Join the change
2017 Loviisa power plant
Our environment
When combating climate change nuclear is part of the solution
In 2017, the Loviisa power plant generated a total of 8.16 terawatt hours (net) of po-wer, corresponding to more than 10% of the energy generation in Finland. As a producer of clean energy, the Loviisa po-wer plant and carbon-free nuclear power play a significant role in mitigating clima-te change. The greenhouse gas emissions during nuclear power’s lifecycle are as low as those for wind, hydro and solar power.
Electricity production at the Loviisa nuclear power plant results to approxima-tely 6 million tonnes less carbon dioxide emissions in the atmosphere compared to the equivalent amount produced with fossil fuels.
The safety condition of the power plant remained good, and both the production and equipment availability was on a very high level. For Fortum, excellence in sa-
fety is the foundation of our business and safe performance is a sign of professiona-lism. We strive to be a safe workplace for our employees and for the contractors and service providers who work for us. We be-lieve that all work injuries are preventab-le when competence and the right attitude prevails, when potential risks are addres-sed and when measures are taken to safe-guard against them.
In 2017 we stayed within all permit li-mits in terms of environmental impacts.
The collective radiation dose of the Loviisa po-wer plant’s personnel was record low compared to years when similar outages have taken place. As in previous years, the four-year moving ave-rage for radiation dose continued its down-ward curve. Replacing the seals on the prima-ry circulation pumps to antimony-free seals has reduced radiation levels caused by antimo-ny nuclides around the primary circuit. Long-term development efforts to lower the dosage of radiation workers during annual outages have produced significant results at both plant units.
Emissions of radioactive effluents into the environment in 2017 were, as in previous years, significantly lower than the limits set for nuclear power plant emissions. Based on
emissions and meteorological data, the esti-mated radiation dosage to the surrounding population was about 0.3% of the set dose limit and about one ten-thousandth of the nor-mal annual radiation dosage Finns are expo-sed to for other reasons.
The radiation monitoring programme carried out in the surroundings of the po-wer plant occasionally detected radionucli-des originating from the plant, but the concentrations detected were very small. Radioactive substances from the power plant’s emissions appeared mainly in the indicator organisms in the marine environ-ment and in samples of sedimented materialsand sludge from the bottom of the sea.
Radiation safety
Waste managementWaste management at the Loviisa power plant is comprised of two separate areas: waste management for the non-controlled area and waste management for the control-led area. All waste generated in the cont-rolled area is treated as radioactive. Waste generated outside the controlled area can be treated as waste from a conventional in-dustrial plant.
The goal of conventional waste manage-ment is to prevent the production of waste and to reduce the amount of landfill waste through effective sorting. In 2017, a total of 753 tonnes of waste was transported out from the power plant area. Of this, 10% was land-filled, 87% was recycled and the remaining
3 % was treated as hazardous waste.Waste generated in the controlled area is
divided into three categories: Low-level waste (maintenance waste), intermediate-level was-te (liquid waste), and high-level waste (spent fuel). Maintenance waste is either cleared as non-active and treated as conventional waste, or disposed of in the final repository located in a depth of 110 metres in the power plant area. Thanks to efficient sorting and packa-ging, in 2017, the amount of maintenance waste for final disposal was record low. Li-quid waste is treated and puridified liquid is conducted into the sea or stored and solidifiedin concrete. Spent fuel is stored to await finaldisposal at Posiva Oy’s facilities in Olkiluoto,
PersonnelOwn personnel
417Men
Loviisa power plant, own personnel
2017 1
2017 665
2016 1
2017 5 2016 4
2016 502
Loviisa power plant, external personnel
Observation reports
Occupational safetyOCCUPATIONAL INCIDENTS
The power plant makes use of an observation report procedure, collecting information to be used at the power plant and for safety-related statistics. Accident reports are also made for “near miss” incidents and possibly hazardous incidents.
92,9 %Load factor
Loviisa 1
92,9%Loviisa 2
93%
Environmental balance sheet 2017 The environmental work of the Loviisa power plant is managed according to an ISO 14001 certified environmental management system.
IN 2017, LOVIISA NUCLEAR POWER PLANT GENERATED
8.16 TWH ELECTRICITY without carbon dioxide emissions The amount of electricity generated at the Loviisa power plant is almost equivalent to the total electricity consumption of the cities of Helsinki, Espoo and Vantaa.
2017 2016
Noble gases, TBq(Kr-87 equivalent)
4,8 5,6 14 000
Iodine, TBq(I-131 equivalent
0,000001 0,000001 0,22
2017 2016
Cooling water, million m³
1 372 1 340 1 800
Thermal load into the sea, TJ
57 651 56 210 60 000
Tritium, TBq 14,7 13,4 150
Other radioactive nuclides, TBq
0,00164 0,0001 0,89
2017 2016
Biological oxygen demand, kg 174 118
Chemical oxygen demand, kg 580 319
Phosphorus, kg 9,3 5,4
Nitrogen, kg 1 164 1 021
Solids, kg 505 451
Domestic water volume, m3 25 835 23 155
Annual load caused by domestic water
2017 2016
Phosphorus, kg 9,9 2,1
Nitrogen, kg 1 796 96
Solid matter, kg 68 64
Process waste water amount, m3 164 590 71 387
Annual load caused by process waste water
82Women
84% 16%
= LOVIISA NUCLEAR POWER PLANT’S SHARE OF FINLAND’S TOTAL ELECTRICITY PRODUCTION10%
Total amount of waste handled at the Loviisa power plant in 2017
as material
as energy
Waste to landfill
Hazardous waste
Radioactive maintenance waste (to final repository)
Radioactive liquid waste for solidification
Spent fuel
Total
808 t
Waste to recycling 81%62% 19%
9%
3%2%
2%3%
= 499 13temporary employees
External personnel
Technical support in Espoo 170 Permanent contractors approx. 100 During annual outages approx. 700
Emissions into air
Emissions into water
Permitted annual emissions
Permitted annual emissions
The domestic wastewater generated is treated at the power plant area’s biologi-cal-chemical wastewater treatment plant, to which about 25,835 m³ of wastewater was piped in 2017.
In accordance with the environmen-tal permit, domestic wastewater must be treated so that the biological oxygen de-mand (BOD7atu) of wastewater dischar-ged into the sea does not exceed 15 mg/l and total phosphorus concentration 0.7 mg/l as annual averages. The efficiency of the treatment process must be at least 90% for both variables.
According to the monitoring results, the
treatment plant reached results compliant with the conditions of the permit: the biolo-gical oxygen demand of treated wastewater was 5.52 mg/l on average and total phospho-rus concentration 0.32 mg/l in 2017.
The environmental permit of the po-wer plant does not set any limits for the process wastewater load. However, the nutrient load caused by the process was-tewater is monitored through samples taken in accordance with the monito-ring programme. The load caused by process wastewater in 2017 was 9.9 kg of phosphorus, 1796 kg of nitrogen and 68 kg of solids.
Waste water
Cooling waterThe power plant’s most significant envi-ronmental impact is the thermal load on the sea caused by the cooling water, which heats up by about 10 degrees as it passes through the plant. The highest tempera-ture of the cooling water discharged into the sea was 27.8 °C in the summer and the limits (34 °C) set for the temperature were not exceeded.
In practice, 2/3 of the thermal energy produced by the reactor ends up in the sea with the cooling water. According to temperature measurements, the dischar-ged water raises the temperature of the sea water during the growing season by about 1-2.5 degrees within a 1-2 kilometre
range from the discharge point.The cooling water discharge area re-
mains unfrozen throughout the winter. The size of the open water and thin ice area depends on winter temperatures. In 2017 the power plant used a total of about 1,372 million m³ of sea water for cooling, and the thermal load on the sea totalled 57,651 TJ.
In accordance with the environmen-tal permit, the amount of cooling water should not exceed 1,800 million m³ or 56 m³/s. The amount of thermal load on to the sea may not exceed 60 000 J annual-ly. The limits set by the permit were not exceeded.
Service waterThe process and domestic water required by the power plant is sourced from Lake Lappominjärvi, which is located about 5 kilometres north of the power plant. The water is purified before use at the water plant and the water used as process water is additionally treated at the deminerali-zation plant.
In 2017 the total volume of water with-drawn from Lake Lappominjärvi was about 222,951 m³. According to the service water withdrawal permit, the power plant can withdraw up to 180 m³/h of water from the lake for a short period of time and a maximum of 150 m³/h per quarter.
No permit limits were exceeded at the Lo-viisa power plant in 2017, nor were there any breaches of permit conditions.
A total of 6 chemical and oil leaks were reported. One of the incidents was the breakdown of a tractor for out-door maintenance, from which a small
amount of hydraulic oil leaked into the pavement.
The other leaks consisted of refrige-rant leaks from air conditioning systems as a result of various equipment malfun-ctions. All the leaks were less than 100 lit-res in volume.
Environmental incidents
The most important task of our nuclear power operations is to
produce electricity safely, reliably and competitively, in the short
term and long term, while complying with the principles of nuclear
and radiation safety, waste management safety, and nuclear
material control.
Our operations are based on a high-level safety culture and quality
and on continuous improvement.
Our own world-class expertise is a prerequisite for safety and
competitiveness. Nuclear Services business is built upon this strong
competence base, and our customers are in the centre of the
solutions we provide.
Fortum Power and Heat OyPL 23, Fi-07901 Loviisawww.fortum.com/loviisa@FortumNuclearLayout Creative Peak