TRITEX BLEACHING SYSTEM FOR CELLULOSIC FIBERS AND BLENDS Slide 2
TRITEX BLEACHING SYSTEM Reduced water and energy consumption Short
Process time Safe dyeing High reproducibility Slide 3 TRITEX
BLEACHING PROCESS Bleaching 0.4 g/l Triscour Jet Conc 0.2 g/l
Trilube BW liq 0.1 g/l Tristabilizer Jet-5 3.0 g/l NaOH 50% 6.0 g/l
H2O2 35% Neutralisation 1.0 ml/l Triassist DSA H2O2 elimination 0.1
ml/l Triminox GH 50 C 100 C 50 C 4.0 C/min 15 min 80 C -3.0 C/min
dyeing 110 C 30 min Total Process time: 75 Min Liquor Ratio 6:1
Rinsing bath: 1 Slide 4 TRISCOUR JET CONC 100% active detergent
developed especially to provide the following properties: Excellent
degree of whiteness Outstanding hydrophilicity and very good
absorbancy Low foam product suitable for all kinds of machines
Stable to high pH and electrolytes Very efficient for cleaning
cotton/elastane blends Suitable for PDF and Full white Slide 5
TRISCOUR JET CONC Hydrophilicity after discontinuous peroxyde
Bleach Competition Rewetting 8 sec Triscour Jet Conc Instant
Rewetting Triscour Jet-4 No redeposition Removal of oils and grease
efficiency Competition Poor detergency Slide 6 TRISCOUR JET CONC
The graph illustrates that Triscour Jet CONC results in a superior
white Slide 7 TRISCOUR JET CONC Limit for Jet application Foam
level (mm) Slide 8 Draves Test This demonstrates that the speed of
wetting of 100% bleached cotton with Triscour JET CONC is faster
than the competition The Draves Test: 100% cotton yarn is bleached
with the products to be evaluated and then dried. The yarn is
attached to a weight by the use of thread and then dropped into a
cylinder filled with water. From the time the weight is at the
bottom of the cylinder to the time the tread attached to the yarn
and the weight sags is recorded as the wetting speed. 0 Seconds
Triscour Jet CONC 15 Seconds Competition 0 Seconds45 Seconds When
the thread sags thetime is stopped Thread and weight Bleached Yarn
Slide 9 TRIASSIST DSA Removes residual alkali from bleaching Core
neutralisation of the fabric Excellent dispersing properties and
prevent deposits on fabric and machinery Good binding properties
with Fe, Ca and Mg No formation of undesired salts or buffers
during neutralisation Slide 10 Works over a very broad range of pH
from 3 to 10 Efficient in a wide temperature spectrum up to 65 C
TRIMINOX GH Slide 11 THANK YOU!
