7/15/2019 Volvo S60 manual
1/233
003 Volvo S60
2 0 0 3
VOLVO
S60
ntroduction
Welcome to the world-wide family of Volvo owners. We trust that you will enjoy many years of safe
iving in your Volvo, an automobile designed with your safety and comfort in mind. To help ensure
our satisfaction with this vehicle, we encourage you to familiarize yourself with the equipment
escriptions, operating instructions and maintenance requirements/recommendations in this manual.
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (1 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
2/233
003 Volvo S60
so urge you and your passengers to wear seat belts at all times in this (or any other) automobile. An
course, please do not operate a vehicle if you may be affected by alcohol, medication or any
mpairment that could hinder your ability to drive.
our Volvo is designed to meet all applicable safety and emission standards, as evidenced by the
rtification labels attached to the driver's door opening and on the left wheel housing in the engine
ompartment.
or further information please contact your retailer, or:
n the USA:
olvo Cars of North America
ustomer Relations
O. Box 914
ockleigh, New Jersey 07647-0914
00-458-1552
n Canada:
olvo Canada Ltd.
75 Gordon Baker Road
orth York, Ontario M2H 2N7
00-663-8255
General Information
hiftlock (automatic transmission)
When your car is parked, the gear selector is locked in the (P)ark position. To release the selector fro
is position, turn the ignition key to position II (or start the engine), depress the brake pedal, press th
utton on the front side of the gear selector and move the selector from (P)ark.
eylock (automatic transmission)
When you switch off the ignition, the gear selector must be in the (P)ark position before the key can
moved from the ignition switch.
nti-lock Brake System (ABS)
he ABS system in your car performs a self-diagnostic test when the vehicle first reaches the speed o
pproximately 12 mph (20 km/h). The brake pedal will pulsate several times and a sound may be aud
om the ABS control module. This is normal.
uel filler door
he fuel filler door, located on the right rear fender, is connected to your car's central locking system
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (2 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
3/233
003 Volvo S60
ess the button on the light switch panel (see illustration on page 30) when the car is at a standstill t
nlock the fuel filler door. Please note that the fuel filler door will remain unlocked until the car begi
move forward. An audible click will be heard when the fuel filler door relocks.
uel filler cap
fter refueling, close the fuel filler cap by turning it clockwise until it clicks into place. If this cap is
osed tightly or if the engine is running when the car is refueled, the Malfunction Indicator Lamp ("
heck Engine" light) will illuminate.
mportant information
efore you operate your car for the first time, please familiarize yourself with the new- engine oil
onsumption information on page 78. You should also be familiar with the information in chapters o
wo and four of this manual.
formation contained in the balance of the manual is extremely useful and should be read after
perating the vehicle for the first time.
he manual is structured so that it can be used for reference. For this reason, it should be kept in the
r ready access.
o not export your Volvo to another country before investigating that country's applicable safety and
xhaust emission requirements. In some cases it may be difficult or impossible to comply with these
quirements. Modifications to the emission control system( s) may render your Volvo not certifiable
gal operation in the U. S., Canada and other countries.
ll information, illustrations and specifications contained in this manual are based on the latest prod
formation available at the time of publication. Please note that some vehicles may be equipped
fferently, depending on special legal requirements. Optional equipment described in this manual m
ot be available in all markets.
olvo reserves the right to make model changes at any time, or to change specifications or design
ithout notice and without incurring obligation.
WARNING!
CALIFORNIA Proposition 65 Warning!
Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals
known to the state of California to cause cancer, and birth defects or other reproductive harm. Inaddition, certain fluids contained in vehicles and certain products of component wear contain or em
chemicals known to the State of California to cause cancer, and birth defects or other reproductive
harm.
Volvo and the environment
olvo is committed to the well being of its customers. As a natural part of this commitment, we care
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (3 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
4/233
003 Volvo S60
bout the environment in which we all live. Caring for the environment means an everyday involvem
reducing our environmental impact.
olvo's environmental activities are based on a holistic view, which means we consider the overall
nvironmental impact of a product throughout its complete life cycle. In this context, design, product
oduct use, and recycling are all important considerations.
production, Volvo has partly or completely phased out several chemicals including freons, lead
hromates, naphtanates, asbestos, mercury and cadmium; and reduced the amount of chemicals used
ur plants 50% since 1991.olvo was the first in the world to introduce into production a three-way catalytic converter with a
ambda sond, now called oxygen sensor, in 1976. The current version of this highly efficient system
duces emissions of harmful substances (CO, HC, NOx) from the exhaust pipe by approximately 95
nd the search to eliminate the remaining emissions continues. Volvo is the only automobile
anufacturer to offer CFC-free retrofit kits for the air conditioning system of all models as far back a
e 1975 model 240. Advanced electronic engine controls, refined purification systems and cleaner f
e bringing us closer to our goal.
fter Volvo cars and parts have fulfilled their use, recycling is the next critical step in completing th
fe cycle. The metal content is about 75% of the total weight of a car, which makes the car among thost recycled industrial products. In order to have efficient and well controlled recycling, many Vol
ariants have printed dismantling manuals, indicating the weight and material of individual compone
or Volvo, all homogeneous plastic parts weighing more than 1.7 oz. (50 grams) are marked with
ternational symbols that indicate how the component is to be sorted for recycling.
addition to continuous environmental refinement of conventional gasoline-powered internal
ombustion engines, Volvo is actively looking at advanced technology alternative-fuel vehicles.
When you drive a Volvo, you become our partner in the work to lessen the car's impact on the
nvironment. To reduce your vehicle's environmental impact, you can:
Maintain proper air pressure in your tires. Tests have shown decreased fuel economy with impropflated tires.
Follow the recommended maintenance schedule.
Drive at a constant speed.
See an authorized Volvo retailer as soon as possible for inspection if the check engine (malfunctio
dicator) lamp illuminates, or stays on after the vehicle has started.
Properly dispose of any vehicle-related waste such as used motor oil, used batteries, brake pads, et
When cleaning your car, use Volvo's own car care products, all of which have systematically been
dapted to the environment.
or additional information regarding the environmental activities in which Volvo Cars of Northmerica, LLC. and Volvo Car Corporation are involved, visit our Internet Home Page at: http://www
olvocars.com
remAir®
n the surface of the radiator in the engine compartment, there is a special coating called
emAir®. PremAir® works as a catalytic converter, converting most of the ground leve
zone passing through the radiator into oxygen, thereby reducing harmful ground-level ozone.
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (4 of 8)12/30/2006 4:13:09 PM
http://www.volvocars.com/http://www.volvocars.com/http://www.volvocars.com/http://www.volvocars.com/7/15/2019 Volvo S60 manual
5/233
003 Volvo S60
nstruments, switches and controls
Page
Front fog lights 30
Headlights/Parking lights/switch for unlocking fuel filler
oor30
Rear fog light 30
Turn signals/High/low beams 32
Cruise control 36
Horn iv
Instrument panel 22
Audio controls in steering wheel 162
Windshield wipers 33
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (5 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
6/233
003 Volvo S60
0. Parking brake (hand brake) 37
1. Center console switches 27
2. Climate control 43
3. Audio system 157
4. 12 V socket 37
5. Hazard warning flashers 34
6. Glove compartment 62
7. Panel vents 45
8. Text window 26
9. Temperature gauge 22
0. Odometer/ Trip odometer/Cruise control indicator 22/36
1. Speedometer 22
2. Turn signal indicators 22
3. Tachometer 22
4. Ambient temperature/Clock/Selected gear indicator 22
5. Fuel gauge 22
6. Indicator and warning symbols 23
7. - -
8. Panel vents 45
9. Instrument lighting 30
0. Lighting panel 30
1. Reading lights 58
2. Interior lighting 58
3. Sun roof control 41
4. Seat belt reminder iv
5. Rearview mirror 406. Lock button, for all doors 71
7. Blocking rear seat power windows 38
8. Controls, power windows 38
9. Controls, sideview mirrors 40
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (6 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
7/233
003 Volvo S60
Contents
Contents
Safety
Instruments and controls
Climate control
Interior
Locks and alarm
Starting and driving
Wheels and tires
Car care
Maintenance and service
Specifications
Audio
Index
Back Cover
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (7 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
8/233
003 Volvo S60
Contents | Top of Page
ile:///K|/ownersdocs/2003/2003_S60/03s60_00.htm (8 of 8)12/30/2006 4:13:09 PM
7/15/2019 Volvo S60 manual
9/233
003 Volvo S60
2 0 0 3VOLVO
S60
Safety
pg. 1 Safety
eat belts 2
Airbags (Supplemental Restraint System) 4
ide airbags (SIPS airbags) 10
nflatable Curtain (IC) 12
nspection of airbags, inflatable curtains and seat belt
ensioners13
WHIPS 14
hild safety 16
ccupant safety, Reporting safety defects 20
pg. 2 Safety
eat belts
ot wearing a seat belt is like believing "It'll never happen to me!" Volvo, the inventor of the three-p
at belt, urges you and all occupants of your car to wear seat belts and ensure that children are prope
strained, using an infant, car or booster seat determined by age, weight and height. Volvo also belie
o child should sit in the front seat of a car.
OTE: Legislation in your state or province may mandate seat belt usage.dditionally, most states and provinces have already made it mandatory for occupants of a car to use
at belts.
o, urging you to "buckle up" is not just our recommendation - legislation in your state or province m
andate seat belt usage. The few seconds it takes to buckle up may one day allow you to say, "It's a
ood thing I was wearing my seat belt."
OTE: A chime will sound several times if the driver has not fastened his/her seat belt.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (1 of 14)12/30/2006 4:13:10 PM
http://-/?-http://-/?-7/15/2019 Volvo S60 manual
10/233
003 Volvo S60
Extending the lap belt
o buckle a seat belt:
ull the belt out far enough to insert the latch plate into the receptacle until a distinct click is heard. Tat belt retractor is normally "unlocked" and you can move freely, provided that the shoulder belt is
ulled out too far. The retractor will lock up as follows:
if the belt is pulled out rapidly
during braking and acceleration
if the vehicle is leaning excessively
when driving in turns
or the seat belt to provide maximum protection in the event of an accident, it must be worn correctl
When wearing the seat belt remember:
The belt should not be twisted or turned.
The lap belt must be positioned low on the hips (not pressing against the abdomen).
ake sure that the shoulder belt is rolled up into its retractor and that the shoulder and lap belts are t
efore exiting the car, check that the seat belt retracts fully after being unbuckled.
necessary, guide the belt back into the retractor slot.
hild seats:
ease refer to page 19 for information on securing child seats with the seat belts.
pg. 3 Safety
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (2 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
11/233
003 Volvo S60
uring pregnancy
egnant women should always wear seat belts. Remember that the belt should always be positioned
ch a way as to avoid any possible pressure on the abdomen. The lap portion of the belt should be
cated low, as shown in the above illustration.
WARNING!
Seat belts:
q Never use a seat belt for more than one occupant. Never wear the shoulder portion of the belt und
he arm, behind the back or otherwise out of position. Such use could cause injury in the event of an
accident. As seat belts lose much of their strength when exposed to violent stretching, they should b
replaced after any collision, even if they appear to be undamaged.
q Never repair the belt on your own; have this work done by an authorized Volvo retailer only.
q Any device used to induce slack into the shoulder belt portion of the three-point belt system will
have a detrimental effect on the amount of protection available to you in the event of a collision.q The seat back should not be tilted too far back. The shoulder belt must be taut in order to functio
properly.
q Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We
also recommend that children who have outgrown these devices sit in the rear seat with the seat bel
properly fastened.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (3 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
12/233
003 Volvo S60
Sample label found on all seat belts with tensioners
pg. 4 Safety
Airbags (Supplemental Restraint System)
river's side airbag
s an enhancement to the three-point seat belt system, your Volvo is equipped with a Supplemental
estraint System (SRS) to complement the three-point seat belt system. The inflatable airbag is insta
lded up in the center of the steering wheel. The wheel is embossed with SRS.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (4 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
13/233
003 Volvo S60
WARNING!
Never drive an SRS equipped car with your hands on the steering wheel pad / airbag
housing.
assenger side airbag
he airbag on the front passenger side is folded up in a compartment above the glove compartment. Tanel is embossed SRS.
WARNING!
No objects, accessory equipment or stickers may be placed on, attached to, or installed near the SR
cover in the center of the steering wheel, the SRS cover above the glove compartment or the area
affected by airbag deployment.
Passenger side airbag - location
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (5 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
14/233
003 Volvo S60
WARNING!
As its name implies, SRS is designed to be a SUPPLEMENT to - not a replacement for - the three-
point belt system. For maximum protection, wear seat belts at all times. Be aware that no system ca
prevent all possible injuries that may occur in an accident.
When installing any optional equipment, make sure that the SRS system is not damaged. Do not
attempt to service any component of the SRS yourself. Attempting to do so may result in seriouspersonal injury. If a problem arises, take your car to the nearest authorized Volvo retailer for
nspection as soon as possible.
pg. 5 Safety
OTE: Deployment of SRS components occurs only one time during an accident. In a collision whe
eployment occurs, the airbags and seat belt tensioners activate. Some noise occurs and a small amou
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (6 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
15/233
003 Volvo S60
powder is released. The release of the powder may appear as smoke-like matter. This is a normal
haracteristic and does not indicate fire.
OTE: Volvo's dual-threshold, dual-stage airbags use special sensors that are integrated with the fro
at buckles. The point at which the airbag deploys is determined by whether or not the seat belt is b
ed, as well as the severity of the collision. Collisions can occur where only one of the airbags deplo
the impact is less severe, but severe enough to present a clear injury risk, the dual-stage airbags are
ggered at just 70% of their total capacity. If the impact is more severe, the dual-stage airbags are
ggered at full capacity.
WARNING!
Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We al
recommend that occupants under 4 feet 7 inches (140 cm) in height who have outgrown these devic
sit in the rear seat with the seat belt fastened.
Never drive with the airbags deployed. The fact that they hang out can impair the steering of your c
Other safety systems can also be damaged. The smoke and dust formed when the airbags are
deployed can cause skin and eye irritation in the event of prolonged exposure.
pg. 6 Safety
Airbags (Supplemental Restraint System) (Contd)
WARNING!
Children must never be allowed in the front passenger's seat. Volvo recommends that ALL occupan
adults and children) shorter than 4 feet 7 inches (140 cm) be seated in the back seat of any vehicle
with a front passenger-side airbag. See page 19 for guidelines.
Occupants in the front passenger's seat must never sit on the edge of the seat, sit leaning toward the
nstrument panel or otherwise sit out of position. The occupant's back must be as upright as comfor
allows and be against the seat back with the seat belt properly fastened.
Feet must be on the floor, e.g. not on the dash, seat or out of the window.
No objects or accessory equipment, e.g. dash covers, may be placed on, attached to, or installed nea
he SRS hatch (the area above the glove compartment) or the area affected by airbag deployment (s
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (7 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
16/233
003 Volvo S60
llustration on page 4).
There should be no loose articles, e.g. coffee cups, on the floor, seat or dash area.
Never try to open the SRS cover on the steering wheel or the passenger side dash. This should only
done by an authorized Volvo service technician.
Failure to follow these instructions can result in injury to the vehicle occupants
Warning light in the instrument panel
self-diagnostic system incorporated in the sensor monitors the SRS. This system does not, howeve
onitor the Side Impact Protection System (SIPS) airbags. If a fault is detected, the warning light wi
uminate. The light is included in the warning/indicator light cluster in the instrument panel. Norma
e SRS warning lamp should light up when the ignition key is turned to positions I, II or III and sho
o out after 7 seconds or when the engine is started. Check that this light is functioning properly eve
me the car is started.
he following items are monitored by the self-diagnostic system:
Sensor unit
Cable harness
Gas generator
WARNING!
f the SRS warning light stays on after the engine has started or if it comes on while you are driving
drive the car to the nearest authorized Volvo retailer for inspection as soon as possible.
pg. 7 Safety
OTE: The information on this page does not pertain to the Side Impact Protection System airbags.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (8 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
17/233
003 Volvo S60
When are the airbags deployed?
he SRS system is designed to deploy during certain frontal or front-angular collisions, impacts, or
ecelerations, depending on the crash severity, angle, speed and object impacted. The SRS sensor is
esigned to react to both the impact of the collision and the inertial forces generated by it and to
etermine if the intensity of the collision is sufficient for the seat belt tensioners or airbags to be
eployed.
the airbags have been deployed, we recommend the following:
Have the car towed to an authorized Volvo retailer. Never drive with the airbags deployed.
Have an authorized Volvo retailer replace the SRS system components.
Use only new, Genuine Volvo Parts when replacing SRS components (airbags, seat belts, tensione
c.).
When are the airbags NOT deployed?
ot all frontal collisions activate the SRS system. If the collision involves a nonrigid object (e.g., a s
ift or bush), or a rigid, fixed object at a low speed, the SRS system will not necessarily deploy. Fro
rbags do not normally deploy in a side impact collision, in a collision from the rear or in a rollover
tuation. The amount of damage to the bodywork does not reliably indicate if the airbags should hav
eployed or not.
eat belts - the heart of the Volvo safety system
he heart of the Volvo safety system is the three-point seat belt (a Volvo invention)! In order for the
RS system to provide the protection intended, seat belts must be worn at all times by everyone in th
r. The SRS system is a supplement to the seat belts.
WARNING!
Never drive with the airbags deployed. The fact that they hang out can impair the steering of your c
Other safety systems can also be damaged. The smoke and dust formed when the airbags are
deployed can cause skin and eye irritation in the event of prolonged exposure.
pg. 7 Safety
Airbags (Supplemental Restraint System) (Contd)
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (9 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
18/233
003 Volvo S60
WARNING!
f your car has been subjected to flood conditions (e.g. soaked carpeting/standing water on the floor
of the vehicle) or if your car has become flood-damaged in any way, do not attempt to start the
vehicle or put the key in the ignition before disconnecting the battery (see below). This may cause
airbag deployment which could result in personal injury. Have the car towed to an authorized
Volvo retailer for repairs.
Automatic transmission:
Before attempting to tow the car, use the following procedure to override the shiftlock system to
move the gear selector to the neutral position.
q Switch off the ignition for at least 10 minutes and disconnect the battery
q Wait at least one minute
q Insert the key in the ignition and turn it to position II
q Press firmly on the brake pedal.
q Move the gear selector from (P)ark to the (N) eutral position.
here is no maintenance to perform on the SRS yourself. The month and year shown on the decal on
oor pillar indicate when you should contact your Volvo retailer for specific servicing or replacemen
rbags and seat belt tensioners. This service must be performed by an authorized Volvo retailer.
hould you have any questions about the SRS system, please contact your authorized Volvo retailer
olvo Customer Support.:
n the USA:
olvo Cars of North America, LLC.
ustomer Relations
O. Box 914
ockleigh, New Jersey 07647-0914
00-458-1552
n Canada:olvo Canada Ltd.
75 Gordon Baker Road
orth York, Ontario M2H 2N7
00-663-8255
pg. 9 Safety
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (10 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
19/233
003 Volvo S60
ront airbag (SRS) system
s an enhancement to the three-point seat belt system, your Volvo is equipped with a Supplemental
estraint System (SRS). The Volvo SRS consists of an airbag (2) on both the driver's and passenger'
des and seat belt tensioners in both front door pillars. The system is designed to supplement the
otection provided by the three-point seat belt system. All three rear seat belts are also equipped wit
nsioners.
he SRS system is indicated by the "SRS" embossed on the steering wheel pad and above the glove
ompartment, and by decals on both sun visors and on the front and far right side of the dash.
he airbags are folded and located in the steering wheel hub and above the glove compartment.
eployment: The SRS airbags are designed to deploy during certain frontal or front-angular collisio
mpacts, or decelerations, depending on the crash severity, angle, speed and object impacted. The
rbags may also deploy in certain non-frontal collisions where rapid deceleration occurs.
he airbag system includes gas generators (1) surrounded by the airbags (2) and front seat belt
nsioners for both of the front seats. To deploy the system, the sensor (3) activates the gas generator
using the airbags to be inflated with nitrogen gas.
s the movement of the seats' occupants compresses the airbags, some of the gas is expelled at a
ontrolled rate to provide better cushioning. Both seat belt tensioners also deploy, minimizing any se
elt slack. The entire process, including inflation and deflation of the airbags, takes approximately tw
nths of a second.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (11 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
20/233
003 Volvo S60
WARNING!
The SRS is designed to help prevent serious injury. Deployment occurs very quickly and with
considerable force. During normal deployment and depending on variables such as seating position
one may experience abrasions, bruises, swellings, or other injuries as a result of airbag(s) deployme
Never try to repair any part of the SRS or SIPS bag systems yourself. Any interference in the systemcould cause malfunction and serious injury. All work on these systems should be performed by an
authorized Volvo retailer.
pg. 10 Safety
ide airbags (SIPS airbags)
SIPS airbag*
IPS airbag (front seats only)
s an enhancement to the structural Side Impact Protection System built into your car, the car is also
quipped with Side Impact Protection System (SIPS) airbags. The SIPS airbag system consists of air
odules built into the sides of both front seat backrests, wires and gas generators/sensor units (see
ustration on next page).
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (12 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
21/233
003 Volvo S60
he SIPS airbag system is designed to help increase occupant protection in the event of certain side
mpact collisions. The SIPS airbags are designed to deploy only during certain side-impact collisions
epending on the crash severity, angle, speed and point of impact. The airbags are not designed to
eploy in all side impact situations.
OTE: SIPS airbag deployment (one airbag) occurs only on the side of the vehicle affected by the
mpact. The airbags are not designed to deploy in all side impact situations.
A SIPS airbag warning decal is also located at the end of the instrument panel on the driver's side o
r.
WARNING!
The SIPS airbag system is a supplement to the Side Impact Protection System and the three-point s
belt system. It is not designed to deploy during collisions from the front or rear of the car or inrollover situations.
The use of seat covers on the front seats may impede SIPS airbag deployment.
No objects, accessory equipment or stickers may be placed on, attached to or installed near, the SIP
airbag system or in the area affected by SIPS airbag deployment (see illustration above). Never try
open or repair any components of the SIPS airbag system. This should be done only by an authorize
Volvo service technician.
n order for the SIPS airbag to provide its best protection, both front seat occupants should sit in an
upright position with the seat belt properly fastened.
Failure to follow these instructions can result in injury to the occupants of the vehicle in the event o
an accident.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (13 of 14)12/30/2006 4:13:10 PM
7/15/2019 Volvo S60 manual
22/233
003 Volvo S60
pg. 11 Safety
he SIPS airbag system
his system consists of a gas generator (1), the side airbags (2), and electronic sensors/cables (3).
Contents | Top of Page
ile:///K|/ownersdocs/2003/2003_S60/03s60_01a.htm (14 of 14)12/30/2006 4:13:10 PM
http://-/?-http://-/?-7/15/2019 Volvo S60 manual
23/233
003 Volvo S60
pg. 12 Safety
nflatable Curtain (IC)
olvo Inflatable Curtain (VIC)
his system consists of inflatable curtains located along the sides of the roof liners, stretching from t
nter of both front side windows to the rear edge of the rear side door windows. It is designed to hel
otect the heads of the occupants of the front seats and the occupant of the outboard rear seatingositions in certain side impact collisions.
OTE: IC system deployment occurs only on the side of the vehicle affected by the impact.
certain side impacts, BOTH the Inflatable Curtain (IC) and the Side Impact Airbag System (SIPS
ag) will deploy, whereas, in some cases, ONLY the Inflatable Curtain (IC) will deploy. In cases wh
OTH the IC and the SIPS-bag deploy, deployment will occur simultaneously.
the inflatable curtain deploys, it remains inflated for approximately 3 seconds.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (1 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
24/233
003 Volvo S60
WARNING!
The IC system is a supplement to the Side Impact Protection System. It is not designed to deploy
during collisions from the front or rear of the car or in most rollover situations.
Never try to open or repair any components of the IC system. This should be done only by an
authorized Volvo service technician.
The inflatable curtains are designed to deploy only during certain side-impact collisions, depending
on the crash severity, angle, speed and impact. The inflatable curtains are not designed to deploy in
all side impact situations.
n order for the IC to provide its best protection, both front seat occupants and both outboard rear se
occupants should sit in an upright position with the seat belt properly fastened; adults using the seat
belt and children using the proper child restraint system. Only adults should sit in the front seats.
Children must never be allowed in the front passenger seat. See page 19 for guidelines. Failure to
follow these instructions can result in injury to the vehicle occupants in an accident
pg. 13 Safety
nspection of airbags, inflatable curtains and seat belt
ensionershe year and month specified on the decal in the door pillar( s) is the date when you should contact y
olvo retailer to inspect and, if necessary, replace the airbags and seat belt tensioners. If you have an
uestions concerning either system, contact an authorized Volvo retailer.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (2 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
25/233
003 Volvo S60
pg. 14 Safety
WHIPS
Whiplash Protection System (WHIPS) -front seats only
he WHIPS system consists of specially designed hinges and brackets on the front seat backrests and
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (3 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
26/233
003 Volvo S60
ead restraints designed to help absorb some of the energy generated in a collision from the rear ("re
nded").
the event of a collision of this type, the hinges and brackets of the front seat backrests are designed
hange position slightly to allow the backrest/head restraint to help support the occupant's head befor
oving slightly rearward. This movement helps absorb some of the forces that could result in the
hiplash effect.
WARNING!
The WHIPS system is designed to supplement the other safety systems in your car. For this system
function properly, the three-point seat belt must be worn. Please be aware that no system can preve
all possible injuries that may occur in an accident.
f your car has been involved in a collision, the front seat backrests must be inspected by an
authorized Volvo retailer even if the seats appear to be undamaged. Certain components in the
WHIPS system may need to be replaced. Do not attempt to service any component in the WHIPS
system yourself.
WARNING!
f the rear seat backrests are folded down, cargo must be secured to prevent it from sliding forward
against the front seat backrests in the event of a collision from the rear. This could interfere with thaction of the WHIPS system.
The WHIPS system is designed to function in certain collisions from the rear, depending on the cra
severity, angle and speed.
Occupants in the front seats must never sit out of position. The occupant's back must be as upright a
comfort allows and be against the seat back with the seat belt properly fastened.
pg. 15 Safety
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (4 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
27/233
003 Volvo S60
WARNING!
Any contact between the front seat backrests and the folded rear seat could impede the function of t
WHIPS system. If the rear seat is folded down, the occupied front seats must be adjusted forward so
hat they do not touch the folded rear seat.
Boxes, suitcases, etc. wedged behind the front seats (see illustration in center column) could imped
he function of the WHIPS system.
pg. 16 Safety
Child safety
olvo recommends the proper use of restraint systems for all occupants including children. Rememb
at, regardless of age and size, a child should always be properly restrained in a car.
our car is also equipped with ISOFIX attachments, which make it more convenient to install child s
ee page 17).
estraint systems for children are designed to be secured in the vehicle by lap belts or the lap portion
lap-shoulder belt. Such child restraint systems can help protect children in cars in the event of an
cident only if they are used properly. However, children could be endangered in a crash if the child
straints are not properly secured in the vehicle. Failure to follow the installation instructions for yo
hild restraint can result in your child striking the vehicle's interior in a sudden stop.
olding a child in your arms is NOT a suitable substitute for a child restraint system. In an accident,
hild held in a person's arms can be crushed between the vehicle's interior and an unrestrained person
he child could also be injured by striking the interior, or by being ejected from the vehicle during a
dden maneuver or impact. The same can also happen if the infant or child rides unrestrained on the
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (5 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
28/233
003 Volvo S60
at. Other occupants should also be properly restrained to help reduce the chance of injuring or
creasing the injury of a child.
ll states and provinces have legislation governing how and where children should be carried in a ca
nd out the regulations existing in your state or province. Recent accident statistics have shown that
hildren are safer in rear seating positions than front seating positions when properly restrained. A ch
straint system can help protect a child in a vehicle. Here's what to look for when selecting a child
straint system:
It should have a label certifying that it meets applicable Federal Motor Vehicle Safety Standards
MVSS 213) - or in Canada, CMVSS 213.
Make sure the child restraint system is approved for the child's height, weight and development - t
bel required by the standard or regulation, or instructions for infant restraints, typically provide this
formation.
In using any child restraint system, we urge you to carefully look over the instructions that are
ovided with the restraint. Be sure you understand them and can use the device properly and safely
is vehicle. A misused child restraint system can result in increased injuries for both the infant or chnd other occupants in the vehicle.
When a child has outgrown the child safety seat, you should use the rear seat with the standard seat b
stened. The best way to help protect the child here is to place the child on a cushion so that the seat
elt is properly located on the hips (see page 2). Legislation in your state or province may mandate th
e of a child seat or cushion in combination with the seat belt, depending on the child's age and/or s
ease check local regulations.
specially designed and tested booster cushion (not available in Canada) for children between the a
3 and approximately 10 years, weighing 33 - 80 lbs (15 - 36 kg) and 38 - 54" (97 - 137 cm) in heig
n be obtained from your Volvo retailer.
WARNING!
Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We al
recommend that children under 4 feet 7 inches (140 cm) in height who have outgrown these devicesit in the rear seat with the seat belt fastened.
q Keep vehicle doors and trunk locked and keep keys out of a child's reach. Unsupervised children
could lock themselves in an open trunk and risk injury. Children should be taught not to play in
vehicles.
q On hot days, the temperature in the trunk or vehicle interior can rise very quickly.
Exposure to these high temperatures for even a short period of time can cause heat-related injury or
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (6 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
29/233
003 Volvo S60
death. Small children are particularly at risk.
pg. 17 Safety
OFIX fasteners and seat guide
OFIX fasteners are installed in the rear seat (second row of seats in seven-seat models) on theutboard positions. One set of ISOFIX guides is also provided. Consult your Volvo retailer for more
formation on child safety accessories.
pg. 18 Safety
Child safety (Contd)
Child restraint anchorages
hild restraint anchorages
olvo cars are equipped with child restraint top tether anchorages in the rear seat. Refer to the child
anufacturer's instructions for information on securing the child seat.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (7 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
30/233
003 Volvo S60
WARNING!
Child Restraint Anchorages are designed to withstand only those loads imposed by correctly fitted
Child Restraints. Under no circumstances are they to be used for adult seat belts or harnesses. The
anchorages are not able to withstand excessive forces on them in the event of collision if full harnes
seat belts or adult seat belts are installed to them. An adult who uses a belt anchored in a Child
Restraint Anchorage runs a great risk of suffering severe injuries should a collision occur. Do notnstall rear speakers which would require the removal of the top tether anchors or interfere with the
proper use of the top tether strap.
pg. 19 Safety
eeping child seats in place (ALR/ELR*)
o make child seat installation easier, each seat belt (except for the driver's belt) is equipped with acking mechanism to help keep the seat belt taut.
When attaching the seat belt to a child seat:
Attach the seat belt to the child seat according to the child seat manufacturer's instructions.
Pull the seat belt out as far as possible.
Insert the seat belt latch plate into the buckle (lock) in the usual way.
Release the seat belt and pull it taut around the child seat.
sound from the seat belt retractor will be audible at this time and is normal.
he belt will now be locked in place.
his function is automatically disabled when the seat belt is unlocked and the belt is fully retracted.
WARNING!
Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We al
recommend that children who have outgrown these devices sit in the rear seat with the seat belt
properly fastened.
mportant!
Why Volvo believes no child should sit in the front seat of a car.
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (8 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
31/233
003 Volvo S60
s quite simple really. A front airbag is a very powerful device designed, by law, to help protect an
dult. Because of the size of the airbag and its speed of inflation, a child should never be placed in th
ont seat, even if he or she is properly belted or strapped into a child safety seat. Volvo has been an
novator in safety for over fifty years, and we'll continue to do our part. But we need your help. Plea
member to put your children in the back seat, and buckle them up.
olvo has some very specific recommendations:
Always wear your seat belt.Airbags are a SUPPLEMENTAL safety device which, when used with a three-point seat belt can h
duce serious injuries during certain types of accidents. Volvo recommends that you do not disconn
e airbag system in your vehicle.
Volvo strongly recommends that ALL children sit in the rear seat of any vehicle and that they be
operly restrained.
A child should NEVER sit in the front passenger seat of any vehicle equipped with a passenger-si
ont airbag.
Volvo recommends that ALL occupants (adults and children) shorter than four feet seven inches (
m) be seated in the back seat of any vehicle with a front passenger side airbag.
rive safely!
Automatic Locking Retractor/Emergency Locking Retractor
pg. 20 Safety
Occupant safety, Reporting safety defects
eat belt maintenance
heck periodically that the seat belts are in good condition. Use water and a mild detergent for clean
heck seat belt mechanism function as follows: attach the seat belt and pull rapidly on the strap.
olvo Concern for Safety
afety is the Volvo cornerstone. Our concern dates back to 1927 when the first Volvo rolled off the
oduction line. Three-point seat belts (a Volvo invention), safety cages, and energy-absorbing impaones were designed into Volvo cars long before it was fashionable or required by government
gulation. We will not compromise our commitment to safety. We continue to seek out new safety
atures and to refine those already in our cars. You can help. We would appreciate hearing your
ggestions about improving automobile safety. We also want to know if you ever have a safety conc
ith your car. Call us in the U. S. at: 800-458-1552 or in Canada at: 800-663-8255.
ccupant safety
ow safely you drive doesn't depend on how old you are but rather on:
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (9 of 10)12/30/2006 4:13:11 PM
7/15/2019 Volvo S60 manual
32/233
003 Volvo S60
How well you see.
Your ability to concentrate.
How quickly you make decisions under stress to avoid an accident.
he tips listed below are suggestions to help you cope with the ever changing traffic environment.
Never drink and drive.
If you are taking any medication, consult your physician about its potential effects on your driving
bilities.Take a driver-retraining course.
Have your eyes checked regularly.
Keep your windshield and headlights clean.
Replace wiper blades when they start to leave streaks.
Take into account the traffic, road, and weather conditions, particularly with regard to stopping
stance.
eporting Safety Defects in the U.S.
you believe that your vehicle has a defect which could cause a crash or could cause injury or deathou should immediately inform the National Highway Traffic Safety Administration (NHTSA) in
ddition to notifying Volvo Cars of North America. If NHTSA receives similar complaints, it may op
n investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall
medy campaign. However, NHTSA cannot become involved in individual problems between you,
our retailer, or Volvo Cars of North America. To contact NHTSA, you may either call the Auto Saf
otline toll-free at 1-800-424-9393 (or 202-366-0123 in Washington, D.C. area) or write to: NHTSA
Department of Transportation, Washington D. C. 20590. You can also obtain other information ab
otor vehicle safety from the Hotline.
olvo strongly recommends that if your vehicle is covered under a service campaign, safety or emis
call or similar action, it should be completed as soon as possible. Please check with your local reta
Volvo Cars of North America, LLC if your vehicle is covered under these conditions.
HTSA can be reached at:
ternet : http://www.nhtsa.dot.gov
elephone:
888-DASH-2-DOT (1-888-327-4236) (toll free)
800-424-9393 (toll free)
202-366-0123 (in Washington DC area)
Contents | Top of Page
ile:///K|/ownersdocs/2003/2003_S60/03s60_01b.htm (10 of 10)12/30/2006 4:13:11 PM
http://www.nhtsa.dot.gov/http://www.nhtsa.dot.gov/7/15/2019 Volvo S60 manual
33/233
003 Volvo S60
2 0 0 3VOLVO
S60
nstruments and controls
pg. 21 Instruments and controls
nstrument panel 22
ndicator and warning symbols 23
witches in the center console 27
teering wheel adjustment 29ighting panel 30
Manually unlocking the fuel filler door 31
urn signals 32
Windshield wipers/washer 33
Hazard warning flashers, rear window/sideview mirror defroster, heated front
eats34
rip computer (option)35
ruise control 36
arking brake, electric socket/cigarette lighter 37
lectrically operated windows 38
earview mirror/sideview mirrors 40
lectrically operated sun roof (option) 41
pg. 22 Instruments and controls
nstrument panel
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (1 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
34/233
003 Volvo S60
Turn signal indicators - right - left
Text window
he text window displays information and warning messages.
Temperature gauge
he pointer should be approximately midway on the gauge when driving. Do not drive the car if th
arning light is on. The text window will provide you with additional information. If the enginemperature remains high, check coolant level - see page 121.
Trip odometer
he trip odometers are used for measuring shorter distances. The right-hand digit gives tenth of a mi
lometer. Press the button for more than 2 seconds to reset. Change between trip odometers 1 and 2
ing one short press on the button.
Odometer
Speedometer
Warning symbol
High beam indicator
Tachometer
dicates engine speed in thousands of revolutions per minute (rpm). Do not drive for long with theeedle in the red section. The engine has an built-in function preventing excessively high engine spe
When this function operates, you may discern some pulsation, which in that case is quite normal.
0. Gear and driving mode indicator
he currently selected driving mode is displayed here. If you use the optional Geartronic function on
utomatic transmission, the currently selected gear will be displayed.
1. Ambient temperature gauge
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (2 of 12)12/30/2006 4:13:12 PM
http://-/?-http://-/?-7/15/2019 Volvo S60 manual
35/233
003 Volvo S60
his display indicates the air temperature outside your car. A "snowflake" symbol in the text window
splayed when the temperature is in the range of 23 - 36 F (-5 - +2 C).
ease note that this symbol does not indicate a fault with your car.
t low speeds or when the car is not moving, the temperature readings may be slightly higher than th
tual ambient temperature.
2. Clock/set button
urn the button to set the clock.
3. Fuel gauge
he fuel tank holds approximately 18.5 US gals (70 liters) or 19 US gals (72 liters) on models equipp
ith All Wheel Drive.
When a warning light in the gauge comes on, there are approximately 1.8 US gal. (8 liters) of fuel
maining in the tank.
4. Indicator and warning symbols
pg. 23 Instruments and controls
ndicator and warning symbols
he indicator and warning symbols light up when you turn the ignition key to the driving position
osition II) before starting. This shows that the symbols are functioning. When the engine starts, all
mbols go out. If the engine is not started within 5 seconds, all symbols except CHECK ENGINEgo out. Certain symbols may not have their functions illustrated, depending on the car's equipme
he symbol for the parking brake goes out when the parking brake is released.
Warning symbol in center of dashboard
his symbol shines as a red or yellow light depending on the severity of the discovered fault.
ed symbol - Stop the car as soon as possible in a suitable location and read the message shown in t
xt window.
ellow symbol - Follow the instructions shown in the text window.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (3 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
36/233
003 Volvo S60
Anti-lock brake system ABS
the warning light comes on, there is a malfunction of the ABS system (the standard braking system
ill still function). The vehicle should be driven to a Volvo retailer for inspection. See page 92 for
dditional information.
Stability Traction Control (STC)* system or Dynamic Stability Traction Control (DSTC)stem**
his indicator light will flash when STC or DSTC is actively working to stabilize the car. See page 9
r more detailed information.
RAKE Brake failure warning light
the light comes on while driving or braking, stop immediately, open the hood and check the brake
uid level in the reservoir. See page 122 for reservoir position and page 125 for instructions.
Canadian models are equipped with this warning light:
the BRAKE and ABS warning lights come on at the same time, this could indicate a fault in t
rake system.
Stop the car in a suitable place and switch off the engine.
Restart the engine.
If both warning lights go off, no further action is required.
If both lights are still on after the engine has been restarted, switch off the engine again and check
ake fluid level (see page 122 for the location of the brake fluid reservoir).
Standard on all models except the T5 turbo.
* Standard on the T5 turbo, option on all other models.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (4 of 12)12/30/2006 4:13:12 PM
http://-/?-http://-/?-http://-/?-http://-/?-http://-/?-http://-/?-7/15/2019 Volvo S60 manual
37/233
003 Volvo S60
pg. 24 Instruments and controls
ndicator and warning symbols (Contd)
WARNING!
f the fluid level is below the MIN mark in the reservoir or if a "Brake failure - Service urgent"
message is displayed in the text window: DO NOT DRIVE. Have the car towed to an authorized
Volvo retailer and have the brake system inspected.
If the brake fluid level is above the MIN mark, drive carefully to an authorized Volvo retailer and
ave the brake system inspected.
pg. 25 Instruments and controls
Supplemental Restraint System SRS
the light comes on (or stays on after the vehicle has started), the SRS diagnostic system has detecte
ult. Drive to an authorized Volvo retailer for an inspection of the system. See the SRS section for m
formation.
Generator warning light
the light comes on while the engine is running, have the charging system checked.
Seat belt reminder
his symbol lights up to indicate that the driver has not fastened his/her seat belt.
ARK BRAKE Parking brake applied
his light will be on when the parking brake (hand brake) is applied. The parking brake lever is situa
etween the front seats.
Canadian models are equipped with this symbol.
Rear fog light
his light indicates that the fog light is on.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (5 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
38/233
003 Volvo S60
Turn signal indicator - trailer (certain models)
you are towing a trailer, this light will flash simultaneously with the turn signals on the trailer. If th
ght does not flash when signaling, neither the trailer's turn signals nor the car's turn signals are
nctioning.
Oil pressure warning light
the light comes on while driving, stop the car and then stop the engine immediately and check
e engine oil level. See page 124. If the light stays on after restart, have the car towed to the nearest
uthorized Volvo retailer. After hard driving, the light may come on occasionally when the engine is
ling. This is normal, provided it goes off when the engine speed is increased.
HECK ENGINE Malfunction indicator light
n-Board Diagnostic II (OBDII): As you drive, a computer called "OBDII" monitors your car's engi
ansmission, electrical and emission systems. The CHECK ENGINE light will light up if the compu
nses a condition that potentially may need correcting. When this happens, please have your carhecked by a Volvo retailer as soon as possible.
CHECK ENGINE light may have many causes. Sometimes, you may not notice a change in your
ehavior. Even so, an uncorrected condition could hurt fuel economy, emission cleanliness, and
iveability. Extended driving without correcting the cause could even damage other components in
our car.
Canadian models are equipped with this warning light.
pg. 26 Instruments and controls
ndicator and warning symbols (Contd)
Messages in the text window
When a warning light in the instrument panel comes on, a message is also displayed in the text wind
fter you have read the message, you can erase it by pressing button A (see illustration).
OTE: Certain messages cannot be erased until the condition has been corrected.
a warning message is displayed when e.g. you are using the trip computer this message must be er
efore you can access the function of your choice. Press button A to erase the warning message.
ou can scroll through the stored messages by pressing button A (see illustration). The text window
e cleared (the message will be returned to memory) by pressing button A again.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (6 of 12)12/30/2006 4:13:12 PM
http://-/?-http://-/?-7/15/2019 Volvo S60 manual
39/233
003 Volvo S60
Message Meaning:
TOP SAFELY:Stop and switch off the engine - to help prevent serious risk of
damage.
TOP ENGINE:Stop and switch off the engine - to help prevent serious risk of
damage.
ERVICE URGENT: Take your car to an authorized Volvo retailer for inspection assoon as possible.
EE MANUAL:Refer to your owner's manual. For additional information, pleas
contact your Volvo retailer.
ERVICE REQUIRED:
Take your car to an authorized Volvo retailer for inspection at y
convenience (but preferably before the next scheduled
maintenance service).
IX NEXT SERVICE:Have the system affected inspected at the next scheduled
maintenance service.
IME FOR REGULAR
ERVICE:
This light will come on at 7,500 mile (12,000 km) intervals, afte
750 hours of driving or after 12 months, whichever occurs first,
remind the driver that the service interval has been exceeded. T
light will stay on for 2 minutes after start until reset by the
servicing retailer.
pg. 27 Instruments and controls
witches in the center console
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (7 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
40/233
003 Volvo S60
The positions of these buttons may vary, depending on the specifications of your car
Folding head restraints
his button is used to fold down the outboard rear head restraints. The ignition key must be in positio
II or the engine must be running.
OTE: If the head restraints have been folded down, they must be returned to their original position
anually. The head restraints should be in the upright position before the rear seat backrests are fold
own.
WARNING!
For safety reasons, no one should be allowed to sit in the outboard rear seat positions if the head
restraints are folded down. If these positions are occupied, the head restraints should be in the uprig
fixed) position.
Valet lock (trunk lock)
essing this switch locks the trunk, even if the doors are unlocked. The trunk will remain locked eve
e doors are locked/unlocked using the master key or the remote control.
o use this function:
Turn the master key to position II.
Press the "Valet lock" button. An LED in the button will light up and "VALET LOCK ON" will b
splayed on the text window to indicate that this function is activated.
The function can be turned off (deactivated) by turning the ignition key to position II and pressingValet lock" button again (the LED in the button will go out and "VALET LOCK OFF" will be
splayed in the text window).
Not in use
Stability Traction Control (STC)/Dynamic Stability Traction Control (DSTC) (option)
ess this switch for at least half a second to turn the Spin Control (SC) function of the STC/ DSTC
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (8 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
41/233
003 Volvo S60
stem on or off. An LED in the switch will light up to indicate that the system is on. See page 93 fo
ore information on STC/ DSTC. The SC function should be switched off if you, for any reason,
mporarily have to drive with tires of different dimensions (e.g., spare tire).
OTE:To help reduce the risk that the SC function is turned off inadvertently, the switch must be he
for at least half a second to disable this function. "STC/DSTC SPIN CONTROL OFF" will be
splayed in the text window.
pg. 28 Instruments and controls
witches in the center console (Contd)
his function will be automatically reactivated when the engine is restarted.
WARNING!
Please be aware that the car's handling characteristics may be affected if Spin Control function is
switched off.
Not in Use
Temporarily disconnecting the alarm sensors (option)ee page 76 for more details.
Not in use
12 volt socket
his 12 volt socket can be used to plug in certain accessories such as cellular telephones, etc. The
nition key must be in position 1 (or higher) for the auxiliary socket to function.
OTE: The auxiliary sockets can also be used for cigarette lighters, which are available at your Voltailer.
pg. 29 Instruments and controls
teering wheel adjustment
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (9 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
42/233
003 Volvo S60
oth the height and the reach of the steering wheel can be adjusted to a comfortable position for the
iver. Pull down the lever on the left of the steering column. Adjust the steering wheel to a suitable
osition and press the lever back into place to lock the steering wheel in the new position. Check tha
eering wheel is locked in the new position.
WARNING!
Never adjust the steering wheel while
driving.
pg. 30 Instruments and controls
ighting panel
- Headlights and parking lights
All lighting off.
Models with daytime running lights:
ow beam headlights will automatically come on if the ignition key is in position II. Front and rear
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (10 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
43/233
003 Volvo S60
arking lights and license plate lights will also be on. Volvo recommends the use of daytime running
ghts. If, however, you would prefer to have these lights turned off (USA only), please consult your
olvo retailer. Please note that the use of daytime running lights is mandatory in Canada.
Parking lights on. The parking lights should be switched off when you leave the car to help
void battery drain.
Headlights, parking lights, license plate lights and instrument panel illumination are on if the
nition key is in position II.
the headlight switch is in this position, all lights will go out when the ignition is switched off.
he headlight switch must be in this position before the high beams will function.
witch from high to low beams and vice versa by pulling the turn signal switch lever on the left side eering column toward you.
- Instrument lighting
ove the thumb wheel up to increase brightness or down to decrease brightness. There is also an
strument panel illumination sensor (see illustration on page 46) which automatically adjusts the lev
illumination.
he symbols have maximum illumination in daylight (only the background lighting can be adjusted)
ght, both the symbol light and background lighting can be adjusted.
- Unlocking the fuel filler door
ess this button when the car is at a standstill to unlock the fuel filler door. Please note that the fuel
ler door will remain unlocked until the car begins to move forward. An audible click will be heard
hen the fuel filler door relocks.
ee also page 80.
OTE: If the fuel filler door does not unlock after the button has been pressed, please see page 31 fo
formation on manually unlocking this door.
- Front fog lights *
he front fog lights will function only in combination with the low beam headlights.
n LED in the switch indicates when the front fog lights are on.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (11 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
44/233
003 Volvo S60
- Rear fog light*
he rear fog light is considerably brighter than the normal tail lights and should be used only when
onditions such as fog, rain, snow, smoke or dust reduce visibility for other vehicles to less than 500
50 meters).
n LED in the switch indicates when the rear fog light is on.
he rear fog light will only function in combination with the high/low beam headlights. By design, thone rear fog light only, located in the driver's side tail light cluster.
Standard on T5/accessory on the other models.
hese lights will be automatically switched off the next time the car is started.
Contents | Top of Page
ile:///K|/ownersdocs/2003/2003_S60/03s60_02a.htm (12 of 12)12/30/2006 4:13:12 PM
7/15/2019 Volvo S60 manual
45/233
003 Volvo S60
pg. 31 Instruments and controls
Manually unlocking the fuel filler door
Manually unlocking the fuel filler door
OTE: Cotton gloves are available in the tool kit located in the spare wheel well.
he electric motor that controls the fuel filler door locking mechanism is located on the inside of the
nder on the passenger side of the car, just behind the fuel filler door. To unlock this door manually
Turn the knob (A) 1/4 turn counterclockwise to release the cover panel (B).
Fold down the cover panel to access the electric motor (C).
Press the catch (D) rearward to unlock the fuel filler door, or forward to lock the door.
pg. 32 Instruments and controls
urn Signals
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (1 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
46/233
003 Volvo S60
Lane change position
maneuvers such as lane changing, the driver can flash the turn signals by moving the turn signal le
the first stop and holding it there. The lever will return to the neutral position when released.
Signal lever engaged for normal turns
High/low beam switch (headlights on).
ove the lever towards the steering wheel and release it.
eadlight flasher (headlights off).
ove the lever towards the steering wheel. The headlight high beam will be on until the lever is rele
OTE:
the turn signal indicator flashes faster than normal, check for a burned-out turn signal bulb.
Exterior courtesy lights
ome Safe System
When you leave your car at night, you can make use of the courtesy lighting function:
Remove the key from the ignition switch.
Pull the direction indicator lever towards the steering wheel (as when using the headlight flasher
nction).
Exit the car and lock the doors.
he headlights, parking lights, license plate lights and the lights in the sideview mirrors will now comn and remain on for 30, 60 or 90 seconds (the time interval is at your discretion and can be changed
n authorized Volvo retailer).
pproach lighting
When approaching the car at night, press the yellow button in the central locking remote control (see
ustration on page 69). This lights up the interior courtesy lights, parking lights, license plate lights
e lights in the sideview mirrors.
pg. 33 Instruments and controls
Windshield wipers/washer
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (2 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
47/233
003 Volvo S60
Windshield wipers
Windshield wipers off
the lever is in the 0 position and you move it upwards, the wipers will sweep one stroke at a time f
long as you hold the lever up.
Intermittent wiper function With the lever in this position, you can set the wiper interval by
wisting the control ring (A) upward to increase wiper speed or downward to decrease the speed.
ain sensor (option)
he rain sensor replaces the intermittent wiper function and automatically regulates wiper speed
cording to the amount of water on the windshield. The sensitivity of the sensor can be adjusted by
wisting control A upward or downward.
ctivating the rain sensor function:
Switch on the ignition.
Move the windshield wiper lever to the intermittent position.he rain sensor is deactivated when the ignition is switched completely off.
o reactivate the rain sensor function:
Switch on the ignition.
Move the windshield wiper lever to position 0 and then back to the intermittent position.
AUTION:When washing the car in an automatic car wash, etc move the windshield wiper lever to position 0 or
witch off the ignition completely to deactivate the rain sensor. If the sensor function is left on, the
ipers will start inadvertently in the car wash and could be damaged.
Wipers operate at "normal" speed
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (3 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
48/233
003 Volvo S60
Wipers operate at "high" speed
- Windshield washer/headlight washer (certain models)
he wipers will make 2-3 sweeps across the windshield and headlights (certain models) after the leve
leased.
pg. 34 Instruments and controls
Hazard warning flashers, rear window/sideview mirrorefroster, heated front seats
azard warning flashers
he four-way flasher should be used to indicate that the vehicle has become a traffic hazard. To active flashers, press the triangular button in the center dash. Press the button again to turn off the flashe
OTE: Regulations regarding the use of the hazard warning flasher may vary, depending on where
ve.
deview mirror and rear window defroster
ess the switch to start heating the rear window and sideview mirrors to remove ice or condensation
n LED in the switch will light up.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (4 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
49/233
003 Volvo S60
timer automatically switches off the heating to the sideview mirrors after approximately 6 minutes
the rear window after approximately 12 minutes. The LED will go out correspondingly.
eated front seats (option)
The front seat heating can be switched on and off as required.
Press the switch once for maximum seat heating. Both LEDs in the switch will be lit.
Press the switch a second time for comfort heating. One LED in the switch will be lit.
Press the switch a third time to turn the heating off completely. The seat heating for the passenger
ould be switched off when the seat is not occupied.
pg. 35 Instruments and controls
rip computer (option)
he trip computer stores information gathered from several systems in your car and has four menus t
n be displayed in the text window.
Driving distance on current fuel reserveAverage fuel consumption
Current fuel consumption
Average speed
Current speed in mph (Canadian models only)
OTE: Warning messages from the car's monitoring systems will override the trip computer functio
a warning message is displayed in the text window while you are using the trip computer, you mus
knowledge the message by pressing button A. Press button A again to return to the trip computer
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (5 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
50/233
003 Volvo S60
nction.
rip computer controls
he four* trip computer functions can be accessed by twisting control B one step at a time in either
rection. Twisting a fifth** time returns you to the original function.
he trip computer can be reset (current data will be erased from system memory) by pressing RESET
utton C).
Driving distance on current fuel reserve
his function shows the approximate distance that can be driven on the fuel remaining in the tank. Th
lculation is based on average fuel consumption during the last 12 miles (20 km) of driving and the
mount of fuel remaining in the tank when the reading was taken.
When the driving distance on current fuel reserve is less than 12 miles (20 km), "----" will be display
the text window.
Average fuel consumption
his value indicates fuel consumption since the last time the trip computer was reset (by pressing
ESET, button C). When the engine is switched off, information on fuel consumption is stored and
mains in system memory until the RESET (button C) is pressed again.
Current fuel consumption
his value indicates the current fuel consumption, based on readings taken once per second. When th
r is not moving, "----" will be displayed.
Average speed
his value indicates average speed since the last time the trip computer was reset (by pressing RESE
utton C). When the engine is switched off, information on average speed is stored and remains in
stem memory until the RESET (button C) is pressed again.
Current speed in miles per hour (Canadian models only)
his function provides the driver with an instantaneous conversion of the car's current speed from km
mph.
Five functions on Canadian models
*A sixth time on Canadian models
pg. 36 Instruments and controls
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (6 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
51/233
003 Volvo S60
Cruise control
ruise control
he cruise control panel is located on the left side of the steering wheel hub.
ngaging cruise control/setting speed
Press the CRUISE button
Press + or - to set the current speed
Increase or decrease speed as desired
OTE: Cruise control will not function at speeds below 22 mph (35 km/h).
raking
ruise control is automatically disengaged when the brake pedal is depressed. The currently set speeored in memory. Quickly pressing resume will return the car to the previously set speed.
cceleration
Momentary acceleration, such as when passing another car, does not affect cruise control operatio
he car will automatically return to the previously set speed when you release the accelerator pedal.
When the cruise control is already engaged, the car's speed can be increased or decreased by holdi
own + or - until the car reaches the desired speed. One short press on either symbol corresponds to
eed change of approximately 1 mph (1.6 km/h).
isengaging cruise control
ruise control can also be disengaged by:
Pressing the CRUISE button.
Putting the gear selector in (N)eutral.
OTE: Cruise control is automatically disengaged if the engine is switched off, if the gear selector i
aced in (N)eutral, if the car's speed drops to under 70% of the currently set speed or if the wheels s
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (7 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
52/233
003 Volvo S60
spin.
emporarily disengaging cruise control
Press 0 to temporarily disengage cruise control. Press "resume" to return to the previously set
eed.
Press the brake pedal. Press "resume" to return to the previously set speed.
WARNING!
Cruise control should not be used in heavy traffic or when driving on wet or slippery roads. Cruise
control may not maintain set speed on steep downgrades.
pg. 37 Instruments and controls
arking brake, electric socket/cigarette lighter
arking brake (hand brake)
he lever is situated between the front seats. The brake is applied to the rear wheels. The indicator li
the instrument panel will light up to indicate when the parking brake is applied. Apply the parking
ake by pulling up firmly on the lever. Release the parking brake by depressing the button at the ende lever and lowering the lever completely.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (8 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
53/233
003 Volvo S60
Auxiliary 12 volt socket
WARNING!
Always use the parking brake (hand brake) when parking. On hills, also turn the front wheels towar
he curb. The indicator light in the instrument panel will light up even if the parking brake is applieonly slightly. Be sure to pull the lever up sufficiently
uxiliary sockets
hese 12 volt sockets can be used to plug in certain accessories such as cellular telephones, etc. The
ust be in position I (or higher) for the auxiliary socket to function.
he auxiliary sockets can also be used for cigarette lighters, which are available at your Volvo retaile
OTE: The cover should be kept on when the auxiliary socket is not in use.
shtrays
olvo cars in North America do not have an ashtray in the front seat as standard equipment. If you w
have an ashtray in the front seat, please contact your Volvo retailer.
pg. 38 Instruments and controls
lectrically operated windows
lectrically operated windows
he electrically operated windows are controlled by buttons in the arm rests. The ignition switch mu
e ON * (ignition key in position I, II or the engine running) for the electrically operated windows to
nction.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (9 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
54/233
003 Volvo S60
o lower: Press down the front edge of the button to the first detent ("stop").
o raise: Lightly pull up the front edge of the button to the first detent ("stop").
The electrically operated windows will also function after the ignition has been switched off as lon
either of the front doors has been opened.
uto up/down function (front doors only):
ther front door window can be opened or closed automatically.
uto down: Press the front part of the button as far down as possible and release it immediately. To
op the window at any time, pull the button up.
uto up: Pull the front part of the button up as far as possible and release it immediately. To stop the
indow at any time, press the button down.
A - front windows,, B - rear windows
OTE: The electrically operated windows in the front seat have an overload protecting circuit break
hich reverses movement of the electrically operated windows to their starting points if they are
bstructed in any way. Thereafter the windows will operate normally again.
WARNING!
Always remove the ignition key when the vehicle is unattended.Make sure that childrens' hands are clear before raising the windows.
Never leave children unattended in the car.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (10 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
55/233
003 Volvo S60
Cutout switch for rear windows
utout switch for rear windows
he electrically operated rear door windows can be disabled by a switch located on the driver's door
ustration).
the LED in the switch is OFF: The rear door windows can be raised or lowered with the buttons
e rear door armrests or with the buttons on the driver's door armrest.
the LED in the switch is ON: The rear door windows can only be raised or lowered with the butt
n the driver's door armrest.
pg. 39 Instruments and controls
lectrically operated window in the front passenger's seat
he control for the electrically operated window in the front passenger's seat operates that window o
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (11 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
56/233
003 Volvo S60
lectrically operated windows in the rear doors.
he rear door windows can be operated with the control on each door and the switch on the driver's
oor. If the LED in the switch for blocking electrically operated windows in the rear doors (located i
e driver's door control panel) is on, the rear door windows can only be operated from the driver's d
pg. 40 Instruments and controls
Rearview mirror/sideview mirrors
earview mirror
Normal position
Night position, reduces glare from following headlights
utodim function (option)
he autodim function reacts to headlights from following traffic and automatically reduces glare.
OTE: This function is automatically switched off when the gear selector is placed in the Reverse
osition.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (12 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
57/233
003 Volvo S60
lectrically operated sideview mirrors
he mirror control switches are located on the driver's door armrest.
river's side: Press the L switch (an LED in the switch will light up) to activate the adjustment cont
nd then use this control to adjust the driver's door mirror.
assenger's door: Press the R switch (an LED in the switch will light up) and then use the adjustme
ontrol to adjust the passenger's door mirror.
fter you have adjusted the mirror(s), press the L or R switch again (the LED will go out) to deactiv
e adjustment control.
WARNING!
The mirrors should always be adjusted prior to driving. Objects seen in the passenger's side wide-
angle sideview mirror are closer than they appear to be.
emote central locking and sideview mirror memory-option
you lock the car and later unlock it with the same remote control and open the driver's door, the
deview mirrors (and the driver's seat) will automatically move to the position they were in when yo
ft the car. This feature will work in the same way with all of the remote control transmitters (up to
at you use with your car. This feature will not function if you lock your car with the key.
pg. 41 Instruments and controls
lectrically operated sun roof (option)
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (13 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
58/233
003 Volvo S60
lectrically operated sun roof
o operate the sun roof, the ignition key must first be turned to the intermediate or drive position
osition I, II or the engine running).
To slide open the sun roof: Pull the switch back to the first detent ("stop") and hold it until the sun
of has opened to the position you prefer. The sun roof will initially open to the "comfort" 1 position
ull and hold the switch again to open the sun roof completely.
A position where the sun roof is not quite fully open which helps alleviate "rumbling" wind noise.
AUTO open: Pull the switch as far back as possible and release it to automatically slide open the s
of to the "comfort" position. Pull the switch again to open the sun roof completely.
To close the sun roof: Push the switch forward to the first detent ("stop") and hold it until the sun r
as closed completely.
AUTO close: Push the switch forward as far as possible and release it to automatically close the su
of.
OTE: If the sun roof is impeded during AUTO close, it will reverse direction, reopen and stop.
Ventilation position (opening the rear edge of the sun roof): With the sun roof closed, push up the
ction of the switch.
o close, pull the front section of the switch straight down until the sun roof has closed completely.
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (14 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
59/233
003 Volvo S60
WARNING!
q Never open/close the sun roof if it is obstructed in any way when in operation.
q Never allow a child to operate the sun roof.
q Never extend any object or body part though the open sun roof, even if the vehicle's ignition is
completely switched off.
q Never leave a child alone in a vehicle.
AUTION:
Remove ice and snow before opening the sun roof.
Do not operate the sun roof if it is frozen closed.
Never place heavy objects on the sun roof.
pg. 42 Instruments and controls
lectrically operated sun roof (option) (contd)
un visor:
he optional sun roof also features a sliding sun visor. The visor slides open automatically when the
of is opened. The visor must be closed manually.
WARNING!
The sun roof must never be obstructed in any way when in
operation.
Contents | Top of Page
ile:///K|/ownersdocs/2003/2003_S60/03s60_02b.htm (15 of 15)12/30/2006 4:13:13 PM
7/15/2019 Volvo S60 manual
60/233
003 Volvo S60
2 0 0 3VOLVO
S60
Climate control
g. 43 Climate control
limate control systems - general information 44
ir distribution 45
lectronic climate control, ECC (2.4T and T5) 46
Manual climate control with air conditioning, (A/
)50
g. 44 Climate control
limate control systems - general information
ondensation on the inside of the windows
eeping the insides of the windows clean will help reduce the amount of condensation that forms on the windo
se a commercial window cleaning agent to clean the windows.
e and snowways keep the air intake grille at the base of the windshield free of snow.
abin air filter
eplace the cabin air filter with a new one at the recommended intervals. The filter should be replaced more of
hen driving under dirty and dusty conditions. The filter cannot be cleaned and therefore should always be
placed with a new one.
nsors
he sunlight sensor on the dashboard and passenger compartment temperature sensor in the ECC control panel
ould not be covered in any way as this could cause incorrect information to be sent to the ECC system.
arking the car in warm weather
your car has been parked in the sun in warm weather, opening the windows and sun roof (option) for several
nutes before driving will help release the warm air from the passenger compartment. When the engine is run
ose the windows and sun roof and use the recirculation function for several minutes to enable the air conditio
cool the compartment as quickly as possible.
indows and optional sun roof
he ECC system (2.4T and T5 models only) will function best if the windows and optional sun roof are closed
ile:///K|/ownersdocs/2003/2003_S60/03s60_03.htm (1 of 10)12/30/2006 4:13:14 PM
7/15/2019 Volvo S60 manual
61/233
003 Volvo S60
u drive with the sun roof open, we recommend that you manually adjust the temperature and blower control
ED in the AUTO switch should be off).
cceleration
he air conditioning is momentarily disengaged during full-throttle acceleration.
imate control maintenance
l maintenance on the climate contro