Upload
others
View
31
Download
0
Embed Size (px)
Citation preview
SPECIFICATIONS
Amplifier Section
Continous Max. Output Voltage is 8 Volts Per Channel,
Min., at 47 Kohms from 20Hz to 20kHz with no more than
0.02% totaharmonic distortion.
e Input (Sensitivity/Impedance)
SN ey Zee ree ee, coe 2.5mV /47 Ki
Tuner, Aux/Video, CD, Tape 1, 2 Play .. 150mV /47K&2
» Phono Overload Level (T.H.D. 0.1%, tkHz)
Tape i 2 Hetake sare eae ee 1450mV/2.2K&2
e Frequency Response
Phono 1, 2 (RIAA Equalization)
ig bcd Gee CLE EES BE 90Hz to 20kHz = 0.5dB
Tuner, Aux/Video, CD, Tape 1, 2 Play
nee hes BRE TRE NE 20Hz to 80kHz = 3dB
@ Tone Control
Pace (TOUR 2) ep. et eee eee et + 10dB
Treble (LOK 2)] Sak aoe Be ees SO + 10dB
® Loudness Control (Volume Control set at —40dB
er 8 *# # © —
Position) ..- eee +7dB (100Hz), + 4dB (10kHz)
e Subsonic Filter. .-.---2 eee 20Hz (—12dB/Oct)
e High Filter... . 6s eer! 8KHz (—12dB/Oct)
eMNNeawowe eae ee ee ee et —20dB
e Hum & Noise (IHF, Short-Circuited, A Network)
ST 7 SN ee ee 95dB
Tuner, Aux, CD, Tape 1. 2PIGV oc eee Fee 110dB
Miscellaneous
Power Requirements ...-----+ s+ -ce- AISD>0V . 50Hz
Power Consumption. ...----e+ eset en ree _ .30W
Dimensions ..-----:°°° 420(W) x 88(H)« 380(D)mm
Weight (without package)... .- +e eee rer tte .5.9kg
Furnished Parts
Operating Instructions ..---- +s srr
Connection Cord....--- seer
Note:
e Specifications and design subject to possi tie modifica-
tion without notice due to improvements.
FRONT PANEL FEATURES
ome |
1. POWER SWITCH
C ress to ON position to turn on the pre-amplifier. Upon power up, a muting circuit presents a short delay in order to suppress the sometimes annoying sound present at switch-on.
2. 3. BASS AND TREBLE CONTROLS Use these controls to adjust the bass and the treble. If you turn the bass control clockwise from its center Position, you will be able to emphasize the sound in the low- frequency range. Conversely, turning the bass control counter clockwise from the center position, you will attenuate the sound. Use the treble contro! to adjust the sound in the high- frequency range in the same manner.
4. BALANCE CONTROL Use this control to balance the volume of the left and right channels.
-. 5, VOLUME CONTROL oe this control to adjust the output level to the speakers
and headphones. Turn it clockwise to increase the output level. No sound will be heard if you set it to “o”’.
6. HEADPHONE JACK Plug the headphones into this Jack when you want to listen through your stereo headphones. Besure to turn down the volume level before plugging in the headphones. Turn up the volume level to a comfortable listening level once the headphonese are adjusted.
7. FUNCTION SELECTOR Use this selector to select the Program source. When set, the function indicator above the Panel corresponding to the Position of the function selector will light up. CD: Select when you wish to listen to a Compact Disc
Player.
AUX: Select when listening to a program source which is conected to the AUX jacks.
TUNER: Select when listening to radio broadcasts from the tuner.
PHONO 1, 2: Select either Phono 1 or Phono 2 when playing a record on the corresponding turn- table.
8. FUNCTION INDICATORS The CD, AUX, TUNER, PHONO 1, 2 function indicators light up in accordance with the position of the function selector.
9. TAPE MONITOR SWITCH Use these buttons to select the program source which is being reproduced.
TAPE 1: Select to monitor a recording or a tape being played back on the tape deck which is connected to the TAPE 1 jacks.
TAPE 2: Select to monitor a recording or a tape being played back on the tape deck which is connected to the TAPE 2 jacks.
OFF: Select whenever you are not playing back a tape or monitoring a recording.
10. TAPE COPY SWITCH Use these switches when using two tape decks to copy recorded tapes or edit tapes. This switch is otherwise kept at the OFF position. “TAPE 12: When Playing back the tape on a deck con-
nected to the TAPE 1 jacks and recording (copying) on a deck connected to the TAPE 2 jacks.
TAPE 2» 1: When Playing back the tape on a deck con- nected to the TAPE 2 jacks and recording (copying) on a deck connected to the TAPE 1 jacks.
OFF: Set to this position when not copying.
11. MUTE SWITCH Set this switch to — 20dB to attenuate the audio output indicated by the volume control by 20dB.
12. SUBSONIC FILTER SWITCH When depressed, the subsonic filter (20Hz cut-off) reduces turn-table rumble, record warp noise and other ultra low frequency noise.
13. LOUDNESS SWITCH This compensates for human hearing characteristics by boosting the bass and treble response at low volume listening levels to achieve a more pleasing tone balance.
14. TONE SWITCH Set this switch to ON when adjusting the bass and treble controls. When set to OFF, the tone contro] Circuits are disengaged and frequency response is flat. This function is convenient for checking Phono cartridge and speaker tone quality and listening room acoustics.
15. HIGH FILTER SWITCH The high filter with a cut-off frequency of 8kHz is actuated when this switch is set to the 8kHz position. The high filter serves to attenuate frequencies higher than 8kHz in a 12dB/oct slope. This is why it is effective in suppressing high-frequency noise or noise from scratches on records being played.
16. MONO The sound from the L channel and R channel is mixed, and heard from both left and right speaker systems. Apart from playing back monaural sources, this switch is useful for checking the phase of the speaker system and volume balance.
hasan eetamiaeteintaeentaeemeteemmmentneiore enema rere eT
BLOCK DIAGRAM
®)
“™
@&
| | | |
-P
| | =
BASS
TONE AMP PART
TREBLE
----------------- TONE
PART
Le
BALANCE
:
| |
|
Po
F
que
ene
Gas
ou
Gms
eam
eae
| ame
aw
owen
ow
B
Ww
¢
rs
7
/EL@
LOH
13
z
4h
1
le
|
a1
°
|
og
4
lé
| P 3
|
=
aa 7
| |
‘h 4
a
| OC
| ‘
3
3 a
| |
_| |
| ee me ens axe Gu GED GED Gm GD om | con oe en
DD om
3
ra
3
oO
uw
4
23 y
|
i 8
t
9
é |
:
to ot
| q
AC 220V/50Hz
———
aes ee
GS Ree
| r
} eee
rr Te
|
a ee eae
enn nn n=
!
MWB
OE
r
isan
eae
4
Cf
©
ot
!
|
=
<q
| ! a
.
——
3
ji &
yore
| Tk
| |
| 2!
| Raila
ae
|é
- .
) F |
ens oe
s
i
ma
: WB
SoH ant
ae |
! 50" a
fist | i ine ha =e
=
9
bax |
Se ee 2 —
ee
= zi
Cees
.
L|.--
~] [
. .
ee
1
TAPE COPY PART
L
| !
:
2 2
5 Bg
eo 9
&g 5
:
:
Ss a
Fee
*
: Let
Ly
|
arene
eee
L
CHANNEL
7 R CHANNEL
(THE SAMe AS THE
> GREED GD GEESE GD CESSES GD CEE 6S CEE 2 GSES aD
L CHANNEL. )
2 CEES GD CEES GD GEER eS Goes CHD = a
STirin
ASSEMBLY
XS os SG
woe
warrrtKn ENO
j v4 et
a z
, re
|
{ A- 170 —- 186- 02 )
SWITCH
( A- I70 — 185 — 02 )
(ER ) evar
FUNCTION
ASSEMBLY
ar ASSEMBLY
CONTROL
oe aoe T ONES ) i
Q~ck
es: pesspipsinerati
SIE EE Le
pe
eT
|
|g E
a) 1 88
| 010.0.0.0000000000000000
1 98
i et
| TUONO
UOUUO HU
UO OUN0UUT
=
- z
a
; aie
: i
a
so!
a
) Lio bee
eH
@
g g
x
a x .
d rs)
u x
SCHEMATIC DIAGRAM
> xT S2l- 1: MOND «OFF On OS50i- 504 | 280ul7~-oRsaTur—on/Y
2: MUTE OFF Om Q505— 508 © KTASTO-OR FLAT AMP
@301,3%2 : 2K 6— OR ® :
Se al ee a ctr 0508 ,510 | KTDeSO- v/0
O31-B4, 317-320: KTTZ2AO-OL sf
{ = baa, so2 > SIs eos & =e ay,
PHONO EQUALIZER
sS0r-u 2) s501-20/2
ee [ge UH Rete ayaeal lem =a iE =
eel eet see EL
S
nae SSOGOO] ehh 8 [560000]
tT
STO: SUBECMEC FILTER OFF OW 8702: HHGM FILTER OFF ON
a
QIQ7 : KTASIT—Y
Q008 : KTCIG6ZT-V
IN4002
5] me coal a F Ae see
° ai a sSoP
R204 7 ee Ee ae ’ S328
D2I7 : KLR RED
22K
D 28,219221-225 : KG «GREEN
AED
ates Poca dee cake: -59 55959901
266
fad - ho See
SS eae
r+ @ mes Spat 1999900009] oe ee ee Oe
Cau or, eatin
S30P] 330°4 7%
L sa
aries ma, 1/en,2 5%
Q90 O90
500000 s101-— 2
TOLERANCE UnLERS OTHERWISE lot”
2. CAPACITORS HH
IMOICATED 1 CAPACITY WD / / Bees
VOLTAGE (V) UMLESS OTHERWISE [|__| giesio LTV
NOTED P : pf.
a vam Sin sn
C7 :-pe worase(v) |
Tres ts THE Bac SCHEMATIC PLAY
pigment, BUT THE = ACTUAL | sioi—3 |
caacurr may Wary DUE TO quae an ee EEE AS SS SSS SS ALAA Si? =
eee ee ie eer S10l—1: TRE COPY OFF ic wLIO2) «6: «Lc7ee o2 > TSA (7S) sea-i: Tom on «OFF Qt, 403,404 . KTDeSeO-v/0 DIO! - 4,107, 208 © inecos
sian-2: TAPE mB ON OFF QZOI—GZOS, 118: KTC wes— GR/ Y D2, 211,24: sues? (ev) 860-2. sumecmIc on OFF Q2,408,406 . KTBS34-Y/0 0105 ,106,303 © mseeB(20v)
g00t-3. TE BOON OOFE our * KTAIONS~ GY 0203-208 . eal aa SEOi- 3: HOM FULTER OM OFF QOS, 105, 401,e08 : KTC2240- BL/GR 0304 ¢ a 7Sza (S6v)
9304 © IN?7S2 0220 - (m 7SORC4. TV) 023,215 | Q80 1-608 , FOI-702 © KIT Z240-GR QN04, 106 : STASTO— OL/ GR
D303 | ineee(20v) 0210, 108 : InsesBUIS¥) D108 401,408 Q703, 704: KTC2240-8L Q107 : KTASIT— WO
0301, 302 aide : «KIC B27T-Y/O
EXPLODED VIEW
ELECTRICAL PARTS LIST
Notes: When ordering parts, first convert Resistance value
into Code from as shown in the following examples.
RESISTORS:
1114 (100) 25 Carbon Film Resistor, 5%, 1/4W, Tapping ex) Resistor Value
4.7... 479 56 ass 560 680 ..... 681
8.2K .... 822 : 4 reer 123 220K ..... 224
ELECTROLYTIC CAP.:
1420)000 65 Electrolytic Capacitor, 20%, Tapping ex} Working Voltage
T6V ..... 3 25 ccces 4 SOM Szesiee 5 SOV ..... 6 63V ..... 7 6.3V 1
CERAMIC CAP.:
1886 O10) 41 ~— Ceramic Capacitor,SL, +5%, Non-Tapping. ex) CKD YB... 716 CKDYF...756 CCD CH....806
CCDSL .... 886 CCD RH...846 CCD TH....866
Capacitor Value
4PF...... 040 A7PF ....... 470 220PF ..... 221 1800PF... 182 O.01pF ..... 103 0.047uF.... 473
Tolerance
C=t0 25pF..0 D=tO5pF...1 F=ti1pF.... 2
Bay, eee 4 K=+10%..... 5 2= +80 9 99°"
MYLAR CAP-::
1506 (]01(051 Mylar Capacitor, Standard, + 10%, Non- Tapping
ex) Capacitor Value |
0.0015uF ....152 O.0O27nF ... 273 O.lueF.... 104
Tolerance
J=+5%...4 K=2t10%.... 5
STYROL CAP.:
1536 (JOIC) 41 Styrol Capacitor, + 5%, Non-Tapping ex) Capacitor Value
430pF ..... 431 1800pF ... 182 .
Miscellaneous Parts
P.C Board Assemblies
289960101 EARTH WIRE
PARTS NO. DESCRIPTION CAPACITORS
A17A18602 CONTROL ASS'Y REF.NO. PARTS NO. DESCRIPTION
A17A18602 CONTROL ASS'Y C202, C203, C217 142601065 ELEC, CAP, CEA, 1, 50V C218, C338
AF ASSEMBLY C336 142622965 ELEC. CAP, CEA, 2.2, 50V C337 142633965 ELEC. CAP, CEA, 3.3, 50V C116, C207, C208 142647965 ELEC. CAP, CEA, 4.7, 50V C211, C212 C226, C229, C233 142310065 ELEC, CAP, CEA, 10, 16V
REF. NO. PARTS NO. DESCRIPTION a ee a
10101, 1C102 244132472 IC, LC7818 C246, C249, C253 0301, Q302 240410511 F.E.T. 2SK 146-GR C256, C259, C263 Q102, 0405, 0406 240110321 TR, KTB834-Y C266, C269, C326 Q101, 0403, Q404 240310621 TR, KTD880-Y C327 O104, 0108, 0303240011425 TR. KTA970-BL C201, C221, C222 142447065 ELEC. CAP, CEA, 47, 25V
Q304, 0308. 0306 C117 142310165 ELEC. CAP, CEA, 100, 16V
aaGs sen Ga00 C112, C113 142410165 ELEC. CAP, CEA, 100, 25V
sang ass Gate C114, C115, C331 «142510165 ELEC. CAP, CEA, 100, 35V
Q108 240210921 TR, KTC1627A-Y C332, C333, C334 0311, 0312, 0313 240211828 TR, KTC2240-BL C107, C108 142633061 ELEC. CAP, CEA, 33, 50V
Bea ea eas C319, C321 142322161 ELEC. CAP, CEA, 220, 16V
ener C105, C106 142610261 ELEC. CAP, CEA, 1000, 50V
O103, 0108, 0401 240211825 TR, KTC2240-GR C204, C216 142422261 ELEC. CAP, CEA, 2200, 25V
nee C403, C404 142347161 ELEC. CAP, CEA, 470, 16V
Q118, Q201,Q202 240211135 TR, KTC1815-GR C223 142433065 ELEC. CAP, CEA, 33, 25V
0203 C206, C213, C401 142410065 ELEC. CAP, CEA, 10, 25V
Q117 240011831 TR, KTA1015-GR C402 ae 740010421. TR. KTABITACY C214 142610161 ELEC. CAP, CEA, 100, 50V
D108, D203, D204 241017995 DIODE, ISS133 C118 142647865 ELEC. CAP, CEA, 0.47, 50V
5205, D206. D207 C317, C318 188618045 CERAMIC CAP, CCDSL, 18J
0208. D213, D215 C109, C111 188610345 CERAMIC CAP, CCDSL, 103J
5307 D302, DA0t C302, C304, C306 188622145 CERAMIC CAP, CCDSL, 221J
AOD C308 101, D102, D103. 241318111 DIODE, 1N4002 C224, C225,C227 188633145 CERAMIC CAP, CCDSL, 331J
mid G07 0202 C228, C231, C232 Seed pre C234, C235, C237
D201, D211, D214 242118031 ZENER DIODE, 1N967B, 18V C238, C241, C242
D105, D106, D303.-« 242120031 ZENER DIODE, 1N968B, 20V C244, C245, C247
D108, 0210 742113031 ZENER DIODE, 1N964B, 13V C248, C251, C252
D216 742107541 ZENER DIODE, 1N755A, 7.5V C254, C255, C257 D220 742104731 ZENER DIODE, 1N745A, 4.7V C258, C261, C262
D304 742105651 ZENER DIODE, 1N752A, 5.6V C264, C265, C267 C268, C301, C303
C407, C408, C409 188647145 CERAMIC CAP, CCDSL, 4715 C411
REF. NO. PARTS NO. DESCRIPTION C497 188627145 CERAMIC CAP, CCDSL, 271J C499 188627141 CERAMIC CAP,CCDSL,271J |
POM See ne ance C300 175647355 CERAMIC CAP, CKDYF, 473K. S Cechaei: GE ein iAGk C311, C312 150612241 MYLAR CAP, COMA, 122J
aaa Se ai. cee OR C328, C329 150639241 MYLAR CAP, COMA, 392J
pied Bee a. PONT OR ee C313, C314 150633341 MYLAR CAP, COMA, 333J
a STEEL 16G1. CONNECTOR. AC C206, C215, C322 150647341 MYLAR CAP, CQMA, 473J
ae sta Oca Ee C315, C316 150612441 MYLAR CAP, COMA, 124J
ae Se ani 1 ONNECTOR Ob C324, C325 150647241 MYLAR CAP, COMA, 4724
CN101 215858501 CONNECTOR, 10P CN106 216812201 WAFER, 3P C101 199810401
: 213126202 POWER TRANSFORMER F101 218862101 T250mA/250V S101 220221001 POWER SWITCH
221110901 AC, POWER CORD
REF. NO.
R116 R101, R107 R201, R233 R361
R231 R114
i
RESISTORS
PARTS NO.
113133223
113247923 113147123
113156123 113182123 113110223 113147223
CONTROL ASSEMBLY
SEMICONDUCTORS
REF. NO.
Q501, Q502, Q503
Q504
0505, Q506, Q507
Q508
0601, Q602, Q603
Q604, Q701, Q702
. 9, Q510
(2,03, Q704
D217
D218, 0219, 0221
D222, 0223, D224
D225
PARTS NO.
240410441
240011411
240211811
240310621 240211821 241912101 241902101
DESCRIPTION
METAL OXCIDE, 3.3K, 1W
METAL OXCIDE, 4.7, 2W METAL OXCIDE, 470, 1W
METAL OXCIDE, 560, 1W METAL OXCIDE, 820, 1W METAL OXCIDE, 1K, 1W METAL OXCIDE, 4.7K, TW
DESCRIPTION
F.E.T. KTK117-BL
TR, KTA970-GR
TR, KTC2240-GR
TR, KTD880-Y TR, KTC2240-BL LED, KLR114E LED, KLGI1I4E
OTHERS
REF. NO.
VR102 VR101 VR103, VR104 $101 $501 S601
$201, $202, 5203 $204, $205, $206 $207, $208
PARTS NO.
250117201 250117301 250121301 220233301 220233201 220233401 220899901
215550901 215911401
DESCRIPTION
BALANCE MAIN
TONE
TACT SW
PHONE JACK CONNECTOR ASS'‘Y, 3P
CAPACITORS
C607, C608, C712 C713 C614, C621, C622 C615 C740, C750 C516, C517, C718 C719 C505, C506, C609 C611, C618, C619 C705, C706 C616, C617, C707 C708, C716, C717 C77, C78, C93, C94, C666, C667 C509, C511, C512 C513, C612, C613 C507, C508, C514 C515 C501, C502 C605, C606 C709, C711 C601, C602, C603 C604 C701, C702, C703 C704 C714, C715 C503, C504
142601061
142622961
142647961 142610061
142510161
145547961
142610061
188633041
188610141
188627141 188668141 188668141 150622341
150633341
150622241 150647341
PARTS NO. DESCRIPTION
ELEC.CAP, CEA, 1, 50V
ELEC. CAP, CEA, 2.2, 50V
ELEC. CAP, CEA, 4.7, 50V ELEC. CAP, CEA, 10, 50V
ELEC. CAP, CEA, 100, 35V
ELEC. CAP, CEA, 4.7, 35V
ELEC. CAP, CEA, 10, 35V
CERAMIC CAP, CCDSL, 33J
CERAMIC CAP, CCDSL, 101J
CERAMIC CAP, CCDSL, 271J CERAMIC CAP, CCDSL, 681J
CERAMIC CAP, CCDSL, 681J MYLAR CAP, COMA, 223J
MYLAR CAP, CQMA, 333J
MYLAR CAP, CQMA, 222J MYLAR CAP, CQMA, 6814
PARTS LIST EXTERIOR
NO PARTS NAME
EARTH WIRE
KNOB ASS'Y VR NUT PANEL, FRONT
NUT, JACK MIC
oOmMnN AOA hWN = PANEL, BASE
10 KNOB, POWER
11 PHONE, JACK
12 KNOB, TACT STATION(A)
13 KNOB, TACT STATION(B)
14 FOOT ASS'Y
15 FRAME, SIDE (R)
16 FOOT
17 COVER, BOTTOM
18 JOINT, P.C.B
19 KNOB, PUSH
20 JOINT, POWER
21 FRAME, SIDE(L)
22 JOINT, POWER
23 POWER, S/W
24 CUSHION
25 MAIN, P.C.B
26 BUSHING, STRAIN R/F
27 PANEL, REAR
28 TERMINAL, EARTH
29 CORD POWER(AC)
30 BOARD SIDE (L)
31 BONNET
32 BOARD SIDE (R)
33 TRANS
34 HEAT SINK
35 CONTROL P.C.B
36 FUNCTION S/W ASS'Y
37 SHEET, SIDE
38 BADGE
39 SCREW
40 WASHER
41 SCREW
42 SCREW
43 SCREW
44 SCREW
KNOB ASS'Y, ROTARY
LENS, INDICATOR
DECORATION, SIDE
PARTS NO.
289930701
311481701
311481801
311607002
311510101
311091804
711312009
311480501
311480301
364030101
215550901
311481501
311481601
311481001
331622401
311480801
331622501
364032111
331093502
381070501
331622301
381030301
217018641
371510501
A17018501
820111501
311510201
215570501
221110901
311481201
311480601
311481101
213126202
331204501
217016611
217018631
311472701
321410401
746440801
702005003
776840601
776842001
776441001
776440601
MATERIAL
Al + ABS
Al + ABS
Al
PMMA
ABS
ABS
ABS
ABS
ABS
Al+ TPR
SECC
TPR
SECC
MYLON 6
ABS
ABS
SECC
ABS
EVA
P.C.B
NYLON
SECC
MDF
PVC+SECC
MDF
Al
P.C.B
P.C.B
PVC
Q “4 <
seer BWM ON eH NY BAN eB BP eae wAnNe On hms wW
Ww