6
Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions V. Saraswathy*, S. Muralidharan, R.M. Kalyanasundaram, K. Thangavel, S. Srinivasan Concrete Corrosion & Failure Analysis Group, Corrosion Science and Engineering Division, Central Electrochemical Research Institute, Karaikudi, Tamil Nadu 630 006, India Received 7 July 2000; accepted 26 January 2001 Abstract The objective of this present investigation is to design a composite corrosion-inhibiting admixture system comprising of both mineral and chemical admixtures and to evaluate its performance in concrete under macrocell corrosion conditions. The newly designed corrosion- inhibiting admixture system performed very well in chloride-contaminated concrete. Steel embedded in ordinary Portland cement suffered severe corrosion. In concrete incorporating the designed admixture system, steel showed a 10-fold decrease in corrosion rate of steel embedded in concrete under accelerated macrocell corrosion conditions. The compressive strength of mortars was not affected by adding the designed admixture system. D 2001 Elsevier Science Ltd. All rights reserved. Keywords: Admixture; Macrocell corrosion; Reinforcement corrosion; Chloride contaminated concrete 1. Introduction In recent years the use of various chemical and mineral admixtures in making high-performance concrete has increased significantly [1,2]. There is not enough informa- tion available on corrosion-inhibiting admixtures for steel embedded in concrete. Corrosion-inhibiting admixtures are mainly used in concrete exposed to seawater or to varying degrees of exposure to aggressive chemical environment. The use of different classes of corrosion-inhibiting admix- tures in concrete have been reviewed by various authors [3 ± 7]. Earlier studies looked at numerous corrosion inhibition admixtures with the most attention focused on sodium nitrite, potassium chromate, sodium benzoate and stannous chloride. El-Jazairi et al. [8] examined the mechanical properties of mortars produced with sodium nitrite, potassium chro- mate, sodium benzoate and calcium chloride. They found a marked decrease in compressive strength as high as 20% to 40%, when the corrosion-inhibiting admixtures were added to concrete. In contrast, calcium chloride increased the compressive strength, but the tensile strengths were adversely affected by the addition of sodium nitrite and sodium benzoate. Among all, only sodium nitrite inhibited the corrosion of steel embedded in concrete in the presence of chloride environments. They concluded that corrosion was uniform with sodium benzoate and pitting occurred with sodium nitrite. Collepardi, Cigna et al. and Nurnberger and Beul [9±11] cautioned about the possibility of accelerated pitting of steel reinforcement in the presence of chloride when insufficient nitrite ``under dosage'' is present in concrete and expressed reservations with regard to the possible migration and leaching out of nitrite from concrete. Sodium nitrite, however, suffers two disadvantages, one affecting reduction of strength and the other is the risk of the alkali±aggregate reaction which can be made worse by the addition of sodium nitrite [12,13]. Recently Monticelli et al. [14] studied more than 30 compounds as corrosion inhibitors for concrete application. Hansson et al. [15] also studied the principles of corrosion inhibitors in concrete. Calcium nitrite meets ASTM C494 specifications as a concrete accelerator [8,16]. Calcium nitrite-based admixture provides a simple and cost effective corrosion protection * Corresponding author. Tel.: +91-4565-427550; fax: +91-4565-427779. E-mail address: [email protected] V. Saraswathy). Cement and Concrete Research 31 2001) 789 ± 794 0008-8846/01/$ ± see front matter D 2001 Elsevier Science Ltd. All rights reserved. PII:S0008-884601)00468-9

Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

Embed Size (px)

Citation preview

Page 1: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

��������� � � ��� ����� ����������������� ���������

�� ��� �������� � ������� ���� ��������� �������� ��������

�� ������������ �� ������������ ���� ������������� � !�������� �� ��������

�������� �������� �� ��� ��� ��� ������ �������� ������ ��� ��������� ������ ������ � ����������� �������� ���������

�������� �� !��� "#$ $$"� ����

�������� " #��� $%%%& ���� ��� $' #����� $%%(

��������

!�� ��)������ � ���� ����� ����������� �� �� ����� � ��� ����� ����������������� ��������� ������ ��� ����� � ���� ������ ��

�������� ���������� �� �� �������� ��� �������� � ������� ���� ��������� �������� ��������� !�� ���� ������� ���������

�������� ��������� ������ ������� ���� ���� � ������������������� �������� ����� �������� � ������� *������ ����� ������

������ ��������� + ������� ���� ������ ��� ������� ��������� ������� ����� ������ � (%���� �������� � �������� ���� � �����

�������� � ������� ���� ����������� ��������� �������� ��������� !�� ��� ������� ������� � ������� ��� �� ������ �� ����� ���

������� ��������� ������� � $%%( �������� ������ ,��� -�� ������ ���������

���%����& -��������& ��������� ��������& ���������� ��������& .������� ���������� �������

� ���� ������

+ ����� ����� ��� ��� � ������� �������� �� ������

���������� � ��/�� ����� �������� ������� ���

�������� ���������� 0(�$1� !���� �� �� ����� ������

��� ��������� � ����������������� ���������� �� �����

�������� � �������� .���������������� ���������� ���

����� ���� � ������� �� ���� �� �������� �� �� ������

������� � �� ����� �� ���������� �������� ���������

!�� ��� � ������ ������� � ����������������� ������

����� � ������� ���� ��� �������� �� ������� ������� 023

"1� ������� ������� ���/�� �� ������� �������� ��������

���������� ���� ��� ���� ������� ������ � ������ �������

�������� ��������� ������ ��4���� �� ������ ���������

���#�4���� �� ��� 051 ������� ��� ��������� �� ������

� ������� ������� ���� ������ ������� �������� �����

����� ������ ��4���� �� ������� ��������� !��� ��� �

���/�� �������� � ��� ������� ������� �� ���� �� $%6 ��

7%6� ��� ��� ����������������� ���������� ���� �����

�� �������� + �������� ������� �������� �������� ���

��� ������� �������� ��� ��� ������ �������� ����

��������� ������ �� ��� ������� � ������ ������ ��

������ ��4����� -��� ���� ��� ������ ������ ��������

��� �������� � ����� �������� � ������� � ��� ������

� �������� ���������� !��� �������� ���� ��������

��� ����� ���� ������ ��4���� �� ����� ��������

���� ������ �������

.���� ����� .��� �� ��� �� 8�������� �� 9��� 0:3((1

�������� ����� ��� ���������� � ����������� ����� � �����

���������� � ��� ������ � �������� ��� ��������

������ ;;���� ������<< �� ����� � ������� �� �� ������

����������� ���� ������ �� ��� ������� �������� ��

������� ��� � ������ ��� ��������

������ ������� �������� ����� ��� ������������� ��

������ �������� � ������� �� ��� ����� �� ��� ���/ � ���

��/���3��������� ������� ����� �� �� ���� ����� �� ���

������� � ������ ������ 0($�(21�

������� ��������� �� ��� 0(71 ������� ���� ��� 2%

��� ���� �� �������� ��������� �� ������� � ��������

=���� �� ��� 0(>1 ���� ������� ��� ���� ��� � ��������

��������� � ��������

.������ ������ ����� -�!� .7:7 � ���������� �� �

������� ����������� 05�('1� .������ ������������ ���������

������� � ��� �� �� ���� ������� �������� ��������� .����� ���� �������!���? @:(�7>'>�7$">>%& ��?@:(�7>'>�7$""":�

�'�� �������? ����������A��������� B�� ����������C�

.���� �� .������ �������� 2( B$%%(C "5:3":7

%%%5�557'D%(DE 3 ��� ��� ������ � $%%( �������� ������ ,��� -�� ������ ���������

*++? �%%%5 �557' B%( C%%7'5 �:

Page 2: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

������ �� ��� �������� ������� ��� � ����� ��������� 9��

������� ������ �� �� ���������� �����������4�� � +����

F�� �� ����� ������� ��� � ����������� ���������� ����

!�� ����� ����������� �� �� ����� � ���� ��� �����

����������������� ��������� ������ ������� ������ ���

������� �� ������ ������ �� ������� ����������� ���������

� ����� �������� � ������� �� ��� ���� �� ��������� �� ���

�������� �������� ���� ��������� �������� ���������

� ��������� �� ����� �

()*) +����� � ����

()() ��������� �, �- ����� ����

!�� ��� ����� ���� �� ������ ��� �� ������? (?2?7�>

B�D� G %�'C

()#) .��������� �, �������� �� �������� ��������

- ���������� ������� � ����� � ��4� $":� (>$� ((7�� ��� ������� �� �� -�!� H (%:�:$ �� ���������

�������� �������� ���� ����� ���������� ��� ���� ��� ������

�� �� ������?

�� � ��4� (% �� ��������� 2%% �� ����� ���� ���� ��

���� ���� �� �������� � ��� ���� �������� +������� ���

���� ����� ���������� ���� ���� ������ � ������������

����� ��������� ���� ������ �� ������ ���� �������

��������� ������ !�� �� ��� � ��� ����� ���� �� ���� ��

��� ������ ��� � ������ ���� �� �������� !�� ���� ��

������� ����� ��� �������� �� (?$ � ����� �� �����

����������� ��������� !�� ���������� � ��������� � ����

�� ���� �� ���� � I��� (� + ���� ��� ���� �� ���������

�� ���� ����� ��� $$% ��� !�� ������� ����� ���

���� �� ��/�� ���������� �������� �� �� ���� �������

�� ��� ��� ���������� ���������

.������ � ������ ���� �� ���� ���� (?2?7�> ��� ����

� �D� ����� � %�'� J���� ������� -� ����� ���������

�������� ���������� ���� ����� �� ����� ������������

!�� � ������ ���� ����������� ��������� -��� $7 � �

������� ��� � ������ ���� �������� �� ����� � �������

��������� ����� �� $5 ����� !��� ��� ��� ������� � ������

���� ���)����� �� 26 8�.� ������ ����� ����������� ����

������ F� �������� ������ �� ����� ����� ������� � (>

���� ������ ���� 26 8�.� �������� �� (> ���� ������

����������� ���� ������� ��� ����� ������ ������ ��

��������� ������ ������ ������� �������� ��� �� ���

��� ����������� � �������� -�� ��� ������� � ������ ����

���)����� �� ��� ��� ���� ������ � ���� ������

()/) ��������'��0��� ���-���� ������

!�� ������ ������� ������� ���� �� ������?

I��� (� ��������� ���� � ��������� � ������

F������ *������ ����� .������ �� +��7>'�$%%%

H����� ������ ���������� ,������ ��������� ���������

������� �� ������

���������� � ����� ��4�

������� ��� 7�"> �� ��

���� ��� (% �� �

+��7>'�$%%%

H����� �� ���������� ,���� ���� ����� ���

B����� ������� �

������ ��� �K��� �� $�'C

������� �� ������

L�� +++ � +��252�(:"%

��� ���� �� �� ����������

.��������� M������ ���� B/�D�2C

F������ *������ ����� $5>

I�� ��� :>

.����� ���������� ((7%

I�� ���������� ("(%

F�� N!� B�*�C 25%37$%

O���� ������ B�*�C $2>3$'%

�������� $%3$26

F������ *������ ����� B(%%6C F*.

F*.@I�� ��� B">6?$>6C I-

F*.@I-@ ������ ��������� B(6C -

F*.@I-@ ������ ��������� B(6C

@ ������ ������� B(6C

9

F*.@I-@ ������ ��������� B(6C

@ ������ ������� B(6C @ ������ ������ B(6C

.

F*.@I-@ ������ ��������� B(6C

@ ������ ������� B(6C @ ������ ������ B(6C

@ ������� ����� B%�>6C

J

1) �����%���� �� � ) 2 ������ ��� �������� �������� #* 3($$*4 567857/":%

Page 3: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

()9) +������

()9)*) .������ ��) ���0�� �, ��� ��

!�� � � ������� ������� � ���� ����� ���� ���

�������� �� ����� ����� ���� �������� ������ ��

����� �������� ���� ��������� ������� ��������� B�.�C

�� ������� ����������

()9)() +������ ������� ��) ���0�� �, ��� ��

��������� ������ ��� ������ ���� �� ������� ���

�������� ���� � ������� ����� ���������� !�� �� ���

�� ������ ��� ������ ���� ������� �� � (%%�� ��������

�� ��������� ������ ��� ������� ��� ��� ������� � G1D

(%%� .����� ��� �������� ��� � ����� ����� ���� ���

������� ��������� ������ � ��� ������ � ������ �� (% �-�� �������� !�� ����� ������� � �� ��� ��� ���� ������ �

�� ����� B(>% ����C �� ����� ��� ������ � �������

�������� �� ������ ����������

()9)#) ��� ��������� ������� ��) ���0�� �, ��� ��

!�� ����� ��������� ������ �� ���� ������ ��� ������

����� �� �� -�!� H (%:�:$ B�K� (C�

��: � ��:�( � ���:��:�(���: � :�(��$� �(�

����� !.G ����� �������� B��������C& �: G ���� B������C ��

����� ����������� � ��� ��������� ������ �� ������� ���&

:G��������� ������ B�� �C �� ���� �:�

()9)/) �,,��� �, ���-���� �� ���������� ��������

.�� ������� ������� � ����� � ��4� (%%� (%%� (%%�� ������� ������� *������ ����� B������C ��

� ������ ������� ������� ����������������� ������

����� ���� ������ � � -+�+, ��� ������ ������ ������

����� � �� ����� � $%%% /8 �� �� +� 7>'�$%%%� !��� ����

��� ������� ��� � ��� ������ � �������

������ B(?2C � ������ ���� ����� �� ����� ����� �

%�> ������� ������� ����������������� ����������

���� ����� �� $5 ���� � ���������������� ����� ��

��� �������

()9)9) ;�� ����� ��� <��������� �������� �, ��������

-� ��� �� � ��� �� ����� ������ ��� �������

� ������ ���� � ��� � � �� ��� ���� B�����C ���

����� �� ������ ���� �� �� ������ � ����� � ��������

� ���� ������� !�� �������� ���� � ���� ����� �����

�������� � ������ BF*.C � ����� �� � �������

����������������� ���������� ���� ��������� �� ������

������ ������ ���� ������ �� �� ������ � �����������

�� ���� B�� �C�

()9)") ������ ��� ��� ,�� � �� ��� ��� ,��� �� ����

!�� ���� ��� ��� ��������� ��� ��� ���� ����

������� ����������� �� �������� !�� (%% �� �

������� ��� �� ��� ���/� ���� $%% �� � �������

��������� ����� � � ������ ���/ ���� ������� ���/

���/�� �� ( �� !�� ������� ��� ��� ������� ������� �

P����� ����� � �� 8�� 7$� !�� ������� �� ���� ���

��� ������� ��� �� ��� ��� ����4�� �� ��/������

�� ��� ��� �������� ������ �� �� ��� �������

��������� 0("1�

- >%��� ������� ������� ��� �� � � (%%��� ���/�� ��

��� ��/������ � ��� ��� �� ��� �������� � ����� � =

���� � ������� ���������� = ������

- $%��� ������� ������� ��� ��/� �� ��� ��� ��������

��� ��������� �� ������� ������ ������ ���� ��������

�������� �� � ��������� !�� ����� � �������� �����

��� �� ������ � ����� � ���� �� ������ B �C � ���

����� � ������ � ��� �� ��/� �� ��������

� ������� �� ���������

#)*) .������ ��) ���0�� �, ��� ��

!�� ��������������� ��������������� � �������� ����

����� �������� ����������� ������ � �.� ���� ���� ���

���� � I��� $� I��� ��� ����� �� ��� ������ ����

�������� � �� �� ����� � �� ����� �� ��� ��� �������

������ ������� ������ ����� ��� % �� � 2%% �� ���

�.� ����� �������� ��� ������ ������� � ��������

����� ����� -��� ����� ����� �������� � ������ � ����

��� ������ � ���� ���� ������� ������� � � 7%%�� ��� �.� �� ��� ������ � �� ����� ������� �����

������� ����� -� 9� .� �� J ������ ������� ������

����� ��� � (>% �� � 2%% �� ��� �.�� !��� �����

����� ���������� ��� ��� �� ��� ����� ������ �����

��� � ��� ����� ����� ��� ���� ��� ������ � �� ������

-��� ��� ������ � �� ������ ����� ���� �������� �

������� ������� �������� ��������� ������ � ���� ����

������� ������� � � >>% �� ��� �.�� !��� ��������

��� ������ �������� � ��� ����� 9�� ��� ����� �����

�������� � ������� ��������� ������� ������ ����

������� �������� ������ J ������ ��� � 2>% ��

��� �.� ��� ���� ��� ������ � �� ������ + ������ J

����� ������ ������� ��� �������� ��� �� ��� �������

�� �� ��� ����� ���� ���� �� ������� �� �������

����� ���� ���� ��� ������ �� ����� � ������ ����

I��� $� *������� ��� ����� � ������ �� ������ ������� ����

��������� ���������

1) �����%���� �� � ) 2 ������ ��� �������� �������� #* 3($$*4 567857/ ":(

Page 4: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

��� �� ������� ����� ������� ��� ����� ��/������

��� ��� ����� ������� !�� ���������� � ��� ��� �����

��� ����� �� ���� � ��� �����/�� ���� ���� �������

�������� !�������� ��� ������� ���� � ��� ����� ���

������� � ����� �������� � ��� ����� ������ ��� �

��� ������ � ������ ����������� � ���������� ������

��� ����

-� ��� �� � �� ������ ��� �������� �������� � �����

�������� � ������� �� ��� ������ ������� ����� �

������� ��� ����� � ������ ������ ��� �����?

� � � � � � � � �� � ���

#)() +������ ������� ��) ���0�� �, ��� ��

!�� ��������� ������ �� ������� ������ ��������

����������� ���� ���� ��� ���� � I��� 2� I��� ��� ������

�� ��� �������� ���� ��� ���� ��� ������ � �� ����� �

�������� ������ ����� ������ ���� �� �������� �

��� ��� �������� -��� ����� ������ � �� ����� ����� ����

�������� � ������ ������ � ���� ���� ������ � ���

����� � 7> �-� ������� ��� ����� ���� �������� ���������� ������� ������ ������ � ��� ����� � (> �-�- ��������� ������� � ������ ��� �������� �� ��� ������

� ������ !��� ���������� ������� ����� ���� � ��� ����

� ��������� �������� ��� �������� ��� ��� �� ���

������� � � �������� ������ ��� ��� ��� ������� ���

������ � �������� ��� � ��� ����� ������� !�� ���

�������� ��� ���� ������� �� ������� ��� ����� �

������ ��������� -� ��� �� � ��� �� ����� ����� ���

�������� � ��������� ������ �� ��� ������ �������

������ ��� �����?

� � � � � � � � �� � ���

-��� ����� ������� �������� ������ J ������

��������� ����� � ��������� ������ ���� !��� ������

����� �������� ���� ��� ������ � ��������� ��� ��/�

���������� �������� �� ������ ������ ���� �������

����� � ��� ������� �� ���� � ������ ��� ��� �����

� ��� ����� ����� !�� ������ �������� � ������ J

�� �� �� ����� �� ������� !�� �������� ������ �

�������� �� ��� ����� ���� ��������� �� ��� ������

��� ����� �������� ������� ��� ������ ��� ����� ������

���� ��� ��������� �� ��� ��� ����� ����� + ��� ����

� ����� ���� �������� � F*. �������� �����������

��/� �������� ���� ����� �� ���� � ��� ����� ������

�� ����� ���� ������ ���� ���� ��� �������� �������

.���K������ >% �- ������ ��� � ��� ���������� F

��� ����� ���� � ������ J ��� ����� �������� ���� ��I�$F2 ��� ��� ������ ����/�� �� ��������� �� ����

����� ������ !�������� ������ ��� �������� �����

���� ��� ����� ���� ��� ���� �������� ���� .����

K������ � ������������ �������� ��� �������� ����������

��� ���� ����� � ��� ��� ���� �������� ������ ��

����� �������

#)#) ��� ��������� ������� ��) ���0�� �, ��� ��

!�� ����� ��������� ������ ���������� ���� ���� ��

������� ��������� ������� ��� ����������� � I��� 7� I���

��� ����� �� ��� ������� �������� ���� �� �������� �

��������� ������ ��� ����� � ������ ��������� ��� ���

������� ������ ��������� ����� � ������ ��� � ��

��� ������ � �� ������ -��� ����� ������ � �� �����

���� �� ���� ���� �������� ����� ����� �������� �

������� *������ ����� ������ :% .������� �������

��� ����� ����� �������� � ������� ��������� �������

����� -� 9� .� �� J ������ ��� ����� >% .��������

-� ��� �� � ��� ���� ����� B���� ��� ������C ����� ����

�������� � ������� *������ ����� ������ 2$> .���

����� ������� ��� ����� ����� �������� � �������

��������� ������� ������ � ������ ������� -� ��������

�������� ��� �������� � ��� ����� ��������� ������ �� ���

������ ������� ������ ��� �����?

� � � � � � � � �� � ���

��� ���� ��� ������ � �� ����� ������ J ������

��������� ����� � ������ ���� !��� ���������� �������

����� ���� ��� � ��� ������ � ��������� ��� ���������

������� ��������� ������ ��� �������� � �������� �����

� ��������

!�� ����� ������� ���� � ��������� ���� ����

�������� � ������� ��� ����� � ������ �� ���������

������ ��� ����� � ������ ��������

I��� 7� !���� ��������� ������ ��� ����� � ������ �� ������ �������

���� ��������� ���������

I��� 2� ��������� ������ ��� ����� � ������ �� ������ ������� ����

��������� ���������

1) �����%���� �� � ) 2 ������ ��� �������� �������� #* 3($$*4 567857/":$

Page 5: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

#)/) �,,��� �, ���-����� �� ���������� ��������

.�� ������� ������� � (?2 ������ �� ���� ���� �D

� G %�> ���� $5 ���� � ����� ��� �� ����� � !���� (�

!�� ������� ��� ������� ������� �� (%%6 F*. ���

$%�> Q $ �*� ������� ���� �� ������� ��������� �������

������ ��� ������� ������� ����� ��� $( �� $> �*��

I��� ���� ����� �� ��� �������� ���� ��� ������� �

���������� ��� �� ���� ��� ��� ������� ������� �

�������� !�� �� ����� ����K������ �� ���� ���������

0(51 ������� �� ��� ������� �� ������ ��� �������� � �����

�������� � ������� � ���������� �������� ���������

�� �� ���� �� �� �� ���� ��� ������� �� ������ �

�������� + ���� �� ���� ������ J ������ ������ ���

����� ������� ��������

#)9) ;�� ����� ��� <��������� �������� �, ��������

�, ����

-� ��� �� � ��� ���� ����� ��� ����� ����� �������� �

������� *������ ����� �� � ������� ��������� ���

������ ���� ����4�� �� K���������� �� K���������� �������

��� � ����� � ��������� !�� ������ ����������� ��

������ ���� ���� ��� �� ����� � !���� (�

!�� K���������� ��������� �������� ���� � (%%6 F*.

�������� ����� ������ 5%6 �������� 4��� 9�� �

���������� �������� ����� ������ ��� $6 ��������

4��� ������� . �� J ������ ��������� ����� �

�������� ��� � ��� ������ � ���������� �������� ��

��� ����� ������

!�� K���������� ��������� �������� ���� ����� ����

�������� � (%%6 F*. ������ � �������� ���� � %�$$:

�� �� ������� ����� ���� �������� � ������� ���������

�������� ������ ���� ���� �������� ���� B!���� (C�

-�������� � ��� ���� � ������ J� � (%���� �������� �

�������� ���� ��� �������� B%�%$: �� �C� -��� �����

�� ������� �������� ������ J ��������� ������ ���

���������� � ����� �������� � ������� ���� ����������

��������� �������� ���������

#)") � �� ��� ��� ,��� �� ���� ��������

!�� ������� � ���� ��� �� ������� ��� �� ����� �

!���� (� I��� ���� ����� �� �� �������� ���� ���� �������

*������ ����� �� F*. ������� $>6 �� ���

������ � ������ �������� � ��/������ B = G ((�'C

������� ��� ��� ������� ������� ������ ����������

� ������� ��/������ B = G ($�$C ��� ���� ��� ������

� �������� ������ �� ������ !��� ���������� �������

����� ���� ��� ��/������ � ������� ��� �� �� ���

������ �� ����� ����������� !�� ���������� �

��/������ ��� � ��� ������ � ������ ������ �

��������� ��� �� ��� ����� ����� �� ������ ��� �����

������ ������� ���������� ��� ���� ������ !�� ���

�������� ������ ��������� ���� �� ����� � !���� (� -�

��� ���� ������� ��� �������� �������� ��� ���

������� ����� ������ ����� �������� � ���������

!�� ��� �������� ������ ��������� ������ ��� ���� �

��� ��� � ������� ���� ����� ��� (>(% �� (>'% �

� ���������

� �����������

!�� ������� ��������� �� �� ���� ��� ��� �����

�����������?

(� ����� �������� � ������� *������ ����� ������

������ �������� ���� ��������� ��������� =���

����� ������� ������� �� ����� ��� ��������

��������� �� ������ � ������

$� !�� ��/������ � ������� ��� �� �� ��� ������ ��

����� ��� ����������������� �����������

2� -�������� ������� ������� ���������� �������� ��

������ �� ��� ��������� ��� �������� ���� � �����

�������� � ������� ���� ����������� ��������

�������� ��� ���� �������� ��� ��� ������� �������

� ��������

7� -�������� ������� ������� ���������� �������� ��

������ ������ � (%���� �������� � �������� ����

� ����� �������� � ������� ���� �����������

��������� �������� ���������

>� .������� ������� �� ������� ����� ��� �����

������� ������� ��������� ��������� ��� ��������

���� � ����� �������� � ������� �� ������ ���

���������� ���� ��������� ���������

�������� ������

-������ ���/ ��� J�������� .�.�+� ����/���� �� ���

/�� �������� �� ������ ���� � ���

!���� (

M���������� �� K���������� ��������� � ��������

������

.�� �������

������� B�*�C

-�/������

B =C

I��� ��������

������ B �C

-��� ������

B6C

.������� ����

B�� �C

J���������

�����

F*. $%�> Q $ ((�' (>%% 5% %�$$: 3

F*.@I- (5�> Q (�$ ((�' (>'% > %�(>7 (�>%

- $( Q (�> ($�% (>$% $ %�(2$ (�"2

9 $$ Q $�> ($�$ (>7% $ %�%:5 $�27

. $2 Q $�% ($�$ (>7> %�> %�%52 $�"'

J $>�> Q (�" ($�$ (>(% %�> %�%$: "�:%

1) �����%���� �� � ) 2 ������ ��� �������� �������� #* 3($$*4 567857/ ":2

Page 6: Evaluation of a composite corrosion-inhibiting admixture and its performance in concrete under macrocell corrosion conditions

����������

0(1 =� L���� =�H� P����� ��,� ������ ��,� .�����K������ .������� �

����� ���� � ������� ������� ������ �������� �� ������ ���

��������� ������ *������ 2( B(::$C 2"372�

0$1 8�*� ����������� .������� ���������� � ������� R ���� �����

�� ��� ��������� �������� +��� .���� #� "2 B(::2C 2'"32"7�

021 J�I� H���� .������� ��������� �� �������� �������? .������� �

������ � �������� -�� .���� +���� �* 7: B(:">C :> B-������

.������ +�������� J������� �+C�

071 8��� 9��/�� -� ��������� !������� ������ � ������� ������ ������

��� �������� � �������� ������� ������ ����� �� ��������?

����� �������� � �������� !��� � ���� ���� ($(( B(:5:C (5�

0>1 8��� 9��/�� -� ��������� .������ ������ �������� �������� �

�������� �? �� ��4K��4 B���C� -��������� �� .������� *����

+�� ��� �� 9�������� ��� (73("� .�� �� S =���� ,����

(::%� � $>(�

0'1 .� � 8���� ��-� I�������� H��� 9������/�� F����� ����� ������

��� �������� ���������� �� �������� �������� .���� +�� (7 B7C

B(::$C 7>3>(�

0"1 N� ������� - �� ����� � �������� ��������� .������� �� ������

��� �������� � ����� � �������� �? ��8� ����� B���C� *���� +��

.�� ���� �� ��� N��� � �������� ������� -������� *����� ����

����� N � $73$5 #���� B(::7C 5>(35'7�

051 9� ���#�4����� 8��� 9��/�� P��� H����� !�� ��� � ������� ������

�� � �������� �������� ��������� �� ����� ���������� � ���

������ �? .�,� *���� �P�#� !��������� *�9� 9������ B����C�

.������� � ���������� � .������� ��������� ,���� (::%�

� >"(3>5>�

0:1 �� .���� ����� -��������� �� �������� �+,�� *���� + B(::%C $5"�

0(%1 �� .���� H� I��������� I� H������� �� *��������� +����� � �������

������ � ��� ���������� �������� � ������� �������� �������

������ ������� �? ��8� ����� B���C� *���� +�� .�� ���� �� ���

N��� � �������� ������� -������� *����� �������� N � $73$5

#���� B(::7C 5"535:$�

0((1 N� 8��������� P� 9���� ������ ���� I�������4�/� �� *�.�

9���������� �� 9�������������� �� �� +������� �� ��� ���

����� �� ����� � ��������� 9���� P��/��� ������ 7$ B(::(C >2"�

0($1 �� � H����� .������� �� �������� �������� � �������� �����?

*��� +� +������� � ��/���� ��������� 9�� .������ #� > B(:"%C

(:53$%2�

0(21 �� � H����� P�O� =���/�� .������� �� �������� �������� � ���

������ �����? *��� ++� �������� � �������� 9�� .������ #� > B(:"%C

$%73$%5�

0(71 .� ���������� -� I������ H� !��������� - ����� � ��������

��������� �� ������� � �������� .��� .���� ���� 2% B$%%%C

'2>3'7$�

0(>1 .��� =����� ,� ���������� 9�9� =� �� .������� ��������� �

�������? *��� +� !�� ���� ���� .��� .���� ���� $5 B(::5C

("">3("5$�

0('1 -��� ��������� #��� H������ !�H� �������� P��� *������� -�!�

� ��� !���� *���� 8�� '$: B(:""C 5: B-�!�� *������� ���C�

0("1 � !�������� H� ���������� �� O�������� - �� ����� �����

�K�� �� ������ �������� ����� � ������� ����������� +��� .����

#� ': B(::>C "(23"(>�

0(51 �� ������������ �� ����������� � !�������� �� ��������� .���

������� ���� � ��������� �� ���������� ��� � ��� �������� � �����

� �������� #� - �� ������������ 2% B$%%%C ($>>3($>:�

1) �����%���� �� � ) 2 ������ ��� �������� �������� #* 3($$*4 567857/":7