Jiuzhou DTT1609 - Service Manual. …Shenzhen Jiuzhou Electric CO.,LD PAGE DESCRIPTION SIZE: Version History V1.0: 2011-07-24 Created BLOCK DIAGRAM POWER BLOCK MSD5043-V60 TUNER RCA

service manual

DTT1609

CONTENTS

3.2 COMPONENT LAYOUT OF MAIN BOARD

1.6 AUDIO

2.1 SCHEMATIC OF POWER SUPPLY

# ADDITIONAL TROUBLESOOTHING

3 SCHEMATIC.COMPONENT LAYOUT AND BOM OF MAIN BOARD

3.1 SCHEMATIC OF MAIN BOARD

3.3 BOM OF MAIN BOARD

1.1 SHORT TEST

1 MAIN BOARD TROUBLE SHOOTING GUIDE

1.2 POWER

1.3 MAIN CLOCK

1.4 CVBS

1.5 RGB

2.2 COMPONENT LAYOUT OF POWER SUPPLY

2 SCHEMATIC.COMPONENT LAYOUT AND BOM OF POWER SUPPLY

Main Board Trouble Shooting Guide(DTT1609)Here are the procedures you can refer to whenever terrestrial receivers do notoperate properly. You can check problems and repair the units on the basic levelaccording to the following procedures

Main Board

1

2

3 5

4

7

68

9 10

1. SHORT TEST☞Before turning on AC power, check POSITIVE VOLTAGE and also check whether SHORTbetween GROUND's and PIN SHORT for TUNER are detected or not.

2. Checking POWER.☞ +12V(SCART),+5V(ANTENNA_POWER,IR,VIDEO BUFFER,HDMI,USB), +3.3V(TUNER, FLASH,CPU),+2.5V(DEMOD),+1.5V(DDR3,CPU),+1.3V(CPU DEMOD)

1

1

+5V

+12V

+5V For HDMI

6

+3V3 ForTuner

2

+3V3For Cpu

10+3V3

+1V5For Cpu

+1V5 ForDDR3

3

+1V3 ForCpu

2

10+2V5 ForDEMOD

5

+1V3 ForDEMOD

+5V ForUSB

8

+5V For VideoBuffer

+5V For Audio

3. Check MAIN CLOCK 24MHz and SYSTEM CLOCK (PLL) to operate normally after SYSTEMoperates.☞For the first thing, check 24MHz from Y401 flows into [OSCI(PIN B18)] of MAINCPUIf the 24MHz is unstable, Check Y401 is damaged or not.If you are firm belief of damage for the device, then replace the device.☞ And then, check that 800MHz is being supplied to DDR3 with RESETIf the clock 800MHz on Pin-J7&K7 of U401 is not generated from inside of thechip,Please check the soldering state of U401,U402 and U403

(MAIN CLOCK) 24MHz

(DDR3 CLOCK) 800MHz

DDR3 CLOCK 800Mhz

MAIN CLOCK

4. In case that MAIN CPU operates normally but there is no VIDEO display.▶ In case of no OSD display.☞ If OSD is not displayed, check first if VIDEO SIGNAL is detected from[R419(CVBS),R416(R),R417(G),R418(B)] of MAIN CPU.☞ And then, check any part with no DATA after checking VIDEO SIGNAL from VIDEOSIGNAL PORT of MAIN CPU, or SCART▶ In case of no MPEG display☞ There can be a variety of reasons for the case☞ Check first that CHANNEL of TP SIGNAL is locked properly.☞ After this signal input to the resistor connected to MAIN CPU is done normally,A/V DATA comes out from MAIN CPU and flows into MPEG CHIP(MAIN CPU). If there is noproblem to here, it is thought that MAIN CPU and channel are operating without anyfault.☞ In case of no MPEG display to this point, inspect any disorder by checkingU701(TUNER IC) and I/F of MAIN CPU.

VIDEO SIGNAL

If wave-form is not like thispicture, check that wave-formoutput is normal from eachterminal

7. In case of normal VIDEO SIGNAL flowing out but abnormal AUDIO SIGNAL.☞ Check that ADAC_L(U201 PIN2),ADAC_R(U201 PIN9) signals have normal inputting andoutputting from MAIN CPU. The signal is linked to SCART.

5. In case of no MPEG and no OSD at the same time.☞ Check that 1Vp_p(0.7Vp_p for RGB) comes out normally from VIDEO PART(CVBS) ofMAIN CPU.

BLUEGREENRED CVBS

# ADDITIONAL TROUBLESOOTHING

1) STAND-BY mode on Set.Ordinarily, STAND-BY mode results from SHORT on LNB. Check first if TR on LNB hasstopped, and then in case that STAND-BY mode resulted from wrong software, down-loada proper software.

There is a TR's as a switchingrole on the LNB bundle. 5V comesout normally from Q751. Ifvoltage is not enough or steady,check if the voltage is impressedproperly from Q751.

POWER SWITCH

2) Screen problem in colorIf you have Black-and-White screen. It mainly results from distorted 24MHzfrequency. In case of no screen display or differentcolor displayed, it also mainly results from the Y401 problem. Additionally, in casethat the screen display works but is with one color only, for example blue, green,or red, it mainly results from software fault(possiblely detected only on RGB TV).

RGB Circuit

RED GREEN BLUE

Red signal input

Blue signal input

Green signal input

3) Weak TUNER signalCheck first that the voltage is impressed to LNB. If there is nothing wrong in LNBVoltage, check if the voltage is impressed well into TUNER bundle and if data flowout properly. If every condition is satisfied, TUNER itself can be considered to bedefective. In occasion, precise inspection should be done in case that there isSHORT between pins(fault rarely made by a worker).

4) Screen ratio problemIf a strange ratio in 4:3 and 16:9 is detected, the voltage of TV scart pin number 8is below 9V. In case of around 7V, screen will be shown with 16:9 ratio. In case ofover 10V, the ratio will be 4:3. If there is still a fault on screen after adjustingscreen ratio, it means the resistance of R595 on the circuit is not 1K. If thevoltage is normal but the voltage switch does not operate properly, it means thatQ593 TR is not operating normally. In addition, Q592 can affect the problem becauseQ592 is a TV/sat transferring switch .

16:9= 6V 4:3=11.3V

16:9-High 3.3V

4:3-Low 0V

2 SCHEMATIC.COMPONENT LAYOUT AND BOM OF POWER SUPPLY

2.1 SCHEMATIC OF POWER SUPPLY

2.2 COMPONENT LAYOUT OF POWER SUPPLY

3 SCHEMATIC.COMPONENT LAYOUT AND BOM OF MAIN BOARD

3.1 SCHEMATIC OF MAIN BOARD

Xuewei

A2 OF 111

2011-12-19

V1.1

56 4

D

C

B

A

C

B

1APP.BY DATECHECK.BY

D

2

2

1

3REV. HISTORY OF MODIFICATIONS

COPYRIGHT C 2011 Shenzhen Jiuzhou Electric CO.,LD

Electric CO.,LD.'S PRIOR WRITTEN CONSENT.COPIED OR PUBLISHED WITHOUT Shenzhen Jiuzhou BE DISCLOSED TO ANY UNAUTHORIZED PERSON.NEITHER THIS DOCUMENT NOR ITS CONTENTS SHALL

TRADE SECERTSPROPRIETARY TO Shenzhen JiuzhouDOCUMENT ARECONFIDENTIAL AND CONTSTITUTEJiuzhou Electric CO.,LD. THE CONTENTS OF THISTHIS DOCUMENT IS THE PROPERTY OF Shenzhen

Electric CO.,LD.

DOC. REV.:

PROJECT CODE:

SHEET:

DRAWN BY:

CHECKED BY:

APPROVED BY:

DESIGNED BY:DATE

DATE

DATE

DATE

PCB P/N:

SCH P/N:

DESCRIPTION

DOC.NO.:

SIGN

SIGN

SIGN

SIGN

MODEL NO.:

A

Shenzhen Jiuzhou Electric CO.,LD

PAGE DESCRIPTION

SIZE:

Version History

V1.0: 2011-07-24 Created

BLOCK DIAGRAM

POWER BLOCK

MSD5043-V60

TUNER

RCA

Video buffer

Audio OP SCART

ESD HDMI1.3

ESD USB

DDR3

Serial FLASH

Front pannelPOWER

LOW IF

I2C,AGC

LMI

L/R

CVBSY/PB/PR

SPI

IR

5V/2A

T2 DEMOD

TSI2C

(MSB1230)

(128MB)

(4MB)

Nand FLASH(128MB)

EEPROM(2KB)

PHY RJ45

OPTION

MII

SPDIF

PAM2312

DC/DC

MP1482

DC/DC

VCC5V

VCC3_3V_PD

VDDC1V2

PAM2312

DC/DC DDR1V5

MOSFETVCC5V_PD

USB/HDMI

Video Buffer

MSD5043 CORE

DDR3

LM1117-3.3VLDO VCC3_3V_PM PLL,RESET

FLASH

Front pannel

MSD5043

DC/DC AUDIO OPVCC12V

PD_CTRL

2 A

50 mA

20 mA

1 A

300 mA

1.2A

250 mA

AC/DC

T2 DEMOD

LM1117-2.5VLDO VCC2_5V

T2 DEMOD50 mA

EEPROM

TUNER

PAM2312

DC/DC VCC1_8V_PD

220 mATUNER

MSD5043

A2 OF 112

2011-12-19Xuewei

V1.1

56 4

D

C

B

A

C

B


D

2

2

1





Electric CO.,LD.

DOC. REV.:

PROJECT CODE:

SHEET:

DRAWN BY:

CHECKED BY:

APPROVED BY:

DESIGNED BY:DATE

DATE

DATE

DATE

PCB P/N:

SCH P/N:

DESCRIPTION

DOC.NO.:

SIGN

SIGN

SIGN

SIGN

MODEL NO.:

A


PAGE DESCRIPTION

SIZE:

GPIO MAPPING:

TV/AV

USB

Front panel

ANT_OVERLOAD TUNER

USB_OCD

PD_CTRL

SCART

/FLASH_WP

MUTE_CTRL

TUNER

SAR1

PD_CTRL

PM_GPIO8

RGB/CVBS

MODE_0

PM_GPIO0

S_GPIO4

SCART

USB

PM_GPIO6

PM_GPIO5

SAR3

NOTE

PM_GPIO1

PM_GPIO2

SAR2

USAGE DETAIL

POWER CTRL

AUDIO_MUTE

/USB_CTRL

SFLASH

PM_GPIO3

ANT_PWR_CTRL

USAGE

FE_RST

S_GPIO1

DEMOD

S_GPIO2

16:9/4:3 SCART

Front panel

Front panelFP_CLK

FP_DATA

FP_STB

V1.1

MSD5043 GPIO & CONFIG

2011-12-19Xuewei

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.

THIS DOCUMENT IS THE PROPERTY OF ShenzhenJiuzhou Electric CO.,LD. THE CONTENTS OF THISDOCUMENT ARECONFIDENTIAL AND CONTSTITUTETRADE SECERTSPROPRIETARY TO Shenzhen Jiuzhou

NEITHER THIS DOCUMENT NOR ITS CONTENTS SHALLBE DISCLOSED TO ANY UNAUTHORIZED PERSON.COPIED OR PUBLISHED WITHOUT Shenzhen Jiuzhou Electric CO.,LD.'S PRIOR WRITTEN CONSENT.


HISTORY OF MODIFICATIONSREV.

3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

3 11OFA2

HIGH ACTIVE

System Reset

CRYSTAL SPEC:24MHZ CL=20PFRR<30R20PPM

CRYSTAL

Debug

CHIP_CONFIG[1]

CHIP_CONFIG[2]

CHIP_CONFIG[3]

CHIP_CONFIG[0]

HW STRAP

CHIP_CONFIG[3~0]0011: MIPS_no_EJ_NOR80100: MIPS_EJ1_NOR80101: MIPS_EJ2_NOR8

close MStar IC

VIDEOI2C PULL UP

EEPROM

READ=A1H

WRITE=A0H

E0/E1/E2=0/0/0

Device address

R409 1K

CE402 47uF/16V

R40810K

R411

100RR41010K

R402 1M

R403 33R

Y401 24MHz

C41033P

C41133P

1 2

3

D401BAV99

B

E

C

Q4013906

C41510uF0805

R405 0R

R413 100R

R41510K

1

2

3

4

CN401

4PIN 2.0MM

R41410K

R412 100R

TS1/I2S_OUT_IN/SPI/EJ

TS0

I2C

SM/CCIR_IN_OUT/EJ

DEMODHDMI

VIDEO

AUDIO

USB

U20TS1_CLK_/_I2S_IN_BCK_/_EJ_DINT_/_TMS_MCUU19TS1_D7_/_I2S_IN_WS_/_EJ_RST_/_TDO_MCU_/_T20TS1_D6_/_I2S_IN_D0_/_EJ_TCK_/_RX2T21TS1_D5_/_EJ_TMST19TS1_D4_/_I2S_OUT_MUTER21TS1_D3_/_I2S_OUT_BCKR20TS1_D2_/_I2S_OUT_D0_/_SPI_CLKR19TS1_D1_/_I2S_OUT_WS_/SPI_IRQP20TS1_D0_/_I2S_OUT_D1_/_SPI_CSZ_/_EJ_TDOP19TS1_VLD_/_I2S_OUT_D2_/_SPI_MOSI_/_EJ_TDIN20TS1_SYNC_/_I2S_OUT_MCK_/_SPI_MISO_/_EJ_T

N19TS0_CLKM21TS0_D7M20TS0_D6M19TS0_D5L20TS0_D4L19TS0_D3K20TS0_D2K21TS0_D1K19TS0_D0J21TS0_VLDJ20TS0_SYNC

H20I2CM0_SDAH19I2CM0_SCL

D1EJ_DINT_/_CIR_D7_/_SM_C4D2EJ_RST_/_CIR_D6_/_SM_C8E2EJ_TMS_/_CIR_D4_/_SM_CDE3EJ_TCK_/_CIR_D5_/_SM_GPIOF3EJ_DO_/_CIR_D3_/_SM_RSTF2EJ_TDI_/_CIR_D2_/_SMC_VCCF1EJ_TRSTN_/_CIR_D1_/_SM_IOG2CIR_D0_/_SM_CLK

A4HDMI_CH2_P B4HDMI_CH2_M C4HDMI_CH1_P B5HDMI_CH1_M C5HDMI_CH0_P B6HDMI_CH0_M A6HDMI_CLK_P C6HDMI_CLK_M B7

HDMI_SCL C7HDMI_SDA

C2DAC_B C1DAC_R B1DAC_G B2DAC_X

C3AVSS_DAC_BIAS

D3SPDIF_OUT

A3AU_LINE_L

A2AU_LINE_R

B3AU_VRM

B9USB_DP_P2 A9USB_DM_P2 B10

VBUS_P2

W11USB_DP_P0 Y11USB_DM_P0

B8HSYNC_/_HDMI_HDP

A7HDMI_CEC

C21RF_AGCD21IF_AGCF20IM_QE20IP_QG21IM_IG20IP_I

F21AVSS_MPLL

U401-A

MSD5043-V60

R401 0R

GPIO

UART

ETH/GPIO

SPI

NAND/CCIR_IN_OUT/CI

B19PM_GPIO0C16PM_GPIO1B16PM_GPIO2C15PM_GPIO3A15PD_CTRLB15PM_GPIO5D14PM_GPIO6D16PM_GPIO7D15PM_GPIO8E17PM_GPIO9

C20SAR0B17SAR1C17SAR2D17SAR3

A16IRIN

A19UART_RXC18UART_TX

B12TXD0C11TXD1B11TXENA12TXCLKC12RXD1A13RXD0B13COLC13MDCB14MDIO

C10VSYNC_/_ET_RSTA10SPDIF2_/_GPION21S_GPIO4R18S_GPIO3Y10S_GPIO2W10S_GPIO1G3S_GPIO0_/_CIR_CLK

B18XTAL_IN

A18XTAL_OUT

C14RESET

H3

DDR3_A0

L3

DDR3_BA2

H2

DDR3_A2

J2

DDR3_A13

J1

DDR3_A9

K1

DDR3_RESET

K2

DDR3_A7

K4

DDR3_A5

L2

DDR3_BA0

L4

DDR3_A3

M4

DDR3_WEZ

M1

DDR3_CASZ

M5

DDR3_ODT

M3

DDR3_RASZ

N4

DDR3_DQ4

P5

DDR3_DQ2

N5

DDR3_DQ6

P4

DDR3_DQ0

N2

DDR3_DQM1

P2

DDR3_DQ13

P3

DDR3_DQ11

R1

DDR3_DQ15

R3

DDR3_DQ9

T4

DDR3_DQS0

T5

DDR3_DQSB0

T2

DDR3_DQS1

T3

DDR3_DQSB1

U3

DDR3_DQ12

V2

DDR3_DQ8

V3

DDR3_DQ14

W1

DDR3_DQ10

Y1

DDR3_DQM0

U5

DDR3_DQ3

V5

DDR3_DQ5

U4

DDR3_DQ1

V4

DDR3_DQ7

Y2

DDR3_MCLK

AA2

DDR3_MCLKZ

AA6

DDR3_BA1

Y6

DDR3_A10

W4

DDR3_CKE

Y7

DDR3_A4

AA7

DDR3_A12

W9

DDR3_A1

Y8

DDR3_A6

W8

DDR3_A8

AA9

DDR3_A11

AA12CIR_OUT_D7_/_CI_A14 W12CIR_OUT_D6_/_CI_A13 AA13CIR_OUT_D5_/_CI_A12 Y13CIR_OUT_D4_/_CI_A11 W13CIR_OUT_D3_/_CI_A10 Y14CIR_OUT_D2_/_CI_A9 W14CIR_OUT_D1_/_CI_A8 Y15CIR_OUT_D0_/_CI_A7 AA15

CIR_OUT_CLK_/_CI_A6 Y21NF_RBZ_/_CI_A5 AA19NF_REZ_/_CI_A2 W19

NF_CEZ W18NF_CLE_/_CI_A3 Y19NF_ALE_/_CI_A0 Y20NF_WEZ_/_CI_A1 AA20NF_WPZ_/_CI_A4 AA18NF_D0_/_CI_D0 Y18NF_D1_/_CI_D1 W17NF_D2_/_CI_D2 Y17NF_D3_/_CI_D3 W16NF_D4_/_CI_D4 Y16NF_D5_/_CI_D5 AA16NF_D6_/_CI_D6 W15NF_D7_/_CI_D7 V17

CIR_IN_D7_/_CI_IORDN V18CIR_IN_D6_/_CI_IOWRN U18

CIR_IN_D5_/_CI_OEN W20CIR_IN_D4_/_CI_WEN V19

CIR_IN_D3_/_CI_REGN V16CIR_IN_D2_/_CI_CEN W21

CIR_IN_D1_/_CI_IRQAN V21CIR_IN_D0_/_CI_WAITN V20CIR_IN_CLK_/_CI_RST T18

CI_CDN

A20SPI_CK B21SPI_DI B20SPI_DO C19SPI_CZ

U401-B

MSD5043-V60

R433 1K

R434 1K

R430 NC

R435 NC

R432 NC

R436 1KR437 NC

R431 1K

L401 FB/60R

0603

R419 82RR4274K7

R4264K7

C4092.2nF

R418 75RR417 75RR416 75R

R420 33RR421 33RR422 33R

C412 1041A0

2A1

3A2

4GND

5SDA

6SCL

7WP

8VCC

U413

AT24C64N-SC27

VCC3_3V_PM

[3] OSC_XOUT[3]

OSC_XIN

[3]SYS-RST

VCC3_3V_PM

[3]UART-TX

[3]UART-RX

[7]SPDIF_OUT

[3,7]IDAC_OUT_X

[6] HDMI_SCL[6]

HDMI_SDA

[6] HDMI-TX1P

[6] HDMI-TX0N

[6] HDMI-TX0P

[6] HDMI-TXCLKP[6] HDMI-TXCLKN

[6] HDMI-TX2N

[6] HDMI-TX1N

[6] HDMI-TX2P

[6] HDMI_HPD

[3,8]IIC-SDA[3,8]IIC-SCL

[7]LINE_OUTL

[7]LINE_OUTR

[7]MUTE_CTRL

[10]PD_CTRL

[10]IR

[6]/USB_CTRL

[5]

B_MADR3

[5]

B_BA1

[5]

B_WEZ

[5]

B_MDATA15

[5]

B_DQM1

[5]

B_MDATA2

[5]

B_CASZ

[5]

B_MADR10

[5]

B_DQM0

[5]

B_MADR0

[5]

B_MDATA14

[5]

B_MADR7

[5]

B_MDATA7

[5]

B_MADR13

[5]

B_MCLKZ

[5]

B_MDATA3

[5]

B_MDATA9

[5]

B_DQS1M

[5]

B_MADR8

[5]

B_MADR12

[5]

B_MDATA13

[5]

B_MCLK

[5]

M1_BA2

[5]

B_MDATA1

[5]

B_MADR2

[5]

B_MDATA12

[5]

B_DQS1P

[5]

B_MADR4

[5]

B_MDATA5

[5]

B_MADR5

[5]

B_MDATA10

[5]

B_MADR1

[5]

B_MDATA4

[5]

B_MDATA11

[5]

B_DQS0M

[5]

B_MADR6

[5]

B_MDATA0

[5]

B_ODT

[5]

B_MDATA8

[5]

B_BA0

[5]

M1_CKE

[5]

B_MADR9

[5]

B_MDATA6

[5]

B_DQS0P

[5]

B_MADR11

[5]

B_RASZ

[5]

B_RST

[10]FP_STB

[10]FP_DATA

[10]FP_CLK

[3]SYS-RST

[3]OSC_XIN[3]OSC_XOUT

[3]UART-RX[3]UART-TX

[3]CI_OEZ

[3] CI_WEZ[3] CI_REGZ[3]

CI_CEZ

[5] SPI_CLK[5] SPI_DI[5] SPI_DO[5] SPI_CZ0

[3]CI_OEZ

[3]CI_WEZ

[3]CI_REGZ

[3]CI_CEZ

VCC3_3V_PD

[3,7]IDAC_OUT_X

VCC3_3V_PD

[3,8]IIC-SCL

[3,8]IIC-SDA

[6] USB1_DP[6] USB1_DM

[5]/FLASH_WP

[6]SC0CLK

[6]SC0_AUX1[6]SC0_AUX2

[6]SC0_5V/3V

[6]SC0DET

[6]SC0RESET[6]SC0CMDVCC[6]SC0DATAIN

[3,7] IDAC_OUT_R

[3,7] IDAC_OUT_B

[3,7] IDAC_OUT_G

[3,7]IDAC_OUT_R[3,7]IDAC_OUT_G[3,7]

IDAC_OUT_B

[8]TS_CLKTS_D7TS_D6TS_D5TS_D4TS_D3TS_D2TS_D1

[8]TS_D0[8]TS_VAL[8]TS_SYNC

[7]RGB/CVBS

[7]16:9/4:3[7]TV/AV

[8]ANT_PWR_CTRL[8]

ANT_OVERLOAD

[6]USB_OCD

[8]FE_RST

[10]STATE

[10]POWER_KEY

[9]ET_TXD0

[9]ET_MDIO

[9]ET_MDC

[9]ET_COL

[9]ET_RXD0

[9]ET_RXD1

[9]ET_TXCLK

[9]ET_TXEN

[9]ET_TXD1

[9]ETH_RST

[5] NF_RBZ[5]

NF_REZ[5]

NF_CEZ[5] NF_CLE[5] NF_ALE[5]

NF_WEZ[5]

NF_WPZ[5] NF_D0[5]

NF_D1[5]

NF_D2[5] NF_D3[5] NF_D4[5]

NF_D5[5]

NF_D6[5] NF_D7

[3,8] IIC-SCL[3,8] IIC-SDA

VCC3_3V_PD

Xuewei

MSD5043 POWER PIN

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

2011-12-19

4 11OFA2

V1.1

40mil

30mil

30mil

PM_3V3

POWER 1V2

POWER 1V5

POWER 3V3

R2GNDR4GNDR5GNDR6GNDR9GNDR10GNDR13GNDR17GND

T1GNDT6GNDT7GNDT8GNDT9GNDT10GNDT11GNDT12GNDT13GNDT14GNDT15GNDT16GNDT17GND

U2GNDU6GNDU7GNDU8GNDU9GNDU10GNDU11GNDU12GNDU13GNDU14GNDU15GNDU16GNDU17GND

C8TEST_PIN

F4GNDF5GNDF6GNDF7GNDF8GNDF9GNDF10GNDF11GNDF12GNDF13GNDF14GNDF15GNDF16GNDF17GNDF19GND

V1GNDV6GNDV7GNDV8GNDV9GNDV10GNDV11GNDV12GNDV13GNDV14GNDV15GND

W2

GND

W3

GND

W5

GND

W6

GND

W7

GND

Y3

GND

Y4

GND

Y5

GND

Y9

GND

Y12

GND

AA3

GND

AA4

GND

AA10

GND

D4

GND

D5

GND

D6

GND

D7

GND

D8

GND

D9

GND

D10

GND

D11

GND

D12

GND

D13

GND

E4

GND

E5

GND

E6

GND

E7

GND

E8

GND

E9

GND

E10

GND

E11

GND

E12

GND

E13

GND

E14

GND

E15

GND

E16

GND

E19

GND

G1

GND

G4

GND

G5

GND

G6

GND

G7

GND

G8

GND

G9

GND

G10

GND

G11

GND

G12

GND

G13

GND

G14

GND

G15

GND

G16

GND

G17

GND

G19

GND

H4

GND

H5

GND

H6

GND

H7

GND

H8

GND

H9

GND

H10

GND

H11

GND

H12

GND

H13

GND

H14

GND

H15

GND

H16

GND

H17

GND

J5

GND

J6

GND

J7

GND

J8

GND

J9

GND

J10

GND

J11

GND

J12

GND

J13

GND

J14

GND

J15

GND

J16

GND

J17

GND

J18

GND

K3

GND

K5

GND

K6

GND

K7

GND

K8

GND

K9

GND

K10

GND

K11

GND

K12

GND

K13

GND

K14

GND

K15

GND

K16

GND

K17

GND

K18

GND

P17

GND

P18

GND

P13

GND

P9

GND

P10

GND

P6

GND

N17

GND

N18

GND

N13

GND

N9

GND

N6

GND

N3

GND

N1

GND

M17

GND

M18

GND

M13

GND

M9

GND

M6

GND

M2

GND

L17

GND

L18

GND

L15

GND

L8

GND

L9

GND

L10

GND

L11

GND

L12

GND

L13

GND

L5

GND

L6

GND

J19

GND

J3

GND

J4

GND

H18

GND

D18

GND

D19

GND

D20

GND

M11VDDC_1V2 M12VDDC_1V2 N11VDDC_1V2 N12VDDC_1V2 P11VDDC_1V2 P12VDDC_1V2 R11VDDC_1V2 R12VDDC_1V2 M10

AVDD12_HDMI N10DVDD12_DDR

L7AVDD_DDR_DATA M7AVDD_DDR_DATA N7AVDD_DDR_DATA P7AVDD_DDR_DATA R7AVDD_DDR_DATA R8AVDD_DDR_MCLK M8AVDD_DDR_CMD N8AVDD_DDR_CMD P8AVDD_DDR_CMD

R14VDDP_3V3 P14VDDP_3V3 P15

VDDP_OTP_3V3 P16VDDP_OTP_3V3 R15VDDP_OTP_3V3 R16VDDP_OTP_3V3

N14AVDD3V3_MEMPLL M15

AVDD3V3_USB N15AVDD3V3_USB M14

AVDD3V3_HDMI M16AVDD3V3_DAC N16AVDD3V3_DAC L14AVDD3V3_AU L16

AVDD3V3_ADC

F18AVDD3V3_NODIE

G18AVDD3V3_DMPLL

E18DVDD_NODIE

C9

GND

U401-CMSD5043-V60

C449104

C448103

C452104

C450104

C453104

C447104

C451104

C45510uF0805

C45410uF0805

C459104

C458103

C462104

C460104

C461104

C45610uF0805

C466

104

C465

103

C469

104

C467

104

C464

104

C468

104

C46310uF0805

C470

104

L462

FB/60R0603 C471

104

L463

FB/60R0603 C473

104C47210uF0805

L464

FB/60R0603 C475

104C47410uF0805

C476

103

C4771uF

VDDC1V2

1V5D

VCC3_3V_PD

3V3A_AU3V3A_ADC

VDDC1V2

VCC3_3V_PD

VCC3_3V_PD 3V3A_AU VCC3_3V_PD 3V3A_ADC

3V3A_MPLL

VCC3_3V_PM 3V3A_MPLL

1V5D

DDR & FLASH

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

Xuewei 2011-12-19

5 11OFA2

V1.1

Serial NOR FLASH

Flash Reset

Flash Reset

Place Close to DRAM

NAND Flash (8-bit)1Gbit

Nand flash

A1NCA2NCA3NCA4NC

F1NC

B1NCB2SCLKB3GNDB4VCC

F2NC

C1NCC2/CSC3NCC4/WP_SIO2

F3NC

D1NC D2

SO_SIO1 D3SI_SIO0 D4NC_SIO3

F4NC

E1NC E2NC E3NC E4NC

U405

NC(MX25Lxx_55d)

A2NCA3NCA4NCA5NC

B1NCB2SCKB3GNDB4VCCB5NC

C1NCC2/CSC3RDY//BSYC4/WPC5NC

D1NC D2SO D3SI D4

/RESET D5NC

E1NC E2NC E3NC E4NC E5NC

U403

M25PX64

L481

FB/60R0603

C48210uF0805

C483104

C428104

C431104

C429104

C438104

C435104

C427104

C436104

C437104

C430104

C434104

R455100R

C445103

R4531K 1%

R4541K 1%

C423104

C424104

C42610uF0805

R456100R

R469 0R

R491 0R

R494 0R

R446 0R

R496 0R

R499 0R

R492 0R

R497 0R

R472 0R

R468 0R

R462 0R

R466 0R

R489 0R

R464 0R

R486 0R

R498 0R

R487 0R

R470 0R

R448 0R

R457 0R

R479 0R

R477 0R

R465 0R

R490 0R

R482 0R

R459 0R

R461 0R

R495 0R

R484 0R

R475 0R

R485 0R

R449 0R

R460 0R

R483 0R

R481 0R

R463 0R

R473 0R

R471 0R

R480 0R

R493 0R

R488 0R

R476 0R

R458 0R

R478 0R

R474 0R

R447 0R

R467 0R

R4511K 1%

R4521K 1%

C422104

C421104

N3A0P7A1P3A2N2A3P8A4P2A5R8A6R2A7T8A8R3A9L7A10R7A11N7A12

D7DQU0 C3DQU1 C8DQU2 C2DQU3 A7DQU4 A2DQU5 B8DQU6 A3DQU7

C7DQSU B7

/DQSU

D3DMU

E3DQL0 F7DQL1 F2DQL2 F8DQL3 H3DQL4 H8DQL5 G2DQL6 H7DQL7

F3DQSL G3

/DQSL

E7DML

M2BA0N8BA1M3BA2

L2/CSJ3/RASK3/CASL3/WE

J7CK K7

/CK K9CKE

K1ODT

T2/RESET

M8VREFCA

H1VREFDQ

L8

ZQ

A1

VDDQ

A8

VDDQ

C1

VDDQ

C9

VDDQ

D2

VDDQ

E9

VDDQ

F1

VDDQ

H2

VDDQ

H9

VDDQ

B9

VSSQ

B1

VSSQ

D1

VSSQ

D8

VSSQ

E2

VSSQ

E8

VSSQ

F9

VSSQ

G1

VSSQ

G9

VSSQ

B2

VDD

D9

VDD

G7

VDD

K2

VDD

K8

VDD

N1

VDD

N9

VDD

R1

VDD

R9

VDD

A9

VSS

E1

VSS

G8

VSS

J2

VSS

J8

VSS

M1

VSS

M9

VSS

P1

VSS

P9

VSS

T1

VSS

T9

VSS

J1NC1J9NC2L1NC3L9NC4M7NC5T3A13T7NC7

B3

VSS

U402

DDR3_2Gbit_1600

R450

240R 1%

D5CLE

H4I/O0

C3WP

C8R/B

C6CE

D4RE

C7WE

K3

VSS

J6

VDD

H8

VDD

C5

VSS

C4ALE

J4I/O1K4I/O2K5I/O3K6I/O4J7I/O5K7I/O6J8I/O7

K8

VSS

U406Nand 128M

C484104

C485102

R425 4K7

R4244K7

L482

FB/60R0603

3V3_FLASH

3V3_FLASH

[5]F_NCC1[3,5]SPI_CZ0

[5] F_NCE1[5] F_NCE2[5]

F_NCE3[5]

F_NCE4

[5] F_NCD1[3,5] SPI_DO[3,5]

SPI_DI[5]

3V3_FLASH

[5]F_NCA2[5]F_NCA3[5]

F_NCA4

[5]F_NCB1[3,5]SPI_CLK

[3,5]/FLASH_WP

[5]RDBUSY

[3,5]/FLASH_WP

[5]RDBUSY

[3,5]SPI_CZ0

[5]F_NCC1

[3,5]SPI_CLK

[5]F_NCB1

[5]F_NCA4

[5]F_NCA3

[5]F_NCA2

[5]3V3_FLASH

[3,5] SPI_DI

[3,5] SPI_DO

[5]F_NCD1

[5] F_NCE4

[5]F_NCE3

[5] F_NCE2

[5] F_NCE1

3V3_FLASHVCC3_3V_PM

1V5D

1V5D

[5] MVREF-DQ

[3]B_MADR13[3]B_MADR9

[3]B_BA0[3]M1_BA2

[3]B_RST[3]B_MADR7


[3]B_MADR10[3]B_BA1


[3]M1_CKE



[3]B_CASZ[3]B_RASZ

[3]B_MCLK[3]B_MCLKZ


[3]B_ODT[3]B_WEZ

[3]B_MDATA11[3]B_MDATA13


[3]B_DQS1P[3]B_DQS1M



[3]B_DQM0[3]B_DQM1



[3]B_DQS0M[3]B_DQS0P



[5] B-MADR13[5] B-MADR9

[5] M1-BA0[5]

M1-BA2

[5] B-RST[5] B-MADR7


[5]B-MADR10

[5] M1-BA1


[5] M1-CKE


[5] B-MADR11[5]

B-MADR1

[5] CASZM1[5] RASZM1

[5] M1_CLK+[5] M1_CLK-


[5]B-ODT

[5] WEZM1

[5] B-MDATA11[5] B-MDATA13

[5] B-MDATA15[5]

B-MDATA9

[5] B-DQS1P[5] B-DQS1M



[5] B-DQM0[5]

B-DQM1


[5] B-MDATA2

[5] B-MDATA0

[5] B-DQS0M[5] B-DQS0P

[5] B-MDATA1[5]

B-MDATA3


1V5D

[5] MVREF-CA

[5]B-MADR0[5]B-MADR1[5]B-MADR2[5]B-MADR3[5]B-MADR4[5]B-MADR5[5]B-MADR6[5]B-MADR7[5]B-MADR8[5]B-MADR9[5]B-MADR10[5]B-MADR11[5]B-MADR12

[5]M1-BA0[5]M1-BA1[5]M1-BA2

[5]RASZM1[5]CASZM1[5]WEZM1[5]B-ODT

[5]MVREF-CA

[5]B-MADR13

[5] B-DQM1[5] B-DQS1P[5] B-DQS1M

[5] B-MDATA8[5] B-MDATA9[5] B-MDATA10[5] B-MDATA11[5] B-MDATA12[5] B-MDATA13[5] B-MDATA14[5] B-MDATA15

[5] B-DQM0[5] B-DQS0P[5] B-DQS0M

[5] B-MDATA0[5] B-MDATA1[5] B-MDATA2[5] B-MDATA3[5] B-MDATA4[5] B-MDATA5[5] B-MDATA6[5] B-MDATA7

[5] MVREF-DQ

[5] M1_CLK+[5] M1_CLK-[5] M1-CKE[5] B-RST

1V5D

B-MADR14

[3]NF_D0[3]NF_D1[3]NF_D2[3]NF_D3[3]

NF_D4[3]NF_D5[3]NF_D6[3]NF_D7

[3] NF_REZ[3]

NF_CEZ[3] NF_CLE[3] NF_ALE[3] NF_WEZ[3]

NF_WPZ[3] NF_RBZ

3V3_NAND

VCC3_3V_PD 3V3_NAND

2011-12-19

V1.1

HDMI & USB & Smart card

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

Xuewei

6 11OFA2

HDMI

USB Power

H:5V_USB ON

L:5V_USB OFF

USBPOWERAP2191:

H:5V_USB OFF

L:5V_USB ON

AP2181:

Screw Holes

Smart Card

1TX2+

2TX2SD

3TX2-

4TX1+

5TX1SD

6TX1-

7TX0+

8TX0SD

9TX0-

10TXC+

11TXCSD

12TXC-

13CEC

14RSVD

15SCL

16SDA

17GND

18+5V

19HPD

23

GND

22

GND

21

GND

20

GND

J601

C6022.2uF0603

R631ESD

R630ESD

R629ESD

R6112K

R6122K

R613 100R

R614 100R

C601104

R61647K

R632ESD

R615 1K

R601 5R1R602 5R1

R603 5R1R604 5R1

R605 5R1R606 5R1

R607 5R1R608 5R1

R50510K

R50610K

C503104

1OUT

2GND

3 FLG

5 IN

4 EN

U501AP2191

R50710K/NC

C502

104

C50110UF0805

CE501470uf/10v

R50810K

R628

ESD

R627

ESD

R626

ESD

R625

ESD

R624

ESD

R623

ESD

R622

ESD

R621

ESD

R509 100R

15V2D-3D+4GND5SHIELD

J501

USB A/Female 2.0 pitchR512

ESD

R511

ESD

R501 5R1R502 5R1

1

T3

T

1

T4

T

C512

8.2P

C511

8.2P

23

4 5

6

8

7

9

X2

23

4 5

6

8

7

9

X4

23

4 5

6

87

9

X1

1

X5HOLE

1

MARK2

MARK1

MARK3

MARK

1

MARK1

MARK

1

MARK4

MARK1

MARK5

MARK

F601FUSH

SMD1210

B

EC

Q601BC857

R6191K

R617 NC(0R)

R618

220R

1VCC

2RST

3CLK

4C4

9SC_DET1

10SC_DET2

8C8

7IO

6VPP

5GND

J502

ICA-619

R56718K

C56610P

C568104

C567150P

1CLKDIV12CLKDIV23RFU14GNDP5S26VDDP7S18VUP9PRES10PRES11I/O12AUX213AUX114CGND

28AUX2UC 27AUX1UC 26I/OUC 25XTAL2 24XTAL1 23

OFF 22GND 21VDD 20

RSTIN 19CMDVCC 18

NC 17VCC 16RST 15CLK

U502

ST8024

R56410K

C563104

C562 104

C564104

R56110K

C561104

C565104

R56610K

R565 NC

R529

0R

R521

10K

R522

10K

R523

10K

R524

10K

R525

10K

R526

10K

R527

10K

R528

10K

1NC

21A

3GND

5VCC

41Y

U481

NC(741GU04)

CE561100uf/10v

L561 FB/60R

0603

R568 0R

C56933P

R569 1K

R57068K

1

X3HOLE

1

T1

T 1

T2

T 1

T5

T1

MARK6

MARK

R2 ???

[3] HDMI-TX2P[3] HDMI-TX2N

[3] HDMI-TX1N

[3] HDMI-TX0P[3] HDMI-TX0N

[3] HDMI-TXCLKP[3] HDMI-TXCLKN

[3] HDMI-TX1P

HD5V

[3]HDMI_SDA

[3]HDMI_SCL

[3]HDMI_HPD

HD5V

[3]USB1_DP

[3]USB1_DM

[3]USB_OCD

[3]/USB_CTRL

VCC5V_PD 5V_USBVCC5V_PD

5V_USB

VCC5V_PD

[6]SC_RST [6]

SC_I/O

[6]SC_CLK

[6]SC_K1

VCC3_3V_PD

[6]SC_K1[6]

SC_I/O

[3,6] SC0DATAIN

[3,6]SC0CLK

[3,6] SC0DET

[6] SC0_RESET[3,6] SC0CMDVCC

[6]SC_RST

[6] SC_CLK

[6]SC_VCC

[6]SC_VCC

VCC5V_PD

[3,6]SC0_AUX2

[3,6]SC0DATAIN

[3,6]SC0CLK

[3,6]SC0DET

[3,6] SC0RESET

[3,6] SC0CMDVCC

[3,6]SC0_5V/3V

[3,6]SC0_AUX1

[3,6] SC0_AUX1[3,6]

SC0DATAIN

VCC3_3V_PD

[3,6] SC0_AUX1

[3,6] SC0_AUX2

[6]AUX2

[6]AUX1

[6]AUX1

[6]AUX2

[3,6]SC0_5V/3V

[3,6]SC0RESET

[6]SC0_RESET

VCC3_3V_PD

VCC5V_PD

(GPIOxx)(GPIOxx)16:9/4:3

1

X

0

GPIOMODE

(9.5V~12V)

16:9

AV

TV (0V)

(5V~8V)

AV/TV

1

1

0

RGB OUT (1-3V) 1

STB StandBy

GPIO

0

MODE

CVBS OUT (0V) 0

RGB/CVBS(GPIOxx)

AUDIO & VIDEO & SCART

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

Xuewei 2011-12-19

7 11OFA2

V1.1

SPDIF OUT

TV SCART

4:3/16:9 Control

RGB/CVBS Control

Video Buffer

Near Connector

Near Connector

AUDIO OP

UVP>1.15V

L252

FB120R0603

C252

104C25310P

R25475R

R252

100R

L251 FB120R

0603

R253

100R

R25122R

C251104

B

E

C

Q2513904

1 R/OUT

2 R/IN

3 L/OUT

4 GND

5 GND

6 L/IN

7 BLUE

8 FUNCTION

9 GND

10 NC

11 GREEN

12 NC

13 GND

14 NC

15 RED/C

16 BLANK

17 GND

18 GND

19 VIDEO/O

20 VIDEO/IN

21 SHIELD

J801

C254100P

R597

150R

R59810K

B

E

C

Q5943904

R599

1K

R560150R

R593

10K

B

EC

Q5923904

R594

1.5K0603

R5951.5K0603

B

E

C

Q5933904

R596

10K

R59110K

R59210K

1IN1

2IN2

3IN3

4VCC

8OUT1

7OUT2

6OUT3

5GND

U302

NCS2553

R312 75R

R315 75R

R317 75R

C32447P

L304 600R

C32247P

L305 600R

C32347P

L306 600R

C309104

C308104

L301 FB/60R

0603

CE301100uf/16v

R301NC

1IN1

2IN2

3IN3

4VCC

8OUT1

7OUT2

6OUT3

5GND

U301

NCS2553

R304 75R

R305 75R

C30747P

L303 600R

C304 150P

C305 150P

L302 600R

C30647P

12

3

45

6

J301

C231102

C232102

R215

0R

R217

0R

R216220K

C2162.2nF

R218220K

C2182.2nF

-

+

1-IN1

2OUT1

8UVP

3EN

4PVSS

5CN

6CP

7PVDD

9OUT2

10-IN2

11

EPAD_GND

U201SGM8905

R219

100K

C217

2.2uF0805

C220390P

R221

5.1K

C2240.33uF

C2250.33uF

R220

100K

C219

2.2uF0805 C221

390P

R222

5.1K

R224 390K

C223 6.8P

R223 390K

C222 6.8P

R232 4K7

R231 1K

R226 330R

R225 330R

C2270.33uF

R22810K

C2260.33uF

R22710K

R233

5.1K

R234

1.1K

R235NC(1M)

C201104

L201 FB/60R

0603

CE201100uf/16v

[3]SPDIF_OUT

VCC5V_PD

[7]PR_OUT

[7]Y_OUT

[7]PB_OUT

[7]FB_OUT

[7]SCART_MODE

[7]LINE_OUT_L

[7]LINE_OUT_R

[7]CVBS_SCART

[7]FB_OUT

[3]RGB/CVBS

VCC5V_PDVCC5V_PD

VCC12V

[3]TV/AV

[3]16:9/4:3

[7]SCART_MODE

VCC5V_PD VCC5V_PD

5VA

[3]IDAC_OUT_R

[3]IDAC_OUT_G

[3]IDAC_OUT_B

[7]PR_OUT

[7]Y_OUT

[7]PB_OUT

VCC5V_PD 5VA

[3]IDAC_OUT_X

[7]CVBS_RCA

[7]CVBS_SCART

[7]CVBS_RCA

[7]LINE_OUT_L

[7]LINE_OUT_R

[7]SPDIF

[7]SPDIF

[3]LINE_OUTL

[3]LINE_OUTR

5VA_A

[3] MUTE_CTRL

[7]LINE_OUT_R

[7]LINE_OUT_L

5VA_A

VCC5V_PD 5VA_A

TUNER & DEMOD

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

Xuewei 2011-12-19

8 11OFA2

V1.1

Half NIM Tuner

ANTENNA_POWER

BPF Reserved

H/W StrapH/W Strap x4bitsI2C slave address: GPIO_0=0, I2C slave address=0xD2 (Default)GPIO_0=1, I2C slave address=0xF2 Boot Source:GPIO_3=0, Boot from SPI Flash (Default)GPIO_3=1, Load code with SPIF interface SPIF ID:GPIO_11,TS_ERR=00, ID=00 (Default)GPIO_11,TS_ERR=01, ID=01 GPIO_11,TS_ERR=10, ID=10 GPIO_11,TS_ERR=11, ID=11

1.2V 250mA 3.3V 50mA

CRYSTAL SPEC:24MHZ CL=20PFRR<30R20PPM

CRYSTAL

I2C

AGC

GPIO_11

2.5V for DEMOD

Close to tunerClose to Demod

L751 22uH

0805

CE751470uf/10v

C752104

C735104

R7154K7

L703

FB/120R/600mA0603

C708NC

L702

FB/120R/600mA0603

C736104

1TS_SYNC

2TS_VLD

3TS_D[0]

4TS_D[1]

5TS_D[2]

6TS_D[3]

7VDD33

8VSS

9VDD

10TS_D[4]

11TS_D[5]

12TS_D[6]

13TS_D[7]

14TS_CLK

15TS_ERR

16VSS

17

RESETZ

18

VDD33

19

VSS

20

VDD

21

VSS

22

SPIF_BUSY_ERR

23

SPIF_CLK/SPI_CK

24

SPIF_D[0]/SPI_DI

25

SPIF_D[1]/SPI_DO

26

SPIF_CSZ/SPI_CZ

27

SPIF_INT

28

VDD33

29

VSS

30

VDD

31

VDD33

32

GPIO[11]

33 AVDD_SAR34 SAR_RSSI35 VSS(AVSS_SAR)36 AVDD33_ADC37 QM38 QP39 IM40 IP41 VSS(AVSS_ADC)42 AVDD25_ADC43 AVDD_MPLL44 XTAL_OUT45 XTAL_IN46 VSS(AVSS_MPLL)47 AVDD_APLL_TS/SDR48 VSS(AVSS_APLL_TS/SDR)

49

GPIO[0]

50

VDD33

51

VDD

52

VSS

53

VDD33

54

I2CM_SCL

55

I2CM_SDA

56

RF_AGC

57

IF_AGC

58

VSS

59

VDD

60

VDD33

61

TESTPIN

62

I2CS_SCL

63

I2CS_SDA

64

GPIO[3]

U701MSB1230

C706NC

R708 NC(10K)

C704 104

L707

FB/60R/300mA0603

C709NC

R706 2K

R7144K7

R713 22R

L706

FB/60R/300mA0603

R709 NC(10K)

C737104

L708

FB/60R/300mA0603

C703104

R707 NC(10K)

C721104

C707NC

C705 104

R705 2K

C734104

L705

FB/60R/300mA0603

R712 22R

R719 1M

R718 100R

Y701 24MHz

C71133P

C71233P

C722104

C723104

C724104

C725104

C726104

C733104

CE703100uf/10v

C727104

C728104

C729104

C730104

C731104

CE702100uf/10v

L704

FB/120R/600mA0603

CE704100uf/10v

C732104

R732 100RR733 100R

R742 100RR743 100R

C71022nF

R7161K

R717 10K

R731 10K

R710 10K

C114104

C113104

L710

FB/60R/300mA0603

C11510uF0805

R721 100R

R722 100R

C73933P

C73833P

1

ADJ/GND

2OUT

3IN

4OUT

U100SA1117BH-2.5TR

R725 10K

L709NC(1.8uH)

0603

C741NC

R726 0R

R727 0R

R728 100R

C742104

R741 33R

R7511R50805

B

E

C

Q7518550

R759

10K

C751104

R752 1K B

E

C

Q7523906

R75310K

R7541K

R755100K

B

E

C Q7533904

R756

1K

R75710K

R75810K

C75310uF0805

1ANT_POWER

2B1(1.8V)

3B2(3.3V)

4SDA

5SCL

6XOUT

7IF_AGC

8IF1+

9IF1-

10

GND

11

GND

TUNER2VA4M1EX2124

R744 100R

R745 100R

C74433P

C74533P

[8]IM_Q

[8]IP_Q

ANTENNA_POWER

AVDD3VVCC3_3V_PD

FE_AVDD_APLL_TS_SDR3V3FE 1_2V_DVDDC1V2 3V3FE FE_AVDD_SAR 3V3FE 3V3FE 3V3FE

3V3FE

FE_AVDD33_ADC FE_AVDD_MPLL

3V3FE

3V3FE

3V3FE

1_2V_D

1_2V_D

3V3FE

1_2V_D

3V3FE

3V3FE

3V3FE

1_2V_D

1_2V_D

3V3FE

FE_AVDD_SAR

FE_AVDD33_ADC

[8]IM[8]IP

FE_AVDD_APLL_TS_SDR

FE_AVDD25_ADCFE_AVDD_MPLL

[8]XTAL_IN

[8]XTAL_OUT

[8]SPI_WPN

[3] FE_RST

[8] TS_ERR[3]

TS_CLK

[3] TS_D0[3] TS_VAL[3] TS_SYNC

[8]

GPIO_0

[8]

SCL_T

[8]

SDA_T

RF_AGC

[8]

IF-AGC

[8]

SCL_DEMOD

[8]

SDA_DEMOD

[8]

GPIO_3

[8]IM

[8]IP

[8]IP_Q

[8]IM_Q

[8]GPIO_0[8]GPIO_3[8]TS_ERR

[8]SDA_T

[8]SCL_T

[8] XTAL_OUT[8] XTAL_IN

VCC3_3V_PD FE_AVDD25_ADCVCC2_5V

3V3FE

[8]IF-AGC

[8]IFAGC

[8]SPI_WPN

VCC5V_PD

VCC2_5V

[3]IIC-SDA

[3]IIC-SCL

[8]SCL_DEMOD

[8]SDA_DEMOD

3V3FE

VCC5V_PD

ANTENNA_POWER

[3]ANT_PWR_CTRL

VCC3_3V_PD

[3]ANT_OVERLOAD

AVDD3V

[8] SDA_T[8]

SCL_T

[8]IFAGC

AVDD1.8V

A2 OF 119

2011-12-19Xuewei

V1.1

56 4

D

C

B

A

C

B


D

2

2

1





Electric CO.,LD.

DOC. REV.:

PROJECT CODE:

SHEET:

DRAWN BY:

CHECKED BY:

APPROVED BY:

DESIGNED BY:DATE

DATE

DATE

DATE

PCB P/N:

SCH P/N:

DESCRIPTION

DOC.NO.:

SIGN

SIGN

SIGN

SIGN

MODEL NO.:

A


PAGE DESCRIPTION

SIZE:

Note:VDDCR decoupling capacitors andtest point should be placed as closeto LAN8720 as possible.

Close to LAN8720 for EMI !

0603 Package

R658

75R

1TD+

2TDC

3TD-4NC1

5NC26RD+

7RDC

8RD-

9RX-

10RXC

11RX+

12NC3

13NC4

14TX-

15CMT

16TX+

T651HY60168O

C651

10P

R657

75R

R654

49.9R

C6591nF/2KV

R653

49.9R

R661510R

C655104

R659

75R

R662 0R0805

R655

49.9R

R656

75R

R660510R

R652

49.9R

C656103

1TX+2TX-

3RX+

4TXCT5RXCT

6RX-7NC8CH_GND

11GND12GND9

10

13LED0+

14LED0-

15LED1+

16LED1-

J651

98LEDC03-1X1 TP/RJ45

C672104

C66810uF0805

R672NC

C667104

R683 33R

R67410K

R6751.5K

R665 100R

R677 0R

C663104

R666 100R

C66233P

R684 1M

R676 300K

C66430P

R667 100R

R679 0R

C66610uF0805

R681 0R

12MDIO

13MDC

7RXD1/MODE18RXD0/MODE0

14NINT/REFCLKO

10RXER/PHYAD0

16TXEN17TXD018TXD1

11CRS_DV/MODE2

15

NRST

5XTAL1/CLKIN

4XTAL2

24RBIAS

25VSS/FLAG

9VDDIO

19

VDD1A

1VDD2A

23RXP 22RXN

20TXN

21TXP

6VDDCR

2LED2/NINTSEL

3LED1/REGOFF

U651

QFN24P

LAN8720A

R670 33R

R678 0R

R668 100R

L662

FB120R0603

R671NC

C66530P

Y651 25MHz

C6744.7uF0603

C6731uF

C661NC

L661

FB120R0603

R673NC

C671104

C670104

R669 100R

C669104

R680 0R

R682 10K

R68512.1K

C652

10P

C653

10P

C654

10P

C657

103

C658

104

PHY_TCM1

PHY_TCM0

[9]MDIORX+

[9]MDIORX-

[9]MDIOTX+

[9]MDIOTX-

[9]LED1/REGOFF

[9]LED2/NINTSEL

DCT

CH_GND

GND_EARTHGND_EARTH

GND_EARTH

EDVDD3_3V

EDVDD3_3V EAVDD3_3V

[3]ET_RXD0

[3]ET_RXD1

[3]ET_TXD0

[3]ET_TXD1

[3]ET_COL

[3]ET_TXEN

EDVDD3_3V VDDCREDVDD3_3V

[3]ET_MDIO

[3]ET_MDC

RXER/PHYAD0

[3]ET_TXCLK

EDVDD3_3V

[3] ETH_RST

[9] MDIOTX-

[9] MDIOTX+

[9] MDIORX-

[9] MDIORX+

[9]LED1/REGOFF

[9] LED2/NINTSEL

EAVDD3_3V EDVDD3_3V VDDCRVCC3_3V_PD VCC3_3V_PD EAVDD3_3V

EAVDD3_3V

V1.1

Xuewei

DC/DC & FRONT PANNEL

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

2011-12-19

10 11OFA2

5V Switch

DC/DC 1.8V (DDRII POWER)

0.6V

0.6V

DC/DC 3.3V

3.3V@600mA

1.5V For DDR3

3.3V for Standby

Front Panel Connector

[email protected]

DC/DC 1.2V (Core Power)

0.923V

Power control

GREEN

RED

12V

LED & DRIVER IC

R182

10K

C181104

R183

10K R1841K

C142

22P

R142

150K 1%

R143100K 1%

1EN

2

GND

3SW

4IN

5FB

U141PAM2312/SY8008

R141

100R

C14110uF0805

C14310uF0805

CE142100uf/16v

L141

FB120R0805

C152

22P

R152

47K 1%

R15310K 1%

1EN

2

GND

3SW

4IN

5FB

U151PAM2312/SY8008

C15110uF0805

L152

4.7uH/1AC15310uF0805

CE152

100uf/16v

L151

FB120R0805

C105104

C106

104

1

ADJ/GND

2OUT

3IN

4OUT

U102LM1117-3.3V

B

EC

Q1823904

Q181

DMP2225L

C10710uF0805

C155104

C145104

C123

47P

C124

47P

C122

47P

L121 101T0805

C121

47P

CE121 100uf/16v

R121 10K

B

E

C

Q1223904

G

S D

Q123

BS870

R1274K7

R126100R

R12410K

L122 600R

L123 600R

L124 600R

L125 600R

B

E

C

Q1213904

R122 10K

R12310K

1

2

3

4

5

6

CON121

6PIN 2.0MM

R1254K7

1

BS

2

IN3

SW

4

GND

5FB

6

COMP

7EN

8SS

U131MP1482

C13110uF0805

C132104

R13410K

C13447nF

C133 10nF

L132 10uH/2A

DIP 5*8

R132

20K 1%

R13347K 1%

C13510uF0805

CE132220uf/16v

L131 FB120R0805

R186

10K

R18510K

B

E

C

Q1843904

B

E

C

Q1833904

R1881K

R18710K

C146

104

L142

4.7uH/1A

L181 NC/FB120R

0805

R154

100R

C154

104

R135

100R

C136104

CE107100uf/16v

R1044K7

C111104

3

OUT1 VSS

2 VS

IR101

HX1838-2160

R102 33R

0805

R1034K7

R191

1K

R192

1K

R196

220R

R195

1K

13

2

D191

R193 NC(330R)

R194 330R

1 2

3 4

SW101

POWER

B

E

C

Q1913904

B

E

C

Q1923906

C11210uF0805

R171

0R

C171 105

0603

C172 105

0603

C173 105

0603

C174

104CE171

47uf/10v

L171

FB120R0603 C175

104

1 2

3

D171

BAV99

1 2

3

D172

BAV99

C176NC(10uF)0805

CE17247uf/25v

3DP

5G

11A12

DIG1

10F

9DIG2

7B

8DIG3

6DIG4

4C 2D 1E

D122

ULF-2481N2G4 12PIN

1 DI/O2 CLK3 STB4

KEY15KEY2

6VDD7SEG1/KS18SEG2/KS29SEG3/KS3

10SEG4/KS4

11SEG5/KS512SEG6/KS6

13SEG7/KS7

14SEG8/KS8

15SEG9/KS9

16SEG10/KS10

17GRID7

18GRID6

19GRID5

20GRID4

21GRID3

22GND

23GRID2

24GRID1

U101SM1668

R128100K

R129100K

D121 IN4148

SMD1206

R101NC0805

CE122

100uf/16v

1V5DVCC5V

VCC3_3V_PDVCC5V

VCC3_3V_PMVCC5V

VCC5V VCC5V_PD

[10]POWER_ON/OFF

VCC5V

[3,10] IR

[10]FP_DAT_FRONT

[10] FP_CL_FRONT

[10]FP_STB_FRONT

[3]FP_STB

[3]FP_DATA

VCC5V

[10]FP_STB_FRONT

VCC5V

[10]FP_DAT_FRONT

VCC3_3V_PM

[3]FP_CLK

[10]FP_CL_FRONT

VCC5V

VDDC1V2

[3]PD_CTRL

[10]POWER_ON/OFF

VCC5V

[10]POWER_ON/OFF

[10]POWER_ON/OFF

[10]POWER_ON/OFF

[3,10]IR

VCC3_3V_PM

VCC3_3V_PM

[3]STATE

[3]POWER_KEY

VCC3_3V_PM

VCC5V

[10]PWM

VCC5VVCC12V

[10]PWM

[10]FP_CL_FRONT

[10]FP_DAT_FRONT

[10]FP_STB_FRONTKEY0KEY1

VCC5V

[10]DP

[10] G

[10]F

[10] E[10] D[10]

C[10]

B[10] A

[10]U-1

LOCKPOWER

[10]A

[10] B[10] C[10] D[10] E[10] F[10] G[10]

DP

[10]U-1

[10]U-2

[10]U-3

[10]U-4

[10] U-2

[10] U-3[10] U-4

U-5

!!

!

!!

!

AC-DC

SIZE:


AMODEL NO.:

SIGN

SIGN

SIGN

SIGN

DOC.NO.:

DESCRIPTION

SCH P/N:

PCB P/N:

DATE

DATE

DATE

DATEDESIGNED BY:

APPROVED BY:

CHECKED BY:

DRAWN BY:

SHEET:

PROJECT CODE:

DOC. REV.:

Electric CO.,LD.





3

1

2

2

D

CHECK.BY DATEAPP.BY

1

B

C

A

B

C

D

46 5

Xuewei 2011-12-19

11 11OFA2

V1.1

AC-DC

快速放电电路

Fuse

50V

21

3

4

5

6

7

89

10

T901

KB1025-15582

1

2

4

3

U902

LTV-817-C

4D

8S

7 5 3

2BP

1EN

6

U901

TNY176DG

F902

T1AL 250V

D912

IN4007

D913

IN4007

D911

IN4007

D910

IN4007

RT901

10D-9

1

23

U903TL431

C91010uF/400V

C911

22uf/400v

C913472/1KV

R921200K 1206

D9161N4007

R919

100K 0603

C91210uf/50v

L902

4.7uH/2A

C916

470uf/16v

R924100R 0805

R9231K 0603

R925

1K 0603

R92710K 0603

R926

9.53K 0603

C914

104 0603

R922200K 1206

R920

470R 0603

1 2

34

LF902

UU9.8

D917 1N5822

R928

22R 0805

C921

102 0805

CY902 1000P

D

S

BP

EN

C915

1000uf/16v

D91818V

1

2

CN902

3PIN 3.96MM

D914

IN4007

R915

1M 1206

D915

IN4148

R917470K 0603

C917104 0603

B

E

C

Q9028550

R9181.6K 0603

C918104 0603

R916

1M 1206

R1

NC 0603

D919 NC

D9201N4148

C920

104 0805

R930

10K 0603

C1NC 0805

VCC5V

BOMNo. DTT1609Version 1.0Released 制作人名

SMD

Item Q'ty Location Remark1 5 L302 L303 L304 L305 L306 贴片磁珠GZ1005D601TF，600 ohm,200MA，1005

2 18 L171 L201 L251 L252 L301 L401 L462 L463 L464 L481 L561 L702L704 L705 L706 L707 L708 L710 BG1608B101BF 100 ohm 100M 0603

3 5 L131 L141 L151 L703 L751 CBG201209U101T/BG2012B101TF, 100 ohm 300MA4 2 L142 L152 4.7uH，±20%，1.7A，45*32mm／SM4532-4R7M5 2 C511 C512 C-CERAMIC, CHIP ;8.2pF， +/-0.25PF, 50V, NPO, TP,10056 2 C253 C566 C-CERAMIC, CHIP ; 10pF, 5%, 50V, NPO, TP, 10057 2 C142 C152 C-CERAMIC, CHIP ; 22pF, 5%, 50V, NPO, TP, 10058 9 C410 C411 C569 C711 C712 C738 C739 C744 C745 C-CERAMIC, CHIP ; 33pF, 5%, 50V, NPO, TP, 10059 5 C306 C307 C322 C323 C324 C-CERAMIC, CHIP ; 47pF, 5%, 16V, NPO, TP, 100510 3 C222 C223 C254 C-CERAMIC, CHIP ; 100pF, 5%, 50V, NPO, TP, 100511 3 C304 C305 C567 C-CERAMIC, CHIP ; 150pF, 10%, 50V, X7R, TP, 100512 2 C220 C221 C-CERAMIC, CHIP ; 390pF, 10%, 50V, X7R, TP, 100513 4 C226 C227 C231 C232 C-CERAMIC, CHIP ; 1nF, 10%, 25V, X7R, TP, 1005,14 3 C216 C218 C409 C-CERAMIC, CHIP ; 2.2nF, 10%, 50V, X7R, TP, 1005,15 6 C133 C445 C448 C458 C465 C476 C-CERAMIC, CHIP ; 10nF, 10%, 50V, X7R, TP, 100516 1 C710 C-CERAMIC, CHIP ; 22nF, 10%, 25V, X7R, TP, 100517 1 C134 C-CERAMIC, CHIP ; 47nF, 10%, 16V, X7R, TP, 1005

18 86

C105 C106 C111 C113 C114 C132 C136 C145 C146 C154 C155C174 C175 C181 C201 C251 C252 C308 C309 C412 C421 C422C423 C424 C427 C428 C429 C430 C431 C434 C435 C436 C437C438 C447 C449 C450 C451 C452 C453 C459 C460 C461 C462C464 C466 C467 C468 C469 C470 C471 C473 C475 C483 C502C503 C561 C562 C563 C564 C565 C568 C601 C703 C704 C705C721 C722 C723 C724 C725 C726 C727 C728 C729 C730 C731C732 C733 C734 C735 C736 C737 C742 C751 C752

C-CERAMIC, CHIP ; 100nF, +80-20%, 16V, Y5V, TP,1005

19 2 C224 C225 C-CERAMIC, CHIP ; 330nF, +80-20%, 10V, Y5V, TP,100520 1 C477 C-CERAMIC, CHIP ; 1uF, 10%, 6.3V, X5R, TP,100521 3 C914 C917 C918 C-CERAMIC, CHIP ; 100nF, 10%, 50V, X7R, TP,160822 3 C171 C172 C173 C-CERAMIC, CHIP ; 1uF, 10%, 16V, X7R, TP,160823 1 C602 C-CERAMIC, CHIP ; 2.2uF, +80-20%, 10V, Y5V, TP,160824 1 C921 C-CERAMIC, CHIP ; 1000pF, 10%, 50V, X7R, TP, 2012,25 1 C920 C-CERAMIC, CHIP ; 100nF, +80-20%, 50V, Y5V, TP, 2012

深圳九洲公司ShenzhenJiuzhouCo.,LtDR.

SMD

26 2 C217 C219 C-CERAMIC, CHIP ; 2.2uF, +80-20%, 16V, Y5V, TP,201227 3 C135 C143 C153 C-CERAMIC, CHIP ;10UF, 10%, 6.3V, X5R, TP,2012,

28 17 C107 C112 C115 C131 C141 C151 C415 C426 C454 C455 C456C463 C472 C474 C482 C501 C753 C-CERAMIC, CHIP ; 10uF, +80-20%, 10V, Y5V, TP,2012

29 54

R171 R215 R217 R401 R405 R446 R447 R448 R449 R457 R458R459 R460 R461 R462 R463 R464 R465 R466 R467 R468 R469R470 R471 R472 R473 R474 R475 R476 R477 R478 R479 R480R481 R482 R483 R484 R485 R486 R487 R488 R489 R490 R491R492 R493 R494 R495 R496 R497 R498 R499 R726 R727

R-CHIP ; 0 ohm, 5%, 1/16W, DA, TP, 1005

30 10 R501 R502 R601 R602 R603 R604 R605 R606 R607 R608 R-CHIP ; 5.1 ohm, 5%, 1/16W, DA, TP, 100531 3 R251 R712 R713 R-CHIP ; 22 ohm, 5%, 1/16W, DA, TP, 100532 5 R403 R420 R421 R422 R741 R-CHIP ; 33 ohm, 5%, 1/16W, DA, TP, 1005

33 24R126 R135 R141 R154 R252 R253 R411 R412 R413 R455 R456R509 R613 R614 R718 R721 R722 R728 R732 R733 R742 R743R744 R745

R-CHIP ; 100 ohm, 5%, 1/16W, DA, TP, 1005

34 2 R560 R597 R-CHIP ; 150 ohm, 5%, 1/16W, DA, TP, 100535 2 R195 R618 R-CHIP ; 220 ohm, 5%, 1/16W, DA, TP, 100536 3 R194 R225 R226 R-CHIP ; 330 ohm, 5%, 1/16W, DA, TP, 1005

37 19 R184 R188 R191 R192 R196 R231 R409 R431 R433 R434 R436R569 R599 R615 R619 R716 R752 R754 R756 R-CHIP ; 1K ohm, 5%, 1/16W, DA, TP, 1005

38 4 R611 R612 R705 R706 R-CHIP ; 2K ohm, 5%, 1/16W, DA, TP, 100539 9 R103 R104 R125 R127 R232 R426 R427 R714 R715 R-CHIP ; 4.7K ohm, 5%, 1/16W, DA, TP, 100540 2 R221 R222 R-CHIP ; 5.1K ohm, 5%, 1/16W, DA, TP, 1005

40 43

R121 R122 R123 R124 R134 R182 R183 R185 R186 R187 R227R228 R408 R410 R414 R415 R505 R506 R508 R521 R522 R523R524 R525 R526 R527 R528 R561 R564 R566 R591 R592 R593R596 R598 R710 R717 R725 R731 R753 R757 R758 R759

R-CHIP ; 10K ohm, 5%, 1/16W, DA, TP, 1005

42 2 R219 R220 R-CHIP ; 12K ohm, 5%, 1/16W, DA, TP, 100543 1 R567 R-CHIP ; 18K ohm, 5%, 1/16W, DA, TP, 100544 2 R223 R224 R-CHIP ; 36K ohm, 5%, 1/16W, DA, TP, 100545 1 R570 R-CHIP ; 68K ohm, 5%, 1/16W, DA, TP, 100546 2 R216 R218 R-CHIP , 220Kohm, 5%, 1/16W, DA, TP, 100547 2 R402 R719 R-CHIP ; 1M ohm, 5%, 1/16W, DA, TP, 100548 10 R254 R304 R305 R312 R315 R317 R416 R417 R418 R419 R-CHIP ; 75 ohm, 1%, 1/16W, DA, TP, 100549 1 R450 R-CHIP ; 240 ohm, 1%, 1/16W, DA, TP, 100550 4 R451 R452 R453 R454 R-CHIP ; 1K ohm, 1%, 1/16W, DA, TP, 100551 1 R234 R-CHIP ; 1.1K ohm, 1%, 1/16W, DA, TP, 100552 1 R233 R-CHIP ; 3K ohm, 1%, 1/16W, DA, TP, 100553 1 R571 R-CHIP; 24k ohm 1%, 1/16W, DA, TP, 100554 1 R153 R-CHIP ; 10K ohm, 1%, 1/16W, DA, TP, 100555 1 R132 R-CHIP ; 20K ohm, 1%, 1/16W, DA, TP, 100556 3 R133 R152 R616 R-CHIP ; 47K ohm, 1%, 1/16W, DA, TP, 100557 4 R128 R129 R143 R755 R-CHIP ; 100K ohm, 1%, 1/16W, DA, TP, 1005

58 1 R142 R-CHIP ; 150K ohm, 1%, 1/16W, DA, TP, 100559 2 R529 R568 R-CHIP; 0 Ohm 5%, 1/10W, DA, TP, 160860 1 R920 R-CHIP; 470 Ohm 5%, 1/10W, DA, TP, 160861 2 R923 R925 R-CHIP , 1Kohm, 5%, 1/10W, DA, TP, 160862 3 R594 R595 R918 R-CHIP; 1.6K ohm 5%, 1/10W, DA, TP, 160863 2 R927 R930 R-CHIP; 10Kohm 5%, 1/10W, DA, TP, 160864 1 R919 R-CHIP , 100Kohm, 5%, 1/10W, DA, TP, 160865 1 R917 R-CHIP; 470K ohm 5%, 1/10W, DA, TP, 160866 1 R926 R-CHIP ; 9.53Kohm, 1%, 1/10W, DA, TP, 160867 1 R751 R-CHIP; 1.5 ohm 5%, 1/8W, DA, TP, 201268 1 R102 R-CHIP , 33ohm, 5%, 1/8W, DA, TP, 201269 1 R924 R-CHIP; 100 ohm 5%, 1/8W, DA, TP, 201270 1 R928 R-CHIP ; 22 ohm,5%, 1/8W, DA, TP, 321671 2 R921 R922 R-CHIP ; 200k ohm, 5%, 1/4W, DA, TP, 321672 2 R915 R916 R-CHIP ; 1M ohm, 5%, 1/4W, DA, TP, 3216

73 14 R511 R512 R621 R622 R623 R624 R625 R626 R627 R628 R629R630 R631 R632 ESD:ES0402V014BT，SMT 0402

74 1 F601 TRF18-010V60-EF SMD保险丝 1812 60V，（临时使用）

75 3 D171 D172 D401 High-speed double diode;BAV99,SOT-23.PHILIPS76 2 D121 D915 DIODE-SWITCHING ; RLS4148/LL4148,ST/CJ4148,100V,450mA,LL-34 77 2 D914 D916 DIODE-RECTIFIER ; IN4007(DO-214AC) SMT78 1 D918 Diode-Zener：ZMM18，18V，LL-34，SMD79 1 D920 FAST RECOVERY RECTIFIER FR104 (DO-214AC) SMT80 1 Q123 N-CHANNEL ENHANCEMENT MODE FIELD EFFECT TRANSISTOR BS870-7-F SOT-23

81 11 Q121 Q122 Q182 Q183 Q184 Q191 Q251 Q592 Q593 Q594 Q753 TR-SMALL SIGNAL ; KST3904-MTF/MMBT3904LT1/LMBT3904LTIG,NPN,-60V,-40V,-200mA,350mW,SOT-23

82 3 Q401 Q601 Q752 TR-SMALL SIGNAL ; KST3906-MTF/MMBT3906LT1,PNP,-40V,-40V,-200mA,350mW,SOT-23

83 2 Q751 Q902 贴片三极管S8550(SOT23-3)PNP84 1 Q181 MOS transistor : DMP2225L P- CHANNEL SOT23-385 1 U100 800 mA LDO 稳压器 SA1117BH-2.5TR 2.5V 固定电压输出 SOT-22386 1 U101 LED Driver/Controller:CS1668/TM1668 /WS1668,SOP24

87 1 U102 800 mA LDO 稳压器 SA1117BH-3.3TR 3.3V 固定电压输出 SOT-223

88 1 U131 IC-VOLTAGE REGULATOR:MP1482 SOP-889 2 U141 U151 Step-Down DC-DC Converter：PAM2312AAB，1A ，SOT23-590 2 U301 U302 Video filter driver: NCS2553,SOIC-891 1 U402 DDR3：NT5CB64M16DP-DH (64M words × 16 bits) 1600MHZ 96-Ball WBGA

92 1 U403 FLASH：S25FL064P0XBHIS30，64Mbit，BGA24（6 x 4 pin）（6 mmx 8 mm，1.0 mm pitch）

93 1 U413 IC-EEPROM ; AT24C16AN-10SU-2.7, 3.3V, 16K, SOIC-8,

94 1 U501 1.5A SINGLE CHANNEL CURRENT-LIMITED POWER SWITCH AP2191WG-7 \ AP2191DWG-7 SOT25

95 1 U502 ST8024LCDR Smartcard interface SOP-28

96 1 U701 Digital DVB-T/T2 Demodulator：MSB1230 - LF，64-pin LQFP

97 1 U201 Capless 2Vrms to 3Vrms Line Driver with Adjustable Gain:SGM8905 MSOP-10

98 1 U401 DVB-T/C HD STB System-on-Chip:MSD5043-I00,BGA-41799 1 J601 HDMI 座: 51U019S-301N-A-B*//161A0012 ，19PIN，Pitch=0.5mm

100 1 PCB DTT1609MB 2011-12-20 167.5*(117.5*2)MM (双面板)

Item Q'ty Location Remark

1 1 L902 IND-MOLDED,4.7UH Ferrite DR2W6*8.3-4.7UH／4.7uH DR2W6*8

2 1 L132 IND-MOLDED,22uH Ferrite 3A DR2W9*12-220K-PVC／22uh DR2W9*123 3 CE171 CE172 CE402 C-AL ; 47uF, 20%, 25V-5*11*5, FORMING CUT TYPE4 8 CE107 CE122 CE201 CE301 CE561 CE702 CE703 CE704 C-AL ; 100uF, 20%, 16V-5*11*5, FORMING CUT TYPE5 3 CE132 CE142 CE152 C-Aluminum :220UF 16V 20% BARREL6.3*12*5.0 高频低阻

6 2 CE501 CE751 C-AL ; 470uF,20% ,16V, 8*12*5 FORMING CUT TYPE7 1 C910 C-Aluminum : 10UF 400V 20% BARREL10*17*5 105℃高压电容

8 1 C911 C-Aluminum : 15UF 400V 105℃ 20% BARREL 13*16*5 高压电容

9 1 C912 C-AL ; 10uF, 20%, 50V-5*11*2.010 1 C916 C-AL ; 470uF,20% ,16V, 8*12*3.5MM FORMING CUT TYPE11 1 CY902 Y1-CAP 1000PF 400V 20% BARREL 8*10*2512 1 C913 4.7nF 1KV Y5U 10%

13 1 C915 C-Aluminum :1000UF 16V 20% BARREL10*16*5 高频低阻供应商：金富康

14 4 D910 D911 D912 D913 DIODE-RECTIFIER ; 1N4007ID,1000V,1A,DO-4115 2 D917 D919 SCHOTTKY BARRIER RECTIFIERS 1N5822 3.0A TO-2716 1 U903 Regulator MOSFET:ZL431AZ-ATRE1 ,precision is 0.4% ,TO-9217 1 U902 光耦: LTV-817-CN, 200~400%, DIP-418 1 U901 Power switch IC:TNY176PN DIP-8C19 2 Y401 Y701 晶体：24.000MHZ,±20PPM，20pF，HC-49S DIP

20 1 LF902 Filter Transformer: LB1111-8496A,17*12*17mm,4Pin,Pin Length:3.5mm

21 1 T901 变压器：KB1025-17474 ，EE-19，5（二脚空缺）+5（六八十脚空缺） Pin，立式

22 1 F902 双冒绕丝保险管:3T 250V/1A, ф4×11mm23 1 RT901 R-NTC: 10 OHM,20%,负温系数,黑色

24 1 CN902 CH-3x3.96 (NO Middle PIN)25 1 CN401 2.54-4Z,TJC3-4A PITCH=2.54MM,4P,WITH LOCK 26 1 J301 AV4-8.4-33 WYRB 带屏蔽

27 1 J502 SMARTCARD：ICA-611 STF，Standoff H=17.10mm 常闭，10Pin 汉宝 28 1 J801 Single SCART Connector no shield cover SC103 21P29 1 IR101 IC-REMOTE CONTROL ; HM338-WS 3PIN 30 1 FOR IR101 SUPPER :7MM31 1 D122 4-digit 7-segment display：LIM-2483N25E 单排6mm+13mm 12pin 橙色共阴黑面白胶

32 1 FOR D122 9mm SUPPORT33 1 D191 3RG9HW M3/ LL-309IGM2E-I1-2A/AVL-313RGD-01,共阴(红绿双色)DIP

DIP

34 1 FOR D191 LED SUPPORT 12MM35 1 J501 USB-A-04,USB插座，侧弯90度36 1 SW101 SWITCH PUSH 6X6X2DH5 H:1.5mm37 TUNER2 DVB-T2/T TUNER:FH-RT232A4 9+2PINS 立式

38 1 (FOR U401) Heat SINK(25*25*20 white )

# OTHER TROUBLESOOTHING

2, If there is a heavy mosaic when your STB works, or even NO SIGNAL, please changethe crystal in the TUNER; and if that fails, change the Tuner module directly.

1, Testing the chip and the DEMOD's crystal frequency(Y401 Y701) with a frequencyspectrograph, to make sure it's within ±20PPM(±480HZ)；

3, If the fuse blew out, please change the F902 and check the D910,D911,D912,D913,tosee if they are burnout.

www.s-manuals.com

http://www.s-manuals.com

Documents

Jiuzhou DTT1609 - Service Manual. …Shenzhen Jiuzhou Electric CO.,LD PAGE DESCRIPTION SIZE: Version History V1.0: 2011-07-24 Created BLOCK DIAGRAM POWER BLOCK MSD5043-V60 TUNER RCA