Daily Mobile Crane Inspection Checklist

Section A: Inspection

s/no Items OK Not OK N/A Remarks

Truck

1. Carrier Structure

2. Tyre pressure

3. Wheel Nuts

4. Radiator water

5. Engine Oil Level

6. Diesel Level

7. Diesel Tank

8. Any Retrofitted Fuel Tanks

9. Battery water level

Power Transmission System

10. Power take-off (PTO)

11. Propeller Shaft

Hydraulic System

12. Hydraulic tank

13. Hydraulic Pump

14. Hydraulic hose

15. Hydraulic Oil

Slewing System

16. Slewing Table

17. Slewing Gear and bearing

Boom Elevation System

18. Elevating Cylinder

Boom Telescopic System

19. Boom Structure

20. Fly-jib

21 Single Top

Sheave and hook block

22. Sheave and hook block

Wire Rope

23. Boom Hoist wire

24. Load hoist wire

Hoisting System

25. Winch motor

26. Clutch

27. Brake

SWP– 04.38 Page 1 of 2Rev 0

Contractor Company

LM Cert No. Date of Expiry

Daily Mobile Crane Inspection Checklist

s/no Items OK Not OK N/A Remarks

28. Wire rope

29. Hook Block

Crane Control System

30. Operation Control

31. Selector Switch

Safety Device

32. Angle indicator

33. Pressure Gauge

34. LRI

35. Anti-two block

36. Boom Stop

Outrigger System

37. Outrigger

38. Jack Cylinder

39. Float

Additional Remarks:

* Item No.8: Provide crane specification

Section B: Endorsement by Appointed Personnel

Note: All the above checklist items must be completed. All deficiencies must be reported to the lifting supervisors and must be rectified before using the crane.

Record of Corrective actions Taken (if any):

_______________________________________________________________________________________

_______________________________________________________________________________________

Note: Lifting Supervisor must complete the “Lifting Operation Safety Inspection Checklist” after verifying this checklist.

SWP– 04.38 Page 2 of 2Rev 0

Inspected by (shall be done by Crane Operator)

Date / Time Signature

Approved by (shall be done by Lifting Supervisor)

Date / Time Signature