 PLUG, CONNECTOR 4P

< FERRITE BEAD >

FB205 1-216-864-11 METAL CHIP 0 5% 1/10W

< IC >

IC901 6-703-550-01 IC TA7809LSIC902 8-759-518-68 IC PQ12RF21IC903 6-703-550-01 IC TA7809LSIC904 6-703-546-01 IC TA7804LSIC905 6-703-547-01 IC TA7805LS

IC906 6-703-547-01 IC TA7805LS

< TRANSISTOR >

Q903 8-729-113-13 TRANSISTOR FA1A4M-T1L33

Q904 8-729-113-13 TRANSISTOR FA1A4M-T1L33Q905 8-729-209-60 TRANSISTOR 2SB1375Q906 8-729-113-13 TRANSISTOR FA1A4M-T1L33

< RESISTOR >

R901 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR902 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR903 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR905 1-216-833-11 METAL CHIP 10K 5% 1/10WR906 1-216-833-11 METAL CHIP 10K 5% 1/10W

******************************************************

A-4728-690-A RF BOARD, COMPLETE****************

< CAPACITOR >

C001 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC002 1-124-779-00 ELECT CHIP 10uF 20% 16VC003 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC004 1-124-779-00 ELECT CHIP 10uF 20% 16VC005 1-128-993-21 ELECT CHIP 22uF 20% 10V

C006 1-128-993-21 ELECT CHIP 22uF 20% 10VC008 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC009 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC010 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25VC011 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V

C012 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC013 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC014 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC015 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC016 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C017 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC018 1-164-172-11 CERAMIC CHIP 0.0056uF 10% 25VC019 1-164-172-11 CERAMIC CHIP 0.0056uF 10% 25VC020 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC021 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C022 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC023 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC024 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC025 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC026 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V



C037 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC038 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC039 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC040 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC041 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C042 1-164-218-11 CERAMIC CHIP 180PF 0.25PF 50VC049 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

< CONNECTOR >

CN001 1-815-031-11 CONNECTOR, FFC/FPC (ZIF) 24P

POWER AMP REGULATOR RF

101


HCD-GN88D

CN002 1-784-836-21 CONNECTOR,FFC(LIF(NON-ZIF))29PCN003 1-784-861-21 CONNECTOR, FFC(LIF(NON-ZIF))9P

< DIODE >

D001 8-719-988-61 DIODE 1SS355TE-17D002 8-719-988-61 DIODE 1SS355TE-17

< IC >

IC001 6-703-551-01 IC SP3723BDAOPM

< COIL >

L001 1-412-031-11 INDUCTOR CHIP 47uHL002 1-412-031-11 INDUCTOR CHIP 47uH

< TRANSISTOR >

Q001 8-729-903-46 TRANSISTOR 2SB1132-PQ002 8-729-903-46 TRANSISTOR 2SB1132-P

< RESISTOR >

R001 1-218-668-11 METAL CHIP 100 0.5% 1/10WR003 1-216-803-11 METAL CHIP 33 5% 1/10WR004 1-216-803-11 METAL CHIP 33 5% 1/10WR005 1-216-841-11 METAL CHIP 47K 5% 1/10WR006 1-216-817-11 METAL CHIP 470 5% 1/10W




R022 1-216-813-11 METAL CHIP 220 5% 1/10WR023 1-216-820-11 METAL CHIP 820 5% 1/10WR024 1-216-864-11 METAL CHIP 0 5% 1/10WR025 1-216-809-11 METAL CHIP 100 5% 1/10WR026 1-218-718-11 METAL CHIP 12K 0.5% 1/10W


R034 1-219-570-11 METAL CHIP 10M 5% 1/10WR035 1-216-864-11 METAL CHIP 0 5% 1/10WR041 1-216-821-11 METAL CHIP 1K 5% 1/10W

******************************************************

1-687-132-11 SENSOR BOARD************

< CONNECTOR >

CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE)3P******************************************************

A-4734-889-A SUB TRANS BOARD, COMPLETE (MX)A-4734-967-A SUB TRANS BOARD, COMPLETE (AUS)A-4749-088-A SUB TRANS BOARD, COMPLETE

(E15,E3,E51,PH,SP,MY)A-4749-091-A SUB TRANS BOARD, COMPLETE (TH)A-4749-093-A SUB TRANS BOARD, COMPLETE (EA)

***********************

< CAPACITOR >

0C971 1-113-925-11 CERAMIC 0.01uF 20% 250VC973 1-126-933-11 ELECT 100uF 20% 16VC975 1-126-767-11 ELECT 1000uF 20% 16VC976 1-164-159-21 CERAMIC 0.1uF 50V(TH)C976 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)

C977 1-164-159-21 CERAMIC 0.1uF 50V(TH)C977 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C978 1-164-159-21 CERAMIC 0.1uF 50V(TH)C978 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)

< CONNECTOR >

CN971 1-568-106-11 PIN, CONNECTOR(3.96mm PITCH)4P(E15,E3,E51,EA,PH,SP,MY)

CN971 1-564-321-00 PIN, CONNECTOR(3.96mm PITCH)2P(AUS,MX,TH)

CN974 1-564-321-00 PIN, CONNECTOR(3.96mm PITCH)2PCN976 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE)4P

< DIODE >

D971 8-719-991-33 DIODE 1SS133T-72D972 8-719-200-82 DIODE 11ES2-NTA1B (TH)D972 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT TH)D973 8-719-200-82 DIODE 11ES2-NTA1B (TH)D973 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT TH)

D974 8-719-200-82 DIODE 11ES2-NTA1B (TH)D974 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT TH)D975 8-719-200-82 DIODE 11ES2-NTA1B (TH)D975 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT TH)

< IC >

IC971 6-703-546-01 IC TA7804LS

< TRANSISTOR >

Q971 8-729-119-79 TRANSISTOR 2SC2785TP-FEK

< RESISTOR >


< RELAY >

0RY971 1-755-276-11 RELAY, POWER

< SWITCH >

0S901 1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR)(EXCEPT AUS,MX,TH)


RF SENSOR SUB TRANS

102


HCD-GN88D

< TRANSFORMER >

0T972 1-437-775-21 TRANSFORMER, POWER (EA,MX)0T972 1-437-751-12 TRANSFORMER, POWER (EXCEPT EA,MX)******************************************************

A-4732-892-A SURROUND BOARD, COMPLETE (EXCEPT TH)A-4734-262-A SURROUND BOARD, COMPLETE (TH)

***********************

< CAPACITOR >

C301 1-126-963-11 ELECT 4.7uF 20% 50VC302 1-162-286-21 CERAMIC 220PF 10% 50V(TH)C302 1-162-286-31 CERAMIC 220PF 10% 50V

(EXCEPT TH)C303 1-107-473-11 CERAMIC 220PF 5% 50VC304 1-126-947-11 ELECT 47uF 20% 10V

C306 1-136-495-11 FILM 0.068uF 5% 50VC307 1-136-495-11 FILM 0.068uF 5% 50VC308 1-128-576-11 ELECT 100uF 20% 63VC319 1-162-306-11 CERAMIC 0.01uF 30% 16VC341 1-126-963-11 ELECT 4.7uF 20% 50V


(EXCEPT TH)C343 1-107-473-11 CERAMIC 220PF 5% 50VC344 1-126-947-11 ELECT 47uF 20% 10VC346 1-136-495-11 FILM 0.068uF 5% 50V

C347 1-136-495-11 FILM 0.068uF 5% 50VC351 1-126-963-11 ELECT 4.7uF 20% 50VC352 1-162-286-21 CERAMIC 220PF 10% 50V(TH)C352 1-162-286-31 CERAMIC 220PF 10% 50V

(EXCEPT TH)C353 1-107-473-11 CERAMIC 220PF 5% 50V

C354 1-126-947-11 ELECT 47uF 20% 10VC356 1-136-495-11 FILM 0.068uF 5% 50VC357 1-136-495-11 FILM 0.068uF 5% 50VC358 1-128-576-11 ELECT 100uF 20% 63V

< CONNECTOR >

CN303 1-564-509-11 PLUG, CONNECTOR 6P* CN304 1-564-520-11 PLUG, CONNECTOR 5P

< DIODE >

D301 8-719-991-33 DIODE 1SS133T-72D341 8-719-991-33 DIODE 1SS133T-72D351 8-719-991-33 DIODE 1SS133T-72D381 8-719-991-33 DIODE 1SS133T-72D382 8-719-991-33 DIODE 1SS133T-72

D391 8-719-991-33 DIODE 1SS133T-72

< GROUND TERMINAL >

EP301 1-537-738-21 TERMINAL, GROUND

< IC >

IC301 6-600-168-01 IC STK443-090

< TRANSISTOR >

Q301 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ341 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ351 8-729-119-79 TRANSISTOR 2SC2785TP-FEK

Q381 8-729-119-76 TRANSISTOR 2SA1175TP-HFEQ383 8-729-119-76 TRANSISTOR 2SA1175TP-HFE

Q384 8-729-900-36 TRANSISTOR BA1F4M-TPQ385 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ386 8-729-900-36 TRANSISTOR BA1F4M-TP

< RESISTOR >

R301 1-249-417-11 CARBON 1K 5% 1/4W FR302 1-249-437-11 CARBON 47K 5% 1/4WR303 1-249-411-11 CARBON 330 5% 1/4WR304 1-249-437-11 CARBON 47K 5% 1/4W

0R305 1-234-499-21 ENCAPSULATED COMPONENT

R307 1-249-417-11 CARBON 1K 5% 1/4W FR308 1-249-434-11 CARBON 27K 5% 1/4WR309 1-249-441-11 CARBON 100K 5% 1/4WR310 1-260-076-11 CARBON 10 5% 1/2W

0R311 1-212-881-11 FUSIBLE 100 5% 1/4W

R319 1-247-862-11 CARBON 20K 5% 1/4W0R320 1-202-972-61 FUSIBLE 1 5% 1/4W


R341 1-249-417-11 CARBON 1K 5% 1/4W FR342 1-249-437-11 CARBON 47K 5% 1/4WR343 1-249-411-11 CARBON 330 5% 1/4WR344 1-249-437-11 CARBON 47K 5% 1/4W

0R345 1-234-499-21 ENCAPSULATED COMPONENT

R347 1-249-417-11 CARBON 1K 5% 1/4W FR348 1-249-434-11 CARBON 27K 5% 1/4WR349 1-249-441-11 CARBON 100K 5% 1/4WR350 1-260-076-11 CARBON 10 5% 1/2WR351 1-249-417-11 CARBON 1K 5% 1/4W F

R352 1-249-437-11 CARBON 47K 5% 1/4WR353 1-249-411-11 CARBON 330 5% 1/4WR354 1-249-437-11 CARBON 47K 5% 1/4W

0R356 1-234-499-21 ENCAPSULATED COMPONENTR357 1-249-417-11 CARBON 1K 5% 1/4W F

R358 1-249-434-11 CARBON 27K 5% 1/4WR359 1-249-441-11 CARBON 100K 5% 1/4WR360 1-260-076-11 CARBON 10 5% 1/2W

0R361 1-212-881-11 FUSIBLE 100 5% 1/4W0R387 1-215-891-11 METAL OXIDE 680 5% 2W

0R388 1-215-891-11 METAL OXIDE 680 5% 2WR390 1-249-429-11 CARBON 10K 5% 1/4WR395 1-249-429-11 CARBON 10K 5% 1/4WR396 1-249-433-11 CARBON 22K 5% 1/4WR397 1-249-417-11 CARBON 1K 5% 1/4W F

R399 1-249-417-11 CARBON 1K 5% 1/4W FR401 1-249-417-11 CARBON 1K 5% 1/4W FR402 1-249-433-11 CARBON 22K 5% 1/4W

< RELAY >

RY381 1-755-417-12 RELAYRY382 1-755-417-12 RELAY

******************************************************


SUB TRANS SURROUND

103


HCD-GN88D

1-687-669-11 SW BOARD********

S751 1-786-514-11 SWITCH, LEVER (SLIDE) (LEVER)******************************************************

1-686-930-11 TRANS BOARD***********

< CAPACITOR >

C941 1-128-576-11 ELECT 100uF 20% 63V

< CONNECTOR >

CN997 1-564-509-11 PLUG, CONNECTOR 6P* CN998 1-564-510-11 PLUG, CONNECTOR 7P

< DIODE >

D977 8-719-024-99 DIODE 11ES2-NTA2B

< FUSE HOLDER >

FH9741 1-533-233-11 FUSE HOLDERFH9742 1-533-233-11 FUSE HOLDERFH9751 1-533-233-11 FUSE HOLDERFH9752 1-533-233-11 FUSE HOLDERFH9761 1-533-233-11 FUSE HOLDER

FH9762 1-533-233-11 FUSE HOLDERFH9771 1-533-233-11 FUSE HOLDERFH9772 1-533-233-11 FUSE HOLDERFH9781 1-533-233-11 FUSE HOLDERFH9782 1-533-233-11 FUSE HOLDER

FH9791 1-533-233-11 FUSE HOLDERFH9792 1-533-233-11 FUSE HOLDER

< RESISTOR >

0R941 1-217-637-00 FUSIBLE 1 5% 1/4W******************************************************

A-4732-883-A VIDEO BOARD, COMPLETE (EXCEPT TH)A-4734-505-A VIDEO BOARD, COMPLETE (TH)

*******************

< CAPACITOR >

C215 1-126-964-11 ELECT 10uF 20% 50VC216 1-126-964-11 ELECT 10uF 20% 50VC217 1-126-964-11 ELECT 10uF 20% 50VC218 1-126-964-11 ELECT 10uF 20% 50VC219 1-126-964-11 ELECT 10uF 20% 50V

C220 1-126-964-11 ELECT 10uF 20% 50VC221 1-126-964-11 ELECT 10uF 20% 50VC222 1-126-964-11 ELECT 10uF 20% 50VC709 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC710 1-126-964-11 ELECT 10uF 20% 50V

C711 1-126-964-11 ELECT 10uF 20% 50VC712 1-126-926-11 ELECT 1000uF 20% 10VC713 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC714 1-126-933-11 ELECT 100uF 20% 16VC715 1-126-960-11 ELECT 1uF 20% 50V

C716 1-126-960-11 ELECT 1uF 20% 50VC717 1-126-960-11 ELECT 1uF 20% 50VC718 1-126-960-11 ELECT 1uF 20% 50VC719 1-126-960-11 ELECT 1uF 20% 50V

C720 1-126-960-11 ELECT 1uF 20% 50V

C721 1-126-933-11 ELECT 100uF 20% 16VC722 1-164-156-11 CERAMIC CHIP 0.1uF 25VC723 1-164-156-11 CERAMIC CHIP 0.1uF 25VC724 1-126-935-11 ELECT 470uF 20% 6.3VC725 1-128-551-11 ELECT 22uF 20% 25V

C726 1-126-935-11 ELECT 470uF 20% 6.3VC727 1-128-551-11 ELECT 22uF 20% 25VC728 1-126-935-11 ELECT 470uF 20% 6.3VC729 1-128-551-11 ELECT 22uF 20% 25VC730 1-126-933-11 ELECT 100uF 20% 16V

C731 1-126-965-91 ELECT 22uF 20% 50VC732 1-126-933-11 ELECT 100uF 20% 16VC733 1-126-965-91 ELECT 22uF 20% 50VC734 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC735 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C736 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC737 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC738 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC739 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC740 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C741 1-126-965-91 ELECT 22uF 20% 50VC742 1-126-947-11 ELECT 47uF 20% 16VC848 1-164-156-11 CERAMIC CHIP 0.1uF 25VC849 1-126-916-11 ELECT 1000uF 20% 6.3V

< CONNECTOR >

CN207 1-779-289-11 CONNECTOR,FFC(LIF(NON-ZIF))21PCN208 1-779-293-11 CONNECTOR,FFC(LIF(NON-ZIF))25P

* CN710 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN711 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE)2PCN712 1-779-285-11 CONNECTOR,FFC(LIF(NON-ZIF))17P

< DIODE >

D710 8-719-988-61 DIODE 1SS355TE-17D711 8-719-988-61 DIODE 1SS355TE-17

< FERRITE BEAD >

FB710 1-216-864-11 METAL CHIP 0 5% 1/10WFB711 1-216-864-11 METAL CHIP 0 5% 1/10WFB712 1-216-864-11 METAL CHIP 0 5% 1/10WFB713 1-216-864-11 METAL CHIP 0 5% 1/10WFB714 1-216-864-11 METAL CHIP 0 5% 1/10W

FB715 1-216-864-11 METAL CHIP 0 5% 1/10WFB798 1-216-864-11 METAL CHIP 0 5% 1/10W

< IC >

IC710 8-759-295-90 IC NJM2244M-TE2IC711 6-702-335-01 IC MM1568AJBE

< JACK >

J710 1-793-483-11 JACK, PIN 3P (COMPONENT VIDEO OUT)J711 1-774-227-11 JACK, PIN 1P (VIDEO OUT)J712 1-537-943-11 TERMINAL, S (S-VIDEO OUT)

< JUMPER RESISTOR >

JR713 1-216-864-11 METAL CHIP 0 5% 1/10W

SW TRANS VIDEO


104


HCD-GN88D

JR716 1-216-864-11 METAL CHIP 0 5% 1/10WJR717 1-216-864-11 METAL CHIP 0 5% 1/10WJR720 1-216-864-11 METAL CHIP 0 5% 1/10WJR721 1-216-864-11 METAL CHIP 0 5% 1/10W

< COIL >

L710 1-414-189-31 INDUCTOR 100uHL711 1-414-183-41 INDUCTOR 10uH

< TRANSISTOR >

Q215 8-729-802-80 TRANSISTOR 2SC3661-TBQ216 8-729-802-80 TRANSISTOR 2SC3661-TBQ217 8-729-802-80 TRANSISTOR 2SC3661-TBQ218 8-729-802-80 TRANSISTOR 2SC3661-TBQ219 8-729-802-80 TRANSISTOR 2SC3661-TB

Q220 8-729-802-80 TRANSISTOR 2SC3661-TBQ221 8-729-802-80 TRANSISTOR 2SC3661-TBQ222 8-729-802-80 TRANSISTOR 2SC3661-TBQ710 8-729-113-69 TRANSISTOR FN1F4M-T1M32Q711 8-729-113-13 TRANSISTOR FA1A4M-T1L33

< RESISTOR >







R716 1-218-285-11 METAL CHIP 75 5% 1/10WR717 1-218-285-11 METAL CHIP 75 5% 1/10WR718 1-216-845-11 METAL CHIP 100K 5% 1/10WR719 1-216-833-11 METAL CHIP 10K 5% 1/10WR720 1-218-285-11 METAL CHIP 75 5% 1/10W

R721 1-216-833-11 METAL CHIP 10K 5% 1/10W******************************************************

A-4732-868-A VOLUME BOARD, COMPLETE (EXCEPT TH)A-4734-534-A VOLUME BOARD, COMPLETE (TH)

*********************

< CAPACITOR >

C614 1-162-294-31 CERAMIC 0.001uF 10% 50VC615 1-124-589-11 ELECT 47uF 20% 16VC750 1-164-159-21 CERAMIC 0.1uF 50V(TH)C750 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C751 1-164-159-21 CERAMIC 0.1uF 50V(TH)

C751 1-164-159-11 CERAMIC 0.1uF 50V(EXCEPT TH)

C752 1-164-159-21 CERAMIC 0.1uF 50V(TH)C752 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)C1000 1-164-159-21 CERAMIC 0.1uF 50V(TH)C1000 1-164-159-11 CERAMIC 0.1uF 50V

(EXCEPT TH)

< CONNECTOR >

CN605 1-568-860-11 SOCKET, CONNECTOR 17P

< DIODE >

D1001 6-500-529-01 DIODE SLI-325URT31W (VOL 1)D1002 6-500-529-01 DIODE SLI-325URT31W (VOL 2)D1003 6-500-529-01 DIODE SLI-325URT31W (VOL 3)D1004 6-500-529-01 DIODE SLI-325URT31W (VOL 4)D1005 6-500-529-01 DIODE SLI-325URT31W (VOL 5)

D1006 6-500-529-01 DIODE SLI-325URT31W (VOL 6)D1007 6-500-529-01 DIODE SLI-325URT31W (VOL 7)D1008 6-500-529-01 DIODE SLI-325URT31W (VOL 8)D1009 6-500-529-01 DIODE SLI-325URT31W (VOL 9)D1010 6-500-529-01 DIODE SLI-325URT31W (VOL 10)

D1011 6-500-529-01 DIODE SLI-325URT31W (VOL 11)D1012 6-500-647-01 DIODE SEL5E20C-S-TP

(MULTI CHANNEL DECODING)D1013 8-719-991-33 DIODE 1SS133T-72

< IC >

IC603 6-600-174-01 IC RPM7240-H4

< TRANSISTOR >

Q1001 8-729-116-02 TRANSISTOR BA1A4M-TPQ1002 8-729-116-02 TRANSISTOR BA1A4M-TPQ1003 8-729-116-02 TRANSISTOR BA1A4M-TPQ1004 8-729-116-02 TRANSISTOR BA1A4M-TPQ1005 8-729-116-02 TRANSISTOR BA1A4M-TP

Q1006 8-729-116-02 TRANSISTOR BA1A4M-TP

< RESISTOR >

R625 1-249-401-11 CARBON 47 5% 1/4W FR750 1-249-410-11 CARBON 270 5% 1/4W FR759 1-249-427-11 CARBON 6.8K 5% 1/4W FR760 1-249-429-11 CARBON 10K 5% 1/4WR761 1-249-431-11 CARBON 15K 5% 1/4W

R762 1-249-433-11 CARBON 22K 5% 1/4WR763 1-249-435-11 CARBON 33K 5% 1/4WR765 1-249-413-11 CARBON 470 5% 1/4W FR766 1-249-415-11 CARBON 680 5% 1/4W FR767 1-249-417-11 CARBON 1K 5% 1/4W F

VOLUMEVIDEO

105


HCD-GN88D

R768 1-249-419-11 CARBON 1.5K 5% 1/4W FR769 1-249-419-11 CARBON 1.5K 5% 1/4W FR770 1-249-421-11 CARBON 2.2K 5% 1/4W FR771 1-247-843-11 CARBON 3.3K 5% 1/4WR772 1-249-425-11 CARBON 4.7K 5% 1/4W F

R773 1-249-427-11 CARBON 6.8K 5% 1/4W FR774 1-249-429-11 CARBON 10K 5% 1/4WR775 1-249-431-11 CARBON 15K 5% 1/4WR776 1-249-433-11 CARBON 22K 5% 1/4WR777 1-249-435-11 CARBON 33K 5% 1/4W

R1001 1-249-413-11 CARBON 470 5% 1/4W FR1002 1-249-413-11 CARBON 470 5% 1/4W FR1003 1-249-413-11 CARBON 470 5% 1/4W FR1004 1-249-413-11 CARBON 470 5% 1/4W FR1005 1-249-413-11 CARBON 470 5% 1/4W F

R1006 1-249-413-11 CARBON 470 5% 1/4W FR1007 1-249-413-11 CARBON 470 5% 1/4W FR1008 1-249-413-11 CARBON 470 5% 1/4W FR1009 1-249-413-11 CARBON 470 5% 1/4W FR1010 1-249-413-11 CARBON 470 5% 1/4W F

R1011 1-249-413-11 CARBON 470 5% 1/4W FR1012 1-249-407-11 CARBON 150 5% 1/4W FR1013 1-249-429-11 CARBON 10K 5% 1/4W

< SWITCH >

S748 1-476-504-11 ENCODER, ROTARY (VOLUME)S750 1-771-410-21 SWITCH, TACTILE (DISPLAY)S759 1-771-410-21 SWITCH, TACTILE (SOUND FIELD)S760 1-771-410-21 SWITCH, TACTILE (P.FILE)S761 1-771-410-21 SWITCH, TACTILE (ILLUMINATION)

S762 1-771-410-21 SWITCH, TACTILE (GAME EQ)S763 1-771-410-21 SWITCH, TACTILE (GROOVE)S765 1-771-410-21 SWITCH, TACTILE (DVD TOP MENU/DIRECTION)S766 1-771-410-21 SWITCH, TACTILE (FM MODE/REPEAT)S767 1-771-410-21 SWITCH, TACTILE

(TUNER MEMORY/PLAY MODE)

S768 1-771-410-21 SWITCH, TACTILE (AMP MENU)S769 1-771-410-21 SWITCH, TACTILE (MUSIC EQ)S770 1-771-410-21 SWITCH, TACTILE (MOVIE EQ)S771 1-771-410-21 SWITCH, TACTILE (EFFECT ON/OFF)S772 1-771-410-21 SWITCH, TACTILE (DVD MENU)

S773 1-786-528-11 SWITCH, ROTARY (<,,,M,m,PUSH ENTER)******************************************************

MISCELLANEOUS*************

0 1-569-007-11 ADAPTOR, CONVERSION (E3,E15)0 1-569-008-21 ADAPTOR, CONVERSION (E51,EA,PH,SP,MY)0 1-770-019-51 ADAPTOR, CONVERSION PLUG (TH)

6 1-693-603-31 TUNER (FM/AM)11 1-775-165-11 WIRE (FLAT TYPE) (17 CORE) (220mm)

70 1-773-040-11 WIRE (FLAT TYPE) (17 CORE) (120mm)73 1-773-110-11 WIRE (FLAT TYPE) (19 CORE)75 1-796-487-31 DECK, MECHANICAL (CDM43RR23)79 1-751-688-11 WIRE (FLAT TYPE) (13 CORE)

0103 1-696-847-21 CORD, POWER (AUS)

0103 1-777-071-53 CORD, POWER (E51,EA,PH,SP,MY)0103 1-824-818-11 CORD, POWER (TH)0103 1-827-226-11 CORD, POWER (E15,E3,MX)

152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)

226 1-775-265-11 WIRE (FLAT TYPE) (29 CORE)

227 1-824-106-12 CABLE, FLEXIBLE FLAT (24 CORE)0229 1-477-263-11 OPTICAL PICK-UP (TDP022W)0F974 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V)0F975 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) (T6.3AL 250V)0F976 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (8A 250V)

0F977 1-576-655-11 FUSE, GLASS TUBE (DIA. 5) (8A 250V)0F978 1-533-471-11 FUSE, GLASS TUBE (DIA. 5) (4A 250V)0F979 1-533-470-11 FUSE, GLASS TUBE (DIA. 5) (3.15A 250V)

M741 A-4723-963-A MOTOR ASSY, TABLEM751 A-4737-553-A MOTOR ASSY, LOADING

M891 1-763-072-11 FAN, DCRE701 1-477-680-11 ENCODER, ROTARY

0T910 1-439-741-11 TRANSFORMER, POWER(AUS,E15,E3,E51,PH,SP,MY,TH)

0T910 1-439-842-11 POWER TRANSFORMER (EA,MX)

VOLUME


HCD-GN88D

SUPPLEMENT-1File this supplement with the service manual.

Subject: DVD OSD Test Mode

Ver 1.1 2003.08

E ModelAustralian Model

9-877-457-81

SERVICE MANUAL

2

HCD-GN88D

[GENERAL DESCRIPTION]The Test Mode allows you to make diagnosis and adjustment eas-ily using the remote commander and monitor TV. The instructions,diagnostic results, etc. are given on the on-screen display (OSD).

[STARTING TEST MODE]1. Press the +/1 button to turn the power on, and set the function

to DVD.2. While pressing the x and Z button, turn the [VOLUME]

knob clockwise to enter the test mode.3. It displays “SERVICE IN” on the liquid crystal display, and

displays the Test Mode Menu on the monitor screen as follows.(At the bottom of the menu screen, the model name and revisionnumber are displayed)

Test Mode Menu

0. Syscon Diagnosis1. Drive Auto Adjustment2. Drive Manual Operation3. Mecha Aging4. Emergency History5. Mecha Error History6. Version Information7. Video Level Adjustment

Exit: POWER KeyModel :MHC-GN88D xxRevision :x.xx

4. To execute each function, select the desired menu and press itsnumber on the remote commander RM-SR246D.

5. To release from test mode, press the +/1 button and turn thepower off.

[OPERATING TEST MODE]0. SYSCON DIAGNOSISThe same contents as board detail check by serial interface can bechecked from the remote commander operation.On the Test Mode Menu screen, press [10/0] key on the remotecommander, and the following Check Menu will be displayed.

### Syscon Diagnosis ###

Check Menu0. Quit1. All2. Version3. EEPROM4. GPIO5. SD Bus6. Video

0-0. QuitQuit the Syscon Diagnosis and return to the Test Mode Menu.

0-1. All (All items continuous check)This menu checks all diagnostic items continuously. Normally, allitems are checked successively one after another automaticallyunless an error is found, but at a certain item that requires judg-ment through a visual check to the result, the following screen isdisplayed for the key entry.

DVD OSD Test Mode • Example display

### Syscon Diagnosis ###

Diag All CheckNo.2 Version

2-3. ROM Check SumCheck Sum = xxxx

Press NEXT Key to ContinuePress PREV Key to Repeat

For the ROM Check, the check sum calculated by the Syscon isoutput, and therefore you must compare it with the specified valuefor confirmation.Following the message, press the [NEXT ] button to go to thenext item, or press the [ PREV] button to repeat the sameoperation again.To quit the diagnosis and return to Check Menu screen, press the[RETURN] key on the remote commander to display Check Menu.

• Error occurredIf an error occurred, the diagnosis is suspended and error is dis-played.Press the [RETURN] key on the remote commander to quit thediagnosis, or press the [ PREV] button to repeat the samecheck where an error occurred, or press the [NEXT ] button tocontinue the check from the item next to faulty item.

General Description of Checking MethodSelecting 2 and subsequent items calls the submenu screen of eachitem. And selecting 2 and subsequent items executes respectivemenus and outputs the results.For the contents of each submenu, see “Check Items List” as be-low.

Check Items List:0-2. Version

0-2-1. All0-2-2. Revision0-2-3. ROM Check Sum0-2-4. Model Type0-2-5. Region

0-3. EEPROM Check0-3-1. Sampling Check0-3-2. Detail Check

0-4. GP I/O Check0-5. SD Bus Check0-6. Video Check

0-2. Version0-2-2. Revision

The revision number of ROM (IC206) that the program forthe DVD system processor (IC207) is stored.

0-2-3. ROM Check SumCheck sum is calculated.(4 digits hexadecimal number)

0-2-4. Model TypeModel name is displayed. (MHC-GN88D)

>

.

>

.

3

HCD-GN88D

0-2-5. RegionModel destination code is displayed. (2 digits number)

0-3. EEPROM Check0-3-1. Sampling Check

EEPROM check at every 64 words.It compares read data with write data of each address. Whenthere are discrepancies between two data, it displays error.

0-3-2. Detail CheckEEPROM check at every 1 word.It compares read data with write data of each address. Whenthere are discrepancies between two data, it displays error.

0-4. GP I/O CheckPull up/down setting check of the DVD system processor (IC207)pin 150, 151 and 154 (for clock setting port).

0-5. SD Bus CheckSD bus data check between DVD decoder (IC701) and D-RAM(IC706).

0-6. Video CheckOutput the color bars for video level adjustment.

1. DRIVE AUTO ADJUSTMENTOn the Test Mode Menu screen, press the [1] key on the remotecommander, and the Adjustment Menu will be displayed.

•Use DVD reference disc unless othermise indicated.[DVD reference disc]• LUV-P01 (4-999-032-01) (CD)•TDV-540C (J-2501-235-A) (DVD-DL)• TDV-520CSO (J-2501-236-A) (DVD-SL)

## Drive Auto Adjustment ##Adjustment Menu

0. ALL 1. DVD-SL 2. CD 3. DVD-DL

Exit: RETURN

Normally, [10/0] is selected to adjust DVD (single layer), CD andDVD (dual layer) in this order. But, individual items can be ad-justed for the case where adjustment is suspended due to an error.In this mode, the adjustment can be made easily through the op-eration following the message displayed on the screen.The disc used for adjustment must be the one specified for adjust-ment.

1-0. ALLPress the [10/0] key on the remote commander, and the servo setdata in EEPROM will be initialized. Then, 1. DVD-SL disc, 2.CD disc and 3. DVD-DL disc are adjusted in this order.Each time one disc was adjusted, it is ejected. Replace it with thespecified disc following the message. You can finish the adjust-ment by pressing the [RETURN] button on the remote commander.

Note: During adjustment of each disc, the measurement for disc type judg-ment is made. As automatic adjustment does not judge the disctype unlike conventional models, take care not to insert wrong typediscs. Also, do not give a shock during adjustment.

1-1. DVD-SL (single layer)Press the [1] key on the remote commander and insert a DVDsingle layer disc following the message. Then the adjustment willbe made through the steps below, then adjusted values will bewritten to the EEPROM.

DVD Single Layer Disc Adjustment Steps:1. Sled reset2. Disc check memory SL3. Wait 300 msec4. Set disc type SL5. LD on6. Spindle start7. Wait 1 sec8. Focus servo on 09. Auto track offset adjust10. CLVA on11. Wait 500 msec12. Tracking on13. Wait 1 sec14. Sled on15. Check CLV on16. Auto focus offset adjust17. Auto focus gain adjust18. Auto focus offset adjust19. EQ boost adjust20. Auto track gain adjust21. All servo stop22. EEP copy loop filter offset

1-2. CDPress the [2] key on the remote commander and insert a CD discfollowing the message. Then the adjustment will be made throughthe steps below, then adjusted values will be written to theEEPROM.

CD Adjustment Steps1. Sled tilt rest2. Disc check memory CD3. Wait 500 msec4. Set disc type CD5. LD on6. Spindle start7. Wait 500 msec8. Focus servo on 09. Auto track offset adjust10. CLVA on11. Wait 500 msec12. Tracking on13. (TC display start)14. Wait 1 sec15. Sled ON16. Check CLV on17. Auto focus offset adjust18. Auto focus gain adjust19. Auto focus offset adjust20. EQ boost adjust21. Auto track gain adjust22. All servo stop

4

HCD-GN88D

1-3. DVD-DL (dual layer)Press the [3] key on the remote commander and insert a DVDdual layer disc following the message. Then the adjustment willbe made through the steps below, then adjusted values will bewritten to the EEPROM.

DVD Dual Layer Disc Adjustment Steps:1. Sled tilt reset2. Disc check memory DL3. Wait 500 msec4. Set disc type DL5. LD on6. Spindle start7. Wait 1 sec

Layer 1 Adjust8. Focus servo on 09. Auto track offset adjust10. CLVA on11. Wait 500 msec12. Tracking on13. Wait 500 msec14. Sled on15. Check CLV lock16. Auto loop filter offset adjust, Auto focus adjust17. Auto focus gain adjust18. Auto focus offset adjust19. EQ boost adjust20. Auto loop filter offset adjust21. Auto Track Gain Adjust

Layer 0 Adjust22. Focus jump (L1 t L0)23. Auto track offset adjust L024. CLVA on25. Wait 500 msec26. Tracking on27. Wait 500 msec28. Sled on29. Check CLV lock30. Auto Focus Adjust31. Auto focus gain adjust32. Auto focus offset adjust33. EQ boost adjust34. Auto track gain adjust35. All servo stop

2. DRIVE MANUAL OPERATIONNote: This mode is used for design, and not used in service fundamen-

tally.

On the Test Mode Menu screen, press the [2] key on the remotecommander, and the Operation Menu will be displayed. For themanual operation, each servo on/off control and adjustment canbe executed manually.

## Drive Manual Operation ##Operation Menu

1. Disc Type 2. Servo Control 3. Track/Layer Jump 4. Non EEPROM Write Adjust 5. EEPROM Write Adjust 6. Memory Check 7. Disc Check Memory 8. Error Rate Display 9. SACD Water Mark

Exit: RETURN

>.

In using the manual operation menu, take care of the followingpoints. These commands do not provide protection, thus requiringcorrect operation. The sector address or time code field is dis-played when a disc is loaded.

Note:1. Set correctly the disc type to be used on the Disc Type screen.2. In case of an alarm, immediately press the x button to stop the

servo operation, and press the +/1 button to turn the poweroff.

Basic operation:(controllable from front panel or remote commander) +/1 : Power OFF (release the Test Mode) x : Servo stop Z : Stop and eject/Loading[RETURN] : Return to Operation Menu or Test

Mode Menu[ PREV], [NEXT ] : Transition between sub modes of

menu[1] to [9], [10/0] : Selection of menu itemsCursor o / O : Increase/Decrease in manually ad-

justed value

2-1. Disc Type

Disc Type

Disc Type Select

1. Disc Type Auto Check 2. Set Disc Type DVD 3. Set Disc Type CD 4. Set Disc Type Hybrid

Exit: RETURN

2-1-1. Disc Type Auto Check1) Press the [1] key on the remote commander to display the Disc

Type Auto Check screen.2) Insert a disc and press the [ENTER] key on the remote

commander.3) It judges the type of inserted disc automatically and displays

the disc type and so on as below.

Disc Type Auto Check

Disc Type xx Layer xx Mirr Time xx Mirr Count xx FZC Count xx PI Reference xx PI Peak xx

ENTER.Execute

Exit: RETURN

Disc Type : CD, DVD or Hybrid (SACD)Layer : SINGLE, DUAL or HYBRIDMirr Time : Mirror time of between disc surface and record sur-

face when disc type judgment. (hexadecimal num-ber)

5

HCD-GN88D

Mirr Count : The number of times which mirror counts betweendisc surface and record surface when disc type judg-ing.

FZC Count : The number of times which focus zero cross pointsof each layer when lens down.

PI Reference: The average of PI reference voltage. (hexadecimalnumber)

PI Peak : PI peak level voltage. It performs only when disctype judgment is successful. (hexadecimal number)

2-1-2. Disc Type DVDIt sets up so that it may judge as a disc type of specification of thedisc with which the set was inserted.

[1]: DVD single layer disc (12 cm)[2]: DVD dual layer disc (0 layer, 12 cm)[3]: DVD dual layer disc (1 layer, 12 cm)[4]: DVD-RW disc (12 cm)[5]: DVD single layer disc (8 cm)[6]: DVD dual layer disc (0 layer, 8 cm)[7]: DVD dual layer disc (1 layer, 8 cm)[8]: DVD-RW disc (8 cm)

2-1-3. Disc Type CDIt sets up so that it may judge as a disc type of specification of thedisc with which the set was inserted.

[1]: CD disc (normal speed, 12 cm)[2]: CD disc (double speed, 12 cm)[3]: CD disc (normal speed, 8 cm)[4]: CD disc (double speed, 8 cm)[5]: CD-RW disc (normal speed, 12 cm)[6]: CD-RW disc (double speed, 12 cm)[7]: CD-RW disc (normal speed, 8 cm)[8]: CD-RW disc (double speed, 8 cm)

2-1-4. Disc Type HybridIt sets up so that it may judge as a disc type of specification of thedisc with which the set was inserted.

[1]: SACD Hybrid disc (SACD layer, 12 cm)[2]: SACD Hybrid disc (CD layer, normal speed, 12 cm)[3]: SACD Hybrid disc (CD layer, double speed, 12 cm)[4]: SACD Hybrid disc (SACD layer, 8 cm)[5]: SACD Hybrid disc (CD layer, normal speed, 8 cm)[6]: SACD Hybrid disc (CD layer, double speed, 8 cm)

2-2. Servo ControlNote: Be sure to perform the disc type setup before performing this item.

Servo Control 1.LD off R.Sled FWD 2.Focus off L.Sled REV 3.SPDL off U.Sled Reset 4.CLVA off D.Sled Limit 5.Trk. off 6.Sled off 7.Fcs.Srch off

0.All Servo Off

Exit: RETURN

On this screen, the servo on/off control necessary for replay isexecuted. Normally, turn on each servo from 1 sequentially andwhen CLVA is turned on, the usual trace mode becomes active. Inthe trace mode, DVD sector address or CD time code is displayed.This is not displayed where the spindle is not locked.The spindle could run overriding the control if the spindle systemis faulty or RF is not present. In such a case, do not operate CLVA.

[1] LD : Turn on/off the laser.[2] Focus : Search the focus and turn on the focus.[3] SPDL : Turn on/off the spindle.[4] CLVA : Turn on/off normal servo of spindle servo.[5] Trk. : Turn on/off the tracking servo.[6] Sled : Turn on/off the sled servo.[7] FCS. Srch : Turn on/off the focus search.[10/0] : All servo off.[R] Sled FWD (right cursor) : Move the sled forward.[L] Sled REV (left cursor) : Move the sled reverse.[U] Sled FWD (up cursor) : Reset the sled.[D] Sled REV (down cursor) : Limit in the sled.

2-3. Track/Layer Jump

Track/Layer Jump 1. 1Tj FWD 2. 1Tj REV 3.500Tj Fine FWD 4.500Tj Fine REV 5.10kTj Dirc FWD 6.10kTj Dirc REV 7.20kTj Dirc FWD 8.20kTj Dirc REV

0. All Servo Off

Exit: RETURN

On this screen, track jump, etc. can be performed. Only for theDVD dual layer disc, the focus jump and layer jump are displayedin the right field

[1] 1Tj FWD : 1 track jump forward.[2] 1Tj REV : 1 track jump reverse.[3] 500Tj FWD: 500 track jump (fine search)forward.[4] 500Tj REV : 500 track jump (fine search) reverse.[5] 10kTj FWD: 10k track jump (direct search) forward.[6] 10kTj REV : 10k track jump (direct search) reverse.[7] 20kTj FWD: 20k track jump (direct search) forward.[8] 20kTj REV : 20k track jump (direct search) reverse.[10/0] : All servo off.

2-4. Non EEPROM Write Adjust

Non EEPROM Write Adjust

1. Focus Offset 2. Focus Gain 3. Trk. Offset Coarse 4. Trk. Offset Fine 5. Trk. Gain 6. EQ Boost

0.All Servo Off

Exit: RETURN

On this screen, each item can be adjusted manually. Select thedesired number [1] to [10/0] from the remote commander, andcurrent setting for the selected item will be displayed, then in-crease or decrease numeric value with the O key or o key. IfCLV has been applied, the jitter is displayed for reference for theadjustment.

6

HCD-GN88D

[1] Focus Offset : Adjusts focus offset.[2] Focus Gain : Adjusts focus gain.[3] TRK. Offset coares :

Adjusts tracking offset of the RF amp(IC001) side.

[4] TRK. Offset fine :Adjusts tracking offset of the DSP (IC401)side.

[5] TRK. Gain : Adjusts track gain.[6] EQ Boost : Adjusts amount of boost of equalizer.[10/0] : All servo off.

2-5. EEPROM Write Adjust

EEPROM Write Adjust

1. Focus Offset 2. Focus Gain 3. Trk. Offset Coarse 4. —————— 5. Trk. Gain 6. EQ Boost

0.All Servo Off

Exit: RETURN

On this screen, each item can be adjusted automatically. Select thedesired number [1] to [10/0] from the remote commander, andselected item is adjusted automatically.

[1] Focus Offset : Adjusts focus offset.[2] Focus Gain : Adjusts focus gain.[3] TRK. Offset coarse :

Adjusts tracking offset of the RF amp(IC001) side.

[5] TRK. Gain : Adjusts track gain.[6] EQ Boost : Adjusts amount of boost of equalizer.[10/0] : All servo off.

2-6. Memory CheckDisplay images are shown as follows, and all two screens are ableto switch by the O key (UP) or o key (DW).

EEPROM Data 1/2 CD SL L0 L1Focus Gain xx xx xx xxTrk. Gain xx xx xx xxFocus Offset xx xx xx xxTrk. Offset xx xx xx xxEQ. Boost xx xx xx xxPI Level xx xx -- --Fcs. Balance -- xx -- --Jitter xx xx xx xxMirror Time xx xx xx --FE Level -- xx -- --Traverse Lv1. -- xx -- --Next:DW Default:CLR Exit:RET

EEPROM Data 2/2 CDRW DVDRWFocus Gain xx xxTrk. Gain xx xxFocus Offset xx xxTrk. Offset xx xxEQ. Boost xx xx

Prev:UP Default:CLR Exit:RET

On this screen, current servo adjusted data stored in the EEPROMare displayed. The adjusted data are initialized by pressing the[CLEAR] key, but be careful that they are not recoverable afterinitialization.Before clearing the adjusted data, make a note of the set data. Thisscreen will also appear if [0]-All is selected in the Drive AutoAdjustment. In this case, default setting cannot be made.

2-7. Disc Check Memory

Disc Check Memory

1. SL Disc check 2. CD Disc check 3. DL Disc check

Exit: RETURN

On this screen, measure the mirror time of chucked disc, and writeto the EEPROM.

2-8. Error Rate Display

Error Rate DisplayUC CR Address

PI1 Err Now xx xxxx xxxxxxxxMax xx xxxx xxxxxxxxAvg xx xxxx

PI2 Err Now xx xxxx xxxxxxxxMax xx xxxx xxxxxxxxAvg xx xxxx

PO Err Now xx xxxx xxxxxxxxMax xx xxxx xxxxxxxxAvg xx xxxx

Exit: RETURN

On this screen, measure and display the error rate.

UC : Incorrect valueCR : Correct valueAdd : Address

7

HCD-GN88D

2-9. SACD Water Mark Check (Not used)

SACD Water Mark Check

PSP AMP PSN

Start: ENTER Stop: RETURN

On this screen, measure the PSP AMP value and PSN value ofSACD water mark.

3. MECHA AGINGOn the Test Mode Menu screen, selecting [3] executes the agingof the mechanism deck.

### Aging Test MENU ###

** Pls use over 40min. CD **Operation Menu

1. Open/Close Test

Exit: RETURN

1) On the Aging Test MENU screen, press the [1] key on theremote commander to display the Open/Close Test screen.

2) Insert discs and press the [ENTER] key on the remotecommander.

3) Is starts the aging.During aging, the disc number, operating status and repeat cycleare displayed. Aging can be aborted at any time by pressingthe [RETURN] key. After the operation is stopped, press the[RETURN] key to return to the Aging Test MENU.

4. EMERGENCY HISTORYOn the Test Mode Menu screen, selecting [4] displays the infor-mation such as servo emergency history.The history information from last 1 up to 10 can be scrolled withthe O key or o key. Also, specific information can be displayedby directly entering that number with ten keys.

### EMG. History ###

Laser Hours CD xxxxhxxmDVD xxxxhxxm

a. bb xx xx xx xx xx xx xxxx xx xx xx xx xx xx xx

a. bb xx xx xx xx xx xx xxxx xx xx xx xx xx xx xx

Select:1-9 Scroll:UP/DOWN (1.Latest EMG.) Exit: RETURN

xxxxhxxm : The laser on total hours. Data below minutes areomitted.

a. : Error number.bb : Error code.xx : Not used.

• Clearing History InformationClearing laser hours:

Press the [DVD DISPLAY] and [CLEAR] keys in this order.Then both CD and DVD data are cleared.

Clearing emergency history:Press the [DVD TOP MENU] and [CLEAR] keys in this order.

Initializing set up data:Press [DVD MENU] and [CLEAR] keys in this order.The data have been initialized when “EEPROM Initialize Fin-ished” message is displayed.

• Code list of Emergency History10: Communication to RF AMP (IC001) failed.11: Each servo for focus, tracking, and spindle is unlocked.12: Check sum error of EEPROM (IC204).14: Communication to servo DSP (IC509) failed, or servo DSP

(IC509) is faulty.15: Communication to DVD decoder (IC701) failed, or DVD

decoder (IC701) is faulty.16: Communication to DSD decoder (IC801) failed, or DSD

decoder (IC801) is faulty. (Not used)20: Initialization of sled servo failed. It is not placed in the ini-

tial position.23: Sled servo operation error.24: Made a request to move the sled servo to wrong position.30: Tracking balance adjustment error.31: Tracking gain adjustment error.33: Focus bias adjustment error.34: Focus gain adjustment error.35: Equalizer adjustment error.40: Focus servo does not operate.41: With a DVD dual layer disc, focus jump failed.50: CLV (spindle) servo does not operate.51: Spindle does not stop.60: Made a request to seek nonexistent address.61: Seek error of retry more than regulated times.70: Control data could not be read.80: Disc reading failed.

5. MECHA ERROR HISTORYOn the Test Mode Menu screen, selecting [5] displays the infor-mation of mechanism deck error history.The history information from last 1 up to 8 can be scrolled withthe O key or o key.

### Mecha Error History ###

1. aa bb cc dd ee xx xx xx 2. aa bb cc dd ee xx xx xx 3. aa bb cc dd ee xx xx xx 4. aa bb cc dd ee xx xx xx 5. aa bb cc dd ee xx xx xx 6. aa bb cc dd ee xx xx xx 7. aa bb cc dd ee xx xx xx 8. aa bb cc dd ee xx xx xx

Scroll:UP/DOWN(1.Latest Err.) Exit: RETURN

8

HCD-GN88D

aa: Initialization is completed or not.FF : Complete.other number: Not complete.

bb:Operating status of mechanism deck at an error occurred.(lod sq jcp)00 : Initializing.10 to 15 : Open operating.16 to 19 : Kicking cause open failed.1A to 1F : Open operating.20 to 27 : Complete the open operation.28 : No disc and complete the open operation.29 to 2F : Complete the open operation.30 to 3F : Close requesting.40 to 4F : Open requesting.50 to 5F : Close operating.60 to 6F : Complete the chucking operation.80 to 8F : Complete the release operation.

(BU is home position)90 to 9F : BU down operating.A0 to AF : Opening/closing the shutter. Or stationary state in

open/close the shutter is enablement.B0 to BF : BU up requesting.C0 to CF : BU down requesting.D0 to DF: BU upping.E0 to EF : No disc checking in disc loading.

cc : Operating status of table at an error occurred.(tbl sq jcp)13 : The rotation stop position determination error of a table11 to 12 : The loading position determination error of a table

dd: Operating status of mechanism deck at an error occurred.(lod OP jcp)00 : Complete the operation.10 to 1F : Open operating.20 to 2F : Close operating.30 to 3F : Release operating.60 to 6F : Chucking operating.70 to 7F : Kicking operating.80 to 8F : Returning the BU to home position. (after kicking)

ee : The status of table operation. (“n” is unfixed)(tbl op jcp)1n : Rotating in the direction of a forward.2n : Rotating in the direction of a reverse.

6. VERSION INFORMATIONOn the Test Mode Menu screen, selecting [6] displays the ROMversion and region code.The parenthesized hexadecimal number in version field ischecksum value of ROM.

## Version Information ##

IF con. Ver.x. xx

SYScon. Ver.x. xx (xxxx)Model MHC-GN88DRegion 0xConfig xxxxxxxx

Front End Ver.x.xx

Exit: RETURN

IF con. : The version of system controller (IC501).SYScon. : The version of DVD system processor (IC207).Front End : The version of mechanism controller (IC901).

7. VIDEO LEVEL ADJUSTMENT

On the Test Mode Menu screen, selecting [7] displays color barsfor video level adjustment. During display of color bars, OSD dis-appears but the menu screen will be restored if pressing the [RE-TURN] key.

HCD-GN88D

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2003.06 New

1.1 2003.08 SUPPLEMENT-1 : DVD OSD test mode.

1.2 2004.03 Change of the IC206 part No. (SPM-04023)

1.3 2004.06 Addition of note on DMB03 board exchange.

Addition of RFMON level check. (SPM-04038, SPM-04049)

Documents

HCD-GN88D - Diagramas Electrónicos Para Reparararchivos.diagramas.mx/audio/HCD-GN88D-1.3.pdfMiNi Hi-Fi COMPONENT SYSTEM E Model Australian Model HCD-GN88D Ver 1.3 2004.06 9-877-457-04