COSHH RISK ASSESSMENTAssessmentRef No.

TBC

Product Name & Product Code:

Jangro Kitchen Degreaser Heavy Duty, 5LBB015-5

Description of Substance:

Powerful cleaning and degreasing of all kitchen surfaces

Location Used: Kitchen areas: Floors, Hard Surfaces and HobsName & Address of Supplier Hazard

Statements:Yes

Wray Brothers Limited9 – 13 Pleasant Hill StreetLiverpool. L8 5SYT: 0151 709 2271

Precautionary Statements

Yes

MSDSAttached:

Yes

Use of SubstanceDilution How to Use5 litre bucketsDilute 1:50 parts hot water (100ml per 5L / 3 x pelican pumps per 5L). Mop, wipe or spray surface.

Spray bottlesTo re-fill a spray bottle. Dilute 30ml per 600ml (1 x pelican pump per 600ml) cold water.

Kitchen Floors & Hard SurfacesAdd to mop bucket for cleaning kitchen floors from 5 litre bottle or spray onto surface and wipe.

HobsSwitch off appliance and allow to cool. Spray onto surface and wipe clean. Rinse with clean water.

RefillRefill should be undertaken by Supervisor only.Task is to be carried out no higher than waist height.

Substance Properties PPE Requirements

Corrosive ArmProtection

HandProtection

EyeProtection

Skin/Body Protection

Signal Word:DANGER

Oversleeves GlovesBSEN 388:2003,

BSEN 374-2:2003, BSEN 374-3:2003

Over SpectaclesEN166:2001

Tabard

Route(s) of Exposure Group(s) at RiskInhalation No Ingestion Yes Operatives Yes Other (specify

below)Skin Yes Eyes Yes Other

employeesNo e.g. visitors or

the public

First Aid MeasuresInhalationUnlikely route of exposure as the product does not contain volatile substances. If spray/mist has been inhaled, proceed as follows. Move affected person to fresh air and keep warm and at rest in a position comfortable for breathing.

Skin contactWash with plenty of water. Get medical attention promptly if symptoms occur after washing.

IngestionDo not induce vomiting. Give plenty of water to drink. Get medical attention immediately.

Eye contactRinse immediately with plenty of water. Remove any contact lenses and open eyelids wide apart. Get medical attention immediately. Continue to rinse

Control MeasuresFire Precautions

Thermal decomposition or combustion products may include the following substances:Irritating gases or vapours.

Spillage Procedures

Small Spillages: Flush away spillage with plenty of water.Large Spillages: Contain and absorb spillage with sand, earth or other non-combustible material. Collect and place in suitable waste disposal containers and seal securely

Storage Requirements

Keep only in the original container in a cool, well-ventilated place.Store away from the following materials: Oxidising materials.

Disposal Procedures

Discharge used solutions to drain. Small amounts (less than 5 Litres) of unwanted product may be flushed with water to sewer. Larger volumes must be sent for disposal by approved waste contractor. Rinse out empty container with water and consign to normal waste.

Workplace ExposureWorkplace Exposure Limits Yes (refer to MSDS) Health Surveillance

RequirementsNot Applicable

Hazard Statements Precautionary StatementsH314 Causes severe skin burns and eye damage.

P102 Keep out of reach of children.P260 Do not breathe spray.P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.P301+P330+P331 IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/ shower.P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.P315 Get immediate medical advice/ attention.P501 Dispose of contents/ container in accordance with local regulations.

CertificationName of Assessor

Emily Taylor Signed

Date December 2017 Date Review

As and when an accident occurs or a change to this chemical