20
Suitable for all Ferroli Combination Boilers Radio Thermostat Clock Part Number: 30800009 Installation & User Instructions

Radio Thermostat Clock Installation & User Instructions

Embed Size (px)

Citation preview

Page 1: Radio Thermostat Clock Installation & User Instructions

Suitable for all Ferroli Combination Boilers

Radio Thermostat ClockPart Number: 30800009

Installation & User Instructions

Page 2: Radio Thermostat Clock Installation & User Instructions

�������

*����� ��

��� �%�� ��� ���

%�� ���� ��

�� ���� �������1��2���

�� ���������������������� �����

����� ���� ��������

%���������������������

3���� ��������

3�������

��� ���4��

5� �������������� ��

$��� �2��

2

Page 3: Radio Thermostat Clock Installation & User Instructions

Short Description

Short description Radio Thermostat Clock - Transmitter

The Radio Thermostat Clock is a 7 day radio frequency (RF) wirelessthermostat/ timer which communicates with a special receiver designedto replace the universal digital timer fitted to most of Ferroli’s combinationboilers.

The Radio Thermostat Clock is battery powered and can be sitedwherever conventional room thermostats would normally be sited.

In combination with the Radio Thermostat Clock receiver, the RadioThermostat Clock transmitter creates a room thermostat clock of highlyadvanced technology. The device is wireless and controls the heatingboiler via radio, providing comfortable room temperatures.

Safety Instructions

Safety Instructions

Both receiver and transmitter should be fitted by a competent person.

It is imperative to observe the generally applicable safety measures,such as: Before starting any work on fitting the receiver, switch off powersupply and secure against switching on.

Do not use any metallic and sharp pointed objects for the operation ofthe keys.

For technical data, see label on the unit or data sheet.

3

Page 4: Radio Thermostat Clock Installation & User Instructions

���" ������������

# $ % &

$��������� �

5��2�$�������

�� "�'�� ��"

"����7��1�8�'����������

?�� ����7����8�'�����������

�1� ������1�����'�����������,�@�+

(������!�%������������������������� ��� ����#������������������1����� ���������,�@�+#���� �����,�@����������������������� ��� ����)�7%�1������������ ����� ������1����1�2����������8

%�������������� ����1�������� ����#��������������1����+�������������� ��������� ��� ���)

4

Page 5: Radio Thermostat Clock Installation & User Instructions

Optima 01 Range

Domina, Modena and Falcon (MF02)

Step 1 Remove clock from control panel.Step 2 Swap wiring as shown. Make sure Live is connected to terminal 1 (wire

colour is not conclusive of polarity)Step 3 Fit receiver into control panel.

Note. If the Radio thermostat clock is going to replace the existing room thermostatthis must be linked out on the room thermostat terminal block.

RadioThermostat

Clock Receiver

UniversalDigitalClock

4 3 2 1

5 3 2 1

Step 1 Remove clock from control panel.Step 2 Swap wiring as shown. Make sure Live is connected to terminal 1 (wire

colour is not conclusive of polarity)Step 3 Fit receiver into control panel.

Note. If the Radio thermostat clock is going to replace the existing room thermostatthis must be linked out on the room thermostat terminal block located in the electricalcompartment on the underside of the boiler.

RadioThermostat

Clock Receiver

UniversalDigitalClock

4 3 2 1

5 3 2 1

5

Page 6: Radio Thermostat Clock Installation & User Instructions

Domina, Modena and Falcon

Step 1 Remove clock from control panel.Step 2 Swap wiring as shown. Make sure Live is connected to terminal 1 (wire

colour is not conclusive of polarity)Step 3 Fit receiver into control panel.

Domicompact Range

RadioThermostat

Clock Receiver

UniversalDigitalClock

4 3 2 1

5 3 2 1

Note. If the Radio thermostat clock is going to replace the existing room thermostatthis must be linked out on the room thermostat terminal block.

RadioThermostat

Clock Receiver

UniversalDigitalClock

4 3 2 1

5 3 2 1

Step 1 Remove clock from control panel.Step 2 Swap wiring as shown. Make sure Live is connected to

terminal 1 (wire colour is not conclusive of polarity)Step 3 Fit receiver into control panel.

Note. If the Radio thermostat clock is going to replace the existing room thermostatthis must be linked out on the room thermostat terminal block.

6

Page 7: Radio Thermostat Clock Installation & User Instructions

Optimax 25C

Step 1 Remove clock from control panel.Step 2 Swap wiring as shown.Step 3 Fit receiver into control panel.

Maxima 35C

Step 1 Remove the boiler front cover and lower the control box.

Step 2 Remove the terminal block cover.Step 3 Cut off connect block bare back wires

approx. 7mm and connect brown to terminal 1 and blue to terminal 3 on the outlet side of the block.

Step 4 Connect brown and blue onto receiverterminals 1 and 2. Make sure live is connected to terminal 1.

Step 5 Connect the two grey wires to terminal 3 and 4 on the receiver. On the main boiler terminal block remove link wire from terminals 4 and 5 and connect the two grey wires.

RadioThermostat

Clock Receiver

UniversalDigitalClock

4 3 2 1

5 3 2 1

Note. If the Radio thermostat clock is going to replace the existing room thermostatthis must be linked out on the room thermostat terminal block.

7

Step 6 Place receiver on back of terminal block cover and mark two diagonallyopposed fixing holes, with the cover removed drill two 2.2mm holes.Mount the receiver using the shortest two screws supplied with the radiothermostat.

Page 8: Radio Thermostat Clock Installation & User Instructions

Optimax HE Range

Step 1 Remove boiler outer case and lower control box.Step 2 Remove control box cover.Step 3 Connect brown and blue JST plug onto PCB terminal block X2.

Step 4 Connect brown and blue onto receiver terminals 1 and 2. Make sure live is connected to terminal 1. (the wire colour is not conclusive of polarity) .

Step 5 Connect the two grey wires to terminal 3 and 4 on the receiver. Onthe main boiler terminal block remove link wire from terminals 5 and 6 and connect the two grey wires.

Step 6 Place receiver on back of terminal block cover and mark twodiagonally opposed fixing holes, with the cover removed drill two 2.2mm holes. Mount the receiver using the shortest two screws supplied with the radio thermostat.

8

Page 9: Radio Thermostat Clock Installation & User Instructions

Installation

ATTENTION!

LED

Button

9

Location

Emergency running mode

If no valid radio signal is received from the receiver for more than 1 hour, emergency runningmode is activated. ED value 12.8 minutes, switch-on time 30%. See page 16.

Radio link installation

1. Install transmitter and select continuous radio operationsystem mode. (See page 17)

2. Press receiver button and hold down for 2 seconds. TheLED flashes twice. Then release the button. The LED remainson between 1 and 10 seconds. When a correct link betweenthe transmitter and receiver has been established the LEDgoes off. Subsequent RF transmissions are indicated visuallyby a momentary flash of the LED.

3. Move transmitter to required location and observe LED tomonitor reception. If no reception and appropriate locationmust be found.

4. Stop continuous radio operation.

1

2

Note: If no reception is possible it has to be checked whether any metalliccupboards or other metallic obstacles may interfere.

Page 10: Radio Thermostat Clock Installation & User Instructions

����������������0

���� �������������

��� ������

����

?���������������

?���������� ������

>�� ��3���� ��

�������3���� ��

3��������4��

�� ����5�����

��� ����3�

5� ��������������� ��

10

Page 11: Radio Thermostat Clock Installation & User Instructions

�����+������'����

�����+���������������+��"���

11

Page 12: Radio Thermostat Clock Installation & User Instructions

������+��( �+ ��

A��������> � �>����� �:������� ��� ������1��2����7 � ��8)�(&��(#� � �������� ���� �������������������� ��� 2�� /����!

> .���.����)�)�'��,.����)�)�'�3���

>�.��0.����)�)�'��6.����)�)-� �)����)�)�'���)����)�)�'�7�����':���������� ��������������������8

>,.���.����)�)�'��+.����)�)�'�5� �����

>+.�3��������������� � ������ ���

>�������> � �>+����� �:����������:�� �������)(�2����"����������� �+ ��

12

Page 13: Radio Thermostat Clock Installation & User Instructions

����"����������� �+ ��

/����

������C39���.���'��0.,�������C3�9��0.,��'���.,�������C39���.,��'���.��

������������ ���C�����9�:� � ���:������������1����:���� )%�� ��������� ���������:� ������������ ,� ����� ��� �0),���

������������ ���C����9�:� � ���:�������������1����:���� )%�� ��������� ��������:� ��������������� ����� ��� ��),���)

����� �����/ �3�����������),���� ���0),��1����:���� �:���������� ���C�����9�:� ��� ����)

���������������3?-�3!!�����������:���� ��������� ������� ��)����� ��������:���� ����,����� ��:��2�)

13

Page 14: Radio Thermostat Clock Installation & User Instructions

)� ����+*����������������� ���

.���������� �����

A �������������#� ������ ��������� �� �����)�!�� ����������������������:������ ��������2��)���������������� ������������:������� ���:��������� ������� �������2��)����������2������1�� ��1� ��:��2� ��� �� ������� ��

)� ����+*�������������+����� ���

������������ ��������������+��"���

������� ������������� ��� � ������������� ������)

)� ����+*����(� ����������

(� ���� �����

������/ ������ ���� �� ������ ���� � ������������� � ������ �������� ��������� )�B� �� �����/ ��������������������� ������ ����1� ������������#� �������� ���1� �����:��2� �� �� ������� ��)

14

Page 15: Radio Thermostat Clock Installation & User Instructions

)� ����+�����-��������������

-������)� �����

%�� ����������������� ������ �������:���� �������� �������:�������)

15

Page 16: Radio Thermostat Clock Installation & User Instructions

)" ��*��

)" �����

%�� �������� ��������������������:�������������2��)������������������������������� ��� �����/ ��1� ����������������� ���)����������������������1�)

��������

�����+�� �"���

�,& ����� �����)����)�7��������� ������ ��#��� ����� ���8

�,% ����� ���� �����)�7��� ������ ���� �������������8

�,$ ����� ������)�����)�7��1��� ������� ��8

����&*���������� �������� ����:� 1���� �� ������ ���������������)������������ ������� �������� ���� �����1��� �������������������� ���� ������ ����������)

16

Page 17: Radio Thermostat Clock Installation & User Instructions

���������� ������ �����

� � ���

'=�%�� ����� � �'=�>����������� �����

���!�%�$&�&��:� ���������������������������������������� �:����'���������)

'=�� � ��������������

17

Page 18: Radio Thermostat Clock Installation & User Instructions

����

18

Page 19: Radio Thermostat Clock Installation & User Instructions

����

19

Page 20: Radio Thermostat Clock Installation & User Instructions

��������������� �� ��������������������� ��� ���������������� ������ ������ �������� ��� ���

�������������������������� ������������ ����� ���� ���������������������������������������

��������������� ���

!������"��� ��#"��������$��#������ ��%���� �����&� � �#���� �'(��'���� #

� ��������)�*& +�,�*�������-�������������.�������������� !�/.�������������0

���������.�������������� !�/.�������������, 80.1

0.11

44.7

/07/

01