Upload
tranminh
View
226
Download
0
Embed Size (px)
Citation preview
Revamping the Regional Railway Systems in Eastern and Southern AfricaMark Pearson and Bo GiersingRegional Integration Research Network Discussion Paper (RIRN/DP/12/01)
Mineral Resource Based Growth Pole Industrialisation - Phosphate Report
Regional Integration Research NetworkOpen Dialogues for Regional Innovation
C.C. Callaghan
Page i
Preface
Since its establishment in 2009, Trade Mark Southern Africa (TMSA) has supported the
Tripartite of the Common Market of Eastern and Southern Africa (COMESA), the Southern
African Development Community (SADC) and the East African Community (EAC), in
developing and implementing its regional integration agenda. This involves supporting the
design and planned implementation of the Tripartite Free Trade Area (FTA), improving the
economic competitiveness of the region and reducing costs of cross-border transactions
through a transport corridor approach addressing both trade facilitation issues and
infrastructure constraints.
Focused industrial development is essential in the COMESA-EAC-SADC Tripartite region to
fundamentally change the economy and to promote high yield sectors. Such development
brings not only an improvement in the GDP and job provision, but promotes knowledge
accumulation and technological sophistication that have far reaching benefits for the
economy.
This research was conducted under the topic “Tripartite ‘Growth Pole’ Diagnostic
Reports: Analysis of Potentials and Prospects for Minerals-Based Industrialisation.”
The research is packaged in four (4) Sub-Sector Reports on hydrocarbons, ferrous metals,
base metals and phosphates and a Consolidated ‘Growth Poles’ Report. The reports profile
and prioritise a number of potential regional ‘growth poles’ throughout eastern and southern
Africa. In the ‘first sort’ each known minerals deposit was analysed through three (3) filters
as follows:
1. By size of deposit (size of known indicated resource);
2. By status of deposit (levels of investment in developing the deposit); and,
3. By ‘expert group’ assessment (market conditions and supporting infrastructure).
The research reviewed available information on mineral deposits and the status of their
development and analysed the extent to which realisable mining and mineral development
opportunities can contribute to and enhance regional development. Data constraints limited
the research to the Eastern and Southern Africa region and defined a limited number of
plausible ‘growth poles’, which could provide a platform to accelerate industrialisation in the
region.
The results from these three filters were then combined through a ‘second sort’, which
enhanced the analysis by clustering minerals within a defined locality into potential ‘growth-
pole’ value chains. In line with ‘growth pole’ theory the basis for any prioritisation was
whether the initial ‘critical mass’ of investment had been achieved. The minimum critical level
Page ii
of investment is considered to be achieved when five key pre-conditions have been met,
namely:
1. A recognised global multi-national corporation (MNC) has made a significant investment in developing a mineral deposit or a cluster of mineral deposits;
2. Such an investment commitment reflects that the regulatory environment for trade and investment in sufficiently robust to support large-scale projects;
3. Similarly, this size of investment in developing a world-class resource confirms that the long term global market outlook for the target commodity is equally robust;
4. It also acknowledges that any supply-side infrastructure constraints can be overcome by the projects cash-flows and that infrastructure development itself represents an opportunity for the lead developer, in the transport and energy sectors for example; and,
5. Finally, the participation of a strong ‘anchor’ investor substantially strengthens the prospects for developing upstream linkages to local suppliers and new downstream industries as a result of the presence of and initial investment by the global mining company.
In addition to these pre-conditions the research also considers two additional criteria to
prioritize ‘growth-pole’ potential. The first was the extent to which the value-chain could be
developed given prevailing market conditions, and the second was whether value-chain
linkages straddle national borders to assume a regional posture.
Based on these considerations the following seven (7) regional growth poles were prioritised
in order of potential:
1. Tete, Mozambique – Southern Malawi (Hydrocarbons, Ferrous Metals and Phosphates);
2. Copperbelt, Zambia – Copperbelt, DRC (Base Metals);
3. Cabinda, Angola – Bas Congo, DRC – Soyo, Angola (Hydrocarbons and Phosphates);
4. Rovuma Basin, Mozambique – Ruvuma and Songo-Songo Basins, Tanzania (Hydrocarbons);
5. Lephalale, South Africa – Morepule, Botswana (Hydrocarbons);
6. Kabanga, Tanzania – Musongati, Burundi (Base Metals); and,
7. Central Zimbabwe – Central Mozambique (Hydrocarbons and Ferrous Metals).
Page iii
An initial scoping study is currently being conducted to develop a fuller picture of the Tete,
Mozambique – Southern Malawi ‘Growth Pole’, which has been expanded to include
Eastern, Zambia, in collaboration with the World Bank and the governments of Malawi,
Mozambique and Zambia.
TMSA, under its Regional Integration Research Network initiative, commissioned Chris
Callaghan to conduct the research. Chris Callaghan is an independent consultant whose
career includes stints as a Mining Sector Specialist at the Development Bank of Southern
Africa (DBSA) and a Senior Manager at MINTEK South Africa, the state-run Mining
Technology Research Institute. The TMSA lead was Graham Smith, TMSA Programme
Manager - Corridors. The study benefited particularly from guidance and inputs by Dr.
Judith Fessehaie, TMSA Industrial Development Expert and Mr. Bo Giersing, TMSA Ports
and Railway Specialist, Mr. Jurgens Van Zyl, an independent Mining and Development
Finance Specialist, currently under contact to Business Leadership South Africa (BLSA) and
Dr. Paulo Fernandes, a Logistics Specialist at Mott MacDonald/PDNA South Africa. These
individuals ‘peer reviewed’ the prioritisation methodology, which underpinned the selection of
the Growth-Poles. Other TMSA colleagues provided some early inputs into the terms of
reference for the study.
More Information
The reports can be downloaded on the TMSA website at
www.trademarksa.org/publications/mineral-resource-based-growth-pole-industrialisation
Reports include the Consolidated Growth Poles and Value-Chains Report and four (4) Sub-
Sector Minerals Reports on Hydrocarbons (Coal, Oil and Gas), Ferrous Metals (Iron and
Steel), Base Metals (Chrome, Manganese, Nickel, Vanadium, Copper, Zinc and Lead) and
Phosphates report.
Page iv
Table of abbreviations Companhiá de Fosfatos de Angola COFAN
Di-ammonium phosphate DAP
Direct application phosphate rock DAPR
Deoxyribonucleic acid DNA
Democratic Republic of the Congo DRC
El Nasr Phosphate Company ENMC
Life of mine LOM
Mono-ammonium phosphate MAP
Mono-ammonium phosphate with zinc MAPZN
Millions of tonnes Mt
Millions of tonnes per annum Mtpa
Nitrogen-Phosphate-potassium NPK
Phosphorous pentoxide P2O5
Per annum pa
Phosphate rock PR
Run of mine ROM
Single Superphosphate SSP
Tonnes t, ton
Tonnes per annum tpa
Triple superphosphate TSP
Table of Definitions
Single Superphosphate
A relatively simple fertiliser developed from rock phosphate dissolved in sulphuric acid to produce monocalcium phosphate and gypsum. SSP contains 7-9% P (16-20% P2O5)
Triple Superphosphate
TSP is produced by reacting finely ground phosphate rock with liquid phosphoric acid to produce monocalcium phosphate (no gypsum). TSP contains 17-23% P (44-52% P2O5).
Page v
Table of Contents
1 Introduction .......................................................................................................... 1
2 Phosphates .......................................................................................................... 2
2.1 Introduction ............................................................................................................... 2 2.2 Fundamental concepts ............................................................................................. 2
2.2.1 Sedimentary phosphate rocks ............................................................................... 3 2.2.2 Igneous (intrusive) Phosphate rocks ..................................................................... 3
2.3 Market ......................................................................................................................... 4 2.3.1 Uses ...................................................................................................................... 4 2.3.2 Production ............................................................................................................. 4 2.3.3 Demand ................................................................................................................. 6 2.3.4 Supply ................................................................................................................... 6 2.3.5 Trade ..................................................................................................................... 8 2.3.6 Price .................................................................................................................... 11 2.3.7 Value added products and substitution ............................................................... 12 2.3.8 Substitutes .......................................................................................................... 13 2.3.9 Challenges .......................................................................................................... 13
3 Angola ................................................................................................................. 14
3.1 Cabinda Phosphates ............................................................................................... 14 3.1.1 Cacata ................................................................................................................. 14 3.1.2 Chibuete .............................................................................................................. 14 3.1.3 Mongo Tando ...................................................................................................... 16 3.1.4 The Lucunga River phosphates .......................................................................... 16 3.1.5 Carbonatites ........................................................................................................ 16
4 Botswana ............................................................................................................ 18
5 Burundi ............................................................................................................... 19 5.1 Matongo ................................................................................................................... 19
6 Comores ............................................................................................................. 20
7 DRC ..................................................................................................................... 21 7.1 Sedimentary Phosphates ....................................................................................... 21
Page vi
7.1.1 Kanzi Project ....................................................................................................... 21 7.1.2 Igneous phosphates ............................................................................................ 21 7.1.3 Lueshe carbonatite .............................................................................................. 21
8 Djibouti ............................................................................................................... 23
9 Egypt ................................................................................................................... 24 9.1 Introduction ............................................................................................................. 24 9.2 Red Sea Coastal Area ............................................................................................. 24 9.3 Nile Valley deposits ................................................................................................ 25 9.4 Abu Tartur ................................................................................................................ 25 9.5 Resource .................................................................................................................. 26 9.6 Beneficiation ............................................................................................................ 26
10 Eritrea ............................................................................................................... 27
11 Ethiopia ............................................................................................................ 28 11.1 Bikilal ...................................................................................................................... 28 11.2 Other deposits ....................................................................................................... 28
12 Kenya ................................................................................................................ 29
12.1 Mrima Hill Carbonatite .......................................................................................... 29 12.2 Rangwe Area Intrusives ....................................................................................... 29 12.3 Fertiliser plant ....................................................................................................... 29
13 Lesotho ............................................................................................................. 30
14 Libya ................................................................................................................. 31
15 Madagascar ...................................................................................................... 32
16 Malawi ............................................................................................................... 33
16.1 Tundulu .................................................................................................................. 33
17 Mauritius ........................................................................................................... 34
18 Mozambique ..................................................................................................... 35 18.1 Sedimentary deposits ........................................................................................... 35 18.2 Igneous deposits ................................................................................................... 35
18.2.1 Cone Negose .................................................................................................... 35 18.2.2 Evate ................................................................................................................. 35
Page vii
18.2.3 Lucuisse ............................................................................................................ 37 18.2.4 Mont Muande .................................................................................................... 37
19 Namibia ............................................................................................................. 38 19.1 Igneous deposits ................................................................................................... 38 19.2 Sedimentary offshore deposits ........................................................................... 38
19.2.1 The Sandpiper project ....................................................................................... 38 19.2.2 Phosphate in Tailings ........................................................................................ 39
20 Rwanda ............................................................................................................. 40
21 Seychelles ........................................................................................................ 41
22 South Africa ..................................................................................................... 42 22.1 Foskor Mine (Palaborwa) ...................................................................................... 42 22.2 Glenover ................................................................................................................. 42 22.3 Schiel ...................................................................................................................... 43 22.4 Spitskop ................................................................................................................. 43 22.5 Sedimentary phosphates ..................................................................................... 43
22.5.1 Agulhas Bank deposits ...................................................................................... 43 22.5.2 Other deposits ................................................................................................... 44
23 South Sudan .................................................................................................... 45
24 Sudan ................................................................................................................ 46 24.1 Jebel Abyad and Abu Hasem .............................................................................. 46 24.2 Halaib District ........................................................................................................ 46 24.3 Nuba Mountains .................................................................................................... 46 24.4 Other Phosphates ................................................................................................. 47
25 Swaziland ......................................................................................................... 49
26 Tanzania ........................................................................................................... 50
26.1 Igneous (carbonatite) Phosphates ...................................................................... 50 26.1.1 The Sangu-Ikola carbonatite ............................................................................. 50 26.1.2 The Ngualla carbonatite .................................................................................... 50 26.1.3 Mbalizi, Songwe and Sengeri Hill ...................................................................... 50 26.1.4 Panda Hill .......................................................................................................... 50 26.1.5 Metamorphic Apatite limestones ....................................................................... 51
Page viii
26.1.6 Lacustrine Phosphates ...................................................................................... 51
27 Uganda ............................................................................................................. 53 27.1 Sukulu (Sigulu) ...................................................................................................... 53 27.2 Bukusu (Busumbu) ............................................................................................... 54
28 Zambia .............................................................................................................. 55 28.1 Nkombwa Hill carbonatite .................................................................................... 55 28.2 Kaluwe carbonatite. .............................................................................................. 55 28.3 Chilembwe phosphate deposit ............................................................................ 55 28.4 Mumbwa North phosphate deposit ..................................................................... 56
29 Zimbabwe ......................................................................................................... 57 29.1 Dorowa carbonatite ............................................................................................... 57 29.2 Shawa ..................................................................................................................... 57 29.3 Chishanya .............................................................................................................. 57 29.4 Katete ..................................................................................................................... 58
Appendix I. Deposit size categories (kt) .............................................................. 62
Appendix II. Listing of deposits ........................................................................... 63
Appendix III. Rock phosphate minerals .............................................................. 64
List of Figures
Figure 1: World Phosphate deposits ........................................................................................ 3
Figure 2: Phosphate surplus and deficit in arable soils ........................................................... 5
Figure 3: World Phosphate Mine Production 2011 .................................................................. 5
Figure 4: World fertiliser use 2010 (45 Mt nutrients) ................................................................ 7
Figure 5: World fertiliser use estimate 2020 (60 Mt Nutrients) ................................................ 7
Figure 6: World Phosphate reserves ....................................................................................... 8
Figure 7: Phosphate fertiliser production 2010 (46 Mt nutrients) ............................................. 9
Figure 8: Phosphate Rock exports 2010 ................................................................................. 9
Figure 9: Phosphate fertiliser Exports 2010 ........................................................................... 10
Figure 10: Phosphate Rock imports 2010 ............................................................................. 10
Figure 11: Phosphate fertiliser Imports 2010 ......................................................................... 11
Page ix
Figure 12: Phosphate Rock price 2011-2013 ........................................................................ 11
Figure 13: Phosphate fertiliser products ................................................................................ 12
Figure 14: Cabinda and DRC phosphate field ....................................................................... 15
Figure 15: The Tundulu Carbonatite Complex, Malawi ......................................................... 33
Figure 16: Phosphate occurrences in Mozambique .............................................................. 36
Figure 17: Phosphate prospect at Jebel Abyad ..................................................................... 47
Figure 18: Sukulu Carbonatite ............................................................................................... 53
Figure 19: Dorowa Phosphate Mine ...................................................................................... 58
List of Tables
Table 1: Tripartite Countries with a Phosphate resource ......................................................... 6
Page 1 4 Growth Poles Phosphates
1 INTRODUCTION TradeMark Southern Africa has awarded the first stage of a study to set out a pragmatic
approach for industrial development, based on mineral resources in southern and eastern
Africa to Letlapa Consulting. This report is the fourth in a series of reports for this project.
The reports are:
1. Inception report, in which the project is formulated
2. Ferrous metals report outlining ferrous metals opportunities in the tripartite area.
3. Non Ferrous metals report summarising the principle deposits of copper, lead and zinc in the tripartite area.
4. Phosphate report (this report). This report will summarise the principle deposits of phosphates in the tripartite area.
5. Energy commodities report. This report will outline the major deposits of coal oil and gas in the tripartite area.
6. Growth poles and value chains. This report will be the culmination of the first stage of the greater study on growth poles based on mineral resources and will outline high level value chains for a set of mineral clusters that may develop into growth poles.
Page 2 4 Growth Poles Phosphates
2 PHOSPHATES
2.1 Introduction Sedimentary marine phosphorites make up the majority of phosphate rock resources, with
the largest sedimentary deposits to be found in northern Africa, China, the Middle East, and
the United States. Intrusive deposits (carbonatite) are found in Brazil, Canada, Finland,
Russia, as well as southern and eastern Africa. Phosphate resources have also been
identified on the continental shelves and on seamounts in the Atlantic Ocean and Pacific
Ocean (Jasinski, 2013).
Phosphate mines vary in grade from as low as 5% to more than 40 % P2O5. Since
phosphoric acid plants generally require a feedstock of 26-34% P2O5, lower grade mines
must upgrade their product to a suitable level
2.2 Fundamental concepts Phosphorous is an essential primary nutrient in the growth of crops and is an important
constituent of DNA. Because the world has a very large population, food to support the
population can no longer be grown on available land without the support of fertiliser.
Phosphates are therefore required in increasing quantities for food security. Most farmland
soils are phosphorus deficient and in addition, phosphorous readily combines with iron and
aluminium in the soil to produce insoluble phosphates that are not available for plant uptake,
which may mean that more phosphate needs to be added to get the desired growth
stimulation.
Consumption of phosphate rock is mainly by the fertiliser sector (85% of all phosphate rock).
Although phosphate rock can be used directly as fertilizer, the release of the phosphate from
most sources is too slow and phosphate rock is usually converted to chemical fertilizer
before use in the agricultural industry. Deposits that are suitable for direct use have a high
reactivity (the phosphate is relatively soluble in acid soils with low Ca and P concentrations)
and these include “Langfos” from Langebaan in the Western Cape Province of South Africa,
phosphates from Minjingu in Tanzania, and possibly those from Cabinda and Bas Congo
(van Straaten, 2002).
Rock phosphate consists most often of minerals in the apatite group. Pure apatite is rare
since it allows substitution of various other molecules within its lattice and a number of
Page 3 4 Growth Poles Phosphates
varieties are found in deposits. A list of the major mineral species can be found in Appendix
III. Depending on the accessory minerals present and the amount of apatite or related
minerals in the phosphate rock, it may have a wide range of solubility. The most soluble
varieties can be applied directly and are referred to as direct application phosphate rock
(DAPR).
There are broadly two types of phosphate deposit, sedimentary and igneous (island deposits
– not dealt with here – are recent deposits and technically a subset of sedimentary deposits).
The deposits in the tripartite area are largely igneous in nature (see Figure 1).
Figure 1: World Phosphate deposits
Source: Van Kauwenbergh, 2011
2.2.1 Sedimentary phosphate rocks Sedimentary phosphate deposits range in age from Precambrian to Recent and occur
throughout the world. About 80% of phosphate rock used commercially is obtained from
marine sedimentary deposits containing an apatite variety called francolite which typically
contains about 30-35% P2O5. Most sedimentary deposits were probably formed in offshore
marine conditions on continental shelves. Sedimentary phosphate rocks range from
unconsolidated to weakly cemented and to highly indurated rocks (Van Kauwenbergh,
2010).
2.2.2 Igneous (intrusive) Phosphate rocks Igneous phosphate rocks commonly contain one of the apatite varieties (fluorapatite,
hydroxyapatite or chlorapatite) with some 35-42% P2O5. Igneous phosphate rock is exploited
Page 4 4 Growth Poles Phosphates
chiefly in Russia, South Africa, Brazil, Finland and Zimbabwe. Igneous phosphate ores are
often low in grade (less than 5% P205), but can often be easily upgraded to high-grade
products (Van Kauwenbergh, 2010).
2.3 Market
2.3.1 Uses Phosphate rock is used primarily to produce phosphate fertilisers (~85%) but also in animal
feed supplements (~7%), detergents, food preservatives, safety matches, fire extinguishers,
anti-corrosion agents, cosmetics, fungicides, ceramics, water treatment and in the chemical,
dental and pharmaceutical industries. Phosphorous is also used in metallurgy especially in
the steel and copper industry. For use in the fertiliser industry the phosphate rock needs to
contain at least 26% P2O5 and about 5% CaCO3. Furthermore it should have less than 4%
combined iron and aluminium oxides and have a very low chlorine content of less than
0.02%.
Overuse, especially of poor quality phosphatic fertilisers can lead to severe soil pollution.
De Ridder and others (2012) point out that cadmium concentration in EU soils is already a
concern. Furthermore Moroccan phosphates are high in cadmium and unless the cadmium
is removed from the final product the situation can be expected to become more severe.
Even though Africa has by far the greatest phosphate resources much of African arable land
is highly deficient in phosphate (see Figure 2) and enhanced crop production is to be
expected once more fertilisers are applied to African cropland.
2.3.2 Production The USGS expected world phosphate rock production to increase from 220 Mtpa in 2012 to
256 Mtpa by 2018, with most of the growth from Morocco. Phosphate rock mines are also
being developed or expanded within Africa in Angola, Congo (Brazzaville), Egypt, Ethiopia,
Guinea-Bissau, Namibia, Mali, Mauritania, Mozambique, Senegal, South Africa, Togo,
Tunisia, Uganda, and Zambia (Jasinski, 2013). In the rest of the world there is development
in Australia, Brazil, Canada, China, Kazakhstan, and New Zealand.
China, the USA and Morocco (including Western Sahara) accounted for over 60% of global
production in 2011 (See Figure 3), whilst Morocco is by far the world’s largest exporter (De
Ridder, et al, 2012).
Page 5 4 Growth Poles Phosphates
Figure 2: Phosphate surplus and deficit in arable soils
Due to the threat posed by lack of access to phosphates for the EU, steps for recovery and
recycling of phosphate from human sewage sludge are underway in Europe, but
infrastructure and governance mechanisms remain obstacles (De Ridder, et al, 2012).
Figure 3: World Phosphate Mine Production 2011
Source: Mineral commodity Survey, Jasinski (2013)
Page 6 4 Growth Poles Phosphates
Table 1: Tripartite Countries with a Phosphate resource
Angola
DRC
Egypt
Ethiopia
Kenya
Malawi
Mozambique
Namibia
South Africa
Sudan
Uganda
United Republic of Tanzania
Zambia
Zimbabwe
2.3.3 Demand After many years of oversupply, the phosphate market moved into undersupply in 2007 and
2008. Jasinski (2013) projected world consumption of P2O5 in fertilizer to increase from
41.9 Mtpa in 2012 to 45.3 Mtpa in 2016. Global demand in phosphate is expected to
continue to grow by 2-3% pa in line with growth in the fertiliser industry. Since there is no
substitute for phosphate and as long as populations grow so will the phosphate industry to
allow those populations to be fed. It is notable that there is an increasing trend towards
conversion of phosphate rock into phosphoric acid before export; this is most likely due to
the cost of transport.
China was the major user of fertiliser phosphates in 2010 (see Figure 4) and is likely to
remain the highest consumer due to its population. Although African consumption is
currently low, if one looks at continued strong growth in Africa, and because of the
population pressure exerted, and the need for food security, Africa could grow to be the third
major consumer by 2020 (see Figure 5).
2.3.4 Supply There are many arguments for and against the concept of “peak phosphorous”, but
regardless of individual opinion on the theory there is no doubt that land based phosphates
outside of Morocco and Western Sahara are in relatively short supply and that inhabitants of
many countries may feel that their food security is under threat.
Page 7 4 Growth Poles Phosphates
Figure 4: World fertiliser use 2010 (45 Mt nutrients)
Source: NPK101, FAO, 2011
Figure 5: World fertiliser use estimate 2020 (60 Mt Nutrients)
Note: Own Estimate
Although phosphate rock may be relatively plentiful it is important note that to manufacture
fertilizers profitably the rock must contain at least 26% P2O5, and preferably be free of
deleterious elements (and especially of heavy metals).
Up to 2009 the USGS estimated world “reserves” to be in the range of 16,000 Mt of
phosphate rock (5,600 Mt in Morocco) and a global “reserve base” to be 47,000 Mt of
phosphate rock (20,000 Mt in Morocco). In 2010 in the face of strong peak phosphate
projections, the International Fertilizer Development Centre (IFDC) reported world global
Page 8 4 Growth Poles Phosphates
“reserves” to amount to 60,000 Mt of rock, based mainly on an increase of Moroccan and
West Saharan reserves from 5,700 Mt to 51,000 Mt of phosphate rock. The USGS then
increased Moroccan reserves to 50,000 Mt and global reserves to 70,000 Mt!
The IFDC estimate was based on one single article by Gharbi, listing deposits as reserves.
Other publications from Gharbi and the Moroccan producer issued in the same period listed
the same deposits as resources. Later publications by the Moroccan producer report
reserves of 20,000 Mt.
Figure 6: World Phosphate reserves
Source: Mineral commodity Survey, Jasinski (2013), Blair, 2011
Like so many mineral commodities, value addition is not always done in the country of origin.
Figure 7 shows where the fertilisers based on phosphate rock are produced. This picture
could also see change if some of the larger deposits in the Tripartite were mined and beneficiated locally.
2.3.5 Trade Phosphate fertilizer, particularly in the form of di-ammonium phosphate (DAP) and mono-
ammonium phosphate (MAP), is widely traded.
De Ridder and others (2012) have expressed concern over the implementation of access
restrictions, trade barriers, and export quotas by producing countries. Furthermore, the
industry is tending toward vertical integration, with mining companies increasingly producing
Page 9 4 Growth Poles Phosphates
fertilizers, phosphoric acid and other products, especially where there is local demand. As a
result the picture for phosphate rock export is very different from the production (see Figure
8) and because of the location of beneficiation centres; it is also different to exports of
phosphate fertilisers (Figure 9).
Figure 7: Phosphate fertiliser production 2010 (46 Mt nutrients)
Source: NPK101
Figure 8: Phosphate Rock exports 2010
Source: IFA, 2013.
Page 10 4 Growth Poles Phosphates
Figure 9: Phosphate fertiliser exports 2010
Source: NPK101
If the importing areas are considered then it becomes very clear which regions have a
phosphate deficit and these are mainly Europe and India. Africa is also in deficit but
fertilizers are still underused in Africa at this point in time and as a result there is not much
import into Africa (see Figure 10). In Figure 11 the fertiliser imports are shown. This shows
‘other’ is the major importer because most countries have neither mines nor factories to
beneficiate phosphate rock.
Due to possible future phosphate shortages some countries remain very protective of their
phosphate resources. For example Business week (2013) indicated that China had imposed
a 135% tariff on phosphate rock exports.
Figure 10: Phosphate Rock imports 2010
Source: IFA, 2013.
Page 11 4 Growth Poles Phosphates
Figure 11: Phosphate fertiliser Imports 2010
Source: NPK101
2.3.6 Price Due to tight market conditions in 2007 and 2008 there was a major price spike (see Figure
12), with phosphate rock prices peaking at over $400/t and DAP prices over $1200/t. The
volatility in phosphate rock and phosphoric acid prices (previously set on an annual basis)
has continued, and prices are not expected to return to the long term pricing but rather to
remain high, and to stabilise at over $125/t.
Figure 12: Phosphate Rock price 2011-2013
Source: Infomine 2013
Page 12 4 Growth Poles Phosphates
2.3.7 Value added products and substitution Although phosphate rock used for soil fertilisation may be used directly if the activity of the
phosphate is high, most often it is formed into a fertiliser product (Figure 13), to make
transporting of the products easier, and to ensure that final application rates can be better
controlled.
Figure 13: Phosphate fertiliser products
Source: NPK101
2.3.7.1 Phosphoric Acid
Phosphoric acid is obtained by combining phosphate rock with sulphuric acid, to produce
3H3PO4. The main environmental problem presented from this process is the disposal of the
great quantity of gypsum produced as a by-product. Since there is a distinct lack of
phosphate resources in South Asia this region is a captive market. Note that gypsum finds
use in many industries dependent on its specific quality. It is also an important soil
ameliorant especially where clayey soils are found.
2.3.7.2 MAP & DAP Phosphoric acid can be combined with ammonia to form mono-ammonium phosphate (MAP)
and di-ammonium phosphate (DAP). The advantages of these ammonium phosphates are:
Both nitrogen and phosphorus are available in the fertiliser
They can be produced in granular form
Page 13 4 Growth Poles Phosphates
2.3.7.3 NPK Nitrogen-Phosphate-potassium (NPK) fertilizers are compound fertilizers consisting of the
three major plant nutrients (often also with micronutrients). NPK is usually available in
granule form to make distribution easy. NPK is produced by neutralizing phosphoric and
sulphuric acid with ammonia and adding potassium chloride and UAN (a solution of urea and
ammonium nitrate), followed by drying and granulation.
2.3.7.4 Single Superphosphate (SSP) Single superphosphate (SSP) is produced made by acidifying phosphate rock. The P2O5
content of SSP is 16-20% (8-9% P). A sulphuric acid plant is usually a prerequisite.
Hydrofluoric acid (HF), which escapes from the process as a gas may be captured to
represent a significant by-product.
2.3.7.5 Triple Superphosphate (TSP)
Triple Superphosphate (TSP) is formed by treating phosphate rock with phosphoric acid. It
has 40-49% P2O5 (about 20% P). The major advantage of TSP is the high concentration of
phosphorous which leads to lower transport costs per tonne of phosphorous. However, the
majority of the phosphorous in the product comes from the phosphoric acid, which is
expensive; furthermore it does require rock with a high P2O5 content.
2.3.8 Substitutes There are no substitutes for phosphorous, and there would not be enough supply from
organic sources to meet the world demand.
2.3.9 Challenges The availability of water is critical in the phosphate rock beneficiation process. Without water,
deposits may be left untouched, or only partially utilised. Dry screening may be used to
produce concentrates if ore characteristics are suitable. Seawater or brack water may be
used for washing and size classification and for flotation. However a final rinse will be
required to remove the impurities introduced (eg NaCl).
Page 14 4 Growth Poles Phosphates
3 ANGOLA Van Straaten (2002) reports phosphates in the Cabinda area, at Lucunga River, northeast of
Luande and in 8 carbonatite complexes
3.1 Cabinda Phosphates Extensive sedimentary phosphate deposits occur in Cabinda and stretch into the DRC
(Figure 14). The phosphate beds are Upper Cretaceous to Lower Eocene in age and are
concentrated in two zones. A lower phosphate zone with three beds, 3 m, 12 m and 9 m
thick, and the upper phosphate zone with a single bed of 13-23 m thick. The phosphates are
made up of pellets, oolites and organic fragments. The lower beds grade at 10-20% P2O5
and of the upper beds at 15-20% P2O5. Weathering and leaching extend to depths of 100 m
or more and in some places have increased the grade of the phosphate beds to 32-38%
P2O5 (Hodge and Partners 1978 in van Straaten, 2002). Minbos Resources is currently busy
with exploration in Angola and the DRC and has an exploration target of 333 – 538 Mt
grading 10% - 20% P2O5 in its Cabinda licence area (Minbos, 2012). Currently there is an
inferred resource of 304.8 Mt at 11.5% P2O5. Van Kauwenbergh (2006) gives data on costs
and some engineering data of a proposed Companhiá de Fosfatos de Angola (COFAN)
mine and beneficiation facility.
3.1.1 Cacata The Cacata deposit is in the Nhenha river valley, some 60 km east of Cabinda City. The
Cacata area has an indicated resource (included in the overall Cabinda licence resource) of
30.4 Mt at 17.2% P2O5. The Cacata area would be mined first and it is expected that it would
be able to support a large scale phosphate rock complex producing about 1.25 Mtpa over 10
years LOM. It will be an open-pit operation with a conventional beneficiation process to
produce a 35% P2O5 product (Minbos, 2012).
3.1.2 Chibuete The deposit occurs north-northeast of Lake Massabi near the Congo Border, COFAN
estimated a “probable reserve” of 93.66 Mt at 15.55% P2O5 was estimated. Chibuete is
included in the overall Minbos Cabinda licence estimate, it has a 150 Mt inferred resource at
8.3% P2O5 (Minbos, 2013).
Page 15 4 Growth Poles Phosphates
3.1.2.1 Ueca
Also included in the Minbos licence area, this deposit is about 8.25 km long and 460-550 m
wide. COFAN planned to mine this deposit which they estimated at 147.08 Mt at 11.91%
P2O5, under 9.8 m of overburden (Van Kauwenbergh, 2006).
Figure 14: Cabinda and DRC phosphate field
Source: Minbos, 2012
3.1.2.2 Moampoate
A small deposit included in the Minbos licence, COFAN estimated that it had 37.83 Mt at
33% P2O5 divided into several localised sections (Van Kauwenbergh, 2006).
3.1.2.3 Chivovo
Also included in the Minbos licence area and reserve estimate is the Chivovo deposit which
occurs some 10 km north of Dinge. It consists of lenticular phosphatic sandstones which
Page 16 4 Growth Poles Phosphates
contain 29% P2O5 (van Straaten, 2002). Minbos has an inferred resource of 6.7 Mt at 20.3%
P2O5 at this deposit (Minbos, 2013).
3.1.3 Mongo Tando This deposit was studied by COFAN and is included in the Minbos licence area. COFAN
estimated a resource of 37.2 Mt under 38.2 m of overburden. Average P2O5 content is not
given (Van Kauwenbergh, 2006). Minbos has an inferred resource of 117.7 Mt at 13.6%
P2O5 at this locality (Minbos, 2013).
3.1.4 The Lucunga River phosphates The second largest potential for Tertiary phosphate development in Angola exists in the
Lucunga River area some 40 km north of the port of Ambrizete. The phosphate beds are of
the unconsolidated nodular type. There are deposits at Coluge, Lendiacolo and
Quindonacaxa. The phosphate reserves at Quindonacaxa, based on data of Antonio Martins
(1963) are 20,255,903 tonnes at 18.54% P2O5 (van Straaten, 2002). Agronomic work by
Melo (1984) indicated good agronomic effectiveness of Quindonacaxa PR applied directly on
acid soils (pH< 5.5). This deposit was mined intermittently between 1981 and 1984 by the
state owned company Fosfatos de Angola (FOSFANG) under a joint venture with Bulgaria
(Premoli 1994 in van Straaten, 2002).
Total resources for the Lucunga river phosphates have been estimated at 28 Mt at 18-26%
P2O5. The phosphate beds are commonly 0.2-2.0 m thick with localized areas having a
thickness of over 5 m. Overburden varies from 0.1 m in the Lendiacola area to 2.4 m in the
Quindonacaxa area (van Straaten, 2002).
3.1.5 Carbonatites Igneous phosphates are known from several Cretaceous carbonatite complexes. They are:
Canata, Capuia, Bailundo, Longonjo, Bonga, Capunda, Lupongola and Virulundo
carbonatites. More work needs to be done to establish resources and grades on these
deposits.
3.1.5.1 Longonjo
Black Fire Minerals has a rare-earth project license at Longonjo, about 600 km southeast of
Luanda, which covers an area of 3,670 km2. Previous explorations at Longonjo have
returned up to 18.9% total rare earth oxides, and up to 9% copper and 6 g/t of gold from the
Page 17 4 Growth Poles Phosphates
Cassenha Hill prospect (Finlayson, 2012). Exploration is currently being undertaken by
Dromana Estate for rare earths.
Page 18 4 Growth Poles Phosphates
4 BOTSWANA There are no significant phosphate deposits known in Botswana.
Page 19 4 Growth Poles Phosphates
5 BURUNDI The economy of Burundi is largely based on agriculture and therefore it is of particular
importance to understand the relevant mineral resources in the area for the better production
of crops.
5.1 Matongo A phosphate deposit occurs at Matongo (70 km north of Bujumbura (3o 4' S; 29o 37' E)). The
deposit is a residual phosphate overlying a strongly weathered carbonatite, which is part of
the Neoproterozoic Upper Ruvubu alkaline complex. The phosphate deposit is up to 55 m
thick. The composition of the ore varies considerably but contains approximately 30%
fluorapatite and 17% “caxonite” (an iron-phosphate mineral), as well as minor clay, feldspar
and limonite. A feasibility study showed reserves of 17.3 Mt of ore at 11.0% P2O5 (cutoff 5%
P2O5) or 40 Mt at 5.6% P2O5 (Kurtanjek and Tandy 1989 in Van Straaten 2002). The
engineering company MacKay and Schnellmann showed that there was insufficient high-
grade material to support a superphosphate plant (Songore 1996 in Van Straaten 2002).
Page 21 4 Growth Poles Phosphates
7 DRC
7.1 Sedimentary Phosphates Sedimentary phosphates occur in the Bas Congo region, at the border with the Cabinda
enclave. These are a continuation of the Cabinda deposits.
UNDP exploration in the late 1970’s focused on the Fundu Nzobe, Vuangu, and Kanzi areas.
Fundu Nzobe in the north has five phosphate bearing layers. The thickness and grade of
these sedimentary phosphate beds are: Bed I: 11.5 m, 11.5-18.5% P2O5; Bed II: 5.5 m, 18-
19.4% P2O5; Bed III: 20 m, 18-19.7% P2O5; Bed IV: 5.1 m, 20.6% P2O5; Bed V: 10.7 m, 31%
P2O5. However mining would be complicated as a result of structural deformation (open
folding and faulting) and overburden. Superficial sand overburden reaches 20 m and more in
some places. The resources in the Fundu Nzobe area are substantial but have not been
assessed with certainty due their complex structural setting (Barry 1981 in van Straaten,
2002).
7.1.1 Kanzi Project Kanzi in Bas Congo, has a single, relatively uniform layer of phosphorite which is 8-10 m
thick with 14% P2O5. It is covered by a thick sandy giving a 'waste-to-ore' ratio of 2:1-10:1.
The Kanzi project was drilled in 1974 and 1978-1980 and metallurgical test work done then
produced a concentrate of 34% P2O5 with recoveries of 60%-70%.
The project is now a part of the Minbos licence area and Minbos has declared a maiden
inferred resource of 46 Mt at 17.2% P2O5 including a high grade zone of 31 Mt at 21.4%
P2O5. More land adjacent to this is currently under application for licencing.
7.1.2 Igneous phosphates Other phosphate resources available in the DRC include igneous phosphate resources,
mainly associated with carbonatites.
7.1.3 Lueshe carbonatite The Lueshe carbonatite (1°0'S; 29°8'E) is mainly made up of a syenite and carbonatite, with
little apatite as an accessory mineral (Maravic and Morteani 1980 in van Straaten, 2002). An
average chemical analysis of the lateritic residual soils is 5-9% P2O5 (Maravic et al. 1983 in
van Straaten 2002). Lueshe pyrochlore mine has operated on and off since 2000 (Yager,
2013), and it is uncertain what its current status is.
Page 22 4 Growth Poles Phosphates
7.1.3.1 Bingu (Bingo) The Bingu carbonatite (0°5'N; 29°31'E) is a carbonatite with possible phosphate reserves,
however like Lueshe it really is more a niobium deposit that could produce phosphate as a
byproduct (Appleton, 2002).
Page 24 4 Growth Poles Phosphates
9 EGYPT
9.1 Introduction Egyptian producer El Nasr has recently secured a long term offtake agreement for 600 ktpa
of rock phosphate, valued at $90 M from Malaysian Phosphate Additives. Malaysian
Phosphate Additives may also assist local companies to set up a plant to serve the local
demand in Egypt for about 200 ktpa, for food, industrial and feed phosphates (Business
Times, 2013).
Jasinski (2013) indicates Egyptian reserves are 100 Mt, this is the same figure given by the
USGS 2 years ago.
Egyptian sedimentary phosphates occur in the upper Cretaceous to lower Tertiary sediments
of the Duwi Formation. There are three main groups of deposits, all lying between the
latitudes 26.67°N and 29.5°N (Notholt et al).
Deposits along the Red Sea coast: the deposits occur primarily some 20-30 km south and southwest of the Port City of Safaga, and inland from the Port of Quseir to the south.
Along the Nile Valley: Deposits occur mainly between Idfu and Qena, especially near Sebaiya
On the Abu Tartur Plateau
The phosphates all occur in one of three phosphate members of the Duwi Formation
9.2 Red Sea Coastal Area Most of the Red Sea deposits have been structurally deformed and the phosphates are
preserved in basin-like structures surrounded by Precambrian rocks, however at Wadi
Gasus the sedimentary sequence extends all the way to the coast (van Kauwenbergh,
2010). Phosphate beds were mined in the Safaga area from 1911, with P2O5 content ranging
from 20-28%. The mines were underground room and pillar operations, and the product was
shipped to Safaga. The final product contained 29.3% P2O5.
There were also seven underground mines operating inland of the port of Quseir (Kosseir),
on preserved potash deposits in synclinal or monoclonal structures. Here the P2O5 content
was 20-30% but could be as high as 37% in places (Savage, 1987 in van Kauwenbergh,
2010). The Quseir deposits were worked since 1912; the final product had about 30% P2O5.
Interestingly in some cases the material was washed with seawater (van Kauwenbergh,
2010).
Page 25 4 Growth Poles Phosphates
There was originally a “reserve” of some 40 Mt at the Hamrawein underground mine some
40 km south of Safaga, the P2O5 content was 12.5-20% when the mine stared in 1978. The
planned capacity of 600 ktpa concentrate was never achieved (Van Kauwenbergh, 2010).
In 2000 the red sea phosphate company merged together with the Hamrawein mine into the
El Nasr Phosphate Company (ENMC). The ENMC indicated in 2006 that there were still
1.6 Mt of reserves in the Red sea area, with a minimum of 27% P2O5 and 5.0 Mt of (ENMC,
2006 in van Kauwenbergh, 2010). The state owned EI Nasr Mining Company (NMC) now
controls all the reserves and resources of the Sebaiya area, the eastern desert and the Red
Sea coastal area (Van Kauwenbergh, 2010). Reserves are very limited in the Red Sea area
and several deposits have been worked out many years ago (Notholt, et al 2005)
9.3 Nile Valley deposits ENMC had 10 working mines in the area in 2010. A total estimated resource of phosphate
in the eastern desert is 1,878 Mt (Abdel Malik Farah, 2005 in Van Kauwenbergh, 2010).
West Sebaiya proven reserves were as 24 Mt of ore, whilst East Sebaiya reserves were
indicated as 34 Mt at about 29-30% P205. The concentrate reserves of the West Sebaiya
area are 15 Mt at about 27% P205.
Notholt et al (2005), indicate that the most promising deposits here are those of Abu Had
and Wadi Batur with a probable resource of 395 Mt at 20-24% P2O5.
9.4 Abu Tartur At Abu Tartur phosphate beds occur in the lower member of the Duwi formation and are
some 3.9 m thick. They were discovered in 1961, and in 1979 the World Bank financed an
$11m feasibility study. The bed averages ~25% P2O5 and tests showed that it could be
upgraded to 31.31% P2O5 (van Kauwenbergh, 2010). In 1980, an underground mine was
developed using the fully mechanised longwall mining technique with an average panel
length of 1,100 m. The ore is beneficiated and loaded onto trains. In 2006 the production
was 500-600 ktpa of concentrate at 28-30% P2O5. The concentrate was produced into single
superphosphate (SSP), triple superphosphate (TSP) by Abu Zaabal Chemical and Fertiliser
Company and to SSP by the Egyptian Financial and Industrial Company (EFIC).
“Indicated reserves” were 715 Mt, although within the mine area the reserve was 65 Mt of
unoxidised ore and 20 Mt of oxidised ore.
Page 26 4 Growth Poles Phosphates
9.5 Resource There are several widely differing figures for reserves and resources in Egypt and
unfortunately none of these appear to conform to any internationally accepted standard.
There are also many more deposits than discussed here, but again few references appear to
be consistent and a much more detailed study of the literature would be required to
understand the full ambit of Egyptian phosphate deposits. Van Kauwenbergh (2010) gives
the IFDC reserve estimate for Egypt as 52 Mt and the resource as 3,400 Mt.
9.6 Beneficiation Output from the West Sebaiya mines is used to manufacture phosphoric acid and phosphate
fertilisers at Abu Zaabal near Cairo.
Page 28 4 Growth Poles Phosphates
11 ETHIOPIA Ethiopia occupies the northern end of the Eastern Rift valley, and as a result thick
sequences of Tertiary volcanic rocks occupy much of the country along the rift valley. Older
(Proterozoic) rocks occur in western and to some extent in eastern Ethiopia. The Rift Valley
has relatively young lacustrine sediments and volcanics, but although several alkaline plugs
are known from Ethiopia, no carbonatite has been found (van Straaten, 2002).
11.1 Bikilal The phosphate mineralization in the Bikilal deposit, 17 km north-northeast of Ghimbi, in the
Welega region, is unusual, in that it is associated with a Proterozoic layered gabbro-
anorthosite intrusion. Low-grade phosphates (mean of 4.56% P2O5) occur as apatite-
magnetite-ilmenite mineralization in hornblendites (Abera 1988; Assefa 1991 in van Straaten
2002). The mineralised zone is about 15 km long and 0.7 to 1.2 km wide. The apatite is a
relatively unreactive fluorapatite and “reserve” estimates to a depth of 200 m, are 127 Mt at
3.5% P2O5, 23.8% Fe203, 7.3% Ti02 (Yohannes 1994, in van Straaten 2002). Gebre-Selassie
(2000) reported that the Ethiopian Geological Survey had verified more than 200 Mt at Bikilal
(Van Kauwenbergh, 2010). Ghebre (2010) set the minable reserve of the deposit to be
181 Mt at 3.5% P2O5. He gives an indicated resource of 435 Mt at 3% and an inferred
resource of 145 Mt at 3.1% P2O5.
Although concentrates of up to 36% P2O5 were produced using simple processing
techniques, the recovery rate was low at only 40-58% (Abera et al. 1994 in van Straaten,
2002), However, Ghebre (2010) records that bulk samples sent to Bateman Phosphate
technologies in South Africa for processing gave a concentrate of 33% P2O5 with a 38%
recovery. The concentrate had low contaminants and Ghebre considers it to be suitable for
phosphoric acid production.
11.2 Other deposits Phosphates have been reported in several boreholes drilled elsewhere in Ethiopia, but there
is no indication of the possible size of these occurrences.
Page 29 4 Growth Poles Phosphates
12 KENYA The phosphate resources of Kenya include small guano deposits and small igneous
phosphate resources associated with carbonatites with the most significant deposit being at
Mrima Hill carbonatite. Phosphates also occur in the Rangwe area, in the Koru carbonatite
and associated with vein type iron ore at Ikutha.
12.1 Mrima Hill Carbonatite Lying some 65 km southwest of Mombasa the ferruginous soils covering the Mrima Hill
carbonatite represent a niobium and phosphate target. The resource is given by Notholt and
others (2005) as 37 Mt at 0.67% Nb2O5. The phosphate is mainly in the form of the minerals
gorceixite and monazite and although the phosphate content can be as high as 23%, the
average is 3-4% P2O5. The deposit probably has little value for its agricultural phosphate
potential.
12.2 Rangwe Area Intrusives Although individual samples in this area on the eastern shore of Lake Victoria have been
interesting, no appreciable volume of material has been located.
12.3 Fertiliser plant It is understood that a fertiliser plant at Mombasa is being considered, utilising Kenyan and
Tanzanian raw materials.
Page 30 4 Growth Poles Phosphates
13 LESOTHO Small amounts of phosphates have been found in sediments of the Karoo Supergroup. No
significant deposit appears to exist.
Page 31 4 Growth Poles Phosphates
14 LIBYA There are no significant phosphate deposits known in Libya.
Page 32 4 Growth Poles Phosphates
15 MADAGASCAR Madagascar is underlain by Precambrian metamorphic basement rocks in the eastern part of
the country, and Karoo and younger sedimentary formations which overlie the basement in
the west.
Sedimentary phosphates with <20% P2O5 occur in Cretaceous and Tertiary sediments of the
Mahajanga Basin of northwest Madagascar. Phosphates also occur in upper Cretaceous
sediments near Marovoay, and south of Soalara, as well as near Sitampiky. Phosphates
have also been reported from the Antonibe Peninsula where they occur at the base of
Palaeocene sediments. Low-grade phosphatic sediments occur in lacustrine environments
at Lake Alaotra, and in Pliocene marls near Antanifotsy (van Straaten, 2002).
Igneous apatites are reported from phlogopite-bearing pyroxenites, near Betroka and Bekily
(van Straaten, 2002).
None of the occurrences of phosphate appear on current knowledge to be significant.
Page 33 4 Growth Poles Phosphates
16 MALAWI Apatite is found in several igneous bodies in Malawi with the Tundulu Carbonatite in the
Mlanje district being of economic importance. Resources at Tundulu are about 800 kt at
>20% P2O5. At a lower grade of 17% the reserve is 2 Mt (Appleton, 2002). There are also
some 2.4 Mt of phosphate at 7-14% P2O5 in residual soils over a metapyroxenite at Mlindi.
Notholt (2005) referring to a written communication with Appleton (1986) indicates that
eluvial deposits at Chingale contain 8.8 Mt at 3.7% P2O5. There may also be interesting
enrichments at Chilwa island, the Kangankunde carbonatite complex, and at several other
intrusions.
16.1 Tundulu Lying at the southern end of Lake Chilwa this apatite rich rock has 20.80-38.94% P2O5 with a
very low solubility. The phosphate alone does not lead to an economic prospect but Malunga
(1999) quoted in Van Kauwenbergh (2010) suggests that together with the Niobium
(0.017%) and medium weight Rare Earths (0.019%), this may still prove to be profitable.
The deposit at Tundulu in Malawi contains some 1.9 Mt ore to a depth of 50 m with a P2O5
content of 15-20%, which equates to more than 275 kt of P2O5 according to Malunga, 2001.
Figure 15: The Tundulu Carbonatite Complex, Malawi
Page 34 4 Growth Poles Phosphates
17 MAURITIUS The only phosphate known in Mauritius is based on Guano at the islands of Cargados.
Page 35 4 Growth Poles Phosphates
18 MOZAMBIQUE Mozambique has several phosphate deposits (Evate, Cone Negose, Mont Muande Mont
Fema). Several pegmatites also contain phosphate minerals.
18.1 Sedimentary deposits Besides small guano deposits, there are strong indications of sedimentary Tertiary
phosphates in Mozambique (Davidson 1986 in van Straaten 2002). One such deposit occurs
to the west and northwest of Beira, in the glauconite-bearing Eocene Cheringoma
Formation, which contains fossil fish and teeth beds, and is seen as a potential source rock
for phosphorites (see Figure 16, van Straaten, 2002). The Cheringoma Formation appears to
be an extension of the Miocene Uloa beds in South Africa. Van Kauwenbergh (2006)
referring to Manhica (1991) reports that there are sediments containing 0.7-3.1% P2O5 near
Magude, north of Maputo.
18.2 Igneous deposits
18.2.1 Cone Negose Occurring some 80 km southwest of Fingoe, this is a metasomatic enrichment in a Mesozoic
volcanic carbonatite, with vents and dikes cutting Karoo sediments. Phosphate enrichment
occurs in late stage carbonatite rock (Manhica 1991 in van Straaten, 2002). No estimates on
phosphate grade and tonnage are available.
18.2.2 Evate The Evate deposit is located on the SE flank of the Monapo Complex about 100 km east of
Nampula. The Monapo Complex measures 40 x 53 km and is one of the largest alkaline
complexes in the world. The rocks of the complex form steeply dipping, concentric lithologies
suggesting multiple intrusions of cone sheets. Apatite concentrations occur in mineralised
zones about 3 km long, 830 m wide and 600 m thick. The most important mineralization
occurs in lenticular bodies, about 400 m long and 4-20 m wide with P2O5 grades of 4-6%.
Apatite mineralization grades from 6-30% and is associated with magnetite, pyrrhotite,
calcite, olivine and pyrite (Callaghan, 2002 after Goncalves and Deus, 2002).
The Evate deposit is large and contains 155.4 Mt of ore at 9.32% P2O5, (Orris and Chernoff,
2002) 5.76% Fe, 1.21% TiO2, 47.69% CaO. However, the phosphates here have high
chlorine content of 0.18%, clearly in excess of industry standards of 200 ppm (Siegfried,
Page 36 4 Growth Poles Phosphates
2001). This would cause excessive corrosion of vessels within a phosphoric acid plant and is
a major drawback of the deposit since the capital costs of a plant would be greatly increased
due to expensive alloys being required that will better resist the corrosion.
However, it may be possible to remove some of the chlorine as is done by the Jordan
phosphate company.
Vale has a mining right for 30 years on Evate and plans to bring it into production by 2017
with a 3.5 Mtpa capacity (myinvestorguide, 2013). The project includes using the phosphate
in a fertiliser factory to be built in the coastal district of Nacala-a-Velha. The project is still in
its prefeasibility stage.
Figure 16: Phosphate occurrences in Mozambique
Source: van Straaten, 2002 after Cilek, 1989.
Page 37 4 Growth Poles Phosphates
18.2.3 Lucuisse Lucuisse is a carbonatite with possible metasomatic enrichment, which contains monazite,
apatite, pyrochlore, columbite, zircon and magnetite.
18.2.4 Mont Muande The Mont Muande prospect is about 30 km northwest of Tete, on the north bank of the
Zambezi River. On the other side of the river it is known as the Mont Fema deposit
In accordance with a joint venture with North River Resources plc, Baobab can earn up to
90% in the Mont Muande magnetite project. They have completed stage 1 in April 2013 and
have currently earned a 60% shareholding. Baobab commissioned Coffey Mining Pty Ltd to
assess the exploration target based on the previous work. Coffey Mining defined an
exploration target of 200-250 Mt of ore. The estimates were made based on to an average
depth of 42 m (deepest hole # 135 m).
The 10 hole diamond drilling programme completed during 2011 intersected broad packages
of magnetite and phosphate mineralisation. Results from 9 of the holes have shown
magnetite rich intersections. Tests show that these can be concentrated to 69% Fe at a
mass recovery of 26%. Magnetite intercepts generally report an enrichment of phosphate
compared to background values with an average head grade of 4% P2O5. In the non-
magnetic component of the Davis Tube recovery process, phosphate ran at 5.5% on
average. Testwork is still awaited for final phosphate concentration (Baobab, 2013).
Van Straaten, 2002 cites Davidson 1986 as indicating a 200 kt content of P2O5 at Mont
Muande.
Page 38 4 Growth Poles Phosphates
19 NAMIBIA Phosphates on the Namibian shelf were discovered in the late 1960s. The phosphate
deposit off Walvis Bay was called the Sandpiper Deposit by Gencor and has retained that
name. In the 1990s the Sandpiper deposit was considered as sub economic based on the
price for rock phosphate concentrate (1991: $42.50/t). After the 2008 price shock, the price
has settled at a new level of around $150-$200/t.
19.1 Igneous deposits Low-grade phosphates are associated with several of the alkaline and carbonatite
complexes in Namibia. These have an average P2O5 content as follows:
Okorusu complex, in the Otjiwarongo District: 3-4% P2O5,
Ondumakorume complex, 13 km northeast of Kalkfeld: 7% P2O5, - Appleton (2002) suggests that this may be the most promising carbonatite in Namibia
Kalkfeld complex, 11 km northwest of Kalkfeld: 6.7% P2O5,
Osongombe complex, southwest of Kalkfeld: 6.5% P2O5,
Otjisazu complex, southeast of Kalkfeld, in the Okahandja District: 3-9% P2O5. Van Straaten (2002) indicates that, based on the work of Schneider and Schreuder (1992), this deposit has at least 35 Mt of phosphate ore at 3-9% P2O5 to a depth of 30m.
Epembe Carbonatite southwest of Swartbooisdrift: 3.5% P2O5
19.2 Sedimentary offshore deposits
19.2.1 The Sandpiper project Namibia Marine Phosphate (Pty) Ltd., (NMP) is proceeding with the sandpiper project on the
Namibian continental shelf about 120 km south-southwest of Walvis Bay in water depths of
180-300 m. The eastern boundary of the Mining Licence Area is approximately 40-60 km off
the coast (directly west of Conception Bay). The Mining Licence covers an area of
2,233 km2. NMP plans to dredge marine sediments containing 18% to 20% P2O5. A
feasibility study completed in 2012 showed that a 3 Mtpa facility to produce a concentrate of
28% P2O5 was viable dependent on market conditions.
The deposit is very uniform and continuous and comprises unconsolidated fine sand sized
phosphorite ooliths and pellets, falling in the 100 to 500 micron grain size range. These
pellets are made up mainly of calcium carbonate and phosphate (P2O5). They can also
contain quartz grains, ilmenite and sulphides (UCL, 2013).
Page 39 4 Growth Poles Phosphates
NMP has confirmed a JORC compliant resource of 4,313 Mt at 20.43% P2O5. The company
plans to dredge initially from water depths of up to 225 m and recover 5 Mtpa of ore. This will
be transported to shore and pumped by means of a sinker line pipeline to a buffer pond.
Here oversize will take place and the final slurry pumped to a processing plant near Walvis
Bay for desliming, gravity separation, attrition, washing and drying. It is expected that about
3 Mtpa will be bulk loaded for export from Walvis Bay for a 25 year life of mine.
19.2.2 Phosphate in Tailings The tailings dams at Okuruso Fluorspar mine (situated between Otjiwarongo and Otavi)
contain sufficient phosphates to merit further investigation for using the substance in crop
fertiliser and animal feeds (Waldo, 2013).
The consultant chemist working on the project is confident that the project will be feasible at
full scale production. In the laboratory process Calcium nitrate - also valuable in the
agricultural industry - is also being produced as a byproduct of the phosphate.
Page 40 4 Growth Poles Phosphates
20 RWANDA There are no significant phosphate deposits known in Rwanda.
Page 41 4 Growth Poles Phosphates
21 SEYCHELLES Besides guano, the only phosphates present in the Seychelles are some oolitic phosphorites
that cover some solution eroded limestone surfaces on the island of Esprit.
Page 42 4 Growth Poles Phosphates
22 SOUTH AFRICA
22.1 Foskor Mine (Palaborwa) The Palaborwa Igneous Complex, in the Limpopo Province, has 14 distinct rock types. The
deposit comprises a volcanic plug some 1.5 - 3.5 km in width and 6.5 km in length. There
are three lobes to the intrusion, they are: the North Pyroxenite, Loolekop and South
Pyroxenite. Apatite is the only phosphate mineral present and copper minerals and
magnetite are present in the Loolekop lobe (Foskor, 2012).
There are four mines operating in the Palaborwa Igneous Complex. Palaborwa Mining
Company (PMC) operates a copper mine in the central portion of the complex, as well as a
vermiculite mine in the southern portion of the complex. Foskor operates two phosphate rock
mining operations, one situated in the North Pyroxenite area and another in the South
Pyroxenite area (Foskor, 2012).
The SAMREC compliant ore reserves were calculated taking into account a cut-off that
would provide a feed grade to economically produce a saleable (36.5% P2O5) phosphate
rock concentrate (Foskor, 2012). The mineral reserves at 31 March 2012 are given for the
north and south pyroxenites pits and total 1,553 Mt at 6.9% P2O5 (Proved: 1,391 Mt at
6.93%; Probable: 162 Mt at 6.62%). The measured and indicated mineral resource is given
as 4,856 Mt at 6.7% P2O5.
22.2 Glenover Phosphate mineralization occurs at the Glenover Carbonatite Complex some 88 km north of
Thabazimbi in Limpopo Province. Phosphates occur in all three rock types that make up the
complex, the apatite haematite breccia zone, as well as the carbonatite and pyroxenite
intrusives. The complex is 4.7 km long and 3.5 km wide and intrudes the sedimentary rocks
of the Waterberg Group. The breccia body occurs near the centre of the complex. Between
1962 and 1983 Goldfields mined the high grade (>30% P2O5) central portion of the ore body
to produce 1.45 Mt of 36% P2O5 concentrate (Wilson 1998).
Galileo Resources is currently undertaking a prefeasibility study on the deposit with the aim
of re-opening the mine. Their resource study (Geo-Consult, 2012) gave an indicated
resource of 16.78 Mt at 9.71%. The Galileo annual report gives the resource at 28.928 Mt at
Page 43 4 Growth Poles Phosphates
1.24% total rare earth oxides and 9.52% P2O5 (Galileo, 2013), it appears that the project is
now being seen as a rare earth play.
22.3 Schiel The Schiel Complex is a large syenitic complex with subordinate carbonatite, foskorite, and
syeno-gabbro. Verwoerd (1986) as quoted in ‘Rocks for Crops’ records an ore “reserve” of
36 Mt at 5.1% P2O5 in the weathered zone to a depth of 39.6 m.
22.4 Spitskop The Spitskop Complex is about 14 km across. Three concentric, vertical apatite-rich zones
occur. The inner ring grades 6.5% P2O5 whilst two small lenticular bodies associated with
the outer rings grade 6.5 and 8.5% P2O5. The apatite is finely intergrown with iron oxides,
and producing a phosphate concentrate with more than 20% P2O5 has been difficult (Wilson
1998).
22.5 Sedimentary phosphates The largest known sedimentary phosphate resources in South Africa are the offshore
deposits. On the western coast phosphorite pellets have been found both offshore and on
adjacent coastal terraces extending from Cape Town for about 220 km to the north. Small
occurrences are associated with Upper Tertiary sediments in the coastal area of KwaZulu
and Upper Dwyka Shales and Upper Ecca Shales of the Karoo Supergroup.
22.5.1 Agulhas Bank deposits Large diagenetic replacement phosphate resources occur over limestones on the continental
shelf. The deposits consist of boulders and cobbles of phosphatized limestone, in a matrix of
glauconite, microfossils and quartz sand. Grade in samples ranges from 10-25% P2O5.
The largest concentration occurs between Cape Point and Saldanha Bay with an estimated
resource of 5,500 Mt at 17.8% P2O5. In the area from Cape Agulhas to Cape Recife there is
estimated to be a further 3,500 Mt at 16.2% P2O5 (Wilson 1998).
Although the Agulhas bank deposits are very large, Roux and others (1989) indicate that
they are not amenable to upgrading.
Page 44 4 Growth Poles Phosphates
Jara Exploration has a 26% stake in an offshore mineral exploration licence of the South
African Coast, close to Ports. The licence, applied for in 2011 is for glauconitic sand, potash,
and phosphate. The licence is valid for 5 years. After exploration is finalized Jara Exploration
will apply for a Mining licence. It plans to start mining 2020 or when a mining licence is
granted (Jara, 2013).
22.5.2 Other deposits A mine on the farm Langeberg, near Langebaanweg produced 24 Mt at 10% P2O5 before it
closed in 1992. There remains a proven reserve of 25 Mt at 8.5% P2O5 (Wilson, 1998). In
2010 a new mine (Gecko Fert) was opened at Langebaanweg and is currently in operation.
On the farm Philips Kraal and its surrounds there is a 30.2 Mt deposit at 4-6% P2O5 (Wilson,
1998).
On the farm Elandsfontein, 15 km east of Langebaan there is a deposit of some 50 Mt at
8.5% P2O5. There is an unexploited deposit of 23.6 Mt at 6% P2O5 on the farm Sandheuvel.
There are also several other, smaller deposits in the area.
There is a small bed of nodular phosphate in Miocene beds in the Uloa area along the lower
reaches of the Umfolozi River in northern KwaZulu-Natal. The deposit extends into
Mozambique. There are also numerous other small deposits in South Africa.
.
Page 45 4 Growth Poles Phosphates
23 SOUTH SUDAN There are no phosphate deposits known in South Sudan.
Page 46 4 Growth Poles Phosphates
24 SUDAN
24.1 Jebel Abyad and Abu Hasem Regency Mines plc, is currently conducting an exploration programme in Sudan for
phosphate. Faith Khalil, governor of the Northern State, announced the discovery of big
quantities of phosphate at the Jebel Abyad (White Mountain) in 2011 Sudan news Agency,
2011).
Regency has farm-in rights under an option agreement with International Mineral Resources
(Agrominerals Sudan) Ltd. Regency announced in April 2013 that it had added 26,000 km2
area to north of Jebel Abyad (Figure 17) and dropped some less prospective zones, based
on the results of geological desk-top studies by the Company of publicly available material
and data from the Sudanese Ministry of Minerals.
A 26,000 km2 area to the north of the Abu Hashem licence, known as Jebel Abyad, has
been granted to IMRAS by the Ministry of Minerals. At the same time the IMRAS holdings at
Abu Hashem have been reduced following field trips and sampling by Regency geologists in
2012 and 2013. Regency is currently developing a programme of work, consisting of
geochemical sampling and geological mapping along 350 km of transect lines.
24.2 Halaib District Some 300 km north-northwest of Port Sudan phosphates occur in association with Upper
Cretaceous to Tertiary clastic sediments (Van Straaten, 2002).
24.3 Nuba Mountains There are two occurrences of phosphate breccia (Uro and Kurun) in the northeastern Nuba
Mountains some 250 km southeast of El Obeid. The phosphate mineralization of Uro
(11°40'N; 31°23'E) is associated with a uranium anomaly. Secondary Al-rich phosphates
occur in a breccia zone within graphite schists. In the middle portion of the Uro anomaly
samples gave 6.44% P2O5 (Van Straaten, 2002).
Another uranium anomaly with phosphate mineralization occurs 1 km south of Kurun (11°35'
N; 31°25'E), about 25 km south of the Uro occurrence. Sampling on a grid pattern gave
P2O5 concentrations of 0.27-36.48%, with a mean of 20.06%. A preliminary resource
estimate at Kurun indicates 1.68 Mt at 20% P2O5 (Van Straaten, 2002).
Page 47 4 Growth Poles Phosphates
Figure 17: Phosphate prospect at Jebel Abyad
Source: Regency (2013)
24.4 Other Phosphates At Jebel Dumbeir near Er Rahad (12°31' N; 30°45'E) there are small carbonatite plugs and
dykes close to a nepheline-syenite. The area is strongly affected by potassic metasomatism
and is fractured. Anomalous values of F, U, Ba, Sr are reported, but no phosphates have
been described so far (Van Straaten, 2002).
Page 48 4 Growth Poles Phosphates
The occurrences of apatite in pegmatites in the Baiyuda Desert, 130 km north-northwest of
Atbarah, are of no practical and economic importance (Van Straaten, 2002).
Page 49 4 Growth Poles Phosphates
25 SWAZILAND No phosphate deposits are known to exist in Swaziland.
Page 50 4 Growth Poles Phosphates
26 TANZANIA Tanzania is the host to igneous (carbonatite) phosphate, lacustrine phosphates in the rift
valley, metamorphic phosphates and guano.
26.1 Igneous (carbonatite) Phosphates The carbonatites are of either Mesozoic or Precambrian age and are associated with the
eastern and western arms of the rift valley. The carbonatites with the highest phosphorus
concentrations occur along the tectonically active Western Rift. Twenty-one carbonatite
complexes containing apatite occur in Tanzania (Appleton, 2002).
26.1.1 The Sangu-Ikola carbonatite This carbonatite near Lake Tanganyika is composed of three elongated bodies, the largest
of which is 14 km long and 1.5 km wide. The total length of the elongated carbonatite
complex is more than 30 km. Initial phosphate exploration delineated eluvium with 10% -
15% P2O5 (van Straaten 1983). The primary carbonatite contained up to 7% P2O5 (van
Straaten, 2002).
26.1.2 The Ngualla carbonatite Located some 200 km north of Mbeya (7"42'S; 32"50'E), this carbonatite has a diameter of
about 3 km. Phosphates increase from 0.4% P2O5 in the iron-rich carbonatite phase to 3%
P2O5 in the magnesium-rich phase and to 3-6% P2O5 in the calcium rich phase. No formal
phosphate resource evaluation has been undertaken (van Straaten 2002).
26.1.3 Mbalizi, Songwe and Sengeri Hill The Cretaceous carbonatites of Mbalizi (8°55' S; 33°21'30" E), Songwe Scarp (8°45’-54'S;
33°12’-30'E), and Sengeri Hill (8°57'30"S; 33°11'30"E) contain only small resources.
26.1.4 Panda Hill Panda Hill (8°59'30"S; 33°14'E), some 25 km west-southwest of Mbeya along the Tanzania-
Zambia railway, has a resource 480 Mt with an average grade of 0.33% Nb205 and 3.5%
P2O5. This includes about 1 Mt of residual phosphates with an average grade of 10.31%
P2O5 and 0.77% Nb205 in the Kunja-Mtoni zone of Panda Hill. The apatite is probably
fluorapatite and will therefore have a low solubility (van Straaten 2002). Appleton (2002)
gives a resource of 125 Mt at 6%. Residual soils have 17-25% P2O5.
Page 51 4 Growth Poles Phosphates
Verona Capital has an exclusive 4 year development option on the Panda Hill Niobium
Project. Panda Hill is an early stage niobium mine development project. The project has a
good niobium grade resource and indicative metallurgy for a world class niobium mine
(Verona, 2013). The mine has an inferred (JORC) resource of 56 Mt at 0.50% Nb2O5 with a
strip ratio of 1:1. Cradle resources Limited has recently announced that it has purchased a
50% interest in the mine (Cradle, 2013). The mine has a potential to be one of the most
significant niobium mines in the world.
26.1.5 Metamorphic Apatite limestones Apatite bearing limestones occur in the Zizi area in the Morogoro District, as well as near
Lupingu along Lake Malawi. At Zizi, the occurrence is a 20 m wide and 1,150 m long lens in
high grade metamorphic rocks with about 1.8 Mt of ore at 6.9% P2O5 to a depth of 30m.
26.1.6 Lacustrine Phosphates The most important lacustrine phosphate in Tanzania occurs at Minjingi Hill. Similar
occurrences are reported from the Pyramids, two conical hills 10 km south of Minjingu, and
at the Chali Hills in the central Dodoma Region. Another lacustrine phosphate occurs in the
Usangu Flats in southwest Tanzania.
26.1.6.1 Minjingu phosphate
The deposit occurs some 110 km southwest of Arusha. It was discovered in 1956 and has
been mined since 1983. Phosphate beds are inter-layered with greenish claystones, chert
beds and thin analcime bearing volcanic tuff beds. The deposit consists mainly of detrital
cormorant bones and vertebrae, fins, spines, etc. of cichlid fishes. The beds also contain
clastic silicate fragments, derived from the metamorphic rocks that form the centre of
Minjingu Hill which was an island in a palaeo-lake at the time of formation. (van Straaten,
2002)
Two types of phosphate ores have been identified at Minjingu, the 'soft' ore and the 'hard'
ore. The soft ore is composed of several up to 2-3 m thick, whitish-grey, coarse-clastic
phosphate bone beds which grade 22-25% P2O5. The hard ore surrounds Minjingu Hill,
overlying and rapidly grading into the soft phosphates below. The hard phosphate ore is
several metres thick and consists of indurated, massive, siliceous phosphorites grading
about 24% P2O5. Reserve calculations cited by the mine geologist (Mwambete, pers. comm.
July 1997 in van Straaten, 2002), were 3.3 Mt soft ore and 4.8 Mt hard ore.
Page 52 4 Growth Poles Phosphates
The relatively high uranium content of these phosphates (0.41-1.1 kg/t) could present a
health hazard to miners especially through inhalation of the dust and therefore miners should
wear masks on site (van Straaten 2002)
The Minjingu Phosphate Company (MIPCO) started to produce a concentrate in 1983 and
shipped it by truck and rail to the fertilizer plant in Tanga for processing into SSP, TSP and
phosphoric acid. However, the Tanga fertilizer plant closed in 1991. MEM (2005) indicates
that the ROM material averaged at 22% P2O5 and this was upgraded to 30% on site by dry
grinding and screening. It gives “reserves” at “slightly less than 10 Mt”.
In 2001 MIPCO was liquidated and sold to private investors. The new company, Minjingu
Mines and Fertiliser Ltd. (MMFL) revived mining (van Straaten, 2002, van Kauwenbergh,
2006). MMFL now markets their product as “Minjingu Organic Hyper Phosphate+”. It
produces about 165 ktpa of ROM ore and beneficiates it to 30% P2O5 through sun drying,
sieving and sorting and gravity classification (Minjingumines, 2013).
Page 53 4 Growth Poles Phosphates
27 UGANDA The most important resources in Uganda are around the Sukulu (Sigulu) and Bukusu
(Busumbu) carbonatite complexes near Tororo northeast of Lake Victoria.
Minor occurrences of phosphate are also known from the Budeda carbonatite, Butriku
(Sekululu) carbonatite, Toror Hills carbonatite, Totoro Hill, Fort Portal, Lake Kyekora and
Katwe-Kikorongo, but these probably have little potential (IFDC, 1998 in Appleton 2002).
27.1 Sukulu (Sigulu) This deposit (Figure 18) lies 6 km southwest of Tororo close to the Lake port of Jinja, and
near to the Kampala-Mombasa railway line. Appleton (2002) gives a resource of 230 Mt at
11-13% P2O5 in reddish soils of 15-67 m thick overlying the Sukulu complex. Apparently the
material has a very low reactivity and would require fine grinding before chemical
processing. These deposits have been mined from 1962-1978 and locally converted to SSP
using acid locally produced from imported sulphur.
Figure 18: Sukulu Carbonatite
Page 54 4 Growth Poles Phosphates
An MOU has been signed between India's Gujarat State Fertilizers and Chemicals Limited
(GSFC) and Nilefos minerals to develop the Sukulu mines. Nilefos Minerals is in advanced
stages of finalising the Resettlement Action Plan with the residents at the project site,
together with the help of the Government of Uganda. A court recently ruled in favour of
better compensation for over 6,000 residents in the 26 km2 radius in Osukuru and Rubongi
sub-counties where phosphate deposits occur (Sanya, 2013)
The Chinese firm (Guangzhou Dongsong Energy Group) has negotiated a 49 year lease to
mine 230 Mt of phosphates in an area of 26 km2 in eastern Uganda in the Sukulu Hills in
Tororo District. The firm will produce phosphate fertilizers and phosphoric acid in Uganda
(Tentena, 2013).
27.2 Bukusu (Busumbu) Lying 25 km north-northeast of Tororo (0° 50'12" N and 34° 15'55" E) this is a carbonatite
complex which measures 13 km in diameter. It is covered with eluvium of 30-60 m in
thickness. In places it is overlain by phoscrete with a content of some 25% P2O5 consisting
mainly of francolite. Appleton (2002) quotes reserves of >1 Mt at 21% P2O5. A resource of
50 Mt might be present (Notholt, 1994 in Appleton 2002).
Page 55 4 Growth Poles Phosphates
28 ZAMBIA Igneous phosphates in Zambia are associated with carbonatites and syenites. There are no
sedimentary deposits known.
28.1 Nkombwa Hill carbonatite Located in northeastern Zambia, some 25 km east of Isoka (10°09'S; 32°51'E), this is a 1.5 x
2.5 km carbonatite which is 689 ± 26 million years old (Tack et al. 1984 in van Straaten,
2002).
The main phosphate mineral at Nkombwa Hill is isokite (CaMg(PO4)F), together with
strontium-rich fluorapatite. The resource has been estimated at more than 200 Mt at 4.54%
P2O5. Analyses of the residual and transported soils at Nkombwa Hill have shown up to 10-
18% P2O5. Appleton (2002) indicates that there is no effective beneficiation method for
isokite.
African Consolidated resources plc has acquired the rights for the Rare earths and
phosphates at Nkombwa Hill (ACRPLC, 2010).
28.2 Kaluwe carbonatite. Kaluwe is located at the junction between the middle Zambezi, lower Zambezi and Luangwa
Rift Valleys in southern Zambia (15"10'S; 30°01'E). It is a sheet-like carbonatite, at least
250 m thick and on average of 1.5 km wide, and is folded into a northwest plunging syncline.
The main outcrop extends for more than 10 km from east to west. The resource is given by
Bwerinofa and Somney (1977) in van Straaten (2002) to be 207 Mt at 2.5% P2O5.
Beneficiation tests have shown that the recovery of apatite from this resource is difficult
because the apatite grains are intergrown with carbonates. However, the overlying soils
have a resource the 6.6 Mt at 11% P2O5 (10.8 Mt at 4.14% P2O5) (Sliwa 1991 in van
Straaten, 2002). Beneficiation tests have been encouraging, with a phosphate concentrate
of 30.4% P2O5 produced at a recovery rate of 73.8% (Mulela 1991 in van Straaten, 2002).
Niobium could form a valuable co-product.
Both the rock and residual soils have undergone successful testing for concentration with the
soils producing a 33% P2O5 concentrate with a 60% recovery (van Kauwenbergh, 2006).
28.3 Chilembwe phosphate deposit
Page 56 4 Growth Poles Phosphates
The syenite-related Chilembwe phosphate deposit is located at 13°59'S; 31°41'E, some
40 km northeast of Petauke in the Eastern Province is composed mainly of apatite and
quartz and apatite-biotite-amphibole rocks in syenite. The origin of the deposit is unknown
and some authors contend that it is of metasedimentary rather than igneous origin.
Mulele (1991) (quoted in van Straaten, 2002) calculated the reserves of the Chilembwe
deposit and reported the tonnage of two of the four phosphate ore bodies as:
Body No. 2 = 1.64 Mt at 11.8% P2O5 (at 6% P2O5 cut off),
Body No. 4 = 0.22 Mt at 9.9% P2O5.
These ores have been tested for concentration of the apatite and these have been
successful with high grade concentrates being produced. Orebody number two was
concentrated with gravity methods alone, whilst orebody number 4 required an addition of
magnetic separation but then gave an excellent concentrate of 36-38% P2O5 (% recovery not
given). Fines would have to be treated by flotation (van Kauwenbergh, 2006).
28.4 Mumbwa North phosphate deposit This syenite-hosted phosphate mineralization (at 14°45'S:26°50'E), is some 50 km northwest
of Mumbwa in the Central Province. Resource estimates indicate 0.5 Mt at 8-12% P2O5
(Sliwa 1991 in van Straaten 2002). The largest of the pegmatite bodies is estimated to
contain 0.22 Mt at 16% P2O5 with a cutoff of 5% P2O5 (Mulela 1991 in van Straaten, 2002).
Page 57 4 Growth Poles Phosphates
29 ZIMBABWE Zimbabwean rock phosphate resources are all associated with carbonatites. There are also
guano deposits but there are no known sedimentary phosphates.
29.1 Dorowa carbonatite The Dorowa phosphate mine is an opencut mine (see Figure 19) which is located in the
Buhera District at 19°04'S: 31°46'E along the tarmac road from Nyazura to Murambinda.
This carbonatite has hydroxyfluor-apatite mineralisation. In 2002 the northern ore body was
being mined at 3-3.5 kt per day. The ore was upgraded from 6.5% to 35-36% P2O5 at the
mine site through crushing, sieving, magnetic separation and flotation. The phosphate
concentrate was transported by road and rail to Harare, where SSP and TSP was produced
at the ZimPhos factory (van Straaten, 2002, van Kauwenbergh, 2006). Mining at Dorowa
involves ripping and dozing in soft rock and drilling as well as blasting in hard rock. Van
Straaten, (2002) indicates that the company Dorowa Minerals Ltd., claimed total measured
resources as being 72-78 Mt at 6.56% P2O5 (Barber 1991 in Van Straaten, 2002).
Dorowa is currently owned by Chemplex which is itself owned by the Zimbabwe
governments’ Industrial Development Corporation (IDC). Mhlanga (2013) indicates that the
IDC is looking for investors into Chemplex which is experiencing cash flow problems. In
November 2012 it was reported that Chemplex Corporation had shut down its subsidiary
Dorowa Minerals (the country's sole producer of phosphate) two months previously, citing
liquidity challenges. The problem apparently related to the fact that Zimphos was facing cash
flow challenges in purchasing other inputs for the production of fertiliser (Mugabe, 2012).
29.2 Shawa The Shawa alkaline ring complex, located at 19°12'S: 31°42'E in the Buhera District is about
5 km in diameter. The thick residual soils in the centre of complex are phosphate rich,
derived from weathering of the carbonatite. Phosphate resources of the residual soils were
calculated to be 20.3 Mt at 10.8% P2O5, plus a further 2.7 Mt at 16% P2O5. Shawa is
currently mined for vermiculite. The high-grade vermiculite (coarser grained) is located along
faults. The vermiculite occurs to a depth of 40 m, beyond which it transforms into phlogopite.
The life of mine is about 30 years (IMERYS, 2013).
29.3 Chishanya
Page 58 4 Growth Poles Phosphates
The Chishanya carbonatite complex at 19°45'S: 32°18'E in eastern Zimbabwe, is about
1.5 km wide and 5 km long. The northern part of the complex was estimated to contain 1.6 kt
of ore per metre depth with an average grade of 8% P2O5. Concentrates of up to 32% P2O5
were produced in the laboratory (van Straaten, 2002, van Kauwenbergh, 2006). Chishanya
is currently being assessed for its rare earth and phosphate potential by African consolidated
Resources plc. First stage drilling has been completed and the company is currently
undertaking flotation tests to ensure that the product can be upgraded (ACRPLC, 2012).
Figure 19: Dorowa Phosphate Mine
29.4 Katete The Katete carbonatite at 18° 09'S; 26° 53'E northeast of Hwange is intruded into sediments
of the Karoo Supergroup. Phosphates at Katete occur in the form of monazite and the
phosphorus content in the primary and secondary environment is low, ranging from 0.1 to
1.19% P2O5. Katate is currently being explored by Premier African Minerals for rare earths
(Premier, 2013)
Page 59 4 Growth Poles Phosphates
References
ACRPLC, 2010. African Consolidated Resources Plc Nkombwa Hill Rare Earths and Phosphate Project, Zambia. Accessed 1 July 2010. http://www.acrplc.com/Investors/News/2010/Nkombwa%20Hill%20Rare%20Earths%20and%20Phosphate%20Project,%20Zambia%2011.06.10.pdf
ACRPLC, 2012. Exploration, Development and Production in Zimbabwe and Zambia. Accessed 1 July 2012. http://www.acrplc.com/Investors/Presentations/Investor%20Presentation%20-%20website.pdf
Appleton JD, 2002. Local phosphate resources for sustainable development in sub-Saharan Africa. British Geological Survey. Report CR/02/121/N
Baobab, 2013. Muande Magnetite / Phosphate Joint Venture. BaobabResources plc website. Accessed 27 June 2013. http://www.baobabresources.com/projects/mt-muande
Blair D, 2011. US finds ‘world-class’ phosphate in Iraq. Financial Times, September 7, 2011. Accessed 25 June 2013. http://www.ft.com/intl/cms/s/0/a7b82096-d969-11e0-b52f-00144feabdc0.html#axzz2XEQOOMEv
Business Times, 2013. MPA secures Egypt's rock phosphate. Tuesday, June 25, 2013. http://www.btimes.com.my/articles/20130404114118/Article/ Accessed 25 June 2013.
Business Week, 2013. Take care with phosphates find. East African Business week. Wednesday, 29 May 2013 Accessed 27 June 2013. http://www.busiweek.com/editorial/editorial/5204-take-care-with-phosphates-find
Callaghan C (compiler) 2002. Mineral scan of the Zambezi River and Beira Corridor Spatial Development Initiatives. 247p.
Callaghan, C. (compiler) 2002b. Mineral scan of the Nacala Spatial Development Initiative Key Findings. Mintek Restricted Client Communication (unfinished) 47p.
Cradle, 2013. Cradle to acquire the Panda Hill Niobium Project , Tanzania. Asx/Media announcement, 2p. Accessed 2 July 2013. http://www.asx.com.au/asxpdf/20130403/pdf/42f0wgsb326lbm.pdf
De Ridder M, de Jong S, Polchar J and Lingeman S, 2012. Robust Strategies in Times of Uncertainty The Hague Centre for Strategic Studies No 17 | 12 | 12. Accessed 25 June 2013. http://www.hcss.nl/reports/risks-and-opportunities-in-the-global-phosphate-rock-market-robust-strategies-in-times-of-uncertainty/116/
FAO, 2011. Current world fertilizer trends and outlook to 2015. Food And Agriculture Organization of the United Nations. Rome, 2011. Accessed 27 June 2013. ftp://ftp.fao.org/ag/agp/docs/cwfto15.pdf
Finlayson R, 2012. Australian Miner Boasts Angolan Treasure Trove of Gold, Rare Earths, Metals and Minerals. Released April 19, 2012 Accessed 28 June 2013. http://www.blackfireminerals.com.au/IRM/Company/ShowPage.aspx/PDFs/1295-36963572/AustralianMinerBoastsAngolanTreasureTrove
FOSKOR, 2012. Integrated annual report. 31 March 2012. Accessed 26 June 2013. http://www.foskor.co.za/pdf/annual_reports/ar_2012.pdf
Page 60 4 Growth Poles Phosphates
Galileo, 2013. Galileo Resources plc. Annual Report, 2013. 70p. Geo-Consult, 2012. Glenover Carbonatite Geological and Resource Report - August 2012.
Geo-Consult International (Pty) Ltd. Accessed 26 June 2013). http://www.galileoresources.com/projects/Glenover%20Geological%20and%20Resource%20Report%203%20August%202012.pdf
Ghebre WM, 2010. Geology and Mineralization of Bikilal phosphate deposit, Western Ethiopia, implication and outline of gabbro intrusion to East Africa zone. Iranian Journal of Earth Sciences 2 (2010) / 158-167. Accessed 29 June 2013.
IDC, 2011. Chemplex corporation limited. Accessed 23 March 2011. www.idc.co.zw/index.php?option=com_content&view=article&id=38&Itemid=52
IFA, 2013. International Fetilizer Association Website. Accessed 25 June 2013. http://www.fertilizer.org/ifa/HomePage/STATISTICS
IMERYS, 2013. About Shawa Mine. Company website accessed 2 July 2013. http://www.imerysvermiculite.com/sm_about.htm
Jara, 2013. The Jara Exploration website. Accessed 26 June 2013. http://www.jaraexploration.com/
Jasinski SM, 2013. Phosphate Rock. U.S. Geological Survey, Mineral Commodity Summaries, January 2013. Accessed 25 June 2013. http://minerals.usgs.gov/minerals/pubs/commodity/phosphate_rock/mcs-2013-phosp.pdf
MEM, 2005. Tanzania. Opportunities for mineral resource development. Ministry of Energy and minerals, United Republic of Tanzania. 130p
Mhlanga P, 2013. Chemplex Seeks Fresh Capital. The Financial Gazette, 27 Jun 2013. Accessed 1 July 2013. http://www.financialgazette.co.zw/?p=43943
Minbos, 2012. Emerging African Phosphate Developer. Investor Presentation, January 2012. Accessed 25 June 2013. http://www.proactiveinvestors.com.au/genera/files/companies/minbos_presentation.pdf
Minbos, 2013. West African Focused Phosphate Developer. The Next Generation: Preparing for Production. Investor update May 2013. Accessed 28 June 2013. http://www.minbos.com/assets/documents/presentations/mnb-marketing-presentation-may-2013.pdf
Minjingumines, 2013. Minjingu Mines and Fertiliser Ltd. Company Website. Accessed 1 July 2013. http://minjingumines.com/link7.htm
Mugabe T, 2012. Zimbabwe: Dorowa Mine Shuts Down. The Herald. 27 November 2012. Accessed 1 July 2013. http://allafrica.com/stories/201211270377.html
Myinvestorguide 2013. Interview: Murilo Ferreira, CEO of Vale do Rio Doce. Accessed 26 June 2013. http://www.myinvestorguide.com/#!murilo-ferreira/c1j23
Notholt AJG, Sheldon RP and Davidson DF, 2005. Phosphate Deposits of the World Volume: 2 Phosphate Rock Resources. ISBN:9780521673334. 600p. Cambridge Earth Science series.
NPK 101, 2013. N_P_K world website. Accessed 27 June 2013. http://npk101.wordpress.com/category/phosphate-fertilizers/
Page 61 4 Growth Poles Phosphates
Premier, 2013. Katete REE Project. Company Website, Accessed 1 July 2013. http://www.premierafricanminerals.com/page.php?pID=22&ppID=3
Regency, 2013. Regency mines. Accessed 30 June 2013. http://www.regency-mines.com/files/7013/6603/6431/RGM_April2013_presentation.pdf
Roux EH, de Jager DH, du Plooy JH, Nicotra A, van der Linde GJ and de Waal P, 1989. Phosphate in South Africa. J. S. Atr. Inst. Min. Metal/., vol. 89, no. 5. May 1989. pp. 129-139. http://www.saimm.co.za/Journal/v089n05p129.pdf Accessed 25 June 2013.
Sanya S, 2013. Uganda: Sukulu Phosphate Mines to Get Sh535 Billion Boost. 26 January 2013. New Vision. http://allafrica.com/stories/201301280297.html Accessed 2 July 2013.
Sudan News Agency, 2011. Sudan: Discovery of Big Quantities of Phosphate in the Northern States. 2 August 2011. http://allafrica.com/stories/201108030695.html Accessed 1 July 2013.
Tentena P, 2013. Uganda: China to dig for phosphates in Uganda. East Africa Business Week. Accessed 1 July 2013. http://allafrica.com/stories/201305221144.html
Van Kauwenbergh S, 2006. Fertilizer Raw Material Resources of Africa. IFDC, 454p. Accessed 27 June 2013. http://www.inter-reseaux.org/IMG/pdf/02_Van_Kauwenbergh--Fertilizer_Raw_Material_Resources.pdf
Van Kauwenbergh S, 2010. World Phosphate Rock Reserves and Resources. IFDC, September 2010. http://pdf.usaid.gov/pdf_docs/PNADW835.pdf Accessed 24 June 2013.
Van Kauwenbergh S, 2011. Phosphate Forecast: How Far Can We Go (How Deep Can We Dig?). Centre for the Development of Fertilizer Technology, Universidade Federal de Uberlandia, October 2011. Accessed 25 June 2013. http://www.cefert.feq.ufu.br/gerenciador/uploads/arquivos/Steven-Van-Kauwenberg-Centre-for-the-Development-of-Fertilizer-Technology.pdf
Van Straaten. P. 2002. Rocks for crops. Agrominerals of sub-Saharan Africa. ICRAF, Nairobi, Kenya, 338pp.
Verona, 2013. Verona Capital website. Accessed 2 July 2013. http://www.veronacapital.com.au/about-us/recent-presentations.html
Waldo, 2013. Namibia: Phosphates in Okuruso Tailings for Crop Fertiliser. Namibia Economist. Accessed 3 July 2013. http://allafrica.com/stories/201303010994.html
Wilson MGC, 1998. Phosphate. In: The Mineral resources of South Africa (Wilson MGC and Anhaeusser CR, eds) Handbook, Council for Geoscience, 16 p 525-531.
Yager TR, 2013. The Mineral Industry of Congo (Kinshasa) U.S. Geological Survey Minerals Yearbook—2011. May 2013. pp11.1-11.9.
Page 62 4 Growth Poles Phosphates
APPENDIX I. DEPOSIT SIZE CATEGORIES (KT)
Past production plus RESOURCES in CONTAINED metal/product up to…
Commodity Size 5 Size 4 Size 3 Size 2 Size 1 Size 0 Chrome 100, 000 10,000 1,000 100 10 or unknown
Coal 5,000,000 1,000,000 500,000 100,000 50,000 10,000 or unknown
Copper 5,000 1,000 100 50 5 1 or unknown
Iron 1,000,000 100,000 10,000 5,000 1,000 100 or unknown
Lead 1,000 200 50 10 5 or unknown
Manganese 500,000 100,000 10,000 1,000 100 10 or unknown
Natural Gas (bcm) 1,000 500 100 10 1 0.1 or unknown
Oil (Mbls) 10,000 1,000 100 10 1 0.2 or unknown
Phosphate 5,000,000 1,000,000 100,000 10,000 1,000 100 or unknown
Vanadium 1,000 500 100 50 5 1 or unknown
Zinc 5,000 1,000 200 50 10 5 or unknown
Nickel 1,000 500 100 50 10 1 or unknown
Page 63 4 Growth Poles Phosphates
APPENDIX II. LISTING OF DEPOSITS
Name State Com Size Province Status Latitude (° )
Longitude (°E)
Lucunga Angola P 2 Huambo Deposit -12.8266 15.6705
Chivovo Angola P 2 Cabinda Prospect -4.9576 12.3
Cacata Angola P 2 Cabinda Prospect -5.157 12.48
Ueca Angola P 3 Cabinda Prospect -5.0426 12.27
Mongo Tando Angola P 3 Cabinda Prospect -5.05 12.15
Moampoate Angola P 3 Cabinda Prospect -4.975 12.24
Chibuete Angola P 3 Cabinda Prospect -4.92 12.21
Matongo Burundi P 2 Kayanza Deposit -3.05 29.62
Lueshe DRC P 0 North Kivu Mine -0.986 29.14
Kanzi Project DRC P 2 Bas Congo Prospect -5.457 12.64
Red Sea Deposits Egypt P 2 Red Sea Governate
Mines 26.3 34.1
West Sabaiya Egypt P 4 Western Desert Mine 25.171 32.66
Abu Tartur Egypt P 4 Western Desert Mine 25.38 30.09
East Sabaiya Egypt P 5 Eastern Desert Mine 25.198 32.76
Bikilal Ethiopia P 3 Welega Deposit 9.32 35.88
Mrima Hill Kenya P 1 Kwale Deposit -4.49 39.26
Tundulu Hill Malawi P 1 Southern Deposit -15.5333 35.8
Evate Mozambique P 3 Nampula Prospect -14.8585 40.241
Sandpiper Namibia P 4 Offshore Prospect -24.4 13.8
Schiel Complex South Africa P 2 Limpopo Deposit -23.166 30.45
Langeberg South Africa P 2 Western Cape Mine -32.966 18.111
Glenover South Africa P 2 Limpopo Prospect -23.8688 27.1628
Elandsfontein South Africa P 2 Western Cape Deposit -33.09 18.17
Foskor Mine South Africa P 4 Limpopo Mine -29.9656 31.1255
Agulhas Bank South Africa P 5 Offshore Deposit -35 22
Minjingu Tanzania P 2 Manyara Mine -3.7 35.87
Panda Hill Tanzania P 3 Mbeya Mine (9.0100) 33.2300
Sukulu Uganda P 3 Busia Prospect 0.64 34.16
Kaluwe Zambia P 2 Lusaka Deposit -15.052 29.997
Shawa Zimbabwe P 2 Manicaland Deposit -19.2 31.7
Dorowa Zimbabwe P 2 Manicaland Mine -19.065 31.77
Source: Own Data, Internet articles, Google earth, http://pubs.usgs.gov/of/2009/1045/ASCII/Ni_Cr_PGE.txt, http://mineral-resources.findthedata.org
Page 64 4 Growth Poles Phosphates
APPENDIX III. ROCK PHOSPHATE MINERALS
Mineral Chemical formula Apatite group Ca5 (F,Cl,OH)(PO4)3 - Hydroxylapatite Ca5OH(PO4)3 - Fluorapatite Ca5F(PO4)3
- Francolite (variable composition) (Ca, Mg, Sr, Na)10F2�3(PO4, SO4, CO3)6 - Chlorapatite Ca5Cl(PO4)3 Gorciexite BaAl3(PO4)2(OH)5.H2O Monazite (Ce,La,Nd,Th)PO4
Isokite CaMg(PO4)F
Regional Integration Research Network | TradeMark Southern Africa+27 12 349 7500 www.trademarksa.org/rirn | [email protected]
ABOUT TRADEMARK SOUTHERN AFRICA
Trade Mark Southern Africa (TMSA) is a UKAid supported project that works with the Common Market for Eastern and Southern Africa (COMESA), the East Africa Community (EAC) and the Southern African Development Community (SADC) Tripartite to lower the physical, political and economic barriers that isolate national economies. The purpose of the programme is to improve southern Africa’s trade performance and competitiveness for the benefit of poor men and women.
TMSA’s activities address current constraints to trade. By supporting regional collaboration through the enabling environment in the COMESA-EAC-SADC Tripartite area, TMSA is helping African countries to unleash their full potential. For more information about TMSA please visit our website at www.trademarksa.org.