INSTALLATION GUIDE RESIDENTIAL MASONRY 2017permacon.ca/sites/default/files/2017-07/GuideTechMaconnerie_Ang17.pdf · INSTALLATION GUIDE RESIDENTIAL MASONRY 2017 ... Laﬁ tt stone

INSTALLATION GUIDE

RESIDENTIAL MASONRY

2017

C1-C4_MacGuideTecInst17.indd 2C1-C4_MacGuideTecInst17.indd 2 2017-04-18 9:42 AM2017-04-18 9:42 AM

2

MacGuideTecInst17_Ang.indd 2MacGuideTecInst17_Ang.indd 2 2017-04-18 10:46 AM2017-04-18 10:46 AM

INDEX – 3

INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

MONDRIAN STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

LAFITT STONE/LAFITT ALTO . . . . . . . . . . . . . . . . . . . . . . . . 8

LEXA STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

DUFFERIN PLUS STONE . . . . . . . . . . . . . . . . . . . . . . . . . . 12

LAMINA STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

CINCO STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

CINCO BRICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

MELVILLE NORMAN BRICK . . . . . . . . . . . . . . . . . . . . . . . . . 19

MELVILLE SLIK BRICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

URBANIKA BRICK AND STONE . . . . . . . . . . . . . . . . . . . . . . 21

CARDIFF ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

SEAMLESS TEXTURES AND

HATCHING PATTERNS LIBRARY . . . . . . . . . . . . . . . . . . . . . 24

INDEX


4 – INTRODUCTION

SUGGESTION NO 3

PROVIDE A MINIMUM OVERLAP OF 4 INCHES

The minimum overlapping of the stone should be a minimum of 4 inches.

These are just a few basic rules to help you successfully complete

your masonry project.

For further technical information we suggest you to consult

the following sources:

• In English: CSA Standards, Applicable Building Code and the CCMPA.

• In French: IMQ, Normes CSA and Code National du Bâtiment

SUGGESTION NO 1

AVOID BOXES

When a group of stones forms a compartment (rectangle or square) it

creates joints that should be broken. Adding a different dimension stone

usually solves the problem. However, in some projects, such as small

columns or pilasters, it is diffi cult (or impossible) to avoid them.

AVOID GOOD PRACTICE

SUGGESTION NO 2

AVOID LONG VERTICAL OR HORIZONTAL JOINTS

To maintain an aesthetic appearance of the wall, we suggest taking the

height of the largest stone as the maximum reference for the vertical

joints. Concerning the length of the horizontal joints, they should be less

than 4 feet long.

THE PURPOSE OF THIS GUIDE IS TO EXPLORE IN MORE

DETAIL CERTAIN AESTHETIC CHARACTERISTICS OF

PERMACON’S PRODUCTS AND PRESENT SEVERAL BEST

PRACTICES WITH REGARDS TO MASONRY INSTALLATION.

WE HOPE THIS GUIDE WILL HELP YOU ACHIEVE IN THE

BEST POSSIBLE WAY YOUR MASONRY PROJECTS USING OUR

EXTENSIVE PRODUCT LINES.

WE HAVE INCLUDED SOME SUGGESTIONS TO FOLLOW WHEN

INSTALLING MASONRY.

PLEASE NOTE ALL PERMACON PRODUCTS ARE

MANUFACTURED WITH NATURAL INGREDIENTS LIKE SAND

AND STONE. THEREFORE, IT IS NORMAL AND DESIRABLE THAT

THE FINAL BUILDING APPEARANCE SHOWS COLOR VARIATION.

INTRODUCTION

4 feet max

4 inch

See “Tricks” page 4

Max


BEST PRACTICES – 5

GENERIC CROSS SECTION FOR A MASONRY INSTALLATION

TYPICAL WOOD STUD WALLCONSTRUCTION:

1/2 in gypsum board

1 in wood furring

Vapor barrier

2 in x 6 in wood studs

with 6 in batt insulation

Exterior sheeting

Air-barrier

1 in air gap

3 1/2 Masonry Veneer

Typical masonry wall ties

Flashing

10 in foundation wall

TYPICAL CONCRETE BLOCK WALL CONSTRUCTION:

1/2 in gypsum board

1 in metal furring

Concrete block

Insulation

1 in air gap

3 1/2 Masonry Veneer


Flashing


TRICKS (Regarding suggestion NO 2)

To avoid long joints, we recommend that you follow these two

simple tricks:

Trick NO 1

Install a small (S) and a medium (M) size stone beside a large (L) stone.

Trick NO 2

For two courses, alternate a sequence of small (S) and medium (M)

stones. This technique is particularly effi cient to avoid long horizontal

joints.

LM

M

M

S S

S


6 – DESCRIPTIVE DATA SHEET / MONDRIAN® STONE

MONDRIAN® STONEDESCRIPTION

This new innovative generation of stone will add prestige and distinction

to your design. Its texture, defined edges, slightly chiselled surfaces and

slender forms provide a modern look. Available in three exclusive trendy

colours — it can be installed in linear or modular patterns and blends

perfectly with our Mondrian landscaping products.

Characteristics and benefi ts

• Proposes a cutting-edge style with an attractive texture.

• Is available in three trendy and contemporary colours.

• Allows for a modular or linear installation.

• Reduces the number of cuts required and

waste due to its modular dimensions.

• Includes a percentage of stones with textured ends to achieve corners.

• Matches perfectly with our landscaping products, including Trafalgar

paver, Mondrian paver and slabs.

CHOICE OF PROPORTIONS | Large Stones of 7 13/16 in (198 mm)

A

3 1/2 in x 3 in x variable

90 mm x 76 mm x variable

B

3 1/2 in x 4 1/2 in x variable


C



(Sold separately)

MODULES

1 CUBE OF LARGE STONES + 2 CUBES OF SMALL AND MEDIUM STONES – MODULAR PATTERN

1 CUBE OF LARGE STONES + 2 CUBES OF SMALL AND MEDIUM STONES – LINEAR PATTERN

1 CUBE OF SMALL AND MEDIUM STONESLINEAR PATTERN


DESCRIPTIVE DATA SHEET / MONDRIAN® STONE – 7

SIZES – STONE CLADDING

* The dimensions are actual. Allow a 1/3 in (8 mm) mortar joint in order to obtain nominal dimensions.

457 mm18 in*

508 mm 20 in*

559 mm22 in*

609 mm24 in*

660 mm26 in*

711 mm28 in*

76 mm3 in*

90 mm3 1/2 in*

114 mm4 1/2 in*

198 mm7 13/16 in*


10 %

50 %

25 %

8 – DESCRIPTIVE DATA SHEET / LAFITT® STONE / LAFITT® ALTO STONE

LAFITT® STONE / LAFITT® ALTO STONEDESCRIPTION

Lafi tt stone will amaze you with the natural look of its subtle colour

tones and a texture that evokes — incredibly — stone carved by a

stonemason. Replacing proportions of stones with the Lafi tt Alto Stone

with its enhanced texture will contribute to overall richness and aesthetic

success. Lafi tt stone is also a technical achievement that contributes

tangibly to sustainable development through minimal loss and waste

during installation.


• Unique pigmentation process, resulting in a product that maintains its

colour year after year.

• Hand chiselled texture reminiscent of stone.

• Total design freedom:

- Choice of large stone ratios

- Choice of stone ratios with enhanced texture (Lafi tt Alto)

- Choice of colour ranges (elemental and duos)

• Modular formats = less cutting and waste = material savings.

• Perfect complement to our bricks and several Permacon

landscaping products.

A



B



C



(Sold separately)

CHOICE OF PROPORTIONS | Large stones of 11 1/2 in (292 mm)

9 cubes of 4 in (102 mm) and 7 in (178 mm)for 1 cube of 11 1/2 in (292 mm)

1 cube of 4 in (102 mm) and 7 in (178 mm)for 1 cube of 11 1/2 in (292 mm)

3 cubes of 4 in (102 mm) and 7 in (178 mm)for 1 cube of 11 1/2 in (292 mm)

UNITS (ALL SIZES ARE AVAILABLE IN LAFITT OR LAFITT ALTO)


DESCRIPTIVE DATA SHEET / LAFITT® STONE / LAFITT® ALTO STONE – 9

SIZES – VENEER STONE

Note: *The dimensions are actual. Allow a 1/2 in (13 mm) mortar joint in order to obtain

nominal dimensions.

Note: *The dimensions are actual.

20 1/2 in* (521 mm)

19 in*(483 mm)

17 1/2 in*(444 mm)

16 in*(406 mm)

14 1/2 in*(368 mm)

13 in*(330 mm)

11 1

/2 in

* (2

92 m

m)

7 in

*(1

78 m

m)

4 in

*(1

02 m

m)

16 in*(406 mm)

14 1/2 in*(368 mm)

13 in*(330 mm)

11 1/2 in*(292 mm)

10 in*(254 mm)

8 1/2 in*(216 mm)

7 in*(178 mm)

Depth3 1/2 in*(90 mm)


10 – DESCRIPTIVE DATA SHEET / LEXA® STONE

LEXA® STONEDESCRIPTION

The Lexa stone is an innovative product with clean lines to achieve a

modern masonry veneer look. Thanks to its avant-garde style, this new

veneer is infused with elegance and simplicity.


• Proposes a cutting-edge style with an attractive texture.

• Offers a streamlined appearance.

• Is available in four exclusive colours.

• Allows for a modular or linear installation.

• Reduces the number of cuts required and

waste due to its modular dimensions.

• Presents chamfered edges to accentuate

clean lines.

• Includes a percentage of stones with finished ends to achieve corners.

• Matches perfectly with our landscaping products, including Lexa paver

and slab, Mondrian paver and slabs and Esplanade slab.

CHOICE OF PROPORTIONS | Large Stones of 7 13/16 in (198 mm)

A



B



C



(Sold separately)

MODULES

1 CUBE OF LARGE STONES + 2 CUBES OF SMALL AND MEDIUM STONES – MODULAR PATTERN

1 CUBE OF LARGE STONES + 2 CUBES OF SMALL AND MEDIUM STONES – LINEAR PATTERN

1 CUBE OF SMALL AND MEDIUM STONESLINEAR PATTERN


DESCRIPTIVE DATA SHEET / LEXA® STONE – 11

SIZES – STONE CLADDING

* The dimensions are actual. Allow a 1/3 in (8 mm) mortar joint in order to obtain nominal dimensions.

457 mm18 in*

508 mm 20 in*

559 mm22 in*

609 mm24 in*

660 mm26 in*

711 mm28 in*

76 mm3 in*

90 mm3 1/2 in*

114 mm4 1/2 in*

198 mm7 13/16 in*


25 %10 %

50 %

12 – DESCRIPTIVE DATA SHEET / DUFFERIN® PLUS STONE

DESCRIPTION

This modular stone offers a rustic and classic approach.The Dufferin Plus

stone has wavy texture with soft edges.

Characteristics and benefi ts of Dufferin Plus stone

• Affordably priced.

• Material savings – modular dimensions and accessories reduce the

number of cuts required as well as waste.

• Design fl exibility – choice of two types of joints that provide very

different looks, variable proportions of large stones and accessories to

create interesting architectural details that require few or no cuts.

• Perfect complement to Cinco or Melville Slik bricks and Permacon


DUFFERIN® PLUS STONE

A



B



C



(Sold separately)

UNITS

CHOICE OF PROPORTIONS | Large stones of 9 1/2 in (240 mm)

9 cubes of 3 1/2 in (90 mm) and 5 1/2 in (140 mm)for 1 cube of 9 1/2 in (240 mm)

1 cube of 3 1/2 in (90 mm) and 5 1/2 in (140 mm)for 1 cube of 9 1/2 in (240 mm)

3 cubes of 3 1/2 in (90 mm) and 5 1/2 in (140 mm)for 1 cube of 9 1/2 in (240 mm)


DESCRIPTIVE DATA SHEET / DUFFERIN® PLUS STONE – 13

SIZES – VENEER STONE

Note : *The dimensions are actual. Allow a 3/8 in (10 mm) mortar joint to achieve

the nominal dimensions.

Note : *The dimensions are actual.

Depth3 1/2 in*(90 mm) 5

1/2

in*

(140

mm

)9

1/2

in*

(240

mm

)

17 1/2 in*(444 mm)

15 1/2 in*(390 mm)

3 1/

2 in

* (9

0 m

m)

11 1/2 in*(290 mm)

13 1/2 in*(340 mm)

9 1/2 in*(240 mm)

7 1/2 in*(190 mm)

5 1/2 in*(140 mm)

DUFFERIN® PLUS STONE


14 – DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA®

UNITS

NOTE:

* These dimensions are actual. Allow a 1/4 in (6 mm) mortar joint in order to obtain nominal

dimensions. Lamina stone is offered in a fi nish that provides the appearance of stacked stones

embellished throughout the years. It is completely normal that some stones present a small

amount of softer edges and rounded corners.

LAMINA® STONE / MONO LAMINA®

DESCRIPTION

The only full bed masonry veneer that offers a stacked stone look. Lamina

stone provides a distinct appearance that enhances your architectural

design through its innovative texture. This multi-length stone offers a

great deal of benefi ts thanks to its unique design. Its original texture

and colour choices with the addition of Mono Lamina units offer an

enhanced variety to further personnalize and bring out the best in

every project. Lamina stone may be used on your entire facade or just

to accentuate certain architectural elements such as wall sections or

skirting.


• An attractive stacked stone appearance thanks to its innovative texture

and stunning colours.

• A 90 mm thick stone veneer used in a conventional masonry manner.

• Various stone textures and depths per unit.

• Easy to install due to its unique single height and its four different

lengths.

• Can be easily combined with our existing Permacon masonry and


• Fewer cuts and waste onsite thanks to its modularity.

• Deeper mortar bed providing a sturdier more durable veneer.

• Competitive price compared to other masonry systems.

E

3 1/2 in x 3 3/4 in x 7 3/4 in

90 mm x 95 mm x 197 mm

G

3 1/2 in x 3 3/4 in x 15 3/4 in

90 mm x 95 mm x 400 mm

A

3 1/2 in x 3 3/4 in x 7 3/4 in

90 mm x 95 mm x 197 mm

C

3 1/2 in x 3 3/4 in x 15 3/4 in

90 mm x 95 mm x 400 mm

F

3 1/2 in x 3 3/4 in x 11 3/4 in

90 mm x 95 mm x 299 mm

H

3 1/2 in x 3 3/4 in x 19 3/4 in

90 mm x 95 mm x 502 mm

B

3 1/2 in x 3 3/4 in x 11 3/4 in

90 mm x 95 mm x 299 mm

D

3 1/2 in x 3 3/4 in x 19 3/4 in

90 mm x 95 mm x 502 mm

MONO UNITS


DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA – 15

TYPICAL CROSS SECTION

TYPICAL WOOD STUD WALLCONSTRUCTION:

1/2 in gypsum board

1 in wood furring

Vapor barrier

2 in x 6 in wood studs

with 6 in batt insulation

Exterior sheeting

Air-barrier

1 in air gap

3 1/2 Lamina stone


Flashing


TYPICAL CONCRETE BLOCK WALL CONSTRUCTION:

1/2 in gypsum board

1 in metal furring

Concrete block

Insulation

1 in air gap

3 1/2 Lamina stone


Flashing


INSTALLATION PATTERN

LAMINA STONE LAMINA STONE AND MONO LAMINA (Suggested proportion: 80% Lamina + 20% Mono Lamina)


16 – DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA

Identify the “mortar joints” and the “inner joints”.The basic principle would be to have the “mortar joints”and “inner joints” as similar in thickness as possible.

In order to make sure that all the mortar joints have the same color, tool them when they have the same fi rmness. It should be noted that the fi rmer the joints, the darker the colour will be when tooled.

Forty percent (40%) of the stones have a textured end to easily achieve corners. They are easily identifi able, always located on one side of a row on the cube.

Try to achieve a “mortar joint” of approximately 6 mm (1/4 in) thick so that you can obtain an equal appearance throughout the stones.

Once the installation is complete, clean the wall thoroughly with a stiff brush in order to remove any excess mortar. Remove any residue in the “inner joint” with a trowel, a thin jointing tool or any other similar tool. Leave wall to dry for approximately 24 hours or until completely dry. Wash with any stone or masonry cleaner recommended by Permacon. Repeat this last step as needed.

Leave a recessed joint of 6 mm (¼ in) deep comparedto the deepest stone, so that all joints appear equal.

inner joints

mortar joints

back wall

1/4 in

SPECIFIC INSTALLATION GUIDE

You will notice that the cubes come with all four modules of Lamina stone.

We suggest the use of mortar in its natural colour so that it can easily blend into the stone colours. We advise using a thin jointing tool to achieve a 6 mm (1/4 in) thick joint.

Lamina stone is installed like any other masonry veneer.The units should be installed randomly.

All of the stones measure 90 mm (3 1/2 in) in actual depth and 95.25 mm (3 3/4 in) in actual height for an easy installation.

The selection of each stone needs to be as random in length and texture as possible to achieve a more natural look and feel. Avoid creating “boxes” while installing, by overlapping the stones at least 101.6 mm (4 in) to obtain the best interlocking results.

Each stone has different reliefs. This should be taken into consideration when installing the stone.

Incorrect Correct

101.6 mm

(4 in)


DESCRIPTIVE DATA SHEET / CINCO® STONE – 17

CINCO® STONEDESCRIPTION

Cinco stone is truly versatile, due to its six distinct color options and

a look that is part brick, part stone. With a double height and in fi ve

different lengths that are easy to mix and match, Cinco stone can also

be used in design patterns with Cinco brick. Easy to use, Cinco stone

perfectly complements the entire range of Permacon masonry and



• Versatile: use alone or with Cinco Brick.

• Cost effective (installs like a brick).

• Unique look that is part brick, part stone.

• Attractive chiselled texture.

• Perfect complement to the entire range of Permacon’s masonry and




UNIT

INSTALLATION PATTERNS

CINCO STONELINEAR PATTERN

CINCO STONE AND CINCO BRICK MODULAR PATTERN

CINCO STONE AND CINCO BRICK LINEAR PATTERN

SIZES

Note: *These dimensions are actual. Allow a 3/8 inch (10 mm) mortar joint in order to obtain nominal dimensions.

7 23

/32

in*

(196

mm

)

19 5/8 in*(499 mm)

Depth3 1/2 in*(90 mm)

11 5/8 in*(295 mm)

17 5/8 in*(448 mm)

15 5/8 in*(397 mm)

13 5/8 in*(346 mm)


18 – DESCRIPTIVE DATA SHEET / CINCO® BRICK

CINCO® BRICKDESCRIPTION

Is it brick or stone? Inspired by buildings constructed at the turn of

the last century, Cinco brick was created in part to resemble stone.

With its wide array of matched colours and lengths, Cinco brick

creates the perfect accompaniment for Lafi tt stone and Cinco stone.

Cinco brick offers you a visual impact at an affordable price. Its unique

height makes the installation similar to brick both in pattern and cost,

while its choice of lengths and textures closely resemble stone. This

product has everything you need to turn your imagination loose.


• Combines the best of stone and brick.

• Harmonizes perfectly with stone, especially Lafi tt stone, thanks to its

multiple lengths, texture and colours.

• Installs like brick so costs are signifi cantly lower than stone.



UNIT

SIZES (3.2 bricks/ft2)

Note: *These dimensions are actual. Allow a 3/8 inch (10 mm) mortar joint in order to obtain nominal dimensions.

Depth

3 1/2 in*

(90 mm)

15 5/8 in*

(397 mm)

11 5/8 in*

(295 mm)

13 5/8 in*

(346 mm)

9 5/8 in*

(244 mm)

7 5/8 in*

(194 mm)

3 5

/8 in

*

(92

mm

)

18 – DESCRIPTIVE DATA SHEET / CINCO® BRICK


DESCRIPTIVE DATA SHEET / MELVILLE NORMAN® BRICK – 19

MELVILLE® NORMAN BRICKDESCRIPTION

This new, ultra-trendy contemporary brick has long and slender

proportions. It comes in a smooth fi nish with sharp edges and its

manufacturing process offers unparalleled dimensional stability for this

brick format.

The result is a modern look with clean lines and an even surface. What’s

more, the colours pair beautifully with Lexa stone and other Permacon

masonry and landscaping products.


• Choice of trendy colours

• Manufacturing process offers unparalleled dimensional stability

to the brick

• Laying with 1/3 running bond pattern avoids cuttiny bricks at the

corner for a more effi cient installation

• Uniform distribution of pigments throughout the bricks that preserve their

colour year after year rather than just on the surface.


Note : *Actual dimensions. Allow 3/8 in (10 mm) mortar joint in order to obtain nominal dimensions.

2 1/4 in*

(57 mm)

3 1/2 in*

(90 mm)

11 1/2 in*

(290 mm)

3 1/2 in x 2 1/4 in x 11 1/2 in

90 mm x 57 mm x 290 mm

UNITS


20 – DESCRIPTIVE DATA SHEET / MELVILLE® SLIK BRICK

MELVILLE® SLIK BRICKDESCRIPTION

Melville Slik brick is a classic brick designed to offer major cost benefi ts

(materials and installation). Melville Slik brick has a smooth texture with

sharped edges.

Offered in a larger size and available in a wide variety of earth tones,

this versatile urban-style brick can be used alone or in combination with

stone. Melville Slik brick also coordinates perfectly with Permacon’s

masonry and various other landscaping products.


• Choice of earth tones and subtle colours.

• Size lowers overall costs (materials and installation).

• Holes in the brick make it easier to install and provide increased

adhesion to mortar.

• Uniform distribution of pigments throughout the brick that preserve

their colour year after year rather than just on the surface.

• Perfect complement to Dufferin Plus stone and many of Permacon’s

landscaping products to create a stunning overall effect.

A

3 1/2 in x 3 1/8 in x 10 1/8 in

90 mm x 79 mm x 257 mm

B

3 1/2 in x 3 1/8 in x 10 1/8 / 8 3/8 in

90 mm x 79 mm x 257/212 mm

UNITS


Note: *Actual dimensions. Allow 3/8 in. (10 mm) mortar joint in order to obtain nominal dimensions.

17 percent of the brick on the pallet are in the angled format.

3 1/8 in*

(79 mm)

3 1/2 in*

(90 mm)

10 1/8 in*

(257 mm)

3 1/8 in*

(79 mm)

3 1/2 in*

(90 mm)

10 1/8 in*

(257 mm)

8 3/8 in*

(212 mm)


DESCRIPTIVE DATA SHEET / URBANIKA® BRICK AND STONE – 21

URBANIKA® BRICK AND STONEDESCRIPTION

With its generous proportions, lightly chiseled texture, and sharped edges,

Urbanika brick gives your home a clean, contemporary look. Urbanika

stone with a slate-like texture is also available in the same family. It is

ideal for the starting course of a masonry wall, and its modular format

complements Urbanika brick perfectly—making it a valuable asset for

designing projects


• Choice of trendy and subtle colours.

• Size lowers overall costs (materials and installation).

• Uniform distribution of pigments throughout the brick that preserve

their colour year after year rather than just on the surface.

A

3 1/2 in x 3 1/2 in x 11 7/16 in

90 mm x 90 mm x 290 mm

B

3 1/2 in x 7 1/2 in x 15 3/8 in

90 mm x 190 mm x 390 mm

UNITS


Note: *Actual dimensions. Allow 3/8 in. (10 mm) mortar joint in order to obtain nominal dimensions.

17 percent of the brick on the pallet are in the angled format.

3 1/2 in*

(90 mm)

3 1/2 in*

(90 mm)

11 7/8 in*

(290 mm)

7 1/2 in*

(190 mm)

3 1/2 in*

(90 mm)

15 3/8 in*

(390 mm)


SILL – BUFFED

5 1/2” X 23 1/4” X 3 1/2”

140 mm x 590 mm x 90 mm

(jamb and lintel)

BLOCK 600 – BUFFED

3 1/2” x 7 1/2” x 23 1/4”

90 mm x 190 mm x 590 mm

REVERSIBLE SILL –

SMOOTH OR GUILLOTINE

5 11/16” X 36” X 3”

145 mm x 914 mm x 75 mm

(jamb and lintel)

QUOIN 2 – SMOOTH

11 7/16” x 23 1/4” x 3 1/2”

290 mm x 590 mm x 90 mm

BLOCK 400 – BUFFED

3 1/2” x 7 1/2” x 15 3/8”

90 mm x 190 mm x 390 mm

RECTANGULAR COPING – BUFFED

3 1/2” x 15 3/8” x 23 1/4”

90 mm x 390 mm x 590 mm

QUOIN 1 – SMOOTH

7 1/2” x 23 1/4” x 3 1/2”

190 mm x 590 mm x 90 mm

QUOIN 3 – SMOOTH

7 1/2” x 15 3/8” x 3 1/2”

190 mm x 390 mm x 90 mm

JAMB – SMOOTH

10 1/8” X 36” X 3 1/2”

257 mm x 914 mm x 90 mm

BUFFED

SMOOTH

22 – DESCRIPTIVE DATA SHEET / CARDIFF® ACCESSORIES

UNITS (SOLD SEPARATELY)

CARDIFF® ACCESSORIESDESCRIPTION

This range of ornamental stones will enhance the exterior appearance of

your home with a distinctive look. Such features as high density concrete

makes for a durable and aesthetic material. Cardiff accessories with three

fi nishes available also offer great fl exibility for numerous applications.


• Savings on material thanks to its longer sill and jamb lengths,

means less cuts and waste onsite.

• High density concrete makes it more durable.

• Flexibility and innovation in the design thanks to its RocArt

chiselled, buffed and smooth fi nishes.

• Choice of neutral colours that can easily be matched with all products.

• The chiselled texture sill matches the height of a max size brick

such as Melville Slik brick.

• The RocArt fi nish keystone allows for a one inch (25 mm) projection

while keeping a 90 mm deep mortar bed.

• The RocArt, buffed or smooth fi nish sills can also be used as jambs or lintels.

ROCART

SILL – ROCART

5 7/8 in x 36 in x 3 1/2 in

150 mm x 914 mm x 90 mm

(jamb and lintel)

KEYSTONE – ROCART

4 1/2 in x 9 7/16 / 4 1/2 in x 12 1/4 in

115 mm x 240 / 115 mm x 310 mm

CHISELLED

SILL – CHISELLED

5 7/8 in x 37 3/8 in x 3 1/8 in

150 mm x 948 mm x 79 mm

(jamb and lintel)

KEYSTONE – CHISELLED

3 1/2 in x 7 7/8 / 5 7/8 in x 10 1/4 in

90 mm x 200 / 150 mm x 260 mm

QUOIN – CHISELLED

3 1/2 in x 23 3/8 in x 11 1/2 in

90 mm x 593 mm x 290 mm

JAMB– CHISELLED

5 1/2 in x 23 3/8 in x 3 1/2 in

140 mm x 593 mm x 90 mm


POSSIBILITIES OF APPLICATIONS FOR CARDIFF ACCESSORIES

WINDOW OR DOOR SURROUND WINDOW OR DOOR SURROUND

CORNER DETAIL SKIRT WALL

DESCRIPTIVE DATA SHEET / CARDIFF® ACCESSORIES – 23


24 – SEAMLESS TEXTURES AND HATCHING PATTERNS LIBRARY

Seamless textures and hatching patterns libraryAVAILABILITY CHART

Download all the seamless textures and hatching patterns available

from our website: http://www.permaconpro.ca/pro_support.html

Download Permacon hatching patterns for the following types of

software: AutoCAD, Dynascape

Download Permacon seamless textures for the following types of

software: AutoCAD, Dynascape, Google Sketchup, Photoshop

Seamlesstextures

Hatching patterns

Mondrian Stone • •Lafitt Stone • •lexa Stone • •Dufferin Plus Stone • •Lamina Stone • •Cinco Stone • •Cinco Brick • •Melville Slik Brick • •Melville Norman Brick • •Urbanika Brick • •Urbanika Stone • •Cardiff Stone • N/A



1-888-PERMACON

PERMACON.CA

PERMACON BOLTON

3 BETOMAT COURT

BOLTON, ONTARIO L7E 2V9

TELEPHONE: 905-857-6773

FAX: 905-857-4774

PERMACON MILTON

8375 5th SIDE ROAD

MILTON, ONTARIO L9T 2X7

TELEPHONE: 905-875-4215

FAX: 905-875-1350

PERMACON OTTAWA SOUTH

6860 BANK STREET

METCALFE, ONTARIO K0A 2P0

TELEPHONE: 613-821-0898

1-800-361-2707

FAX: 613-821-4593

PERMACON OTTAWA WEST

6775 HAZELDEAN ROAD

STITTSVILLE, ONTARIO K2S 1B9

TELEPHONE: 613-821-0898

1-800-361-2707

FAX: 613-821-4593

PERMACON ST-EUSTACHE

500, RUE SAINT-EUSTACHE

SAINT-EUSTACHE, QUEBEC J7R 7E7

TELEPHONE: 450-491-7800

FAX: 450-491-1071

PERMACON MONTREAL

8140, BOMBARDIER STREET

ANJOU, QUEBEC H1J 1A4

TELEPHONE: 514-351-2120

FAX: 514-351-7454

PERMACON QUEBEC

8845, PIERRE-BERTRAND BLVD

QUÉBEC, QUEBEC G2K 1W2

TELEPHONE: 418-622-3333

FAX: 418-622-9603

PERMACON SHERBROOKE

1080, PANNETON STREET

SHERBROOKE, QUEBEC J1K 2B4

TELEPHONE: 819-564-1414

FAX: 819-564-1340

PERMACON TROIS-RIVIÈRES

1100, DE LA COMMUNE BLVD

TROIS-RIVIÈRES, QUEBEC G9A 2W6

TELEPHONE: 819-378-2721

FAX: 819-378-6125

C1-C4_MacGuideTecInst17.indd 1C1-C4_MacGuideTecInst17.indd 1 2017-04-18 9:42 AM2017-04-18 9:42 AM

Documents

INSTALLATION GUIDE RESIDENTIAL MASONRY 2017permacon.ca/sites/default/files/2017-07/GuideTechMaconnerie_Ang17.pdf · INSTALLATION GUIDE RESIDENTIAL MASONRY 2017 ... Laﬁ tt stone