Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

1

REMANTA REsearch program on Micro Aerial vehicle

and New Technologies Application

Brieuc DANET(Brieuc.Danet@onera.fr)

4th European Micro-UAV MeetingToulouse, 15th September 2004

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

2

1. Objectives of the Research Program

2. Topic 1 : Experimental Aerodynamics

3. Topic 2 : Flight Mechanics and Control

4. Topic 3 : Materials, Structures, Actuators

5. Continuation of the Project

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

31. Objectives

Objective: Feasability and interest of a flapping-wing MAV

Caracteristics of the vehicle:

• Small size : wing span < 15 cm

• Mass ~ 100 g

• Ability of stationary flight

• Large autonomy

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

41. Objectives

Biomimetism

Understand the phenomena that permit animals to fly

Find accurate technical solutions

Copying nature is not the right way(multipurpose aspect of parts of the body)

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

51. Objectives

Scientific and technological challenge:

Low Reynolds aerodynamics Numerous complex unsteady phenomena (dynamic stall, wake capture)

Control and command of wing kinematics in cruise, stationary Unusual flight dynamics flights and manoeuvers

Huge influence of mass Light materials Flexible structures Aeroelasticity High frequency sollicitations Accurate actuators

Large interactions between the domains

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

6 Topic # 1: Experimental Aerodynamics

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

7

2 objectives:

- qualitative: observe and describe to understand phenomena

Visualizations of aerodynamic flows

- quantitative: correlate wing kinematics with sustentation and propulsion to feed models with empiric data

Measurements of aerodynamic forces and torques

2. Topic #1: Experimental Aerodynamics

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

82. Topic #1: Experimental Aerodynamics

Experiments in the air:

- Uneasy visualizations- Inertial forces >> Aerodynamic forces i.e. difficult analysis of measures

Experiments in water with conservation of :

Reynolds number ( )

and reduced frequency ( )Uc

Re

fcf *

airwaterairwater ffUU ,

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

92. Topic #1: Experimental Aerodynamics

Facilities

Lille: Water Tank

- Section H1.5m x W1.5m x L25m

- V (moving platform) = 0.1 to 1 m/s

- Injection of dyed liquid.

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

102. Topic #1: Experimental Aerodynamics

Facilities

Toulouse: Water Tunnel

- max Flow rate 20 l/s (slaved)

- Section up to H500xP600 (V=13 cm/s)

- Slaved and controlled dyed liquid injection (flow rate and position)

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

11

Testing conditions

• Re ~ 104 - 105

• NACA 0012 Profile (not optimal but well documented)

• Realization of a coupled mechanism 2D : plunging and pitching

3D : flapping and pitching

• Application: cruise flight

• Measurements: - 5 components balance (no axial component) for measurement of forces and torques and evaluations of Cx, Cz,…- Image acquisition. Laser Tomography

2. Topic #1: Experimental Aerodynamics

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

122. Topic #1: Experimental Aerodynamics

2D Mechanism

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

13

3D Mechanism

2. Topic #1: Experimental Aerodynamics

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

142. Topic #1: Experimental Aerodynamics

Mechanism installed on the wall

Coupled Mechanism

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

152. Topic #1: Experimental Aerodynamics

2 testing campaigns (2003 & 2004): More than 800 tests (3D and quasi-2D)

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

16

Results

2. Topic #1: Experimental Aerodynamics

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

172. Topic #1: Experimental Aerodynamics

Visualizations

f = 0.5 Hz ; U = 0 m/s f = 0.5 Hz ; U = 0.25 m/s

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

18 Topic # 2: Flight Mechanics and Control

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

193. Topic #2: Flight Mechanics and Control

Unusual Flight Mechanics

• Model based on the flight analysis of insects and birds

• Cruise and hovering flights

• Linear model + unsteady effects (Dynamic delayed stall, etc)

• Use of aerodynamic data issued from experiments (open literature and ONERA )

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

20 Topic # 3: Materials, Structures, Actuators

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

214. Topic #3: Materials, Structures, Actuators

- Selection, elaboration and characterization of light materials (composites carbon/epoxy)

- Modelization of structures under high frequency requests with aero coupling

- Search of actuators adapted to kinematics

Concepts inspired by nature

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

224. Topic #3: Materials, Structures, Actuators

Light MaterialsTerphane 29 m

Composite T300/914

Total Mass: 0,6 g

60 m

m

60 mm

frequency : 30 Hzdistance between supports : 10 mmdeformation : +/- 0,1 or 0,2 or 0,4 mm

Flexion tests :

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

234. Topic #3: Materials, Structures, Actuators

Structures

Rotation axisFlapping articulation

Pitching articulation

WingCalage

Assumptions:• ROTOR code (D. Petot)• 3D mechanism• Rotation simulates forward flight• Decoupled joints• Classical aerodynamic• Rigid Wing• Low Mass• fondamental beat frequency : 8 Hz

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

244. Topic #3: Materials, Structures, Actuators

Actuators• Dynamical model “at resonance”

• non-linear model

• behavior of actuators - active behavior - elastic and inertial behavior

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

25

Continuation of the Project (work for 2005)

• Numerical aerodynamics : Different approaches are now in progress : NS, LES

- NS 2D- Adaptative grid- Re = 1000- U = 1m/s- c = 2 cm

Stc = 0.8 (f = 40 Hz) Stc = 0.4 (f = 20 Hz)

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

26

Continuation of the Project (work for 2005)

• Experimental aerodynamics: - A second mechanism to widen the range of kinematic parameters (hovering flight)- Visualization of the flows

• Implementation of flight mechanics and aeroelasticity with unsteady models

Jour

nées

mic

rodr

one

- O

NE

RA

– S

epte

mbr

e 20

04

D

iapo

N°

27

Contacts:

• Management:Agnès Luc-Bouhali (Agnes.Luc-Bouhali@onera.fr)

• Flight Mechanics and Control: Laurent Planckaert (Laurent.Planckaert@onera.fr)

• Aerodynamics:Jean-Bernard Paquet (Jean-Bernard.Paquet@onera.fr)

• Materials, Structures, Actuators:Daniel Osmont (Daniel.Osmont@onera.fr)