Upload
sri-dharan
View
412
Download
20
Embed Size (px)
Citation preview
11
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO PIPELINE NETWORK DIVISION
HSEHSEINDUCTIONINDUCTION
22
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
PLEASE NOTEKEEP YOUR MOBILE PHONE KEEP YOUR MOBILE PHONE
EITHER INEITHER IN SILENTSILENT OROR
SWITCH OFFSWITCH OFF MODE TILLMODE TILL
END OF THIS SESSION .END OF THIS SESSION .
THANK YOUTHANK YOU
33
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Emergency Evacuation Procedure In Maqta Office
• When you hear Fire alarm, stop all activities.• Do not panic• People sitting in the left ROW evacuate first followed
by the next ROW in the right and next.• Go to the assembly point near to the emergency exit. • Wait for the instruction from Incident Controller
44
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE INDUCTION OUTLINE
• Maqta office layout and office emergency evacuation.
• Gasco Strategic Objectives & HSE Policy statement , HSE Subordinates Policies
• Introduction to Gasco / Divisions • HSE Commitment• Pipelines network & Product list • Pipelines Division / Regions • PTW area classification
55
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• Hazardous Area classifications• H2S ( Killer Gas), Zone Classification• General Emergency Procedures• Road safety requirements• Noise, Heat • Waste Management • HSE Requirements, PPE – Personal Protective
Equipments • Manual handling • First Aid • Incident Classification, Investigation & Reporting
Standard -ICIR
HSE INDUCTION OUTLINE- (Cont’d)
66
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO STRATEGIC OBJECTIVES
PERFORM THE BUSINESS WITH THE VISION OF:
• NO HARM TO PEOPLE
• PROTECT THE ENVIRONMENT (पर्या��वरण)
• IMPROVE ASSET (सं�पत्ति�) INTEGRITY
77
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
88
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
NEW 24” LEANGAS PROJECT From BuHasa to BAB & BAB to
THAMAMA C
99
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• Installation of New 24” leangas pipeline and demolition of the existing pipeline.
• Laying from BuHasa NGL station to Bab manifold and From Bab to THAMAMA C manifold
• Total length of 51.4 km.
• Diameter of Pipeline 24”
• Between Bu-Hasa And Bab there is Three sectionizing valve – SV1, SV2, SV3.
About project
1010
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Introduction of Gasco /Divisions
GASCO ( Abu Dhabi Gas Industries Ltd) is the operational company in Abu Dhabi responsible for processing onshore natural gas and associated gas from onshore oil production .
The company began as a joint venture incorporated in 1978 with ownership shared between ADNOC as a major shareholder (68%), Shell Abu Dhabi (15%) , Total (15%) and Partex (2%).
1111
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO has following Plant Divisions• Habshan /Bab
• Bu Hasa
• Asab
• Ruwais
1212
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Pipeline Network Division
Is responsible for the smooth and un- interrupted distribution of the products to various locations through the pipeline network
1313
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Pipelines Division maintains the whole
pipelines network of GASCO , approximately 2600 km in length , in
various sizes
ranging from 4 to 48 inch diameters
1414
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE Commitment
To ensure that GASCO pipelines division activities are carried out with full concern to health, safety and environment of its work force, public and environment .
To achieve this commitment HSE INDUCTION training will be provided to all its newly hired, transferred & Contractor employees to familiarize them with the pipelines divisions HSE policy, regulation and requirements
1515
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
OAG PIPELINE
1616
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
1717
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Pipelines Network product List
• Sales Gas ( Sweet Gas)• NGL (Natural Gas Liquids)• Condensate• Acid Gas ( Gas Mixture with High concentration
of H2S )• Crude oil • Nitrogen • Water
1818
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
PIPELIENS DIVISION/REGIONSFor the sake of operational convenience , the
whole Pipelines network is divided into
Eastern Region
Western Region
1919
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
EASTERN REGION
• Th-C – Maqta P/L -( From Km 60)• Al Dhafra Pipeline• Emirates Steel Factory (ESI)• Gulf Sponge P/L• Maqta Taweela P/L• Maqta-Zayed Military City P/L• Maqta – Umal Naar Refinery• Ghantoot CRS to Ghantoot NGV Station
2020
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
EASTERN REGION
• Maqta KM 42 ---- to Emal
• Al Ain SV – 6 to Tuwaisa - Al Ain SV – 9 to Air College
• Al Ain Cement Factory Pipeline Launcher to Receiver• Al Ain Arkan Cement Factory Launcher to Receiver• Al Ain Power Station P/L
2121
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
WESTERN REGION
• Th – C to Maqta up to KM - 60• Asab to Bab P/L• Buhasa to Bab P/L• Asab – Thamama – C – P/L• Thamama – C to Asab P/L• Bab – Thamama – C – P/L• Thamama – C – Ruwais P/L• Thamama-C- Mirfa Power Station P/L
2222
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
WESTERN REGION
• Ruwais –Shweihat• Ruwais Industrial Area P/Ls • Das Island to Habshan P/L• NGL & Condensate Lines ( Asab , Habshan,
Bab,MP-21, Bu Hasa, & Ruwais)• Mirfa – Habshan N2 P/L• Mirfa – Ruwais N2 P/L• Habshan – Masdar Shams P/L• Madina Zayad Power Station P/L
2323
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
PTW AREA CLASSIFICATION
Due to the presence of Hydrocarbons (flammable materials) areas in the pipelines Division are classified as follows:
RESTRICTED AREA &
UNRESTRICTED AREA
2424
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
2525
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Following areas the Restricted Areas in Pipelines
• 30 Meters from any Gas /Liquid Manifold
Station, Consumer Receipt Station (CRS), Valve Station (SV), Pig launcher/ receiver station and blow off station.
• 30 Meters from the centre of the nearest pipeline in the corridor
2626
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
The above areas are classified as “RESTRICTED AREA”
Due to the Presence of Hydrocarbons & Potential hazards of
• Fire / Explosion.
• Toxic Gas Release
• Flammable Gas Release
2727
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
(RESTRICTED AREA) CRS
2828
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
(RESTRICTED AREA) Maqta manifold
2929
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
All Pipelines are Protected & Identified by
Berm
3030
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Identification Sign Boards with emergency Tel: Nos Identification Sign Boards with emergency Tel: Nos
3131
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Hazardous Area Classifications
• The Hazardous areas :is an area in which explosive gas/air mixture are ,or could be ,expected to be present in quantities. These area require special precautions to limit the sparking potential of electrical equipments
• Hazardous areas are classified into Zones as follows according to American standard .
• Zone 0 : An area in which explosive gas/air mixture is continuously present or present for long periods e.g. void space of tank containing volatile flammable liquid –However in P/Ls network the Zone 0 not available
3232
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Hazardous Areas • Zone 1 : An area in which explosive gas/air mixture is likely
to occur in normal operation– Considered 3.0 meters radius from pig launchers/Receivers Gates
• Zone 2 : An area in which explosive gas/air mixture is not likely to occur in normal operation but if it does occur it will be for a short time- Consider :
a- 7.5 meters radius from pig launchers/Receivers Gates b- 5.0 meters radius from vent pipe ,pressure relief valves c- 3.0 meters radius from screwed fitting flange
3333
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Hazardous Areas in Pipelines Division
3434
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Killer Gases-H2S & SO2 ( Hydrogen Sulphide & Sulphur Dioxide )
3535
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Introduction to H2S
Hydrogen Sulphide (H2S) is an extremely dangerous chemical compound, causing serious incidents in the hydrocarbon industry every year. It is a colorless, highly toxic and flammable gas, heavier than air tends to settle in low areas, smell like rotten eggs ( सड़े अं�डे) in low concentration, its deadens the sense of smell in high concentration that has been identified as Major Accident Hazard (MAH) in GASCO operations. In the past there have been a number of H2S related Incidents in GASCO and other ADNOC Group companies, such as:• BuHasa Fatal Incident (2002).• Ruwais H2S Exposure Incident (2006).• Habshan LTI due to H2S Exposure Incident (2008).• Fatal Incidents in ADGAS and ADCO (2008 and 2009).
3636
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• Sulphur dioxide (SO2) is a colourless gas with a pungent like Sulphur dioxide (SO2) is a colourless gas with a pungent like burning rubber odour. odour.
• It has many industrial & agricultural uses. It has many industrial & agricultural uses. • It is shipped and handled as a compressed gas in a special It is shipped and handled as a compressed gas in a special
containers.containers.• Some foods & wines are preserved with small amounts of Some foods & wines are preserved with small amounts of
Sulphur Dioxide that are safe for most people.Sulphur Dioxide that are safe for most people.• Sulphur dioxide dissolves in water very easily. Sulphur dioxide dissolves in water very easily. • Liquid under pressure • It cannot catch fire.It cannot catch fire.
Introduction to SO2
3737
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• It is almost 20% Heavier than air/1.189 times density air• Strong, suffocating odor • Rotting eggs
DEATHDEATH
CLINICALCLINICAL
DIEASEDIEASE
LATENTLATENTDISEASEDISEASE
HEALTHHEALTH
3838
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Effects of H2S On Man at various concentrations
•100 ppm = 0.01 %100 ppm = 0.01 % - Deadens the sense of smell in 3 to 5 minutes . May burn eyes and throat and cause drowsiness.
•500 ppm = 0.05%500 ppm = 0.05% - Dizziness , Loss of reasoning and balance . Breathing stops in a few minutes. Prompt resuscitation ( Artificial Respiration) required immediately
1000 ppm – 0.1%1000 ppm – 0.1% - Unconsciousness occurs immediately, followed by death or brain damage if not rescued promptly.
3939
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
H2S ppm = Parts of H2S per million parts of Air.
• At 1 ppm - Odor Detectable by smell.
• 1 ppm = Occupational Exposure Limit (OEL) – ( The Maximum Time Weighted average for an 8 hour work shift.
4040
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
4141
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Pipelines with H2S
• 20” Bu Hasa - BAB Gas Pipeline.including its header
at Bab Manifold • 36” Buhasa – Habshan Plant gas Pipeline• 20” Bab MF – Thamama – C gas Pipeline including its header at
Thamama – C manifold• 20” Thamama – C MF – Habshan Plant gas Pipeline• 12” BAB- Habshan AGR ( Acid Gas recovery) Pipeline.• 30” HP & MP Gas Pipeline Between Units 12 & 13• 36” HP & MP Gas Pipeline Between Units 12 & 13• 30” OAG Pipeline from Ruwais to Habshan• 16” Buhasa – MP 21 NGL Pipeline including the Receiver• 30” Bab – Ruwais NGL Pipeline• 24” MP 21 – Ruwais NGL Pipeline• 36” Thamama – C – Asab Pipeline and its branches
4242
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone Classifications
In accordance with ADNOC COP V4 – 10 & 11 , GASCO H2S Standard HSE –ST - 016.
H2S Zone classified in to 3 zones
• Red Zone• Yellow Zone• Green Zone
4343
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone Classifications
RED Zone:- A red Zone is considered to exist if there is a possibility of Hydrozen Sulphide release which could be rapidly lethal (more than 1000 ppm). The following stations are red zones under Pipelines Division.
RED Zone:- All 6 Stations of OAG Pipeline, MP – 21 NGL Station.
For RED Zone following access controls are required.• Only H2S Competent people shall enter.• H2S detector shall be worn.• Positive pressure full face escape mask shall be carried • Record to be maintained at MCR.
4444
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone Classifications
As seen from above figure the red zone at BVS1 is spread throughout the facility as well as extending outside the fence area. The red zone is extending to a distance of 42 meters from ROV 9033 in South-South West (SSW) direction and 62 meters in South East direction.
4545
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone ClassificationsYellow Zone:- A yellow Zone is considered to exist if there is a possibility of Hydrozen Sulphide release which could be rapidly injurious ( 50 - 1000 ppm). The following stations are the yellow zones under Pipelines Division.
YELLOW Zone:- SV1, SV2 & SV3 of 20” Buhasa to Bab Manifold Pipeline.
For YELLOW Zone following access controls are required• Only H2S Competent people shall enter.• H2S detector shall be worn.• Positive pressure full face escape mask shall be carried.
4646
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
The yellow zone is localized and not spread throughout the facility. However for access restrictions, it is recommended to classify the entire station as yellow zone considering the small size of the facility.
GASCO H2S Zone Classifications
4747
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone Classifications
Green Zone:- A green zone is the area where the personnel would be able to safely evacuate in the event of an accidental release (less than 50 ppm) without the need for emergency escape set but where exposer above the TLV (5 ppm ) is possible. The following stations are the green zones under Pipelines Division.SV2, SV3 & 902 Receiver of 30” Bab – Ruwais NGL Pipeline.SV2, SV3 & 901 Receiver of 24” MP21 – Ruwais NGL Pipeline.BVS1, BVS2 & BVS3 of 36” Buhasa – Habshan Pipeline.BVS1, BVS2, BVS3 & BVS 4 of 36” Thamama C – Asab Pipeline.Madinat Zayed CRS (CRS 602)Bab Gas Manifold & Thamama C Gas Manifold
4848
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GASCO H2S Zone Classifications
For GREEN Zone following access controls are required• H2S awareness.• H2S detector shall be worn.
4949
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Permit to work application by operations
Application of GASCO PTW Standard is considered adequate for breaking into H2S containment more than 500 ppm H2S in process fluid. However, following additional H2S controls shall also be applied:• Entry controls as per Section 7.3.1;• Process Venting containing more than 5 ppm H2S shall be avoided; and• Isolations: Double block with bleed for temporary for work duration less than a shift period but full positive isolation shall be required for durations longer than a shift.
5050
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE Requirements in Restricted area Smoking is not permitted . Items like Cigarette lighters or Matches
or any other spark producing materials ( Source of Ignition) shall not be taken inside the
restricted area
PPE ( Personal Protective equipments shall be used
while entering and or working in Restricted Area
5151
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE Requirement in Restricted Area
Valid Work Permits are Mandatory to perform any Non Routine Activity in Restricted Area
Work Permit
Hot Work Permit
Category 1
Hot Work Permit
Category 2
5252
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE Requirement in Restricted Area
Mobile Phones, Cameras, other Tools and Equipments which
are considered as a Source of Ignition are not permitted inside the
Restricted Areas.
5353
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
UNRESTRICTED AREAS IN PIPELINES
• Pipelines Division offices. • Non-Operation related facilities e.g. offices, kitchens and
bathrooms, inside CRS and manifold buildings except TH C manifold building
• Note: Smoking is prohibited in the above areas inside
CRS and manifold buildings even if they are classified as unrestricted areas.
5454
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
GENERAL EMERGENCY PROCEDURE
5555
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
ACTIONS TO BE TAKEN IN CASE OF EMERGENCY• AT ANY PLANT - FOLLOW THE FACILITY RESPONSE PLAN
• ON PIPLEINE CORRIDORS, MANIFOLDS OR CRS s
• Stop all the activities.• Switch off all equipments .• Observe the wind Direction.• Evacuate to the safe location (cross/up wind )according to
your location. • Inform Main Control Room ( MCR) about the incident on
the following Tel.numbers.
5656
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
MCR TELEPHONE NUMBERS(24 Hours Coverage)
02-60 3790002-60 37900
02-558 261402-558 2614
050-662 0432050-662 0432
TOLL FREE 800 (GASC0) 42726TOLL FREE 800 (GASC0) 42726
5757
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
ROAD SAFETY REQUIREMENT
In line with company road safety procedure :
Never Drive Company Vehicle Without a Valid UAE Driving License .
All Drivers ( Both Professional and Occasional drivers ) must have GASCO Document for Safe Driving)
5858
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
ROAD SAFETY REQUIREMENT
• Both driver and the passengers must wear seat belts while IN Vehicle.
The maximum number of people that can be carried is equal to the number of seat belts ( That means 4 People can travel if there are 4 seat belts )
5959
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Observe the speed limits
Never use Mobile phone while driving
6060
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
NOISE
• “Noise” is unwanted or health damaging sound
6161
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
NOISE
The primary source of noise at the pipelines is flow noise. A high-frequency, random noise often occurs when gas and
liquid, travelling at high velocity through a valve, undergoes a rapid and severe drop in pressure. Short high excursions
(>85 dB) in noise levels may also result from specific operations such as venting, or from specific maintenance
operations. (Reference: Pipelines Division’s QHRA Report)
6262
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Controls
Hearing protection (ear muffs and ear plugs) provided to all employees who may be exposed to high noise.
All employees receive in-house initial and annual training with respect to selection, use and care of PPE.
Supervisors conduct regular “tool box talks” with field personnel.
Medical surveillance program for Noise-Induced Hearing Loss in line with ADNOC COP V3-10.
Implementing OHRA and QHRA Report Recommendations like area barricading, dual hearing protection etc.
6363
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
6464
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HEAT
Heat Related Illnesses
When body is unable to cool itself through sweating, heat related illness may occur. These can range from heat rash, heat cramps and heat
syncope (fainting) to life threatening heat exhaustion and heat stroke.
The most severe heat related illnesses are heat exhaustion and heat stroke. If left untreated, they could be fatal.
6565
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Symptoms of Heat Exhaustion
Headaches, dizziness (चक्कर) or light-headedness
Weakness (नि�र्ब लता�)
Nausea & vomiting
Sweating with pale, clammy skin
Rapid breathing
Cramps in arms, legs or abdominal wall
Decreased or dark coloured urine
6666
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Symptoms of Heat Stroke
Headaches, dizziness or light-headedness
Red, hot, dry skin with no sweating
Rapid deterioration in the level of response
Seizures or fits
Unconsciousness (र्ब�हो�श)
6767
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
In case of Heat Exhaustion or Heat Stroke
Call for medical help immediately
Move the victim to a cool, shaded area. If the symptoms include dizziness or light-headedness, lay the victim on his back. If the symptoms include nausea or vomiting, or the victim is unconscious, lay the victim on his side.
Loosen and remove any heavy clothing
Have the person drink cool water (a cup every 15 minutes), if able to do so.
In the case of heat stroke, cool the body by fanning and sponge with cold water. Place ice packs under the armpits and groin area.
6868
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Prevention Strictly implement ‘mid break rule’ in summer by Abu Dhabi Government. Be aware of the symptoms of heat related illnesses and immediately inform Supervisor if they persist. Learn how to respond to heat related illnesses. Build up tolerance slowly to work in hot weather. Use the buddy system, with people working in pairs Perform the heaviest work during the coolest part of the day. Drink plenty of cool water before starting work. Continue to take cool water (a cup every 15 – 20 minutes) whilst working in hot environment Wear light, loose fitting, breathable clothing such as cotton. Take extra care when wearing personal protective clothing or equipment, such as respirator. Work in the shade, if possible. Take frequent short breaks in cool, shaded areas to allow the body to cool down. Maintain a balanced diet. Avoid tea, coffee and soft drinks. These beverages contain caffeine that increase the risk of heat related illnesses. Take extreme care if you have a history of high blood pressure, diabetes, kidney problems or fever. Implement and follow OHRA & QHRA Report recommendations related to Heat stress.
6969
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Waste Management
7070
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• Due to nature of the activities carried out in pipelines Division the only waste generated form normal operation activities is the hydrocarbon sludge- that must be transferred to Ruwais Waste management Area-Inline Pipelines division approved Waste management Procedure & ADNOC Code of practice Waste Management ( ADNOC COP 2- 05)
Waste management
7171
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Waste classification
• Domestic & municipal waste
• Non-hazardous industrial & commercial waste
• Hazardous waste
7272
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Domestic & Municipal Waste
7373
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Non-hazardous industrial & commercial waste
7474
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Hazardous Waste• Toxic/poisonous• Flammable• Corrosive• Reactive
7575
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Labeling
7676
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Waste temporary storage
7777
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Transporting
7878
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
HSE REQUIREMENTS
PPE ( Personal Protective Equipment )
It is the responsibility of the employer/company to provide
the required PPE ( Personal Protective Equipment) to their
employees and ensure that all employees wear them.
7979
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• Eye - Safety glasses and goggles
• Face - Face shields
• Head - Hard hat
• Feet - Safety Shoes
• Hands/arm - Gloves
• Body - Cover All
• Ear (Hearings) - Ear plugs/ muffs
• Nose - Respirators
• H2S monitor
8080
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
• It protects you against adverse weather condition.
• High visibility clothing vests enables big trucks to identify you and avoid colliding with you
• It protects your heads , eyes, ear, body, foot and Hands/arm from damage or injury
8181
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
TYPES OF PPEs
Helmet(Head Protection)
Safety Shoe( Foot Protection)
Ear Muff/Plug(Ear Protection)
Safety Glass( Eye Protection)
Gloves( Hand Protection)
Safety Harness/Life LineWorking at Height)
8282
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
TYPES OF PPEs
Breathing Apparatus
Escape Mask
Face Mask ( Dust Mask)
8383
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Manual Handling Kinetic Lifting Technique
for a Simple Load
8484
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Kinetic Lifting Technique For Lifting a Sack From the
Ground
8585
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Manual Handling Kinetic Lifting Technique for Lifting Sacks From a Truck
8686
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
First-Aid
• First aid is the emergency care given to an injured person by a first aid trained person or member of the community , until medical care can be obtained.
8787
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
First-Aid
• To asses a situation quickly and safely and summon appropriate help.
• To identify the nature of injury
• To arrange removal of casualty to hospital as early as possible for further medical care.
8888
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
All incidents are to be reported in the Gasco incident reporting system which is available in
Gasco Intranet
Incident Classification, Investigation and Reporting Standard
(ICIR)
8989
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Incident reporting
9090
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
Purpose of Incident reporting
• To make all concerned aware of what happened in other parts of the plant/site.
• To understand the reason for the incident
• To learn lesson from the mistakes others did.
• Remember: there is no “BLAME CULTURE”
9191
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION
REMEMBER!!!
SAFETY IS FIRST IN OUR BUSINESS & IN OUR HANDS
9292
GASCO PIPELINE NETWORK DIVISION
HSE DEPARTMENT HSE INDUCTION