TABLE OF CONTENTS - Sobyco Electricsobyco.net/products/sobyco.pdf · Male Inlet 5678C Female Inlet 5679C 6-15 5666C 5669C 5678C 5679C 20 AMP 250V 2-Pole 3-Wire Description Part #

SOBYCO ELECTRIC SUPPLY 1-800-992-2524

…………… ……..5 Lamp holders, Incandescent ………….. …..30…………… ……21 Lighting, Amusement - ZSV ………….. …..28…………… ……21 Meters ………….. …..48…………… ……22 Motor Starter, Heaters ………….. …..43…………… ……20 Motor Starters, Magnetic ………….. …..42…………… ……21 Multi-Pin Connectors, Single/Double Clamp .55,56…………… ……20 NEMA Config Chart for Wiring Devices …..15…………… ……21 Outlet Boxes, Weatherproof ………….. …..62…………… ……21 Pins, Bridge ………….. …..33…………… ……23 Pins, Cotterless Hitch ………….. …..33…………… ……19 Pins, Locking ………….. …..33…………… ……49 Pins, Lynch ………….. …..34…………… ……62 Pins, Safety ………….. …..34…………… 16,17,18 Portable Control Cable ………….. ……2…………… …....31 Portable Cord ………….. ……1…………… 36,37.38,39 Portable Power Cord ………….. ….3,4…………… ...40,41 Push Buttons ………….. …..47…………… …….35 Receptacles, Duplex Straight Blade ……6…………… …….64 Relays, General Purpose ………….. …..45

Connectors, Butt, Ring, Spade …………… ……62 Spellers ………….. …..32Connector Blocks, Multi-Cable, Polaris type …….60 Tapes, all types ………….. …..62Connectors, Compression …………… …….61 Testing Equipment ………….. .53,54Connectors, Solderless …………… …….61 Tools & Accessories ………….. …..51Contactors, DS, Meltric …………… …….59 Water Hose & Accessories ………….. …..50Cord Grip, Non-Metallic …………… …….61 Watertight Pin & Sleeve Devices ………….. .57,58Definite Purpose Contactors …………… ……44 Wire Nuts ………….. …..62Drum Controls, Reversing …………… ……46 Wiring Devices, Midget Locking Devices ……8Emergency Lighting …………… ……52 Wiring Devices, NEMA Locking Devices ..9-13Flood Lighting, HID …………… ……24 Wiring Devices, Straight Blade ………….. …..14Flood Lighting, Quartz Halogen …………… ……24 Wiring Devices, Straight Blade Devices ……7Floor Mats …………… ……50Fluorescent Ballast Cross Reference ……27Fluorescent Fixtures …………… ..25,26Fluorescent Fixture, Vapor proof …………… ……26Fluorescent Tube Guards …………… ……23Fuses and Accessories …………… ……63Ground Rods/Ground Rod Clamps ……64Heat Shrink Tubing …………… ……64Lamp holders, Fluorescent …………… ……29

TABLE OF CONTENTS

Bulbs, Flood………….

Circuit Breaker, Q-Line, Plug InCompression Splices.

Building Wire…………Bulbs, Decorative……

Circuit Breaker Load CentersCircuit Breakers……..

Cable Protectors & CrossoversCable Ties……………Cam Locks…………..Chasers………………

Bulbs, Fluorescent…..Bulbs, Incandescent…Bulbs, Indicator………Bulbs, Miniature………Bulbs, Rough Service.Bulbs, Sealed Beam…Bulbs, Shatter Proof…Bulbs, Sign……………


1


3


4

SOBYCO ELECTRIC SUPPLY 1-800-992-2524Full-load Current, Three Phase ac MotorsFrom National Electrical Code, 1984 Edition, Table 430-150 Electrical Formula - For obtaining Kw, Kva,

Hp and Amps

115V 230V 480V 575V 2300V 230V 480V 575V 2300V0.5 4 2 1 0.8

0.75 5.6 2.8 1.4 1.11 7.2 3.6 1.8 1.4

1.5 10.4 5.2 2.6 2.12 13.6 6.8 3.4 2.73 9.6 4.8 3.95 15.2 7.6 6.1

7.5 22 11 910 28 14 1115 42 21 1720 54 27 2225 68 34 27 53 26 2130 80 40 32 63 32 2640 104 52 41 83 41 3350 130 65 52 104 52 4260 154 77 62 16 123 61 49 1275 192 96 77 20 155 78 62 15100 248 124 99 26 202 101 81 20125 312 156 125 31 253 126 101 25150 360 180 144 37 302 151 121 30200 480 240 192 49 400 201 161 40

Hp x 746E x % Eff x PF

Hp x 7461.73 x E x % Eff x PF

Kw x 1000.E xPF

Kw x 10001.73 x E x PF

Kva x 1000E

Kva x 10001.73 x E

1000I x E x % Eff x PF

746IxE x 1.73 x %EffxPF

746Amps from Kva

Single Phase Three PhaseI x E x PF

1000I x E x 1.73 x PF

1000I x E1000

I x E x 1.73

Wanted

Kilowatts (Kw)

Kva

Horsepower Hp

5

THHN or THWN or MTW or T90 Nylon or TWN 75 * 14 AWG - 750 MCM - 600 Volts * Gas & Oil Resistant

AMPS

Synchronous TypeUtility Power Factor

AMPSHpInduction Type - Squirrel-edge & Wound-rotor

Amps from Kw

Amps from Hp

SOBYCO ELECTRIC SUPPLY 1-800-992-2524Full-load Current, Three Phase ac MotorsFrom National Electrical Code, 1984 Edition, Table 430-150 Electrical Formula - For obtaining Kw, Kva,

Hp and Amps

115V 230V 480V 575V 2300V 230V 480V 575V 2300V0.5 4 2 1 0.8

0.75 5.6 2.8 1.4 1.11 7.2 3.6 1.8 1.4

1.5 10.4 5.2 2.6 2.12 13.6 6.8 3.4 2.73 9.6 4.8 3.95 15.2 7.6 6.1

7.5 22 11 910 28 14 1115 42 21 1720 54 27 2225 68 34 27 53 26 2130 80 40 32 63 32 2640 104 52 41 83 41 3350 130 65 52 104 52 4260 154 77 62 16 123 61 49 1275 192 96 77 20 155 78 62 15100 248 124 99 26 202 101 81 20125 312 156 125 31 253 126 101 25150 360 180 144 37 302 151 121 30200 480 240 192 49 400 201 161 40

Hp x 746E x % Eff x PF

Hp x 7461.73 x E x % Eff x PF

Kw x 1000.E xPF

Kw x 10001.73 x E x PF

Kva x 1000E

Kva x 10001.73 x E

1000I x E x % Eff x PF

746IxE x 1.73 x %EffxPF

746Amps from Kva

Single Phase Three PhaseI x E x PF

1000I x E x 1.73 x PF

1000I x E1000

I x E x 1.73

Wanted

Kilowatts (Kw)

Kva

Horsepower Hp

5

THHN or THWN or MTW or T90 Nylon or TWN 75 * 14 AWG - 750 MCM - 600 Volts * Gas & Oil Resistant

AMPS

Synchronous TypeUtility Power Factor

AMPSHpInduction Type - Squirrel-edge & Wound-rotor

Amps from Kw

Amps from Hp

SOBYCO ELECTRIC SUPPLY 1-800-992-2524NEMA Configurations shown represent a diagram of the female receptacle, male is opposite

Wiring Devices / Straight Blade

15 AMP 125V 2-Pole 3-WireDescription Part #Plug 5266CConnector 5269CMale Inlet 5278CFemale Inlet 5279C

5-15 5266C 5269C 5278C 5279C

20 Amp 125V 2-Pole 3-WireDescription Part #Plug 5366CConnector 5369CMale Inlet 5378CFemale Inlet 5379C

5-20 5366C 5369C 5378C 5379C


6-15 5666C 5669C 5678C 5679C


6-20 5466C 5469C 5478C 5479C

7

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig


Wiring Devices / Straight Blade


5-15 5266C 5269C 5278C 5279C

20 Amp 125V 2-Pole 3-WireDescription Part #Plug 5366CConnector 5369CMale Inlet 5378CFemale Inlet 5379C

5-20 5366C 5369C 5378C 5379C


6-15 5666C 5669C 5678C 5679C


6-20 5466C 5469C 5478C 5479C

7

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig


15 AMP Midget Locking Devices

15 AMP 125V 2-Pole 2-Wire Non-GroundingDescription Part #

Midget Locking Plug 7465-NMidget Locking Connector 7464-NMidget Locking Flanged Inlet 7466-NMidget Locking Flanged Outlet 7468-N ML-1 7465-N 7464-N 7466-N 7468-N

15 AMP 125V 2-Pole 3-Wire GroundingDescription Part #Midget Locking Plug 7594-NPMidget Locking Connector 7593-NCMidget Locking Flanged Inlet 7595-MB

Midget Locking Flanged Outlet 7596-ER ML-2 7594-NP 7593-NC 7595-MB 7596-ER

15 AMP 125/250V 3-Pole 3-Wire Non-GroundingDescription Part #

Midget Locking Plug 7485-NP

Midget Locking Connector 7484-NC

Midget Locking Flanged Inlet 7486-MB

Midget Locking Flanged Outlet 7487-ER ML-3 7485-NP 7484-NC 7486-MB 7487-ER

15 AMP Locking Devices

15 AMP 125V 2-Pole 3-Wire GroundingDescription Part #

Single Flush Receptacle 4710-FR

Duplex Flush Receptacle 4700-FR

Locking Plug 4721-NP

Locking Connector 4732-NC

Locking Flanged Inlet 4716-MB L5-15

Locking Flanged Outlet 4715-ER 4710-FR 4700-FR 4721-NP 4732-NC 4716-MB 4715-ER

15 AMP 250V 2-Pole 3-Wire GroundingDescription Part #

Single Flush Receptacle 70615-FR

Duplex Flush Receptacle 70615-DR

Locking Plug 70615-NP

Locking Connector 70615-NC

Locking Flanged Inlet 70615-MB L6-15

Locking Flanged Outlet 70615-ER 70615-FR 70615-DR 70615-NP 70615-NC 70615-MB 70615-ER

8

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig


20 AMP NEMA Locking Devices

20 AMP 250V 2-Pole 2-Wire Non-GroundingDescription Part #Single Flush Receptacle 7210-BLocking Plug 7102-NLocking Connector 7101Locking Flanged Inlet 8808Locking Flanged Outlet 8809 7210-B 7102-N 7101 8808 8809

20 AMP 125V 2-Pole 3-Wire GroundingDescription Part #Single Flush Receptacle 70520-FRLocking Plug 70520-NPLocking Connector 70520-NCLocking Flanged Inlet 70520-MBLocking Flanged Outlet 70520-ER 70520-FR 70520-NP 70520-NC 70520-MB 70520-ER

20 AMP 250V 2-Pole 3-Wire GroundingDescription Part #Single Flush Receptacle 70620-FRLocking Plug 70620-NPLocking Connector 70620-NCLocking Flanged Inlet 70620-MBLocking Flanged Outlet 70620-ER 70620-FR 70620-NP 70620-NC 70620-MB 70620-ER

20 AMP 125/250V 3-Pole 3-Wire Non-GroundingDescription Part #Single Flush Receptacle 71020-FRLocking Plug 71020-NPLocking Connector 71020-NCLocking Flanged Inlet 71020-MBLocking Flanged Outlet 71020-ER 71020-FR 71020-NP 71020-NC 71020-MB 71020-ER

20 AMP 125/250V 3-Pole 3-Wire Non-GroundingDescription Part #Single Flush Receptacle 7310Locking Plug 9965Locking Connector 7314Locking Flanged Inlet 7327Locking Flanged Outlet 7328 7310 9965 7314 7327 7328

9

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig



30 AMP 125V 2-Pole 3-Wire GroundingDescription Part #Single Flush Receptacle 70530-FRLocking Plug 70530-NPLocking Connector 70530-NCLocking Flanged Inlet 70530-MBLocking Flanged Outlet 70530-ER L5-30 70530-FR 70530-NP 70530-NC 70530-MB 70530-ER

30 AMP 250V 2-Pole 3-Wire GroundingDescription Part #Single Flush Receptacle 70630-FRLocking Plug 70630-NPLocking Connector 70630-NCLocking Flanged Inlet 70630-MBLocking Flanged Outlet 70630-ER L6-30 70630-FR 70630-NP 70630-NC 70630-MB 70630-ER

30 AMP 125/250V 3-Pole 3-Wire GroundingDescription Part #Single Flush Receptacle 71030-FRLocking Plug 71030-NPLocking Connector 71030-NCLocking Flanged Inlet 71030-MBLocking Flanged Outlet 71030-ER L10-30 71030-FR 71030-NP 71030-NC 71030-MB 71030-ER

30 AMP 125/250V 3-Pole 4-Wire GroundingDescription Part #Single Flush Receptacle 71430-FRLocking Plug 71430-NPLocking Connector 71430-NCLocking Flanged Inlet 71430-MBLocking Flanged Outlet 71430-ER L14-30 71430-FR 71430-NP 71430-NC 71430-MB 71430-ER

30 AMP 250V 3-Phase 3-Pole 4-Wire GroundingDescription Part #Single Flush Receptacle 71530-FRLocking Plug 71530-NPLocking Connector 71530-NCLocking Flanged Inlet 71530-MBLocking Flanged Outlet 71530-ER L15-30 71530-FR 71530-NP 71530-NC 71530-MB 71530-ER

11

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig



30 AMP 120/208 3-Phase Y 4-Pole 4-WireDescription Part #Single Flush Receptacle 71830-FRLocking Plug 71830-NPLocking Connector 71830-NCLocking Flanged Inlet 71830-MBLocking Flanged Outlet 71830-ER L18-30 71830-FR 71830-NP 71830-NC 71830-MB 71830-ER

30 AMP 120/208 3-Phase 4-Pole 5-Wire GroundingDescription Part #Single Flush Receptacle 72130-FRLocking Plug 72130-NPLocking Connector 72130-NCLocking Flanged Inlet 72130-MBLocking Flanged Outlet 72130-ER L21-30 72130-FR 72130-NP 72130-NC 72130-MB 72130-ER

12

NEMAConfig

NEMAConfig



30 AMP 120/208 3-Phase Y 4-Pole 4-WireDescription Part #Single Flush Receptacle 71830-FRLocking Plug 71830-NPLocking Connector 71830-NCLocking Flanged Inlet 71830-MBLocking Flanged Outlet 71830-ER L18-30 71830-FR 71830-NP 71830-NC 71830-MB 71830-ER

30 AMP 120/208 3-Phase 4-Pole 5-Wire GroundingDescription Part #Single Flush Receptacle 72130-FRLocking Plug 72130-NPLocking Connector 72130-NCLocking Flanged Inlet 72130-MBLocking Flanged Outlet 72130-ER L21-30 72130-FR 72130-NP 72130-NC 72130-MB 72130-ER

12

NEMAConfig

NEMAConfig



50 AMP 250DC 600AC 3-Pole 4-WireDescription Part #Locking Plug 3765NLocking Connector 3764NReceptacle 3769FRLocking Flanged Inlet 3768MB

3765-N 3764-N 3769-FR 3768-MB

50 AMP 250DC 600AC 3-Pole 4-WireDescription Part #Locking Plug 7765NLocking Connector 7764NReceptacle 7379FRLocking Flanged Inlet 7958MB

7765-N 7764-N 7379-FR 7958-MB

50 AMP 125/250V 3-Pole 4-WireDescription Part #Locking Plug CS6365NLocking Connector CS6364NReceptacle CS6369FRLocking Flanged Inlet CS6375MB

CS6365N CS6364N CS6369FR CS6375MB

50 AMP 250V 3-Phase 3-Pole 4-WireDescription Part #Locking Plug CS8365NLocking Connector CS8364NReceptacle CS8369FRLocking Flanged Inlet CS8375MB

CS8365N CS8364N CS8369FR CS8375MB

13

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig


50 & 60 AMP Straight Blade Devices

50 AMP 125/250V 3-Pole 4-WireDescription Part #Flush Receptacle 9450-FRAngle Plug 9452-ANP

NEMA 14-50

9450-FR 9452-ANP

60 AMP 125/250V 3-Pole 4-WireDescription Part #Flush Receptacle 9460-FRAngle Plug 9462-ANP

NEMA 14-60

9460-FR 9462-ANP

60 AMP 250V 3-Phase 3-Pole 4-WireDescription Part #Flush Receptacle 8460-FRAngle Plug 8462-ANP

NEMA 15-60

8460-FR 8462-ANP

60 AMP 120/208 3-Phase 4-Pole 4-WireDescription Part #Flush Receptacle 8360-FRAngle Plug 8362-ANP

NEMA 18-60

8360-FR 8362-ANP

14

NEMAConfig

NEMAConfig

NEMAConfig

NEMAConfig


NEMA Configuration Chart Locking Devices

15


#8-#4 BLACK A 100864-1 A 100869-7 E1015-8331 A 100865-1 A 100868-7#8-#4 RED E1015-8308 A 100864-1 A 100869-9 E1015-8333 A 100865-1 A 100868-9#8-#4 GREEN E1015-8310 A 100864-1 A 100869-11 E1015-8335 A 100865-1 A 100868-11#8-#4 WHITE E1015-8311 A 100864-1 A 100869-12 E1015-8336 A 100865-1 A 100868-12#8-#4 BLUE E1015-8313 A 100864-1 A 100869-14 E1015-8338 A 100865-1 A 100868-14

#8-#4 BLACK E1015-1625#8-#4 RED E1015-1627#8-#4 GREEN E1015-1629#8-#4 WHITE E1015-1630#8-#4 BLUE E1015-1631

#8-#4 BLACK

BLACKRED

GREENWHITEBLUE

BLACKBLACK

A100793-1A100792-1

CAP FOR MALECAP FOR FEMALE

E1015-2358

PROTECTIVE CAPSDESCRIPTIONCOMPLETE PART #COLOR

E1015-2352E1015-2354E1015-2356E1015-2357E1015-2329

E1015-2348

E1015-2312E1015-2314E1015-2316E1015-2317E1015-2350

COLOR

E1015-2324E1015-2326E1015-2328

THREE WAY "T" CONNECTORSDOUBLE FEMALE COMPLETE

PART #TAPPING "T" COMPLETE PART

#PARALLELING "T" COMPLETE

PART #

E1015 SERIESConnectors and Accessories for cable size#8-4 600 volts, rated up to 150 amps

FEMALE PLUGCOMPLETE

PART #CONTACT ONLY

PART #INSULATOR

ONLY PART #

MALE PLUGCOMPLETE

PART #

cam lok

NON-VULCANIZEDCABLE

SIZE COLOR

FEMALE RECEPTACLEMALE RECEPTACLE

COLOR

COMPLETE PART #

E1015-1600

CONTACT ONLYPART #

INSULATORONLY PART #

CABLESIZE COLOR

E1015-8306

E1015-1605E1015-1606

COMPLETE PART #

16

ANGLE STYLE COMPLETE PART # OFFSET STYLE COMPLETE PART #

E1015-1602E1015-1604

Threaded stud size 5/16" -18

FEMALE TERMINAL CONNECTORSCABLE

SIZEE1015-575 E1015-625


400 AMP RATINGEZ1016 SERIES cam lok

#2-2/0 BLACK A 200630-1 A 200074-19 EZ1016-8375 A 200640-3 A 200075-19#2-2/0 RED EZ1016-8352 A 200630-1 A 200074-21 EZ1016-8377 A 200640-3 A 200075-21#2-2/0 GREEN EZ1016-8354 A 200630-1 A 200074-23 EZ1016-8379 A 200640-3 A 200075-23#2-2/0 WHITE EZ1016-8355 A 200630-1 A 200074-24 EZ1016-8380 A 200640-3 A 200075-24#2-2/0 BLUE EZ1016-8356 A 200630-1 A 200074-38 EZ1016-8381 A 200640-3 A 200075-44

2/0-4/0 BLACK EZ1016-8362 A 200639-1 A 200074-60 A 200641-1 A 200075-602/0-4/0 RED EZ1016-8364 A 200639-1 A 200074-62 A 200641-1 A 200075-622/0-4/0 GREEN EZ1016-8366 A 200639-1 A 200074-64 A 200641-1 A 200075-642/0-4/0 WHITE EZ1016-8367 A 200639-1 A 200074-65 A 200641-1 A 200075-652/0-4/0 BLUE EZ1016-8368 A 200639-1 A 200074-66 A 200641-1 A 200075-66

#2-4/0 BLACK

#2-4/0 BLACK E1016-1600S E1016-1631S#2-4/0 RED E1016-1602S E1016-1633S#2-4/0 GREEN E1016-1604S E1016-1635S#2-4/0 WHITE E1016-1605S E1016-1636S#2-4/0 BLUE E1016-1612S E1016-1643S

#2-4/0 BLACK E1016-1700 E1016-1725#2-4/0 RED E1016-1702 E1016-1727#2-4/0 GREEN E1016-1704 E1016-1729#2-4/0 WHITE E1016-1705 E1016-1730#2-4/0 BLUE E1016-1706 E1016-1731

BLACK E1016-2324 E1016-2312 E1016-2352

BLACK A 100601-1 CAP FOR MALEBLACK A 100602-1 CAP FOR FEMALE

PLATED A 100895-1 SNAP BACK METAL CVRALUM 100444 SPACER

BLACK E1016-9500 MFFFBLACK E1016-2306 TRIPLE FEMALEBLACK E1016-2382 DOUBLE MALE

17

THREE-FER TAPPING TEECOLOR PART # DESCRIPTION

PROTECTIVE CAPSCOLOR COMPLETE PART # DESCRIPTION

DOUBLESET-SCREW

THREE WAY LAY DOWN "T" CONNECTORS

COLOR PARALLELING "T" COMPLETE PART #

TAPPING "T" COMPLETE PART #

DOUBLE FEMALE COMPLETE PART #

OFFSET STYLE COMPLETE PART #

ANGLE STYLE COMPLETE PART #

INSULATED RECEPTACLESCABLE

SIZE COLOR MALE COMPLETE PART # FEMALE COMPLETE PART #

E1016-575 E1016-625

400 AMP RATING

EZ1016-8391

EZ1016-8387EZ1016-8389

EZ1016-8350

THREADEDSTUD

Stud hole size 1/2"

CABLESIZE COLOR

CONTACT ONLYPART #

INSULATORONLY PART #

EZ1016-8392EZ1016-8393

FEMALE TERMINAL CONNECTORS

CABLESIZE COLOR

Connectors and Accessories for cable size#2-4/0 600 volts, rated up to 400 amps

FEMALE PLUGCOMPLETE

PART #CONTACT ONLY

PART #INSULATOR

ONLY PART #

MALE PLUGCOMPLETE

PART #

cam lok

NON-VULCANIZED


BLACKRED

GREENWHITEBLUE

BLACKRED

GREENWHITEBLUE

BLACKBLACK

BLACKBLACK

A400001 E1016 Lektralink Assembly Tool A200020-1 COM-A-LONG for pulling male contact in 100300 Spraylube #70, 12oz 1015 Series

100300-1 Spraylube 16oz w/brush applicator A200020-2 COM-A-LONG for pulling female contact in A101208 2oz tube silicon grease for lubricating 1015 Series

business end of synthetic rubber insulators A200020-3 COM-A-LONG for pulling male contact in A100632 Tool for removing E1016 contacts from 1016 Series

insulators A200020-4 COM-A-LONG for pulling female contact in A100072 Cable Cutter - #6-4/0 cable 1016 Series

cam lok

NON-VULCANIZED

COLOR

DESCRIPTION

PROTECTIVE CAPS

E1017 SERIESConnectors and Accessories for cable size350-750MCM 600 volts, rated up to 690 amps

FEMALE PLUGCOMPLETE

PART #CONTACT ONLY

PART #INSULATOR

ONLY PART #

MALE PLUGCONTACT ONLY

PART #INSULATOR

ONLY PART #COLOR

A 200612-1 A 200056-1

COMPLETEPART #

E1017-350

COLOR

A 200612-1A 200612-1A 200612-1A 200612-1

E1017-355E1017-356

CABLE SIZE

350-750MCM

PART # DESCRIPTION

FEMALE TERMINAL CONNECTORS

E1017-1812 E1017-1613 E1017-1637 E1017-1638

PLUG ASSEMBLY TOOLS AND ACCESSORIESPART #

350-500MCM350-500MCM

E1017-352E1017-354

CABLE SIZE

350-500MCM350-500MCM350-500MCM

A 200056-6A 200056-37

E1017-375E1017-377E1017-379E1017-380

A 200056-3A 200056-5

A 200614-2A 200614-2A 200614-2A 200614-2

A 200040-1A 200040-3A 200040-5A 200040-6A 200040-39

90 DEG COMPLETEPART #



30 DEG COMPLETE PART #

E1017-381 A 200614-2

FEMALE RECEPTACLEMALE RECEPTACLE

E1017-1600E1017-1604E1017-1608E1017-1610

E1017-1601E1017-1605E1017-1609E1017-1611

E1017-1625E1017-1629E1017-1633E1017-1635

E1017-1626E1017-1630E1017-1634E1017-1636

350-750MCM350-750MCM350-750MCM350-750MCM

A100604-1CAP FOR MALE

Bolt hole size 5/8"

CABLE SIZE

250-750MCM250-750MCM

ANGLE STYLE COMPLETE PART # OFFSET STYLE COMPLETE PART #

OFFSET STYLEE1017-625

CAP FOR FEMALE

18

Stud size 1/2"-13

ANGLE STYLEE1017-575

DESCRIPTIONCOMPLETE PART #COLOR

A100603-1

SOBYCO ELECTRIC SUPPLY 1-800-992-2524Sign BulbsItem # Bulb Watts Volts Base Description7.5S11C S-11 7.5 130 Medium7.5S11TR S-11 7.5 130 Medium7.5S11TY S-11 7.5 130 Medium 7.5S11/Transparent Yellow7.5S11R S-11 7.5 130 Medium 7.5S11/Ceramic Red7.5S11Y S-11 7.5 130 Medium 7.5S11/Ceramic Yellow10S11NC S-11 10 130 Intermed10S11NTB S-11 10 130 Intermed 10S11N/Transparent Blue10A11NTG S-11 10 130 Intermed 10S11N/Transparent Green10S11NTR S-11 10 130 Intermed 10S11N/Transparent Red10S11NTY S-11 10 130 Intermed 10S11N/Transparent Yellow10S11NR S-11 10 130 Intermed 10S11N/Ceramic Red10S11NW S-11 10 130 Intermed 10S11N/Ceramic White10S11NY S-11 10 130 Intermed 10S11N/Ceramic Yellow11S14C S-14 11 130 Medium 11S14/Clear11S14IF S-14 11 130 Medium 11S14/Inside Frosted11S14TB S-14 11 130 Medium 11S14/Transparent Blue11S14TG S-14 11 130 Medium 11S14/Transparent Green11S14PK S-14 11 130 Medium 11S14/Transparent Pink11S14TP S-14 11 130 Medium 11S14/Transparent Purple11S14TR S-14 11 130 Medium 11S14/Transparent Red11S14TY S-14 11 130 Medium 11S14/Transparent Yellow11S14B S-14 11 130 Medium 11S14/Ceramic Blue11S14G S-14 11 130 Medium 11S14/Ceramic Green11S14O S-14 11 130 Medium 11S14/Ceramic Orange11S14W S-14 11 130 Medium 11S14/Ceramic White11S14Y S-14 11 130 Medium 11S14/Ceramic Yellow11S14R S-14 11 130 Medium 11S14/Ceramic Red

Turbo BulbsItem # Bulb Watts Volts Base24V T-3 3 24 E-1060V T-3 4 60 E-10T33-24 T-5.5 5 24 E-14T33-60 T-5.5 10 60 E-14T33-130 T-5.5 10 130 E-14T33-220 T-5.5 10 220 E-14

19

BULBRITE

SYLVANIA

7.5S11/Clear7.5S11/Transparent Red

10S11N/Clear

OSRAM


50A19/Rough Service 75A19/Rough Service 100A19/Rough Service 40A19/Rough Service/Tuffskin 60A19/Rough Service/Tuffskin 100A19/Rough Service/Tuffskin 200PS25/Rough Service/Tuffskin

Part # Bulb Base Volts Amps4405 Par 36 Screw Terminals 12.8 304414 Par 36 Screw Terminals 12.8 184435 Par 46 Screw Terminals 12.8 304515 Par 36 Screw Terminals 6.4 304535 Par 46 Screw Terminals 6.4 3035AR111/4/SSP Multi-Post 6 35

Part # Description6430 Festoon 24 Volt 3 Watt 28mm6423 Festoon 24 Volt 5 Watt 35mm6424 Festoon 24 Volt 5 Watt 41mm6429 Festoon 24 Volt 10 Watt 41mm

Part # Description30R20FL 30 Watt R20 Flood50R20FL 50 Watt R20 Flood65BR30FL 65 Watt BR30 Flood100PAR-A 100 Watt Par38 Amber100PAR-B 100 Watt Par38 Blue100PAR-G 100 Watt Par38 Green100PAR-PK 100 Watt Par38 Pink100PAR-R 100 Watt Par38 Red100PAR-Y 100 Watt Par38 Yellow

Globe10, 15, 25G16.5/Clear/Candelabra Base25, 40, 60G25/Clear or White25, 40, 60, 100, 150G40/Clear or WhiteChandelier25, 40, 60 Watt/Clear or Frosted Torpedo25, 40, 60 Watt/Clear or Frosted Bent Tip25F15/Clear or Amber Flame Tip

Rough Service

Sealed Beam Lamps

Aluminum Reflector

21

Indicator Lamps

Flood Lights

Decorative


50A19/Rough Service 75A19/Rough Service 100A19/Rough Service 40A19/Rough Service/Tuffskin 60A19/Rough Service/Tuffskin 100A19/Rough Service/Tuffskin 200PS25/Rough Service/Tuffskin

Part # Bulb Base Volts Amps4405 Par 36 Screw Terminals 12.8 304414 Par 36 Screw Terminals 12.8 184435 Par 46 Screw Terminals 12.8 304515 Par 36 Screw Terminals 6.4 304535 Par 46 Screw Terminals 6.4 3035AR111/4/SSP Multi-Post 6 35

Part # Description6430 Festoon 24 Volt 3 Watt 28mm6423 Festoon 24 Volt 5 Watt 35mm6424 Festoon 24 Volt 5 Watt 41mm6429 Festoon 24 Volt 10 Watt 41mm

Part # Description30R20FL 30 Watt R20 Flood50R20FL 50 Watt R20 Flood65BR30FL 65 Watt BR30 Flood100PAR-A 100 Watt Par38 Amber100PAR-B 100 Watt Par38 Blue100PAR-G 100 Watt Par38 Green100PAR-PK 100 Watt Par38 Pink100PAR-R 100 Watt Par38 Red100PAR-Y 100 Watt Par38 Yellow

Globe10, 15, 25G16.5/Clear/Candelabra Base25, 40, 60G25/Clear or White25, 40, 60, 100, 150G40/Clear or WhiteChandelier25, 40, 60 Watt/Clear or Frosted Torpedo25, 40, 60 Watt/Clear or Frosted Bent Tip25F15/Clear or Amber Flame Tip

Rough Service

Sealed Beam Lamps

Aluminum Reflector

21

Indicator Lamps

Flood Lights

Decorative


Slimline Watts Length Bulb Color Medium Bi-Pin Watts Length Bulb ColorF96T12/CW/WM 60 96" T-12 Cool White F40T12/CW/WM 34 48" T-12 Cool WhiteF96T12/DX 75 96" T-12 Daylight F40T12/D/X 40 48" T-12 DaylightF84T12/CW 65 84" T-12 Cool White F40T12/R 40 48" T-12 RedF72T12/CW 55 72" T-12 Cool White F40T12/GR 40 48" T-12 GreenF72T12/D 55 72" T-12 Daylight F40T12/GO 40 48" T-12 GoldF64T12/CW 52 64" T-12 Cool White F40T12/B 40 48" T-12 BlueF60T12/CW 50 60" T-12 Cool White F40T12/BL 40 48" T-12 Blacklight BlueF48T12/CW 32 48" T-12 Cool White FO32/730 32 48" T-8 3000K.75 CRIF48T12/GO 32 48" T-12 Gold FO32/735 32 48" T-8 3500K.75 CRIF42T12/CW 36 42" T-12 Cool White FO32/741 32 48" T-8 4100K.75 CRIF36T12/CW 30 36" T-12 Cool White FO32/830 32 48" T-8 3000K.82 CRIF24T12/CW 21 24" T-12 Cool White FO32/835 32 48" T-8 3500K.82 CRI

FO32/841 32 48" T-8 4100K.82 CRIHigh Output Watts Length Bulb Color F30T12/CW 25 36" T-12 Cool WhiteF120T12/CW/HO 135 120" T-12 Cool White F30T8/CW 30 36" T-8 Cool WhiteF117T12/CW/HO 132 117" T-12 Cool White FO25/730 25 36" T-8 3000K.75 CRIF108T12/CW/HO 124 108" T-12 Cool White FO25/735 25 36" T-8 3500K.75 CRIF96T12/CW/HO/WM 95 96" T-12 Cool White FO25/741 25 36" T-8 4100K.75 CRIF96T12/D/HO 95 96" T-12 Daylight F25T12/CW/33" 25 33" T-12 Cool WhiteF96T12/CW/VHO 215 96" T-12 Cool White F25T12/CW/28" 25 28" T-12 Cool WhiteF84T12/CW/HO 100 84" T-12 Cool White F20T12/CW 20 24" T-12 Cool WhiteF72T12/CW/HO 85 72" T-12 Cool White F20T12/R 20 24" T-12 RedF72T12/D/HO 85 72" T-12 Daylight F20T12/GR 20 24" T-12 GreenF72T12/CW/VHO 165 72" T-12 Cool White F20T12/GO 20 24" T-12 GoldF64T12/CW/HO 80 64" T-12 Cool White F20T12/B 20 24" T-12 BlueF60T12/CW/HO 75 60" T-12 Cool White F20T12/BLB 20 24" T-12 Blacklight BlueF48T12/CW/HO 60 48" T-12 Cool White FO17/730 17 24" T-8 3000K.75 CRIF42T12/CW/HO 55 42" T-12 Cool White FO17/735 17 24" T-8 3500K.75 CRIF36T12/CW/HO 45 36" T-12 Cool White FO17/741 17 24" T-8 4100K.75 CRIF24T12/CW/HO 35 24" T-12 Cool White F15T12/CW 15 18" T-12 Cool White

F15T8/CW 15 18" T-8 Cool WhiteCircline Watts Dia. Bulb Color F15T8/BLB 15 18" T-8 Blacklight BlueFC8T9/CW 22 8" T-9 Cool White F14T12/CW 14 15" T-12 Cool WhiteFC12T/CW 32 12" T-9 Cool White F14T8/CW 14 15" T-8 Cool WhiteFC16T9/CW 40 16" T-9 Cool White F13T5/CW 13 21" T-5 Cool White

F8T5/BLB 8 12" T-5 Blacklight BlueU-Shape 6" Watts Length Bulb Color F6T5/CW 6 9" T-5 Cool WhiteFB40/CW/U/6 34 22.5" T-12 Cool White F6T5/BLB 6 9" T-5 Blacklight BlueFB40/WW/U/6 34 22.5" T-12 Warm White F4T5/CW 4 6" T-5 Cool White

T-12 T-8 T-5 T-9 T-12

22

MOST BULBS AVAILABLE IN DAYLIGHT

Fluorescent Tubes

OSRAM GESYLVANIA


* If the lamp is broken, virtually all glass, phosphor and mercury are safely contained within the coating.

* Skin tight plastic coating, not a sleeve - which can allow dust, oil and heat build-up, which causes lower lumen output and premature lamp burnout.

* Standard coating has UV stabilizers to block ultraviolet emissions up to 390 nanometers.

* Coating will not yellow, crack or flake.

* Light output loss is less than 1%.

* Even an 8' foot lamp can be easily and safely installed by just one person.

* Safe installation and disposal - you never touch bare, unprotected glass.

* Available in all sizes, colors and Kelvin temperatures.

* Our lamps are 100% inspected for coating thickness, integrity and lighting performance.

TUBE GUARDS PROVIDE FULL PROTECTION AGAINST THE DANGERS OF LAMP BREAKAGE. MADE OF CLEAREXTRUDED POLYCARBONATE . MEETS ASTM D-635 TESTMEETS ALL OSHA, FDA, NEC AND USDA REQUIREMENTS

AVAILABLE IN 4 OR 8 FOOT LENGTHS FOR T8 - T12 LAMPSAVAILABLE IN CLEAR, RED, GREEN, BLUE, PINK, AMBER

MADE OF HEAT RESISTANT PLASTIC. WILL HOLD LAMPSIN PLACE EVEN WHEN BROKENTWO END CAPS SUPPLIED WITH EACH TUBE GUARD

23

END CAPS

FLUORESCENT TUBE GUARDS

Shat-R-Shield Plastic-Coated, Shatterproof Lamps

Reusable, Unbreakable


Utilizing T-3 tungsten halogen lamps, the Quartzliter luminaire provides "Instant on" low cost illumination for use in sportslighting, automobile outdoor sales areas, sign lighting, security, building, outdoor amusement lighting and other applications.Die cast aluminum housing with cast-in fins for efficient heat dissipation. Thermal shock and impact resistant clear temperedglass mounted in a die cast aluminum door frame. Corrosion resistant hardware with gray polyester finish.

QL-TB Cross arm trunnion box. Half yoke with large wiring box for mounting to any flat surfaceQL505G Replacement glass for QL505QL1505G Replacement glass for QL150800-2166-0108 Replacement lamp holders for QL505 (pair)705327 Replacement lamp holders for QL1505 (pair)

Mega Flood Trunnion FLL-250PQPKMega flood with trunnion mount allowseasy surface mounting for aiming FLL-400PQPKflexibility. Factory wired with 3 footflexible cord. Adjustable aiming over FLLX-1000MHQPKT180 deg arc. Mounting can be lockedsecurely in place. Lamp supplied with /PCfixture.

320-006 Wire Guard

Series: A (16" diameterDescription: High BayDistribution: narrow, medium

or widefield adjustable

Wattage: MH: 175-1000W

SPX22M1000Q5SPX22M1500Q5

Catalog Numbers

High Bay ATLAS LIGHTING

HID FLOOD LIGHTS Catalog Numbers Dimensions

ATLAS LIGHTING

24

Hubbell Quartzliter QL Series Halogen Fixtures

QL505Standard 1/2" swivel knuckle 300/500 watt

QL1505Standard 1/2" swivel knuckle 1000/1500 watt

Accessories Description

QL-TB

ATLAS LIGHTING


General DescriptionThe economy pan, a basic all purpose fluorescent lighting fixture, has a wide Description Lengthrange of applications. All fixture parts snap together for ease of installation CH215 18"and maintenance. Side knockouts are included for convenient outlet switch CH220 24"and conduit. Chain hangers are also provided on the sides and back. CH230 36"

CH240 48"Specifications CH172 72"Body: Die formed heavy gauge cold rolled steel. CH272* 72"Pan Cover: Snap on type, fabricated in two sections for 72" & 96" bodies CH196 96"to simplify installation. Same cover can be used for shallow or deep CH296* 96"fixtures.Ends & Socket Plates: Snap in type. Ends can also be used for end coupler *Available in Tandem stylewhen fixtures are installed in continuous rows.Finish: Phosphate coating baked white enamel with 85% reflectivity.Mounting: Fixtures designed for surface, stem or hanging. Can be installedas individual units or in continuous rows.

General DescriptionThis pan is ideally suitable for high output (800MA) & Power Groove installations Description Length(1500MA). This unit which has a wide range of use, can also be used for CH148/248 HO/VHO 48"Slimline, Rapid Start & Trigger Start applications. All fixture parts snap CH172/272 HO/VHO 72"together for ease of installation and maintenance. Side knockouts are included CH196/296 HO/VHO 96"for convenient outlet switch and conduit. Chain hangers are also provided onthe sides and back.

SpecificationsBody: Die formed heavy gauge cold rolled steel. Designed with stiffener ribs onside for extra strength.Pan Cover: Snap on type, fabricated in two sections for 72" & 96" bodies tosimplify installation.Ends & Socket Plates: Snap in type. Ends can also be used for end coupler whenfixtures are installed in continuous rows.Finish: Phosphate coating baked white enamel, high reflectivity.Mounting: Fixtures designed for surface, stem or chain hanging. Can be installedas individual units or in continuous rows.

JANORO

25

CHANNELTWO LIGHT

FIXTURE MFG

JANOROFIXTUREMFG

CHANNELH/O - VHO


Heavy Duty Diamond Plate,.090 Corrosion Resistant - Single Pin orHigh Output, 15A Male & FemaleTwist Lock. Expanded Metal Screen Guards

Size8'8'

Enclosures will accept 1 or 2 lamp, rapid start,TDA 4' and TOA 8'

high output and slimline type fluorescentfixtures (fixtures by others)

Specifications:Gasketed enclosures shall be U.L. listed for wet anddamp locations. These enclosures shall have a fiberglassupper housing, top embossed, gasketed diffuser retentionslot and a 85-15 acrylic crepe pattern DR diffuser. Gasketshall be compressible, closed-cell neoprene type and shallbe continuously bonded to the upper housing. Provided with the enclosure are six (on 4' units) and twelve (on 8'units) Celcon retaining latches and two snap-in and plugs.

The complete Gasketed Enclosure shall be as manufacturedby A.L.P Lighting & Ceiling Products.

2H OutputSgl Pin

JAN96-2HOJAN96-2

2

26

DIAMOND PLATE FLUORESCENT FIXTURES

JANOROFIXTUREMFG

FeaturesModel Lamps


Fluorescent LampholdersCAT # RATING TYPE DESCRIPTION128M 660W 1000V Plunger Bracket or end mount w/12" leads127F 660W 600V Fixed214 Fixed Fits 1.125" square hole

Bolt down type for pedestal mounting215 Plunger Tombstone w/terminal screws for single pin lamps

227W 660W 600V Bi-Pin Bolt down type for bi-pin lamps Includes starter lamp base

314 660W 600V Fixed Push in terminals, shallow base315 660W 1000V Plunger Slide in for single pin lamps516 660W 1000V Plunger Snap-in for single pins lamps517 660W 600V Fixed Fits 1.52" round hole w/keyway

526W 660W 600V Bi-Pin Commercial bi-pin lampholder Slide in mounting

630 660W 1000V Plunger Tombstone recessed vertical double contact snap-in631 660W 600V Fixed for high output lamps w/rubber gasket810 660W 600V Fixed Recessed double contact811 Plunger Tombstone for high output lampsPE 660W 1000V Plunger Tombstone for high output lampsSA 660W 600V Fixed Recessed vertical double contact

660W 600V

660W 1000V

29

660W 1000V


DD SF BA E10

CAP & BASE

CA E10

BA E14

090

098

DD SF

PL 290

28

Available inFuchsia, Purple, Yellow, Lime Green, Orange, Red, Blue, Green, Clear, Frosted White

LIGHTS CO.

CAP & BASE

PL 398

SOCKETSCREW-IN

W/COMP NUT

SOCKETSCREW-IN

W/COMP NUT

Available inFuchsia, Purple, Yellow, Lime Green, Orange, Red, Blue, Green, Clear, Frosted White

CA E14


Fluorescent LampholdersCAT # RATING TYPE DESCRIPTION128M 660W 1000V Plunger Bracket or end mount w/12" leads127F 660W 600V Fixed214 Fixed Fits 1.125" square hole

Bolt down type for pedestal mounting215 Plunger Tombstone w/terminal screws for single pin lamps

227W 660W 600V Bi-Pin Bolt down type for bi-pin lamps Includes starter lamp base

314 660W 600V Fixed Push in terminals, shallow base315 660W 1000V Plunger Slide in for single pin lamps516 660W 1000V Plunger Snap-in for single pins lamps517 660W 600V Fixed Fits 1.52" round hole w/keyway

526W 660W 600V Bi-Pin Commercial bi-pin lampholder Slide in mounting

630 660W 1000V Plunger Tombstone recessed vertical double contact snap-in631 660W 600V Fixed for high output lamps w/rubber gasket810 660W 600V Fixed Recessed double contact811 Plunger Tombstone for high output lampsPE 660W 1000V Plunger Tombstone for high output lampsSA 660W 600V Fixed Recessed vertical double contact

660W 600V

660W 1000V

29

660W 1000V


Incandescent LampholdersCAT # DESCRIPTION

124 600W 250V

167

554

555

731

732

734

974

4734

9063

9350

90-474

705327

554

600W 250VHeavy duty phenolic single circuitSpeed nut available for sign board mounting

3000W 600V Quartz recessed single contactFront flange mount, standard leads

3000W 600V

RATINGMedium base socket rubberizedInternal soldered 6" pigtail leadsTwo piece medium base pin type

Quartz recessed single contactRear flange mount, standard leads

75W 125V Pin type intermediate base w/twist-on pin capSpeed nut available for sign board mounting

660W 250V Pin type medium base socketAvailable with hook for temporary light applications

660W 250V Pin type medium base socketBolt on mounting w/twist-on pin cap

75W 125V Pin type candelabra base socketTwo piece phenolic material

660W 250V Medium base snap-in pin type socket, front mountedExcellent for OEM applications

660W 250V Pony cleat medium base socketPhenolic material for surface mounting

660W 250V Porcelain keyless medium base socket

1500W 250V

Two piece ring type w/screw terminals500W 130V Porcelain material for quartz bulb

Sold in pairs (set of two lampholders)

30

555

167 9063

93504734-2

732 90-474 124

Use in Hubbell Quartzliter fixture


Model 33 Chasers are most commonly used on flashing incandescent bulbsigns where "dark spots" chase around a border or directional motion isincorporated into a field of bulbs. The Model 33 can be used to chase neon,though it must be incorporated on the primary side of any transformers.Model 33 Chasers are available from stock with three, four or five circuitsand larger chasers are available by special order.

Like all FMS flashers, Model 33 Chasers are ruggedly constructed to provideyears of smooth, quiet, trouble free service. The Model 33 Chaser featuresmolded terminal blocks, permanently lubricated bearings and all corrosionresistant surfaces. Contacts on the Model 33 Chasers are rated to handle10 amps each and are accessible for easy replacement.

115 Volt Motor: 50/60 cycle. UL and cUL listed.Also available in 220 volt.

33-C5

Standard Carton 4 units

Shipping Weight 18 pounds per carton(5 pounds per ind boxed unit)

33-C5 22 pounds per carton(6 pounds per ind boxed unit

Model Cam Cut33-C3 3 8 lobe 270 210 345033-C4 4 8 lobe 270 210 460033-C5 5 7 lobe 215 190 5750

The Model 66 Chaser is generally used to create a scintillating or "twinkling"action in fields of flashing bulbs. They can also be wired to create a chasingaction. These units are constructed of very heavy duty materials to stand upunder constant use with heavy loads.

The Model 66 Chaser features a simple wiring design for easy installationand three shielded ball bearings which require no maintenance. As on allFMS flashers, the contacts are formed of a special silver alloy that actuallyperforms better than pure silver.

The flashing speed of the Model 66 Chaser can be easily adjusted byremoving motor shades using just a screw driver. The flasher is suppliedwith a shade on each motor and as shades are removed the flashing speeddecreases. When operating with shades on (430 flashes per circuit perminute) the contacts on all Model 66 units are rated at 12.5 amps each.When operating with shades off (250 flashes per circuit per minute) thecontacts on the 3and 4 point units are rated at 20 amps each, while thecontacts on the 5 and 6 point units are rated at 17.5 amps each.

Flasher Size 66-C3, C4 7" x 6" x 4"66-C5, C6 7.25" x 9" x 4"

Standard Carton 66-C3, C4 4 units Model Circuits Shade Off66-C5, C6 1 unit

66-C3 3 4300 6900Shipping Weight 66-C3 24 pounds per carton

(7 pounds per individual unit) 66-C4 4 5750 920066-C4 26 pounds per carton

(7 pounds per individual unit) 66-C5 5 7125 1005066-C5, C6 10 pounds per carton

66-C6 6 8625 12075

31

Model 66 High Speed Scintillator or Chaser

Total Watts Capacity @ 115 volts Shade On

6.5" x 5" x 4.75"8" x 5" x 4.75"

33-C3 or C4

Number of Circuits

Flashes per Shade On

Circuit per MinuteShade On

Total Watts Capacity at 115 Volts

FMSModel 33 Chasers

Flasher Size 33-C3 or C4


Model 33 Spellers are designed for applications where electric circuits are to be flashed in custom sequences such as with spelling or other animation. Variable in both cycle speed and cam cut, Model 33 Spellers are some of the most versatile sign controllers available. The flashing sequence on each Model 33 Speller is custom made to customer specifications. The units can be built with as few as one circuit or as many as necessary to accommodate the requested flashing sequence. Neon can be controlled by installing the speller on the primary side of transformers.

To aid customers in ordering Model 33 Spellers, we have developed the sequence charting system explained below. "Cycle" refers to the time required for the flashing action to go thru its complete performance and start to repeat. "Cycle time" is expressed in seconds. "Circuit" refers to the current controlled by one cam and one set of contact points. The time on for a circuit is indicated by a dark square, the time off by a blank square. The charts below show some of the more common sequences but nearly any sequence can be constructed. Complete your own chart for a custom sequence. Call or fax to discuss any sequencing problems.

115 volt motor, 50/60 cycle. UL and cUL listed.

Also available in 220 volt.

Model

33-S1F 1 2-8 33-S6M 6 4-20 33-S12S 12 8-4033-S1M 1 4-20 33-S6S 6 8-40 33-S12XS 12 18-9033-S1S 1 8-40 33-S6XS 6 18-90 33-S13S 13 8-4033-S1XS 1 18-90 33-S7M 7 4-20 33-S13XS 13 18-9033-S2F 2 2-8 33-S7S 7 8-40 33-S14S 14 8-4033-S2M 2 4-20 33-S7XS 7 18-90 33-S14XS 14 18-9033-S2S 2 8-40 33-S8M 8 4-20 33-S15S 15 8-4033-S2XS 2 18-90 33-S8S 8 8-40 33-S15XS 15 18-9033-S3F 3 2-8 33-S8XS 8 18-90 33-S16XS 16 18-9033-S3M 3 4-20 33-S9M 9 4-20 33-S17XS 17 18-9033-S3S 3 8-40 33-S9S 9 8-40 33-S18XS 18 18-9033-S3XS 3 18-90 33-S9XS 9 18-90 33-S19XS 19 18-9033-S4F 4 2-8 33-S10M 10 4-20 33-S20XS 20 18-9033-S4M 4 4-20 33-S10S 10 8-4033-S4S 4 8-40 33-S10XS 10 8-4033-S4XS 4 18-90 33-S11S 11 8-4033-S5F 5 2-8 33-S11XS 11 18-9033-S5M 5 4-2033-S5S 5 8-4033-S5XS 5 18-90

Sequence OneCycle Time in Seconds

* 1 on 2 on 3 on 1 4 on 5 on 6 on 2

3* All off All on All off 4

5* Repeat 6

* Wipe on Wipe off 12

* All off 34

* Repeat 56

FMSModel 33 Spellers

Speed in Numberof Circuits

Secondsper Cycle Model



32

Secondsper Cycle

Circ

uits

Circ

uits

Sequence FiveCycle Time in Seconds

Secondsper Cycle Model


Bridge Pins are reusable and ideal for quick assemblyapplications. Made of high quality zinc plated spring wire steel for strength, security and corrosion resistance

Cat No. Dim. B Dim.C Dim. A21-04 1 7/16 3/8 .072521-05 1 7/8 5/8 .091521-06 2 3/8 23/32 .12021-07 2 11/16 25/32 .14821-08 3 3/4 11/32 .17821-09 5 1 7/32 .243

Easier than standard wire lock pins. Push down on wire loop to lock, pull upon tab toremove. Tab guides wire looped to a locked position when installing. Made of lowcarbon steel, zinc plated wire loop of hard drawn spring wire.

Cat No. Dim. A Dim. C Wire Dia.28-02 2 1/2 5/16 1 5/828-04 2 1/4 3/8 1 1/228-06 2 1/2 3/8 1 5/828-07 2 1/2 1/4 1 3/4

Cotterless Hitch pins feature a ball locking mechanism for holding the pin in place. Easy to insert orremove for quick disconnect applications. Made of zinc plated steel with easy grip pull ring andstainless steel ball lock. No special tools needed.

C

Cat No. Ring Dia. Dim. A Dim. B Dim. C30-03 15/16 3/16 1 13/16 230-08 15/16 1/4 1 3/4 2 A

33

C

Bridge Pins (Hairpin Cotters)

Tab Lock Pins

B

Cotterless Hitch Pins


Heavy Duty Spring Wire Plated

Cat No. Dim. A Dim. B Dim. C Dim. D25-04 1 3/4 1 1/16 3/8 .05825-05 2 3/4 1 11/16 5/8 .09125-06 4 3/8 2 13/16 13/16 .12025-07 5 3/4 3 3/4 1 1/8 .148

Positive locking pin for retaining clevis pin. Made from hard-drawn M-B plated spring wire.Use wherever safety is an issue.

Cat No Pin Dia ShaftLength

UsableLength

PinDiameter

63-01 3/16 1 5/8 1 7/16 1 5/863-02 1/4 1 11/16 1 7/16 1 5/863-03 5/16 1 11/16 1 7/16 1 5/863-04 7/16 1 5/8 1 7/16 1 5/8

Designed to be one of the finest quick disconnect fasteners available. Forged for maximum strengththese rugged pins are zinc electroplated and dichromate dipped for corrosion resistance. The designof the self-locking ring allows the pin to be securely held in place and provides an easy grip for quickremoval.

Pins are manufactured low carbon steel with a Rockwell Hardness of Rb80-100. Ringsare of hot drawn spring steel with a Rockwell Hardness of Rc47-48

34

Safety Pins

Lynch Pin

B

A

C

D


UL Listed (Molded Case Circuit Breakers #489)Federal Government Specification Qualified (WC-375B)60 Degree C/75 Degree Conductor RatingQuick-Make, Quick-BreakBox Type Terminals

15 THQP115 THQL1115 - THHQL1115 - TXQL111520 THQP120 THQL1120 - THHQL1120 - TXQL112025 THQP125 THQL1125 - - TXQL112530 THQP130 THQL1130 - - TXQL113035 THQP135 THQL1135 - - -40 THQP140 THQL1140 - - -45 THQP145 THQL1145 - - -50 THQP150 THQL1150 - THHQL1150 - -

Two-pole (3): Incorporates Internal Common Trip Bar15 THQP215 THQL2115 THQL22015 THHQL2115 THHQL22015 TXQL211520 THQP220 THQL2120 THQL22020 THHQL2120 THHQL22020 TXQL212025 THQP225 THQL2125 THQL22025 THHQL2125 THHQL22025 TXQL212530 THQP230 THQL2130 THQL22030 THHQL2130 THHQL22030 TXQL213035 THQP235 THQL2135 THQL22035 THHQL2135 THHQL22035 -40 THQP240 THQL2140 THQL22040 THHQL2140 THHQL22040 -45 THQP245 THQL2145 THQL22045 THHQL2145 THHQL22045 -50 THQP250 THQL2150 THQL22050 THHQL2150 THHQL22050 -60 - THQL2160 THQL22060 THHQL2160 THHQL22060 -70 - THQL2170 THQL22070 THHQL2170 THHQL22070 -80 - THQL2180 THQL22080 THHQL2180 THHQL22080 -90 - THQL2190 THQL22090 THHQL2190 THHQL22090 -100 - THQL21100 THQL22100 THHQL21100 THHQL22100 -110 - THQL21110 - THHQL21110 - -125 - THQL21125 - THHQL21125 - -125 - TQDL21125* - THQDL21125* - -150 - TQDL21150* - THQDL21150* - -175 - TQDL21175* - THQDL21175* - -200 - TQDL21200* - - -

Three-pole (3): Incorporates Internal Common Trip Bar15 - - THQL32015 - THHQL32015 TXQL3201520 - - THQL32020 - THHQL32020 TXQL3202025 - - THQL32025 - THHQL32025 TXQL3202530 - - THQL32030 - THHQL32030 TXQL3203035 - - THQL32035 - THHQL32035 -40 - - THQL32040 - THHQL32040 -45 - - THQL32045 - THHQL32045 -50 - - THQL32050 - THHQL32050 -60 - - THQL32060 - THHQL32060 -70 - - THQL32070 - THHQL32070 -80 - - THQL32080 - THHQL32080 -90 - - THQL32090 - THHQL32090 -100 - - THQL32100 - THHQL32100 -

1 - UL Listed as HACR (heating, air conditioning and refrigeration) Cu Al2 - UL Listed as SWD (switching duty) Suitable for 120 volts a/c fluorescent lighting loads 15-25 14-8 12-83 - 15-100 amp UL Listed as HACR (heating, air conditioning and refrigeration) 30-50 8-4 8-4* - Requires four one-inch spaces 15-30 14-8 12-8

35-60 8-3 8-370-125 6-1/0, 2-2/0 4-1/0, 2-2/0

120/240V A/C 240V A/C

Am

pere

R

atin

g

65,000 A/CTYPE THQP

1/2-inch ModuleTYPE THQL

1-inch ModuleTYPE THHQL1-inch Module

TYPE TXQL1-inch Module

10,000 A/C 22,000 A/C

120/240V A/C

Cat # Cat # Cat # Cat # Cat # Cat #

120/240V A/C 120/240V A/C 240V A/C

AmpereRating

Wire Size AWG/kcmil

Single-pole (1)

THHQL1145THHQL1140THHQL1135THHQL1130THHQL1125

35

1/0-250 1/0-250

Q Line Plug-in Circuit Breakers

THQP

THQLTHHQLTXQLTQDL

THQDL125-200

THQDL21200*

BreakerType


UL Listed (Panel boards #67)60 Degree C/75 Degree C Conductor RatingIndoor Fronts Combination Surface/FlushSuitable for use as Service Entrance Equipmentwhen installed in accordance with theNational Electrical Code22,000 Amps RMS Symmetrical Short Circuit Rating except where noted

Factory Installed Main Lugs - PowerMark Gold catalog numbers shown in italics

1p 2p 1p 2p2 1 4 1 4 TL240C(3) 2A TL240R1(4) R1A TGL12 1 4 1 4 TPL240C(3) 2 TPL240R(4) R1A TGL12 1 4 1 4 TL270C(3) 2A TL270R1(4) R1A TGL12 1 4 1 4 TPL270C(3)(5) 2 TPL270R(4)(5) R1 TGL12 1 4 1 4 TPL212C(3) 2 TPL212R(4) R1 TGL14 2 8 3 8 TL412C(3) 2A TL412R1(4) R1A TGL14 2 8 3 8 TL412CT 2A TL412RT1 R1A TGL1 Installed4 2 8 3 8 ------------ -- TL412R2 R1B TGL14 2 8 3 8 TPL412C(3)(5) 2 TPL412R(4)(5) R1 TGL14 2 8 3 8 TPL412CT(3) 2 TPL412RT(4)(6) R1 TGL1 Installed6 3 12 4 12 TLM612F1,S1(8) 3 TLM612R(8) R2 TGL28 4 16 6 16 TLM812F1,S1(8) 3 TLM812R(8) R2 TGL2

12 6 24 10 24 TLM1212CCU(10) 4 TLM1212RCU(10) R3 TGK24 Installed12 6 24 10 24 TLM1212CCUG(10) 4 ---------- --- TGK12 or TGK2424 12 - - 24 TLM2412CCU(10) 7 TLM2412RCU(10) R4 TGK24 or TGK3220 10 8 8 30 TLM2015CCU 8 ---------- --- TGK3224 12 4 4 30 TLM2415CCU 9 TLM2415RCU R6 TGK24 or TGK3216 8 14 14 32 TLM1620CCU 8 TLM1620RCU R5 TGK3216 8 16 16 32 TLM1620CCUG 8 ---------- --- TGK32 Installed20 10 18 18 40 TLM2020CCU 9 TLM2020RCU R6 TGK24 or TGK4220 10 18 18 40 TLM2020CCUG 9 ---------- R6 TGK42 Installed32 16 6 6 40 TLM3220CCU 12 ---------- --- TGK3240 20 - - 40 TLM4020CCU 13 TLM4020RCU R8 TGK42

24 20 - - 24 TL2440F,S(7) 16 TL2440R(7) R9 (2) TGL242 20 - - 42 TL4240F,S(7) 16 TL4240R(7) R9 (2) TGL2

(1) 6-42 circuit devices UL Listed for (3) No door, 10kA/C (7) Not suitable for use as service (10) For main breakerbottom mounted lugs by installing entrance equipment. order TQMH000. Alsocomplete unit (box, interior and (4) 10k A/C order THQL, THHQL orfront) upside down (8) For main breaker, order TXQL 2-pole circuit

(5) Maximum branch or main THMB000. Also order THQL, breaker(2) 40-225 amp 1 phase devices have circuit breaker rating: 90 amp THHQL or TXQL 2-pole

removable closing cap. Larger w/Cu, 70 amp w/Al circuit breaker (11) TLM load centers areampere devices require field cut field convertible to mainopenings. Order hubs separately. (6) 125 amp maximum branch (9) TPL load centers are circuit breaker load

capacity thermoplastic, TL load centers centers.are galvanized steel.

(2)250-350(Cu)(2)350-500(Al)

(2) TGL2

TGK4242

24

Catalog #(9) Box #

TL4260F,S(7)

TLM4222CCU 14

1720 - -

20 - -225

400

600

42

42

70

125

150

200

40

Catalog #(9) Box #Catalog #

14-6(Cu)12-6(Al)

Order Separately

Mai

n A

mpe

re

Rat

ing

6-2/0

1-3/0(Cu)

TL4260R(7)

TLM4222RCU R8

R9

2-3/0(Al)

1-250 (Cu)2/0-250(Al)

1-300(Cu)2/0-300(Al)

(2)2/0-250

1*THQL 1/2*THQP

6-2/0

1-2/0

36

PowerMark Plus and Gold Circuit Breaker Load CentersMain Lugs Factory Installed (11)

Single-phase, Three-Wire, 120/240 Volts a/c, Top Feed (1)

Equipment Ground Kit

Main Wire Size AWG/kcmil

Cu-Al

Outdoor Type 3R Enclosure(2)Indoor Type 1 EnclosureMaximum Spaces

Total1-PoleSpaces


UL Listed (Panel board #67) Indoor Fronts Combination Surface/Flush60 Degree C/75 Degree C Conductor Rating Suitable for use as Service Entrance10,000 Amps RMS Symmetrical Equipment when installed inShort Circuit Rating Standard accordance with the National Electrical Code(Main Breaker)22,000 Amps RMS SymmetricalShort Circuit Rating Optional(Main Lugs, Main Breaker by fieldreplacing main breaker.)

37

Main Circuit Breaker or Main Lugs

Factory Installed

PowerMark Plus Circuit Breaker Load CentersThree-Phase


Indoor Enclosures PowerMark Plus and Gold Circuit Breaker Load Centers

38


PowerMark Plus and Gold Circuit Breaker Load CentersOutdoor Enclosures

39


QO Circuit Breakers

QO115 1 15 120 VACQO120 1 20 120 VACQO130 1 30 120 VACQO140 1 40 120 VACQO150 1 50 120 VACQO160 1 60 120 VACQO220 2 20 120/240 VACQO230 2 30 120/240 VACQO240 2 40 120/240 VACQO250 2 50 120/240 VACQO260 2 60 120/240 VACQO270 2 70 120/240 VAC

QO2100 2 100 120/240 VACQO315 3 15 120/240 VACQO320 3 20 120/240 VACQO330 3 30 120/240 VACQO340 3 40 120/240 VACQO350 3 50 120/240 VACQO360 3 60 120/240 VACQO370 3 70 120/240 VAC

QO3100 3 100 120/240 VAC FA 100A 15-100 240-480 1,2,3Q2 225A 100-225 240 2 or 3Q4 400A 250-400 240 2 or 3KA 250A 70-250 600 2 or 3LA 400A 125-400 600 2 or 3MA 800A 300-800 600 2 or 3

Max Short-Circuit System Ratings

SL100 100 65,000 25,000 18,000SL225 225 65,000 35,000 25,000SL400 400 65,000 35,000 25,000SL800 800 65,000 65,000 25,000

SL1200 1200 125,000 100,000 65,0003 Pole, Plug-on style for use with I-LINE Panel boards

* Main Lugs Part # No. of Poles Amperes* Single Phase Three Wire - 120VAC - UL Listed QO115GF 1 15 120VAC Fixed Mains - Factory Installed Main Lugs QO120GF 1 20 120VAC 10,000 RMS Sym. Amperes Short Circuit Current Rating QO130GF 1 30 120VAC* Three Phase QO Load Centers are also available QO215GF 2 15 120/240VAC

QO220GF 2 20 120/240VACQO230GF 2 30 120/240VAC

I-Line Breakers

QO Ground Fault Interrupters

VoltageRating

Number of Poles

Part # AmpereRating

240VAC 480VAC

FrameSize

AmpereRating

Voltage

Sub-Feed Lug Kits

40

Circuit Breakers

Available styles: Plug-on, Bolt-on, Unit MountNumber of

PolesAmpereRating

VoltageRating

Part #

600VAC

Load Centers

BreakerTypes


Siemens and T&B panel boards and are classified to replace many of these illustrated

Brand Type Brand TypeWestinghouse BR Murray MPBryant BR Siemens QPChallenger C General Electric THOLSylvania C Thomas & Betts TB

Amp Rating 1 Pole 2 Pole15 TB115C TB215C20 TB120C TB220C30 TB130C TB230C40 TB140C TB240C50 TB150C TB250C

Amp Rating 1 Pole 2 Pole 3 Pole15 TB115 TB215 TB31520 TB120-TB TB220 TB32025 TB125 TB225 TB32530 TB130 TB230 TB33035 TB135 TB235 TB33540 TB140 TB240 TB34045 TB145 TB245 TBT34550 TB150 TB250 TB35060 TB160 TB260 TB36070 TB170 TB270 TB37080 TB280 TB38090 TB290 TB390

100 TB2100 TB3100125 TB2125

Amp Rating 1 Pole 2 Pole15 GFB-115 GFB-21520 GFB-120 GFB-22025 GFB-125 GFB-22530 GFB-130 GFB-23040 GFB-24050 GFB-250

Circuit BreakersThomas & Betts Classified Breakers

* Meets rigorous UL test requirements (UL File E-162469)

Type TB - 120/240 VAC - 10,000 A/C

* Meet electrical inspector's requirements for being a compatible replacement for those specific breakers previously referred to as "interchangeable"* Are mechanically interchangeable with those specific breakers sold in the U.S. today

Standard Circuit Breakers

* Are suitable for use in most Westinghouse, Bryant, Challenger, Sylvania, GE, Murray,

in the following chart

Circuit Breaker Compatibility Chart

UL Classified Circuit Breakers

41

Ground Fault Circuit BreakersType GFB - 120 VAC - 10,000 A/CSingle Phase & Three Phase Load

Centers in Stock

SOBYCO ELECTRIC SUPPLY 1-800-992-2524GE NEMA Rated Full Voltage Starters

CR306, CR386 Non-Reversing Magnetic Motor Starters1600 Horsepower Maximum NEMA Sizes 00-9

600 Volts Maximum 50/60 Hertz

42

SOBYCO ELECTRIC SUPPLY 1-800-992-2524GE NEMA Rated Full Voltage Starters

Motor Starter Heaters

43

Part # Amps Poles VoltsC202U10 20 2 24C202U20 20 2 110C202U30 20 2 208/240 * A Trusted Name

C252U10 25 2 24 * Approved by Leading

C252U20 25 2 110 Compressor OEM'sC252U30 25 2 208/240 * ARI 780 Rated Design

C302U10 30 2 24 * Made in U.S.A.

C302U20 30 2 110C302U30 30 2 208/240C402U10 40 2 24C402U20 40 2 110C402U30 40 2 208/240

ACC-323-UM10 30 2 24ACC-323-UM20 30 2 120ACC-323-UM30 30 2 208/240ACC-333-UM10 30 3 24ACC-333-UM20 30 3 120ACC-333-UM30 30 3 208/240ACC-343-UM10 30 4 24ACC-343-UM20 30 4 120ACC-343-UM30 30 4 208/240ACC-423-UM10 40 2 24ACC-423-UM20 40 2 120ACC-423-UM30 40 2 208/240ACC-433-UM10 40 3 24ACC-433-UM20 40 3 120ACC-433-UM30 40 3 208/240ACC-443-UM10 40 4 24ACC-443-UM20 40 4 120ACC-443-UM30 40 4 208/240ACC-533-UM10 50 3 24ACC-533-UM20 50 3 120ACC-533-UM30 50 3 208/240 * ARI 780 Rated Design

ACC-633-UM10 60 3 24ACC-633-UM20 60 3 120 * Made in U.S.A.ACC-633-UM30 60 3 208/240

Part #34300-332 Aux. Interlock INO/INC Model 9334300-337 Aux. Interlock INO/INC Model 9334220-332A Aux. Interlock, 20/25A, 2NO2NC35320-1543 30/40A 24V Coil for Model 8635320-1501 30/40A 110V Coil for Model 8635320-1502 30/40A 208/240V Coil for Model 8635520-501 50/60/75A 110V Coil for Model 8635520-502 50/60/75A 208/240V Coil for Model 86


ARROW HARTPRODUCTS UNLIMITED

DESIGN 93

with TAPE WOUND COILS

NEW COMPACT DESIGN 93

WITH ENCAPSULATED COILS

DEFINITE PURPOSE CONTACTORSHVAC MODELS

44

ACCESSORIES & COILSDescription


24*120*

24*120*240*24*

120*240*24**120*240**24**

120**240**24**120*240**24**120*240*

* Stock Delivery ** 14 Week Delivery

General Purpose Pushbutton StationNormally Used with A/C Magnetic Starters1/2" & 3/4" conduit holes on each side

* Surface Mounted* Totally Enclosed* Meets U.L. and C.S.A. Flame Retardant Standards* All Contacts are Inlaid Silver* 600 Volt/10 Amps Continuous Duty* Green Start Button is SP/NO Momentary Contact* Red Stop Button is SP/NC Momentary Contact* Actual Size: 4-1/2" x 2-1/2"

RC-PRD3 RC-PRD5 RC-PRD7 RC-PRD11

RC-PRD5AGO-

RC-PRD7AGO-

General Purpose Relays

RC-PRD3AYO-24*

120*240*

SPST - NO - DMSingle Pole, Double Throw

25 AMPS @ 277VAC

2HP @ 250VAC

RC-PRD11AGO-

1HP @ 120VAC

RC-PRD5AYO-

RC-PRD7AYO-

RC-PRD11AYO-

RC-PRD3AGO-

2HP @ 250VAC7 AMPS @ 50VDC RES.

10 AMPS @ 600VAC

10 AMPS @ 600VAC SPDTSingle Pole, Double Throw240*

25 AMPS @ 240VAC20 AMPS @ 277VAC

DPST - NODouble Pole. Single Throw,

Normally Open1HP @ 120VAC

7 AMPS @ 50VDC RES.

DPDTDouble Throw

30 AMPS @ 277VAC RES.1.5HP @ 120VAC2HP @ 250VAC

DPDTDouble Throw

10 AMPS @ 600VAC

SPST - NO - DMSingle Pole, Double Throw

SPDTSingle Pole, Double Throw

30 AMPS @ 277VAC RES.

1-2-3 Position Pushbutton Stations STANDARD DUTY NEMA 1 ENCLOSURES

PART # COIL VOLTS AMPS Contact Arrangements

1.5HP @ 120VAC2HP @ 250VAC

10 AMPS @ 600VAC

DPST - NODouble Pole. Single Throw,

Normally Open

45

Part # SS-600


Part # FurnasRS-1 R-44 2X441 H-268 AG-2 DR-02 CA1

RS-1A 2X440 AG-2 DR-001 CA2 115v 230V 115V 230V 440-550V 115V 230VRS-1M R-44R H-274 DR-02 A1 RS-1A Yes 1-1/2 2 1/4 1/4RS-2 J-2 2X442 H-353 RS-1 Yes 1-1/2 2 2 2 1 1/4 1/4RS-5 J-5 2X443 H-284 BG-1 RS-1M* Yes 1-1/2 2 2 2 1 1/4 1/4

RS-2 1-1/2 2 2 2 2 1 1RS-5 Yes 2 3 3 5 7-1/2 2 2

OF MAX 1400g - 3in.lbs. 900g - 2in.lbs. OF MAX 1400g - 3in.lbs. 900g - 2in.lbs.RF MIN 227g - 1/2 lb. 50g - 2in.oz. RF MIN 227g - 1/2lb. 50g - 1/2lb.PT MAX 15 to 20 degree 25 to 30 degree PT MAX 15 to 20 degree 25 to 30 degreeQT MIN 25 degree 60 degree QT MIN 25 degree 60 degreeDT MAX 12 degree 16 degree DT MAX 12 degree 16 degreeTF MAXTT MIN

2720g - 4in.lbs. 43 degree

----- 90 to 100 degree

TF MAXTT MIN

2720g - 4in.lbs.43 degree

1820g - 4in.lbs.90 deg + 10 deg

RCL-302 RCL-303Part # RCL-300 RCL-301 Part #

Standard Roller LeverSpring Return

Adj Length Roller LeverSpring Return

Reversing Drum ControlsForward-Off-Reverse - 6 Stationary Maintained Contacts

Drum Switch Cross Reference

For single-phase only

One piece metal frame heavy gauge pressed steel (grey finish). Covers are cold rolled steel, lined with Nomex. Tops are fabricated of steel, formed with flange for maximum protection against dust and moisture. Rotor contacts formed of hard rolled copper, firmly attached to steel rod covered by Bakelite tubing for best insulation. All finger contacts are cold forged copper. Arch shields and finger boards of laminated Bakelite. Spring roller and cam action incorporated to prevent "arcing" and "burning" of contacts. Corrosion protected construction. Operated by hand. Wiring diagrams included with each switch.

GECR-102- HORSEPOWER RATING

SINGLE PHASE POLYPHASE DC

46

Precision Oil Tight Limit Switches

WWGrainger

Cutler Hammer Arrow Hart

SquareD

PART #

NOTE: DO NOT USE WITH INSTANT REVERSE MOTORS*RS-1M MOMENTARY ONLY

U.L. & CSA APROV


Flush

Extended

40mm Mushroom

40mm Mushroom(Twist to release)

DOA95

N5B01VN

N5B11VNS 202

S 201 ZN5B10VN

S 211Z

S 233 N5B10VN

Configuration

Keyswitch operator - 2 position Key removes in left position only

Pushbutton Operators

N5B20VN

N5B11VN

1 NC

1 NO

1 NO - 1 NC

2 NO

Contact Blocks

N5B01VN

N5B10VN

"Safe Run"

"On Off"

Legend

Specialty OperatorsCat #

XOX circuit type w/contact blocks

OX circuit type w/contact blocks

Description NS X SC

2 position knob selector switch XO circuit type w/contact blocks

Button Type Catalog # (plus color: B, R, G, W, Bl, Y, Br, Gr) Catalog #

N5X PN - G

N5X PN - S

N5X EM4 - N

N5X ET4 - N1

OOX circuit type w/contact blocks 3 position knob selector switch

47

XO circuit type w/contact blocks 2 position knob selector switch

OOX circuit type w/contact blocks

"Start"

"Stop"

Legend PlatesCat #

3 position knob selector switch XOO circuit type w/contact blocks


*0.99999.9 hours *Indicates total run-time hours of equipment operation*Six digit readout *NonReset, eliminates false readings*Limited lifetime warranty *Size: 3-1/2" X 3-1/2"89X89mm*Available in 120, 240, 480 Volt *Additional Options: 50Hz; Resetable

*Self-contained; no ext *Continuous overloads to 120% of full scale potential trans required*Accuracy +- 2%*Use on 50Hz or 60Hz *3-1/2" X 3-1/2" 89X89mm*Additional ranges and DC models available*Available in 0-150AC Amps, 0-300AC Amps, 0-600AC Amps

*Accuracy +- 0.5% *Pointer type with an off-scale zero mark for adj with*Circuit burden 4VA max no power applied*Self contained solid state *3-1/2" X 3-1/2" 89X89mm electronic freq transducer*100-125 VAC 55-65 Hz*Additional Options: 50Hz; 400Hz; 208VAC; 240VAC

*Accuracy +- 2% *High overload current capability*Use on 50Hz or 60Hz *Circuit burden: less than 0.5VA*For use with external current *Iron vane indicates true ms value or voltage transformer independent of waveform*3-1/2" X 3-1/2" 89X89mm *0-50AC Amps; 0-100AC Amps; 0-150AC Amps; 0-200AC Amps*Additional ranges and DC *0-300AC Amps; 0-600AC Amps; 0-1000AC Amps; 0-1200AC Amps models available

48

YOKOGAWA METERS

Elapsed Time Meter

240-311

FrequencyMeter

254-350

ACAmp Meters

250-340

*Iron vane indicates true ms value or voltage independent of waveform

ACVolt Meters

250-344


Cable Protectors and CrossoversWe feature Peterson Cable Protectors as the solution to cable/pedestrian protection in high traffic areas, such ashotels, convention centers, exhibit halls and carnival midways. The product's unique design, the system of three footsections can be easily connected, disconnected or moved to accommodate varied needs.

These products are made for heavy duty use. End boots and angle sections are also available.

All models include: + High load-bearing capacity provides maximum cable protection,allowing extensive savings on cable maintenance and replacement + Compact and lightweight modular sections proved ease in handlingstoring and transporting + Effortless set-ups and break-downs offer labor savings + Interlocking system capability allows multi-length configurations + Designed for a full range of indoor and outdoor use + Engineered to protect cables from damage by physical pressure + High visibility color + High adhesion polyurethane compound for sure footed traction

5 Channel SystemWidth

"B"Height

"C"Channel

Width "D"Channel

Height "E"Weight

lbs Model #

20" 2.00" 1.25" 1.10" 28 YJ5-125

49

Yellow Jacket Classic Bumble Bee


Meets all Federal Standards for odorless & tasteless

Made in the U.S.A.

Pistol Grip spray nozzles available

Water Hose Fitting Accessories:Heavy Duty Cast Brass WaterFittings available in 1/2", 5/8", 3/4""Y" adapters with or without cut-offs

3/8" wide for narrow slot ends5/8" wide for wide slot ends

Small-Medium-Large

50

3/8" X 3' X 60'ANTI-FATIGUE - SLIP-RESISTANT - WEAR RESISTANT

CUT TO SIZE - MADE IN U.S.A.

CLEAR FOOD GRADE WATER HOSE

Cat #

F-6

Punch Type ClampsCat # Clamp ID Band Width

Sizes Available

Clamp Tool Set

F-311

5212

FLOOR MATS SAFE - N - EASY

Cat # DescriptionF100

Worm Type Clamps

* 200 PSI - 5/8" ID - FDA Approved *

Ask us about having YOUR NAME custom printed

1-1/2" 5/8"

1-3/8" 3/8"F-4 1" 5/8"


Catalog # Description5166 7-pocket tool pouch5225 Adjustable web belt603-3 Screwdriver w/3in. Round shank & No. 1 Phillips tip603-4 Screwdriver w/4in. Round shank & No. 2 Phillips tip605-4 Screwdriver w/4in. Round shank & 1/4" Cabinet tip605-6 Screwdriver w/6in. Round shank & 1/4" Cabinet tip11045 Wire stripper/cutter for 10-18 gauge solid wireJ248-8 Diagonal cutting pliers w/angled headJ203-8N Long-nose pliers w/side cuttersJ213-9NECR Side cutting pliersJ502-10 Pump pliers w/1-3/4" jaw capacity917-25 High visibility power return measuring tape

WARNING:* Always wear approved eye protection* NOT Insulated. Cushion grip screwdriver handles and

plastic dipped or slip on plastic are provided primarily for comfort. They are NOT intended for protection against electrical shock.* Do NOT use the tools provided in this on or near live electrical circuits* The tool belt provided in this is NOT an occupational protective belt* Do NOT open the tape measure case. Spring motor is under tension and opening may cause injury.

603-4

J213-9NECR11045

J203-8N

605-6

51

ELECTRICIANSTOOL SET

KLEIN TOOLSFor Professionals…Since 1857

J248-8

5166

5225

5145

917-25

J502-10


Completely self-containedFully automatic operationCompact low profile design in neutral finishUniversal mounting plate with "EZ" quick connect for rapidlabor saving installationPush to test switch6-volt, pure lead, maintenance free batteryEnvironmentally-coated, solid state chargerAutomatic low-voltage disconnect (LVD)Universal transformer for 120 or 277 VACListed for damp locationsCharge rate/power on LED indicator lightInjection-molded, V-O flame retardant high impactthermoplastic housing

Completely self-containedFully automatic operationCompact low-profile design in neutral finishPush to test switchAutomatic low-voltage disconnect (LVD)Universal transformer for 120 or 277 VACInjection-molded, V-O flame retardant high impactthermoplastic housingCharge rate/power on LED indicator lightListed for damp locationsUniversal mounting canopy includedNi-Cad battery on EM units

Universal mounting canopy includedDamp location ratedPush to test switch6V, sealed lead acid, maintenance free batteryAutomatic low-voltage disconnect (LVD)Universal transformer for 120 or 277 VACTwo fully adjustable, glare free lighting headsInjection-molded, V-O flame retardant high impactthermoplastic housingFully automatic operationEnergy consumption of less than 4W for red letters and lessthan 5W for green letters

52

EMERGENCY LIGHTINGModel R-1

Model CXTEU2RW

Model XTEU2RWEM


AC Voltage: 4.000V, 40.00V, 400.0V, 6000 VAC Current: 0-40.00A, 400.0A Accuracy: +- 1.9% Rdg + 8 LSDAC Accuracy: +- 1.5% Rdg + 5 LSD @(4.000V, 40.00V, 400.0V)DC Voltage: 0-400.0 mV, 4.00V, 40.00V, 400.0V 600VDC Accuracy: +- 0.5% Rdg + 3 LSD @(4.000V, 40.00V, 400.0V)Resistance: 0-400.0 Ohms, 4.000 kOhms, 400.0 kOhmsFrequency: 10Hz to 100kHz Accuracy: +- 0.5% Rdg + 4 LSDCapacitance: 500.0nF, 5.000uF, 50.00uF, 50.0uF, 3000uF Accuracy: +- 3.5% Rdg + 6 LSDTemperature: -4 deg F to 572 deg F (-20 deg C to 300 deg C) Accuracy: +- 2.0% Rdg + 6 deg F** Diode Test** Hold and Maximum reading functions** Accommodates conductors up to 1.02" (26mm) in diameter** Auto ranging** Auto power off and low battery indication** Rubber over-molded case** Unit ships with industrial test leads, carrying case, Type K thermocouple probe, battery

AC Voltage: 4.000/40.00/400.0/600V +-(2.0% Rdg + 5 LSD) @ 4-400V range, 50 & 60 HzAC Current: 400.0/1000 A +-(1.5% Rdg + 5 LSD) @ 50 & 60 HzDC Voltage: 400.0mV/4.000/40.00/400.0/600V +-(1.7% Rdg + 3 LSD) @ 4-400V rangeResistance: 400.0Ohm, 4.000/4.00/400.0kOhm, 4.000/40.00MOhm +-(1.0% Rdg + 4 LSD)

@ 400Ohm-400kOhm range** Auto and manual ranging** Relative zero mode** Auto power off** Data hold** Diode Test** Audible continuity** Accommodates conductors up to 1.77" (45mm) in diameter

AC Voltage: 0-150/300-600V +- 3% of full scaleAC Amps: 6/15/40/100/300A +- 3% of full scaleTemperature: -25 to 225 deg FResistance: 0-1000Ohm, 0-100.000Ohm +- 3% arc** AC Volts to 600** AC Amps to 300** Ohms to 100,000** Temperature (with optional probe) to 225 deg F** Pointer lock** 1" Diameter Jaw** Calibrated for use on 50 or 60 Hz systems** Taut Brand meter movement** Drop proof to 5 feet

53

SPECIFICATIONS FS-3 Analog AC Clamp-On Multimeter

FS-3

SPECIFICATIONS ACD-14FX Clamp-On Multimeter ACD-14FX

SPECIFICATIONS ACD-6 PRO Clamp-On Multimeter

ACD-6 PRO


AC/DC Voltage: 400mV 4.00/40.00/4.00.0/600VResistance Ranges: 400.0 Ohms 4.000/40.00/400.0 kOhms 4.000MOhms/40.00MOhms Note: AC accuracy may be affected by outside interferenceAC/DC Current: 400/4000uA 40/400 mA 4/10 ADisplay: Large Backlight LCD DisplayResistance: 400.0 Ohms 4.000/40/400.0 kOhms 4.000MOhms/40.00 MohmsFrequency: 10.00/100.0/1000 Hz 10.00/100.0/1000 kHz 10M HzDuty Cycle: 0.1%_99.9%** AC/DC micro Amps for sensor diagnosis** Diode Test** Audible Continuity Test** Data Hold** MAX, MIN and Relative measurements** Auto and Manual Ranging** Auto Power Off (can be disabled)** Tilt StandSafety: CAT-III 600V

AC Voltage: 24/120/208/240/277/480/600VDC Voltage: 6/12/24/36/48/110/220V Note: AC accuracy may be affected by outside interferenceContinuity: 0-85kOhms** Non-contact voltage detection** Automatically turns ON and OFF** Automatically selects AC Voltage, DC Voltage or Continuity** Indicated seven levels of AC or DC Voltage** Polarity Indication** Visual continuity indication (LED)** Continuity buzzerSafety: CAT-III 600V

** Detect AC Voltage (100 - 600 V)** Use non-contact method of Voltage testing** Totally insulated, no exposed metal or conductive parts** Find and pinpoint breaks in wires** Voltage Buzzer and Voltage Shaker

54

SPECIFICATIONS AM-240 Digital Multimeter AM-240

SPECIFICATIONS VPC-10N Voltage & Continuity Tester

SPECIFICATIONS VP-600SB


55


56


Watertight Pin & Sleeve Devices

57


Watertight Pin & Sleeve Devices

58


DS Contactors

Meltric Corporation

59


The Finest in Multi-Cable Connector Blocks

60

NSi ProductsThe Polaris System

IT Series

INSULATED IN-LINE SPLICER/REDUCER

INSUL-TAP CONNECTORS FOR 2 WIRESFor sizes 3/0 AWG and smaller. IT Series connectors are available in two styles - with wires being connected from the same side or from opposite sides of the connector (ITC Series). For sizes 250MCM and larger, removable access plugs allow for entry from either side of the connector, for maximum flexibility in the field

ISR Series

INSULATED MULTI-CABLE CONNECTOR BLOCKS - WIRE ENTRY FROM EITHER SIDE

Excellent for connecting two wires in-line or splicing different sized wires. Removable access plugs cover the hex screws.

ISRW SeriesINSULATED IN-LINE SPLICER/REDUCER FOR DIRECT BURIAL

Suitable for connecting two in-line. UL Listed for direct burial. Requires no taping, compounds, heat shrink or cutting -to-size in the field.

IPL SeriesINSULATED MULTI-CABLE CONNECTOR BLOCKS - WIRE ENTRY FROM ONE SIDE

Our standard insulated connector. Molded for precise fit and supplied with removable access plugs over the hex screws. Available with 3 to 14 ports. Wire entry ports on one side only.

IPLD Series

Available with up to 12 wire ports. Comes complete with removable access plugs which allow cable to enter from either side of the connector. Ultimate flexibility in the field at an excellent price

IPLDH SeriesHEAVY DUTY INSULATED CONNECTOR BLOCKS - WIRE ENTRY FROM EITHER SIDE

Heavy duty connectors designed to handle the most demanding applications from 250MCM to 750MCM. The connector block is double the size of the standard IPLD Series connector and there are two pressure screws per cable. Wire entry ports on both sides of the connector allow for access from either side.

IPLM SeriesINSULATED CONNECTOR BLOCKS WITH MOUNTING HOLES-WIRE ENTRY FROM 1 SIDESimilar to IPL Series connectors except equipped with mounting holes at each end of the connector for isolated mounting direct to trough, panel, or wire way. Wire ports on one side only.

IPLMD SeriesINSULATED CONNECTOR BLOCKS W/MOUNTING HOLES-WIRE ENTRY FROM EITHER SIDE

CONNECTORS TO FIT YOUR APPLICATION

We can custom engineer and fabricate an insulated block system for any project. Choose any/all of the following features: offset wire entry, mounting capability, stacked wire holes or pass-through wire holes. We can solve all of your connection problems. Shipment is generally in less than 2-3 days.

Custom-Designed UL Listed

Similar to IPLD Series connectors except with mounting holes at each end of the connector for isolated mounting direct to trough, panel or wire way. Wire entry ports on both sides of the connector.

PL SeriesNON-INSULATED CONNECTORS

One-hole increments of the same size, up to 14 holes. Made from 6061-T6 aluminum alloy with rounded edges for easy handling. Conductive plating for low contact resistance.


Part # Wire Range A B C D6T 4-14 0.938 .375 .500 .3754T 4-14 1.060 .375 .500 .2502T 2-14 1.150 .440 .580 .2500T 1/0-14 1.340 .530 .690 .2502/0T 2/0-14 1.470 .560 .750 .2503/0T 3/0-6 1.750 .719 .844 .266250T 250MCM-6 1.438 .810 1.000 .313300T 300MCM-6 1.940 .820 1.000 .313350T 350MCM-6 2.120 .900 1.090 .375500T 500MCM-4 2.813 1.250 1.563 .406600T 600MCM-2 2.813 1.19 1.58 .375800T 800/300MCM 3.375 1.750 1.938 .6561000T 1000-500MCM 3.375 1.750 1.938 .6562-0T (2)1/0-14 1.340 1.120 .690 .2502-2/0T (2)2/0-14 1.470 .560 .750 .3132-250T (2)250MCM-6 1.438 1.750 1.000 .3132-350T (2)350MCM-6 2.120 1.880 1.090 .5002-600T (2)600MCM-2 2.810 2.440 1.580 .5002-800T (2)800-300MCM 3.375 3.188 1.938 .6562-1000T (2)1000-500MCM 3.375 3.188 1.938 .656

Part # Wire Color Range A B C D E F5217-8-3/8 Red #8 1.69 .48 .06 .34 .31 .696-8RI-5/16 Blue #6 1.75 .50 .06 .34 .31 .695225-4-5/16 Grey #4 1.81 .56 .08 .34 .38 .69BLU-2S10 Brown #2 1.94 363 .10 .41 .41 .81BLU-1/0S20 Pink 1/0 2.06 .73 .12 .41 .41 .81BLU-2/0S4 Black 2/0 2.31 .81 .12 .56 .5. 1.06BLU-3/0S Orange 3/0 2.88 .94 .13 .56 .53 1.06BLU-4/0S1 Purple 4/0 2.53 1.06 .13 .58 .53 1.06BLU-025 Yellow 250mcm 2.69 1.13 .14 .58 .53 1.06

Cord Grip IPON ConnectorsCatalog # DescriptionK1234N3802 3/8" Cord Grip ConnectorK1234N1202 1/2" Cord Grip ConnectorK1235N3402 3/4" Cord Grip ConnectorK1234N1002 1" Cord Grip Connector

61

Dimensions

ELECTRICAL ACCESSORIESSolderless Connectors

Dimensions

Short Barrel One Hole Compression Connectors

SOBYCO ELECTRIC SUPPLY 1800-992-2524

Part # Hub Size Outlets Part # Color1B50-3 1/2" 2 3104 (#18-22) Red1B75-3 3/4" 3 3105 (#14-16) Blue1B50-4 1/2" 4 3106 (#10-12) Yellow1B75-4 3/4" 41B50-5 1/2" 5 Part # Color1B75-5 3/4" 5 3117 (#14-16) Blue

3124 (#10-12) YellowPart # Hub Size Outlets

1DB50-3 1/2" 3 Part # Color1DB75-3 3/4" 3 3120 (#14-16) Blue1DB50-4 1/2" 4 3126 (#10-12) Yellow1DB75-4 3/4" 4

Part # Part # Color1C-DH Dup Recept - Horiz WP566 (#14-22) Blue1C-DV Dup Recept - Vert WP555 (#14-22) Orange1C-SH Single Recept - Horiz WP111 (#12-18) Yellow1C-SV Single Recept - Vert WP133 (#10-18) Red1C-GH GFCI Recept - Horiz1C-GV GFCI Recept - Vert1-BC Blank Cover Part # Color LengthEXR-1 Extension Ring CV04 White 4"

CV07 White 7"CVB07 Black 7"

Part # Hub Size Outlets CV14 White 14"2B50-3 1/2" 3 CVB14 Black 14"2B75-3 3/4" 3 CVB18 Black 18"2B50-4 1/2" 4 CVB24 Black 24"2B75-4 3/4" 42B50-5 1/2" 52B75-5 3/4" 5

Black White PurplePart # Hub Size Outlets Brown Red Blue

2DB75-5 3/4" 5 Green Grey Orange2DB100-5 1" 5 Yellow

Friction and Rubber Tape also availablePart #

2C-2D Two Dup Recept2C-2S Two Single Recept2C-2G Two GFCI Recept Part #2C-SD Single & Dup Recept MM410C 1-Gang 16-in-1 Combo. 2.75" Depth, Clear2C-CS Single & GFCI Recept MM2410C 2-Gang 55-in-1 Combo, 2.75" Depth, Clear2C-CD Dup & GFCI Recept2-BC Blank CoverEXR-2 Extension Ring

Two Gang 2-5/8" Deep

WEATHERPROOF BOXES ELECTRICAL CONNECTORSSingle Gang 2" Deep

Single Gang 2-5/8" Deep

Cable Ties

Electrical Tape 3/4"x66'Colors

AccessoriesDescription

Two Gang 2" Deep

Butt Connectors

Ring Connectors

Spade Connectors

Wire Nuts

62

In-Use Clear Bubble CoversDescription

AccessoriesDescription

SOBYCO ELECTRIC SUPPLY 1800-992-2524

FUSESElectronic Fuses

Type Description

ABC 1/4"x1-1/4" Ceramic Fast Acting

AGA 1/4"x5/8" Glass Fast Acting 1/16" thru 30 Amp

AGC 1/4"x1-1/4" Glass Fast Acting 1/32nd thru 35 Amp

ATC 32V Automotive Blade Fast Acting 3 thru 40 Amp

GBB 1/4"x1-1/4" Ceramic Very Fast Acting Cartridge 1 thru 30 Amp

GMA 5mm x 20mm Glass Fast Acting 63mA thru 15 Amp

MOL 250 VAC Fast-Acting Midget Fiber

Cartridge FusesAmps Volts Dual Element

30 250

60 250 NON-60 ECNR-60

100 250 NON-100 ECNR-100

200 250 NON-200 ECNR-200

400 250 NON-400 ECNR-400

Fuse Blocks and Fuse Holders

Bolt down Fuse Holders1/4" x 1-1/4"

NON-30 ECNR-30

ELNE-400

ELNE-30

ELNE-60

ELNE-100

ELNE-200

Amperages

1/8th thru 30 Amp

.5 thru 30 Amp

One Time Replacement Link

Plug Fuses15-30 Amp

1/4" x 1-1/4"Panel Mounted

Panel Mounted w/ BlownFuse Lamp Indicator

63

Other fuse types and amperages available upon request

1/4" x 1-1/4" In-Line Fuse Holder


Cat. # Expanded RecoveredTWHS 500-6 .500" .250"HWHS 110-12 1.10" .350"HWHS 150-12 1.50" .470"HWHS 200-12 2.00" .630"

Compression Splices (Tinned Copper)

SC-6 SC-4 SC-2 Brown SC-1 Green SC-1/0 1/0 Pink SC-2/0 2/0 Black SC-3/0 3/0 Orange SC-4/0 Purple SC-250 Yellow SC-350 Red

Ground Rods/Ground Rod Clamps

G-5 1307-B G588 C5810

Crimping Tool

Completely self-contained, no additional dies required

5/8" x 10"Copper5/8" x 8' Galvanized

Cat. # Rod Size5/8"

Blue Gray

1/2" - 1" 2 Stranded

Max Grd Wire2 Solid

1246

64

Heat Shrinkable TubingFlexible flame retardant, thin wall, general purpose heat shrinkable polyolefin tubing has a 2:1 shrink ratio. Used for electrical insulation, wire harness bundling, wire jacket marking and color coding, it also splices and makes functional terminations. Available in black, white, red, green, blue and clear. Standard packaging is either 6? lengths in blister boxes, or in economical 25? spools. UL Recognized to Standard 224. Black, white and colored thin wall tubing meet MIL-DTL-23053/5, Class 1. Clear meets MIL-DTL-23053/5, Class 2 and is not flame retardant. Rated 600 volts, 125°C.

HWHS 268-12 2.68" .870"

Wire Size Color Code Cat. #

350250

4/0

Documents

TABLE OF CONTENTS - Sobyco Electricsobyco.net/products/sobyco.pdf · Male Inlet 5678C Female Inlet 5679C 6-15 5666C 5669C 5678C 5679C 20 AMP 250V 2-Pole 3-Wire Description Part #