SAB 193-233-283 Screw compressor unit - · PDF fileScrew compressor unit ... Spare parts manual - SAB 193/233/283 001200 en 2015.11. Abbreviations in this manual include: ... the Unisab

Screw compressor unitSAB 193-233-283

Spare parts manual en

Contents 1. Spare parts list SAB 193/233/283 4

1.1.1 How to use the spare parts list 4

1.1.2 Recommended spare parts 6

1.1.3 General arrangement SAB 193/233/283 8

1.1.4 Screw compressor, typical (SGC 1913/1918 shown) 12

1.1.5 Oil separator, typical 16

1.1.6 Oil filter - single, typical 20

1.1.7 Oil filter - dual, typical 22

1.1.8 Oil cooler piping, typical (SAB 193/233/283 S/L) 24

1.1.9 Oil cooler piping, typical (SAB 283E) 28

1.1.10 Liquid injection 30

1.1.11 Suction/discharge/service/stop valve, typical 34

1.1.12 Spare parts list for all suction/discharge/service/stopvalves 35

1.1.13 Discharge stop/check valve 36

1.1.14 Economizer 39

1.1.15 Oil pump 41

1.1.16 Coupling assembly 43

1.1.17 Piping and instrumentation, typical 45

1.1.18 Compressor ports locations 48 2. Numerical parts list 53

Spare parts manual - SAB 193/233/283001200 en 2015.11 3/62

1. Spare parts list SAB 193/233/283

1.1.1 How to use the spare parts listSAB Rotary screw compressor unit

This spare parts list applies to standard Sabroe rotary screw compressor units, models SAB193/233/283.

Units built with special options, modifications or conversions are not considered.

Item numbers only apply to units with PED (Pressure Equipment Directive 97/23/EC) approvalwhen this is relevant.

Concerning rotary screw compressors (models SGC) and Unisab control systems, please referto the specific spare parts lists.

The spare parts list provides identification for detail parts by Figure and Index number (Fig-Index column), Item number and Description.

To find the correct replacement item, locate the item in Figure 1, 2, etc. Note the Index num-ber and refer to the corresponding Fig-Index in the spare parts list to see Item number andDescription.

Consider that some parts depend on voltage, set pressure etc. and that your unit may have aspecial modification.

Some figure numbers are not applicable for this spare parts list, eg figures 11 and 15 and aretherefore excluded.

Quantity per assembly or item is stated in the Qty. column and always applies to each unitunless otherwise specified. If the quantity is 0 (zero) this either means that the Item numberis included as information only or it may be that the actual quantity is stated elsewhere egunder Description or in a footnote.

Some of the Item Numbers are included for information purposes only and are not usuallyconsidered spare parts.

If the word “Assembly” (not the abbreviation “Ass.”) is included in Description, the Item num-ber may be included for information purposes only and is not necessarily a spare part. Pleasecontact Refrigeration Parts Centre for more information.

The P&I Ref. column contains the connection designation of the item as shown in a typical P&Idiagram (see fig. 16) as well as the P&I diagram of your particular unit when this is relevant.A reference like P128 means item no. 128 and can only be seen in your specific P&I diagram.

Unit of measure in the Description column etc. is always stated in SI-units unless otherwisespecified, eg subfixed “ if in inches.

American drawing standards, third angle projection method, are used in all figures.

The Numerical parts list at the end of the manual can be used to locate a specific item inthe spare parts list. Look for the part by Item number and it will refer to the Figure and Indexnumber (Fig-Index column) where it is located.

Abbreviations for more than one item or model eg:

SAB 193/233S/L means SAB 193 S + SAB 193 L + SAB 233 S + SAB 233 L

LG-1/2/3 means LG-1 + LG-2 + LG-3

Spare parts list SAB 193/233/283

4/62Spare parts manual - SAB 193/233/283

001200 en 2015.11

Abbreviations in this manual include:

Ang. angle OD= outside diameter equal to

Ass. assembly Rc. cooling medium refrigerant

Cp. compressor Reg regulating

DN (+space) nominal diameter Sc. seal cap

f. for Ser. service

g gauge Str. straight

Hex. hexagon Wc. cooling medium water

ID= inside diameter equal to ø diameter (ISO-standard)

L= length equal to

N/A not applicable ornot available

The unit pipe system name plate (example below) listing unit pipe system type, year andidentification number etc., is attached to the frame below the compressor.

Note: Please provide Sabroe unit pipe system type, year and identification numberwhen requesting a quotation or placing an order. Failure to include this informationmay delay the processing of your request.



1.1.2 Recommended spare partsNote: There is no specific drawing for this figure. This list is based on one typical unit. Con-sider that your unit may have special modifications. When stocking for more than one unit,the quantity should be adjusted to meet your individual requirements.

Fig-Index

P&IRef.

Item number Description

Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

00-01 531B0099H01 Filter, coalescing, convoluted (A)SAB 193 S/L: 2 or 3 pcs.SAB 233 S/L: 3 or 4 pcs.SAB 233 E : 4 or 5 pcs.SAB 283 S/L: 4 or 5 pcs.SAB 283 E : 5 or 6 pcs.

0 X X X X X X X X

00-01 1331.605 O-ring ø380,37 x 5,33 , Manway 1 X X X X X X X X00-02 720M0174G01EU Spare parts kit for each oil filter (m) 1 X X X X 00-02 720M0184G01EU Spare parts kit for each oil filter (m) 1 X X X X00-02 531A0218H02 Element, SuperFilter II (O)

SAB 193/ 233S/L : 2 pcs.SAB 233E/283 : 3 pcs.

1 X X X X X X X X

531B0100H02 Element, SuperFilter II (AJ) 1 X X X X 531B0100H03 Element, SuperFilter II (AJ) 1 X X X X00-02 959A0053H01 Gasket ø7-13/16" x 1/8" 1 X X X X X X X X00-02 959A0082H01EU Gasket ø251/222 x 2 1 X X X X X X X X00-03 TE-1/3 1373.325 Temperature sensor including pocket,

L=1301 X X X X X X X X

00-03 TE-1/3 1377.441 Temperature sensor , L=130 (l) 1 X X X X X X X X00-03 TE-2 1373.319 Temperature sensor including pocket,


00-03 TE-2 1377.438 Temperature sensor , L=80 (l) 1 X X X X X X X X00-03 TE-4 1373.326 Temperature sensor including pocket,


00-03 TE-4 1377.442 Temperature sensor , L=95 (l) 1 X X X X X X X X00-03 TE-

1/2/3/41349.135 Seal ring, bonded, for G 1/4 A (H)

(for pocket sealing purpose)1 X X X X X X X X

00-04 PE-4 1373.339 Pressure transducer, -1/9 bar (AC) 1 X X X X X X X X00-04 PE-4 1373.337 Pressure transducer, -1/9 bar

4-20 mA / 24 VDC (Z) (AD)1 X X X X X X X X

00-04 PE-1/2/3 1373.340 Pressure transducer, -1/25 bar (AC) 1 X X X X X X X X00-04 PE-1/2/3 1373.338 Pressure transducer, -1/25 bar




001200 en 2015.11

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

00-05 HTR-1/2 1555.123 Ass., Oil heater, 1000W/120V 1 X X X X X X X X00-05 HTR-1/2 1555.125 Ass., Oil heater, 1000W/240V 1 X X X X X X X X00-06 951A0114H05 Coil 110/120V 50/60Hz (W) 2 X X X X X X X X00-06 951A0114H06 Coil 220/240V 50/60Hz (W) 2 X X X X X X X X00-06 951A0113H20 Seal kit (W) 2 X X X X X X X X00-07 1372.538 Coil 10W 110V 50/60Hz (n) 1 X X X X X X X X00-07 1372.537 Coil 10W 220/240V 50/60Hz (n) 1 X X X X X X X X A) Quantity depends on operating conditions of the unitH) Quantity is for each sealing purposeO) Quantity as required (may be suggested)W) For solenoid valve in the compressor hydraulic systemZ) For package without Unisab II control onlyl) Repair kit complete (sensor insert with connector) excluding pocketm) Necessary filter elements and gaskets, see also Fig-Index 04-02/07/10 (reuse seal centre)n) Only for solenoid valve in liquid injection coolingAC) For package with Unisab II control onlyAD) For package with Unisab III control only(AJ) After January 2015



1.1.3 General arrangement SAB 193/233/283

Fig. 1: Drawing for list 01



001200 en 2015.11

List 01

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

01-01 INF See further information f. compressor infig.2 or Service Part List f. SGC Cp.

1 X X X X X X X X

01-02 INF See further information for couplingin fig.14

1 X X X X X X X X

01-03 INF See further information for motor inthe Operating manual

1 X X X X X X X X

01-04 UI Unused Index 0 X X X X X X X X01-05 INF See further information in

the Unisab manual1 X X X X X X X X

01-06 SUC Index 06 concerns suction stop andcheck valves (J)

0 X X X X X X X X

01-06 1361.075 Stop valve, Ang., Sc., SVA-ST 125 1 X 01-06 1361.076 Stop valve, Ang., Sc., SVA-ST 150 1 X X R R 01-06 1361.077 Stop valve, Ang., Sc., SVA-ST 200 1 X X X R R R R01-06 1361.108 Stop valve, Ang., Sc., SVA-DH 250 1 S S X X X X01-06 1361.135 Stop valve, Ang., Sc., SVA-DH 300 1 S S S S01-06 PE-4 1373.339 Pressure transducer, -1/9 bar (AC) 1 X X X X X X X X01-06 PE-4 1373.337 Pressure transducer, -1/9 bar


01-06 956A0050H03 Check valve, 5" 1 X 01-06 956A0050H04 Check valve, 6" 1 X X 01-06 956A0050H05 Check valve, 8" 1 X X X 01-06 956A0050H06 Check valve, 10" 1 X X01-06 959A0054H31 Gasket for flange 5" 2 X 01-06 959A0054H32 Gasket for flange 6" 2 X X 01-06 959A0054H33 Gasket for flange 8" 2 X X X 01-06 959A0054H34 Gasket for flange 10" 2 X X01-07 DIS Index 07 concerns discharge stop

and check valves (J) (Q)0 X X X X X X X X

01-07 1361.074 Stop valve, Ang., Sc., SVA-ST 100 1 X X 01-07 1361.075 Stop valve, Ang., Sc., SVA-ST 125 1 X X 01-07 1361.076 Stop valve, Ang., Sc., SVA-ST 150 1 X X X 01-07 1361.077 Stop valve, Ang., Sc., SVA-ST 200 1 X



Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

01-07 1372.589 Check valve, Ang., GVD 100 (T) 1 X X 01-07 1372.591 Check valve, Ang., GVD 125 (T) 1 X X 01-07 1372.593 Check valve, Ang., GVD 150 (T) 1 X X X 01-07 1372.595 Check valve, Ang., GVD 200 (T) 1 X01-07 956A0045H02 Check valve, Ang., GVD 100 (U) 1 X X 01-07 956A0046H02 Check valve, Ang., GVD 125 (U) 1 X X 01-07 956A0047H02 Check valve, Ang., GVD 150 (U) 1 X X X 01-07 956A0048H02 Check valve, Ang., GVD 200 (U) 1 X01-08 INF See further information for single

oil filter in fig.4 and fordouble oil filter in fig.5

0 X X X X X X X X

01-09 INF See further information foroil separator in fig.3

0 X X X X X X X X

01-10 INF See further information foroil pump in fig.13

0 X X X X X X X X

J) Spare parts kits and sets for stop valve in fig.9Q) Spare parts kits and sets for check valve in fig.10R) Only with refrigerant R717S) Only with refrigerant HCFC/HFCT) Only at high stage operating modeU) Only at booster operating mode

Z) For package without Unisab II control onlyAC) For package with Unisab II control onlyAD) For package with Unisab III control only



001200 en 2015.11



1.1.4 Screw compressor, typical (SGC 1913/1918 shown)




001200 en 2015.11

List 02

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

L

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

02- 534E0672G01 Screw compressor SGC 1913 1 X 02- 534E0672G02 Screw compressor SGC 1918 1 X 02- 534E0697G01 Screw compressor SGC 2313 1 X 02- 534E0697G02 Screw compressor SGC 2317 1 X 02- 534E0708G01 Screw compressor SGC 2321 1 X 02- 534E0753G01 Screw compressor SGC 2813 1 X 02- 534E0753G02 Screw compressor SGC 2817 1 X 02- 534D1270G01 Screw compressor SGC 2821 1 X02-01 INF See further information (P) 0 X X X X X X X X02-02 INF See further information (P) 0 X X X X X X X X02-03 INF See further information (P) 0 X X X X X X X X02-04 INF See further information (P) 0 X X X X X X X X02-05 535E0122H01 Block, manifold f. two solenoid valves 1 X X X X X X X X02-05 SC-1/2

SC-3/4BP

535E0122H11 Valve, needle, flow regulator in block 5 X X X X X X X X

02-06 980A0012A61 O-ring, manifold to compressor 4 X X X X X X X X02-07 901A0228H20 Screw, hex. socket cap M6 x 80 4 X X X X X X X X02-08 1, 2 1372.409 Control valve block,

manifold & regulating valves 120V2 X X X X X X X X

02-08 1, 2 1372.404 Control valve block,manifold & regulating valves 240V

2 X X X X X X X X

02-08 1554.1718 DIN cable connector GDME-211-RA-10 2 X X X X X X X X02-08 1554.1719 DIN cable connector GDME-211-RB-10 2 X X X X X X X X02-08 1554.159 Gasket f. DIN cable connector 4 X X X X X X X X02-09 951A0113H20 Seal kit f. four-way solenoid valve 2 X X X X X X X X02-10 INF See further information (P) 0 X X X X X X X X



Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

L

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E



02-12 INF See further information (P) 0 X X X X X X X X02-13 INF See further information (P) 0 X X X X X X X X02-14 INF See further information (P) 0 X X X X X X X X P) See Service Part List for SGC compressorY) Including all mounting hardware (coils, cable connectors and gaskets, seal kit)Z) For package without Unisab II control onlyAC) For package with Unisab II control onlyAD) For package with Unisab III control only



001200 en 2015.11



1.1.5 Oil separator, typical




001200 en 2015.11

List 03

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

03- PV-1 548E0387EU Assembly, Oil separator OHU 06026 1 X X 03- PV-1 548E0388EU Assembly, Oil separator OHU 07269 1 X X 03- PV-1 548E0389EU Assembly, Oil separator OHU 09135 1 X 03- PV-1 548E0390EU Assembly, Oil separator OHU 09135 1 X X 03- PV-1 548E0391EU Assembly, Oil separator OHU 10737 1 X03-01 1331.605 O-ring ø380,37 x 5,33 , Manway 1 X X X X X X X X03-02 LG-1/2/3 0342974 Sight glass 2" 3 X X X X X X X X03-02 LG-1/2/3 2356.309 Gasket, aluminium ø70/60 x 1,5 3 X X X X X X X X03-03 959A0054H30 Gasket for flange 5" 1 X X 03-03 959A0054H32 Gasket for flange 6" 1 X X X 03-03 959A0054H33 Gasket for flange 8" 1 X X X03-04 HTR-1 1555.123 Ass., Oil heater, 1000W/120V 1 X X X X 03-04 HTR-1/2 1555.123 Ass., Oil heater, 1000W/120V 2 X X X X03-04 HTR-1 1555.125 Ass., Oil heater, 1000W/240V 1 X X X X 03-04 HTR-1/2 1555.125 Ass., Oil heater, 1000W/240V 2 X X X X03-05 1349.248 Seal ring, steel, ø26/21,1 x 4,5 1 X X X X X X X X03-05 LSL-1 1553.423 Switch, oil level sensing, 24V (AC) 1 X X X X X X X X03-05 LSL-1 1553.422 Switch, oil level sensing, 24V (AD) 1 X X X X X X X X03-06 1349.135 Seal ring, bonded, for G 1/4 A (H)

(for pocket sealing purpose)1 X X X X X X X X

03-06 TE-2 1373.319 Temperature sensor, L=80 1 X X X X X X X X03-06 TE-4 1373.326 Temperature sensor, L=95 1 X X X X X X X X03-07 2416.L11 Dual safety valve DSV 1/SFA 15

Assembly, (E) (F)1 X X

03-07 2416.L19 Dual safety valve DSV 1/SFA 15Assembly, (E) (F)

1 X X

03-07 2416.L16 Dual safety valve DSV 2/SFV 20Assembly, (F)

1 X X X X

03-07 1364.349 Double stop valve DSV 1 1 X X X X 03-07 1364.353 Double stop valve DSV 2 1 X X X X03-07 1364.361 Safety valve SFA 15, 22 bar g 2 X X X X 03-07 1364.363 Safety valve SFA 15, 24 bar g 2 X X X X 03-07 1364.371 Safety valve SFA 15, 26 bar g 2 X X X X 03-07 2416.241 Safety valve SFV 20, 22 bar g 2 X X X X03-07 2416.264 Safety valve SFV 20, 24 bar g 2 X X X X03-07 YYYY.YYY Safety valve SFV 20, 26 bar g (G) 2 X X X X03-07 1377.257 Repair kit, gaskets for DSV 1 1 X X X X 03-07 1377.258 Repair kit, gaskets for DSV 2 1 X X X X03-07 1377.255 Kit, gaskets f. two SFA 15 on DSV 1 1 X X X X 03-07 1377.256 Kit, gaskets f. two SFV 20 on DSV 2 1 X X X X03-07 1377.259 Repair kit f. SFA 15 (gaskets+cone) 1 X X X X 03-07 2453.082 Repair kit f. SFV 20 (gaskets+cone) 1 X X X X



Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

03-08 531B0099H01 Filter, coalescing, convoluted (A)SAB 193 S/L: 2 or 3 pcs.SAB 233 S/L: 3 or 4 pcs.SAB 233 E : 4 or 5 pcs.SAB 283 S/L: 4 or 5 pcs.SAB 283 E : 5 or 6 pcs.

0 X X X X X X X X

03-09 UI Unused Index 0 X X X X X X X 03-10 540D0217G02EU Retainer, filter end plate (B) or (C) 1 X X X X X X X X03-11 540D0217G03EU Stud bolt, double 1/2-13 UNC x 918 (B) 1 X X X X X X X X03-12 902A0021H01 Nut, hexagon 1/2-13 UNC (B) 2 X X X X X X X X03-13 1436.075 Washer, plain, hardened ID=13 (B) 1 X X X X X X X X03-13 1436.075 Washer, plain, hardened ID=13 (C) 1 X X X X X X X X03-14 1423.014 Screw, hexagon 1/2-13 UNC x 32 (C) 1 X X X X X X X X03-15 2356.272 Gasket ø225/169 x 2 (C) 1 X X X X X X X X03-16 1349.123 Cutting ring, pipe OD=28 Series L 1 X X X X X X X X03-16 P108 1361.054 Stop valve, Ang., Sc., SVA-ST 25 (J) 1 X X X X X X X X A) Quantity depends on operating conditions of the unitB) Quantity is for each coalescer filterC) Quantity is for each unused filter openingE) Only safety valves can be replacedF) Set pressure depends on operating conditionsG) Not availableH) Quantity is for each sealing purposeJ) Spare parts kits and sets for stop valve in fig.9AC) For package with Unisab II control onlyAD) For package with Unisab III control only



001200 en 2015.11



1.1.6 Oil filter - single, typical




001200 en 2015.11

List 04

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

04- 720M0312G01EU Assembly, Single oil filter 1 X X 04- 720M0328G01EU Assembly, Single oil filter 1 X X 04- 720M0350G01EU Assembly, Single oil filter 1 X 04- 720M0335G01EU Assembly, Single oil filter 1 X X 04- 720M0357G01EU Assembly, Single oil filter 1 X04-01 OF-1 553E0013EU Ass., Oil filter OF 2111/DN 40 (D) 1 X X 04-01 OF-1 553E0015EU Ass., Oil filter OF 2111/DN 50 (D) 1 X X 04-01 OF-1 553E0014EU Ass., Oil filter OF 2115 (D) 1 X X X X04-02 959A0082H01EU Gasket ø251/222 x 2 1 X X X X X X X X04-02 2355.253 Gasket ø250/225 x 3, grooved steel w.

graphite for PED/AD 2000 oil filter1 X X X X X X X X

04-03 553A0001EU Cover, end 1 X X X X X X X X04-04 1424.109 Screw, hexagon M16 x 80 10 X X X X X X X X04-05 1432.072 Nut, hexagon M16 10 X X X X X X X X04-06 535A0144H01 Plate, clamping 1 X X X X X X X X04-07 959A0053H01 Gasket ø7-13/16" x 1/8" 1 X X X X X X X X04-08 1413.356 Screw, hex. socket cap M8 x 21 6 X X X X X X X X04-08 1436.034 Washer, plain ID=8,4 6 X X X X X X X X04-09 333Q0001268 Rod, threaded

1/2-13 UNC x 31-1/2"1 X X X X

04-09 333Q0001267 Rod, threaded 1/2-13 UNC x 47" 1 X X X X04-10 531A0218H02 Element, SuperFilter II 2 X X X X 04-10 531B0100H02 Element, SuperFilter II (AJ) 1 X X X X 04-10 531B0100H03 Element, SuperFilter II (AJ) 1 X X X X04-10 531A0218H02 Element, SuperFilter II 3 X X X X04-11 900A0007H01 Seal center 1 X X X X 04-11 900A0007H01 Seal center 2 X X X X04-12 900A0008H01 Yoke, bottom 1 X X X X X X X X04-13 1436.005 Washer, plain ID=13 1 X X X X X X X X04-14 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X X X X X X X04-15 902A0021H01 Nut, hexagon 1/2-13 UNC 2 X X X X X X X X04-16 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X X X X X X X04-17 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X 04-17 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 X X 04-17 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X X X X04-18 1364.325 Reg. valve, Ang., Sc., REG 40 #10 (J) 1 X X X X X X X X D) See cross-sectional view in fig.4J) Spare parts kits and sets for stop valve in fig.9(AJ) After January 2015



1.1.7 Oil filter - dual, typical




001200 en 2015.11

List 05

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

05- 720M0311G01EU Assembly, Dual oil filters 1 X X 05- 720M0329G01EU Assembly, Dual oil filters 1 X X 05- 720M0336G01EU Assembly, Dual oil filters 1 X X X 05- 720M0356G01EU Assembly, Dual oil filters 1 X05-01 OF-1/2 553E0013EU Ass., Oil filter OF2111/DN 40 (D) 2 X X 05-01 OF-1/2 553E0015EU Ass., Oil filter OF 2111/DN 50 (D) 2 X X 05-01 OF-1/2 553E0014EU Ass., Oil filter OF 2115 (D) 2 X X X X05-02 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 3 X X 05-02 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 3 X X 05-02 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 3 X X X X05-03 1361.065 Stop valve, Str., Sc., SVA-ST 40 (J) 1 X X 05-03 1361.066 Stop valve, Str., Sc., SVA-ST 50 (J) 1 X X 05-03 1361.068 Stop valve, Str., Sc., SVA-ST 65 (J) 1 X X X X05-04 1361.117 Stop valve,

Ang., Sc., SNV-ST CD10 (K) (J)1 X X X X X X X X

05-05 1364.325 Reg. valve, Ang., Sc., REG 40 #10 (J) 1 X X X X X X X X05-06 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X X X X X X X D) See cross-sectional view in fig.4J) Spare parts kits and sets for stop valve in fig.9K) Quantity is for each oil filter



1.1.8 Oil cooler piping, typical (SAB 193/233/283 S/L)




001200 en 2015.11

List 06

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

06- R TSOC 1952.084 Oil cooler PSHE 66, Rc. 1 X X X X X 06- R TSOC 1952.086 Oil cooler PSHE 116, Rc. 1 X X 06- R TSOC 1952.088 Oil cooler PSHE 190, Rc. 1 X X 06- R TSOC 1952.090 Oil cooler PSHE 288, Rc. 1 X 06- R TSOC 1952.092 Oil cooler PSHE 56, Rc. 1 X X 06- R TSOC 1952.096 Oil cooler PSHE 136, Rc. 1 X X 06- W WCOC 1952.085 Oil cooler PSHE 66, Wc. 1 X X X X X 06- W WCOC 1952.087 Oil cooler PSHE 116, Wc. 1 X X 06- W WCOC 1952.089 Oil cooler PSHE 190, Wc. 1 X X 06- W WCOC 1952.091 Oil cooler PSHE 288, Wc. 1 X 06- W WCOC 1952.093 Oil cooler PSHE 56, Wc. 1 X X 06- W WCOC 1952.097 Oil cooler PSHE 136, Wc. 1 X X 06-01 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 X X X X 06-01 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X X X 06-02 STR-2 950A0001H08EU Strainer 2", flange size 1-1/2" (L) 1 X X 06-02 STR-2 950A0001H06EU Strainer 2", flange size 2" (L) 1 X X 06-02 STR-2 950A0001H07EU Strainer 2-1/2", flange size 2-1/2" (L) 1 X X X 06-02 950A0001H27 Kit for 2" strainer (L) (V) 1 X X 06-02 950A0001H25 Kit for 2" strainer (L) (V) 1 X X 06-02 950A0001H26 Kit for 2-1/2" strainer (L) (V) 1 X X X 06-02 950A0001H40 Screen gasket for 2" strainer (L) 1 X X X X 06-02 950A0001H41 Screen gasket for 2-1/2" strainer (L) 1 X X X 06-02 950A0001H34 Flange gasket for 2" strainer (L) 2 X X X X 06-02 950A0001H35 Flange gasket for 2-1/2" strainer (L) 2 X X X 06-03 CV-2 956A0012G03EU Check valve, Str., 1-1/2" (L) 1 X X 06-03 CV-2 956A0012G10EU Check valve, Str., 2" (L) 1 X X 06-03 CV-2 956A0012G05EU Check valve, Str., 2-1/2" (L) 1 X X X 06-03 959A0057H04 Flange gasket OD=2-5/16" (L) 2 X X 06-03 959A0057H07 Flange gasket OD=3-1/4" (L) 2 X X 06-03 950A0001H35 Flange gasket OD = 3-3/4” (L) 2 X X X 06-04 1344.369 Flange DN 40 (L) 2 X X X X X



Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

06-04 1344.370 Flange DN 65 (L) 2 X X 06-05 959A0054H25 Gasket OD=3-3/4" (L) 2 X X X X X 06-05 959A0054H27 Gasket OD=5-1/8" (L) 2 X X 06-06 901A0172H03EU Kit, screws f. flange DN 40 (L) 2 X X X X X 06-06 901A0172H05EU Kit, screws f. flange DN 60 (L) 2 X X 06-07 TCV-1 1375.117 Valve, temperature control ORV 40 H1 1 X X 06-07 TCV-1 1375.118 Valve, temperature control ORV 50 H2 1 X X X X X 06-07 TCV-1 1375.121 Valve, temperature control ORV 65 H3

(M)1 X X

06-07 148H3243 Kit, thermostat and gasket f. ORV 25/40H1

1 X X

06-07 148H3244 Kit, thermostat and gasket f. ORV 40/50H2

1 X X X X X

06-07 148H3245 Kit, thermostat and gasket f. ORV 65/80H3 (M)

X X

06-08 UI Unused Index 0 X X X X X X X 06-09 UI Unused Index 0 X X X X X X X 06-10 UI Unused Index 0 X X X X X X X 06-11 UI Unused Index 0 X X X X X X X 06-12 UI Unused Index 0 X X X X X X X J) Spare parts kits and sets for stop valve in fig.9L) Only if with oil pumpM) Only in combination with PSHE 136/188V) Consists of screen, spring and screen gasket



001200 en 2015.11



1.1.9 Oil cooler piping, typical (SAB 283E)




001200 en 2015.11

List 07

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

07- R TSOC 1952.094 Oil cooler PSHE 72, Rc. 1 X07- R TSOC 1952.098 Oil cooler PSHE 188, Rc. 1 X07- W WCOC 1952.095 Oil cooler PSHE 72, Wc. 1 X07- W WCOC 1952.099 Oil cooler PSHE 188, Wc. 1 X07-01 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X07-02 UI Unused Index 0 X07-03 CV-2 956A0012G05EU Check valve, Str., 2-1/2" (L) 1 X07-04 STR-2 950A0001H07EU Strainer2-1/2", flange size 2-1/2" (L) 1 X07-04 950A0001H41 Screen gasket f. 2-1/2" strainer (L) 1 X07-04 950A0001H35 Flange gasket f. 2-1/2" strainer (L) 2 X07-04 950A0001H26 Kit for 2-1/2" strainer (L) (V) 1 X07-05 1344.371 Flange DN 80 (L) 2 X07-06 959A0054H28 Gasket OD=5-7/8" (L) 2 X07-07 901A0172H06EU Kit, screws f. flange DN 80 (L) 2 X07-08 UI Unused Index 0 X07-09 TCV-1 1375.118 Valve, temperature control ORV 50 1 X07-09 TCV-1 1375.121 Valve, temperature control ORV 65 (M) 1 X07-09 950A0294H11 Kit, thermostat and gasket f. ORV 40/50 1 X07-09 950A0297H11 Kit, thermostat and gasket f. ORV 65

(M)1 X

J) Spare parts kits and sets for stop valve in fig.9L) Only if with oil pumpM) Only in combination with PSHE 136/188V) Consists of screen, spring and screen gasket



1.1.10 Liquid injection




001200 en 2015.11

List 08

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

08- 3449.K03 Assembly, Liquid injection cooling 1 X X 08- 3449.K04 Assembly, Liquid injection cooling 1 X X 08- 3449.K05 Assembly, Liquid injection cooling 1 X 08- 3449.K06 Assembly, Liquid injection cooling 1 X X 08- 3449.K07 Assembly, Liquid injection cooling 1 X

08-01 P170 1361.053Stop valve, Ang., Sc., SVA-ST 20 (J)(q)(t)

1 X X X X X X X X

08-01 P170 1361.054 Stop valve, Ang., Sc., SVA-ST 25 (J)(r)(t) 1 X X X X X X X X08-01 P170 1361.055 Stop valve, Ang., Sc., SVA-ST 32 (J)(s)(t) 1 X X X X X X X X08-01 P170 1361.079 Stop valve, Str., Sc., SVA-ST 20 (J)(q)(u) 1 X X X X X X X X08-01 P170 1361.067 Stop valve, Str., Sc., SVA-ST 25 (J)(r)(u) 1 X X X X X X X X08-01 P170 1361.064 Stop valve, Str., Sc., SVA-ST 32 (J)(r)(u) 1 X X X X X X X X08-02 P165 1361.078 Stop valve, Str., Sc., SVA-ST 15 (J) (p) 1 X X X X X X X X08-02 P165 1361.079 Stop valve, Str., Sc., SVA-ST 20 (J) (q) 1 X X X X X X X X08-02 P165 1361.067 Stop valve, Str., Sc., SVA-ST 25 (J) (r) 1 X X X X X X X X08-02 P165 1361.065 Stop valve, Str., Sc., SVA-ST 40 (J) (s) 1 X X X X X X X X08-03 1377.262 Gasket (set of 2), ring ø32/22 x 1,0 (p) 2 X X X X X X X X08-03 1336.029 Gasket (set of 2), ring ø39/29 x 1,5 (r) 2 X X X X X X X X08-03 P167 1372.395 Solenoid valve EVRAT 10 (excl. coil) (o) 1 X X X X X X X X08-03 P167 1372.347 Solenoid valve EVRA 15 (excl. coil) (p) 1 X X X X X X X X08-03 P167 1372.348 Solenoid valve EVRA 20 (excl. coil) (q) 1 X X X X X X X X08-03 P167 1372.349 Solenoid valve EVRA 25 (excl. coil) (r) 1 X X X X X X X X08-03 P167 1372.039 Solenoid valve EVRA 32 (excl. coil) (s) 1 X X X X X X X X08-03 P167 1372.538 Coil 10W 110V 50/60Hz 1 X X X X X X X X08-03 P167 1372.537 Coil 10W 220/230V 50/60Hz 1 X X X X X X X X08-03 P166 1375.174 Strainer, Str., FA 15 (p) 1 X X X X X X X X08-03 1377.250 Repair kit (strainer and gasket), FA 15 1 X X X X X X X X08-03 1377.078 Seal kit (f. cover and flange), FA 15 1 X X X X X X X X08-03 P166 1375.173 Strainer, Str., FA 20 (q) 1 X X X X X X X X08-03 1377.251 Repair kit (strainer and gasket), FA 20 1 X X X X X X X X08-03 1377.079 Seal kit (f. cover and flange), FA 20 1 X X X X X X X X08-03 P166 1375.076 Strainer (body), Str., FIA 25 D (r) 1 X X X X X X X X08-03 P166 1375.078 Strainer (body), Str., FIA 40 D (s) 1 X X X X X X X X08-03 P166 1375.082 Element 100 my for FIA 25-40 1 X X X X X X X X08-03 P168 1377.263 Sight glass SGT 15 TG (p) 1 X X X X X X X X08-03 P168 1377.268 Sight glass SGT 24 TG (r) 1 X X X X X X X X



Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

08-03 P168 2511.022 Sight glass MLI 40 D (s) 1 X X X X X X X X08-04 P169 1379.014 Actuator ICAD 600 for motorvalve 1 X X X X X X X X

08-04 P169 954A0070H01EUMotor valve ICM 20-A (excluding actua-tor)

1 X X X X X X X X

08-04 P169 954A0070H02EUMotor valve ICM 20-B (excluding actua-tor)

1 X X X X X X X X

08-04 P169 954A0070H03EUMotor valve ICM 20-C (excluding actua-tor)

1 X X X X X X X X


1 X X X X X X X X


1 X X X X X X X X

08-04 1377.447 Spare parts kit, gaskets/O-rings f. ICM 20 1 X X X X X X X X08-04 1377.448 Spare parts kit, gaskets/O-rings f. ICM 25 1 X X X X X X X X08-04 1377.449 Spare parts kit, gaskets/O-rings f. ICM 32 1 X X X X X X X X08-04 1377.453 Manual magnet tool f. ICM 20-32 1 X X X X X X X X08-05 P172/175 SPEC Application-specific or customized (j) 3 X X X X X X X X08-06 PI SPEC Application-specific or customized (j) 1 X X X X X X X X08-07 YY-9 951A0053H01 Solenoid 3-way valve PE (excluding coil) 1 X X X X X X X X08-07 951A0095H01 Coil 11W 120V 50/60Hz 1 X X X X X X X X08-07 951A0095H02 Coil 11W 240V 50/60Hz 1 X X X X X X X X08-08 SPEC Application-specific or customized (j) 1 X X X X X X X X08-09 SPEC Application-specific or customized (j) 1 X X X X X X X X J) Spare parts kits and sets for stop valve in fig.9j) Contact Refrigeration Parts Centre for more informationo) If liquid injection flow max. 8.6 kg/minp) If liquid injection flow max. 15.6 kg/minq) If liquid injection flow max. 25.9 kg/minr) If liquid injection flow max. 57.6 kg/mins) If liquid injection flow max. 227 kg/mint) If liquid injection, single flowu) If liquid injection, dual flow



001200 en 2015.11



1.1.11 Suction/discharge/service/stop valve, typical


List 06

Fig -Index

P&I Ref.Item

numberDescription Qty.

SA

B1

57

HR

40

BA

R C

O2

SA

B1

57

HR

52

BA

R C

O2

SA

B1

57

HR

40

BA

R R

71

7

SA

B1

57

HR

52

BA

R R

71

7

SA

B1

57

HR

60

BA

R R

71

7

06- - Suction/discharge/servicestop valve(See chart below)

1 X X X X X

06-01 - Cone and cone seal (k) X X X X X06-02 - Packing gland (k) X X X X X06-03 - Packing washer (k) X X X X X06-04 - O-ring (k) X X X X X06-05 - O-ring (k) X X X X X06-06 - Gasket (k) X X X X X06-07 UI Unused index 06-08 - Washer (k) X X X X X06-09 UI Unused index 06-10 - Cap (k) X X X X X06-11 - Gasket for cap (k) X X X X X06-12 - Soft backseat (k) X X X X X06-13 - Wear ring (k) X X X X X k) Quantity as required for one valve in the actual kit



001200 en 2015.11

1.1.12 Spare parts list for all suction/discharge/service/stop valves

ItemNumber

DescriptionRepair kit

(a)

Kit,Packing gland

(b)

Kit,Cap including

gasket (c)

1364.325 Reg. valve, Ang., Sc., REG 40 #10 2453.044 1377.249 1365.0981361.117 Stop valve, Ang., Sc., SNV-ST CD10 (d) (d) (d)1361.052 Stop valve, Ang., Sc., SVA-ST 15 1377.417 1377.273 1365.0961361.078 Stop valve, Str., Sc., SVA-ST 15 1377.417 1377.273 1365.0961361.053 Stop valve, Ang., Sc., SVA-ST 20 1377.417 1377.273 1365.0971361.079 Stop valve, Str., Sc., SVA-ST 20 1377.417 1377.273 1365.0971361.054 Stop valve, Ang., Sc., SVA-ST 25 1377.418 1377.249 1365.0981361.067 Stop valve, Str., Sc., SVA-ST 25 1377.418 1377.249 1365.0981361.055 Stop valve, Ang., Sc., SVA-ST 32 1377.418 1377.249 1365.0981361.064 Stop valve, Str., Sc., SVA-ST 32 1377.418 1377.249 1365.0981361.056 Stop valve, Ang., Sc., SVA-ST 40 1377.418 1377.249 1365.0981361.065 Stop valve, Str., Sc., SVA-ST 40 1377.418 1377.249 1365.0981361.057 Stop valve, Ang., Sc., SVA-ST 50 1377.419 1377.274 1365.0981361.066 Stop valve, Str., Sc., SVA-ST 50 1377.419 1377.274 1365.0981361.063 Stop valve, Ang., Sc., SVA-ST 65 1377.420 1377.274 1365.0981361.068 Stop valve, Str., Sc., SVA-ST 65 1377.420 1377.274 1365.0981361.073 Stop valve, Ang., Sc., SVA-ST 80 1377.421 1377.279 1365.0991361.074 Stop valve, Ang., Sc., SVA-ST 100 1377.422 1377.279 1365.0991361.075 Stop valve, Ang., Sc., SVA-ST 125 1377.423 1377.282 1365.1001361.076 Stop valve, Ang., Sc., SVA-ST 150 1377.424 1377.282 1365.1001361.077 Stop valve, Ang., Sc., SVA-ST 200 1377.425 1377.283 1365.1011361.108 Stop valve, Ang., Sc., SVA-DH 250 1377.285 1377.284 1365.1151361.135 Stop valve, Ang., Sc., SVA-DH 300 1377.286 1377.284 1365.115 a) SVA-ST consists of: Cone complete including screw and steel balls, packing gland including gasketsand all other necessary gaskets (Index 1-6/11-12)SVA-DH consists of: Cone wear ring including gaskets, packing gland including gasketsand all other necessary gaskets (Index 1-6/11-12)b) Consists of packing gland including gaskets (Index 2-5)c) Consists of cap with gasket (Index 10/11).d) No spare parts available (tighten packing gland or replace all with a new valve)



1.1.13 Discharge stop/check valve


Spare parts list for check valve

Itemnumber

DescriptionBonnetgasket

Seal kit (e)Spring kit0.5 bar (f)

Spring kit2 bar (f)

1372.589 Check valve, Ang., GVD 100 (T) 956A0045H11 956A0045H12 N/A 956A0045H141372.591 Check valve, Ang., GVD 125 (T) 956A0046H11 956A0046H12 N/A 956A0046H141372.593 Check valve, Ang., GVD 150 (T) 956A0047H11 956A0047H12 N/A 956A0047H141372.595 Check valve, Ang., GVD 200 (T) 956A0048H11 956A0048H12 N/A 956A0048H14956A0045H02 Check valve, Ang., GVD 100 (U) 956A0045H11 956A0045H12 956A0045H15 N/A956A0046H02 Check valve, Ang., GVD 125 (U) 956A0046H11 956A0046H12 956A0046H15 N/A956A0047H02 Check valve, Ang., GVD 150 (U) 956A0047H11 956A0047H12 956A0047H15 N/A956A0048H02 Check valve, Ang., GVD 200 (U) 956A0048H11 956A0048H12 956A0048H15 N/A T) Only at high stage operating modeU) Only at booster operating modee) Consists of gasket and various rings (Index 16-22)f) Consists of plate, rivet and spring (Index 14/28-29)



001200 en 2015.11

List 07

Fig -Index

P&I Ref.Item

numberDescription

Qty

.

SA

B1

57

HR

40

BA

R C

O2

SA

B1

57

HR

52

BA

R C

O2

SA

B1

57

HR

40

BA

R R

71

7

SA

B1

57

HR

52

BA

R R

71

7

SA

B1

57

HR

60

BA

R R

71

7

07- - Assembly, Discharge stop/check valve(Item No.see Fig-Index 01-07)Spare parts for:- stop valve, see fig.9- check valve, see chartprevious page

1 X X X X X

07-01 - Housing 1 X X X X X07-02 - Bonnet 1 X X X X X07-03 - Piston cylinder 1 X X X X X07-04 - Piston rod 1 X X X X X07-05 - Piston 1 X X X X X07-06 - Cone 1 X X X X X07-07 - Spring screw 1 X X X X X07-08 - Spring bushing 1 X X X X X07-09 - Cone plate 1 X X X X X07-10 - Cone rod 1 X X X X X07-11 - Rear bushing 1 X X X X X07-12 - Front bushing 1 X X X X X07-13 - Spring 1 X X X X X07-14 - Spring (f) 1 X X X X X07-15 - Plug (not shown) 1 X X X X X07-16 - Teflon ring (e) 1 X X X X X07-17 - Bonnet gasket (e) 1 X X X X X07-18 - Nylon washer (e) 1 X X X X X07-19 - Glyde ring (e) 1 X X X X X07-20 - O-ring (e) 1 X X X X X07-21 - O-ring (e) 1 X X X X X07-22 - O-ring (e) 1 X X X X X07-23 - Spring ring 1 X X X X X07-24 - Spring ring 1 X X X X X07-25 - Spring ring 1 X X X X X07-26 - Nut 1 X X X X X07-27 - Set screw (O) 0 X X X X X07-28 - Marking plate (f) 1 X X X X X07-29 - Rivet (f) 1 X X X X X07-30 - Washer 1 X X X X X07-31 - Nut 1 X X X X X07-32 - Screw 1 X X X X X07-33 1361.117 Stop valve, Ang., Sc.,

SNV-ST CD10 (J)1 X X X X X

J) Spare parts kits and sets for stop valve in Fig. 9.O) Quantity as required (may be suggested)e) Consists of gasket and various rings (Index 16-22)f) Consists of plate, rivet and spring (Index 14/28-29)



List 11 is not applicable for this part list

Fig. 11: There is no drawing for list 11.



001200 en 2015.11

1.1.14 Economizer




List 12

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

12- 535M0001G03EU Kit, Economizer connection system 1 X X 12- 535M0001G04EU Kit, Economizer connection system 1 X X X 12- 535M0001G06EU Kit, Economizer connection system 1 X X 12- 535M0001G07EU Kit, Economizer connection system 1 X12-01 STR-5 950A0001H08EU Strainer 2", flange size 1-1/2" 1 X X 12-01 STR-5 950A0001H06EU Strainer 2", flange size 2" 1 X X X X X 12-01 STR-5 950A0001H09EU Strainer 3", flange size 3" 1 X12-01 950A0001H27 Kit for 2" strainer (V) 1 X X 12-01 950A0001H25 Kit for 2" strainer (V) 1 X X X X X 12-01 950A0001H28 Kit for 3" strainer (V) 1 X12-01 950A0001H40 Screen gasket f. 1-1/2" & 2" strainer 1 X X X X X X X 12-01 950A0001H41 Screen gasket f. 2-1/2" & 3" strainer 1 X12-01 950A0001H34 Flange gasket f. 1-1/2" & 2" strainer 2 X X X X X X X 12-01 950A0001H35 Flange gasket f. 2-1/2" & 3" strainer 2 X12-02 CV-3 956A0025H23EU Check valve, Str., 1-1/2", modified 1 X X 12-02 CV-3 956A0025H24EU Check valve, Str., 2", modified 1 X X X X X 12-02 CV-3 956A0025H25EU Check valve, Str., 3", modified 1 X12-03 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X 12-03 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 X X X X X 12-03 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X12-04 944A0358H02EU Flange, Square, 1-1/2" 1 X X 12-04 944A0358H03EU Flange, Square, 2" 1 X X X 12-04 3013.386 Flange, Square, DN 65 1 X X X12-04 959A0057H05 Gasket OD=2-3/4" 1 X X 12-04 959A0057H07 Gasket OD=3-1/4" 1 X X X 12-04 2356.202 Gasket ø95/71 x 1,5 1 X X X12-04 1356.030 Reducer DN 65/DN 50 1 X X 12-04 1356.031 Reducer DN 80/DN 65 1 X J) Spare parts kits and sets for stop valve in fig.9V) Consists of screen, spring and screen gasket



001200 en 2015.11

1.1.15 Oil pump




List 13

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

13-01 PM-1 960A0082G01 Ass., Oil pump, 1 hp3x400/460V 50/60Hz

1 X X

13-01 PM-1 960A0082G07 Ass., Oil pump, 1-1 1/2 hp3x400/460V 50/60Hz

1 X X

13-01 960A0082H01 Pump only (f. 1&1-1/2 hp) 1 X X X X 13-01 914A0015H02 Motor only (f. 1&1-1/2 hp) 1 X X X X 13-01 960A0066H11 Coupling only (f. 1&1-1/2 hp) 1 X X X X 13-01 PM-1 960A0082G04 Ass., Oil pump, 3 hp

3x400/460V 50/60Hz1 X

13-01 960A0082H02 Pump only (f. 3 hp) 1 X 13-01 914A0015H03 Motor only (f. 3 hp) 1 X 13-01 960A0066H12 Coupling only (f. 3 hp) 1 X 13-01 PM-1 960A0083G02 Ass., Oil pump, 5 hp

3x400/460V 50/60Hz1 X X

13-01 960A0083H01 Pump only (f. 5 hp) 1 X X 13-01 914A0016H02 Motor only (f. 5 hp) 1 X X 13-01 960A0067H13 Coupling only (f. 5 hp) 1 X X 13-01 PM-1 960A0083G07 Ass., Oil pump, 7 1/2 hp

3x400/460V 50/60Hz1 X

13-01 960A0083H03 Pump only (f. 7-1/2 hp) 1 X13-01 914A0016H05 Motor only (f. 7-1/2 hp) 1 X13-01 960A0067H12 Coupling only (f. 7-1/2 hp) 1 X13-01 960A0076H41 Kit, Shaft seal f. pump, 1-3 hp (N) 1 X X X X X 13-01 960A0077H41 Kit, Shaft seal f/pump, 5&7-1/2 hp (N) 1 X X X13-02 CV-3 956A0014H01 Check valve, Str., 3/4" 1 X X X X 13-02 CV-3 956A0014H02 Check valve, Str., 1" 1 X X X X N) Consists of shaft seal, O-ring, bearings and locknut



001200 en 2015.11

1.1.16 Coupling assembly




List 14

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

14- 1524.275 Ass., Coupling ø65 & ø2,251" (g) (h) 1 X X 14- 1524.281 Ass., Coupling ø65 & ø2,501" (g) (h) 1 X X X 14- 1524.288 Ass., Coupling ø65 & ø3,251" (g) (i) 1 X X X14- 1524.276 Ass., Coupling ø70 & ø2,251" (g) (h) 1 X X 14- 1524.282 Ass., Coupling ø70 & ø2,501" (g) (h) 1 X X X 14- 1524.289 Ass., Coupling ø70 & ø3,251" (g) (i) 1 X X X14- 1524.283 Ass., Coupling ø80 & ø2,251" (g) (i) 1 X X 14- 1524.284 Ass., Coupling ø80 & ø2,501" (g) (i) 1 X X X 14- 1524.285 Ass., Coupling ø80 & ø3,251" (g) (i) 1 X X X14-01 720C0078H11 Kit, Disc pack including all fasteners 2 X X X X X 14-02 720C0079H11 Kit, Disc pack including all fasteners 2 X X X g) Motor and compressor bore respectivelyh) As spare parts kit use 14-01i) As spare parts kit use 14-02

List 15 is not applicable for this part list

Fig. 15: There is no drawing for list 15.



001200 en 2015.11

1.1.17 Piping and instrumentation, typicalShowing single oil filter, oil pump and oil cooler




List 16

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

16-01 720B0030G01EU Ass., Strainer and check valve 1 X X X X X X X X16-01 STR-1 1375.154 Strainer, Str., FA 15 1 X X X X X X X X16-01 1377.250 Repair kit (strainer and gasket), FA 15 1 X X X X X X X X16-01 1377.078 Seal kit (f. cover and flange), FA 15 1 X X X X X X X X16-01 CV-1 1372.268 Check valve, Str., NRVA 15 1 X X X X X X X X16-01 1377.439 Piston ass. f. check valve NRVA 15/20 1 X X X X X X X X16-01 1377.440 Valve seat f. check valve NRVA 15/20 1 X X X X X X X X16-01 1377.262 Gasket (set of 2), ring ø32/22 x 1,0 1 X X X X X X X X16-02 1361.054 Stop valve, Ang., Sc., SVA-ST 25 (J) 1 X X X X X X X X16-03 UI Unused Index 0 X X X X X X X X16-04 UI Unused Index 0 X X X X X X X X16-05 UI Unused Index 0 X X X X X X X X16-06 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 10 X X X X X X X X16-07 P108 1361.054 Stop valve, Ang., Sc., SVA-ST 25 (J) 1 X X X X X X X X16-08 1364.325 Reg. valve, Ang., Sc., REG 40 #10 (J) 1 X X X X X X X X16-09 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X 16-09 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 X X 16-09 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X X X X16-10 TCV-1 INF See further information for temperature

control valve at Fig-Index 06-071 X X X X X X X

16-10 TCV-1 INF See further information for temperaturecontrol valve at Fig-Index 07-09

1 X

16-11 P119 1361.057 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 X X X X 16-11 P119 1361.063 Stop valve, Ang., Sc., SVA-ST 65 (J) 1 X X X X16-12 TE-1/3 1373.325 Temperature sensor, L=130 2 X X X X X X X X16-12 TE-2 1373.319 Temperature sensor, L=80 1 X X X X X X X X16-12 TE-4 1373.326 Temperature sensor, L=95 1 X X X X X X X X16-12 TE-

1/2/3/41349.135 Seal ring, bonded, for G 1/4 A

for pocket sealing purpose (H)1 X X X X X X X X

16-13 PE-1/2/3 1373.340 Pressure transducer, -1/25 bar (AC) 3 X X X X X X X X16-13 PE-1/2/3 1373.338 Pressure transducer, -1/25 bar




16-14 CV-4 1364.022 Check valve, Str., 3 bar, ø10-G 1/4 A(T)

1 X X X X X X X X

16-14 CV-4 1364.404 Check valve, Str., 1 bar, ø10-G 1/4 A(U)

1 X X X X X X X X

16-15 P106 1361.054 Stop valve, Ang., Sc., SVA-ST 25 (J) 1 X X X X X X X X16-16 INF See further information at

Fig-Index 01-070 X X X X X X X X



001200 en 2015.11

Fig-Index

P&IRef.


Qty

.

SA

B1

93

S

SA

B1

93

L

SA

B2

33

S

SA

B2

33

L

SA

B2

33

E

SA

B2

83

S

SA

B2

83

L

SA

B2

83

E

16-17 INF See further information atFig-Index 01-06

0 X X X X X X X X

16-18 CV-3 956A0014H01 Check valve, Str., 3/4" 1 X X X X 16-18 CV-3 956A0014H02 Check valve, Str., 1" 1 X X X X16-19 STR-2 INF See further information for strainer at

Fig-Index 06-021 X X X X X X X

16-19 STR-2 INF See further information for strainer atFig-Index 07-04

1 X

16-20 CV-2 956A0012G03EU Check valve, Str., 1-1/2" (L) 1 X X 16-20 CV-2 956A0012G10EU Check valve, Str., 2" (L) 1 X X 16-20 CV-2 956A0012G05EU Check valve, Str., 2-1/2" (L) 1 X X X X16-21 NV-2 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J)

A plugged T-union are prepared for thistype of stop valve and a pressure equal-izing line if needed (valve and line arecustomers supply)

1 X X X X X X X X

16-22 P127 2417.232 Safety valve POV 40 1 R R R R 16-22 P127 1364.348 Safety valve POV 1050 1 S S R R R 16-22 P127 1364.396 Safety valve POV 2150 1 S S S R16-22 P127 1364.396 Safety valve POV 2150 2 S S S16-23 P128 2416.203 Safety valve BSV 8, 20 bar g 1 X X X X X R R R16-23 P128 2416.224 Safety valve BSV 8, 22 bar g 1 X X X X X R R R16-23 P128 2416.315 Safety valve BSV 8, 24 bar g 1 X X X X X R R R16-23 P128 2356.137 Gasket, Aluminium ø30/16 x 1,5 1 X X X X X R R R16-23 P128 2356.127 Gasket, Aluminium ø24/13 x 1,5 1 X X X X X R R R16-23 P128 2416.203 Safety valve BSV 8, 20 bar g 2 S S S16-23 P128 2416.224 Safety valve BSV 8, 22 bar g 2 S S S16-23 P128 2416.315 Safety valve BSV 8, 24 bar g 2 S S S16-23 P128 2356.137 Gasket, Aluminium ø30/16 x 1,5 2 S S S16-23 P128 2356.127 Gasket, Aluminium ø24/13 x 1,5 2 S S S H) Quantity is for each sealing purposeJ) Spare parts kits and sets for stop valve in fig.9L) Only if with oil pumpT) Only at high stage operating modeR) Only if refrigerant is R717S) Only if refrigerant is HCFC/HFCU) Only at booster operating modeZ) For package without Unisab II control onlyAC) For package with Unisab II control onlyAD) For package with Unisab III control only



1.1.18 Compressor ports locations

Fig. 17: SGC 1913/1918



001200 en 2015.11

Fig. 18: SGC 2313/2317



Fig. 19: SGC 2321



001200 en 2015.11

Fig. 20: SGC 2813/2817



Fig. 21: SGC 2821



001200 en 2015.11

2. Numerical parts list

2.1.1 Parts list

Item number Fig-Index0342974 03-021331.605 00-011331.605 03-011336.029 08-031344.369 06-041344.370 06-041344.371 07-051349.123 03-161349.135 00-031349.135 03-061349.135 16-121349.248 03-051356.030 12-041356.031 12-041361.052 09-1361.053 08-011361.053 09-1361.054 03-161361.054 08-011361.054 09-1361.054 16-021361.054 16-071361.054 16-151361.055 08-011361.055 09-1361.056 04-171361.056 05-021361.056 09-1361.056 12-031361.056 16-091361.057 04-171361.057 05-021361.057 06-011361.057 09-1361.057 12-031361.057 16-091361.057 16-111361.063 04-171361.063 05-021361.063 06-011361.063 07-011361.063 09-1361.063 12-031361.063 16-091361.063 16-111361.064 08-011361.064 09-

Numerical parts list


Item number Fig-Index1361.065 05-031361.065 08-021361.065 09-1361.066 05-031361.066 09-1361.067 08-011361.067 08-021361.067 09-1361.068 05-031361.068 09-1361.073 09-1361.074 01-071361.074 09-1361.075 01-061361.075 01-071361.075 09-1361.076 01-061361.076 01-071361.076 09-1361.077 01-061361.077 01-071361.077 09-1361.078 08-021361.078 09-1361.079 08-011361.079 08-021361.079 09-1361.108 01-061361.108 09-1361.117 04-141361.117 04-161361.117 05-041361.117 05-061361.117 09-1361.117 10-331361.117 16-061361.117 16-211361.135 01-061361.135 09-1364.022 16-141364.325 04-181364.325 05-051364.325 09-1364.325 16-081364.348 16-221364.349 03-071364.353 03-071364.361 03-071364.363 03-071364.371 03-071364.396 16-221364.404 16-14



001200 en 2015.11







001200 en 2015.11

Item number Fig-Index1432.072 04-051436.005 04-131436.034 04-081436.075 03-131524.275 14-1524.276 14-1524.281 14-1524.282 14-1524.283 14-1524.284 14-1524.285 14-1524.288 14-1524.289 14-1553.422 03-051553.423 03-051554.159 02-081554.1718 02-081554.1719 02-081952.084 06- R1952.085 06- W1952.086 06- R1952.087 06- W1952.088 06- R1952.089 06- W1952.090 06- R1952.091 06- W1952.092 06- R1952.093 06- W1952.094 07- R1952.095 07- W1952.096 06- R1952.097 06- W1952.098 07- R1952.099 07- W2356.127 16-232356.137 16-232356.202 12-042356.272 03-152356.309 03-022416.203 16-232416.224 16-232416.241 03-072416.264 03-072416.315 16-232416.L11 03-072416.L16 03-072416.L19 03-072417.232 16-222453.044 09-2453.082 03-072511.022 08-033013.386 12-04



Item number Fig-Index333Q0001267 04-09333Q0001268 04-093449.K03 08-3449.K04 08-3449.K05 08-3449.K06 08-3449.K07 08-531A0218H02 00-02531A0218H02 04-10531A0218H02 04-10531B0099H01 00-01531B0099H01 00-01531B0099H01 03-08531B0099H01 03-08534D1270G01 02-534E0672G01 02-534E0672G02 02-534E0697G01 02-534E0697G02 02-534E0708G01 02-534E0753G01 02-534E0753G02 02-535A0144H01 04-06535E0122H01 02-05535E0122H11 02-05535M0001G03EU 12-535M0001G04EU 12-535M0001G06EU 12-535M0001G07EU 12-540D0217G02EU 03-10540D0217G03EU 03-11548E0387EU 03-548E0388EU 03-548E0389EU 03-548E0390EU 03-548E0391EU 03-553A0001EU 04-03553E0013EU 04-01553E0013EU 05-01553E0014EU 04-01553E0014EU 05-01553E0015EU 04-01553E0015EU 05-01720B0030G01EU 16-01720C0078H11 14-01720C0079H11 14-02720M0174G01EU 00-02720M0184G01EU 00-02914A0016H05 13-01944A0358H02EU 12-04944A0358H03EU 12-04950A0001H06EU 06-02



001200 en 2015.11

Item number Fig-Index950A0001H06EU 12-01950A0001H07EU 06-02950A0001H07EU 07-04950A0001H08EU 06-02950A0001H08EU 12-01950A0001H09EU 12-01950A0001H25 06-02950A0001H25 12-01950A0001H26 06-02950A0001H26 07-04950A0001H27 06-02950A0001H27 12-01950A0001H28 12-01950A0001H34 06-02950A0001H34 12-01950A0001H35 06-02950A0001H35 07-04950A0001H35 12-01950A0001H40 06-02950A0001H40 12-01720M0311G01EU 05-720M0312G01EU 04-720M0328G01EU 04-720M0329G01EU 05-720M0335G01EU 04-720M0336G01EU 05-720M0350G01EU 04-720M0356G01EU 05-720M0357G01EU 04-900A0007H01 04-11900A0007H01 04-11900A0008H01 04-12901A0172H03EU 06-06901A0172H05EU 06-06901A0172H06EU 07-07901A0228H20 02-07902A0021H01 03-12902A0021H01 04-15913A0092G02 00-05913A0092G02 03-04913A0092G02 03-04913A0092G04 00-05913A0092G04 03-04913A0092G04 03-04914A0015H02 13-01914A0015H03 13-01914A0016H02 13-01950A0001H41 06-02950A0001H41 07-04950A0001H41 12-01950A0294H11 06-07950A0294H11 07-09



Item number Fig-Index950A0297H11 06-07950A0297H11 07-09951A0053H01 08-07951A0095H01 08-07951A0095H02 08-07951A0113H20 00-06951A0113H20 02-09951A0114H01 02-08951A0114H02 02-08951A0114H05 00-06951A0114H05 02-08951A0114H06 00-06951A0114H06 02-08954A0070H01EU 08-04954A0070H02EU 08-04954A0070H03EU 08-04954A0071H01EU 08-04954A0072H01EU 08-04956A0012G03EU 06-03956A0012G03EU 16-20956A0012G05EU 06-03956A0012G05EU 07-03956A0012G05EU 16-20956A0012G10EU 06-03956A0012G10EU 16-20956A0014H01 13-02956A0014H01 16-18956A0014H02 13-02956A0014H02 16-18956A0025H23EU 12-02956A0025H24EU 12-02956A0025H25EU 12-02956A0045H02 01-07956A0045H02 10-956A0045H11 10-956A0045H12 10-956A0045H14 10-956A0045H15 10-956A0046H02 01-07956A0046H02 10-956A0046H11 10-956A0046H12 10-956A0046H14 10-956A0046H15 10-956A0047H02 01-07956A0047H02 10-956A0047H11 10-956A0047H12 10-956A0047H14 10-956A0047H15 10-956A0048H02 01-07956A0048H02 10-



001200 en 2015.11

Item number Fig-Index956A0048H11 10-956A0048H12 10-956A0048H14 10-956A0048H15 10-956A0050H03 01-06956A0050H04 01-06956A0050H05 01-06956A0050H06 01-06959A0053H01 00-02959A0053H01 04-07959A0054H25 06-05959A0054H27 06-05959A0054H28 07-06959A0054H30 03-03959A0054H31 01-06959A0054H32 01-06959A0054H32 03-03959A0054H33 01-06959A0054H33 03-03959A0054H34 01-06959A0057H04 06-03959A0057H05 12-04959A0057H07 06-03959A0057H07 12-04959A0082H01EU 00-02959A0082H01EU 04-02960A0066H11 13-01960A0066H12 13-01960A0067H12 13-01960A0067H13 13-01960A0076H41 13-01960A0077H41 13-01960A0082G01 13-01960A0082G04 13-01960A0082G07 13-01960A0082H01 13-01960A0082H02 13-01960A0083G02 13-01960A0083G07 13-01960A0083H01 13-01960A0083H03 13-01980A0012A61 02-06DIS 01-07INF 01-01INF 01-02INF 01-03INF 01-05INF 01-08INF 01-09INF 01-10INF 02-01INF 02-02



Item number Fig-IndexINF 02-03INF 02-04INF 02-10INF 02-12INF 02-13INF 02-14INF 16-10INF 16-10INF 16-16INF 16-17INF 16-19INF 16-19SPEC 08-05SPEC 08-06SPEC 08-08SPEC 08-09SUC 01-06UI 01-04UI 03-09UI 06-08UI 06-09UI 06-10UI 06-11UI 06-12UI 07-02UI 07-08UI 16-03UI 16-04UI 16-05



001200 en 2015.11

Documents

SAB 193-233-283 Screw compressor unit - · PDF fileScrew compressor unit ... Spare parts manual - SAB 193/233/283 001200 en 2015.11. Abbreviations in this manual include: ... the Unisab