HYDROGEN SULFIDE(H2S)

AWARENESS TRAINING

Hydrogen sulfide presents a potential hazard to workers at many work sites.

occurs as an unwanted by-product many different industries or occupations. ensure protection against exposure be aware of its properties, what to do in emergency situations.

HYDROGEN SULFIDE AWARENESS(H2S)

Hydrogen sulfide is also produced by the putrefication of organic matter.

It may accumulate in sewers, sewage treatment plants.

HYDROGEN SULFIDE AWARENESS(H2S)

PHYSICAL AND CHEMICAL CHARACTERISTICS

• highly toxic, poisonous gas

• deadly to humans

• has no visible color.

• It is soluble in hydrocarbons and water at a ratio of 4: 1,

• highly corrosive to certain metals due to either hydrogen embrittlement or sulfide stress cracking.

• flammable when mixed with air at a temperature of

500 degrees F,

• lower flammability limit is 4.3% while the upper

flammability limit is 46% by volume in air.

• When ignited, H2S produces Sulfur Dioxide (SO2)

which is extremely hazardous and may leave victims

disabled with pneumonia or respiratory damage.

PHYSICAL AND CHEMICAL CHARACTERISTICS

• is 20% heavier than air, and can be dispersed great distances with only a slight breeze

• unidentified locations about refineries or industrial settings could indicate detectable levels of H2S

• may include low lying areas such as: utility vaults, pits, ditches, trenches, confined spaces, inside dikes, or poorly ventilated areas.

PHYSICAL AND CHEMICAL CHARACTERISTICS

PERSONAL DETECTION

• H2S also known as Rotten-Egg Gas

• or Sour Crude

• can be easily detected due to a strong odor of rotten eggs, or

• to others, a sweet, offensive, sickening odor

Although it can be detected at a low concentration of 1 ppm, this early warning property should not be depended upon as an accurate indicator of its presence.

Hydrogen sulfide detection by your nose may not occur as a concentration of this gas between 100 and 150 ppm can deaden your sense of smell.

PERSONAL DETECTION

HEALTH EFFECTS

• rapidly-acting systemic poison

• causes respiratory paralysis and asphyxia

• can irritate the eyes and respiratory tract at low concentrations.

• a concentration greater than 700 ppm, inhalation may cause coma and/or death after a single breath.

• Each individual person may be affected differently by different concentration levels.

• Some individuals are more sensitive.

• If you should smell the presence of H2S or

hear warnings from monitor alarms, then immediately evacuate this area.

HEALTH EFFECTS

HEALTH EFFECTS

Classed as a chemical asphyxiate

Similar to carbon monoxide and cyanide gases.

Inhibits cellular respiration and uptake of oxygen, causing biochemical suffocation.

TYPICAL EXPOSURE SYMPTOMS

0 - 10 ppm - Irritation of the eyes, nose and throat

10 - 50 ppm - Headache, Dizziness, Nausea and vomiting, Coughing and breathing difficulty

50 - 200 ppm - Severe respiratory tract irritation, Eye irritation / acute conjunctivitis, Shock, Convulsions, Coma, Death in severe cases

TYPICAL EXPOSURE SYMPTOMS

Prolonged exposures at lower levels can lead to:

•bronchitis,•pneumonia,•migraine headaches, •pulmonary edema, and •loss of motor coordination.

MONITORING

Exposure should be minimized by employing adequate engineering controls and safe working practices.

Where engineering controls cannot adequately control levels of exposure, it may be necessary to supplement them with the use of suitable personal protective equipment (PPE) such as supplied-air respirators.

MONITORING

Identification of hydrogen sulfide concentrations may require monitoring.

The exposure limit should be set to alarm at a concentration of 10 ppm.

FIRST AID

First aid needs will depend on the concentration level

Do not immediately rush to the aid of an affected coworker unless properly trained and without protecting yourself with proper PPE.

FIRST AID

Signs and symptoms of an exposure:

• respiratory paralysis by inhalation,

• burning sensation of the eyes due to contact,

• or skin irritation.

FIRST AID

Inhalation - remove victim to fresh air immediately. If not breathing, administer mouth-to-mouth artificial respiration until medical assistance arrives

If breathing is restored but slow and labored, administer 100% oxygen by canister/mask as H2S is

rapidly detoxified by the body.

Maintain normal body temperature. Transportation to medical services should follow immediately.

FIRST AID

Eye or skin contact - should be treated by a 15 minute wash/flush at a safety shower/eye-wash station.

If irritation or discomfort persists, transportation to medical services should follow immediately.

REFERENCES

Regional poison control center: 1-800-222-1222

Centers for Disease Control and Prevention Public Response Hotline (CDC) 800-CDC-INFO888-232-6348 (TTY)E-mail inquiries: cdcinfo@cdc.gov

Centers for Disease Control and PreventioN (CDC), National Institute for Occupational Safety and Health (NIOSH), Pocket Guide to Chemical Hazards