Concentric Slave Cylinder Catalogue CSC - ABES SCORPIO 2.0 SUV 90kw (F4R) 05- CSMH01 MAZDA SOHO 1.3i 96-98 CSMZ01 1.4i 98-01 CSMZ01 MERCEDES BENZ A-CLASS APPLICATION YEAR ABES P/N

2015

Concentric Slave Cylinder Catalogue

CSC

Warning

Do not manually depress the CSC.

This action will cause damage to the seals.

Incorrect handling will cancel the warranty,

of both the CSC and the Clutch kit.

General fitting procedure for Concentric Slave Cylinders (CSC)

The fitment of a Concentric Slave Cylinder CSC must be carried out in a clean area.

Clean the inside and outside of the bell housing / gearbox. Also clean the pipe work and couplings to

the CSC.

Make sure that everything that has been cleaned is then dried off and no cleaning fluid or solvents is

left behind.

Check that the couplings of the new and old CSC are the same. There are CSC’s which are the same

shape and size but the coupling varies in diameter.

Closely inspect the gearbox input sleeve; it must be clean and smooth. There must be no burrs or

any other damage to the input sleeve.

Check that the clutch plate is installed the correct way around. Some clutch plates have longer

bosses on the engine side. If this type of clutch plate is installed incorrectly and the longer boss is on

the gear box side it could foul against the CSC. This will damage the CSC and the warranty will be

void.

Install the CSC to the gearbox.

Do not remove any plugs that may be blanking off the connections before the CSC is installed. Make

sure that the CSC is installed flat against the mounting surface. Any face seal or rubber sealant that is

used should be in accordance with the vehicle manufacture’s specification. If the CSC is not seated

correctly the back face plate can push out, this will cause a failure.

Note:

That some CSC’s have an input sleeve seal built in. This seal must be lubricated. Failure to lubricate

the seal will result in damage and the seal will leak.

Flush the hydraulic system including the master cylinder and connecting piping. This is to ensure that

there is no contamination in the system that can damage the CSC.

Connect the piping to the CSC and refill the system with the correct specification hydraulic fluid.

Do not use a “Brake bleeding device” or “Power assisted bleeding device”.

Bleeding of the CSC system cannot be carried out by using a brake bleeding devise as it will cause the

system to over pressurize, this will result in damage to the system and seals. This will void the

warranty. The CSC must then be replaced once it has been over pressurized.

Cont.…

Do not pump the clutch pedal. Repeated pumping of the clutch during the bleeding process can

cause the CSC to over stroke.

Depress the clutch pedal wait a short period for the system to stabilize. Open the bleeding screw or

nipple and release any air. Close the bleeding screw, release the clutch pedal. This process must be

repeated until the air is out of the system. This will take +/- 20 repeats to fully bleed the system.

Remember to top up the hydraulic fluid in the reservoir.

Whilst every precaution has been taken to ensure the accuracy whilst compiling this

information, ABES Technoseal disclaims all liability for the consequences of this

information that may be incorrect.

Guarantee.

With the correct fitment procedures and proper driving, this Concentric Slave

Cylinder will give a long period of trouble free service. All ABES Technoseal

Concentric Slave Cylinders are guaranteed for 12 months from date of supply,

against defects or faulty workmanship. This does not include failure due to

incorrect installation, abuse or misuse. This guarantee is limited to

replacement of faulty parts only, and we accept no liability for consequential

damage or labour costs.

APPLICATION YEAR ABES P/N

ALFA ROMEO 147

2.0 16 Valve Twin Spark 110 kw (AR32310) 00-09 CSAL01

156

2.0 16 Valve Selespeed 110 kw (AR937A1) 03- CSAL01

156 2.0 16 valve Twin Spark 114kw 98-02 CSAL01

159

1.8 TBi 16 Valve 147kw (939B1) 11- CSAL03

1.9 JTS 113kw 06-09 CSAL02

2.2 JTS 135kw 06-09 CSAL02

BRERA

2.2 JTS 135kw 06-10 CSAL02

MITO

1.4 Turbo 114kw (199A8) 09- CSAL03

SPIDER

2.2 JTS 135kw 07-10 CSAL02

AUDI A3

1.8 T 20 Valve 132kw 6 Speed 99-03 CSVW02

1.8 T FSi 118kw 6 Speed (CDAA) 08- CSVW02

2.0 T FSi 147kw (AXX, BWA, CAWB) 04- CSVW02

2.0 TDi 103kw (AVZ, BKD, BMM) 03-10 CSVW02

3.2 V6 Quattro 184kw (BDB, BMJ) 04-08 CSVW02

S3

1.8 T Quattro 20 Valve 165kw 6 Speed (BAM) 01-05 CSVW02

2.0 TFSi Quatro 188kw (BZC, CDLC) 07- CSVW02

TT

1.8 T Quattro 20 Valve 165kw 6 Speed (APX, BAM) 01-06 CSVW02

2.0 T FSi 147kw (AXX, BWA, CAWB) 04- CSVW02

2.0 T FSi 200kw (CDLB) 09- CSVW02

3.2 V6 Quattro 184kw (BUB) 07-10 CSVW02

CHEV CAPTIVA

2.0 D 07- CSCH01

2.4 D 07- CSCH02

OPTRA

1.6 (F16) 08- CSCH03

FIAT CORMA

2.2i 16 Valve 108kw (194A1) 06- CSFT02

GRANDE PUNTO

1.9 MJT 88kw (939A1) 06-08 CSFT01

FORD BANTAM

1.3i (Rocam) 02- CSFD01

1.6i (Rocam) 02- CSFD01

1.8 Diesel (YD18 TCI) 02-05 CSFD01

FIESTA

1.3 (Endura) 96-98 CSFD01

1.3 (Rocam) 01-04 CSFD01

1.4i 98-01 CSFD01

1.4i 16 Valve 59kw (Duratec ,FXJB) 01-04 CSFD06

1.4i 16 Valve 04-10 CSFD06

1.4i 16 Valve 71kw (SPJA,SPJC) 08- CSFD06

1.6i (Rocam) 00-04 CSFD01

1.6i RSi (Rocam) 00-04 CSFD01

1.6i 16 Valve 04-08 CSFD03

1.6TDCi 16 Valve 66kw (HHJA) 08- CSFD06


1.6Ti-VCT 16 Valve 88kw (HXJA) 08- CSFD06

ST 150 2.0i 16 Valve 110kw (N4JB) 04-08 CSFD03

NOTE: THERE ARE DIFFERENT COUPLING NOZZELS FOR THE ABOVE. PLEASE CHECK BEFORE FITTING

CSFD01 11mm pipe fitting


FOCUS

1.6 16 Valve 74kw (Duretec) 03-05 CSFD01

1.6 16 Valve 74kw 03-05 CSFD06

1.8 TDCi 85kw (KKDA) 04-05 CSFD02

2.0 16 Valve 96kw (Duretec) 00-05 CSFD01

2.0 16 Valve 96kw (Zetec) 00-05 CSFD02

2.0 16 Valve 96kw 00-05 CSFD06




FOCUS II

2.0 16 Valve 107kw (AODA, AODB) 01-08 CSFD05

2.0 16 Valve 107kw 08-10 CSFD05

ST 2.5 Turbo 166kw (B5254T3) 02-10 CSFD08

FOCUS III

2.0 GDi Sport 11-12 CSFD08

IKON



1.6i (Duretec) 08- CSFD01

1.6i (Duretec) 08- CSFD03




KA






MONDEO II

1.8i 16 Valve (Zetec ) 97-01 CSFD04

2.0i (Zetec ) 97-01 CSFD04

MONDEO III

2.0i 16 Valve Ghia (Duratec) 00-02 CSFD04

2.0i 16 Valve Ghia 107kw 02-06 CSFD04

3.0 ST220 166kw (Duratec, MEBA) 03-07 CSFD04

LAND ROVER FREELANDER

2.0 Td 84kw (M47) 00-07 CSLR01

FREELANDER 2

2.2 Td4 118kw (DW12T) 07- CSLR02

MAHINDRA SCORPIO

2.0 SUV 90kw (F4R) 05- CSMH01

MAZDA SOHO

1.3i 96-98 CSMZ01

1.4i 98-01 CSMZ01

MERCEDES BENZ A-CLASS


W168

A160 75kw (M166.96) 00-05 CSMB03

A190 92kw (M166.99) 00-05 CSMB03

W169

A170 85kw (M266.94) 05-09 CSMB03

A180 85kw (M266.94) 05-09 CSMB03

A200 100kw (M266.96) 05-12 CSMB03

B-CLASS

W245

B170 85kw (M266.94) 07- CSMB03

B180 85kw (M266.96) 06- CSMB03

B200 100kw (M266.96) 09-11 CSMB03

C-CLASS

W203

C180 00-02 CSMB01

C180 Kompressor 02-07 CSMB01


C220 CDi 02-07 CSMB01

C230K 02-07 CSMB01

W204

C180 Kompressor 08- CSMB01

C200 Kompressor 08- CSMB01

C200 CDI 100kw 11- CSMB01

C220 CDI 125kw 08-10 CSMB01

C250 CDI 150kw 11- CSMB01

C203



R 170

SLK 200K 05-10 CSMB01

R 171

SLK 200K 05-10 CSMB01

SPRINTER

308CDI 2.2 TDi Minibus, Panel van (OM611, OM612) 00-07 CSMB01

309CDI Bus, Panel van (om646) 07- CSMB01

311CDI 2.2TDi Minibus, Panel van, Truck (OM611) 00-07 CSMB01

313CDI Bus, Panel van (OM646) 07- CSMB01

318CDI Bus, Panel van (OM642) 07- CSMB01

411CDI 2.2 TDi Bus, Panel van, Truck (OM611) 00-04 CSMB01

413CDI 2.2 TDi Bus, Panel van, Truck (OM611) 00-04 CSMB01

416CDI 2.7 TDi Panel van, Truck (OM612) 00-04 CSMB01

515CDI 2.2 TDi Bus, Panel van (OM646) 07- CSMB01

518CDI 2.2 TDi Bus, Panel van (OM642) 07- CSMB01

616CDI 2.7 TDi Truck (OM612) 00-04 CSMB01

VITO

112CDI Minibus 2.2 TD (OM611) 02-04 CSMB02

115CDI 2.2 TDI Minibus & Crewbus (OM646) 04- CSMB01

NISSAN GRAND LAVINA

1.6i (HR16DE) 07- CSNS02

INTERSTAR

2.5 dCi 84kw (G9U.720) 04- CSNS04

2.5 DCi Turbo 84kw Panel van(G9U) 06- CSNS01

JUKE

1.6i 16 Valve (HR16DE) 11- CSNS02

LAVINA

1.6i (HR16DE) 08- CSNS02


MICRA

1.4i 16 Valve 65kw (CR14DE) 04-10 CSNS02

1.5dCi 60kw (K9K.722) 06-10 CSNS02

NP200

1.6 8 Valve 64kw (K7M710) 09- CSNS02

1.6 16Valve 77kw (K4M690) 09- CSNS02

PRIMASTAR

1.9 dCi 100 74kw (F9Q.760) 08- CSNS04

QASHQAI

1.6i 16 Valve 84kw (HR16DE) 07- CSNS02

2.0i 104kw (MR20DE) 07- CSNS03

2.0 dCi 110kw (M9R.830) 08- CSNS03

TIIDA



X-TRAIL

2.0i 104kw (MR20DE) 07- CSNS03

2.0 dCi 110kw (M9R.830) 08- CSNS03

2.5 125kw (QR25DE) 08- CSNS03

OPEL ASTRA G

2.0 16 Valve CDX F18 Gearbox 99-05 CSOP03

2.0 16 Valve CDX F23 Gearbox 01-05 CSOP04

2.0 16 Valve CSX F18 Gearbox 99-05 CSOP03

2.0 16 Valve CSX F23 Gearbox 01-05 CSOP04

2.0 16 Valve Turbo Coupe 01-05 CSOP04

2.2 16 Valve 02-05 CSOP04

ASTRA H

1.4i 05-09 CSOP02

1.9 CDTi 88kw - 100kw (Z19DTH, Z19DTJ) 05-09 CSOP05

2.0 Turbo 125kw (Z20LEL) 05-09 CSOP07

2.0 GTC T urbo 147kw (Z20LER) 05-09 CSOP07

GTC 2.0 Turbo 177kw (Z20LEH) 05-09 CSOP05

CORSA C

1.7CDTi 02-08 CSOP04

CORSA C COMMERCIAL

1.4i 66kw (Z14XEP) PANEL VAN 04- CSOP02

CORSA D

1.3 CDTi 66kw (Z13DTH) 08- CSOP07

1.4i 66kw (Z14XEP) 08- CSOP02

1.6i Turbo 110kw (Z16LEL) 08- CSOP07

1.6 OPC Turbo 141kw (Z16LER) 08- CSOP07

MERIVA B

1.4 T 103kw (A14NET, B14NET) 12- CSOP07

MOVANO

2.5DTi 84kw (G9U.720) 04- CSOP06

2.5DTi 84kw (G9U.7.20, G9U.7.24,G9U.7.54) 05- CSOP08

VIVARO

1.9DTi 74kw (F9Q.760) 07- CSOP06

1.9DTi 74kw Turbo diesel (F9Q760) 07- CSOP08

ZAFIRA

2.0 16 Valve OPC (LET) 05- CSOP04

2.2 16 Valve 02-05 CSOP04

ZAFIRA II

1.9 CDTi 100kw (Z19DTH) 06- CSOP05

2.0 OPC Turbo 177kw (Z20LEH) 07- CSOP05

RENAULT


CLIO III

1.4i 16 Valve 72kw (K4J) 06- CSRN03

1.4i 16 Valve 72kw (K4J) 06- CSRN04

1.4i 16 Valve 72kw ( K4J740) 06- CSRN01

1.5 dCi 60kw (K9K750) 06-10 CSRN01

1.5dCi 60kw (K9K.750) 06-10 CSRN04

1.6i 16 Valve 83kw (K4M800 & K4M801) 06- CSRN01

1.6i 16 Valve 83kw (K4M.800, 801, 804) 06- CSRN03

1.6i 16 Valve 83kw (K4M.800, 801, 804) 06- CSRN04

2.0i 16 Valve Sport 145kw (F4R.830) 07- CSRN06


KOLEOS

2.0 dCi 16 Valve 110kw (M9R.830) 08- CSRN06

2.5i 16 Valve 126kw (2TR2.700, 702, 703) 08- CSRN06

LAGUNA

2.0 94kw (F4R712) 03-06 CSRN01

2.0 Turbo 125kw(F4R) 06-09 CSRN07


LAGUNA II

1.8i 80kw (F4P.770) 03-04 CSRN03

2.0i 98kw (F4R) 03-06 CSRN03

2.0 Turbo 125kw (F4R.784) 06-10 CSRN06

MEGANE II

1.5 dCi 60kw (K9K.724) 03- CSRN04

1.6i 16 Valve 83kw (K4M.760) 03- CSRN04

1.9dCi 88kw (F9Q.750) 03-08 CSRN02

1.9dCi 88kw (F9Q.800) 08-09 CSRN02

2.0i 100kw (F4R.770) 03-08 CSRN02

2.0i Turbo 16 Valve 165kw (F4R.774) 06- CSRN02

MEGANE III

1.9dCi 96kw (F9Q.803) 09- CSRN02

MODUS

1.2i 16 Valve 55kw (D4F.740) 05-06 CSRN04

1.4i 16 Valve 72kw (K4J.770) 05-08 CSRN04

SCENIC

1.9dCi 75kw (F9Q.750) 01-04 CSRN03

2.0i 16 Valve 102kw (N7Q.700) 01-04 CSRN03


SCENIC II

1.6i 16 Valve 85kw (K4M.770) 03-08 CSRN02

1.6i 16 Valve 85kw (K4M.770) 03-08 CSRN04

1.9dCi 88kw (F9Q.8.70, F9Q.72) 04-08 CSRN07

1.9dCi 88kw (F9Q.812) 04-08 CSRN02

2.0i 16 Valve 100kw (F4R.771) 03-08 CSRN02


SCENIC III

1.6i 16 Valve 81kw (K4M.858) 09- CSRN04

TRAFFIC

1.9dCi Turbo diesel 74kw (F9Q.7.60,F9Q 7.62) (3 BOLT HOLES) 07- CSRN07

1.9dCi 100 74kw (F9Q.760) (2 BOLT HOLES) 07- CSRN06

SEAT

ALTEA

2.0 TDi 103kw (BMM, BMN) 06-08 CSVW02

IBIZA

1.9 TDi 96kw (ASZ, BLT) 06-08 CSVW02

1.9 TDi Cupra 118kw (BPX, BUK) 06-08 CSVW02

LEON


2.0 TDi 103kw (BMM, BMN) 06-08 CSVW02

2.0 T FSi 147kw (BWA) 06-08 CSVW02

2.0 T FSi Cupra 177kw (BWJ) 06-08 CSVW02

VOLVO

C30

2.0i 107kw (B4204-S3) 05-07 CSVL02

2.0i 107kw (B4204-S3) 07- CSVL02

2.5 T5 165kw (B5254T7) 07- CSVL04

C70

2.3i T5 Turbo 20 Valve 176kw (B5234T3) 98-02 CSVL01

2.5 T5 169kw (B5254T7) 06- CSVL04

S40

2.0i 100kw (B4204S2) 97-03 CSVL01

2.0i T 121kw (B4204T3) 98-04 CSVL01

2.0i T4 147kw (B4204T5) 98-00 CSVL01

S40 II

1.8i 92kw (B4184S8, S11) 05-07 CSVL02

1.8i 92kw (B4184S8, S11) 07- CSVL02

2.0i 100kw 04-07 CSVL01

2.0 Turbo Diesel 100kw (D4204T) 05- CSVL05

2.0i 107kw (B4204S3) 05-07 CSVL02

2.0i 107kw (B4204S3) 07- CSVL02

2.4i 125kw (B5244S4) 04-07 CSVL05

2.5 T5 `165kw (B5254T3) 04-07 CSVL04

S60

2.0i Turbo 20 Valve 132kw (B5204T5) 01-10 CSVL01


2.4i 20 Valve 124kw (B5244S) 00-01 CSVL01

2.4i Turbo 20 Valve 147kw (5244T3) 02-03 CSVL01


S60 II

2.0 D3 120kw (D5204T2) 11- CSVL04

V40

2.0i Turbo 121kw (B4204S) 97-00 CSVL01

2.0i T4 147kw (B4204T5) 98- CSVL01

V50

2.0 Diesel 100kw (D4204T) 05- CSVL05

2.5 T5 165kw (B5254T3) 05- CSVL04

V60

2.0D3 120kw (D5204T2) 11- CSVL04

V70

2.0i Turbo 132kw (B5202S) 04- CSVL01

2.4i 20 Valve 125kw (B5244S) 00- CSVL01

2.4i Turbo 20 Valve 147kw (B5244T) 00- CSVL01

XC60

2.0D3 120kw (D5204T2) 11- CSVL04

2.4D 129kw (D5244T14) 09-10 CSVL04

XC70

2.4i Turbo 20 Valve AWD 147kw (B5244T3) 00-02 CSVL01

2.5 Turbo 20 Valve AWD 154kw (B5254T2) 03-08 CSVL01

VOLKSWAGEN

CARAVELLE T4

2.5 TDi, Syncro 4x4 Turbo Diesel 75kw (ACV) 99-05 CSVW01

CARAVELLE T5

2.0 TDi 103kw (CAAC, CCHA) 10- CSVW02


2.5 TDi, 96kw (AXE) 05-10 CSVW02

2.5 TDi, Syncro 4x4 Turbo Diesel 128kw (AXD) 05-10 CSVW02

CRAFTER

30-35 Bus 2.5TDi 80kw (BJK) 06- CSVW03

30-35 Bus 2.5TDi 120kw (BJM) 06- CSVW03

EOS

2.0 T FSi 147kw (CAWB, CCTZ, CCZA) 08- CSVW02

GOLF 4

1.8 GTi 132kw 6 Speed (AGN) 99-04 CSVW02

GOLF 5

2.0 GTi 147kw (AXX, BWA, CAWB) 05-10 CSVW02

2.0 TDi 103kw (AZV) 05-10 CSVW02

GOLF 6

2.0 TDi 103kw (CBAB) 10- CSVW02

2.0 GTi 155kw (CCZB, CDLF) 09- CSVW02

JETTA 4

1.8T Executive 132kw 6 Speed (AUQ) 01-04 CSVW02

JETTA 5

2.0 TFSi 147kw (BWA, BPY) 05- CSVW02

2.0 TDi Sport 103kw (BKD) 05-11 CSVW02

JETTA 6

2.0 TDi 103kw (CFFB) 11- CSVW02

PASSAT

1.8 TSi 118kw (CDAA) 08- CSVW02

2.0 TDi 103kw (BKP) 05- CSVW02

2.0 TDi 125kw (BMP) 05- CSVW02

2.0 T FSi 147kw 05- CSVW02

PASSAT CC

2.0 TSi 147kw (CAWB, CCZA) 09- CSVW02

SHARAN

1.8 Turbo 110kw (AJH) 99-00 CSVW04

1.9 TDi (AHU,ANU,AUY 03-06 CSVW04

2.8 VR6 128kw (AAA, AMY) 99-00 CSVW04

Buyers GuideABES P/N APPLICATION YEAR

CSAL01 ALFA 147 2.0 16 Valve Twin Spark 110 kw (AR32310) 00‐09

CSAL01 ALFA 156 2.0 16 Valve Selespeed 110 kw (AR937A1) 03‐

CSAL01 156 2.0 16 valve Twin Spark 114kw 98‐02

CSAL02 ALFA 159 1.9 JTS 113kw 06‐09

CSAL02 ALFA 159 2.2 JTS 135kw 06‐09

CSAL02 ALFA BRERA 2.2 JTS 135kw 06‐10

CSAL02 ALFA SPIDER 2.2 JTS 135kw 07‐10

CSAL03 ALFA 159 1.8 TBi 16 Valve 147kw (939B1) 11‐

CSAL03 ALFA MITO 1.4 Turbo 114kw (199A8) 09‐

NO IMAGE CSCH01 CHEV CAPTIVA 2.0 D 07‐

CSCH02 CHEV CAPTIVA 2.4 D 07‐

CSCH03 CHEV OPTRA 1.6 (F16) 08‐

CSFD01 FORD BANTAM 1.3i (Rocam) 02‐

CSFD01 FORD BANTAM 1.6i (Rocam) 02‐

CSFD01 FORD BANTAM 1.8 Diesel (YD18 TCI) 02‐05

CSFD01 FORD FIESTA 1.3 (Endura) 96‐98

CSFD01 FORD FIESTA 1.3 (Rocam) 01‐04

11mm pipe fitting CSFD01 FORD FIESTA 1.4i 98‐01

CSFD01 FORD FIESTA 1.6i (Rocam) 00‐04

CSFD01 FORD FIESTA 1.6i RSi (Rocam) 00‐04

CSFD01 FORD FOCUS 1.6 16 Valve 74kw (Duretec) 03‐05

CSFD01 FORD FOCUS 2.0 16 Valve 96kw (Duretec) 00‐05

CSFD01 FORD IKON 1.3i (Rocam) 01‐07

CSFD01 FORD IKON 1.6i (Rocam) 01‐07

CSFD01 FORD IKON 1.6i (Duretec) 08‐

CSFD01 FORD KA 1.3i (Rocam) 05‐09

CSFD02 FORD FOCUS 1.8 TDCi 85kw (KKDA) 04‐05

CSFD02 FORD FOCUS 2.0 16 Valve 96kw (Zetec) 00‐05

CSFD03 FORD FIESTA 1.6i 16 Valve 04‐08

CSFD03 FORD FIESTA ST 150 2.0i 16 Valve 110kw (N4JB) 04‐08

CSFD03 FORD IKON 1.6i (Duretec) 08‐

CSFD03 FORD KA 1.3i (Rocam) 05‐09

CSFD04 FORD MONDEO II 1.8i 16 Valve (Zetec ) 97‐01

CSFD04 FORD MONDEO II 2.0i (Zetec ) 97‐01

CSFD04 FORD MONDEO III 2.0i 16 Valve Ghia (Duratec) 00‐02

CSFD04 FORD MONDEO III 2.0i 16 Valve Ghia 107kw 02‐06

CSFD04 FORD MONDEO III 3.0 ST220 166kw (Duratec, MEBA) 03‐07

CSFD05 FORD FOCUS II 2.0 16 Valve 107kw (AODA, AODB) 01‐08

CSFD05 FORD FOCUS II 2.0 16 Valve 107kw 08‐10

CSFD06 FORD FIESTA 1.4i 16 Valve 59kw (Duratec ,FXJB) 01‐04

CSFD06 FORD FIESTA 1.4i 16 Valve 04‐10

CSFD06 FORD FIESTA 1.4i 16 Valve 71kw (SPJA,SPJC) 08‐

CSFD06 FORD FIESTA 1.6 TDCi 16 Valve 66kw (HHJA) 08‐

CSFD06 FORD FIESTA 1.6 Ti‐VCT 16 Valve 88kw (HXJA) 08‐

12mm pipe fitting CSFD06 FORD FOCUS 1.6 16 Valve 74kw 03‐05

CSFD06 FORD FOCUS 2.0 16 Valve 96kw 00‐05

ABES P/N APPLICATION YEAR

CSFD08 FORD FOCUS II ST 2.5 Turbo 166kw (B5254T3) 02‐10

CSFD08 FORD FOCUS III 2.0 GDi Sport 11‐12

CSFT01 FIAT GRANDE PUNTO 1.9 MJT 88kw (939A1) 06‐08

CSFT02 FIAT CORMA 2.2i 16 Valve 108kw (194A1) 06‐

CSLR01 LANDROVER FREELANDER 2.0 Td 84kw (M47) 00‐07

CSLR02 LANDROVER FREELANDER 2 2.2 Td4 118kw (DW12T) 07‐

CSMB01 MERCEDES BENZ C‐CLASS W203 C180 00‐02

CSMB01 MERCEDES BENZ C‐CLASS W203 C180 Kompressor 02‐07

CSMB01 MERCEDES BENZ C‐CLASS W203 C200 Kompressor 02‐07

CSMB01 MERCEDES BENZ C‐CLASS W203 C220 CDi 02‐07

CSMB01 MERCEDES BENZ C‐CLASS W203 C230K 02‐07

CSMB01 MERCEDES BENZ C‐CLASS W204 C180 Kompressor 08‐

CSMB01 MERCEDES BENZ C‐CLASS W204 C200 Kompressor 08‐

CSMB01 MERCEDES BENZ C‐CLASS W204 C200 CDI 100kw 11‐

CSMB01 MERCEDES BENZ C‐CLASS W204 C220 CDI 125kw 08‐10

CSMB01 MERCEDES BENZ C‐CLASS W204 C250 CDI 150kw 11‐

CSMB01 MERCEDES BENZ C‐CLASS C203 C230 Kompressor 01‐02

CSMB01 MERCEDES BENZ C‐CLASS C203 C230 Kompressor 02‐05

CSMB01 MERCEDES BENZ R170 SLK 200K 05‐10

CSMB01 MERCEDES BENZ R171 SLK 200K 05‐10

CSMB01 MERCEDES BENZ SPRITER 308CDI 2.2 TDi Minibus, Panel van (OM611, OM612) 00‐07

CSMB01 MERCEDES BENZ SPRITER 309CDI Bus, Panel van (om646) 07‐

CSMB01 MERCEDES BENZ SPRITER 311CDI 2.2TDi Minibus, Panel van, Truck (OM611) 00‐07

CSMB01 MERCEDES BENZ SPRITER 313CDI Bus, Panel van (OM646) 07‐

CSMB01 MERCEDES BENZ SPRITER 318CDI Bus, Panel van (OM642) 07‐

CSMB01 MERCEDES BENZ SPRITER 411CDI 2.2 TDi Bus, Panel van, Truck (OM611) 00‐04

CSMB01 MERCEDES BENZ SPRITER 413CDI 2.2 TDi Bus, Panel van, Truck (OM611) 00‐04

CSMB01 MERCEDES BENZ SPRITER 416CDI 2.7 TDi Panel van, Truck (OM612) 00‐04

CSMB01 MERCEDES BENZ SPRITER 515CDI 2.2 TDi Bus, Panel van (OM646) 07‐

CSMB01 MERCEDES BENZ SPRITER 518CDI 2.2 TDi Bus, Panel van (OM642) 07‐

CSMB01 MERCEDES BENZ SPRITER 616CDI 2.7 TDi Truck (OM612) 00‐04

CSMB01 MERCEDES BENZ VITO 115CDI 2.2 TDI Minibus & Crewbus (OM646) 04‐

CSMB02 MERCEDES BENZ VITO 112CDI Minibus 2.2 TD (OM611) 02‐04

CSMB03 MERCEDES BENZ A‐CLASS W168 A160 75kw (M166.96) 00‐05





CSMB03 MERCEDES BENZ B‐CLASS W245 B170 85kw (M266.94) 07‐

CSMB03 MERCEDES BENZ B‐CLASS W245 B180 85kw (M266.96) 06‐

CSMB03 MERCEDES BENZ B‐CLASS W245 B200 100kw (M266.96) 09‐11

CSMH01 MAHINDRA SCORPIO 2.0 SUV 90kw (F4R) 05‐


CSMZ01 MAZDA SOHO 1.3i 96‐98

CSMZ01 MAZDA SOHO 1.4i 98‐01

CSNS01 NISSAN INTERSTAR 2.5 DCi Turbo 84kw Panel van(G9U) 06‐

CSNS02 NISSAN GRAND LAVINA 1.6i (HR16DE) 07‐

CSNS02 NISSAN JUKE 1.6i 16 Valve (HR16DE) 11‐

CSNS02 NISSAN LAVINA 1.6i (HR16DE) 08‐

CSNS02 NISSAN MICRA 1.4i 16 Valve 65kw (CR14DE) 04‐10

CSNS02 NISSAN MICRA 1.5dCi 60kw (K9K.722) 06‐10

CSNS02 NISSAN NP200 1.6 8 Valve 64kw (K7M710) 09‐

CSNS02 NISSAN NP200 1.6 16Valve 77kw (K4M690) 09‐

CSNS02 NISSAN QASHQAI 1.6i 16 Valve 84kw (HR16DE) 07‐

CSNS02 NISSAN TIIDA 1.6i 16 Valve 81kw (HR16DE) 06‐

CSNS03 NISSAN QASHQAI 2.0i 104kw (MR20DE) 07‐

CSNS03 NISSAN QASHQAI 2.0 dCi 110kw (M9R.830) 08‐

CSNS03 NISSAN TIIDA 1.6i 16 Valve 81kw (HR16DE) 06‐

CSNS03 NISSAN X‐TRAIL 2.0i 104kw (MR20DE) 07‐

CSNS03 NISSAN X‐TRAIL 2.0 dCi 110kw (M9R.830) 08‐

CSNS03 NISSAN X‐TRAIL 2.5 125kw (QR25DE) 08‐

CSNS04 NISSAN INTERSTAR 2.5 dCi 84kw (G9U.720) 04‐

CSNS04 NISSAN PRIMASTAR 1.9 dCi 100 74kw (F9Q.760) 08‐

CSOP02 OPEL CORSA C 1.4i 05‐09

OPEL ASTRA H1.4i 05‐09

OPEL CORSA C COMMERCIAL 1.4i 66kw (Z14XEP) PANEL VAN 04‐

CSOP03 OPEL ASTRA G 2.0 16 Valve CDX F18 Gearbox 99‐05

OPEL ASTRA G 2.0 16 Valve CSX F18 Gearbox 99‐05

CSOP04 OPEL ASTRA G 2.0 16 Valve CDX F23 Gearbox 01‐05

CSOP04 OPEL ASTRA G 2.0 16 Valve CSX F23 Gearbox 01‐05

CSOP04 OPEL ASTRA G 2.0 16 Valve Turbo Coupe 01‐05

CSOP04 OPEL ASTRA G 2.2 16 Valve 02‐05

CSOP04 OPEL CORSA C 1.7CDTi 02‐08

CSOP04 OPEL ZAFIRA 2.0 16 Valve OPC (LET) 05‐

CSOP04 OPEL ZAFIRA 2.2 16 Valve 02‐05

CSOP05 OPEL ASTRA H 1.9 CDTi 88kw ‐ 100kw (Z19DTH, Z19DTJ) 05‐09

CSOP05 OPEL ASTRA H GTC 2.0 Turbo 177kw (Z20LEH) 05‐09

CSOP05 OPEL ZAFIRA II 1.9 CDTi 100kw (Z19DTH) 06‐

CSOP05 OPEL ZAFIRA II 2.0 OPC Turbo 177kw (Z20LEH) 07‐

CSOP06 OPEL MOVANO 2.5DTi 84kw (G9U.720) 04‐

CSOP06 OPEL VIVARO 1.9DTi 74kw (F9Q.760) 07‐

CSOP07 OPEL ASTRA H 2.0 Turbo 125kw (Z20LEL) 05‐09

CSOP07 OPEL ASTRA H 2.0 GTC T urbo 147kw (Z20LER) 05‐09

CSOP07 OPEL CORSA D 1.3 CDTi 66kw (Z13DTH) 08‐

CSOP07 OPEL CORSA D 1.6i Turbo 110kw (Z16LEL) 08‐

CSOP07 OPEL CORSA D 1.6 OPC Turbo 141kw (Z16LER) 08‐

CSOP07 OPEL MERIVA B 1.4 T 103kw (A14NET, B14NET) 12‐


CSOP08 OPEL MOVANO 2.5DTi 84kw (G9U.7.20, G9U.7.24,G9U.7.54) 05‐

CSOP08 OPEL VIVARO 1.9DTi 74kw Turbo diesel (F9Q760) 07‐

CSRN01 RENAULT CLIO III 1.4i 16 Valve 72kw ( K4J740) 06‐

CSRN01 RENAULT CLIO III 1.5 dCi 60kw (K9K750) 06‐10

CSRN01 RENAULT CLIO III 1.6i 16 Valve 83kw (K4M800 & K4M801) 06‐

CSRN01 RENAULT LAGUNA 2.0 94kw (F4R712) 03‐06

CSRN02 RENAULT MEGANE II 1.9dCi 88kw (F9Q.750) 03‐08

CSRN02 RENAULT MEGANE II 1.9dCi 88kw (F9Q.800) 08‐09

CSRN02 RENAULT MEGANE II 2.0i 100kw (F4R.770) 03‐08

CSRN02 RENAULT MEGANE II 2.0i Turbo 16 Valve 165kw (F4R.774) 06‐

CSRN02 RENAULT MEGANE III 1.9dCi 96kw (F9Q.803) 09‐

CSRN02 RENAULT SCENIC II 1.6i 16 Valve 85kw (K4M.770) 03‐08

CSRN02 RENAULT SCENIC II 1.9dCi 88kw (F9Q.812) 04‐08

CSRN02 RENAULT SCENIC II 2.0i 16 Valve 100kw (F4R.771) 03‐08

CSRN03 RENAULT CLIO III 1.4i 16 Valve 72kw (K4J) 06‐

CSRN03 RENAULT CLIO III 1.6i 16 Valve 83kw (K4M.800, 801, 804) 06‐

CSRN03 RENAULT LAGUNA II 1.8i 80kw (F4P.770) 03‐04

CSRN03 RENAULT LAGUNA II 2.0i 98kw (F4R) 03‐06

CSRN03 RENAULT SCENIC 1.9dCi 75kw (F9Q.750) 01‐04

CSRN03 RENAULT SCENIC 2.0i 16 Valve 102kw (N7Q.700) 01‐04

CSRN04 RENAULT CLIO III 1.4i 16 Valve 72kw (K4J) 06‐

CSRN04 RENAULT CLIO III 1.5dCi 60kw (K9K.750) 06‐10

CSRN04 RENAULT CLIO III 1.6i 16 Valve 83kw (K4M.800, 801, 804) 06‐

CSRN04 RENAULT MEGANE II 1.5 dCi 60kw (K9K.724) 03‐

CSRN04 RENAULT MEGANE II 1.6i 16 Valve 83kw (K4M.760) 03‐

CSRN04 RENAULT MODUS 1.2i 16 Valve 55kw (D4F.740) 05‐06

CSRN04 RENAULT MODUS 1.4i 16 Valve 72kw (K4J.770) 05‐08

CSRN04 RENAULT SCENIC II 1.6i 16 Valve 85kw (K4M.770) 03‐08

CSRN04 RENAULT SCENIC III 1.6i 16 Valve 81kw (K4M.858) 09‐

CSRN06 RENAULT CLIO III 2.0i 16 Valve Sport 145kw (F4R.830) 07‐

CSRN06 RENAULT KOLEOS 2.0 dCi 16 Valve 110kw (M9R.830) 08‐

CSRN06 RENAULT KOLEOS 2.5i 16 Valve 126kw (2TR2.700, 702, 703) 08‐

CSRN06 RENAULT LAGUNA II 2.0 Turbo 125kw (F4R.784) 06‐10

2 BOLT HOLES CSRN06 RENAULT TRAFFIC 1.9dCi 100 74kw (F9Q.760) 07‐

CSRN07 RENAULT LAGUNA 2.0 Turbo 125kw(F4R) 06‐09

CSRN07 RENAULT SCENIC II 1.9dCi 88kw (F9Q.8.70, F9Q.72) 04‐08

CSRN07 RENAULT TRAFFIC 1.9dCi Turbo diesel 74kw (F9Q.7.60,F9Q 7.62) 07‐

3 BOLT HOLES

CSVL01 VOLVO C70 2.3i T5 Turbo 20 Valve 176kw (B5234T3) 98‐02

CSVL01 VOLVO S40 2.0i 100kw (B4204S2) 97‐03

CSVL01 VOLVO S40 2.0i T 121kw (B4204T3) 98‐04

CSVL01 VOLVO S40 2.0i T4 147kw (B4204T5) 98‐00

CSVL01 VOLVO S40 II 2.0i 100kw 04‐07

CSVL01 VOLVO S60 2.0i Turbo 20 Valve 132kw (B5204T5) 01‐10


CSVL01 VOLVO S60 2.4i 20 Valve 124kw (B5244S) 00‐01

CSVL01 VOLVO S60 2.4i Turbo 20 Valve 147kw (5244T3) 02‐03


CSVL01 VOLVO V40 2.0i Turbo 121kw (B4204S) 97‐00

CSVL01 VOLVO V40 2.0i T4 147kw (B4204T5) 98‐

CSVL01 VOLVO V70 2.0i Turbo 132kw (B5202S) 04‐

CSVL01 VOLVO V70 2.4i 20 Valve 125kw (B5244S) 00‐

CSVL01 VOLVO V70 2.4i Turbo 20 Valve 147kw (B5244T) 00‐

CSVL01 VOLVO XC70 2.4i Turbo 20 Valve AWD 147kw (B5244T3) 00‐02

CSVL01 VOLVO XC70 2.5 Turbo 20 Valve AWD 154kw (B5254T2) 03‐08

CSVL02 VOLVO C30 2.0i 107kw (B4204‐S3) 05‐07

CSVL02 VOLVO C30 2.0i 107kw (B4204‐S3) 07‐

CSVL02 VOLVO S40 II 1.8i 92kw (B4184S8, S11) 05‐07

CSVL02 VOLVO S40 II 1.8i 92kw (B4184S8, S11) 07‐

CSVL02 VOLVO S40 II 2.0i 107kw (B4204S3) 05‐07

CSVL02 VOLVO S40 II 2.0i 107kw (B4204S3) 07‐


CSVL04 VOLVO C30 2.5 T5 165kw (B5254T7) 07‐

CSVL04 VOLVO C70 2.5 T5 169kw (B5254T7) 06‐

CSVL04 VOLVO S40 II 2.5 T5 `165kw (B5254T3) 04‐07

CSVL04 VOLVO S60 II 2.0 D3 120kw (D5204T2) 11‐

CSVL04 VOLVO V50 2.5 T5 165kw (B5254T3) 05‐

CSVL04 VOLVO V60 2.0D3 120kw (D5204T2) 11‐

CSVL04 VOLVO XC60 2.0D3 120kw (D5204T2) 11‐

CSVL04 VOLVO XC60 2.4D 129kw (D5244T14) 09‐10

CSVL05 VOLVO S40 II 2.0 Turbo Diesel 100kw (D4204T) 05‐

CSVL05 VOLVO S40 II 2.4i 125kw (B5244S4) 04‐07

CSVL05 VOLVO V50 2.0 Diesel 100kw (D4204T) 05‐

CSVW01 VOLKSWAGEN CARAVELLE T4 2.5 TDi, Syncro 4x4 Turbo Diesel 75kw (ACV) 99‐05

CSVW02 AUDI A3 1.8 T 20 Valve 132kw 6 Speed 99‐03

CSVW02 AUDI A3 1.8 T FSi 118kw 6 Speed (CDAA) 08‐

CSVW02 AUDI A3 2.0 T FSi 147kw (AXX, BWA, CAWB) 04‐

CSVW02 AUDI A3 2.0 TDi 103kw (AVZ, BKD, BMM) 03‐10

CSVW02 AUDI A3 3.2 V6 Quattro 184kw (BDB, BMJ) 04‐08

CSVW02 AUDI S3 1.8 T Quattro 20 Valve 165kw 6 Speed (BAM) 01‐05

CSVW02 AUDI S3 2.0 TFSi Quatro 188kw (BZC, CDLC) 07‐

CSVW02 AUDI TT 1.8 T Quattro 20 Valve 165kw 6 Speed (APX, BAM) 01‐06

CSVW02 AUDI TT 2.0 T FSi 147kw (AXX, BWA, CAWB) 04‐

CSVW02 AUDI TT 2.0 T FSi 200kw (CDLB) 09‐

CSVW02 AUDI TT 3.2 V6 Quattro 184kw (BUB) 07‐10

CSVW02 SEAT ALTEA 2.0 TDi 103kw (BMM, BMN) 06‐08

CSVW02 SEAT IBIZA 1.9 TDi 96kw (ASZ, BLT) 06‐08

CSVW02 SEAT IBIZA 1.9 TDi Cupra 118kw (BPX, BUK) 06‐08

CSVW02 SEAT LEON 2.0 TDi 103kw (BMM, BMN) 06‐08

CSVW02 SEAT LEON 2.0 T FSi 147kw (BWA) 06‐08

CSVW02 SEAT LEON 2.0 T FSi Cupra 177kw (BWJ) 06‐08

CSVW02 VOLKSWAGEN CARAVELLE T5 2.0 TDi 103kw (CAAC, CCHA) 10‐

CSVW02 VOLKSWAGEN CARAVELLE T5 2.5 TDi, 96kw (AXE) 05‐10

CSVW02 VOLKSWAGEN CARAVELLE T5 2.5 TDi, Syncro 4x4 Turbo Diesel 128kw (AXD) 05‐10

CSVW02 VOLKSWAGEN EOS 2.0 T FSi 147kw (CAWB, CCTZ, CCZA) 08‐

CSVW02 VOLKSWAGEN GOLF 4 1.8 GTi 132kw 6 Speed (AGN) 99‐04

CSVW02 VOLKSWAGEN GOLF 5 2.0 GTi 147kw (AXX, BWA, CAWB) 05‐10

CSVW02 VOLKSWAGEN GOLF 5 2.0 TDi 103kw (AZV) 05‐10

CSVW02 VOLKSWAGEN GOLF 6 2.0 TDi 103kw (CBAB) 10‐

CSVW02 VOLKSWAGEN GOLF 6 2.0 GTi 155kw (CCZB, CDLF) 09‐

CSVW02 VOLKSWAGEN JETTA 4 1.8T Executive 132kw 6 Speed (AUQ) 01‐04

CSVW02 VOLKSWAGEN JETTA 5 2.0 TFSi 147kw (BWA, BPY) 05‐

CSVW02 VOLKSWAGEN JETTA 5 2.0 TDi Sport 103kw (BKD) 05‐11

CSVW02 VOLKSWAGEN JETTA 6 2.0 TDi 103kw (CFFB) 11‐

CSVW02 VOLKSWAGEN PASSAT 1.8 TSi 118kw (CDAA) 08‐

CSVW02 VOLKSWAGEN PASSAT 2.0 TDi 103kw (BKP) 05‐

CSVW02 VOLKSWAGEN PASSAT 2.0 TDi 125kw (BMP) 05‐

CSVW02 VOLKSWAGEN PASSAT 2.0 T FSi 147kw 05‐

CSVW02 VOLKSWAGEN PASSAT CC 2.0 TSi 147kw (CAWB, CCZA) 09‐

CSVW03 VOLKSWAGEN CRAFTER 30‐35 Bus 2.5TDi 80kw (BJK) 06‐

CSVW03 VOLKSWAGEN CRAFTER 30‐35 Bus 2.5TDi 120kw (BJM) 06‐

CSVW04 VOLKSWAGEN SHARAN 1.8 Turbo 110kw (AJH) 99‐00

CSVW04 VOLKSWAGEN SHARAN 1.9 TDi (AHU,ANU,AUY 03‐06

CSVW04 VOLKSWAGEN SHARAN 2.8 VR6 128kw (AAA, AMY) 99‐00

Cross Reference

LUK P/N ABES P/N

510 0015 30 CSAL01

510 0101 10 CSAL02

510 0104 10 CSAL03

510 0163 10 CSCH01

CSCH02

510 0174 10 CSCH03

510 0011 11/ 510 0011 10 CSFD01

510 0023 10 CSFD02

510 0062 10 CSFD03

510 0001 10/ 510 0172 10 CSFD04

510 0124 10 CSFD05

510 0058 10 CSFD06

510 0140 10 CSFD07

510 0102 10 CSFD08

510 0104 10 CSFT01

510 0038 11/ 510 0038 10/ 510 0079 10 CSFT02

510 0083 10 CSLR01

510 0102 10 CSLR02

510 0035 10 CSMB01

510 0036 10 CSMB02

510 0009 10 CSMB03

510 0025 11 / 510 0025 10 CSMH01

510 0011 11/ 510 0011 10 CSMZ01

510 0025 11 / 510 0025 10 CSNS01

510 0097 10 CSNS02

510 0111 10 see 510 0164 10 CSNS03

510 0116 10 CSNS04

510 0038 11/ 510 0038 10/ 510 0079 10 CSOP04

510 0104 10 CSOP05

510 0116 10 CSOP06

510 0101 10 CSOP07

510 0025 11 / 510 0025 10 CSOP08

510 0097 10 CSRN01

510 0100 10/ see 510 0088 10 CSRN02

510 0098 10 CSRN03

510 0090 10 CSRN04

510 0111 10 see 510 0164 10 CSRN06

510 0116 10 CSRN06

510 0025 11 / 510 0025 10 CSRN07

510 0010 10 CSVL01

510 0124 10 CSVL02

510 0140 10 CSVL03

510 0102 10 CSVL04

510 0103 10 CSVL05

510 0016 10 CSVW01

510 0177 10 CSVW02

510 0035 10 CSVW03

510 0001 10/ 510 0172 10 CSVW04

ABES TECHNOSEAL.DIVISION OF HUDACO TRADING (PTY) LTD

(REG. NO. 1984/005432/07)

POSTAL ADDRESS:P.O. BOX 8189

ELANDSFONTEIN1406

REPUBLIC OF S.A.

EMAIL: [email protected]

ADDRESS:3 WANKEL STREET

JET PARK EXT. 1BOKSBURG

1459

TEL: +27 (11) 397-4070

FAX: +27 (11) 397-4326

Documents

Concentric Slave Cylinder Catalogue CSC - ABES SCORPIO 2.0 SUV 90kw (F4R) 05- CSMH01 MAZDA SOHO 1.3i 96-98 CSMZ01 1.4i 98-01 CSMZ01 MERCEDES BENZ A-CLASS APPLICATION YEAR ABES P/N