© Copyright 2014 Zoeller Co. All rights reserved.502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com

FM27850414

Supersedes0114

TECHNICAL DATA SHEETHIGH HEAD FLOW-MATE SERIES

Models 161/4161, 163/4163, 165/4165 Effluent Pumps

SK1413

SINGLE SEAL

DOUBLE SEAL

19 5/16" [491 mm]

6" [152 mm]

4" 8 3/4"

6 1/2"

4" [102 mm]

6 11/32" [161 mm]

1 1/2" NPT STANDARD2" NPTOR3" NPTAVAILABLE

[222 mm]

[165 mm]

[102 mm]

6” (152 mm)

21 3/16” (538 mm)

4”(102 mm)

8 3/4”(222 mm)

6 1/2”(165 mm)

1 1/2" NPT STANDARD2” NPT or3” NPT Available

4” (102 mm)

4” (102 mm)

SK374

PRODUCT SPECIFICATIONS

NOTE: The sizing of effluent systems normally requires variable level float(s) controls and properly sized basins to achieve required pumping cycles or dosing timers with nonautomatic pumps.

MO

TOR

Horse Power 1/2 (161/4161, 163/4163) or 1 (165/4165)

Voltage 115 - 575

Phase 1 or 3 Ph

Hertz 60 Hz

RPM 3450

Type Permanent split capacitor or 3 Ph

Insulation Class B

Amps 2.4 - 15.5

PU

MP

Operation Automatic or nonautomatic

Auto On/Off Points 15-3/4" (400 mm) / 5-1/4" (133 mm)

Discharge Size 1-1/2" NPT (optional 2" or 3" flange)

Solids Handling 3/4" (19 mm) spherical solids

Cord Length 20' (6 m) standard

Cord Type1 Ph: UL listed 3-wire neoprene cord and plug or 3 Ph: 4-wire with no plug

Max. Head 86.5' (26 m)

Max. Flow Rate 100 GPM (379 LPM)

Max. Operating Temp. 130° F (54° C)

Cooling Oil filled

Motor Protection Auto reset thermal overload (1 Ph)

MA

TE

RIA

LS

Upper Bearing Ball bearing

Lower Bearing Ball bearing

Mechanical Seals Carbon and ceramic

Impeller Type Non-clogging vortex

Impeller Bronze

Hardware Stainless steel

Motor Shaft SAE 1117 carbon steel or 416 stainless steel

Gasket Neoprene square ring and gasket

Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.

®

Your Peace of Mind is Our Top Priority ®

Tested to Standard UL778 andCertified to CSA

Standard C22.2 No. 108

R

R LU

NOTE: See model comparison chart for specific details.

All Class 30 cast iron construction.

© Copyright 2014 Zoeller Co. All rights reserved.502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com

SELECTION GUIDE1. Integral float operated mechanical switch, no external control required.

2. For automatic use single piggyback variable level float switch or double piggyback variable level float switch. Refer to FM0477.

3. See FM1228 for correct model of simplex control panel.

4. See FM0712 for correct model of duplex control panel.

5. Variable level control switch 10-0743 used as a control activator, specify simplex (3) float or duplex (4) float system. Refer to FM0526.

009920

PUMP PERFORMANCE CURVEMODELS 161/4161-163/4163-165/4165

GALLONSLITERS 0 80

FLOW PER MINUTE160 240 320

165/4165

TOTA

L DY

NAM

IC H

EAD

12

20

30

10

0

4

8

10 20 30

80

70

60

50

40

16

20

24

163/4163

40 50 60 70

161/4161

80 90 110

90

FEET

MET

ERS

100

400

NOTE: No UL listing for 200/208 1 Phase pumps, model 186 & 191, or double seal series.

MODELS 161/4161 165/4165163/4163Feet LitersGal.LitersGal.LitersGal.Meters

24.480Shut-off Head:

--56 ft. (17m)

--

50

7060

4030

152025

510

----

15.2

21.318.3

9.112.2

7620----

4562

170233

100

4.66.17.6

3.01.5

322857970

297265

93 352379

381086.5 ft. (26m)

--66 ft. (20m)

----

57

172206

12533

--15

4655

50

2339

5558

231231

223227

216

605957

6161

616059

6161

189

87148

208220

231227223

231231

ModelMODEL COMPARISON CERTIFICATIONS

Seal Mode Volts Ph Amps HP Hz Lbs Kg Simplex Duplex CSA UL

M161 Single Auto 115 1 15.5 1/2 60 80 36 1 --- Y Y

N161 / N4161 Single / Double Non 115 1 15.0 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y N(1)

D161 Single Auto 230 1 7.5 1/2 60 80 36 1 --- Y Y

E161 / E4161 Single / Double Non 230 1 7.5 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y Y

* H161 Single Auto 200 1 8.8 1/2 60 80 36 1 --- Y N

* I161 / I4161 Single / Double Non 200 1 8.8 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y N

* J161 / J4161 Single / Double Non 200 3 6.4 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* F161 / F4161 Single / Double Non 230 3 5.2 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* G161 / G4161 Single / Double Non 460 3 2.9 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* BA161/BA4161 Single / Double Non 575 3 2.4 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y N

M163 Single Auto 115 1 15.0 1/2 60 80 36 1 --- Y Y

N163 / N4163 Single / Double Non 115 1 15.0 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y N(1)

D163 Single Auto 230 1 7.5 1/2 60 80 36 1 --- Y Y

E163 / E4163 Single / Double Non 230 1 7.5 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y Y

* H163 Single Auto 200 1 8.5 1/2 60 80 36 1 --- Y N

* I163 / I4163 Single / Double Non 200 1 8.5 1/2 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y N

* J163 / J4163 Single / Double Non 200 3 6.0 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* F163 / F4163 Single / Double Non 230 3 4.8 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* G163 / G4163 Single / Double Non 460 3 2.9 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* BA163/BA4163 Single / Double Non 575 3 2.4 1/2 60 80 / 87 36 / 39 3 & 5 4 & 5 Y N

D165 Single Auto 230 1 10.2 1 60 80 36 1 --- Y Y

E165 / E4165 Single / Double Non 230 1 10.2 1 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y Y

* H165 Single Auto 200 1 12.6 1 60 80 36 1 --- Y N

* I165 / I4165 Single / Double Non 200 1 12.6 1 60 80 / 87 36 / 39 2 or 3 & 5 4 & 5 Y N

* J165 / J4165 Single / Double Non 200 3 7.5 1 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* F165 / F4165 Single / Double Non 230 3 7.4 1 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* G165 / G4165 Single / Double Non 460 3 3.7 1 60 80 / 87 36 / 39 3 & 5 4 & 5 Y Y

* BA165/BA4165 Single / Double Non 575 3 3.0 1 60 80 / 87 36 / 39 3 & 5 4 & 5 Y N

* no molded plug (1) UL listed unit available with 20 Amp plug. (2) CSA approval with 20 Amp plug. (3) 20 Amp outlet, P/N 10-0060 must be used. Additional cords lengths are available in 25' (8 m), 35' (11 m), and 50' (15 m).

TOTAL DYNAMIC HEAD FLOW PER MINUTE

All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).CAUTION

© Copyright 2014 Zoeller Co. All rights reserved.502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com

TECHNICAL DATA SHEETHIGH HEAD FLOW-MATE SERIESModels X161, X163, X165 Effluent Pumps

Class I, Division 1, Group C & D Rated

AUTOMATIC

NONAUTOMATIC

PRODUCT SPECIFICATIONS

NOTE: The sizing of effluent systems normally requires variable level float(s) controls and properly sized basins to achieve required pumping cycles or dosing timers with nonautomatic pumps.

MO

TOR

Horse Power 1/2 (X161, X163) or 1 (X165)

Voltage 115 - 575

Phase 1 or 3 Ph

Hertz 60 Hz

RPM 3450

Type Permanent split capacitor or 3 Ph

Insulation Class B

Amps 2.4 - 15.5

PU

MP

Operation Automatic or nonautomatic

Auto On/Off Points 19-1/2" (495 mm) / 9-3/4" (248 mm)

Discharge Size 1-1/2" NPT (optional 2" or 3" flange)

Solids Handling 3/4" (19 mm) spherical solids

Cord Length 20' (6 m) standard

Cord Type UL listed 5-wire (1 Ph) or 8-wire (3 Ph) SOOW

Max. Head 86.5' (26 m)

Max. Flow Rate 100 GPM (379 LPM)

Max. Operating Temp. 104° F (40° C)

Cooling Oil filled

Motor Protection Auto reset thermal overload (1 Ph) or thermal sensor (3 Ph)

MA

TE

RIA

LS

Upper Bearing Ball bearing

Lower Bearing Ball bearing

Mechanical Seals Carbon and ceramic with stainless steel parts

Impeller Type Non-clogging vortex

Impeller Bronze

Hardware Stainless steel

Motor Shaft 416 stainless steel

Gasket Neoprene square rings

NOTE: See model comparison chart for specific details.

6 1/2

8 3/4

1 1/2" NPT STANDARD2" NPTOR3" NPTAVAILABLE

22 29/32

4 9/16

4 9/16

23 9/32

1 1/2" NPTCONDUIT CONNECTION

CHECK VALVE

6 1/16

SK1912

4 9/16 8 3/4

6 1/2

1 1/2” NPT STANDARD2” NPTOR3” NPTFLANGE AVAILABLE

4 9/16

8 9/16

1 1/2” NPTCONDUIT

CONNECTION

24 15/16

21 1/2

4 29/32 6 1/16

SK2506

Standard 3600 & 3615

R

Tested to CSA Standard C22.2

No. 145

All Class 30 cast iron construction.

© Copyright 2014 Zoeller Co. All rights reserved.502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com

SELECTION GUIDE1. See FM1705 for correct intrinsically safe simplex or duplex panel

2. See FM0526 for variable level control switches rated 30VDC are used as a control activator. Quantity required dependent upon panel selection.

3. Integral float operated mechanical switch; no external control required

4. Automatic pumps: Use the optional seal-failure panel (10-1031) to enable the moisture sensor circuit if required by local codes

009920

ModelMODEL COMPARISON CERTIFICATIONS

Seal Mode Volts Ph Amps HP Hz Lbs Kg Simplex Duplex FM CSA

MX161 Single Auto 115 1 15.5 1/2 60 123 55 3 & 4 --- Y Y

NX161 Single Non 115 1 15.5 1/2 60 114 51 1 & 2 1 & 2 Y N(1)

DX161 Single Auto 230 1 7.5 1/2 60 123 55 3 & 4 --- Y Y

EX161 Single Non 230 1 7.5 1/2 60 114 51 1 & 2 1 & 2 Y Y

HX161 Single Auto 200 1 8.8 1/2 60 123 55 3 & 4 --- Y N

IX161 Single Non 200 1 8.8 1/2 60 117 53 1 & 2 1 & 2 Y N

JX161 Single Non 200 3 6.4 1/2 60 117 53 1 & 2 1 & 2 Y Y

FX161 Single Non 230 3 5.2 1/2 60 117 53 1 & 2 1 & 2 Y Y

GX161 Single Non 460 3 2.9 1/2 60 117 53 1 & 2 1 & 2 Y Y

BAX161 Single Non 575 3 2.4 1/2 60 117 53 1 & 2 1 & 2 Y N

MX163 Single Auto 115 1 15.0 1/2 60 123 55 3 & 4 --- Y Y

NX163 Single Non 115 1 15.0 1/2 60 114 55 1 & 2 1 & 2 Y N(1)

DX163 Single Auto 230 1 7.5 1/2 60 123 55 3 & 4 --- Y Y

EX163 Single Non 230 1 7.5 1/2 60 117 53 1 & 2 1 & 2 Y Y

HX163 Single Auto 200 1 8.5 1/2 60 123 55 3 & 4 --- Y N

IX163 Single Non 200 1 8.5 1/2 60 117 53 1 & 2 1 & 2 Y N

JX163 Single Non 200 3 6.0 1/2 60 117 53 1 & 2 1 & 2 Y Y

FX163 Single Non 230 3 4.8 1/2 60 117 53 1 & 2 1 & 2 Y Y

GX163 Single Non 460 3 2.9 1/2 60 117 53 1 & 2 1 & 2 Y Y

BAX163 Single Non 575 3 2.4 1/2 60 117 53 1 & 2 1 & 2 Y N

DX165 Single Auto 230 1 10.2 1 60 124 56 3 & 4 --- Y Y

EX165 Single Non 230 1 10.2 1 60 114 51 1 & 2 1 & 2 Y Y

HX165 Single Auto 200 1 12.6 1 60 124 56 3 & 4 --- Y N

IX165 Single Non 200 1 12.6 1 60 117 53 1 & 2 1 & 2 Y N

JX165 Single Non 200 3 7.5 1 60 117 53 1 & 2 1 & 2 Y Y

FX165 Single Non 230 3 7.4 1 60 117 53 1 & 2 1 & 2 Y Y

GX165 Single Non 460 3 3.7 1 60 117 53 1 & 2 1 & 2 Y Y

BAX165 Single Non 575 3 3.0 1 60 117 53 1 & 2 1 & 2 Y N

* no molded plug (1) UL listed unit available with 20 Amp plug. (2) CSA approval with 20 Amp plug. (3) 20 Amp outlet, P/N 10-0060 must be used. Additional cords lengths are available in 25' (8 m), 35' (11 m), and 50' (15 m).

TOTAL DYNAMIC HEAD FLOW PER MINUTE

All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).CAUTION

PUMP PERFORMANCE CURVEMODELS X161-X163-X165

410

GALLONSLITERS

0

0 80

10 20 30

FLOW PER MINUTE160 240

40 50 60 70

320

80 90 110

X165

TOTA

L DY

NAM

IC H

EAD

50

30

20

40

8

12

16

90

80

70

60

20

24

X163

X161

MET

ERS

FEET

100

400