SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR · A weekly clean using water and 30% vinegar or a mild detergent is all it takes to remove dirt, soap scum and other contaminants. Spray

SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR

Disclaimer: Products in this specification manual must by regulation be installed by licensed and registered trade people. The manufacturer/distributor reserves the right to vary specifications or delete models from their range without prior notification. Dimensions are nominal measurements only. Dimensions and set-outs listed are correct at time of publication however the manufacturer/distributor takes no responsibility for printing errors.

Tech Page Version 1

To see the complete CUSTOM GLASS range go to www.reece.com.au/bathrooms

CLEANING RECOMMENDATIONSWe recommend the use of soapy water or approved cleaners.

This product should not be cleaned with abrasive materials.

Damage caused by any improper treatment is not covered by the product warranty - refer to Warranty Conditions.

Please refer to detailed Cleaning Instructions on page 14.

SPECIFICATIONS Recommended use Domestic, Hotel, and Commercial

Material Screen-6mm Clear Toughened Glass. Glass Infill- 5mm Clear Toughened Glass.

Australian Safety Standards Compliant.

Floor Suitability Tiled Floor Installation

Door Opening Option Left or Right

Handle Standard Knob

Frame & Support Rail Colour Polished Silver

Optional Extras 1789912 - Installation Charge

1791295 - Shower Screen Removal

SIZE VARIATIONSCode SIZE ADJ FRONT DOOR SIZE INFILL GLASS HEIGHT

1789864 900 820-900 702 180 1950

1789865 1000 980-1060 702 340 1950

1789866 1200 1140-1220 702 500 1950

1789867 1500 1460-1540 702 840 1950

page 1 of 14


Dimensions are shown in MillimetresDimensions are nominal measurements only.

1950

975

975

73.5

73.5

1803

Min 820 Max 900

820

Min 820 Max 900

180 548

55

702100

page 2 of 14


980

Min 980 Max 1060

340 548

55

702100

1950

975

975

73.5

73.5

1803

Min 980 Max 1060

page 3 of 14


1950

975

975

73.5

73.5

1803

Min 1140 Max 1220

1140

Min 1140 Max 1220

500 548

55

702100

page 4 of 14


1950

975

975

73.5

73.5

1803

Min 1460 Max 1520

1460

Min 1460 Max 1520

840 548

55

702100

page 5 of 14

SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOORImportant NoteINSTALLATION INSTRUCTIONS

-2-

Important Pre-Installation Information

- Please read this entire instruction book before commencing installation.

- A licenced tradesman must be used for the Leave-

care. with handleand moment possible last the until corners glass the on protectors plastic the

installation.

-

* Use the correct type of drill bit for the material being drilled, with 6mm required for anchor fixing and 3mm used for

screwing directly into the wall studs.

** As with all toughened glass, take care while handling and wear safety goggles and gloves for personal protection.

Silicone Sealant Drill Level Rubber Mallet

Pencil Phillips Screwdriver Tape Measure

Utility Knife

Cutting Pliers

8mm 5/16( ") and3mm (1/8") Drill Bits Safety Goggles Gloves

If water alone is not enough to clean the glass, Custom Glass recommends the use of mild

Maintenance

Tools Required

detergent solutions only.

Custom GlassSHOWER SCREENFRONT ONLY

- Branch

Reece Local your Through arranged be Can Installation Required If

8

page 6 of 14


G

X1

X7/X10/X12/X13

Drill's Not Supplied

X1

X7

X1

X2

X2 X1

X1

ST4X35 X7

ST4X35 X7

ST4X10 X7/X9

Componets Front OnlyA Boxfor

Handle

Door

Infill

Wall Plugs

Top Caps

Rail

Door Seal

Fixings

Screens fabricated pre are

wide 1220 to up

10

COMPONENTS

Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference

page 7 of 14


Semi Fra em d Pivot 80mm Adjustment

BoxFront Only

A Type

Custom Glass

6mm Clear ToughenedGlass Door

5mm Clear Toughened Glass Infill Panel

Door

Infill Panel

9

page 8 of 14


12

3

7

4

6

5

8

9

10

Custom

FRONT SCREEN SHOWERONLY

Glass

Item's assembled

pre are 2 and 1

11

INSTALLATION INSTRUCTIONS

page 9 of 14


b

a 3 3

a

7 7

4 4

b 2.2 2.1

Custom

FRONT SCREEN SHOWER ONLY

Glass

Item level be must

Channels Wall G

Close

Channel. wall opposite the into and out Screen the Extend and Channel Wall opposite the with

up Screen the Line Channel. wall the toin screen of side infill push Minimun, theto Screen

Minimum

Maximum

12

Don’t risk it, use a licensed plumber.™

page 10 of 14


c

c

5

6 1

2

d

9

d

CustomFRONT SCREEN SHOWERONLY

Glass

Align

gap even an achieve

to this reverse to need may You

direction. opposite the in Bottom the

and channel the into posible as far as top the pushing

by adjusted be can this even.

is gap the sure making rail, Head

the with door glass the of top the

Only rail head the with level is

door the once 5# off fit

page 11 of 14


e e

B. 4 10

B. 1

B. 2 B. 3

f f

8

CustomFRONT SCREEN SHOWER ONLY

Glass

Top Channels Wall of

top cover to Caps

14Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference

page 12 of 14


48 H

CustomFRONT SCREENSHOWERONLY

Glass

Silicone Supplied Not

Silicone

outside the on rail bottom

the seal Only out. and inside Channels Wall

both Down

15

page 13 of 14


DETAILED CLEANING INSTRUCTIONS

Easy Clean Treated Glass

After showering we strongly recommend you squeegee the glass to remove water from the surface.

A weekly clean using water and 30% vinegar or a mild detergent is all it takes to remove dirt, soap scum and other contaminants.

Spray the vinegar and water on the glass and wipe with a soft cloth, leave this on the sur-face for several minutes before rinsing and drying the glass.

Aluminium Frame and Metal ComponentsThe simplest and most preferred method of cleaning your unit is by washing with clean water and drying with a soft cloth.

Do not use Abrasive powders, steel and Teflon pads or dirty and gritty rags. The anodised coating on the Aluminium is one of the hardest substances known, however, it will be dam-aged by strong acidic or alkaline solutions. These solutions may dull and discolour the finish.

The most reliable preventative measure to preserve your screen is to wipe the surface dry with a soft cloth after each use.

Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference

page 14 of 14

Documents

SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR · A weekly clean using water and 30% vinegar or a mild detergent is all it takes to remove dirt, soap scum and other contaminants. Spray