ADAPTIVE LIGHTING CONTROLS PANEL:
Susan Zamos, FP Controls, Sun-TechRod Stummer, Owlet, Schreder Group
TOPICS•Communication standards•Commissioning•Control System Features•Reporting/User Interface
Open Communication
Standards
The 7 OSI Layers
The Open Systems Interconnection (OSI) Model was developed by International Organization for Standardization (ISO) in the 1980s as an attempt to make communication between any two systems possible.
Before this, every equipment manufacturer implemented its own set of rules (protocols). Therefore, two computers made by different companies could not "understand" each other.
7
6
5
4
3
2
1
OtherApplications
OtherMedia Technologies ZigBee® Technology
LonWorks™ TechnologyEIA & De facto Standard
US DOT NTCIP 1213 Electrical Lighting &
Management SystemsStandard
To Assure Interoperability,- All 7 OSI Layers Must Be Supported
7
6
5
4
3
2
1
7
6
5
4
3
2
1
Why ZigBee?• Open Global Standard• Supports Mesh Networks• Low Duty Cycle• Low Latency/Power• Low Cost• Up to 65,000 Nodes Per Network• 128-bit AES Encryption• Interoperability Between Products• Robust and Reliable• Self-healing, Re-routing Network
Why ZigBee?• Industrial Grade Wireless• 16 Communication Channels
• Each with Max. Bandwidth• Auto or Manual Selection• Dynamic Frequency
Hopping• Noise Detection
• 250 kbit/second• 50X Faster than Powerline• Open Intl. Standard IEEE
802.15.4
Zigbee Applications• Demand Response • Advanced Metering Infrastructure • Automatic Meter Reading • Lighting controls • HVAC control • Heating control • Wireless smoke and CO detectors • Home security • Blind, drapery and shade controls • Medical sensing and monitoring • Remote control of home entertainment systems • Indoor location sensing • Advertising on mobile devices
ZigB
eevs
Oth
er W
irele
ssZigBee 802.11
(Wi-Fi)Bluetooth UWB (Ultra Wide Band) Wireless USB IR Wireless
Data Rate 20, 40, and 250 Kbits/s 11 & 54 Mbits/sec 1 Mbits/s 100-500 Mbits/s 62.5 Kbits/s 20-40 Kbits/s115 Kbits/s
4 & 16 Mbits/s
Range 10-100 meters 50-100 meters 10 meters <10 meters 10 meters <10 meters (line of sight)
Networking Topology Ad-hoc, peer to peer, star, or mesh
Point to hub Ad-hoc, very small networks
Point to point Point to point Point to point
Operating Frequency 868 MHz (Europe)900-928 MHz (NA), 2.4
GHz (worldwide)
2.4 and 5 GHz 2.4 GHz 3.1-10.6 GHz 2.4 GHz 800-900 nm
Complexity (Device and application impact)
Low High High Medium Low Low
Power Consumption (Battery option and life)
Very low (low power is a design goal)
High Medium Low Low Low
Security 128 AES plus application layer
security
64 and 128 bit encyption
Other Information Devices can join an existing network in
under 30ms
Device connection requires 3-5 seconds
Device connection requires up to 10
seconds
Typical Applications Industrial control and monitoring, sensor networks, building automation, home
control and automation, toys,
games
Wireless LAN connectivity, broadband
Internet access
Wireless connectivity between devices such
as phones, PDA, laptops, headsets
Streaming video, home entertainment
applications
PC peripheral connections
Remote controls, PC, PDA, phone, laptop
links
Where Does ZigBee Fit?
ZigBee – A Growing Standard!
“Low power wireless sensing and control markets, enabled by ZigBee, are experiencing exponential growth. Today, ZigBee chipset suppliers are shipping tens of millions of
units and the market is poised to grow to hundreds of millions of units within the next few years. Our research with more than 600 companies has found that the ZigBeemarket has "crossed the chasm" and is now a mainstream technology. Despite a
challenging economy, 802.15.4/ZigBee unit sales have increased an average of 62% per year since 2007. Moreover, chipsets using ZigBee specifications made up 75% of
the 802.15.4 shipped units in 2009.”
ON WORLD Research Group (Published May ‘10)
Commissioning a System• Commissioning Plan
– RF Mapping Plan for Network Planning• Important to plan the optimum number and positions for the Base
Stations (Gateways) to achieve proper radio coverage. Radio planning tools should be used that make use of geographic terrain and clutter data and radio propagation models.
• The radio model / map is then used in conjunction with a site survey with local authorities and contractor staff to confirm Base Station sites and document installation details.
Typical Radio Mapping
• Asset list and information• Commissioning Training – Before starting
installations! • Dimming profiles for each type fixture (response to
0-10 v dimming signal is not typically linear)• Operational Training – make sure user’s
expectations are realistic• The better the planning, the better the system.
Commissioning
The endpoints (nodes)of a mesh network mustbe installed starting close to the coordinatorin order to maintain the mesh.
The endpoints of a star network can be installed randomly throughout the coverage area.
Adaptive Lighting Controls Panel
CONTACT INFORMATION:
Susan ZamosSales Director
Sunrise Technologies - FP Outdoor Lighting Controls54 Commercial St., Raynham, MA 02767
Control System Features• Monitoring / Maintenance
• Reduce Night Inspections• Diagnose Faults• Reduce Repair Times
• Trimming (Constant Lumen Output)• Eliminates Over-Lighting
• Selective Dynamic Dimming• Save Energy in Off-Peak Periods
• Metering• Insures Energy Savings From Utilities
Monitoring
• Diagnose• Lamp Failures and Cycling• Driver/Ballast Failures• Power Failures• Energy Usage Changes• Lamp Life and Driver Warranty History
Trimming(Constant Lumen Output)
• Reduces Wattage in Early Life Stages and Maintains Optimum Lumen Output
• As the Light Engine / Lamp Ages, Wattage is Gradually Increased to Maintain Optimum Lumen Output
Dimming
• 0-10 VDC• Simple and Reliable• Requires Dimming Driver/Ballast• Most common in U.S.
• DALI• Developed for Indoor• Offers 2-Way Communication• Widely Used in Europe (HID)
Metering
• Dimming streetlights can save up to 30% in energy
• Utilities need a reliable metering method to credit cities for this energy savings
Metering• Utilities are requiring a minimum ± 2% accuracy
• On-board power meter chipset• Not an algorithmic estimation
• Must measure accurately in a• Steady-state• Dim modes
• Leading the Standards• CPUC (Calif. Public Utility Comm.)• PG&E Utility
• San Jose, San Francisco• MSSL (Controls Task Force Spec.)• NEMA, NIST-SGIP, ANSI
User InterfacesField Level
RF Communication Interface (IEEE 802.15.4, ZigBee Protocol)Enables the luminaire controller to control the LED driver
Gateway LevelCommunication interface to the management serverManages and stores information from the field controllers
Server LevelScalable database (Microsoft, Oracle, SAP)Webserver applicationProvides a graphical user interface (GUI) reachable with a standard webbrowser (Internet Explorer, Firefox, Chrome, Safari, etc.)
Build the wireless communication and management system
Supports:• Continuous live data between
gateway router and luminaire controllers
• Data is stored at the gateway router level and uploaded to the server database on demand or on a pre-defined schedule
• Field initiated communication requests is established between the gateway controller and server through configuring IT services (SNMP) to send alarm notifications (text message, email, etc.)
User Interfaces
Web Interface• Standard user/role permission configuration• Permissions set for user/groups•Monitoring• Reporting• Configuration•Administration
• Special rights for manual commands and expert views
Graphical User Interface
Used during commissioning to locate luminaire controllers and gateway routers on mapping software
Mapping Interface
Used to visually monitor operation of field level luminaire controllers and gateway routers
Mapping Interface
• Malfunctions (Error Reporting)Broken lamp/ballast, energy-limits, power factor, lost nodes, communication loss
Reporting System
Example of Error Reporting Screen
• Malfunctions (Error Reporting)Broken lamp/ballast, energy-limits, power factor, lost nodes, communication loss
• Monitoring (Live View)Individuals/Groups, Dim-Levels, Control-Signals, Run Hours, Switch On/Off Times, Errors, Energy Consumption, Electrical Power Usage, Voltage, Current, Power Factor, Controller Failure, Device Uptime, Temperature, Communication Quality, Timestamp, Calculated Sun Elevation, Device Information
Reporting System
Example of Monitoring Screen
• Reporting (Energy and Detail Report)• Energy Consumption on City, District, Area and Streetlight Level• Table and Chart Views• Streetlight Level: Energy Consumption, Run Hours, Burning Hours
Dimming Profile, On/Off Times, Error List• Reports Viewable On-Line and Exportable to CSV and PDF
Reporting System
Example of Screen Reports
Energy Report
Error Report
Example of Admin Screen
Example of Admin Screen
Example of Configuration Screen
SmartPhone, iPAD, Remote Interface
Controls Panel
CONTACT INFORMATION:Rod Stummer
Director of Business DevelopmentSchreder Lighting – OWLET Controls
2105 W. Corporate Drive, Addison, IL 60101Office: 847-621-5100 Cell: 847-345-2414
???