4
For dependable service, it is of utmost importance that instructions given below are followed for selection, inspection, installation, commissioning, operation and maintenance. Semi-Automatic Star Delta Starter Our new SASD -11 starter complies with the latest standards IS13947 and IEC947 Installation: Remove the front cover. Mount the starter on a vertical wall / plate free from vibrations with proper nuts and bolts. Refer fig. 9 for mounting dimensions and fig. 4 for permissible displacement. Remove the rubber grommets for the incoming and outgoing cable connections. Connect incoming and outgoing cables as follows (Refer fig. 3): Use proper cable glands to ensure dust proofing. For conduit entry use packed washers. Select correct size of cables from Table-1 Connect line and motor leads exactly as per wiring diagram pasted inside the cover of the starter. Terminate the incoming cable on the terminal block. Terminal Screws : M5; Tightening torque : 150 210 Ncm. Connect outgoing cables on the Relay (K1) terminals and Delta Contactor (Q3) terminal. Terminal Screws: M4; Tightening torque : 80 110 Ncm. Connect the earthing conductor to terminals marked (earth) on the starter body. The Starter in now ready for commissioning. Selection: Refer Table 1 for recommended selection of SASD starters. Select Back-up fuse rating for different starters from the selection tables. The recommendation of the fuses and fuse switches is according to Type-2 co-ordination as per IS-13947 (Part 4 / Sec 1) and IEC947-4-1. Inspection: Remove the Housing Cover. Ensure that the relay range and coil voltage are as per your requirement. Inspect interior for breakage. If you find a serious defect, do not use the product but have it checked by an authorized Siemens dealer or an electrician. Fig. 1 : SASD-11 Starter Fig. 2 : Starter Front View À Á Â Ã Ä Å Æ Ç À ON Push Button Á OFF Push Button  RESET Push Button à Earthing Screws Ä Rubber Grommets Å Name Plate Æ Incoming Cable Ç Outgoing Cables È Cover Fixing Screws Fig. 3 : Cable Connections È I Operating Instructions Hazardous Voltage can cause Electric Shock and burns. Disconnect Power before proceeding with any work on this equipment Warning: ! Kanchan Eneterprises Ph.no.-2533 3226 / 4766 Email id- [email protected]

S903 - Semi-Automatic Star Delta Starter - Kanchan …kgrp.in/pdfs/simens/Semi-Automatic-Star-Delta-Starter.pdfS903 - Semi-Automatic Star Delta Starter.p65 Author VIVEK Created Date

  • Upload
    vukiet

  • View
    245

  • Download
    5

Embed Size (px)

Citation preview

Page 1: S903 - Semi-Automatic Star Delta Starter - Kanchan …kgrp.in/pdfs/simens/Semi-Automatic-Star-Delta-Starter.pdfS903 - Semi-Automatic Star Delta Starter.p65 Author VIVEK Created Date

For dependable service, it is of utmost importance that instructions given below are followedfor selection, inspection, installation, commissioning, operation and maintenance.

��������������� �������� �� ��������������� �������������� �������������� �� ������� �������������������

������������

� ���!������"�������!��#

� $��������� ������������!����������� % ������"����"����!�&������ ��������������� �����&��� # �"���"�'#���"����������'����� ��� �����"�'#���"������� �&����� ���������#

� ���!��������&&���'������ "��������������'��������'���'��&������������� #

� ���������������'��������'���'��&�� �� �"����� �( �"���"�'#��)*

+ , �����������&���'���� ����� ������ ������"��'#�-��������������.�� �����/���� ��� #

+ ��������������� �0���"���&�� "����1�&����

+ �������������������������� ��2����.�� ����������'���'������ ������ ���������!����"����� ������#

+ 1��������������������'��&�������������������&���/#1������������� �*�$341�'������'����5���*�36�+�7�6�8��#

+ �����������'���'���&�� ������� ���.�(9�)��������� �������������������(:�)��������#�1������������� *$�4�1�'������'����5���*;6�+���6�8��#

� �������������������'��������������������� ����/��� ��(�����)������� �������&��.#

1����������������������.�"������� �����'#

��������

� �"���1�&�����"�������������� ����������"���� ������ #

� �������<��/����"� �������'�"����""������ ������ �"������� �����������&�� #�1������������������"�����"� � ����"� �� ������ �� ���������'���1.���7���������������� �������������(=����� % �����)��������������#

��� ������

� ���!������>�� ��'���!��#

� �� �����������������.����'����������!����'������� �����.�����5��������#

� �� ��������������"���&���/�'�#

� �"�.���"������ ����� ���"���?�������� ��������������&����!���������/���&.����������0��������� ������������������������#

-�'#���*��������������

-�'#�7�*���������-�����@���

��

� �8�=� ��<�����

� �--�=� ��<�����

� ���1�=� ��<�����

� �������'������

� �&&���A������

� 8����=����

� �������'���&��

� ���'���'���&��

��!���-�2��'�����

-�'#���*���&�������������

� ���������������������

���������������������������������������������������

� ��������=�����&�"�������������'�������.����/������� ��5�������

� �����!

Kanch

an E

neter

prise

s

Ph.no.-

2533

3226

/ 476

6

Email id

- e@

kanc

hana

nand

.com

Page 2: S903 - Semi-Automatic Star Delta Starter - Kanchan …kgrp.in/pdfs/simens/Semi-Automatic-Star-Delta-Starter.pdfS903 - Semi-Automatic Star Delta Starter.p65 Author VIVEK Created Date

-�'#�B�*���������'����������� ��� ��"��,C36�����.

�������������

������������������������������ ��������������������#

+ �!�����������.���������� ��� � ��������"�'#B����&��� ������� �����������!���'���������'����������""�������������� ��"� ���������#

+ ��������� ���������"������2#�����#�&�"������� ��'����&����/��&������������.����� �����#

� ���������������!"���������������������������������������������� ����������������������� �����������������#�$%����������������������������������������� �����

� ����������� ���� ���&���'����������������������������������������������� ���������������(���� �������� ����������� ��������������������������'�����������������������������

� �����������������������

1���'�!������������� ��� �("�'#�B)�����!���'��!���� ��"��������'� ���� �0� ��"�&�����������. �������������.���������������������������!�� ������������������������� ��� �"����� ���#�1����������'����� ���������"�������. � ������'�"������������ ����#�����������'����������� �(����������������������)���� ������������������&���73D��"�����!������&�������"����������������� ��� #

� �������

� -��� ������'����������?���� A������� ��&���������/���E�F("�'#�7)?���������"���B�;� ��( ������'�������"����������)#1�������!������E�8F�&�����#$����������������������.�����'������E����F������������"���E����F�����������#

� -��� ������'�������������� ����� ��&���������/���E�E("�'#�7)#

Fig. 4 : Maximum permissibledisplacement from vertical plane

� ��������.� ��������!�����������.���6#3;����� �����������������������#

-����2���� �����'��"��!�����������.?"������������ �������� �'�!��&�����*

)�������'���������*�������������+������������������

� �������'������������"�������*

+ -�� �� ���������������&.��� ��'�����E�8F�&����� ��������"�'#7�������������"��;��6� ��#�1�������!������E�8F&�����#�$���������������������.�����'�������E����F�����������#

+ $�� ���������������/���&.������������������.������������ �������� ����.� ����������������������(������������������������������ �� ����.����)#

+ ��������������#

� �!�����������.� �����'*

+ -������ �������������� �������!�����������.������������� ����������� ���� ����&.�����������#��������& ������"�����������?� ����������������'�!��&����*

+ ������������������������������"����6���� #�1����'�������.���������������.� �����'������������ #�������������.����� ��'���.���'����!������������ � �����'#

-�'#�3�*� ���.�-�����@���

$�2������3�

����� �&��

)��������,���

��-�����������!�-�!���������

+ �� ����������������"��� ��������#��"���������.���� ����������������� �����������&��������.� ��#��"�������� ?� ����������������'����!���������&�"��������������/#

� -�2�����"�������!��#

�������

� "������������������������������������'� ������������������������ � ����������������� ��'���������������������'�����

Kanch

an E

neter

prise

s

Ph.no.-

2533

3226

/ 476

6

Email id

- e@

kanc

hana

nand

.com

Page 3: S903 - Semi-Automatic Star Delta Starter - Kanchan …kgrp.in/pdfs/simens/Semi-Automatic-Star-Delta-Starter.pdfS903 - Semi-Automatic Star Delta Starter.p65 Author VIVEK Created Date

� ����� ��.������������ ���������&�����E���"� � ��F�����?�����&���/��&������������.�� ����&���� �������������������������������/�� �����������?� ������������� ������ ������EF?������� ��'��� �"�� ����������� ��"���#������ �������!����"���������.����� ����!������?���������&�������������.��� ���������2������"��������� #�1������������&���� ����������.�"������������.�� ��� ���(-�'#�3)#

� ���������� ��������"���� �����'?���� �<����&��������/���E F��"���������.��� ����������������!������#������� �� ����������������&���� ���������.��"����.����� �����������.#���������������������"����� #�<�"������ �����'���#

.����������

� 9������������������� ��"���#

� ����'������������������ ���� "����������������#

� 8��������������� ��������"���!�����������.#�=��� ���������������������.#

� <���/����'��"� ��!��%����.��������� ���� ������""�����������������"�#��"����� ��.?����������������� ��"���������������� ��7�7B#� ���!�����'��&��� �������� ������������ ��������!����������������"����#,�������������� ����� � ���������������� �&��"����������� ��� ��������������������������������"����� ������.#

� �"������������������ ?������������'�������� �������� �"�������#

� �������������� ��"���������������"����.����� �!����.������������������.��6D��"�������'����������������������� #�-�������� ��"������������������������"����������EA������������������� ����������G$����������F#

� ������������"��!������� ���.( �"���-�'#���G�;)�*

+ ���!��

�# � ���������������� ���������������������.�������� #

7# ���'���.���� ���������'���'���������� ���� �"�������������������#

�# -�������� �������� �'�!�����-�'#���"�������!����"����.#

+ �"�2��'

�# ��������������������.�2����.�� ������������'����#

-�'#�;�*� ���.� �"�2��'

-�'#���*� ���.� ���!��

/��������������01

����

7# ����������������.�������� �(H�?H7?H�)���(1�?17?1�)��"�:���������������

�# �"���-�'#�;�"��������� #

��������������������������+�������� �������������������+��� �����������'�����2����%

�# �� �����������������.���/�� ���'�'��������� �����������&� �������#

3# 1�'��������������������������� ���� #

B# ��������������� �������������� ��������/����������� �&.��"�����'�������������'���'���#

Kanch

an E

neter

prise

s

Ph.no.-

2533

3226

/ 476

6

Email id

- e@

kanc

hana

nand

.com

Page 4: S903 - Semi-Automatic Star Delta Starter - Kanchan …kgrp.in/pdfs/simens/Semi-Automatic-Star-Delta-Starter.pdfS903 - Semi-Automatic Star Delta Starter.p65 Author VIVEK Created Date

������ �H��# I=���������!���������� ������������ ������ #���� �5�����.������������������������� ����"����� � �&J�����������'���������������������#�-������� ��� ������������������� ��""���#I

�=�666;�6�����B�66�= ��6;6�736

3�����1 ���-!������������-"������������3 ������43#5�6#-#!77

$���� �("�) �("�) ��������� ��������� ���������� ���������� ���������������� �=��� �=��� H��� ����%���� �!������������.����36�� -� �� ����� �����&��� �0������3@ 5������ 5������ 1.�� <��/��� �����������������(��7)

��'������� ��'������� > ��"� � �������' ���'���'H����������� =�� � ������� 1.�� 1.�� ����' ("���� ����.) (��������)

(9C%>=) �� ;�;�%�7;� �� ;�;�%�7;� �"������ �"������ ��'� ()() () �) �) 1.�� ()

�#3%�6 �3#� ;#; �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK B����6 �9H�� 73 � 7#3

�#�%�7#3 ��#3 ��#7 �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK ;��7#3 �9H�� 73 � 7#3

��%�3 7� ��#7 �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK �6��B �9H�� �7 � 7#3

�3%76 �7 �;#� �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK �7#3�76 �9H�� 36 �6 �

�;#3%73 �;#3 77#7 �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK �B�73 �9H36 36 �6 �

�����������8�� ���������

�#3%�6 ��#3 ��#7 �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK ;��7#3 �9H�� 73 � 7#3

�#�%�7#3 73 ��#� �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK �6��B �9H�� �7 � 7#3

��%�3 7� �B#� �1C6��76�6K3� �1C6�����6K3� �,C3�667�KK �7#3�76 �9H�� 36 �6 �

��������� K�( �"���1�&���7�"���!����'������ )�������KK�( �"���1�&�����"������� )

3�����5

������������ ./2)

7�6@��66@

��3@ C

3�����4

���� ����������

9!:

B#�����6 �L;�����7#3 �9�6����B 7�7#3���76 7<�B���73 7�

3�����;

���-"�����3����

�� ���������� �����*�

7�6@���3@ 7��3��6�66�

-�'#���*����� �����������

Kanch

an E

neter

prise

s

Ph.no.-

2533

3226

/ 476

6

Email id

- e@

kanc

hana

nand

.com