52
LENNOXOEMPARTS.COM FIGURE 1 G26 FURNACEY AG26 HEAT EXCHANGE ASSEMBLY Combustion Process: 1. A call for heat starts the combustion air blower. 2. Outdoor air is drawn through pipe into the burner compartment where it mixes with gas in a con- ventional style inshot burner. 3. The SureLight ignition system lights the burners. 4. Combustion products are drawn downward through the heat exchanger. Heat is extracted as indoor air passes across the outside surface of the metal. 5. Latent heat is removed from the combustion products as air passes through the coil. Conden- sate (water) is formed as the combustion prod- ucts cool. 6. As the combustion products exit the coil, con- densate is collected and drained away. 7. Combustion products are pulled from the heat exchanger and forced into the flue. 7 5 4 6 2 3 1 Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. Corp. 9721-L11 G26 Service Literature Revised 07-2001 G26 SERIES UNITS G26 series units are high-efficiency upflow gas furnaces manufactured with DuralokPlust aluminized steel clamshell-type heat exchangers. G26 units are available in heating capacities of 50,000 to 125,000 Btuh and cooling applications up to 5 tons. Refer to Engineering Handbook for proper sizing. Units are factory equipped for use with natural gas. A kit is available for con- version to LPG operation. G26-1 and -2 model units use electronic (intermit- tent pilot) ignition. G26-3, -4, -5 and -6 model units feature the Lennox Sur- eLightT silicon nitride ignition system. Each unit meets the California Nitro- gen Oxides (NO x ) Standards and California Seasonal Efficiency require- ments without modification. All units use a redundant gas valve to assure safety shut-off as required by A.G.A. or C.G.A. Information contained in this manual is intended for use by qualified service technicians only. All specifications are subject to change. Procedures out- lined in this manual are presented as a recommendation only and do not su- persede or replace local or state codes. In the absence of local or state codes, the guidelines and procedures outlined in this manual (except where noted) are recommended only.

Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

Embed Size (px)

Citation preview

Page 1: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

FIGURE 1

G26 FURNACEYAG26 HEAT EXCHANGE ASSEMBLY

Combustion Process:

1. A call for heat starts the combustion air blower.

2. Outdoor air is drawn through pipe into the burnercompartment where it mixes with gas in a con-ventional style inshot burner.

3. TheSureLight ignitionsystemlights theburners.

4. Combustion products are drawn downwardthrough the heat exchanger. Heat is extractedas indoor air passes across the outside surfaceof the metal.

5. Latent heat is removed from the combustionproducts as airpasses through thecoil.Conden-sate (water) is formed as the combustion prod-ucts cool.

6. As the combustion products exit the coil, con-densate is collected and drained away.

7. Combustion products are pulled from the heatexchanger and forced into the flue.

7

5

4

6

2 3

1

Page 1 1997 Lennox Industries Inc.

Litho U.S.A.

Corp. 9721-L11

G26Service Literature Revised 07-2001

G26 SERIES UNITSG26 series units are high-efficiency upflow gas furnaces manufactured withDuralokPlust aluminized steel clamshell-type heat exchangers. G26 unitsare available in heating capacities of 50,000 to 125,000 Btuh and coolingapplications up to 5 tons. Refer to Engineering Handbook for proper sizing.

Units are factory equipped for use with natural gas. A kit is available for con-version to LPG operation. G26-1 and -2 model units use electronic (intermit-tent pilot) ignition. G26-3, -4, -5 and -6 model units feature the Lennox Sur-eLightT silicon nitride ignition system. Each unit meets the California Nitro-gen Oxides (NOx) Standards and California Seasonal Efficiency require-ments without modification. All units use a redundant gas valve to assuresafety shut-off as required by A.G.A. or C.G.A.

Information contained in this manual is intended for use by qualified servicetechnicians only. All specifications are subject to change. Procedures out-lined in this manual are presented as a recommendation only and do not su-persede or replace local or state codes. In the absence of local or statecodes, the guidelines and procedures outlined in this manual (except wherenoted) are recommended only.

Page 2: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 2

SPECIFICATIONS

Model No. G26Q2-50 G26Q3-50 G26Q3-75 G26Q4/5-75

Input Btuh (kW) 50,000 (14.7) 75,000 (22.0)

Output Btuh (kW) 46,000 (13.5) 47,000 (13.8) 70,000 (20.5) 69,000 (20.2)

lA.F.U.E. 92% 92.4% 92.0% 92.0%

California Seasonal Efficiency 85.9% 86.5% 86.3% 83.8%

¡Exhaust pipe connection (PVC) diameter— in. (mm) 2 (51)

¡Intake pipe connection (PVC) diameter— in. (mm) 2 (51)

Condensate drain connection (PVC)— in. (mm) 1/2 (12.7)

Temperature rise range — _F (_C) 40-70 (22-39) 30-60 (17-33) 40-70 (22-39) 20-50 (11-28)

High static certified by (A.G.A./C.G.A.) — in. wg. (Pa) .50 (125)

Gas Piping Size I.P.S.in. 1/2

Gas Piping Size I.P.S.Natural or LPG/propane

mm 12.7

Blower wheel nominalin. 10 x 7 10 x 8 11-1/2 x 9

Blower wheel nominaldiameter x width

mm 254 x 178 254 x 203 292 x 229

Blower motor output — hp (W) 1/5 (149) 1/3 (249) 3/4 (560)

Nominal coolingTons 1 to 2 2 to 3 3-1/2 to 5

Nominal coolingthat can be added

kW 3.5 to 7.0 3.5 to 10.6 12.3 to 17.6

Shipping weight — lbs. (kg) 1 package 150 (68) 157 (71) 157 (71) 182 (83)

Electrical characteristics 120 volts — 60 hertz — 1 phase (all models) (less than 12 amps)

b Optional Accessories (Must Be Ordered Extra)b

LPG/Propane kit (optional) 65K27 (all models)

Filter and Filter Rack Kits}No. & size of filters - in. (mm)

Single (44J20) Ten Pack (66K61)(1) 14 x 25 x 1 (356 x 635 x 25)

Single (44J21)Ten Pack (66K62)

(1) 20 x 25 x 1(508 x 635 x 25)

Concentric Vent/Intake Air/Roof Termination Kit (optional) 60G77 — 1 1/2 inch (38 mm)

¡Vent/Intake Air Roof2 inch (51 mm) 15F75

¡Vent/Intake Air RoofTermination Kit (optional) — vent size

3 inch (76 mm) 44J41

¡Vent/Intake Air WallTermination Kit (optional) — vent size

2 inch (51 mm)15F74 (ring kit) — 22G44 (close couple) — 30G28 (WTK close couple)

30G79 (WTKX close couple with extension riser)

Termination Kit (optional) — vent size3 inch (76 mm) 44J40 (close couple) or 81J20 (WTK close couple)

Twinning KitsNon-continuous low speed 64H88 (all models)

Twinning Kits(optional)

Continuous low speed 35J93 (all models)

Continuous Low Speed Blower Switch (optional) 44J06 (-1 and -2 models) Not used with Twinning Kits

lAnnual Fuel Utilization Efficiency based on U.S. DOE test procedures and FTC labeling regulations. Isolated combustion system rating for non-weatherized furnaces.}Polyurethane frame type filter.¡Determine from venting tables proper intake and exhaust pipe size and termination kit required.

Page 3: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 3

SPECIFICATIONS

Model No. G26Q3/4-100 G26Q4/5-100 G26Q3/4-125 G26Q4/5-125

Input Btuh (kW) 100,000 (29.3) 125,000 (36.6)

Output Btuh (kW) 91,000 (26.7) 93,000 (27.2) 115,000 (33.7) 116,000 (34.0)

lA.F.U.E. 92.0% 92.0% 91.0% 92.0%

California Seasonal Efficiency 86.6% 85.8% 87.5% 87.0%

¡Exhaust pipe connection (PVC) diameter— in. (mm) 2 (51)

¡Intake pipe connection (PVC) diameter— in. (mm) 3 (76)

Condensate drain connection (PVC)— in. (mm) 1/2 (12.7)

Temperature rise range — _F (_C) 50-80 (28-44) 40-70 (22-39) 55-85 (31-47) 50-80 (28-44)

High static certified by (A.G.A./C.G.A.) — in. wg. (Pa) .50 (125)

Gas Piping Size I.P.S. in. 1/2Gas Piping Size I.P.S.Natural or LPG/propane mm 12.7

Blower wheel nominal in. 10 x 10 11-1/2 x 9 10 x 10 11-1/2 x 9Blower wheel nominaldiameter x width mm 254 x 254 292 x 229 254 x 254 292 x 229

Blower motor output — hp (W) 1/2 (373) 3/4 (560) 1/2 (373) 3/4 (560)

Nominal cooling Tons 2 to 4 3-1/2 to 5 2 to 4 3-1/2 to 5Nominal coolingthat can be added kW 7.0 to 14.1 12.3 to 17.6 7.0 to 14.1 12.3 to 17.6

Shipping weight — lbs. (kg) 1 package 186 (84) 198 (90) 218 (99) 218 (99)

Electrical characteristics 120 volts — 60 hertz — 1 phase (all models) (less than 12 amps)

b Optional Accessories (Must Be Ordered Extra)b

LPG/Propane kit (optional) 65K27 (all models)

Filter and Filter Rack Kits}No. & size of filters - in. (mm)

Single (44J21) Ten Pack (66K62)(1) 20 x 25 x 1 (508 x 635 x 25)

Concentric Vent/Intake Air/Roof Termination Kit (optional) 33K97 — 2 inch (51 mm)

¡Vent/Intake Air Roof 2 inch (51 mm) 15F75¡Vent/Intake Air RoofTermination Kit (optional) — vent size 3 inch (76 mm) 44J41

¡Vent/Intake Air WallTermination Kit (optional) — vent size

2 inch (51 mm)15F74 (ring kit) — 22G44 (close couple) — 30G28 (WTK close couple)

30G79 (WTKX close couple with extension riser)Termination Kit (optional) — vent size

3 inch (76 mm) 44J40 (close couple) — 81J20 (WTK close couple)

Twinning Kits Non-continuous low speed 64H88 (all models)Twinning Kits(optional) Continuous low speed 35J93 (all models)

Continuous Low Speed Blower Switch (optional) 44J06 (-1 and -2 models) Not used with Twinning Kits

lAnnual Fuel Utilization Efficiency based on U.S. DOE test procedures and FTC labeling regulations. Isolated combustion system rating for non-weatherized furnaces.}Polyurethane frame type filter.¡Determine from venting tables proper intake and exhaust pipe size and termination kit required.NOTE - 2 inch x 3 inch (51 mm x 76 mm) adaptor is furnished with -100 and -125 furnaces for exhaust pipe connection.

BLOWER PERFORMANCE DATAFILTER AIR RESISTANCE

cfm (L/s) in. w.g. (Pa)

0 (0) 0.00 (0)

200 (95) 0.01 (0)

400 (190) 0.03 (5)

600 (285) 0.04 (10)

800 (380) 0.06 (15)

1000 (470) 0.09 (20)

1200 (565) 0.12 (30)

1400 (660) 0.15 (35)

1600 (755) 0.19 (45)

1800 (850) 0.23 (55)

2000 (945) 0.27 (65)

2200 (1040) 0.33 (80)

2400 (1130) 0.38 (95)

2600 (1225) 0.44 (110)

Page 4: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 4

��#9�������#���� ��:���

�'()*���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$��� ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 ���% %�% "+% <<% "�% �(0 *�0 �"0 �<0

��0 �% �0+% %�% "*% <<0 "�% �%0 *00 ��0 �(%

��0 %0 �0(% %0% "(% <%% "0% �"0 (<0 ��0 �(0

��0 *% �0�% "+0 ""% <�0 �+0 ��% ((0 ��0 �%0

�"0 �00 ++% "*0 "�% *%% �%% ��% ("% �0% ��%

�%0 ��% +%0 "%0 "0% *%% �%% �00 (�% �+% ��%

�(0 �%0 +00 "�% �+0 *"0 �%0 �<0 %"0 �%% ��%

�*0 �*% <�% �<% �(% ((0 ��0 �%% %�0 �%0 �0%

�<0 �00 (�0 �+0 �"0 %<% �*% �"0 �(0 �*0 �<0

�+0 ��% %+0 �<0 ��% �+0 �<% ��% ������� ������� �������9��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'+()*���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �"<% *00 %+0 ��*% (00 "<% �0"% "+% �+0 <"0 �+% ��0

��0 �% �""% (<0 %(% ��%0 %+0 "(0 �0�0 "<% �*% <�0 �+0 �00

��0 %0 ��+0 (%% %"% ���% %<0 ""% �0�0 "*% �(% <�% �<% �+0

��0 *% ��"% (�% %�0 ��+0 %(0 "�% +<% "(% �"% *+0 �*% �<%

�"0 �00 ��+0 (�0 %00 ��%0 %"% "0% +%% "%0 ��% *<0 �*0 �*%

�%0 ��% ���% %<0 "<0 �0+% %�% �<% +�0 "�% ��% *�% �"% �%%

�(0 �%0 ��(0 %"% "(0 �0�0 "<% �(% <*% "�% �00 *00 ��0 �"0

�*0 �*% �0*% %0% ""0 +%0 "%0 �"% <%% "0% �<0 (00 �<% ��0

�<0 �00 +*% "(0 "�% <(% "�0 ��% ("% �0% �%0 %�0 �"0 �+%

�+0 ��% <"% "00 �<% (�% �+0 �(% %"% �%% ��% �*% �*% �<09��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'+(,)���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �"+0 *0% (%0 ��"0 (�0 %"0 �0(0 %00 ""0 <*0 "�0 �(0

��0 �% �"�% (*% (�% ��0% (�% %�% �0%0 "+% "�% <(% "�0 �%0

��0 %0 ��<% (%% (0% ��(0 %+% "+0 �0�% "<% "0% <%0 "00 ��%

��0 *% ���0 (�0 %<0 ���% %*% "*0 �000 "*0 �<% <�% �+% ��%

�"0 �00 ��(0 %+% %(0 ��(0 %"% ""% +(% "%% �(% <�0 �<0 ��0

�%0 ��% ��00 %(% %"0 ��00 %�0 "�0 +�0 "�% �"% **0 �(% �+0

�(0 �%0 ���% %�0 %�% �0�% "+0 "00 <*0 "�0 ��% *�% �"% �<0

�*0 �*% �0�% "+0 "+% +(0 "%% �*% *<0 �*0 �0% (<% ��% �(%

�<0 �00 +�% ""0 "*% <(% "�0 �"% *�% �"0 �<% ������� ������� �������

�+0 ��% <0% �<0 ""% (�0 �+% �+% %"0 �%% �"0 ������� ������� �������9��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'-.)(,)���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$��� �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �"�% ��"0 ��"0 ���0 �000 �0�% �<*% <<% <%% �(�% **0 *0% �"�0 (*% %<%

��0 �% ���0 ��00 ��00 �0+0 +<% �00% �<�% <(% <�% �(�% *(0 *00 �"�0 (*0 %<%

��0 %0 ��(% �0*0 ��(% �0"% +(% ++0 �*+% <"% <�% �%<0 *"% (+0 ��+0 (%% %<0

��0 *% ���0 �0"% ��"% �000 +"% +*0 �*(% <�% <�0 �%"% *�0 (*% ��(% ("% %*%

�"0 �00 ��"% �0�0 ���0 �+%0 +�0 +%% �*�0 <�0 *+% �%�0 *�% (*0 ��"0 (�0 %*0

�%0 ��% �0*% +<0 �0<% �<<% <+0 +�0 �(<0 *+% *<% �"*% (+% ((% ���0 (�0 %(%

�(0 �%0 �000 +"% �0(0 �<�% <(0 +�0 �(�0 **0 **0 �"�% (*% (%% ��*0 (00 %%%

�*0 �*% �+�% +�% �0"0 �**% <"0 <+% �%(% *"0 *%% ��+% ((0 ("% ���0 %*% %"%

�<0 �00 �<"0 <*0 �00% �*0% <0% <*0 �%�% *�% *"% ��"% (�% (�0 ��(% %%0 %�%

�+0 ��% �*(0 <�0 +<0 �(�0 *(0 <"% �"%% (<% *�% ��*% (00 (�% ���0 %�% %�09��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

Page 5: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 5

��#9�������#���� ��:���

�'+.-(�**���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �0(% +*% +�0 �*(0 <�0 *�% �%*0 *"0 (%% ��"% %+0 %�0

��0 �% �000 +"% <*% �*�0 <�% *0% �%%0 *�0 (�% ��"0 %<% "+0

��0 %0 �+�% +�0 <"% �(<% *+% (*% �%�% *�% %+0 ���% %<0 "*0

��0 *% �<"0 <*0 <00 �(�% *(% (�0 �"*% (+% %(% ���0 %*0 "%%

�"0 �00 �*"0 <�0 *(0 �%%0 *�0 %+% �"�% (*0 %�% ��(% %%0 "�0

�%0 ��% �(%0 *<0 *�0 �"(0 (+0 %(0 ���% (�0 %00 ���0 %�% "0%

�(0 �%0 �%"% *�0 *00 ��*0 ("% %�0 ��(0 %+% "*% �0"% "+% �<%

�*0 �*% �"�0 (*0 ((0 ��%0 %+0 "+% ��*0 %%0 ""% +%0 "%0 �%%

�<0 �00 ��*0 (00 (�0 ���0 %�% ""% �0�% "<% �+% <�% �+0 ��%

�+0 ��% �0"% "+% %(0 +(% "%% "0% <<% "�0 �(0 *00 ��0 �+09��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'-.)(�**���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$��� �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �"00 ���% ��%% ��<% �0�0 �0*0 �+"0 +�% +0% �*"0 <�0 *(% �%*0 *"0 ((%

��0 �% ��%0 ���0 ���0 ��%0 �0�% �0%% �+�0 +0% <<% �*�0 <0% *%% �%�% *�0 ("%

��0 %0 ��+0 �0<0 ��<% ��0% ++% �0�% �<*% <<% <(% �(<% *+% *"0 �%0% *�0 ("0

��0 *% ���% �0%0 ��*0 �0(0 +*0 �00% �<"% <*0 <%0 �(%% *<0 *�0 �"<% *00 (�0

�"0 �00 ��(% �0�0 ���0 �0�0 +%0 +<% �<0% <%0 <�% �(�0 *(% *�0 �"%0 (<% (�0

�%0 ��% ��0% ++% ���% �+%0 +�0 +(0 �*%% <�0 <�0 �%<% *%0 *00 �"�% (*0 (0%

�(0 �%0 �0"0 +(% �0<0 �<+% <+% +"0 �*00 <00 *+0 �%"0 *�% (+0 ��<0 (%0 %+%

�*0 �*% �+%% +�% �0"% �<�0 <(0 +�% �("0 **% **% �"*% (+% (*0 ��"0 (�0 %+0

�<0 �00 �<%0 <*% �00% �*�0 <�% <<% �%<0 *"% *%% �"�0 (*% ((0 ��+0 (�0 %<0

�+0 ��% �**0 <�% +<% �(%0 *<0 <%% �%0% *�0 *"0 ��*0 ("% ("% ���% %<0 %(%9��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'+.-(�)���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �0*0 +*% +�0 �*�% <�0 *�% �%%% *�% ("0 ���% %<% %00

��0 �% �0�0 +%0 <<% �*�0 <0% *00 �%�% *�% (�% ���% %<0 "+0

��0 %0 �+%0 +�0 <%0 �(*% *+0 (<0 �%00 *�0 (00 ���0 %*0 "*0

��0 *% �+*% +�0 <�0 �(�0 *(% ("% �"(% (+0 %*% ��<% %(0 "%%

�"0 �00 �*<% <"0 **% �%(0 *�% (�% �"�% (*0 %"% ��"0 %"0 "�%

�%0 ��% �*00 <00 *"% �"*% (+% %*% ��"% (�% %�0 �0+0 %�% "�%

�(0 �%0 �%<% *%0 *0% �"�0 ((% %%% ��*% (00 "+0 �0�% "+0 �+0

�*0 �*% �"*% (+% (*% ���0 (�0 %�% ��<% %(0 "(0 +*% "(0 �*0

�<0 �00 ��%0 (�% ("0 ��00 %(% "<% �0+0 %�% "�% <(% "�0 �"0

�+0 ��% ��00 %(% %+% �0<0 %�0 ""% +(% "%% �<% *�% ��% �009��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

�'-.)(�)���#9�������#���� �

�2�!��0%���0�� ����>�%��!�0�$�������90����0���/! �;� ��%�<!���0/��2�!��0%���0�� ��!����! ��=? �!$���(��=? �!$��� �!$���(��< ��<

��&�<&=& �0 ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90��� ;� �.� 90���

0 0 �"00 ���% ���0 ��*% �0�% �0"0 �+(% +�% <+% �*+0 <"% *<0 �(�0 *(0 (*0

��0 �% ���% �0+0 ��*% ���% �00% �0�% �+�0 +�0 <*% �*(0 <�0 **0 �%<0 *"% ((0

��0 %0 ��%% �0(% ��%0 �0<0 +<0 �000 �<<0 <<% <(0 �*"0 <�0 *%% �%%0 *�0 ("%

��0 *% ��+% �0�% ���0 �0�0 +(0 +*% �<"0 <*0 <�% �*�0 <0% *%0 �%�0 *�% (�%

�"0 �00 ���0 �000 ��00 �+*0 +�0 +(0 �*+0 <"% <�% �((% *<% *�0 �"+% *0% (�0

�%0 ��% �0%0 +(% �0<0 �+�0 +00 +�" �*"% <�% <00 �(�0 *(% *�% �"(0 (+0 (�0

�(0 �%0 �+<% +�% �0%0 �<"0 <*0 +0% �(<% *+% *<% �%(% *"0 *0% �"�% (*0 (�0

�*0 �*% �<<% <+0 �0�0 �**0 <�% <+0 �(�% *(% **% �%�% *�% (<% ��*0 ("% %+%

�<0 �00 �<�% <%% �00% �(+0 <00 <(0 �%*0 *"0 *%0 �"%0 (<% (*0 ���% (�0 %<0

�+0 ��% �*�% <�0 +<0 �(�% *(0 <�% �"<% *00 *�% ��<% (%% (%% ��"% %+0 %(%9��7�@���������� ��������������� ����� ���� ��� ��������&�%���'������������������ ��&� ���������'�������������������=�� �����/���� ����� �����

Page 6: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 6

����4��0�$��������������>������������

>!�����/!�02����

��������>!�����/!�:�0�!�!���!@���!$�02����

�@��A0%!����!�=�? )*B***����?�1�-&,�C93 ,)B***����?�1&*�C93 �**B***����?�18&+�C93 �)B***����?�1+&�C93

�!!� �!�!�� ��& �� ��& �� ��& �� ��& ��

�% "�( ���A� �< � %� � %� � %�

�0 (�� � %� � %� � %� � *(

�% *�( � %� � %� � %� � *(

�0 +�� � %� � %� � %� � *(

"0 ���� � %� � %� � %� � *(

%0 �%�� � %� � %� � %� � *(

%% �(�< � %� � %� � *( � *(

(0 �<�� � *( � *( � *( � *(

*0 ���� � *( � *( � *( � *(

<0 �"�" � *( � *( � *( � *(

+0 �*�" � *( � *( � *( � *(

�00 �0�% � *( � *( � *( � *(

��0 ���% � *( � *( � *( � *(

��0 �(�( � *( � *( � *( � *(

��0 �+�( � *( � *( � *( ������� �������

F,9,F-F�4,47�!791�$ �=�/�=-/9�#7 �@ �()*�@�%���� �&��%��'��� �� ��+0�������������A�������&�<���'������ ��������&�%��8������� ���� �&"�(��'� ��'��(,)�@�%���� �&��%��'��� �� ��+0�����������������&%����'������ ��������&�%��8������� ���� �&"�(��'� ��'��(�**�@�%���� �&��%��'��� �� ��+0�����������������&%����'������ ��������&�%��8������� ���� �&"�(��'� ��'��(�)�@�%���� �&��%��'��� �� ��+0������������������&%����'������ ��������&�%��8������� ���� �&"�(��'� ��'�

?79�,91�9��7 �@ ����+0����������8������� � �%���� �&��%��'���� ���� ���� ���������"%������������8���� ����+0�����������"%�����������8������� � ���%���� �&�*%��'���� ���� ���� ����������� �&�0%���'����� ����������&%����'������ �����������8������� � �<���� �&��"��'���������&*(���'������ �������,� �3������7����� ���������� ���� ������������� ������������������&%�������*(���'����� ��������������� ����00��������%����������������� ����������� ���7����� ��������� � ����� ���� �����A�������&�<���'������ �������������������������A��&�<���'���������&%����'������ �����������7����� ��������� � ����� ���� ���������&%����'������ ������������������������������&*(���'������ ����������� ����������0� �������������� ���B� ������������

��������� ��� ����D���3.���1C�.��3

�����0% ���!��0% �!�=�?��;���/!D�!!�1�3�����0%�������/!���E!D�� ?!�1��3

���!��0%:�0�!�!�

D�� ?!�1��3�*

1+&*-73*

1&*83+*

18&�--3-*

1�&�83)*

1�)&-*3*

1�7&773,*

1�&++37*

1-&+7-38*

1,&-+3�**

1+*&-7*3

�A"&(��%'

��("&+��"('

"�&����'

�+&�<�'

�"&�(<'

�0&�%*'

�<&�%�'

�(&�"%'

�%&�"�'

�"&�"0'

��&��*'

��&��"'

�A<&+�%�'

�"+�&���%��'

+%&��(+'

(%&��<"'

%�&��"*'

"%&���*'

"0&����'

�(&��0�'

��&�*�'

��&�<<'

�+&�<�'

�*&�*('

�A�&���*'

�(��&�*�*++'

�*%&"�+('

��0&��"0'

+*&��*%'

<�&����'

*�&��0*'

((&��<*'

(�&��*�'

%*&��(�'

%�&��%0'

%0&��"�'

�A"&�+�0%'

�<�"&�0�+�0'

�(0&�0��+'

�%0&*�0<'

�00&%�(('

�*0&"�<�'

�%�&"��<'

��<&��+�'

��%&��%"'

��<&���"'

��0&����'

�0�&��+�'

�&�%�"'

��0"+&�(�("%'

(<0&�+��%'

"(%&����*'

�*%&�0�(�'

��0&+�0('

�<%&<�0*'

�(0&*��('

�"0&(�<0'

��0&(���'

�0%&%�<0'

�+%&%�%�'

�.�A"&���*%'

���<0&�%�0%�'

�"00&�+�("'

+%0&�(�+0'

**0&���<0'

((0&�<�(+'

%<0&�(�"�'

%�0&�%�0�'

"+0&���<*'

"(0&���0�'

"�0&����<'

"00&�����'

�.�A�&�<��'

��(�0&"0�<+"'

��00&%+�"('

"(0&"���"'

��<0&���"�'

++0&�<�0�'

+00&�%�"<'

<�0&���+"'

*%0&����"'

(+0&�+�%"'

(%0&�<�"�'

(�0&�*�%('

�&%0�<'

��0(*&%��%0�'

�+%0&����<%'

�*%0&**�<*'

��00&(���0'

�+00&%��<0'

�(<0&"*�%*'

�%�0&"��0"'

�"00&�+�("'

��00&�(�<�'

���0&�"�%%'

��%0&���%('

�.�A�&(��%'

��"(+&(*�*��'

(�00&�*<��+'

"�%0&�����*'

�%�0&++�(*'

�000&<"�+%'

�(%0&*%�0"'

�"00&(*�+('

��%0&(��*�'

�0%0&%<�0%'

�+%0&%%���'

�<%0&%���<'

�&*(��'

��0(<&**�+�*'

��000&����"<'

**00&��<�0�'

(�%0&�*(�+<'

%�00&�%0�0*'

"*%0&��"�%0'

"�00&����*('

�+00&��0�"�'

�*00&�0"�**'

�"%0&+*�(+'

��%0&+��0�'

"&�0��('

"�0�(&�0���(0'

��000&(%���*'

�%<00&""*��+'

��<00&�(��""'

�0+00&�0<�("'

+*00&�*"�(*'

<<00&�"+��<'

<�00&��+��('

*%00&�����*'

*�00&�0��<<'

(*00&�<+�*�'

����������� ���� � �� ���� �� ��� ��� ���� ���� ����� �� ��� ��� ����� ��� ����� �� �� � ���� ������ ����

Page 7: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4����*

��D+����#����D� #��#�����

��4�#�4

#�6,97�

1!� �=,67/�1� B7�

=/7 $��,/,9��B7�=,��,91

6-/97/�6�E� 7F6!G

4��#$4!��7

4��#$�4!��7�;,�$6�/672�=,��,91�92�=!�F7

/�!!.�-�� ;,�#$

1� �?�!?7��92F�9,=�!2

6-/97/6�E

#�?7/

=!�F7� ,1$�1!�

2���34����F

$7���7E#$�917/� 7F6!G

#�9279 7/�#�,!

#�9�/�!��/�9 =�/F7/

#�9�/�!�6�E�#�?7/

2��/�,9�7/!�#B ;,�#$

#�9�/�!�?�!���17

#,/#-,��6/7�B7/

;�/F$7�27/

&#�!!7#��/'6�E

#�!2�$7�27/�&#�!!7#��/'

6�E

#�F6- �,�9��,/6!�;7/

#�F6- �,�9��,/�/,=,#7

6!�;7/�##7 2��/

6-/97/�##7 4�97!

=!-7�/�9 ,�,�9

#�F6- �,�9��,/4/�?7�&4/7 � -/7'� ;,�#$

-44!G�,/

6!�;7/

4/,F�/G�!,F,�&�!�7/9��7� �G!7 '

=!-7�#�!!�/

��������

Page 8: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4����<

�������

��������� ������

������� ��� #>��

��������#�

��������������4�������� #�����#���� �

���

���������������#� ����#��:����#4������������ ���������(

������

9�������:1 #��� �#�3

�#�

#�:������ #��

#�:����:��1 #��� �#��3

�#�

#������#�������#9����#�#�

#������#�������#9��

����>��>�

�����#�:

�������+

����������������#��������#�

2,==7/79�,�!&#�F6- �,�9��,/'4/7 -/7� ;,�#$

#�9�/�!�6�E

#�F6- �,�9��,/�6!�;7/

6!�;7/�F���/�#�4�#,��/

#�!2�$7�27/�6�E

=!�F7� ,1$��1!�

1� �F�9,=�!2

-44!G��,/�2-#�=!�917

-447/�?7 ��4�97!

4/,F�/G�!,F,�

1� �?�!?7

$7�27/�6�E#�9279 ��7

�/�4

!�;7/�?7 ��4�97!

6!�;7/�F���/

6-/97/6�E

6!�;7/�$�- ,91

6!�;7/#�F4�/�F79�

#,/#-,��6/7�B7/

2��/�,9�7/!�#B ;,�#$

=!-7��/�9 ,�,�9

Page 9: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

6!�#B

;$,�797-�/�!

6/�;9

H(+

�������������#9�� ���#���9�����#�58

�������

4����+

�������-

��4�(����#������������#�

F�B7�-4�6�E

F�B7�-4�6�E

-9,�#�6,97�

6������������ ��������������� ����������� �������������� ����������� ���������� ��������������

H�#B�H(+

4!-1�4(+

6!�;7/�F-!!,�9

6!�;7/�F-!!,�9

#����:������������#� ����:������������#�

!����?� ����7� ���F�3��-�6�������� �������-�� ����H(+�4������������6 �B��3� ����F�3��-��6��

!����?� ����7� ��������B��3� �,��F�3��-��6���H(+4������������ ����B��3�

,� � �������-�� �

�����9���������������4������#������ ��������#�

��#�����#��:&

�D����� #��#�����

1�(���� ������� ����������������������1�������� ����

�� � �������������������������������������)����� ����� �

������������������������������������ ��������������

��������������������������� ���������������������

������� �����������������

1�(���� ����������������� ������������ ����������

������������������� ����3��3���� �&� ��� ��'�

�� �� �&������ ��'�����8�������� ��������� �������

���

�D�0C!(�/���2�1��=��!�)3

����������� ������3�������������������������%��������

���� ��� ��� ������ ������� � � ����� ��� ��� � ���� ���� ��

��� �������� ������ ���� ����� ������&������"'�

�������)

��4�(����#�

6�E

#�?7/

H�#B�H(+ ���������3

���6!�;7/�F-!!,�9

4�;7/�79�/G�B9�#B�-�

��0?�!,97�?�!��174,1��,!�#�997#�,�9

-9,�1/�-92

6������������ ��������������� �������� �� ���=�����"

�����������&���'�� �� ����������������� �� �����3����������������������������0?������ ������ ���������������������������� ��������������������������,������) ������������������� ���������H(+�:��3������������� ���� �������� ������������� � ��������3� ��� ���:��3�� ��������(����0?������������ ����� �"������ ���������������� ��� � ���������������� ������ �� ��� �������� ��� ������ ��� � ��� ��� ��� ��� �������� �����3�������������������� ������� ��� ������5����������� ���������������� ���

�D �����%���2� ��/��!���

�� #���#���#�

�������,

�� �������4��

���������� #���#�1D+��?���=?�D���$!%��3

:##�������# 4�9�� �

������#����

Page 10: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

�������8

���� ������������������

4�����0

7��� ������������ �������� ��&��%')���� � ������

��&��'������"?������ ����3��&#6<'������� ������ ������

������,������ ��)������� ���3���� ���& %�'������� ��

��� ����� ������H��3������������I�������J� �������� ��

����� ����� ����� ���������������������������

�����

�D� �����%���0��;���!��1��3

�� ���������� ������ ����� ����������������

�������� �����"�� ���� ����� ������ ������������

�������������� ���"0?���� ������0?��������������"?

��������

D� �� ������!0C!��1 �73

���"?������ ����3������������ ������ ����� ���������

��� ��� ������� ������ � � �� ��� � ��� ������

&��'���������3������ ������� ���?��,�� ������� ��������

�������� � ������3������� �������������� ���� ����������� �

������������3��������������������� ������������ ��

�� ���� ��������

+D:�������!�%� C��<�� ?�1�)�3

������ ���3���� ���� ����"��� ���%?�#������� ����

����� ������������� ���������������������� ��������� �

�����;���� ������������������� ������ ���������

����

-D�%0�!��!�����1D+��?���=?�D���$!%�3

������������������� ����� ������ �������� ������������� �� ���������<����������������� ����������3� ��� ������������ ����� ��� ���� ������� � �������������������� ������ .�� ���������������������� ����� ��������� ������������������������������ �� ������������� ��� ����������2�������� ��)����������������������� ��������� ����� �������������������������� �������� ��!��� ��� �������� ������������ ��������������������������������������������

�������7

����#� �����#�

�#���������������������0�*��� �#�����#9������������������������*&,��� �#����������������������������*&�)��� �#����

�A<J

%A�(J

���� � ��� !" ������ ������ ������� �#��$

����� ���� ��� ������� �������� %��� ���� ���� ���

������ � &��� ������� ��� � �������� ���������

)D����!��

������� ���������� �������&����������+'��6����������� ��� � ���� �� � � �8���� ��:�� ��� �� �� ���� � ������ ��� ������������� ������������������������������������������������ �� ������ ��� �� ������������������������6�������������������������������������������6������� ����������������������� ��������� ���F�,9�79�9#7��� ����� ������������7������������������������������������������ ����� � ������������ �&����������� �����������5�'��������������� ��������� � ���������������������������������� ������ �������������������������������������������7������������������������5����������������� � ������ ��/���� �!�����/�����4� ��!�� �������� ���5��������� ������������� �� ���������� ���������������������� �������� ����������� ���������������3����� ��������������� ������� ��������������,������ ��) ���������� ����� ����������������&=������'������ ����� ������������&�����'����� � ���� � ������ �� ����� ������ ��

:������?� C�?0E0�$&

:�� ���! ��/�<!���!;��!��!�A� ��=&� �����%�������;�!%$��!/0��0�%!&��;� �����%�������/!�0�%!B����/%F�!/%0 !�!����!� �����%&

0�� 0��!���G��F����$!0�?&����0;!��/!�0�����<�%%�!��%���;��!/0������0��!�/�!$&

D����!��=?���=��������F��!���+�1D+��?���=?�D���$!%�3

����1�(.�� �����.(��������� ������8��������� �� ��!����� ���.�!��� ����� ������ ����������� �������� ������� ����� ������&�������0��� ���� �� ������������� ������� ������'��������� �&�������<�������'����������������� ��3���������� ��� ����������������� ������� ���� �������� ������� ��!��� � �� ��� �������� ���������:� ���������� ������������������� ���� ��!72����� ���� ������ �������� ��������� ��������� ���� �&"'���������� ��� �������� ������ ���������� ���������������������"����:��3������ �������������� �����-�� ���8��������� �� �� ��!��� � ���� ���� ��� ������� �� �� ��� ���� ���� ���� .����������� ���� � �� �� �� � ������� ������� ��!��� ����� ������������������������.�� ����,��� ������� ����������������������� ������������� ����� ��������������������� ������� ����� � ������ ������������������������������� � �������)� ��������������� ���������� ������� �

���� � '� ��� ��#��� ���&�� ���� ����� �� ����(���)��� )�' ������ * ���� ����� � ������� �� ������� ����� ��� ��&���

Page 11: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

���������� #���#���#��:

��������*

���������� #���#�����������:��������#��

�#6�#��!

�#6�$7��

4�/B

�#6�!�;

�##

�E

$��

$�1��##

97-�/�!

�"?�#�$��

�"?�#�/�9

=!�F7� 79 7

6����.�#����� �����&!����?� '

6����.�$�� ���� �����&!����?� '

�� ��� ��6���� ������&2���'

#� ������!�� �����6���

����������������&!����?� '

��0?�#�$ � ��������

��0?�#�$ �,���

$�� ��������������&!����?� '

��0?�#�9�� ���

�"?�#�$ �����������

�"?�#�/� �������������

=����� ������������

�������

���������

���������������#�

��A��K

%A<J ����������������#��&:&#���������#������

������

����:����#��� � #:����4��������#��:���:H�� #��� ���"��������#�����������#�������� ��#����#�� #���#���#��:����#��&

��:�I� ��:�I :�� �����#�

,F-!��97�- !�;�=!� $

,F-!��97�- !�;�=!� $

4���.�9������� ��������������������������������� ����������

,F-!��97�- �=� �=!� $

,F-!��97�- �=� �=!� $

9������� ���.������������������ �������������� �� ���� � ���� � �

!�;�=!� $ �9

4������ ����������� ������-�� ���� ������(�B<+0����"!<%L�!��� ���� ������� ����%� ����������� �������������� ����������� �;� �������-�� ���� ������%(!<���+*!"<L�!��� ���� �������� ���������� �������

������ ����������� �;� �������

�== !�;�=!� $

4��������� ������������������%� ������������������������������ M��/L6��3������� A������ ���� M��/L�#������ ����������3��M��/L�4��������� ��

��������� ��� ��� ���������� �����������

�!�7/9��,91� !�;=!� $

�!�7/9��,91� !�;=!� $

;� �������.������������ ����� ��

!�;�=!� $ �== =�������������� �� ����������������5���

�9 !�;�=!� $ /��� ���� ���������/L�+���������� ���������� ������

�9�9�==

�9�==�9

#���� ��������������� ������������ ���

=� ��=!� $ !�;�=!� $ F������������ ���������� �� ��������������� ���

!�;�=!� $ =� ��=!� $ !����������������F�������������*����������/���������������������

�!�7/9��,91�=� �=!� $

�!�7/9��,91�=� �=!� $

,����������������������� ���������*%��� �M��/L�63������� M��/L��������� ������ �

���� � (��& ����� �+���� , -. ���� ����� ��� ������� /��� ����� �+���� 0 -. ������ ������� ��� ������� '��� ��� ���#� ����� ������ 1 ��,2 #��*#��

Page 12: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

������+

���!��=?���#��:��5�)�153����������:��������#��

����I ��� ��#�

� ,���

� 9 �-���

� ,��� �9�� ��

" #���� ������6����!����?� ���

% 9 �-���

( #���� ������6����9�� ��

������-

���!��=?���#��:��5)7�15�3����������:��������#��

����I ��� ��#�

� 4�����!��� �,�

� 1���?�����#���

� /����� � �� �����

" 1���?������"?

% 4������ �� ���,�

( 4������ �� �������4�����!��� ���

* 9 �-���

< /����� � �� ���,�

+ 1���

����#�

�%! �����0�� � $�� ?0�=!� 0�� 0;;! �� !%! ����� ��/��!���&��0C!�/�! 0�������$����=�;���0 !����0%%0�����0�$��!�A� !����/���! ���?!�;���0 !H�!%! ����� � �����%�&� ��! 0������� <�%%� ?!%/� ��0A��$� �����%� !2/����!� ��� !%! �����0�� � $��( ?0�=!��F�/�����=��?!�;���0 !B��?!� �����%�0�$�?!��! ?�� �0��0���?!��0�!�!%! �����0�� �/��!�(��0%&��!���0%�E!�!%! �����0�� � ?0�=!��F���� ?��=?0�$�0�$�0%%����%�����0����/0���!$���������;0 !B�� ?�0���?!�=0��A0%A!�����%�<!��$! CB��!;��!�/!�(;�����=�0�F��!�A� !�/�� !$��!&

��� ��#����� �:�� ������1��:3

��! 0�������0�$���� !$��!�

0D�%! ����� ��=��������������������� � ��� ��!��� ��� ����� �� ������

��� ��������������������� ���������� �������� ����

���� ������ ������������� ������������� ������������&��.

������'������� ������������� ��� ����� ������� ���

���)� �������� �������������������5����;���� ��

������� ���� ��� ��� ������� ��� ��� ��� ��� � �����)� ��

���������� ����������������%.��������.��������

������,�� ������������� ������� �������� �����.�A������

� ��)� ����� �������� �;� ������.4������ �� ��

��������%.���� ���.�� ������

��� �� ����%.��������.���������)� ��� ��!��� ������

��������� ���0���������� �������� ������������

���������".������ ���������� ����1�(���� ���� �����

(�B<+)��"!<%��%(!<�L� ������� �� ���������5����� ��

��� ��������� ���".������ �����-�� ���� ������+*!"<L

���� �� ���������5����� ��������".���������� ��� �����,�

���� ������� ������������ ���".����������)� ������

������� �������� ������� ������� ��������������.��

������ ����� ��������%����������� ���� ���������� ����

������ ���&���������� ������ ���� ���')� ����� ��������

;� ������.=�����=������������� ����(0.���� �����

����)� ����� ������������� ������� �����8������������

���� ��!��� ��� ������������������� ��� ��� ��

������ ���������� ������� ���� ������������������� ��)

��� ��!��� ��� ��� ���5������������ ������5�� ������

�� ������������������������� �������� ���� ������

�������� ����� ���� � ������� ��� ���� ������� �������

���� ������� �� ������������������������� ���� ���

��������� ������������������%%������������ ����%( �

���������� )� ����� ����������������������� ��� ������

�� ���������� ����������� ����������������������

�D�0�����!� �����%

���������� ������"%������������ ���:�� ������=�����

����& ���� �� � ����������� ����� �� ������ �������

����������� ������'� ���������:�� ������ ��������� ������

��� �������� ����� ��� ��!��� ��� ��� ����� ������

��� �������������� ������� ����������� ������+0��������

=������ �������������� ���� ����������:�� ����� ��� ����

������������������ ����� ������������

��������

���(#���������:5�������

����:�� ����.��� �����)������������� ��� ���������� ����

(0���� +0���� ��0���� �<0����

,D�%�<!���������0�$� 0/0 �����

����1�(���� ���������� ������������ �������� �

����������0?�������� ����� ������� �� �� ������

�������������������� ��� �����%���� �����

Page 13: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

������)����#9������������*>����

6!�;7/�F���/ $4

1�(N�

#�4

�A� %F=2��*0?

1�(N"A%

1�(N�A" �A� *�%F=2��*0?

�A" "0F=2��*0?

1�(N� �A% %F=2��*0?

7D ���������������%�<!��1�3���� 1�(� ��� �� ���� �� ����� ��� ��� ����� � ���� ��

����� ���������������� ������������������� ������

�� ��������������������4 #���������4�����0?�#

� ��4 #�� ��������������� �������� ���� ��

������������� ������� ������������ ����������������

����%�������������� ����� �������������� ��������

���������� ���������� ����� ���������� ������������

���� ����� ������� �����8�������� �������� ����������

��� ���������������� ���������� ���

�������������� �������� ��� � �������� ������������������������� ���������� �������������� ���������� ������ ��������������� ����������������2�������������� ��)� ������������� ������������������ ����� ,�� ��� ������� ���� &���������� ��� ���')� ������������ ���������;���� ������������� �������) ������� ����� ��&��'�������� ���������� ������������� ����� ��������� ���

8D����0�F������� �����%�1��*3���� ������ ���� � & �0'� ��1�(� ��� �� ��� ��� ��� ��� ��

��������� ������ ������� ��������������;��������������

������������� ������ ���������)� ������� �����������,�� ��

���� ���� �����)� ������������ �������5��� ������������

�����������.�����5��� ���������������������� ��� �� ��

��������� ���������� � ����� ���� ���� ����������

��� ��������� ���� ��������� ������:�� ����������� ��

������������������ ��� ��� ����������� ����������

����$����)� ����� ��� ������������ ����� ���������

������� �

��������+

����������� #>���1�3

������ #���#��1��*3��#������������������:����������������

SPAD

E C

ON

NE

CT

OR

S

LIM

IT

�������0F��!�!@��//!$�<��?�!��?!����F%!�%����&

�*D��%%�����<�� ?�1�-,3�D+��?���=?�D=�������� ���� ��� "*������ 4 ��9�#������� ����� ������ ���� ����� ������ �������� ��������������������&����������"'�� "*��������� � ������������ ����� �����;���� "*����������������� �&������ ���������3������ �������� �����������')� ������������ ���� �� ���)����� ��� ���� ����� �� ������� ���������� ������������ �� ��� "*��������1�(���� �� ������ ������ � ������ �00�=�O����=�&+��#�O�(�*�#'����� ����� �������������������� ���� �������������������� ������3� ��&P(%B(0'���������������1�(�.������.��������

��������-

�������#��#����9�� ��1�-,3

=!�F7�/�!!�-� ;,�#$�& "*'

��D�� D+��%�<!�� �����%���)�1D��0�$�D���$!%�3

����1�(.������.���������� ��� ���5�� ���6##������������

��������� �������$�� ��� ������6##������������ ������

��� ������������� ��� ������������������������� �

������ ���� ������������������ ���������� �������

�����:�� ����)���� ������ �I�����J� �������=���I��J� ���

���������:�� ���������������������������� � ����� ���)

��0������"?�#��!������ ����������� � ��������� ��

��0?�#������� ����������(�

�0�������=�

=���I��J� ������& ���� �� � ����������� ����� �� ������

������������������ ������'������ ���������� ���������

��� �����:����������������� ���6##����������� �

����� ����������%������:�� �����I���J� �����)���� �������

����� �:������������� ����������������������

�� ������ �������=���I�J� ���������� ���� �� �"%�������

�������� ���:�� �����

����34� ��� 5���6 �#� � ��� ��� ��&7 ������� ���� �

���� �8������ #�� ���� ��#��� �#� (,� �� ��� ��$

������ � ���+���� ���� �� ���&��� 4� ��� ����7 ��$

9��� ���&�� �� ������ �#� �������

=������%������ �������������I��J� ��������������:����

������������ ������-�� �������������� ������� ������I��J

�� ������+0���������=���I��J� �������������� ���� ����

��������������������:�� ����� ��� ����������������������� ����

��������I��J� ������������ �� ����� ������� ������������� ��

�� �����������������������& �� ���)���������� ���

�� � ���� ������������������9� ��-���������� ���A

����������������� ������ )� ��������� ���������� ��

��'�

��������)

���(#���������:5�������

�*0��0

�%0 +0

����:�� �������� �����L/�����:��������6##�������������� ������ ��� ������������� ���

��������� ���������� ����

�,F,91H-F47/

�,F,914,9

&������'

!�����:�����������0�������������� ������

Page 14: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����"

����#9��� #���#��(�� (+��1��)3

��������

��0�%!�7��?�<��!����0%�$!��=�0�����&

�0�%!�7��?�<���!����0%�$!��=�0�����&

27��#$�6!7 �/,4��9�7�/!G6��/2 ��9!G

�D�=������� �����%�1D��0�$�D���$!%�3

1�(�.������.���������� ����������� ��� �� ���� ����� ��

������� �������H�����#� ������������ ����� ����

��� ����� ����������� �������

� ��������

;���� ������������������� )� ����� ���������� �����

���������� ��� ���� ��� ��8������ �� ��� ��� ������� ��� ��

���������� �������������� ����;���� ���������

��� ��������)� ����� ������� ��������3���������� ��

��� ������� ����� �� ������ ��;�������������������)� ������

������� ���������������������� ������ ����� ��� �������

��������������������� � ���� ����"%�������������

1����������������������������� ������������� ���

���� ������ ����������� ��)������������������������

�����)������� ������� ���������� ���������,�������� ����

���� �������������� ���� � �������)� ������������

������

������ �������� ��� ����� �����<%���������,������ �����

� �����������)� ����� ���������3� �&������ ������������

����!72'��;� ���������� ����� ����������� �������

���� ����������� ��� ���� � ������������ ������� ��

��8����������� ������ ������ &;� ������� ����� '�� ,�� ���

���� ����������������)��� ������������ ������ �������������

����)� ������� �����8������������ ����� ��%���� �����

,������ ������� �������������� �� ����( �� �)� ����� ������

��� ������������ ������� �����������F��������� ���

���������������������� ���� � ����������� �����

��������� ���������������������

��������,

������#�� #���#���+

4�/B�-�4-�

77���6!7�(=�/��7/F,9�!27 ,19��,�9

:������?� C�?0E0�$&���/0�C��!%0�!$� ��/��!���� ���0��?�=?�A�%�0=!&��:�� ���! ��/�<!���!;��!��!�A� ��=& �����%��������;�!%$��!/0��0�%!&���;� �����%�������/!�(0�%!B����/%F��!/%0 !�!����!� �����%&

0�� 0��!���G��F����$!0�?&�����0;!��/!�0�����<�%%�!��%���;��!/0������0��!�/�!$&

������

������#�� #���#���+����������:��������#��

�!����0% �F/! ��� ����

1/�-92 �A"J� ���� #����� �1���

�$ �� �A"J� ���� ��� ��!��� ��"?�#�,��� =��2������ ���� �� ��

4�?�� �A"J� �����"?�#��� �� � �4�� �����

��1���?����

F�?�� �A"J� �����"?�#��� �� � �F��������

��1���?����

79 7�" �A"J� ���� F������=����� �������,���

-���3��4�������6���;�� $����?� ���� ��3��� ��

Page 15: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����%

��� ��������

���� ��������� �� ����8��������� ���������� ���!72����� �� ������ ���� ��� ��� � ���� ��� �� ��� !72���� ��������������� �����*�

������,

����0 !� �����%��+�:�0=����� ���:

��:���0�! �!0���= �!�!$F

������� 9�������� �� �������

���=����&��������A%��������'

#� ��/� �4���

=������ � �����=������,��� ���#�� ��;����/� �

6����!�3������ �

���#� ��=������4���=������$���!�3�

,��4�������1��� ����������B)���/��������K� � �2������=�� �!��� �0� �������,��!72�/����������

;����2������,��/� ����)�/������#� ��

������7

��#9��� #���#����)����������:��������#��

�!����0%1:!��=�0�������9����=:�0=�0�3

�F/! ��� ����

G2� ������� ���� �� #�����2�����

12� ������� ���� �� 6����2�����

/2� ������� ���� �� �"?�#� ������ �

;2� ������� ���� �� $�� ����2�����

�2� ������� ���� ��

�"?�#�#�����,�������� �

,69�&9' �A"J� ���� ��0?�#�,���6����#���

9��&9' �A"J� ������0?�#�9�� ��

&!��!����?� ����9�� ��'

#�69�&9' �A"J� ������0?�#�#���� ������6����#��

��

E=F/9&9' �A"J� ���� ��0?�#���������#���

$ ,9�&9' �A"J� ������0?�#�$ � ������,��� ��

#����&9 �-���'

#�6 �A"J� ���� �� �������0?�#� #���� ������6���

!� �A"J� ���� ��0?�#�!����?� ����,�

� �A"J� ���� �� �������0?�#

�6����#��������

E=F/ �A"J� ���� �"?�#�,��=���������

2 �A"J� ����2�����#���� ����-������6����!����

#= �A"J� ���� �� �������0?�#� #� ������6�������

$ �A"J� ���� �� �������0?�#� 6����$�� �������

�## �A"J� ���� �� �������0?�#� ���������&7���� �������#�����)�$��������)�7 ��'

�"?&�"' �A"J� ���� �"?�#�,��� �=���������

!,F,�&!' �A"J� ����

�"?�#�,��=��4�����!��� ��!��� ����L�#�����1���?����������������6����!��� �#����L�������,��� ��

; �A"J� �����"?�#������ � �2�������� �� ������2������ ���� �� ��� �I�$ J

����������,��� ���#� �

?�!?7 79 7�&?' �A�(J� ���� �"?�#�,��� �=��1���?����

� �A"J� �����"?�#�#����=�

,��� ���#� ������1���?����

#�F�&#' �A"J� ���� �"?�#�#�������������

��� �� �������� ��� ��� ���������� ��� ����#���� � ��� ����� � �������� �� � ������� ����� ��:������ ��������7 4��7 ��� � ��������� &�� ���#�����

��������������� �������� ���� � )� ������� ����� ������5����������� ����� ��!72����� ��&� ������'���������� ����������� ��������5������ ���%�������������������)� ����� ������� ���������������� �������������������3� ���� ����� ���

,����� ����� ����� ����<%�������)�������������� �� �����

���������� �������� ���� ��� �� �� � �����5�� �������

�������������������������� ���������5����� �������

�� �� �� ��� � ������� ��3� �� ������ �� ��� ��� � ������ ��

��������<%��������������������

;������� � ������ ���������)������������ ��������5������

���3� ���������������� ����� ������������I��J����

�� ������� ���� � ������ ���������������� �

,����� ����������� ������������� ��������� ���<%������� ���

������ ��)� ����� ���� ��� ����00>���� �����������

���3������ �������� ���������������5������ ������� ������

�� �� �� ������� ������� ��� (0����� �� � �� ������ �����

2����� ���(0����� �������� ��������� ���!72��� �������

��������������������������������������������� �� ��

����������)��� ��� ���������� �����8������� � �)�������

������� ����������

,����� ������������ ������� ������� ���� � �����������

����� )�� �������������� ����������������5���� ����0�<

�������������������������5�������������������� �

���������)� ������3�������� ������������5���� �����������

�������� ���<%������� ���������� ��������������,�� ���

I������ J� ������ ���� ���(� ����� &��� � ������ ����� ���

����������� ������ ')� ����� ����3��� ����� ���!72

�������������� ���������� �����8��������������� �� ��

���� � ��� �� �������������������������� ���

������

,������������� �� �������� ��� ���� � ������������ )��

��� ��� ���������� �����0������������������ ����,�

���������� ��������� ��� ���0�������)� ����� ��������

��3� ����� ���!72��������

�+D��%��B��/0�C��%! ���$!B��%0�!��!�����1D��0�$�D���$!%�3

=������<������ ����������� ������ )�����������)

���3����� ���������������������� ����� ����������

�� ����3� ����� �� ������ ��������� ����� ��� ��������

���� ����������������� ���������������������������

�� ����� ��� ���������� ����� ������������ ����� ����

8����� �� ���� ���������� ���������������� �����������

���������������� ���������������)����� �"������������

������� ����� ������ ����� ������� ������������������

�����=������+������� ��������� ����� ��� ����� ��������

�������� ����������������, ������� �� � �� � ������

������� ������������� �� ����� �������� �������

Page 16: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����(

�������7

���� �������������#�.��� ��#:��#��������#�A�!<�%��C��=�0����$!��;�����!��

=/7 $��,/�,9��B7

6-/97/�6�E

F�9,=�!2

6-/97/

4,!��$��2

4�/B7!7#��/�27

=!�F7� 79 �/

1�4

6 ����� �������������������������������������� ��

���������� �����������������4�� ���������� ������

����������������������������� �������� ����� �

����� �

��������8

���#�B�����4���� (��#:�

��:�����������#�

�A<�&���%'�,������A���&�0��'

4�/B�7!7#�/�27

=!�F7� 79 �/

4,!��

4,!���$��2

1�4

4�/B�;,/7

79 �/�;,/7

�-D�0��>0%A!����1�(��������������������������� �������$��������

;�� ��/������ ����������0����������������� ���������

������ � ����������� ����� �����,�� ���������������� ���

�������)� �������� ������������� ���������

�"?�#� ������������������ ��3��������� ����� ��� �������������� ���������� ��������������������� ��� �������� ������� ����� ����"?��������� � ���IF?J� ����������� ���$���������FA#���A�� ���������� ���;�� �/���������� ���������������,��� ������ �� �������� ��������� ����� ������������������ ���:�� ��� ������&������0�'������� ����� ����������/����� ������������� ������

���������������������������������

���!41����������3� �������������������3� ��������������������� �������������&��� ���������.������.����� �����'����������� ���������3� ������!�4�������������������� �������������������� ����������9� ������������������ ������ �������

�������������

���

�������#� #>����� ��9

1�%0 C3

��:5������� ��919?��!3

��������0/!�!$���$:�<��1�!$3

���������

���������������#�

�������#� #>���� ��9

9������#:�����+������>��>��������#���:5��������� ��9

�# ���#�

�#���9����>�7*-�����>��>��������#���:5��������� ��9��# ���#�

��:5�������� ��919?��!3

������

�������*

��������� ���!"����

�������������������� ������������������ ���������

���� ��������������������������������� ������ ��

�������� � ������������������ ������������ ��������

������� ������������������������� ���������� ��� ��

����� ��� ���� �������� ���� ������ � �� � ������ �

��������������������������������� �� ���� �������

�� ����������� ���� �������� ����������������� ������

��� � ���� ���� ������ �

Page 17: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����*

BURNER BOX PRESSURE(Negative inches water gauge

.��0.0��0 .0�" .0�( .0�<��%

��0

��%

��(

��*

��<

��+

���

���

���

��"

GA

S V

ALV

E O

UT

PUT

MA

NIF

OL

D P

RE

SSU

RE

(po

sitiv

e in

ches

wat

er c

olum

n)�#�����#������#��1�0���0%��0�������3

measured on right side of burner box)

1������������� ����������� ���������O��0>����������������������������� ������� ���� ������������ ���� �����7������� ����������������������� ���� ��)��� � ���)��� �3�A������ �������� ������� ������ ��

��47/��,�9�����$, �7E�/7F7F�G�,92,#��7���6!�#B72

�-�!7���/���$7/�4/�6!7F

�47/��,�9�����$, �7E�/7F7F�G�,92,#��7���6!�#B72

,9!7���/���$7/�4/�6!7F�

��������

.��0.0��0 .0�" .0�( .0�<(�0

(�%

*�0

(��

(��

(��

(�"

(�(

(�*

(�<

(�+

�#�����#������#��1�&�&��0�������3

BURNER BOX PRESSURE(Negative inches water column

GA

S V

ALV

E O

UT

PUT

MA

NIF

OL

D P

RE

SSU

RE

(po

sitiv

e in

ches

wat

er c

olum

n)

measured on right side of burner box)

��47/��,�9�����$, �7E�/7F7F�G�,92,#��7���6!�#B72

�-�!7���/���$7/�4/�6!7F

�47/��,�9�����$, �7E�/7F7F�G�,92,#��7���6!�#B72

,9!7���/���$7/�4/�6!7F�

1������������� ����������� ���������O��0>����������������������������� ������� ���� ������������ ���� �����7������� ����������������������� ���� ��)��� � ���)��� �3�A������ �������� ������� ������ ��

�������

=���������������������������������� �� �����������

������������������������1�������)�����������

������������������� ���������A������ ��������

�������������������������������������� �����

����������������� �����3���������������� ��

�������������+�

�)D:�;;!�!���0%���!����!��<�� ?�1�-31 �����������������A!��<�� ?3

1�(���������� ������8��������� ����������� ����������

��� ������ ����� ������ �������������������� ���������

��� ��� � �������� ������������������������������

���������������������������� ����������� �� �������

������� ��� � ��������������� ������������������ �

���� ��� ������ �� ��� ������� ��� ��� ����� ��� ��

������������������������

���� ��� ��� ��� �� ����������� ������� ��� ������� ���

������� ��� ������� ������� ����� ��� ��� �������� �� ��

���� ��� �� ��� ���������� �� ��� ��� ��� ��� ������

�������� ������ �������� ��������������� ���� �

����������������� ������ ���������� ����������)

���� � ���)� ������ ���������� �� � �������� ������������������ �����, �������������� � � ������� ����� ������ ���������������������������� ������������� ������������������0��� ������������������������������ ����� ��������� ���� � ������������� ������������������$!�;����?!�;���0 !�����/!�0�!B��?!�%0�=!���!=0��A!������0%(<0F�� �!� ��� �?!� ���������� 0��� �%�<!�� ��$!� �;� �?!�<�� ?� ,�� ���������������� ��������� �� ������������� ��)� ������ ������������ �������������������� ���&���������0��0��������� ��������'���������� �������� � ������� ����� ��

�������+

:����������������������9�� �� �� �����

6-/9�7/6�E

1� ?�!?7

79 ,91$� 7

#�F6- �,�9�,/�4/7 � -/7� 79 �,91�$� 7

#�F6- �,�9�,/�6!�;7/

6-/97/6�E

79 ,91$� 7

1� ?�!?7

�77

4/7 -/7 ;,�#$ 79 ,91$� 7

$� 76�/62,==7/79�,�!

4/7 -/7 ;,�#$

!7=�� ,27��=�4/7 -/7� ;,�#$�Q�F�/7�971��,?7/,1$�� ,27��=�4/7 -/7� ;,�#$�Q�!7 �971��,?7�&#���� �R�'

������� ��������� ���� ��������� ���:�� ������, ���������� �

��� ������� ������������ �������������

=������"������ ����������������� �����8����� ���

���� ��� � ��� ���� ,�� ��� ��� ��� ���� � � ������������

������ ��� �8������������ ���)� ������ ������� �����

���� �������������� ���� ��

;���� ��������� ��� ������� ������� ���)� �������

��������� �3���� � ������������� ���

Page 18: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����<

2,==7/79�,�!� ;,�#$�#!� 72

.��0.0��0

.��0

.0��

0

.0�"

.0�(

.0�<

.���

.0�" .0�( .0�< .���

6-/97/�6�E� ���,#�4/7 -/7

#�F6- �,�9��,/�6!�;7/� ���,#�4/7 -/7

:�������������9�� ��#���1����0 !�<�%%������/!�0�!3

����������������#�����#�������� ���� ������� ��#����������������9�� ��#�����:���#��:��#��������:��#����#�����##����

�������-

���������:�������� ������������� �������� ������� ����������� ��������� ������������� ������������������� �����������$����)� ��������� ������� ���� ��������������� ������ ��������� �����������,�� ����� ����� �� ����0����������������� ���)� ������ ������� ��� ���6������ ������ :�������������������� ��;������ ���������

9�������0;!�F��0E0�$&�������;;�=0����//%F��!;��!�G��/(!���=� �<�� ?� ��� �!����=� �<�� ?� $�;;!�!���0%&� �;�<�� ?� ��� �/!�0���=� /��/!�%F� 0�$� �!0%!$� ��(���������F��!�� ����/!�0���=� ��/��/!�%FB�0�/�(�!���0%%F� %!�?0%� ����0����� <�%%� �!� �!0�!$� <?!��<�� ?� ����F/0��!$&�:#��#�����#9�������##�������9��������������������������:&

#���3������������������ ����������������������������� ��

����� �����, ������� �� � �������� �� � ������ ������

I���J�0����������������� ������������ ���������� ���� ��

!��3���������� ������������������ ������������� ����� �3��

������ � ������� �� ����� ������ ��������� ��� ��� ��� � ���

������)������������)�����������)������ ��������

��������� ���1�������)����� ������������������

5��&�������"'� ������ �������������� �� ��������� �� �

����������,��� ��������������� ������5��&�����

�"'� ������ �������������� �� ������������ �� ���������

#����� ����������� �$$��� ��

����������� �������������� ���������������������������

��������� ���������� ������������� ��L

��. /����� ���� � ����������������� ������������. 2������� ����������� ������������������ ������

��� ��������������������������%�

�������)

������:��.-J�&$&���������#�������:��#>�:�:

���:��#����������������(������� �#�����������#�

��:� #������#��������#9��

���2/�=��1�-17

���4/7 -/7 ;,�#$

���4/7 -/7 79 ,91�$� 7

��. ,�� ������� ������� ���������������"�. ���� ����� �������������� ���������������;���$

��� &�� ����� �� ���� �8������ &��#�������3������������������� ������ ��� � ������ ��3�� �� ������ ������� �� �� ��� � ���� ������� ������ � ��&������� ����%����� ��'�

%�. /����� ���� � ����������������� ����������(�. /�������� ����������������/���� ��������� �����

������������ ���� ������������������ ���*�. 2������� ����� ������ ������������������ ��

������� ��������������������������%�

<�. ,�� ������� ������� ���������������

Page 19: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����+

+�. ���� ����� �������������� ���������������;���$

��� &�� ����� �� ���� �8������ &��#��

�����3������������������� ������ ��� � ���

�����3������������������� ����� ������������� ����

� � ��&������� ����%����� ��'��6 ���������������

���������� �����������������������"�

�0. #������������� ��������"��6������ ������

������3����������&������� � ���������� �� � ��

������)� ����������� ������ � ��������� �� ����

� � �� ������'�� �� �� � ��� ����� �� � ����� � � �

���������������� ����������������� ���������

������� �����������$!��;����?!�;���0 !�����/!�0�!B��?!

%0�=!���!=0��A!������0%<0F���!�����?!� ���������

0����%�<!����$!��;��?!��<�� ?

7�������.����������� ������������� ���������(0J

���� ��� ���������� ������������� ����������0J�

4������������� ��������(0J�.���0JQ��%0J

�?!� /�!����!� $�;;!�!���0%� �?��%$� �!� =�!0�!�

�?0�� *&*J� 9& &

1-8&,�03&

��. ;���� �� � �������� �)������ ���� � ������������������� � ����������

��. /����� ��� � ������ ���� ����� /���� ���� ��������� ��������������� ���� ������������������ ���

,������������ �������� ������� �� � ������������ ������

����� ������0J� ������������������������3���

��. /�� �� ������������ �������� �3����� �

��. 4������ ��� ��� ������ ��� � ��� ��� ��� ���� ��������

��. #������ ��������������� ���������

"�. ;����������������� ��� ��������

%�. 6��3������ ��������������3������� ����������

��D��� ��������:�����������#�

F�3��������� ������� �������������������� ����� ���� ��

��� �� ������������������������

�D�> �5����� !�!����=���� !$��!

9������:������#������#��#�K����!��;�����> �=%�!�0F��=���!�$����=��F��!�� ?! C&��!��A!��/0�C/%�=�<��!�;�����=������� �����%��!;��!��*>�/�<!����0//%�!$&��! ���! ��<��!�0;�!���<�������!�&

��.� F������������ ���� ������ ������������ ��

��. 2�������������������������)�����������������������������,���������� ���������)�������������������������� ������ ������3� ��������� ��������3����:�� �

��. #�������������������� ����:�����

"�. ��� ��� �:�� �������3���� ������ ������� �����������

%�. -���������������������� ���4?#��������4?#�

�6 �����������6 ���� ����� �%� ��%��������� ����

�������3� ������������ ������������������������

��� ������ ������3� ��/������������������������

�������������� �

(�. 4�� �������������� ������ � ��������������������������3� ������������ ������#���� ������������������� ���� ����� ��������� � �����������3� �� ���3����� �3���������������� �� �����3� ������������������ � ������������

������#� � ���� �� ��� ������ '� ��� ����& ��#��

�� ��� ������ ������� �#����

*�. ,������ ������ �������������� ��� �������� � �����)

����������� �����������3� ����������������������

����� ��� ������� )�������������� ��������������

��3� ��� ���� �� ���� �������������A"� ��������

���������&�� �� ��� �������������������� ��'� ���� ���

� �� ����� � �������� ����� :�� � ��� ����)� 4?#����

�������$���:�� � �� ����� ���������&������� ���

�0�������'�

�����*���#��� ������ �� �#������ &��� "� ��$

���� ����� ���� �������� �� �#���� -�##�� ���&�

������ ��� �� ���� &��� ������� ����

<�. �� ����������)������������������ ���������� ������ �� ������3� �� �������������� :�� ���������������������� ���� �������� ������������������������ ��������� ����������������� ������������ ������ �

+�. $������:�� ������������������� ��������� ��������� ������ �

�D>!����=� ����$!�0��������� ���3���������� �� ��� �������������� A����� �3�

������������� ��� ������ ����"J� &(�0��'��������������J

&*(��'����������,����1�(������������������������������

�������������� ����� ���� ����������������)� �����5�

�� ��� ���� ���� ��� � ����� �� �� � ���� ������������� � ��

����3����;� �� �� ������ ��� �������������������������

�� �)� ������� ������� �����������������5����� ���������

�� ����� ��� ��������������������� ��������������3��

������������ �� ����������������������

����#�����;;� �!��� ����������0��� 0�� 0��!�?!0$0 ?!�B�0��!0B�$�EE��!������0�/?F2�0����&��2 !���A!�!2(/����!���� ���0���0�!$� ����������0���<�%%��!��%���� �0;!�F� 0�$� /!�;���0� !� �!%0�!$� /���%!��&�A��$�!2/����!�����?!�;�%%�<��=������0� !������?! ����������0�����//%F"�!��0�!���<0A!���%������L ?%����0�!$�<02!��0�$� %!0�!��L ?%����!��0�!��<�����=�/��%� ?!�� 0%�L90�!����;�!���=� ?!�� 0%�L:!D� ��=��0%������ ?!�� 0%�L 0������!��0 ?%���$!L�0%�=!���F/!��!;��=!�0���L %!0���=���%A!����1�� ?�0��/!� ?%���!�?F%!�!3L�������=���C�B�/0�����!��A!��B�A0����?!�B�!� &L�F$�� ?%��� �0 �$L !�!����0�$�=%�!�L������0�� �;0��� ���;�!�!���;��� %��?!��$�F!��L�0�$�0����F�0 �$�<0�?��=��0�!��0%�&

Page 20: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����0

���0C!���/��=

���. #���� ��� �3���������������������� ���� ���� � �

����� �

���. /� ��������� �� �������� �� �����#� ������� �

��� ���� �������������� �� ������������������� ����

�� �3��������� ����� ������ ���

�2?0������/��=

���. #���� ������� ���������� �������������3� ���� ��

�� ������ �������� ��� ������

���. ������5� ��������������� ��������� ���������3� �

������� ���������������A"J�&(��'�������������J

&�0%��'�����5� �������������� ������������

$�5� ��� ������������ ����������� �������� ��

�����%�� ��&��%��'�������������������������"0������

���� ����������� �������� ����������� ��&�+��'�

���� � �8����� ���� ������ �� ����� �������� ��

#��� ���� ����� ��� �� ���� �� ��& ������

���� � �8����� ���� #��� �� �������� &�� ,<"6

�,0##� *�#����8 �� �+������� &��� ��� ������� ��$

������ ����� '� ��� ����� ��� ���� �� �8����� ���

���� �� ������ ��= �8����� �8����� #��� �� ��������

&�� ,<"6 �,0##� *�#����8 �� �+��������

����#�:������$�� ?0�=!�!2?0���������0��!2�����=���0 C�����0 C��?0��0%����!�A!��0���?!��=0��0//%�0� !&�;�A!��� 0%�$�� ?0�=!��?���=?�0��!2�����=�����!$��0 C�����!@���!$B����!����> �/�/!�����$!��?!���0 C����%��?!�!�$�����!F��$��?!���/�������%!��!�$��;��?!�!�0%���0 C&

����#��?!��!2?0����A!���/�/!��/!�0�!����$!��/�����A!/�!����!�0�$�������!� ��/%!�!%F��!0%!$����/�!(A!���%!0C0=!��;� ����������/��$� ���������?!�%�A(��=��/0 !&

�!��A0%��;������;���� ������>!����=��F��!�

,�� ������� � �� �������� ������������������������

��� ���� ��� ��� ������� ��� �� �� ����� �� ���� ���

��������)� ������ ������� ���������� ������ ������

��� � ������������� ������������������������������ ��

�������������� ������������������������&� ���������

������� ����� ������� ��'��������� ��� � ������

��� ��� ���� ��� ���� ,�� ��� ��� ���� ��� ��� ���� ����

��� �������������)���� ������� ������������� �����

��� ������������� ���

���. �������������������������� ����������� ��������

���

���. ?�������������� � ������ ������� ������������5�

������5� ����� ��������� ������ ������������3�

������� �� ��)����3���)���������� ��������

���������������������������������������� ���

���. ,�������������� ����)������������������������������

����������������� ����� ������������������ ������

��������� �������������� ��� � ����������� ���

��� ������ ��� ������� ��� ��������� ������������

���� �� �� ���� ����� ���� ���� ����������� � � ���

��� ��� � ����������� ������� �����������������

���� � ����)� ����� ��� ����� ���� ���� �� ��� ���

���� �)��� ������������ ��� ����������������2��

��� ���������������� ������#������������������

���

�"�. =���� ��� ���� ���� ��� �� ����4����� ������������

������ ������ ��� ������ ������:�� � ���� � � �

������������������ ���� ��������

�%�. ��� ������������� � ������ ������������������� ��%

���� ��� �� ����� ����� ��� ���� -��� ��� ������ �

�� ����������)����3������������ �)������

�(�. �� ��� ������������ ������� �� ������������������

������������� ��� � ����������� ������� ��

��������� ������� �� ������� ����������)�� ��

��)�������)������� �����)��������������������

���� ��� ����������� ���������� � ���� ������

���� ���������

�*�. ,�� ������ ��� ���� ��� ������� ������ ���� �� ��

����� �� �)� ��� �������� ���� ��� ������ � ��

��� ���������������� ������� �������������.

��5��� �������� �������������5������� ���������

������ ��������� �� ������������������1���� ������

�� �� ���������� ���9� �����=����1���#����9 ,

R���.����� ���-� ���)����� ��������� ��#� �����

9� ����1�������4������������������� ������5���

������ ��� ��� ���� � � ������� �� ��� #�9A

#1�.6�"+������������� ���9� ����1�������4����

,�� ���� ���#������#������

���0C!�0�$��2?0������/��=��!����0�����

,� �3������������ ��������������� ����� �����5� ����

��������� ������������� ������� ����� ������,��� �

�������� ���� ���� ���)��� ����� ����� ��� ����� ��

��������������=�������(� ������<����� ������� ��

���� ����

���. -���������������������� ������ ��� �� �� �3�

���������� ��������

���. ���������:�� �)�������������������)����� ��� ������

��������������������� �

Page 21: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

���. 4����������� �������������� ���������������

���� ��������� ���� ������ ��������������� �����

�����(��!�� ���� �3����������������&��������������'

��� ������ � �������� �� ����� �.������ ��� �� ���

���� ��������� ����� ���)������������� �����

��� ���������� ������ �3�������

7����� ������� �3����� ����� ������������������

5�����2�� ���� ���� ����� �������������� ��

����������)���� ���� � ����� �3���������������� ��

������ ����� ���������� ���������� �� ���

�"�. ,� �3������������ ������������������������������

�� ��������������� � ����� �������&���� � ���

��� � ���'�� �F������������ ��� ����J�&*(��'��

�� ����� ��������(J�&�%���'������������� ��

���� ����

�%�. 7����� ����������� � ����� ��� ���� �� �������

������,��� ��������� ���)����J�E��.�A�J��������

�J���� ���)��J����J����������J���� ������� ��������

�� ��������� ���������� ��� ���� �� ���� �� ��� ����

���� �������� ���������� ��������� ����� �3������

����

�� ����� ����� ���)� ����� �3��������������� ����

�� ��� ���� ����������� ��+0��������& ���������('�

�������

�##�����������#��4��1�)�,)3���D-8�*, �;����1)�3�>!����=1--5-�3���D),7��;���+�1,3�>!����=

�� #�:���#��:���� ���� �

�.�1�+3��#����������#����

�� #�:���#��:��� �

+�2��1,�2�)�3�#��2��D�.�1)��2�+73�> ���:� ��

+1,3����&

��1+*)3���#>��>��������#9� �������#�

+�1,3�#��1)�3��>

��#>�:������#���#������4����:�������������

7�1*+3����

�� ?!�1��3

���#�����:��������!�� �!!������/!�;��0�!$��!�0%�������0C!0�$�!2?0���� �!����0�����&�:���=����<�%%� 0��!;�!!E!D�/��0�$��0F��%� C��?!��!����0�����&

���� � 4� &���� ����� ��#�������� � ����& 0"��/ �����7 �8$����� ���� #��� �� �������� &�� ,<"6 �,0##�7 *�#����8 ��

�+������� &��� ��� ������� �������� ����� '� ��� �����

��� ������ ���� �� �8����� ��� ���� �� ������ ��= �8�����

�8����� ��� #��� �� �������� &�� ,<"6 �,0##� *�#����8 ��

�+�������� 4� �8���#� ��� �#��� �����7 0<>6 �,?##� *�$

#����8 �� �+������� � ���##������ 4�������� �� ������

���� �� �8����� ��� #��� �� ������ �� &������ �� ������

�������� ���# ������������

���� � '���� �8���#��� ��� ��#���������7 ����&

�����8#����� "��/ � � @���7 ���� &�� ���� ���� �� ������� ������� ���������� ����7 ���� &��� ��������7

#�� ���# � � ��� �8����� ���#����� ���� �������� ���

��� ���# �������� ��������� )����� ��� �#�� �� �� ����� 2

#����� &�� �������� #��� �� ������#�� *���7 � ������

���� #�� �� �������� �� �8����� ���� ��� ���#�����

�� ������� ����.������ -����� ���� ���������� �� �

�������� ���# )����8� (�� ���������� A��� ����� ���

���� ��#�����

���� � ���� #��� �� ����� �� ���� ���������� �� �8$

����� ��� ��� ����� ����

�(�. ������������������ ����� ������������������� �)����

���� � ������� ������ �� ���� �� �������� �� ��J

&�0%��'� ������ ��� � ����� ������ ,� �3�� ������

�������������� ������������� ����������*�

�������,

�.�1�+3�����������������#����

�� #�:���#��:���� �

�1)�3��> �D�.�1+73��>

��1+*)3����&

����D�.�1)��2�+73

�> ���:� ��

�.�1�+3�����������������#�

�1�)3��������

�1)�3��> #������

7�1*+3�������

#����:�9���

�� ?!��1��3 �#��>��99���������4��

1�)5,-3���D-8�*, ��;����1)*&73�>!����=

�*�. ������������������ ����� ���)���������������� ��

��� ������� ����� ��������� ��������� ���������� ��

������ ����� �3����������<J�&�0���'�

Page 22: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

�<�. ,���� �3������������ ����������� ���������������������

� ��� ��� ����� ���� �������� ��� � ��� ��

� �� ���)����������� �������� ����������� ��&�+��'

���������������������/���� �������������������

������������� ����;�B������ ����� ���3� ����

����� ��������������� ����������� ���� ����������(

�����3� �;�BE����������������*��;����������

������ �3������������ �������������� ���������)� ��

������ ������������������ ��.�A�J�&�<��'��� �� ��

������������������ �3�����������������8��������� ���

+0�� ����� ������� -����� ������ ����� ���� %� �&��%�'� � ����8������� ����� ���� ��������

�������7

�#��>��99�������������#�

1�--3���D-8�*, :�;����1)*&73�>!����=1--5-*3���D),*���;���+�1,&3�>!����=

�� ?!�1��3

#����:��9���

�.�1�&,3��#�����������#������ #�:���#��:���� �

#/����0%�����$�<��?�<�

1���0C!�#�%F3

�������8

��1+*)3���#>��>��������#9� �������#�

�������

����������������#�

����4����������#�

����4�

�� ?!��1��3

#� ����� ��##��#�����������#�1*�,,3���D-8�*, ��;����D)*�M�D,)�������#�%F1++48,3���D7,8-�;����D�**�M�D�)�������#�%F

���#��������� 0�0$�0������0%%0������#�%F"��� 0 ��$0� !� ��� ��. ��D��-8&�� 0�$� &B� �?!��������0%%�<!$�$���0� !��!�<!!���?!� �����(�����0������0C!���%!��0�$��?!�!2?0�������%!���;���?!�0//%�0� !���?0%%������!�%!����?0���J�1+*)��3&

�������+*

�������

����������������#�

����4����������#�

����4� ��1+*)3����&0��A!�=�0$!&

#� ����� �9�������������#�1*�,,3���D-8�*, ��;����D)*�M�D,)�������#�%F1++48,3���D7,8-�;����D�**�M�D�)�������#�%F

�� ?!��1��3

�������+�

N�?����!$� !����������! !��0�F�;����D)*�����������=��D�.J�A!����=&�!!�A!����=��0�%!����/0=!��;����02�����A!����=�%!�=�?��<��?��?��

0��0�=!�!��&

��1+*)3���#>��>��������#9� �������#�

�� #�:���#��:��� �

���&�0%'�F,9������&%�'�0�&%0<'�F�E������&*('

<�&�0�'F,9�

�.�1�+3��#����������#�

�.�1�+3��#����������#����

�� #�:���#��:��� �

��#>�:������#���#������4����:

���������������>���+�18�-3

#����:��9���

�� ?!�1��3

��:��>��99������������������#�

1�)�,-3���D-8�*, ��;���J�1)�3�>!����=

�+�. 4�� ��� ����� ���������� ��������������������

� �� ������������� ����������������������� ��

&���������������'�������� ����������� �����������

��������J�&�0%��'�������������������2�� ����

�� ������������)�� �������)�������)��� ��������

� �����������������2�� ���� ��� ����� ��

���������� ������J�������������������������3�

����� ����� ���1�(�������� ���������� ���� )�#� ���

,?�����������)� ������ ����� ��� ����� ���������� ��

������������������,�� ����������������������)����

� ������� �9� �����=����1���#����9 ,�R���.����

-� ���)��������� �� �������#�9A#1�.6�"+���A����

���9� ����1�������4�����,�� ���� ���,�� �� ���

���#������ ���� ���������� ����� �������������

���� ���J� &�0%��'� �������������� ����������

��������� ��������� �� ������������

Page 23: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

;���� ��5� ����� ��� ��)� �������� ��������� �

����� ���������� ����� ��)������� ��)�������

�������������8������ ����"�� ��&����'���- ���� �����

�����/���� � ������� �#�9A#1�.6�"+���������

����� ���� �������#��������� ���� �� ����������

�����:������ ���

� ���� � ����� ��)�������� ���� �3��� ����� ���

� �� ���� �� ����� ��� ��������� �� ������ &��

������������� ������� �������� ��������� �

� �� ������ ����'��, �������������� �� � ������

���� �� �� �� ������� ����� ����(���� �&��<�'����

������������� ��������� ���������� ����������

���� ������� ����� ����

���#����� ���������� 0��� ���0C!� ��%!�� 0�$� !2?0���� ���%!��?��%$������!�%� 0�!$�<��?����;�&�1�&7�3��;�$�F!��A!����� ���������� 0��� ��%!�� ��� ���%!�� �;� 0���?!�� 0/(/%�0� !&����/��=��?��%$�����!2���%!����?0��+�;�&�1&8��3;�����/!���=������0���?!�����%$��=&

�������+

�� ?!��1��3��#���>��9

9�������������#�1�--3���D-8�*, :�;���1)�3�>!����=1--5-*3���D),*���;���+1,3�>!����=

+�1,3�#��1)�3�8*�����#9

�.�1�+3�#��

��������#�

�� ?!�1��3

+�1,3�#��1)�3�8*�����#9

+�2��1,�2�)�3�#�

�2��D�.�1)��2�+73

��:� ������������# �(

��#�

�#��#���������������#�

#/����0%�����($�<�

1�����?�<�3�0F��!���!$���

���0C!�#�%F

�������++

������#�������� �����(����

#�������9��������

�0. ���������������������������� �����������������

%���� �&��%��'������������"0�4?#���������������

&�+��'����6 .2;?)�4?#.2;?)� 4/.���4?#)����

2/.�(�4?#�������������� �����������������������

�� �������������� �������� ���� ��������������

���� ���

��. ,�� ����� ����� ������� ���� � ��� :�� �� � �� ��

�����)�������� ��������������� ��������������

������ ������������� �������� ���������������

������

��. ,��� ���������� � ������ ������� ���� �� ���� ����

��������

��. ;����������������� ���������������������������� ���

��� ������������ ������������� ���)����������

���� ������)���3���������������������������

�� ������� ��� �������������

�". 6������� ����������� ����� ���������� ��)��

��� ��������������� ���� ����������������������

��� ����� ���3� ��;�B����������� �� �����5��

����)�������������������%�

�������+-

�1+*)3

)1�,3

�.�1�+3���0�����%0�������

�� ��$�����!$��/0 !

��������>���

����4��>���

#����:��9���

��������>���

����4�>���

������>�!<

��$!�>�!<

>�������������#��9�������������#��4���1+*�73�9�4

�� ?!��1��3

Page 24: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����"

�������+)

�������>���

����4��>��� %.�A�&�"0'

������>�!<

��&�0%'

%&��*'

�<�F�E�&"%*'

��������>���

����4�>���

��$!�>�!<

#���#����>�������������#���#�������������������������#�9�������������#��4���9�4

�� ?!��1��3

�������+

���F,9�&�0%'

�����1���

#>����������>����9����.�1�+3�#��

��������#�

������>�!<

��$!�>�!<

>�������������#���#:���9�4�9�������������#��4���1+*�73�����:�:�>�����#�����:�� ������ �

�� ?!��1��3

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

)1�,3

)(�.

1�-*3

����������

����4����

���:�

1+*)3

ÉÉÉÉÉÉÉÉÉÉÉ

7�1*+3

�������

��1+*)3�������

��#>�����:�

����4����

����������

���:�

�������+,

>�������������#���#:���9�4��1+*�,83

�������#���������#�����:�� ������ �

"&�0�'

<�F,9�

&�0�'

��������>���

����4�>���

���:�

���:�

�������>���

����4�>���

�"&<("'

��&�0%'

+&��+'

9��7.7������� ������ � ������� ������ ��� �� �� �A�J� &����'���� ������ ���� ,�� �� �3�� ��������� ����������������)���� ���� ����� ���� ������ ������ ������� � ������ ��7������ ���� ���� ���������� ���

������>�!<

��$!�>�!<

OU

TSI

DE

WA

LL

��>������������������� ������

9��7.2�� ���������������� ����������� ����� ����������������� �� ��3��,���� ��������������� ������������ ��������������������� ��3�����8����)����� ������������������������ ��� ������������������������ ���������������� ����� ����������� � ����,�������� ���� ������������)� ��������� ���� ���� ���������� ��������� ���� ���� ������ ������ ������������� ���������� ����8���� � �3������� ������� ����� ������� ��������� ����

�������+7

<J�.���J&�0����.��0%��'

�J�.�<J&*(��.�0���'

�J�.�<J&*(��.�0���'

Page 25: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����%

��$!��0�!���/��=

�������� ����������������� ������ ������ ��������� ����������� ����������#������ ���������������������� �������� ���� ������� ����������� ���������5�������������� ���������3������������������������ ������ �������������������������������� ����������������� �������� ���������������������������������������1�(��� ��

���. 2� ������������������������ ���������� � ������ �

���. #���� ��A�J�&����'����� �������������&������'��� ���������������� ���������� �� ����,�� ���������� �� �� ������������� �� ��� ��� ������ �����������2� �������� �������� �������� ���������� ���������������� ������:�� �� ���������"0�

27��,!��=�=!-7��/�4

������������������D��0�$�D

��$!%�

-9,��#�6,97�

IGJ�#�997#��/

6�����/�#�4

/-667/�#�997#��/

$� 7�#!�F4

$� 7�6�/6

�������+8

#�:���������������1����%!;�������=?������0%%0����3

�������-*

#�:����:(���#�

������

�:�����

�:�����

������ ���� �##��#�� ��

#������#�������#9������ 4(

��

#�:�����������

���. -��� �������������� ��&�A�J�4?#����A�J�F4�'����

����������&�A�J�4?#'� �������������� ����� ��

������ ��,�������������� � � �����������)��A�J�#4?#��

�A�J�F4������ �������A�J�#4?#��������� ������

����

�"�. 1����������� � ������� �������� ������������ �

��������� ���IH�� �#���� ����4������J���� ���

����������A���� ������������������������� ��

��������������� �������������� ������ �� ��� �

������ ����������������� ������ ���:�� �

������=?�(�0�$���$!� ��$!��0�!��2��"

,�� ���� ���������A���� �������������� ���� ����

�� ��� ������ � ���� ���� � ��� ���� �� �� � ��

����������������� ���������� �� ���

�����!;�(�0�$���$!� ��$!��0�!��2��"

,��� �������A���� �������������� ������ �����

������� ��������� ����� ����� �������� �����

�������� ����� �� ����� � ��� �����������

������� ���������� �� ���

�%�. #���� ������������������������� ������������� ��

����������4�������������������� ��� ������ ������

���� ������������������ ���������"��

����#�:��������!� �//!�������=����!2�����=� �//!�� ��$!��0�!�%��!��;���$�0���%��!&

�������-�

#�:���������������1�%�����=�������!�A!��!$�?�=?!���?0�� ��%&3

Page 26: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����(

�������-

��D+����#����D��#:��� #�:���������#>�����# ����

�=!-7��/�4

#�!2$7�27/6�E

=!-72/�,9$� 7

$7�27/�6�E#�9279 ��7��/�4

"

%

(

*

?79�

#�F6- �,�9�,/�6!�;7/

��$!��0�!��!��A0%���� !��"

�. #������ ���������� ����������� ���� �� ������������� ��� �����������������

�. #������ ��������������� ����������� ����=�������� ������������ � ������� ������������������������ ������������� � �������������������� �� ���

�. =�������� ���������������� � �������������������� �� ������������� )� �������������������� ������������

". #������ �� ���������� ���������� ������������������� ����������

%. ;� �� ������ ���� ����� ��� ��������� ���� ���� ��� ��� ���� �� � ������������������ �� ���

(. ;���� ����������������������� � ����������)��� ������������������ � ��������� ������������

*. ��� �� ����� ������� �� ��� ��� � � ��8����)��� ������ � ��� �8������������� ��� ��� ��������� �������� ��� ����������������&������������������ ��� ��� ���������������'�

:������#�� #�:����:��� #�:������������

#�!2�$7�27/�6�E

$� 7�6�/6

/-667/�6�����/�#�4

�A�JF4��4!-1�A�JF4�����=7F�!74?#�4,47��2�4�7/

�A�J4?#

#�,!��479,91�67$,92#�!2�$7�27/�6�E

:������#�����������

$� 7�6�/6

(

%

#�9279 ��7=/�F�#�,!

"

=!-7�2/�,9�$� 7 ,27�27��,!��=$7�27/�6�E

#�9279 ��,�9�/�4

=/�9��27��,!��=$7�27/�6�E

#�9279 ��,�9�/�4

�(�. #���� �������� ������������&�A�J�S����T� 2/���

���� ��������� �����'� �������� ������� ����

���������������������� �� �����������#�����

�� ���������� ����������������������������

���� �������,����������������������������)�������

�� ���������� ��������� �������� ��������#�����

�� ���������������������� ����� ���� ������� ����

������ ���������5������������� ���������3���

�������������,�� �������� ��������)������ �������3� ����

���������� ���������� ��������������������$�� ���

������3� �����������������!������������������ ��M

(� ��&��<�'�.�3� �����<B"<M��"� ��&*���'�.�3� �����<B"+M

����%0� ��&�%���'�.�3� �����<B%0�

���D�����(��

�D��!%����0�F�0�$��!0���0%� ?! C���. ,����� ����� ����������)�� ��������������� ����� �����

����������� ��������� �������8�����

Page 27: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����*

��. #���3��� ����� ��������� ���� ����?� ������� ����� ������������ ����� ���������� ���,��� )������ � ������������������������ �������� ������ �������� � ������� �

��. ,����� ����� ������������ �� ������������������������2�������������������������������

�D�!0���=���0��(�/

=�/�G�-/� �=7�G�/7�2�67=�/7�!,1$�,91

����#��?� C�0�$������?0E0�$&

��������0�!�!@��//!$�<��?��?!����!��=?���=������

�F��!�&�:������0��!�/�����%�=?���0��0%%F&

9������:��������!��?���;���0 !��;�0�F�/0���?0���!!����$!�(<0�!�&����/! ���?!�;���0 !�0�$��!/%0 !�0�F�/0����;�?!� �����%��F��!��0�$�0�F�=0�� �����%�<?� ?�?0��!!����$!��<0�!�&

9�������;��A!�?!0���=�� ��������;�=0����//%F�;0�%������?���;;B��?����;;��?!��0��0%�=0��A0%A!�����?!�0//%�0� !�!;��!��?�����=��;;�!%! ��� 0%���//%F&

����#��!;��!�0��!�/���=����/!�;����0�F��!�A� !�����0��(�!�0� !B�������?!�!%! ��� 0%�/�<!����������#���0�$�� ���! ���<�� ?&

67=�/7�!,1$�,91���������������� ����������������

�������6������ ���������� � � �����������������

�������������� ������������������ ����� ������

-��������������� ���������� ��� ��������� ��3���

9�������� ����,�� ���3��������� ���������� ����������)

��� � �� ������� )��������8���������������� ����������

=����� ��� ���������������� �������������������

1�(���� ������8��������� �� ��� ��!��� � ���� ������ ���

2��9���� ��� � �������������� ��������� �����������

7���� ���� ���� � ������������ )����������������� �� ��

�������� ���������� ������ ��� �� ������ ���������������

��� ������ ���� �� ��!��� ����� ������ ���

%�&�'�����������(����)*������+,-

9�������;�F���$������;�%%�<��?!�!������� ������!20 �%FB�0;��!� ���!2/%�������0F� �!��%�� 0����=�/��/!��F$0�0=!B�/!����0%���G��F����%�����;�%�;!&

��. ��#�U�/���� ������� ������� ���� � �������������� ������� ���

��. � � ���� � � ����� ��� ������. ��������������� ��������� ��������"�. ����� ���������� ��� �8������� �� �� ��� ���� ��� ������

�������� �� ������� ���� �� ���������2����� �� ���� � ����������������

%�. /�������� ��������������(�. ���$��������?/<�0"�����������)� ���3��������

���������3���� � ��#����=�;�� ��/������(7����������)�������� ��� �#��&�2�� ������ ����������"��

����

�9

�==

�������-+

�#���9����>�7*-������������>��>�

����>��>����#9�����#����#����#�

9������#:����+������>��>�

����>��>���#9����#��

�#����#�

*�. ;�� ������&%'����� ��� ������� ����������,����� ������������)� ��4U�,������ ����������������������������������K��������=���� ��������������K������ �� �����,�������� ������������� ���� �� ���

<�. =�$��������?/<�0"�����������)� ���3����

������ ��� ����3���� � #��� =� ;�� �/������(7�����������)�������� ��� �#�&

+�. /���������� ���������������0. �������������� ��������� ���� ���. � � ���� � � ���������� ����

�����B��� ��� � ������ �������7 ����� , ������� ,,

#�� ���� �� �� �������� �� ����� �� ���# ���� ����

������� ���� ��������� ��� &��� ��������� ����

� ���7 ��� #�� ���� ����� ��� ��� �� �� ����& ���������

���� �� ���� ��� � ���#�� ���������

Page 28: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����<

��. �,�� ���������������� ���� �)������ ������ �� ���I����������1�����-�� J�������������������� ������������������������

'��'�� ��$$����'��� �

��. � � ���� � � ����� ��� ����

��. ��������������� ��������� ���� �������������� ����������

��. /�������� ���� ����������������

"�. ���$��������?/<�0"�����������)� ���3��������

���������3���� �#����=�;�� ��/������(7����������)�������� ��� �#����2�� �����

%�. /���������� ��������������

D�0;!�F������!�=!� F��?��$�<�

����������� ������#�������������������������������

:D�2�!�$!$��!���$��?��$�<�

������� ���� � ���� � �I-9�##-4,72J������#���

���������������&� ���� ����������� ����� ���� '� �������

������������3��� ������ ���������������������

���� �������������������)������������� ��������� ������

�����������������

/���� �IF��� ������J���� ����� ���������������� ���

���� �� ��� � ������ ������� �� ��������� �� ���

�������������� ����

�>D������������������>� �� �� 4�

�D�&�&�&. &�&�&� !���;� 0����

������� �������1��������#�1������������� �������� ��

������� �����/���� � ���1�(����� �������,�� ���� ��

,�� �� ���F������,���� ���

�D�2?0���� #�0�$� #� ���!��

#����2��������������������������������������

������������� ����������������)����������� ���1�()������

����� ����������;���� ������ ������������� �����

������� ����������)� ���#����� �� ��� ��������� ���

�� ����� (�0>� ���� <�0>� �� �� ���� ���� ���� �� ����

*�%>�����+�%>���!�4���������#���� �� �������������� ���

0�0">������������ �������������,����� �������� ������

�� ������������ �������� ������������ ��� ���#��

����)� ������ ��������������3�������������������#��

�!����=�;���0�����0%%F�?�=?� #�0�$� #&

������ ����� �� ���� ���#��A#���� �� ���� ���6�����

����#��� �� ��� �� ���=�� ��#��������� ��� ����� ���

�� �� ����#��A#����������������#����������� ������ ���

���������������� ��� �� �3� ����������=���� �������

��������������� �����3�#��A#���� ���1�(��������

���. 2������5��J/J����A��������� ��������� ���� )�:�� ���� ����� ��������� ����� ����A<.�*�94������������������������ ��������#��A#���������

���. ,�� ������������������� ��� � �� ��������. � ����������=�� ����������� ���� ����������"�. � � ���� � � ������� ��� ���������������� � ���

�%����� ����%�. ;����#��A#�� �� ������������ �)� ��������� )���

���� ���� ���� ��������� � ��� � ���� ���� ��.7J/%0��� �/%�=���� %��!��;;�/���&

D�0����/��=

1��� ������� ������� ������� � �������� ����0�%J;�#�

��������������� ����������� ��������� �� ���������

�������� �� ����������� ������� ���������� ���� ������

����������� �� ������������(��� �����������

#������������������������� �������:�� ����������

���� �� � ��� �������8��������� ���������

:D�!����=��0����/��=

;����������� �� �������������)� ���������������� ���

�������� ����������� ����1���������������������������

���:�� ��� ���� ����0�%�����&�"J�;�#�'�� ���������""� ,�

��������������8���� ������� ����0�%�����&�"J;�#�')����

������������� .��������������������� �� ���� ����

�� �����������������������

�������--

!*( C*)C� B4)) ��� -�)' ��(� A;�((D;� 4��E��(( �/ ��2 A(4! �,>6B����

����������������D#��

>��>��9�����#���#�:

�#������������������

��

����� �

��#��������>��>�

������������������# �:����1���� ��3

Page 29: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����+

�������-)

����>��>�

�������:��������

��������:��������1����:��:3

����>��>�

���������������D#��>��>�

���#�������� 0�!�!�!�=!� F��?��$�<������!@���!$B�������;;�?!��0����?��(�;;�A0%A!�0�$�$�� ���! ���?!��0��/�<!���������&���?!�!� �����%���?��%$��!�/��/!�%F%0�!%!$��F��?!�����0%%!�&

;��������3���������������� �������������3�)��������

������������B� ������� ���� ���������������������

�������������� ������������������������-�������������� �

1���!��3�2� �� ����� ����������������, �������������

����� !����� ����� �� � ������ ��6�00��� ���#��

<"��.!�0)����� ����� �����

2�� ������� ����)��������)������������ ���������

���� ��� �����3����������3��

�D�!����=��0����//%F���!����!;���� �� ���������������������)������ � �� �������

���� �������� ���&������������'�� ���������""��#���3

������������������ ����� � ������� ���������� ���!�

��������������� ������ ������ �������������$���

��������������� ����������� �������� �����������

�������=��� ����������� �)���� ������������ ����

��������� ������ ������ �����"�%J�;�#���������0J�;�#�

=�!�4��������� �)���� ������������ ���� �����������

������ ������ �����<�0J��������0J�;�#�

������ �������� ���� ���� ���)��������� ��������������3��

����� ���)��� �������� �� ���� ����� ����� ����������

������� �������� ������������ ���������������������

�D ?! C��0��;�%$���!����!F������� ��������� 4������ ��� ��� �������� ������

���������������������� ���&���������������

������'�� F������� *�������� 4������ ��� ��� �������

�������������������� ������������������ �������

� ����� � ��� ������ � ������&��������� ������������

���'�

�� ���������������������������3���������:�� ��)�����3

������������� ����������F���������������� �� �

�� �������� ������ �������� �����������&1?�'��#���3���

������������� ��������������������������� ��������

������� ���:�� ��� �

F���������� ������������� ���1�(�����������������

���� ���� ����������������������������������������� � ��

��� �� 9���� �������� ��� ���� ������� �� �� ���� ���

��� �������%� ���%���������&������������'��=�!4A���������

������ ������������ ��������������*�%����������&���

��������'�

���#����������0;!�FB� ���! ��0��?��(�;;�A0%A!��!�<!!���?!�0���!�!��0�$��?!�=0���0/����/!������?����;;��;=0��/�!����!�����?!��0���!�!�&

�������������������� ���� ������������ ��8������:�� �

��� �� ��� �����+�����)���������������� ����������� �

���������������&����������������'�

.# �$�� �/"������0��������#�����!� � �/ 1��2

!�

��. #���� � �� ������� �� �� � ���������������

��. 2������� ����������������������������������������������!������������������������� �� ��������� ���������"(�

��. � ���� ����������%����� �������� � ������� ����� � ��

Page 30: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����0

�������-

�����#�:� �� 4

���>��>�

��������#��

���>��>�

�#��>��9�����>��>��:�����

#�������������

���

�#������

���������

"�. ;�������� ������ ������ � �� �����5�)�� ���� ���������=��������������� ���������������� ���� ���������9� ���� ���� ������ ���� ������ !�4�� ���� ������ ����� ���������� ������������ ��3��

%�. �� ������������� � �� �����5�� ��%����� ��)� ����������� ������� ���� ������ � ������� ������ �� �����+��/����� �������� ������� �������������������������

����%��!���!����!�1���%!�3���&�9& &

������8����>��>����������#�N

��%�O0���0���0%

�&�& *�%�O0�*

�����1��!%3

�����(��� ��� ��� ��� ��#��� #���#���� �� ���� ��

�� ������ ������ ��� ���� �������� ���� ��� ��

������ �������� ��� �����

�����'���� ��� ���� ��������7 ��� ��� &�� ��

��������F

������� ��� ���� ���� ������ �� ����� ������ ����$

�� �� ������� ���������� ���� �8�������

*���#��� �� ��� ��� ����� ����� ��� ��������

&�� �� �������� %������ ��� ���& ���� ���� �����

���#�� ��� ���������

(�. ;���� �� ��������� ��������� �� �������������� ������� ���������������

9���������!�0�$�!2/%������?0E0�$&�?!�!������� ������������!�;�%%�<!$�!20 �%F& 0�� 0��!�0�;��!����!2/%�������!��%���=����/��/!��F$0�0=!B�/!����0%���G��F����%�����;�%�;!&

�D����/!���0���%�<�1�//��2��0�!3=��������������� ��� ����� �%����� ������������3�

�������������2� ������ �����������������<�������

���������� ����� ����� ���&������� ����������

���������� �� ����'�2��������� ������������ � ���

��� ������0����������:�� ���������������������������

��� ��� �����������

����� �� ����� ������ ������7 ���� ��� ��� �������� �������� ������� �� #�����

�������*

���������� �# 4���� ����

�! ��$��;���#�!��!A�%�����

� �����0���0% ��

�������� ��;�:�0%

� ��;�:�0%

�� ��;�:�0%

� ��;�:���

.%0 *� �"" �<0 �(0

.*% "< +( ��0 �"0

.�00 �( *� +0 �<0

.��% �+ %< *� �""

�������������9� ���.�000�� �A���� ��������������!4.�%00�� �A����

�D��=?��%����$!�:!�0�!-�� ����������������� �������� � ����������� ��8���

3� �����:�� ��� ��������� �����������*%00�� ������� ���

F�������������������������� ����������� ���� ���

����������� ,����� � ��� ��� ������� ������ � ���������� ���

*%00���� �&��"<��')����� �����������

�������� � ��� ���� ���#����� ���� ������ ��� ���

��������

���#����������0;!�FB��?���������;;�0�$��!��A!��0���!�!��0������0��0��0 ��0�!��!0$��=�?0���!!�����0��!$&�0C!� 0�!�����!/%0 !�/�!����!��0/�/%�=&

�D�%0�!���=�0%���0��������2#��� ������������ �����3� �������������

������ ��� ��!��� �����H�����1**(����� ����� ���-��

��������������� ��������&�� �������*<$%"0�'����������

���!����� �������� ����������������

=����� &������'� ������� ��� ��� ���� ����� ���� � �����

���������� ������� ����� �� ����� �������������

������������ ���� ����#��� ����������� �������

�� ����� ��������� ������ ������ �������� �����

��� �

����!0���!��%0�!���=�0%"

��. � � ����� ��� �� � ���2#��� �����������,��� � ����������� � ���?2#�������������� �������������� ����� �����=������ ��������� ��������� ����&.'�������

��. ���������������� ���� ��� ��

��. 2������� �������������������� ������������� ���� ��

Page 31: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

�������-7

����� �������������F�9�F7�7/

1�(�-9,�

4������

"�. #���� �&O'�������� �������� ����� ����� ������������� ���� ���������"*�

%�. #���� �&.'��������� ��� �������� ����������� ��������"*�

(�. ������������� ��������������� ���� � ��� �� � ���������� ���

*�. ;������� ����� �)������� �������� �����������/����������2#��� �Q���2#��������

��������

��������������� �#����

1�(�.������.� 9��� 0��%1�(� ������ ������ F������ 0��%

1�( � " %9��� �0�*

1�(�.�)�.")�.%��� .( �����

!� �0�*����.(������

F������ 0��%

79 �/;,/7

������-,

,19,�,�9#�9�/�!

&1**(� $�;9'

I 79 7J��7/F,9�!

2,1,��!F7�7/

=!�F7� 79 �/

�����������������

&O'&.'

�/�9 2-#7/

>D���� ���#��������� ���� ������� �

�D�%�<!��#/!�0�����0�$��$G����!��

����� ��� �����&�� � � �������.�� �������� ���

���� ��� ����� �� ��� ����#����� ��������

��. 6������� �������������� ��� ���� � ��� ���� ���

��. 1�������)��������� �������� �� � ���� � ����������������� ����;� ��������� �������9���� ��)�������� ����� ���������;� ��������� �������-������� ��)��������������� ���������� ������ ���������������� ���������������� ��������

��. ,�����������)������������ ������ ����������������� ����� ������ ����������==���� ���

�D�!�/!�0���!����!������ ��� ���� �� 1�(� ��� �� �������� �� ��� � ���� )

����������)������������������ � ������������

��3����� ������ �� ������� ��������������������� ���

�� ������� ���� ����� ���� �����������I�,/��7F4��/, 7

°=J���� ����� ������ �� ������� ������!0���!��!�/!�0���!����!"

��. 4������������ ����� ������ ��������������� ��

������������!�� ������������ ����� ����� ������

��5� �������� ���������������� ������� ����3������

���� ���� ���� ������ ����������

��. � � ���� � � ������� ��� ����

��. �� ��������� ����� ��������������� ���������

�� ������ ������ ��������)���� �� � ��� ����������

�������������������������� ����������� ����� ������

� ������� ���,�� ��� ����� ������ ���)��������

������������,�� ����� ������ �����)���� �����3

���������� ���4������ ���������� ���������� ����)����

������ ����� ������ � ������ ����� ���� �

������������������ �������� ���6���� ���������

��� ������ �����������

D�2�!��0%���0�� ���!����!

��. F������ ������ ���������������������"<�

��. 4��������A"J������ �����

������������� �����������

� � ���� � ��� ��� ����

������ ,��� � ����� �

������������ �������������

�� ���� � ������ ���� ���

����� ��� ������ �� ���

�������#���� � ��� 5�

������ �������� �� � ������������&������'�����

�� ������ ���������� ������ ���)������ � ��� ��

����������� �� � ���� ������ ����������=

��� ������ ����.��� ���� ���)������� ��� ������

�� �������� ������ � ���� �������

��. ;� ������ ��������� ������������ ��������

������)������� �������� ������������:�� �����

��� ������� �������� ���������������������

���:���8������ ��

"�. 4������������ �� ��������0�%J�;�#�

%�. ��������� ������������ �������3��������� ��

:D�%�<!���/!!$��0/���!0$%!���������

D�B�DB�D+�0�$�D-���$!%�

6���������� �������� ��������������� ����������

�������������������� ��� ����� � ��������� �������

����� ��2������� ������������� ����� � ����

��������������� ���6��������������� ���������� ����

��������

'���� ���3��&������� ���� � �#����

��. ����������� ������� ��������

��. /�������������������

��. 2������� ������� ������������ �

"�. 4���������������� ���������� �������������������������������

%�. ���� �������������������� ����������������&/���Q��� ���)�6���3�Q������)�;�� ��Q�����'�

(�. 2������������������ � ��� ������������ ��������� ���� ������ ���� ���������������&���� ��� �������������'��,��� ����� ��������� ���� ����������������������� ���������%0�

*�. /������������������� � �� ��

Page 32: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4������

�������-8

����!��A!��%�<!�"

�. �������������� ���������-�����H(+� ��� 4(+� ��� ��� �� �������3�

�. 2������� � ���� � ������������� ������������������� ��� �������� ���

�. 2������� �H%<A4%<���� ��������������3�

". 2������� � H"�A4"�� ��� ����� �

%. !����������&�'������������� ����������� ��$��������� ������������� ������ ����������

(. /����� ������ &�'� ���� ��������������� � "

%�(

%

�������)*

��#9�������:��������� ��#�$�/97

#�997#��/

F���/

274/7 ���6����/7!7� 7;,/7� �7/F,9�!�� 7!7#�#�997#��/�!�#��,�9�=�/97;� 4772�&/7=7/����-9,�;,/,91�2,�1/�F'�� � ,9 7/�;,/7�-9�,!�,��, � 7#-/7!G,9�4!�#7�

�������

�������+

�D�%�<!���/!!$��0/���!0$!$�������

D)�0�$�D���$!%�

6���� ������ ��������������������� ��� ��!��� �� ������� ��� �������0��-������ ������� �������������������� ��������J4�/B�F�J������J4�/B�F�J�� ��� ��!��� ������������� ���� ����������� ��� ���J�#6�$7���J� ����������� ��������� ����������� �� � ���J�#6�#��!J� �������������� ����������� ���������� ��� � ���J�#6�!�;J� �������������������� ������� � ��)� ���������� ������� ����

������ �����J�#6�$7��J��� �� �������� ��� �J4�/B

F�J��J4�/B�F�J�� ��� ���������������� � ������

���������������

>�D��������� �

/� ����������� ������������ ��������� ������������������%��

�������)�

�#��#���������������

����� �������#��#�

������������ ���

����������#������

��:��������� �����13

����� ���#��

����� ��� 4

�D��%�!��� � ��� ���������� �� ����� ��� ���� �����)� ��� ��� ���������������3�����������L��. =�� ��� ������ ��� ������ ��� �� ���� ���� ��� � ��

������������������������ �� ���������������������� ���

Page 33: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 33

2 - Reusable foam filters used with the G26 can bewashed with water and mild detergent. When dry, theyshould be sprayed with filter handicoater prior to rein-stallation. Filter handicoater is RP Products coatingno. 418 and is available as Lennox part no. P-8-5069.

3 - If replacement is necessary, order Lennox part no.31J81 for 14” x 25” (356 x 635mm) filter for G26-50and -75 units and P-8-7831 for 20” x 25” (508 x635mm) filter for G26Q4/5-75,G26-100 and -125units.

B-Cleaning Heat Exchanger and BurnersIf cleaning the heat exchanger becomes necessary, followthe below procedures and refer to figure 1 when disas-sembling unit. Use papers or protective covering in front offurnace while removing heat exchanger assembly.

1 - Turn off electrical and gas power supplies to furnace.

2 - Remove upper and lower furnace access panels.

3 - Remove four (4) screws around air intake fitting andlift intake pipe up and away.

4 - Loosen hose clamp securing top of flue transition tobottom of flue collar. Remove screw securing flue col-lar to top cap and lift exhaust pipe and flue collar upand away.

5 - If electrical field make-up box is located inside theunit, it must be removed.

6 - Remove gas supply line connected to gas valve.

7 - Mark all gas valve wires and disconnect them fromvalve. Mark and remove wires from flame roll-outswitch.

8 - Remove top cap of unit.

9 - For -1 and -2 units, mark and disconnect spark andsensor wire from ignition control. For -3 units, removesensor wire from SureLight control. Disconnect 2-pinplug from the ignitor.

10- Mark and disconnect pressure switch tubing fromboth sides of the pressure switch.

11- Loosen two (2) screws holding gas manifold supportat vestibule panel.

12- Remove four (4) burner box screws at the vestibulepanel and remove burner box and gas valve/manifoldassembly with bracket.

13- Drain condensate trap. Disconnect condensate linefrom the outside of unit. Remove condensate linefrom condensate trap by turning the adapter fittingcounterclockwise. The fitting has standard right handthreads.

14- Disconnect the drain hose from the flue transition tothe elbow on the cold header (collector) box trap. On-1 and -2 units remove two (2) screw from flue ”Y” trapat cabinet from door flange.

15- Disconnect the 2-pin plug from the combustion airblower at the blower deck. Remove four (4) screwsfrom combustion air blower and remove flue transitionand blower assembly from cabinet. Take care not tolose the combustion air orifice.

16- Disconnect 9-pin plug from the blower compartmentat the blower deck.

17- Remove 9-pin plug above the blower deck.

18- Remove the limit switch and the pressure switch fromthe vestibule panel.

19- Remove two (2) screws from the front cabinet flangeat the blower deck. Remove front screws from cabinetat blower deck on left and right sides. Cabinet sidesmust be slightly spread to clear heat exchanger pas-sage.

20- Remove screws along vestibule sides and bottomwhich secure vestibule panel and heat exchanger as-sembly to cabinet. Remove heat exchanger then re-move cold end header box. Remove baffles from con-denser tubes.

21- Back wash heat exchanger with soapy water solutionor steam. If steam is used it must be below 275_F(135_C) .

22- Thoroughly rinse and drain the heat exchanger. Soapsolution can be corrosive so take care that entire as-sembly is completely rinsed.

23- Re-install heat exchanger into cabinet making surethat the clamshells of the heat exchanger assemblyare resting in the notches of the support located at therear of the cabinet. This can be viewed by removingthe indoor blower and examining through the bloweropening.

24- Re-secure the supporting screws along the vestibulesides and bottom to the cabinet.

25- Re-install cabinet screws on sides and front flange atblower deck.

26- Re-install the limit switch and pressure switch on thevestibule panel.

27- Re-install 9-pin plug to blower deck and connect it tothe 9-pin plug from below the blower deck.

28- Re-install the combustion air blower. Be careful thatthe plastic orifice on the blower inlet has not fallen out.See figure 1. Reconnect the 2-pin plug to the wire har-ness. Re-install the flue transition in the cabinet andre-attach the drain tube. Route the drain tube belowthe combustion air blower housing and to the elbowon the cold header (collector) box trap. See figure 23.

29- Re-install condensate line with adapter to conden-sate trap. Use fresh Teflon tape to ensure a leak-freejoint. Re-connect to condensate line outside of theunit.

Page 34: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����"

���/%�;�!$�����!���!��A0%"

�. /������������ �������� �� ������ &�'� ���� �������� ���� �� � �����&%'�

�. /����� ��� � ���)� ���3���� ���� ����� ����� /������������������������������������

�. /�������������������

�������)

�������� ���.���#>��

��

4��#$�4!��76�/672�4/7 -/7 ;,�#$��/,=,#7

6-/97/�F�-9�,916/�#B7�

4��#$�4!��7

-9,��?7 ��4�97!

�0. /����� ���� ���������������� ��� ���������������

������� ����3� ��, ������� �� � �� � �������������

���3� �� ��������������� ���������������� �����

������� ����� ��������������� ������ ������������

��. ;� �� ������������� ������ ����� ������ )�����

��� ����������� ��� �������������� ���� ��� �����

��� ����������� � ��������� ���� ������ ��

��������� �������� ����������� � ��������

��� ��� ������������

��. /������ � ���������������� ������

��. /����� ���� ������ ���� �

�". /����� �������� ���������� ���� �����������������

���� �F���������������� �#���/������ ������

���������� ���� ���

���� � D�� � �������$�������� ,"�C ������ &���

#��� �� �������� ��������

�%. /������ ��������������� �����������

�(. /����� ������������3�����������������

�*. /����� ���������� �����A����������������������������

��� � ������ � ���������������� ����������,��� � ��

� ���� ��������������� � ��� ���� �������� �����

������� ��� �������������

�<. /����� ������ �3��������� ���� ����������� ��������

�+. /�������� �����������������������������

"0. /���� ���� �� �������������������������� ��������

��� ������������� �����������������

"�. =����������� ������� �� ���������� ���� ��������

��)����� ����������� ���%����� ��� ���������� ����

���������������)����������� �����������

%!0���=��?!�����!�����!��%F���. ����������� �������������������������� ��������

/���������������������������������������

���. 2������� � ������������������� ������������2������

���� �� ���� ��������� ��� ���� ��)� ��� �����������

�������������������� �� ����3���� �����������

� �������������

���. /����� ����� &%'� ������ ������������������

�����1�(.%0���� ��������������&"'�������

�"�. !���� ��&�'���������� �������������� �

�����������3��������� � ������������� ��������

��� ������ �����������4�����������������

������

�(�. ��� .������ .����� ���������� ���� � ������ � ������

����������������� ����3����������������������������

����� � �������������

�*�. �9�.������.����� ����3������������� ����3����

������������ ������������ � ������� ����� ��

��� .����3������������� � ���������� ��� ��

��������� � ��� ��!��� ��� ���2������� ������

�������� ������� �� � �����������

�<�. !���� ��&�'�������� � �������������������

���3� �

�+�. 4������ ������ �������� �������������������������� �

������ � ������ ����������������������� ����3�

�������������� ������ ������������ ������ �����

������� � � ��� ���� �������A���� ������ ��������

���������3������� � ���������������3� ��������

������ ���������������

�0. -��������A"J��� �����)������ ����������� ���

���������������� �� ���������

Page 35: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

4�����%

��. ;��������� ������� )����� ���������������&.�).�

��� �'������ ����������������&.����� �'�� � ������

�� )��������������������� ������������������

�������� �� ��� �����������

��. /��������� �������������� ����3� �������

������������������������A"J��� ������ �����

�������������������3� �

��. #������������������������������� ������ ������� �

������ ������������������?�������������� ���������

��������������������������3����������������

������� ���/������������3����

�". /����� �������� �������������3� �������������

������

���� � 4����� �� ���� #��� �� �������� �� ��� �������

��� �� ��� ������ ���# ��� #���� ������ �����������

(��&� &�� ������� ��� ����� ������ #��� ��

�������� ���# ��� ��#� ��� �� ��� ����� ��� �������

��� ������ �� ������ � ��� �#����� ����� ������ � ���

������� ��� ����� ������ ��������� � &�� #���� ���$

��� ���������� ��&��� ������ ���

�%. /���������������� �������������3��� ��������

�� �� � ���� ����� �� �� ���3� �� � ���� ��� ��

� ���������3�������������������������� ��� �

�� ��� ����� ��� ��������� F�3�� �� ���� �� � ��

������ ���������� �� ����������� ����� ��

������������� ������������������������ ���������

�������� ���������/����� ���� ��� ��������

�(. /����� ���� ��������������A�������������������������

���� ���� ������ ������������� ����������������� � ��

��������� �������� ������������������ ���������

��������� ���� � ���3� � � ��� ������ ������ ������

#���3� �� ��������3� ������������������������

����������� ���������������������������������������

���������,��� � ������� � ���������������� �����

�����������)� ���������� ������� ��������������

���3� ���� �������������������������������� �� ��

�� ����������� �����������������

�*. ,����� � ����������������� ����������� � ����� ������

������������������������ ��������������� ��

�� ����/����� ����������������

�<. /����� ���� ��������� ������� ���������������

F�3��������������� ��� � ������������3� ��� �����

���������� ��� ��� ��������������� �� ������

�����)������� � ������� � ��������� ��� ������

�+. ���� ��� ��� ��������������� ��������������3�

� ������ ������������

�0. /����� ���� ������� ���������� ���� � �������������

���������� �F���������������� �#��

��. ���.������.����� ���.��� ���� ������3�����&������

��� �'� � �������������� �� � ������� ������

���/�.��� ���� ������������ � ��������������

�� ������� ����� ������.����� ������� ���� ��������

���� ������� � ������������/����� ��������������

���� ����� ������������� �

��. /������ ���������� ���������������.������.����� �

������ ���� ������ �����������

��. /������������������������

�". =����������� ������� �� �����������������������

��� �� ��������������� ���� ����������

�%. /�������������������������

D��//%F������%�<!�

��.� #���3��������������������������������������

��.� F ������������� ������� ����������M����� �������� �������8�����

:D�%! ��� 0%

��.� #���3���������������������� ����

��. #���3������ ����3����� ��������� ��� �����

��. #���3������ ��� ����� ���� �&��� ���� ���'�

"�. #���3����������������� �

F �9������ �VVVVVVVVV�� ���VVVVVVVVV

�%�. #���3� ����� �� ���� �&�������������'������� ����

�D���0C!�0�$��2?0�������!�

#���3� �� �3������������ � ������������������� �����

��� �����������3������ ������������3��������������3

������� �������������������������� ���

�D����%0����

�� ��������������� ������������������ ������������� ��

�� �����,����������)���������� ��������� ������

�D9���!��E��=�0�$� ��$!��0�!���0/� 0�!

��. ����������� ���� �

��. $���������������������� ���� ��������� ���� ��

���������������� ���� � ����� �����

��. /�������������������������������������� �

�����7�� ���� ����������?�������������� �� ���

���������������/�������� �����������

"�. /������ ����������� �� ���������� ���� ��

,����� � ��� ������������ �

Page 36: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 36

>��D9������:������B���'��� ��#��#������#��M��#������##�����D��!%$�9����=B��?!�����0�� ���! �����

�������)+

1 ;G #/

����������� #���#�

#���#��#�

�����#����

������#� #���#�

���>��>�

�����

��� 4

��#9�

�#� #������#� #��� �#�

����:���������:� ��������->�>#���������:���������:������>#�����

���� ����D+��?���=?�D��#:�������:�9������:������

�� �

��

��

���

���

��

���

���

��

��

��

���

���

���

��

��

������#����

:##�������# 4�9�� �

#������#�������#9��

#������#�������#>��9�� �

����:��4�D��

�#�

��:

58 9����

�#�� ���#���������:&�1��� ��#�� ����� ������3

�����#�����:�:B�:#��#���������� ���#���9�������58&

1; / G

������#��#���9�� �

�������)-

#�F4/7 �/W

#�FF�9

4�;7/

$7��

,92��/�6!�;7/

#�FF�9

$ �-9,�#�FF�9

$ �-9,�#�F4/7 �/

9

�����0 !

��$!����=������?!�����0�

��0�$� #�:����������������#�����:��������#��

1�!;!������/! �;� ��?!�����0��0�$����$��������&3

#��!,91�

9

Page 37: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 37

�D9����=�:�0=�0����1D+�M�D-��?�<�3

4

1

2

32

5

67

3

Page 38: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 38

����������'��� ��#��#������#����������� #���#�

�#��������������#:� ���#��������������#:�

#�9�/�!� 7!=.#$7#B��B�GX

6-/97/��==X&#�9�,9-�- �=!�F7�#$7#B'

�#�����#������#�"!72�P��..� !�;�=!� $!72�P��..� !�;�=!� $

G�(

G�(

G�(

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/�27!�G��==�

!72�P���9!72�P���9

&/7 7��#�9�/�!�6G��-/9,91�F�,9�4�;7/��==�'

4�!�/,�G�/7?7/ 72�!72�P��..�=� ��=!� $!72�P��..� !�;�=!� $

�#9���#�

#�F6- �,�9��,/�6!�;7/��9�=�/��� 7#�92�

�-/9�,92-#7/��9�=�/��� 7#�92�, �4�!�/,�G�/7?7/ 72X

/�!!�-�� ;,�#$�#!� 72X

�����#����� ������#������"!72�P��..�=� ��=!� $!72�P��..�=� ��=!� $

, �#�F6- �,�9��,/4/7 -/7� ;,�#$��479X

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/��==�;,�$�27!�G�!72�P��..��9��!72�P��..� !�;�=!� $�

7N-79#7�$�!2 �-9�,!�/�!!�-�� ;,�#$�#!� 7 �

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��9�,92��/�6!�;7/��9�$7��,91� 4772�

!72�P��..� !�;�=!� $!72�P��..��==

1� �?�!?7��==�#�F6- �,�9��,/�6!�;7/��==�

,92��/�6!�;7/��==�;,�$�27!�G�!72�P���==

!72�P�� !�;�=!� $& �8������������� ������������� ��������� ���� � ���� ���� ��'

��G�(

��

, ��$7/74/�47/�1/�-92X

, �?�!��17�6�?7�*%�?�!� X

!�;�?�!��17� ,19�!����!72�$�!2 -9�,!�?�!��17�/, 7 ��6�?7�*%�?�!� �

��G�(

��

,19�!�,F4/�47/1/�-92����!72� ,19�!�$�!2 -9�,!�-9,��, 4/�47/!G1/�-9272�

��

��

, �#�F6- �,�9��,/�6!�;7/�797/1,R72X�&$�1��##��7/F,9�!�, �797/1,R72�;,�$�#���6�'

$� �#�F6- �,�9��,/�4/7 -/7 ;,�#$�#!� 72�,9���%�F,9-�7 X

G�(

G�(4/7 -/7� ;,�#$�, �,9�;��#$1-�/2�F�27�1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�

,92��/�6!�;7/��==�;,�$�27!�G�!72�P��..��==��!72�P��..� !�;�=!� $�

, �%�F,9-�7�/7 7��47/,�2�#�F4!7�7X

��

�%� 7#�92�#�F6- �,�9��,/�6!�;7/�4/74-/17,9,�,��72�6G�#!� 72�4/7 -/7� ;,�#$�

G�(

G�(

#������:����������

G�(

��

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��9�,92��/�6!�;7/��9�

!72�P���!�7/9��,91�=� ��=!� $!72P���!�7/9��,91�=� ��=!� $#$7#B�=�/�6/�B79�,19,��/��/

��479�,19,��/�#,/#-,�

Page 39: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 39

����������'��� �� #������:

�#��������������#:� ���#��������������#:�

=!�F7�/7#�,=,#��,�9�#-//79��#$7#B#�9�=!�F7�67�4/�?79�;,�$,9�"

7#�92 ��=�7/�1� �?�!?7��479 X&�0��%��������'

��=!�F7�4/7 79�X

,92��/�6!�;7/��9�27!�G�671,9 ���=�7/�"% 7#�92�27!�G)��#6�$7��� 4772��92��##

�7/F,9�!�, �797/1,R72�

4/,F�/G��92� 7#�92�/G�!,F,� ;,�#$7 �#!� 72X

#�F6- �,�9��,/�4/7 -/7 ;,�#$�#!� 72X

!�;�=!�F7� ,19�!&2���� ������ ���� ������� �'

!72�P��..� !�;�=!� $!72�P��..�=� ��=!� $

1� �?�!?7�27.797/1,R72�#�F6- �,�9��,/�6!�;7/�27.797/1,R72�,92��/�6!�;7/��9�-9�,!� ;,�#$�#!� 7 �

!72�P��..� !�;�=!� $��!72�P��..��9�, �!,F,�� ;,�#$�#!� 72X

1� �?�!?7�27.797/1,R72�#�F6- �,�9��,/�6!�;7/��9�

,92��/�6!�;7/��==�;,�$�27!�G!72�P��..��==��!72�P��..� !�;�=!� $�

$� �#�6� ;,�#$�#!� 72�,9���%�F,9-�7 X

�%� 7#�92�#�F6- �,�9��,/�6!�;7/�4/74-/17,9,�,��72�6G�#!� 72�4/7 -/7� ;,�#$�

G�(

,19,��/�;�/F�-4�..��0� 7#�92 �

G�(

"� 7#�92��/,�!�=�/�,19,�,�9��1� �?�!?7�479 ��,19,��/�797/1,R72�=�/��� 7#�92

�=�7/�?�!?7��479 ��6��/2�+*!"<��9!GL�,19,��/797/1,R72�=�/�=-!!�". 7#�92�,19,�,�9��/,�!�

G�(

=!�F7� ��6,!,R��,�9�47/,�2�

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��9�,92��/�6!�;7/��==�

$� �#�9�/�!�=�,!72���� 79 7�=!�F7�=�/=,?7�#�9 7#-�,?7��/,7 �2-/,91��� ,91!7

$7���27F�92X

��

;��#$1-�/2�F�27��1� �?�!?7��==�#�F6- �,�9��,/�6!�;7/��==�

,92��/�6!�;7/��==�;,�$�27!�G!72�� ,19�!�;��#$1-�/2�=�,!-/7�#�27�, �(0�F,9-�7�/7 7��47/,�2�#�F4!7�7X

G�(

G�(

��

> (����'(

G�(

$� �#�9�/�!�/7 7��,19,�,�9 7N-79#7�=�-/��,F7 X

G�(

��

=!�F7� ,19�!��6�?7�0�*�F,#/��F4 X

��

G�(

G�(

$� �4/,F�/GA 7#�92�/G�!,F,��/7 7�X& ��� �������2,�19� �,#�#�27 ������� ���� ���� ��'

��

G�(

��

G�(

/�!!�-�� ;,�#$�#!� 72X

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/��==�;,�$�27!�G�!72�P��..��9��!72�P��..� !�;�=!� $�

7N-79#7�$�!2 �-9�,!�/�!!�-�� ;,�#$�#!� 7 �

��

G�(

G�(��

�$7/F� ����27F�92� ��, =,72�

!72�P��C�P�� ,F-!��97�- � !�;�=!� $7 �

#�F6���,/�6!�;7/�#�9�,9-7 �%� 7#�92�4� �4-/17��=�7/��K ����27F�92�, � ��, =,72��,9�2��/��,/�6!�;7/�#�F4!7�7 � 7!7#�72�I�==J27!�G�67=�/7� $-��,91��==���#6�$7��)�$�1�##��92��##��7/F,9�! �27.797/1,R72�

G�(

G�(

G�(

��

%�F,9-�7�4/7 -/7� ;,�#$;��#$1-�/2�F�27�

G�(

Page 40: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 40

##�������'��� ��#��#������#����������� #���#�

�#����� ##������#:� ���#����� ##������#:�

,19,�,�9�#�9�/�!�F�,9�4�;7/��9�

#�9�/�!� 7!=�2,�19� �,#�#$7#B�, �#�9�/�!��47/��,91�9�/F�!!GX

G�(

,19�!�4�!�/,�G�/7?7/ 72����!72�

�#9���#�

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/��==�;,�$�9�/F�!�27!�G� ,19�!�#,/#-,��6��/2�=�,!-/7����!72�

,9�7//-4��F�,9�4�;7/����/7 7��#�9�/�!�

G�(

�-/9�,92-#7/��9�=�/��� 7#�92�

, �4�!�/,�G�/7?7/ 72X

/�!!�-�� ;,�#$�F�9,��/72�#�9�,9-�- !G�, �/�!!�-�� ;,�#$�#!� 72X

#$7#B�=�/�F�,9�6-/97/�=!�F7� 79 7�, �F�,9�6-/97/�=!�F7��==X

!72L� !�;�=!� $�/��7�/7F�,9 �-9#$�9172�$/�-1$�-��#��!,91�#G#!7�

�$7/F� ����#�!! �=�/�#��!,91�

#�F4/7 �/�#�9��#��/��92� G �7F�=�9797/1,R72�;,�$�0� 7#�92�27!�G���#6�#��! 4772��92��##���7/F,9�!�, �797/1,R72�

#�F4/7 �/��==�

�$7/F� �����479 �

G �7F�=�9��92��##���7/F���==;,�$�0� 7#�92�27!�G�

��

G�(

��

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/��==�;,�$�9�/F�!�27!�G� ,19�!�#,/#-,��6��/2�=�,!-/7����!72�

7N-79#7�$�!2 �-9�,!�/�!!�-�� ;,�#$�#!� 7 �

��

1� �?�!?7��==��#�F6- �,�9��,/�6!�;7/��==�,92��/�6!�;7/��==�;,�$�9�/F�!�27!�G� ,19�!�#,/#-,��6��/2�=�,!-/7����!72�

7N-79#7�$�!2 �-9�,!�=!�F7�, �9��� 79 72�

��

, ��$7/74/�47/�1/�-92X

, �?�!��17�6�?7�*%�?�!� X

!�;�?�!��17� ,19�!����!7��$�!2 -9�,!�?�!��17�/, 7 ��6�?7�*%�?�!� �

��G�(

��

,19�!�,F4/�47/1/�-92����!72� ,19�!�$�!2 -9�,!�-9,��, 4/�47/!G1/�-9272�

Page 41: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 41

#�����#����#9�����:�������'��� ��#��#������#����������� #���#�

!72L� !�;�=!� $�/��7�/7F�,9 -9#$�9172��$/�-1$�-�� 7N-79#7�

F�9-�!�=�9� 7!7#�,�9�F�27�����$7/F� ����#�9�/�!�&1'�797/1,R7 � G �7F�=�9�����#6!�;�� 4772���##���7/F,9�!�, �797/1,R72�

�$7/F� ����#�!! �=�/�$7���&;'�

�$7/F� ����#�!! �=�/�#��!,91�

6��/2�9���(�B<+0� G �7F�=�9�27.797/1,R72�� G �7F�=�9797/1,R7 ��9��#6�$7��� 4772��=�7/

9�/F�!�27!�G�

�$7/F� �����479 ��#�F6- �,�9��,/�92�$�1��##��7/F,9�!�27.797/1,R7�

G �7F�=�9� ;,�#$72�����#6�#��! 4772���##���7/F��/7F�,9 ��9�

�$7/F� �����479 �

6��/2�(�B<+L� G �7F�=�9��==���##���7/F��==��&�=�7/��==�27!�G�#�F4!7�72'�

F�9-�!�=�9� 7!7#�,�9�F�27�����$7/F� ����#�9�/�!�&1'�797/1,R7 � G �7F�=�9�����#6

!�;� 4772���##���7/F��797/1,R72�

9� G7

G7 9�

$�1��##���7/F��797/1,R7 �;,�$�#�F6���,/�6!�;7/�

6��/2�9����"!<%)�%(!<�)�+*!"< G �7F�=�9� ;,�#$7 �����#6�$7��� 4772�=�7/�9�/F�!�27!�G�&����������������5��'

6��/2 ��"!<%)�%(!<���92�+*!"<L G �7F�=�9� ;,�#$7 ���

!�;� 4772��=�7/�9�/F�!�27!�G�&����������������5��'

D�!0���=��!@�!� !��;�#/!�0����

��. ;���� ������������������� )�;���� ��� ���� � ����

���5���;��� ������������ ���� ���"?�#�

��. �0����������� ���� ������� "*���� ���� �����

�������#��������� ������� �����

��. ������ ��� �������5�������� �����������6(�

#���� ����������������� ��� �<������ �����

������� ���������&��� ������ �������� �����.�A�

���� ���� �� �� ���� �� �%����� ��;� ������

4������ �� ��������'������� �<�������)����%.����

�����.�����������

"�. ������ � �� �� �����5��� ���� �� �� �0.�����

���.���������������

%�. 1������������������".������ ���������� ���

(�. =��������������)������������������������ ������

�����

*�. �� ��"%.�����������)� ������ ��� �������5������

�������6��

<�. ;������� ������������� ������)�;���� ������� ���

�� � ���.�����5���;��� ��� ������ ��� �������

��.�����5��� ��������������#���� ����������

6(��� ��������%.�������� .���������)��������

�������6������� ���������� ����==� ����������

Page 42: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 42

:D����!��=?��� �����%������%!��?�����=����$!��#�����������#9�����B����#>�����������#������:����:���#���������

��#����"���������������#�#�������������� ##����B��������B�#�� #�����#��������#:�

��$����� ������%!� 0��! ���! ��A!�� �����.� ���!���

�&�

�D�6 �������� ������� ������� ����� ����

�&�&�

F���� �� ���� ��0?� � � ��������� ��� �

� ��#����D�#���3���0?�������� ����2� ������������������������������

!72P�.���!72P�.���

�&�&

F���������������������������� ����

� ��#����D�#���3������ �����������0?� ������3������������ �������� ��#���.�#���3��"?������� ��� ������

�&�&+

#���� ����3�� ������������� �����

� ��#����D�/������������ ����3������ ������� �� ������ �������� ���� ��� ��#���D�,������� ����3��� ���� ���)�����3���� �

�&�&-

2��� ���3���� ����������

� ��#����D�#���3� �� ������ �������� ��� ������������������� ��#���D�#���3���������� ���� ���� ��)������������������ ��� ��#��+�D�#���3��� ���� ������� �������������� ����/����������������� �����

�&�&)

��������=������

� ��#����D�#���3� �� � �������� �� ����"?��/����������������� �����

�&�&

=�������� ������

� ��#����D�,������ ��������� �����������������3��)������������

�&

� D�2����� ��� ���� �� ������ ��� ��.�

����

�&&�

/��.� ���� �������

� ��#����D�F����������� � �����.� ���� ������������� ��� ���� ��� ��#���D�2� ������ ����������� �����.� ��� ����� ��� ���������������������������

!72P� �

�&&

/��.� ���� ����������

� ��#����D�#���3��� ���� ���������.� ��� ����/���������.� ���� ��������� ��������� �� ������ �������� ���� ��

!72P�.��)

!72P�. ���=�����&&+

F�� ���� ����� ����� ��� � � ��#� � D #���3 ����� ����� ��� ��� ��!72P� ���=����F�������������������� ����� ��.� ���� ���

� ��#����D�#���3������������ ���� ���� ���

�&&-

9������������� �������

� ��#����D�#���3�+.��������� ����������� ��� ��� ������� ��#���D�#���3��� ���� ���� ������ ����������

�&+

� .� ���� ��� �������.��� �������������������� ������5������������ ������5���.��2����� ������� �������� ������������ ������

�&+&�

��0?�������������� ���������

� ��#����D�#���3� �����0?����������������� ����� ������� ��� ��� ��� ��#���D�/������ ��������������� ���� � ����0?������������ ���

!72P�.=�� �=����)!72P�. ���=�����

��0?������������ ���

�&-

�.������� ����������� �������� ��������������� ������5���.�2����� ������� ��������������������� ���

�&-&�

����� ����� ��� ��� ����� � ����� �

� ��#����D�#���3�����0?� ������ �����������,�������)�����3��������������� ����

����� ���

!72P�. ���=����!72P�. ���=����

�&-&

=����������� ������������ �

� ��#����D�,�������������� �� �����)������������

Page 43: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 43

��#������"�������������#�#�������������� ##����B��������B�#�� #�����#��������#:�

��$����� ������%!� 0��! ���! ��A!�� �����.� ���!���

�&)

D������� �������.��� �������� ����������������������5���2� � �� � �� � � �

�&)&�

,���������� � ������ �

� ��#�� �� D� #���3� �� � ��� ��� � ��� ����������� ��#���D�,�� �������������������� � ����� �

�D�2����� ������� �������� ������������������

�&)&

(.4�������� ������������� � ������ � �������� �����

� ��#����D�#���3�(.��������� ��������� ���� ����#�� ������� ������ ��� ���� ��

!72P�.�� ��� ����=�� �=����!72P�.�� ��� ����=�� �=����

�&)&+

!������ ������������*%?�

� ��#����D�#���3� �� � ���������� �����������*%?��2� ���������������� ���������������������� ��� ���� � ����� ��

��#������"�������������#�#�������������� ##�����#�����������#:�B����� #����(��#��������#9���#�������� #�����#��&�������9���� #���#���#��:��:���� #:�:�������#>&���88,B�9����#���������� ##����������#������������������#:�B�9���� #�(

�����#��������#9��� � �����)��� #�:��#��))��� #�:��#��&

��$����� ������%!� 0��! ���! ��A!�� �����.� ���!���

&�

D������� �������.��� �������� ����������������������5����D�2����� ������� �������� �������������������.�-�� ���� ���� ��������� ����� �� � 9� � �++*M ����� ��

&�&�

��������� ������ �

� ��#����D�#���3������ ������������������� ���� ��� ��� ���� � ����� ��#���3���� .���������� ��������� ���� ���� ���

������� ��9�����++*M������ ���������������������%����������%%����������

!72P�.�� ��� ����=�� �=����!72P�.�� ��� ����=�� �=����

&�&

63��������������� �

� ��#����D�-���������� ������������� ��������� ���� �� ,�� ���� ���������� � ������� ������0�+������+�*����)�������� ������� �

��#�����+"�������������#����������������������#:�B� #������#��������#9���:#���#���������O�

��$����� ������%!� 0��! ���! ��A!�� �����.� ���!���

+&�

�D�-�� ���� ����� �������������� ������������������D�#���� ����������������� �� � �� ����$�� ������������.�2����� ������� �������� ������� �������

+&�&�

4��������������&����8������'���� �����

� ��#����D�#���3��� ���� ���������� ��&��'� �� �������� ��� �� ������������������� ��#���D�#���3����� �� ��������������� ��� &���������� ��� �'� ���� � �� � ���� 2� ����������������� ��� ��� ������������������� ����3������ ���

� �����

!72P�. ���=����)!72P�.��

+&�&

F������������������������������ ����� ����� ���� ��&��'�

� ��#����D�#���3������ ������������������� �����#�� ����������A�������������������� ����

+&

�.�-�� ���� ����� ����������������� ������������������.�#���� ����������������� �� � �� ����$�� ������������D�2����� ������� �������� ���������

+&&�

F������������������������������ ���� ������ �����������

� ��#����D�#���3������ ������������������� �����#�� ����������A�������������������� ����

�D�2����� ������� �������� ������������ ��������������

!72P�.���)!72P�. ���=����

+&&

4��������� ���� ��3�������

� ��#����D�#���3� �� � ������������� ����������� �� � �������� �������������� ������/����������������� �����

Page 44: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 44

��#�����+"�������������#����������������������#:�B� #������#��������#9���:#���#��������O��1 #��&3&

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

+&+

�.�-�� ���� ����� ����������������� ������������������D�#���� ����������������� �� � �� ����$�� ������������D�2����� ������� �������� ������������ �� ������ ��� � % ���� �� �� �

+&+&�

F������������������������������ ���� ������ �����������

� ��#����D�#���3������ ������������������� �����#�� ����������A�������������������� ����

��� ��� ������� ������%����� ����� ���� �����������

!72P�.���)�!72P�. ���=����

+&+&

#���� ������������������

� ��#����D�,�� ���������0?� ������ ��������������� ������ ���� �)�������������� �����������

��#�����-"�������������#����������������������#:�B� #������#��������#9����������O��B������#�������#��������O�:&

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

-&�

�D�-�� ���� ����� ��������������� ������������������D�#���� ����������������5���� � � ��� ��� ������

-&�&�

4��������� �������� ��������� ������ �� ������ ���������

��� ���������

� ��#����D�#���3� �� � ������������� ����������� ��� ��� � ���� #�� ��� � �� ��������� ���������

�� ������� ������������.�2����� ������� �������� ������������ ����������������%����� ����� ���� �����������

-&�&

4��������� �������� ��������� ��� �� ������� ����������������

� ��#����D�/����������� �� ������� �� �������������������A� ����

!72P�.���

-&�&+

4��������� ����������������

� ��#�� �� D�#���3� ������� ��� ��� ������ ����3���/������������3���������

!72P� ���!72P�. ���=���� -&�&-

#������ ��������������� ��������

� ��#����D�#���3����������� ������������������� ���/������������ ������������#���3 �� � ���������� �������������� ������ ���

-&�&)

4��������� �������� ��������� ������������� ���������������

������������� ���

� ��#����D�#���3� ���������� ����������

����� ������������� ���������������

������������� ����� ���� ���� ����� ��

��� ���

� ��#���D�#���3����� �� ������� ��������

���� ���� ��/������������3����

� ��#��+�D�#���3���������� ���5�������

������� ��� ������ ���� ������ �� ����

-&�&

;������������� ������ �������� ������ )������������ ������� ��

������ ���

� ��#�� �� D�#���3� �� � ��� ���� ��������� ��������� ��������� ������ ��/���������������� ���������������

-&�&,

F������������������������������ ����� ����������� ���

� ��#����D�#���3������ ������������������� �����#�� ����������A�������������������� ����

-&�&7

4��������� ����������

� ��#����D�,������ �����������������������������������3��)� ������������� �������������������/����������������� ��������� ����������� ��������� ��

Page 45: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 45

��#�����)"�������������#����������������������#:�B� #������#��������#9���������O��B������#�����������O�:&�1 #��&3

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

)&�

�.�-�� ���� ����� �������������

�� �����������������

#���� �� �� ���� �����5��

)&�&�

#���3� �� ����������������������� ������ �

� ��#�� �� D�#���3� ����� ������� � � ��� ����������4������������� ����������J�;#��� ���� ���������������!������������������������������"�%J�;#����� ��������<�0J;#��������

�.�#���� ����������������5��

�� ��$�� �����������

�D�,��� ���������5����� ���� �������

���� �

)&�&

F������������������������������� ����� ���� �.������ �����

�������������

� ��#����D�#���3������ ������������������� �����#�� ����������A�������������������� ����

!72P�.�� ��� ���� ���=����

!72P�.�� ��� ���� ���=����

)&�&+

F������ ��������������������� ���� ��

� ��#����D�#���3� �� ��"?������������� � ������������������� �����%���������� ����� ������������� �� ���� ��#���D�/������� �������������"?�������������� ������������ ����� &����3� ��������������������������������������������������'�� ��#��+�D�/������� ����� ����������"?���� ���������� �������

���#�����"���������������9��������������:����:����������������:#9�������������

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

&�

�.�6����������� ������� ������������

&�&�

;�������� ������ �3� ������� ����� ���� ������ �

� ��#����D�#���3���� � ����� ���3� ���� �������.�A�J����������� ������ �&3� (01**'���%0����*%����� �������J����������� ������ �&3� ���B+*'���00�C��%����� ��

�.�6��������� ��� ���� ���� ������� ��� ���������.� � ���������.�2����� ������� �������� ������������ �������

&�&

#������ ���������������� ��������������

� ��#����D�#���3�������� ��������������� � ����)� ���� ���� ���3����� #������ �������������������������� ������������/���������������������������� �������������� ��������

!72P�.���!72P�. ���=����

&�&+

!���������������� ����� � �������������� ���

� ��#����D�#���3����� �� ������ ����� ��������� ��/������������3����� ��#��"�#���3���������� ���5����� ����� ���� ������ �� ����

&

� .� #���� ��� ��� ����� �����5���� ������� �����������6 �� � � � �� ��

&&�

���������������������������� ������

� ��#����D�#���3� �� ������������������� ���&������0'����� �� � ���������������������� ������ �� �� ������������ ���� ��

�.�6��������� ��� ������ �� ����� ��.��� ��%� ���� ����� �������� ��������� ����� �������������������� ���� ������

&&

�������������������3���

� ��#����D�#���3������3��������� ��#���D���� ��� ���� ������� �������������,����������������������������� ��������� ����� ������

!72P�.�� ��� ���� ���=����!72P�.�� ��� ���� ���=����

&&+

������������������������ ������ �

� ��#����D�#���3������� ������� ����� ������������� ������ ������� ��#���D�#���3������� ������� ����� ��������������� ������ ������� ��#��+�D�#�� ������� ��������������� �

&&-

#� ������� �������������

� ��#����D�#���3� ������������������� ���������������,�� ��������������������������0�*0��������)�����3� ������������������� ������ ����� ���� ��#���D�/������)������)������ ����������������,������� �����������)������ ��������������������2��9���#!7�9�/�2;,�$� �92�4�47/�� �92�4�47/�;,!!#�9�/,6-�7�����$7�#�9��F,9��,�94/�6!7F���#��"�2�� �� ��� � �������������

Page 46: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 46

��#�����"���������������9������������:����:����������������:#9��������������1 #��&3

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

&+

�.�#���� ����������������5���� ������� ������������.�6��������� ��.�/��.� ���� ��� ���������� ����� ������������.�2����� ������� ����������.� ���������

&+&�

-�� ����������������00>��� ��������� ������ �

� ��#����D�#���3� �� � ������������������� �������������� ������������ ��� ������ ����� ������ �� ������������������ ��#���D�?����� �� � ������ ��������������5��� ��� �����5����� ����� ���������� ������ ����� ������ �� ����� ��#��+�D�#���3����������������������� �������������3���������� �� ��#��-�D�#���3� ������� �� �� �������� ��� �������������� ������������ �����

!72P�.��!72P�. ���=����

&+&

1�������������3�� � ����������������� ���

� ��#����D����� ����������� ������3������������#��"�6���������� � �� ��������� �������� (��#���D�#���3����������3����� � ��� ������������ ����� ���� -��� ������� �� ��� ����3��� �� ���&������� ���� �� ���'�

&+&+

������3����� � �������� ������� ����� ������������ ���������)����������� ���������)��������

��� �����������

� ��#����D�#���3���������3����� �����:�� ���� ��� ��� � ��������� ���������� #��� ��� ���������������#����� �������#��� ��#���D� �������3���������������&����� ������ ����������������������')����������� ��������������������)� �������� ������ ����������� �����!�������������

&+&-

,���������� ����� ����� ������ ������������������������ ������

� �� ������ ����������

� ��#����D�#���3���� ��������� ��� ���� �� ���� ��� ��� ��� � ��������� ���������#������������������ ������������ �� ������������ ��#��� D�=�1�(����� �������)�����3� ���������� ������������#������������������� �����(�0>�����<�0>���91�������� �����*�%>�����+�%>���!4��#����������������������0">�&"0044F'���������.��������������������������� ���91��!4�

&+&)

6��������� ���������� ����� �����������

� ��#����D�#���3� �� � �������������������� ������ ���� ������ �������������������#��� � ������ ����� ���������������������

&-

�D�#���� ����������������5���� ������� ������������.�6��������� ����������� ������ ������ �� ����� ��.�2����� ������� ���������� �������������������

&-&�

/������� ��������������������������� ������������������ ������������ ����4������������� ��5�����

�����������������������

� ��#����D�#���3� ������ ������������ ���������������� �3����� ��/������������ ����������� ��� ����� �3������������ ���� ������������������������ ���� ��#��� D�#���3� �� ��� � �� �3������������� ���� ���� ���� ���� ������ �� ���

�������������

!72P�.�� ��� ���� ���=����!72P�.�� ��� ���� ���=����

&-&

,�������������.���

� ��#�� �� D�/����� ����� ���� ������ � �����.���� �� ���)� � ���� �� �� ��� � ������������������/������� �� ������������������

Page 47: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 47

��#�����"���������������9������������:����:����������������:#9��������������1 #��&3

&)

�.�#���� ����������������5���� ������� �������������.�6��������� ��.�2����� ������� ���������� ���������������������.�9��7J�-�� ����� ����� �(0������ ��;� ������������������������ ��� �� ��� �����������������

!72P�.�� ��� ���� ���=����!72P�.�� ��� ���� ���=����

&)&�

!����������������� ����������� ��� �� �����������������

����

� ��#����D�#���3� �� � ��������������������� ���� ��#���D�#���3� �� � ������������������������� ������ �� �� ������������ ����� ��4����� ��� �� ��� � ������������ ��

��#�����,"� #���#�����������#9�������������:���������������#:�

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

,&*

�.�-�� ���� ������ ����� � �������� ������� ��������������������� ���

,&�&�

��������������������� ���� ��������

� ��#����D�#���3� ��������������������� ����� ���������4�������� �� ��������������������������� ������� ������ ���

����������

!72P�. ���=����!72P�.=�� �=����

,&�&

������������ ����� ���

� ��#����D�#���3������������� ����� ����� �����������#����� ������������� ��� ��������������������2��9���- 7� �92�4��47/� ��� #!7�9� /�2�� �92� 4�47/� ;,!!#�9�/,6-�7� ��� �$7� #�9��F,9��,�94/�6!7F�

��#�����7"���:##����#9����������#�#���������� ##����B��������B�#�� #�����#��������#:�

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

7&*

�.�,�������������� ���� ������ ���������)������)����� �������

7&�&�

F������������������������������ ����� ��� �����������

� �

� ��#���D�#�� ����������A� ������������������� �����#���3������ ������������������� ����

7&�&

��0?����� ���������������� � ����������������������� ������

���

� ��#����D�#���3�����0?�� � ���������������������������������5����JGJ)�J1J)�����J;J������������� �� ��� ��� �� ���� ������� � ���9 �� �� ������J;K���������5��)� ������������������"%���������,�� ���������0?� �������� � ����� � ������������� ���� �)������� ���� �

7&�&+

2���� ������ �����

� ��#����D�,�� �������� ���0?������JGJ)�J1J)�J;J���������5��)�������� ����� ��

��#�����8"��������� �:������������#��������#�

��$����� ������%!� 0��! ���! ��A!�� ����. ���!���

.�F������� ������� ,��� ���� �� � ��#���D�#�������������� ��� )�2�����

Page 48: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 48

+

)

-

, 7

�D���D��0�$�D���$!%���� ;������������ � ��������)���0?����� ��� ����

�� �� ���3���� ��� & %�'� � ����� ��� ������� ���������� ���������� ��&��'����� �������������������2��� ���3���� ������ ��������������������� ���������� ����

��� �������������"?�#� � ��������I�"?�#J�������,�� ��) �������I/J����������������"?�#� � �������I/#J�� ������� ���� � �&� �����'�

��� ;���� ������������������� )�;���� ��� ���� � �������5���;��� ������������ ���� ���"?�#�

�"� #�6��� ���������� �������5��� �������� ����������&6('��;���� �������� �������������������������)������ ������������� ���& �<'�������

�%� ;���� �<� �����)� ��������� ������ ���� � & �0'� �������)� ������� ����� ������� ������ ��������������������3�

�(� ;�������������������)����3�� ���������������������� ����� ������������

�*� �� ��"%�������)�������� ��&��'������5��� �������������

<� ;������� ������������� ������)�;���� ��� ���� � ��������5���;��� ������������ ������ ����������� ��������� ������������5��� ���������������������� ������������������ ����� �������)� ���������������������������� ��������&+0.��0��������'������ ����:�������������� ��

Page 49: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 49

�D� ���%�<!�� �����%�D��0�$�D���$!%�

#$7#BL�.-9,��4�;7/

�.,9�7/!�#B� ;,�#$�.�/�9 =�/F7/".!,F,�� ;,�#$

��/�

, �"?�#��#/�

/�C��X

G7

H-F47/��#/� #/7; �/�C�1

G7

2�7 �-9,��47/��7X

9�

9�

, 6!�;7/

/-99,91��9�$,1$ 4772X

9�,

��0?�#��#/� 9��C��X

/74!�#76##�

9�G7

G7

#$7#B�6!�;7/;,/,91��926!�;7/

, ��0?�#��#/�

9��C��##X

9�/74!�#76##�

G7

H-F47/��#/� �/�C;

&/7F�?7�/�C�1�H-F47/'

, #�F6���,/�6!�;7/

�9X

9�

/74!�#76##�

9� , ��0?�#��#/�

9��C�#�6X

#$7#B#�F6- �,�9��,/��6!�;7/

G7

G7 �/7�6-/97/ !,�X

9�

#$7#BL�.#�F6- �,�9��,/�6!�;7/

�.,19,�,�9�#�9�/�!�.1� �?�!?7".,19,��/

%.!,F,�� ;,�#$7 (.4/�?7� ;,�#$G7

, �6!�;7/�/-99,91��9�!�; 4772)�"%� 7#��=�7/�=-/9�#7

!,1$� X

9�,

��0?�#��#/� 9��C�$X

G7

, �"?�#��#/�

��C�?X

/74!�#76##�

9�

9�

#$7#B;,/,91

G7 , ��0?�#��#/�

9��C��##X

G7

/7F�?7/�C�;H-F47/

�=�7/�$7� 7!7#�72�,F7)�2�7 ��$76!�;7/��-/9

�==X

G7 9�

G7

/74!�#76##�

792��=��7 �

� ��#������##����

��#9 ����

9�

/74!�#76##�

#$7#B�6!�;7/;,/,91��926!�;7/

�������))

#$7#B�#,/#-,�6/7�B7/��/7 7��,=

97#7 �/G�

Page 50: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 50

�D�,,��=������� �����%�D��0�$�D���$!%�

��/�

G7

9�

�,,�������#�� #���#����#������##����

�/0�C����/�!�!�������/�%���<�%%�����%�=?�

��++��H�����#� ��)�,����/���� ����� �����������

������ ����������� �������

���������X

������������ �� ������������

�����

,���"?�#�� ����� ���������

��������X

/������#� ��

,������ �������������������� ��K���������� ���X

#�� �����������

9������

�2/%�������0E0�$&�:��������!��0� ?����!���;���=0��/�!����!&

,������� ���� ����X

F�3��������� ��������� ��3��3����� �� ����#���3��������������

,���B)���������� �������

,�����3����0�������������� ���������

� ���X

#�� ����������� ������

������������ ��#���3���������������

792

G7

G7

G7

G7

G7

9�

9�

9�

9�

�������)

Page 51: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 51

��/�

G7

9�

�,,�������#�� #���#����#������##�����D��0�$�D��#:���

����/0�C�0�$��F��!��<�%%�����<��C

��++��H�����#� ��)�,����/���� ����� �����������

,���"?�#�� ������$ ����������X

#���3� ����������L�'���0?�#� ������'���������'������ �

����� ���� � ��� �� ����0���������#������ �� �������� �������������� �����������&�*������ ��'�

,�����3����� ���X

�� ������������3� ��2� ������ ���#����L�'�=����� ����������'�,� ������������ ���

�'�=���������� ������� �������� ����

2������ ��������� ���������

�����X

/����������������

�����==��������� ���

,��������� ����������������������� ��� ����3 ������X

#���� ��������� ��� ����9�

��������� ����

,��������� ����������� ��)����

����3��X

/�������������

,�����3����� ������������3��X

/���������� �����

,�����3�����0�������������� �������� ������ ���X

#�� ��/����������� ������������9��������� ����

792/�������� ��

G7

G7

9�

9�

9�

G7

9�

G7

9�

G7

9�

G7

�������),

Page 52: Service Literature G26 SERIES UNITS - Heating & Air Parts SERVICE.pdf · Page 1 ª 1997 Lennox Industries Inc. Litho U.S.A. ... ignition. G26-3, -4, ... Information contained inthis

LENNOXOEMPARTS.COM

Page 52

��/�

G7

9�

�,,�������#�� #���#����#������##����D��0�$�D��#:���

��%���%�=?��������0���A0%A!�<�%%����� ��!���

��++��H�����#� ��)�,����/���� ����� �����������

2������3� ���������� ���%���������� �����

���� �X

,���"?�#�� ����� �����������������X

/�������� ��

#�� ���

�������

#�� ������

/�����������������

,������������������������������ ��� � �������

����������X

,������ �������������

������� ��K������������ ���X

F�3��������������������������� ����������������� �������� �������������������������������

,������������������������������ ��� � �������

"���������X

#���� ��������

/�����������

,����������������3��X

#�� �

#�� �

,�������������������� X

,����������������� �� ��� ����� ��

������X

2����������������3��� ���� �

���������� ��X

/������������

2������� ������������������� ��������������������������

�������"�������������� ����� �)������ �2#�������� ���� ����

������������������������ �������"�

,����� ���� ���������)���������� ��������)������������������)������)���� ��

,��2#����� 0��%���������

��� �X

/�������� ��

792

9�

9�

G7

9�

9�

G7

G7

�������)7

G7

G7

G7

G7

9�

9�

9�G7

9�

G7 9�