Embed Size (px)
Citation preview
Union County Lumber Company NPDES Application for New Permit
February 19, 2015
NPDES Application for New Permit Prepared for: Union County Lumber Company 5482 Junction City Highway El Dorado, AR 71730
Prepared by: GBMc
219 Brown Lane & Associates
Bryant, AR 72022
February 19, 2015
February 19, 2015
CONTENTS Application Summary Form 1 Area Maps FEMA Map Water Supply Sources Form 2D Process Flow Diagram Form 2F Site Drainage Map Design Drawings and Specification Design Calculations Certificates of Good Standing Disclosure Statement
Application Summary
February 19, 2015
APPLICATION SUMMARY Union County Lumber is reopening an existing lumber mill located at 5482 Junction Highway in El Dorado, AR. The facility was formerly owned by Georgia Pacific. The facility contains a wet deck operation that is used to keep logs wet when stored on-site. The wet deck operation contains two ponds. One is used to recirculate water to the wet deck. The other pond is a free board pond that is used to collect overflow water from the recirculation pond in times of a large storm event and as make-up water wet deck operations. The recirculation pond was closed upon permanent shutdown of the facility by GP. Union County Lumber plans to re-open the recirculation pond in the same location as it was previously. This application package is being submitted for a State Construction Permit and to request coverage under an NPDES permit for the wet decking activities at the facility. Included with this application package are Forms 1, 2D, 2F, Area Maps, Site Diagram, Water Supply Sources, Flow Diagram, Design Drawings and Calculations, Disclosure Statement, and other pertinent information necessary to complete the permit renewal process.
Form 1
Revised September 2014
Arkansas Department of Environmental Quality NPDES PERMIT APPLICATION
FORM 1
INSTRUCTIONS:
1. This form should be typed or printed in ink. If insufficient space is available to address any item please continue on an attached sheet of paper.
2. Please complete the following Section(s). If a Section is not required, please check the Not Applicable (N/A) box at the top of the Section.
Sections A B C D E F G H I POTW X X X X X Industrial User X X X X X X X X Construction Permit Only X X * X X X Modification X X X X X * * X X All Other Applicants X X X X X X
* As necessary
3. If you need help on SIC or NAICS go to www.osha.gov/oshstats/sicser.html
4. If you have any questions about this form you may call NPDES Section at 501-682-0622 or go to www.adeq.state.ar.us/water. You may also contact :
Department Information in Regard to Telephone # Arkansas Department of Health Water Supply 501-661-2623
5. The following EPA Forms in addition to Form 1 is required for processing your application: Form 2A - Municipal Dischargers Form 2B - Form 2C - Existing Manufacturing, Commercial, Mining, and Silvicultural Operations
Concentrated Animal Feeding Operations
Form 2D - New Sources and New Dischargers Application for Permit to Discharge Process Wastewater Form 2E - Facilities Which Do Not Discharge Process Wastewater (i.e. Domestic, Non contact cooling water) Form 2F - Application for Permit to Discharge Storm Water Discharges Associated With Industrial Activity
6. Where to Submit
Return the completed form by mail to: Arkansas Department of Environmental Quality Permits Branch, Water Division 5301 Northshore Drive North Little Rock, AR 72118 Or by email to: [email protected]
Page 2 Revised September 2014
NPDES PERMIT APPLICATION FORM 1
ARKANSAS DEPARTMENT OF ENVIRONMENTAL QUALITY
WATER DIVISION 5301 Northshore Drive
North Little Rock, AR 72118-5317 www.adeq.state.ar.us/water
PURPOSE OF THIS APPLICATION
INITIAL PERMIT APPLICATION FOR NEW FACILITY INITIAL PERMIT APPLICATION FOR EXISTING FACILITY MODIFICATION OF EXISTING PERMIT REISSUANCE (RENEWAL) OF EXISTING PERMIT MODIFICATION AND CONSTRUCTION OF EXISTING PERMIT CONSTRUCTION PERMIT
SECTION A- GENERAL INFORMATION 1. Legal Applicant Name (who has ultimate decision making responsibility over the operation of a facility or activity):
Union County Lumber Company Note: The legal name of the applicant must be identical to the name listed with the Arkansas Secretary of State.
2. Operator Type: Private State Federal Partnership Corporation Other
State of Incorporation: Arkansas 3. Facility Name: Union County Lumber Company – El Dorado Mill
4. Is the legal applicant identified in number 1 above, the owner of the facility? Yes No
5. NPDES Permit Number (If Applicable): AR00
6. NPDES General Permit Number (If Applicable): ARG
7. NPDES General Storm Water Permit Number (If Applicable):
8. Permit Numbers and/or names of any permits issued by ADEQ or EPA for an activity located in Arkansas that is presently held by the applicant or its parent or subsidiary corporation which are not listed above:
Permit Name Permit Number Held by
None
9. Give driving directions to the wastewater treatment plant with respect to known landmarks:
4 miles south of Highway 82 on Highway 167 (Junction City Highway)
10. Facility Physical Location: (Attach a map with location marked; street, route no. or other specific identifier)
Street: 5482 Junction City Highway
City: El Dorado County: Union State: AR Zip: 71730
Page 3 Revised September 2014
11. Facility Mailing Address for permit, DMR, and Invoice (Street or Post Office Box):
Name: Robert Hanry Title: Operation Manager
Street: 5482 Junction City Highway P.O. Box N/A
City: El Dorado State: AR Zip: 71730
E-mail address*: [email protected] Fax: N/A
* Is emailing all documents (permit, letters, DMRs, invoices, etc.) acceptable to the applicant? Yes No
12. Neighboring States Within 20 Miles of the permitted facility (Check all that apply):
Oklahoma Missouri Tennessee Louisiana Texas Mississippi
13. Indicate applicable Standard Industrial Classification (SIC) Codes and NAICS codes for primary processes
2421 SIC Facility Activity under this SIC or NAICS:
321113 NAICS Operation of a Sawmill
14. Design Flow: Variable MGD Highest Monthly Average of the last two years Flow: N/A MGD
15. Is Outfall equipped with a diffuser? Yes No
16. Responsible Official (as described on the last page of this application):
Name: Brian Fehr Title: President
Address: 5482 Junction City Highway Phone Number: 870-315-9397
E-mail Address: N/A
City: El Dorado State: AR Zip: 71730
17. Cognizant Official (Duly Authorized Representative of responsible official as describe on the last page of this application):
Name: Robert Hanry Title: Operation Manager
Address: 5482 Junction City Highway Phone Number: 870-315-9397 E-mail Address: [email protected]
City: El Dorado State: AR Zip: 71730
18. Name, address and telephone number of active consulting engineer firm (If none, so state):
Contact Name: Amanda Gallagher
Company Name: GBMc & Associates
Address: 219 Brown Lane Phone Number: 501-847-7077
E-mail Address: [email protected]
City: Bryant State: AR Zip: 72022
19. Wastewater Operator Information
Wastewater Operator Name: N/A License number:
Class of municipal wastewater operator: I II III IV
Class of industrial wastewater operator: Basic Advanced
Page 4 Revised September 2014
SECTION B: FACILITY AND OUTFALL INFORMATION
1. Facility Location (All information must be based on front door (Gate) location of the facility):
Lat: 33 ° 07 ‘ 56.1 “ Long: 92 ° 38 ‘ 7.0 “ County: Union Nearest Town:
El Dorado
2. Outfall Location (The location of the end of the pipe Discharge point.):
Outfall No. 001:
Latitude: 33 ° 08 ’ 15.7 ” Longitude: 92 ° 38 ’ 22.9 ”
Where is the collection point?
Name of Receiving Stream (i.e. an unnamed tributary of Mill Creek, thence into Mill Creek; thence into Arkansas River):
Unnamed tributary of Bayou de L’outre, thence to Bayou de L’outre, and thence to the Ouachita River
Outfall No. N/A:
Latitude: ° ’ ” Longitude: ° ’ ”
Where is the collection point?
Name of Receiving Stream (i.e. an unnamed tributary of Mill Creek, thence into Mill Creek; thence into Arkansas River):
3. Monitoring Location (If the monitoring is conducted at a location different than the above Outfall location):
Outfall No. N/A:
Lat: ° ‘ “ Long: ° ‘ “
Outfall No. :
Lat: ° ‘ “ Long: ° ‘ “
Outfall No. :
Lat: ° ‘ “ Long: ° ‘ “
4. Type of Treatment system (Included all components of treatment system and Attach the process flow diagram):
Sedimentation Pond
Page 5 Revised September 2014
5. Do you have, or plan to have, AUTOMATIC sampling equipment or CONTINUOUS wastewater flow metering equipment at this facility?
Current: Flow Metering Yes Type: _ ________ No N/A Sampling Equipment Yes Type: _ _______ No N/A
Planned: Flow Metering Yes Type: _ ________ No N/A Sampling Equipment Yes Type: _ ______ No N/A
If YES, please indicate the present or future location of this equipment on the sewer schematic and describe the equipment below:
If NO, please describe the method and location of flow measurement below:
Flow Weir
6. Is the proposed or existing facility located above the 100-year flood level? Yes No
NOTE: FEMA Map must be included with this application. Maps can be ordered at www.fema.gov .
If "No", what measures are (or will be) used to protect the facility?
7. Population for Municipal and Domestic Sewer Systems: N/A 8. Backup Power Generation for Treatment Plants
Are there any permanent backup generators? Yes No
If Yes, How many? Total Horespower (hp)?
If No, Please explain? Sedimentation pond does not require electricity to operate.
Page 6 Revised September 2014
SECTION C – WASTE STORAGE AND DISPOSAL INFORMATION
1. Sludge Disposal Method (Check as many as are applicable):
Landfill
Landfill Site Name ADEQ Solid Waste Permit No.
Land Application: ADEQ State Permit No.
Septic tank Arkansas Department of Health Permit No.:
Distribution and Marketing: Facility receiving sludge:
Name: Address:
City: State: Zip: Phone:
Rail: Pipe: Other:
Subsurface Disposal (Lagooning):
Location of lagoon How old is the lagoon?
Surface area of lagoon: Acre Depth: ft Does lagoon have a liner? Yes No
Incineration: Location of incinerator
Remains in Treatment Lagoon(s):
How old is the lagoon(s)? Has sludge depth been measured? Yes No
If Yes, Date measured? Sludge Depth? ft If No, When will it be measured?
Has sludge ever been removed? Yes No If Yes, When was it removed?
Other (Provide complete description): Sedimentation ponds will be cleaned out on an as needed basis. Union County Lumber will dispose of the waste materials in an ADEQ approved method.
Page 7 Revised September 2014
SECTION D - WATER SUPPLY SEE ATTACHMENT – WATER SUPPLY SOURCES
Water Sources (check as many as are applicable):
Private Well - Distance from Discharge point: Within 5 miles Within 50 miles
Municipal Water Utility (Specify City):
Distance from Discharge point: Within 5 miles Within 50 miles
Surface Water- Name of Surface Water Source:
Distance from Discharge point: Within 5 miles Within 50 miles
Lat: ° ‘ “ Long: ° ‘ “
Other (Specify):
Distance from Discharge point: Within 5 miles Within 50 miles
Page 8 Revised September 2014
NOT APPLICABLE (N/A):
SECTION E: FINANCIAL ASSURANCE AND DISCLOSURE STATEMENT
1. Arkansas Code Annotated § 8-4-203provides for financial assurance requirements for permitting non-municipal domestic sewage treatment systems. Arkansas Code 8-4-203 (b)(1)(A)(i) – “The department shall not issue, modify, or renew a National Pollutant Discharge Elimination System permit or state permit for a non-municipal domestic sewage treatment works without the permit applicant first demonstrating to the department its financial ability to cover the estimated costs of operating and maintaining the non-municipal domestic sewage treatment works for a minimum period of five (5) years.”
The applicant must provide a detailed estimate of the operation and maintenance (O&M) costs for the facility for a five year period. Once the O&M estimate is approved, the applicant must provide financial assurance in order to show that the facility is able to cover the costs of operating and maintaining the treatment system for the next five years.
The minimal financial assurance may be demonstrated to the department by using the following as outlined in Arkansas Code 8-4-203(b)(2):
A. Obtaining insurance that specifically covers operation and maintenance costs B. Obtaining a letter of credit; C. Obtaining a surety/performance bond; D. Obtaining a trust fund or an escrow account; or E. Using a combination of insurance, letter of credit, surety bond, trust fund, or escrow account.
2. Disclosure Statement:
Arkansas Code Annotated Section 8-1-106 requires that all applicants for any type of permit or transfer of any permit, license, certification or operational authority issued by the Arkansas Department of Environmental Quality (ADEQ) file a Disclosure Statement with their application. The filing of a Disclosure Statement is mandatory. No application can be considered administratively complete without a completed Disclosure Statement. The form may be obtained from the ADEQ web site at:
http://www.adeq.state.ar.us/disclosure_stmt.pdf
Page 9 Revised September 2014
NOT APPLICABLE (N/A):
SECTION F – INDUSTRIAL ACTIVITY
1. Does an effluent guideline limitation promulgated by EPA (Link to a Listing of the 40 CFR Effluent Limit Guidelines) under Section 304 of the Clean Water Act (CWA) apply to your facility?
YES (Answer questions 2 and 3) NO
2. What Part of 40 CFR? 429
3. What Subpart(s)? I K
4. Give a brief description of all operations at this facility including primary products or services (attach additional sheets if necessary):
Logs are received on-site. A portion of the logs are stored before use in a wet deck area. Logs are debarked, and sawed. Rough green lumber is kiln dried, trimmed in planer mill, and shipped.
5. Production: (projected for new facilities) N/A
Last 12 Months Highest Production Year of Last 5 Years
Product(s) Manufactured lbs/day* lbs/day*
(Brand name) Highest Month Days of Operation Monthly Average Days of Operation
* These units could be off-lbs, lbs quenched, lbs cleaned/etched/rinsed, lbs poured, lbs extruded, etc.
Page 10 Revised September 2014
NOT APPLICABLE (N/A):
SECTION G - WASTEWATER DISCHARGE INFORMATION
Facilities that checked “Yes” in question 1 of Section F are considered Categorical Industrial Users and should skip to question 2.
1. For Non-Categorical Users Only: List average wastewater discharge, maximum discharge, and type of discharge (batch, continuous, or both), for each plant process. Include the reference number from the process flow schematic (reference Figure 1) that corresponds to each process. [New facilities should provide estimates for each discharge.]
No. Process Description Average Flow
(GPD) Maximum Flow
(GPD) Type of Discharge (batch, continuous, none)
N/A
If batch discharge occurs or will occur, indicate: [New facilities may estimate.]
Number of batch discharges: per day Average discharge per batch: (GPD)
Time of batch discharges at (days of week) (hours of day)
Flow rate: gallons/minute Percent of total discharge:
Answer questions 2, 3, 4, and 5 only if you are subject to Categorical Standards.
2. For Categorical Users: Provide the wastewater discharge flows for each of your processes or proposed processes. Include the reference number from the process flow schematic (reference Figure 1) that corresponds to each process. [Note: 1) New facilities should provide estimates for each discharge and 2) Facilities should denote whether the flow was measured or estimated.]
No. Regulated Process Average Flow
(GPD) Maximum Flow
(GPD) Type of Discharge (batch, continuous, none)
001 Wet Deck Runoff Variable Variable Intermittent
No. Unregulated Process Average Flow
(GPD) Maximum Flow
(GPD) Type of Discharge (batch, continuous, none)
001 Kiln Condensate Variable Variable Intermittent
Equipment Washdown Variable Variable Intermittent
No. Dilution (e.g., Cooling Water)
Average Flow (GPD)
Maximum Flow (GPD)
Type of Discharge (batch, continuous, none)
001 Storm Water Runoff Variable Variable Intermittent
Makeup (Well Water) Variable Variable Intermittent
Page 11 Revised September 2014
If batch discharge occurs or will occur, indicate: [New facilities may estimate.]
Number of batch discharges: N/A per day Average discharge per batch: (GPD)
Time of batch discharges at (days of week) (hours of day)
Flow rate: gallons/minute Percent of total discharge:
3. Do you have, or plan to have, automatic sampling equipment or continuous wastewater flow metering equipment at this facility?
Current: Flow Metering Yes Type: _ ________ No N/A Sampling Equipment Yes Type: _ _______ No N/A
Planned: Flow Metering Yes Type: _ ________ No N/A Sampling Equipment Yes Type: _ ______ No N/A
If yes, please indicate the present or future location of this equipment on the sewer schematic and describe the equipment below:
N/A
4. Are any process changes or expansions planned during the next three years that could alter wastewater volumes or characteristics?
Yes No (If no, skip Question 5)
5. Briefly describe these changes and their effects on the wastewater volume and characteristics:
N/A
Page 12 Revised September 2014
NOT APPLICABLE (N/A):
SECTION H -TECHNICAL INFORMATION
Technical information to support this application shall be furnished in appropriate detail to understand the project. Information in this Part is required for obtaining a construction permit or for modification of the treatment system.
1. Describe the treatment system. Include the types of control equipment to be installed along with their methods of operation and control efficiency.
Union County Lumber is re-opening a sawmill in El Dorado, AR. The facility was formerly owned by Georgia Pacific. The facility contains a wet deck operation that is used to keep logs wet when stored on-site. The main wet deck operation contains two ponds. One is used to recirculate water to the wet deck. The other pond is a free board pond that is used to collect overflow water from the recirculation pond in times of a large storm event and as make-up water for the wet deck operation. The recirculation pond was closed upon permanent shutdown of the facility by GP. The closed recirculation pond will be re-commissioned by excavating fill that was placed for closure and re-construction of a levee and spillway. The pond will have a capacity of 1,7480,000 gallons. An overflow structure will be placed two feet below the top of bank. The recirculation pond will overflow into the freeboard pond. The freeboard pond will be used to maintain a 10-year 24 hour holding capacity.
2. One set of construction plans and specifications, approved (Signed and stamped) by a Professional Engineer (PE) registered in Arkansas, must be submitted as follows:
a. The plans must show flow rates in addition to pertinent dimensions so that detention times, overflow rates, and loadings per acre, etc. can be calculated.
b. Specifications and complete design calculations. c. All treated wastewater discharges should have a flow measuring device such as a weir or Parshall flume installed.
Where there is a significant difference between the flow rates of the raw and treated wastewater, a flow measuring device should be provided both before and after treatment.
3. If this application includes a construction permit disturbing five or more acres, a storm water construction permit must be obtained by submitting a notice of intent (NOI) to ADEQ.
Area Maps
1,000
FeetGB M
Union CountyLumber
ITSTRATEGIC E NV IRONME NTA L SE RVIC ES
219 B ro wn La neBrya nt, A rkan sa s 72 022Drawn by:
2480.000.G2
c
TOPOGRAPHICLOCATION MAPUNION COUNTY LUMBEREL DORADO MILL
2480-14-050Project No.:
AAGChecked by:
AAGApproved by:
02/05/2015Date:
SHOWNScale:
Pvt
Jackson
Junc
tion C
ity Hw
y
Iron Mountain RdCabin Trl
Caveman Rd
Union 765
Summit Dr
Wood Acres Dr
Moudy
Loop
Mahony Farm Rd
Brantley Rd
Mt Union Cutoff
Lucy Rd
Mt Union RdUnion 766
Union
228
Union 770
Sun C
rest
Dr
Joshua Trl
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Pvt
Bayou de Loutre
Imagery ©2015 , DigitalGlobe, State of Arkansas, USDA Farm ServiceAgency
1,000
Feet
Streams GB M
Union CountyLumber
ITSTRATEGIC ENVIRONMENTAL SERVICES
219 Brown LaneBryant, Arkansas 72022Drawn by:
2480.000.G1
c
AERIAL PHOTOGRAPHYLOCATION MAPUNION COUNTY LUMBEREL DORADO MILL
2480-14-050Project No.:
AAGChecked by:AAGApproved by:
02/05/2015Date:
SHOWNScale:
FEMA Map
Water Supply Sources
February 19, 2015
WATER SUPPLY SOURCES The following have sources within 5 miles of Union County Lumber – El Dorado Mill:
- BOY SCOUT CAMP DESOTO - FAIRCREST WATER ASSOCIATION - GREAT LAKE CHEMICAL CORPORATION – SOUTH PLANT - JOHNSON TOWNSHIP WATER ASSOCIATION - PARKERS CHAPEL PUBLIC WATER
The following have surface sources within 50 miles of Union County Lumber – El Dorado Mill:
- ASHLEY MINERAL SPRING - CAMDEN WATERWORKS - EL DORADO CHEMICAL COMPANY - MAGNOLIA WATERWORKS
Form 2D
Form Approved. OMB No. 2040-0086. Approval expires 8-31-98.
Please print or type in the unshaded areas only
EPA I.D. NUMBER (copy from Item 1 of Form 1)
Form
2D NPDES
New Sources and New Dischargers
Application for Permit to Discharge Process Wastewater I. Outfall Location
For each outfall, list the latitude and longitude of its location to the nearest 15 seconds and the name of the receiving water.
Latitude Longitude Outfall Number (list) Deg. Min. Sec. Deg. Min. Sec.
Receiving Water (name)
II. Discharge Date (When do you expect to begin discharging?)
III. Flows, Sources of Pollution, and Treatment Technologies A. For each outfall, provide a description of: (1) All operations contributing wastewater to the effluent, including process wastewater, sanitary
wastewater, cooling water, and storm water runoff; (2) The average flow contributed by each operation; and (3) The treatment received by the wastewater. Continue on additional sheets if necessary.
Outfall Number
1. Operations Contributing Flow (List)
2. Average Flow (Include Units)
3. Treatment (Description or List codes from Table 2D-1)
EPA Form 3510-2D (Rev. 8-90) PAGE 1 of 5
001 33 08 15.7 92 38 22.9 Unnamed tributary of Bayou de L'outre,
thence to Bayou de L'outre, thence to
the Ouachita River.
As soon as possible.
001 Wet Decking Operations
Storm Water Runoff
Kiln Condensate
Equipment Washdown
Variable
Variable
Variable
Variable
Sedimentation 1-U
Septic Tank
Septic Tanks
B. Attach a line drawing showing the water flow through the facility. Indicate sources of intake water, operations contributing wastewater to the effluent, and treatment units labeled to correspond to the more detailed descriptions in Item III-A. Construct a water balance on the line drawing by showing average flows between intakes, operations, treatment units, and outfalls. If a water balance cannot be determined (e.g., for certain mining activities), provide a pictorial description of the nature and amount of any sources of water and any collection or treatment measures.
C. Except for storm runoff, leaks, or spills, will any of the discharges described in Items III-A be intermittent or seasonal? YES (complete the following table) NO (go to Section IV)
1. Frequency 2. Flow Outfall
Number a. Days
Per Week (specify average)
b. Months Per Year
(specify average)
a. Maximum Daily Flow Rate (in mgd)
b. Maximum Total Volume
(specify with units)c. Duration (in days)
IV. Production
If there is an applicable production-based effluent guideline or NSPS, for each outfall list the estimated level of production (projection of actual production level, not design), expressed in the terms and units used in the applicable effluent guideline or NSPS, for each of the first 3 years of operation. If production is likely to vary, you may also submit alternative estimates (attach a separate sheet).
Year A. Quantity Per Day B. Units Of Measure c. Operation, Product, Material, etc. (specify)
EPA Form 3510-2D (Rev. 8-90) Page 2 of 5 CONTINUE ON NEXT PAGE
x
N/A
N/A
CONTINUED FROM THE FRONT
EPA I.D. NUMBER (copy from Item 1 of Form 1) Outfall Number
V. Effluent Characteristics
A and B: These items require you to report estimated amounts (both concentration and mass) of the pollutants to be discharged from each of your outfalls. Each part of this item addresses a different set of pollutants and should be completed in accordance with the specific instructions for that part. Data for each outfall should be on a separate page. Attach additional sheets of paper if necessary.
General Instructions (See table 2D-2 for Pollutants) Each part of this item requests you to provide an estimated daily maximum and average for certain pollutants and the source of information. Data for all pollutants in Group A, for all outfalls, must be submitted unless waived by the permitting authority. For all outfalls, data for pollutants in Group B should be reported only for pollutants which you believe will be present or are limited directly by an effluent limitations guideline or NSPS or indirectly through limitations on an indicator pollutant.
1. Pollutant 2. Maximum Daily
Value (include units)
3. Average Daily Value
(include units) 4. Source (see instructions)
EPA Form 3510-2D (Rev. 8-90) Page 3 of 5 CONTINUE ON REVERSE
001
pH 9.0 s.u. 6.0-9.0 s.u. Effluent Limitation Guidelines
Biochemical Oxygen Demand (BOD)
Chemical Oxygen Demand (COD)
Total Organic Carbon (TOC)
Total Suspended Solids (TSS)
Flow
Ammonia (as N)
Temperature Ambient Ambient
35.0 mg/L* N/A
250 mg/L*
Variable Variable Codes 3 and 4
Codes 3 and 4
N/A
Code 3
Code 3
130 mg/L* N/A Code 3
37 mg/L* Code 3
23 mg/L* Variable
N/A
Code 3
* These values are only estimates and are based on the last permit application for the facility (August
2006)when it was owned by Georgia Pacific.
CONTINUED FROM THE FRONT EPA I.D. NUMBER (copy from Item 1 of Form 1)
C. Use the space below to list any of the pollutants listed in Table 2D-3 of the instructions which you know or have reason to believe will be discharged from any outfall. For every pollutant you list, briefly describe the reasons you believe it will be present.
1. Pollutant 2. Reason for Discharge
VI. Engineering Report on Wastewater Treatment
A. If there is any technical evaluation concerning your wastewater treatment, including engineering reports or pilot plant studies, check the appropriate box below.
Report Available No Report
B. Provide the name and location of any existing plant(s) which, to the best of your knowledge resembles this production facility with respect to production processes, wastewater constituents, or wastewater treatments.
Name Location
EPA Form 3510-2D (Rev. 8-90) Page 4 of 5 CONTINUE ON NEXT PAGE
None.
x
Georgia Pacific - El Dorado Mill Same Site - Union County Lumber purchased the existing facility from Georgia Pacific.
Process Flow Diagram
Form 2F
Please print or type in the unshaded areas only.
EPA ID Number (copy from Item 1 of Form 1) Form Approved. OMB No. 2040-0086 Approval expires 5-31-92
FORM
2F NPDES
U.S. Environmental Protection Agency Washington, DC 20460
Application for Permit to Discharge Storm Water Discharges Associated with Industrial Activity Paperwork Reduction Act Notice
Public reporting burden for this application is estimated to average 28.6 hours per application, including time for reviewing instructions, searching existing data sources, gathering and maintaining the data needed, and completing and reviewing the collection of information. Send comments regarding the burden estimate, any other aspect of this collection of information, or suggestions for improving this form, including suggestions which may increase or reduce this burden to: Chief, Information Policy Branch, PM-223, U.S. Environmental Protection Agency, 1200 Pennsylvania Avenue, NW, Washington, DC 20460, or Director, Office of Information and Regulatory Affairs, Office of Management and Budget, Washington, DC 20503.
I. Outfall Location For each outfall, list the latitude and longitude of its location to the nearest 15 seconds and the name of the receiving water.
A. Outfall Number (list) B. Latitude C. Longitude
D. Receiving Water (name)
II. Improvements
A. Are you now required by any Federal, State, or local authority to meet any implementation schedule for the construction, upgrading or operation of wastewater treatment equipment or practices or any other environmental programs which may affect the discharges described in this application? This includes, but is not limited to, permit conditions, administrative or enforcement orders, enforcement compliance schedule letters, stipulations, court orders, and grant or loan conditions.
2. Affected Outfalls 4. Final Compliance Date 1. Identification of Conditions,
Agreements, Etc. number source of discharge 3. Brief Description of Project a. req. b. proj.
B: You may attach additional sheets describing any additional water pollution (or other environmental projects which may affect your discharges) you now have under way or which you plan. Indicate whether each program is now under way or planned, and indicate your actual or planned schedules for construction.
III. Site Drainage Map
Attach a site map showing topography (or indicating the outline of drainage areas served by the outfalls(s) covered in the application if a topographic map is unavailable) depicting the facility including: each of its intake and discharge structures; the drainage area of each storm water outfall; paved areas and buildings within the drainage area of each storm water outfall, each known past or present areas used for outdoor storage of disposal of significant materials, each existing structural control measure to reduce pollutants in storm water runoff, materials loading and access areas, areas where pesticides, herbicides, soil conditioners and fertilizers are applied; each of its hazardous waste treatment, storage or disposal units (including each area not required to have a RCRA permit which is used for accumulating hazardous waste under 40 CFR 262.34); each well where fluids from the facility are injected underground; springs, and other surface water bodies which received storm water discharges from the facility.
EPA Form 3510-2F (1-92) Page 1 of 3 Continue on Page 2
001 33 08 15.7 92 38 22.9 Unnamed tributary of Bayou de L'outre
N/A
EPA ID Number (copy from Item 1 of Form 1) Form Approved. OMB No. 2040-0086 Approval expires 5-31-92
VII. Discharge information (Continued from page 3 of Form 2F)
Part A – You must provide the results of at least one analysis for every pollutant in this table. Complete one table for each outfall. See instructions for additional details.
Maximum Values (include units)
Average Values (include units)
Pollutant and
CAS Number (if available)
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Number of
Storm Events
Sampled Sources of Pollutants
Oil and Grease N/A Biological Oxygen Demand (BOD5) Chemical Oxygen Demand (COD) Total Suspended Solids (TSS)
Total Nitrogen
Total Phosphorus pH Minimum Maximum Minimum Maximum
Part B – List each pollutant that is limited in an effluent guideline which the facility is subject to or any pollutant listed in the facility’s NPDES permit for its process wastewater (if the facility is operating under an existing NPDES permit). Complete one table for each outfall. See the instructions for additional details and requirements.
Maximum Values (include units)
Average Values (include units)
Pollutant and
CAS Number (if available)
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Number of
Storm Events
Sampled Sources of Pollutants
EPA Form 3510-2F (1-92) Page VII-1 Continue on Reverse
The facility was not operational at time of preparation of application. Thus, sampling was not performed.
pHDebris
The facility was not operational at time of preparation of application. Thus, sampling was not performed.
Continued from the Front Part C - List each pollutant shown in Table 2F-2, 2F-3, and 2F-4 that you know or have reason to believe is present. See the instructions for additional details and
requirements. Complete one table for each outfall.
Maximum Values (include units)
Average Values (include units)
Pollutant and
CAS Number (if available)
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Grab Sample Taken During
First 20 Minutes
Flow-Weighted Composite
Number of
Storm Events
Sampled Sources of Pollutants
Part D – Provide data for the storm event(s) which resulted in the maximum values for the flow weighted composite sample.
1. Date of Storm Event
2. Duration
of Storm Event (in minutes)
3. Total rainfall
during storm event (in inches)
4. Number of hours between
beginning of storm measured and end of previous
measurable rain event
5. Maximum flow rate during
rain event (gallons/minute or
specify units)
6. Total flow from
rain event (gallons or specify units)
7. Provide a description of the method of flow measurement or estimate.
EPA Form 3510-2F (1-92) Page VII-2
N/A
N/A
A weir will be used to determine flow.
Site Drainage Map
!
!!
!!
!!
!!
!!
!
!!
!
!
!
!
!
!
!
!
!!
!
!
!!
!!
!
!
!
!
!
!
!
!
!!
!! ! !
!! ! !
!!
!(Outfall 001
Imagery ©2015 , DigitalGlobe, State of Arkansas
.200
Feet
!( OutfallFlowCulvertSpillway
!! DrainagePondsBasin BoundaryG B MAAG SHEET TITLE
AAGAAGIT
APPR.CK.BYREVISIONDATENO
CHECKED BY
APPR. BY
DRAWN BY Strategic Environmental Services219 Brown Lane
Bryant, Arkansas 72022
JOB NAME PROJECT NO. REV. NO
DWG. NO.SCALE
DATE2480-14-05002/05/2015
SHOWN
DESIGNED BY
SITE DRAINAGE MAPc
UNION COUNTY LUMBER COMPANYEL DORADO, ARKANSAS S1
Free BoardPond
RecirculationPond
Kiln Condensate/Equipment Washdown
Wet DeckOverflow
Design Drawings and Specifications
1
Construction Specifications for Union County Lumber
Recirculation Pond Site Preparation Areas designated for borrow areas, embankment, and structural works shall be cleared, grubbed and stripped of topsoil. All trees, vegetation, roots and other objectionable material shall be removed. All trees shall be cleared and grubbed within 15 feet of the toe of the embankment. All cleared and grubbed material shall be disposed of outside and below the limits of the reservoir as directed by the owner or his representative. If available, suitable topsoil will be stockpiled in a convenient location for use on the embankment and other designated areas. Earth Fill Material – The fill shall be taken from the site when applicable and can be trucked in from an off-site source as needed. It shall be free of roots, stumps, wood, rubbish, and stones greater than 6”, frozen or other objectionable materials. Materials used in the outer shell of the embankment must have the capability to support vegetation of the quality required to prevent erosion of the embankment. Placement – Areas on which fill is to be placed shall be scarified prior to placement of fill. Fill materials shall be placed in maximum 8 inch thick (before compaction) layers which are to be continuous over the entire length of the fill. The most permeable borrow material shall be placed in the downstream portions of the embankment. The principal spillway must be installed concurrently with fill placement and not excavated into the embankment. The embankment fill shall not be placed higher than the centerline of the principal spillway until after the spillway has been installed. Compaction –Compact each 8-inch layer with equipment prior to placement of the next lift. Stabilization All borrow areas shall be graded to provide proper drainage and left in a sightly condition. All exposed surfaces of the embankment, spillway, and berms shall be stabilized by hydromulching or seeding and matting in accordance with local Natural Resources Conservation Service Standards and Specifications.
2
Erosion and Sediment Control Construction operations will be carried out in such a manner that erosion will be controlled and water and air pollution minimized. State and local laws concerning pollution abatement will be followed. Construction plans shall detail erosion and sediment control measures.
Design Calculations
GBMc & Associates
219 Brown Lane Sheet No. 1 of 1 Bryant, AR 72022 Date 02/04/15
By AAG Chkd SKH Date 02/04/15 Project No. 2480-14-050
SUBJECT: Union County Lumber Calculations
Introduction:
Union County Lumber is re-opening a sawmill in El Dorado, AR. The facility was formerly owned by Georgia Pacific. The wet deck operation, which is used to keep logs wet when stored on-site, contains two ponds. One is used to recirculate water to the wet deck. The second pond is a free board pond that is used to collect overflow water from the recirculation pond in times of a large storm event. The recirculation pond was closed upon permanent shutdown of the facility by GP. The closed recirculation pond will be re-commissioned by excavating fill that was placed for closure and re-construction of a levee and spillway. The recirculation pond will overflow into the existing freeboard pond. The freeboard pond will be used to maintain a 10-year 24 hour holding capacity.
Available Storage Volume:
CADD was used to determine the available storage volume in the recirculation and freeboard ponds. Recirculation Pond = 233,000 ft3
(1,742,000 gallons)
Existing Freeboard Pond = 684,000 ft3
(5,116,000 gallons)
10 year – 24 hour Storm Volume Determination:
In accordance with Figure 6.3 below, the 10 year – 24 hour rainfall amount for El Dorado, AR is approximately 7 inches.
Reference: Rainfall Frequency / Magnitude Atlas for the South-Central United States SRCC Technical Report 97-1 Geoscience Publications, Louisiana State University
GBMc & Associates
219 Brown Lane Sheet No. 2 of 1 Bryant, AR 72022 Date 02/04/15
By AAG Chkd SKH Date 02/04/15 Project No. 2480-14-050
SUBJECT: Union County Lumber Calculations
Therefore, the required storage volume from a 10 year – 24 hour storm event, assuming fully saturated soil conditions, can be calculated as follows: Volume = drainage area * 10 year-24 hour storm event = 10 acres * 43,560 ft2
/acre* 7” *(1ft/12”)
= 254,100 ft
3
= 1,900,800 gallons The volume of the freeboard pond is 684,000 ft3
(5,116,000 gallons). The freeboard pond has sufficient capacity to contain a 10 year-24 hour storm event.
Certificates of Good Standing
D(.
In Testimony Whereof, I have hereunto set my hand and affixed my official Seal. Done at my office in the City of Little Rock, this 9th day of December, 2014.
STATE
OF STATE
Mark Martin ARKANSAS SECRETARY OF STATE
To All to Whom These Presents Shall Come, Greetings:
I, Mark Martin, Arkansas Secretary of State of Arkansas, do hereby certify that the following and hereto attached instrument of writing is a true and perfect copy of
Application for Certificate of Authority
of
UNION COUNTY LUMBER COMPANY
filed in this office December 9, 2014 to be a Foreign For Profit Corporation formed under the laws of the State of DELAWARE in the Country of United States.
I further certify that said Foreign For Profit Corporation, having complied with all statutory requirements in the State of Arkansas, is qualified to transact business in this State.
Arkansas Secretary of State
FILED - Arkansas Secretary of State - Mark Martin - Doc#: 5270792002 - Filing#: 811065777 - Filed On: 121912014 - Page(s): 2
JiLISdIISdS eureLary 431 LULU
Mark Martin State Capitol • Little Rock, Arkansas 72201-1094 501-682-3409 • www.sos.arkansas.gov
Business & Commercial Services, 250 Victory Building, 1401 W. Capitol, Little Rock
Application for Certificate of Authority (Please type or print)
Pursuant to the provisions of the Business Corporation Act of 1987, Act 958 of 1987, the undersigned as the duly authorized and acting president, secretary, treasurer, superintendent or managing agent in the State of Arkansas, of the foreign corporation named below (the "corporation") for which this statement is submitted, under oath hereby states:
1a. The name of the corporation is: UNION COUNTY LUMBER COMPANY
b. Fictitious name to be used in Arkansas:
(The corporation may use a fictitious name to transact business in Arkansas if its real name is unavailable and it delivers to the Secretary of State for filing a copy of the resolution of its board of directors certified by its secretary adopting a fictitious name.)
2. The state, territory or foreign country under whose laws the corporation was incorporated is:
Delaware Date Incorporated: 11/21/2014 Period of Duration: Perpet
3. The nature of the business of the corporation and the object or purposes to be transacted, promoted or carried on by it are:
Any lawful act or activity for which a corporation may be organized under the Arkansas Business Corporation Act.
4. The address of the general office or place of business of the corporation in Arkansas is designated to be: 5482 Junction City Hwy El Dorado Arkansas 71730
(Street at Address) (City) (State) (ZIP)
5. The name and address of the registered agent of the corporation upon whom Service of Process is authorized to be made in Arkansas is:
(Name) National Registered Agents, Inc.
124 West Capitol Ave, Suite 1900 Little Rock AR 72201 (Street at Address) (City) (State) (ZIP)
6. The address of the general office or principal place of business of the corporation is: 5482 Junction City Hwy El Dorado Arkansas 71730
(Street at Address) (City) (State) (21P)
7. The number and par value, if any, of shares of the corporation's capital stock owned or to be owned by residents of Arkansas:
Number of shares: 100
8. The foreign corporation shall deliver with the completed application a certificate of existence (or document of similar import) duly authorized by the Secretary of State or other official having custody of corporate records in the state or country under whose laws it is incorporated.
9. A filing fee of $300.00 is submitted herewith in accordance with Act 958 of 1987. Witness the hand and seal of the corporation executed under oath by the undersigned in behalf of the corporation on this the
day of December 2014
10. I understand that knowingly signing a false document with the intent to file it with the Arkansas Secretary of State is a
Class C misdemeanor and is punishable by a fine up to $100.00 and/or imprisonment up to 30 days.
Witness the hand executed under oath by the undersigned in behalf of the corporation on this the VL.' day of December , 2014
UNION COUNTY LUMBER COMPANY
(Name of Corporation) (Signature of Authorized Officer)
BRIAN FEI-IR, PRESIDENT Fee $300.00 payable to Arkansas Secretary of State
F-01/Rev. 1/07
Par value of shares: $1.00
5644358 8300
141506892 You may verify this certificate online at corp.delaware.goviauthver.shrml
Jeffrey W. Bullock, Secretary of State AUTHEN TION: 1937516
DATE: 12-09-14
Delaware PAGE 1
Tie First State
I, JEFFREY W. BULLOCK, SECRETARY OF STATE OF THE STATE OF
DELAWARE, DO HEREBY CERTIFY "UNION COUNTY LUMBER COMPANY" IS
DULY INCORPORATED UNDER THE LAWS OF THE STATE OF DELAWARE AND IS
IN GOOD STANDING AND HAS A LEGAL CORPORATE EXISTENCE SO EAR AS
THE RECORDS OF THIS OFFICE SHOW, AS OF THE NINTH DAY OF
DECEMBER, A.D. 2014.
AND I DO HEREBY FURTHER CERTIFY THAT THE SAID "UNION COUNTY
LUMBER COMPANY" WAS INCORPORATED ON THE TWENTY-FIRST DAY OF
NOVEMBER, A.D. 2014.
AND I DO HEREBY FURTHER CERTIFY THAT THE FRANCHISE TAXES
HAVE NOT BEEN ASSESSED TO DATE.
Disclosure Statement
ARKANSAS DEPARTMENT OF ENVIRONMENTAL QUALITY
DISCLOSURE STATEMENT
Instructions for the Completion of this Document:
A. Individuals, firms or other legal entities with no changes to an ADEQ Disclosure Statement,
complete items 1 through 5 and 18.
B. Individuals who never submitted an ADEQ Disclosure Statement, complete items 1 through 4, 6, 7,
and 16 through 18.
C. Firms or other legal entities who never submitted an ADEQ Disclosure Statement, complete 1
through 4, and 6 through 18.
Mail to:
ADEQ
DISCLOSURE STATEMENT
[List Proper Division(s)]
5301 Northshore Drive
North Little Rock, AR 72118-5317
Hand Deliver to:
ADEQ
DISCLOSURE STATEMENT
[List Proper Division (s)]
5301 Northshore Drive
North Little Rock, AR 72118-5317
1. APPLICANT: (Full Name)
2. MAILING ADDRESS (Number and Street, P.O.Box Or Rural Route) :
3. CITY, STATE, AND ZIPCODE:
4. (check all that apply.)
Individual Corporate or Other Entity
Permit License Certification
New Application Modification
Operational Authority
Renewal Application (If no changes from previous disclosure statement, complete number 5 and 18.)
5. Declaration of No Changes:
The violation history, experience and credentials, involvement in current or pending environmental lawsuits, civil and criminal, have not changed since the
last Disclosure Statement I filed with ADEQ on
Signature of Individual or Authorized Representative of Firm or Legal Entity
(Also complete #18.)
Air
Environmental Preservation and Technical Service
Water Solid WasteHazardous Waste MiningRegulated Storage Tank
Union County Lumber Company, LLC
5482 Junction City Highway
El Dorado, AR 70730
x
x
xx
x
N/A
x
6. Describe the experience and credentials of the Applicant, including the receipt of any past or present permits, licenses, certifications or operational
authorization relating to environmental regulation. (Attach additional pages, if necessary.)
7. List and explain all civil or criminal legal actions by government agencies involving environmental protection laws or regulations against the Applicant *
in the last ten (10) years including:
1. Administrative enforcement actions resulting in the imposition of sanctions;
2. Permit or license revocations or denials issued by any state or federal authority;
3. Actions that have resulted in a finding or a settlement of a violation; and
4. Pending actions.
(Attach additional pages, if necessary.)
* Firms or other legal entities shall also include this information for all persons and legal entities identified in sections 8-16 of this Disclosure Statement.
N/A
N/A
8. List all officers of the Applicant. (Add additional pages, if necessary.)
NAME: TITLE:
STREET:
CITY, STATE, ZIP:
NAME: TITLE:
STREET:
CITY, STATE, ZIP:
NAME: TITLE:
STREET:
CITY, STATE, ZIP:
9. List all directors of the Applicant. (Add additional pages, if necessary.)
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
10. List all partners of the Applicant. (Add additional pages, if necessary.)
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
11. List all persons employed by the Applicant in a supervisory capacity or with authority over operations of the facility subject to this application.
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
Brian Fehr President
P.O. Box 2626 424 Loop RoadVanderhoof, British Columbia, Canada VOJ 3A0
Barrie Topper Secretary/Treasurer
1425 Alder AveVandehoof, British Columbia, Canada VOJ 3A1
N/A
Brain Fehr President
P.O. Box 2626 424 Loop RoadVanderhoof, British Columbia, VOJ 3A0
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
12. List all persons or legal entities, who own or control more than five percent (5%) of the Applicant's debt or equity.
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
13. List all legal entities, in which the Applicant holds a debt or equity interest of more than five percent (5%).
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
14. List any parent company of the Applicant. Describe the parent company's ongoing organizational relationship with the Applicant.
NAME:
STREET:
CITY, STATE, ZIP:
Organizational Relationship:
15. List any subsidiary of the Applicant. Describe the subsidiary's ongoing organizational relationship with the Applicant.
NAME:
STREET:
CITY, STATE, ZIP:
Organizational Relationship:
Comact Equipment Inc. Parent Company
4000, 40th Street West
St.-Georges de Beauce, Quebec, Canada G5Y 8G4
N/A
N/A
N/A
N/A
N/A
Comact Equipment Inc.
4000, 40th Street West
St-Georges de Beauce, Quebec, Canada G5Y 8G4
Comact Equipment Inc, a sawmill equipment manufactuer, owns 100% of the shares of Union
County Lumber Company, LLC
N/A
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:
17. List all federal environmental agencies and any other environmental agencies outside this state that have or have had regulatory responsibility over the
Applicant.
16. List any person who is not now in compliance or has a history of noncompliance with the environmental laws or regulations of this state or any other
jurisdiction and who through relationship by blood or marriage or through any other relationship could be reasonably expected to significantly influence
the Applicant in a manner which could adversely affect the environment.
NAME:
STREET:
CITY, STATE, ZIP:
TITLE:N/A
N/A
N/A
